Data Sheet

28113

STR-S6707 THRU
STR-S6709

OFF-LINE SWITCHING REGULATORS

WITH BIPOLAR SWITCHING TRANSISTOR
COLLECTOR

COMMON

BASE

SINK

The STR-S6707, STR-S6708, and STR-S6709 are specifically

designed to meet the requirement for increased integration and reliability in off-line quasi-resonant flyback converters. These devices incorporate the primary control and proportional drive circuit with a thirdgeneration high-voltage bipolar switching transistor.

T
C

FAULT

Crucial system parameters such as maximum ON time and OFF

time are fixed during manufacture. Local control circuit decoupling and
layout are optimized within each device.

S
DRIVE

FAULT
LATCH

OSC.

R
DRIVE

OVER-CURRENT
PROTECTION

FDBK

INHIBIT

V IN

U
Y
D
L
O

Cycle-by-cycle current limiting, under-voltage lock-out with hysteresis, over-voltage protection, and thermal shutdown protect these
devices during all normal and overload conditions. Over-voltage
protection and thermal shutdown are latched after a short delay. A
versatile triple-level inhibit circuit includes the OFF time synchronization
required to establish quasi-resonant operation. The inhibit function has
also been expanded to initiate operation in stand-by mode in which the
power supply delivers a small fraction of the steady-state output power.
The dual requirements of dielectric isolation and low transient thermal
impedance and steady-state thermal resistance are satisfied in an overmolded single-in-line power package.

+
REF.

+
UVLO

Dwg. PK-001

D
E

ABSOLUTE MAXIMUM RATINGS

Supply Voltage, VIN ........................... 15 V
Output Voltage, VCEX ....................... 850 V
VEBO ................................................ 7 V
Continuous Output Current,
IC .......................................... See Table
1 ms Single-Pulse Output Current,
ICM ........................................ See Table
Sink Current, IS ......................... See Table
Drive Current, ID .......................... -700 mA
Feedback Current, IFDBK ................. 20 mA
Inhibit Voltage, VINH ........................... 15 V
Over-Current Protection Voltage Range,
VOCP ............................................ 3.5 V
Insulation Voltage,VWM(RMS) ........... 2000 V
Package Power Diss., PD ........ See Graph
Output Junction Temperature, TJ .. +150C
Internal Frame Temperature, TF ... +125C
Operating Temperature Range,
TA ............................... -20C to +125C
Storage Temperature Range,
Tstg ............................. -40C to +125C

I
D

C
S

R
O

E
C

N
O

N
E

Proven in substantial volumes, these devices and their fixedfrequency counterparts represent a significant advance in off-line SMPS
reliability growth and integration.

U
N

I
T

N
O

R
P

R
E

FEATURES

Quasi-Resonant Operation for Low EMI and High Efficiency

Output Power to 220 W
Low-Power Output Standby Mode
Pulse-by-Pulse Over-Current Protection
Latched Over-Voltage and Thermal Protection
Third-Generation Switching Transistor with Proportional Drive
Maximum ON Time and Off Time Set During Manufacture
Internal Under-Voltage Lockout with Hysteresis
Over-Molded SIP with Integral Isolated Heat Spreader

F
E

Always order by complete part number:

Max. Cont.
Peak
Part Number
Current, IC
Current, ICM
STR-S6707
STR-S6708
STR-S6709

6A
7.5 A
10 A

12 A
15 A
20 A

Max. Sink
Current, IS
1.5 A
1.5 A
2A

STR-S6707 THRU STR-S6709

OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
STR-S6707 AND STR-S6708 FUNCTIONAL BLOCK DIAGRAM

INHIBIT

IN

UVLO
OVER-VOLT.
PROTECT

FAULT
LATCH
S

PROPORTIONAL
DRIVE
Q

1 k

REF.

DRIVE

SINK

BASE

COLLECTOR

COMMON

OVER-CURRENT
PROTECTION

0.7

TSD
OSC.

Rton
+
0.75 V
+
FDBK

7
3300 pF

1.4 V

Rtoff

-1 V

+
5.1 V

Dwg. FK-001

ALLOWABLE PACKAGE POWER DISSIPATION

MAXIMUM SAFE OPERATING AREA

30
STR-S6709 (20 A)

54 W

MOUNTING SURFACE
TEMPERATURE

STR-S6708 (15 A)
STR-S6707 (12 A)

RECOMMENDED MAX.
FRAME TEMP. = +100C

40

LIMITED BY FRAME
TEMP. = +125C MAX.
20

COLLECTOR CURRENT in AMPERES

ALLOWABLE PACKAGE POWER DISSIPATION in WATTS

60

10

5.0

3.0
L = 6 mH
IB1 = 2.5 A (STR-S6707/08) or 3 A (STR-S6709)
IB2 = 0.8 A (STR-SA6707/08) or 1.2 A (STR-S6709)
ton = 100 s
dc < 1%
1.0

FREE AIR
0.5

3.2 W
0.3

0
20

60
100
TEMPERATURE in C

140

200

400

600

800

1000

COLLECTOR-EMITTER VOLTAGE in VOLTS

Dwg. GK-003-2

115 Northeast Cutoff, Box 15036

Worcester, Massachusetts 01615-0036 (508) 853-5000
Copyright 1994 Allegro MicroSystems, Inc.

Dwg. GK-002

STR-S6707 THRU STR-S6709

OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS

STR-S6709
FUNCTIONAL BLOCK DIAGRAM
AS ABOVE
EXCEPT FOR SINK OUTPUT

SINK

20

ELECTRICAL CHARACTERISTICS at TA = +25C, VIN = 8.5 V, voltage measurements are referenced to Common (pin 2) (unless otherwise noted).
Characteristic
On-State Voltage
Under-Voltage Lockout
Over-Voltage Threshold
Output Leakage Current
Output Saturation Voltage

Symbol
VINT
VINQ
VOVP(th)
ICEX
VCE(sat)

VBE(sat)

DC Current Gain
Maximum ON Time
Minimum OFF Time
Over-Current Threshold
Feedback Threshold Volt.
Inhibit Threshold Voltage

Latch Holding Current

Latch Reset Voltage
Supply Current
Insulation RMS Voltage
Thermal Shutdown
Thermal Resistance

hFE
ton
toff
VOCP(th)
VFDBK(th)
VINH(th)

IINH
VQ
IIN(ON)
IIN(OFF)
VWM(RMS)
TJ
RJM

Test Conditions
Turn-on, increasing VIN
Turn-off, decreasing VIN
VCE = 850 V, VBE = -1.5 V
STR-S6707, IC = 2 A, IB = 400 mA
STR-S6708, IC = 3 A, IB = 600 mA
STR-S6709, IC = 4 A, IB = 800 mA
STR-S6707, IC = 2 A, IB = 400 mA
STR-S6708, IC = 3 A, IB = 600 mA
STR-S6709, IC = 4 A, IB = 800 mA
VCE = 4 V, IC = 1 A

Oscillation stops
Oscillation synchronized
Oscillation stops (fault latch set)
VIN reduced from 10.7 V to 4 V
IIN 100 A, VIN reduced from 10.7 V
Operating
All terminals simultaneous reference
metal plate against backside
Output junction to mounting surface

Limits
Min. Typ. Max.
7.6
8.0
8.4
4.6
4.9
5.2
9.2

10.7

100

400

400

400

1.5

1.5

1.5
29

61
33

41
45

55
-0.9 -1.0 -1.1

650

0.65 0.75 0.85

1.4
2.0
3.2
5.1
5.6

500
2.5
3.1

15

29

200
2000

Units
V
V
V
A
mV
mV
mV
V
V
V

s
s
V
mV
V
V
V
A
V
mA
A
V

125

C
C/W

NOTES: Negative current is defined as coming out of (sourcing) the specified device terminal.
Typical Data is for design information only.

150
2.0

STR-S6707 THRU STR-S6709

OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS

TYPICAL CHARACTERISTICS

100

50

DC CURRENT GAIN

30

VCE= 4 V
10

STR-S6709
STR-S6708
STR-S6707

5.0

3.0

1.0
0.01

0.03

0.1

1.0
0.3
3.0
COLLECTOR CURRENT in AMPERES

10

100

30

Dwg. GK-001

115 Northeast Cutoff, Box 15036

Worcester, Massachusetts 01615-0036 (508) 853-5000

STR-S6707 THRU STR-S6709

OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS
TYPICAL QUASI-RESONANT FLYBACK CONVERTER
WARNING: lethal potentials are present. See text.

+ OUTPUT

+
8

FULL-BRIDGE
RECTIFIER

AC INPUT
100 V/120 V

+
S

VOLTAGE
SENSE

OUTPUT
+

7
+

6
+

Dwg. EK-004A

APPLICATIONS INFORMATION
WARNING These devices are designed to be operated at lethal voltages and energy levels. Circuit
designs that embody these components must conform with applicable safety requirements. Precautions must be taken to prevent accidental contact with power-line potentials. Do not connect
grounded test equipment.
The use of an isolation transformer is recommended during circuit development and breadboarding.
Recommended mounting hardware torque:
4.34 5.79 lbfft (6 8 kgcm or 0.588 0.784 Nm).
Recommended metal-oxide-filled, alkyl-degenerated oil base, silicone grease:
Dow Corning 340, or equivalent

STR-S6707 THRU STR-S6709

OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS

Dimensions in Inches
(for reference only)

0.953 0.008
T M REF.

0.610

0.130

0.008

0.216

0.008

0.008

0.709 0.008

1.49 0.012

0.118

0.130
0.004

0.276
0.016

0.216
1

0.016

0.033

9
0.100

0.026

0.004

+0.008
0.004

0.177

+0.008
0.004

0.028

PACKAGE
CENTER

LEAD
CENTER

Dwg. MK-003-9 in

NOTE: Exact body and lead configuration at vendors option within limits shown.

115 Northeast Cutoff, Box 15036

Worcester, Massachusetts 01615-0036 (508) 853-5000

STR-S6707 THRU STR-S6709

OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS

Dimensions in Millimeters
(controlling dimensions)

24.2 0.2
T

REF
M
3.3

15.5 0.2

0.2

5.5
0.2

18.0 0.2

23.0 0.3

3.0

3.3
0.1

7.0
0.4

5.5
1
0.85

0.4

9
2.54
0.1

+0.2
0.1

0.65
+0.2
0.1

4.5
0.7

PACKAGE
CENTER

LEAD
CENTER

Dwg. MK-003-9 mm

NOTE: Exact body and lead configuration at vendors option within limits shown.

The products described here are manufactured in Japan by Sanken Electric Co.,
Ltd. for sale by Allegro MicroSystems, Inc.
Sanken Electric Co., Ltd. and Allegro MicroSystems, Inc. reserve the right to
make, from time to time, such departures from the detail specifications as may be
required to permit improvements in the design of their products.
The information included herein is believed to be accurate and reliable.
However, Sanken Electric Co., Ltd. and Allegro MicroSystems, Inc. assume no
responsibility for its use; nor for any infringements of patents or other rights of third
parties which may result from its use.

STR-S6707 THRU STR-S6709

OFF-LINE
QUASI-RESONANT FLYBACK
SWITCHING REGULATORS

POWER CONVERSION/POWER MANAGEMENT

SELECTION GUIDES
SWITCHING REGULATOR PMCMs
Part
Number*
3002M

Application
5 V Switching Regulator and a
9 V Switching Regulator

VI
7.0-33 V

Max PO

3004M

5 V Switching Regulator and

Dual 9 V Switching Regulator

7.0-33 V

500 mA
2 x 400 mA

Bipolar
Bipolar

S5703

Quasi-Resonant Flyback Converter

110/120 V

140 W

500 V

6A

Bipolar

S5707

Quasi-Resonant Flyback Converter

85-265 V
220/240V

90 W
140 W

850 V

6A

Bipolar

S5708

Quasi-Resonant Flyback Converter

85-265 V
220/240 V

120 W
180 W

850 V

7.5 A

Bipolar

S6703

Quasi-Resonant Flyback Converter

110/120V

140 W

500 V

6A

Bipolar

S6704

Quasi-Resonant Flyback Converter

110/120 V

100 W

500 V

5A

Bipolar

S6707

Quasi-Resonant Flyback converter

85-265 V
220/240 V

90 W
140 W

850 V

6A

Bipolar

S6708

Quasi-Resonant Flyback Converter

85-265 V
220/240 V

120 W
180 W

850 V

7.5 A

Bipolar

S6709

Quasi-Resonant Flyback Converter

85-265 V
220/240 V

160 W
220 W

850 V

10 A

Bipolar

8033S

3.3 V Switching Regulator

5.5-28 V

3A

Bipolar

8050S

5.0 V Switching Regulator

7.0-40 V

3A

Bipolar

8090S

9.0 V Switching Regulator

12-40V

3A

Bipolar

8120S

12 V Switching Regulator

15-40 V

3A

Bipolar

8150S

15 V Switching Regulator

18-40 V

3A

Bipolar

Power Switch
500 mA
Bipolar
400 mA
Bipolar

* Complete part number includes additional characters to indicate operating temperature range and/or package style.
Also includes linear regulator output for 15.7 V at 1.0 A.

115 Northeast Cutoff, Box 15036

Worcester, Massachusetts 01615-0036 (508) 853-5000