INTERACTIVE SCHEMATIC

Bookmarks X

Options

Features
This document is best viewed at a
Cover Page screen resolution of 1024 X 768.
Information To set your screen resolution do the following:
Component Table
Tap Table
RIGHT CLICK on the DESKTOP.
Fluid Power Symbols Select PROPERTIES.
Electrical Symbols CLICK the SETTINGS TAB.
Schematic
MOVE THE SLIDER under SCREEN RESOLUTION
Machine Views
Front Frame
until it shows 1024 X 768.
Rear Frame CLICK OK to apply the resolution.
Tap Views

The Bookmarks panel will allow you to

quickly navigate to points of interest.

EC-C2 E-C60
EC-C3

E-C61

Click on any text that is BLUE and underlined.

These are hyperlinks that can be used to navi-
gate the schematic and machine views.

EC-C1

When only one callout is showing on a machine view this

VIEW ALL CALLOUTS button will make all of the callouts visible. This button is
located in the top right corner of every machine view page.

HOTKEYS (Keyboard Shortcuts)

FUNCTION KEYS
Zoom In “CTRL” / “+”
Zoom Out “CTRL” / “-”
Fit to Page “CTRL” / “0” (zero)
Hand Tool “SPACEBAR” (hold down)
Find “CTRL” / “F”
 RENR7885-07
May 2015

3500B and 3500C

Generator Set Engine
Electrical System
3500B: 3500B: 3500B: 3500B: 3500C:
DB31-UP CPA192-UP ZAH1-UP YAR1-UP CT21-UP
DC31-UP CTA155-UP CTJ199-UP ZAR1-UP DD51-UP
DD31-UP BMB132-UP ZAJ1-UP ZBR1-UP DD61-UP
GD31-UP CNB1189-UP BPJ477-UP GZS1-UP YBD1-UP
JD31-UP CTB199-UP BRK287-UP YAT1-UP SBG1-UP
JM31-UP YBB1-UP YAM1-UP YBT1-UP SBJ1-UP
DB41-UP CMC1241-UP FDN1599-UP YAW1-UP SFJ1-UP
DC41-UP CTC268-UP JCN1-UP YBW1-UP SBK1-UP
DD41-UP YBC1-UP YAN1-UP BGX120-UP SEK1-UP
JM41-UP ZAD1-UP ZAP1-UP JCY1-UP
DB81-UP JDE1-UP ZBP1-UP YAY1-UP
DB91-UP BLF166-UP YAP1-UP YAZ1-UP
DD91-UP CTG326-UP PBR1-UP 1FZ1-UP
CTH313-UP PDR1-UP 1GZ1-UP
JCH1-UP GAR1-UP 1HZ1-UP

© 2015 Caterpillar, All Rights Reserved Printed in U.S.A.

CID / MID / FMI

Failure Mode Identifiers (FMI)¹

FMI No. Failure Description
Component Identifiers (CID¹) 0 Data valid but above normal operational range.
Module Identifier (MID²) 1 Data valid but below normal operational range.
Engine Control 2 Data erratic, intermittent, or incorrect.
(MID No. 036) 3 Voltage above normal or shorted high.
CID Component 4 Voltage below normal or shorted low.
1 Injector Cylinder #1 5 Current below normal or open circuit.
2 Injector Cylinder #2 6 Current above normal or grounded circuit.
3 Injector Cylinder #3 7 Mechanical system not responding properly.
4 Injector Cylinder #4 8 Abnormal frequency, pulse width, or period.
5 Injector Cylinder #5 9 Abnormal update.
6 Injector Cylinder #6 10 Abnormal rate of change.
7 Injector Cylinder #7 11 Failure mode not identifiable.
8 Injector Cylinder #8 12 Bad device or component.
9 Injector Cylinder #9 13 Out of calibration.
10 Injector Cylinder #10 14 Parameter failures.
11 Injector Cylinder #11 15 Parameter failures.
12 Injector Cylinder #12 16 Parameter not available.
13 Injector Cylinder #13 17 Module not responding.
14 Injector Cylinder #14 18 Sensor supply fault.
15 Injector Cylinder #15 19 Condition not met.
16 Injector Cylinder #16 20 Parameter failures.
91 Throttle Position Sensor ¹The FMI is a diagnostic code that indicates what type of failure has occurred.
94 Fuel Delivery Pressure Sensor Event Codes
100 Engine Oil Pressure Sensor
Engine Control
101 Crankcase Air Pressure Sensor
Event Code Condition
105 Inlet Manifold Temperature Sensor
E0004 Engine Overspeed Shutdown.
110 Engine Coolant Temperature Sensor
168 Electrical System Voltage E0007 High Aftercooler Temperature Derate.
175 Engine Oil Temperature Sensor E0008 High Aftercooler Temperature Shutdown.
190 Engine Speed Sensor E0009 High Altitude Derate.
248 CAT Data Link E0012 High Crankcase Pressure Derate.
253 Personality Module
E0013 High Crankcase Pressure Shutdown.
254 Electronic Control Module
E0015 High Engine Coolant Temperature Derate.
261 Engine Timing Calibration
E0016 High Engine Coolant Temperature Shutdown.
262 5 Volt Sensor Power Supply
263 Digital Sensor Power Supply (8V or 12V) E0017 High Engine Coolant Temperature Warning.

268 Programmed Parameter Fault E0021 High Exhaust Temperature Derate.

273 Turbocharger Outlet Pressure Sensor E0031 Air Filter Restriction Derate.
274 Atmospheric Pressure Sensor E0038 Low Engine Coolant Temperature Warning.
275 Right Turbocharger Inlet Pressure Sensor E0040 Low Engine Oil Pressure Shutdown.
276 Left Turbocharger Inlet Pressure Sensor
E0043 Low System Voltage Warning.
279 Aftercooler Coolant Temperature Sensor (front)
E0095 Fuel Filter Restriction Warning.
289 Fuel Pressure Sensor - before fuel filter
E0099 Engine Oil Filter Restriction Warning.
336 Engine Control Switch
337 Remote Emergency Stop Switch E0100 Low Engine Oil Pressure Warning.
338 Engine Pre-lube Pump Relay E0101 High Crankcase Pressure Warning.
446 Air Shutdown Relay E0162 High Boost Pressure.
542 Engine Oil Pressure Sensor - before oil filter E0173 High Exhaust Temperature Warning.
545 Ether Injection Control Relay E0190 Engine Overspeed Warning.
546 Ether Injection Current (amps) Limit Relay
E0198 Low Fuel Pressure.
799 Service Tool
E0255 Diagnostic Reset.
827 Left Exhaust Temperature Sensor
E0264 Emergency Stop Activated.
828 Right Exhaust Temperature Sensor
1495 Injector Codes E0272 Inlet Air Restriction Warning.

¹ The CID is a diagnostic code that indicates which circuit is faulty. E0279 High Aftercooler Temperature Warning.
E2087 Air Intake Closed
² The MID is a diagnostic code that indicates which electronic control module
diagnosed the fault. E2088 Air Intake Detection Circuit Detected but Not Installed
RELATED MANUALS

Related Electrical Service Manuals

Title Form Number
Alternator: 5N-5692 SENR4978
Electric Starting Motor: 207-1562 SENR3581

Specifications RENR5057
Troubleshooting RENR5059
WIRE DESCRIPTION
Wire Wire
Wire Color Description Wire Color Description
Number Number
Power Circuits Control Circuits (Continued)
101 RD Aux. Circuit Breaker A732 BK Injector 12 Return
109 RD Alternator A733 BK Injector 13 Return
113 RD Keyswitch A734 BK Injector 14 Return
115 RD ECM Relay A735 BK Injector 15 Return
116 RD Power To Breaker A736 BK Injector 16 Return
117 RD Power To SMMS Breaker A746 WH Turbo Outlet Pressure
118 RD Smms Breaker To SMMS Relay A747 WH Atmospheric Pressure
119 RD Power To Prelube Breaker A751 WH Aftercooler Coolant Temp
120 RD Smms1 To SMMS2 C700 RD +8v Engine Mounted Sensors
121 RD ECM Breaker To SOS Timer E700 RD +8v Remote Mounted Sensors
122 RD Power To ASOS Breaker E795 WH Crankcase Pressure
123 RD ASOS Breaker To ASOS Relay E796 WH Unfiltered Oil Pressure
150 RD ECM Relay E797 BK Shutdown Notify -
155 RD General Alarm E798 RD Shutdown Notify Return
Ground Circuits F701 RD Starter Motor Mag Control
102 BK Ground F702 BK Rated Speed
200 BK Ground F703 WH LH Turbo Exhaust Temp
229 BK Ground F704 WH RH Turbo Exhaust Temp
A229 BK - Battery F705 RD Prelube Mag Control
A235 BK Digital Reference F708 RD Air Shutoff Drive
Basic Circuits F713 WH LH Turbo Inlet Pressure
304 WH Starter 1 F714 WH RH Turbo Inlet Pressure
314 PU Starter 2 F715 BK Shutdown C
354 RD Shutoff Timer F716 BK Start / Run / Stop
382 RD Ether Aid Sol F718 BK Prelube Pressure Switch Override
383 BK Ether Hold In F719 BK E-stop 2
Monitoring Circuits F720 BK Ether Manual Override
497 RD Coolant Level + F722 BK Droop Speed Signal
A403 BK Coolant Level - F723 PK Timing Cal +
C465 RD Prelube Relay F724 PU Timing Cal -
G429 WH Oil Temp Signal F725 WH Filtered Fuel Pressure
H401 RD Air Shutoff Switch F732 WH Secondary SpeedTiming Sensor
Control Circuits F737 WH Unfiltered Fuel Pressure
A700 RD Engine Mounted Sensor Supply G701 BK Starter Solenoid +
A701 RD Injector 1 G705 GN Prelube Pump +
A702 RD Injector 2 M755 YL CAN Data Link +
A703 RD Injector 3 M756 GN CAN Data Link -
A704 RD Injector 4 M757 BK CAN Data Link Shield
A705 RD Injector 5 838 BK LH MPU Shield
A706 RD Injector 6 838 GN LH MPU Common
A707 RD Injector 7 838 YL LH MPU Signal
A708 RD Injector 8 846 WH Coolant Level Sensor
A709 RD Injector 9 852 RD Air Shutoff Solenoid
A710 RD Injector 10 892 BR CAT Data Link -
A711 RD Injector 11 893 GN CAT Data Link +
A712 RD Injector 12 R800 RD +8v Engine Mounted Sensors
A713 RD Injector 13 T800 RD Engine Oil Temp Sensor - A
A714 RD Injector 14 993 BK Analog Signal Reference
A715 RD Injector 15 994 WH Filtered Oil Pressure
A716 RD Injector 16 996 RD Speed/timing Sensor +
A721 BK Injector 1 Return 997 RD +5v Engine Mounted Sensors
A722 BK Injector 2 Return 998 BK Speed/timing Sensor -
A723 BK Injector 3 Return 999 WH Speed/timing Sensor Signal
A724 BK Injector 4 Return C941 WH Coolant Temp
A725 BK Injector 5 Return E967 WH Block Coolant Level
A726 BK Injector 6 Return E996 BK SCAC Coolant Level Sensor
A727 BK Injector 7 Return E998 BK Digital Reference
A728 BK Injector 8 Return M975 WH Engine Oil Temp
A729 BK Injector 9 Return R993 BK Analog Signal Reference
A730 BK Injector 10 Return R997 RD +5v Engine Mounted Sensors
A731 BK Injector 11 Return R998 BK Digital Reference
T998 BK Engine Oil Temp Sensor - C
 HARNESS and WIRE
Electrical Schematic Symbols
Symbols

Pressure Temperature Level Flow Circuit Breaker

Symbol Symbol Symbol Symbol Symbol

Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has
screw terminals and a wire can be disconnected from it.

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be
disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the
machine.

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it
opens the contacts of a normally closed reed switch.

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its
T
resistance changes to give an indication to the gauge of the temperature or pressure.

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet
when current flows through it. The electromagnet can open or close the switch part of the relay.

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current
flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a
permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an
internal switch that places the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols

Wire, Cable, or Harness Assembly Identification: Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...)
Includes Harness Identification Letters and Harness
Connector Serialization Codes (see sample).
Harness Connector Serialization Code: The "C" stands for
"Connector" and the number indicates which connector in the
harness (C1, C2, C3, ...).
AG-C4 L-C12
111-7898 3E-5179 L-C12
3E-5179
Part Number: for 1 Part Number: for
Connector Plug
Connector Receptacle
2

Plug Receptacle
Pin or Socket Number

5A
1 Deutsch connector: Typical representation
Component
of a Deutsch connector. The plug contains all Fuse (5 Amps) 9X-1123 Part Number
2 sockets and the receptacle contains all pins.
325-AG135 PK-14
1 Sure-Seal connector: Typical representation Harness identification code:
of a Sure-Seal connector. The plug and receptacle This example indicates wire group 325, Wire Gauge
2 contain both pins and sockets. wire 135 in harness "AG". Wire Color
 7 6 5 4 3 2 1
101-E12 RD-14
101-E13 RD-14
E-C9 RECEPTACLE AS E-C18
102-E16 BK-14 155-E34 RD-16 1698670 1330970
102-E17 BK-14 3E3364
155-E35 RD-16
102-E18 BK-14 M756-E42 YL-SHD A H401-E168 RD-18 1 LEFT AIR
382-E179 RD-18
113-E15 RD-18 M755-E43 GN-SHD B H401-E169 RD-18 2 SHUTOFF SWITCH
382-E180 RD-18
M757-E46 BK-SHD C
383-E181 BK-18
E-S11 383-E182 BK-18
150-E5 RD-14 150-E7 RD-12 M756-E47 YL-SHD A A TERMINATING RESISTOR
892-E41 BR-18 LEFT AIR SHUTOFF SOLENOID
150-E4 RD-14 M755-E48 GN-SHD B B 1743016 852-E166 RD-12
893-E28 GN-18 1416747 (4 TURBO CONFIG)
150-E6 RD-14 M757-E49 BK-SHD C C 200-E167 BK-12
E-C1 993-E77 BK-18 2304073 (2 TURBO CONFIG)
ELECTRONIC CONTROL MODULE J1 1607690 993-E78 BK-18 E-C8
(ECM) 206-2710 155-E33 RD-16 993-E79 BK-18 1698670
1 E-S5 155-E35 RD-16 993-E80 BK-18 E-C27
+5V ENGINE MOUNTED SENSORS 2 997-E65 RD-18 155-E34 RD-16 993-E81 BK-18 E-C10 2304013 E-C27
ANALOG SIGNAL REFERENCE 3 993-E66 BK-18 200-E156 BK-18 1698670
993-E82 BK-18 1698670
+8V ENGINE MOUNTED SENSORS 4 A700-E105 RD-18 R997-E95 RD-18 A +5V LEFT TURBO INLET R997-E95 RD-18 A +5V LEFT TURBO INLET
993-E83 BK-18 AFTERCOOLER TEMPERATURE
DIGITAL REFERENCE 5 A235-E106 BK-18 200-E162 BK-10 997-E69 RD-18 A OR-18 +V R993-E98 BK-18 B GROUND PRESSURE SENSOR R993-E98 BK-18 B GROUND PRESSURE SENSOR
993-E84 BK-18 SENSOR C SIGNAL
AFTERCOOLER COOLANT TEMP 6 A751-E85 WH-18 993-E77 BK-18 B BK-18 GROUND F713-E102 WH-18 C SIGNAL 2746717 F713-E102 WH-18 1611703
994-E89 WH-18
E COOLANT TEMP
CAT DATA LINK +
7
8
C941-E88 WH-18
893-E26 GN-18
200-E165 BK-12 997-E69 RD-18 A751-E85 WH-18 C WH-18 SIGNAL 1022240 NOTE D E
997-E70 RD-18
CAT DATA LINK - 9 892-E39 BR-18 200-E167 BK-12 997-E71 RD-18 E-C7
RATED SPEED SIGNAL 10 F702-E20 BK-18 997-E72 RD-18 2304013 E-C7
LH TURBO EXHAUST TEMP 11 F703-E107 WH-18 229-E8 BK-14 1698670
997-E73 RD-18 ATMOSPHERIC PRESSURE FOR USE WITH EMCP II
RH TURBO EXHAUST TEMP 12 F704-E110 WH-18 229-E9 BK-14 997-E70 RD-18 A +5V 997-E70 RD-18 A +5V ATMOSPHERIC PRESSURE
997-E74 RD-18 E-C29
SECONDARY SPEED/TIMING SENSOR 13 F732-E19 WH-18 229-E10 BK-14 993-E78 BK-18 B GROUND SENSOR 993-E78 BK-18 B GROUND SENSOR ENGINE OIL
997-E75 RD-18 A747-E86 WH-18 C SIGNAL 1552269
14 354-E1 RD-18 A747-E86 WH-18 C SIGNAL 2746717 1611703
EF-C1 EF-C2 TEMPERATURE SENSOR
997-E76 RD-18 838-E118 YL-SHD 1 BK-18 LEFT MAGNETIC PICKUP
SCAC COOLANT LEVEL SENSOR 15 E996-E185 BK-18 354-E2 RD-18 NOTE D 3E3382 1698670 (EMCPII) 102-2240
A229-E37 BK-16 838-E117 GN-SHD 2 WH-18 1895746
FILTERED OIL PRESSURE 16 994-E89 WH-18 E-S16 OR-18
A229-E38 BK-16 E-C6 838-E119 BK-SHD 1 497-EF1 RD-18 A +V
UNFILTERED OIL PRESSURE 17 E796-E90 WH-18 382-E171 RD-18 382-E179 RD-18 BK-18
A235-E106 BK-18 2304013 E-C6 WHEN USED 2 A403-EF2 BK-18 B GROUND
+5V ENGINE MOUNTED SENSORS 18 R997-E93 RD-18 382-E180 RD-18 1698670
A700-E105 RD-18 PLUG INTO 3 846-EF3 WH-18 C WH-18 SIGNAL
19 E-S17 997-E71 RD-18 A +5V TURBO OUTLET PRESSURE 997-E71 RD-18 A +5V TURBO OUTLET PRESSURE
A702-E122 RD-18 ALTERNATOR (45A) E-C30 4
ETHER MANUAL OVERRIDE 20 F720-E173 BK-18 383-E172 BK-18 383-E181 BK-18 5N5692 993-E79 BK-18 B GROUND SENSOR 993-E79 BK-18 B GROUND SENSOR
A704-E126 RD-18 A746-E87 WH-18 C SIGNAL E-C30 5
START/RUN/STOP 1 21 F716-E21 BK-18 383-E182 BK-18 A746-E87 WH-18 C SIGNAL 2766793 1611704
A706-E130 RD-18 ALT 1552273 6
START/RUN/STOP 2 22 F716-E22 BK-18 NOTE D
A708-E134 RD-18 R T800-E111 RD-18 1
E-STOP 1 23 F715-E24 BK-18 497-E114 RD-18 109-C1 RD-4 +
A710-E138 RD-18 E-C11 T998-E112 BK-18 2 ENGINE FOR USE WITH EMCP III
FILTERED FUEL PRESSURE 24 F725-E92 WH-18 838-E117 GN-SHD EG-C1
A712-E142 RD-18 1698670 G429-E113 WH-18 3 OIL TEMPERATURE
UNFILTERED FUEL PRESSURE 25 F737-E91 WH-18 838-E118 YL-SHD 3E3382
A714-E146 RD-18 997-E59 RD-18 4 CONNECTOR
26 M975-E68 WH-18 838-E119 BK-SHD 200-C2 BK-4 997-E76 RD-18 A OR-18 +V COOLANT TEMPERATURE ENGINE OIL
A716-E150 RD-18 993-E67 BK-18 5 1
27 846-E116 WH-18 993-E84 BK-18 B BK-18 GROUND SENSOR EG-C2 TEMPERATURE SENSOR
A722-E123 BK-18 M975-E68 WH-18 6 WHEN USED 2
E-STOP 2 28 F719-E25 BK-18 852-E164 RD-12 C941-E88 WH-18 C WH-18 SIGNAL 1022240 1552269 (EMCPIII) 195-2150
A724-E127 BK-18 PLUG INTO 3
29
A726-E131 BK-18 POWER DISTRIBUTION BOX E-C30 4
BLOCK COOLANT LEVEL 30 E967-E177 WH-18 852-E166 RD-12 A728-E135 BK-18 E-C12 5 E993-EG2 BK-18 2 BK-18 GROUND
ANALOG SENSOR 22 31
A730-E139 BK-18 2370227 E-C12 6 M975-EG3 WH-18 1 WH-18 SIGNAL
32 1698670
A732-E143 BK-18 109-C1 RD-4 109-C1 RD-4
SPEED/TIMING SENSOR SIGNAL 33 999-E14 WH-18 892-E41 BR-18 70A 997-E75 RD-18 A +5V FILTERED FUEL PRESSURE 997-E75 RD-18 A +5V FILTERED FUEL PRESSURE
A734-E147 BK-18 200-C2 BK-4
CAN DATA LINK - 34 M755-E43 GN-SHD 892-E39 BR-18 E-S8 ALTERNATOR BREAKER 993-E83 BK-18 B GROUND SENSOR 993-E83 BK-18 B GROUND SENSOR
A736-E151 BK-18 F725-E92 WH-18 C SIGNAL E-C32
ANALOG SIGNAL REFERENCE 35 R993-E94 BK-18 892-E40 BR-18 2038986 F725-E92 WH-18 C SIGNAL 2746719 1611705 E-C32
A746-E87 WH-18 2304013
36 NOTE D 1698670
A747-E86 WH-18 109-W1 RD-4 R997-E96 RD-18 A +5V RIGHT TURBO INLET A +5V RIGHT TURBO INLET
37 893-E28 GN-18 R997-E96 RD-18
38 893-E26 GN-18 E-C13 R993-E99 BK-18 B GROUND PRESSURE SENSOR R993-E99 BK-18 B GROUND PRESSURE SENSOR
E-S7 A751-E85 WH-18 E-C13 F714-E103 WH-18 C SIGNAL
39 893-E27 GN-18 AIR SHUTOFF 2370227 F714-E103 WH-18 C SIGNAL 2746717 1611703
C941-E88 WH-18 1698670
TIMING CAL - 40 354-E178 RD-18 TIMER 200-H4 BK-18 A +5V UNFILTERED FUEL PRESSURE NOTE D
F724-E63 PU-18 E700-E183 RD-14 997-E74 RD-18 997-E74 RD-18 A +5V UNFILTERED FUEL PRESSURE
TIMING CAL + 41 F708-E175 RD-16 2395794 121-R1 RD-18 B GROUND SENSOR
F723-E62 PK-18 993-E78 BK-18 E796-E90 WH-18 993-E82 BK-18 993-E82 BK-18 B GROUND SENSOR
CAN DATA LINK SHIELD 42 M757-E44 BK-18 993-E79 BK-18 F737-E91 WH-18 C SIGNAL 2746719 F737-E91 WH-18 C SIGNAL 1611705
E996-E185 BK-18 200-H3 BK-18
SPEED/TIMING SENSOR + 43 996-E64 RD-18 993-E80 BK-18 NOTE D E-C39
E998-E187 BK-14
44 993-E82 BK-18 1552269
F703-E107 WH-18 E-C14
45 993-E66 BK-18 993-E81 BK-18
E-S10 F725-E92 WH-18 AIR SHUTOFF RELAY 2370227 E-C14 A701-E120 RD-18 1
46 993-E83 BK-18 1698670 INJECTOR 1
F737-E91 WH-18 F708-E175 RD-16 9X8124 A721-E121 BK-18 2
47 993-E84 BK-18 997-E72 RD-18 A +5V FILTERED OIL PRESSURE 997-E72 RD-18 A +5V FILTERED OIL PRESSURE
M756-E42 YL-SHD F708-E163 RD-16
48 993-E77 BK-18 993-E80 BK-18 B GROUND SENSOR 993-E80 BK-18 B GROUND SENSOR
M756-E47 YL-SHD 852-E164 RD-12
D CAN DATA LINK +
49
50 M756-E42 YL-SHD 994-E89 WH-18
993-E67 BK-18 M756-E50 YL-SHD 852-E166 RD-12
994-E89 WH-18 C SIGNAL 2746719 994-E89 WH-18 C SIGNAL
NOTE D
1611705
E-C40 NOTE
NOTE
A:
B:
CONNECTORS AND WIRES ARE NON EXISTENT ON THE 3512 AND 3508 ENGINES
CONNECTORS AND WIRES ARE NON EXISTENT ON THE 3508 ENGINE
D
M756-E52 YL-SHD 1552269
SPEED/TIMING SENSOR - 51 998-E3 BK-18 996-E64 RD-18 NOTE C: SHOWN FOR REFERENCE ONLY
M755-E43 GN-SHD 123-V1 RD-8 E-C15 A703-E124 RD-18 1
+ BATTERY 52 150-E4 RD-14 997-E71 RD-18 INJECTOR 3 NOTE D: WIRING FOR NONCURRENT PRODUCTION ENGINES USING “E” HARNESSES 237-9018, 237-9014 OR 237-9010.
M755-E48 GN-SHD 2370227 E-C15 A723-E125 BK-18 2
+ BATTERY 53 150-E6 RD-14 997-E70 RD-18 1698670
M755-E54 GN-SHD 122-T1 RD-8
54 997-E74 RD-18 40A 997-E73 RD-18 A +5V UNFILTERED OIL PRESSURE 997-E73 RD-18 A +5V UNFILTERED OIL PRESSURE PART NUMBER CHANGE LOCATION NOTE DESCRIPTION
M755-E56 GN-SHD
+ BATTERY 55 150-E5 RD-14 997-E73 RD-18 AIR SHUTOFF BREAKER 993-E81 BK-18 B GROUND SENSOR 993-E81 BK-18 B GROUND SENSOR
E-C41
M757-E46 BK-SHD E796-E90 WH-18 C SIGNAL HARNESS AS
AIR SHUTOFF TRIPPED DETECTION 56 H401-E169 RD-18 997-E65 RD-18 997-E72 RD-18 2038987 E796-E90 WH-18 C SIGNAL 2746719 1611705
1552269
E-S9 M757-E49 BK-SHD
GENERAL ALARM DRIVE + 57 155-E33 RD-16 997-E75 RD-18 NOTE D E 341-0609 00 A-7 ENGINE - 3516
M757-E58 BK-SHD 200-H2 BK-18 A705-E128 RD-18 1
58 997-E76 RD-18 INJECTOR 5 E 237-9018 05 A-7 D ENGINE - 3516
M757-E60 BK-SHD E-C19 A725-E129 BK-18 2
59 997-E69 RD-18
1552269 E 341-0608 00 A-7 A ENGINE - 3512
DIGITAL REFERENCE 60 M757-E45 BK-18 997-E59 RD-18
61 PRELUBE RELAY 1 E 237-9014 04 A-7 A,D ENGINE - 3512
998-E3 BK-18 A702-E122 RD-18 E-C42
62 F705-E160 RD-18 9X8124 2 INJECTOR 2
999-E14 WH-18 A722-E123 BK-18 1552269 E 341-0607 00 A-7 A,B ENGINE - 3508
- BATTERY 63 229-E8 BK-14
C465-E161 RD-10 A707-E132 RD-18 1 E 237-9010 05 A-7 A,B,D ENGINE - 3508
64 A229-E36 BK-16 INJECTOR 7
E-S6 E-C20 A727-E133 BK-18 2 F 242-7392 00 A-2 SPEED/TIMING SENSOR JUMPER
- BATTERY 65 229-E9 BK-14 A229-E38 BK-16
PRELUBE PRESSURE SWITCH OVERRIDE 66 120-P1 RD-8 1552269 G - - A-2 C SPEED/TIMING SENSOR JUMPER
F718-E159 BK-18 A229-E37 BK-16
- BATTERY 67 229-E10 BK-14 A704-E126 RD-18 1 EA 245-1149 00 B-2 COOLANT LEVEL JUMPER - EMCP II
68 40A 119-N1 RD-8 2 INJECTOR 4
A235-E106 BK-18 A724-E127 BK-18 E-C43
- BATTERY 69 A229-E36 BK-16 A403-E115 BK-18 EC 245-1150 00 A-2 COOLANT LEVEL JUMPER - EMCP III
PRELUBE BREAKER 1552269
KEYSWITCH 70 113-E15 RD-18 A700-E105 RD-18 2038987 EF 245-1149 00 E-1 ENGINE OIL TEMP JUMPER - EMCP II
E-C21 A709-E136 RD-18 1
A701-E120 RD-18 101-E12 RD-14 INJECTOR 9 EG 253-1888 01 D-2 ENGINE OIL TEMP JUMPER - EMCP III
E-C2 1552269 A729-E137 BK-18 2
A702-E122 RD-18 101-E13 RD-14
J2 1471443 1 NOTE B
A703-E124 RD-18 102-E16 BK-14 STARTER MOTOR A706-E130 RD-18
1 200-U2 BK-18 MAGNETIC SWITCH 2 INJECTOR 6 WIRE AS
INJECTOR 1 + A701-E120 RD-18 A704-E126 RD-18 102-E17 BK-14 A726-E131 BK-18 E-C44
INJECTOR 1 RTN 2 F701-E11 RD-18 (SMMS) 2
A721-E121 BK-18 A705-E128 RD-18 102-E18 BK-14 1552269 H 242-7063 00 C-5 RELAY COIL TO GND LUG
INJECTOR 2 + 3 A702-E122 RD-18 A706-E130 RD-18 9X8124
150-E7 RD-12 314-E158 PU-8 A711-E140 RD-18 1 J 242-7064 00 C-5 ECM BREAKER TO ECM RELAY
INJECTOR 2 RTN 4 A722-E123 BK-18 A707-E132 RD-18 E-C22 INJECTOR 11
200-E156 BK-18 A731-E141 BK-18 2
INJECTOR 15 + 5 A715-E148 RD-18 A708-E134 RD-18 1552269 K 242-7065 00 C-5 AUXILIARY BREAKER TO PWR LUG
200-E162 BK-10 120-CC1 RD-8
STARTER SOLENOID + 6 G701-E29 BK-16 A709-E136 RD-18 200-E165 BK-12 A708-E134 RD-18 1 L 242-7065 00 C-5 ATCH SMMS BREAKER TO PWR LUG
7 200-U1 BK-18 2 INJECTOR 8
STARTER SOLENOID - A710-E138 RD-18 A728-E135 BK-18

RD-18
BK-18
BK-18
BK-18
200-E167 BK-12 STARTER MOTOR M 241-0236 00 C-5 ATCH SMMS BREAKER TO SMMS RELAY

BK-4
RD-8
RD-8
RD-4
8 200-U2 BK-18
A711-E140 RD-18 200-U1 BK-18 MAGNETIC SWITCH
9 F701-E11 RD-18 N 242-7065 00 C-5 ATCH PRELUBE BREAKER TO PWR LUG
A712-E142 RD-18 (SMMS) 1 E-C45
ETHER HOLD IN + 10 F701-E154 RD-18 9X8124 P 241-0236 00 D-5 ATCH PRELUBE BREAKER TO PRELUBE RELAY
382-E171 RD-18 A713-E144 RD-18

121-R1
200-H2
200-H3
200-H4

200-C2
119-N1
122-T1
109-W1
229-E8 BK-14 304-E157 WH-8 1552269
11 A714-E146 RD-18 R 242-7390 00 C-5 ATCH ECM BREAKER TO ASOS TIMER
PRELUBE PUMP + 12 229-E9 BK-14 118-M1 RD-8 E-C23 A713-E144 RD-18 1
G705-E55 GN-18 A715-E148 RD-18 INJECTOR 13
229-E10 BK-14 1552269 A733-E145 BK-18 2 T 241-0234 00 C-5 ATCH AIR SHUTOFF BREAKER TO PWR LUG
AIR SHUTOFF DRIVE 13 F708-E163 RD-16 A716-E150 RD-18
INJECTOR 5 + 14 354-E1 RD-18 40A 117-L1 RD-8 1 NOTE A U 250-8472 00 C-5 ATCH SMMS GROUND
A705-E128 RD-18 A721-E121 BK-18 A710-E138 RD-18
15 354-E2 RD-18 POWER 2 INJECTOR 10
INJECTOR 5 RTN A725-E129 BK-18 A722-E123 BK-18 STARTER MOTOR MAGNETIC SW (SMMS) BREAKER A730-E139 BK-18 V 241-0232 00 D-5 ATCH AIR SHUTOFF BREAKER TO AIR SHUTOFF RELAY
STUD E-C46
INJECTOR 6 + 16 A706-E130 RD-18 A723-E125 BK-18 2038987 NOTE B
354-E178 RD-18 CBL-A1 RD-4 1552269
INJECTOR 6 RTN 17 A726-E131 BK-18 A724-E127 BK-18
A715-E148 RD-18 1 CABLE AS
C INJECTOR 15 RTN 18
19
A735-E149 BK-18 A725-E129 BK-18
A726-E131 BK-18
116-K1 RD-8
E-C24
1552269 A735-E149 BK-18 2 INJECTOR 15
A 242-7397 00 B-5 ATCH POWER DISTRIBUTION BOX TO STARTER-3512 & 3516
C
ETHER HOLD IN - 20 852-E164 RD-12 101-E12 RD-14 20A 1
383-E172 BK-18 A727-E133 BK-18 A712-E142 RD-18 A 241-0237 00 B-5 ATCH POWER DISTRIBUTION BOX TO STARTER-3508
21 852-E166 RD-12 101-E13 RD-14 ELECTRONIC CONTROL 2 INJECTOR 12
A728-E135 BK-18 AUXILIARY A732-E143 BK-18
22 A729-E137 BK-18 C465-E161 RD-10 BREAKER MODULE(ECM) C 242-7398 00 D-5 ATCH POWER DISTRIBUTION BOX TO ALTERNATOR-3516
E798-E31 RD-18 2038989 BUSSBAR C 241-0242 00 E-5 ATCH POWER DISTRIBUTION BOX TO ALTERNATOR-3512
23 A730-E139 BK-18 2427061
F701-E154 RD-18 E798-E31 RD-18 E-C5
INJECTOR 9 + 24 A709-E136 RD-18 A731-E141 BK-18 C 241-0240 00 E-5 ATCH POWER DISTRIBUTION BOX TO ALTERNATOR-3508
F705-E160 RD-18 H401-E170 RD-18 1552269
INJECTOR 9 RTN 25 A729-E137 BK-18 A732-E143 BK-18 20A
F708-E163 RD-16 F723-E62 PK-18 1 TIMING CALIBRATION(TC) W 241-0244 00 D-5 ATCH ALTERNATOR BREAKER TO PWR LUG
INJECTOR 16 + 26 A716-E150 RD-18 A733-E145 BK-18 ELECTRONIC CONTROL

200-H2 BK-18
200-H3 BK-18
200-H4 BK-18
PROBE CONNECTOR

200-C2 BK-4
INJECTOR 16 RTN 27 MODULE (ECM) BREAKER F724-E63 PU-18 2 AA 7L-5887 03 B-5 ATCH STARTER JUMPER +BATT
A736-E151 BK-18 A734-E147 BK-18
SHUTDOWN NOTIFY - 28 E797-E32 BK-18 A735-E149 BK-18 H401-E170 RD-18 2038989 E-C25 AC 7L-5887 03 B-5 ATCH STARTER JUMPER -BATT
29 121-R1 RD-18 1552269
A736-E151 BK-18 E-C33
30 115-J1 RD-12 1
A746-E87 WH-18 A714-E146 RD-18 3E3364
31 314-E158 PU-8 354-E178 RD-18 2 INJECTOR 14
A747-E86 WH-18 30 A734-E147 BK-18
INJECTOR 13 + 32 304-E157 WH-8 354-E2 RD-18 86 ELECTRONIC CONTROL H401-E170 RD-18 1 RIGHT AIR
A713-E144 RD-18 A751-E85 WH-18 NOTE A
INJECTOR 13 RTN 33 354-E1 RD-18 H401-E168 RD-18 2 SHUTOFF SWITCH (+) BATTERY
A733-E145 BK-18 C465-E161 RD-10 MODULE (ECM) RELAY
INJECTOR 10 + 34 A710-E138 RD-18 85 9Y2921 E-C26
INJECTOR 10 RTN 35 A730-E139 BK-18 C700-E174 RD-18 87 87A 1552269 (+) BATTERY SWITCHED
TURBO OUTLET PRESSURE 36 150-E7 RD-12 1
A746-E87 WH-18 C941-E88 WH-18 A716-E150 RD-18 RIGHT AIR SHUTOFF SOLENOID
37 2 INJECTOR 16 852-E164 RD-12 STARTING CIRCUIT
ATMOSPHERIC PRESSURE A747-E86 WH-18 E700-E183 RD-14 A736-E151 BK-18 1416747 (4 TURBO CONFIG)
LH TURBO INLET PRESSURE 38 102-E16 BK-14 200-H1 BK-18 200-H1 BK-18 200-E165 BK-12
F713-E102 WH-18 E967-E177 WH-18 2304073 (2 TURBO CONFIG)
102-E17 BK-14 200-E165 BK-12 GROUND (-) BATTERY / SENSOR RETURN
RH TURBO INLET PRESSURE 39 F714-E103 WH-18 E996-E185 BK-18
INJECTOR 3 + 40 102-E18 BK-14 200-E167 BK-12 STUD
A703-E124 RD-18 E998-E186 BK-14 E-C34 SENSOR / ACTUATOR SUPPLY
E-S18 200-E156 BK-18 200-E162 BK-10 CBL-A2 BK-4
INJECTOR 3 RTN 41 A723-E125 BK-18 E998-E184 BK-14 E998-E176 BK-18
200-E162 BK-10 200-E156 BK-18 E-C4 7N9737
INJECTOR 4 + 42 A704-E126 RD-18 E998-E187 BK-14 SIGNAL TO ECM
INJECTOR 4 RTN 43 200-U1 BK-18 102-E17 BK-14 8T8736 F701-E153 RD-18 1 BK-18 AIR START SOLENOID
A724-E127 BK-18 E795-E104 WH-18
44 200-E165 BK-12 102-E16 BK-14 A 200-E156 BK-18 2 BK-18 5N8980 CONTROL (POSITIVE) FROM ECM
E796-E90 WH-18 155-E34 RD-16
45 200-E167 BK-12 102-E18 BK-14 B CONTROL (RETURN) FROM ECM
E797-E32 BK-18 A229-E37 BK-16
CRANKCASE PRESSURE 46 229-E8 BK-14 229-E8 BK-14 C
E795-E104 WH-18 M757-E58 BK-SHD SERVICE CAT DATA LINK
47 229-E9 BK-14 229-E9 BK-14 D
E798-E31 RD-18 893-E28 GN-18 CONNECTOR E-C35
INJECTOR 7 + 48 229-E10 BK-14 229-E10 BK-14 E J1939 DATA LINK
A707-E132 RD-18 F701-E152 RD-18 892-E41 BR-18 1698670
INJECTOR 7 RTN 49 E-S13 200-U1 BK-18 F
A727-E133 BK-18 M755-E54 GN-SHD RIGHT TURBO INLET EXHAUST
INJECTOR 8 + 50 G R800-E108 RD-18 A OR-18 +V HIGHWAYS
A708-E134 RD-18 F701-E154 RD-18 M756-E50 YL-SHD TEMPERATURE SENSOR
INJECTOR 8 RTN 51 H R998-E109 BK-18 B BK-18 GROUND
A728-E135 BK-18 F701-E153 RD-18 200-E156 BK-18
F704-E110 WH-18 C WH-18 SIGNAL 1637882
INJECTOR 12 + 52 A712-E142 RD-18 F702-E20 BK-18 200-E162 BK-10 J
53 200-E165 BK-12
DIGITAL REFERENCE 54 R998-E109 BK-18 F703-E107 WH-18 200-E167 BK-12
E-C47 E-C36
55 F704-E110 WH-18 497-E114 RD-18 304-E157 WH-8 E-C32 SYMBOL DESCRIPTION
1698670 2304013
+8V ENGINE MOUNTED SENSORS 56 R800-E108 RD-18 F705-E160 RD-18 838-E117 GN-SHD 1698670
R997-E97 RD-18 A +5V CRANKCASE PRESSURE
+8V ENGINE MOUNTED SENSORS 57 C700-E174 RD-18 F708-E163 RD-16 838-E118 YL-SHD E700-E183 RD-14 A RD-18 +V SEPARATE CIRCUIT AFTERCOOLER R997-E97 RD-18 A +5V CRANKCASE PRESSURE
G S R993-E100 BK-18 B GROUND SENSOR R993-E100 BK-18 B GROUND SENSOR CIRCUIT CONNECTED
INJECTOR 11 + 58 A711-E140 RD-18 F713-E102 WH-18 838-E119 BK-SHD E998-E187 BK-14 B BK-18 GROUND COOLANT LEVEL SENSOR
E795-E104 WH-18 C SIGNAL 2746717 E795-E104 WH-18 C SIGNAL 1611703
INJECTOR 11 RTN 59 A731-E141 BK-18 F714-E103 WH-18 846-E116 WH-18 E996-E185 BK-18 C GN-18 ALARM 1656634
MTR BAT CIRCUIT NOT CONNECTED
B INJECTOR 14 +
INJECTOR 14 RTN
60
61
A714-E146 RD-18
A734-E147 BK-18
F715-E24 BK-18 852-E164 RD-12
852-E166 RD-12
STARTER 1
2071562
CBL-A1 RD-4
CBL-AA1 BK-0000
NOTE D
ELECTRICAL CONNECTION TO
B
INJECTOR 12 RTN 62 A732-E143 BK-18 F716-E21 BK-18 993-E67 BK-18 E-C3 MACHINE STRUCTURE
E-S12 MOTOR 1552264 E-C37 PRELUBE PRESSURE SWITCH
63 F716-E22 BK-18 996-E64 RD-18 1552269 1501240 INTERNAL ELECTRICAL CONNECTION
FOR USE WITH EMCP II
64 F716-E23 BK-18 997-E59 RD-18 155-E35 RD-16 1 TO SURFACE OF COMPONENT
+8V REMOTE MOUNTED SENSORS 65 2 F718-E159 BK-18 1 BK-18 EA-C1 EA-C2 COOLANT LEVEL SENSOR (EMCPII)
E700-E183 RD-14 F718-E159 BK-18 998-E3 BK-18 M756-E52 YL-SHD
DIGITAL REFERENCE 66 3 THERMOCOUPLE R993-E101 BK-18 2 BK-18 3E3382 1698670 1656634 CONNECTOR
E998-E184 BK-14 F719-E25 BK-18 999-E14 WH-18 CBL-A2 BK-4 M755-E56 GN-SHD
67 A403-E115 BK-18 CBL-AC1 BK-0000 CONNECT TO NEGATIVE(-) A229-E38 BK-16 4 CONNECTOR RD-18
1 497-EA1 RD-18 A +V H# CIRCUIT GROUPING DESIGNATION
68 F720-E173 BK-18 A701-E120 RD-18 TERMINAL OF STARTER MOTOR CBL BK-00 M757-E60 BK-SHD 5 BK-18
WHEN USED 2 A403-EA2 BK-18 B GROUND
DROOP SPEED SIGNAL 69 F722-E30 BK-18 A703-E124 RD-18 314-E158 PU-8 6
PLUG INTO 3 846-EA3 WH-18 C GN-18 ALARM
70 F722-E30 BK-18 A705-E128 RD-18 CONNECT TO POSITIVE(+) 7 ATCH WIRE, CABLE, COMPONENT
E-C38 4
A707-E132 RD-18 TERMINAL OF STARTER MOTOR CBL RD-00 CBL BK-00 8 5
G S C465-E161 RD-10 MOTOR PRELUBE MOTOR
F723-E62 PK-18 A709-E136 RD-18 6
CIRCUIT CONNECTED
E-C31 POS NEG POS NEG 200-E162 BK-10 3T7583
F724-E63 PU-18 A711-E140 RD-18
GENERATOR HARNESS F725-E92 WH-18 A713-E144 RD-18 STARTER 2 MTR BAT CBL-AA1 BK-0000 E-C16 SPLICE
CONNECTOR 8T9834 1698670 FOR USE WITH EMCP III
F732-E19 WH-18 A715-E148 RD-18 2071562 E-C38
1 BATTERY 1 BATTERY 2 A OR-18 +V LEFT TURBO INLET EXHAUST EC-C1
GENERATOR HARNESS LH MPU SHIELD 838-E119 BK-SHD F737-E91 WH-18 A721-E121 BK-18 MOTOR A700-E105 RD-18 1552273
LH MPU COMMON 2 838-E117 GN-SHD A723-E125 BK-18 CUSTOMER SUPPLIED A235-E106 BK-18 B BK-18 GROUND TEMPERATURE SENSOR 3E3382
CONNECTOR PINOUT LH MPU SIGNAL 3 838-E118 YL-SHD G429-E113 WH-18 A725-E129 BK-18 NOTE C F703-E107 WH-18 C WH-18 SIGNAL 1637882
497-E114 RD-18 1
DESCRIPTIONS: A403-E115 BK-18 2 COOLANT 1
AUXILIARY POWER 4
5
101-E12 RD-14 G701-E29 BK-16 A727-E133 BK-18
E-C17 846-E116 WH-18 3 LEVEL WHEN USED 2 EC-C2
1698670
COOLANT LEVEL SENSOR (EMCPIII)
1656634
COLOR ABBREVIATIONS
AUXILIARY POWER 101-E13 RD-14 A729-E137 BK-18 CBL-AC1 BK-0000 4 PLUG INTO 3
1552269 C700-E174 RD-18 CONNECTOR
ENGINE OIL TEMP SENSOR- A
ENGINE OIL TEMP SENSOR- B
6
7
T800-E111 RD-18
G429-E113 WH-18
G705-E55 GN-18 A731-E141 BK-18
A733-E145 BK-18 382-E179 RD-18 1 WH-18 ETHER SOLENOID 1
E998-E176 BK-18 5 E-C38 4 C700-EC1 RD-18 A RD-18 +V ABBREV COLOR
E967-E177 WH-18 6 5 E998-EC2 BK-18 B BK-18 GROUND
ENGINE OIL TEMP SENSOR- C 8 T998-E112 BK-18 H401-E169 RD-18 A735-E149 BK-18 383-E181 BK-18 2 BU-18 2358824 6 E967-EC3 WH-18 C YL-18 SIGNAL RD RED
ETHER AUTO/MANUAL 9 F720-E173 BK-18 H401-E170 RD-18 C465-E161 RD-10
COOLANT LEVEL SENSOR- A 10 497-E114 RD-18 C700-E174 RD-18 WH WHITE
COOLANT LEVEL SENSOR- B 11 A403-E115 BK-18 M755-E42 YL-SHD E795-E104 WH-18 E-C28 F-C2 F-C1
COOLANT LEVEL SENSOR- C 12 846-E116 WH-18 M755-E50 YL-SHD E967-E177 WH-18 E-C48 1552272 3E3376 3E3370
OR ORANGE
CAT DATA LINK + 13 893-E27 GN-18 M755-E47 YL-SHD E998-E176 BK-18 1552269
996-E64 RD-18 1 996-F1 RD-18 A OR-18 +V SPEED/TIMING SENSOR
YL YELLOW
CAT DATA LINK - 14 892-E40 BR-18 E-S2 M755-E52 YL-SHD F701-E153 RD-18 382-E180 RD-18 1 WH-18 ETHER SOLENOID 2 NOTE B
998-E3 BK-18 2 998-F2 BK-18 B BK-18 GROUND
DIGITAL REFERENCE 15 E998-E186 BK-14 M755-E53 YL-SHD F704-E110 WH-18 383-E182 BK-18 2 BU-18 2358824
999-E14 WH-18 3 999-F3 WH-18 C WH-18 SIGNAL
1296628 PK PINK
START/RUN/STOP 16 F716-E23 BK-18 M756-E43 GN-SHD F713-E102 WH-18 F732-E19 WH-18 4 BK BLACK
SHUTDOWN D 17 F719-E25 BK-18 M756-E48 GN-SHD F714-E103 WH-18
KEYSWITCH 18 113-E15 RD-18 M756-E54 GN-SHD F718-E159 BK-18
19 E-S3
GY GRAY
SHUTDOWN C F715-E24 BK-18 M756-E56 GN-SHD F723-E62 PK-18
20 M756-E57 GN-SHD F724-E63 PU-18 G-C1 G-C2 PU PURPLE
RATED SPEED 21 F702-E20 BK-18 E-S1 F732-E19 WH-18 3E3376 3E3370
DROOP SPEED 22 F722-E30 BK-18 M757-E44 BK-18 M757-E46 BK-SHD G429-E113 WH-18 1
G-S2
A
BR BROWN
996-G1 RD-18 G-S1 996-G5 RD-18 PRIMARY
AIR SHUTOFF TIMER/ENGINE SHUTDOWN 23 354-E1 RD-18 M757-E45 BK-18
STARTER MOTOR MAG CONTROL 24 F701-E152 RD-18 H401-E168 RD-18
2 998-G2 BK-18 998-G6 BK-18 B SPEED/TIMING GN GREEN
3 999-G3 WH-18 999-G3 WH-18 C SENSOR
SHUTDOWN NOTIFY POWER 25 E798-E31 RD-18 M757-E49 BK-SHD 4 BU BLUE
F732-G4 WH-18
SHUTDOWN NOTIFY RETURN 26 E797-E32 BK-18 M757-E58 BK-SHD G-C3
A STARTER SOLENOID DRIVE +
AIR SHUTOFF TIMER/ENGINE SHUTDOWN
27
28
G701-E29 BK-16
354-E2 RD-18 M757-E61 BK-SHD
E-S4 M757-E60 BK-SHD H401-E169
H401-E170
RD-18
RD-18
NOTE C 3E3370 A
996-G7 RD-18 A SECONDARY
PRELUBE MAG CONTROL 29 F705-E160 RD-18 M975-E68 WH-18 B
998-G8 BK-18 SPEED/TIMING
PRELUBE PUMP DRIVE + 30 G705-E55 GN-18 M975-E68 WH-18 R800-E108 RD-18 C
FOR USE WHEN 2 F732-G4 WH-18 SENSOR
31 R800-E108 RD-18 R993-E98 BK-18 SPEED/TIMING SENSORS
32 R993-E99 BK-18 ARE USED
33 R993-E98 BK-18 R993-E100 BK-18
34 E-S15 R993-E101 BK-18
CAN DATA LINK + 35 M756-E53 YL-SHD R993-E94 BK-18 R993-E99 BK-18 R997-E95 RD-18
CAN DATA LINK -
BATTERY -
36
37
M755-E57 GN-SHD
102-E18 BK-14
R993-E100 BK-18
R993-E101 BK-18
R997-E96
R997-E97
RD-18
RD-18
THIS SCHEMATIC IS FOR THE 3500B AND 3500C GENERATOR SET ENGINE ELECTRICAL SYSTEM
CAN DATA LINK SHIELD
BATTERY -
38
39
M757-E61 BK-SHD
102-E16 BK-14 R997-E95 RD-18
R998-E109
T800-E111
BK-18
RD-18
MEDIA NUMBER: RENR7885-07
40
BATTERY - 102-E17 BK-14
R997-E93 RD-18
E-S14
R997-E96 RD-18
T998-E112 BK-18
SCHEMATIC PART NUMBER: 237-9000, CHANGE: 03, VERSION: -
R997-E97 RD-18 Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
R998-E109 BK-18
in neutral and with parking brake set.
T800-E111 RD-18 Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
T998-E112 BK-18
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.

7 6 5 4 3 2 1
 FRONT AND REAR VIEW
VIEW ALL CALLOUTS

COOLANT TEMPERATURE
SENSOR
E-C11

RIGHT TURBO INLET

LEFT TURBO INLET PRESSURE SENSOR
PRESSURE SENSOR E-C32
FILTERED OIL E-C27
PRESSURE SENSOR
E-C14
ATMOSPHERIC
PRESSURE SENSOR
E-C7
TURBO OUTLET
PRESSURE SENSOR
E-C6

AFTERCOOLER
TEMPERATURE SENSOR
E-C10
ELECTRONIC CONTROL
MODULE (ECM) E-C2
ELECTRONIC CONTROL
MODULE (ECM) E-C1
CAN DATA LINK
TERMINATING
RESISTOR
E-C8 & E-C9
LEFT MAGNETIC
PICKUP GENERATOR
E-C29 HARNESS
CONNECTOR
E-C31
FRONT VIEW REAR VIEW
 LEFT SIDE VIEW
VIEW ALL CALLOUTS

LEFT AIR SHUTOFF SWITCH

CONNECTOR LEFT TURBO INLET
E-C18 PRESSURE
LEFT TURBO SENSOR
INLET EXHAUST LEFT AIR SHUTOFF E-C27
TEMPERATURE SOLENOID
FILTERED OIL SENSOR
PRESSURE E-C16
FILTERED FUEL SENSOR
PRESSURE E-C14
SENSOR
E-C12

UNFILTERED
FUEL
PRESSURE
SENSOR
E-C13
UNFILTERED OIL
PRESSURE SPEED/TIMING
SENSOR CONNECTOR
E-C15 E-C28
AFTERCOOLER
TEMPERATURE SPEED/TIMING
SENSOR SENSOR
E-C10 F-C1 OR G-C2

ELECTRONIC
CONTROL
MODULE (ECM)
STARTER 2
SERVICE
CONNECTOR
E-C4
STARTER 1
SEPARATE CIRCUIT
AFTERCOOLER
COOLANT LEVEL
CONNECTOR
E-C47 ETHER SOLENOID 2
THERMOCOUPLE E-C48
POWER DISTRIBUTION BOX
CONNECTOR
E-C3
ETHER SOLENOID 1
E-C17
 REAR VIEW OF POWER DISTRIBUTION BOX
VIEW ALL CALLOUTS

AIR SHUTOFF STARTER MOTOR

CIRCUIT BREAKER MAGNETIC SWITCH (SMMS)
PRELUBE CIRCUIT BREAKER
RELAY PRELUBE
AUXILIARY
ALTERNATOR CIRCUIT BREAKER CIRCUIT BREAKER
CIRCUIT BREAKER
ELECTRONIC CONTROL MODULE
(ECM) CIRCUIT BREAKER
ELECTRONIC CONTROL MODULE
AIR SHUTOFF (ECM) RELAY
TIMER
STARER MOTOR
MAGNETIC SWITCH
AIR SHUTOFF (SMMS) 1 RELAY
RELAY
STARER MOTOR
MAGNETIC SWITCH
GROUND STUD (SMMS) 2 RELAY

TO
ALTERNATOR
POWER
STUD

TO
STARTER
 RIGHT SIDE VIEW
VIEW ALL CALLOUTS

RIGHT AIR
SHUTOFF SWITCH RIGHT TURBO
RIGHT AIR
CONNECTOR INLET EXHAUST
SHUTOFF SOLENOID
E-C33 TEMPERATURE
RIGHT TURBO
INLET PRESSURE SENSOR E-C35
SENSOR E-C32
CRANKCASE PRESSURE
SENSOR E-C36
COOLANT LEVEL
SENSOR E-C38

GENERATOR
HARNESS
CONNECTOR
E-C31

ENGINE OIL
TEMPERATURE
CONNECTOR E-C30

TIMING CALIBRATION
CONNECTOR E-C5
AIR START SOLENOID
CONNECTOR E-C34
PRELUBE PRESSURE
SWITCH E-C37

PRELUBE MOTOR
CONNECTOR & SPLICE LOCATIONS & CONNECTOR TABLES
DT
CONNECTOR TABLE E-C33
CLR-GA
WIRE NAME POS TERM/PLUG
RD-18
H401-E170 1 8T-8729
RD-18
H401-E168 2 8T-8729
ACCESSORY TABLE DT CONNECTOR TABLE E-C5
E-T5
(852-RD) E-C33 QTY PART NAME P/N CLR-GA WIRE NAME POS TERM/PLUG
DT CONNECTOR TABLE E-C38 RIGHT AIR RIGHT AIR
SHUTOFF 1 R E C E P TA C L E A S . 3E-3364 PK-18 F723-E62 1 8T-8730
SHUTOFF
CLR-GA WIRE NAME POS TERM/PLUG SWITCH 1 PLUG AS. 155-2269 PU-18 F724-E63 2 8T-8730
SOLENOID
RD-18 497-E114 1 8T-8730 E-T7 1 WEDGE 3E-3365 MATING
PRELUBE MATING
BK-18 A403-E115 2 8T-8730 DT CONNECTOR TABLE E-C37 (C465-RD) MOTOR CONNECTOR
E-T6 CONNECTOR
CLR-GA WIRE NAME POS TERM/PLUG DT CONNECTOR TABLE E-C35
WH-18 846-E116 3 8T-8730 (200-BK) E-C34
BK-18 F718-E159 1 8T-8730 E-T8 CLR-GA WIRE NAME POS TERM/PLUG
RD-18 C700-E174 4 8T-8730 AIR START
(200-BK) E-C36 RD-18 R800-E108 A 8T-8730 DT CONNECTOR TABLE E-C30
BK-18 E998-E176 5 8T-8730 BK-18 R993-E101 2 8T-8730 E-C5 SOLENOID SUR SL CONNECTOR TABLE E-C34
CRANKCASE TIMING
PRESSURE SENSOR BK-18 R998-E109 B 8T-8730 CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG
WH-18 E967-E177 6 8T-8730 E-C37 CALIBRATION
PRELUBE PRESSURE WH-18 F704-E110 C 8T-8730 RD-18 F701-E153 1 7N-7779 RD-18 T800-E111 1 8T-8730
ACCESSORY TABLE CONNECTOR
SWITCH E-C35 BK-18 200-E156 2 7N-7779 BK-18 T998-E112 2 8T-8730
QTY PART NAME P/N MATING DT CONNECTOR TABLE E-C36
RIGHT TURBO ACCESSORY TABLE WH-18 G429-E113 3 8T-8730
1 PLUG AS. 155-2273 CONNECTOR CLR-GA WIRE NAME POS TERM/PLUG INLET EXHAUST
1 RECEPTACLE AS. 3E-3382 TEMPERATURE QTY PART NAME P/N RD-18 997-E59 4 8T-8730
RD-18 R997-E97 A 8T-8730
1 WEDGE 155-2263 1 PLUG AS. 7N-9737 BK-18 993-E67 5 8T-8730
BK-18 R993-E100 B 8T-8730
1 CLIP AS 3T-3048 WH-18 M975-E68 6 8T-8730
AMP CONNECTOR TABLE E-C1 DRC CONNECTOR TABLE E-C2 E-C38 WH-18 E795-E104 C 8T-8730
COOLANT ACCESSORY TABLE
CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG LEVEL NOTE A QTY PART NAME P/N
1 9G-3695 RD-18 A701-E120 1 8T-8730 SENSOR E-C46 1 PLUG AS. 155-2273
E-C39 E-C43 E-C44 E-C45 CYL #15
RD-18 997-E65 2 8T-8730 BK-18 A721-E121 2 8T-8730 DT CONNECTOR TABLE E-C12 DT CONNECTOR TABLE E-C15 CYL #1 E-C40 CYL #9 NOTE B CYL #11 CYL #13 1 WEDGE 155-2263
BK-18 993-E66 3 8T-8730 RD-18 A702-E122 3 8T-8730 CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG CYL #3 E-C41 E-C42
CYL #5 CYL #7 DT CONNECTOR TABLE E-C45 DT CONNECTOR TABLE E-C27
RD-18 A700-E105 4 8T-8730 BK-18 A722-E123 4 8T-8730 RD-18 997-E75 A 8T-8730 RD-18 997-E73 A 8T-8730 DT CONNECTOR TABLE E-C39 E-S15
DT CONNECTOR TABLE E-C41 DT CONNECTOR TABLE E-C43 CLR-GA WIRE NAME POS TERM/PLUG E-C30 CLR-GA WIRE NAME POS TERM/PLUG
BK-18 A235-E106 5 8T-8730 RD-18 A715-E148 5 8T-8730 BK-18 993-E83 B 8T-8730 BK-18 993-E81 B 8T-8730 CLR-GA WIRE NAME POS TERM/PLUG
CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG RD-18 A713-E144 1 8T-8730 ENGINE OIL RD-18 R997-E95 A 8T-8730
WH-18 A751-E85 6 8T-8730 BK-16 G701-E29 6 8T-8730 WH-18 F725-E92 C 8T-8730 WH-18 E796-E90 C 8T-8730 RD-18 A701-E120 1 8T-8730 TEMPERATURE
RD-18 A705-E128 1 8T-8730 RD-18 A709-E136 1 8T-8730 BK-18 A733-E145 2 8T-8730 E-S14
WH-18 C941-E88 7 8T-8730 7 9G-3695 BK-18 A721-E121 2 8T-8730 SENSOR BK-18 R993-E98 B 8T-8730
DT CONNECTOR TABLE E-C13 DT CONNECTOR TABLE E-C14 BK-18 A725-E129 2 8T-8730 BK-18 A729-E137 2 8T-8730 WH-18 F713-E102 C 8T-8730
GN-18 893-E26 8 8T-8730 8 9G-3695 DT CONNECTOR TABLE E-C46
CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG DT CONNECTOR TABLE E-C40
BR-18 892-E39 9 8T-8730 9 9G-3695 DT CONNECTOR TABLE E-C42 DT CONNECTOR TABLE E-C44 CLR-GA WIRE NAME POS TERM/PLUG E-C32 DT CONNECTOR TABLE E-C29
RD-18 997-E74 A 8T-8730 RD-18 997-E72 A 8T-8730 CLR-GA WIRE NAME POS TERM/PLUG
BK-18 F702-E20 10 8T-8730 RD-18 382-E171 10 8T-8730 CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG RD-18 A715-E148 1 8T-8730 RIGHT TURBO CLR-GA WIRE NAME POS TERM/PLUG
BK-18 993-E82 B 8T-8730 BK-18 993-E80 B 8T-8730 RD-18 A703-E124 1 8T-8730 INLET PRESS
WH-18 F703-E107 11 8T-8730 11 9G-3695 RD-18 A707-E132 1 8T-8730 RD-18 A711-E140 1 8T-8730 BK-18 A735-E149 2 8T-8730 E-S12 YL-SHD 838-E118 1 8T-8730
WH-18 F737-E91 C 8T-8730 WH-18 994-E89 C 8T-8730 BK-18 A723-E125 2 8T-8730 SENSOR E-S13
WH-18 F704-E110 12 8T-8730 GN-18 G705-E55 12 8T-8730 BK-18 A727-E133 2 8T-8730 BK-18 A731-E141 2 8T-8730 GN-SHD 838-E117 2 8T-8730
E-C15 DT CONNECTOR TABLE E-C32
WH-18 F732-E19 13 8T-8730 RD-16 F708-E163 13 8T-8730 UNFILTERED E-C11 DT CONNECTOR TABLE E-C11
ACCESSORY TABLE CLR-GA WIRE NAME POS TERM/PLUG DRC CONNECTOR TABLE E-C31
14 9G-3695 RD-18 A705-E128 14 8T-8730 OIL PRESSURE COOLANT CLR-GA WIRE NAME POS TERM/PLUG NOTE : THE ACCESSORY TABLE TO THE LEFT
E-C12 SENSOR TEMPERATURE QTY PART NAME P/N RD-18 R997-E96 A 8T-8730 E-C31 CLR-GA WIRE NAME POS TERM/PLUG
BK-18 E996-E185 15 8T-8730 BK-18 A725-E129 15 8T-8730 RD-18 997-E76 A 8T-8730 APPLIES TO CONNECTORS E-C19 THRU 26 GENERATOR
FILTERED SENSOR 1 PLUG AS. 155-2269 AND CONNECTORS E-C39 THRU 46. IT ALSO BK-18 R993-E99 B 8T-8730 BK-SHD 838-E119 1 8T-8730
WH-18 994-E89 16 8T-8730 RD-18 A706-E130 16 8T-8730 FUEL PRESSURE BK-18 993-E84 B 8T-8730 HARNESS
1 WEDGE 155-2261 APPLIES TO CONNECTORS E-C5, E-C29, E-C37 & E-C48 . WH-18 F714-E103 C 8T-8730 CONNECTOR GN-SHD 838-E117 2 8T-8730
WH-18 E796-E90 17 8T-8730 BK-18 A726-E131 17 8T-8730 SENSOR E-C14 WH-18 C941-E88 C 8T-8730
RD-18 R997-E93 18 8T-8730 BK-18 A735-E149 18 8T-8730 E-C13 FILTERED YL-SHD 838-E118 3 8T-8730
DT CONNECTOR TABLE E-C23 DT CONNECTOR TABLE E-C25 E-C29
UNFILTERED OIL PRESSURE DT CONNECTOR TABLE E-C19 DT CONNECTOR TABLE E-C21 RD-14 101-E12 4 126-1768
19 9G-3695 19 9G-3695 FUEL PRESSURE SENSOR CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG LEFT MAGNETIC
BK-18 F720-E173 20 8T-8730 BK-18 383-E172 20 8T-8730 SENSOR CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG PICKUP RD-14 101-E13 5 126-1768
RD-18 A710-E138 1 8T-8730 RD-18 A714-E146 1 8T-8730 E-C27
BK-18 F716-E21 21 8T-8730 21 9G-3695 RD-18 A702-E122 1 8T-8730 RD-18 A706-E130 1 8T-8730 LEFT TURBO RD-18 T800-E111 6 8T-8730
BK-18 A730-E139 2 8T-8730 BK-18 A734-E147 2 8T-8730
E-C7 E-S10 BK-18 A722-E123 2 8T-8730 BK-18 A726-E131 2 8T-8730 INLET PRESSURE WH-18 G429-E113 7 8T-8730
BK-18 F716-E22 22 8T-8730 22 9G-3695 SENSOR
ATMOSPHERIC DT CONNECTOR TABLE E-C24 DT CONNECTOR TABLE E-C26 BK-18 T998-E112 8 8T-8730
BK-18 F715-E24 23 8T-8730 23 9G-3695 PRESSURE SENSOR DT CONNECTOR TABLE E-C20 DT CONNECTOR TABLE E-C22
WH-18 F725-E92 24 8T-8730 RD-18 A709-E136 24 8T-8730 CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG BK-18 F720-E173 9 8T-8730
E-C6 E-S9 CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG
WH-18 F737-E91 25 8T-8730 BK-18 A729-E137 25 8T-8730 RD-18 A712-E142 1 8T-8730 RD-18 A716-E150 1 8T-8730 RD-18 497-E114 10 8T-8730
TURBO OUTLET RD-18 A704-E126 1 8T-8730 RD-18 A708-E134 1 8T-8730
WH-18 M975-E68 26 8T-8730 RD-18 A716-E150 26 8T-8730 BK-18 A732-E143 2 8T-8730 BK-18 A736-E151 2 8T-8730 BK-18 A403-E115 11 8T-8730
PRESSURE SENSOR BK-18 A724-E127 2 8T-8730 BK-18 A728-E135 2 8T-8730
27 9G-3695 BK-18 A736-E151 27 8T-8730 E-C24 WH-18 846-E116 12 8T-8730
E-C19 E-C20 E-C21 E-C22 E-C23 E-C25 E-C26
BK-18 F719-E25 28 8T-8730 BK-18 E797-E32 28 8T-8730 CYL #2 CYL #4 CYL #6 CYL #8 CYL #10 CYL #12 CYL #14 CYL #16 GN-18 893-E27 13 8T-8730
29 9G-3695 29 9G-3695 DT CONNECTOR TABLE E-C6 BR-18 892-E40 14 8T-8730
WH-18 E967-E177 30 8T-8730 30 9G-3695 CLR-GA WIRE NAME POS TERM/PLUG E-C10 NOTE B NOTE A BK-14 E998-E186 15 126-1768
AFTERCOOLER E-S3 BK-18 F716-E23 16 8T-8730
31 9G-3695 31 9G-3695 RD-18 997-E71 A 8T-8730 TEMPERATURE SENSOR
32 9G-3695 RD-18 A713-E144 32 8T-8730 BK-18 993-E79 B 8T-8730 BK-18 F719-E25 17 8T-8730
WH-18 999-E14 33 8T-8730 BK-18 A733-E145 33 8T-8730 WH-18 A746-E87 C 8T-8730 E-S2 E-S8 RD-18 113-E15 18 8T-8730
E-S5 E-S4 E-S7
GN-SHD M755-E43 34 8T-8730 RD-18 A710-E138 34 8T-8730 E-S6 E-S17 E-C16 BK-18 F715-E24 19 8T-8730
DT CONNECTOR TABLE E-C7 E-C47 E-S18 E-S16 LEFT 20 9G-3695
BK-18 R993-E94 35 8T-8730 BK-18 A730-E139 35 8T-8730 SEPARATE CIRCUIT E-C28
CLR-GA WIRE NAME POS TERM/PLUG TURBO SPEED/TIMING BK-18 F702-E20 21 8T-8730
36 9G-3695 WH-18 A746-E87 36 8T-8730 E-C4 AFTERCOOLER E-C3 INLET
RD-18 997-E70 A 8T-8730 COOLANT LEVEL NOTE X CONNECTOR BK-18 F722-E30 22 8T-8730
37 9G-3695 WH-18 A747-E86 37 8T-8730 SERVICE THERMOCOUPLE NOTE V EXHAUST
BK-18 993-E78 B 8T-8730 CONNECTOR CONNECTOR CONNECTOR TEMP RD-18 354-E1 23 8T-8730
38 9G-3695 WH-18 F713-E102 38 8T-8730
WH-18 A747-E86 C 8T-8730 DT CONNECTOR TABLE E-C28
39 9G-3695 WH-18 F714-E103 39 8T-8730 RD-18 F701-E152 24 8T-8730
DT CONNECTOR TABLE E-C8 DT CONNECTOR TABLE E-C3 E-C17 E-C48 CLR-GA WIRE NAME POS TERM/PLUG
PU-18 F724-E63 40 8T-8730 RD-18 A703-E124 40 8T-8730 E-C2 OR P2 ETHER RD-18 E798-E31 25 8T-8730
DT CONNECTOR TABLE E-C10 CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG ETHER NOTE W E-C18 RD-18 996-E64 1 8T-8730
PK-18 F723-E62 41 8T-8730 BK-18 A723-E125 41 8T-8730 ELECTRONIC SOLENOID #1 SOLENOID #2 LEFT AIR BK-18 E797-E32 26 8T-8730
CLR-GA WIRE NAME POS TERM/PLUG CONTROL MODULE E-C8 YL-SHD M756-E47 A 8T-8730 RD-16 155-E35 1 8T-8730 BK-18 998-E3 2 8T-8730
CAN DATA GN-SHD M755-E48 SHUTOFF BK-16 G701-E29 27 8T-8730
BK-18 M757-E44 42 8T-8730 RD-18 A704-E126 42 8T-8730 RD-18 997-E69 A 8T-8730 (ECM) B 8T-8730 YL-SHD M756-E52 2 8T-8730 MATING SWITCH
LINK MATING WH-18 999-E14 3 8T-8730
RD-18 996-E64 43 8T-8730 BK-18 A724-E127 43 8T-8730 BK-18 993-E77 B 8T-8730 CONNECTOR NOTE Z RD-18 354-E2 28 8T-8730
BK-SHD M757-E49 C 8T-8730 GN-SHD M755-E56 3 8T-8730 CONNECTOR WH-18 F732-E19 4 8T-8730
44 9G-3695 44 9G-3695 WH-18 A751-E85 C 8T-8730 E-C1 OR P1 E-S1 RD-18 F705-E160 29 8T-8730
BK-16 A229-E38 4 8T-8730 ACCESSORY TABLE
45 9G-3695 45 9G-3695 ELECTRONIC DT CONNECTOR TABLE E-C9 GN-18 G705-E55 30 8T-8730
BK-SHD M757-E60 5 8T-8730 QTY PART NAME P/N
CONTROL MODULE E-C9 CLR-GA WIRE NAME POS TERM/PLUG 31 9G-3695
46 9G-3695 WH-18 E795-E104 46 8T-8730 (ECM) 6 9G-3695
CAN DATA LINK YL-SHD M756-E42 A 8T-8730 E-T2 1 PLUG AS. 155-2272
47 9G-3695 47 9G-3695 E-M29 E-T1 32 9G-3695
7 9G-3695 (200-BK) 1 WEDGE 155-2262
GN-SHD M755-E43 B 8T-8730 E-T30 (F708-RD) 33 9G-3695
48 9G-3695 RD-18 A707-E132 48 8T-8730 8 9G-3695 (F708-RD) LEFT AIR (852-RD)
49 9G-3695 BK-18 A727-E133 49 8T-8730 BK-SHD M757-E46 C 8T-8730 E-M28 SHUTOFF 34 9G-3695
DT CONNECTOR TABLE E-C16 ACCESSORY TABLE E-T17 E-M16 (852-RD)
ACCESSORY TABLE SOLENOID YL-SHD M756-E53 35 8T-8730
YL-SHD M756-E42 50 8T-8730 RD-18 A708-E134 50 8T-8730 QTY PART NAME P/N (H401-RD) (354-RD) E-T4
CLR-GA WIRE NAME POS TERM/PLUG QTY PART NAME P/N E-T9 (314PU) GN-SHD M755-E57 36 8T-8730
BK-18 998-E3 51 8T-8730 BK-18 A728-E135 51 8T-8730 1 PLUG AS. 155-2264 (200-BK) NOTE Y
RD-18 A700-E105 A 8T-8730 1 PLUG AS. 169-8670 STARTER #2 BK-14 102-E18 37 126-1768
RD-14 150-E4 52 126-1768 RD-18 A712-E142 52 8T-8730 1 RECEPTACLE AS. 3E-3388 E-M25
BK-18 A235-E106 B 8T-8730 1 RECEPTACLE AS 133-0970 (F701-RD) E-T31 BK-SHD M757-E61 38 8T-8730
RD-14 150-E6 53 126-1768 53 9G-3695 1 WEDGE 155-2259
WH-18 F703-E107 C 8T-8730 1 PLUG AS 174-3016 E-T22 (354-RD) E-M13 BK-14 102-E16 39 126-1768
54 9G-3695 BK-18 R998-E109 54 8T-8730 ( 102-BK )
1 WEDGE 155-2266 HD10 CONNECTOR TABLE E-C4 (F701-RD)
RD-14 150-E5 55 126-1768 55 9G-3695 DT CONNECTOR TABLE E-C17 E-T3 BK-14 102-E17 40 126-1768
NOTE A: CONNECTORS AND WIRES ARE NON EXISTENT
RD-18 H401-E169 56 8T-8730 RD-18 R800-E108 56 8T-8730 CLR-GA WIRE NAME POS TERM/PLUG CLR-GA WIRE NAME POS TERM/PLUG (304-WH) ACCESSORY TABLE ON THE 3512 AND 3508 ENGINES.
DT CONNECTOR TABLE E-C47 STARTER # 1
RD-16 155-E34 A 8T-8729 E-T27 QTY PART NAME P/N
RD-16 155-E33 57 8T-8730 RD-18 C700-E174 57 8T-8730 RD-18 382-E179 1 8T-8730 CLR-GA WIRE NAME POS TERM/PLUG (F705-RD) E-T24 NOTE B: CONNECTORS AND WIRES ARE NON EXISTENT
58 9G-3695 RD-18 A711-E140 58 8T-8730 BK-18 383-E181 2 8T-8730 BK-16 A229-E37 B 8T-8729 (304-WH) E-T11 1 PLUG AS. 8T-9834 ON THE 3508 ENGINES.
RD-14 E700-E183 A 126-1768
BK-SHD M757-E58 C 8T-8729 E-T21 ( 200-BK ) 1 BOOT 6I-4348 NOTE E: HARNESSES 341-0609, 341-0608 & 341-0607 HAVE DT
59 9G-3695 BK-18 A731-E141 59 8T-8730 ACCESSORY TABLE BK-14 E998-E187 B 126-1768
GN-18 893-E28 D 8T-8729 (314-PU) CONNECTORS REPLACED WITH AMP SEAL CONNECTORS
BK-18 M757-E45 60 8T-8730 RD-18 A714-E146 60 8T-8730 QTY PART NAME P/N BK-18 E996-E185 C 8T-8730 E-M14
E-T26 (229-BK) DT CONNECTOR TABLE E-C18 FOR: E-C6, E-C7, E-C12, E-C13, E-C14, E-C15, E-C27, E-C32 AND E-C36.
61 9G-3695 BK-18 A734-E147 61 8T-8730 1 PLUG AS. 155-2269 BR-18 892-E41 E 8T-8729 (C465-RD) E-T10
ACCESSORY TABLE (200-BK) CLR-GA
WIRE NAME POS TERM/PLUG NOTE V: THIS HARNESS BREAKOUT MOVES TO A LOCATION
62 9G-3695 BK-18 A732-E143 62 8T-8730 GN-SHD M755-E54 F 8T-8729 E-M19 E-S11
2 PLUG 9G-3695 QTY PART NAME P/N (101-RD) RD-18H401-E168 1 8T-8729 NEAR THE E-C22 BREAKOUT IN THE 237-9014 HARNESS.
YL-SHD M756-E50 G 8T-8729 E-T12
BK-14 229-E8 63 126-1768 63 9G-3695 1 WEDGE 155-2261 1 PLUG AS. 169-8670 (200-BK) IT MOVES TO A LOCATION NEAR THE E-C21 BREAKOUT IN THE
E-T18 RD-18H401-E169 2 8T-8729 237-9010 HARNESS.
64 9G-3695 64 9G-3695 H 9G-3695 E-T15
1 RECEPTACLE AS. 3E-3370 (798-RD) ACCESSORY TABLE
J 9G-3695 (150-RD) NOTE W: THIS HARNESS BREAKOUT MOVES TO A LOCATION
BK-14 229-E9 65 126-1768 RD-14 E700-E183 65 126-1768 1 WEDGE 155-2276 QTY PART NAME P/N
NOTE : THE ACCESSORY TABLE BELOW ACCESSORY TABLE NEAR THE E-C22 BREAKOUT IN BOTH THE 237-9014 HARNESS
BK-18 F718-E159 66 8T-8730 BK-14 E998-E184 66 126-1768 1 RECEPTACLE AS. 3E-3364 AND THE 237-9010 HARNESS.
APPLIES TO CONNECTORS E-C6 THRU 8 DT CONNECTOR TABLE E-C48 QTY PART NAME P/N
BK-14 229-E10 67 126-1768 67 9G-3695 AND CONNECTORS E-C10 THRU 16. IT ALSO 1 PLUG AS. 155-2269 NOTE X: THIS HARNESS BREAKOUT MOVES TO A LOCATION
68 9G-3695 68 9G-3695 APPLIES TO CONNECTORS E-C27, E-C32, CLR-GA WIRE NAME POS TERM/PLUG 1 RECEPTACLE AS. 8T-8736 NEAR THE E-C22 BREAKOUT IN THE 237-9014 HARNESS.
E-C35 & E-C36. 1 WEDGE 3E-3365 E-C48 DOES NOT EXIST IN THE 237-9010 HARNESS.
BK-16 A229-E36 69 8T-8730 BK-18 F722-E30 69 8T-8730 RD-18 382-E180 1 8T-8730 1 CAP-RECEPTACLE 8C-6354
ACCESSORY TABLE BK-18 383-E182 2 8T-8730 120mm HEAT SHRINK 113-7027 NOTE Y: THIS HARNESS BREAKOUT MOVES TO A LOCATION NEAR
RD-18 113-E15 70 8T-8730 70 9G-3695
QTY PART NAME P/N BETWEEN THE E-C22 AND THE E-C23 BREAKOUTS IN THE 237-9014
ACCESSORY TABLE ACCESSORY TABLE HARNESS. IT MOVES TO A LOCATION TO THE RIGHT OF THE
1 PLUG AS. 169-8670 E-C22 BREAKOUT IN THE 237-9010 HARNESS.
QTY PART NAME P/N QTY PART NAME P/N
1 WEDGE 155-2276
1 PLUG AS. 160-7690 1 PLUG AS. 147-1443 HARNESS 237-9018(3516), HARNESS 237-9014(3512) & HARNESS 237-9010(3508) NOTE Z: THIS HARNESS BREAKOUT MOVES TO A LOCATION NEAR
THE E-C24 BREAKOUT IN THE 237-9014 HARNESS. IT MOVES
HARNESS 341-0609(3516), HARNESS 341-0608(3512) & HARNESS 341-0607(3508) (NOTE E) TO A LOCATION NEAR THE E-C22 BREAKOUT IN THE 237-9010
HARNESS.