HORN
Fig. 1: Horn Circuit
POWER DOOR LOCKS
Fig. 2: Power Door Lock Circuit
POWER WINDOWS
Fig. 3: Power Windows Circuit
RADIO
Fig. 4: Radio Circuits
STARTING/CHARGING
4.9L
Fig. 5: 4.9L, Charging Circuit
Fig. 6: 4.9L, Starting Circuit
5.0L
Fig. 7: 5.0L, Charging Circuit
Fig. 8: 5.0L, Starting Circuit
5.8L
Fig. 9: 5.8L, Charging Circuit
Fig. 10: 5.8L, Starting Circuit
7.3L
Fig. 11: 7.3L, Charging Circuit
Fig. 12: 7.3L, Starting Circuit
7.5L
Fig. 13: 7.5L, Charging Circuit
Fig. 14: 7.5L, Starting Circuit
WIPER/WASHER
Fig. 15: 2-Speed Wiper/Washer Circuit
Fig. 16: Interval Wiper/Washer Circuit
PART 2
Fig. 1: Engine Compartment & Headlights (Grids 1-3)
Fig. 2: Electronic Engine Control (EEC) (4.9L) (Grids 4-7)
Fig. 3: Electronic Engine Control (EEC) (5.0L & 5.8L EFI) (Grids 8-11)
Fig. 4: Electronic Engine Control (EEC) (7.5L EFI) (Grids 12-15)
Fig. 5: Transmisssion Electronic Control Assembly (TECA) (Diesel W/ E4OD) (Grids 16-19)
Fig. 6: Fuse Block (Grids 20-23)
Fig. 7: Clutch Interlock, Cruise Control & Wiper/Washer (Grids 24-27)
Fig. 8: Instrument Cluster & A/C Heater Function (Grids 28-31)
Fig. 9: Electronic Shift Control & Passenger Compartment (Grids 32-35)
Fig. 10: Passenger Compartment & Taillights (Grids 36-39)
Fig. 1: Horn Circuit
Fig. 2: Power Door Lock Circuit
Fig. 3: Power Windows Circuit
Fig. 4: Radio Circuits
Fig. 5: 4.9L, Charging Circuit
Fig. 6: 4.9L, Starting Circuit
Fig. 7: 5.0L, Charging Circuit
Fig. 8: 5.0L, Starting Circuit
Fig. 9: 5.8L, Charging Circuit
Fig. 10: 5.8L, Starting Circuit
Fig. 11: 7.3L, Charging Circuit
Fig. 12: 7.3L, Starting Circuit
Fig. 13: 7.5L, Charging Circuit
Fig. 14: 7.5L, Starting Circuit
Fig. 15: 2-Speed Wiper/Washer Circuit
Fig. 16: Interval Wiper/Washer Circuit
PART 2
COMPONENT LOCATIONS
Component Location (Figure No.)
A/C CLUTCH RESISTOR DIODE E 30 (8)
A/C COMP CLUTCH E 29 (8)
A/C/HEATER FUNCTION SELECTOR SWITCH E 28 (8)
ALTERNATOR (DIESEL) C 2 (1)
ALTERNATOR (DIESEL, 165 AMP) D 3 (1)
ALTERNATOR (GAS) B 3 (1)
BACK-UP LIGHT SWITCH D 20 (6)
BACK-UP/NEUTRAL SAFETY SWITCH (A/T) A 26-27 (7)
BATTERY A 1 (1)
BEAM SELECT SWITCH E 20 (6)
CAB MARKER LIGHTS A 38 (10)
CARGO LIGHT D 33, E 35 (9)
CHARGE IND RELAY (DIESEL) D 2 (1)
CIGAR LIGHTER C 23 (6)
CLUTCH INTERLOCK SWITCH (M/T) A 24 (7)
CLUTCH INTERLOCK SWITCH JUMPER (A/T) B 27 (7)
CONN C300 D 33 (9)
COURTESY LIGHTS D-E 33-35 (9)
CRUISE CONTROL D-E 24-27 (7)
DIR FLASHER D 21 (6)
DIR/HAZARD SWITCH C 24-25 (7)
DISISTRIBUTOR A 7, A 11, A 15 (2) (3) (4)
DOOR SWITCHES C 33-34 (9)
DUEL BRAKE WARNING DIODE/RESISTOR B 33 (9)
E4OD TRANS E 4, E 9, E 12, E 17 (2,3,4,5)
EEC POWER RELAY A 4, A 8, A 12 (1) (3) 4)
ELECT ENGINE CONTROL (EEC) (4.9L) B-E 4 (2)
ELECT ENGINE CONTROL (EEC) (5.0L/5.8L) . B-
E 8 (3)
ELECT ENGINE CONTROL (EEC) (7.5L) B-E 12 (4)
ELECTRONIC SHIFT CONTROL MODULE A-B 35 (9)
ENGINE COMPARTMENT LIGHT A 1 (1)
FLUID LEVEL SWITCH C 32 (9)
FUEL PUMP RELAY A 5, A 9, A 13 (2) (3) (4)
FUEL TANK SELECT SWITCH (DIESEL) B-C 31 (8)
FUEL TANK SELECT SWITCH (GAS) A 31 (8)
FUEL TANK SELECT VALVE (DIESEL) B 31 (8)
FUEL TANK SENDER (DIESEL) E 37 (10)
FUEL TANK UNIT (GAS W/ DUAL TANKS) C-D 38 (10)
FUEL TANK UNIT (SINGLE TANK) E 37 (10)
FUEL WATER SWITCH D 31 (8)
FUS LINK Z A 18-19 (5)
FUS LINKS A 2-3, B-C 2, C 3 (1)
FUSE BLOCK C 21-22 (6)
GLOVE BOX LIGHT C 34 (9)
GLOW PLUG CONTROLLER B 19 (5)
HAZARD FLASHER D 24 (7)
HEATER FUNCTION SELECTOR SWITCH D 30 (8)
HEGO SENSOR C 7, C 11, C 15 (3) (4)
HORN RELAY D 25-26 (7)
HORN RELAY JUMPER E 26 (7)
IGN SUPPRESS RESISTOR B 6, B 10, B 14 (2,3,4)
IGNITION COIL A 7, A 11, B 15 (2) (3) (4)
IGNITION SWITCH A 21-23 (6)
ILLUM LIGHTS B 20 (6)
INERTIA SWITCH (DUAL TANKS) A 31 (8)
INERTIA SWITCH (SINGLE TANKS) D 38, E 38 (10)
INSTRUMENT CLUSTER A-C 28 (8)
INTERVAL GOVERNOR C 26 (7)
LEFT DOOR SWITCH C 33 (9)
LOW VACUUM WARNING (DIESEL) C 31 (8)
MAIN LIGHT SWITCH D-E 23 (6)
MANUAL LEVER POSITION SENSOR
(MLPS) B 7, B 11, B 15, C 19, A 25
(2,3,4,5,7)
MAP/DOME LIGHTS E 33, E 35 (9)
OVERDRIVE SW E 6-7,10-11,14-15, C 18 (2,3,4,5)
PARK BRAKE SWITCH B 33 (9)
POWER DOOR LOCKS C-E 32 (9)
POWER WINDOW SWITCH B-C 36-37 (10)
RABS SYSTEM A-B 32-33 (9)
RADIO (PARTIAL) C-D 35 (9)
REAR DEFOGGER SWITCH A 36 (10)
SEAT BELT SWITCH E 21 (6)
SELF TEST OUTPUT
CONNECTOR C 7, C 11, C 15, E 19 (2,3,4,5)
STARTER RELAY (DIESEL) B-C 3 (1)
STARTER RELAY (GAS) A 3 (1)
STOP LIGHT SWITCH E 24 (7)
TAILGATE WINDOW SWITCH D-E 36 (10)
TECA POWER RELAY E 19 (5)
TRAILER CONN B 39, C 39 (10)
TRAILER ELECT BRAKE CONTROL CONN C 38 (10)
TRAILER/MARKER LIGHT RELAY B 38 (10)
TRANSMISSION ELECT CONTROL ASSY
(TECA)
(DIESEL) B-E 16 (5)
VEHICLE SPEED
SENSOR B 4, B 8, B 12, A 16 (2,3,4,5)
VOLTAGE REGULATOR (DIESEL) D 2 (1)
WARNING CHIME MODULE E 22 (6)
WARNING INDS (DIESEL) D 30 (8)
WASHER MOTOR E 1 (1)
WIPER MOTOR E 1 (1)
WIPER/WASHER SWITCH (INTERVAL) D 26-27 (7)
WIPER/WASHER SWITCH (STANDARD) E 3 (1)
4WD IND SWITCH B 29-30 (8)
4WD SHIFT CONTROL SWITCH A 33-34 (9)
Fig. 1: Engine Compartment & Headlights (Grids 1-3)
1991 Ford Pickup F-Series
Fig. 2: Electronic Engine Control (EEC) (4.9L) (Grids 4-7)
1991 Ford Pickup F-Series
Fig. 3: Electronic Engine Control (EEC) (5.0L & 5.8L EFI)
(Grids 8-11)
1991 Ford Pickup F-Series
Fig. 4: Electronic Engine Control (EEC) (7.5L EFI) (Grids
12-15)
1991 Ford Pickup F-Series
Fig. 5: Transmisssion Electronic Control Assembly
(TECA) (Diesel W/ E4OD) (Grids 16-19)
1991 Ford Pickup F-Series
Fig. 6: Fuse Block (Grids 20-23)
1991 Ford Pickup F-Series
Fig. 7: Clutch Interlock, Cruise Control & Wiper/Washer
(Grids 24-27)
1991 Ford Pickup F-Series
Fig. 8: Instrument Cluster & A/C Heater Function (Grids
28-31)
1991 Ford Pickup F-Series
Fig. 9: Electronic Shift Control & Passenger Compartment
(Grids 32-35)
1991 Ford Pickup F-Series
Fig. 10: Passenger Compartment & Taillights (Grids 36-39)
1991 Ford Pickup F-Series
