GTO Series

75.4
75.4II
4 CHANNEL POWER AMPLIFIER
SERVICE MANUAL

JBL Consumer Products

250 Crossways Park Dr.
Woodbury, New York 11797 Rev4vvv3/2009

Downloaded from www.Manualslib.com manuals search engine

 Power Amplifier GTO 75.4/75.4II
- CONTENTS -

SPECIFICATIONS ………………………………….……..1
FEATURES/TEST CONDITIONS……..…………………2
INSTALLATION………………….……...……..…...…...…3
CONNECTIONS………………….……...……..…...…..…4
SET-UP/CONTROLS ……..………………..…….….…...5
INSTALLING NEON TUBES..…….…….………………..5
BASIC TROUBLESHOOTING..…….…….………………7
TYPICAL SYSTEM WIRING..…….…….……………..…8
EXPLODED VIEW/PARTS LIST…….….….…………....9
MECHANICAL PARTS LIST..…….…….…………….....10
AMPLIFIER BLOCK DIAGRAM…………………….……11
P.C.B. DRAWINGS….……………………………….…….12
ELECTRICAL PARTS LIST ..……….……….…….….…16
VERSION II ELECTRICAL PARTS LIST ADDENDUM….……….19
IC/TRANSISTOR PINOUTS..……..….…….….….….…..20
GTO 75.4 SCHEMATICS………..………………..……...23
GTO 75.4II SCHEMATICS………..……………………...26
PACKING……..…………………………………………....29

GTO 75.4/75.4II Specifications

Output Power: 104W RMS x 4 channels @ 4 ohms; ≤1% THD + N

(14.4V supply) 142W RMS x 4 channels @ 2 ohms; ≤1% THD + N
284W RMS x 2 channels @ 4 ohms; ≤1% THD + N
Signal-to-noise ratio: 80dBA (reference 1W into 4 ohms)
Dynamic power: 163W @ 2 ohms
Effective damping factor: 6.38 @ 4 ohms
Frequency response: 10Hz – 83kHz (–3dB)
Maximum input signal: 5.8V
Maximum sensitivity: GTO 75.4 - 230mV
GTO 75.4II - 75mV
DC Offset <50Mv (-50%)
Output regulation: .069dB @ 4 ohms
Idle Current 1.3A
Input Impedance 22kΩ
Max Current Draw 52A @ 4 ohms
83A @ 2 ohms
Dimensions: 15 1/8 x 12 5/16 x 2 3/8” (L x W x D)
(384mm x 313mm x 60mm)
Fuses: 30A x 2

JBL continually strives to update and improve existing products, as well as create new ones. The specifications and details in
this and related JBL publications are therefore subject to change without notice.
1
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

2
Downloaded from www.Manualslib.com manuals search engine
54 PM Page 2

GTO 75.4/75.4II

INSTALLATION

WARNING: Playing loud music in an • Before drilling or cutting holes, use a POWER CONNECTIONS Speaker Connections
automobile can hinder your ability to hear utility knife to remove unwanted fabric The GTO amplifiers are capable of Refer to the application guides on the
traffic and permanently damage your or vinyl to keep material from snagging delivering extremely high power levels, pages that follow. Speaker connections
hearing. We recommend listening at low or in a drill bit. and require a heavy-duty and reliable should be made using a minimum of
moderate levels while driving your car. JBL • When routing cables, keep input-signal connection to the vehicle’s electrical system 16-gauge wire.
accepts no liability for hearing loss, bodily cables away from power cables and in order to perform optimally. See Figure 1
injury or property damage resulting from speaker wires. for connection location. Please adhere to High-Level Input Connections
the use or misuse of this product. • When making connections, make the following instructions carefully: The GTO75.4 and GTO75.4II
certain they are secure and properly amplifiers are equipped with speaker-level
IMPORTANT: To get the best insulated. Ground Connection inputs that allow you to add an amplifier
performance from your JBL Grand Touring® Connect the amplifier’s Ground (GND) to head units that do not have RCA line
• If the amplifier’s fuse must be replaced,
Series amplifiers, we strongly recommend terminal to a solid point on the vehicle’s outputs. The speaker outputs for the
use only the same type and rating as
that installation be entrusted to a qualified metal chassis, as close to the amplifier source unit should be connected to the
that of the original. Do not substitute
professional. Although these instructions as possible. Refer to the chart below to amplifier using the supplied connector
another kind.
explain how to install GTO amplifiers in a determine minimum wire-gauge size. Scrape (square four-wire plug). Remember to
general sense, they do not show specific away any paint from this location; use a star- check for proper polarity. The GTO301.1,
installation methods that may be required CHOOSING A LOCATION type lock washer to secure the connection. GTO601.1 and GTO1201.1 amplifiers are
for your particular vehicle. If you do not AND MOUNTING THE not equipped with high-level inputs.
have the necessary tools or experience, AMPLIFIER Power Connection
do not attempt the installation yourself. Choose a mounting location in the trunk Connect a wire (see chart at right for NOTE: When using the high-level inputs,
Instead, please ask your authorized JBL or cargo area where the amplifier will not appropriate gauge) directly to the vehicle’s the AUX outputs can be used to pass a
car audio dealer about professional be damaged by shifting cargo. Amplifier positive battery terminal, and install an line-level signal to another amplifier.
installation. cooling is essential for proper amplifier appropriate fuse holder within 18" of the
operation. If the amplifier is to be installed battery terminal. Do not install the fuse at Wire Gauge Chart
INSTALLATION in an enclosed space, make sure there is this time. Route the wire to the amplifier’s Amplifier Maximum Minimum
WARNINGS AND TIPS sufficient air circulation for the amplifier location, and connect it to the amplifier’s Model Current Draw Wire Gauge
• Always wear protective eyewear when to cool itself. Positive (+12V) terminal. Be sure to use GTO75.4 85A #8 AWG
using tools. appropriate grommets whenever routing G
• Turn off the audio system and other When mounting the amplifier under a wires through the firewall or other sheet AWG
electrical devices before you start. seat, ensure that it is clear of all moving metal. Failure to adequately protect the AWG
Disconnect the (–) negative lead from seat parts and does not affect the seat positive wire from potential damage may These recommendations assume 7' – 10'
your vehicle’s battery. adjustments. Mount the amplifier so it result in a vehicle fire. When you are done wire runs. If your installation differs mark-
is not damaged by the feet of backseat routing and connecting this wire, you may edly, you will need to adjust the wire
• Check clearances on both sides of
passengers. Make sure that the amplifier install the fuse at the battery. gauge accordingly.
a planned mounting surface before
is mounted securely using nuts and bolts
drilling any holes or installing any
or the supplied mounting screws. Remote Connection
screws. Remember that the screws
can extend behind the surface. Connect the amplifier’s Remote (REM)
Mount the amplifier so that it remains terminal to the source unit’s Remote Turn- IMPORTANT NOTE: If you are planning
• At the installation sites, locate and dry – never mount an amplifier outside On lead using a minimum of 18-gauge wire. to use optional neon tubes, install them
make a note of all fuel lines, hydraulic the vehicle or in the engine compartment. before making any electrical connections
brake lines, vacuum lines and electrical
NOTE: When using the speaker level to the amplifier (refer to“Installing Neon
wiring. Use extreme caution when cut-
inputs, connect the remote (REM) terminal Tubes” on page 5).
ting or drilling in and around these areas.
to the source unit. If your source unit does
not have a remote turn-on connection,
connect the amplifier’s (REM) terminal to
Figure 1. Terminal connection end plate. the vehicle’s accessory circuit.

Downloaded from www.Manualslib.com manuals search engine

3:54 PM Page 4

GTO 75.4/75.4II

CONNECTIONS – GTO 75.4/75.4II

The GTO 75.4/75.4II can be set up for stereo
4-channel, 3-channel or bridged – +

2-channel operation, as shown in + –

Figures 6 through 8.

NOTE: For simplicity, Figures 6 through

8 do not show power, remote and input
connections.

NOTE: Minimum speaker impedance

for stereo operation is 2 ohms.
Minimum speaker impedance for
bridged operation is 4 ohms. + –

– +

Figure 6.GTO 75.4/75.4II amplifier in 4-channel (stereo) operation to drive front and rear full-range speakers.

+ –

– +

Figure 7.GTO 75.4/75.4II is set up for 3-channel operation to drive a set of full-range speakers and a subwoofer.

Figure 8.GTO 75.4/75.4II used in bridged 2-channel mode to drive a set of components or subwoofers.

Downloaded from www.Manualslib.com manuals search engine

:54 PM Page 6

GTO 75.4/75.4II
INSTALLATION AND SETUP

SETTING THE SETTING INPUT INSTALLING NEON TUBES

CROSSOVER(S) SENSITIVITY (OPTIONAL)
Determine your system plans and set the 1. Initially turn the INPUT LEVEL control(s) 1. Using a Phillips screwdriver, remove all
crossover mode switch accordingly. If you to minimum (counter clockwise). screws on the amplifier’s output/power
plan to use the GTO 75.4/75.4II to drive 2. Reconnect the (–) negative lead to the end panel and set them aside.
full-range speakers, set the crossover vehicle’s battery. Apply power to the 2. Using a 3 ⁄32-inch Allen wrench, remove
mode to FLAT and skip to “Setting Input audio system and play a dynamic music only the screws on the amplifier’s (top)
Sensitivity.” track. clear cover and set them aside.
3. On the source unit, increase the volume 3. Remove the end panel and slide the
Initially set the crossover frequency control to 3/4 volume. Slowly increase cover off. Set both parts aside.
control midway. While listening to music, the INPUT LEVEL control(s) toward three 4. Locate the enclosed hardware bag and
adjust the crossover for the least o’clock until you hear slight distortion remove the four clips. Each clip has a
perceived distortion from the speakers, in the music. Then reduce the INPUT square end and a larger round end.
allowing them to reproduce as much LEVEL slightly until distortion is no Using a round end, press two clips onto
bass as possible. longer heard. each neon tube (e.g., Street Glow AN9
or equivalent), as shown in Figure 13.
Systems using a separate subwoofer set NOTE: After the source unit is on, red LEDs 5. For each tube, align both clips so the
the crossover mode to HP (high pass) for (on the top panel) will light, indicating the square ends slide onto an exposed
your full-range speakers. Adjust the amplifier is on. If not, check the wiring, extrusion edge, as shown in Figure 9.
crossover frequency to limit bass and especially the remote connection from the Do not cover any screw holes. When
provide increased system volume with source unit. Also refer to “Troubleshooting” AUX OUTPUT installed correctly, each neon tube will
less distortion. on the next page. GTO 75.4/75.4II amplifiers are sit under an extrusion and not be visible
equipped with full-range outputs that can when viewed from directly above.
For subwoofers, choose the highest be used to connect additional amplifiers. 6. Route each neon tube’s power cable
frequency that removes vocal information through its respective NEON hole on the
from the sound of the subwoofer. NOTE: When using the high-level inputs, end panel (see Figure 13).
the AUX outputs can be used to pass a 7. Slide the cover back into place and re-
If using the GTO 75.4/75.4II to drive a line-level signal to another amplifier. install its screws. Then, replace the end
subwoofer(s), set the crossover mode to panel and reinstall its screws.
LP (low pass). 8. Finish the installation of the neon tubes
as instructed in their owner’s manual.
Figure 12.

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4/75.4II

Downloaded from www.Manualslib.com manuals search engine

GTO Amp OM 2/3/04 3:54 PM Page 7

GTO 75.4/75.4II
INSTALLATION AND SETUP

To Neon
Power
Supply

To Neon
Power
Supply

Figure 13. Installing neon tubes in a JBL GTO amplifier.

TROUBLESHOOTING

SYMPTOM LIKELY CAUSE SOLUTION SYMPTOM LIKELY CAUSE SOLUTION

No audio No voltage at BATT+ Check voltages at No audio Voltage more than 16V Check vehicle
(POWER LED or REM terminals, amplifier terminals (PROTECT or less than 8.5V on charging system for
is off) or bad or no ground with VOM LED is on) BATT+ connection defective voltage
connection regulator
No audio DC voltage on Amplifier may need Distorted audio Input sensitivity is Check INPUT
(PROTECT LED amplifier output service; see enclosed not set properly, or LEVEL setting; or
flashes every warranty card for amplifier or source check speaker wires
4 seconds) service information unit is defective for shorts or grounds
No audio Amplifier is Make sure amplifier Distorted audio Short circuit in Remove speaker leads
(PROTECT overheated cooling is not blocked and PROTECT speaker or wire one at a time to locate
LED is on) at mounting location; LED flashes shorted speaker or
verify speaker system wire, then repair
impedance is within Music lacks Speakers are not Check speaker
specified limits (see “punch” connected properly connections for
“Specifications” on proper polarity
the next page)
No audio Voltage less than 9V on Check vehicle
(PROTECT BATT+ connection charging system for
and POWER defective voltage
LEDs flash) regulator

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4/75.4II

Grand Touring

8
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II
GTO 75.4/75.4II Exploded View

1 2 3 4 5 6 7 8
9

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4/75.4II
Mechanical Parts List

10
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

GTO 75.4/75.4II BLOCK DIAGRAM

11

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4/75.4II

12
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

DST0013-00

J43 7.5m/m
J42
J29

W2 C34
ST-11A-2-8P

60m/m
WIRE
J30 TER01
7.5m/m

7.5m/m
TER02 WF-9604
7.5m/m 105(M)TL
FRONT FRONT 7.5m/m REM GND

IN4004
L/CH 7.5m/m
R/CH

D02
REAR FH01 J31 105(M)"TL" J322

10m/m
10m/m
10m/m
10m/m
J32 BJ06

J335
J334
J333
J332BJ01
J323
R262 REAR 35m/m
C01

J41
J40 7.5m/m
10m/m
10m/m
10m/m
10m/m
10m/m
10m/m

55m/m

55m/m
7.5m/m

6m/m

BJ02
680/2W 7.5m/m
680/2W 1N5404 7.5m/m

J33
D01

6m/m
7.5m/m
4.7/0.5W 104(M) 7.5m/m

R04
56K
R362 C03 104P

J300
4.7/0.5W
R261 C261 7.5m/m

R361

J39
J38
J37
J36
J35
J34
680/2W 7.5m/m
J01

12.5m/m
R462 1K J02 47

FQP50N06
R92 C3198GR R56

J336 BJ04 35m/m

4.7/0.5W Q02 J03 17.5m/mJ05
430K R63 J04
104(M) 8.2K 17.5m/mJ06

2
104(M)
R461 Q90 C3198GR

C461
R05

BJ0535m/m
C361 4.7K 2200/25"WL"

CL-310
22K A1266GR

100/16V
R91 Q11 R11
C05 Q56
680/2W R90 47K 3.9K
47 R55

FQP50N06
R12 C11
10

12.5m/m
J310
R162 17.5m/mJ07

104(M)
R15 47/16V

10m/m
10m/m
104P 17.5m/mJ08
C14 C60

J337J22
C161
J53 6m/m

L03
4.7KF

20m/m
10K
R161 A1266GR R13 R62

2
Q12 10.5KF

J21
4.7/0.5W J52 6m/m R60 Q55
24K 2200/25V"WL" 47
R21 6m/m 1SS133 C04

FQP50N06
D03 R54
J09
17.5m/m
J54 A1266GR Q33

12.5m/m
12.5m/m
12.5m/m
12.5m/m
12.5m/m
12.5m/m
12.5m/m
17.5m/m
J10

10m/m
10m/m
C12 100/16V

TL494CN
220/0.5W
20m/m J111 R51 1K
68K 220/0.5W R52 Q54

J24
J23
R25 R41 47

2
J50
J49
J48
J47
J46
J45
J44
A1266GR R53

FQP50N06
102(M) 17.5m/mJ11
C21 Q23 2200/25"WL"

51
17.5m/mJ12

J233
24K 1SS133

J
473P
R22

C32
15m/m D04 C06 7.5m/m
J55 6m/m U01 J51 7.5m/m

J2 J2726
820

1
Q53

60m/m

J
7.5m/m

4
R16
WIRE
10/16V R46

8
W1
4.7K C800 7.5m/m 47

FQP50N06
105(M)TL R02 7.5m/m 17.5m/m
A1023Y J13

10m/m
10m/m
10m/m
C3198BL Q01 17.5m/m J14
C31 Q21 4.7K

55m/m

BJ03
10K R01
55m/m

(0.7x15):(0.7x4):(0.7x1):(0.7x1)
R14
BJ07

100/16V
104P R45 Q46

J58
J57
J56
C22 47

FQP50N06
1K C13
J98 20m/m 17.5m/m J15
R31 10/0.5W
J97 20m/m 10/25V R03 17.5m/m J16
20m/m C15 22K
J320 1SS133 R32

4T:11T:8T:8T
D11 R44 Q45
33K

44PHI
R34 15K R33 47

FQP50N06
T01
15K A1268GR 17.5m/m J17
47/25V 17.5m/m J18
12.5m/m R35 C16 Q22
15m/m
YG225D2

J10912.5m/m
J110

J94 R42

J59
20m/m J330 J311

25m/m
J93 1K
12.5m/m

12.5m/m 20m/m J104 J11212.5m/m R43 Q44

20m/m J103 J11312.5m/m 47

FQP50N06
17.5m/m J19
L0

D41 18m/m J102

17.5m/m J20
1

18m/m J101
J11412.5m/m

12.5m/m
J11512.5m/m

J92
CL-510

J91 Q43
YG225D2

R61
18m/m J100

C33

FTD5-350
12.5m/m
18m/m

TH01
J99
J108
J107

12.5m/m C08
8

473P
222(M)
C51

10K
J90
17.5m/m
17.5m/m

5
470/50V

D42 J89
12.5m/m

3RD
100/2W

3RD.
6
7
18m/m J88
SCREW
L02

18m/m J87 R30

D54

D53
D52

D51
15m/m 18m/m J86
J83 J8212.5m/m 18m/m J85
12.5m/m
12.5m/m

C63

J8112.5m/m 18m/m GTO75.4

CL-510

J84
470/50V

473P

15m/m

4.7/50V4.7/50V
15m/m

FR154
FR154

FR154

FR154
Q181
C61

J80

C67
C3198GR 7.5m/m 18m/m J78

4700/50V"HC"
4700/50V"HC"

473P
Q281 7.5m/m 20m/m J77
J72
J71

C3198GR

C57
J79 15m/m J76
C181 15m/m J75

C53
R181
R281
J69
J70

J68
J67
J66

100/16V 15m/m J74

10m/m
10m/m

150/2W
15m/m
56K

J73
C52

150/2W
56K

J61
J60
C62
J65
J64

R381
56K
22m/m
22m/m
22m/m
22m/m

17.5m/m
23m/m

R481
J62

56K
J63

J117
17.5m/m

R291

R191
15m/m J321
15m/m J118 7.5m/m
J116 J144
20m/m C3200GR 6m/m 2.2/50V C3200GR 1.5K
1.5K
J119 Q451 Q251 R251
R451 J157 15m/m
2.2/50V C241
22m/m 100P C441 100P 15K
6m/m
6m/m J145

1K C251 R252 15K

J158 22m/m
C451 R452
220/16V

0.1/3W 1K R241
R46047 1SS133 R441 1K 1SS133 47 J159 15m/m
220/16V
TIP35C

R436 R236
TIP35C
D451 1K R231 D251
J146

R431
19m/m J120 A1266GR 2.2/50V A1266GR 6m/m
6m/m 2.2/50V C191 C231 Q233 J156
J143 Q433
100P C431 100P C1027Y
J125

J165

22m/m J121 C1027Y C291 5.6K C232 Q234

Q434 C432 5.6K R232 R260 0.1/3W
1K R432 1K 3.9K
1N4744

3.9K 5.6K R235 J160 17.5m/m

J166 20m/m

Q435 R437 R435 5.6K R237

R242 Q235
7.5m/m

22m/m J122 13.7KF C3198GRR442 C3198GR 13.7KF

1N4744
C3200GR

D291

C3200GR
D191

R471 Q432 22 22 Q232 R271 J161 22m/m

22m/m J123 R234
Q240
Q440

6m/m 1KF R434 1KF 473(M)

J142 R472 100/16V R272 J162 22m/m
22m/m

22m/m J124 100/16V C240

473(M) A1266GR C271 A1266GR 2.7K J163 22m/m
C440 Q442 C471 22 Q242
22 R247
2.7K C3198GR R244 120 J164 22m/m
R447 R444 10m/m C3198GR
0.1/3W Q431 22 Q231 R250
120 22 J147
TIP36C

TIP36C

R470 68P R233 68P A1023Y J16711m/m

11m/mJ126 R450 C421 R433 C221
330/16V

22KF Q244 J16811m/m

11m/mJ127 A1023Y A1266GR 22KF R221 A1266GR J169 17.5m/m
Q444 R421
22m/m
Q441
22 22 Q241 J1556m/m
J128
J1416m/m 100P R443 R243 100P 1K
1K C442 2.2/50VC242 R245 0.1/3W
J170

7.5m/m 2.2/50V C192 R270

R445
6m/m

C3198GR 1KF C3198GR 47

J130
6m/m

Q445 J129 C420 1KF Q245

47 Q443 R420 R220 C220 Q243 R246
17.5m/m J131 R446
10m/mJ148J14910m/m J171 22m/m
1.5K C3200GR 2.2/50V 2.2/50V C3200GR 1.5K
330/16V

0.1/3W R351 Q351 C341 C141 Q151 R151 7.5m/m

100P R15215K
TIP35C

TIP35C

R360 15K 1K J172

J132 100P 1K
R352 C351 R341 R141 C151 J173 22m/m
10m/m 47
1SS133 1K 1SS133 R136
22m/m J133 R33647 D351 R331
1K
C292 R131 D151
6m/m 7.5m/m
22m/m J134 A1266GR 2.2/50V 2.2/50V A1266GRJ154 0.1/3W
SCREW

J140 Q333 C331 C131 Q133 R160

J1536m/m
Q335 C1027Y 100P 5.6K 5.6K 100P C1027Y J174 22m/m Q135
22m/m R332 R132
C3200GR

J135 Q334 C332 C132 Q134

C3200GR

3.9K 1K 5.6K 5.6K 1K J175 22m/m

22m/m 3.9K
Q340

Q140

J136 R337 R335 R342 R142 R135 R137

13.7KF C3198GR 22 C3198GR 13.7KF
22m/m J137 R371 22 J176 22m/m
Q332 R334 R134 Q132 R171
473(M)"TL" 1KF 100/16V"SRE" 1KF J177 22m/m
R372 100/16V"SRE" 473(M)"TL"
C340 R172
0.1/3W 2.7K A1266GRC371 C171 A1266GRC140 J178 22m/m
R347 Q342 22 22 2.7K
TIP36C

TIP36C

R370 Q142
120 R344 R144 R147 J17919m/m
C3198GR 22 22 C3198GR 120
R350 Q331 Q131 R150
A1023Y 68P R333 7.5m/m
R133
7.5m/m 68P A1023Y
12.5m/m J138 Q344 22KF 22KF C121
6m/m C321 J150
Q144 0.1/3W
A1266GRR321 22 J151 R121 A1266GR
J139 Q341
22 J1526m/m R170
Q345 R343 R143 Q141 Q145
1K 100P2.2/50V"SRE" 2.2/50V"SRE" 100P R1451K
R345 C342 C120 C142
C320
47 C3198GR 1KF 1KF C3198GR 47
U110

R346 Q343 R120 Q143 R146 NJM2068LD

R320
CON301-1 6m/m CON101-1
J200
U310

NJM2068LD
R266

R265

R165

R166
J210

1K
10m/m
1K

1K

1K

TM2501-DG-14P TM2501-DG-14P
1

RL-IN +15V GNDS RR-OUT FR-OUT GNDS +15V FR-IN

6m/m

1
R365

J229
R465

R466

104P
C410

104P

7.5m/m
R366

J22812.5m/m

6m/m
1K

C400
1K

1K

RR-IN -15V RL-OUT FL-OUT -15V FL-IN

1K

10m/m J203 J201

10m/m 22P
104P
104P

C200

J223 J208 C126

C210

10m/m 20m/m J202 10m/m 10KF

1

J224 11m/m 6m/m J209 R126

1K J205 J204 1K
R407 15m/m R128
10m/m

22P 20m/m J206 J213 10KF

J221

47KF 1K
R303
C405 22P R125
47KF 20m/m J207 R207 C205 6m/m
22P R405 47KF J211
C306 1K
PAM631-01

R205
NJM2068LD

NJM2068LD

47KF 47KF 47KF

REV. 0

6m/m R127
NJM2068LD

R306 R402 R103 1K

7.5m/m

6m/m J214
6m/m 47KF R227
J222

J230 J225 R106 10m/m 10KF

10P 10P 22P J215 R225
C304 C404 C106 6m/m
22P 47KF 47KF 10P J212
C305 R102 C204
R406 6m/m 22P
2

2
2

47KF J22610m/m
47KF
2

C226
270K 22/16V"SRE"

270K 22/16V"SRE"

270K 22/16V"SRE"

270K 22/16V"SRE"

J216 R203
R324

R423

R424

R305
R323

6m/m

6m/m 10KF
270K22/16V"SRE"

270K22/16V"SRE"

270K22/16V"SRE"

270K22/16V"SRE"
R124

R123

R223

R224

J219

6m/m 10m/m U101 22P U111 R226

J231 U301 J227 J217 47KF C206
R105 47KF 1K
47KF 22P 10P R228
R302 C406 C104 R206
47KF 22P
R403 1K
R107
C105 47KF
R202
22/16V"SRE"

22/16V"SRE"

22/16V"SRE"

22/16V"SRE" R129

1K
22/16V"SRE" 102P

22/16V"SRE"

22/16V"SRE"

22/16V"SRE" 102P

C324

C323

C423

C424

C124

C123

C223

C224

R307 6m/m
4.7/50V"SRE"

4.7/50V"SRE"

J218
10K 10K 10K 10K
C228
C128

R322 R422 7.5m/m R122 R222

C102

C103

C202

C203
C302

C402

C403 22KF
C303

J220
HI301 HI101
RCA301 R+ L+ R+ L+ 22KF 22KF
100K

SW302 SW102 R101 R201

100K
22KF

R401

C401
C301

R301

R229
102P

102P
C101

C201

R- L- LED01 R- L-
JSS2219 HNRD-3401L JSS2219
R L R L
R L
R292

RCA101
R192
1K

1K

LAD1140-04PBK STEREO MONO STEREO MONO LAD1140-04PBK DJB-554A

DJB-562D
TOL-30aSBaCAa-B2
LED02

13
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

TER01

2W
TER02

43C
20D

10C
R262 D01
R362
C03

R261 C261

40R
R462
R56

163R
R461
R92 Q02 R63
R05

50C
C361

65Q
Q90 L03
R11
R91 Q11 R55

164C
R162 R12
R90 C11
R15
C14 C60
J53

55Q
161C
R13 R62

013J
Q12 R54

40C
R161 J52 R60
R21
D03
U01
J54
Q33
R52

45Q
R51
C12
R41
R25

60C
Q23 R53
C21
R22
D04

35Q
J51
23C

J55
R46
R16
R02 C800
1W

C31
Q01
Q21

64Q
R01
R14
R45
C22
C13
J98 R31 R03

J97 C15

54Q
J320 R32
D11 R44
R33
R34
R35 Q22
J94 C16
J311 R42

44Q
BJ07
J330
J104 J112
14D

J103 J113
R43
J102
95J

J101

34Q
J92 T01
10

J91
L

J100
411J
511J

J90 J99 C08

24D

J89

10HT
16R
R30

33C
J88 C51
J87
J86

DR3

.DR3
38J

J82 J85
J81 J84
17J
27J

20L

C61

35D
45D

25D

15D

76C
08J

J78
Q181
J77 C52

35C
Q281 J76

75C
J75 C62
97J

J74
C181
56J
46J

J73
16J
181R

06J
182R

192R
07J

191R
96J
86J
76J
66J

R381
R481

J117
J321
J144
J118
26J

R251
36J

J119 R451 Q451 C241 Q251

J157
J116
R460 C451 C441 C251 R252
R452 R241 J158
R441
R436 D251 R236
D451 R231
R431 J159
C191
J120 Q233 J156
J143 Q433 C291 C231
541J
641J

C431
532Q
534Q

C432 C232 Q234 R260

Q434 R232
J121 R432
R435 R235 R237
R437 R242 J160
R442
J122 D291 D191 R271
R471 Q232
Q432 R234 J161
R434
521J

J123 J142 R472 R272

561J
661J

C240 J162
J124
044Q

042Q

C271
C440 Q442 C471 J163
Q242 R247
R244
R470 R444 J164
R447 Q431 J147 Q231 R250
R450 R433 R233 J167
C421 C221
J126 Q244 J168
J127 R221
Q444 R421 J155 J169
Q441
542Q

Q241
544Q

C192 R243
J128 J141 R443 R270
C442 C242 R245
R445
C420 C220
J129 R420 R220 Q243 R246
R446 Q443
J148 J149
031J

J131
071J

J171
R360 R351 R151
Q351 C341 C141 Q151
R152 J172
R352 C351 R341 R141 C151
C292 J173
J132 R136
R336 R131 D151
D351 R331 J154
533Q

531Q

J133
R160
J134
J140 Q333 C331 C131 Q133 J153
C332 R332 R132 C132 J174
Q334 Q134
J135
R337 R335 R342 R142 R135 J175
J136 R137
041Q

R371 Q332 R334

043Q

R134 Q132 R171 J176

J137
C340 R372 R172 J177
R370 C371 C171 C140
R347 Q342 J178
R344 R144 Q142 R147
J179
R350 Q331 Q131 R150
R333 R133
543Q

541Q

Q344 C321 C121

J138 R121 Q144 R170
R321 J150 J151
J139 J152
Q341 R343 R143 Q141
R345 C342 C142 R145
C320 C120
R346 R320 R120 Q143 R146
CON301-1 Q343 CON101-1
011U

J200
013U

562R

561R

661R
662R

012J

J223 J203 J201 J208

J202 C126
663R

563R

922J
564R

664R

014C

J224 J209
J205 R126
822J

012C

J204 R128
R407 J206 J213
C405 R125
R303 J207 R207 C205
122J

R405 J211
C306 R205
R127
R306 R402 R103
J214
R227
J230 J225 R106 J215
R225
C304 C404 C106
222J

J212
C305 R406 R102 C204
J226 C226
R305 J216 R203
U101
J227 U111 R226
J231 U301 J217 C206
324R
423R

424R
323R

R105
321R

422R

912J
421R

322R

R228
R302 C406 C104 R206
R403 C105
R107 R202
323C
423C

324C

424C

R307
421C

422C
321C

322C

J218
R322 R422 R122 R222
301C
201C

202C

302C

J220
204C

304C
203C

303C

R101
R201
821C

822C
921R
104R

102C
103R

104C

101C
103C

922R

SW302 SW102 HI101

HI301
291R

RCA101
292R

RCA301

14
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

15
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

TRS-00-00087 TRANSISTOR SMALL SIGNAL PNP KTA1023Y Q01,144,244,344,444 5

TRS-00-00088 TRANSISTOR SMALL SIGNAL NPN KTC1027Y Q134,234,334,434 4
TRS-00-00091 TRANSISTOR SMALL SIGNAL PNP KTA1268GR Q22 1
TRS-00-00111 TRANSISTOR SMALL SIGNAL NPN KTC3200GR Q151,251,351,451 4
TRS-00-00110 TRANSISTOR SMALL SIGNAL NPN KTC3198GR Q02,90,131,132,143,181,231,232,243,281 16
Q331,332,343,431,432,443
TRS-00-00090 TRANSISTOR SMALL SIGNAL PNP KTA1266GR Q11,12,23,33,133,141,142,233,241,242 16
Q333,341,342,433,441,442
TRS-00-00109 TRANSISTOR SMALL SIGNAL NPN KTC3198BL Q21 1

DIO-00-00108 DIODE FAST RECOVERY FR154 D51,52,53,54 4

DIO-00-00003 DIODE RECTIFIER IN4004 D02 1
DIO-00-00006 DIODE SWITCHING SIGNAL 1SS133 D03,04,11,151,251,351,451 7

RES-00-00437 RESISTOR METAL FILM 1/5WF 1K OHM R120,172,220,272,320,372,420,472 8

RES-00-00523 RESISTOR METAL FILM 1/5WF 4.7K OHM R62 1
RES-00-00402 RESISTOR METAL FILM 1/5WF 10K OHM R125,126,225,226 4
RES-00-00399 RESISTOR METAL FILM 1/5WF 10.5K OHM R60 1
RES-00-00417 RESISTOR METAL FILM 1/5WF 13.7K OHM R171,271,371,471 4
RES-00-00467 RESISTOR METAL FILM 1/5WF 22K OHM R101,121,201,221,301,321,401,421 8
RES-00-00537 RESISTOR METAL FILM 1/5WF 47K OHM R102,103,105,106,202,203,205,206,302,303 16
R305,306,402,403,405,406

RES-00-00610 RESISTOR CARBON FILM 1/5WJ 10 OHM R15 1

RES-00-00660 RESISTOR CARBON FILM 1/5WJ 22 OHM R133,134,143,144,233,234,243,244,333,334 16
R343,344,433,434,443,444
RES-00-00716 RESISTOR CARBON FILM 1/5WJ 47 OHM R43,44,45,46,53,54,55,56,136,146 16
R236,246,336,346,436,446

RES-00-00615 RESISTOR CARBON FILM 1/5WJ 120 OHM R150,250,350,450 4

RES-00-00756 RESISTOR CARBON FILM 1/5WJ 820 OHM R16 1
RES-00-00633 RESISTOR CARBON FILM 1/5WJ 1K OHM R31,42,52,92,107,127,128,131,135,141 38
R145,165,192,207,227,228,231,235,241,245
R265,292,307,331,335,341,345,365,407,431
R435,441,445,465,166,266,366,466
RES-00-00598 RESISTOR CARBON FILM 1/5WJ 1.5K OHM R151,251,351,451 4
RES-00-00644 RESISTOR CARBON FILM 1/5WJ 2.7K OHM R147,247,347,447 4
RES-00-00676 RESISTOR CARBON FILM 1/5WJ 3.9K OHM R12,137,237,337,437 5
RES-00-00702 RESISTOR CARBON FILM 1/5WJ 4.7K OHM R01,02,11 3
RES-00-00720 RESISTOR CARBON FILM 1/5WJ 5.6K OHM R132,142,232,242,332,342,432,442 8
RES-00-00751 RESISTOR CARBON FILM 1/5WJ 8.2K OHM R05 1
RES-00-00608 RESISTOR CARBON FILM 1/5WJ 10K OHM R13,14,61,122,222,322,422 7
RES-00-00623 RESISTOR CARBON FILM 1/5WJ 15K OHM R34,35,152,252,352,452 6
RES-00-00658 RESISTOR CARBON FILM 1/5WJ 22K OHM R32,91 2
RES-00-00663 RESISTOR CARBON FILM 1/5WJ 24K OHM R21,22 2
RES-00-00687 RESISTOR CARBON FILM 1/5WJ 33K OHM R33 1
RES-00-00714 RESISTOR CARBON FILM 1/5WJ 47K OHM R90 1
RES-00-00730 RESISTOR CARBON FILM 1/5WJ 56K OHM R04,181,281,381,481 5
RES-00-00742 RESISTOR CARBON FILM 1/5WJ 68K OHM R25 1
RES-00-00604 RESISTOR CARBON FILM 1/5WJ 100K OHM R129,229 2
RES-00-00706 RESISTOR CARBON FILM 1/5WJ 430K OHM R63 1
RES-00-00664 RESISTOR CARBON FILM 1/5WJ 270K OHM R123,124,223,224,323,324,423,424 8
RES-00-00053 RESISTOR METAL FILM 1/2WJ 4.7 OHM R161,261,361,461 4
RES-00-00018 RESISTOR METAL FILM 1/2WJ 10 OHM R03 1
RES-00-00038 RESISTOR METAL FILM 1/2WJ 220 OHM R41,51 2

ELC-00-00223 CAPACITOR ELECTROLYTIC "SMS" 2.2/50V C131,141,220,231,241,331,341,420,431,441 10

ELC-00-00229 CAPACITOR ELECTROLYTIC "SMS" 4.7/50V C57,67 2
ELC-00-00195 CAPACITOR ELECTROLYTIC "SMS" 10/16V C800 1
ELC-00-00203 CAPACITOR ELECTROLYTIC "SMS" 10/25V C15 1
ELC-00-00198 CAPACITOR ELECTROLYTIC "SMS" 47/16V C14 1
ELC-00-00205 CAPACITOR ELECTROLYTIC "SMS" 47/25V C16 1
ELC-00-00199 CAPACITOR ELECTROLYTIC "SMS" 100/16V C11,12,13,181,271,471 6
ELC-00-00200 CAPACITOR ELECTROLYTIC "SMS" 220/16V C191,291 2
ELC-00-00201 CAPACITOR ELECTROLYTIC "SMS" 330/16V C192,292 2
16
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

ELC-00-00249 CAPACITOR ELECTROLYTIC "SRE" 2.2/50V C120,320 2

ELC-00-00250 CAPACITOR ELECTROLYTIC "SRE" 4.7/50V C128,228 2
ELC-00-00641 CAPACITOR ELECTROLYTIC "SRE" 22/16V C102,103,123,124,202,203,223,224,302,303 16
C323,324,402,403,423,424
ELC-00-00243 CAPACITOR ELECTROLYTIC "SRE" 100/16V C171,371 2
MYC-00-00020 CAPACITOR MYLAR 5% 100V 102(M) J C21 1
MYC-00-00031 CAPACITOR MYLAR 5% 100V 222(M) J C08 1
MYC-00-00038 CAPACITOR MYLAR 5% 100V 473(M) J C240,440 2
MYC-00-00094 CAPACITOR MYLAR 5% 100V 104(M) J C161,261,361,461 4
MYC-00-00090 CAPACITOR MYLAR 5% 63V "TL" 473(M) J C140,340 2
MYC-00-00085 CAPACITOR MYLAR 5% 63V "TL" 105(M) J C01,31,34 3

CEC-00-00077 CAPACITOR CERAMIC DISK 50V "NPO" 10P F C104,204,304,404 4

CEC-00-00090 CAPACITOR CERAMIC DISK 50V "NPO" 22P F C105,106,126,205,206,226,305,306,405,406 10
CEC-00-00108 CAPACITOR CERAMIC DISK 50V "NPO" 68P F C121,221,321,421 4
CEC-00-00073 CAPACITOR CERAMIC DISK 50V "NPO" 100P F C132,142,151,232,242,251,332,342,351,432 12
C442,451
CEC-00-00074 CAPACITOR CERAMIC DISK 50V 102P F C101,201,301,401 4
CEC-00-00102 CAPACITOR CERAMIC DISK 50V 473P F C32,33,53,63 4
CEC-00-00076 CAPACITOR CERAMIC DISK 50V 104P F C03,22,60,200,210,400,410 7

JUP-00-00043 JUMPER 0OHM JUMPER 6m/m J33,52,53,54,55,116,130,139,140,141 34

J142,143,145,146,152,153,155,156,170,200
J203,204,211,212,214,216,217,218,219,225
J229,230,231,300
JUP-00-00044 JUMPER 0OHM JUMPER 7.5m/m J01,02,03,04,25,26,27,28,29,30 31
J31,32,40,41,42,43,79,80,129,144
J150,151,154,165,172,201,220,222,322,323
J331
JUP-00-00045 JUMPER 0OHM JUMPER 10m/m J21,22,23,24,34,35,36,37,38,39 32
J56,57,58,64,65,132,147,148,149,208
J209,210,215,221,223,224,226,227,332,333
J334,335
JUP-00-00052 JUMPER 0OHM JUMPER 11m/m J126,127,167,168,205 5
JUP-00-00046 JUMPER 0OHM JUMPER 12.5m/m J44,45,46,47,48,49,50,71,72,81 27
J82,89,90,91,92,93,94,109,110,112
J113,114,115,138,228,336,337
JUP-00-00047 JUMPER 0OHM JUMPER 15m/m J51,60,61,73,74,75,76,83,117,157 14
J159,213,311,321
JUP-00-00048 JUMPER 0OHM JUMPER 17.5m/m J05,06,07,08,09,10,11,12,13,14 23
J15,16,17,18,19,20,62,63,107,108
J131,160,169
JUP-00-00066 JUMPER 0OHM JUMPER 18m/m J78,84,85,86,87,88,99,100,101,102 10
JUP-00-00074 JUMPER 0OHM JUMPER 19m/m J120,179 2
JUP-00-00049 JUMPER 0OHM JUMPER 20m/m J77,97,98,103,104,111,118,166,202,206 14
J207,310,320,330
JUP-00-00075 JUMPER 0OHM JUMPER 22m/m J66,67,68,69,119,121,122,123,124,125 28
J128,133,134,135,136,137,158,161,162,163
J164,171,173,174,175,176,177,178
JUP-00-00076 JUMPER 0OHM JUMPER 23m/m J70 1
JUP-00-00042 JUMPER 0OHM JUMPER 25m/m J59 1

ICO-00-00022 I.C P.W.M TL494CN U01 1

ICO-00-00112 I.C DUAL OP AMP "SIP-08P" NJM2068LD U101,110,111,301,310 5

FET-00-00023 F.E.T N-CH MOSFET FQP50N06 Q43,44,45,46,53,54,55,56 8

TRS-00-00188 TRANSISTOR AUDIO POWER NPN TIP35C Q135,235,335,435 4

TRS-00-00207 TRANSISTOR AUDIO POWER PNP TIP36C Q145,245,345,445 4
TRS-00-00111 TRANSISTOR SMALL SIGNAL NPN KTC3200GR Q140,240,340,440 4

DIO-00-00152 DIODE FAST RECOVERY YG225D2 D41,42 2

DIO-00-00048 DIODE RECTIFIER 1N5404 D01 1
DIO-00-00206 DIODE ZENER 1W 15V 1N4744A D191,291 2

17
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

DIO-00-00278 LED RED COLOR HNRD-3401L LED01 1

DIO-00-00303 LED BLUE COLOR TOL-30aSBaCAa-B2 LED02 1
RES-00-01046 RESISTOR MOR/S 2WJ (15m/m FORMING) 100 OHM R30 1
RES-00-01264 RESISTOR MOR/S 2WJ (15m/m FORMING) 150 OHM R291 1
RES-00-01265 RESISTOR MOR/S 2WJ (17.5m/m FORMING150 OHM R191 1
RES-00-01041 RESISTOR MOR/S 2WJ (15m/m FORMING) 680 OHM R162,262,362,462 4
RES-00-00895 RESISTOR WIRE WOUND 3WJ(FORMING 20m/m0.1 OHM R160,170,260,270,360,370,460,470 8

THS-00-00013 THERMISTOR NTC RESISTOR FTD5-350 TH01 1

ELC-00-00234 CAPACITOR ELECTROLYTIC "SMS" 470/50V (12.5x20m/m) C51,61 2
ELC-00-00727 CAPACITOR ELECTROLYTIC "WL" 2200/25V (16x25m/m) C04,05,06 3
ELC-00-00714 CAPACITOR ELECTROLYTIC "HC" 4700/50V (25x30m/m) C52,62 2

COR-TF-00386 CORE 4(0.7x15):11(0.7x4):8(0.7x1):8(0.7x1) 44PHI MAGNETICS T01 1

COI-00-00093 INDUCTOR DRUM COIL CL-510 L01,02 2
COI-00-00028 INDUCTOR BAR COIL CL-310 L03 1
SWI-00-00024 SWITCH SLIDE SWITCH JSS-2219 SW102,302 2
JAC-00-00043 RCA JACK GOLD PLATED DJB-554A RCA101 1
JAC-00-00042 RCA JACK GOLD PLATED DJB-562D RCA301 1
TER-00-00241 TERMINAL GOLD PLATED DST0013-00 (3P) TER01 1
TER-00-00251 TERMINAL GOLD PLATED 2! 8P ST-11A-2-8P TER02 1
JUP-00-00005 JUMPER METAL JUMPER 55m/m BJ01,02,03,07 4
JUP-00-00003 JUMPER METAL JUMPER 35m/m BJ04,05,06 3

HOD-00-00011 FUSE HOLDER WF-9604 FH01 1

CON-00-00128 WAFER LAD1140-04PBK HI101,301 2
WIR-00-00208 WIRE ASS'Y 300m/m CHD1140-04PBK ACCESSORY 2
WIR-00-00015 WIRE AWG #22 BK 3.2PHI RING LUG 60m/m W1,2 2
HED-00-00115 HEADER PIN SOCKET TM2501-DG-14P 14P CON101-1,301-1 2
TUB-00-00008 TEFLON TUBE 0.7PHI 10m/m TH01,Q140,240,340,440 6
TUB-00-00009 TEFLON TUBE 0.7PHI 15m/m LED02 2
TUB-00-00006 TEFLON TUBE 0.7PHI 20m/m LED01 2
FUS-AT-00006 AUTO FUSE 30A SET2+ACCESSORY2 4

PCB-00-01355 P.C.B FR-4 DOUBLE LAYER, 1Oz BROWN PAS319-01 148x92m/m 1

ICO-00-00113 I.C DUAL OP AMP "SOP-08" NJM2068M U102,103,104,105,302,303,304,305,306,307 10

RES-08-00239 RESISTOR SMD 0805 1/8WF 9.31K OHM R257,457 2

RES-08-00022 RESISTOR SMD 0805 1/8WF 15K OHM R155,255,355,455 4
RES-08-00088 RESISTOR SMD 0805 1/8WF 47K OHM R256,456 2
RES-08-00117 RESISTOR SMD 0805 1/8WF 91K OHM R156,356 2

RES-08-00225 RESISTOR SMD 0805 1/8WJ 820 OHM R108,208,308,408 4

RES-08-00148 RESISTOR SMD 0805 1/8WJ 1K OHM R391,392,491,492 4
RES-08-00201 RESISTOR SMD 0805 1/8WJ 5.6K OHM R113,115,213,215,313,315,413,415 8
RES-08-00210 RESISTOR SMD 0805 1/8WJ 6.8K OHM R396,496 2
RES-08-00132 RESISTOR SMD 0805 1/8WJ 10K OHM R110,111,112,114,210,211,212,214,310,311 16
R312,314,410,411,412,414
RES-08-00187 RESISTOR SMD 0805 1/8WJ 39K OHM R393,493 2
RES-08-00141 RESISTOR SMD 0805 1/8WJ 150K OHM R397,497 2

CEC-08-00009 CAPACITOR SMD 0805 12pF C156,356 2

CEC-08-00017 CAPACITOR SMD 0805 20pF C256,456 2
CEC-08-00042 CAPACITOR SMD 0805 47pF C111,211,311,393,411,493 6
CEC-08-00040 CAPACITOR SMD 0805 473pF C195,196,295,296,395,396,495,496 8

MYC-00-00157 CAPACITOR MYLAR 5% 63V "TL" 823J C113,115,213,215,313,315,413,415 8

MYC-00-00083 CAPACITOR MYLAR 5% 63V "TL" 104J C391,392,491,492 4

ELC-00-00241 CAPACITOR ELECTROLYTIC"SRE" 10/16V C125,155,225,255,325,355,425,455 8

SWI-00-00112 SWITCH SLIDE SWITCH JSS2301S120 SW101,301 2

VOL-00-00337 VOLUME V123H CO 20RS B20K (10%) 20KBx2 VR101,301,303 3
VOL-00-00338 VOLUME V124H CO 20RS C50K (10%) 50KCx4 VR102,302 2
HED-00-00245 PIN CONNECTOR TM2008-D81G-14P 14P CON101,301 2

18
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

GTO 75.4 Version II Electrical Parts List Addendum

The following chart below represents electrical parts differences in

Version I and II models:

MODEL PART NAME PART NO SPEC DESIGNATOR

GTO 75.4 RESISTOR RES-00-00437 1/5WF 1K OHM R120,220,320,420
1
GTO 75.4II RESISTOR RES-00-00545 1/5WF 5.6K OHM R120,220,320,420
GTO 75.4 RESISTOR RES-00-00417 1/5WF 13.7K OHM R171,271,371,471
2
GTO 75.4II RESISTOR RES-00-00508 1/5WF 33K OHM R171,271,371,471
GTO 75.4 RESISTOR RES-08-00225 SMD 0805 1/8WJ 820 R108,208,308,408
OHM
3
GTO 75.4II RESISTOR RES-08-00242 SMD 0805 1/8WF 240 R108,208,308,408
OHM
GTO 75.4 RESISTOR RES-08-00022 SMD 0805 1/8WF 15K R155,255,355,455
OHM
4
GTO 75.4II RESISTOR RES-08-00116 SMD 0805 1/8WF 9.1K R155,255,355,455
OHM
GTO 75.4 RESISTOR RES-08-00239 SMD 0805 1/8WF R257,457
9.31KOHM
5
GTO 75.4II RESISTOR RES-08-00200 SMD 0805 1/8WJ 5.1K R257,457
OHM
GTO 75.4 CAPACITOR CEC-08-00009 SMD 0805 12PF C156,356
6
GTO 75.4II CAPACITOR CEC-08-00023 SMD 0805 22PF C156,356
GTO 75.4 CAPACITOR CEC-08-00017 SMD 0805 20PF C256,456
7
GTO 75.4II CAPACITOR CEC-08-00037 SMD 0805 39PF C256,456

GTO 75.4 POWER TERMINAL TER-00-00241 (3P) DST0013-00 TER01

8
GTO 75.4II POWER TERMINAL TER-00-00277 (3P) DK-03B03-AG-1-DN TER01
GTO 75.4 SPEAKER TERMINAL TER-00-00251 (8P) ST-11A-2-8P TER02
9
GTO 75.4II SPEAKER TERMINAL TER-00-00273 (8P) DK-0802-AG-1-DN TER02
GTO 75.4 CAPACITOR CEC-00-00004 Ceramic, 102pf 50v C101,201,301,401
10
GTO 75.4II CAPACITOR CCEA1CH100T Electrolytic, 10uf 16v C101,201,301,401

19
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

20
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

21
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4/75.4II

22
Downloaded from www.Manualslib.com manuals search engine
 GTO 75.4 Page1 Schematic

C126

A
22P

R126 R125 C192 C191

10KF 10KF 330/16V 220/16V 15V R191 27.7V
FRONT-R VCC2
R-OUT C128 R128 150/2W 38.6V
RCA101-C 4.7/50V"SRE"1K 2 REAR-R D191 R131 VCC1
1 -
+15V C400 C200 R192
DJB-554A + 1K 1N4744(15V) 1K R135 R136 38.1V
3 104P 104P 37.6V 47
U111-A 1K
R127 C131
NJM2068LD 2.2/50V R132 Q133
R129 1K LED02 A1266GR
5.6K

12.95V
100K R112 TOL-30aSBaCAa-B2 R292

0V
C105 Q131
0.759V Q134
10K 1K Q132 C132
22P 1.478V C3198GR 38.6V

-1.47V
C1027Y
C3198GR 100P Q135
PROT
C102 R102 R105 C111 TIP35C
22/16V"SRE"
47KF 47KF 47P -15V Q151
C156 R151 R152 C3200GR
12P
R111 C113 C115 1.5K 15K

0V

-0.324V
R133 R134 R137
R107 10K

-0.607V
LOW INPUT R-CH 823M"TL" 823M"TL" 22 22 3.9K

0.238V
R101 C104 2 1K
- R156 91KF
RCA101-A 22KF 10P U103-B

-0.607V
+ 1 C155 R155 R113 U104-B C151
DJB-554A 3 R110 NJM2068M R115 U105-B R160
C103 R103 10/16V 15KF 6 VR102A 5.6K NJM2068M SW101-A
U101-A 6 6 VR102C 5.6K NJM2068M R150 0.1/3W D151 100P
10K -
C140
22/16V"SRE"
47KF VR101-A 7 - 6 JSS2301S120 C125 R120 C120 120 1SS133
NJM2068LD 5 + 7 - LPF -0.632V

B
20KB 5 50KC + 7 10/16V"SRE" 1KF 2.2\50V"SRE" Q140
5 50KC + 7 HPF 473(M)"TL"
4 5 C3200GR R170
C101 R106 C106 FLAT 0.1/3W
R108 U102-B A

0.546V
102P 47KF 22P R143 R144 R147

0.546V
820 NJM2068M R114 R121 C121 0V

0.568V
22KF 22 22 2.7K Q181
10K 68P
Q145 R181 C3198GR
TIP36C 56K

Q144
R165 C142
Q141 Q142 -0.987V A1023Y
1K R142 100P

-0.483V
5.6K R281 Q281
A1266GR A1266GR Q143 C181
U110-A 56K C3198GR
100/16V
NJM2068LD +15V C3198GR
R166 -12.80V
1 -38.1V
HI101 3 1K C141 R145
+
R141 -37.6V R146
LAD1140-04PBK FRONT-R -15V 2.2/50V 1K -38.6V TER02-A
C123 R123 - 1 1K 47
2 2 F/ROUT
22/16V"SRE" 270K VEE1 R161
SW102 C195 C196 R162ST-11A-2-8P
+ -27.7V 4.7/0.5W
R122 JSS2219 473P 473P -15V R291
R171 680/2W
C124 R124 2
10K MONO VEE2 R172 13.7KF
22/16V"SRE" 270K 150/2W
1KF C161
- C295 C296 104(M)
HI-INPUT
C224 R224 2 STEREO
32-320Hz VARIABLE X-OVER 473P 473P C410 C210 C292 C291 D291
C171
22/16V"SRE" 270K R266 100/16V"SRE"
1

C
330/16V 220/16V 1N4744(15V)
6 1K 104P 104P C261
- -
-15V
R222 C223 R223 FRONT-L 104(M)
2 + 7 +15V
10K 22/16V"SRE" 270K 5 R262
+ U110-B 38.6V R261 680/2W
NJM2068LD 4.7/0.5W
VCC1 F/LOUT
R231
R235 R236
1K
1K 37.6V 47
R265
38.1V
1K C231 R232
R212 2.2/50V 5.6K Q233
Q232 A1266GR
10K Q231
C205 C232
C3198GR C3198GR 0.759V Q234
22P 100P
C1027Y
C211
0V
C202 R202 R205 47P Q235
Q251
22/16V"SRE"
47KF 47KF TIP35C
R211 C213 C215 C3200GR
10K
-0.324V

823M"TL" 823M"TL" R233 R234 R237

-0.607V

-0.607V

LOW INPUT L-CH R207 3.9K

0V

22 22
0.238V

R201 C204 6 1K U103-A R251 R252

- C255 U102-A U104-A 1.5K 15K
RCA101-B 22KF 10P 8 R210 NJM2068M R213 R215 U105-A
+ 7 10/16V NJM2068M 2 VR102B NJM2068M SW101-B R250 R260
5.6K NJM2068M 0.1/3W D251
DJB-554A 5 3 10K - 2 VR102D 5.6K 120 C251
C203 R203 VR101-B 1 - 2 JSS2301S120 C225 R220 C220 1SS133
2 + 1 - LPF C240 100P
22/16V"SREz"
47KF U101-B 20KB 3 50KC + 1 10/16V"SRE" 1KF 2.2\50V 0.568V
0.546V

3 50KC + 1 HPF
-0.483V

NJM2068LD 3 473(M) Q240

C3200GR R270

D
R208 FLAT
820 R255 R256 47KF 0.1/3W
C201 R206 C206
0.546V

15KF R221 C221 R243 R244 R247 0V

102P 47KF 22P R257 R214
C256 10K 22KF 68P 22 2.7K
9.31KF 22
20P Q245
TIP36C
Q244
Q241 Q242 C242
C226 A1023Y
100P
R242 A1266GR A1266GR
22P
5.6K Q243
-0.987V

C3198GR
R226 R225
10KF 10KF C241 -38.1V
R241 R245 R246
FRONT-L 2.2/50V 1K 1K 47 -38.6V
-37.6V

L-OUT C228 R228

RCA101-D 4.7/50V"SRE"1K 6 REAR-L *NJM2068LD* VEE1
DJB-554A 7 -
#4PIN : -15V -15V R271
+
5 #8PIN : +15V R272 13.7KF
U111-B
R227 1KF
R229 NJM2068LD
1K C271
100K
100/16V

1 2 3 4 5 6 7 8
23

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4 Page2 Schematic

A
13.56V 13.62V 14.4V
Q01
L03
A1023Y FH01 B+
CL-310
R03
14.4V
D01 30Ax2
10/0.5W C01
R63 1N5404
105(M)"TL"
430K C800 R02
D02 R04 R01
10/16V 4.7K
REM 1N4004 56K 4.7K
Q02
C3198GR
R05
8.2K
12.90V

13.86V

4.45V
0.695V
R60
10.5KF

R46 Q46

B
R62
C60 47 FQP50N06
4.7KF D53
104P
FR154
VCC2 27.7V
D54 C57
R45 Q45 4.7/50V
FR154
47 FQP50N06
D51
FR154
C67
5V R44 Q44
D52 4.7/50V
47 FQP50N06
FR154
VEE2 -27.7V
D41
L01 C53
C14 Q43 T01 YG225D2 CL-510
D04 R43 473P
47/16V FQP50N06 38.6V
1SS133 47 VCC1
16 15 14 13 12 11 10 9 C52
1 C51 4700/50V"HC"
1 R30
C06 C05 100/2W 470/50V"SMS"
R42
Q23 2200/25"WL"2200/25"WL" C08

C
R11 R13 R15 U01 1K
10K 10 R41 A1266GR 222(M)
4.7K TL494CN C03 C61 C62
5V

220/0.5W
104P 470/50V"SMS"
4700/50V"HC"
Q53
5V Q12 D03 R53 VEE1 -38.6V
1 2 3 4 5 6 7 8 1SS133 FQP50N06 D42 L02 C63
A1266GR 47 C04 CL-510
YG225D2 473P
2200/25"WL"
Q11 4T:11T:8T:8T
1
A1266GR (0.7x15):(0.7x4):(0.7x1):(0.7x1)
Q54
R54
0V

6.14V R52 FQP50N06

47
Q33 1K
TH01
A1266GR
R12 R14 50KTH R21 R90 R22 R51
10K C12 24K 47K 24K C13 220/0.5W Q55
3.9K
100/16V R25 100/16V R55
FQP50N06
68K 47

C11
C21
100/16V Q56
D11 102(M) R56
R16 FQP50N06
LED01 47
0V

820 1SS133
Q90 R92 HNRD-3401L

D
C3198GR 1K
0V

R91 13V
22K

14.4V
0V

5V 38.5V
R31 R32 Q22
1K 22K A1268GR

Q21
C3198BL C22 C15 R33 C16
104P R34 C33 W1 W2
10/25V 33K 15K 47/25V 473P CASE GND 60m/m CASE GND 60m/m

R35
PROT C31 C32
R61 C34
15K

E
105(M)"TL"
10K
105(M)"TL"
473P
38.5V

1 2 3 4 5 6 7 8
24

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4 Page3 Schematic

A
+15V

38.6V
+15V VCC1
R331
R335 R336
1K 47
12.95V 1K 37.6V
38.1V
C331 R332 Q333
2.2/50V A1266GR
R312 5.6K
C305
10K Q331 Q334
22P Q332 C332
C3198GR 0.759V C1027Y 38.6V

0V
C3198GR 100P
C302 R302 R305 C311 Q335 PROT
22/16V"SRE"
47KF 47KF 47P TIP35C Q351
C356 12P C3200GR
R311 C313 C315
R307 10K R333 R334 R337 R351 R352
LOW INPUT R-CH 823M"TL" 823M"TL"

-0.607V

-0.607V

0.238V
R301 C304 2 1K 22 22 3.9K
- R356 91KF 1.5K 15K

B
RCA301-A 22KF 10P U303-B
+ 1 C355 R355 R313 U304-B C351
DJB-562 3 R310 NJM2068M R315 U305-B U306-A
C303 R303 10/16V 15KF 6 VR302A NJM2068M SW301-B R350 R360
5.6K VR302C NJM2068M
U301-A 6 10K - 6 5.6K NJM2068M 120 0.1/3W D351 100P
22/16V"SRE"
47KF VR301-A 7 - 6 JSS2301S120 C340
NJM2068LD 5 + 7 - LPF R391 C325 R320 C320 1SS133
20KB 5 50KC + 7 1K 0.568V 473(M)"TL"
5 50KC + 7 HPF 3 10/16V"SRE" 1KF 2.2\50V"SRE"
4 5 + Q340
C3200GR R370
C301 R306 C306 FLAT R392 - 1
R308 U302-B 2 0.1/3W
102P 47KF 22P 1K

0.546V
VR303-A

0.546V
820 NJM2068M R314

-0.483V
20KB R393 R343 R344 R347
R321 C321
10K 22 22 2.7K
22KF 68P Q345

0V
39K
TIP36C
C393

R365 Q344
C391 47P Q341 Q342 C342
1K A1023Y
104(M)"TL" A1266GR A1266GR 100P
U310-A Q343
NJM2068LD -15V R396
R366 C3198GR

-0.987V
1 6.8K R342
HI301 3 1K U306-B R345 -38.1V
+ C392 5.6K
LAD1140-04PBK REAR-R NJM2068M R346

-37.6V
C323 R323 - 1 104(M)"TL" 5 -12.8V 1K TER02-B
2 + 47 -38.6V
22/16V"SRE" 270K 2 SW302 C341 R/ROUT
+15V R397 - 7 R341 VEE1 R361
+ JSS2219 6 2.2/50V R362 ST-11A-2-8P
R322 150K 4.7/0.5W
C324 R324 1K R371 680/2W
10K MONO
22/16V"SRE" 270K 2 R372 13.7KF R381
C361
STEREO 1KF 56K

C
- 104(M)
C424 R424 C395 C396 -15V
HI-INPUT
22/16V"SRE" 270K
2
R466 32-320Hz VARIABLE X-OVER 473P 473P 50Hz 0~12dB BASSBOOST C371 A
1 100/16V"SRE"
6 1K
- -
C461
R422 C423 R423 REAR-L R481
2 + 7 104(M)
10K 22/16V"SRE" 270K 5 C495 C496 +15V 56K R462
+ U310-B 473P 473P
NJM2068LD 38.6V R461 680/2W
R431 4.7/0.5W
-15V VCC1 R/LOUT
1K
R435 R436
R465 12.95V 1K 37.6V 47
1K C431 38.1V
R412 2.2/50V R432 Q433
10K 5.6K A1266GR Q434
C405 Q431 Q432
C432 C1027Y
22P C3198GR C3198GR 0.759V
C411 100P

0V
C402 R402 R405 47P
LOW INPUT L-CH 22/16V"SRE"
47KF 47KF Q435
R411 C413 C415 Q451
TIP35C
10K C3200GR
823M"RL" 823M"TL" R433 R434 R437
R407
-0.607V

-0.607V

-0.324V

22 22 3.9K
0.238V

R401 C404 6 1K U303-A

0V

- C455 U302-A R413 U304-A U305-A R451 R452

RCA101-B 22KF 10P 8 R410 NJM2068M VR302B R415 U307-A 1.5K
+ 7 10/16V NJM2068M 2 NJM2068M SW301-A R450 15K
5.6K VR302D NJM2068M R460
DJB-562 5 3 10K - 2 5.6K NJM2068M 120 D451
C403 R403 VR301-B 1 - 2 JSS2301S120 0.1/3W
2 + 1 - LPF R491 C425 R420 C420 1SS133 C451
22/16V"SRE"
47KF U301-B 20KB 3 50KC + 1 1K C440
3 50KC 1 HPF 3 10/16V"SRE" 2.2\50V 0.568V 100P

D
+ 1KF
NJM2068LD 3 +
473(M) Q440
R408 FLAT R492 - 1
R455 R456 47KF 2 C3200GR R470
C401 R406 C406 820 1K
15KF R414 VR303-B
R447 0.1/3W
0.546V

0.546V

102P 47KF 22P R457 20KB R493 R421 C421 R443 R444
C456 10K
9.31KF 2.7K
-0.483V

20P 22KF 68P 22 22

0V
39K Q445
C493 TIP36C
C491 Q444
47P C442
104(M)"TL" Q441 Q442 A1023Y
100P -0.987V
R496 A1266GR A1266GR

6.8K R442 Q443

U307-B 5.6K C3198GR
*NJM2068LD* C492
NJM2068M -38.1V
#4PIN : -15V 104(M)"TL" 5 -12.80V R445 R446
+
C441 R441
1K 47 -38.6V
-37.6V

#8PIN : +15V R497 - 7 1K

6 2.2/50V
150K VEE1
R471

-15V R472 13.7KF

1KF
C471
100/16V

1 2 3 4 5 6 7 8
25

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4II Page1 Schematic GTO 75.4II

Q01
L03
A1023Y FH01 B+
CL-310
12V
R03 30Ax2
D01
10/0.5W C01
R63 1N5404
105(M)"TL"
430K C800 R02
D02 R04 R01
10/16V 4.7K
REM 1N4004 56K 4.7K
Q02
C3198GR
R05
8.2K

R60
10.5KF

R46 Q46
R62
C60 47 FQP50N06
4.7KF D53
104P
FR154
VCC2
D54 C57
R45 Q45 4.7/50V
FR154
47 FQP50N06
D51
FR154
C67
R44 Q44
D52 4.7/50V
47 FQP50N06
FR154
VEE2
D41
L01 C53
C14 Q43 T01 YG225D2 CL-510
D04 R43 473P
47/16V FQP50N06
1SS133 47 VCC1
16 15 14 13 12 11 10 9 C52
1 C51 4700/50V"HC"
1 R30
C06 C05 100/2W 470/50V"SMS"
R42
Q23 2200/25"WL"2200/25"WL" C08
R11 R13 R15 U01 1K
10K 10 R41 A1266GR 222(M)
4.7K TL494CN C03 C61 C62
220/0.5W
104P 470/50V"SMS"
4700/50V"HC"
Q53
Q12 D03 R53 VEE1
1 2 3 4 5 6 7 8 1SS133 FQP50N06 D42 L02 C63
A1266GR 47 C04 CL-510
YG225D2 473P
2200/25"WL"
Q11 4T:11T:8T:8T
1
A1266GR (0.7x15):(0.7x4):(0.7x1):(0.7x1)
Q54
R54
R52 FQP50N06
47
Q33 1K
TH01
A1266GR
R12 R14 50KTH R21 R90 R22 R51
10K C12 24K 47K 24K C13 220/0.5W Q55
3.9K
100/16V R25 100/16V R55
FQP50N06
68K 47

C11
C21
100/16V Q56
D11 102(M) R56
R16 FQP50N06
LED01 47
820 1SS133
Q90 R92 HNRD-3401L
C3198GR 1K

R91
22K

R31 R32 Q22

1K 22K A1268GR

Q21
C3198BL C22 C15 R33 C16
104P R34 C33 W1 W2
10/25V 33K 15K 47/25V 473P CASE GND 60m/m CASE GND 60m/m

R35
PROT C31 C32
R61 C34
15K
105(M)"TL"
10K
105(M)"TL"
473P

26

JBL

GTO75.4II 2004.02.28 CHUNG LAM

CL 1-40031A "RX"->"WL" C04,05,06 2004.02.26 B 2004.02.28
1

CLS-AP-3038
DIGITAL CO.L
1 3 2004.02.28

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4II GTO 75.4II Page2 Schematic
C126
22P

R126 R125 C192 C191

10KF 10KF 330/16V 220/16V +15V
R191
FRONT-R VCC2
R-OUT C128 R128 150/2W

RCA101-C 4.7/50V"SRE"1K 2 REAR-R D191 R131 VCC1

1 -
+15V C400 C200 R192
DJB-554A + 1K 1N4744(15V) 1K R135 R136
3 104P 104P 47
U111-A 1K
R127 C131
NJM2068LD 2.2/50V R132 Q133
R129 1K LED02 A1266GR
5.6K
100K R112 TOL-30aSBaCAa-B2 R292 Q131
C105 Q134
10K 1K Q132 C132
22P C3198GR C1027Y
C3198GR 100P Q135
PROT
C102 R102 R105 C111 TIP35C
3 -15V Q151
22/16V"SRE"
47KF 47KF 47P
C156 R151 R152 C3200GR
22P
R111 C113 C115 R133 R134 R137 1.5K 15K
R107 10K
LOW INPUT R-CH 823M"TL" 823M"TL"
R101 C104 2 1K 22 22 3.9K
- 3 R156 91KF
RCA101-A 22KF 10P U103-B C151
+ 1 C155 R155 R113 U104-B R160
DJB-554A 3 R110 NJM2068M R115 U105-B
C103 R103 10/16V 9.1KF 6 VR102A 5.6K NJM2068M SW101-A
U101-A 6 - 6 VR102C 5.6K NJM2068M 3 R150 0.1/3W D151 100P
10K C140
22/16V"SRE"
47KF VR101-A 7 - 6 JSS2301S120 C125 R120 C120 120 1SS133
NJM2068LD 5 + 7 - LPF Q140
20KB 5 50KC + 7 10/16V"SRE" 5.6KF2.2\50V"SRE" 473(M)"TL"
5 50KC + 7 HPF
4 4 5 C3200GR R170
R106 C106 3 FLAT
C101 0.1/3W
47KF 22P
R108 U102-B A
10/16V"SRE" 240F NJM2068M R114 R121 R143 R144 R147
C121
22KF 22 22 2.7K Q181
10K 68P
Q145 R181 C3198GR
TIP36C 56K

Q144
R165 C142
Q141 Q142 A1023Y
1K R142 100P
5.6K R281 Q281
A1266GR A1266GR Q143 C181
U110-A 56K C3198GR
100/16V
NJM2068LD +15V C3198GR
R166
1
HI101 3 1K C141 R145
+
LAD1140-04PBK FRONT-R 2.2/50V R141 1K R146 TER02-A
C123 R123 - 1 -15V
2 1K 47
2 F/ROUT
22/16V"SRE" 270K VEE1 R161
SW102 C195 C196 R162ST-11A-2-8P
+ 3 R171 4.7/0.5W
R122 JSS2219 473P 473P -15V R291 680/2W
C124 R124 2
10K MONO VEE2 R172 33KF
22/16V"SRE" 270K 150/2W
1KF C161
- C295 C296 104(M)
HI-INPUT
C224 R224 2 STEREO
32-320Hz VARIABLE X-OVER 473P 473P C410 C210 C292 C291 D291
C171
22/16V"SRE" 270K R266 100/16V"SRE"
1 330/16V 220/16V 1N4744(15V)
6 1K 104P 104P C261
- -
-15V
R222 C223 R223 FRONT-L 104(M)
2 + 7 +15V
10K 22/16V"SRE" 270K 5 R262
+ U110-B R261 680/2W
NJM2068LD 4.7/0.5W
VCC1 F/LOUT
R231
R235 R236
1K
R265 1K 47
1K C231 R232
R212 2.2/50V 5.6K Q233
Q232 A1266GR
10K Q231
C205 C232
C3198GR C3198GR Q234
22P 100P
C1027Y
C211
C202 R202 R205 47P Q235
Q251
22/16V"SRE"
47KF 47KF TIP35C
R211 C213 C215 C3200GR
10K R233 R234 R237
823M"TL" 823M"TL"
LOW INPUT L-CH R207 3.9K
22 22
R201 C204 6 1K U103-A R251 R252
- C255 U102-A U104-A 1.5K 15K
RCA101-B 22KF 10P 8 R210 NJM2068M R213 R215 U105-A
+ 7 10/16V NJM2068M 2 VR102B NJM2068M SW101-B R250 R260
5.6K NJM2068M 3 0.1/3W D251
DJB-554A 5 3 10K - 2 VR102D 5.6K 120 C251
C203 R203 VR101-B 1 - 2 JSS2301S120 C225 R220 C220 1SS133
2 + 1 - LPF C240 100P
22/16V"SREz"
47KF U101-B 20KB 3 50KC + 1 10/16V"SRE" 5.6KF 2.2\50V
3 50KC + 1 HPF
NJM2068LD 3 3 473(M) Q240
3 C3200GR R270
R208 FLAT
4 R255 R256 47KF
R206 C206 240F 0.1/3W
C201 9.1KF 3 R221 C221
47KF 22P R257 R214 R243 R244 R247
10/16V"SRE" C256 3 2.7K
10K 22KF 68P 22
5.1K 22
39P Q245
TIP36C
Q244
Q241 Q242 C242
C226 A1023Y
100P
R242 A1266GR A1266GR
22P
5.6K Q243
C3198GR
R226 R225
10KF 10KF C241 R241 R245 R246
FRONT-L 2.2/50V 1K 1K 47
L-OUT C228 R228
RCA101-D VEE1
4.7/50V"SRE"1K 6 REAR-L
DJB-554A 7 -
-15V R271
3
+
5 R272 33KF
U111-B
R227 1KF

27
R229 NJM2068LD
1K C271
100K
100/16V

R120,220 1KF->5.6K / R171,271 13.7FK->33KF

3 CL 1-40182A R108,208 820->240F / R155,255 15K->9.1K 2004.06.14 JBL
R257 9.31KF->5.1K/C156 12P->22P/C256 20P->39P

2 CL 1-40061A 100K->270K R123,124,223,224 2004.02.26 GTO75.4II 2004.08.14 CHUNG LAM

1 CL 1-40027A 100->1K R166,266 2004.01.30 CL 1-40239A C101,201 102P->10/16V"SRE" 2004.08.10 E
4
CLS-AP-3038
2004.08.14
DIGITAL CO.LTD
2 3 2004.08.14

08

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4II GTO 75.4II Page3 Schematic
+15V

+15V VCC1
R331
R335 R336
1K 47
1K
C331 R332 Q333
2.2/50V A1266GR
R312 5.6K
C305
10K Q331 Q334
22P Q332 C332
C3198GR C1027Y
C3198GR 100P
C302 R302 R305 C311 Q335 PROT
22/16V"SRE"
47KF 47KF 3 47P TIP35C Q351
C356 22P C3200GR
R311 C313 C315
R307 10K R333 R334 R337 R351 R352
LOW INPUT R-CH 823M"TL" 823M"TL"
R301 C304 2 1K 22 22 3.9K
- 3 R356 91KF 1.5K 15K
RCA301-A 22KF 10P U303-B
+ 1 C355 R355 R313 U304-B C351
DJB-562 3 R310 NJM2068M R315 U305-B U306-A
C303 R303 10/16V 9.1KF 6 VR302A NJM2068M SW301-B R350 R360
5.6K VR302C NJM2068M
U301-A 6 10K - 6 5.6K NJM2068M 3 120 0.1/3W D351 100P
22/16V"SRE"
47KF VR301-A 7 - 6 JSS2301S120 C340
NJM2068LD 5 + 7 - LPF R391 C325 R320 C320 1SS133
20KB 5 50KC + 7 1K 473(M)"TL"
5 50KC + 7 HPF 3 10/16V"SRE" 5.6KF 2.2\50V"SRE"
4 4 5 + Q340
3 C3200GR R370
C301 R306 C306 FLAT R392 - 1
R308 U302-B 2 0.1/3W
10/16V"SRE" 47KF 22P 1K VR303-A
240F NJM2068M R314 R343 R344 R347
20KB R393 R321 C321
10K 22 22 2.7K
22KF 68P Q345
39K
TIP36C
C393

R365 Q344
C391 47P Q341 Q342 C342
1K A1023Y
104(M)"TL" A1266GR A1266GR 100P
U310-A Q343
NJM2068LD -15V R396
R366 R342 C3198GR
1 6.8K
HI301 3 1K U306-B R345
+ C392 5.6K
LAD1140-04PBK REAR-R NJM2068M R346
C323 R323 - 1 104(M)"TL" 5 1K TER02-B
2 + 47
22/16V"SRE" 270K 2 SW302 C341 R/ROUT
+15V R397 - 7 R341 VEE1 R361
+ JSS2219 6 2.2/50V R362 ST-11A-2-8P
R322 150K 3 4.7/0.5W
C324 R324 1K R371 680/2W
10K MONO
22/16V"SRE" 270K 2 R372 33KF R381
C361
- STEREO 1KF 56K
C424 R424 C395 C396 104(M)
HI-INPUT
22/16V"SRE" 270K
2
R466 32-320Hz VARIABLE X-OVER 473P 473P 50Hz 0~12dB BASSBOOST -15V
C371 A
1 100/16V"SRE"
6 1K
- -
C461
R422 C423 R423 REAR-L R481
2 + 7 104(M)
10K 22/16V"SRE" 270K 5 C495 C496 +15V 56K R462
+ U310-B 473P 473P
NJM2068LD R461 680/2W
R431 4.7/0.5W
-15V VCC1 R/LOUT
1K
R435 R436
R465 1K 47
1K C431
R412 2.2/50V R432 Q433
10K 5.6K A1266GR Q434
C405 Q431 Q432
C432 C1027Y
22P C3198GR C3198GR
C411 100P
C402 R402 R405 47P
LOW INPUT L-CH 22/16V"SRE"
47KF 47KF Q435
R411 C413 C415 Q451
TIP35C
10K C3200GR
823M"RL" 823M"TL" R433 R434 R437
R407
22 22 3.9K
R401 C404 6 1K U303-A R451 R452
- C455 U302-A R413 U304-A U305-A
RCA101-B 22KF 10P 8 R410 NJM2068M VR302B R415 U307-A 1.5K
+ 7 10/16V NJM2068M 2 NJM2068M SW301-A R450 15K
5.6K VR302D NJM2068M R460
DJB-562 5 3 10K - 2 5.6K NJM2068M 3 120 D451
C403 R403 VR301-B 1 - 2 JSS2301S120 0.1/3W
2 + 1 - LPF R491 C425 R420 C420 1SS133 C451
22/16V"SRE"
47KF U301-B 20KB 3 50KC + 1 1K C440
3 50KC + 1 HPF 3 10/16V"SRE" 5.6KF 2.2\50V 100P
NJM2068LD 3 3 +
473(M)
3 Q440
R408 FLAT R492 - 1
4 R455 R456 47KF 2 C3200GR
R406 C406 240F 1K R470
C401 9.1KF 3 R414 VR303-B
47KF 22P R457 20KB R493 R447 0.1/3W
10/16V"SRE" C456 3 R421 C421 R443 R444
10K
5.1K 22KF 68P 22 2.7K
39P 22
39K Q445
C493 TIP36C
C491 Q444
47P C442
104(M)"TL" Q441 Q442 A1023Y
R496 100P
A1266GR A1266GR

6.8K R442 Q443

U307-B 5.6K C3198GR
C492
NJM2068M
104(M)"TL" 5 R445 R446
+
C441 R441
R497 - 7 1K 47
6 2.2/50V 1K
150K VEE1
3 R471

-15V R472 33KF

1KF
C471

28
100/16V

R320,420 1KF->5.6K / R371,471 13.7FK->33KF

3 CL 1-40182A R308,408 820->240F / R355,455 15K->9.1K 2004.06.14 JBL
R457 9.31KF->5.1K/C356 12P->22P/C456 20P->39P

2 CL 1-40061A 100K->270K R323,324,423,424 2004.02.26 GTO75.4II 2004.08.14 CHUNG LAM

CL 1-40027A 100->1K R366,466 CL 1-40239A C301,401 102P->10/16V"SRE" 2004.08.10 2004.08.14
1 2004.01.30 4 E

CLS-AP-3038
DIGITAL CO.LTD
ECN NO 3 3 2004.08.14

09

Downloaded from www.Manualslib.com manuals search engine

 GTO 75.4/75.4II

Item Part Number Description Qty

BOX-36-146AA GTO 75.4 Gift box carton 1

1
BOX-36-146AC GTO 75.4II Gift box carton 1
2 INN-42-004A0 End Pads 2
MAN-00-0195A GTO 75.4 Owner’s manual 1
(USA)
MAN-01-0195Z GTO 75.4II Owner’s manual 1
3 (USA)
MAN-00-0196A GTO 75.4 Owner’s manual 1
(Europe)
CAR-WA-004A Warranty Card 1
4 FUS-AT-00006 Fuse 30A 2
SC4-NP-40250 Mounting screw 4
STT1 PH 4X25 NI
BKT-14-523A0 Bracket lamp SK-5/BK 4
WIR-00-00208 Wire Ass’y 2
CHD1140-04P BK
5 Pair Pack carton 1

29
Downloaded from www.Manualslib.com manuals search engine