INTERNAL #
Final Inspection Check List
VIN: Job/Ro Number: Date:
Final inspection done by : Before ( ) After ( ) Repairs
Technician (HVT if e-tron): Service advisor:
Ok/Nok/NA Rectified
Periodic Maintenance Service / General Repairs
1 Customer voice addressed ( VOC ). All approved jobs (Paid / Warranty / Goodwill Etc)).
Maintenance table prepared correctly ( check ElsaPro for Correct Job selected Ex - ATF replacement at 60K , brake
2
oil replacement in 2 years)
3 All jobs mentioned in Maintenance table are carried out as per Audi guidelines
4 Repairs carried out as per workshop manual( all child parts replaced)
7 Guided fault findings completed, adaptation carried out correctly
8 Online Diagnosis log sent ,Protocol ID: (Final & complete Zero fault code log)
9 DISS ticket closed with necessary information
10 Safety related defects identified documented & informed to service advisor(if any)
11 Tire pressure Check
12 Defects that can lead to Consequential damage identified, documented & informed to Service advisor(if any)
Additional Checks
13 Engine oil level, coolant level, brake fluid level and power steering fluid level
14 Coolant level (visually), brake fluid level (E-tron)
15 Horn,exterior,interior illuminations,wiper blades,wiper washer
16 Visual inspection of brake pads/brake discs ,pipes ,tyres/wheels - as applicable
17 Jack , wheel lock, first aid kit, wheel caps are in place
18 Replaced parts well packed & placed inside boot
19 Field campaigns checked/processed if applicable
Test Drive
Points to be checked during the test drive
20 Electric motor : power output, acceleration (E-Tron)
21 Engine : Performance,misfiring,idling speed,acceleration
22 Gear selection:ease of operation,gear level position
23 Automatic gerabox:selector level position,shiftlock/ignition key removal lock,shift behavior,dash panel insert di
24 Brake pedal and handbrake:operation,travel and effectiveness,pulling to one side,juddering ,squeal
25 ABS function:pulsing must be felt at brake pedal when performing ABS-controlled braking.
26 Steering:operation,steering free play,steering wheel centralised when wheels are in straight-ahead position.
27 Sun roof (slide/tilt)/ Noise
28 Cruise control system:operation
29 MMI system (radio,navigation,etc.)
30 Radio system-Check for channel skipping during drive
31 Driver Information System(DIS):functions
32 Air conditioner :operation
33 Vehicle :moving off line when traveling straight a head (level road)
34 Imbalance :wheels,drive shafts
35 Wheel bearing:noises
36 Rattling noises from vehicle interior
37 Charging flaps, operation check , both sides
38 Engine:hot starting behavior
Additional findings noticed by FI ( not part of customer voice)
1)
2)
3)
4)
Final Inspection status (Ok/Nok) :
1 2 4 5 6
Test Result
Date Date Date Date Date
Recommendations for test drive mileages and additional notes
* PDI and service:3-5 km
INTERNAL
* Running concerens and noises/rattles:5-10km
#
*Note if a customer gives specific instructions as to when a noise or a running concern occurs then the road test should be conducted in Remarks:
that manner within the scope of the law, but with the consent of the customer in writing. TYRE PRESSURE CHECK Extended road tests
should also be approved by the customer on writing. F/L:R/L: All road tests should be documented on the work order with a reason for
carrying out the road test.
i.g.
* Carried out 10km road test for rattle from rear seats. Signature:
* Carried out 5km post service road test as per maintenance table. Date:
