Parts Manual

Transfer Switch
40/70/125 Amp

OT/ON−CT/CN (Spec G−K)

English
Original Instructions 8-2018 0962−0218 (Issue 5)
Safety Precautions
The following symbols are used in Cummins Inc. manuals to alert users to the potentially dangerous condi-
tions relating to maintenance of equipment and replacement of parts. Please read and observe.

This symbol warns of immediate hazards which will result in severe personal injury or
death.

This symbol refers to a hazard or unsafe practice which can result in severe personal
injury or death.

This symbol refers to a hazard or unsafe practice which can result in severe personal in-
jury or product or property damage.

Product Safety Precautions

Before operating the generator set, read the manuals and become familiar with them and the equipment.
Safe and efficient operation can be achieved only if the equipment is properly operated and maintained.
Many accidents are caused by failure to follow fundamental rules and precautions.
Note: It is in the Operator’s interest to read and understand all Health and Safety information
together with all Warnings and Cautions contained within the documentation relevant
to the generator set, its operation and daily maintenance.

Improper operation and maintenance can lead to severe personal injury or loss of life
and property by fire, electrocution, mechanical breakdown or exhaust gas asphyxiation.
Read and follow all safety precautions in the health and safety manual 0908−0110.

Service and repair of Cummins Inc. equipment must be performed by trained, experi-
enced personnel only. Improper service, repair or replacement of parts may result in
damage to equipment & property, severe personal injury or death. Do not use this cata-
log as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY
INSTRUCTIONS in the Service Manual appropriate for the equipment you are working
on.

Contact with USED ENGINE OILS has been identified by a United States federal agency
and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When
checking or changing engine oils take all necessary precautions not to ingest, breathe
the fumes or contact the used oil.

Contact with ASBESTOS has been identified by a United States federal agency and
some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When
handling engine gaskets take all necessary precautions not to ingest, breathe or contact
the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks
and clothing!

Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has
been identified by a United States federal agency and some USA state agencies as caus-
ing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gaso-
line and fuel additives or using solvents take all necessary precautions not to ingest,
breathe the fumes or contact the liquids. Use adequate ventilation and wear protective
gloves, masks and protective clothing!
 Introduction
This catalog applies to the OTIII Spec G, H, J & K Transfer Switches as indicated below. Each illus-
trated part is identified by a reference number corresponding to the same reference number in the
parts list for that group. Parts illustrations are typical. Using the model and spec number from the
switch box nameplate, select the parts that apply to your automatic transfer switch. Unless other-
wise noted in the parts description, parts are interchangeable between models.

Model Selection Table

OT C U 125 A 00000 G

Transfer Switch Series Specification Letter

OT = 3 Pole Designates Major Manufacturing
ON = 4 Pole Changes

Application Code Specification Number

A = Non−Automatic Factory code designating a
B = Utility to Utility combination of accessories
C = Utility to Generator Set (2 wire)
D = Generator Set to Generator Set
E = Generator Set to Generator Set (3 wire) Voltage & Frequency Code
F = Remote Control (Slave) A = 120 V 60 Hz 1 Ph 2 Wire
G = Remote Control (LRS) B = 120/240 V 60 Hz 1 Ph 3 Wire
H = Utility to Generator Set C = 120/208 V 60 Hz 3 Ph 4 Wire
D = 120/240 V 60 Hz 3 Ph 4 Wire
E = 240/480 V 60 Hz 3 Ph 4 Wire
Standards Code F = 220/380 V 60 Hz 3 Ph 4 Wire
U = UL Listed G = 277/480 V 60 Hz 3 Ph 4 Wire
C = CSA Approved H = 347/600 V 60 Hz 3 Ph 4 Wire
N = No Approval Required J = 120/240 V 60 Hz 1 Ph 4 Wire
K = 416−440,480 V 60 Hz 3 Ph 4 W
M = 110/220 V 50 Hz 1 Ph 4 Wire
N = 120/240 V 50 Hz 1 Ph 3 Wire
Ampere Rating P = 120/240 V 50 Hz 1 Ph 4 Wire
40, 70, 125 S = 120/240 V 50 Hz 3 Ph 4 Wire
T = 220/380 V 50 Hz 3 Ph 4 Wire
U = 240 V 50 Hz 1 Ph 2 Wire
Y = 380,400,416 V 50 Hz 3 Ph 4 W
R = Special

Feature Options can be determined by reading them off the nameplate or by accessing the follow-
ing screen through the Distributor On−Line computer system. Note that the first digit typed on this
screen is a code number corresponding to an individual Cummins Inc. product (1=Engines,
2=Gensets, 5=Generator Ends, 6=LT’s, 7=OT’s/BT’s) and that the spec number is always kept to
the right and zero filled if the spec number is less than five digits.

MAD2
ITEM NO: 702835
.............
A015 260 Amps Continuous
A029 4 Pole Switch for Program
A035 Utility to Genset
A042 Three Phase (3 or 4 Wire)
A044 60 Hz Frequency
A046 UL Listed

Copyright  2018 Cummins Inc. 1

THIS PAGE IS INTENDED TO BE BLANK

2 Copyright  2018 Cummins Inc.

 Index

A Bracket, End −Terminal, 23

Bracket, Mounting − Circuit Breaker, 52
Actuator, Linear, 11
Bracket, Plate − Door, 21
Adhesive, 27
Bracket, Switch − Auxiliary, 14
Arm, Interlock, 13
Bracket, Terminal, 11
Breaker, Circuit, 11
B Bumper, 27

Bar, Bus − Jumper, 12

Bar, Bus − Load, 12 C
Bar, Cross, 13
Cabinet, 48
Bar, Interlock, 12
Cabinet, Control, 25
Bar, Neutral, 12
Capacitor, 11
Barrier, 13
Chute, Arc, 13
Barrier, Bar − Cross, 13
Circuit Breaker, Heaters, 52
Barrier, Base, 12
Circuit Breaker, Main, 52
Barrier, Chute − Arc, 13
Clamp, 12
Barrier, Handle, 11
Clip, Pin, 27
Barrier, Phase, 13
Clock, Exerciser, 39
Barrier, Retainer, 13
Conduit − Transfer Switch to Generator Set, 51
Barrier, Switch, 14
Contactors, Interlocking, 21
Base, Mounting, 12
Control Assembly, 17
Block and Cross Bar Assembly, 12 , 13
Control Plate, Accessory, 19
Block, Auxiliary, 21
Cover, Transition − Programmed, 42
Block, Contact, 13 , 25 , 29
Cover, Board − PC, 17
Block, Terminal, 11 , 19 , 21
Cover, Charger − Battery, 33 , 35 , 37
Block, Terminal − Sectional, 23 , 28 , 31 , 38 , 41 ,
43 , 48 Cover, Contact, 11
Cover, Meter, 27
Board, PC − 2 to 3 Wire Convertor, 43
Cover, Signal − Elevator, 38
Board, PC − Battery Charger, 33 , 35 , 37
Board, PC − Elevator Signal, 38 Cover, Start − 3 Wire, 43

Board, PC − Mother, 17
Board, PC − Programmed Transition, 42 D
Board, PC − Sequencer, 45 Door, Cabinet, 27 , 48
Board, PC − Time Delay, 17
Board, PC − Transformer, 17
Board, PC − Voltage Sensor, 17
E
Bracket, Accessory Control Plate, 19 Edging, 27
Bracket, Door, 27
Bracket, End, 30 , 48 F
Bracket, End − Terminal, 28 , 31 , 38 , 41 , 43 , 44
Fuse, 33 , 35 , 37

Copyright  2018 Cummins Inc. 3

 Index

G Lamp, Indicating, 23
Latch, Cam, 27
Gasket, Cover − Meter, 27
Lever, Switch − Auxiliary, 14
Gasket, Door, 27
Light, Indicating, 25
Load Shed, 28
H Lug, Solderless, 12 , 13

Handle Assembly, Actuator, 13 , 15

Handle, Door, 25 M
Handle, Switch, 15
Marker, Adhesive − Relay, 29
Harness, Wiring, 12
Meter, Ampere, 27
Harness, Wiring − 3 Wire Start, 43
Meter, Ampere − DC, 33 , 35 , 37
Harness, Wiring − Battery Charger, 33 , 35 , 37
Meter, Frequency, 25
Harness, Wiring − Battery Charger Alarm, 31
Meter, Volt, 25
Harness, Wiring − Elevator Signal, 38
Module, Alarm, 40
Harness, Wiring − Main, 19 , 23
Mount, Tie − Cable, 33 , 35 , 37 , 46
Harness, Wiring − Main (600 Volts), 21
Harness, Wiring − Meter, 25
Harness, Wiring − Programmed Transition, 42 P
Hinge, Door, 27 Paint, Green, 27
Holder, Fuse, 33 , 35 , 37 Pin and Ribbon Assembly, 17 , 38 , 43
Housing − Lamp (White), 23 Pin, Contact, 47
Housing, Pin, 47 Pin, Hinge, 27
Housing, Socket, 47 Plate (Open Construction), 23
Plate, Clock − Exerciser, 39

I Plate, Door, 19 , 21
Plate, End − Terminal, 28 , 31 , 38 , 41 , 43
Insert, 13
Plate, End − Terminal , 23 , 48
Plate, Mounting − Sequencer, 45
J Plate, Relay, 46

Jumper, Terminal, 11 Plug, Hole, 17 , 25 , 27

Plug, Keying, 17

K
Key, 25 , 44
R
Rail, Block − Terminal, 31
Rail, Relay, 44
L Rail, Terminal, 23 , 28 , 30 , 38 , 41 , 43 , 48
Label, Block − Terminal, 28 , 38 , 41 , 43 Rectifier, Bridge, 35 , 37
Label, Block − Terminal , 23 Rectifier, SCR, 35 , 37
Label, Operation, 29 Relay, 24VAC, 19 , 21
Label, Switch, 29

4 Copyright  2018 Cummins Inc.

 Index
Relay, Control, 29 , 30 , 44 Switch, Transfer, 9 , 11 , 51
Relay, Monitor, 46
Relay, Programmed Transition, 42
T
Resistor, Fixed, 33
Tag, Terminal, 23 , 28 , 38 , 41 , 43
Rod, Actuator, 11
Tag, Terminal , 48
Rod−End, Actuator, 11
Tape, Sealing − Transfer Switch to Generator Set,
51
S Template, Module − Alarm, 40
Terminal, 12 , 13
Sequencer, 45
Terminal, Ring, 30 , 46
Shield (Open Construction), 23
Terminal, Spade, 33 , 35 , 37 , 46
Shield, Accessory Control Plate, 19 , 21
Terminal, Tap, 12
Shield, Meter, 25
Terminal, Tap − Plier, 30
Sleeving, Insulation, 27
Tie, Cable, 11 , 27 , 29 , 33 , 35 , 37 , 38 , 39 , 42
Socket, Contact, 47
, 43
Spacer, Bar − Neutral, 27
Transformer (Primary Voltage), 33 , 35 , 37
Spacer, Mounting, 13
Transformer, Current, 27 , 48
Splice, Inline, 40
Transformer, Power, 19 , 21 , 23
Spring, Conical, 27
Transformer, Stepdown, 27
Standoff, Insulator, 12
Transition, Programmed, 42
Strain Relief, 47
Strip, Marker, 11
Switch, 12
U
Switch Assembly, Auxiliary, 14 U−Strap, 13
Switch, Action − Snap, 14
Switch, Auxiliary, 12 W
Switch, Phase Selector, 27
Washer, Centering, 33
Switch, Selector, 25 , 29 , 44
Washer, Flat, 27
Switch, Toggle, 19 , 21
Wrapper, Charger − Battery, 33 , 35 , 37

Copyright  2018 Cummins Inc. 5

 Feature/Options

Beginning with Spec J, feature option codes applicable to the individual unit are listed on the Transfer Switch
Nameplate. The following describes these codes;

A028 Poles − 3 L004 Auxiliary Relay − Emergency Source

A035 Application − Utility to Genset L005 Auxiliary Relay − Normal Source
A036 Application − Utility to Utility L101 Auxiliary Relay − 24 VDC Coil
A037 Application − Genset to Genset L102 Auxiliary Relay − Emergency Position
A038 Application − Non−Automatic/Remote L103 Auxiliary Relay − Normal Position
A041 System − 1 Phase 2 or 3 Wire L104 Auxiliary Relay − Genset Start
A042 System − 3 Phase 3 or 4 Wire L201 Auxiliary Relay − 12 VDC Coil
A044 Frequency − 60 Hertz L202 Auxiliary Relay − Emergency Position
A045 Frequency − 50 Hertz L203 Auxiliary Relay − Normal Position
A046 Listing − UL L204 Auxiliary Relay − Genset Start
A047 Certification − CSA
A048 Listing − Not Applicable M001 Module − Signal
M002 Module − 3 Wire Start
B001 Cabinet − Type 1 M003 Terminal Block − 30 Place
B002 Cabinet − Type 3R M004 Monitor − Phase/Sequence Balance
B003 Cabinet − Type 4 M006 Sequencer − Standby Set Start 12 Volt
B004 Construction − Open M007 Load Shed − From Emergency
M008 Module − Alarm
C015 Start Time Delay − 90 Seconds M010 Sequencer − Standby Set Start 24 Volt
C016 Control − Over Voltage & Over/Under
Hertz Source 2 N001 Switch − Auto/Manual
C017 Control − Over Voltage & Over/Under N002 Terminal Block − Battery Charger
Hertz Source 1 Alarm
N005 Terminal Block − Source 1/2 Remote
D001 Meters − None Signal
D002 Meters − Door Mounted N013 Harness, Extension − 4 Feet

J001 Clock − 7 Day Exerciser R020 Voltage − 120

J021 Programmed Transition 0.5 to 7.5 R021 Voltage − 208
Second Delay R022 Voltage − 220
J022 Programmed Transition 1 to 60 R023 Voltage − 240
Second Delay R024 Voltage − 380
R025 Voltage − 416
K001 Battery Charger − 2 Amp, 12/24 Volt R026 Voltage − 480
K002 Battery Charger − 10 Amp, 12 Volt R027 Voltage − 600
K003 Battery Charger − 10 Amp, 24 Volt
S046 Current Rating − 40 Amps
L001 Auxiliary Relay − 24 VAC Coil S047 Current Rating − 70 Amps
L002 Auxiliary Relay − Emergency Position S048 Current Rating − 125 Amps
L003 Auxiliary Relay − Normal Position

6 Copyright  2018 Cummins Inc.

 Abbreviations
Some of the following abbreviations may be used throughout this Parts Manual;

Alternating Current AC Not for sale NFS

Ampere Amp Nominal Pipe Thread NPT
As Required A/R Outside Diameter OD
Automatic Voltage Regulator AVR Phase Ph
Direct Current DC Printed Circuit PC
External Tooth ET Right RT
External−Internal Tooth EIT Specification Spec
Inside Diameter ID Union National Coarse UNC
Internal Tooth IT Union National Fine UNF
Kilowatt kW Volts Alternating Current VAC
Liquid Petroleum Gas LPG Volts Direct Current VDC
Left LT With W/(ET, IT, or EIT)
Meter M(meter number)
Millimeter mm

Copyright  2018 Cummins Inc. 7

 Transfer Switch Assembly

20
15

17

22

16

18 19

13
14

3
11 5

4
2

12
1

10 21
9
11

8 Copyright  2018 Cummins Inc.

 Transfer Switch Assembly

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Switch Assembly − Transfer 50 Hertz

(Includes parts marked *) 306−3486−03 1 220 Volt, 1 Ph, 2 Wire
40 Amp 306−3486−03 1 115/200 Volt, 1 Ph, 3
60 Hertz Wire
306−3485−01 1 120 Volt, 1 Ph, 2 Wire 306−3486−03 1 220/380 Volt, 3 Ph, 4
306−3485−03 1 120/240 Volt, 1 Ph, 3 Wire
Wire 306−3486−03 1 120/208 Volt, 3 Ph, 4
306−3485−03 1 120/208 Volt, 3 Ph, 4 Wire
Wire 306−3486−05 1 240/416 Volt, 3 Ph, 4
306−3485−03 1 120/240 Volt, 3 Ph, 4 Wire
Wire 125 Amp
306−3485−06 1 240/480 Volt, 3 Ph, 4 60 Hertz
Wire 306−3487−01 1 120 Volt, 1 Ph, 2 Wire
306−3485−05 1 220/380 Volt, 3 Ph, 4 306−3487−03 1 120/240 Volt, 1 Ph, 3
Wire Wire
306−3485−06 1 277/480 Volt, 3 Ph, 4 306−3487−03 1 120/208 Volt, 3 Ph, 4
Wire Wire
306−3485−04 1 347/600 Volt, 3 Ph, 4 306−3487−03 1 120/240 Volt, 3 Ph, 4
Wire Wire
50 Hertz 306−3487−06 1 240/480 Volt, 3 Ph, 4
306−3485−03 1 220 Volt, 1 Ph, 2 Wire Wire
306−3485−03 1 115/200 Volt, 1 Ph, 3 306−3487−05 1 220/380 Volt, 3 Ph, 4
Wire Wire
306−3485−03 1 220/380 Volt, 3 Ph, 4 306−3487−06 1 277/480 Volt, 3 Ph, 4
Wire Wire
306−3485−03 1 120/208 Volt, 3 Ph, 4 306−3487−04 1 347/600 Volt, 3 Ph, 4
Wire Wire
306−3485−05 1 240/416 Volt, 3 Ph, 4 50 Hertz
Wire 306−3487−03 1 220 Volt, 1 Ph, 2 Wire
70 Amp 306−3487−03 1 115/200 Volt, 1 Ph, 3
60 Hertz Wire
306−3486−01 1 120 Volt, 1 Ph, 2 Wire 306−3487−03 1 220/380 Volt, 3 Ph, 4
306−3486−03 1 120/240 Volt, 1 Ph, 3 Wire
Wire 306−3487−03 1 120/208 Volt, 3 Ph, 4
306−3486−03 1 120/208 Volt, 3 Ph, 4 Wire
Wire 306−3487−05 1 240/416 Volt, 3 Ph, 4
306−3486−03 1 120/240 Volt, 3 Ph, 4 Wire
Wire
306−3486−06 1 240/480 Volt, 3 Ph, 4
Wire
306−3486−05 1 220/380 Volt, 3 Ph, 4
Wire
306−3486−06 1 277/480 Volt, 3 Ph, 4
Wire
306−3486−04 1 347/600 Volt, 3 Ph, 4 Continued on next page
Wire

Copyright  2018 Cummins Inc. 9

 Transfer Switch Assembly

20
15

17

22

16

18 19

13
14

3
11 5

4
2

12
1

10 21
9
11

10 Copyright  2018 Cummins Inc.

 Transfer Switch Assembly

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 306−3384 1 *Switch Assembly (See separ−

ate page for components) 50 Hertz
2 306−4268 1 *Cover, Contact (Labeled) 320−0606 1 220 Volt, 1 Ph, 2 Wire
3 332−2605 2 *Jumper, Terminal 320−0606 1 115/200 Volt, 1 Ph, 3 Wire
4 821−0005 4 *Screw, Lock − Flange 320−0606 1 220/380 Volt, 3 Ph, 4 Wire
(#10−32 x 1/2) 320−0606 1 120/208 Volt, 3 Ph, 4 Wire
5 *Actuator, Linear 320−0876 1 240/416 Volt, 3 Ph, 4 Wire
60 Hertz 14 306−3395 1 *Rod, Actuator
306−3401−01 1 120 Volt, 1 Ph, 2 Wire 15 306−1989 2 *Barrier, Handle
306−3401−03 1 120/240 Volt, 1 Ph, 3 Wire 16 332−2832 2 *Block, Terminal
306−3401−03 1 120/208 Volt, 3 Ph, 4 Wire 17 *Capacitor
306−3401−03 1 120/240 Volt, 3 Ph, 4 Wire 60 Hertz
306−3401−06 1 240/480 Volt, 3 Ph, 4 Wire 312−0257−03 1 120 Volt, 1 Ph, 2 Wire
306−3401−05 1 220/380 Volt, 3 Ph, 4 Wire 312−0203 1 120/240 Volt, 1 Ph, 3 Wire
306−3401−06 1 277/480 Volt, 3 Ph, 4 Wire 312−0203 1 120/208 Volt, 3 Ph, 4 Wire
306−3401−03 1 347/600 Volt, 3 Ph, 4 Wire 312−0203 1 120/240 Volt, 3 Ph, 4 Wire
50 Hertz 312−0257−01 2 240/480 Volt, 3 Ph, 4 Wire
306−3401−03 1 220 Volt, 1 Ph, 2 Wire 312−0228 2 220/380 Volt, 3 Ph, 4 Wire
306−3401−03 1 115/200 Volt, 1 Ph, 3 Wire 312−0257−01 2 277/480 Volt, 3 Ph, 4 Wire
306−3401−03 1 220/380 Volt, 3 Ph, 4 Wire 312−0203 1 347/600 Volt, 3 Ph, 4 Wire
306−3401−03 1 120/208 Volt, 3 Ph, 4 Wire 50 Hertz
306−3401−05 1 240/416 Volt, 3 Ph, 4 Wire 312−0203 1 220 Volt, 1 Ph, 2 Wire
6 815−0652 6 *Screw, Cap − Hex Head − W/IT 312−0203 1 115/200 Volt, 1 Ph, 3 Wire
(#10−32 x 1/2) 312−0203 1 220/380 Volt, 3 Ph, 4 Wire
7 526−0008 5 *Washer, Flat (#10) 312−0203 1 120/208 Volt, 3 Ph, 4 Wire
8 800−0008 2 *Screw, Cap − Hex Head 312−0228 2 240/416 Volt, 3 Ph, 4 Wire
(1/4−20 x 1−1/4) 18 815−0029 4 *Screw, Machine − Flat Head
9 850−0040 2 *Washer, Lock (1/4) (#10−32 x 1/2)
10 526−0018 2 *Washer, Flat (1/4) 19 870−0131 4 *Nut, Hex − W/ET (#10−32)
11 815−0651 6 *Screw, Machine − Round Head 20 306−3394 1 *Bracket, Terminal
(#6−32 x 3/4) 21 332−0942 4 *Tie, Cable
12 306−3400−01 2 *Rod−End, Actuator 22 332−2903 2 *Strip, Marker
13 *Breaker, Circuit 821−0028 4 Screw, Lock (3/8−16 x 1/2) (Not
60 Hertz illustrated)
320−0608 1 120 Volt, 1 Ph, 2 Wire 870−0133 4 Nut, Lock (3/8−16) (Not
320−0606 1 120/240 Volt, 1 Ph, 3 Wire illustrated)
320−0606 1 120/208 Volt, 3 Ph, 4 Wire
320−0606 1 120/240 Volt, 3 Ph, 4 Wire
320−0876 1 240/480 Volt, 3 Ph, 4 Wire
320−0876 1 220/380 Volt, 3 Ph, 4 Wire
320−0876 1 277/480 Volt, 3 Ph, 4 Wire
320−0606 1 347/600 Volt, 3 Ph, 4 Wire
* Parts included in Transfer Switch Assembly

Copyright  2018 Cummins Inc. 11

 Switch Assembly

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

306−3384 Switch Assembly (Includes parts 16 526−0008 2 *Washer, Flat (#10)

marked *) 17 815−0180 3 *Screw, Cap − Hex Head
1 306−3399 1 *Base, Mounting (#10−32 x 3/4)
2 306−3403 1 *Barrier, Base 18 306−3397 1 *Bar, Interlock
3 306−2013 1 *Block and Cross Bar Assembly 19 337−2315 1 *Bar, Bus − Load
(See separate page for 20 332−2370 5 *Standoff, Insulator
components) 21 800−0004 5 *Screw, Cap − Hex Head
4 815−0653 4 *Screw, Machine − Round Head (1/4−20 x 5/8)
(#10−32 x 1−3/4) 22 851−0027 6 *Washer, Conical (1/4)
5 306−4173 1 *Switch Assembly, Auxiliary − 23 337−2316 1 *Bar, Bus − Load
Emergency (See separate 24 *Lug, Solderless
page for components) 332−2880 6 Spec G
6 815−0652 9 *Screw, Machine − Hex Head 332−3084 6 Spec H & J
W/IT (#10−32 x 1/2) 25 337−2313 1 *Bar, Bus − Load
7 332−2352 1 *Clamp 26 800−0005 1 *Screw, Cap − Hex Head
8 338−2012 1 *Harness, Wiring (1/4−20 x 3/4)
9 821−0005 6 *Screw, Locking Head (#10−32 x 27 526−0018 6 *Washer, Flat (1/4)
1/2) 28 850−0040 6 *Washer, Lock (1/4)
10 851−0031 9 *Washer, Conical (#10) 29 862−0001 1 *Nut, Hex (1/4−20)
11 337−2314 3 *Bar, Bus − Jumper 30 337−2317 1 *Bar, Neutral
12 332−2834 3 *Terminal, Tap 31 800−0003 5 *Screw, Cap − Hex Head
13 306−4174 1 *Switch Assembly, Auxiliary − (1/4−20 x 1/2)
Normal (See separate 32 850−0030 3 *Washer, Lock (#10)
page for components) 33 332−2366 1 *Terminal
14 306−2013 1 *Block and Cross Bar Assembly 34 870−0053 3 *Nut, Hex (#10−32)
(See separate page for
components)
15 815−0538 2 *Screw, Machine − Round Head * Parts included in 306−3384 Switch Assembly
W/IT (#8−32 x 1/2)

12 Copyright  2018 Cummins Inc.

 Block and Cross Bar Assembly

3
1 23

11

8
2 7

16

20 19
18 9 4
14
21
17
6
5
13
10

12
15

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Block and Cross Bar Assembly 12 306−1962 1 *Barrier, Retainer

(Includes parts marked *) 13 306−1964 1 *Barrier, Phase − Left Hand
306−2013 1 Emergency 14 306−1965 1 *Barrier, Phase − Right Hand
306−2017 1 Normal 15 815−0527 2 *Screw, Pan Head − Thread
1 306−2031 1 Block, Contact Forming (#10−16 x 1/2)
2 306−1972 1 Bar, Cross 16 306−1996 1 *Handle Assembly, Actuator
3 815−0539 2 Screw, Machine − Round Head (See separate page for
W/IT (#8−32 x 5/8) components)
4 306−1968 3 U−Strap 17 815−0388 2 *Screw, Pan Head − Cross
5 306−3495 3 Insert Recessed (#6−32 x 1/2)
6 Lug, Solderless 18 850−0020 2 *Washer, Lock (#6)
332−2835 3 Spec G 19 306−2032 1 *Barrier
332−3085 3 Spec H & J 20 332−2366 3 *Terminal
7 813−0103 3 Screw, Machine − Round Head 21 526−0002 2 *Washer, Flat (#6)
(#10−32 x 3/4) 22 526−0048 2 *Washer, Flat (#8)
8 306−1984 1 *Arm, Interlock 23 306−2178 1 *Spacer, Mounting
9 306−1961 3 *Chute, Arc
10 306−1966 3 *Barrier, Chute − Arc
11 306−1967 2 *Barrier, Bar − Cross * Parts included in Block and Cross Bar Assembly

Copyright  2018 Cummins Inc. 13

 Auxiliary Switch Assembly

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Switch Assembly, Auxiliary (In− 4 309−0393 4 *Switch, Action − Snap

cludes parts marked *) 5 815−0686 2 *Screw, Machine − Hex Head
306−4174 1 Normal (#6−32 x 3−1/4)
306−4173 1 Emergency 6 870−0201 2 *Nut, Lock (#6−32)
1 306−4163 1 *Bracket, Switch − Auxiliary
2 306−1993 1 *Lever, Switch − Auxiliary
3 306−3391 5 *Barrier, Switch * Parts included in Auxiliary Switch Assembly

14 Copyright  2018 Cummins Inc.

 Actuator Handle Assembly

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

306−1996 1 Handle Assembly, Actuator (In− 4 812−0068 1 *Screw, Machine − Round Head
cludes parts marked *) (#6−32 x 1)
1 306−1994 1 *Handle, Switch − Left Hand 5 870−0201 2 *Nut, Lock (#6−32)
2 306−1995 1 *Handle, Switch − Right Hand
3 812−0066 1 *Screw, Machine − Round Head
(#6−32 x 3/4) * Parts included in 306−1996 Actuator Handle Assembly

Copyright  2018 Cummins Inc. 15

Control Assembly

11

16 Copyright  2018 Cummins Inc.

 Control Assembly

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Board, Printed Circuit − Mother 5 Board, Printed Circuit − Trans−

300−3953−01 1 Utility to Generator former
300−3267 1 Generator to Generator 60 Hertz
2 Cover, Board − Printed Circuit 300−3119 1 120 Volt, 1 Ph, 2 Wire
(Includes Label) 300−3092 1 120/240 Volt, 1 Ph, 3 Wire
306−3470 1 Spec G & H 300−3092 1 120/208 Volt, 3 Ph, 4 Wire
306−3980 1 Spec J 300−3092 1 120/240 Volt, 3 Ph, 4 Wire
3 Board, Printed Circuit − Time 300−3092 1 240/480 Volt, 3 Ph, 4 Wire
Delay (J2) 300−3092 1 220/380 Volt, 3 Ph, 4 Wire
300−3094 1 Standard 300−3092 1 277/480 Volt, 3 Ph, 4 Wire
300−3261 1 Extended (90 sec.) 300−3118 1 347/600 Volt, 3 Ph, 4 Wire
4 Board, Printed Circuit − Voltage 50 Hertz
Sensor (J1, J3) 300−3092 1 220 Volt, 1 Ph, 2 Wire
300−3121 1 Undervoltage (50 & 60 Hz.) 300−3092 1 115/200 Volt, 1 Ph, 3 Wire
300−3093−01 1 Over/Under Voltage & Over/ 300−3092 1 220/380 Volt, 3 Ph, 4 Wire
Under Frequency (60Hz) 300−3092 1 120/208 Volt, 3 Ph, 4 Wire
300−3093−02 1 Over/Under Voltage & Over/ 300−3092 1 240/416 Volt, 3 Ph, 4 Wire
Under Frequency (50Hz) 6 815−0544 9 Screw, Machine − Round Head
300−4275 1 Undervoltage (5 sec.) W/IT (#6−32 x 1/2)
300−4276−01 1 Overvoltage (5 sec.) (60 Hz.) 7 517−0256 10 Plug, Hole
300−4276−02 1 Overvoltage (5 sec.) (50 Hz.) 8 323−1387 1 Pin and Ribbon Assembly
9 332−1877 5 Tie, Cable
11 332−1917 3 Plug, Keying

Copyright  2018 Cummins Inc. 17

Accessory Control Plate
(All except 600 Volt)

18 Copyright  2018 Cummins Inc.

 Accessory Control Plate
(All except 600 Volt)

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Plate, Door 7 Transformer, Power (T1, T2)

301−9754 1 Standard 60 Hertz
319−0002 1 Load Shed 315−0655−01 1 120 Volt, 1 Ph, 2 Wire
Label 315−0655−02 1 120/240 Volt, 1 Ph, 3 Wire
098−5773 1 Standard 315−0655−02 1 120/208 Volt, 3 Ph, 4 Wire
098−5680 1 Load Shed 315−0655−02 1 120/240 Volt, 3 Ph, 4 Wire
2 301−9774 1 Bracket (Includes Label) 315−0655−02 1 240/480 Volt, 3 Ph, 4 Wire
098−5681 1 Label, Bracket 315−0655−03 1 220/380 Volt, 3 Ph, 4 Wire
3 332−2884 1 Block, Terminal 315−0655−02 1 277/480 Volt, 3 Ph, 4 Wire
4 #*Relay, 3PDT − 24VAC 315−0655−03 1 347 Volt, 3 Ph, 4 Wire
307−2575 2 Standard (K1, K2) 50 Hertz
307−2575 1 Load Shed from Emergency 315−0655−02 1 220 Volt, 1 Ph, 2 Wire
(K1) 315−0655−02 1 115/200 Volt, 1 Ph, 3 Wire
5 308−0406 1 Switch, Toggle − DPDT (S1) 315−0655−03 1 220/380 Volt, 3 Ph, 4 Wire
6 *Harness, Wiring − Main 315−0655−02 1 120/208 Volt, 3 Ph, 4 Wire
Standard 315−0655−03 1 240/416 Volt, 3 Ph, 4 Wire
60 Hertz 8 821−0040 8 Screw, Self−Locking − Flanged
338−2071 1 120 Volt, 1 Ph, 2 Wire (#10−32 x 5/16)
338−2062 1 120/240 Volt, 1 Ph, 3 Wire 9 810−0085 1 Screw, Machine − Round Head
338−2062 1 120/208 Volt, 3 Ph, 4 Wire Brass (#8−32 x 1−1/8)
338−2062 1 120/240 Volt, 3 Ph, 4 Wire 10 815−0539 2 Screw, Machine − Round Head
338−2062 1 240/480 Volt, 3 Ph, 4 Wire W/IT (#8−32 x 5/8)
338−2062 1 220/380 Volt, 3 Ph, 4 Wire 11 860−0008 1 Nut, Hex (#8−32)
338−2062 1 277/480 Volt, 3 Ph, 4 Wire 12 815−0555 A/R Screw, Pan Head W/ET
338−2062 1 347 Volt, 3 Ph, 4 Wire (#6−32 x 3/8)
50 Hertz 13 526−0048 1 Washer, Flat (#8)
338−2062 1 220 Volt, 1 Ph, 2 Wire 14 307−2648 2 #Relay, 4 Pole − 24VAC (Only
338−2062 1 115/200 Volt, 1 Ph, 3 Wire used on Load Shed from Emer−
338−2062 1 220/380 Volt, 3 Ph, 4 Wire gency Units) (K2, K4)
338−2062 1 120/208 Volt, 3 Ph, 4 Wire 15 870−0221 1 Nut, Lock W/ET (#8−32)
338−2062 1 240/416 Volt, 3 Ph, 4 Wire 16 856−0002 1 Washer, Lock E/EIT (#8)
Load Shed from Emergency 17 098−5387 4 Label, Danger
60 Hertz 18 870−0131 6 Nut, Lock W/ET (#10−32)
338−2096 1 120 Volt, 1 Ph, 2 Wire 19 301−9961 1 Shield (Includes Label)
338−2097 1 120/240 Volt, 1 Ph, 3 Wire 098−5699 1 Label
338−2097 1 120/208 Volt, 3 Ph, 4 Wire 20 815−0544 8 Screw, Machine − Round Head
338−2097 1 120/240 Volt, 3 Ph, 4 Wire W/IT (#6−32 x 1/2)
338−2097 1 240/480 Volt, 3 Ph, 4 Wire 21 098−5589 1 Label, Caution
338−2097 1 220/380 Volt, 3 Ph, 4 Wire
338−2097 1 277/480 Volt, 3 Ph, 4 Wire
338−2097 1 347 Volt, 3 Ph, 4 Wire
50 Hertz
338−2097 1 220 Volt, 1 Ph, 2 Wire
338−2097 1 115/200 Volt, 1 Ph, 3 Wire
338−2097 1 220/380 Volt, 3 Ph, 4 Wire
* Load Shed Units use Reference #14
338−2097 1 120/208 Volt, 3 Ph, 4 Wire
# Note: If customer requests K2 Relay, if K4 filled, supply
338−2097 1 240/416 Volt, 3 Ph, 4 Wire
307−2648. If not, supply 307−2575
338−2337 1 Non−Automatic (120 Volt
Only)

Copyright  2018 Cummins Inc. 19

 Accessory Control Plate
(600 Volt)

16
9

6
15
13
11
10 3

17 7

18
4

22

14

19
12

20
21

20 Copyright  2018 Cummins Inc.

 Accessory Control Plate
(600 Volts)

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319−0009 1 Plate, Door (Includes Label) 11 860−0008 1 Nut, Hex (#8−32)

098−5734 1 Label 12 815−0550 6 Screw, Pan Head Cross Re−
2 301−9774 1 Bracket (Includes Label) cessed W/ET (#6−32 x 3/8)
098−5681 1 Label 13 526−0048 1 Washer, Flat (#8)
3 332−2884 1 Block, Terminal 14 307−2648 1 Relay, 4 Pole − 24VAC (Load
4 307−2597 1 Contactors, Interlocking Shed from Emergency Units)
(24VAC) 15 870−0221 1 Nut, Lock W/ET (#8−32)
5 308−0406 1 Switch, Toggle (S1) 16 856−0002 1 Washer, Lock W/EIT (#8)
6 *Harness, Wiring − Main (600 17 098−5387 4 Label, Danger
Volts) 18 870−0131 6 Nut, Lock W/ET (#10−32)
338−2072 1 Standard 19 301−9961 1 Shield (Includes Label)
338−2098 1 Load Shed from Emergency 098−5699 1 Label
338−2337 1 Non−Automatic 20 815−0544 8 Screw, Machine − Round Head
7 Transformer, Power (T1, T2) W/IT (#6−32 x 1/2)
315−0655−04 2 Spec G 21 098−5589 1 Label, Caution
315−0662 2 Spec H & J 22 307−2600−01 1 Block, Auxiliary
8 821−0040 8 Screw, Self−Locking − Flanged
(#10−32 x 5/16)
9 810−0085 1 Screw, Machine − Round Head
(#8−32 x 1−1/8)
10 815−0538 2 Screw, Machine − Round Head
Cross Recessed W/IT (#8−32
x 5/8) * Load Shed Units use Reference #14

Copyright  2018 Cummins Inc. 21

 Plate Assembly
(Open Construction)

18

9
15
14

11
10

13

12
17

16

22
19

6, 20

1
2
3, 20
8 4, 20
5, 20

22 Copyright  2018 Cummins Inc.

 Plate Assembly
(Open Construction)

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 301−9961 1 Shield (Includes Label) 18 098−5710 1 Label, Block − Terminal

2 098−5387 2 Label, Danger 19 319−2050−01 1 Plate, Open Construction
3 322−0392−06 1 Housing, Lamp (White) 20 322−0133 4 Lamp, Indicating
4 322−0392−04 1 Housing, Lamp (Green) 21 Harness, Wiring − Main (Not
5 322−0392−02 1 Housing, Lamp (Amber) Shown)
6 322−0392−01 1 Housing, Lamp (Red) Non−Automatic/Remote
7 815−0538 8 Screw, Machine − Round Head 338−2958 1 All Except 600 Volt
Cross Recessed w/IT 338−2957 1 600 Volt
(#8−32 x 1/2) Load Shed
8 815−0544 22 Screw, Machine − Round Head 338−2959 1 120 Volt
Cross Recessed w/IT 338−2982 1 600 Volt
(#6−32 x 1/2) 338−2981 1 All Except 120 & 600 Volt
9 332−2837−07 1 Rail, Terminal All Except Non−Automatic/
10 332−2839 2 Bracket, End − Terminal Remote & Load Shed
11 332−2842−16 2 Tag, Terminal (51−60) 338−2961 1 120 Volt
12 332−2836−02 1 Block, Terminal − Sectional 338−2960 1 600 Volt
13 332−2841 1 Plate, End − Terminal 338−2962 1 All Except 120 & 600
14 815−0446 4 Screw, Round Head − Cross Volt
Recessed w/IT Thread Cutting 22 Transformer, Power
(#8−32 x 1/2) 315−0723−05 2 120 Volt
15 332−2877 2 Tie, Cable 315−0723−06 2 208/220/240/480 Volt
16 870−0131 4 Nut, Hex w/ET (#10−32) 315−0723−07 2 380/416 Volt
17 878−0032 1 Laminate Material 315−0723−08 2 600 Volt

Copyright  2018 Cummins Inc. 23

 Door and Cabinet

37
36
39

35

33 NEMA 4
29

32 1

NEMA 3 & 4
30 21
28

38

23
20
18
29
22
12
13
31
25
3

2 27

5 19
9 8 15
11
4
14
7
16

26 40
24

17

10, 34 6

24 Copyright  2018 Cummins Inc.

 Door and Cabinet

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Cabinet, Control 13 870−0439 6 Nut, Nylon

Spec G 14 Meter, Volt − AC
301−9766 1 NEMA 1 60 Hertz
319−0363 1 NEMA 3R 302−1692 1 120 Volt, 1 Ph, 2 Wire
319−0152 1 NEMA 4 302−1175 1 120/240 Volt, 1 Ph, 3 Wire
Spec H & J 302−1175 1 120/208 Volt, 3 Ph, 4 Wire
319−1182 1 NEMA 1 302−1175 1 120/240 Volt, 3 Ph, 4 Wire
319−0363 1 NEMA 3R 302−1711 1 240/480 Volt, 3 Ph, 4 Wire
319−0152 1 NEMA 4 302−1711 1 220/380 Volt, 3 Ph, 4 Wire
319−0363−01 1 NEMA 12 302−1711 1 277/480 Volt, 3 Ph, 4 Wire
Spec K 302−1710 1 347/600 Volt, 3 Ph, 4 Wire
319−1429 1 NEMA 1 50 Hertz
319−1098 1 NEMA 3R 302−1175 1 220 Volt, 1 Ph, 2 Wire
319−1099 1 NEMA 4 302−1175 1 115/200 Volt, 1 Ph, 3 Wire
319−1098−01 1 NEMA 12 302−1711 1 220/380 Volt, 3 Ph, 4 Wire
2 322−0170 1 Light, Indicating − Normal 302−1175 1 120/208 Volt, 3 Ph, 4 Wire
(Green) 302−1711 1 240/416 Volt, 3 Ph, 4 Wire
3 322−0137 1 Light, Indicating − Emergency 15 Harness, Wiring − Meter
(Red) 60 Hertz
4 322−0387−02 1 Light, Indicating − Normal 338−2063 1 120 Volt, 1 Ph, 2 Wire
Source Available (Clear) (P12/TB4/S13/M2,3,4)
5 322−0168 1 Light, Indicating − Emergency 338−2135 1 120 Volt, 1 Ph, 2 Wire
Source Available (Amber) (P12/TB4/S13/M2,3,4)
6 Switch, Selector (Includes Key) (250 − 1000 Amp Meter)
(S12) 338−2133 1 120/240 Volt, 1 Ph, 3 Wire
308−0848 1 Spec G (P12−1/TB4/S13/M2,3,4)
308−0849 1 Key (fits Item 6, Spec G) 338−2133 1 120/208 Volt, 3 Ph, 4 Wire
Spec H & J (P12−1/TB4/S13/M2,3,4)
NEMA 1 338−2133 1 120/240 Volt, 3 Ph, 4 Wire
308−0991 1 Utility to Utility (P12−1/TB4/S13/M2,3,4)
308−0992 1 Non−Automatic/Remote 338−2134 1 240/480 Volt, 3 Ph, 4 Wire
308−0997 1 Sequencer − Standby (P12/TB4/T3/S13/M2,3,4)
Set Start 338−2134 1 220/380 Volt, 3 Ph, 4 Wire
NEMA 4 (P12/TB4/T3/S13/M2,3,4)
308−0993 1 Non−Automatic/Remote 338−2134 1 277/480 Volt, 3 Ph, 4 Wire
308−0994 1 Utility to Genset (P12/TB4/T3/S13/M2,3,4)
308−1054 1 Fire Pump Applications 338−2134 1 347/600 Volt, 3 Ph, 4 Wire
308−1055 1 Fire Pump Applications 50 Hertz
308−0989 1 Key (Fits item 6, 338−2133 1 220 Volt, 1 Ph, 2 Wire
Spec H & J) (P12−1/TB4/S13/M2,3,4)
7 308−0854 1 Block, Contact − Normally 338−2133 1 115/200 Volt, 1 Ph, 3 Wire
Closed (1 Phase) (P12−1/TB4/S13/M2,3,4)
8 308−0850 1 Block, Contact − Normally Open 338−2134 1 220/380 Volt, 3 Ph, 4 Wire
(1 Phase) (P12/TB4/T3/S13/M2,3,4)
9 406−0613 1 Handle, Door (Includes Key) 338−2133 1 120/208 Volt, 3 Ph, 4 Wire
406−0649 1 Key (Fits item 9) (P12−1/TB4/S13/M2,3,4)
Spec K 338−2134 1 240/416 Volt, 3 Ph, 4 Wire
406−0912 1 Handle, Door (With Key) (P12/TB4/T3/S13/M2,3,4)
406−0649 1 Key (Fits item 9) 338−3203 1 Open Construction
10 517−0137 2 Plug, Hole
11 302−1992 1 Meter, Frequency (45 − 65 Hz) Continued on next page
12 306−3464 1 Shield, Meter

Copyright  2018 Cummins Inc. 25

 Door and Cabinet
(Continued)

37
36
39

35

33 NEMA 4
29

32 1

NEMA 3 & 4
30 21
28

38

23
20
18
29
22
12
13
31
25
3

2 27

5 19
9 8 15
11
4
14
7
16

26 40
24

17

10, 34 6

26 Copyright  2018 Cummins Inc.

 Door and Cabinet
(Continued)

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

16 Meter, Ampere 29 815−0544 14 Screw, Machine − Round Head

302−1805−01 1 40 Amp (#6−32 x 1/2)
302−1678 1 70 Amp 30 332−2877 7 Tie, Cable
302−1805−02 1 125 Amp 31 332−1348 2 Spacer, Bar − Neutral
17 Transformer, Current 32 319−0145 1 Cover, Meter
1 Phase 33 319−0146 1 Gasket, Cover − Meter
338−2204−01 1 40 Amp 34 517−0266 A/R Plug, Hole
338−2204−02 1 70 Amp 35 812−0177 8 Screw, Machine − Round Head
338−2204−03 1 125 Amp (5/16−18 x 3/4)
3 Phase 36 406−0519 8 Spring, Conical
338−2205−01 1 40 Amp 37 301−6727 8 Bracket, Door
338−2205−02 1 70 Amp 38 525−0305 1 Paint, Green − 13 oz. Spray Can
338−2205−03 1 125 Amp 39 526−0022 8 Washer, Flat (5/16”)
18 Door, Cabinet 098−5589 1 *Label, Caution
Spec G 815−0652 8 *Screw, Hex Head − Thread
NEMA 1 Forming (#10−32 x 1/2)
301−9806 1 With Meter Holes 870−0281 A/R *Nut, Lock (3/8−16)
301−9760 1 Without Meter Holes 323−1333 1 *Connector
NEMA 3R 098−5692 1 *Label, Product ID
319−0362−02 1 With Meter Holes 098−5693 1 *Label, Lamp
319−0362−01 1 Without Meter Holes *Label, Door
NEMA 4 098−5694 1 With Switch
319−0143−02 1 With Meter Holes 098−5695 1 Without Switch
319−0143−01 1 Without Meter Holes 098−5387 3 *Label, Danger
Spec H & J & K 870−0131 11 *Nut, Hex (#10−32)
NEMA 1 870−0134 6 *Nut, Lock (1/4−20)
319−1176−01 1 With Meter Holes 098−5589 1 *Label, Caution
319−1178−01 1 Without Meter Holes 518−0404 1 *Adhesive
NEMA 3R 508−0233 A/R *Washer, Rubber
319−0362−04 1 With Meter Holes 870−0386 16 *Nut, Acorn (Nylon)
319−0362−03 1 Without Meter Holes *Gasket, Door
NEMA 4 895−0293−01 2 22.57” Long
319−0143−04 1 With Meter Holes 895−0293−07 2 23.82” Long
319−0143−03 1 Without Meter Holes 895−0293−02 2 26.13” Long
NEMA 12 895−0293−03 2 26.70” Long
319−0362−06 1 With Meter Holes 895−0293−05 2 28.39” Long
319−0362−05 1 Without Meter Holes 895−0293−09 2 28.68” Long
319−0124 1 Open Construction 895−0293−11 2 32.38” Long
19 Latch, Cam 895−0293−04 2 34.73” Long
306−3465 1 NEMA 1 − Single Point 895−0293−06 2 38.14” Long
306−3466 1 NEMA 1 − 3 Point 895−0293−08 2 51.08” Long
306−3525 1 NEMA 3 895−0293−10 2 65.24” Long
20 406−0610−02 2 Hinge, Door 098−5777−01 1 *Label, Warning
21 406−0610−03 2 Pin, Hinge 098−6635 1 *Label, Ground
22 406−0610−04 2 Clip, Pin 870−0439 6 *Nut, Acorn
23 508−0231 3 Bumper 526−0022 8 *Washer, Flat (5/16)
24 Switch, Phase Selector 821−0028 2 *Screw, Lock (3/8−16 x 1/2)
308−0905 1 1 Phase 815−0221 4 *Screw, Drive
308−0904 1 3 Phase 098−6367 1 Label, Torque
25 898−0778 1 Sleeving, Insulation 40 315−0662 1 Transformer, Power (T4)
26 Transformer, Stepdown (T3)
315−0731 1 380/416 Volt
315−0377 1 480/600 Volt
27 821−0004 4 Screw, Lock (#10−32 x .31)
28 508−1045 2 Edging * − Parts not Illustrated

Copyright  2018 Cummins Inc. 27

 Load Shed

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 332−2837−09 1 *Rail, Terminal 6 870−0221 2 *Nut, Hex w/ET (#8−32)

2 332−2836−01 2 Block, Terminal − Sectional 7 098−5710 1 *Label, Block − Terminal
3 332−2839 2 Bracket, End − Terminal
4 332−2841 1 Plate, End − Terminal
5 332−2842−13 2 Tag, Terminal (21−30) * Not used with Open Construction

28 Copyright  2018 Cummins Inc.

 Auto/Manual Switch

3
1

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Switch, Selector (S12) (Includes Spec G & H

Key) 308−0849 1 NEMA 1
Spec G & H 308−0988 1 NEMA 4
308−0851 1 NEMA 1 308−0989 1 Spec J
308−0886 1 NEMA 4 308−0955 1 *Switch, Selector (S14)
Spec J 308−0989 1 Key
308−0990 1 NEMA 1 307−2578 2 *Relay, Control
Open Construction 815−0446 4 *Screw, Round Head − Cross
308−0990 1 Utility to Genset Recessed w/IT (#8−32 x 1/2)
308−0957 1 Utility to Utility 332−0802 1 *Terminal, Ring (#8)
2 308−0850 1 Block, Contact − Normally Open 098−6561 1 *Label, Operation
3 Tie, Cable 332−2420 2 *Mount, Tie − Cable
332−0942 10 Units with Cabinet 098−6697 1 *Label, Switch
332−0941 10 Open Construction 532−0374 1 *Marker, Adhesive − Relay
* Parts used on Open Construction Utility to Utility Only (Not
Illustrated)

4 Key, Replacement (Fits Item 1)

Copyright  2018 Cummins Inc. 29

 Auxiliary Relay

7 6
5

8
1

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 332−2879−02 1 Rail, Terminal 5 853−0005 2 Washer, Lock ET (#8)

2 Relay, Control 6 526−0003 2 Washer, Flat (#8)
307−2578 1 24 VAC 7 332−2230 1 Terminal, Tap − Plier
307−2582 1 12 VDC 8 332−0802 1 Terminal, Ring (#8)
307−2583 1 24 VDC 334−1842 1 Wire, 16 AWG − 600V TEW (12”)
3 332−2878 2 Bracket, End (Not Shown)
4 860−0008 2 Nut, Hex (#8−32)

30 Copyright  2018 Cummins Inc.

 Battery Charger Alarm

1 9

2 3

41 6
42
43
44
45
7 46
47
48
49
50

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 338−2349 1 Harness, Wiring − Battery 5 332−2839 2 Bracket, End − Terminal

Charger Alarm 6 332−2841 1 Plate, End − Terminal
2 Tie, Cable 7 332−2842−15 2 Tag, Terminal (41−50)
332−0942 20 Units with Cabinets 8 870−0221 2 Nut, Hex w/ET (#8−32) (Units
332−0941 5 Open Construction with Cabinets Only)
3 332−2837−09 1 Rail, Block − Terminal (Units with 9 098−5710 1 Label, Block − Terminal (TB3)
Cabinets Only) (Units with Cabinets Only)
4 332−2836−02 1 Block, Terminal − Sectional

Copyright  2018 Cummins Inc. 31

 Battery Charger
(2 Amp)

19

16
1, 3
5 14
19
9 4
16
2
15
16

20 16

13
7

12

10 22
18
11

21

8 17

32 Copyright  2018 Cummins Inc.

 Battery Charger
(2 Amp)

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Harness, Wiring − Battery 14 304−0037 1 Resistor, Fixed − 6” Long

Charger 15 304−0139 1 Resistor, Fixed − 2” Long
338−2161 1 Units with Cabinet 16 304−0015 4 Washer, Centering
Open Construction 17 813−0116 1 Screw, Round Head
338−2949 1 Genset to Genset (#10−32 x 6−1/2)
338−2161 1 Utility to Genset 18 813−0112 1 Screw, Round Head
338−2983 1 3 Wire Start (#10−32 x 2−1/2)
2 870−0131 4 Nut, Lock W/ET (#10−32) 19 870−0131 2 Nut, Lock W/ET (#10−32)
3 332−2777 2 Terminal, Spade 20 815−0550 4 Screw, Pan Head W/ET
4 332−2420 8 Mount, Tie − Cable (#6−32 x 3/8)
5 332−0942 20 Tie, Cable 21 815−0549 4 Screw, Pan Head W/ET
6 301−9990 1 Wrapper, Charger − Battery (#6−32 x 1/4)
7 301−9992 1 Cover, Charger − Battery 22 821−0040 4 Screw, Lock (#10−32 x 5/16)
(Includes Label)
098−5708 1 Label
8 302−0807 1 Meter, Ampere − DC
9 338−2149 1 Harness, Wiring − Battery
Charger
10 321−0175 1 Holder, Fuse
11 321−0153 1 Fuse, 3 Amp
12 300−2946 1 Board, Printed Circuit − Battery
Charger
13 Transformer (Primary Voltage)
60 Hertz
315−0621−01 1 120 Volt
315−0621−02 1 208 Volt
315−0621−02 1 240 Volt
315−0621−03 1 380 Volt
315−0621−02 1 480 Volt
315−0621−04 1 600 Volt
50 Hertz
315−0621−02 1 200 Volt
315−0621−02 1 208 Volt
315−0621−02 1 220 Volt
315−0621−03 1 380 Volt
315−0621−03 1 416 Volt

Copyright  2018 Cummins Inc. 33

 Battery Charger
(10 Amp 12 Volt)

20

19
2 21

7 17

9
23
22
11
15
23

20
8
13

20
14
12

16 19

10 18

34 Copyright  2018 Cummins Inc.

 Battery Charger
(10 Amp 12 Volt)

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 098−4339 1 Label, Option 14 321−0127 1 Fuse, 15 Amp

2 Harness, Wiring − Battery 15 Transformer (Primary Voltage)
Charger 60 Hertz
338−2161 1 Units with Cabinet 315−0665 1 120 Volt
Open Construction 315−0665 1 208 Volt
338−2949 1 Genset to Genset 315−0665 1 240 Volt
338−2161 1 Utility to Genset 315−0671 1 380 Volt
338−2983 1 3 Wire Start 315−0673 1 480 Volt
3 870−0131 4 Nut, Lock W/ET (#10−32) 315−0675 1 600 Volt
4 332−2777 2 Terminal, Spade 50 Hertz
5 332−2420 8 Mount, Tie − Cable 315−0667 1 200 Volt
6 332−0942 20 Tie, Cable 315−0669 1 220 Volt
7 319−0072 1 Wrapper, Charger − Battery 315−0677 1 240 Volt
8 319−0073 1 Cover, Charger − Battery 315−0679 1 347 Volt
Label 315−0667 1 380 Volt
500 Volt 315−0667 1 400 Volt
098−5807 1 4.5 Amp 315−0669 1 416 Volt
098−5808 1 2.5 Amp 315−0669 1 440 Volt
098−5809 1 2.0 Amp 16 300−3160 1 Board, Printed Circuit − Battery
098−5995 1 1.5 Amp Charger
098−5996 1 1.0 Amp 17 305−0653 1 Rectifier, Bridge
600 Volt 18 821−0040 4 Screw, Lock (#10−32 x 5/16)
098−6039 1 1.0 Amp 19 815−0550 8 Screw, Pan Head W/ET
9 302−1844 1 Meter, Ampere − DC (#6−32 x 3/8)
10 338−2223 1 Harness, Wiring − Battery 20 822−2048 5 Screw, Pan Head (#8−32 x 1/2)
Charger 21 305−0781 1 Rectifier, SCR
11 321−0237 2 Holder, Fuse (AC Input) 22 822−2049 1 Screw, Pan Head W/ET
12 321−0104 1 Holder, Fuse (DC Output) (#8−32 x 5/8)
13 Fuse 23 870−0221 5 Nut, Lock W/ET (#8−32)
500 Volt 24 C−0308 1 Instruction Sheet
321−0304−01 2 1.0 Amp
321−0304−02 2 1.5 Amp
321−0304−03 2 2.0 Amp
321−0304−04 2 2.5 Amp
321−0304−05 2 4.5 Amp
600 Volt
321−0236 2 1.0 Amp

Copyright  2018 Cummins Inc. 35

 Battery Charger
(10 Amp 24 Volt)

20

19
2 21

7 17

9
23
22
11
15
23

20
8 13

20
14
12

16 19

10 18

36 Copyright  2018 Cummins Inc.

 Battery Charger
(10 Amp 24 Volt)

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 098−4339 1 Label, Option 14 321−0127 1 Fuse, 15 Amp

2 Harness, Wiring − Battery 15 Transformer (Primary Voltage)
Charger 60 Hertz
338−2161 1 Units with Cabinet 315−0701 1 120 Volt
Open Construction 315−0701 1 208 Volt
338−2949 1 Genset to Genset 315−0701 1 240 Volt
338−2161 1 Utility to Genset 315−0707 1 380 Volt
338−2983 1 3 Wire Start 315−0709 1 480 Volt
3 870−0131 4 Nut, Lock W/ET (#10−32) 315−0711 1 600 Volt
4 332−2777 2 Terminal, Spade 50 Hertz
5 332−2420 8 Mount, Tie − Cable 315−0703 1 200 Volt
6 332−0942 20 Tie, Cable 315−0705 1 220 Volt
7 319−0072 1 Wrapper, Charger − Battery 315−0713 1 240 Volt
8 319−0073 1 Cover, Charger − Battery 315−0715 1 347 Volt
Label 315−0703 1 380 Volt
098−5914 1 5.0 Amp 315−0703 1 400 Volt
098−5915 1 4.5 Amp 315−0705 1 416 Volt
098−5916 1 2.5 Amp 315−0705 1 440 Volt
098−5997 1 2.0 Amp 16 300−3244 1 Board, Printed Circuit − Battery
098−5998 1 1.5 Amp Charger
9 302−1844 1 Meter, Ampere − DC 17 305−0653 1 Rectifier, Bridge
10 338−2223 1 Harness, Wiring − Battery 18 821−0040 4 Screw, Lock (#10−32 x 5/16)
Charger 19 815−0550 8 Screw, Pan Head W/ET
11 321−0237 2 Holder, Fuse (AC Input) (#6−32 x 3/8)
12 321−0104 1 Holder, Fuse (DC Output) 20 822−2048 5 Screw, Pan Head (#8−32 x 1/2)
13 Fuse 21 305−0781 1 Rectifier, SCR
321−0304−02 2 1.5 Amp 22 822−2049 1 Screw, Pan Head W/ET
321−0304−03 2 2.0 Amp (#8−32 x 5/8)
321−0304−04 2 2.5 Amp 23 870−0221 5 Nut, Lock W/ET (#8−32)
321−0304−05 2 4.5 Amp 24 C−0308 1 Instruction Sheet
321−0304−06 2 5.0 Amp

Copyright  2018 Cummins Inc. 37

 Elevator Signal

12
3

13
11

2 1 10
6

5
9
8
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 300−3096 1 Board, Printed Circuit − Elevator 7 332−2841 1 Plate, End − Terminal

Signal (Includes Fuses) 8 Tag, Terminal
321−0174 5 Fuse, 5 Amp 250 Volt (F1−F5) 332−2842−12 2 Spec G (11−20)
2 301−9932 1 Cover, Signal − Elevator 332−2842−13 2 Spec H & J (21−30)
(Includes Label) 9 815−0680 4 Screw, Pan Head Recessed
3 Harness, Wiring − Elevator W/ET (#6−32 x 1)
Signal 10 870−0221 2 Nut, Lock W/ET (#8−32)
338−2141 1 Spec G 11 323−1409 1 Pin and Ribbon Assembly
338−2140 1 Spec H & J 12 332−0942 10 Tie, Cable
4 332−2837−09 1 Rail, Terminal 13 098−5710 1 Label, Block − Terminal
5 332−2836−02 2 Block, Terminal − Sectional 332−2842−13 2 Tag, Terminal (21−30)
6 332−2839 2 Bracket, End − Terminal (Not Illustrated)

38 Copyright  2018 Cummins Inc.

 Exerciser Clock

5 1

3
2

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 301−9768 1 Plate, Clock − Exerciser 4 815−0550 2 Screw, Machine − Round Head

2 307−2577 1 Clock, Exerciser Cross Recessed W/ET
3 332−0942 10 Tie, Cable (#6−32 x 3/8)
5 870−0131 2 Nut, Lock W/ET (#10−32)

Copyright  2018 Cummins Inc. 39

 Alarm Module

6
5

4
1

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Module, Alarm 4 862−0001 2 Nut, Hex (1/4−20)

300−3998−01 1 24 Volt AC or DC 5 332−2230 2 Splice, Inline (22−18 Wire)
300−3998−02 1 12 VDC 6 332−0942 3 Tie, Cable
2 800−0006 2 Screw, Cap − Hex Head 539−1344 1 Template, Module − Alarm (Not
(1/4−20 x 7/8) Illustrated)
3 850−0040 2 Washer, Lock (1/4)

40 Copyright  2018 Cummins Inc.

 Remote Connection Signal

9 8

5
51
52
53
54
55 3
56
57
58
59
60 4

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 332−2837−09 1 Rail, Terminal 6 870−0221 2 Nut, Hex w/ET (#8−32)

2 332−2836−01 2 Block, Terminal − Sectional 7 332−0942 10 Tie, Cable
3 332−2839 2 Bracket, End − Terminal 8 098−5710 1 Label, Block − Terminal
4 332−2841 1 Plate, End − Terminal 9 332−2230 2 Terminal, Tap − Plier
5 332−2842−16 2 Tag, Terminal (51−60)

Copyright  2018 Cummins Inc. 41

 Programmed Transition

1
7

6
2

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Board, Printed Circuit − 4 307−2591 1 Relay, Programmed Transition

Programmed Transition (K3)
300−3115−01 1 07.5 Seconds 5 815−0680 4 Screw, Machine − Pan Head
300−3115−02 1 60.0 Seconds Cross Recessed W/ET
2 Cover, Programmed Transition (#6−32 x 1)
(Includes Label) 6 332−0942 8 Tie, Cable
301−9928−01 1 07.5 Seconds 7 815−0550 2 Screw, Pan Head − Recessed
301−9928−02 1 60 Seconds W/ET (#6−32 x 3/8)
3 338−2139 1 Harness, Wiring − Pro−
grammed Transition

42 Copyright  2018 Cummins Inc.

 2 to 3 Wire Convertor

13

11 4

1
10
6

8, 15

2
7

5
9
12

3, 14

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Board, Printed Circuit − 2 to 3 8 332−2842−11 2 Tag, Terminal (1−10)

Wire Convertor 9 815−0680 4 Screw, Pan Head − Recessed
300−3095 1 Spec G & H W/ET (#6−32 x 1)
300−4054 1 Spec J 10 870−0221 2 Nut, Lock W/ET (#8−32)
2 319−1502 1 Cover, Start − 3 Wire (Includes 11 323−1408 1 Pin and Ribbon Assembly
Label) 12 332−0942 12 Tie, Cable
3 Harness, Wiring − 3 Wire Start 13 098−5710 1 Label, Block − Terminal
338−2142 1 Units with Cabinet 14 338−2993 1 Harness, Wiring (Open
338−2987 1 Open Construction Construction − Utility to Genset
4 332−2837−09 1 Rail, Terminal Only)
5 332−2836−02 1 Block, Terminal − Sectional 15 332−2842−14 2 Tag, Terminal (31−40) (Open
6 332−2839 2 Bracket, End − Terminal Construction − Utility to Genset
7 332−2841 1 Plate, End − Terminal Only)

Copyright  2018 Cummins Inc. 43

 Remote Retransfer

11 7 1

6
9
4
12

8
5
3

10

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 332−2879−02 1 Rail, Relay 7 332−2230 2 Terminal, Tap − Plier

2 307−2578 2 Relay, Control 8 332−0802 2 Terminal, Ring (#8)
3 332−2878 2 Bracket, End − Terminal 9 308−0957 1 Switch, Selector (S12)
4 860−0008 2 Nut, Hex (#8−32) 10 098−6561 1 Label, Operation
5 853−0005 2 Washer, Lock − ET (#8) 11 308−0955 1 Switch, Selector (S14)
6 526−0003 2 Washer, Flat (#8) 12 308−0989 A/R Key, Replacement

44 Copyright  2018 Cummins Inc.

 Sequencer

6 2

3 4

5
1

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Board, PC − Sequencer 4 870−0131 4 Nut, Hex w/ET (#10−32)

300−3893−01 1 12 Volt 5 815−0550 4 Screw, Pan Head − Cross
300−3893−02 1 24 Volt Recessed w/ET (#6−32 x 3/8)
2 319−1208 1 Plate, Mounting − Sequencer 6 332−0942 20 Tie, Cable
3 332−2420 10 Mount, Tie − Cable

Copyright  2018 Cummins Inc. 45

 Monitor

3
5

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319−0976−00 1 Plate, Relay 4 332−0941 15 Tie, Cable

2 Relay, Monitor 5 815−0544 6 Screw, Round Head w/IT
307−2801−01 1 240 VAC (#6−32 x 1/2)
307−2801−02 1 380 VAC 6 332−0801 3 Terminal, Ring (#6)
307−2801−03 1 480 VAC 7 332−2630 7 Terminal, Spade (#6)
3 332−2420 5 Mount, Tie − Cable

46 Copyright  2018 Cummins Inc.

 Pins and Sockets

2 3
1 4

5 7
6 8

9 11
10 12
18
16

13 14 15 17
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 323−1292 1 Housing, Pin − 4 Housings) (18−14 AWG)

2 323−1333 1 Housing, Socket − 4 16 323−1195 1 Socket, Contact (Used with
3 323−1317 1 Housing, Pin − 6 Circular Housings)
4 323−1318 1 Housing, Socket − 6 (18−14 AWG)
5 323−1291 1 Housing, Pin − 9 17 323−1199 1 Pin, Contact (Used with
6 323−1325 1 Housing, Socket − 9 Rectangular Housings)
7 323−1314 1 Housing, Pin − 12 (20−14 AWG)
8 323−1315 1 Housing, Socket − 12 18 323−1200 1 Socket, Contact (Used with
9 323−0983 1 Housing, Pin − 12 Rectangular Housings)
10 323−0984 1 Housing, Socket − 12 (20−14 AWG)
11 323−1252 1 Housing, Pin −15 Strain Relief (Not Illustrated)
12 323−1253 1 Housing, Socket − 15 323−1158 1 15 Pin
13 323−1207 1 Housing, Pin − 24 323−1316 1 12 Pin
14 323−1206 1 Housing, Socket − 24 323−1208 1 9 Pin
15 323−1194 1 Pin, Contact (Used with Circular

Copyright  2018 Cummins Inc. 47

 Cabinet
(Set Mounted Switch)

6
12 13
7

10

11

13

3
5
4

319−2381
1

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319−2333 1 Door, Cabinet 8 332−2839 2 Bracket, End

2 098−5387 1 Label, Danger 9 332−2836−02 1 Block, Terminal − Sectional
3 302−1984−04 2 Transformer, Current 10 332−2841 1 Plate, End − Terminal
4 870−0131 4 Nut, Hex − W/ET (#10) 11 332−2842−23 1 Tag, Terminal (101 − 110)
5 319−2483−01 1 Cabinet 12 895−0308 20” Tape − Polyurethane
6 098−6895 1 Label, Alarm 13 895−0172 7” Tape, Neoprene
7 332−3356 1 Rail, Terminal

48 Copyright  2018 Cummins Inc.

 Connecting Hardware
(Set Mounted Switch)
(Diesel Sets)

6
2

4 5

539−1603

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 331−0548 1 Connector, Liquidtite 4 331−0544 5 Washer, Sealing

2 331−0546 1 Connector, Liquidtite (1) 5 331−0543−02 5 Nut, Locking
3 331−0549 1 Conduit, Liquidtite (2’ long) 6 870−2055 3 Nut, Lock − Flange (M8 x 1−1/4)

Copyright  2018 Cummins Inc. 49

 Connecting Hardware
(Set Mounted Switch)
(20 & 25 kW Gas Sets)

3
6
4
3

7 1
8

2
5
1
539−1573

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 331−0547 4 Connector, Liquidtite (1−1/2) 6 815−0858−01 8 Screw, Flange Head

2 331−0550 2 Conduit, Liquidtite (54” long) (M8 x 1−1/4 x 16)
3 331−0546 2 Connector, Liquidtite (1) 7 331−0544 4 Washer, Sealing
4 331−0549 1 Conduit, Liquidtite (54” long) 8 331−0543−02 4 Nut, Locking
5 508−0210 A/R Grommet, Channel Edging

50 Copyright  2018 Cummins Inc.

 Transfer Switch
(10 kW Gas Sets)

8
6
7 5

539−1603

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 895−0172 − Tape, Sealing − Bulk (11/16” Thk 4 331−0546 1 Connector − Liquid Tight (1”)
x 1−1/4” Wide) (Order by the 5 331−0549 − Conduit − Bulk − Liquid Tight
foot − 7 feet required) (1”) (Order by the foot − 2 feet
2 895−0308 − Tape, Sealing − Bulk (1/8” Thk x required)
1” Wide) (Order by the foot − 2 6 331−0544 5 Washer, Sealing
feet required) 7 331−0543−02 5 Nut, Locking − Liquid Tight (1/2”)
3 331−0548 1 Connector, Elbow − 90 Deg − 8870−2055 3 Nut, Locking − Flange Head
Liquid Tight (1”) (M8)

Copyright  2018 Cummins Inc. 51

 Circuit Breakers
(Set Mounted Switch)

2 3

319−2343

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 320−1841−39 1 Breaker, Circuit − Main 4 319−2343−01 1 Bracket, Mounting − Circuit

2 320−1140 1 Breaker, Circuit − Heaters Breaker
3 812−0060 4 Screw, Machine − Round Head 5 098−6879 1 Label, Circuit Breakers
(#6−32 x 5/16) 6 870−0232 2 Nut, Hex − W/ET (1/4)

52 Copyright  2018 Cummins Inc.

 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

098−4339, 35 , 37 300−3121, 17 306−1962, 13 306−3980, 17

098−5387, 19 , 21 , 27 300−3160, 35 306−1964, 13 306−4163, 14
098−5589, 19 , 21 , 27 300−3244, 37 306−1965, 13 306−4173, 12 , 14
098−5680, 19 300−3261, 17 306−1966, 13 306−4174, 12 , 14
098−5681, 19 , 21 300−3267, 17 306−1967, 13 306−4268, 11
098−5692, 27 300−3893−01, 45 306−1968, 13 307−2575, 19
098−5693, 27 300−3893−02, 45 306−1972, 13 307−2577, 39
098−5694, 27 300−3953−01, 17 306−1984, 13 307−2578, 29 , 30 , 44
098−5695, 27 300−3998−01, 40 306−1989, 11 307−2582, 30
098−5699, 19 , 21 300−3998−02, 40 306−1993, 14 307−2583, 30
098−5708, 33 300−4054, 43 306−1994, 15 307−2591, 42
098−5710, 23 , 28 , 31 , 38 301−6727, 27 306−1995, 15 307−2597, 21
, 41 , 43
301−9754, 19 306−1996, 13 , 15 307−2600−01, 21
098−5734, 21
301−9760, 27 306−2013, 12 , 13 307−2648, 19 , 21
098−5773, 19
301−9766, 25 306−2017, 13 307−2801−01, 46
098−5777−01, 27
301−9768, 39 306−2031, 13 308−0406, 19 , 21
098−5807, 35
301−9774, 19 , 21 306−2032, 13 308−0848, 25
098−5808, 35
301−9806, 27 306−2178, 13 308−0849, 25 , 29
098−5809, 35
301−9928−01, 42 306−3384, 11 308−0850, 25 , 29
098−5914, 37
301−9928−02, 42 306−3391, 14 308−0851, 29
098−5915, 37
301−9932, 38 306−3394, 11 308−0854, 25
098−5916, 37
301−9961, 19 , 21 , 23 306−3395, 11 308−0886, 29
098−5995, 35
301−9990, 33 306−3397, 12 308−0904, 27
098−5996, 35
301−9992, 33 306−3399, 12 308−0905, 27
098−5997, 37
302−0807, 33 306−3400−01, 11 308−0955, 29 , 44
098−5998, 37
302−1175, 25 306−3401−01, 11 308−0957, 29 , 44
098−6039, 35
302−1678, 27 306−3401−03, 11 308−0988, 29
098−6561, 29 , 44
302−1692, 25 306−3401−05, 11 308−0989, 25 , 29
098−6635, 27
302−1710, 25 306−3401−06, 11 308−0990, 29
098−6697, 29
302−1711, 25 306−3403, 12 308−0991, 25
098−6879, 52
302−1805−01, 27 306−3464, 25 308−0992, 25
300−2946, 33
302−1805−02, 27 306−3465, 27 308−0993, 25
300−3092, 17
302−1844, 35 , 37 306−3466, 27 308−0994, 25
300−3093−01, 17
302−1984−04, 48 306−3470, 17 308−0997, 25
300−3093−02, 17
302−1992, 25 306−3485−01, 9 309−0393, 14
300−3094, 17
304−0015, 33 306−3485−03, 9 312−0203, 11
300−3095, 43
304−0037, 33 306−3485−04, 9 312−0228, 11
300−3096, 38
304−0139, 33 306−3485−05, 9 312−0257−01, 11
300−3115−01, 42
305−0653, 35 , 37 306−3485−06, 9 312−0257−03, 11
300−3115−02, 42
305−0781, 35 , 37 306−3495, 13 315−0621−01, 33
300−3118, 17
306−1961, 13 306−3525, 27 315−0621−02, 33
300−3119, 17

Copyright  2018 Cummins Inc. 53

 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

315−0621−03, 33 319−0362−05, 27 322−0392−06, 23 332−2230, 30 , 40 , 41 , 44

315−0621−04, 33 319−0362−06, 27 323−0983, 47
332−2352, 12
315−0655−01, 19 319−0363, 25 323−0984, 47
332−2366, 12 , 13
315−0655−02, 19 319−0363−01, 25 323−1158, 47
332−2370, 12
315−0655−03, 19 319−0976−00, 46 323−1194, 47
332−2420, 29 , 33 , 35 , 37
315−0655−04, 21 319−1098, 25 323−1195, 47
, 45 , 46
315−0662, 21 , 27 319−1098−01, 25 323−1199, 47 332−2605, 11
315−0665, 35 319−1099, 25 323−1200, 47 332−2630, 46
315−0667, 35 319−1176−01, 27 323−1206, 47 332−2777, 33 , 35 , 37
315−0669, 35 319−1178−01, 27 323−1207, 47 332−2832, 11
315−0671, 35 319−1182, 25 323−1208, 47
332−2834, 12
315−0673, 35 319−1208, 45 323−1252, 47 332−2835, 13
315−0675, 35 319−1429, 25 323−1253, 47 332−2836−01, 28 , 41
315−0677, 35 319−1502, 43 323−1291, 47 332−2836−02, 23 , 31 , 38
315−0679, 35 319−2050−01, 23 323−1292, 47 , 43 , 48
315−0701, 37 319−2333, 48 323−1314, 47 332−2837−07, 23
315−0703, 37 319−2343−01, 52 323−1315, 47 332−2837−09, 28 , 31 , 38
, 41 , 43
315−0705, 37 319−2483−01, 48 323−1316, 47
332−2839, 23 , 28 , 31 , 38
315−0707, 37 320−0606, 11 323−1317, 47 , 41 , 43 , 48
315−0709, 37 320−0608, 11 323−1318, 47 332−2841, 23 , 28 , 31 , 38
315−0711, 37 320−0876, 11 323−1325, 47 , 41 , 43 , 48
315−0713, 37 320−1140, 52 323−1333, 27 , 47 332−2842−11, 43
315−0715, 37 320−1841−39, 52 323−1387, 17 332−2842−12, 38
315−0723−05, 23 321−0104, 35 , 37 323−1408, 43 332−2842−13, 28 , 38
315−0723−06, 23 321−0127, 35 , 37 323−1409, 38 332−2842−15, 31
319−0002, 19 321−0153, 33 331−0543−02, 49 , 50 , 51 332−2842−16, 23 , 41
319−0009, 21 321−0174, 38 331−0544, 49 , 50 , 51 332−2842−23, 48
319−0072, 35 , 37 321−0175, 33 331−0546, 49 , 51 332−2877, 23 , 27
319−0073, 35 , 37 321−0236, 35 331−0547, 50 332−2878, 30 , 44
319−0124, 27 321−0237, 35 , 37 331−0548, 49 , 51 332−2879−02, 30 , 44
319−0143−01, 27 321−0304−01, 35 331−0549, 49 , 51 332−2880, 12
319−0143−02, 27 321−0304−02, 35 , 37 331−0550, 50 332−2884, 19 , 21
319−0143−03, 27 321−0304−03, 35 , 37 332−0801, 46 332−2903, 11
319−0143−04, 27 321−0304−04, 35 , 37 332−0802, 29 , 30 , 44 332−3084, 12
319−0145, 27 321−0304−05, 35 , 37 332−0941, 29 , 31 , 46 332−3085, 13
319−0146, 27 321−0304−06, 37 332−0942, 11 , 29 , 31 , 33 332−3356, 48
, 35 , 37 , 38 , 39 , 40 , 334−1842, 30
319−0152, 25 322−0133, 23
41 , 42 , 43 , 45
319−0362−01, 27 322−0137, 25 337−2313, 12
332−1348, 27
319−0362−02, 27 322−0168, 25 337−2314, 12
332−1877, 17
319−0362−03, 27 322−0170, 25 337−2315, 12
332−1917, 17
319−0362−04, 27 322−0387−02, 25 337−2316, 12
337−2317, 12

54 Copyright  2018 Cummins Inc.

 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

338−2012, 12 508−1045, 27 815−0652, 11 , 12 , 27 895−0293−06, 27

338−2062, 19 517−0137, 25 815−0653, 12 895−0293−07, 27
338−2063, 25 517−0256, 17 815−0680, 38 , 42 , 43 895−0293−08, 27
338−2071, 19 517−0266, 27 815−0686, 14 895−0293−09, 27
338−2072, 21 518−0404, 27 815−0858−01, 50 895−0293−10, 27
338−2096, 19 525−0305, 27 821−0004, 27 895−0293−11, 27
338−2097, 19 526−0002, 13 821−0005, 11 , 12 895−0308, 51
338−2098, 21 526−0003, 30 , 44 821−0028, 11 , 27 898−0778, 27
338−2133, 25 526−0008, 11 , 12 821−0040, 19 , 21 , 33 , 35
, 37
338−2134, 25 526−0018, 11 , 12
822−2048, 35 , 37
338−2135, 25 526−0022, 27
822−2049, 35 , 37
338−2139, 42 526−0048, 13 , 19 , 21
850−0020, 13
338−2141, 38 532−0374, 29
850−0030, 12
338−2142, 43 539−1344, 40
850−0040, 11 , 12 , 40
338−2149, 33 800−0003, 12
851−0027, 12
338−2161, 33 , 35 , 37 800−0004, 12
851−0031, 12
338−2204−01, 27 800−0005, 12
853−0005, 30 , 44
338−2204−02, 27 800−0006, 40
856−0002, 19 , 21
338−2204−03, 27 800−0008, 11
860−0008, 19 , 21 , 30 , 44
338−2205−01, 27 810−0085, 19 , 21
338−2205−02, 27 812−0060, 52 862−0001, 12 , 40
338−2205−03, 27 812−0066, 15 870−0053, 12
338−2223, 35 , 37 812−0068, 15 870−0131, 11 , 19 , 21 , 23
338−2337, 19 , 21 812−0177, 27 , 27 , 33 , 35 , 37 , 39 ,
45 , 48
338−2349, 31 813−0103, 13
870−0133, 11
338−2949, 33 , 35 , 37 813−0112, 33
870−0134, 27
338−2958, 23 813−0116, 33
870−0201, 14 , 15
338−2959, 23 815−0029, 11
870−0221, 19 , 21 , 28 , 31
338−2961, 23 815−0180, 12 , 35 , 37 , 38 , 41 , 43
338−2983, 33 , 35 , 37 815−0221, 27 870−0232, 52
338−2987, 43 815−0388, 13 870−0281, 27
406−0519, 27 815−0446, 23 , 29 870−0386, 27
406−0610−02, 27 815−0527, 13 870−0439, 25 , 27
406−0610−03, 27 815−0538, 12 , 21 , 23 870−2055, 49 , 51
406−0610−04, 27 815−0539, 13 , 19 878−0032, 23
406−0613, 25 815−0544, 17 , 19 , 21 , 23 895−0172, 51
, 27 , 46
406−0649, 25 895−0293−01, 27
815−0549, 33
406−0912, 25 895−0293−02, 27
815−0550, 21 , 33 , 35 , 37
508−0210, 50 , 42 , 45 895−0293−03, 27
508−0231, 27 815−0555, 19 895−0293−04, 27
508−0233, 27 815−0651, 11 895−0293−05, 27

Copyright  2018 Cummins Inc. 55

THIS PAGE IS INTENDED TO BE BLANK
[Link]
Copyright E 2018 Cummins Inc. All rights reserved.
Cummins, the “C” logo, PowerCommand, AmpSentry, and InPower are trademarks of Cummins Inc.
Other company, product, or service names may be trademarks or service marks of others.
Specifications are subject to change without notice.