SAFETY.CAT.

COM

DICTIONARY OF
PICTOGRAPH SYMBOLS

Excerpted from Operation & Maintenance Manual (SEBD0400-03-01)

2007 Caterpillar
All Rights Reserved

i01658146

Important Safety Information

Most accidents that involve product operation, maintenance and repair are caused by failure to
observe basic safety rules or precautions. An accident can often be avoided by recognizing potentially
hazardous situations before an accident occurs. A person must be alert to potential hazards. This
person should also have the necessary training, skills and tools to perform these functions properly.
Improper operation, lubrication, maintenance or repair of this product can be dangerous and
could result in injury or death.
Do not operate or perform any lubrication, maintenance or repair on this product, until you have
read and understood the operation, lubrication, maintenance and repair information.
Safety precautions and warnings are provided in this manual and on the product. If these hazard
warnings are not heeded, bodily injury or death could occur to you or to other persons.
The hazards are identified by the Safety Alert Symbol and followed by a Signal Word such as
DANGER, WARNING or CAUTION. The Safety Alert WARNING label is shown below.

The meaning of this safety alert symbol is as follows:

Attention! Become Alert! Your Safety is Involved.
The message that appears under the warning explains the hazard and can be either written or
pictorially presented.
Operations that may cause product damage are identified by NOTICE labels on the product and in
this publication.
Caterpillar cannot anticipate every possible circumstance that might involve a potential hazard. The
warnings in this publication and on the product are, therefore, not all inclusive. If a tool, procedure,
work method or operating technique that is not specifically recommended by Caterpillar is used,
you must satisfy yourself that it is safe for you and for others. You should also ensure that the
product will not be damaged or be made unsafe by the operation, lubrication, maintenance or
repair procedures that you choose.
The information, specifications, and illustrations in this publication are on the basis of information that
was available at the time that the publication was written. The specifications, torques, pressures,
measurements, adjustments, illustrations, and other items can change at any time. These changes can
affect the service that is given to the product. Obtain the complete and most current information before
you start any job. Caterpillar dealers have the most current information available.

When replacement parts are required for this

product Caterpillar recommends using Caterpillar replacement parts or parts with equivalent
specifications including, but not limited to, physical dimensions, type, strength and material.
Failure to heed this warning can lead to premature failures, product damage, personal injury or
death.

3
Table of Contents

Table of Contents
Systems Operation Section
General Information ..............................................
Agricultural Tractors ..............................................
Basic .....................................................................
Brake System .......................................................
Clamshell Bucket ..................................................
Climate Control .....................................................
Dozer ....................................................................
Dumper and Hauler ..............................................
Earthmoving Grapple ............................................
Electrical System .................................................
Engine ...................................................................
Excavator and Backhoe ........................................
Excavator and Shovel ...........................................
Felling ...................................................................
Fuel System .........................................................
General .................................................................
Grader ...................................................................
Hydraulic System .................................................
Lighting .................................................................
Loader ...................................................................
Load Handling .......................................................
Log Handling .........................................................
Material Handling ..................................................
Paving ...................................................................
Ripper ...................................................................
Safety ....................................................................
Saw Unit ...............................................................
Scraper .................................................................
Seat ......................................................................
Stabilizer System ..................................................
Telehandler ...........................................................
Track Type Tractor .................................................
Transmission ........................................................
Tree Harvester and Feller Buncher .......................
Winch ....................................................................
Window and Visibility ............................................

4
4
10
12
14
15
17
19
20
21
23
29
33
33
34
36
46
48
51
53
57
58
60
61
64
64
66
67
68
70
71
72
73
77
78
80

Index Section
Index ..................................................................... 82

4
Systems Operation Section

Systems Operation Section

i01781281

Tractor-Ground Speed g00694013

General Information
SMCS Code: 7000
This manual is a listing of the pictrographs
and symbols that are used by Caterpillar. The
pictographs are sorted by application.

Tractor With Front PTO- Side View Of

Machine g00694018

i01552781

Agricultural Tractors
SMCS Code: 7000

Tractor With Rear PTO- Side View Of

Machine g00694129

Level Adjustment - Operator Compartment

Left g00693988
Tractor With Front PTO- Overhead View Of
Machine g00694130
Level Adjustment - Operator Compartment
Right g00693989
Tractor With Rear PTO- Overhead View Of
Machine g00694132
Work Distance Traveled g00693990
Tractor With Towed Implement-Row
Guidance g00694147
Rockshaft - Upper Limit g00693999
Implement Width g00694151

Rockshaft - Lower Limit g00694000

Four-Wheel Drive g00694154

Rockshaft - Depth Control - Maximum

Depth g00694009
Area Worked g00694158

Rockshaft - Depth Control - Minimum

Depth g00694011

5
Systems Operation Section

Area Worked Per Hour g00694162

PTO/Power Take-Off g00694201

Rockshaft-Basic g00694172

PTO/Power Take-Off-Rotational Speed

g00694624:

Rockshaft-Up/Raise g00694174

Tractor- Wheel Slip g00694625

Rockshaft-Down/Lower g00694177

Tractor-Basic- Side View g00694626

Rockshaft- Float g00694181

Tractor- Forward Movement- Side View

g00694627

Remote Cylinder- Basic g00694183

Tractor- Rearward Movement- Side View

g00694628

Remote Cylinder- Extend g00694185

Tractor- Basic- Overhead View

g00694629

Remote Cylinder- Retract g00694189

Tractor- Forward Movement- Overhead

View g00694630

Remote Cylinder- Float g00694193

Tractor- Rearward Movement- Overhead

View g00694633

Differiential Lock g00694199

Tractor- Auxilary Headlights g00694634

6
Systems Operation Section

Tractor- Main Headlights g00694636

Draft Control g00762972

Tractor- Front Wheel Drive g00694640

% Track Slip g00762976

Tractor- Front Wheel Drive- Automatic

Operation g00694641

Tractor- Front Wheel Drive-Brake

g00694644

Machine Ground Speed g00911040

Flow Control g00911045

Trailer 1 g00694656
Right Cylinder Retract g00911046

Trailer 2 g00694660
Remote Cylinder Extend g00911049

Area Worked Per Hour g00694662

Trailer Connector g00717168

Machine Ground Speed g00694664

Forward Speed g00911050

% Track Slip g00694667

Belt Tension g00694670

Percent Slip g00911052

7
Systems Operation Section

Auto Pilot g00904731

Clean Grain Elevator Belt Slip g00904745

Threshing Drum Belt Slip g00904733

Chaff Spreader Belt Slip g00904748

Feeder Chain Belt Slip g00904735

Intensive Separation System Speed

Sensor, Front g00904750

Fan Belt Slip g00904736

Clean Grain Elevator Speed Sensor

Defective g00904753

Threshing Drum Speed Sensor Defective

g00904737

Chaff Spreader Speed Sensor Defective

g00904755

Feeder Speed Sensor Defective

g00904835

Engine Load Drop g00904758

Cleaning Fan Sensor Defective

g00904739

Intensive Separation System Belt Slip,

Rear g00904759

Rear Wheel Position/3D Sieve Pan L/H

g00904740

Chopper Belt Slip g00904760

Main Drive Belt Slip g00904743

Returns Elevator Belt Slip g00904763

Intensive Separation System Belt Slip,

Front g00904744

Threshing Concave Sensor Defective

g00904765

8
Systems Operation Section

Engine Speed Sensor Defective

g00904767
Grain Tank Unloading Tube Out
g00904790

Intensive Separation System Speed

Sensor, Rear g00904769
Air Cleaner Filter Cartridge Clogged
g00904791

Chopper Speed Sensor Defective

g00904771
500 H Service g00904793

Returns Elevator Speed Sensor Defective

g00904777
100 H Service g00904794

Rear Wheel Position/3D Sieve Pan R/H

g00904778
50 H Service g00904795

Cooling Water Level g00904782

10 H Service g00904796

Chopper Not in End Position g00904786

Grain Tank Full g00904798

Hydrostat Filling Level Too Low

g00904787
Grain Tank 70 % g00904800

Measuring Range of Yieldmeter

Exhausted g00904788
Less Than 10 % Fuel Left in Tank
g00904802

Grain Tank Unloading On g00904789

9
Systems Operation Section

Interruption to Sensor For Cutting Height Feed Rake g00904804

Sensitivity Separation g00451315

Rotor Belt Slip g00904812

Sensitivity of Sieve Sensors g00451316

Rotor Speed Sensor Defective

g00904819

Lower Sieve Adjustment g00451317

Threshing Drum Speed g00451306

Concave Position g00451307

Fan Speed - Combine g00904821

Reel Speed - Combine g00451309

Upper Sieve Adjustment g00451310

Parial Width g00904824

Area g00453371

Area Work Rate g00453374

Yield g00453375

Yield Rate g00453377

Daily Recorder g00453378

Main Drive Speed Sensor Defective

g00465184

Feeder Chain Speed g00451313

Tractor - High Drive Basic g00716998

10
Systems Operation Section

Tractor - High Drive Track Slip g00716999

Radio g00679044

Tractor - High Drive Ground Speed

g00717000
Wrench - Service g00679046

Trailer g00717002
Gauge g00679047

i01553732

Basic

Lever Movement (Operation Direction)

g00679048

SMCS Code: 7000

Ladder g00679030
Prohibited g00679049

Up g00679039
Off/Inactive g00679050

Key - Universal g00679040

Wheel g00910482

Fragile g00679041
Oil g00679052

Action Light- Failure Malfunction

g00679042
Water/Coolant g00679054

Broom g00679043

11
Systems Operation Section

Intake Air g00679056

Tire - Pressure g00718127

Exhaust g00679059

Tire - Failure/Malfunction g00718130

Pressure g00679059

Wheel Adjustment - Left Wheel - Move

Out g00718132

Level Indicator g00679061

Wheel Adjustment - Left Wheel - Move In

g00718133

Filter g00679062

Wheel Adjustment - Right Wheel - Move

Out g00718136

Temperature g00679064

Wheel Adjustment - Right Wheel - Move

In g00718137

Failure/ Malfunction g00679065

Loadgate - Basic Symbol g00718418

Temperature Select g00059582

Loadgate - Up g00718419

Horn Radio g00112871

Loadgate - Down g00718420

Tire - Basic Symbol g00718126

Arrow - Direction of Motion of Entire

Machine g00716184

12
Systems Operation Section

Arrow - Direction of Motion of Machine

Components g00716185
Secondary Brake g00688029

Arrow - Pressure of Force g00716186

Park Brake Light g00910836

Prohibited g00716188
Park Brake - On g00688031

Fasten Seat Belt g00716191

Park Brake - Off - Hold g00688033

Push/Pull g00716193
Brake Oil/Fuel Level g00688034

Operator/Identification g00716189
Brake System - Basic g00688037

i01769032

Brake System

Brake Oil/Fluid g00690467

SMCS Code: 7000

Brake System - On g0682250
Brake System - Pressure g00690469

Brake System - Off g00688025

Brake System - Filter g00690470

Brake System - Off - Hold g00688027

13
Systems Operation Section

Brake System - Temperature g00690472

Brake - Oil Temperature g00691066

Park Brake g00690473

Brake - Air Pressure g00691067

Park Brake - Release g00690475

Brake - Park g00691070

Brake System - Failure/Malfunction

g00690476

Secondary Brake - On g00691071

Brake System - First Trailer Failure/Malfunction g00690477

Brake - On g00691072

Brakey System - Second Trailer Failure/Malfunction g00690478

Brake - Off g00691074

Anti-Lock Brake System - Failure/

Malfunction g00690479

Brake - Off - Hold g00691076

Worn Brake Linings g00691060

Brake - Failure g00691077

Brake g00691062

Brake - Oil Pressure g00691078

Brake - Oil Pressure g00691063

Brake Temperature g00904726

14
Systems Operation Section

Brake Oil Coolant g00716562

Clamshell Bucket- Swing Back
g00694859

Brake Oil/Fluid Auxillary Circuit

g00716571
Calmshell Bucket- Hold g00694861

Impending Brake Application g00716574

Clamshell Bucket- Float g00694863

Brake Oil/Fluid - Cold Oil Auxillary Circuit

g00716577
Clamshell Bucket- Constant Closing
Pressure g00694865

Brake Oil Coolant - Fill Container

g00716579
Clamshell Bucket- Basic g00694867

Brake And Steering Oil - Fill Container

g00716953
Clamshell Bucket- Open g00694869

Secondary Brake System - Off

g00716956
Clamshell Bucket- Closed g00694870

i01553986

Clamshell Bucket

Clamshell Bucket- Rotate g00694872

SMCS Code: 7000

Clamshell Bucket- Swing g00694855
Clamshell Bucket- Rotate Clockwise
g00694875

Clamshell Bucket- Swing Forward

g00694858

15
Systems Operation Section

Air- Inside- Circulating g00692877

Clamshell Bucket- Rotate Counter

Clockwise g00694877

i01554009

Air- Outside- Circulating g00692880

Climate Control
SMCS Code: 7000
Temperature Control- Color Required (RedHot/Blue- Cold) g00692861

Air- Filter g00692883

Temperature-High (May Be Red To Signify

Warm/Hot Temperatues) g00692862

Air- Filter Fault g00692884

Temperature- Low (May Be Blue To Signify

Cool/Cold Temperatures) g00692864

Filter Removal g00692885

Air Temperature g00692868

Ventilation/ Air- Circulating Fan- Left

g00692886

Air Flow g00692869

Ventilating/ Air- Circulating Fan- Right

g00692888

Air Flow-Off g00692871

Air Dryer g00692889

Air-Flow-Pressure g00692873

Heater/ Interior Heating g00692890

Air-Flow-Emergency g00692875

Air Conditioning/ Cooling System

g00692891

16
Systems Operation Section

Ventilating/ Air Circulating Fan

g00692893
Air- Flow g00693554

Ventilation Air Flow- Upper g00693521

Air- Temperature g00693578

Ventilation Air Flow- Lower g00693525

Air Filter Pressure g00693580

Ventilation Air Flow- Upper & Lower

g00693527
Temperature Control g00693581

Dehumidifier g00693529
Temperature Control g00693583

Heat Or Heater g00693531

Air Filter g00693586

Air Conditioner g00693533

Temperature Select g00762993

Fan g00693547
Air Recirculate g00762994

Air- Filter g00693548

Fresh Air g00763139

Air- Pressure g00693549

17
Systems Operation Section

Head Louver g00763140

Engine - Air Pressure Fill Container

g00716996

Head And Leg Louver g00763143

Engine - Air Pressure Flow Emptying

g00716997

Leg Louver g00763144

i01554111

Dozer
SMCS Code: 7000
User Mode g00763151

Louver Indicator g00763153

Dozer Blade- Basic g00695246

Dozer Blade- Raise g00695247

Preset Temperature Indicator g00763154

Dozer Balde- Lower g00695320

Dozer Blade- Hold g00695322

Fan Speed Indicator g00763156

Defrost/ Leg Louver g00763159

Cab Temperature Regulator g00763160

Cab Air Flow g00763163

Dozer Blade- Float g00696232

Dozer Blade- Pitch Forward g0696234

Dozer Blade- Pitch Rearward g00696235

18
Systems Operation Section

Dozer Blade- Tilt Left g00696239

Bullldozer- Angle Right g0090998

Dozer Blade- Tilt Right g00696241

Bulldozer- Angle Left g00909989

Dozer Blade- Angle Left g00696244

Bulldozer- Tilt Forward g00909990

Dozer Blade- Angle Right g00696246

Bulldozer- Tilt Rearward g00909992

Bulldozer- Raise g00696248

Dozer Blade - Single Tilt Lock g00717006

Bulldozer- Lower g00696251

Dozer Blade - Dump Automatic
g00717023

Bulldozer- Hold g00696253

Dozer Blade - Carry Automatic
g00717024

Bulldozer- Float g00696255

Dozer Blade - Max Load g00717025

Bulldozer- Tilt Right g00909674

Dozer Blade - Min Load g00717026

Bulldozer- Tilt Left g00909675

19
Systems Operation Section

i01554124

Dumper and Hauler

Dumper/ Hauler Body- Basic g00714760

SMCS Code: 7000

Dumper/ Hauler- Wagon- Center DumpOpen g00763231

Dumper/ Hauler- Wagon- Center DumpClose g00763232

Dumper/ Hauler Body- Raise / Dump

g00714761

Dumper/ Hauler Body- Lower g00714764

Dumper/ Hauler- Wagon- Center DumpHold g00763233

Dumper/ Hauler Body- Hold g00714766

Dumper/ Hauler- Wagon- Center DumpFloat g00763234

Dumper/ Hauler Body- Float g00714767

Dumper/ Hauler Body- Payload

g00714748
Dumper/Hauler Body - Float Off
g00717151
Dumper/ Hauler- Hitch g00714754
Dumper/Hauler - Hitch g00717154

Dumper/ Hauler- Towing g00714755

Dumper/Hauler - Front Brake g00717156

Dumper/ Hauler- Towing- Valve Position

g00714756
Dumper/Hauler Body - Heating
g00717160
Dumper/ Hauler- Basic - Side View
g00714758

20
Systems Operation Section

i01554129

Earthmoving Grapple

Grapple- Swing Forward g00695227

SMCS Code: 7000

Grapple/Clamshell- Stick Extended
g00695202

Grapple Clamshell- Stick Retracted

g00695203

Grapple- Swing Back g00695228

Grapple- Hold g00695229

Grapple/Clamshell-Stick- In g00695206
Grapple- Float g00695230

Grapple/Clamshell-Stick-Out g00695212
Grapple- Constant Closing Pressure
g00695235
Grapple/ Clamshell- Boom-In g00695214

Grapple- Basic g00695237

Grapple/ Clamshell- Boom- Out
g00695218
Grapple- Open g00695239
Grapple/ Clamshell- Boom- Raise
g00695219
Grapple- Close g00695241
Grapple/ Clamshell- Boom- lower
g00695220
Grapple- Rotate g00695242
Grapple- Swing g00695221

Grapple- Rotate Clockwise g00695243

21
Systems Operation Section

Grapple- Rotate Counter Clockwise

g00695245

Boom Swing - Swing Left g00907367

Grapple- Close Automatic g00717005

Boom Swing - Swing Right g00907366

Grapple Skidder - Single Function Boom Basic g00718320

Grapple - Close Automatic g00717005

Grapple Skidder - Single Function Boom Up/In g00718321

i01554154

Electrical System
SMCS Code: 7000

Grapple Skidder - Single Function Boom Down/Out g00718324

Electrical- Off g00714770

Grapple Skidder - Double Function Boom

- Basic g00718339

Voltage- High g00714772

Grapple Skidder - Double Function Boom

- Out g00718342

Voltage-Low g00714773

Grapple Skidder - Double Function Boom

- In g00718345

Converter- Electric g00714774

Grapple Skidder - Double Function Boom

- Up g00718363

Amperes g00714775

Grapple Skidder - Double Function Boom

- Down g00718364

Electrical- Emergency g00714776

22
Systems Operation Section

Vital Information Management System

g00714788
Electrical-Cab Power g00714777

Electrical Monitoring System (EMS)Digital g00714789

Electrical Energy- Outlet g00714779

Electrical Monitoring System (EMS)

g0714793
Direct Current g00714780

Circuit Breaker g00714807

Alternating Current g00714781

Circuit Breaker- Reset g00714808

Ground g00714782

Test- Electrical System g00714809

Fuse g00714784

Test Fault- Electrical System g00714811

Generator- Differential Fault g00714785

Computerized Profiler Control Fault

g00714812
Solenoid g00710325

Display Mode Switch- Rotate Through

Display g00714815
Vital Information Management System
(Electronic Instrumentation) g00714787

Operator Sequence Fault g00714816

23
Systems Operation Section

Radar Sensor g00714818

Electrical Terminal g00717169

Auxilary Power Outlet g00763407

ECM Battery Backup g00717170

Terminal Strip g00717169

i01554198

Engine
SMCS Code: 1000
CA Earth Moving System g00763408

Engine- Electrical Disconnect- Switch On

g00680596

Electronic Display - Basic Symbol

g00717161

Engine- Electrical Disconnect- Switch Off

g00680600

Relay g00717163

Engine- Elapsed Operating Hours

g00680602

Set - Diagnostic Use Only g00717164

Coolant- Flow g0680603

Clear - Diagnostic Use Only g00717165

Engine- After Cooler- Coolant g00680610

Generator - Electrical Power g00717166

Coolant- Conditioner g0680607

Trailer Connector g00717168

Engine- Starting Aid- Coolant Heater

g00680608

24
Systems Operation Section

Engine- Oil Pressure Override

g00680643
Engine- Overload g00680613

Engine Fuel injection- Electronic

g00680644
Engine- Percent Load g00680614

Engine Fuel Injection- Not Electronic

g00680647
Engine- High Idle- Hold g00680618

Engine- Rotational Speed- Automatic

Control g00680662
Engine- Over Crank g00680621

Engine- Coolant- Fan And Shutters

g00680665
Enine- Over Speed g00680623

Tank- Ethanol- Low g00680666

Engine- Increased Horsepower
g00680624

Tank- Ethanol- Empty g00680668

Engine- Service g00680626

Filter Pressure- Ethanol- Primary

g00680670
Engine- Prelube- Start Pressure
g00680635

Filter Pressure- Ethanol- Secondary

g00680672
Engine- Oil Filter Pressure g00680637

Engine- Basic g00680673

25
Systems Operation Section

Engine Oil g00680675

Engine Intake/ Combustion- Air

g00680689

Engine Oil- Pressure g00680676

Engine Intake/ Combustion- Pressure

g00680690

Engine Oil- Level g00680677

Engine Intake/ Combustion- Filter

g00680692

Engine Oil- Filter g00680679

Engine Intake/ Combustion- Temperature

g0068093

Engine Oil- Temperature g00680681

Engine Exhaust Gas g0068095

Engine Coolant g00680683

Engine Exhaust Gas- Pressure

g00680871

Engine Coolant- Pressure g00680685

EngineExhaust Gas-Temperature
g00680876

Engine Coolant- Level g00680686

Engine- Start g00680878

Engine Oil- Filter g00680687

Engine- Stop g00680882

Engine Coolant- Temperature g00680688

Engine- Run g00680884

26
Systems Operation Section

Engine- Urgent Stop g00680913

Engine- Rotational Speed g00680887

Engine- Oil g00680914

Engine- Failure/ Malfunction g00680889

Engine- Oil Filter g00680917

Engine- Choke g00680890

Engine- Oil Filter Pressure g00680918

Engine-Primer g00680892

Engine- Crankcase Pressure g00680920

Engine- Diesel Preheat/ Glow Plugs
g006809894

Engine- Oil Level g00680932

Engine- Electrical Preheat g00680895

Engine- oil Pressure g00680933

Engine-Gas Injection g00680898

Engine- Oil Temperature g00680935

Engine- Hand Throttle g00680900

Engine- Start Or Running g00680939

Electrical Power- Accessories g00680904

Engine- Stop Or Not Running g00680942

27
Systems Operation Section

Throttle Sensor Override g00763412

Engine- RPM g00680944

Idle Shutdown Timer g00716525

Engine- Hours g00680945

Engine- Starting Aid- Ether g00680947

Flexxaire Fan g00763414

Coolant- Level g00680948

Low Idle Indicator g00344972

Coolant g00680949

Engine Solenoid Shutoff g00763416

Coolant- Pressure g00680950

Engine Coolant- Level- Radiator Check

g00763419

Coolant- Temperature g00680952

Engine Coolant- Level- Reservoir Check

g00763422

Primary Air Cleaner g00763423

Coolant- Flow g006809553

Secondary Air Cleaner g00763428

Electrical- Disconnect- Switch- Off
g00680955

Engine Coolant - Additive g00763435

Loader- AEC Switch g00061979

28
Systems Operation Section

Engine Power Mode 100% g00569819

Engine - Run Temperature g00716509

Engine Power Mode 100% of Engine Power

Not Available g00569820
Engine - Low Idle Hold g00716510

AEC Position 1 g00569821

Oil Lubrication Point g00716511

AEC Position 2 g00569822

Engine Prelube - Basic g00716512

Engine Air Filter Service Indicator

g00763436
Engine - Reversible Fan g00716514

Engine Coolant Flow Level g00716474

Engine - Fan Bearing g00716515

Engine Coolant - Extended Life Coolant

g00716499
Engine - Fan Belt Idler g00716516

Engine - Manifold Heat Starting Aid

g00716501
Engine - After Cooler Coolant g00716517

Engine - High Idle Hold Set g00716505

Enigne Coolant - Fill Container
g00716518
Engine - High Idle Hold Reset g00716507

29
Systems Operation Section

Engine - Air Start g00716519

Excavator/Backhoe-Hammer - Hydraulic
g00712543

Engine - Air Start - Fill Container

g00716520

Excavator/Backhoe - Bucket Detach

g00712544

Engine Oil - Fill/Empty Container

g00716521

Excavator/Backhoe - Heavy Lift

g00712545

Engine Coolant - Fill/Empty Container

g00716522

Excavator/Backhoe - Boom Raise Increased Boom Lift g00712546

Engine Brake - "Jake Brake" g00716524

Excavator/Backhoe - Boom Lock Increased StickLift g00712551

Engine Shutdown Timer g00716525

Excavator/Backhoe - Swing Brake Off

g00712552

Hold - Engine Start g00716527

Excavator/Backhoe - Swinglock
Disengage g00712554

Engine Transmission - Ground Speed

g00716528

Excavator/Backhoe - Adustable Boom Raise g00712555

i01743638

Excavator/Backhoe - Adjustable Boom Lower g00712558

Excavator and Backhoe

SMCS Code: 7000
Excavator - House Compartment
g00712532

Excavator/Backhoe - Swing Brake On

g00712558

30
Systems Operation Section

Excavator/Backhoe - Coupler Wedge Disengage g00712560

Excavator/Backhoe - Arm - Out
g00712591

Excavator/Backhoe - Coupler Wedge Engage g00712564

Excavator/Backhoe - Arm - In g00712592

Excavator - Basic - Top View g00712567

Excavator/Backhoe - Arm - Extend
g00712593

Excavator - Basic - Side View g00712569

Excavator/Backhoe - Arm - Retract
g00712597

Excavator/Backhoe - Basic Hoe

Equipment g00712572
Excavator/Backhoe - Bucket - Dump
g00721598

Excavator/Backhoe - Boom - Raise

g00712574
Excavator/Backhoe - Bucket Dig/Rollback g00712600

Excavator/Backhoe - Boom - Lower

g00712575
Excavator/Backhoe - Boom Swing - Basic
g00712605

Excavator/Backhoe - Boom - Extend

g00712582
Excavator/Backhoe - Boom Swing - Left
g00712609

Excavator/Backhoe - Boom - Retract

g00712585
Excavator/Backhoe - Boom Swing - Right
g00712611

Excavator/Backhoe - Boom - Transport

Lock g00712589

31
Systems Operation Section

Excavator/Backhoe - Boom Swing - Lock

g00712612

Backhoe - Swing Left g00712635

Excavator/Backhoe - Boom Swing Brake g00712615

Backhoe - Dig g00712636

Excavator/Backhoe - Boom Side Shift Basic g00712616

Backhoe - Dump g00712637

Excavator/Backhoe - Boom Side Shift Left g00712618

Backhoe - Side Shift g00712640

Excavator/Backhoe - Boom Side Shift Right g00712619

Backhoe - Arm Retracted g00712642

Excavator/Backhoe - Boom Side Shift Lock g00712622

Hammer - Hydraulic g00712643

Backhoe - Boom Lower g00712625

Fine Control g00763438

Backhoe - Boom Raise g00712626

Fine Swing g00763442

Backhoe - Stick In g00712628

Boom Priority g00763505

Backhoe - Swing Right g00712629

Swing Priority g00763507

32
Systems Operation Section

Overload Warning g00763508

Implement Open g00763521

Overload Warning g00763509

Tilt Cab - Raise g00468614

Stick Out g00763510

Tilt Cab - Lower g00468618

Arm Extend g00763513

Cab Tilt- Up g00468830

Swing Left g00763515

Cab Tilt - Down g00468833

Swing Right g00763516

Failure/Malfunction - Boom System
g00717079

VA Boom - Raise g00763517

Failure/Malfunction - Bucket System
g00717080
VA Boom - Lower g00763518
Excavator - Swing Drive Oil Level
g00717081
Combined Circuit g00763519
Bucket Width g00717083

Implement Close g00763520

33
Systems Operation Section

i01753162

i01775392

Excavator and Shovel

Felling

SMCS Code: 7000

SMCS Code: 7000

Excavator/Shovel - Swing Right

g00713829

Felling Head - Basic Symbol g00718269

Excavator/Shovel - Swing Left

g00713830

Felling Head - Tilt Up g00718272

Excavator/Shovel - Basic g00713832

Felling Head - Tilt Down g00718273

Excavator/Shovel - Boom - Raise

g00713836

Fixed Boom Felling Head - Turn Left

g00718274

Excavator/Shovel - Boom - Lower

g00713838

Fixed Boom Felling Head - Turn Right

g00718276

Excavator/Shovel - Arm - Out g00713840

Felling Head - Side Tilt - Tilt Left

g00718277

Excavator/Shovel - Arm - In g00713841

Felling Head - Side Tilt - Tilt Right

g00718279

Excavator/Shovel - Bucket - Dump

g00713842

Felling Shear - Basic Symbol g00718281

Excavator/Shovel - Bucket - Dig/Rollback

g00713843

Felling Shear - Open g00718283

34
Systems Operation Section

Felling Shear - Close g00718286

Felling Shear - Swing Right g00717131

Bunk Jaws/Grab Arms - Basic Symbol

g00718287
Felling Shear - Swing Left g00717133

Bunk Jaws/Grab Arms - Open g00718288

Felling Shears - Shear Blade Off
g00717135

Bunk Jaws/Grab Arms - Close

g00718289
i01765790

Fuel System
Bunk Jaws/Grab Arms - Left Jaw/Arm Out g00718290

SMCS Code: 1000; 7000

Fuel - Gasoline g00691079

Bunk Jaws/Grab Arms - Left Jaw/Arm - In

g00718291
Fuel - Filter Fault g00691080

Bunk Jaws/Grab Arms - Right Jaw/Arm Out g00718292

Fuel or Fuel System - Basic g00691780

Bunk Jaws/Grab Arms - Right Jaw/Arm In g00718293

Fuel - Pressure g00691786

Bunk Jaws/Grab Arms - Ropes - Tighten

g00718294
Fuel - Level g00691791

Bunk Jaws/Grab Arms - Ropes - Slacken

g00718295

35
Systems Operation Section

Fuel - Filter g00691794

Fuel Level Check g00691826

Fuel - Temperature g00691796

Fuel - Pressure g00691828

Fuel System - Failure/Malfunction

g00691798

Fuel Drain g00722460

Fuel Shut-Off g00691802

Fuel Drain Shut-Off g00722462

Diesel Fuel g00691809

Fuel Shut-Off g00722463

Fuel - Filter Pressure g00691811

Fuel System - Water Separator

g00905515

Fuel - Level g00691812

Fuel System - Water Separator - Drain

g00905517

Fuel - Pressure g00691813

Fuel System - Water Separator - Filter Drain g00905518

Fuel Shut-Off g00691814

Fuel - Level g00691824

Fuel - Economy Mode g00716957

Fuel - Heater g00716959

36
Systems Operation Section

Fuel - Water Separator g00716961

Hook - Raise g00905534

Fuel Draining Emptyiing g00716964

Turn - Right g00905538

Fuel - Water Separator Level g00716965

Turn - Left g00905539

i01771260

General

Steering Wheel - Machines g00905540

SMCS Code: 7000

Lift With Fork g00905522
Secondary Steering g00905543

Do Not Lift g00905523

Foot Control g00905544

Do Not Lift With Fork g00905525

Foot Control - Increase g00905545

Lift And Spreader Bar g00905526

Foot Control - Decrease g00905546

Hook - Lower - Emergency g00905528

Ride Control g00905547

Hook - Lower g00905532

37
Systems Operation Section

Open g00905548

Operator Alert g00905568

Close g00905550

Alarm g00905569

Filling g00905551

Convert g00905571

Biodegradable g00905555

Enter Data g00905573

Filter - Installation g00905556

Save Entered Data g00905575

Grease Lubrication - Automatic

g00905557

Cancel Entered Data g00905576

Oil Flow g00905558

Manual Operation/Manual Start

g00905583

Oil Pressure g00905563

Digital Counter g00905581

Front Trunnion - Loader g00905566

Handle g00905586

Rear Trunnion - Loader g00905567

Handle - Pull g00905587

38
Systems Operation Section

Handle - Pull and Rotate g00905588

Conveyor g00905867

Handle - Push g00905590

Fixed Restriction - Common Liquids
g00905869

Handle - Push And Rotate g00905611

Traction Control System - Wheel Slip
g00905871

Handle - One Function g00905614

Wheel Drive g00905872

Handle - One Function g00905616

Pin - Engage g00905873

Handle - Two Function g00905618

Pin - Disengage g00905875

Handle - Multi-Function g00905619

Cushion Axle g00905877

Rotate - Clockwise/Counter Clockwise

g00905623
Dumper/Hauler - Basic g00905878

Lever Movement g00905624

Track Type Tractor - Basic g00905879

Not in Automatic g00905625

39
Systems Operation Section

Manual Operation - Unlock g00905880

Minus/Decrease/Negative Polarity
g00905895

Public Roadway - Switch/Light

g00905881

Horn g00905896

Cab - Basic g00905883

Lighter g00905897

Automatic g00905884

Battery Charging Condition g00905898

On/Start g00905886

Battery Power - Disconnect g00905899

Off/Stop g00905888

Clock/Time/Switch/Timer g00905900

On & Off g00905890

Hourmeter/Elapsed Operating Hours

g00905902

Engage g00905892

Seatbelt - Lapbelt Only g00905903

Disengage g00905893

Fast g00905904

Plus/Increase/Positive Polarity
g00905894

Slow g00905905

40
Systems Operation Section

Continuously Variable - Linear

g00905907
Oil Lubrication Point g00906157

Continuously Variable - Rotational

g00905910
Lift Point g00906158

Volume - Empty g00905912

Jack or Support Point g00906160

Volume - Half Full g00905913

Tie Down Point g00906167

Volume - Full g00905914

Draining/Emptying g00906170

Control Lever Operating Direction - Dual

g00905915
Read Operators Manual g00906175

Control Lever Operating Direction Multiple g00905916

Service Indicator/Read Technical Manual
g00906178

Clockwise Rotation g00906151

Lock g00906182

Counter Clockwise Rotation g00905152

Unlock g00906184

Grease Lubrication Point g00906154

41
Systems Operation Section

Steering Wheel - Tilt Control g00906185

Secondary Steering g00906306

Rearward Moving Machine Arm

g00906187

Left or Left Turn g00906307

Rearward Moving Machine Arm - Cancel

g00906241

Right or Right Turn g00906315

Lock g00906273

Horn g00906318

Unlock g00906243

Back-Up Alarm g00906323

On g00906295

Oil Pressure g00906326

Off g00906302

Oil Temperature g00906328

Hours g00906303

Battery g00906332

Continuously Variable g00906304

Accessory Speed - Low g00906334

Steering g00906305

Accessory Speed - Medium g00906338

42
Systems Operation Section

Accessory Speed - High g00906339

Rimpull 70 % g00680544

Accessory Speed - Low g00680577

Rimpull 75 % g00680548

Accessory Speed - Medium g00680574

Rimpull 80 % g00680549

Accessory Speed - High g00911198

Break g00680552

Accessory Speed - 4 g00906676

Travel Speed Control g00680554

Accessory Speed - Maximum g00584140

Monitor Panel g00680559

Front Wheel Drive g00906340

High Speed Position g00680562

Ride Control Automatic g00906347

Secondary Steering g00680579

Ride Control g00906346

Handle - Pull g00680582

Rimpull 65 % g00680542

43
Systems Operation Section

Handle - Push g00680585

Foot Control - Increase g00906671

Torque Converter/Hour Meter g00680586

Foot Control - Decrease g00906674

Do Not Grease or Lubricate g00680587

Hook Hold g00447227

Do Not Grease or Lubricate g00680593

Hook Hold g00906665

Increase g00906666

Clear g00451345

OK/Enter g00451347

Arrow Up g00451348

Decrease g00906668
Arrow Down g00451349

Shutters g00906669
Broom Tilt Left g00906677

Increase g00327379
Broom Tilt Right g00906678

Decrease g00327380
Speed Hold Control - On g00906679

44
Systems Operation Section

Speed Hold Control - Off g00906680

Control - Cruise g00716332

Validate g00570057
Wheel Clock g00716333

Down Arrow g00570058

Water Container g00716334

Up Arrow/Decimal g00570059
Oil Draining/Emptying g00716336

Main Menu g00570062

Front Trunnion - Basic g00716337

ID Menu g00570063
Rear Trunnion - Basic g00716341

Scroll g00570064
Loader - Control Knob g00716343
Cancel g00570065

Handle - Multifunction g00716381

Help g00570066

Handle - Two Function g00716383

Ride Control - Automatic g00716194

45
Systems Operation Section

Speaker g00716450

Contour Adjustment Machine Tilt Forward

g00716465

Forward g00910763

Contour Adjustment Machine Tilt Back

g00716467

Reverse g00910765

Handle - Two Function g00716384

Material Handler - Magnet g00716451

Handle - One Function g00716386

Fan Cover - Open g00716452

Handle - Multifunction g00716387

Mass or Weight g00716457

Handle - Multifunction g00716391

Slope Adjustment - Operator Compartment

Left g00714658

Hitch g00716392

Slope Adjustment - Operator Compartment

Right g00716460

Cab - Basic g00716394

Contour Adjustment Machine Up

g00716462

Maximum - Upper Limit g00716395

Contour Adjustment Machine Down

g00716464

Maximum - Lower Limit g00716396

46
Systems Operation Section

Alarm Off g00716397

Ladder Position - Down g00716441

Do Not Overload When Lifting

g00716398
Ethanol System Leak g00716442

Grease Lubrication - Automatic - Container

Full g00716399
Filter Pressure - Ethanol - Primary (Not
intended to be used as a fuel filter)
g00716444
Grease Lubrication - Automatic - Container
Empty g00716400
Filter Pressure - Ethanol - Secondary (Not
intended to be used as a fuel filter)
g00716447
Grease Lubrication - Automatic - Fill
Container g00716404
Tank - Ethanol - Low g00910564

Grease Lubrication - Automatic Failure/Malfunction g00716408

Tank - Ethanol - Empty g00910566

Grease Lubrication - Automatic - Auxiliary

g00716410
i01773776

Grader
Grease Lubrication - Autolube Pressure
g00716412

Steering Cylinder - Cap End - Grease

Lubrication Point g00716438

Steering Cylinder - Rod End - Grease

Lubrication Point g00716439

SMCS Code: 7000

Grader Wheel Drive - Front g00696280

Wheel - Hold g00696283

47
Systems Operation Section

Grader Blade - Oil Filter g00696284

Grader - Articulate Left g00697225

Grader Blade - Center Shift g00696285

Grader - Articulate Right g00697227

Grader Blade Float g00696286

Grader Blade - Basic g00697228

Grader Blade - Cushion g00696287

Grader Blade - Raise Whole Blade

g00697230

Grader Blade - Snow Wing - Inner End Raise g00696288

Grader Blade - Lower Whole Blade

g00697240

Grader Blade - Snow Wing - Outer End Raise g00696291

Grader Blade - Lower Left Side

g00697242

Grader Blade - Basic - Side View

g00696292

Grader Blade - Lower Left Side

g00697243

Grader Blade - Pitch Forward g00696295

Grader Blade - Raise Right Side

g00697259

Grader Blade - Pitch Rearward

g00697216

Grader Blade - Lower Right Side

g00697263

Grader Blade - Basic - Overhead View

g00697219

Grader Blade - Side Shift - Left

g00697265

48
Systems Operation Section

Grader Blade - Side Shift - Right

g00697268
Front Scarifier - Raise g00714448

Grader Blade Circle - Rotate Clockwise

g00697271
Front Scarifier - Lower g00714450

Grader Blade Circle - Rotate Counter

Clockwise g00697274
Rear Scarifier - Basic g00714451

Grader Blade Circle - Shift Left

g00697277
Rear Scarifier - Raise g00714453

Grader Blade Circle - Shift Right

g00697278
Rear Scarifier - Lower g00714454

Grader Wheel Lean - Left g00697280

i01773794

Hydraulic System
Grader Wheel Lean - Right g00697282

SMCS Code: 7000

Accumulator Pressure - Gas Charged
g00681170

All Wheel Drive g00189287

Hydraulic - Auxiliary Circuit g00681176

Overload Warning g00906925

Hydraulic Oil - Filter Pressure g00681177

Front Scarifier - Basic g00714446

49
Systems Operation Section

Hydraulic Flow Control - Auxiliary Circuit

g00681178

Hydraulic System - Basic g00681534

Hydraulic - Filter Fault g00681179

Hydraulic Oil g00681536

Hydraulic Lift - Float g00681181

Hydraulic Oil - Pressure g00681537

Hydraulic Oil - Diverter Valve Fourth

Function g00681182

Hydraulic Oil - Level g00681538

Implement Kickout Neutralizer

g00681183

Hydraulic Oil - Filter g00681540

Steering - Oil g00681184

Hydraulic Oil - Temperature g00681541

Steering - Oil Flow g00681186

Hydraulic System - Failure/Malfunction

g00681571

Steering - Oil Filter g00681187

Hydraulic - Oil g00681574

Hydraulic Oil - Unrestricted Flow to Sump

g00681521

Hydraulic - Oil Filter g00681575

Hydraulic Motor g00681532

Hydraulic - Oil Filter Pressure g00681577

50
Systems Operation Section

Hydraulic - Oil Level g00681579

Steering Filter Bypass g00906958

Hydraulic - Oil Pressure g00681581

Implement Return Filter Bypass
g00906960

Hydraulic - Oil Temperature g00691583

Auxiliary g00906961

Steering - Oil g00691586

Auxiliary 2 g00906962

Hydraulic - Auxiliary Circuit g00681589

Hydraulic Shut Off g00906963

Diverter g00681591
Bucket Positioner And Kickout Control
g00906964

Hydraulic Oil Temperature g00681593

Continuous Flow g00906965

Hydraulic Oil Level g00681594

Hydraulic Oil Temperature g00681597

Hydraulic Tank Pressure g00681599

Hydraulic Auxiliary Circuit Override

g00906967

Hydraulic Filter g00906969

51
Systems Operation Section

Hydraulic Tank Strainer g00906970

Headlights - Low/Dipped Beam

g00692483

Hydraulic Oil - Biodegradable g00716556

Work Light g00692507

Steering Oil - Fill/Empty Container

g00716559

Parking Lights g00692508

Hydraulic Oil - Fill Container g00716560

Hazard Warning Lights g00692787

Hydraulic Oil - Fill/Empty Container

g00716561

Beacon g00692788

i01755661

Clearance/Position Lights g00692789

Lighting
SMCS Code: 7000
Lights - Tail g00691864

Turn Signals g00692791

Lights - All g00691865

Turn Signal - First Trailer g00692794

Master Lighting Switch g00691869

Turn Signal - Second Trailer g00692797

Headlights - High/Upper Beam

g00692479

Front Fog Lights g00692798

52
Systems Operation Section

Rear Fog Lights g00692799

Lights - Flood or Work - Front + Rear
g00906928

Instrument Illumination g00692801

First Trailer Right Turn g00906929

Lights - Flood or Work - Front g00692803

First Trailer Left Turn g00906930

Lights - Instrument or Panel g00692805

Right Turn g00906931

Lights - Interior g00692807

Left Turn g00906935

Lights - Beacon g00911103

Rear Work Lights g00112881

Lights - All g00692812

Front Running Lights/Floodlights
g00906936

Lights - Flood or Work - Rear g00692813

Front Side and Mid Lamps g00906939

Front Flood Lights g00059598

Panel Dimmer Control g00906940

Rear Flood Lights g00059600

53
Systems Operation Section

Backup Lights g00764070

Loader - Reweigh g00713884

Panel Lights - Dim g00906943

Loader Articulation - Upper Hitch Bearing

g00713885

Lights - Brake g00716971

Loader - Articulation - Midship Bearing

g00713888

Lights - Reverse Back-Up g00911125

Loader - Bucket - Extend g00713890

i01756537

Loader - Bucket - Retract g00713891

Loader
SMCS Code: 7000
Loader - Control Knob g00911162

Loader - Boom Float g00713879

Loader - Bucket - General Purpose - Raise

(Quick) g00713881

Loader - Bucket - General Purpose - Dump

(Quick) g00713882

Loader - Store (Hold) g00713883

Loader - Wheel - Basic g00713893

Loader - Bucket Grapple - Open

g00713894

Loader - Bucket Grapple - Close

g00713896

Steering - Front Wheel g00713898

Steering - Rear Wheel g00713899

54
Systems Operation Section

Steering - Four Wheel g00713901

Loader - Side-Dump - Bucket - Dump
g00713916

Steering - Independent Front & Back

g00713902
Loader - Side-Dump - Bucket - Return
g00713917

Loader - Bucket - Basic g00713905

Loader - Side-Dump - Bucket - Hold
g00713918

Loader - Bucket - Raise g00713906

Loader - Multi-Purpose - Bucket - Basic
g00713921

Loader - Bucket - Lower g00713907

Loader - Multi-Purpose - Bucket - Open
g00713923

Loader - Bucket - Hold g00713908

Loader - Multi-Purpose - Bucket - Close
g00713926

Loader - Bucket - Float g00713910

Loader - Multi-Purpose - Bucket - Hold
g00713927

Loader - Bucket - Dump g00713912

Bucket - General Purpose - Raise
g00911176

Loader - Bucket - Rollback g00713913

Bucket - General Purpose - Lower
g00911184

Loader - Side-Dump - Bucket - Basic

g00713914

55
Systems Operation Section

Bucket - General Purpose - Hold

g00911188

Bucket - Side Dump - Dump g00714081

Bucket - General Purpose - Float

g00911192

Bucket - Side Dump - Return g00714085

Bucket - General Purpose - Tilt Back

g00911197

Dual Pump g00714088

Bucket - General Purpose - Dump

g00911201

Bucket - Lift Positioner g00911276

Bucket - General Purpose - Dump - Quick

g00911213

Power Guards Lowered g00911277

Bucket - Multi-Purpose - Open

g00911238

Wheel - Hood Acutator g00911278

Bucket - Multi-Purpose - Close

g00911241

Wheel - Crankcase Guard Actuator

g00911279

Bucket - Multi-Purpose - Hold g00911267

Wheel - Power Train Guard Actuator

g00911280

Bucket - Bottom Dump - Open

g00713942

Loader Articulation Lower Hitch Bearing

g00717084

Bucket - Bottom Dump - Close

g00714079

Loader - Wheel - Load And Carry

g00717086

56
Systems Operation Section

Loader - Bucket - Capacity g00717089

Loader - Wheel Power Train/Crankcase
Actuator g00717102

Loader - Wheel Total Mass g00717090

Loader - Bucket - Electrical Control Module
(ECM) g00717103

Loader - Grapple Bucket - Open

g00717092
Loader - Bucket - Raise Or Lower
g00911302

Loader - Grapple Bucket - Close

g00717093

Auto Leveler g00717106

Steering - Rear Wheel Left g00717094

Loader - Bucket - Raise Or Lower Height
Kickout - Automatic Leveler g00717109

Steering - Rear Wheel Left g00717096

Loader - Bucket - Rollback Kickout Automatic Leveler g00717110

Loader - Wheel - Power Train Guard

Actuator g00717098

Loader - Wheel - Crankcase Guard

Actuator g00717099

Loader - Wheel - Radiator Guard Actuator

g00717100

Loader - Wheel - Hood Actuator

g00717101

Loader - Bucket - Lower - Rollback

g00717112

Loader - Bucket - Lower - Dump

g00717113

Lower - Bucket - Raise - Dump

g00717128

57
Systems Operation Section

Lower - Bucket - Raise - Rollback

g00717129

i01775468

Hydraulic Crane - Boom Swing - Lock

g00718454

Hydraulic Crane - Boom Swing - Brake

g00718457

Load Handling
SMCS Code: 7000
Hydraulic Crane - Boom - Raise
g00718421

Cable Crane - Boom - Raise g00718460

Hydraulic Crane - Boom - Lower

g00718430

Cable Crane - Boom - Lower g00718462

Hydraulic Crane - Load - Hoist

g00718434

Cable Crane - Load/Drum - Hoist

g00907585

Hydraulic Crane - Load - Lower

g00718437

Cable Crane - Load/Drum - Lower

g00718468

Hydraulic Crane - Telescope - Extend

g00718439

Cable Crane - Boom Swing - Swing Left

g00718498

Hydraulic Crane - Telescope - Retract

g00718443

Cable Crane - Boom Swing - Swing Right

g00718499

Hydraulic Crane - Boom Swing - Swing

Left g00718445

Cable Crane - Boom Swing - Lock

g00718500

Hydraulic Crane - Boom Swing - Swing

Right g00718449

Cable Crane - Boom Swing - Brake

g00718504

58
Systems Operation Section

i01758477

Log Handling
SMCS Code: 7000

Log Feeder - Basic g00714468

Clamp - Fork - Raise g00714456

Log Feeder - Open g00714645

Clamp - Fork - Lower g00714457

Log Feeder - Close g00714647

Clamp - Fork - Float g00714458

Log Feeder - Feed In g00714648

Clamp - Fork - Tilt Forward g00714459

Log Feeder - Feed Out g00714649

Clamp - Fork - Tilt Back

Log Feeder - Stop/Lock g00714650

Log Grapple - Close Automatic
g00714461
Log Clamp - Basic g00714651
Log Accumulator - Basic g00714462

Log Clamp - Open g00714652

Log Accumulator - Open g00714464

Log Clamp - Close g00714653

Log Accumulator - Close g00900666

59
Systems Operation Section

Log Clamp - Hold g00714654

Log Loader - Arm - Raise g00718373

Log Grapple - Basic g00714655

Log Loader - Pillar - Rotate Clockwise

g00718371

Log Grapple - Open g00714656

Log Loader - Arm Lower g00718376

Log Grapple - Close g00714657

Log Loader -Pillar - Rotate Counter

Clockwise g00718372

Log Grapple - Rotate g00714658

Log Loader - Pillar - Lower g00718369

Log Grapple - Rotate Clockwise

g00714659

Log Loader - Jib - Raise g00718396

Log Grapple - Rotate Counter Clockwise

g00714660

Log Loader - Pillar Raise g00718367

Log or Lumber - Clamp Open g00714661

Log Loader - Jib - Lower g00718397

Clamp - Close g00714662

Log Loader Equipment - Basic Symbol

g00718366

Clamp - Hold g00714663

Log Loader - Arm - Extend g00718378

60
Systems Operation Section

Log Loader - Arm Retract g00718380

Swing Right g00910367

Log Loader - Jib - Extend g00718399

Stick In g00910368

Log Loader - Jib - Retract g00718401

Stick Out g00910369

Log Clamp - Log Eject g00717136

Boom Down g00910370

i01775231

Material Handling

Boom Up g00910372

SMCS Code: 7000

Load Point Height g00910358
Magnet - On g00910374

Load Front Radius g00910360

Magnet - Off g00910375

Side Load Radius g00910362

MH Load Point Height g00910376

Maximum Reach g00910363

MH Maximum Reach g00910377

Swing Left g00910365

61
Systems Operation Section

Steering Charge Filter g00911194

Windrow Elevator - Wheel Height

Adjustment - Front - Right g00714969

Cab Riser - On g00910383

Water Tank - Low Level g00714971

Grapple On - Generator - Off g00396517

High Pressure Wash - Pulsed g00714973

i01734928

High Pressure Wash - Full g00714975

Paving
SMCS Code: 7000
Compactor Drum - Side Shift g00714955

Compactor - Vibrator g00714958

Compactor - Spray -Full g00714961

Compactor - Spray - Pulsed g00714963

Asphalt Cutter g00714965

Windrow Elevator - Wheel Height

Adjustment - Rear g00714967

Compactor - Spray Pressure - Full

g00714977

Compactor - Spray - Pressure - Pulsed

g00714979

Asphalt Cutter - Service - Door Open

g00714980

Forward g00714981

Reverse g00714985

Automatic Speed Adjustment - Machine

Movement g00714987

62
Systems Operation Section

Forward g00714981
By Pass g00717288

Reverse g00714985
Rear Elevation Up g00717289

Emulsion - Normally Used With Spray

g00722578
Rear Elevation Down g00717290

Water - Normally used with Spray

g00722579
Paver - Elevation - Front g00717291

Compactor - Drum Select g00722581

Paver - Elevation - Rear g00717292

Compactor - Drum Select g00721439

Paver - Elevation - Front g00717294

Elevation Up g00717283
Paver - Elevation - Front and Rear
g00717295

Elevation Down g00717284

Body - Down g00717296

Front Elevation Up g00717285

Body - Up g00717297

Front Elevation Down g00717287

63
Systems Operation Section

Body - Up and Down g00717298

Paver - Side Plate g00717309

Screed Extender - Left g00717299

Paver - Mill Conveyor g00717310

Screed Extender - Right g00717300

Compactor - Wheel With Tire - Normally
used with spray symbol g00717468

Paver - Steering - Front g00717301

Compactor - Roller Spray g00717544

Paver - Steering - Four Wheel g00717303

Compactor - Crack of Belt g00717577

Paver - Steering - Crab g00717304

Rotor Out Of Position g00717559

Paver - Steering - Rear g00717305

Roter Held In Up Position g00717561

Paver - Grade/Slope g00717306

Computer Fault g00717566

Paver - Moldboard
Reclaimer/Mixer Rotor Door Closed
g00717568

Paver - Moldboard g00717308

Reclaimer/Mixer Rotor Door Open
g00717569

64
Systems Operation Section

Ripper - Hold g00714413

Reclaimer/Mixer Steering - Front
g00717572

Ripper - Pitch In g00714415

Reclaimer/Mixer Steering - Crab
g00717597

Ripper - Pitch Out g00714418

Reclaimer/Mixer - Steering - Four Wheel
g00717601

Ripper - Raise g00714417

Reclaimer/Mixer Steering - Rear
g00717603

Ripper - Lower g00714418

Tamper g00717613

Ripper - Hold g00714421

i01760781

Ripper
SMCS Code: 7000

Ripper - Shank In g00714422

Ripper - Basic g00714406

Ripper - Shank Out g00714423

Ripper - Raise g00714410

i01760783

Ripper - Lower g00714412

Safety
SMCS Code: 7000
Use No Ether g00714820

65
Systems Operation Section

Shield Eyes - Battery g00714822

Fork - Do Not Stand On g00714856

No Sparks, Flames, Smoking g00714824

Bucket - Do Not Stand In g00714858

Electrical Shock - Hazard g00714825

Bucket - Do Not Stand Under g00714859

Electrical - Dangerous Voltage

g00714827

Alternate Exit g00714862

Rotating Shafts/Rollers - Finger of Hand

Entanglement g00714832

Shield Eyes g00714864

Rotating Gears - Finger or Hand

Entaglement g00714846

Eyewash g0714866

Hot Surface - Burns to Fingers or Hands

g00714848

Ear Protection Required g00714867

Sharp/Cutting Mechanism - Fingers or

Hands g00714849

Caustic Liquids - Chemical Burns to Fingers

or Hands g00714938

Fire (Suppression) g00714851

Battery - Explosive Gas g00714940

Fork - Do Not Stand Under g00714853

Compress Spring Compartment

g00714942

66
Systems Operation Section

Travel Alarm Cancel g00901050

No Room For Person g00714943

No Drilling g00717171
Rotating Driveline - Whole Body
Entaglement g00714944

No Welding g00717172
Falling g00714946

i01775406

Trip Point g00714947

Saw Unit
SMCS Code: 7000
Circular Saw - Basic Symbol g00718311

Cutter/Rotor Warning g00714949

Circular Saw - Out g00718313

Safety Alert g00714950

Circular Saw - In g00718314

Pull the Ring g00714951

Chain Saw - Basic Symbol g00718316

No Hands - Keep Hands Away
g00714953

Chain Saw - Out g00718317

No Step g00714954

Chain Saw - In g00718318

67
Systems Operation Section

Blade - Circular Saw g00908269

Scraper - Bail Down g00712326

i01761439

Scraper Bail & Hitch g00712328

Scraper
SMCS Code: 7000
Tractor/Scraper g00704357

Scraper Hitch g00712332

Wheel Tractor g00712313

Scraper Elevator - Load/Unload

g00712332

Scraper - Powered g00712315

Scraper Bowl - Basic g00712334

Scraper - Wheel Slip g00712316

Scraper Bowl - Raise g00712507

Scraper - Auger Control Forward

g00712317

Scraper Bowl - Lower g00901341

Scraper - Auger Control Reverse

g00712318

Scraper Bowl - Hold g00712514

Scraper Bail g00712324

Scraper Apron - Basic g00712515

Scraper - Bail Up g00712325

Scraper Apron - Raise g00712518

68
Systems Operation Section

Scraper Elevator - Unload g00712530

Scraper Apron - Lower g00712519

Cushion Hitch g00297129

Scraper Apron - Hold g00712520

Ejector Return Detent g00901800

Scraper Apron - Float g00712521

Bowl - Raise and Lower g00901812

Scraper Ejector - Basic g00712522

Apron - Raise and Lower g00901820

Scraper Ejector - Eject g00712523

Wheel Tractor g00482306

Scraper Ejector - Return g00712525

Scraper g00484548
Scraper Ejector - Hold g00712526

Wheel Tractor Scraper - Load Distributor

g00717078
Scraper Elevator - Basic g00712528

i01762737

Scraper Elevator - Load g00712529

Seat
SMCS Code: 7000
Seat - Basic g00693587

69
Systems Operation Section

Seat - Lumbar - Adjustment - In & Out

g00693588

Seat - Height Adjustment - Down

g00693980

Seat - Fore & Aft Isolator g00693591

Seat Height Adjustment - Cushion Front Up & Down g00693981

Seat - Lateral Isolator g00693592

Seat Height Adjustment - Cushion Rear Up & Down g00693982

Seat - Swivel g00693593

Seat - Headrest Adjustment - Up & Down

g00693983

Seat - Weight Adjustment g00693594

Heated Seat g00693984

Seat - Basic g00693605

Seat - Backrest Angle Adjustment

g00901864

Seat - Longitudinal Adjustment - Fore &

Aft g00693973

Seat - Height Adjustment g00901879

Seat - Seatback Adjustment - Fore & Aft

g00693974

Seat - Fore & Aft - Adjustment g00901884

Seat - Height - Adjustment - Up & Down

g00693975

Seat - Height Adjustment - Up g00693979

Seat - Cushion Angle Adjustment

g00901902

70
Systems Operation Section

i01763912

Stabilizer System
SMCS Code: 7000

Axel Stabilizer Unlocked g00902469

Stabilizer - Basic g00694697

Axel Stabilizer Locked g00902481

Left Stabilizer - Up/Raise g00694704

Outrigger - Right Jack Up - Vertical

Retraction Only g00718162
Left Stabilizer - Down/Lower g00694707

Outrigger - Right Jack Down - Vertical

Extension Only g00718160
Right Stabilizer - Up/Raise g00694709

Stop Switch g00902569

Right Stabilizer - Down/Lower g00694712
Right Stabilizer g00902572

Left Stabilizer - Extend g00694715

Left Stabilizer g00902573

Left Stabilizer - Retract g00694717

Left Stabilizer - Lower g00302166

Stabilizer - Raise - Right g00694720

Right Stabilizer - Lower g00302167

Stabilizer - Lower - Right g00694724

71
Systems Operation Section

Right Stabilizer - Extend g00718140

Outrigger - Right Jack Up - Vertical

Retraction Only g00718162

Right Stabilizer - Retract g00718141

Right Stabilizer - Raise/Lower g00717003

Outrigger - Basic Symbol g00718143

Left Stabilizer - Raise/Lower g00717004

Outrigger - Left Beam Out - Horizontal

Extension Only g00718146

i01773870

Telehandler
SMCS Code: 7000
Outrigger - Left Beam In - Horizontal
Retraction Only g00718147

Circle Steer Engaged g00907047

Outrigger - Right Beam Out - Horizontal

Extension Only g00718149

Crab Steer Engaged g00907048

Outrigger - Right Beam In - Horizontal

Retraction Only g00718151

Left Outrigger g00907049

Outrigger - Left Jack Down - Vertical

Extension Only g00718153

Outrigger - Left Jack Up - Horizontal

Retraction Only g00718159

Outrigger - Right Jack Down - Vertical

Extension Only g00718160

Steering Mode Switch g00907050

Transmission Neutralizer g00907051

Steering Mode Master Switch g00907052

72
Systems Operation Section

Hydraulic Quick Coupler g00907053

High Speed g00714995

Boom Speed - Access Platform

g00907055
Low Speed g00714996

Boom Extend - Access Platform

g00907057
Boom Lower g00902599

Boom Raise - Access Platform

g00907058
Boom Hold g00902600

Boom Lower - Access Platform

g00907059
Boom Raise g00765042

Boom Retract - Access Platform

Counterweight Out g00717619

i01764145

Track Type Tractor

Counterweight Hold g00902603

SMCS Code: 7000

Track Type Tractor - Steering g00714990
Counterweight In g00717614

Lubrication - Pivot Shaft g00714993

Slow g00902604

Track Adjust g00714994

73
Systems Operation Section

Fast g00902605

Transmissions, TC, Or Hydraulic - Oil Filter

Pressure g00680980

Steering Oil Filter g00717621

Transmissions, TC, Or Hydraulic - Electronic

Control g00680982

Emergency Lower (Boom) g00902606

Transmissions, TC, Or Hydraulic Engage g00680983

i01764855

Transmission

Transmissions, TC, Or Hydraulic,

Disengage g00680984

SMCS Code: 7000

Transmissions, TC, Or Hydraulic Control
g00690959

Transmission - Auto Kickdown Mode

g00909230

Transmissions, TC, Or Hydraulic Control Quickshift g00680961

Transmissions, TC, Or Hydraulic - Lock

g00680989

Trasmissions, TC, Or Hydraulic Control - Oil

- Pressure g00689062

Transmissions, TC, Or Hydraulic - Unlock

g00680991

Transmissions, TC, Hydraulic, Or Gear Creeper g00680963

Transmissions, TC, Or Hydraulic - Neutral

Lockout g00680999

Transmission, TC, Hydraulic Control Variable Control -Torque Limit g00680965

Clutch - Engage g00681000

Transmissions, TC, Or Hydraulic - Max

Torque g00680966

Clutch - Disengage g00681002

74
Systems Operation Section

Clutch - Brake g00681003

Differential - Oil g00681026

Clutch - Oil Pressure g00681004

Differential - Oil Filter g00681027

Clutch - Impeller g00681005

Differential - Unlock g00681028

Transmission - Synchronous g00681008

Bevel Gear - Oil g00681030

Torque Converter - Off g00681010

Transmission - Basic g00681032

Retarder - Brake g00681011

Transmission Oil g00681033

Retarder - Oil Temperature g00681014

Transmission Oil - Pressure g00681035

Manual g00681017
Transmission Oil - Level g00681037

Wheel Torque Control (Max-Min)

g00681021
Transmission Oil - Filter g00681039

Worn Clutch g006861025

75
Systems Operation Section

Transmission Oil - Temperature

g00681041

Transmission - Forward Second Gear

g00681077

Transmission - Failure/Malfunction
g00681042

Transmission - Forward Third Gear

g00681079

Clutch g00681044

Transmission - Reverse Second Gear

g00681081

Transmission - Neutral g00681048

Transmission, Torque Converter, Or

Hydrostatic - Oil g00681087

Transmission - High Gear/High Gear

Range g00681057

Transmission, Torque Converter, Or

Hydrostatic - Oil Filter g00681117

Transmission - Low/Low Gear Range

Transmission, Torque Converter, Or

Hydrostatic - Oil Filter Pressure
g00681119

Transmission - Forward/Forward Gear

Range g00681064

Transmission, Torque Converter, Or

Hydrostatic - Oil Level g00681120

Transmission Reverse/Reverse Gear

Range g00681066

Transmission - Park g00681069

Transmission - Forward First Gear

g00681074

Transmission, Torque Converter, Or

Hydrostatic - Oil Pressure g00681122

Transmission, Torque Converter, Or

Hydrostatic - Oil Temperature g00681126

Retarder g00681128

76
Systems Operation Section

Retarder - Oil Temperature g00681129

Transmission Oil Temperature
g00681156

Transmission, Torque Converter, Or

Hydrostatic - Control Oil Pressure
g00681130

Transmission, Torque Converter, Or

Hydrostatic - Neutral g00681131

Transmission, Torque Converter, Or

Hydrostatic - Unlock g00681137

Transmission, Torque Conveter, Or

Hydrostatic - Lock g00681143

Transmission, Torque Conveter, Or

Hydrostatic - Park g00681146

Transmission Autoshift - Bidirectional

Mode g00911282

Transmission Autoshift - Bidirectional

Mode g00911284

Second Gear g00911285

First Gear g00911286

Fifth Gear Lockout g00911287

Clutch - Oil Pressure g00681148

Programmable Upshift g00911288

Differential - Lock g00681149

Programmable Downshift g00911289

Differential - Unlock g00681153

Forward g00911290

Transmission Filter g00681154

77
Systems Operation Section

Reverse g00911291

Transmission - Reverse Gear Engaged

g00716537

Reverse Gear g00716537

Retarder - Over Speed g00716552

Traction Control System g00911292

i01775389

Tree Harvester and Feller

Buncher
Automatic Retarder g00911294

SMCS Code: 7000

Tree Harvester/Feller Buncher - Boom/Arm
Movement - Basic Symbol g00718618

Front Differential Oil Filter g00767046

Tree Harvester/Feller Buncher - Boom Raise g00718179
Rear Differential Oil Filter g00911296
Tree Harvester/Feller Buncher - Boom Lower g00718182
Differential Oil Pressure g00716531
Tree Harvester/Feller Buncher - Arm Out g00718191
Differential Oil - Pressure Drain
g00716532
Tree Harvester/Feller Buncher - Arm - In
g00718194
Retarder - Brake Automatic Mode
g00716534
Tree Harvester/Feller Buncher - Boom
Swing - Basic Symbol g00718198
Transmission Oil - Fill/Empty Container
g00716535
Tree Harvester/Feller Buncher - Boom
Swing - Swing Left g00718202

78
Systems Operation Section

Delimber - Fixed Jaw - Close g00718214

Tree Harvester/Feller Buncher - Boom
Swing - Swing Right g00718205

Delimber - Mobile Jaw - Basic Symbol

g00718216
Delimber - Sliding Boom - Basic Symbol
g00718206

Delimber - Mobile Jaw - Open g00718218

Delimber - Sliding Boom - Out g00718207

Delimber - Mobile Jaw - Close g00718219

Delimber - Sliding Boom - In g00718208

Topping Knife - Basic Symbol g00718306

Delimber - Butt Plate - Basic Symbol
g00718209

Topping Knife - Open g00718307

Delimber - Butt Plate - Up g00718210

Topping Knife - Close g00718309

Delimber - Butt Plate - Down g00718211

i01765736

Delimber - Fixed Jaw - Basic Symbol

g00718212

Winch
SMCS Code: 7000
Winch - Underwind g00714668

Delimber - Fixed Jaw - Open g00718213

Winch - Overwind g00714669

79
Systems Operation Section

Winch - In & Out g00714671

Winch - Lock g00714693

Winch - Hold g00714672

Winch - Brake g00714695

Winch - Spool & Drag g00714673

Winch - Reel In g00015381

Winch - Disconnect g00714674

Winch - Reel Out g00015383

Winch - Brake On g00714675

Winch - Overwind g00015385

Winch - Brake Off g00714677

Winch - Basic g00714679

Winch - Spool Out g00714680

Winch - Underwind g00015387

Winch - Brake Off g00015389

Winch - In & Out g00015391

Winch - Brake On g00015393

Winch - Spool In g00714685

Boom Priority Mode g00714717

Winch - Free Spool g00714692

80
Systems Operation Section

Side Window - Washer & Wiper - Multiple

g00716986
Swing Priority Mode g00714718

Windshield - Wiper g00692823

Fine Control Mode g00714721

Windhshield - Wiper - Intermittent

g00692827
Brake - Off g00405506

Windshield - Washer g00682830

Winch Brake On g00511616

Windshield - Washer Fluid g00692831

Winch - Drum Engaged g00717138

Windshield - Washer & Wiper g00692833

Winch - Drum Disengaged g00717141

Windshield - Demister/Defroster
g00692834
i01765774

Window and Visibility

SMCS Code: 7000

Rear Window - Wiper g00692836

Side Window - Wiper g00716975

Rear Window - Wiper - Intermittent

g00692844
Side Window - Washer & Wiper
g00716985

Rear Window - Washer g00692845

81
Systems Operation Section

Rear Window - Washer Fluid g00692846

Side Window - Wiper g00716975

Rear Window - Washer & Wiper

g00692848

Side Window - Washer & Wiper

g00716985

Rear Window - Demister/Defroster

g00692851

Side Window - Washer and Wiper Multiple g00716986

Side/Lateral Window - Demister/Defroster

g00692854

Windshield - Washer and Wiper Intermittent g00716988

Exterior Rear View Mirror Demister/Defroster g00692856

Side Window - Electric - Up g00716989

Exterior Rear View Mirror - Four-Way

Adjustment g00692858

Side Window - Electric - Down

g00716990

Power Windows g00903382

Side Window - Electric - Up And Down

g00716994

Break Glass for Exit g00059604

Windshield Wiper/Washer g00911347

Window - Power g00716994

82
Index Section

Index
A
Agricultural Tractors............................................... 4

Load Handling ....................................................... 57

Loader ................................................................... 53
Log Handling ......................................................... 58

Basic...................................................................... 10
Brake System ........................................................ 12

Material Handling .................................................. 60

P

C
Paving.................................................................... 61
Clamshell Bucket................................................... 14
Climate Control...................................................... 15
R
D

Ripper .................................................................... 64

Dozer ..................................................................... 17
Dumper and Hauler ............................................... 19

E
Earthmoving Grapple ............................................
Electrical System...................................................
Engine ...................................................................
Excavator and Backhoe.........................................
Excavator and Shovel............................................

20
21
23
29
33

Safety ....................................................................
Saw Unit ................................................................
Scraper ..................................................................
Seat .......................................................................
Stabilizer System...................................................
Systems Operation Section ...................................

64
66
67
68
70
4

T
F
Felling .................................................................... 33
Fuel System........................................................... 34

Table of Contents...................................................
Telehandler ............................................................
Track Type Tractor..................................................
Transmission..........................................................
Tree Harvester and Feller Buncher........................

3
71
72
73
77

G
W
General.................................................................. 36
General Information............................................... 4
Grader ................................................................... 46

Winch..................................................................... 78
Window and Visibility............................................. 80

H
Hydraulic System................................................... 48
I
Important Safety Information ................................. 2
L
Lighting .................................................................. 51
2002 Caterpillar
All Rights Reserved

Printed in U.S.A.