KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

56-SDIP-600
I2C BUS NTSC 1 CHIP FOR COLOR TV
The KA2163 is a monolithic integrated circuit for VIF,
SIF, chroma and deflection circuit of NTSC color TV.
The KA2163 also provides audio / video switch and
OSD interface. It combines these functions in a 56
SDIP package and the KA2163B also includes I2C bus
control functions for automatically adjustment.

FUNCTIONS
- VIF/SIF
- Video
- Chroma ORDERING INFORMATION
- Deflection
- OSD interface Device Package Operating Temperature
- I2C bus circuit KA2163 56 -SDIP -20¡É ~ +65¡É

FEATURES

VIF CIRCUIT
- PLL type IF demodulation (bus alignment) OSD CIRCUIT
- Adjustment free AFT without tank coil - Linear RGB input
- RF AGC output (delay point : bus alignment) - Cut off / Drive adjustment (bus adjustment)
- Dual time constant fast AGC - RGB primary color output

SIF CIRCUIT DEFLECTION CIRCUIT

- Inter carrier SIF system - Auto-slicer type high performance
- External sound select switch (bus select) - Sync. separator circuit
- Attenuator circuit - Adjustment free countdown system
- Sync. separation output
VIDEO CIRCUIT - X-ray protect circuit
- Black stretcher - Vertical ramp output
- DC Restoration circuit - Dual time constant AFC circuit
- D.L aperture compensate circuit (bus control) - Horizontal and Vertical position bus adjustment
- Internal filter auto-adjust circuit (fsc link type) - Vertical amplitude adjustment (bus adjustment)
- Uni-color circuit(bus control)
- Y delay line circuit

CHROMA CIRCUIT
- Color control circuit (bus control)
- Tint control circuit

1 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

BLOCK DIAGRAM

H.RAM
X-RAY
X-RAY 29 28 SDA

Bus Interface
VC/D
AFC-2
FBP IN
30 27 SCL

H.VCC
9.0V
Sync. OUT 31 H. VCC
26

V SEPA
AFC-1
H. OUT
H. OUT 32 25 V SEPA FILTER

H. AFC 33 24 V. RAMP

V.RAMP
H SEPA
HC/D
VCO
32fHVCO 34 32fH NFB
23
D. GND 35 22 V. OUT
Sharpness

ABL 36 21 B OUT

Cut-off/drive
Contrast
X2

Bright
TV IN WPL

MTX
37 20 G OUT

ACL 38 19 R OUT
Smoothing

D.VCC
LPF

3.3V
EXT. VIDEO 18 D. VCC
39
Streatch

DEMO
Black

WPS

BLACK DET 40 17 ANALOG B IN

TINT

Analogue RGB
Restoretion

AV/SW OUT 16 ANALOG R IN

41
DC

Y-DL

DC REST 42 15 ANALOG R IN
Color

Killer
Clamp

Trap

43 14
3.58

Y IN F-BLK
GND

AFT 44 GND
13
ACC
AFT

VCXO
APC
BPF

CHROMA IN VCXO
45 12
VCC

VCC
46 11 APC FILTER
DET
I

TV DET. OUT 47 10 LOOP FILTER

SW
VCC

VCC
SIF

SIF VCC
PIF

48 9 PIF VCC
DET
90¡£

PIF TANK 49 PIF IN

8
VCO

PIF TANK 50 7 PIF IN

LOCK
DET
GND
SIF

GND

SIF GND
PIF

51 6 PIF GND
AGC
RF
Limier

AGC
DET

LIMITER IN 52 5 AGC FILTER

AUDIO TV IN
53 4 SIF TANK
DET
FM

DE-EMPHASIS 54 3 RF AGC

EXT. AUDIO 2
55 SOUND OUT
ATT

EXT. AUDIO SOUND OUT

56 1
ATT

2 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

TERMINAL FUNCTION

PIN PIN NAME FUNCTION INTERFACE CIRCUIT

NO.

1 Sound Output This terminal is for Sound

2 Output. 48
3k¥
The maximum flew out 500¥

current of these terminals is

200¥
3.6mA. So, the minimum load 2 Attenuator
34.5k¥
resister is 1k¥Ø . 330¥ìA

3k¥Ø
4.5V

51

9
500¥ 43k¥Ø
3 RF AGC This terminal is for RF AGC
output. 300¥
3
30k¥Ø
Monitor
30k¥Ø
6

This terminal is for connecting 48

SIF detect tank coil.
5.5PF
4 SIF Tank Coil This terminal is for Sound 4
Mute Switch, too. 100¥ 42¥Ø
If this terminal is connected to
500¥ìA
GND, the sound output is
muted.
51

9
200¥ìA
5 AGC Filter This terminal is for PIF 2nd
AGC filter. 50¥Ø 20k¥Ø
5
50¥ìA 100PF

RF AGC AGC
Amplifier
6

6 PIF GND This terminal is for GND of PIF

circuit.

9
100k¥Ø

7 PIF Input This terminal is for IF input. 7

20pF
8 The typical input value is 20pF
90dB¥ìV. 8
1.2k¥Ø 1.2k¥Ø
140¥Ø
700¥Ø 700¥Ø
2V
6

3 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

PIN PIN NAME FUNCTION INTERFACE CIRCUIT

NO.

9 PIF Vcc This terminal is for Vcc of PIF

circuit.

48

10 Loop Filter This terminal is for PIF PLL

loop filter. APC Detection
500¥Ø

10

51

46
500¥Ø 500¥Ø
11 APC Filter This terminal is for APC filter
of fsc oscillation.
300¥Ø
11
5k¥Ø 300¥Ø

Killer
13

46
12 VCXO This terminal is for X’tal of
2.5k¥Ø 2.5k¥Ø
3.58MHz VCXO. 12
1.5pF
2.5k¥Ø 500¥Ø

500¥Ø

14k¥Ø

13

13 GND This terminal is for V/C/D

GND.

46
7.5¥ìA 7.5¥ìA
14 Fast Blanking This terminal is for fast
blanking of RGB input.

800¥Ø
14
1V
13

4 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

PIN PIN NAME FUNCTION INTERFACE CIRCUIT

NO.

46
5k¥Ø 5k¥Ø

2k¥Ø
15 Analog RGB These terminals are for RGB 15
16 Input signal input. 16 2k¥Ø
17
17
2k¥Ø

22.5¥ìA 75¥ìA

13

18 Digital Vcc This terminal is for Vcc of

digital curcuit.

46
400¥Ø 150¥Ø

19 RGB Output This terminal is for RGB 19

20 primary color signal output. 20
21 21

1mA
BLK 150¥Ø

13

46
100¥

22 Vertical Output This terminal is for vertical

pulse output. 50¥Ø
22
10k¥Ø

13

46
150¥Ø 5k¥Ø 5k¥Ø

23 NFB, Vertical These terminals are for NFB 5k¥Ø 5k¥Ø

24 13
24 Ramp. input and vertical ramp
output.
1.1k¥Ø 1.1k¥Ø

100¥ìA
13
50¥ìA
2.8V

RGB Blanking

5 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

PIN PIN NAME FUNCTION INTERFACE CIRCUIT

NO.

46
12.5¥ìA
100¥Ø
25
25 Vertical Sync. This terminal is for vertical
400¥Ø
Separation sync. separation filter. 3k¥Ø

Filter
5k¥ 150¥ìA
13

26 H. Vcc This terminal is for Vcc of

horizontal circuit

50¥ìA 50¥ìA

27 SCL, SDA These terminals are for input SCA 1K¥Ø

28 and output of I2C Bus. 27 SDA 100¥Ø

28
SDA

3.25V
Only

35

This terminal is for input of

26
X-RAY protect signal.The 5k¥Ø 5k¥Ø
5k¥Ø
threshold voltage is 3.5V
29 X-RAY (Typ.). If applied voltage is 1k¥
29
more than threshold voltage,
the X-RAY protect circuit will 100¥ìA 3.5V
make horizontal output a low. 13

26
This terminal is for Fly-back
pulse input.
200¥Ø
30 Fly-back Pulse The Fly-back pulse is the HV
30
Input reference of AFC circuit, gate
pulse and so on.
1.4V

The current needs to keep

152k¥
under 1mA. 13

26
31 Sync. Pulse This terminal is for Sync. pulse 30k¥Ø 1k¥Ø
31
Output output.

13

6 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

PIN PIN NAME FUNCTION INTERFACE CIRCUIT

NO.

26

2pF
32 Horizontal Output This terminal is for horizontal 1k¥Ø 1k¥Ø
pulse output.
50¥Ø
32

13

This terminal is for horizontal 26

AFC filter. H C.D
Input
33 H. AFC The AFC circuit fits the phase 33
between inputed horizontal
sync. signal and horizontal
32fH
pulse which is made by Sync. VCO
countdown 32fH. 13

This terminal is for connecting 26

ceramic oscillator. That
34 32fH VCO constitutes 32fH (503kHz) 1k¥Ø
10k¥Ø

oscillation circuit. The 1k¥Ø 3k¥Ø

34
CSB503F30 (Murata) is 10k¥Ø
recommended. 15¥ìA
600¥ìA
13

35 D. GND This terminal is for GND of

digital circuit.

46

1k¥Ø
36 A.B.L This terminal is for A.B.L 36 10k¥Ø

circuit. 1k¥Ø 10k¥

100¥ìA 100¥ìA
3.4V

100¥ìA
13

46

This terminal is for input of 37

37 TV Input PIF detected signal. The typical
input amplitude is 1.0Vp-p.

13

7 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

PIN PIN NAME FUNCTION INTERFACE CIRCUIT

NO.

46

38 A.C.L This terminal is for ACL 1k¥Ø

10k¥Ø
circuit 38
1k¥Ø 10k¥Ø

3.4V
100¥ìA
100¥ìA 100¥ìA
13

46

39
39 External Video Input This terminal is for input of
external video signal.

13

46

40 Black Peak Detection This terminal is for filter of 3.3k¥Ø 1k¥Ø

1.8k¥Ø

black peak detection. 40

8k¥Ø 1k¥Ø
2.8k¥Ø

13

46
This terminal is for output of 100¥Ø
200¥
41 Video Switch Output video switch which selects
50¥
TV signal or external video. 41 75¥ìA
Amplifier Gain is (Min.) 1.7
(Typ.) 1.9, (Max.) 2.1 . 13

46
2.5k¥
42 D.C. Restoration This terminal is for filter of 2.5k¥Ø
2k¥Ø
APL detection. 42
3k¥Ø

13

8 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

PIN PIN NAME FUNCTION INTERFACE CIRCUIT

NO.

46
3k¥Ø 3k¥Ø

1.5k¥Ø
This terminal is for Y signal
43 Y Input input. 43
The typical input amplitude is 1.5k¥Ø

1.0Vp-p.
150¥ìA
150¥ìA
13

This terminal is for AFT

output. 48
Monitor signal output mode 1k¥Ø
180k¥Ø
5k¥Ø
1k¥Ø
can be selected via Bus. 200¥Ø RFAGC/2
44 A.F.T. B0 B1 OUTPUT 100¥Ø X1
0 0 AFT 44
B
70k¥Ø
0 1 TEST purpose only

4.1V
2k¥Ø 2k¥Ø
1 0 B
51
1 1 RF AGC/2

This terminal is for 46

chrominance signal input.
120k¥Ø 40pF
The typical input signal
45
45 Chroma lnput amplitude is 286mVp-p (at 1k¥Ø 30k¥Ø
burst signal). 120k¥Ø
30k¥Ø
This IC is to go to test mode Killer
20k¥Ø
with this terminal voltage
13
higher than 4.5V.

This terminal is for Vcc of

46 V / C / D Vcc video, Chroma and Deflec-
tion circuit.

48
47 TV Detection Output This terminal is for PIF 200k¥Ø 15k¥Ø 40k¥Ø
detected signal output. 1k¥Ø
2k¥Ø
47 500¥ìA
2pF
51
48 S.I.F. Vcc This terminal is for Vcc of SIF
circuit.

9 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

PIN PIN NAME FUNCTION INTERFACE CIRCUIT

NO.

48
These terminals are for

600¥

600¥
connecting a tank coil of PIF 49 500¥
49 P.I.F. Tank Coil detection circuit.
500¥
50 TOKO Corp. products 50

1k¥

1k¥
2k¥Ø
292GJAS-7475BS(45.75MHz),

2k¥Ø
292GJAS-7476BS (58.75MHz) 600¥

are recommended.
51

51 S.I.F. GND This terminal is for GND of SIF

circuit.

48
4.5k¥
10pF
52 Limiter lnput This terminal is for input of 52
SIF limiter amplifier circuit.
20k¥Ø

23k¥Ø
3V
200¥ìA
51

48
This terminal is for input of
200¥
53 TV Audio Signal SIF detected signal. 53
Input This terminal is connected to 30k¥ Audio Switch
pin 54 via capacitor.
3V 50¥ìA
51

48

200¥
54 De-emphasis This terminal for filter of 53
30k¥

SIF de-emphasis.
10pF

4.5V
51

48

55 External Audio These terminals are for 23.5k¥

55
56 Input external audio input. 23.5k¥
Audio Switch
3V 50¥ìA
51

10 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

Slave address : 88H

SUB D7 D6 D5 D4 D3 D2 D1 D0 PRESET
ADDRESS
00 Trap Color 0000 0000
01 C.Filter Tint 1100 0000
02 A. SW Brightnes 0000 0000
03 BLK Uni-color 0000 0000
04 Mute Sharpness 0110 0000
05 Vertical Phase Horizontal Phase 0001 0000
06 B0 B1 Audio Attenuator 0000 0000
07 B2 B3 DON’T USE (Fix on 100000) 0010 0000
08 B4 V. SW RF AGC 0000 0000
09 AFC WPL Vertical Amplitude 0010 0000
0A V.Fixed PIF VCO 0100 0000
0B R Cut OFF 0000 0000
0C G Cut OFF 0000 0000
0D B Cut Off 0000 0000
0E R Gain 0000 0000
0F B Gain 0000 0000

FUNCTION RANGE (MIN. ~ MAX.) DEFAULT

Color -60 ~ 0dB -60dB
TINT ¡¾ 42¡£ 0¡£
Brightness 1.34 ~ 2.6 ~ 3.86V 1.34V
Uni-Color -24 ~ 0dB -24dB
Sharpness -18 ~ 6dB ~ 14dB (4MHz Gain) 6dB
Audio ATT -85 ~ 6dB -85dB
RF AGC 65dB¥ì ~ 105d¥ìV (0.6dB / bit), 000000 : IF Mute IF Mute
Ver. Amplitude 1.6 ~ 2.4V Center
PIF VCO ¡¾ 2.2MHz (35kHz / bit) Center
RGB Cut-off -0.4 ~ 0.4V -0.4V
RB Gain -3.1 ~ 3.1dB -3.1dB

11 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

FUNCTION RANGE (MIN. ~ MAX.) DEFAULT

3.58 Trap ( 0 ) : On / ( 1 ) : Off On
Chroma Filter ( 0 ) : Band Pass Filter / (1) : Take Off Filter TOF
A, V SW ( 0 ) : TV Mode / (1) : EXT. Mode TV
BLK ( 0 ) : BLK On / (1) : BLK Off On
MUTE (00) : Off / (01) : Y MUTE / (10) : Hout Stop / (11) : Y MUTE + V Stop (01)
H. AFC ( 0 ) : AFC2 Normal / (1) : AFC2 x 3 (0)
WPL ( 0 ) : On / (1) : Off Off
V. Fixed Mode ( 0 ) : Normal / (1) : V Frequency 60Hz Fix Normal
Pin 44’s output is selectable.
B0, B1 (Monitor) (00) : AFT Voltage / (01) : Test Mode / (10) : Blue Output / AFT
(11) : Half of RF AGC Voltage Voltage
B2, B3, B4 Bits for Test Mode.
(Test Mode) Use this IC with these bits (000). (000)

Read Mode
D7 D6 D5 D4 D3 D2 D1 D0
POR AFT IF Lock AFT - V Lock H Lock X-RAY

FUNCTION CONTENTS
POR (Power On Reset) ( 0 ) : SECOND / ( 1 ) : FIRST
AFT Refer to Following Figure
IF LOCK ( 0 ) : LOCK OUT / ( 1 ) : LOCK IN
V LOCK ( 0 ) : LOCK IN / ( 1 ) : LOCK OUT Det. Window : 262H ~ 263H
H LOCK ( 0 ) : LOCK OUT / ( 1 ) : LOCK IN This function is forced to unlock at Vp, so
data is valid after 50H.
X-RAY ( 0 ) : X-RAY OFF / ( 1 ) : X-RAY ON

¡Û Vertical Phase (3bit)

This mode is for changing vertical output timing. D7 D6 D5 MODE
(Vertical picture position is changed 0 ~ 7H as right Table.)
¡Û Horizontal Phase (5bit) 0 0 0 Reference
This mode is for changing horizontal picture position. 0 0 1 1H Delay
Horizontal output phase is changed ¡¾ 3¥ìs as maximum. 0 1 0 2H Delay
¡Û AFT Read Bus
0 1 1 3H Delay

3.3V 1 0 0 4H Delay
AFT
1.7V 1 0 1 5H Delay
1 1 0 6H Delay

D6 1 1 1 7H Delay

D4

12 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

I2C BUS CONTROLLED FORMAT SUMMARY

Bus controlled format of KA2163B is based on I2C Bus Control format of Philips.

Data Transfer Format

S Slave address 0 A Sub address A Data A P
7 bit 8 bit 8 bit

MSB MSB
S : Start Condition
P : Stop Condition
A : Acknowledge

(1) Start and Stop Condition (2) Bit Transfer

SDA SDA

SCL
SCL S P

Start Condition Stop Condition SDA cannot change.

SDA can change.

(3) Acknowledge
(4) Slave Address
from Master High lmpedance A6 A5 A4 A3 A2 A1 A0 R/W
SDA
1 0 0 0 1 0 0 0
from Slave
SDA High lmpedance

from Master
SCL 1 8 9
S

Purchase of SAMSUNG I2C components conveys a license under the Philips Iicense under the Philips I2C Patent
Rights to use these components in an I2C system, provided that the system conforms to the I2C Standard
Specification as defined by Philips.

13 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

MAXIMUM RATING (Ta = 25¡É )

CHARACTERISTIC SYMBOL RATING UNIT

Power Supply Voltage Vcc 12 V
Power Dissipation PDmax 2.19 (Note1) W
Input Terminal Voltage Vin GND - 0.3 ~ Vcc + 0.3 V
Input Signal Amplitude ein 4 Vp-p

Operating Temperature Topr -20 ~ 65 ¡É

Storage Temperature Tstg -55 ~ 150 ¡É

(Note 1) When using the device at above Ta = 25¡É , decrease the power dissipation by
17.5mW for each increase of 1¡É .

(Note 2) As this IC is weak in a surge voltage, handle it with care from being damage.

RECOMMENDED OPERATING CONDITION

CHARACTERISTIC SYMBOL MIN. TYP. MAX. UNIT REMARKS
PIF Power Supply Voltage VCCP 8.5 9.0 9.5 V -

SIF Power Supply Voltage Vccs 8.5 9.0 9.5 V -

V/C/D Power Supply Voltage Vccv 8.5 9.0 9.5 V -
H.Vcc Power Supply Voltage H.Vcc 8.5 9.0 9.5 V -
D.Vcc Power Supply Voltage D.VCC 2.7 3.3 3.8 V -

TV External Video Input Level Vin37/39 - 1.0 - Vp-p including sync.

Standard Video Input Level Vin43 - 1.0 - Vp-p including sync.
Standard Chroma Input Level Vin45 - 286 - mVp-p at burst signal
FBP Width TFBP 10 12 - ¥ìs Vth = 1.4V, Vcc - 1.4V
FBP Input Flow in Current IFBPmax - - 2 mA -
PIF Output Load Resister ROP 2 8.2 - k¥Ø -
SIF Output Load Resister ROS 1 8.2 - k¥Ø -
RGB Output Load Resister RORGB - 1.8 - k¥Ø -
Horizontal Output Load Resistor RHOUT 330 800 - ¥Ø maximum 10mA
Vertical Output Load Resister RVOUT 4.1 5.7 - k¥Ø -
Sync. Separation Output Flow In Isyncmax - - 1 mA -
Current

14 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

ELECTRICAL CHARACTERISTICS
DC CHARACTERISTICS (Unless Otherwise Specified, V CC = 9V, Ta = 25¡É )

PIN CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP. MAX. UNIT

No.
2 Sound Output V2 - 3.20 3.70 4.20 V
3 RF AGC V3 - - 0.00 0.50 V
4 SIF TANK V4 - - - - V
5 AGC Filter V5 - 7.00 7.50 8.00 V
6 PIF GND GND - - 0.00 - V
7 PIF Input V7 - 1.50 2.00 2.50 V
8 PIF Input V8 - - 0.00 0.50 V
9 PIF Vcc VCC - - 9.00 - V
10 Loop Filter V10 - - 4.50 - V
11 APC Filter V11 - 6.00 6.50 7.00 V
12 VCXO V12 - 5.30 5.80 6.30 V
13 V/C/D GND GND - - 0.00 - V
14 F-BLK V14 - - 0.00 - V
15 Analog R Input V15 - 4.40 4.90 5.40 V
16 Analog G Input V16 - 4.40 4.90 5.40 V
17 Analog B Input V17 - 4.40 4.90 5.40 V
18 D.Vcc VCC - - 3.30 - V
19 R Output V19 BRT, C. O Cent 2.40 2.70 2.90 V
20 G Output V20 BRT, C. O Cent 2.40 2.70 2.90 V
21 B Output V21 BRT, C. O Cent 2.40 2.70 2.90 V
22 V out V22 - - - -
23 NFB V23 - - - - -
24 V. Ramp V24 - - - -
25 V SEPA V25 - 5.80 6.30 6.80 V
26 H. VCC V26 - - 9.00 - V

27 SCL V27 - 4.50 5.00 5.50 V

28 SDA V28 - 4.50 5.00 5.50 V
29 X-RAY V29 - - 0.00 - V
30 FBP Input V30 - - - - -
31 Sync. Output V31 - - - - -
32 H. Output V32 - - - - -
33 H. AFC V33 - 7.00 7.50 8.00 V
34 32fH VCO V34 - 5.50 6.00 6.50 V

35 D. GND GND - 0.00 - V

36 ABL V36 BRT, COL Cent 2.90 3.40 3.90 V
37 TV Input V37 2.90 3.00 3.90 V
38 ACL V38 BRT, COL Cent 2.90 3.40 3.90 V

15 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

PIN CHARACTERISTIC SYM- TEST CONDITION MIN. TYP. MAX UNIT

NO. BOL
39 EXT. Video Input V39 - 1.10 1.60 2.10 V

40 Black DET V40 - 6.10 6.60 7.10 V

41 AV/SW Output V41 - 1.80 2.30 2.80 V

42 DC Rest V42 - 5.50 6.00 6.50 V

43 Y Input V43 - 4.00 4.50 5.00 V

44 AFT V44 - 2.00 2.50 3.00 V

45 Chroma Input V45 - 1.60 1.85 2.10 V

46 V / C / D Vcc V46 - - 9.00 - V

47 TV DET. Output V47 - 4.70 5.20 5.70 V

48 SIF Vcc V48 - - 9.00 - V

49 PIF Tank V49 - - - - V

50 PIF Tank V50 - - - - V

51 SIF GND Vcc - - 0.00 - V

52 Limiter Input V52 - - 0.00 0.50 V

53 Audio TV Input V53 - 2.50 3.00 3.50 V

54 De-emphasis V54 Pin4 GND 4.00 4.50 5.00 V

55 EXT. Audio Input V55 - 2.50 3.00 3.50 V

Current Consumption
CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP. MAX. UNIT
IF Power Supply Current Icci - 32.8 46 52.0 mA

V/C/D Power Supply Current Iccv - 52.7 71 76.8 mA

H.Vcc Power Supply Current Icch - 10.7 14 18.4 mA

D.Vcc Power Supply Current Iccd - 5.2 10 11.6 mA

16 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

AC CHARACTERISTICS ( Unless Otherwise Specified, Vcc = 9V, Ta = 25¡É )

PIF

CHARACTERISTIC SYMBOL TEST CONDITION MIN TYP MAX UNIT

V01 1.7 2.0 2.3

Video Detected Output level Note 1 Vp-p
V02 2.0 2.5 3.0

VIN MIN - 42 -
Input Sensitivity Note 2 dB¥ìV
VIN MAX 100 107 -

Sync Tip Level VSYNC Note 3 2.6 2.9 3.2 V

Output Level For No Input VIF Note 4 4.8 5.2 5.6 V

Differential Gain DG - 2 5 %
Note 5
Differential Phase DP - 2 5 ¡£

PIF Output Frequency Characteristic fC Note 6 5 7 - MHz

Carrier Wave Compression Ratio CR 50 55 -

Note 7 dB
2nd Harmonics Compression Ratio HR 50 55 -

PIF Input Resistance RiPIF - 1.5 - k¥Ø

Note 8
PIF Input Capacitance CiPIF - 3.8 - pF

S/N S/N Note 9 52 55 - dB

920kHz Beat I920 Note 10 42 45 - dB

IF AGC Range RWAGC Note 11 61 65 69 dB

V5MEAN 4.2 4.5 4.8

V5MAX 7.4 7.6 -

IF AGC Voltage Note 12 V
V5MIN - 3.8 -

V3MAX 7.7 8.2 -

RF AGC Voltage Note 13 V
V3MIN - 0 0.5

RF AGC Control Range ¥ ÄGRFAGC Note 14 35 40 - dB

AFT Center Voltage V4CENT Note 15 2.2 2.5 2.8 V

V4MAX 4.4 4.8 -

AFT Voltage Note 16 V
V4MIN - 0.2 0.5

AFT Sensitivity ¥ìAFT Note 17 - 40 - kHz/V

AFT Output Resistance RAFTOUT Note 18 40 50 60 k¥Ø

PIF VCO Control Sensitivity ¥âIFVCO Note 19 2.0 2.5 - MHz/V

fph 1.0 1.5 -

PIF VCO Pull-in Range Note 20 MHz
fPI 1.0 1.5 -

PIF VCO Control Range ¥ ÄfPIFVCO Note 21 - 4.4 - MHz

17 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

SIF

CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP MAX. UNIT

.
VAAC 400 500 600 mVrms
Sound Output Level Note 22
VADC - 4.5 - V

Sound Distortion VAUDIO Note 23 - 0.3 1.0 %

AMR AMR Note 24 50 60 - dB

Limiting Sensitivity VLIM Note 25 - 35 - dB¥ìV

Sound Output Frequency fAUDIOH - 130 -

Characteristics Note 26 kHz
fAUDIOL - -130 -

Sound Output Resistance RSOUT Note 27 24 30 36 k¥Ø

ATT
GATTMAXE -2.0 0.0 2.0

GATTMAXT 4.0 6.0 8.0

ATT Gain GATTMEAN Note 28 -16 -12 -9 dB

GATTMIN -99 -85 -

V1VAR - - 50 mV
DC Voltage Drift Note 29
V1DC 3.2 3.7 4.2 V

Ri53 - 30 -
Input Impedance Note 30 k¥Ø
Ri55 - 47 -

Video
Input Impedance Ri41 Note 31 100 - - k¥Ø

Input Dynamic Range Vdi41 Note 32 1.0 1.2 1.5 V

Video Total Gain GY Note 33 4.5 5.0 -

Video Frequency fY Note 34 6.0 7.0 - MHz
Characteristic

Maximum Output Vdo1 Note 35 7.5 8.0 - V

Blackexpanion Amp. Gain GBAMP 1.18 1.43 1.68
Note 36
Black Expansion Start Point GBSTP 40 50 60 IRE

Dc Restoration TDC Note 37 100 103 105 %

GSHcent 1 4 7
Sharpness Control
GSHmax 9 12 15
Characteristics Note 38 dB
GSHmin - -18 -15

Sharpness Delay Time tSHDLY Note 39 - 125 - ns

Cnotrast Control GCNcent 4.5 6 7.5

Characteristics Note 40 dB
GCNmin 22.5 24 28.5

H. V - BLK Output Voltage VBLK Note 41 - 0.7 1.0 V

V-BLK Width TVBLK Note 42 - 3.5~24 - H

fSC Trap Gain GTRAP Note 43 - -28 -20 dB

18 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV
OSD

CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP. MAX. UNIT

Osd Switching Voltage VthOSD Note 44 0.7 1.0 1.3 V
Osd Delay Time tOSDDLY - 15 30
Osd Delay Time Differ- tOSDD - 5 10
ence Note 45 ns

Osd Rising Time ¥óR - 15 30

OSD Falling Time ¥óF - 15 30
Input Clamp Voltage VOSDC Note 46 4.4 4.9 5.4 V
OSD Gain GOSD Note 47 1.8 2.0 2.2 V
Input Dynamic Range VdiOSD Note 48 2.0 2.2 2.4 V

Cutoff Drive
VBRTmax 3.6 4.0 4.3
Brightness Control VBRTcen 2.4 2.7 3.0
Characteristics Note 49 V
VBRTmin 1.0 1.4 1.7
Brightness Control Difference ¥ÄVRGB Note 50 -50 0 50 mV
Between 3Axes
Vcutmax 0.5 0.65 0.8
Vcutcen - 0.00 -
Cutoff Control Characteristics Note 51 V
Vcutmin -0.8 -0.65 -0.5

Gdrvmax 3.75 4.25 4.75

Drive Control Characteristics Gdrvmin Note 52 -4.0 -3.5 -3.0 dB

Chroma
Input Dynamic Range Vdi45 Note 53 0.95 1.5 1.7 V
ea -23 -20 -17
ACC Characteristic eb 3 6 9 dB
Note 54
A 0.9 1.0 1.1
Killer Point EK Note 55 -48 -46 -43 dB
VCXO Frequency Control ¥ Ä fVCXO Note 56 ¡¾ 50 ¡¾ 60 - Hz
Range 0 0
VCXO Frequency Control ¥âVCXO Note 57 - 1.0 - Hz/mV
Sensitivity
VCXO Pull-in Range fVCXOPL Note 58 ¡¾ 30 ¡¾ 45 - Hz
0 0
R/B 0.80 0.84 0.90
Demodulate Relative Gain G/B 0.25 0.29 0.33
Note 59
R-B 101 108 115
Demodulate Relative Phase G-B 236 243 250 ¡£

ECR - 20 40
ECB - 20 40
Carrier Wave Remain Note 60 mVp-p
ECG - 20 40

19 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

CHARACTERISTIC SYMBOL TEST CONDITION MIN. TYP MAX. UNIT

.
VCLRmax 3.9 4.1 4.3 Vp-p
GCLRcen 4.5 6 7.5
Color Control Characteristic Note 61
dB
GCLRmin 38 40 -
Uni-color Control GUNIcen 4.5 6 7.5
Characteristic Note 62 dB
GUNImin 22 24 26
¥ÈTNTcen -7 0 7
TINT Control Characteristic Note 63 ¡£
¥Ä ¥ÈTNT ¡¾ 3 ¡¾ 4 ¡¾ 55
5 5
Video Chroma Delay Time tV - C Note 64 -30 0 30 ns

Deflection
Horizontal Free Run Freq. fH Note 65 -100 0 100 Hz
H. Out Pulse Duty TH Note 66 38 41 44 %
VHL - 0.2 0.3
H. Out Voltage Note 67 V
VHH 2.5 3.0 3.5
VCO Osc. Start Voltage VOSCmin Note 68 3.0 3.5 4.0 V
H. Out Start Voltage VHST Note 69 3.7 4.0 - V
H. Frequency Control Range ¥ Ä fH Note 70 ¡¾ 500 ¡¾ 650 - Hz
H. Freq. Control Sensitivity ¥âH Note 71 - 500 - Hz/V
H. Sync. Pull-in Range ¥ Ä fHPUL Note 72 ¡¾ 450 ¡¾ 500 - Hz
259
H. Pull-in Stop Period THSTP Note 73 - ~272 - H
AFC-2 Control Range TAFC2 Note 74 16 17 - ¥ìs
Horizontal Position Adjustment TPAFC2 Note 75 - ¡¾ 3 - ¥ìs
X-RAY Protection Detection Voltage VXDET 3.35 3.5 3.65
V
X-RAY Protection Hold Voltage VXHLD 3.9 4.2 4.5
Note 76
X-RAY Protection Hold Current VXLD 80 100 120 ¥ìA
Vertical Free Run Freq. fV Note 77 - 295 - H
TVST - 224 -
V. Sync. Pull-in Range Note 78 H
TVEND - 295 -
V. Out Pulse Width TV Note 79 - 8 - H
VVL 2.2 2.4 -
V. Ramp Amplitude Control Note 80 V
VVH - 1.6 1.8
H. Sync. Separation Level Rsepa Note 81 30 35 40 %
Forced V. Osc. (262.5H) fV60 Note 82 - 60 - Hz

20 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

21 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

22 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

23 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

24 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

25 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

26 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

27 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

28 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

29 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

30 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

31 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

32 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

33 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

34 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

35 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

36 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

37 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

38 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

39 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

40 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

41 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

SIGNAL FOR MEASUREMENT

¨ç Input Signal 1
Frequency fo sine wave

0.5V

¨è Input Signal 2

Frequency fo sine wave

0.5V

Burst

42 M/M-97-D008
97-05-20
KA2163 I2C BUS NTSC 1 CHIP IC FOR COLOR TV

TEST CIRCUIT

10k¥Ø

200¥ (¨öW) 10¥ìF

1k¥Ø
5.1V 29 X-RAY SDA 28
47¥ìF
47k¥Ø 1k¥Ø
0.01¥ìF 30 FBP IN SCL 27
8.2k¥
SW30
0.01¥ìF 100¥ìF

9.0
100k¥Ø B 31 Sync. H.VCC 26
330¥Ø 2.2¥ìF
9 8 32 H .OUT V SEPA FILTER 25
0.01¥ì
TC74HC123

H.VCC

1500PF 2.2¥ìF
10 7
33 H. AFC V. RAMP 24
11 6 1¥ìF 2.2k¥
22k¥
12 5 34 32fHVCO NFB 23
CSB 360¥Ø
13 4
14 3
503F30 35 D. GND V. OUT 22
15 2 1¥ìF
100PF 100¥Ø 36 ABL B OUT 21
16 1
100k¥Ø B 10k¥Ø 0.1¥ìF
37 TV IN G OUT 20
1¥ìF
1k¥ 38 ACL R OUT 19
0.1¥ìF

3.3V
75¥Ø 39 EXT. VIDEO D. VCC 18
10¥ìF
40 BLACK DET B IN 17
0.1¥ìF
220k¥ 4.7k¥
41 AV/SW OUT G IN 16 4.7k¥
KA2163B

0.1¥ìF
1.8k¥Ø 1.8k¥Ø 1¥ìF
42 DC REST R IN 15
75k¥Ø 0.1¥ìF 4.7k¥
3.3k¥ 43 Y IN F-BLK 14
0.1¥ìF
4.7k¥
44 AFT GND 13 NR18
0.01¥ìF (3.58MHz)
45 CHROMA IN VCXO 12
330¥ 3.3k¥Ø
0.01¥ìF
46
4.5M

APC FILTER 11
Trap

VCC
1.5¥ìF
47¥ìF 0.022¥ìF
47 TV DET. OUT LOOP FILTER 10 100¥Ø
68¥ìF 2200pF
330¥ 0.01¥ìF
48 SIF VCC PIF VCC 9 0.01¥ìF 47¥ìF

47¥ìF 49 PIF TANK PIF IN 8

SAW

3.9k¥Ø
2k¥
1k¥ PIF TANK
50 PIF IN 7
9V

47pF

22¥ìH
51 SIF GND RIF GND 6 68¥ìF 0.01¥ìF
SW52

0.01¥ìF
0.47¥ìF
4.5M
47pF

BPF

52 LIMITER IN AGC FILTER 5 47¥ìF

1000pF 200¥
53 AUDIO TV IN SIF TANK 4
75¥ 47¥ìF 9.1k¥ 220¥Ø 47¥
54 DE-EMPHASIS RF AGC 3 5.6k¥ 1.6k¥Ø
4700pF
1k¥ 0.01¥ìF
0.01¥ìF
0.47¥ìF 55 EXT. AUDIO SOUND OUT 2
IF IN

0.01¥ìF 75¥Ø
56 EXT. AUDIO SOUND 1
0.47¥ìF

43 M/M-97-D008
97-05-20