Container

Refrigeration
Unit

Models
69NT40-511-1
to
69NT40-511-199
and
69NT40-521
DUE TO THE LARGE NUMBER OF SCHEMATIC
DIAGRAMS CONTAINED IN THIS BOOK, THE
BOOK IS PRESENTED AS TWO FILES.
REFER TO FILE T268--TEXT FOR THE TABLE
OF CONTENTS, CHAPTERS 1 THROUGH 6
AND INDEX.

T-268 Rev G
 OPERATION AND
SERVICE MANUAL

CONTAINER REFRIGERATION UNIT

MODELS
69NT40-511-1
to
69NT40-511-199
and
69NT40-521

Carrier Transicold Division, Carrier Corporation, P.O. Box 4805, Syracuse, N.Y. 13221
E Carrier Corporation 1999 S Printed in U. S. A. 0499
 SECTION 7

SECTION 7
ELECTRICAL WIRING SCHEMATIC AND DIAGRAMS
7.1 INTRODUCTION

This section contains Electrical Schematics and Wiring Diagrams covering the Models listed in Table 1-1. The
following general safety notices supplement the specific warnings and cautions appearing elsewhere in this manual.
They are recommended precautions that must be understood and applied during operation and maintenance of the
equipment covered herein.

WARNING
It has been determined that pressurized, air-rich mixtures of refrigerants and air can undergo
combustion when exposed to an ignition source.
WARNING
Beware of unannounced starting of the evaporator and condenser fans. Do not open the condenser fan
grille before turning power OFF and disconnecting power plug.
WARNING
Make sure power to the unit is OFF and power plug disconnected before removing capacitor(s).
WARNING
Do not attempt to remove power plug(s) before turning OFF start-stop switch (ST), unit circuit
breaker(s) and external power source.
Make sure the power plugs are clean and dry before connecting to any power receptacle.
WARNING
Make sure power to the unit is OFF and power plug disconnected before replacing the compressor.
WARNING
Before disassembly of the compressor make sure to relieve the internal pressure very carefully by
slightly loosening the bolts on both service valve flanges/blank valve pads, then lightly tapping sides of
the valve flanges/pads with a hammer to break the seal.
CAUTION
Use only Carrier Transicold approved Polyol Ester Oil (POE) -- Castrol-Icematic SW20 compressor oil
with R-134a. Buy in quantities of one quart or smaller. When using this hygroscopic oil, immediately
reseal. Do not leave container of oil open or contamination will occur.
WARNING
Do not attempt to do service work on the Controller/DataCORDER module. Breaking of the warranty
seal will void the warranty.
CAUTION
Remove the Controller/DataCORDER module and unplug all wire harness connectors before
performing any arc welding on any part of the container.
Do not remove wire harnesses from module unless you are grounded to the unit frame with a static safe
wrist strap.
NOTE
To avoid damage to the earths ozone layer, use a refrigerant recovery system whenever removing refrigerant.
When working with refrigerants you must comply with all local government environmental laws. In the U.S.A.,
refer to EPA section 608.

7-1 T-268-07
 Figure 7-1. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-2
 SECTION 7

Figure 7-1. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-3 T-268-07
 Figure 7-2. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-4
 SECTION 7

Figure 7-2. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-5 T-268-07
 Figure 7-3. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-6
 SECTION 7

Figure 7-3. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-7 T-268-07
 Figure 7-4. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-8
 SECTION 7

Figure 7-4. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-9 T-268-07
 Figure 7-5. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-10
 SECTION 7

Figure 7-5. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-11 T-268-07
 Figure 7-6. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-12
 SECTION 7

Figure 7-6. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-13 T-268-07
 Figure 7-7. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-14
 SECTION 7

Figure 7-7. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-15 T-268-07
 Figure 7-8. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-16
 SECTION 7

Figure 7-8. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-17 T-268-07
 Figure 7-9. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-18
 SECTION 7

Figure 7-9. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-19 T-268-07
 Figure 7-10. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-20
 SECTION 7

Figure 7-10. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-21 T-268-07
 Figure 7-11. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-22
 SECTION 7

Figure 7-11. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-23 T-268-07
 Figure 7-12. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-24
 SECTION 7

Figure 7-12. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-25 T-268-07
 Figure 7-13. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-26
 SECTION 7

Figure 7-13. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-27 T-268-07
 Figure 7-14. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-28
 SECTION 7

Figure 7-14. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-29 T-268-07
 Figure 7-15. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-30
 SECTION 7

Figure 7-15. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-31 T-268-07
 Figure 7-16. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-32
 SECTION 7

Figure 7-16. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-33 T-268-07
 Figure 7-17. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-34
 SECTION 7

Figure 7-17. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-35 T-268-07
 Figure 7-18. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-36
 SECTION 7

Figure 7-18. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-37 T-268-07
 Figure 7-19. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-38
 SECTION 7

Figure 7-19. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-39 T-268-07
 Figure 7-20. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-40
 SECTION 7

Figure 7-20. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-41 T-268-07
 Figure 7-21. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-42
 SECTION 7

Figure 7-21. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-43 T-268-07
 Figure 7-22. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-44
 SECTION 7

Figure 7-22. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-45 T-268-07
 Figure 7-23. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-46
 SECTION 7

Figure 7-23. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-47 T-268-07
 Figure 7-24. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-48
 SECTION 7

Figure 7-24. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-49 T-268-07
 Figure 7-25. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-50
 SECTION 7

Figure 7-25. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-51 T-268-07
 Figure 7-26. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-52
 SECTION 7

Figure 7-26. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-53 T-268-07
 Figure 7-27. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-54
 SECTION 7

Figure 7-27. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-55 T-268-07
 Figure 7-28. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-56
 SECTION 7

Figure 7-28. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-57 T-268-07
 Figure 7-29. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-58
 SECTION 7

Figure 7-29. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-59 T-268-07
 Figure 7-30. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-60
 SECTION 7

Figure 7-30. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-61 T-268-07
 Figure 7-31. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-62
 SECTION 7

Figure 7-31. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-63 T-268-07
 Figure 7-32. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-64
 SECTION 7

Figure 7-32. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-65 T-268-07
 Figure 7-33. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-66
 SECTION 7

Figure 7-33. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-67 T-268-07
 Figure 7-34. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-68
 SECTION 7

Figure 7-34. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-69 T-268-07
 Figure 7-35. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-70
 SECTION 7

Figure 7-35. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-71 T-268-07
 Figure 7-36. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-72
 SECTION 7

Figure 7-36. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-73 T-268-07
 Figure 7-37. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-74
 SECTION 7

Figure 7-37. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-75 T-268-07
 Figure 7-38. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-76
 SECTION 7

Figure 7-38. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-77 T-268-07
 Figure 7-39. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-78
 SECTION 7

Figure 7-39. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-79 T-268-07
 Figure 7-40. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-80
 SECTION 7

Figure 7-40. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-81 T-268-07
 Figure 7-41. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-82
 SECTION 7

Figure 7-41. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-83 T-268-07
 Figure 7-42. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-84
 SECTION 7

Figure 7-42. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-85 T-268-07
 Figure 7-43. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-86
 SECTION 7

Figure 7-43. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-87 T-268-07
 Figure 7-44. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-88
 SECTION 7

Figure 7-44. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-89 T-268-07
 Figure 7-45. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-90
 SECTION 7

Figure 7-45. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-91 T-268-07
 Figure 7-46. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-92
 SECTION 7

Figure 7-46. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-93 T-268-07
 Figure 7-47. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-94
 SECTION 7

Figure 7-47. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-95 T-268-07
 Figure 7-48. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-96
 SECTION 7

Figure 7-48. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-97 T-268-07
 Figure 7-49. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-98
 SECTION 7

Figure 7-49. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-99 T-268-07
 Figure 7-50. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-100
 SECTION 7

Figure 7-50. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-101 T-268-07
 Figure 7-51. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-102
 SECTION 7

Figure 7-51. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-103 T-268-07
 Figure 7-52. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-104
 SECTION 7

Figure 7-52. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-105 T-268-07
 Figure 7-53. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-106
 SECTION 7

Figure 7-53. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-107 T-268-07
 Figure 7-54. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-108
 SECTION 7

Figure 7-54. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-109 T-268-07
 Figure 7-55. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-110
 SECTION 7

Figure 7-55. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-111 T-268-07
 Figure 7-56. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-112
 SECTION 7

Figure 7-56. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-113 T-268-07
 Figure 7-57. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-114
 SECTION 7

Figure 7-57. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-115 T-268-07
 Figure 7-58. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-116
 SECTION 7

Figure 7-58. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-117 T-268-07
 Figure 7-59. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-118
 SECTION 7

Figure 7-59. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-119 T-268-07
 Figure 7-60. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-120
 SECTION 7

Figure 7-60. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-121 T-268-07
 Figure 7-61. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-122
 SECTION 7

Figure 7-61. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-123 T-268-07
 Figure 7-62. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-124
 SECTION 7

Figure 7-62. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-125 T-268-07
 Figure 7-63. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-126
 SECTION 7

Figure 7-63. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-127 T-268-07
 Figure 7-64. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-128
 SECTION 7

Figure 7-64. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-129 T-268-07
 Figure 7-65. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-130
 SECTION 7

Figure 7-65. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-131 T-268-07
 Figure 7-66. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-132
 SECTION 7

Figure 7-66. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-133 T-268-07
 Figure 7-67. Electrical Schematic -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-134
 SECTION 7

Figure 7-67. Electrical Schematic -- See Model Chart

(Sheet 2 of 2)

7-135 T-268-07
 Figure 7-68. Electrical Wiring Diagram -- See Model Chart
(Sheet 1 of 2)

T-268-07 7-136
 SECTION 7

Figure 7-68. Electrical Wiring Diagram -- See Model Chart

(Sheet 2 of 2)

7-137 T-268-07