TEREX CRANES, INC. P/N 3232U1328 T750 CRANE RATING MANUAL 75 U.S. TON HYDRAULIC CRANE 9700 LB TOTAL COUNTERWEIGHT Terex Cranes, Inc. Highway 501 East / P.O. Box 260002 Conway, SC 29528 9292U1312_8DEFINITIONS *\ RATED LIFTING CAPACITY: THE TOTAL SUSPENDED LOAD, INCLUDING THE WEIGHT OF -MATERIAL AND LOAD HANDLING EQUIPMENT, THAT THE. MACHINE CAN SAFELY LIFT UNDER IDEAL CONDITIONS AT A GIVEN BOOM LENGTH, BOOM ANGLE AND LOAD RADIUS. 2. LOAD RADIUS: THE HORIZONTAL DISTANCE MEASURED BETWEEN THE CENTER OF ROTATION AND THE HOIST LOAD LINE OR TACKLE WITH LOAD APPLIED. 3. LOADED BOOM ANGLE: THE ANGLE BETWEEN THE LONGITUDINAL CENTERLINE OF THE BOOM BASE SECTION AND THE HORIZONTAL AFTER LIFTING THE RATED LOAD AT THE RATED LOAD RADIUS. 4, BOOM POINT ELEVATION: THE VERTICAL DISTANCE MEASURED BETWEEN THE GROUND AND THE BOOM POINT SHEAVE, 5. FREELY SUSPENDED LOAD: LIFTED LOAD HANGING FREE WITH NO’ DIRECT EXTERNAL FORCE APPLIED EXCEPT BY THE HOIST LINE. 6. SIDE LOAD: HORIZONTAL FORCE APPLIED TO THE LIFTED LOAD EITHER ON THE GROUND OR IN THE AIR. 7, WORK AREAS: AREA MEASURED IN A CIRCULAR ARC ABOUT THE CENTER LINE OF ROTATION AS SHOWN IN THE AREA OF OPERATION DIAGRAM. 8. FULLY EXTENDED OUTRIGGERS: ALL OUTRIGGER BEAMS EXTENDED TO MAXIMUM SPREAD, AND WITH ALL FLOATS DOWN AND SET. 9. MID POSITION OUTRIGGERS: ALL OUTRIGGER BEAMS EXTENDED FULLY TO THE MID POSITION POSITIVE STOPS AND WITH ALL FLOATS DOWN AND. SET. 10. RETRACTED OUTRIGGERS: ALL OUTRIGGER BEAMS NOT EXTENDED AND. ALL FLOATS DOWN AND SET. aasas= WANN = THIS MACHINE MEETS THE REQUIREMENTS OF ANSI 830.5; PCSA #4, UPPER, LOWER, BOOM AND JIB STRUCTURES HAVE BEEN TESTED PER SAE J-1063._ MACHINE STABILITY HAS BEEN TESTED PER SAE J—765. THIS MACHINE ALSO CONFORMS TO THE REQUIREMENTS OF THE OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA),-UNITED. STATES DEPARTMENT OF LABOR, IN EFFECT AT THE TIME OF MANUF ACTURE. * «CRANE LIFTING CAPACITITES SHOWN ARE FOR THIS MACHINE AS ORIGINALLY MANUFACTURED AND EQUIPPED BY TEREX CRANES, INC. THE-LIFTING CAPACITIES ONLY APPLY WHEN ALL THE INSTRUCTIONS IN. THIS BOOK-ARE RIGIDLY FOLLOWED. MODIFICATIONS. TO_THIS: ~ MACHINE OR USE OF EQUIPMENT OTHER THAN THAT SPECIFIED CAN RESULT IN A REDUCTION OF CAPACITY. IF IMPROPERLY OPERATED OR MAINTAINED, THIS MACHINE CAN BE HAZARDOUS. OPERATION AND MAINTAINCE OF THIS MACHINE MUST BE IN COMPLIANCE WITH THE INFORMATION IN THE OPERATORS, SHOP, PARTS AND SAFETY MANUALS FURNISHED. IF THESE MANUALS ARE MISSING, OBTAIN REPLACEMENTS THROUGH EX CRANES, INC. REDUCED CRANE LIFTING CAPACITIES FOR THE PARTICULAR JOB SHALL BE ESTABLISHED BY THE USER WITH DUE ALLOWANCE FOR ADVERSE OPERATING CONDITIONS. THESE CONDITIONS INCLUDE THE SUPPORTING SURFACE, PENDULUM. ACTION OF THE LOAD, JERKING OR SUDDEN STOPS OF THE LOAD AND OTHER FA FFECTING-STABILITY, TWO MACHINE LI , ELECTRICAL WIRES, AD’ ‘SE_ WEATHER, WIND, HAZARDOUS SURROUNDINGS, EXPERIENCE OF PERSONNEL, ETC. CRANE LIFTING CAPACITIES ARE BASED ON FREELY SUSPENDED LOADS WITH THE MACHINE LEVELED AND STANDING ON A FIRM UNIFORM SUPPORTING SURFACE. DEPENDING ON THE NATURE OF THE SUPPORTING SURFACE, IT MAY BE_NECESSARY TO HAVE STRUCTURAL SUPPORTS UNDER THE OUTRIGGER FLOAT TO DISTRIBUTE THE FLOAT LOAD“AND INSURE THAT GROUND BEARING CAPACITY OF THE SUPPORTING SURFACE 'S NOT EXCEEDED. NO ATTEMPT SHALL BE MADE TO MOVE A LOAD HORIZONTALLY ON THE GROUND IN ANY DIRECTION. = SIDE LOADING OF THE MACHINE AND LOAD SWING OUT MAY CAUSE STRUCTURAL FAILURE OR MACHINE TIP—OVER. SIDE LOADS MAY BE. GENERATED BY: LIFTING WHEN NOT LEVEL; SWINGING WHEN NOT LEVEL; DRAGGING A LOAD; SUDDEN ACCELERATING OR DECELERATION IN SWINGING; WIND FORCES ON LOAD AND BOOM STRUCTURE;. PUSHING A LOAD. son7inasNs 7. LOADED BOOM ANGLES AT SPECIFIED BOOM LENGTHS GIVE ONLY AN APPROIMATION OF THE OPERATING RADIUS. THE BOOM ANGLE BEFORE LOADING SHOULD BE GREATER TO ACCOUNT FOR BOOM DEFLECTION INCREASING THE RADIUS AS THE LOAD IS LIFTED. 8. POWERED BOOM SECTIONS MUST BE EXTENDED AND RETRACTED EQUALLY. 9. RATED LIFTING CAPACITIES ARE BASED ON CORRECT REEVING. DEDUCTION MUST BE MADE FOR EXCESSIVE REEVING, ANY REEVING OVER THE MINIMUM REQUIRED (SEE WIRE ROPE STRENGTH TABLE) IS CONSIDERED EXCESSIVE AND MUST BE ACCOUNTED FOR. USE WORKING RANGE DIAGRAM TO ESTIMATE THE EXTRA FEET (METERS) OF WIRE ROPE THEN DEDUCT 1 POUND FOR EACH FOOT (1.5 Kg FOR EACH METER) OF EXCESSIVE WIRE ROPE BEFORE ATTEMPTING TO LIFT A LOAD. 10.POSITIONING OR OPERATING AT A RADII OR BOOM LENGTH BEYOND THE MAXIMUMS OR MINIMUMS SHOWN, IS NEITHER INTENDED OR APPROVED. 11. WHEN EITHER BOOM LENGTH OR RADIUS OR BOTH ARE BETWEEN VALVES. LISTED, THE NEXT SMALLEST RATED LIFTING CAPACITY AT EITHER THE NEXT LARGER OR NEXT LONGER OR SHORTER BOOM LENGTH SHALL BE USED 12. POSITIONING OR OPERATION OF LATTICE EXTENSION OR JIB AT BOOM ANGLES BEYOND THE MAXIMUMS OR MINIMUMS SHOWN IS NEITHER INTENDED OR APPROVED. 13.IT IS SAFE TO ATTEMPT TO TELESCOPE ANY LOAD WITHIN THE LIMITS OF THE RATING CHART. THE MAXIMUM LOAD WHICH MAY BE TELESCOPED IS LIMITED BY HYDRAULIC PRESSURE, BOOM ANGLE AND POWERED 800M SECTIONS LUBRICATION. 3292U278_BRANGE DIAGRAM 1750 126" FULL POWER BOOM 100 110 120 130 140 ‘GROUND LEVEL: 10 20 30 40 50 60 70 60 90 100 110 120 130 140 HOOK DISTANCE FROM CENTERLINE OF ROTATION ROTATION HEIGHT ABOVE GROUND - FEETAREAS OF OPERATION -OUTRIGGERS- =) ON OUTRIGGERS” WORK AREA . an ste note ao Ooo Serine Sor Stthiccen Behcoer “WHEN FYDRAULING FRONT] nor : THESE LINES DETERMINE THE TABILIZER IS SET, ‘OVER SIDE* LIMITING POSITION OF ANY LOAD FOR, RATINGS ARE APPLICABLE TO OPERATING WITHIN WORKING AREAS “OVER FRONT" INDICATED, "2080 MAIN & AUXIIARY HOIST REEVING 6X 97 Te INCH {19 mim) BIA, ROPE BREAKING STRENGTH 58800 18. (26600 KG) 1 2 ele s |s | 7 s [se [| 1 16000 | 20000 | 45000 | 60000 | 75000 | g0000 | 108000 |120000 |125000 150000 ‘cae | ga00 | 12600 | 20400 | 27200 | s4000 | 0800 | 7600 | s4400 | 61200 | ee100 "TEa0 AUXILIARY HOIST REEVING _ 6X37 [TE INGH (19 mm DIA, ROPE BREAKING STRENGTH 68800 18. (26600 KG) wats oFuNe| 4 2 3 4 5 6 7 8 9 10 wax [71000 | 22000 | 22000 | #4000 | 85000 | asc00 | 77000 | #8000 | s8000 |1 10000 sexu go00 | 10000 | 15000 | 20000 | 26000 | 20000 | s8000 | 40000 | 48000 | 50000 HOIST REEVING _ 8 X 19 ROTATION RESISTANT al "75 INCH [19 mm) DIA, ROPE BREAKING STRENGTH 51800 18, (23500 KG! sats oF uNe| 1 2 3 4 5 6 7 a 9 10 “axis | 49350 | 20700 | 31050 | 41400 | 81750 | 62100 | 72450 | 82800 | $3150 | ax T4600 | 9300 | 14090 | 18700 | 22400 | 28100 | 32800 | 37500 | 42200 46300 | 929201252.4OPERATION ON OUTRIGGERS 1. READ AND UNDERSTAND ALL WARNINGS AND INSTRUCTIONAL NOTES. RATED LOADS FOR FULLY EXTENDED OUTRIGGERS DO NOT EXCEED 85% OF THE TIPPING LOAD AS DETERMINED BY SAE CRANE STABILITY TEST CODE J765 THE TIRES SHALL BE RAISED CLEAR OF THE GROUND AND FREE OF CRANE WEIGHT BEFORE OPERATING BOOM OR LIFTING LOADS. ALL OUTRIGGER BEAMS MUST BE EXTENDED TO THE SAME LENGTH; FULLY EXTENDED, MID POSITION OR FULLY RETRACTED. RATED LIFTING CAPACITIES ABOVE THE BOLD LINE ARE BASED ON THE MACHINE'S HYDRAULIC OR STRUCTURAL COMPETENCE AND NOT ON MACHINE STABILITY. RATED LIFTING CAPACITIES BELOW THE BOLD LINE ARE BASED ON THE MACHINE'S STABILITY. RATED LIFTING CAPACITIES INCLUDE THE WEIGHT OF HOOK BLOCK, SLINGS AND AUXILIARY LIFTING DEVICES. THEIR WEIGHT MUST BE SUBTRACTED FROM THE LISTED RATED LIFTING CAPACITY TO OBTAIN THE NET LOAD TO BE LIFTED. WHEN LIFTING OVER THE LATTICE EXTENSION THE WEIGHT OF ANY HOOK BLOCK, SLINGS, AND AUXILIARY LIFTING DEVICES AT THE MAIN BOOM HEAD MUST BE ADDED TO THE LOAD WHEN THE LATTICE EXTENSION IS ERECTED BUT UNUSED ADD THREE (3) TIMES THE WEIGHT OF ANY HOOK BLOCK, SLINGS, AND AUXILIARY LIFTING DEVICES AT THE EXTENSION HEAD TO THE LOAD OUTRIGGERS MUST BE IN THE FULLY EXTENDED POSITION WHEN LIFTING AT THE MAIN BOOM HEAD WITH THE LATTICE EXTENSION ERECTED. ADD 150LB TO THE CHART VALUES IF THE AUXILIARY BOOM HEAD SHEAVE IS NOT ERECTED. 3292u1257.¢OPERATION ON OUTRIGGERS 10. ~ 11. 12. EXTENSION RATED LIFTING CAPACITY IS BASED ON LOADED MAIN BOOM ANGLE WITH REFERENCE TO HORIZONTAL, REGARDLESS OF MAIN BOOM LENGTH. REFERENCE RADIUS IS FOR FULLY EXTENDED MAIN BOOM. FOR ANGLES NOT SHOWN, USE THE NEXT LOWER BOOM ANGLE TO DETERMINE THE ALLOWABLE CAPACITY. DO NOT TIP MACHINE TO DETERMINE ALLOWABLE LIFTING CAPACITIES. HANDLING OF PERSONNEL. IS NOT PERMITTED UNLESS IT IS THE LEAST HAZARDOUS WAY TO COMPLETE THE JOB. HANDLING OF PERSONNEL IS ONLY PERMITTED IN ACCORDANCE WITH THE TEREX CRANES INC POLICY GUIDE AND OSHA 1926-550. . USE OF PILE DRIVING/EXTRACTING EQUIPMENT IS APPROVED UNDER THE LIMITATIONS AND OPERATING REQUIREMENTS STATED IN " TEREX CRANES INC. "PILE DRIVING/EXTRACTING POLICY” GUIDE. 3292012588OPERATION ON TIRES 1. READ AND UNDERSTAND ALL WARNINGS AND INSTRUCTIONAL NOTES. CRANE LIFTING CAPACITIES ON TIRES DO NOT EXCEED 75% OF THE TIPPING LOAD. CRANE LIFTING CAPACITIES ON TIRES DEPEND ON TIRE CAPACITY, CONDITION OF THE TIRES AND TIRE AIR PRESSURE. TIRES MUST BE INFLATED TO THE RECOMMENDED PRESSURE BEFORE LIFTING. CRANE LIFTING CAPACITIES REQUIRE LIFTING FROM MAIN BOOM HEAD ONLY ON A SMOOTH AND LEVEL SURFACE. RATED LIFTING CAPACITIES ABOVE THE BOLD LINE ARE BASED ON THE MACHINE'S HYDRAULIC OR STRUCTURAL COMPETENCE AND NOT ON MACHINE STABILITY. RATED LIFTING CAPACITIES BELOW THE BOLD LINE ARE BASED ON THE MACHINE'S STABILITY. RATED LIFTING CAPACITIES INCLUDE THE WEIGHT OF HOOK BLOCK, SLINGS AND AUXILIARY LIFTING DEVICES. THEIR WEIGHT MUST BE SUBTRACTED FROM THE LISTED RATED LIFTING CAPACITY TO OBTAIN THE NET LOAD TO BE LIFTED. ADD 150LB TO THE CHART VALUES IF THE AUXILIARY BOOM HEAD SHEAVE IS NOT ERECTED. FOR PICK AND CARRY OPERATIONS, THE BOOM MUST BE CENTERED OVER THE REAR OF THE MACHINE, THE MECHANICAL SWING LOCK ENGAGED AND THE LOAD MUST BE RESTRAINED FROM SWING, DO NOT TRAVEL WITH BOOM EXTENSION ERECTED. . CREEP: MOTION LESS THAN 200 FEET (60 METERS) IN A 30 MINUTE PERIOD AND NOT EXCEEDING 1 MPH (1.6 KM/H). MAXIMUM RECOMMENDED BOOM ANGLE ON TIRES IS 73° WITHOUT LOAD. _ LIFTING LOADS WITH ERECTED BOOM EXTENSION IS NEITHER INTENDED NOR APPROVED. . HANDLING OF PERSONNEL FROM THE BOOM IS NEITHER INTENDED NOR APPROVED. . OPERATING PILE DRIVING/EXTRACTING EQUIPMENT ON TIRES IS NEITHER INTENDED NOR APPROVED. 929201288_ALIFTING ON TIRES — OUTRIGGERS NOT IN USE| GROUND 1-LIFTING CAPACITIES, SECTION 3 APPLY. LIFTING ON OUTR IGGERS — TIRES CLEAR OF GROUND} FULLY ENTENDED OUTRIGGERS. GROUND 1-STOP PIN IN OUTER POSITION 2-OUTRIGGER CYLINDER FULLY EXTENDED 3-YELLOW STRIPE SHOWING 4-LIFTING CAPACITIES, SECTION 4 APPLY RED STRIPE o ce one MID POSITION QUTRIGGERS GROUND 3232u0+4-A 1-STOP PIN IN INNER POSITION 2-OUTRIGGER CYLINDER EXTENDED TO STOP 3-RED STRIPE SHOWING A-LIFTING CAPACITIES, SECTION 5 APPLY FULLY RETRACTED OUTRIGGERS 1-OUTRIGGER CYLINDER FULLY RETRACTED 2-NO STRIPE SHOWING 3-LIFTING CAPACITIES, SECTION 6 APPLYHOOK BLOCK WEIGHTS = | 9.6 TON BALL HOOK 476 POUNDS 20 TON 1 SHEAVE. HOOK BLOCK 420 POUNDS 75 TON 5 SHEAVE HOOK BLOCK 1174 POUNDS 8.7 M TON BALL HOOK 213 Kg 18.1 M TON 1 SHEAVE HOOK BLOCK 190 Kg 69 M TON 5 SHEAVE HOOK BLOCK 533_Kg NOTE: These weights apply only to TEREX CRANES, Inc supplied equipment. 323201323_8[Sei 1o907 GRY STON Woos 334030 &- 1v (1355) 115N3' WOON WHNIKWA z (GVO ON) HIONST WOOE J3LVIIGNI OS (S33H030) J 1ONY WOO WNMININY Seri TS eor) TSe6) (S88) way 89) teas) Lr) ] (ae) i (ove) o 1of o | of oosz'] of cove | of oor | of coco | 0} oose | of ooezt| o | oozes! o| cove! 0 (C43) Novi (6) savo1 318Ny Woo! 334930 OU3Z i ea 7] fils] some [ies |ianeaet| bony omune - zs acs ‘oi oO1: | z00z6 a) iseI|eonosal x06 mame net inate oa 7 — | oot $6 |~o0sb | 6e | ~oorr | of | ooe | zt aa ~ se) 06 | opes "|" er |ooes |"se}“ooes | sz sen ee i — ee ean EOSE Se o0e9 [er | ~ooc9 | ov | ove | ze | coda | zi 7 ace | |S 08 | 0052 [0s] oorz | rr] ovez | ze} ose | oz] aa —|—_}__| _} 8 sZ | ooss [es] ooze | er] cose | 1p] oss | ce| oove | i a | Se oz | ooeor [96 | oozor | 1s | oozor | ar |oocor [ve | 006s | 2 - [792 189 [ooret es Poot ev | ooztr | se ae [331 03 [-ooser [19 ‘ooze | sb | “coset | oy |r ss" ooaer [+9 ‘oosat |"25}” dost |oi fs os [oozst |z9 [oosar |9s] _oogsi | os EE sr ootzt [69 ‘guste | 09 [oosze [ss] ores —_ Li Sr or |-ooeer [zz ‘0292 | 69] o0zz2'| 65 | ooze aioe | tam |x07 s€ | oosoe | +2} ootez | ez | ooase [6a | o0sez | 29) “ooree | e9| ooose DO0E | SE “se |o€-|oosee | 92 | oopse | +z |_ooaez | 2x | oorae | oz |ooose | 29 | ooser | oozee | ae [Coser | oz) oF | S ~ | ooese [zz | “ooate sz |-oocae | ez | “oozer | oz | ooser | oozes | er | oosss | ie | se 08 oT i I o0s69 [9s | oo69 | 1s | oz st - _ ‘0019 oozie | +9} o0see | 09 [st zt | C _ poooor| a9 | Oooatt| so [zr oO _ ooozor| 12] oooost! eo] or a ae Wa wa wae [ae a wa soma) ay ‘avor]. Fees] 91 ov07] 328 ar ‘ovor] B28 |an vor javavor 810001), oven | “get just L3s0t “186 1389 5" Tsai NIHIONS1 WOOd GsuIMOd oo snouonaaa ‘ 33S ¥0 # 3009 (INT) 3OIATG LNSWOW GOT LHOIIMYALNNOD TW1LOL GNNOd 0026 YVSH HSIAO - SHIDILLNO GIGNSLX3 ATINS NO WOOK L921 - SF SCNNOd NI SALLIOVdY > ONAN GALVY_(G¥O7 ON) STONY Wood s3to30 ZIV 55 (G¥O1 ON) HIONS1 WOOS GALVSIONI HOS (S334530) JIONY WOO WANINIM| INST GOS WANIKYIT (C13) Have )/ (a7) savo7 STON Wo easy ooge | 0 jaUDIM OUTZ ob “0044 “ooste ‘ooze, ‘OOrSE |_es “ooash |"es aos) ae a 'ov07| 322% 189) 0 # 3009 (IW) SOIAZG_ INSWOW avO1 SQNNOd NI SaILIOvd* AHDISMUAINNOD TWLOL GNNOd 0026 3OIS U3AO - SYSDOILNO GIGNILXS ATINS NO WOO 14921 - Sor ‘ONILIIT GALVYSE (VOT ON) STONY WOOS ISuDs v (1334) = (G¥O1 ON) HLONST WOOE GSLWSIGNI HOA (S334530) JTONY WOOS WNWINIM| N31 NOOR WAM 0 ose | o | oozz | 0 | cost} o | cosa: | o (La) ave (e1) savo7 STONY WoOs 334930 WAZ ] | | Te eay 5) Wary Seer OVE) 30 _[_Ooe | 7S] doe [eS] o0ez | er] core _ 33 ‘09 |~over [09 |" oer [9s] ooze | 25 | over i og. | ss |" oes _["e9|~oozs | 09} 00s | 95] o08s 0c: amen an) ee ‘05-|~ ooze |-99|~o0a2_|-e8|~o0sz_| 65 | 0022 Te 0 St-{ 00101 | a9 | oo00r | s9|~o0es |-¢8 | o000r i | Fer OF | oozer | tz |oorer | a9 | oooer | 99] corer an} oozer m2 Se[-oopze Ive] oveci | 12] ooezt | 63 | oor 2s | “corat se ag [Toosee[s7|oosez | 2 | oovez | 2z | core Zs | o0sz2 oowtz | wz | 06 Fd ozs [ZZ] 00818 | Sz | o00ce | e5| “ooze opie tr] 2 oz | _ = ‘0000F 89 | -086r ooser [1S] 02 St 7 — 62] 00068. 00606 | 09 | St | a 7 — “sz |oozr6 {22 [o0000r] 89 | 000at1] so] et oF ooos6| +2 | ooozor iz | 0000s 39 [or 7 [suas |e [wasn] ¥ larauaas| x [wausas| sniovs) 1 ‘avo Rete [ery ‘avd #59 [er ‘avo hell] z ovon | Lez asi 3s01 fsaas] i farauaas 1 av01] RS e1-avo} L [1359 favauaais 81 'a¥07] Ress | a7 ‘avo7] Fete | stave 9S # 3d09 (117) SOIAaG LNAWOW Q¥OT AHOISMHSLNNOD WLOL ANNOd 0046 UVAUAOIS YANO - SUBODIULNO GSLOWULAH NO WOOK 14921 - $0 SCNNOd NISSINOVdy NII GaLveRATED LIFTING CAPACITIES IN POUNDS 40.5 - 75FT BOOM ON TIRES STATIC - OVER REAR 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODE # 02 POWERED BOOM LENGTH IN FEET Tons |__40.5FT “45FT ‘SoFT 65eT TSE] ton raous| S05" [LOAD, LB| see |LOAD, LB| "see |LOAD, LB] seo LOAD, LB| ton" |LOAD, LB| rao e_ |x [pean _| xc [ean xc [ean REAR REAR |r. 0_| 68 _| 38600 | 70 | s8600 [74 | 38100 i 10 32 [65 [35300 [68 | 35000 [72 | 34500 [75 | 34000 12 15 | 60 | 30000 [63 | 29800 [69 | 29400 [72 | 29000 [75 | 28500 | 15 20 [51 123700 [56 | 23600 [63 | 23400 [67 | 23100 [71 | 22800 | 20 25 [41117700 | 47 | 18000 [57 118800 [63 | 16500 | 67 | 16700 | 25 30_| 28 | 12500 [38 | 12800 [50 | 13300 [57 | 13500 [62 | 13600 [30 35 25 | 9300 | 43 | 9700 [52 | 10000 [58 | 10200 {35 40 Lt 34_| 7100 | 46 | 7400 [53 | 7600 | 40_| 45 T 22 | 8100 |39 | 5400 | 48 | 5700 | 45 “$0 { I 3113900 | 42 | 4100 {| 50 (Sen |i I 20 | 2600 [36 | 2800 | 55 ZERO DEGREE BOOM ANGLE LOADS (LB) /( RADII (FT.)) 0 | $100 | 0 | 6700 | 0 | 3200 0 a (34.0 | (38.5) (48.5) | (58.5) | [MINIMUM BOOM ANGLE (DEGREES) FOR INDICATED BOOMLENGTH (NOLOAD) 1-2 | [MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD) 65) TIRE INFLATION CHAI TIRE SIZE _[ ROADING [STATIC [_ 14.00R20 90. 105, (Bis/eor22.5 115 115) (425/65R22.5 120 120 ses2uias4 ARATED LIFTING CAPACITIES IN POUNDS 40.5 - 75FT BOOM ON TIRES CREEP - OVER REAR 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODE # 01 SEE DEDUCTIONS POWERED BOOM LENGTH IN FEET Toad |__40.0FT “45FT ‘S5FT 65FT TET] toa jraowus| ‘scew [LOAD, LB] soo" |LOAD, LB} ecw LOAD, La] ‘seo | LOAD, LB] Rais se ane px [ean | 2c nean_| x 70 [68 _{ 32600 [70 | 32300 [74 [31600 T 12_|65 | 29500 |68 | 29200 | 72 [28700 [75 | 28200 15_| 60 | 25500 _| 63 | 25400 | 69 | 25000 [72 | 24600 | 75 | 24200 | 15 20 [81 | 20400 [56 | 20300 | 63 | 20100 [67 | 19900 [71 | 19600 | 20 25 [41 116300 [47 116300 [57 | 16200 [62 116100 [67 115900 _] 25 REAR |e ZERO DEGREE BOOM ANGLE LOADS (LB) /( RADII (FT.)) 0 | 9100 | 0 | 6700 | 0 | 3200 | 0 |— (34.0) 1 (38.5) 1 (48.5) (58.5) i MINIMUM BOOM ANGLE (DEGREES) FOR INDICATED BOOM LENGTH (NOLOAD) 1-2] MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD 1651 TIRE INFLATION CHART [TIRE SIZE _[ ROADING [| CREEP 44.00R20 | _90 105) ['315/80R22.5 115 115 [425/65R22.5 120 120 sea2ut230_ARATED LIFTING CAPACITIES IN POUNDS 40.5 - 75FT BOOM ON TIRES 2.5 MPH - OVER REAR 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODE #00 SEE DEDUCTIONS POWERED BOOM LENGTH IN FEET. racus [SE |LOno, | EAP L.oA0, tal BSE |LoA0, 5] SR |Load, cal S| Load, sf raous ton | _40.5FT 45FT ‘SFT 65FT TFT toa | a_| "ac [neem |" ean“ nen" ream |S" mean | 0_{ 68 _| 27400 | 70 27100 _| 74 | 26600. | { 10 12 24600 [68 | 24400 [72 | 24000 | 75 | 23600 12 15 coterie 63 [21000 | 69 | 20700 | 72 | 20400 [75 | 20100 | 15 20 [51 | 16600 [56 | 16500 [63 | 16400 [67 | 16200 | 71 | 16100 | 20 | 25_[41 113100 [47 113100 [57 113100 [62 113000 [67 112900 | 25 ZERO DEGREE BOOM ANGLE LOADS (LB) /( RADII (FT.)) 0 | 8500 | 0 | 6600 | o | 3200 | 0 |—_ (34.0) 38.5) | (48.5) i (68.5) MINIMUM BOOM ANGLE (DEGREES) FOR INDICATED BOOM LENGTH (NO LOAD) MAXIMUM BOOM LENGTH (FEET) AT -2 DEGAEE BOOM ANGLE (NO LOAD) TIRE INFLATION CHART - PSI TIRE SIZE _[ ROADING [2.5 MPH 14,00R20 90, { 105, 315/80R22.5 is [ti 425/65R22.5 a a sesautes2_A Sr) n|RATED LIFTING CAPACITIES IN POUNDS 126FT BOOM FULLY EXTENDED 126FT BOOM + S8FT EXTENSION = 164FT TOTAL FULLY EXTENDED OUTRIGGERS - OVER REAR 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES # 11, 12, 13 on SS SS 5° Or se ee OGG Seay = i On gce 30° OFFSET L CODE Ai CODE #12 CODE #13 2 DEG EXT OFFSET WITH 17 DEG EXT OFFSET WITH p06 Ext OFFSET WITH STINGER RETRACTED [ne .o40 STINGER RETRACTED ng. .oo STINGER RETRACTED [ne oss FOR BOOM LENGTHS, FonacowiencTs | FORBOOMLENGTHS |” > 128.0 FT- 164 FT > 128.0164 FT | conse > 128.0 FT-184 FT _| rome TSADED] TORBED sou ToADED 0% LOAD, LB scov| LOAD,LB | ‘on scow | LOAD, LB | Sr ANGLE | aS OVER REAR X0_[ OVER REAR x ‘OVER REAR T1200 [40 i {10500 [45 i _ 900 [50 77 { 7 $300 55 75 | 77 {6800 55 a00___| 60 "73 | 75_| 6500 | 60 e300__| 65 72_1 74 | 6400 | 65 7800__| 70 70! 7 | 6200 | 70 | 7400__| 75 68 [ 70s iat 60008275 7000 | 80 66 | [68_| 5800 | 80 6600) 85, 64 | 66] 5700 85 —_8000___[ 30 2 63, 5500 | 90 74300400 _| S7_| 59_| 5200 _| 100 2900__| 110 52_| 34_| 3700 | 110 | P46 _T 4g 12400 | 120 REFERENCE LOAD RADIUS IS FOR 164 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 164 FT., USE BOOM ANGLES ONLY [MINIMUM BOOM ANGLE (DEG) FOR INDICATED BOOM LENGTH (NO LOAD)|_-2_| [MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD)| 75 LIFTING CAPACITIES OVER REAR AT 0 DEG. BOOM ANGLE | AREA OF —— MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS 1 OPERATION _ANGLI 40.5 45.0 55.0 | 65.0 76.0 [OVER REAR or {5000 5000 4100 | 2400 0RATED LIFTING CAPACITIES IN POUNDS 126FT BOOM FULLY EXTENDED 126FT BOOM + 38FT EXTENSION = 164FT TOTAL FULLY EXTENDED OUTRIGGERS - OVER SIDE 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMi) CODES #11, 12, 13 SSF 2° orrset | Prag 4 30° OFFSET CODE Fit CODE #12 CODE #13 EG EXT OFFSET WITH 17 DEG ExT OFFSET WITH 0 DEG Ext OFFSET with STINGER RETRACTED [ney oa [STINGER RETRACTED [nr so STINGER RETRACTED [4g ao ronscomieeris | Fonasouenaras |ronscomcenoms | 2128.0 FT~164 FT | rons > 128.0 FT- 164 FT_| rons > 128,0 FT 164 FT_| ross TaABES feu THROES sou [ee Scow | LOAD, LB | SY cow | LOAD,LB | a ecow | Loan, te | Ser ange wate | ANGLE e_| x" | oveRsE: x | OVERSEE a0 45 I 50 50 _ 58 55 55 60 60 60 65 65 65 70 70 7 75 im 75 80_ 60 80 a5 85 85 [30 30 30 400 100 59 | 100 _| 110 som 110 REFERENCE LOAD RADIUS IS FOR 164 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 164 FT., USE BOOM ANGLES ONLY MINIMUM BOOM ANGLE (DEG) FOR INDICATED BOOM LENGTH (NO LOAD)| -2 iMAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE SOOM ANGLE (NO LOAD)| 75 LIFTING CAPACITIES OVER SIDE AT 0 DEG. BOOM ANGLE AREAOF — [BOOM| MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS : OPERATION INGLE 40.5 45.0 55.0 | 65.0 750mm OVERSIDE | a° [5000 5000 | 4100 | 2400 OoRATED LIFTING CAPACITIES IN POUNDS 126FT BOOM FULLY EXTENDED 126FT BOOM + 60FT EXTENSION = 186FT TOTAL FULLY EXTENDED OUTAIGGERS - OVER REAR 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES # 14, 15, 16, CODE #4 CODE Fis CODE #16 EG Ext OFFSET WITH 17 O56 EXT OFFSET WITH 0 DEG Ext OFFSET WITH STINGER EXTENDED "Joey. ono STINGER EXTENDED "fog oo STINGER EXTENDED |nee 190 FoR soowuenarHs | ForsoowuensTas | FORBOOMLENGTHS |” > 150.0 FT- 186 FT_| rons > 150.0 FT - 186 FT > 150.0 FT-188 FT _| 05108 [Toxss; —————] Seow or THROES Ses ‘eau | Load, Le | Ser ‘eet | LOAD, LB soon | Loap,te | Ser TS Poanneac] x overnea_| Conn 7717100 | 45 1 a 76 6800__| 50 _ ! = 7 salen G600BEs|B55 eae 7 73 6300 |60_| 77 | 72_| 6100 76_| | 70; 5700 741 {3700 [70 68_| 5800 72 3600 | 75 _| 7 5300__| 80 7 mem as00mat/ S08) 65 5200 eo 72; 3300 | 85 64) 5100 7 3200 90 60 4700 64 | 3100 700 | 56 4200 60_| : 3000 [110 52 3100 56 2700 [120 47 52 3000 | 130 2000 | 140 REFERENCE LOAD RADIUS IS FOR 186 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 186 FT., USE BOOM ANGLES ONLY [MINIMUM BOOM ANGLE (DEG) FOR INDICATED BOOM LENGTH (NO LOAD)[_-2_| [MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD)| 65, LIFTING CAPACITIES OVER REAR AT 0 DEG. BOOM ANGLE. \_ AREA OF BOOM] MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS OPERATION ANGLE 40.5 | 45.0 (55.0sme[eemi65'0) OVERREAR | 0° | 3000 | 3000 [2700 | HeRATED LIFTING CAPACITIES IN POUNDS 126FT BOOM FULLY EXTENDED 126FT BOOM + 60FT EXTENSION = 186FT TOTAL FULLY EXTENDED OUTRIGGERS - OVER SIDE 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES # 14, 15, 16, CODE #14 CODE #15 CODE #16 TGS Ei Genser wr 77 Bea Ext OFFSET wr DoG85 Ext OFFSET with Sincenorenoeo Ee ae STNGeR STEROLS” Yoel FOR BOOM LENGTHS FOR BOOM LENGTHS 7 FOR BOOM LENGTHS: ae Sealer tes F Sis0.0FT= 186°C | rome PISOOFT-188FT | ron coe fees oe, Ry oe | 1080.18 voap.is | St eee] voap.us | Se “| _OVER SIDE rs ‘OVER SIDE x OVER SIDE 7100 | 45 800__| 50 1 6600 6300 a Se) 6100 “76490065 5700 74_| 4600 [70 g 5500 72 [75 67 7i €0. 5 85 &4 30, 601 400 | 56 110 51 120 53-2700 | 120 130 5472100 [130 REFERENCE LOAD RADIUS IS FOR 186 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 186 FT., USE BOOM ANGLES ONLY [MINIMUM 800M ANGLE (DEG) FOR INDICATED BOOM LENGTH (NOLOAD)] -2_] [MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD)| 65 LIFTING CAPACITIES OVER SIDE AT 0 DEG. BOOM ANGLE AREA OF BOOM MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS OPERATION ANGLE 40.5 [45.0 55.0 65.0 j (OVER SIDE o [3000 | 3000 [2700 0 =a)RATED LIFTING CAPACITIES IN POUNDS 126FT BOOM EXTENDED TO SOFT MAXIMUM 90FT BOOM++ 38FT EXTENSION = 128FT TOTAL = FULLY EXTENDED OUTRIGGERS - OVER REAR 9700-POUND TOTAL’ COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES #11, 12, 13 SSS 2° OFFSET = fe ee ee z OFFS eee eee CODE HiT CODE Hie CODE #13 EG EXT OFFSET WITH 17 OEG EXT OFFSET WTA 30.066 Ext OFFSET WITH STINGER RETRACTED [rer 1010 FR RETRACTED [rer 040 ‘STINGER AETAACTED —|aes con FonsoowuensTas | Foraoomvenaas | Fonsoouceneme | 7e.SFT-128FT | rome 78.5 FT-128FT | rons 78.5 FT-128FT | roam fomesy St SE Ed ToRGES a ‘res | LOAD, LB | Br er | tono..s | Se soo | LoaD,ia | Sey OVER REAR x _| Oven REAR — ‘OVER REAR 76000 __| 25 ! t _ 76000 | 30_| i 13600__| 35 77) 9600 [35 emer | il 42400 | 40_| 75 | 8900 40_| [ 0 69, 11500 45 73 | 8400 | 45 76 | 66 to700__{ 50 {70 7300 50_| 73 64 10000__| 55 68 7500__| 55 al il 9300 60_| 65 7100 60, 68 3a 8600__| 5 65 5 568100 70_| _| 70 63 53 7600 75 75 60 | EG 7100 | 80 80 [s7_I 47, e700 | 85 35_| 33 |_ 85 44 6500__| 90 30 50 30 [37,4800 | 700 100 42 100 27 3400 410 410 31 140 REFERENCE LOAD RADIUS IS FOR 128 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 128 FT., USE BOOM ANGLES ONLY [MINIMUM BOOM ANGLE (DEG) FOR INDICATED BOOM LENGTH (NO LOAD)|_-2 [MAXIMUM BOOM LENGTH (FEET) ‘AT -2 DEGREE BOOM ANGLE (NO LOAD)|_75 LIFTING CAPACITIES OVER REAR AT 0 DEG. BOOM ANGLE AREA OF IBCOM| MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS. OPERATION INGLE, 40.5 I 45.0 55.0 65.0 | 75.0 __OVERREAR | 0° [5000 | 5000 4700 2400 (aRATED LIFTING CAPACITIES IN POUNDS 126FT BOOM EXTENDED TO S0FT MAXIMUM. 90FT BOOM + 38FT EXTENSION = 128FT TOTAL FULLY EXTENDED OUTRIGGERS - OVER SIDE 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES # 11, 12, 19 =F 2° OFFSET S| a ra x! : ‘ 30° OFFSET CODE Hi (“cone Fiz (“copes 7] [Rocce orrserwim]__ 77 O56 Ber OFFSET WITH 30 OES EXT OFFSET WITH STINGER RETRACTED Jagr cso STINGEA RETRACTED [ree Ao STINGER RETRACTED” [er coo FOR BOOM LENGTHS 7 FOR BOOM LENGTHS 7 FOR 800M LENGTHS: oa 78.5 FT - 128 FT FoR 28 78.5 FT - 128 FT Fone 78.5 FT - 128 FT FOR 128 [ames] scow TSHOES ou i ‘cow Loan, LB | Sy ‘eon | Loan,ia | Sy oe OVER SOE x0 [evens xc [even Se 76000 | 25 _| a = __15000__| 30 Ei 13500 35 oe 9600 | 12400 40 75 8900. oases 7100 40 474500 45 73 8400 76 | 6800 45 | 10700 50 70 7900 50. 73 | 6500 50 10000 55 | 68 | 7500 55 | 71 6200 55. ____ 9300 60 65_| 7100 60_| Ee) 60 8600 65, 63 6700__| 65 65_| 5800 65_| 8100 79 60 6400 70 | 63 | 5600 70_| ~__ 7600 75. 57 6200 75 60_| 5400 75 7100 80 54 5900 30_| 57 | 5300 80_| 6400 85 51_| 5700 | 85 53 5100 85. 5400__| $0. 48_|__5500__| 90 5015000] 30 aaeeeeeeeaee 100 40 | 4200 __ 400 42 | 4400 100 2500 140 30 | 2700 4410 31 | 2800 110 REFERENCE LOAD RADIUS IS FOR 126 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 128 FT., USE BOOM ANGLES ONLY {MINIMUM BOOM ANGLE (DEG) FOR INDICATED BOOM LENGTH (NO LOAD)! -2 ] IMAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD) 75 3 LIFTING CAPACITIES OVER SIDE AT 0 DEG. BOOM ANGLE. AREAOF — |BOOM| MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS | operation _hnatd 40.5 45.0 55.0 65.0 75.0 [OVER SIDE o [5000 5000 4100 2400 0 mamvinws9700 POUND TOTAL’ COUNTERWEIGHT RATED LIFTING CAPACITIES IN POUNDS 126FT BOOM EXTENDED TO SOFT MAXIMUM 90FT BOOM + 6OFT EXTENSION = 150FT TOTAL FULLY EXTENDED OUTRIGGERS - OVER REAR LOAD MOMENT DEVICE (LMI) CODES # 14, 15, 16 — oo 2° OFFSET ; A ar SY 7° OFFSET Bel arma SP 9° OFFSET CODERS CODE His CODE FE TOE Der OFFSET WITH 7 DEG EXT OFFSET WITH G0 056 ExT OFFSET WITH FINGER EXTENDED [nr ono STINGER EXTENDED foe cso SINGER EXTENDED Ines. cove REFERENCE LOAD RADIUS IS FOR 150 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 150 FT., USE BOOM ANGLES ONLY Foaecomuenamas | FOR BOOMLENGTHS FoRsoomuencTas | 100.5 FT-150FT_| toque 00.5 FT-150FT_| rons 100.5 FT-150FT_| rons foc, | eae [eases] | to [Sse; "| 850 oom’! LOAD,LB | Sx seo’ | LOAO.LB | ‘om | LOAD,LB | Sr 2) OVER REAR x°_| oven REAR x_[oveR Rear 78. 8000 | 30 [1 | a | [ 74___7000__| 40 — | 72 6700 45 78 | 5400 45 = 70 6400 | 50 76_| 5100 50, t 68 «6100 5, “74_| 4900 | 55 78 3900 | 55 66 5800 | 60 a 763700 | 60 64 5400__| 65 70 a 74_| 3600 | 65_| 62 5300__| 70 67 4200 | 70 72 3500__| 70 [60 s100_—*{ 75 “65 | _ 4000 75_ 69_| 3400 75 38 5000 | 80_| 63 3800___| 80 67_| 3300 | 60 | 55 4800__| 85 éi 3700 | 85_| 64 3200 | 85 4700 | 90_| s8_{| 3500 | 90 foams lamer sOoOEsin|oOm| 4400__ | 100 | 53 3300 [700 | 56 2300 | 400 4000 [710 a7 3000 [110 | 50 2800__| 110 ga 000020512088) | 40 2900 | 120 43 [2700 | 120 2700 [130 32 2700__| 130 33_[ 2600 [730 MINIMUM BOOM ANGLE (DEG) FOR INDICATED BOOM LENGTH (NO LOAD)]_-2 MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD)|_65: LIFTING CAPACITIES OVER REAR AT 0 DEG. BOOM ANGLE | AREA OF BOOM MAIN BOOM LENGTH IN FEET, LOAD IN ROUNDS. OPERATION ANGLE 40.5] 45.0 55.0 65.0 (OVER REAR__| 0° 3000 | 3000 2700 | 0 [ saaRATED LIFTING CAPACITIES IN POUNDS 126FT BOOM EXTENDED TO SOFT MAXIMUM 90FT BOOM + 60FT EXTENSION 1S0FT TOTAL FULLY EXTENDED OUTRIGGERS - OVER SIDE 9700: POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES # 14, 15, 16 io SSP 9 2° OFF 3 . SS eee °30° OFFSET al “orm CODERS OES EXT OFFSET WITH 17 O8G EXT OFFSET WiTH 300E6 EXT OFFSET WITH STINGER EXTENDED © |g. ton STINGER EXTENGED "fre 110 STINGER EXTENDED fr oo ForaoomuenaTas | FoRsoom eats | FonsoomtencTas | 400.5 FT-150 FT _| rosso 400.5 FT - 150 FT 400.5 FT-150FT_| rons oso] ——————] Seow [a7 -——— [co] ——— ‘oa | LOAD,LB | SY ‘feo | LOAD, LB sea | Loa,La | Sy x" [7 over sive x" | OvERSIDE x | ovensioe | 78 8000 30_| | 76 7500 | 35 I _ [ _ 74 7000 | 40 | 1 7 (72m 7002 45 78 | —_t 70; 6400 | 50_| 7 I 68 6100__| 55 781 58 66_; 5800 | 60 4600, ml 60 645400 —'| +65 4400) 74_| 65 62 5300 | 70 4200 721 70 60 5100 | 75 4000) 6 | 75 5000 | 80 [3800 67 80 4800 | 85 61 | 3700 64 85 4700 30 58 | 3500 62 | _{ 30 4400 | 100 53_| 3300 {100 56_| 7100 3800) 410 47 | 3000 110 50_| [410 2800 [120 40 2900 120 431 420 32_1 2200 [130 33 130) REFERENCE LOAD RADIUS IS FOR 150 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 150 FT., USE BOOM ANGLES ONLY MINIMUM BOOM ANGLE (OG) FOR INDICATED BOOM LENGTH (NO LOAD)|_-2 [MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD)! 65. LIFTING CAPACITIES OVER SIDE AT 0 DEG. OOM ANGLE AREA OF [BOOM MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS: OPERATION ANGLE 40.5 45.0 55.0 65.0 | ‘OVER SIDE o | 3000 3000 2700 0 i _|RATED LIFTING CAPACITIES IN POUNDS 4126FT BOOM EXTENDED TO 90FT MAXIMUM 90FT BOOM + 38FT EXTENSION = 128FT TOTAL MID POSITION OUTRIGGERS - OVER SIDE/REAR 9?uv POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES # 37, 38, 39 oe SSP 2° OFFSET 4 = peer oe 3e7% A Hl 30° OFFSET or CODE #37, CODE #36 CODE #39. 2 OEG EXT OFFSET WITH 7 DEG EXT OFFSET WITH [20 DEG Ext OFFSET WITH STINGER RETRACTED |e .ov0 STINGER AETRACTEO [ass .c1o| STINGER AETRACTEO _|res wos Forecomcencras | Fonscomuenctas | Fongoomtenctas | * 78.5 FT - 128 FT 78.5 FT-128FT__| eons 78.5 FT-128FT._ | ron rons ToaDeD so ToADED wee sou soo | LOAD, LB | Bea | LOAD, LB toao, Le | oY see ANGLE x2 _[OveRSIDEREAA| 20 _[OVERSIOEREAA Sven SDEREAAL 78 T6000 { 76 15000 I I =7_) 13500 | ee ES | : 12400 75 9900 | 40 i__7i00 [40] 69 11500 73! 8400 45 {6800 45 66 3200__| [70 7900__| 50 6500__{ 50 64 7300, 68 7500__| 55 1 | _6200__ {55 a 5700 [65 6900 | 60_| ilemeic000men 260 58 4400 62_| 5400__| 65 a 5 3300_ [se 4200 [70 a 52 2300 56 | 3200 75_| 13800 75 53 2300__| 80 [2800 | 80 [3300 85. REFERENCE LOAD RADIUS IS FOR 128 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 128 FT., USE BOOM ANGLES ONLY MINIMUM BOOM ANGLE (OEG) FOR INDICATED BOOM LENGTH (NO LOAD)| -2 MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD)| _45 LIFTING CAPACITIES OVER SIDE/REAR AT.0 DEG. BOOM ANGLE. | AREA OF [BOOM MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS. | | OPERATION woud 40.5 | 45.0 | | {OVER SIDE/REAR] 0° | 4800 jena 700 [ | sem 8RATED LIFTING CAPACITIES IN POUNDS 126FT BOOM EXTENDED TO SOFT MAXIMUM 90FT BOOM + 60FT EXTENSION = 150FT TOTAL MID POSITION OUTRIGGERS - OVER SIDE/REAR 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI). CODES # 40, 41, 42 sew ° OFF SE ert exeser 17° OFFSET a CODE #40 CODE #47 CODE #42 72050 EXT OFFSET WITH 17 DEG Ext OFFSET WITH 0 DEG ext OFFSET WITH STINGER EXTENDED" Jue. .Ae STINGER EXTENDED —|og oo STINGER EXTENDED" |ngy coo FORBOOM LENGTHS | FoRsoomuenaTHs | ig 3005FT-1S0FT_| rons 1005 FT-150FT_| rons rons [exes ou fase; ieee cow | LOAD,LB | Sey scow’ | LOAD,LB | cur ey ANGLE aol = 2 OVER SIDEREAA| 2° _[OVER SIDEREAR * [Oven SIDEREAR| 76___8000__| 30 1 a 76 7500 35, I _| [74 7000 | 40 T _ : 72 e700 | 45_| 76_| 5400 70 6400__| 50 76_[ 5100 - 68 6100_—*| 55 4800__ 3900 | 55_| | 66 5800 | 60 [4600 3700 | 60 5400__| 65 3600 ‘4700 | 70 3500 3800__| 75 4000) 3400 5 3000 | 80 [3800 3300__| 80_| 2200 | 85 T3300 3200 | 85 3000__{ 90 7300 | 100 REFERENCE LOAD RADIUS IS FOR 150 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 150 FT., USE BOOM ANGLES ONLY MINIMUM BOOM ANGLE (DEG) FOR INDIGATED BOOM LENGTH (NO LOAD)|_-2_] [MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD)|_45_] LIFTING CAPACITIES OVER SIDE/REAR AT 0 DEG. BOOM ANGLE ‘AREAOF [BOOM MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS OPERATION ANGLE 40.5 | 45.0 VER SIDE/REAR] 0” | 3000 | 2500 |RATED LIFTING CAPACITIES IN POUNDS 126FT BOOM FULLY EXTENDED 126FT BOOM + 38FT EXTENSION = 164FT TOTAL MID POSITION OUTRIGGERS - OVER SIDE/REAR 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES # 37, 38, 39 CODE #37 CODE #38 “CODE Fao] 72OEG EXT OFFSET WITH 17 DEG EXT OFFSET WITH 3006 ext OFFSET WITH STINGER RETRACTED lag ca STINGER RETRACTED [ago STINGER RETRACTED "ne FOREOOMLENGTHS | FOR BOOM LENGTHS | FORBOOMLENGTHS | 3128.0 FT 164 FT | rons > 128.0 FT 164 FT | rons > 128.0 FT 164 FT_| rome toap, LB | Se ‘Ber Loap,is | Se “a | voap,is | Se OVER SIDEREAA x2 _lovensoeneanl xo _ [oven sipenea| 11200 40 i 70500 | 45 —t 8600 50 [8700 50, yo 6700 55 | 8200 55, 77 | 6800 55 5100 60 T 6400 60 75_ 1 6500 60 3800 65 5000 65 73_| 5900 65 85 2700 70 3800 7 7 4600 70 66 2700 ZS. 69 | 3500 75 65 2500. 80, REFERENCE LOAD RADIUS IS FOR 164 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 164 FT., USE BOOM ANGLES ONLY MINIMUM BOOM ANGLE (DEG) FOR INDICATED BOOM LENGTH (NO LOAD)|_-2 MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE 8OOM ANGLE (NOLOAD)| 45) LIFTING CAPACITIES OVER SIDE/REAR AT 0 DEG. BOOM ANGLE ‘AREA OF OM MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS | OPERATION ANGLE 40.5 45.0 T 1 OVER SIDE/REAR 0° 4800 [3700 | [ |RATED LIFTING CAPACITIES IN POUNDS 126FT BOOM FULLY EXTENDED 126FT BOOM + 60FT EXTENSION = 186FT TOTAL MID POSITION OUTRIGGERS - OVER SIDE/REAR 9700 POUND TOTAL COUNTERWEIGHT LOAD MOMENT DEVICE (LMI) CODES # 40, 41, 42 Y ‘30° OFFSET CODE #40 (CODE #47 CODE #42 12086 ExT OFFSET WITH 17 DEG EXT OFFSET WiTH [a0 DEG ExT OFFSET WITH STINGER EXTENDED — |rer cos STINGER EXTENDED — [ner Los STINGER EXTENDED — [ner Los ForeoomuencTas | Forsoou tenets | FoRaooMLeNcTHs | > 165.0 FT 186 FT_| Fons > 185.0 FT - 186 FT_| rome > 165.0 FT - 186 FT_| rons Foam] soot [Consens —————] focue ToaDes sou ‘Sco’ | LOAD,LB | Xr Beow'| LOAD.L8 | Ser Seow’ | LoaD,LB | Sy ANGLE ANGLE a 20° [over x + lover sibeREAR x 7i00 | 45 _ 6600 | 50. 6600 | 55 6300 | 60 5300___| 65 _ 4200 77 ~3200 76 2400 74 REFERENCE LOAD RADIUS IS FOR 186 FT. BOOM ONLY FOR BOOM LENGTHS LESS THAN 186 FT., USE BOOM ANGLES ONLY [MINIMUM BOOM ANGLE (DEG) FOR INDICATED BOOM LENGTH (NO _LOAD)|_-2 [MAXIMUM BOOM LENGTH (FEET) AT -2 DEGREE BOOM ANGLE (NO LOAD)|_ 45 | LIFTING CAPACITIES OVER SIDE/REAR AT 0 DEG. BOOM ANGLE. ] ‘AREAOF [BOOM MAIN BOOM LENGTH IN FEET, LOAD IN POUNDS | L_ OPERATION ANGLE 40.5 [45.0 I | (OVER SIDE/REAR] 0° 3000 | 2500 I |[Soon env nooe SauOTo Wy Casa HLNaT OOS RADE z (G¥O1 ON) HLONST WOO a3 LVSIGNI Hos (S435 30) STONY WOOG WNWINIA) ] Te Cor] | eas war war Tre 0 core | of ooss | 0} cosa | o | oozsi | 0 | oogct | o (Ca) avy )/(@) savo7 3TONY Wood 3auD30 OUIZ 06 [0092 | €y] oose | 96 TL =o T _| [06 ss |~oose || ~oove | oF | SSS aaa se ‘os 009% -|- 05] oosy |b [ 7 08 S| o06s_[ es {008s |p : — [sz |“oz |“ oobz 99 | ~o0ez [is z else - mo s9 | ooze | 6s} o0r6 | ss [ _| Z ‘S59 ‘09 ooror]-29 | oot | as a eee [ee oe 09 ss | oogtt | po [corer | 19 i = _|oss ‘0s | oosei | 29} oogpt | +9 te | a “| 0s _sb_|oorer [69] coast | zo 6 | -0086E st_| ‘oF |"oosst | 22 |oozct [69 ‘oy | o0re ~ [oor se ooszr | 62] coast |e -as | oorze SC 9¢ | oog6! | 94 | oozed | re. as |_oosty osor | Be] OE SZ —_|-_[oo0se {zz | ooaee | sz | ogee “oozor | e9 | o0z6r oosis | 1h] Sz | Oz — 00296 ores | a9 | oozes oss | 1S 02 | Es vozb9 | ec | 00982 |-oorae [09 | st er a ‘ooasa | sz} o06re ‘ooriit| so} zt OF | 002se oossrt| 9} oF [aoa wae wa wae [was] was] oe | soval avo3]5[ an “oven 8 [a7 ‘avo 2 [an v0] a a v0) 32% | ovo) 3 oven | Jo ovo1| 283 a ‘OvOT] omar [oor [ase git 13501 1586 1asz | i389 135s Lagy | aor | over 1334 NIHLONST WOOS G3H4MOd <= tb # 300 (IW) 39IA30 LNAWOW GvO1 G3SN LON 1N@ GaALOaHa NOISNALXS “Ld 8 SANNOd NIS3IUOVdY = DNILAIT GaLy! rr) IHOISMYSLNNOD WLOL GNNOd 0026 HVSH H3AO - SHBDOINLNO GIGNILX] ATIN NO WOOK 14921 - SOF8 ~(avOTON) SONY NOE 33U30 & Lv (135. HLSNSTWOOA AWK (GVO7 ON) HLONS1 WOO# GSLVOIGNI HOS (S3SHOIG) STONY WOOE WANININ| wor i) SOs) oc) aor Toe ° oore | o| ooss | o | oozst | 0 | oo96s | 0 (Ca) awe (en) savor STONY Wood 334530 OURZ 3a] 0% ame “T" - “Tr yy (og|oee Ze | coae [5 7] on - 8 S2_| 00s 1 | oop [ee | “0007 | Or —|-82] oz} “008s 008s — oe ‘89-0092 — EJ 09 | 0096. ee ee ee _|_08 ss [oosrr ‘ooett re] | ss ‘05 | o0szi Fooerr | 16] 05 ‘St | oobbL “Oost ‘oooar | 22 sr | oF | oozsi oveez |-or | over | ve oF s6_| 00st ‘oosve | 25} ocie [er | oozoe | sz se-| |0c_[oos6r [92 |oozze | pe ‘oz | o0see | 29 | ooze |"e9| oorze| as | oosir | os] coger | ae] oso] 62] _0€ [sz ‘ooo | ue €Z|oo8se | oz | oostr | Z9| oozar oozer | 25 | o0e1s ar | oosis | tv | se. 02 — Z| o0eeb | +z | oosab | 12} ootas ‘026s | €9 | ~oovse [9s | oossa [1s | oc st} a ~_[[ooeis'| sz |“oozre ooaez |69.|o0sza | v9 | coves {09 | si af 7 | “00869. oosre "2x "00st | 9 | ooritt| 59} cb | OL 2 ooze | 62} cose [12 | oossbt| 9 | or [308 _ x | aa | & [aa 338 335] wos | aoe = sae ovo] fa ‘ov0 $8 [aa [a ovo) Se ar avon] Mata ‘ov0n] Se a oven sm avon | 13921 Jas 13501 ise | 1358 Lise 1359 ovo TS33 N HLONST WOO GSTIMOd vor ——~ — Lp # 3009 (Iw) 39130 LNaWOW avo AHOFAMH3LNNOO TWLOL aNNOd 0026 GSN LON Ing GLOSS NOISNALXS “1 86 BOIS WIAD - SUIODILNG GIGNSLXS ATINS NO WOO LAE - SOF SGNNOd NI SALLIOVdY ONLI GaLWy—(GVOTONT STONY WOE S3HOIG Z* Ly (1993) HLSNTTWOOe AACA G07 ON HISNS1 WOW GSLVOIONI HO (S33030) STONY NOs WNWINI) al Ta) ast war woe Tr | o ° ooes | 0} ooze | 0 | ov6ri | 0 | oes: | 0 | (C13) lave (6) savo1 318Nv woos 33uDI0 OUaZ ee | OF [anes ae RE Pat Fp Tee O0sr | br{ Oop | Ze} oosh | ze} —_ | [op oe ee eee 08 | oss "er | oozs | zr} 008s | ce} ooes ar) 2 _ - ‘sc | oore | 1s“ o0zz | ar | occ} 66 “008s | ee ia loz oozé [ss |~ 0006 | os |~oo16 | pr | ~ooge | se | c = — Doerr | as} coer }-es| coats | ab | cower |r [08 [-oosat "is oogsr zs | ooeet |-2s — 3 Loorrt cost | 3s Pros o0ss1_ corer | 09 | |i ean GP OOrLt | ‘oosz2 | €9 |_OF ‘O0S6L ‘oorse | Zo ‘ooete | Se se ooate ‘oozee | 02 oovor | ee | O0eee | we] oe -ooave. ovize | ez 060s | er | oolis | ir} se joss | 92 00660 | 9s | o00se [Is | 02 - ~oo6s6 |"¥9 | 00828 {09 |st E i ‘voces | 89 | dogoir| so] et ‘oosse | 12] o0aprtt a9 | or wa] wa wav | Pas Pa ar'0vo avo] 28 | ovo 1 '0v01) fest (a1 av07| £25 [a1 avon 22% |smowy sit 156 ase ass ner a50h | oven Ly # 3009 (IW) 301A30 ANSWOW avor AHOI3MUBINNOO W104 aNNod ooze SN JON In d3L03H3 NOISN31XG “Ls 09 VAY Y3AO - SH3DDIYLNO G3GN3LX3 ATIN NO WOOS L921 - or SGNNOd NISALUOWd' = ONLI GALWH38 z | 1g¥67 ON) HON NOOR GaLVOI (VOT ON) S18ii¥ Wood 334830 z iv 41354) 1ONa1 WOOs WANIKYA] ‘STONY OOS WAWININY i HOS (S3aU! waa ry wa war wae Tore)s)aea [eae ° ° oes | 0} ooze | o| ovsr| o | ovcst} 0 (C.LJ) lave )/ (9) Savo7 STONY WOOd 3au53G OUAZ 8 [008 | 05 | ooze | br | 000 [Ze [oor | ee{—— ee eee ee [ ees iia [no 08 Sz |~oosp | es'| ovr | ar | over | 1¥| ocr | oc | 0086” sees ee | cee [ne |e |e | eee fen ‘od 0009 [98 | 008s" 1s'|~o0zs | ar | 00s |-6¢ | ~o0es a] = 1 [0 | |-s9| ooze |-6s|~o09z | 3 | —oorz | 05 | oor | er a ee a I | |-s9 103 | ~ooas|-2o} ooze | es] ~o0s6 [es | 00s6_|_ ar = 09 ss Poor ra] coer ig} ooze | zs} ooozr [2s ¢ | oo60r STI ss 0s | -ooser [29 oorrr} ro] _ooert | 08 | ooze 9s ott | te] [|] ‘gb |-ootpr |-69{ ooss [29 |" oorzt | b9|_oorel | 09 oozzt | ee ~~ Sr ~o¥_|oopst |" 2z| oovzt 69 |o0961 | z0| ~ooaze | ¢9 ooeez [te | = oF, se-|ooedi [»2 | ooset [ez | oniee | oz} oorse | 29 goers | ey | ooe0e [se 5 o€ |-oozer | 92 | ooeie | ¥z | ooere ‘ooze |oz oos9e | 69,| “0005 ‘Doar [0s] ooror | we] BOSSE] ae] oF | se ~ooare | Z| oorsz | sz} -ooize | ez|~oozve | oz} “oosor |-z9| oosry | ea | ooszr| zs| 060s [er ooris | ty | se [oz a oosse 92 | ooriy | pz | oorze | 12] oovvs | e0| 0069s | €9) oosr9 | 9s} oo0se | 1s | oz st | _ 7] 1 _| ‘oozes ‘00698 | 69 o0sze| 09} St zh aaa = : ~~ ooces | 89] Ooeolr| So} at oO _ cosse | 12] oosbrt| 89] Ob rE eT a sa sae sae sas [| 308 |e Pa sons} “avon fe [27 ‘ovo | Ses er ‘ov07| 28 [a1 ‘ovo7] FS [a7 ‘avo | ss fa ‘ovo a ‘avo 328 J a7 V7] S| sre ovr | —i39et Lit Ligor “Lis iss List Tag OF | over Lb # 3009 (WD) BOIAG_LNAWOW GvOT GSN LON INS G3L93Y3 NOISNSLXS “4 09 AHOIAMAILNNOD WLOL GNNOd 0026 3OIS U3AO - SUSOOMINO GSGNALXA ATINS NO WOOE L49z1 - FOr SANNOd NI SALLOVd"* ONILAIT GALWH