SERVICE MANUAL BG-2S CHASSIS

MODEL COMMANDER DEST. CHASSIS NO. MODEL COMMANDER DEST. CHASSIS NO.

KV-2199M5J RM-869 ME SCC-U07K-A

KV-J21MF2J RM-869 ME SCC-U07L-A

TRINITRON ® COLOR TV
 SPECIFICATIONS

KV-2119M5J KV-J21MF2J Note

Power requirements 110-240 V AC, 50/60 Hz
Power consumption (W) Indicated on the rear of the TV
Television system B/G B/G, I, D/K, M
Color system PAL, PAL 60, SECAM, NTSC4.43, NTSC3.58 (AV IN) PAL, PAL 60, SECAM, NTSC4.43, NTSC3.58
Channel coverage
B/G VHF: E2 to E12 / UHF: E21 to E69 / CATV: S01 to S03, S1 to S41
I – UHF: B21 to B68 / CATV: S01 to S03, S1 to S41
D/K VHF: C1 to C12, R1 to R12/
– UHF: C13 to C57, R21 to R60/
CATV: Z1 to Z39, S01 to S03, S1 to S41
M VHF: A2 to A13 / UHF: A14 to A79 /
–
CATV: A-8 to A-2, A to W+ 4, W+ 6 to W+ 84
Audio output (speaker) 3W + 3W
Inputs ˘ (antenna): 75 ohms external terminal
… (video input) jacks: phono jacks
D (video): 1 Vp-p, 75 ohms
≥ (audio): 500 mVrms, high impedance
Outputs A (earphone) jack: mini jack 2 (headphones) jack
Ú (monitor output) jacks: phono jacks
D (video): 1 Vp-p, 75 ohms
≥ (audio): 500 mVrms
Picture tube 21in.
Measured
Tube size (cm) 54
diagonally
Measured
Screen size (cm) 51
diagonally
Dimensions (w/h/d, mm) 610 × 470 × 474
Mass (kg) 22
Design and specifications are subject to change without notice.

CAUTION SAFETY-RELATED COMPONENT WARNING!!

SHORT CIRCUIT THE ANODE OF THE PICTURE TUBE AND COMPONENTS IDENTIFIED BY SHADING AND MARK ! ON
THE ANODE CAP TO THE METAL CHASSIS, CRT SHIELD, OR THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE
CARBON PAINTED ON THE CRT, AFTER REMOVING THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE
ANODE. THESE COMPONENTS WITH SONY PARTS WHOSE PART
NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN
SUPPLEMENTS PUBLISHED BY SONY.

–2–
 TABLE OF CONTENTS

Section Title Page Section Title Page

1. GENERAL ....................................................................... 4 6. DIAGRAMS

6-1. Block Diagrams ...................................................... 21
2. DISASSEMBLY 6-2. Circuit Boards Location ......................................... 23
2-1. Rear Cover Removal .............................................. 8 6-3. Schematic Diagrams and Printed Wiring Boards ... 23
2-2. A Board Removal ................................................... 8 (1) Schematic Diagram of A Board .............................. 29
2-3. Service Position ...................................................... 8 (2) Schematic Diagrams of C and VM Boards ............ 33
2-4. Replacement of Parts .............................................. 8 6-4. Semiconductors ....................................................... 37
2-5. Demagnetization Coil and Picture Tube Removal . 9
7. EXPLODED VIEWS
3. SET-UP ADJUSTMENTS 7-1. Chassis .................................................................... 39
3-1. Beam Landing ......................................................... 10
3-2. Convergence ........................................................... 11 8. ELECTRICAL PARTS LIST ...................................... 40
3-3. Focus Adjustment ................................................... 13
3-4. G2 (Screen) and White Balance Adjustments ........ 13

4. SELF DIAGNOSIS FUNCTION ............................... 14

5. CIRCUIT ADJUSTMENTS
5-1. Adjustments with Commander ............................... 15
5-2. Adjustment Method ................................................ 16
5-3. A Board Adjustment after IC003 (Memory)
Replacement ............................................................ 20
5-4. Picture Distortion Adjustment ................................ 20

–3–
 SECTION 1 The operating instructions mentioned here are par tial abstracts from the
Operating Instr uctions Manual. The page numbers of the Operating
GENERAL Instruction Manual remain as in this manual.
Getting Started

Rear of TV
Connections to antenna socket

p KV-2199M5J/J14M1J
p KV-J21MF2J to antenna
output

VCR

to … to video
Connecting a VHF antenna or a combination VHF/UHF antenna (video input) and audio
outputs
(video) and
— 75-ohm coaxial cable (round) (audio) inputs

Attach an optional IEC antenna connector to the 75-ohm coaxial cable. Plug the connector into the (antenna) socket : Signal flow
at the rear of the TV.
Rear of TV Rear of TV
When connecting video equipment to the … (video input) jack
On a wall
or Do not connect video equipment to the … (video input) jacks at the front and the rear of your TV simultaneously; otherwise the picture
will not be displayed properly on the screen.

Connecting audio/video equipment using the Ú (monitor output) jack EN

Rear of TV
–4–

Connecting an indoor antenna

to antenna socket

3
p KV-2199M5J/J14M1J
p KV-J21MF2J to antenna
2 output
Audio system

VCR
or
1

Notes
• You are advised to use an outdoor antenna for better reception. to Ú to video
and audio
• Model KV-J14M1J is used for illustration purposes, however, the connection procedure is the same for KV-2199M5J and KV-J21MF2J. (monitor output)
inputs
(video) and
(audio) inputs
Connecting optional equipment : Signal flow

You can connect optional audio/video equipment to your TV such as a VCR, multi disc player, camcorder, video When recording through the Ú (monitor output) jack
game or stereo system. Do not change the channel or video input while recording with a VCR; otherwise the channel or video input you are recording also will be
changed.
Connecting video equipment using the … (video input) jacks
Front of TV Camcorder
to video and
p KV-J21MF2J p KV-2199M5J/J14M1J audio outputs

L(MONO) R

to …
(video input)
(video) and
(audio) inputs
: Signal flow
When connecting monaural audio/video equipment to model KV-J21MF2J
Connect the yellow plug to and the black plug to -L (MONO).
4 -EN Getting Started Getting Started 5 -EN
 If the picture color is poor and/or the sound is 5 Press +/– on the remote commander or 5 Press PROGR +/– or number buttons on the
Presetting channels noisy (for KV-J21MF2J/J14M1J)
Select the appropriate TV system as follows:
. +/– on the TV again. remote commander or PROGR +/– on the TV
until the required program position
1 Press SELECT on the remote commander or the TV or appears on the screen.
1 2 3 1
until “TV SYSTEM” appears.
PROGR 1 2 3 PROGR
2 Press +/– on the remote commander or . +/– on
or 4 5 6 or
the TV until the picture and sound become normal. 7 8 9
To start presetting channels automatically ÷ 0
Notes from the specified program position
• If you do not know your local TV system, consult your nearest
You can preset up to 100 TV channels in numerical authorized service center or dealer.
Press PROGR +/– or number buttons on the remote 6 Press +/– on the remote commander or
• The setting of the “TV SYSTEM” is memorized for each commander or PROGR +/– on the TV until the . +/– on the TV until the required channel
sequence from program position 1 using the buttons on required program position appears on the screen after
program position. picture appears on the screen.
the remote commander or the TV. step 4 of “Presetting channels automatically”.
You can preset TV channels quickly, automatically or
manually. PROGR 1 2 3 PROGR or
Presetting channels automatically or 4 5 6 or
Remote commander 7 8 9

1 Press SELECT on the remote commander or ÷ 0

VHF LOW B/G

the TV until “TV SYSTEM” appears on the

screen (for KV-J21MF2J/J14M1J). 7 Press SELECT on the remote commander or
the TV.
Presetting channels manually SELECT SELECT
Number SELECT
SELECT
–5–

or
or 1 Press SELECT on the remote commander or the 1
TV until “TV SYSTEM” appears on the screen
PROGR +/– TV SYSTEM (for KV-J21MF2J/J14M1J).
SELECT
+/– 2 Press +/– on the remote commander or
Front of TV . +/– on the TV to select the TV system SELECT SELECT Disabling program positions
or
(for KV-J21MF2J/J14M1J).
SELECT PROGR
1 Press PROGR +/– or number buttons on the
TV SYSTEM remote commander or PROGR +/– on the TV
B/G I D/K M until the unused or unwanted program
or 2 Press +/– on the remote commander or
position appears on the screen.
. +/– on the TV to select the TV system
(for KV-J21MF2J/J14M1J).
2 Press SELECT on the remote commander or
3 Press SELECT on the remote commander or or B/G I D/K M
the TV until “MANUAL PROGRAM” appears
the TV until “AUTO PROGRAM” appears on on the screen.
Quick channel presetting
the screen.
1 Press U to turn on the TV. 3 Press +/– on the remote commander or
SELECT SELECT 3 Press SELECT on the remote commander or . +/– on the TV.
or the TV until “MANUAL PROGRAM” appears
on the screen. 4 Press PIC MODE on the remote commander.
AUTO PROGRAM

SELECT SELECT 5 Press SELECT on the remote commander or

4 Press +/– on the remote commander or or the TV.
When the TV is turned on in standby mode, press . +/– on the TV.
u on the remote commander. MANUAL PROGRAM
To preset the disabled program position again
1 Preset the channel quickly, automatically or manually.
2 Press SELECT and PROGR + on the TV 4 Press +/– on the remote commander or
simultaneously for one to two seconds. or . +/– on the TV.
VHF LOW B/G
SELECT PROGR
1 2 3 1
or

6 -EN Getting Started Getting Started 7 -EN

 Operations

• If no buttons or controls are pressed for more than two hours

Watching the TV Turning off the TV Displaying on-screen information after the TV is turned on using the Wake Up Timer, the TV
automatically turns into standby mode. If you want to
To turn off the TV temporarily Press . continue watching the TV, press any button or control on the
Press u on the remote commander. The u indicator TV or remote commander.
The program position, local system, and TV settings are
on the TV lights up. displayed on the screen.
Setting the Sleep Timer

You can set the TV automatically turned off as you

program.
1 Press U to turn on the TV. To turn off the TV completely
Press U on the TV.
1 Press .
If the power on the TV is turned off in standby mode, the AUTO B/G
DYNAMIC
u indicator on the TV may remain alight for a while.

When the TV is turned on in standby mode, press

Setting the Wake Up Timer
u on the remote commander.
You can set the TV automatically turned on as you SLEEP TIMER:30M SLEEP TIMER:60M

2 Select the TV program you want to watch. program.

After 30 minutes After 60 minutes

To select a program position directly Watching the video input 1 Press © repeatedly to set the timer. SLEEP TIMER:OFF SLEEP TIMER:90M

Press the number button. The on-screen display appears and the indicator No sleep timer After 90 minutes
Press …
–6–

. on the TV lights up.

To cancel the Sleep Timer, press repeatedly until
1 2 3
“SLEEP TIMER: OFF” appears, or turn off the TV.
4 5 6
7 8 9
Changing the on-screen display
÷ 0
language
VIDEO 1
To select a two-digit program position, press
WAKE UP TIMER:10M You can use buttons on the remote commander or the
“-/--” before the number buttons. After 10 minutes TV to change the on-screen display language.
For example: to select program position 25, press 0

“-/--,” and then “2” and “5.” To watch TV

Press ;. WAKE UP TIMER:OFF WAKE UP TIMER:12H00M
+/–

2 5 ; No wake up timer After 12 hours SELECT

2 If you want a particular TV program or video

1 Press SELECT until the screen appears as
input to be displayed using the Wake Up Timer,
follows:
To scan through program positions select the TV program or video input.
SELECT
Press PROGR +/– until the program position you
want appears.
3 Press u on the remote commander or set
PROGR Muting the sound the Sleep Timer to turn off the TV in
LANGUAGE / : ENGLISH
standby mode.
Press ¤. ¤
To cancel the Wake Up Timer, press © repeatedly
until “WAKE UP TIMER: OFF” appears, or turn off the
2 Press +/– to select “ ”.

main power of the TV.

3 Press . +/– to adjust the volume.
. Notes : LANGUAGE /
• The Wake Up Timer starts immediately after the on-screen
display disappears.
• The last TV program position or video input just before the TV Note
MUTING
turns into standby mode will appear when the TV is turned on • You can also use SELECT and . +/– on the TV to select the
using the Wake Up Timer. on-screen display language.

8 -EN Operations Operations 9 -EN-EN

 Additional Information

Each time you press SELECT, the screen changes as No picture

Adjusting the follows: Troubleshooting No sound

picture

(Operative for / Press U or u.

NTSC signal / Check the antenna connection.
only)
/ Check the VCR connections.
/ Check the power cord connection.
Note on the SOUND MODE button If you have any problems, read this manual again and / Check the standby mode.
• The sound mode feature is unavailable for your TV. Thus, the check the countermeasure for each of the symptoms
SOUND MODE button on the remote commander is not used
for your TV.
listed below. Good picture
2 Press +/– to adjust the item. If the problem persists after trying the methods below, No sound
SOUND ÷ 0 contact your nearest authorized service center or dealer.
MODE
+/– Snowy picture
SELECT Noisy sound
PIC MODE
/ Press . +.
3 To adjust other items, repeat steps 1 and 2. / Press ¤.

Selecting the picture mode Note No color

–7–

• You can also use SELECT and . +/– on the TV to adjust the / Check the antenna.
Press PIC MODE until the mode you want picture setting. / Check the antenna connection on the TV
appears. and on the wall.
Front of TV
PIC MODE / Check the TV SYSTEM setting (for
SELECT PROGR KV-J21MF2J/J14M1J). / Adjust the COLOR level in the on-screen
display.
Dotted lines or stripes
/ Check the COLOR SYSTEM setting.
If the picture color is abnormal when receiving
Each time you press PIC MODE, the screen changes as TV cabinet creaks
programs through the (antenna) terminal
follows: / Even if the picture or the sound is normal,
Change the “TV SYSTEM” (for KV-J21MF2J/J14M1J) or
changes in the room temperature
Soft picture “COLOR SYSTEM” setting or adjust the “COLOR”
High contrast (good for video Normal / This may be caused by local interference sometimes make the TV cabinet expand or
picture games) picture level in the on-screen display until the color becomes
(e.g. cars, neon signs and hair dryers). contract, making a noise. This does not
normal.
Adjust the antenna for minimum interference. indicate a malfunction.
DYNAMIC SOFT STANDARD If the picture is abnormal when receiving Note on the remote commander
programs through the … (video input) jack Double images or “ghosts”
• The supplied remote commander is used on several models of
Change the “COLOR SYSTEM” setting or adjust the the TV. If you do not find instructions for some controls that
“COLOR” level in the on-screen display until the color are on the remote commander, that means your TV does not
employ the features of those controls, e.g. and SOUND
Note becomes normal.
MODE.
• If you change the picture mode after the following
adjustments, the adjustment changes in accordance with the Note / This may be caused by reflections from Notes
picture mode. • Normally set “COLOR SYSTEM” to “AUTO”. nearby mountains or buildings. A highly • When you turn on the TV, you may hear the “boon” sound
directional antenna may improve the that is caused by the demagnetization of the TV. This does not
If the sound is distorted or noisy when indicate a malfunction.
picture.
• The picture color may become abnormal if you change the
receiving programs through the (antenna)
direction of your TV. To obtain the normal picture color, press
Adjusting the picture setting terminal Good picture U on the TV to turn off the TV for five minutes and then turn
Change the “TV SYSTEM” setting (for KV-J21MF2J/ Noisy sound it on again.
1 Press SELECT until the item you want to J14M1J) in the on-screen display until the sound • Design and specifications are subject to change without notice.
adjust appears. • All contents in the instruction manual are subject to change
becomes clear.
SELECT
without notice.

WARNING
/ Check the TV SYSTEM setting (for Do not install the appliance in a confined space, such as
KV-J21MF2J/J14M1J). a bookcase or built-in cabinet.
10 -EN Operations Additional Information 11-EN
 SECTION 2
DISASSEMBLY

2-1. REAR COVER REMOVAL 2-2. A BOARD REMOVAL

2 Remove the rear cover.

Lever

1 Five screws (BVTP4×16) Lever

A board
2-3. SERVICE POSITION

A board

2-4. REPLACEMENT OF PARTS

For replacement of the Multi Button and Light Guide, cut the welded portions from them, exchange with the new parts, and fix them with
screws (+BVTP) respectively.

2-4-1. REPLACEMENT OF MULTI BUTTON

Cut

Two screws
(BVTP 3x12)
Multi button

–8–
2-5. DEMAGNETIZATION COIL AND PICTURE TUBE REMOVAL

8 Spring

7 Demagnetization
coil

3 C board

4 VM board

5 Deflection yoke

6 Four screws 2 A board

(Tapping screws)

1 Anode cap

9 Picture tube

Cushion

• REMOVAL OF ANODE-CAP
NOTE : Short circuit the anode of the picture tube and the anode cap to the metal chassis, CRT shield or carbon paint on the
CRT, after removing the anode.
• REMOVING PROCEDURES

c
b

b
a

a
Anode button

1 Turn up one side of the rubber cap in 2 Using a thumb, pull up the rubber 3 When one side of the rubber cap is
the direction indicated by the arrow a. cap firmly in the direction indicated separated from the anode button,
by the arrow b. the anode-cap can be removed by
turning up the rubber cap and
pulling it up in the direction of the
• HOW TO HANDLE AN ANODE-CAP arrow c.

1 Don’t hurt the surface of anode-caps with

sharp shaped objects!
2 Don’t press the rubber too hard so as not to
damage the inside of anode-caps!
A material fitting called the shatter-hook
terminal is built into the rubber.
3 Don’t turn the foot of rubber over too hard!
The shatter-hook terminal will stick out or
damage the rubber.

–9–
 SECTION 3
SET-UP ADJUSTMENTS

• The following adjustments should be made when a complete Perform the adjustments in order as follows :
realignment is required or a new picture tube is installed. 1. Beam Landing
• These adjustments should be performed with rated power 2. Convergence
supply voltage unless otherwise noted. 3. Focus
4. White Balance
Controls and switch should be set as follows unless otherwise noted: Note : Test Equipment Required.
PICTURE control ........................................................... normal 1. Color-bar/Pattern Generator
BRIGHTNESS control ................................................... normal 2. Degausser
3. Oscilloscope
.................................................................................................................................................................................................................................

Preparations :
Purity control
• In order to reduce the influence of geomagnetism on the set's
picture tube, face it east or west.
• Switch on the set's power and degauss with the degausser.

3-1. BEAM LANDING

1. Input the white raster signal with the pattern generator.
Contrast
Brightness
normal} Fig. 3-2
2. Set the pattern generator raster signal to green.
3. Move the deflection yoke to the rear and adjust with the purity
control so that the green is at the center and the blue and the red
take up equally sized areas on each side. BLUE RED
(See Figures 3-1 through 3-3.)
4. Move the deflection yoke forward and adjust so that the entire GREEN
screen is green. (See Figure 3-1.)
5. Switch the raster signal to blue, then to red and verify the
condition. Fig. 3-3
6. When the position of the deflection yoke has been decided,
fasten the deflection yoke with the screws. Purity control corrects
this area.
7. If the beam does not land correctly in all the corners, use a
Disk magnets or rotatable
magnet to adjust it. disk magnets correct
(See Figure 3-4.) these areas (a-d).

Deflection yoke positioning

corrects these areas.

Fig. 3-1

d
Fig. 3-4

– 10 –
3-2. CONVERGENCE If the V.STAT magnet is moved in the direction of the a and b
Preparation : arrows, the red, green, and blue points move as shown below.
• Before starting this adjustment, adjust the focus, horizontal size, 1
and vertical size. a a b

• Minimize the brightness setting. B B

b b
• Provide dot pattern. G G
R R
(1) Horizontal and Vertical Static Convergence

2
Center dot a a
R
R G B
G

B
R G B

V.STAT Magnet b b
B G R

3
a b
b a
R B

RV 701 G G
C board SCREEN (G2) b B R

1. (Moving vertically), adjust the V.STAT magnet so that the red,

green, and blue points are on top of each other at the center of
Purity
the screen.
2. (Moving horizontally), adjust the V.STAT magnet so that the
red, green, and blue points are on top of each other at the center
of the screen.
3. Tilt the V.STAT magnet and adjust the static convergence by
opening or closing the V.STAT magnet.

V.STAT

– 11 –
(2) Dynamic Convergence Adjustment
Preparation :
• Before starting this adjustment, adjust the horizontal static 3. Move the deflection yoke as shown in the figure below and
convergence and the vertical static convergence. optimize the convergence.
1. Slightly loosen the deflection yoke screws. 4. Tighten the deflection yoke screws.
2. Remove the deflection yoke spacer. 5. Install the deflection yoke spacer.

R B
B G R
G G
R G B R
B

B G R R G B

R G B B G R

B R
R G B
G G
B G R
R B

(3) Screen-corner Convergence

b
Affix a Convergence correct
b a piece corresponding to the
misconverged areas
a-d : screen-corner a
misconvergence

c d

d
Convergence correct piece

– 12 –
3-3. FOCUS ADJUSTMENT DATA

Adjust FOCUS control on the flyback transformer for the best

focus. 09 RDR 1F SERVICE

Adjustment Item
Item number

09 RDR 1F WRITE MUTING

Green
0
Executes the writing
FOCUS

SCREEN
(NOT USED)
3-4. G2 (SCREEN) AND WHITE BALANCE
FLYBACK TRANSFORMER (T851) ADJUSTMENTS
Note: Screen VR is not used. 1. G2 (SCREEN) ADJUSTMENT (RV701)
1) Set the PICTURE and BRIGHTNESS to normal.
a. AN ITEM OF ADJUSTMENT 2) Put to VIDEO input mode without signals.
Item Adjustment 3) Connect R, G, and B of the C board cathode to the oscillo-
Initial DATA Note
number item scope.
09 RDR 25 WHITE POINT R 4) Adjust G2 (RV701) volume to the value below.
0A GDR 20 WHITE POINT G
0B BDR 20 WHITE POINT B

b. METHOD OF CANCELLATION FROM SERVICE

177±2 V DC
MODE
Set the standby condition (Press [POWER] button on the
commander) and then press [POWER] button again, hereupon it 0V
becomes TV mode.

2. WHITE BALANCE ADJUSTMENTS

c. METHOD OF WRITE FOR MEMORY
1) Set to Service Mode.
1) Set to Service Mode.
2) Input an entire white signal.
2) Press [1] (UP) and [4] (DOWN), select the item for adjustment.
3) Set the PICTURE to maximum.
3) Press [MUTING] button indicate WRITE (Green) on screen.
4) Select RDR(09) with [1] and [4] , and then set the level to 25
4) Press [0] button to write into memory.
with [3] and [6] .
d. MEMORY WRITE CONFIRMATION METHOD 5) Select GDR(0A) and BDR(0B) with [1] and [4] and adjust the
1) After adjustment, pull out the plug from the AC outlet, and level with [3] and [6] for the best white balance.
then plug into the AC outlet again. 6) Write into the memory by pressing [MUTING] then [0] .
2) Turn the power switch ON and set to Service Mode.
3) Call the adjusted items again to confirm adjustments were made.

– 13 –
 SECTION 4
SELF DIAGNOSIS FUNCTION

If no acknowledgement is returned from a device which is turned "ON", the device has a problem.
In this case, one of the LED's responding to the problem device will flicker a defined number of times.

Flickering is operated by lighting the LED's for 60ms each time.

The flickering frequency responding to each failed device is shown below.

Board name A Board A Board

Ref. No. IC003 IC300
NONVOLATILE Y/C JUNGLE
Device MEMORY (TDA8375A)
(ST24C04FB6)

Flickering Frequency 1 3

All the devices are checked one after another from the left of the table.
If an error is found, the responding LED will start flickering.
So, if more than 1 device have failed, only the one on the left side will flicker.

– 14 –
 SECTION 5
CIRCUIT ADJUSTMENTS

5-1. ADJUSTMENTS WITH COMMANDER

Service adjustments are made with the RM-869 that comes with
this unit. 1, 4 Raise/lower the service item number
3, 6 Raise/lower the data
Entering service mode [MUTING] Writes
With the unit on standby - Executes the writing
↓
DISPLAY
↓ 7, - All data becomes the values in memory
5 8, - All user control goes to the standard state
↓ 5, - Service data initialization (Be sure not to use
VOL (+) usually.)
↓ 2, - Write 50Hz adjustment data to 60Hz, or
POWER viceversa.
The operation sequence puts the unit into service mode.
The screen display is :

1 Adjustment item

Item # Data Mode

¤ EG u

00 HSF 08 SERVICE Mode

V …F ;

052S V3.2C 00 50 Depends on the signals

PAL, SECAM : 50
1 2 3 NTSC : 60
4 5 6 German A2 Stereo
Software Version #
7 8 9
OEM CODE
0
SOUND
MODE
. PROGR
2
+ +
A/B H
3D OP0 00 SERVICE
B©
+ p SELECT p
0000 0000 00 50
CI
– p PIC MODE p

TV

(Bit options adjustable)

RM-869

1, 4 Select the adjustment item.

↓
3, 6 Raise/lower the data.
↓
MUTING Writes
↓
- Executes the writing.

– 15 –
5-2. ADJUSTMENT METHOD
Item Number 08
This explanation uses V-SHIFT as an example. Use the same method for Items Number 00-40. Use 1 and 4 to
1. Select 08 V-SHIFT with the 1 and 4 buttons. select the adjustment item, use 3 and 6 to adjust, write with
2. Raise/lower the data with the 3 and 6 buttons. MUTING , then execute the write with -.
3. Select the optimum state. (The standard is 0F for PAL
reception.)
4. Write with the MUTING button.
5. Execute the writing with the - button. (The WRITE
display returns to green SERVICE.)

08 VSF 0C SERVICE GREEN

052S V3.2C 00 50

Adjusted with 3 and 6 buttons

08 VSF 0C WRITE GREEN

052S V3.2C 00 50

Written with MUTING

08 VSF 0C WRITE GREEN

The WRITE display
Blank will change back to
SERVICE.
(2nd line disappear
when written)

Write executed with 0

– 16 –
Adjustment Item Table
Item Adj Initial
Note for Different Data Standard Data Function Device
No. Item Data
00 HSF 24 50/60Hz/RGB 50/RGB 60 2C/33/31/38 H Shift
01 HSZ 23 50/60Hz/RGB 50/RGB 60 35/35/35/35 H Size
02 PAP 21 50/60Hz 25/25 Pin Amplitude
03 CNP 29 50/60Hz 10/0C Corner Pin
04 TLT 20 50/60Hz 20/2D Tilt
05 VSL 20 50/60Hz 1F/1F V Slope
06 VAP ID 50/60Hz 1C/1B V Amplitude
07 SCR 20 50/60Hz 16/16 S Correction
08 VSF 20 50/60Hz 10/10 V Shift
09 RDR 25 28 R Drive
0A GDR 20 G Drive
0B BDR 20 B Drive
0C F0 00 TV/Video/Teletext 00/00/00 ø1 Time Constant
0D AGC 06 TV/Video/Teletext 28/28/28 AGC Take Over
0E VSW 0 TV/Video/Teletext 0/1/0 Video Mute Switch
0F FOR 00 03 Forced Field Frequency
10 DL 0 De-interlace
11 POC 0 Fixed ø1 Synchro. mode
12 COR 0 TV/Video/Teletext 01/00/00 Noise Coring
13 VPX 00 Extra Bits (see below)
14 PMX 27 TV/Video/Teletext 2B/2B/2B Picture Maximum Data
15 PMI 05 04 Picture Minimum Data
16 SBR 4B Sub Brightness
17 SHU 07 Sub Hue
18 SSH 01 TV/Video 01/03 Sub Sharpness
19 SC1 1F 50/60Hz 26/29 Sub Color Lower
1A SC2 0B 50/60Hz 0C/0D Sub Color Higher
1B AIP 40 3F Adjustment IF-PLL
1C VZM 20 19 Vertical Zoom
1D WST 15 W/G Stereo Threshold
1E WBT EA W/G Bilingual Threshold
1F WLL 05 W/G Monaural Threshold
20 ACG 1 AGC Switch auto/constant
21 CDB 28 AGC Gain at Constant Mode
22 FGP 1B FM Prescale for B/G.I.D/K
23 FMP 32 FM Prescale for M
24 FMH 36 FM Prescale for HDEV Mode
25 FMM 65 FM Prescale for HDEV Mode
26 WGP 2A W/G Prescale
27 NIP 6D NICAM Prescale
28 SCP 3B SCART Input Prescale
29 SCV 2A SCART Output Prescale
2A CRM 0 Carrier Muting on/off
2B ACO 1 Audio Clock-out on/off
2C WAC 00 W/G Agreement Count
2D NFT 50 Auto FM Switch Threshold
2E DLG 30 W/G Search Delay
2F DLN 20 NICAM Search Delay
30 DLS 10 Stereo Status Read Delay
31 SMX 73 DFP Volume Maximum
32 ING 00 M System/non-M/Video Input Gain
33 VOM 01 M System only Volume Output Gain
34 TXH 01 Teletext Horizontal Position
35 BKP 00 Picture Data at Blanking OFF
36 ODL 10 Power ON Delay
37 OFR 00 RGB Output Time (STBY OFF)
38 OFM 00 RGB Output Time (AC OFF)

– 17 –
 Item Adj Initial Note for Different
Standard Data Function Device
No. Item Data Data
39 OSH 0A OSD H Position
3A DKS 1 0 D/K Stereo enable/disable
3B MUT 0 Muting on/off at No Sync
3C ABL 0 Bright ABL Switch
3D SCM 0 SECAM Trap active/inactive
3E FBT 1 FBT L/S C/M strict/plain
3F OP0 2F 28 (2199) 2F (J21) Optional Flags 0 (see below)
40 OP1 0F Optional Flags 1 (see below)
41 OP2 00 24 (2199) 04 (J21) Optional Flags 2 (see below)

NOTE
• Note for Different Data Those are the standard data values written on the microprocessor. Therefore, the data values of
the modes are stored respectively in the memory.
In case of a device replacement, adjustment by rewriting the data value is necessary for some
items.
• 50 .............. 50 Hz data
• 60 .............. 60 Hz data
• Note for Different Data listed on the adjustment item table are reference values, therefore it is different for every model.

– 18 –
Option Note

13. VPX bit 7 bit 6 bit 5 bit 4 bit 3 bit 2 bit 1 bit 0
Item HCO EVG SBL PRD – – – VID
Initial data 0 0 0 0 0 0 0 0

HCO EHT Tracking Mode 1 = on V and E–W,0 = only on V 0A (7)

EVG Enable Vertical Guard 1 = enable, 0 = disable 0A (6)
SBL Service Blanking 1 = active, 0 = inactive 0B (7)
PRD Over-voltage Protection Detection 1 = enable, 0 = disable 0B (6)
VID Video Ident Mode 1 = not for ø1-loop, 0 = for ø1-loop 09 (7)

3A. OP0 bit 7 bit 6 bit 5 bit 4 bit 3 bit 2 bit 1 bit 0
Item No TOP AV input AVMUT B/G I D/K M
Initial data 0 1 0 0 1 1 1 1

AV Input 0 0 no AV input model 0 1 1 AV input model

1 0 2 AV input model 1 1 2 AV input and RGB input model
No TOP (for teletext model) 1 = only FLOF available, 0 = both FLOF and TOP available
AVMUT 1 = AV multi is always muted if no signal input, 0 = not muted always
Other optional bits are effective if set to 1.

3B. OP1 bit 7 bit 6 bit 5 bit 4 bit 3 bit 2 bit 1 bit 0
Item – – HDEV 1 V-Curve XTAL SEL SECAM 2nd Lang.
Initial data 0 0 0 0 1 1 1 1

XTAL SEL 0 0 only 4.43 XTAL 0 1 only 3.58 XTAL

1 0 (not used) 1 1 both 4.43 and 3.58 XTAL
1 V-Curve (for monaural model)
1 = using common volume curve for every mode and every TV system
0 = another volume curve available for video mode and M system
HDEV 1 = High Deviation Mode switch available, 0 = not available
Other optional bits are effevctive if set to 1.

3C. OP2 bit 7 bit 6 bit 5 bit 4 bit 3 bit 2 bit 1 bit 0
Item – – No Bal. TV Out Hotel VM D.B.F.B. Thai Bil.
Initial data 0 0 0 0 0 0 0 0

No Bal. (for AV stereo model) 1 = no balance in analog select items, 0 = balance included
Other optional bits are effective if set to 1.
Hotel TV mode should be switched with remote commander from STBY condition as below.
Hotel TV on : push “display”, “8”, “vol +” and “power” sequentially
Hotel TV off : push “display”, “8”, “vol –” and “power” sequentially

– 19 –
5-3. A BOARD ADJUSTMENT AFTER IC003 5-4. PICTURE DISTORTION ADJUSTMENT
(MEMORY) REPLACEMENT Item Number 00 – 08

00 HSF (H SHIFT)
1. Enter to Service Mode.

2. Press commander buttons 5 and - (Data Initialize), and 2

and - (Data Copy) to initialize the data.
01 HSZ (H SIZE)
3. Call each item number, and check if the respective screen shows
the normal picture.
In case some items are not well-adjusted, give them fine
adjustment.
02 PAP (PIN AMPLITUDE)
Write the data per each item number ( MUTING + - ).
4. Select item numbers “3E” (OP0), “3F” (OP1) and “40” (OP2)
and respectively set the bit per model with command buttons
3 and 6.
03 CNP (CORNER PIN)
5. Press commander buttons 8 and - (Test Normal) to return
to the data that was set on the shipment from the factory.
(= Cancel Service Mode.)

04 TLT (TILT)

05 VSL (V SLOPE)

06 VAP (V AMPLITUDE)

07 SCR (S CORRECTION)

08 VSF (V SHIFT)

– 20 –
 SECTION 6
DIAGRAMS
6-1. BLOCK DIAGRAM 6-2. CIRCUIT BOARDS LOCATION

A SYS CONTROLLER, TU, MEMORY Q1207, 1208 C (RGB OUT)

J1201
IF, Y/C JUNGLE, H/V OUT VIDEO
Q1203 VIDEO
POWER SUPPLY, SECAM DECODER AMP
AUDIO/VIDEO INPUT VIDEO
Q1204
BUFFER
AUDIO MONITOR Q712 Q706 Q703
L (MONO)
Q1201, 1202 AMP OUT

VIDEO
VIDEO
BUFFER
*
Q1205
R DRIVE R AMP R OUT

AUDIO
VIDEO R RV701
AMP
IN 1
(FRONT)
L (MONO)
IC201
*
Q1264 *
Q1265
Q709

IK LIMIT
G2

R TONE CONT R MUTE L MUTE J701

9V
IC1210
(1/2)
Q711 Q705 Q702
12 Terminal name of semiconductors in silk screen
6 24 G DRIVE G AMP G OUT 11 5
V901 VM
VIDEO
5
7
9V J251 10
PICTURE TUBE printed circuit ( ＊ )
7 L IN L OUT 27 11 L IN L OUT 5 HEADPHONE 1 8 CN701
VIDEO Q708 H2 1000V
1 Device Printed symbol Terminal name Circuit
IN 1 L (MONO) 200V
IC1210 IK LIMIT 2
(REAR) 4 L IN IC203 H1 Collector
R (2/2) AUDIO OUT
4
1 Transistor
3
1
1 R IN
Q710 Q704 Q701 C Base Emitter
2
9 R IN R OUT 26 12 R IN R OUT 3 B DRIVE B AMP B OUT Collector
SDA SCL CN251
2 Transistor
22 21
*
Q209 Q210
1
2
SP L Q707
Base Emitter

R SP MUTE L SP MUTE 3 IK LIMIT Cathode

4
SP R 3 Diode
Anode
Q714
Cathode
CN103 CN703
+9V BIAS 4 Diode
Anode (NC)
R R
6 6
G G Cathode
5 5
B
4 4
B
5 Diode
Anode (NC)
IK IK
1 1
Common
6 Diode
Anode Cathode

S601 POWER Common

IC521 CN601 7 Diode
Q403, 404
+9V T601 SRT
D601 L605 LFT
1 A Anode Cathode
+9V
FILTER REG Common
TU101 17 2
Q402
+18V AC IN
8 Diode
F601 Anode Anode
IF IF BUFFER SWF401
16 3
Q601
2 6-3. SCHEMATIC DIAGRAMS AND PRINTED WIRING BOARDS
AGC TU U/V L/H IC300 15 4 IC601 REG SW Common
BUS CONTROL +11V PC SW 9 Diode
IC001 µ-COM TV PROCESSOR 9 Anode Anode

59 L/H MUTE 11
Q202

MUTE +7V 17 CVBS IN R 21

Q405
*
Q406–410
Q411, 412, 414,
Q416
*
14 5

OVP
Note: Reference information Common
60 U/V G 20
SYNC SYNC
+B
13 8
1 • All capacitors are in µF unless otherwise noted. RESISTOR : RN METAL FILM 0 Diode
Q109 Q303 FILTER FILTER Cathode Cathode
VC AMP 38 VC
R 51
G 50 G BUFFER
48 IF IN
49 IF IN
B
IK
19
18 Q413,
11 7
DRIVE LATCH
• All electrolytic capacitors are rated at 50V unless otherwise noted. : RC SOLID
Common
Q110
B 49 54 AGC
415, 417
SYNC SYNC
Q418
* 8
• All resistors are in ohms. : FPRD NONFRAMMABLE CARBON !¡ Diode
VC FILTER CVES IN 13 2
: FUSE NONFLAMMABLE FUSIBLE Cathode Cathode
Q108 IC003 MEMORY FILTER FILTER kΩ = 1000Ω, MΩ = 1000kΩ
OSC 6 NECK
BUFFER 9 AGC IICLK1 55 6 CLK
ASSY • Indication of resistance, which does not have one for : RS NONFLAMMABLE METAL OXIDE Anode Cathode
IIDAT1 53 5 DAT 7 CN1701 Q1721–1723 Q1761 Q1762 Q1764 Q1766 Q1767 Q1763,1765 !™ Diode Anode Anode
41 KEY1 7
VIDEO VM
VM AMP
SLICE CORRECTING
VM AMP
VM VM VM rating electrical power, is as follows. : RB NONFLAMMABLE CEMENT Cathode Anode
FILTER AMP AMP BUFFER DRIVE
40 KEY2 IF OUT 6 LEVEL
D1763 1764 E
VM Pitch: 5 mm : RW NONFLAMMABLE WIREWOUND Transistor Source
PROG+ IC002 +5V REG HSYNC 47 41 SSCP/FBT BY 30 IC603 PHOTO COUPLER SHIFT
Rating electrical power 1/4W (CHIP: 1/10W) :* ADJUSTMENT RESISTOR !£ (FET)
Drain
Gate D D
HSYNC 25 R-Y 29 SLICE
+9V Q031 Q1756
S901 OUT 5 +5V T851 FBT
IC602 ERROR AMP
3 4
VM MUTE VM • : nonflammable resistor. COIL : LF-8L MICRO INDUCTOR Source
G G
1 IN TV SYNC 28 BUFFER 5 Transistor
•
S S
PROG– RESET 4 36 RESET +5V
2 5 MUTE VM OUT, ROTATION,
¢ : internal component. CAPACITOR : TA TANTALUM !¢ (FET)
Drain
IC004 IR DET X358 *
Q302 IC354 SECAM
4 6
1 2 2 1
V-PIN DF CIRCUIT
VM • : panel designation, or adjustment for repair. : PS STYROL
Gate
D D
S902 3.58MHz CVBS OUT 38 BUFFER 20 SIN Source
35 EXTAL SIRCS 26 1 2 34 3.58 B-Y 12
1
11
• All variable and adjustable resistors have characteristic curve B, : PP POLYPROPYLENE !∞
Transistor
Drain G G
VOL+ R-Y 11 +135V CN851 (FET) Gate
X101 X443
4.43MHz SECAM 33 1 SREF
200V
2
unless otherwise noted. : PT MYLAR S S

• Readings are taken with a color-bar signal input.

7 1000V Emitter
S903
+5V D901
34 XTAL IC401 SYS-SEL 35 4.43/3.58 5 SYNG –13V
H1
1 : MPS METALIZED POLYESTER !§ Transistor Collector
S906 HOR OUT 40 4
TIMER Q902 9 no mark : PAL : MPP METALIZED POLYPROPYLENE Base
VOL– SELECT EAST/WEST 45 +15V
LED B/G 1 Q030 D801, 891 C1 C2
DRIVE
3 TIMER TSW0 7 3 A
M 2
VERT POS 46 10 ( ) : SECAM : ALB BIPOLAR C2 B1 E1
S904 VERT NEG 47 H PROT DUMPER
: ALT HIGH TEMPERATURE !¶ Transistor B1 B2
Q903
TSW1 8 4 B
D/K 7
T801
[ ] : NTSC 3.58 E2 B2 C1

TV/VIDEO
LED
DRIVE
6
RESP/
NICAM
I 8

26 BLK
BLK/STC 39
IC351 1HDL
Q801

H DRIVE
Q802

H OUT
H+
1
DY1
H+ « » : NTSC 4.43 : ALR HIGH RIPPLE C1 B2 E2
E1 E2

S905
NICAM
ST/BY SYNC 5
H+
2
H–
• Readings are taken with a 10 MΩ digital multimeter. !• Transistor
E1 B1 C2 C1 C2

VM MUTE 58
R-Y 32 11 R-Y
R-Y 16
FV IC801 (2/2) S801 HDY • Voltage are dc with respect to ground unless otherwise noted. B1 B2
B-Y 31 12 B-Y PIN CONT H SENT
• Voltage variations may be noted due to normal production
Q821 L804 H– C1 B2 E2
56 IICLK0 BRT ABL 42 B-Y 14
H–
3
VDY !ª Transistor
E1 B1 C2
E1 E2

54 IIDAT0 VPULSE 17 7 SCL 3 1 PIN OUT 4

VSYNC 48 8 SDA ABL 22 D1505
Q1513 13 V+ tolerances. E1 E2
V– V–
12 BLK HDSW 27 EHTX-RAY 50 V SAW 5 • All voltages are in V. @º Transistor
C1 B2 E2
B1 B2

D591
Q561
D561
IC801 (1/2)
PIN CONT • : Can not be measured. E1 B1 C2
C1 C2
X RAY +135V IC551 V OUT
DY ASS'Y * numbers are waveform reference.
• Circled C1(B2) C2
5 Note:The component identified by shading and @¡ Transistor
E2 B1 E1
B1
+
- 7 4 2
V+
6 • : B + bus. mark ! are critical for safety. Replace only
C2 C1(B2)
E2 E2
HV 6
• : B – bus. with part number specified. (B2)
B1 E1 E2
E1(B2) E2

• : signal path. @™ Transistor

C1 C2
B1

C1 C2
(B2) E1(B2) C2
E2 E1 B1
CN111 @£ Transistor
C2 C1
B1
VIDEO C1 C2
2
VM MUTE
4 – Discrete semiconductot
: KV-2199M5J ONLY
* (Chip semiconductors that are not actually used are included.) Ver.1.5

– 21 – – 22 – – 23 – – 24 –
PRINTED WIRING BOARD A SYS CONTROLLER, TU, MEMORY, IF, Y/C JUNGLE, H/V OUT,
POWER SUPPLY, SECAM DECODER, AUDIO/VIDEO INPUT

– A BOARD –
A BOARD A BOARD WAVEFORMS A BOARD IC300 TDA8735A
Q1208 B–2 1 1 2 3 4 5 6 7 8 9 10 11 12 13
IC Q1209 C–4 1
Q1264 C–1 1
IC001 D–11 Q1265 C–1 1
IC002 E–10 Q1513 G–6 1 A
IC003 E–10
IC004 I–13 DIODE
IC100 E–7
IC201 B–8
IC203 B–10 *
D001 D–9 –
IC300 D–4 D002 C–12 –
IC351 D–8 D003 C–10 3 B
IC354 D–7 D005 E–8 –
IC401 B–7 D008 H–13 –
IC521 E–8 D103 D–1 6
IC551 J–6 D201 B–9 3
IC601 J–8 D251 B–8 3
IC602 H–7 D252 F–12 4
IC603 H–7 D253 C–9 3 C
IC801 F–6 D301 D–8 3
IC1210 A–2 D305 D–8 3
D306 E–6 –
TRANSISTOR D307 D–5 –
D308 C–10 –
* D310 D–9 3
Q030 C–12 1 D311 D–9 – D
Q108 D–2 1 D312 C–6 –
Q109 E–12 1 D315 E–5 –
Q110 E–3 1 D351 E–8 –
Q202 C–9 1 D399 E–5 3
Q207 B–10 1 D401 E–4 3
Q208 B–10 1 D402 C–5 –
Q209 B–9 1 D403 C–9 – E
Q210 B–10 1 D513 G–6 –
Q301 C–7 1 D551 I–5 –
Q302 D–7 1 D561 G–5 –
Q303 D–8 1 D591 I–6 –
Q402 D–4 1 D601 H–12 –
Q403 E–4 1 D604 G–8 –
Q404 E–4 1 D605 G–8 – F A BOARD IC351 TDA4665T-T
Q405 C–6 1 D606 G–9 –
Q406 B–7 1 D607 I–8 –
Q407 B–6 1 D609 I–9 –
Q408 C–7 1 D610 H–8 –
Q409 C–6 1 D611 I–8 –
Q410 C–6 1 D613 E–9 –
Q411 C–6 1 D801 F–2 – G
Q412 C–5 1 D802 F–2 –
Q413 B–5 1 D851 H–4 –
Q414 C–5 1 D852 H–4 –
Q415 B–5 1 D853 I–3 –
Q416 C–5 1 D855 J–4 –
Q417 B–6 1 D857 F–3 –
Q418 B–5 1 D858 F–4 – H
Q561 I–6 – D860 E–2 –
Q801 D–2 – D901 H–13 –
Q802 F–1 – D1201 A–2 –
Q821 E–6 – D1202 B–1 –
Q902 D–10 1 D1203 B–1 –
Q903 D–11 1 D1207 B–2 –
Q1201 A–3 1 D1208 B–2 – I
Q1202 A–3 1 D1209 B–3 –
Q1203 A–2 1 D1504 G–6 –
Q1204 B–2 1 D1505 G–6 –
Q1205 B–3 1
Q1207 A–2 1
J

– 25 – – 26 – – 27 – – 28 –
 (1) Schematic Diagram of A Board
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23

MONITOR
OUT
J1201 J1202
* *

AUDIO IN 1 R

AUDIO IN 1 L

AUDIO IN 1 R

AUDIO IN 1 L
R L
A

VIDEO IN 1

VIDEO IN 1
TO VM BOARD TO C BOARD

ROTATION
CN1701 4 5 6 PIN CN703

VM MUTE

AUDIO R

AUDIO L
(MONO)

(MONO)

(MONO)
CN101 CN103 CN251

H.BLK
CN102

B INT
B DAT
B CLK

B OUT
G OUT
R OUT

VIDEO
4P 6P 4P

SP L
3P

SP R
GRY :S-MICRO

GND

11V

GND

GND

GND
GND
WHT J251
:S-MICRO

NC

9V

NC
NC

IK

9V
:S-MICRO A BOARD * MARK LIST

1
2
3
4

1
2
3
4
5
6
7
8

1
2
3
4
5
6
7

1
2
3
4
3 6 54 12 7 8 9
FB103 KV-2199M5J KV-J21MF2J KV-2199M5J KV-J21MF2J
1.1UH JW099

R181 220 :CHIP

11V 15MM

R3

L3

V3

R2

L2

V2

R1

L1

V1
JR115 C003 # 100p 50V : CHIP Q413 # UN2216-TX
0 C257
C012 # 100p 50V : CHIP Q415 # UN2216-TX

R180 220 :CHIP

:CHIP C254 R264 0.15 C244 897 15 14 21 20 231 10 17 16 564 13 12 19 18 576 3 4 1 2
Q209 0.015
B C339 B:CHIP R246 * :MPS 1000
C409 # 47p 50V CH : CHIP Q416 # 2SD601A

L131 JW(5)
150p UN2216 5.6k 25V
:CHIP RSP-MUTE :CHIP IC203

R182 220 :CHIP

C132
100p TA8248K R256 C412 # 68p 50V CH : CHIP Q417 # UN2216-TX
:CHIP R249 * R247 C1259 AUDIO OUT C247 330
C405 L401 R410 * 6800p 1000 R1216 R1211 R1207 R1204 R1203 R1201 C414 # 100p 50V : CHIP Q418 # UN2216-TX
TU101 1.2µH * Q210 C255 B:CHIP 25V R252 D252 Q1265 470k 68 * R1206 47k 82

JW031 5MM
0.0047 * C416 # 100p 50V : CHIP Q1205 # 2SB709A
BT-AG401 R406
4.7k B:CHIP :ALI R412
*
R413 UN2216 0.015
B:CHIP
C246
10
330 DA204K UN2216 1.3R1213 R1212 :CHIP :CHIP 47k
:CHIP
R1205
82 :CHIP :CHIP
* LSP-MUTE 0

VCC 2

B.S.1
L OUT
VCC 1
R OUT
B.S.2
:CHIP C243 * 1k :CHIP C417 # 100p 50V : CHIP Q1264 # UN2216-TX

15.3
C240 C1204

R IN
L IN
NF 1
10

0.5
8.2
:CHIP

0.5
R250

GND
GND
NF2

GND
[-0.5] **
SWF401 C1205 100

[8.9]8.99
0.15

IF2/NC
R408 C407 R255 C1226 R1254 *
* 16V C418 # 390p 50V : CHIP R009 # 1k : CHIP

(-0.8)

0
* :MPS 220 0.1

0
0
[-0.5]
1.8k D401

(-0.8)
0.0047 4.7

-1.0
D1203

-1.0 0
:CHIP B:CHIP R037 16V C1206 25V C1203
* 1 R1228

AGC

U/V
L/H

AFT
PWM
33V

IF1
IC401 R1215 C1201

**

0(8.9)
I O1 5 1k 0 * * B:CHIP * C419 # 100p 50V : CHIP R014 # 1k : CHIP

TU

+B
:CHIP * R248 R245 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 C251 R1214 470k 1k 100
2

3.7
IG C1202
SWF

8.0
C406 * 5.6k R265 # Q1264 * :CHIP B:CHIP 16V

R242 270 :CHIP

O2 6 9V

C235 100 16V

8.9 10

B/G

D/K

C237 100 16V

SI :CHIP C239 R1241 0.1 C422 # 330p 50V CH : CHIP R058 # 4.7k : CHIP

0
R411 * C242 *

0
0.0047

15.7
15.5
100 1k 25V

8.0
C127 B:CHIP Q402 * 0.01 B:CHIP RM-MUTE

JR110 #
C103 0 G1 G2 16V :CHIP B:CHIP R1202
C424 # 470p 50V CH : CHIP R247 10k : CHIP 1k : CHIP
C 1000p 0.1 2SC2410S 78 C241 R257 R1242 D1207 1k

D1208 RD9.1ESB
0.1 25V B:CHIP
B:CHIP 25V C402 R403 3.9 3.4 9V 1 2 3 4 5 6 7 8 9 JW005 1000 25V MA113 D251 * RD9.1ESB :CHIP
B:CHIP R407
0.01 68 3.9k R440 C1260
# JW003 15MM 0 MA113
15.7 R1226 D1201 RD9.1BSB Q1201 2SD601A C1203 # 0.1 25V B : CHIP R248 10k : CHIP 1k : CHIP

(-0.7)
[-0.6]
B:CHIP :CHIP :CHIP 150 3.2 Q404 JR201 C403 C234 C1213 R1218 *

-1.0
6800p

**
C128
L101 :CHIP 0 * * 22 47 R254 C238 R253 C1212 1 470 C1206 # 0.1 25V B : CHIP R249 15k : CHIP 1k : CHIP
CN100 C258 B:CHIP 16V 0.15 C253
10µH 3.4 R240 4.7 :MPS 10k * :CHIP R1230 R1231
1P 0.15 100

D1202 RD9.1ESB
:FLR50
:MPS JW029 270 16V
:CHIP R1220 10k Q1202 1k C1212 # 1 50V R250 15k : CHIP 1k : CHIP
:MINI FB101 R409 R266 5MM :CHIP C236 JR113 0 :CHIP 1k Q1203 :CHIP 2SD601A
1.1UH C125 100 10k 220 15.7 D1209 :CHIP C1215 # 180p 50V B : CHIP R264 4.7k : CHIP 3.3k : CHIP
0.1 C105 C108 C109 :CHIP 0 -0.8 (-1.0) [-0.6] ** C414 C420 :CHIP
R241 35V 15.0 15.7 * 2SD601A R1227
AGC 1 100 1000 0.0047 * C416 C417 47 39k
25V C408 C233 JR112 C1216 # 0.47 25V B : CHIP R265 4.7k : CHIP 3.3k : CHIP

+20V
16V 16V B:CHIP Q403 * 16V * R251 :CHIP
B:CHIP 0.0047 * 47 MA113 Q207

GND
B:CHIP * C419 D403 16V 0 :CHIP C252
C124 8.9 4.3 (4.5) * 2SB709A 2.2
R1222
C1214
R1233 C1223 # 1 16V B : CHIP R410 # 10k : CHIP
1SS119

R1219
15.0 Q202 * R1243 2.2k

10k
0.1 100 R1240 100 R1229 :CHIP
25V C101 2SB709A R1223 :CHIP 100 16V 470 C1225 0.47 25V # R411 # 2.2k : CHIP
B:CHIP 4700p R243 R244 D201 MA113 MUTE * :CHIP R1232 :CHIP C1216
B:CHIP 10k 10k 3.9k C1215 * CF45 # 1-527-943-32 R412 # 6.8k : CHIP
D C106
3.9 3.77
R102 Q108
:CHIP
0
:CHIP
Q1205 R1244
Q1204
2SB709A
:CHIP *
CF60 # 1-567-100-22 R413 # 2.2k : CHIP
10 1k 2SD601A C424 D253 * *
CF65 # 1-567-101-22 R415 # 220 : CHIP
R909 R908 R907 :CHIP
AGC MUTE * Q418 1.4 Q208 MA113 R1221
8.2k 2.7k 560 33V 8.9 * (-0.8) R1234
:CHIP :CHIP :CHIP R414 -1.5 8.9 L408 [-0.5] 4.9 UN2213 R1224
*
10k
:CHIP * CT45 # 1-579-690-21 R417 # 220 : CHIP
470
3.4 R420 R424 (-0.8) L411 0
:CHIP 3.22 390 2.2k [0] **
C418
* *
**
4 3 2 1 CT60 # 1-409-429-21 R418 # 680 : CHIP
R118 C118 Q407 R417 :CHIP L405 R422 :CHIP 0 *
C135 C102 R101
22k
:CHIP
22 * * * *
Q410 L407 R427 C422
CT65 # 1-409-327-21 R422 # 120 : CHIP
Q413 Q415

C217 0.22 16V B:CHIP

# # 4.7k * * * * C423 0
:CHIP 3.4 * * L410 330p CF65
*
C1210 IC1210 D401 # MA77-TX R423 # 150 : CHIP
S903 S902 S901 C119 L402 3.22 8.9 2.2µH :CHIP R210 R213 100 R1248 Q1207 µPC4558G2
0 D402 # ISS119-25TD R427 # 330 : CHIP

C213 0.018 B:CHIP

0.01 8.9 12µH (0) 0 3.3k 2.7k 16V 1.5k 2SD601A VIDEO BFF
B:CHIP :ALI CT60 R430 :CHIP :CHIP R1249 :CHIP
VOL + CH - CH + R116 R117 8.9 L409
R902 22k 22k 3.4R416 C411 * CT65
*
* 620 Q1208 D1203 # RD9.1ES-T1B R428 # 22k : CHIP
4.7k :CHIP :CHIP 3.22
220 68p 2.7 * 6.7 :CHIP 5 6 7 8

C215 0.022 B:CHIP

E :CHIP K1 C120
0.068
C121
0.068 C116
IC100
HZT33
C114
:CHIP :CHIP 7.2
7.55 R421
220 2.55
1.2
0 (-0.8)
[-0.4]**
(3.6)
0 [3.7] CF60
*
C216
0.22
C214 C218
2SD601A
BUFFER
R1247
R1246
330
:CHIP
R1245
330
:CHIP
R1235
* C1217
D1209
IC401
#
#
RD9.1ES-T1B
LA7910
R429
R430
390 : CHIP
#
180 : CHIP
470 : CHIP
R912 R911 R910 C901 R906 :PT 0.1 C117 100p C410 16V 100
:PT 0 2.8 2.66 27p :CHIP 2.7
8.2k 2.7k 560 470p
:CHIP 4.7k :MPS 100p
9.0 :CHIP R114 :CHIP Q409 L406 R426
150
R432 R434 JR107
* Q417
B:CHIP 2.2 2.2 470
:CHIP C1218 16V J1201 4P 6P R431 # 22k : CHIP
:CHIP :CHIP :CHIP :CHIP :CHIP 470 Q406 2SB709A 6.8µH :CHIP * 470
K2 C122 R119 R120 0.4 :CHIP 3.4 :CHIP * 180p
100 1.8k 330k 2SB709A R419 3.22 C202 C1221 J1202 2P 3P R432 # 470 : CHIP
16V :CHIP :CHIP 0.22 0.47
C900 1k 2.7 Q408 16V JW250 10MM 25V
470p 3.5 0 R113 C115 :CHIP 2SD601A 3.4 2.7 CT55 B:CHIP C1228 JR107 0 : CHIP # R435 # 470 : CHIP
:CHIP 22k 10p 5.5 1
:CHIP :CHIP 3.99 2.55 Q412 Q414 Q416 16V C1219 R1239 JR116 # 0 : CHIP R436 # 22k : CHIP
Q109 * 2SD601A 14 13 12 11 10 9 8 7 6 5 4 3 2 1
S906 S905 S904 Q110 0 0.6 2SD601A R425 R428 R431 R433 * JR116 R436
*
CF55
5.5MHz JR203 B:CHIP JR105 100 4.7
22k 16V JR203 0 : CHIP # R437 # 22k : CHIP

M OUT(R)
R115 Q411 *

TVR
9V 8.9

TVL
* *

B IN(R)
NICAM 8.9 8.9

B OUT(R)

IN R

MON L CREF
2SD601A 390 *

M IN(R)

MON R SCL
IN L

L2
VC AMP Q405

L1

R1
B IN(L)
ST/BY SEL TV/VIDEO VOL - 22k :CHIP * :CHIP
RESPONSE VC-FILTER :CHIP * JW252 # 7.5MM R1204 # 47k : CHIP
3.11 C1223

M OUT(L)
8.9

B OUT(L)
3.4 3.22 8.9

M IN(L)
C413 *
3.4 L403 # 12µH R1207 # 47k : CHIP

TRE(L)
TRE(R)
F TIMER 100 C415 JW252

R OUT
5V R437

L OUT
L403 L404 16V 0.0047 * * L404 # 8.2µH R1213 # 1k : CHIP

SDA

GND
3.4 CF45

GND
0 R415 C409 * * R423 B:CHIP 3.4

9V
D901 3.4 *

R2
* * * 8.9 3.22 8.9 C201
LED 3.11 2.7 3.118.9 R211 0.22 C1225 L405 # 8.2µH R1214 # 470k : CHIP
2.55 R435 3.3k 16V *
C412 :CHIP B:CHIP 15 16 17 18 19 20 21 22 23 24 25 26 27 28 IC201
R914 2 4 R913 R418 * CT45 R429 *
TDA7438B L407 # 15µH R1222 # 1k : CHIP
*

R204 220 :CHIP

R203 220 :CHIP
470 470 * TONE CONT
:CHIP :CHIP
3.7
0
* D402 C209 C210
0.018 0.022
L408 # 1.8µH R1223 # 10k : CHIP
* B:CHIP B:CHIP L409 # 2.2µH R1224 # 10k : CHIP

C207 2.2
C208 2.2
C1222

100 16V
C205 0.47 L411 # 2.7µH R1226 # 39k : CHIP

C204
R212 C206 C203 25V
0 2.7k 0.0022 0.0022 B:CHIP
:CHIP B:CHIP B:CHIP
10 Q403 # UN2216-TX R1234 # 43k : CHIP
Q902 Q404 # UN2216-TX R1235 39k : CHIP 43k : CHIP

BLK
G UN2213 C013 R090 IC001 R058 R054
10k Q405 # 2SB709A R1242 # 1k : CHIP

D305 MA113
0.001 C061 5V
4.0 B:CHIP 10k :CHIP CXP85220A-060S 2.2 16V F:CHIP *
:CHIP
Q407 # 2SB709A R1244 # 100 : CHIP

RD2.2ESB
0

R313 3.3k :CHIP

D311
C060 0(5.0) 5.0

R002 4.7k :CHIP

L001

R003 4.7k :CHIP

C006 R339 Q410 # 2SB709A R1253 1.5k : CHIP 3k : CHIP

R329 0 :CHIP

R328 0 :CHIP

R327 0 :CHIP
C319 0.1 25V B:CHIP
1000p

0.1 25V B:CHIP C320 0.1 25V B:CHIP

1µH

64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
1000p [5.0]5.00 VDD 300
1
B:CHIP R010 B:CHIP :FLR50 C055 R077 C074 :CHIP
0.7(0)

D308 RD2.2ESB
0 1k [0]00 NC 470 100 220p Q411 # 2SD601A SWF401 1-767-663-11 1-760-771-11

MA113
2

D310
17.5MM
25V :CHIP B:CHIP

C305 0.1 25V B:CHIP

JW044
Q903 :CHIP 0.7(0)
[0]00 Q301 R301
C001 R1252 Q412 # 2SD601A

0.1 25V B:CHIP

GND 10k R1250
3

UN2213 O STBYLED/RSP 0.0015 UN2211 R340

D312 RD8.2ESB
820k 3.3k
1.2(0)
[0] 00 B:CHIP
C014 MP 270 R326 :CHIP :CHIP # : Not Used
4

1.2(0)
[0]00

R001 4.7k :CHIP

:CHIP

R004 4.7k :CHIP

3.9k

C359 100 16V

0.001 B:CHIP 0.2

C308
R035 1k :CHIP :CHIP
U/V IC300

17.5MM
5

O LOUDNESS

JW045
[0]00 (0.2)8.8 R076 L301 6.1

D300 MA113
C019 0.001 B:CHIP 1.7(0) C035 0.001 B:CHIP 100 0 8.2µH C306 TDA8375A C301 2.1
O TIMER/ST L/H R325 10
6

0.4(0.3) Q1209

R304 100 :CHIP

R013 R036 1k :CHIP :CHIP C328

R303 100 :CHIP

C056 1000p B:CHIP 1.8(0)
[0]00 [0.2] 0 :FLR50 0.1 C300 C304 JR179
1k :CHIP TSW0 VM 5.33
MUTE C036 0.001 B:CHIP 0 4.1 :CHIP 25V 47 0.1 10 2SD601A 0 :CHIP
7

MA113
R009 C012 100V R302 C1230 FB102

R330 560 :CHIP

B:CHIP

D301
16V 25V
H * * 2.1
TSW1
(0)
[0]00 0.5(4.8) C029 0.001 B:CHIP
8 7 6 5
0 [0] 0 C323
22p
C335
B:CHIP B:CHIP 3.9k 0.1 R1251
1.5 R1253 1.1UH JW161 17.5MM
8

100p
R014 C003 0(5.0) [5.0][0.2]4.8
5.22 C028 0.001 B:CHIP CH:CHIP C344
C307 25V 820k *

CLK
DAT

2.88
* * C072 0.1 X300 B:CHIP

100 :CHIP
C321

100 :CHIP

100 :CHIP
100 :CHIP
AGC II CLK0 :CHIP

100 :CHIP
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32

470 4.9 10 25V

[3.6]

(3.6)0
(4.0)0
38MHz

[0]2.8

(0.6)0

4.00
3.0(0)
[0]00 C047 100p :CHIP

0 :CHIP
B:CHIP

R306

[3.4]
(3.4)

0 (3.6)

(5.3)0
II 5.0 Q303

R305

R312
25V

R307

3.66
R314
IC003

(2.8)0
R008 CLK1

3.66

2.44
C322
C349

[2.8]

[0.5]
2.2k :CHIP C020 0.001 B:CHIP 39.2(0) [0]00 C045 100p :CHIP AT24CO4A C057 2SD601A 10
4

3.66

4.88

3.22
[0]
O SPMUTE II 4.8
DAT0 MEMORY 47p GBFF
R068 C008 R060 330 :CHIP 0 C038 100p :CHIP CH:CHIP C898
100 :CHIP 100p :CHIP BLK 5.0
II DAT1 8.9 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 JW069 R1514 R1515 0.01
C040 R061 1k :CHIP R015 560 :CHIP C037 100p :CHIP 0 20MM 4.7k 100 D1504 100V
0(5.0)[5.0]5.00 YS 0 1SS119

IK

CVBS IN EXT

CALDEC [0]

AUDIO OUT4.4

GND

CVBS-IN INT

MAIN SUPPLY

LUMA IN

C IN 1 (0)

DECOUPLING

SDA[4.8]

SCL

IF V OUT

(0.7)AGC FIL
VCO R FIL.

VCO R FIL.

EXT S IN

S IF IN 4.22
100p :CHIP

PLL IF DEC
:CHIP :PT

G IN 0

R IN

G2.7

B OUT
LUMA IN(3.0)

B IN

ABL
:CHIP

R OUT
IN SW
LUMA OUT
1 2 3 4

0 3.55

3.2PHI1 FIL

0(4.0)
CVBS SW OUT

7.4HOR.OUT

4.0 0.6

0(4.8)
2.4BLK STC

3.7(0)0.5
3.4SECAMOUT

0(3.6)

0(3.4)
2.7PLL
0(3.4)
0(4.9)

0(2.4)

4.8
[4.9]4.99

2.4 4.8
R1513

3.44R-Y IN
0.1 B-Y IN
R062 2.2k :CHIP C018 100p :CHIP T851

OUT
C021 0.001 B:CHIP

TU AGC OUT
0R 10k

EHT/X-RAY
4.43/3.58

VERT. REF

DEC SOUND
VERT. SAW
VERT. NEG
NX-1746

EAST-WEST

VERT. POS
4.00 GND
2.443.58

3.0(3.6)
SECAM TRAP

(3.7)

SSCP/FBT

PHI2 FIL
B-Y OUT
0(5.0)[5.0]5.00 C051 100p :CHIP :CHIP

R-Y OUT
R063 2.2k :CHIP Q1513

(4.6)
0 D1505

10.7
[5.6]
R040 220 :CHIP C1513

(0)
2.6
5.8

4.0
B-INT G

3.6

IF IN
2SD601A

2.6
[0]

DEEMP
IF IN
4.0

[0]
[0]
RD4.7ESB

4.00

1
R072 C042 100p :CHIP 3.2(0)[0]00 R042 390 :CHIP 100 R898

[0]
2.2 6

4.1
0

VCC

[0]
FIL
[0]
3.3k :CHIP V SAW 2.2k

0
MOMUTE B
C022 R025 2.2k :CHIP 0 0 R038 220 :CHIP
I 0.001 B:CHIP 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56
V-PULSE V SYNC R053 2.2k :CHIP
0.3 R338 5
3.3(0)[0]00 R045 2.2k :CHIP C015 56p CH 0 (4.0) 0.8(0)

R311 12k :CHIP

1000p B:CHIP
C064 4.0(0) 0

4.5

3.3
3.1
H SYNC

:CHIP

4.0

[0](3.0)
3.9
1000p

4.1

5.5
[0] :CHIP

[0]
5.8 [4.0] 4.00 [0]

CH:CHIP

R335 10k :CHIP

R332 220 :CHIP

5.0

15p CH:CHIP
3.3(0)[0]00 R021

2200p B:CHIP

4.33
B:CHIP

120k :CHIP 1kR341

L003 JW183 D001

C313 100 16V

4.7k

C361
O AVMULTI EXLC

C341 100p :CHIP

5.0 15µH 10MM :CHIP

X358 3.58MHz 15p C311

3.3(0)[0]00 RD4.7ESB 11

C312
:FLR50 C326 C327 C325

C314
I AVMULTI XLC
12p 10p 10p C316 IC551

C342 0.1 25V B:CHIP

[5.0]5.00 5.0

C310 0.1 25V B:CHIP

0(5.0) R018 220 :CHIP C016 56p CH C331 R321 C336 LA7830

R571 220 :CHIP

:CHIP :CHIP :CHIP 4700p

C340 10000p B:CHIP

O 3DMUTE VDD 10 39k 10
*(0.3) B V-OUT BOOST

C309 0.1 25V B:CHIP

C024 R855

R308 220 :CHIP

R016

X443 4.43MHz
3.1 (0)
[0]00 [0.6] C027 :RN-CP 12

R309 220 :CHIP

C376

R318
0.001 B:CHIP O +BDROP 5.99
X-RAY 0.001 1k C324 0.47 C334 1k

R310 100k :CHIP

C050 V.OUT 1/2W

C333 0.1 25V B:CHIP

C023 3.2(0)[0]00 1.9(0.1) B:CHIP :CHIP C332 2.2 16V 3300p R336 C337

R360 4.7M :CHIP

R033 1 100 -0.9 :RC

UDZ-TE-17
0.001 SW1 BRT ABL C315 0.1 16V B:CHIP B:CHIP 2.2k
1k B:CHIP 0(4.9)[4.9] 0.47 :MPS F:CHIP :CHIP 16V 13
:CHIP 5.0 C049 0.1 25V B:CHIP K1 R071 R331 16V L850

D399
R322 27k :CHIP
SW2 4.99 KEY1
R048 100 :CHIP 330 680k B:CHIP 1 2 3 4 5 6 7 2.2mmH
R026 2.2k :CHIP 0(0.3) [0.3] 0(5.0) [5.0] K2 :CHIP :CHIP C338 R319 R320 7 :EL0606
H SYNC 0.33 KEY2 -0.4

RD9.1ESB
0.47 1.2M 27k 0.4 14.0 -13.0
R031 1k :CHIP 0(4.4) [4.4] 0(0.3)0.77 C026 C362 16V :CHIP :CHIP

D315
SIRCS 4.44 0(2.8) 0.001 R047 C552
J C053
1000p
R041 100 :CHIP 48.5(0)
HD SW
[0]00[2.8]2.88
VC
B:CHIP
C048
0.1 25V B:CHIP 100 :CHIP
D005 C329
C330
0.1
22p
CH:CHIP
B:CHIP 100
35V 8 FV
B:CHIP
[1.0] 1.8(0)
0(1.0) [0]00 C017 100p :CHIP C046
RD5.1ESB 0.0039 25V R554 C555 JW145
TV SYNC 4.99
[5.0] 100p B:CHIP B:CHIP 10p 7.5MM D551
[5.0] 0(5.0)
0(5.0) X101 :CHIP 8V 1000P
B:CHIP 500V GP08D 9
ITTRESET 5.00

JW144
7.5MM
RESET
R028 100 :CHIP 0(4.9)
[4.9] 0(2.2) CAS/4HG
R315 0 :CHIP C554
V.DRIVE C856
IC004 STBY 4.99 [2.2] 2.22
EXTAL 220p 0.001
SBX1981 C058 0(5.0) 500V 500V 10
B
1R-DET 100p
:CHIP [5.0]5.00 0(2.4)[2.4]
2.44
XTAL R057
1k
B
C551
0 4.9 GND 0 [5.0]
(5.0) 5.00
BINTRDY :CHIP 100
C025 R355 D306
C501 35V D855 R853 2
C059 0.001
5V 10 :CHIP D307 C548 470p RGP10G 0.47
1 2 B:CHIP 1SS119 1SS119 500V -13V
D003 MA113

100p C044 0.1 -13V-RECT :FPRD

:CHIP R560 JR050 100V B
3 100p 5.0 R334 0 :MPS DF
R012 :CHIP R007 470 0 4
C009 10k JR101 Q302 :CHIP :CHIP R556 C553 C850
47 :CHIP 5.0
5

R351 0 2SD601A :CHIP R555 470

K 470p 1k 0.0068
L78LR05D-MA

C011 :CHIP C002 C052 L002 10 :CHIP 10k :CHIP B:CHIP 25V
47
4

22 0.1 10µH :CHIP C370 R552 R553 R570 D853

20
5V-REG

16V R029 D008 S REF S IN 3

1
25V
IC002

5V

4.7k C010 :ALI 0.1 R316 150k 22k 0 R561 RGP10G

5.8
3

RD5.6ESB2 0.022 B:CHIP 25V :CHIP :CHIP :CHIP 2.2k

:CHIP
B:CHIP B:CHIP 4.7k
JW073 15V-RECT
11V :CHIP

19
TEST SYNC
2

2
D513 12.5MM
C854 1 4 H1
Q030 D002 RD5.1ESB R854

16
+5V R-Y IN
1

470

1
2SD601A 1SS119 C034 0.47 GND

18
N.C. N.C. 25V 3

3
0.1 C375 C367 R817 :FPRD
BLK 5.0 0.1 C007 15.7 25V 47 1.4 0.1 D591 JW(5) C853 200V

15
N.C. N.C. 25V R883 2

2
0.47 B:CHIP 1SS119 R557 0.001

17
B:CHIP N.C. N.C. 1M

4
X-RAY :CHIP 1.8k 500V 1 1000V
R019 C054 R317 :CHIP B

14
GND B-Y IN

3
0.1 C004 150k 1000p 1k

16
+8V N.C.

5
2.2 :CHIP B:CHIP 1.4 C368 C350 :CHIP Q561 C801
CN851
0.1 47 16V 2SA1091R JR052 L821 4P

13
I.C. N.C. 25V N.C. 33 HV

4
0 10mmH WHT
X-RAY

15
B:CHIP GND :CHIP 160V

6
0.5 :HR :MINI
L R825

12
SYNC B-Y OUT

5
C812 8.2

14
R356 D858 TO C BOARD

7
3.0 R820 0.012 R803 :FPRD
1k C358 C351 IC354 1.5k 1.2kV 2.2k GP08D

11
:CHIP N.C. R-Y OUT TDA8395T CN701

6
0.1 0.1 :RN-CP :PP :CHIP H.CENT-2
1.2

13
R563 C562

8
[0.9] 3.0 25V 25V SECAM 180k 113.8 100
B:CHIP B:CHIP 2 R851

10
I.C. GMD 16V C809 H CENT R857

7
R017 R564 C820 D801 1.2

12
B-Y OUT 5 6 7 8 330p 56k

9
R619 2.2k 1000p ERC06-15S 1 3 :FPRD
GND

56k
+20V

D601 0.47 JW062 :CHIP :CHIP R566 2kV 2kV S801

RBV-406H T601 I.C. +5V B

9
D613 15MM 0.6 0.6 11.4 4

113.3
R131 4.7k C810 R821 D851 C860

10

11

JW(5)
AC-RECT SRT C369 R-Y OUT

R884
R601 JW197 JW(15) 18k 0.1 R562 0 :CHIP IC801 0.0082 100 RGP10G 470p R816
1.2 15MM 2W 25V D351 C352 1.5k R565 µPC4558G2-E1 C808 200V R823 C825 2W
200V-RECT 500V 33k
10W R611 1 18 R521 :RS IC351 B:CHIP GP08D 0.22 :FPRD 56k
PIN-AMP
0.039 :PT 2.2k 0.01 C821 :RS B
:RB C605 C606 R617 1k TDA4665T 16V :CHIP 400V 1/4W
R602 4700p 4700p C604 15k 0.1
C613 JW170 :CHIP 5VSOP B:CHIP
D561 :PP D802
C807
:FPRD
200V 0.1 D857
1.2 10W :RB 500V
330 3W 1/2W R858 1SS119 5.5 1.5 3.2 1.2 :PT 200V
E
500V 400V :RS :RF 470p 1.1UH C374 1.2 R569 ERD29-08J 200V :PT GP08D
R606 E 47 2W 150k :PP H.CENT-1
470 C603 2 17 4 4.9 :RS 4 3 2 1
M 3W
:RS 4700p
500V
E
R622
0.22
2W
JW124
7.5MM
R613
0.47
RN4Z
FB603
D606 1.1UH
C614
2200
25V
1
I O
2
2 1 L807
L805
HLC
C822 1.0 200V :PP
R852
1k
D852
RGP02
C852
0.0047
R860
220k
C861
33 C857 R856
DGC 1 JW204 10MM
:RB R610 3 16 G R834 R882 3 390µH
L808 :FPRD 1000V-RECT 2kV 250V 0.033 10k
THP601 C607 JW196 R623 15k C611 4700p C631 C632 R612 9V SG801 C816 B :MPS
DGC 2 4700p 15MM 100 3W 470p 470p 0.47 D605 FB251
1.1UH
3 10k
:CHIP
2.7k
:CHIP L804 4 1 10 R831 2.2mmH
RN4Z C523 L802

A
3 1 500V C627 :RS 250V 500V E
250V 100 15µH 3.3mmH R802 160V 100 2W :RS
DGC 3 E 680p B B 4 15
R618 IC521 16V JW082 R881 2.2 TU,MEMORY,IF,Y/C JUNGLE,H/V OUT
C602 JW134 10MM 2kV FB610 R615 0.47 C610 PQ09RF11 5MM 560 R826 :FPRD
CN602 4700p 2 B R636 0.45UH 4.7 C612 2200 :CHIP 2.7k 15.8 POWER SUPPLY,AUDIO/VIDEO INPUT
2P 500V 15k 3W :RS 470p 500V B 25V
1

C C633 :CHIP 0.6

:MINI E 5 14
1 4 228.6 1000p C628 D604 JW189 R812
3kV 470p :CHIP RU4AM
T605 7.5MM 12k R832
DGCT 1 GND E +B-RECT
2

LFT :CHIP R827 2.2k

13 0
DGCT 2 2 3 D609 C618 82k :CHIP
R629 33

D1NL20 C624 470p C619 FB601 C609 :CHIP

1000 B:CHIP 680p 1.1UH 100
B
3

CN603 16V 2kV 160V

N 2P WHT :MINI
C621
0.1
250V
0 C623
220
16V
D610
7 12 B R632
1
R801
3.3k
R828
3.9k
:CHIP C823
Q821
2SD2061-E
PIN-OUT C875
:MPS
SINK D1NL20 3W 0.01
4

C608 470p 2kV R :RS T801 B:CHIP C891 47

0 D607 8 11 HDT 680p 100V
D1NL20 R608 B:CHIP
S601 JW(5) IC602 0 Q802
DRIVE
5

CN601 :PUB 9 10 SE115N 3 5 1 4 2SD1878

C616
STR-S6707N

3 1 0 R624 ERROR-AMP H.OUT

2P 18 2W :RS 470p 500V B C802 5 R811 R808 R829 R895
REG-IC

0
JW(5) -0.1
IC601

WHT OCP IC603 3 2 1 0.01 0.33 1.5k R822 C876 1

6

:VH 200V 1 4 0.068

C111 D103 R625 PC123F2 C806 :PT 3 6 1W
:RS FB801 :CHIP 270
1W 100V 1W
:RS
4 2
1000p
DA204K 0 3.9k 228.4 FEEDBACK Q801
1 2SC3209LK 1.1UH :RS :MPS
AC IN 2 B:CHIP
D611 D1NL20 96.0 114.1 58.0
F/B D860 H-DRIVE
7

F601 3 2
1SS119 C805 C811
AC IN 1 R614 0
96.7

3.15A 0 R626 22k 1W :RS PROTECT 220p 0.001

1.8k 7.4 500V 500V
O INH B B
8

50/60Hz 4 1
R804 R805 C804

DY
C634 R627 C630 0 R809
0 470p 1k 1k 22k 0.001 2.2k
110-240V AC B:CHIP R616
470p
250V C622 :CHIP :CHIP B:CHIP 1/2W
V-IN 8.2M B 0.047 :FPRD
9

C625 200V
7.9 FB612 0.001 1W :PT
1.1UH R628 B :RN
1k
GND 3
NC 2
+B 1

1
2

6
5
4
3
2
1
+
-
-
-
+
+
VM OUT
CN609
3P CN111

V
V
H
H
H
H
GND
RED 2P CNDY1
:S-MICRO YEL
TO VM BOARD :S-MICRO 6P H.DY H.DY V.DY V.DY
CN1701 1 2 3 PIN TO VM BOARD
P CN1701 7 8 PIN

– 29 – – 30 – – 31 – – 32 –
 PRINTED WIRING BOARD
C [RGB OUT] (vm) [VM OUT]

– C BOARD – – VM BOARD –

(2) Schematic Diagrams of C and VM Boards

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27

A NECK ASSY
VM

C[RGB OUT] R701

JW(15MM)
RV701
2.2M
R702
680k
1/2W G2 1/2W

R703
1000V

C701
L701
22µH
:EL0607

C704
0.022
1
2
3
1000V
200V
GND
VM
400V
FV FOCUS
G4 1
100k
1/2W
0.0047
2kV
E
:PP 4 H1 CN1701
8P
BLK
(VM OUT)
11 G2 2 CN701 :S-MICRO
B 1
J701
3
G1-1 R705 4P
VM
10
RCV SOCKET 4 3 2.2 WHT +B 1 E
13 5 H1 3W :MINI
:RS (1) NC 2 Q1766 Q1767
6 H2 4 TO A BOARD 2SC3311A 2SC3733-T
H.STAT GND 3 9V VM AMP VM AMP
11 7 G1-2 CN851
9V 4
G1-3 10 9.4
C702
1000p 1 9
KR 9 8 KB 5 4 (2) VM MUTE 5 C1772 Q1762 R1777 R1780 R1788
1.5k
B 100 L1762 R1791 56k 1.2k R1783 R1786
8 KG 6
GND 6 16V 39µH 2SA1309A 330 JW(5MM) 33k
7 :FLR50 D1761 R1784 SLICE AMP 8.4 5.5 C1776 1.8 R1790
1SS119 100 10 120
VIDEO 7 7.8 5.4
C (3)
GND 8 3.9
9.1
D1764 D1763 C1771 1.5 4.7
2W
:RS
2 3 R711 1SS119 1SS119 10 Q1764
R715 R713 6.8k Q1761
R734 6.8k 6.8k 1/2W TO A BOARD 2SC3311A R1766 4.6 2SC3311A 1.1
100 1/2W 1/2W L703 CORING AMP
1/2W JW(5mm) R1762 VM AMP 1.2k R1768 R1770 R1787 R1789
(1)CN609 220 2.2k 33k 0.9 8.2k 470
L705 (2)CN102 3.2 R1778 R1781 C1751
L707 JW(5mm) R1736 12k 270 0.01
JW(5mm) (3)CN111 1.5k :MPS
200V C1780
10
R714 R712 R1774
6.8k R710 150
6.8k 6.8k
D 3W
:RS R 3W
:RS G 3W
:RS
B A51JUH71X C1764
100
16V
C1770
3W
:RS
R1851
10
0.1
C746 C736 C737 R1769 Q1763 200V Q1765
C703 470p
B
470p
B
470p
B C1761 1.8 2SA1837 :PT 2SC4793 R1782 R1785
4.7 L706 L704 L702 L1761 :FPRD VM DRIVE1 1.8
250V JW(5) JW(5) JW(5) KG KB G2 47µH 0.0047
115 VM DRIVE2 :FPRD 39
:FPRD
:FLR50 500V 59
D703 D702 D701 E R1812
1SS119 1SS119 R1775 4.7k
1SS119 R1764 1k 59 1.1 C1775 0
R1728 39 C1763 :FPRD 100
Q705 Q704 V901 10k R1721 L1723 R1722 1/2W 33 D1767 D1768 16V
Q706 2SC2611 560 6.8µH 390 :FPRD 160V 115 MTZJ-39B MTZJ-39B 0.6
2SC2611 G AMP 2SC2611 H PICTURE L1721 L1722 Q1722 5.9 :FLR50 DC BIAS
DC BIAS
147.8

B AMP 2 150µH 330µH 2SC3311A

E R AMP 2 151.4 2 159.9 TUBE R1732
10µ :FLR50 :FLR50 2.5 1.9 1.2 0.7
JW(5MM)

Q709 R762 151.1 Q707 R760 C1722 0

R761

3 2SA10910 JW(5MM) 3 156.2 3 2SA10910 JW(5MM) 560p R1765 R1772 R1776 R1779
R OUT D708 B OUT 145.1 B 560 18k C1778 C1779 18k 560 Q1777
159.8 0.001 0.001 2SC2611
8.9 1 8.3 1SS119 8.8 1 8.4
8.9
1 8.3 C1724 R1727 R1724 Q1723
1.1
R1723
:FPRD :PT :PT DRIVE SW
PROTECT
D709 Q708 D707 CV KR G1 G4 HV 27p 3.3k R1725 1.8 150 2SC3311A 150
7.1

1SS119 151.0 7.1 2SA10910 R722 1SS119 151.1 7.5 390 C1768
0.047
C1769
2.2
C1773
0.047
PROTECT R724
1k
G OUT 1k PROTECT R720
1k
0 200V 160V 200V
:FPRD :FPRD :FPRD R1753 0 :PT :PT
C710 C709 C708 27k
470p R723 D712 470p R721 470p D710 Q1756
B 270k 1SS119 B 680k D711 B R719 1SS119 T0 A BOARD FBT 2SC3311A
:RN 1SS119 300k
F :RN PROTECT PROTECT :RN PROTECT
CN704 AMP
TAB(CONTACT) 0
1 GND

C BOARD WAVEFORMS
8.4 R727 2.1 8.4 R726 2.4 8.4 R725
Q712 1.5k Q711 1.5k Q710 1.5k
2.4

2SC2785 2SC2785 R756

2SC2785
G R DRIVE G DRIVE B DRIVE
1.8

1.6 1.2k 1.8

C714 R729 C713 R728 C712
R730 680p R757 180 680p 150 680p R755
180 B 1.2k B B 1.2k
R733 CN703
R732 R731 6P
33 33 33 WHT
:S-MICRO
JW701
5MM
R G B
1 IK
H D717
RD9.1ESB
D716
1SS119 C717
47p 2 GND
SLICE PROTECT
3 9V
R738 100
C716 4 B IN
100 R739 100
5 G IN
R740 100
6 R IN
TO A BOARD
CN103
I

Schematic diagram Schematic diagrams

H (a) board (c), (vm) boards G
– 33 – – 34 – – 35 – – 36 –
6-4. SEMICONDUCTORS

IC TRANSISTOR

AT24C04A-10PC-B PC123F2 UN2211 2SC3209LK

TDA7438D UN2213 2SC3733-T
µPC4558G2 (8PIN) 4 UN2216
3 2SB709A-QRS
2SD601A-Q
1
2 C

B
1 PQ09RF11 E
TOP VIEW
E C
Small Outline L-leaded Package B
Pin 8 ∼ 98
2SA1091-O
2SA1091-R 2SD1878-CA
CAT24C04P
CXP85220A-060S
TDA4665T
TDA8375A 12
34
TDA8395

SBX1981-11
E C
1 B B
TOP VIEW
C
Dual In-line Package 2SA1309A-QTA E
Pin 6 98
2SC2410SN
2SC2785-HFE 2SD2061-E
LA7830 2SC3311A-QRS-TA

STR-S6707N (9PIN) LETTER SIDE

MARKING SIDE VIEW

1
23
45 B C
67 E

LA7910 (9PIN) E C
B
1
Zip-zag In-line Package
Pin6∼99 
2SA1837

SE115N

1
2
3
B
C E
L78LR05D-MA
1 2SC2611
2 3

LETTER SIDE
TA8248K

1
E C B

– 37 –
DIODE

DA204K MA113-(TX)
UDZ-TE-17-9.1B
3

2
1
3

ANODE
2
1
CATHODE

D1NL20-TA2
EL1Z MA77-TX
GP08D
RGP02-17EL-6433 ANODE
RGP10GPKG23

CATHODE

CATHODE

MTZJ-T-77-39B
RD.2.2ES-B1
ANODE RD.4.7ES-B1
RD.5.1ES-B1
RBV-406H RD5.6ESB2
RD8.2ES-B2
RD9.1ES-B1
1SS119-25
＋

CATHODE

ERC06-15S ANODE
RU4Z

CATHODE

ANODE

ERD29-08J
RU4AM-T3

CATHODE

ANODE

HZT33-02TE

CATHODE

ANODE

– 38 –
 SECTION 7
EXPLODED VIEWS The components identified by
shading and mark ¡ are criti-
NOTE: • The construction parts of an assembled cal for safety.
part are indicated with a collation number Replace only with part number
• Items with no part number and no in the remark column. specified.
description are not stocked because they
are seldom required for routine service. • Items marked " * " are not stocked since
they are seldom required for routine
service. Some delay should be
anticipated when ordering these items. 31
7-1. CHASSIS

: 7-685-648-79 +BVTP 3X12 ■

: 7-685-663-71 +BTP 4X16
■
20

29 9
8
35 ● 23
34
30
11 17

34 35 12
36 19
●
38 16 18
32
15
10 14
6 ● 13

11 24
7 ● 9
8 33
35 ●
34 25

3 26

34 37
28
5 21 27
4 35
22
2
1

REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
1 4-062-935-01 DOOR, CONTROL (J21MF2J) 20 X-4035-299-1 COVER ASSY, REAR (2199M5J) 19
4-062-937-01 DOOR, CONTROL (2199M5J) 21 * 4-055-548-01 GUIDE (L), PWB
2 X-4035-298-1 BEZNET ASSY (2199M5J) 3-7 22 * 4-055-549-01 GUIDE (R), PWB
X-4035-381-1 BEZNET ASSY (J21MF2J) 3-7
3 4-047-464-01 CATCHER, PUSH 23 3-704-372-01 HOLDER, HV CABLE
24 8-598-323-10 TUNER BT-AG401
4 4-055-546-31 BUTTON, POWER 25 ¡ 1-453-250-11 TRANSFORMER ASSY, FLYBACK
5 4-036-405-11 SPRING, COMPRESSION (NX-1746//M3A)
6 4-060-144-01 BUTTON, MULTI 26 * A-1298-433-A A BOARD, COMPLETE (2199M5J)
7 * 4-060-143-01 GUIDE, LIGHT * A-1298-434-A A BOARD, COMPLETE (J21MF2J)
8 4-052-433-01 CUSHION, SPEAKER
27 ¡ 4-389-778-01 HOLDER, AC CORD
9 1-503-902-11 SPEAKER (15X6.5 CM) 28 ¡ 1-574-062-11 CORD, POWER (WITH CONNECTOR)
10 4-372-556-11 SHEET, BLOTTING 2.5A/250V
11 4-057-862-01 SCREW, TAPPING 5+CROWN WASHER 29 1-452-032-00 MAGNET,DISK ; 10mmø
12 4-046-600-01 SPACER, DY 30 4-051-736-21 PIECE A(90), CONV. CORRECT
13 ¡ 8-738-774-05 PICTURE TUBE 21PXD(SDS) (A51JUH71X) 31 4-049-130-01 CLAMPER, CORD

14 ¡ 8-451-280-33 DEFLECTION YOKE (Y21PXA2) 32 * A-1342-405-A VM BOARD, COMPLETE

15 1-452-277-00 MAGNET, BMC 33 1-900-212-58 LEAD ASSY, FOCUS
16 * A-1331-748-A C BOARD, COMPLETE 34 4-374-745-21 CUSHION (A)
17 4-369-318-00 SPRING, TENSION 35 4-302-404-03 SCREW (WASHER HEAD) (+P 4X16)
18 ¡ 1-409-942-11 COIL, DEMAGNETIZATION 36 ¡ 1-452-509-51 NECK ASSY, PICTURE TUBE (NA308)

19 4-049-416-01 SHEET, BLIND 37 4-063-543-01 SPACER

20 X-4034-787-1 REAR COVER ASSY (J21MF2J) 19 38 4-612-010-01 WASHER, FIBER

– 39 –
 Les composants identifies par The components identified by
SECTION 8 une trame et une marque ¡ shading and mark ¡ are criti-
sont critiques pour la securite. cal for safety.
ELECTRICAL PARTS LIST
(a)
Ne les remplacer que par une Replace only with part number
piece portant le numero specifie. specified.

NOTE:
• The components identified by in thisNO.manual

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. PART NO.WhenDESCRIPTION REMARK
indicating parts by reference number,
------------ -------------
The components -------------------
identified by -------------
have been carefully factory-selected ------------
for each -------------
set ------------------- -------------
shading and mark ¡ are criti- in order to satisfy regulations regarding X-ray please include the board name.
cal for safety. radiation. Should replacement be required,
Replace only with part number replace only with the value originally used.
specified. • CAPACITORS
PF : µµ F
• Items marked " * " are not stocked since they are
seldom required for routine service. Some delay • There are some cases the reference number on
should be anticipated when ordering these items. one board overlaps on the other board. Therefore,
when ordering parts by the reference number,
• All variable and adjustable resistors have please include the board name.
characteristic curve B, unless otherwise noted.
RESISTORS
• All resistors are in ohms
• F : nonflammable
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
* A-1298-433-A A BOARD, COMPLETE (KV-2199M5J) C052 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
********************* C053 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V

* A-1298-434-A A BOARD, COMPLETE (KV-J21MF2J) C054 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
********************* C055 1-124-480-11 ELECT 470MF 20% 25V
C056 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
* 4-049-131-01 CASE (A), SHIELD C057 1-163-243-11 CERAMIC CHIP 47PF 5% 50V
4-382-854-11 SCREW (M3X10), P, SW (+) C058 1-163-117-00 CERAMIC CHIP 100PF 5% 50V

C059 1-163-117-00 CERAMIC CHIP 100PF 5% 50V

<CAPACITOR> C060 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
C061 1-164-505-11 CERAMIC CHIP 2.2MF 16V
C001 1-163-011-11 CERAMIC CHIP 0.0015MF 10% 50V C064 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
C002 1-126-965-11 ELECT 22MF 20% 50V C072 1-124-480-11 ELECT 470MF 20% 25V
C003 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
(J21MF2J) C074 1-163-001-11 CERAMIC CHIP 220PF 10% 50V
C004 1-126-961-11 ELECT 2.2MF 20% 50V C101 1-163-017-00 CERAMIC CHIP 0.0047MF 10% 50V
C006 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C103 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
C105 1-104-665-11 ELECT 100MF 20% 16V
C007 1-126-959-11 ELECT 0.47MF 20% 50V C106 1-126-964-11 ELECT 10MF 20% 50V
C008 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C009 1-163-133-00 CERAMIC CHIP 470PF 5% 50V C108 1-126-767-11 ELECT 1000MF 20% 16V
C010 1-163-037-11 CERAMIC CHIP 0.022MF 10% 50V C109 1-163-017-00 CERAMIC CHIP 0.0047MF 10% 50V
C011 1-126-967-11 ELECT 47MF 20% 16V C111 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
C114 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C012 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C115 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50V
(J21MF2J)
C013 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C116 1-136-165-00 FILM 0.1MF 5% 50V
C014 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C117 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C015 1-101-884-00 CERAMIC 56PF 5% 50V C118 1-126-965-11 ELECT 22MF 20% 50V
C016 1-101-884-00 CERAMIC 56PF 5% 50V C119 1-164-232-11 CERAMIC CHIP 0.01MF 10% 50V
C120 1-130-493-00 MYLAR 0.068MF 5% 50V
C017 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C018 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C121 1-130-493-00 MYLAR 0.068MF 5% 50V
C019 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C122 1-104-665-11 ELECT 100MF 20% 16V
C020 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C124 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C021 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C125 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C127 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C022 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
C023 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C128 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C024 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C132 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C025 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C201 1-164-489-11 CERAMIC CHIP 0.22MF 10% 16V
C026 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C202 1-164-489-11 CERAMIC CHIP 0.22MF 10% 16V
C203 1-126-964-11 ELECT 10MF 20% 50V
C027 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
C028 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C204 1-104-665-11 ELECT 100MF 20% 16V
C029 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C205 1-164-161-11 CERAMIC CHIP 0.0022MF 10% 50V
C034 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C206 1-164-161-11 CERAMIC CHIP 0.0022MF 10% 50V
C035 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C207 1-126-961-11 ELECT 2.2MF 20% 50V
C208 1-126-961-11 ELECT 2.2MF 20% 50V
C036 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V
C037 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C209 1-163-024-00 CERAMIC CHIP 0.018MF 10% 50V
C038 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C210 1-163-037-11 CERAMIC CHIP 0.022MF 10% 50V
C040 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C213 1-163-024-00 CERAMIC CHIP 0.018MF 10% 50V
C042 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C214 1-126-961-11 ELECT 2.2MF 20% 50V
C215 1-163-037-11 CERAMIC CHIP 0.022MF 10% 50V
C044 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C045 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C216 1-164-489-11 CERAMIC CHIP 0.22MF 10% 16V
C046 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C217 1-164-489-11 CERAMIC CHIP 0.22MF 10% 16V
C047 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C218 1-126-961-11 ELECT 2.2MF 20% 50V
C048 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C220 1-126-965-11 ELECT 22MF 20% 50V
C233 1-126-967-11 ELECT 47MF 20% 16V
C049 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C050 1-126-960-11 ELECT 1MF 20% 50V C234 1-126-967-11 ELECT 47MF 20% 16V
C051 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C235 1-104-665-11 ELECT 100MF 20% 16V

– 40 –
 The components identified by Les composants identifies par
shading and mark ¡ are criti- une trame et une marque ¡
cal for safety. sont critiques pour la securite.

(a)
Replace only with part number Ne les remplacer que par une
specified. piece portant le numero specifie.

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
C236 1-124-484-11 ELECT 220MF 20% 35V C370 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C237 1-104-665-11 ELECT 100MF 20% 16V C374 1-124-910-11 ELECT 47MF 20% 50V
C238 1-136-167-00 FILM 0.15MF 5% 50V C375 1-124-910-11 ELECT 47MF 20% 50V
C376 1-107-823-11 CERAMIC CHIP 0.47MF 10% 16V
C239 1-104-665-11 ELECT 100MF 20% 16V C402 1-164-232-11 CERAMIC CHIP 0.01MF 10% 50V
C240 1-136-167-00 FILM 0.15MF 5% 50V
C241 1-126-942-61 ELECT 1000MF 20% 25V C403 1-126-965-11 ELECT 22MF 20% 50V
C242 1-164-232-11 CERAMIC CHIP 0.01MF 10% 50V C405 1-163-017-00 CERAMIC CHIP 0.0047MF 10% 50V
C243 1-126-964-11 ELECT 10MF 20% 50V C406 1-163-017-00 CERAMIC CHIP 0.0047MF 10% 50V
C407 1-163-017-00 CERAMIC CHIP 0.0047MF 10% 50V
C244 1-126-942-61 ELECT 1000MF 20% 25V C408 1-163-017-00 CERAMIC CHIP 0.0047MF 10% 50V
C246 1-126-964-11 ELECT 10MF 20% 50V
C247 1-126-942-61 ELECT 1000MF 20% 25V C409 1-163-243-11 CERAMIC CHIP 47PF 5% 50V
C252 1-126-961-11 ELECT 2.2MF 20% 50V (J21MF2J)
C253 1-104-665-11 ELECT 100MF 20% 16V C410 1-163-237-11 CERAMIC CHIP 27PF 5% 50V
C411 1-163-113-00 CERAMIC CHIP 68PF 5% 50V
C254 1-163-023-00 CERAMIC CHIP 0.015MF 10% 50V C412 1-163-113-00 CERAMIC CHIP 68PF 5% 50V
C255 1-163-023-00 CERAMIC CHIP 0.015MF 10% 50V (J21MF2J)
C257 1-136-167-00 FILM 0.15MF 5% 50V C413 1-104-665-11 ELECT 100MF 20% 16V
C258 1-136-167-00 FILM 0.15MF 5% 50V
C300 1-126-967-11 ELECT 47MF 20% 16V C414 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
(J21MF2J)
C301 1-126-964-11 ELECT 10MF 20% 50V C415 1-163-017-00 CERAMIC CHIP 0.0047MF 10% 50V
C304 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C416 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C305 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V (J21MF2J)
C306 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C417 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C307 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V (J21MF2J)
C418 1-163-131-00 CERAMIC CHIP 390PF 5% 50V
C308 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V (J21MF2J)
C309 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C310 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C419 1-163-117-00 CERAMIC CHIP 100PF 5% 50V
C311 1-163-231-11 CERAMIC CHIP 15PF 5% 50V (J21MF2J)
C312 1-163-231-11 CERAMIC CHIP 15PF 5% 50V C420 1-126-967-11 ELECT 47MF 20% 16V
C422 1-163-263-11 CERAMIC CHIP 330PF 5% 50V
C313 1-104-665-11 ELECT 100MF 20% 16V (J21MF2J)
C314 1-164-161-11 CERAMIC CHIP 0.0022MF 10% 50V C423 1-163-263-11 CERAMIC CHIP 330PF 5% 50V
C315 1-107-823-11 CERAMIC CHIP 0.47MF 10% 16V C424 1-163-133-00 CERAMIC CHIP 470PF 5% 50V
C316 1-102-125-00 CERAMIC 0.0047MF 10% 50V (J21MF2J)
C319 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C501 1-102-228-00 CERAMIC 470PF 10% 500V
C320 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C523 1-104-665-11 ELECT 100MF 20% 16V
C321 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C548 1-106-220-00 MYLAR 0.1MF 10% 100V
C322 1-216-295-91 SHORT 0 C551 1-126-968-11 ELECT 100MF 20% 35V
C323 1-163-235-11 CERAMIC CHIP 22PF 5% 50V C552 1-126-968-11 ELECT 100MF 20% 35V
C324 1-164-505-11 CERAMIC CHIP 2.2MF 16V
C553 1-163-019-00 CERAMIC CHIP 0.0068MF 10% 50V
C325 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50V C554 1-102-244-00 CERAMIC 220PF 10% 500V
C326 1-163-229-11 CERAMIC CHIP 12PF 5% 50V C555 1-101-804-00 CERAMIC 10PF 5% 500V
C327 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50V C562 1-104-665-11 ELECT 100MF 20% 16V
C328 1-164-232-11 CERAMIC CHIP 0.01MF 10% 100V C602 1-161-830-00 CERAMIC 0.0047MF 500V
C329 1-163-016-00 CERAMIC CHIP 0.0039MF 10% 50V
C603 1-161-830-00 CERAMIC 0.0047MF 500V
C330 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C604 1-117-752-11 ELECT(BLOCK) 330MF 20% 450V
C331 1-126-964-11 ELECT 10MF 20% 50V C605 1-161-830-00 CERAMIC 0.0047MF 500V
C332 1-136-165-00 FILM 0.1MF 5% 50V C606 1-161-830-00 CERAMIC 0.0047MF 500V
C333 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C607 1-161-830-00 CERAMIC 0.0047MF 500V
C334 1-164-182-11 CERAMIC CHIP 0.0033MF 10% 50V
C608 1-104-332-11 CERAMIC 470PF 10% 2KV
C335 1-102-973-00 CERAMIC 100PF 5% 50V C609 1-124-347-00 ELECT 100MF 20% 160V
C336 1-126-964-11 ELECT 10MF 20% 50V C610 1-126-943-11 ELECT 2200MF 20% 25V
C337 1-104-665-11 ELECT 100MF 20% 16V C611 ¡ 1-117-697-11 CERAMIC 470PF 10% 250V
C338 1-107-823-11 CERAMIC CHIP 0.47MF 10% 16V C612 1-102-228-00 CERAMIC 470PF 10% 500V
C339 1-163-121-00 CERAMIC CHIP 150PF 5% 50V
C613 1-102-824-00 CERAMIC 470PF 5% 50V
C340 1-164-232-11 CERAMIC CHIP 0.01MF 10% 50V C614 1-126-943-11 ELECT 2200MF 20% 25V
C341 1-163-117-00 CERAMIC CHIP 100PF 5% 50V C616 1-102-228-00 CERAMIC 470PF 10% 500V
C342 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C618 1-163-005-11 CERAMIC CHIP 470PF 10% 50V
C344 1-126-964-11 ELECT 10MF 20% 50V C619 1-162-116-00 CERAMIC 680PF 10% 2KV
C349 1-126-964-11 ELECT 10MF 20% 50V
C621 ¡ 1-104-705-51 FILM 0.1MF 20% 250V
C350 1-126-967-11 ELECT 47MF 20% 16V C622 1-106-383-00 MYLAR 0.047MF 10% 200V
C351 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C623 1-126-934-11 ELECT 220MF 20% 16V
C352 1-164-489-11 CERAMIC CHIP 0.22MF 10% 16V C624 1-107-884-11 ELECT 1000MF 20% 16V
C358 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C625 1-102-074-00 CERAMIC 0.001MF 10% 50V
C359 1-104-665-11 ELECT 100MF 20% 16V
C627 1-162-116-00 CERAMIC 680PF 10% 2KV
C361 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V C628 1-163-133-00 CERAMIC CHIP 470PF 5% 50V
C362 1-163-235-11 CERAMIC CHIP 22PF 5% 50V C630 ¡ 1-117-697-11 CERAMIC 470PF 10% 250V
C367 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C631 1-161-830-00 CERAMIC 0.0047MF 500V
C368 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V C632 ¡ 1-117-697-11 CERAMIC 470PF 10% 250V
C369 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
C633 1-161-754-00 CERAMIC 0.001MF 10% 3KV

– 41 –
 Les composants identifies par The components identified by
une trame et une marque ¡ shading and mark ¡ are criti-
sont critiques pour la securite. cal for safety.

(a)
Ne les remplacer que par une Replace only with part number
piece portant le numero specifie. specified.

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
C634 1-163-005-11 CERAMIC CHIP 470PF 10% 50V CF65 1-567-101-11 FILTER, CERAMIC (J21MF2J)
C801 1-123-024-21 ELECT 33MF 160V
C802 1-107-364-11 MYLAR 0.01MF 10% 200V
C804 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V <CONNECTOR>

C805 1-102-244-00 CERAMIC 220PF 10% 500V CN100 * 1-508-784-00 PIN, CONNECTOR (5mm PITCH) 1P
C806 1-126-960-11 ELECT 1MF 20% 50V CN101 * 1-560-124-00 PLUG, CONNECTOR (2.5MM) 4P
C807 1-136-569-11 FILM 1.2MF 5% 200V CN102 * 1-564-506-11 PLUG, CONNECTOR 3P
C808 1-129-746-00 FILM 0.039MF 5% 400V CN103 * 1-564-509-11 PLUG, CONNECTOR 6P
C809 1-162-115-00 CERAMIC 330PF 10% 2KV CN111 * 1-564-505-11 PLUG, CONNECTOR 2P

C810 1-106-365-00 MYLAR 0.0082MF 10% 200V CN251 * 1-564-507-11 PLUG, CONNECTOR 4P
C811 1-162-318-11 CERAMIC 0.001MF 10% 500V CN601 * 1-580-843-11 PIN, CONNECTOR (POWER)
C812 ¡ 1-117-646-11 FILM 12000PF 3% 1.2KV CN602 * 1-508-786-00 PIN, CONNECTOR (5mm PITCH) 2P
C816 1-107-943-11 ELECT 10MF 20% 160V CN603 * 1-508-786-00 PIN, CONNECTOR (5mm PITCH) 2P
C820 ¡ 1-161-731-81 CERAMIC 0.001MF 10% 2KV CN606 1-695-915-11 TAB (CONTACT)

C821 1-104-999-11 MYLAR 0.1MF 10% 200V CN609 * 1-564-506-11 PLUG, CONNECTOR 3P
C822 1-136-111-00 FILM 1MF 5% 200V CN612 1-695-915-11 TAB (CONTACT)
C823 1-164-232-11 CERAMIC CHIP 0.01MF 10% 50V CN613 1-695-915-11 TAB (CONTACT)
C825 1-107-364-11 MYLAR 0.01MF 10% 200V CN614 1-695-915-11 TAB (CONTACT)
C850 1-124-480-11 ELECT 470MF 20% 25V CN615 1-695-915-11 TAB (CONTACT)

C852 1-104-574-11 CERAMIC 0.0047MF 10% 2KV CN851 * 1-508-766-00 PIN, CONNECTOR (5mm PITCH) 4P
C853 1-162-318-11 CERAMIC 0.001MF 10% 500V
C854 1-124-480-11 ELECT 470MF 20% 25V
C856 1-162-318-11 CERAMIC 0.001MF 10% 500V <TRIMMER>
C857 1-136-159-00 FILM 0.033MF 5% 50V
CT45 1-579-690-11 TRAP, CERAMIC (J21MF2J)
C860 1-102-228-00 CERAMIC 470PF 10% 500V CT55 1-404-801-11 TRAP, CERAMIC
C861 1-107-654-11 ELECT 33MF 20% 250V CT60 1-409-429-11 TRAP, CERAMIC (J21MF2J)
C875 1-128-562-11 ELECT 47MF 20% 100V CT65 1-409-327-00 TRAP, CERAMIC (6.5MHZ) (J21MF2J)
C876 1-107-369-11 MYLAR 0.068MF 10% 100V
C891 1-163-007-11 CERAMIC CHIP 680PF 10% 50V
<DIODE>
C898 1-137-150-11 MYLAR 0.01MF 10% 100V
C900 1-163-133-00 CERAMIC CHIP 470PF 5% 50V D001 8-719-109-81 DIODE RD4.7ESB2
C901 1-163-133-00 CERAMIC CHIP 470PF 5% 50V D002 8-719-911-19 DIODE 1SS119-25
C1201 1-104-665-11 ELECT 100MF 20% 16V D003 8-719-041-97 DIODE MA113-(TX)
C1202 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V D005 8-719-109-84 DIODE RD5.1ESB1
D008 8-719-109-89 DIODE RD5.6ESB2
C1203 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V
(J21MF2J) D103 8-719-914-42 DIODE DA204K
C1204 1-104-665-11 ELECT 100MF 20% 16V D201 8-719-041-97 DIODE MA113-(TX)
C1205 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V D251 8-719-041-97 DIODE MA113-(TX)
C1206 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V D252 8-719-914-42 DIODE DA204K
(J21MF2J) D253 8-719-041-97 DIODE MA113-(TX)
C1210 1-104-665-11 ELECT 100MF 20% 16V
D300 8-719-041-97 DIODE MA113-(TX)
C1212 1-126-960-11 ELECT 1MF 20% 50V D301 8-719-041-97 DIODE MA113-(TX)
(J21MF2J) D305 8-719-041-97 DIODE MA113-(TX)
C1213 1-126-960-11 ELECT 1MF 20% 50V D306 8-719-911-19 DIODE 1SS119-25
C1214 1-104-665-11 ELECT 100MF 20% 16V D307 8-719-911-19 DIODE 1SS119-25
C1215 1-163-257-11 CERAMIC CHIP 180PF 5% 50V
(J21MF2J) D308 8-719-109-54 DIODE RD2.2ESB2
C1216 1-164-005-11 CERAMIC CHIP 0.47MF 25V D310 8-719-041-97 DIODE MA113-(TX)
(J21MF2J) D311 8-719-109-54 DIODE RD2.2ESB2
D312 8-719-110-08 DIODE RD8.2ESB2
C1217 1-104-665-11 ELECT 100MF 20% 16V D315 8-719-121-24 DIODE RD9.1ESL
C1218 1-163-257-11 CERAMIC CHIP 180PF 5% 50V
C1219 1-104-665-11 ELECT 100MF 20% 16V D351 8-719-908-03 DIODE GP08D
C1221 1-164-005-11 CERAMIC CHIP 0.47MF 25V D399 8-719-977-22 DIODE DTZ9.1
C1222 1-164-005-11 CERAMIC CHIP 0.47MF 25V D401 8-719-421-40 DIODE MA77 (J21MF2J)
D402 8-719-911-19 DIODE 1SS119-25 (J21MF2J)
C1223 1-164-346-11 CERAMIC CHIP 1MF 16V D403 8-719-911-19 DIODE 1SS119-25
(J21MF2J)
C1225 1-164-005-11 CERAMIC CHIP 0.47MF 25V D513 8-719-109-84 DIODE RD5.1ESB1
(2199M5J) D551 8-719-908-03 DIODE GP08D
C1226 1-126-934-11 ELECT 220MF 20% 16V D561 8-719-911-19 DIODE 1SS119-25
C1228 1-164-346-11 CERAMIC CHIP 1MF 16V D591 8-719-911-19 DIODE 1SS119-25
C1230 1-164-004-11 CERAMIC CHIP 0.1MF 10% 25V D601 8-719-510-53 DIODE D4SB60L
C1259 1-163-019-00 CERAMIC CHIP 0.0068MF 10% 50V D604 8-719-312-10 DIODE RU4AM-T3
C1260 1-163-019-00 CERAMIC CHIP 0.0068MF 10% 50V D605 8-719-067-18 DIODE RN4Z
C1513 1-124-122-11 ELECT 100MF 20% 50V D606 8-719-067-18 DIODE RN4Z
D607 8-719-510-26 DIODE D1NL20-TA2
D609 8-719-510-26 DIODE D1NL20-TA2
<FILTER>
D610 8-719-510-26 DIODE D1NL20-TA2
CF45 1-527-943-00 FILTER, CERAMIC (J21MF2J) D611 8-719-510-26 DIODE D1NL20-TA2
CF55 1-567-099-00 FILTER, CERAMIC D801 8-719-945-80 DIODE ERC06-15S
CF60 1-567-100-00 FILTER, CERAMIC (J21MF2J) D802 8-719-900-26 DIODE ERD29-08J

– 42 –
 The components identified by Les composants identifies par
shading and mark ¡ are criti- une trame et une marque ¡
cal for safety. sont critiques pour la securite.

(a)
Replace only with part number Ne les remplacer que par une
specified. piece portant le numero specifie.

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
D851 8-719-302-43 DIODE EL1Z JR113 1-216-295-91 SHORT 0
JR115 1-216-295-91 SHORT 0
D852 8-719-028-72 DIODE RGP02-17EL-6433 JR116 1-216-295-91 SHORT 0 (J21MF2J)
D853 8-719-302-43 DIODE EL1Z JR117 1-216-295-91 SHORT 0
D855 8-719-302-43 DIODE EL1Z JR118 1-216-295-91 SHORT 0
D857 8-719-908-03 DIODE GP08D
D858 8-719-908-03 DIODE GP08D JR125 1-216-295-91 SHORT 0
JR126 1-216-295-91 SHORT 0
D860 8-719-911-19 DIODE 1SS119-25 JR179 1-216-295-91 SHORT 0
D901 1-810-039-11 LED UNIT JR203 1-216-295-91 SHORT 0 (2199M5J)
D1201 8-719-121-24 DIODE RD9.1ESL JR204 1-216-295-91 SHORT 0
D1202 8-719-121-24 DIODE RD9.1ESL
D1203 8-719-121-24 DIODE RD9.1ESL (J21MF2J)
<COIL>
D1207 8-719-121-24 DIODE RD9.1ESL
D1208 8-719-110-14 DIODE RD9.1ESB3 L001 1-408-397-00 INDUCTOR 1UH
D1209 8-719-121-24 DIODE RD9.1ESL (J21MF2J) L002 1-410-509-11 INDUCTOR 10UH
D1504 8-719-911-19 DIODE 1SS119-25 L003 1-408-605-31 INDUCTOR 15UH
D1505 8-719-109-81 DIODE RD4.7ESB2 L101 1-410-470-11 INDUCTOR 10UH
L301 1-408-408-00 INDUCTOR 8.2UH
<FUSE> L401 1-410-498-11 INDUCTOR 1.2UH
L402 1-410-510-11 INDUCTOR 12UH
F601 ¡ 1-532-237-00 FUSE, TIME-LAG (BET) 3.15A/250V L403 1-410-510-11 INDUCTOR 12UH (J21MF2J)
1-533-223-11 CLIP, FUSE ; F601 L404 1-410-508-11 INDUCTOR 8.2UH (J21MF2J)
L405 1-410-508-11 INDUCTOR 8.2UH (J21MF2J)
<FERRITE BEAD> L406 1-410-507-11 INDUCTOR 6.8UH
L407 1-410-511-11 INDUCTOR 15UH (J21MF2J)
FB101 1-410-397-21 INDUCTOR 1.1UH L408 1-410-500-11 INDUCTOR 1.8UH (J21MF2J)
FB102 1-410-397-21 INDUCTOR 1.1UH L409 1-410-501-11 INDUCTOR 2.2UH (J21MF2J)
FB103 1-410-397-21 INDUCTOR 1.1UH L410 1-410-501-11 INDUCTOR 2.2UH
FB251 1-410-397-21 INDUCTOR 1.1UH
FB601 1-410-397-21 INDUCTOR 1.1UH L411 1-410-502-11 INDUCTOR 2.7UH (J21MF2J)
L802 1-412-527-11 INDUCTOR 15UH
FB603 1-410-397-21 INDUCTOR 1.1UH L804 1-459-075-11 COIL,DYNAMIC CONVERSION CHOKE
FB610 ¡ 1-410-396-41 INDUCTOR 0.45UH L805 ¡ 1-459-769-13 COIL, HORIZONTAL LINEARITY
FB612 1-410-397-21 INDUCTOR 1.1UH L807 1-459-390-00 COIL (WITH CORE)
FB801 1-410-397-21 INDUCTOR 1.1UH
L808 1-412-552-11 INDUCTOR 2.2mH
L821 1-459-111-00 COIL, DRAM CORE (CDI)
<IC> L850 1-408-947-00 INDUCTOR 2.2mH
IC001 8-752-891-61 IC CXP85220A-060S
IC002 8-759-805-37 IC L78LR05D-MA <TRANSISTOR>
IC003 8-759-370-33 IC ST24C04FB6
IC004 8-742-041-12 HYB IC SBX1981-11 Q030 8-729-422-27 TRANSISTOR 2SD601A-Q
IC100 8-759-157-40 IC uPC574J Q108 8-729-422-27 TRANSISTOR 2SD601A-Q
Q109 8-729-422-27 TRANSISTOR 2SD601A-Q
IC201 8-759-476-86 IC TDA7438D Q110 8-729-422-27 TRANSISTOR 2SD601A-Q
IC203 8-759-339-60 IC TA8248K Q202 8-729-216-22 TRANSISTOR 2SA1162-G
IC300 8-759-365-26 IC TDA8375A
IC351 8-759-288-85 IC TDA4665T-T Q207 8-729-216-22 TRANSISTOR 2SA1162-G
IC354 8-759-251-56 IC TDA8395T Q208 8-729-421-19 TRANSISTOR UN2213
Q209 8-729-424-67 TRANSISTOR UN2216
IC401 8-759-800-65 IC LA7910 (J21MF2J) Q210 8-729-424-67 TRANSISTOR UN2216
IC521 8-759-054-12 IC PQ09RA1 Q301 8-729-421-22 TRANSISTOR UN2211
IC551 8-759-801-98 IC LA7830
IC601 8-749-014-00 IC STR-S6707N Q302 8-729-422-27 TRANSISTOR 2SD601A-Q
IC602 8-749-921-89 IC SE115N Q303 8-729-422-27 TRANSISTOR 2SD601A-Q
Q402 8-729-922-66 TRANSISTOR 2SC2410SN
IC603 ¡ 8-749-010-64 PHOTO COUPLER PC123F2 Q403 8-729-424-67 TRANSISTOR UN2216 (J21MF2J)
IC801 8-759-100-96 IC uPC4558G2 Q404 8-729-424-67 TRANSISTOR UN2216 (J21MF2J)
IC1210 8-759-100-96 IC uPC4558G2
Q405 8-729-216-22 TRANSISTOR 2SA1162-G (J21MF2J)
Q406 8-729-216-22 TRANSISTOR 2SA1162-G
<JACK> Q407 8-729-216-22 TRANSISTOR 2SA1162-G (J21MF2J)
Q408 8-729-422-27 TRANSISTOR 2SD601A-Q
J251 1-770-786-11 JACK Q409 8-729-216-22 TRANSISTOR 2SA1162-G
J1201 1-770-660-11 JACK BLOCK, PIN 4P (2199M5J)
J1201 1-779-850-11 JACK BLOCK, PIN 6P (J21MF2J) Q410 8-729-216-22 TRANSISTOR 2SA1162-G (J21MF2J)
J1202 1-770-329-11 JACK, PIN 3P (J21MF2J) Q411 8-729-422-27 TRANSISTOR 2SD601A-Q (J21MF2J)
J1202 1-779-205-11 JACK, PIN 2P (2199M5J) Q412 8-729-422-27 TRANSISTOR 2SD601A-Q (J21MF2J)
Q413 8-729-424-67 TRANSISTOR UN2216 (J21MF2J)
Q414 8-729-422-27 TRANSISTOR 2SD601A-Q
<CHIP CONDUCTOR>
Q415 8-729-424-67 TRANSISTOR UN2216 (J21MF2J)
JR050 1-216-295-91 SHORT 0 Q416 8-729-422-27 TRANSISTOR 2SD601A-Q (J21MF2J)
JR052 1-216-295-91 SHORT 0 Q417 8-729-424-67 TRANSISTOR UN2216 (J21MF2J)
JR101 1-216-295-91 SHORT 0 Q418 8-729-424-67 TRANSISTOR UN2216 (J21MF2J)
JR107 1-216-295-91 SHORT 0 (2199M5J) Q561 8-729-200-17 TRANSISTOR 2SA1091-O
JR112 8-719-041-97 DIODE MA113-(TX)

– 43 –
 Les composants identifies par The components identified by
une trame et une marque ¡ shading and mark ¡ are criti-
sont critiques pour la securite. cal for safety.

(a)
Ne les remplacer que par une Replace only with part number
piece portant le numero specifie. specified.

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
Q801 8-729-140-50 TRANSISTOR 2SC3209LK R114 1-216-041-00 RES, CHIP 470
Q802 8-729-821-87 TRANSISTOR 2SD1878-CA R115 1-216-081-00 RES, CHIP 22K
Q821 8-729-209-15 TRANSISTOR 2SD2012 R116 1-216-081-00 RES, CHIP 22K
Q902 8-729-421-19 TRANSISTOR UN2213 R117 1-216-081-00 RES, CHIP 22K
Q903 8-729-421-19 TRANSISTOR UN2213 R118 1-216-081-00 RES, CHIP 22K
Q1201 8-729-422-27 TRANSISTOR 2SD601A-Q R119 1-216-055-00 RES, CHIP 1.8K
Q1202 8-729-422-27 TRANSISTOR 2SD601A-Q R120 1-216-109-00 RES, CHIP 330K
Q1203 8-729-422-27 TRANSISTOR 2SD601A-Q R131 1-216-464-11 METAL OXIDE 18K 5% 2W F
Q1204 8-729-216-22 TRANSISTOR 2SA1162-G R180 1-216-033-00 RES, CHIP 220
Q1205 8-729-216-22 TRANSISTOR 2SA1162-G (J21MF2J) R181 1-216-033-00 RES, CHIP 220
Q1207 8-729-422-27 TRANSISTOR 2SD601A-Q R182 1-216-033-00 RES, CHIP 220
Q1208 8-729-422-27 TRANSISTOR 2SD601A-Q R203 1-216-033-00 RES, CHIP 220
Q1209 8-729-422-27 TRANSISTOR 2SD601A-Q R204 1-216-033-00 RES, CHIP 220
Q1264 8-729-424-67 TRANSISTOR UN2216 (J21MF2J) R210 1-216-061-00 RES, CHIP 3.3K
Q1265 8-729-424-67 TRANSISTOR UN2216 R211 1-216-061-00 RES, CHIP 3.3K
Q1513 8-729-422-27 TRANSISTOR 2SD601A-Q R212 1-216-059-00 RES, CHIP 2.7K
R213 1-216-059-00 RES, CHIP 2.7K
R240 1-216-035-00 RES, CHIP 270
<RESISTOR> R242 1-216-035-00 RES, CHIP 270
R243 1-216-073-00 RES, CHIP 10K
R001 1-216-065-00 RES, CHIP 4.7K
R002 1-216-065-00 RES, CHIP 4.7K R244 1-216-073-00 RES, CHIP 10K
R003 1-216-065-00 RES, CHIP 4.7K R245 1-216-067-00 RES, CHIP 5.6K
R004 1-216-065-00 RES, CHIP 4.7K R246 1-216-067-00 RES, CHIP 5.6K
R007 1-216-073-00 RES, CHIP 10K R247 1-216-049-91 RES, CHIP 1.0K (J21MF2J)
R247 1-216-073-00 RES, CHIP 10K (2199M5J)
R008 1-216-057-00 RES, CHIP 2.2K
R009 1-216-049-91 RES, CHIP 1.0K (J21MF2J) R248 1-216-049-91 RES, CHIP 1.0K (J21MF2J)
R010 1-216-049-91 RES, CHIP 1.0K R248 1-216-073-00 RES, CHIP 10K (2199M5J)
R012 1-216-017-91 RES, CHIP 47 R249 1-216-049-91 RES, CHIP 1.0K (J21MF2J)
R013 1-216-049-91 RES, CHIP 1.0K R249 1-216-077-00 RES, CHIP 15K (2199M5J)
R250 1-216-049-91 RES, CHIP 1.0K (J21MF2J)
R014 1-216-049-91 RES, CHIP 1.0K (J21MF2J)
R015 1-216-043-91 RES, CHIP 560 R250 1-216-077-00 RES, CHIP 15K (2199M5J)
R016 1-216-049-91 RES, CHIP 1.0K R251 1-216-295-91 SHORT 0
R017 1-216-057-00 RES, CHIP 2.2K R252 1-249-411-11 CARBON 330 5% 1/4W
R018 1-216-033-00 RES, CHIP 220 R253 1-216-073-00 RES, CHIP 10K
R254 1-249-389-11 CARBON 4.7 5% 1/4W
R019 1-216-101-00 RES, CHIP 150K
R021 1-216-065-00 RES, CHIP 4.7K R255 1-249-389-11 CARBON 4.7 5% 1/4W
R025 1-216-057-00 RES, CHIP 2.2K R256 1-249-411-11 CARBON 330 5% 1/4W
R026 1-216-057-00 RES, CHIP 2.2K R257 8-719-041-97 DIODE MA113-(TX)
R028 1-216-025-91 RES, CHIP 100 R264 1-216-061-00 RES, CHIP 3.3K (J21MF2J)
R264 1-216-065-00 RES, CHIP 4.7K (2199M5J)
R029 1-216-065-00 RES, CHIP 4.7K
R031 1-216-049-91 RES, CHIP 1.0K R265 1-216-061-00 RES, CHIP 3.3K (J21MF2J)
R033 1-216-049-91 RES, CHIP 1.0K R265 1-216-065-00 RES, CHIP 4.7K (2199M5J)
R035 1-216-049-91 RES, CHIP 1.0K R266 1-216-073-00 RES, CHIP 10K
R036 1-216-049-91 RES, CHIP 1.0K R301 1-216-073-00 RES, CHIP 10K
R302 1-216-063-91 RES, CHIP 3.9K
R037 1-216-049-91 RES, CHIP 1.0K
R038 1-216-033-00 RES, CHIP 220 R303 1-216-025-91 RES, CHIP 100
R040 1-216-033-00 RES, CHIP 220 R304 1-216-025-91 RES, CHIP 100
R041 1-216-025-91 RES, CHIP 100 R305 1-216-025-91 RES, CHIP 100
R042 1-216-039-00 RES, CHIP 390 R306 1-216-025-91 RES, CHIP 100
R307 1-216-025-91 RES, CHIP 100
R045 1-216-057-00 RES, CHIP 2.2K
R047 1-216-025-91 RES, CHIP 100 R308 1-216-033-00 RES, CHIP 220
R048 1-216-025-91 RES, CHIP 100 R309 1-216-033-00 RES, CHIP 220
R053 1-216-057-00 RES, CHIP 2.2K R310 1-216-097-91 RES, CHIP 100K
R054 1-216-073-00 RES, CHIP 10K R311 1-216-075-00 RES, CHIP 12K
R312 1-216-025-91 RES, CHIP 100
R057 1-216-049-91 RES, CHIP 1.0K
R058 1-216-065-00 RES, CHIP 4.7K (J21MF2J) R313 1-216-061-00 RES, CHIP 3.3K
R060 1-216-037-00 RES, CHIP 330 R314 1-216-025-91 RES, CHIP 100
R061 1-216-049-91 RES, CHIP 1.0K R315 1-216-295-91 SHORT 0
R062 1-216-057-00 RES, CHIP 2.2K R316 1-216-065-00 RES, CHIP 4.7K
R317 1-216-049-91 RES, CHIP 1.0K
R063 1-216-057-00 RES, CHIP 2.2K
R068 1-216-025-91 RES, CHIP 100 R318 1-216-099-00 RES, CHIP 120K
R071 1-216-037-00 RES, CHIP 330 R319 1-216-123-11 RES, CHIP 1.2M
R072 1-216-061-00 RES, CHIP 3.3K R320 1-216-083-00 RES, CHIP 27K
R076 1-216-025-91 RES, CHIP 100 R321 1-216-689-11 METAL CHIP 39K 0.50% 1/10W
R322 1-216-083-00 RES, CHIP 27K
R077 1-216-025-91 RES, CHIP 100
R090 1-216-073-00 RES, CHIP 10K R325 1-216-295-91 SHORT 0
R101 1-216-065-00 RES, CHIP 4.7K R326 1-216-063-91 RES, CHIP 3.9K
R102 1-216-049-91 RES, CHIP 1.0K R327 1-216-295-91 SHORT 0
R113 1-216-081-00 RES, CHIP 22K R328 1-216-295-91 SHORT 0

– 44 –
 The components identified by Les composants identifies par
shading and mark ¡ are criti- une trame et une marque ¡
cal for safety. sont critiques pour la securite.

(a)
Replace only with part number Ne les remplacer que par une
specified. piece portant le numero specifie.

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
R329 1-216-295-91 SHORT 0 R602 1-202-968-11 CEMENTED 1.2 5% 10W
R606 1-215-915-11 METAL OXIDE 470 5% 3W F
R330 1-216-043-91 RES, CHIP 560 R610 1-215-924-00 METAL OXIDE 15K 5% 3W F
R331 1-216-117-00 RES, CHIP 680K
R332 1-216-033-00 RES, CHIP 220 R611 ¡ 1-202-933-61 FUSIBLE 0.1 10% 1/2W F
R334 1-216-041-00 RES, CHIP 470 R612 1-249-377-11 CARBON 0.47 5% 1/4W F
R335 1-216-073-00 RES, CHIP 10K R613 1-249-377-11 CARBON 0.47 5% 1/4W F
R614 1-215-877-11 METAL OXIDE 22K 5% 1W F
R336 1-216-057-00 RES, CHIP 2.2K R615 1-249-389-11 CARBON 4.7 5% 1/4W
R338 1-216-295-91 SHORT 0
R339 1-216-036-00 RES, CHIP 300 R616 ¡ 1-218-265-91 METAL 8.2M 5% 1W
R340 1-216-035-00 RES, CHIP 270 R617 1-215-924-00 METAL OXIDE 15K 5% 3W F
R341 1-216-049-91 RES, CHIP 1.0K R618 1-249-377-11 CARBON 0.47 5% 1/4W F
R619 1-249-377-11 CARBON 0.47 5% 1/4W F
R351 1-216-001-00 RES, CHIP 10 R622 1-217-192-21 WIREWOUND 0.22 10% 2W F
R355 1-216-001-00 RES, CHIP 10
R356 1-216-049-91 RES, CHIP 1.0K R623 1-247-807-31 CARBON 100 5% 1/4W
R360 1-208-291-11 RES, CHIP 4.7M R624 1-216-446-00 METAL OXIDE 18 5% 2W F
R403 1-216-021-00 RES, CHIP 68 R625 1-249-424-11 CARBON 3.9K 5% 1/4W
R626 1-249-420-11 CARBON 1.8K 5% 1/4W
R406 1-216-065-00 RES, CHIP 4.7K R627 1-249-417-11 CARBON 1K 5% 1/4W
R407 1-216-063-91 RES, CHIP 3.9K
R408 1-216-055-00 RES, CHIP 1.8K R628 1-249-417-11 CARBON 1K 5% 1/4W
R409 1-216-025-91 RES, CHIP 100 R629 1-249-399-11 CARBON 33 5% 1/4W
R410 1-216-073-00 RES, CHIP 10K (J21MF2J) R632 1-249-381-11 CARBON 1 5% 1/4W
R636 1-215-924-00 METAL OXIDE 15K 5% 3W F
R411 1-216-057-00 RES, CHIP 2.2K (J21MF2J) R801 1-215-920-11 METAL OXIDE 3.3K 5% 3W F
R412 1-216-069-00 RES, CHIP 6.8K (J21MF2J)
R413 1-216-057-00 RES, CHIP 2.2K (J21MF2J) R802 1-249-385-11 CARBON 2.2 5% 1/4W F
R414 1-216-041-00 RES, CHIP 470 R803 1-216-057-00 RES, CHIP 2.2K
R415 1-216-033-00 RES, CHIP 220 (J21MF2J) R804 1-216-049-91 RES, CHIP 1.0K
R805 1-216-081-00 RES, CHIP 22K
R416 1-216-033-00 RES, CHIP 220 R809 1-247-756-11 CARBON 2.2K 5% 1/2W F
R417 1-216-033-00 RES, CHIP 220 (J21MF2J)
R418 1-216-045-00 RES, CHIP 680 (J21MF2J) R811 1-216-343-00 METAL OXIDE 0.33 5% 1W F
R419 1-216-049-91 RES, CHIP 1.0K R812 1-216-075-00 RES, CHIP 12K
R420 1-216-039-00 RES, CHIP 390 R816 1-249-435-11 CARBON 33K 5% 1/4W
R820 1-216-655-11 METAL CHIP 1.5K 0.50% 1/10W
R421 1-216-033-00 RES, CHIP 220 R821 1-215-911-11 METAL OXIDE 100 5% 3W F
R422 1-216-027-00 RES, CHIP 120 (J21MF2J)
R423 1-216-029-00 RES, CHIP 150 (J21MF2J) R822 1-216-429-00 METAL OXIDE 270 5% 1W F
R424 1-216-057-00 RES, CHIP 2.2K R823 1-249-931-11 CARBON 2.2K 5% 1/4W F
R425 1-216-039-00 RES, CHIP 390 R825 1-249-392-11 CARBON 8.2 5% 1/4W F
R826 1-216-059-00 RES, CHIP 2.7K
R426 1-216-029-00 RES, CHIP 150 R827 1-216-095-00 RES, CHIP 82K
R427 1-216-037-00 RES, CHIP 330 (J21MF2J)
R428 1-216-081-00 RES, CHIP 22K (J21MF2J) R828 1-216-063-91 RES, CHIP 3.9K
R429 1-216-031-00 RES, CHIP 180 (J21MF2J) R829 1-216-053-00 RES, CHIP 1.5K
R429 1-216-039-00 RES, CHIP 390 (2199M5J) R831 1-215-886-11 METAL OXIDE 100 5% 2W F
R832 1-216-057-00 RES, CHIP 2.2K
R430 1-216-041-00 RES, CHIP 470 (J21MF2J) R834 1-216-073-00 RES, CHIP 10K
R431 1-216-081-00 RES, CHIP 22K (J21MF2J)
R432 1-216-041-00 RES, CHIP 470 (J21MF2J) R851 1-249-382-11 CARBON 1.2 5% 1/4W F
R433 1-216-081-00 RES, CHIP 22K R852 1-249-417-11 CARBON 1K 5% 1/4W F
R434 1-216-041-00 RES, CHIP 470 R853 1-249-377-11 CARBON 0.47 5% 1/4W F
R854 1-249-377-11 CARBON 0.47 5% 1/4W F
R435 1-216-041-00 RES, CHIP 470 (J21MF2J) R855 1-202-818-00 SOLID 1K 20% 1/2W
R436 1-216-081-00 RES, CHIP 22K (J21MF2J)
R437 1-216-081-00 RES, CHIP 22K (J21MF2J) R856 1-249-429-11 CARBON 10K 5% 1/4W
R440 1-216-029-00 RES, CHIP 150 R857 1-249-438-11 CARBON 56K 5% 1/4W
R521 1-216-049-91 RES, CHIP 1.0K R858 1-216-370-11 METAL OXIDE 1.2 5% 2W F
R860 1-247-887-00 CARBON 220K 5% 1/4W
R552 1-216-101-00 RES, CHIP 150K R881 1-216-043-91 RES, CHIP 560
R553 1-216-081-00 RES, CHIP 22K
R554 1-163-009-11 CERAMIC CHIP 0.001MF 10% 50V R882 1-216-059-00 RES, CHIP 2.7K
R555 1-249-429-11 CARBON 10K 5% 1/4W R883 1-216-121-91 RES, CHIP 1.0M
R556 1-216-049-91 RES, CHIP 1.0K R895 1-216-349-00 METAL OXIDE 1 5% 1W F
R898 1-249-421-11 CARBON 2.2K 5% 1/4W
R557 1-216-055-00 RES, CHIP 1.8K R902 1-216-065-00 RES, CHIP 4.7K
R560 1-216-295-91 SHORT 0
R561 1-249-421-11 CARBON 2.2K 5% 1/4W R906 1-216-065-00 RES, CHIP 4.7K
R562 1-249-419-11 CARBON 1.5K 5% 1/4W F R907 1-216-043-91 RES, CHIP 560
R563 1-247-885-00 CARBON 180K 5% 1/4W R908 1-216-059-00 RES, CHIP 2.7K
R909 1-216-071-00 RES, CHIP 8.2K
R564 1-216-091-00 RES, CHIP 56K R910 1-216-043-91 RES, CHIP 560
R565 1-216-091-00 RES, CHIP 56K
R566 1-216-065-00 RES, CHIP 4.7K R911 1-216-059-00 RES, CHIP 2.7K
R569 1-247-883-00 CARBON 150K 5% 1/4W R912 1-216-071-00 RES, CHIP 8.2K
R570 1-216-295-91 SHORT 0 R913 1-216-041-00 RES, CHIP 470
R914 1-216-041-00 RES, CHIP 470
R571 1-216-033-00 RES, CHIP 220 R1201 1-216-023-00 RES, CHIP 82
R601 1-202-968-11 CEMENTED 1.2 5% 10W

– 45 –
 Les composants identifies par The components identified by
une trame et une marque ¡ shading and mark ¡ are criti-
sont critiques pour la securite. cal for safety.

(a)(c)
Ne les remplacer que par une Replace only with part number
piece portant le numero specifie. specified.

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
R1202 1-216-049-91 RES, CHIP 1.0K <TRANSFORMER>
R1203 1-216-089-91 RES, CHIP 47K
R1204 1-216-089-91 RES, CHIP 47K (J21MF2J) T601 ¡ 1-429-137-21 TRANSFORMER, CONVERTER (SRT)
R1205 1-216-023-00 RES, CHIP 82 T605 ¡ 1-424-682-11 TRANSFORMER, LINE FILTER
R1206 1-216-089-91 RES, CHIP 47K T801 1-437-195-11 TRANSFORMER, HORIZONTAL DRIVE
T851 ¡ 1-453-250-11 TRANSFORMER ASSY, FLYBACK
R1207 1-216-089-91 RES, CHIP 47K (J21MF2J) (NX-1746//M3A)
R1211 1-216-021-00 RES, CHIP 68
R1212 1-216-049-91 RES, CHIP 1.0K
R1213 1-216-049-91 RES, CHIP 1.0K (J21MF2J) <THERMISTOR>
R1214 1-216-113-00 RES, CHIP 470K (J21MF2J)
THP601 ¡ 1-808-059-32 THERMISTOR, POSITIVE
R1215 1-216-113-00 RES, CHIP 470K
R1216 1-216-113-00 RES, CHIP 470K
R1218 1-216-041-00 RES, CHIP 470 <TUNER>
R1219 1-216-073-00 RES, CHIP 10K
R1220 1-216-049-91 RES, CHIP 1.0K TU101 ¡ 8-598-323-00 TUNER BT-AG401
R1221 1-216-073-00 RES, CHIP 10K
R1222 1-216-049-91 RES, CHIP 1.0K (J21MF2J) <CRYSTAL>
R1223 1-216-073-00 RES, CHIP 10K (J21MF2J)
R1224 1-216-073-00 RES, CHIP 10K (J21MF2J) X101 1-577-358-21 VIBRATOR, CERAMIC
R1226 1-216-689-11 RES, CHIP 39K (J21MF2J) X300 1-411-752-11 COIL
X358 1-567-505-11 OSCILLATOR, CRYSTAL
R1227 1-216-689-11 RES, CHIP 39K X443 1-567-504-11 OSCILLATOR, CRYSTAL
R1228 1-216-049-91 RES, CHIP 1.0K
R1229 1-216-041-00 RES, CHIP 470
R1230 1-216-073-00 RES, CHIP 10K
R1231 1-216-049-91 RES, CHIP 1.0K *************************************************************
R1232 1-216-063-91 RES, CHIP 3.9K * A-1331-748-A C BOARD, COMPLETE
R1233 1-216-057-00 RES, CHIP 2.2K *********************
R1234 1-216-088-00 RES, CHIP 43K (J21MF2J)
R1235 1-216-088-00 RES, CHIP 43K (J21MF2J) 4-382-854-11 SCREW (M3X10), P, SW (+)
R1235 1-216-689-11 RES, CHIP 39K (2199M5J)
R1239 1-249-389-11 CARBON 4.7 5% 1/4W F <CAPACITOR>
R1240 1-216-025-91 RES, CHIP 100
R1241 1-216-049-91 RES, CHIP 1.0K C701 1-162-114-00 CERAMIC 0.0047MF 2KV
R1242 1-216-049-91 RES, CHIP 1.0K (J21MF2J) C702 1-102-074-00 CERAMIC 0.001MF 10% 50V
R1243 1-216-025-91 RES, CHIP 100 C703 1-107-651-11 ELECT 4.7MF 20% 250V
C704 1-130-202-00 FILM 0.022MF 5% 400V
R1244 1-216-025-91 RES, CHIP 100 (J21MF2J) C708 1-102-114-00 CERAMIC 470PF 10% 50V
R1245 1-216-037-00 RES, CHIP 330
R1246 1-216-037-00 RES, CHIP 330 C709 1-102-114-00 CERAMIC 470PF 10% 50V
R1247 1-216-041-00 RES, CHIP 470 C710 1-102-114-00 CERAMIC 470PF 10% 50V
R1248 1-216-053-00 RES, CHIP 1.5K C712 1-102-116-00 CERAMIC 680PF 10% 50V
C713 1-102-116-00 CERAMIC 680PF 10% 50V
R1249 1-216-044-00 RES, CHIP 620 C714 1-102-116-00 CERAMIC 680PF 10% 50V
R1250 1-216-119-00 RES, CHIP 820K
R1251 1-216-119-00 RES, CHIP 820K C716 1-126-968-11 ELECT 100MF 20% 50V
R1252 1-216-061-00 RES, CHIP 3.3K C717 1-101-880-00 CERAMIC 47PF 5% 50V
R1253 1-216-053-00 RES, CHIP 1.5K (2199M5J) C736 1-102-114-00 CERAMIC 470PF 10% 50V
C737 1-102-114-00 CERAMIC 470PF 10% 50V
R1253 1-216-060-00 RES, CHIP 3.0K (J21MF2J) C746 1-102-114-00 CERAMIC 470PF 10% 50V
R1513 1-216-073-00 RES, CHIP 10K
R1514 1-216-065-00 RES, CHIP 4.7K
R1515 1-216-025-91 RES, CHIP 100 <CONNECTOR>

CN701 * 1-508-766-00 PIN, CONNECTOR (5mm PITCH) 4P

<SWITCH> CN703 * 1-564-509-11 PLUG, CONNECTOR 6P
CN704 1-695-915-11 TAB (CONTACT)
S601 ¡ 1-571-433-31 SWITCH, PUSH (AC POWER)
S801 1-572-707-11 SWITCH, LEVER
S901 1-571-532-21 SWITCH, TACTIL <DIODE>
S902 1-571-532-21 SWITCH, TACTIL
S903 1-571-532-21 SWITCH, TACTIL D701 8-719-911-19 DIODE 1SS119-25
D702 8-719-911-19 DIODE 1SS119-25
S904 1-571-532-21 SWITCH, TACTIL D703 8-719-911-19 DIODE 1SS119-25
S905 1-571-532-21 SWITCH, TACTIL D707 8-719-911-19 DIODE 1SS119-25
S906 1-571-532-21 SWITCH, TACTIL D708 8-719-911-19 DIODE 1SS119-25
D709 8-719-911-19 DIODE 1SS119-25
<SPARK GAP> D710 8-719-911-19 DIODE 1SS119-25
D711 8-719-911-19 DIODE 1SS119-25
SG801 1-519-422-11 GAP, SPARK D712 8-719-911-19 DIODE 1SS119-25
D716 8-719-911-19 DIODE 1SS119-25
<FILTER> D717 8-719-121-24 DIODE RD9.1ESL

SWF401 1-767-663-11 SAWF (2199M5J)

SWF401 1-760-771-11 FILTER, SURFACE WAVE (J21MF2J)

– 46 –
 The components identified by Les composants identifies par
shading and mark ¡ are criti- une trame et une marque ¡
cal for safety. sont critiques pour la securite.

(c)(vm)
Replace only with part number Ne les remplacer que par une
specified. piece portant le numero specifie.

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
<JACK> * A-1342-405-A VM BOARD, COMPLETE
***********************
J701 ¡ 1-251-239-11 SOCKET, PICTURE TUBE
4-382-854-11 SCREW (M3X10), P, SW (+)

<COIL>
<CAPACITOR>
L701 1-410-667-31 INDUCTOR 22UH
C1722 1-102-115-00 CERAMIC 560PF 10% 50V
C1724 1-102-961-00 CERAMIC 27PF 5% 50V
<TRANSISTOR> C1751 1-136-153-00 FILM 0.01MF 5% 50V
C1761 1-161-830-00 CERAMIC 0.0047MF 500V
Q704 8-729-326-11 TRANSISTOR 2SC2611 C1763 1-107-638-11 ELECT 33MF 20% 160V
Q704 8-729-326-11 TRANSISTOR 2SC2611
Q704 8-729-326-11 TRANSISTOR 2SC2611 C1764 1-126-933-11 ELECT 100MF 20% 16V
Q705 8-729-326-11 TRANSISTOR 2SC2611 C1768 1-106-383-00 MYLAR 0.047MF 10% 200V
Q705 8-729-326-11 TRANSISTOR 2SC2611 C1769 1-107-667-11 ELECT 2.2MF 20% 160V
C1770 1-104-999-11 MYLAR 0.1MF 10% 200V
Q705 8-729-326-11 TRANSISTOR 2SC2611 C1771 1-126-964-11 ELECT 10MF 20% 50V
Q706 8-729-326-11 TRANSISTOR 2SC2611
Q706 8-729-326-11 TRANSISTOR 2SC2611 C1772 1-126-933-11 ELECT 100MF 20% 16V
Q706 8-729-326-11 TRANSISTOR 2SC2611 C1773 1-106-383-00 MYLAR 0.047MF 10% 200V
Q707 8-729-200-17 TRANSISTOR 2SA1091-O C1775 1-126-933-11 ELECT 100MF 20% 16V
C1776 1-126-964-11 ELECT 10MF 20% 50V
Q708 8-729-200-17 TRANSISTOR 2SA1091-O C1778 1-130-471-00 MYLAR 0.001MF 5% 50V
Q709 8-729-200-17 TRANSISTOR 2SA1091-O
Q710 8-729-119-78 TRANSISTOR 2SC2785-HFE C1779 1-130-471-00 MYLAR 0.001MF 5% 50V
Q711 8-729-119-78 TRANSISTOR 2SC2785-HFE C1780 1-126-964-11 ELECT 10MF 20% 50V
Q712 8-729-119-78 TRANSISTOR 2SC2785-HFE
<CONNECTOR>
<RESISTOR>
CN1701 * 1-564-511-61 PLUG, CONNECTOR 8P
R702 1-244-941-00 CARBON 680K 5% 1/2W
R703 1-249-496-11 CARBON 100K 5% 1/2W
R705 1-216-393-00 METAL OXIDE 2.2 5% 3W F <DIODE>
R710 1-215-922-11 METAL OXIDE 6.8K 5% 3W F
R711 1-247-762-11 CARBON 6.8K 5% 1/2W D1761 8-719-911-19 DIODE 1SS119-25
D1763 8-719-911-19 DIODE 1SS119-25
R712 1-215-922-11 METAL OXIDE 6.8K 5% 3W F D1764 8-719-911-19 DIODE 1SS119-25
R713 1-247-762-11 CARBON 6.8K 5% 1/2W D1767 8-719-982-36 DIODE MTZJ-39B
R714 1-215-922-11 METAL OXIDE 6.8K 5% 3W F D1768 8-719-982-36 DIODE MTZJ-39B
R715 1-247-762-11 CARBON 6.8K 5% 1/2W
R719 1-215-480-00 METAL 300K 1% 1/4W
<COIL>
R720 1-249-923-11 CARBON 1K 5% 1/4W F
R721 1-215-489-00 METAL 680K 1% 1/4W L1721 1-414-191-11 INDUCTOR 150UH
R722 1-249-923-11 CARBON 1K 5% 1/4W F L1722 1-408-621-31 INDUCTOR 330UH
R723 1-215-479-00 METAL 270K 1% 1/4W L1723 1-414-182-11 INDUCTOR 6.8UH
R724 1-249-923-11 CARBON 1K 5% 1/4W F L1761 1-410-478-11 INDUCTOR 47UH
L1762 1-408-416-00 INDUCTOR 39UH
R725 1-249-419-11 CARBON 1.5K 5% 1/4W
R726 1-249-419-11 CARBON 1.5K 5% 1/4W
R727 1-249-419-11 CARBON 1.5K 5% 1/4W <TRANSISTOR>
R728 1-249-407-11 CARBON 150 5% 1/4W
R729 1-249-408-11 CARBON 180 5% 1/4W Q1722 8-729-119-78 TRANSISTOR 2SC2785-HFE
Q1723 8-729-119-78 TRANSISTOR 2SC2785-HFE
R730 1-249-408-11 CARBON 180 5% 1/4W Q1756 8-729-119-78 TRANSISTOR 2SC2785-HFE
R731 1-249-399-11 CARBON 33 5% 1/4W Q1761 8-729-119-78 TRANSISTOR 2SC2785-HFE
R732 1-249-399-11 CARBON 33 5% 1/4W Q1762 8-729-119-76 TRANSISTOR 2SA1175-HFE
R733 1-249-399-11 CARBON 33 5% 1/4W
R734 1-247-739-11 CARBON 100 5% 1/2W Q1763 8-729-017-05 TRANSISTOR 2SA1837
Q1764 8-729-119-78 TRANSISTOR 2SC2785-HFE
R738 1-247-807-31 CARBON 100 5% 1/4W Q1765 8-729-017-06 TRANSISTOR 2SC4793
R739 1-247-807-31 CARBON 100 5% 1/4W Q1766 8-729-119-78 TRANSISTOR 2SC2785-HFE
R740 1-247-807-31 CARBON 100 5% 1/4W Q1767 8-729-142-86 TRANSISTOR 2SC3733
R755 1-249-418-11 CARBON 1.2K 5% 1/4W
R756 1-249-418-11 CARBON 1.2K 5% 1/4W Q1777 8-729-326-11 TRANSISTOR 2SC2611
R757 1-249-418-11 CARBON 1.2K 5% 1/4W
<RESISTOR>
<VARIABLE RESISTOR> R1721 1-249-414-11 CARBON 560 5% 1/4W
R1722 1-249-412-11 CARBON 390 5% 1/4W
RV701 1-230-641-11 RES, ADJ, METAL GLAZE 2.2M R1723 1-249-407-11 CARBON 150 5% 1/4W
R1724 1-249-407-11 CARBON 150 5% 1/4W
R1725 1-249-412-11 CARBON 390 5% 1/4W
************************************************************* R1727 1-247-843-11 CARBON 3.3K 5% 1/4W
R1728 1-249-429-11 CARBON 10K 5% 1/4W
R1732 1-126-964-11 ELECT 10MF 20% 50V

– 47 –
KV-2199M5J/J21MF2J
RM-870 RM-869 Les composants identifies par The components identified by
une trame et une marque ¡ shading and mark ¡ are criti-
sont critiques pour la securite. cal for safety.

(vm)
Ne les remplacer que par une Replace only with part number
piece portant le numero specifie. specified.

---------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------------
REF. NO. PART NO. DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK
------------ ------------- ------------------- ------------- ------------ ------------- ------------------- -------------
R1736 1-249-419-11 CARBON 1.5K 5% 1/4W MISCELLANEOUS
R1753 1-249-434-11 CARBON 27K 5% 1/4W *****************
R1762 1-247-815-91 CARBON 220 5% 1/4W ¡ 1-409-942-11 COIL, DEMAGNETIZATION
R1764 1-247-734-11 CARBON 39 5% 1/2W F 1-452-032-00 MAGNET,DISK ; 10mmø
R1765 1-249-414-11 CARBON 560 5% 1/4W F 1-452-277-00 MAGNET, BMC
R1766 1-249-418-11 CARBON 1.2K 5% 1/4W ¡ 1-452-509-51 NECK ASSY, PICTURE TUBE (NA308)
R1768 1-249-421-11 CARBON 2.2K 5% 1/4W 1-503-902-11 SPEAKER (15X6.5 CM)
R1769 1-249-384-11 CARBON 1.8 5% 1/4W F 1-569-008-11 ADAPTOR, CONVERSION 2P
R1770 1-249-435-11 CARBON 33K 5% 1/4W ¡ 1-574-062-11 CORD, POWER (WITH CONNECTOR)
R1772 1-249-432-11 CARBON 18K 5% 1/4W 2.5A/250V
R1774 1-215-912-11 METAL OXIDE 150 5% 3W F ¡ 8-451-280-33 DEFLECTION YOKE (Y21PXA2)
R1775 1-249-417-11 CARBON 1K 5% 1/4W F ¡ 8-738-774-05 PICTURE TUBE 21PXD(SDS) (A51JUH71X)
R1776 1-249-432-11 CARBON 18K 5% 1/4W
R1777 1-249-438-11 CARBON 56K 5% 1/4W
R1778 1-249-430-11 CARBON 12K 5% 1/4W *************************************************************
R1779 1-249-414-11 CARBON 560 5% 1/4W
R1780 1-249-418-11 CARBON 1.2K 5% 1/4W ACCESSORIES AND PACKING MATERIALS
****************************************
R1781 1-249-410-11 CARBON 270 5% 1/4W
R1782 1-249-384-11 CARBON 1.8 5% 1/4W F 1-417-151-21 MATCHING TRANSFORMER, ANTENNA
R1784 1-247-807-31 CARBON 100 5% 1/4W 1-417-154-11 MATCHING TRANSFORMER, ANTENNA
R1785 1-249-400-11 CARBON 39 5% 1/4W F 1-501-372-81 ANTENNA, TELESCOPIC
R1786 1-249-435-11 CARBON 33K 5% 1/4W 1-501-730-11 ANTENNA, TELESCOPIC
1-501-730-41 ANTENNA, TELESCOPIC
R1787 1-249-428-11 CARBON 8.2K 5% 1/4W
R1788 1-249-419-11 CARBON 1.5K 5% 1/4W 1-569-008-11 ADAPTOR, CONVERSION 2P
R1789 1-249-413-11 CARBON 470 5% 1/4W 3-701-910-00 SCREW, SPECIAL (DIA. 3.8X20)
R1790 1-216-451-11 METAL OXIDE 120 5% 2W F 3-862-260-11 MANUAL, INSTRUCTION
R1791 1-249-411-11 CARBON 330 5% 1/4W * 4-061-177-01 CUSHION (UPPER) (ASSY)
* 4-061-178-01 CUSHION (LOWER) (ASSY)
R1812 1-249-425-11 CARBON 4.7K 5% 1/4W
R1851 1-249-393-11 CARBON 10 5% 1/4W * 4-380-432-21 BAG, PROTECTION
4-392-003-01 BAND, HOLD
4-392-004-01 CLIP

*************************************************************
REMOTE COMMANDER
***********************
1-475-358-12 REMOTE COMMANDER (RM-869)
9-939-697-01 POCKET, COVER (FOR RM-869)

English
Sony Ichinomiya Corporation 98AM08179-1
Printed in Japan
9-965-195-01 Quality Assurance Division © 1998. 1
– 48 –