39HR Spare Parts - S/N: 141200-Lot 15

REFERENCE INFORMATION FOR PARTS DEPARTMENT AND CUSTOMER

Lower Works
P/N Description Qty. New to Consum- Onsite at 0-3 3-6
Region ables Start-Up Years Years
Usage Usage
62044191 Roller, Lower Roller Assy 3 X X X
62037859 Upper roller shaft 1 X X
62037862 Upper Roller and Bearing Assy 1 X X
62044201 Track Shoe 1 X X X
62044199 track pad bolt 20 X X X
62044200 track pad nut 20 X X X
64312358 propel motor 1 X X
62038480 Propel Brake seal kit 4 X X X
62038036 Propel Brake disk kit 4 X X X
62036024 Planetary, Propel 1 X X
62037928 Seal, O-ring 2 X X
62037927 Ring, Back-up 2 X X
62037926 Ring 2 X X
62037925 Seal, Lip 1 X X
62037924 Ring 1 X X
62044207 LH Link 2 X X
62044208 RH Link 2 X X
62044209 pin 2 X X
62044210 Master Pin 1 X X
62044206 Master Bushing 1 X X
62044204 Washer 4 X X
62044205 Bushing 2 X X
62044203 Spacer 2 X X

Air Compressor
P/N Description Qty. New to Consum- Onsite at 0-3 3-6
Region ables Start-Up Years Years
Usage Usage
S011053 air end 1 X X X
S011064 air comp. Oil pump 1 X X
S004023 air comp. Air valve 1 X X X
S004017 main air valve 1 X X
S004024 air comp. Cont. reg. 1 X X X
S022578 air comp. Cont. valve 1 X X X
S045788 air comp. Oil press. Switch 2 X X X
82735003 air comp, oil temp probe 1 X X X
82735005 air comp, air temp probe 1 X X X
S011090 air comp. Oil filter element 5 X X X X
S011092 air comp. Oil filter seal kit 5 X X X X
12858295 air comp. Air transducer 1 X X X
S004012 air rec'r scavenging sight glass 2 X X
62042751 air comp/ primary air filters 24 X X
THIS DOCUMENT IS PROTECTED UNDER APPLICABLE COPYRIGHT LAWS TO THE EXTENT AVAILABLE. ANY UNAUTHORIZED AND UNLAWFUL REPRODUCTION, DISTRIBUTION
OR OTHER USE SHALL BE SUBJECT TO LIABILITY. © 2007 Bucyrus International, Inc. ALL RIGHTS RESERVED.
REV BY REISSUE DATE ECN DESCRIPTION
Bucyrus
International, Inc. PARTS, SPECIAL AND SPARE,
LOT 15
DESCRIPTION REF DWGS DWG SIZE DATE
A005433 ANSI A 05/06/2008
DET ENG CONTACT
G.GRUBER D. BIENFANG
NO SHEET MODEL REV
39HR
UNIT
REVISION DATA A005442 1 of 6 6000 0
COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING
 62300687 air comp/secondary air filters 9 X X
S011061 easy start pump / motor ass'y 1 X X
S022574 drive shaft 1 X X
S027155 separator element 3 X X X X
62053174 comp. Oil pump coupling 1 X X
62046512 Check Valve, Shaft Seal Drain 1 X X X
62046485 Shaft Seal 1 X X X
12910027 Transmitter, Temperature 1 X X
62046273 Gasket, Separator Tank 2 X X
S039479 Cable,Din A,Valve 3 X X X
S039480 Cable,Din A,Switch 3 X X X
S039602 Cable,Shield,Pump 2 X X
S039601 Adapter,Din A to M12 2 X X

Power
Module
P/N Description Qty. New to Consum- Onsite at 0-3 3-6
Region ables Start-Up Years Years
Usage Usage
S027129 Pump Drive Gear Box 1 X X
S023111 Hydrostatic Pump 2 X X X
S023110 Vane Pump 1 X X X
S023108 Open Circuit Pump 1 X X X
S027295 engine coupling element set 1 X X
S023112 divert valve 1 X X
S008642 engine oil filters 32 X X X X
S008643 engine fuel filters 32 X X X X
S008641 engine coolant filters 8 X X X X
S008644 Engine Fuel Filter/Separator 32 X X X X
S033533 Primary Fuel Filter element 32 X X X X
S008658 Ether Cylinder 2 X X X X
S008645 Filter,Engine Air Primary 32 X X X X
S008662 Filter,Engine Air Secondary 16 X X X X
S008659 Alternator 2 X X
S023257 hyd. Tank filter element 18 X X X X
S023258 hyd. Suctin filter element 6 X X X X
S029377 hyd. Charge filter element 6 X X X X
S054501 hyd. Drain return 6 X X X X
S008720 PDT filter 3 X X X X
S008740 Transducer, Pressure 1 X X X
S008660 air conditoner compressor 1 X X
S023260 switch, hyd high temp 1 X X
17182711 switch,fluid level 1 X X
S023265 breather 3 X X X X
S023261 switch, low temp. 1 X X
S027360 exhaust flex. Joint 1 X X
S027402 Exhaust Gasket 1 X X
S027403 Exhauset Gasket 1 X X
S008656 Belt, A/C air compressor 1 X X
S008657 Belt,alternator drive 1 X X
S027340 Kit,Fan Belt 1 X X
S008655 Switch,Eng Prelube 1 X X X
THIS DOCUMENT IS PROTECTED UNDER APPLICABLE COPYRIGHT LAWS TO THE EXTENT AVAILABLE. ANY UNAUTHORIZED AND UNLAWFUL REPRODUCTION, DISTRIBUTION
OR OTHER USE SHALL BE SUBJECT TO LIABILITY. © 2007 Bucyrus International, Inc. ALL RIGHTS RESERVED.

DESCRIPTION
PARTS, SPECIAL AND SPARE, LOT 15
Bucyrus DWG SIZE ANSI A REV 0 REISSUE DATE 05/06/08
International, Inc. NO SHEET

A005442 2
COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING
 S027444 Pump,PDT Cooling 1 X X
S011200 Check Valve 1 X X
S039634 Speed Control 1 X X X
S038554 Speed Sensor 1 X X X
S038531 Speed Control Relay 1 X X X
S038530 Relay 1 X X
S038529 Relay 1 X X
S025199 card driver 1 X X X
S027430 PDT, Cooler Core 1 X
S027429 Air Conditoner Condensor Core 1 X

Main Frame
P/N Description Qty. New to Consum- Onsite at 0-3 3-6
Region ables Start-Up Years Years
Usage Usage
A005103-01 jack spud pin 2 X X X
A005104-01 jack spud pin 2 X X X
C116760-01 jack shoe insert 2 X X
02730150 jack shoe insert nut 2 X X
S021899 jack hydraulic fitting 2 X X X
S004037 jack cylinder 1 X X
S011178 hyd. Oil cooler core 1 X X
S011125 air. Comp. Oil cooler core 1 X X
S025143 fan drain solenoid valve 1 X X
C113964-01 Pipe Arm Clamp-9.25" Pipe 1 X X X
E019387-04 Pipe Arm Clamp-9.25" Pipe 1 X X X
75695750 Spring,Pipe Arm Pawl 2 X X X
S031970 pipe arm clamp cylinder 2 X X X
S011181 pipe arm clamp proximity 2 X X X
S004039 pipe arm gate cylinder 1 X X
S004041 pipe arm lift cylinder (long) 1 X X
S045632 pipe arm ext. cylinder (short) 1 X X
S004036 mast hoist cylinder 1 X X
26580209 Bearing, Cylinder 2 X X
26580213 Bearing, Cylinder 2 X X
26960741 Bearing, Pipe arm lower piviot 1 X X
26960743 Bearning, Pipe Arm Piviot 2 X X
72174381 Seal,Oil 1 X X
72185141 Seal,Oil 2 X X
68146510 O-ring 1 X X
68147825 O-ring 2 X X
62044960 thermostatic valve insert 1 X X X
S025122 valve, directional control 1 X X X
S025120 valve, directional control 1 X X X
S021806 valve, directional control 1 X X X
S011165 motor, fan,air comp cooler 1 X X
S023207 valve, regen 1 X X
S025118 Valve, Cartridge C'balance, Jack 2 X X
S025119 Valve, Cartridge C'balance, Jack 2 X X
S025115 Valve, Cartridge, Check, Jack 1 X X
S025116 Valve, Cartridge, Check, Jack 1 X X
12569211 converter 1 X X X
THIS DOCUMENT IS PROTECTED UNDER APPLICABLE COPYRIGHT LAWS TO THE EXTENT AVAILABLE. ANY UNAUTHORIZED AND UNLAWFUL REPRODUCTION, DISTRIBUTION
OR OTHER USE SHALL BE SUBJECT TO LIABILITY. © 2007 Bucyrus International, Inc. ALL RIGHTS RESERVED.

DESCRIPTION
PARTS, SPECIAL AND SPARE, LOT 15
Bucyrus DWG SIZE ANSI A REV 0 REISSUE DATE 05/06/08
International, Inc. NO SHEET

A005442 3
COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING
 12569226 converter 1 X X X
12579900 relay 1 X X
12092951 contactor 1 X X
12282311 fuse, 50 amp 4 X X X X
12681203 switch, push button 1 X X
S021885 sender, level 1 X X
S011172 valve, cartridge counterbalance 2 X X
S011169 Kit,Seal, Mast Hoist Cylinder 1 X X
12718151 Switch, Proximity 5 X X X
S027205 Fuel,Pump 1 X X
16213043 Cable,SHLD,2-Cond,Profibus 50Ft X
12325201 Connector, Profibus Cable 2 X
S023774 Cable, PDFV, 7-PIN CONN, Shielded 1 X X X
S011167 valve, counterbalance, cartridge 2 X X
S011168 valve, counterbalance, cartridge 2 X X
S011193 O-ring kit 2 X X X X
S021796 Spud shoe assembly 1 X X
62047452 Valve,Pulldown Force 1 X X
S039858 Accumulator 1 X
Operator
Cab
P/N Description Qty. New to Consum- Onsite at 0-3 3-6
Region ables Start-Up Years Years
Usage Usage
17317674 cab light, 12 volt 1 X X X
S036920 Engine Panel 1 X
12783761 switch, selector 1 X X
12783761 switch, selector 1 X X
12569208 converter, DC-DC 1 X X
12579995 relay 2 X X
12324503 clinometer 1 X X
12076167 capacitor 2 X X
12119143 diode 2 X X
12597741 resistor 2 X X
12749077 potentiometer 1 X X X
12749119 rotary master switch 1 X X X
12749070 propel mast switch 1 X X X
12569056 pulldown force pot 1 X X X
12783767 switch, push button 1 X X
12681204 switch 1 X X
12783730 switch, rocker, jack 1 X X X
12783766 switch, sel, 3-position 2 X X
12783758 switch, sel, 3-position 2 X X
12681195 switch, pull-pull (E stop) 1 X X X
12330810 Computer, Display 1 X X
12327019 Port, 2-USB, Ethernet 1 X X
12330812 Battery, UPS, 24VDC 1 X X
12327018 Switch, Ethernet, 5-Pt 1 X X
62046652 module, 24VDC, input 2 X X X
62049302 module, 24VDC, relay output 1 X X X
62045404 module, analog input 2 X X X
62043481 module, computer 1 X X X
THIS DOCUMENT IS PROTECTED UNDER APPLICABLE COPYRIGHT LAWS TO THE EXTENT AVAILABLE. ANY UNAUTHORIZED AND UNLAWFUL REPRODUCTION, DISTRIBUTION
OR OTHER USE SHALL BE SUBJECT TO LIABILITY. © 2007 Bucyrus International, Inc. ALL RIGHTS RESERVED.

DESCRIPTION
PARTS, SPECIAL AND SPARE, LOT 15
Bucyrus DWG SIZE ANSI A REV 0 REISSUE DATE 05/06/08
International, Inc. NO SHEET

A005442 4
COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING
 62046651 module, analog output 2 X X X
62045027 computer 1 X
S033582 Control, Air Conditioner 1 X X
S008646 Filter, Pressurizer 4 X X X X
82300214 Gauge, Fuel 1 X
S033573 Air Conditioner 1 X
S033593 Switch,Drier Pressure 1 X
S033595 Valve,Water 1 X
62049353 Relay,Air Condtioner 1 X
62049356 Valve, Expansion 1 X
62049354 Filter,Return 4 X X X X
62049352 Blower,Air Condtioner 1 X X
62049355 Switch,Air Condtioner 1 X X

Mast
P/N Description Qty. New to Consum- Onsite at 0-3 3-6
Region ables Start-Up Years Years
Usage Usage
S025123 Valve, Directional Control 1 X X X
79446329 Valve, Proportional Control 3 X X X
S025131 Valve, Proportional Control 1 X X
S021865 gasket, air hose 2 X X X
C115682-09 air hose 1 X X X
D022806-11 gasket, air hose 2 X X X
C115682-12 air hose, 65ft Mast 1 X X X
17112536 clamp body 1 X X
17112511 clamp body 10 X X
17112560 clamp body 2 X X
17112513 clamp body 6 X X
17112566 clamp body 2 X X
18230049 rope, wire 290 X X X
D015942-12 gasket, air pipe 1 X X
S004038 cylinder, hose tension 1 X X
S008672 coupling, endoder 1 X X X
12119627 encoder 2 X X X
26118507 sheave bearing 4 X X
26118508 sheave bearing 2 X X
26121280 sheave bearing 2 X X
16213043 remote I/O cable 75 X X X
26217206 guide roller 8 X X
B007632-01 guide roller shaft 8 X X
C113925-01 pinion, idler 2 X X
C116766-01 guide roller assembly 1 X X
S002944 pulldown motor assembly 2 X X
S021770 rotary motor 2 X X
72014001 air seal 1 X X X
82588441 seal, oil 1 X X
68147714 o-ring 1 X X
C115090-04 pad, wear 2 X X X X
D026326-02 pinion, pulldown 2 X X
S004538 pawl, tool wrench 8 X X X
B007719-01 Wear Pads, Tool Wrench-9.25" Pipe 4 X X X X
THIS DOCUMENT IS PROTECTED UNDER APPLICABLE COPYRIGHT LAWS TO THE EXTENT AVAILABLE. ANY UNAUTHORIZED AND UNLAWFUL REPRODUCTION, DISTRIBUTION
OR OTHER USE SHALL BE SUBJECT TO LIABILITY. © 2007 Bucyrus International, Inc. ALL RIGHTS RESERVED.

DESCRIPTION
PARTS, SPECIAL AND SPARE, LOT 15
Bucyrus DWG SIZE ANSI A REV 0 REISSUE DATE 05/06/08
International, Inc. NO SHEET

A005442 5
COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING
 40004821 cylinder, tool wrench 2 X X
S004010 valve, brake 1 X X
97907753 breakout wrench dies 50 X X X X
82210882 shock coupling element 1 X X
82210881 shock coupling element 1 X X
72063360 seal, coupling 1 X X
D019594-01 coupling, bolts 6 X X X
02781700 coupling nuts 6 X X X
03952750 washers 12 X X X
03952950 washers 12 X X X
C114369-01 dust seal 10 X X X X
B007091-02 dust seal retainer 1 X X
S025164 die holder 3 X X
C114337-01 Rod spring 4 X X
82020263 Teckpak 2 X X
A004751-01 Sleeve, bearing 2 X X
79491120 Valve,Shuttle 1 X X
79491119 Valve, Relief, Cartridge, 200 psi 1 X X
79491118 Valve, Relief, Cartridge, Spec, 42 1 X X
A004973-01 Round Pin 4x11 1 X X
S010518 Tube,Scd,4.62x.62Wallx4.00 1 X X
82245471 Assembly,Locking 3.740 ID 2 X X
S010516 Pin, Round 2 2 X X
S010517 Bar,.375x1.25x3.25 2 X X
A005083-01 Pin, Round 4x10 1 X X
OPTIONS
P/N Description Qty. New to Consum- Onsite at 0-3 3-6
Region ables Start-Up Years Years
Usage Usage
82300215 Guage,Water 1 X X
S027258 Valve, Proportional Cntrl,Water Inject 1 X X X
64579034 8.0 GPM Water Pump 1 X X X
64954003 Motor,Water Inj 1 X X
39229910 Coupling,Water Inj 1 X
62051788 Window Washer Tank with pump 1 X
62051796 Window Wiper Blade 10 X X X X
62051793 Windor Wiper Blade 10 X X X X
62051795 Motor,Window Wiper 1 X
62051790 Motor,Window Wiper 1 X
S011186 Cylinder, Carousel 1 X X

THIS DOCUMENT IS PROTECTED UNDER APPLICABLE COPYRIGHT LAWS TO THE EXTENT AVAILABLE. ANY UNAUTHORIZED AND UNLAWFUL REPRODUCTION, DISTRIBUTION
OR OTHER USE SHALL BE SUBJECT TO LIABILITY. © 2007 Bucyrus International, Inc. ALL RIGHTS RESERVED.

DESCRIPTION
PARTS, SPECIAL AND SPARE, LOT 15
Bucyrus DWG SIZE ANSI A REV 0 REISSUE DATE 05/06/08
International, Inc. NO SHEET

A005442 6
COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING COPYRIGHTED-CUSTOMER INFORMATION DRAWING