Revision date: 16/02/2016 Revision: 4

SAFETY DATA SHEET

Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

SECTION 1: Identification of the substance/mixture and of the company/undertaking

1.1. Product identifier

Product name Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

Product number MP0003

1.2. Relevant identified uses of the substance or mixture and uses advised against
Identified uses Cleaner for metals.

1.3. Details of the supplier of the safety data sheet

Supplier Trimite Technologies Ltd
1 Dover Street
Hockley
Birmingham
West Midlands
B18 5HW
Tel: 0121 554 7000 Mon-Thur: 8:30-17:00 Fri: 8:30-13:00
Fax: 0121 554 0242
[email protected]

1.4. Emergency telephone number

Emergency telephone +44 (0) 121 554 7000 Mon-Thur: 8:30-17:00 Fri: 8:30-13:00

SECTION 2: Hazards identification

2.1. Classification of the substance or mixture

Classification
Physical hazards Met. Corr. 1 - H290

Health hazards Skin Corr. 1B - H314 Eye Dam. 1 - H318

Environmental hazards Not Classified

2.2. Label elements

Pictogram

Signal word Danger

Hazard statements H290 May be corrosive to metals.

H314 Causes severe skin burns and eye damage.

1/8
Revision date: 16/02/2016 Revision: 4

Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

Precautionary statements P280 Wear protective gloves/protective clothing/eye protection/face protection.

P301+P330+P331 IF SWALLOWED: Rinse mouth. Do NOT induce vomiting.
P303+P361+P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing.
Rinse skin with water/shower.
P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing.
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove
contact lenses, if present and easy to do. Continue rinsing.

Contains Phosphoric acid

Supplementary precautionary P234 Keep only in original container.

statements P260 Do not breathe vapour/spray.
P264 Wash contaminated skin thoroughly after handling.
P310 Immediately call a POISON CENTER/doctor.
P321 Specific treatment (see medical advice on this label).
P363 Wash contaminated clothing before reuse.
P390 Absorb spillage to prevent material damage.
P405 Store locked up.
P406 Store in corrosive resistant/… container with a resistant inner liner.
P501 Dispose of contents/container in accordance with national regulations.

2.3. Other hazards

This product does not contain any substances classified as PBT or vPvB.

SECTION 3: Composition/information on ingredients

3.2. Mixtures

Phosphoric acid 10-25%

CAS number: 7664-38-2 EC number: 231-633-2

Classification
Skin Corr. 1B - H314
Eye Dam. 1 - H318

2-butoxyethanol 1-10%
CAS number: 111-76-2 EC number: 203-905-0

Classification
Acute Tox. 4 - H302
Acute Tox. 4 - H312
Acute Tox. 4 - H332
Skin Irrit. 2 - H315
Eye Irrit. 2 - H319

The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16.

SECTION 4: First aid measures

4.1. Description of first aid measures

General information Remove affected person from source of contamination. Get medical attention if any discomfort
continues. Show this Safety Data Sheet to the medical personnel.

Inhalation Remove person to fresh air and keep comfortable for breathing. Get medical attention if
symptoms are severe or persist.

2/8
Revision date: 16/02/2016 Revision: 4

Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

Ingestion Do not induce vomiting. Rinse mouth thoroughly with water. Get medical attention
immediately.

Skin contact Remove contaminated clothing and rinse skin thoroughly with water. Continue to rinse for at
least 15 minutes. Get medical attention if symptoms are severe or persist after washing.

Eye contact Remove any contact lenses and open eyelids wide apart. Wash with plenty of water. Continue
to rinse for at least 15 minutes and get medical attention.

Protection of first aiders First aid personnel should wear appropriate protective equipment during any rescue.

4.2. Most important symptoms and effects, both acute and delayed
General information The severity of the symptoms described will vary dependent on the concentration and the
length of exposure.

Inhalation Irritation of nose, throat and airway.

Ingestion May cause chemical burns in mouth, oesophagus and stomach. May cause stomach pain or
vomiting.

Skin contact Burns can occur.

Eye contact Contact with concentrated chemical may very rapidly cause severe eye damage, possibly loss
of sight.

4.3. Indication of any immediate medical attention and special treatment needed
Specific treatments Show this safety data sheet to the doctor in attendance.

SECTION 5: Firefighting measures

5.1. Extinguishing media

Suitable extinguishing media Use fire-extinguishing media suitable for the surrounding fire.

5.2. Special hazards arising from the substance or mixture

Hazardous combustion In combustion, harmful or even toxic fumes may be produced
products

5.3. Advice for firefighters

Protective actions during If risk of water pollution occurs, notify appropriate authorities.
firefighting

Special protective equipment Wear positive-pressure self-contained breathing apparatus (SCBA) and appropriate protective
for firefighters clothing.

SECTION 6: Accidental release measures

6.1. Personal precautions, protective equipment and emergency procedures

Personal precautions Wear protective clothing as described in Section 8 of this safety data sheet.

6.2. Environmental precautions

Environmental precautions Do not allow to enter drains or watercourses. If the product contaminates lakes, rivers, or
sewers, inform the appropriate authorities in accordance with local regulations.

6.3. Methods and material for containment and cleaning up

Methods for cleaning up Absorb spillage with sand or other inert absorbent.

6.4. Reference to other sections

Reference to other sections For personal protection, see Section 8. For waste disposal, see Section 13.

3/8
Revision date: 16/02/2016 Revision: 4

Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

SECTION 7: Handling and storage

7.1. Precautions for safe handling

Usage precautions Do not handle until all safety precautions have been read and understood. Read label before
use.

Advice on general Do not eat, drink or smoke when using this product. Wash hands thoroughly after handling.
occupational hygiene Provide eyewash station and safety shower.

7.2. Conditions for safe storage, including any incompatibilities

Storage precautions Store in tightly-closed, original container in a dry, cool and well-ventilated place. Store at
temperatures between 5°C and 25°C.

7.3. Specific end use(s)

Specific end use(s) The identified uses for this product are detailed in Section 1.2.

SECTION 8: Exposure Controls/personal protection

8.1. Control parameters

Occupational exposure limits
Phosphoric acid
Long-term exposure limit (8-hour TWA): WEL 1 mg/m³ respirable dust
Short-term exposure limit (15-minute): WEL 2 mg/m³ respirable dust
2-butoxyethanol
Long-term exposure limit (8-hour TWA): WEL 123 mg/m³ vapour
Short-term exposure limit (15-minute): WEL 246 mg/m³ vapour
WEL = Workplace Exposure Limit

8.2. Exposure controls

Protective equipment

Appropriate engineering Provide adequate ventilation.

controls

Eye/face protection Wear chemical splash goggles.

Hand protection Wear protective gloves. It is recommended that chemical-resistant, impervious gloves are
worn. To protect hands from chemicals, gloves should comply with European Standard
EN374. The most suitable glove should be chosen in consultation with the glove
supplier/manufacturer, who can provide information about the breakthrough time of the glove
material. Considering the data specified by the glove manufacturer, check during use that the
gloves are retaining their protective properties and change them as soon as any deterioration
is detected.

Other skin and body Wear suitable protective clothing as protection against splashing or contamination. Provide
protection eyewash station and safety shower.

Hygiene measures Good personal hygiene procedures should be implemented. Wash hands thoroughly after
handling. Do not eat, drink or smoke when using this product. Promptly remove any clothing
that becomes contaminated.

Respiratory protection Respiratory protection must be used if the airborne contamination exceeds the recommended
occupational exposure limit. If ventilation is inadequate, suitable respiratory protection must
be worn.

4/8
Revision date: 16/02/2016 Revision: 4

Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

Thermal hazards Contact with hot product can cause serious thermal burns.

Environmental exposure Keep container tightly sealed when not in use. Residues and empty containers should be
controls taken care of as hazardous waste according to local and national provisions.

SECTION 9: Physical and Chemical Properties

9.1. Information on basic physical and chemical properties

Appearance Liquid.

Colour Colourless to pale yellow.

Odour Characteristic.

pH pH (concentrated solution): 1-2

Flash point > 61°C

Relative density ~ 1.1-1.2

Solubility(ies) Miscible with water.

9.2. Other information

Other information No data available.

SECTION 10: Stability and reactivity

10.1. Reactivity
Reactivity Stable at normal ambient temperatures and when used as recommended.

10.2. Chemical stability

Stability Stable at normal ambient temperatures and when used as recommended.

10.3. Possibility of hazardous reactions

Possibility of hazardous Under normal conditions of storage and use, no hazardous reactions will occur.
reactions

10.4. Conditions to avoid

Conditions to avoid Avoid exposure to high temperatures or direct sunlight.

10.5. Incompatible materials

Materials to avoid Alkalis. Massive, solid metal. Powdered metal.

10.6. Hazardous decomposition products

Hazardous decomposition In combustion, harmful or even toxic fumes may be produced
products

SECTION 11: Toxicological information

11.1. Information on toxicological effects

Acute toxicity - oral
ATE oral (mg/kg) 5,000.0

Acute toxicity - dermal

ATE dermal (mg/kg) 11,000.0

Acute toxicity - inhalation

ATE inhalation (vapours mg/l) 110.0

Serious eye damage/irritation

5/8
Revision date: 16/02/2016 Revision: 4

Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

Serious eye damage/irritation Corrosivity to eyes is assumed.

Inhalation Burns can occur.

Ingestion May cause chemical burns in mouth, oesophagus and stomach. May cause chemical burns in
mouth and throat. Swallowing concentrated chemical may cause severe internal injury.

Skin contact Burns can occur.

Eye contact Contact with concentrated chemical may very rapidly cause severe eye damage, possibly loss
of sight.

Route of entry Inhalation Ingestion Skin and/or eye contact Combined

SECTION 12: Ecological Information

12.1. Toxicity
Toxicity No data available.

12.2. Persistence and degradability

Persistence and degradability The product is biodegradable.

12.3. Bioaccumulative potential

Bioaccumulative potential No data available on bioaccumulation.

12.4. Mobility in soil

Mobility The product is water-soluble and may spread in water systems.

12.5. Results of PBT and vPvB assessment

Results of PBT and vPvB This product does not contain any substances classified as PBT or vPvB.
assessment

12.6. Other adverse effects

Other adverse effects Fatal to fish and other aquatic life due to low pH.

SECTION 13: Disposal considerations

13.1. Waste treatment methods

General information This material and its container must be disposed of as hazardous waste.

Disposal methods Dispose of waste to licensed waste disposal site in accordance with the requirements of the
local Waste Disposal Authority.

SECTION 14: Transport information

14.1. UN number
UN No. (ADR/RID) 1805

UN No. (IMDG) 1805

UN No. (ICAO) 1805

UN No. (ADN) 1805

14.2. UN proper shipping name

Proper shipping name PHOSPHORIC ACID, SOLUTION
(ADR/RID)

6/8
Revision date: 16/02/2016 Revision: 4

Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

Proper shipping name PHOSPHORIC ACID, SOLUTION

(IMDG)

Proper shipping name (ICAO) PHOSPHORIC ACID, SOLUTION

Proper shipping name (ADN) PHOSPHORIC ACID, SOLUTION

14.3. Transport hazard class(es)

ADR/RID class 8

ADR/RID classification code C1

ADR/RID label 8

IMDG class 8

ICAO class/division 8

ADN class 8

Transport labels

14.4. Packing group

ADR/RID packing group III

IMDG packing group III

ADN packing group III

ICAO packing group III

14.5. Environmental hazards

Environmentally hazardous substance/marine pollutant

No.

14.6. Special precautions for user

EmS F-A, S-B

ADR transport category 3

Emergency Action Code 2R

Hazard Identification Number 80

(ADR/RID)

Tunnel restriction code (E)

14.7. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code
SECTION 15: Regulatory information

15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
15.2. Chemical safety assessment
No chemical safety assessment has been carried out.

SECTION 16: Other information

Revision date 16/02/2016

7/8
Revision date: 16/02/2016 Revision: 4

Bonderite C-IC 624 MOD (Deoxidine 624 MOD)

Revision 4

SDS number 5995

Hazard statements in full H290 May be corrosive to metals.

H302 Harmful if swallowed.
H312 Harmful in contact with skin.
H314 Causes severe skin burns and eye damage.
H315 Causes skin irritation.
H318 Causes serious eye damage.
H319 Causes serious eye irritation.
H332 Harmful if inhaled.

This information relates only to the specific material designated and may not be valid for such material used in combination
with any other materials or in any process. Such information is, to the best of the company's knowledge and belief, accurate
and reliable as of the date indicated. However, no warranty, guarantee or representation is made to its accuracy, reliability or
completeness. It is the user's responsibility to satisfy himself as to the suitability of such information for his own particular use.

8/8