NOTAS GENERALES

CT-2604 HE-2611 NOTES 1,15 General Notes

DEBUTANIZER DEBUTANIZER HH
COLUMN REBOILER PIT PI NOTES:
2615 2BM 2615 1. FOR EMERGENCY SHUT DOWN CAUSE AND EFFECT RELATION SEE DOCUMENT
VH PSV LPG/F-PCF-GN-PRF-00-001 "CAUSE AND EFFECT CHART".
2. FE-2609 AND FV-2609 HAVE TO BE LOCATED AT GRADE.

3/4"MDB2A1-1
NOTE 11 2604C SPARE
3. VENTILATION NOZZLE.
BLOCKED OUTLET 4. HE-2611 BAFFLE TOP SHALL BE AT LEAST 12 in ABOVE CT-2604 HHL.

3/4"BA-01
6"BA-02 6"x4" 3"K4" 5. DELETED.
FP A2A1
LO 4"x3" SET AT NOTE 17 OVERHEAD VAPORS 6. FACILITY FOR LPG REPROCESS IN CASE OF HIGH PENTANE CONTENT.
B2A1 353 psi-g TO HE-2612 7. FACILITY FOR NGL REPROCESS IN CASE OF HIGH PENTANE CONTENT.
3/4"GL-01 12"-PG-26032-B2A1-PP 8. LOCAL INDICATION ACCESIBLE TO THE OPERATOR.
MP-PRE-26-007-1/1
SEE DETAIL "H" (NO POCKETS) 9. THREE POSITION SWITCH:
NOTE 19 SET@ 320 psi-g MODE 1=NORMAL OPERATION
NOTE 21 3/4"BA-01 PV
PSV FP PIC M=2,3 MODE 2=GAS OPERATION
LC MODE 3=PARTIAL GAS OPERATION
2604B 4"BA-05 2603 FOR DETAIL INFORMATION REFER TO LPG/F-PCF-GN-PRU-00-004 (FILOSOFIA DE CONTROL
BLOCKED OUTLET DE PROCESO).

3/4"BA-01
6"BA-02 6"x4" 3"K4" PV 10. FAILURE CLOSE VALVE POSITION IN LINE 6"-OT-26058-B2A1-EC DIRECTION.
10"-VH-26073-A2A1-VA

FP A2A1 NOTE 17 SET AT 11. DRAINS AND VENTS ACCORDING TO DISCHARGE TYPE ARE GOING TO THE FOLLOWING P&DS:
LO 2603
B2A1 4"x3" 371 psi-g LPG TO OVHD GAS COMPRESSOR DISCHARGE TYPE P&ID
3/4"GL-01 8"-PG-26043-B2A1-EC PU-PRE-07-074-1/1
MP-PRE-26-002-1/1 VC COLD FLARE
SEE DETAIL "H" PU-PRE-07-071-1/1
8"BA-05 8"x6" 6"-300# 8"x6" 8"BA-05

3/4"BA-01
NOTE 21 3/4"BA-01 PI VL LOW PRESSURE FLARE PU-PRE-06-061-1/1
FLP

3/4"BA-01
PSV FP
LO 2613 VH HIGH PRESSURE FLARE MP-PRE-05-002-1/1
2604A 4"BA-05 NOTE 8 DC CLOSED DRAIN PU-PRE-09-091-1/2-2/2

3/4"MDB2A1-1
BLOCKED OUTLET SEE DETAIL "E" 12. 20 DIAMETERS OF STRAIGHT PIPELINE UPSTREAM AND 4 DIAMETERS DOWNSTREAM OF THE
PI
3/4"BA-01

6"BA-02 6"x4" 3"K4" 3/4"MDB2A1-1 NOTE 21 FLOW ELEMENT.

FP A2A1 NOTE 17 SET AT 8"x4" 2614A NOTE 24 13. DELETED.
LO
A2A1 B2A1 4"x3" 353 psi-g TO PY-2605 14. VORTEX BREAKER.
B2A1 2" 3/4"GL-01 PIT PY 6"BA-05 6"GL-03 PIC M=1 15. TRANSMITER MUST BE SIL 2 CERTIFIED.
TI MP-PRE-26-007-1/1
LC 2614A 2614 2605 16. DELETED
SEE DETAIL "H" 3/4"BA-01 2630 PIT 17. PSV INLET/OUTLET DIAMETERS CONFIRMED BASED ON FINAL VENDOR INFORMACION.
NOTE 21 FP 18. DELETED.
2614B

2"-MDB2A1-2
LO

3/4"-MDB2A1-1
TO PIC-2614 19. SET @ 320 psig FOR OPERATION MODE 2 AND 3. FOR OPERATION MODE 1, PIC-2603 SHALL BE
4"BA-05 M=1,2,3 PV FORCED TO OPERATE ON MANUAL MODE AND CLOSE PV-2603.
PI MP-PRE-26-007-1/1 20. HAND SWITCH IS LOCATED AT MATRIX PANEL IN CCR.
TIT
3/4"BA-01

2" 21. FOR TYPICAL DRAIN ARRANGEMENT DETAILS SEE P&ID: LPG/F-PCF-GN-PRE-00-001-01.
LC 2630 PI 2614B TI H 22. I-3FB ACTIVETED UNDER SDV-2633 NOT OPEN (ZSO) AND CONFIRMATION OF CLOSE POSITION
NOTE 3 FIC

8"-PG-26070-B2A1-PP
6" 2614 NOTE 8 2634 (ZSC).
3/4"GL-01

2610 23. FORCE TV-2632 TO FAILURE POSITION WHEN SDV-2608 CLOSES.

NOTE 20 L
HS 24. SELECTOR TO BE PROVIDED FOR TRANSMITTER PIT MAINTENANCE PORPUSES.

3/4"MDB2A1-1
TE
2607A FIT
2630 TIT TE
1½" 2610 NOTE 9
2634 2634 FV
HS
INHIBIT OPEN / CLOSE 2610 LPG REFLUX M=1,2,3
HS 1½" FROM P-2603A/B 2615
6"-LG-26111-B2A1-VA NOTE 12 6"-LG-26039-B2AL-VA
3AR 3FA 2607 12" MP-PRE-26-007-1/1
TI TIT 6"BA-05 6"CK-04 6"BA-05 6"x3" 3"-300# 6"x3" 6"BA-05
24" MIN FO

3/4"BA-01
3/4"BA-01
2667 2667 MH DETAIL "A"
RO DETAIL "B" 1 FE ZLO ZLC
SEE DETAIL "D"
2602 NOTE 21 2610 XXX XXX
BDV
TE 2 0.4" EC
2607 I
2667 VC DC
8"-VH-26072-A2A1-VA 6"-PG-26071-B2A1-PP 3"GL-03 3"BA-05
VH 10 SEE DETAIL "D"
3/4"BA-01

8"BA-05 8"x6" 6"-300# 6"BA-05 TIT TE NOTE 21

NOTE 11 LO FLP LO I I I
2658 2658 SDV
MH
3/4"GL-01

24" XXX
H
TIC
TI
DEBUTANIZER FEED 12"x8" 12" 11 2632
FROM HE-2610 2658 NOTE 8 L ZSO ZSC PST
MP-PRE-26-005-1/1 8"-PC-26061-B2A1-EC
12 TI XXX XXX XXX
3/4"BA-01

(TWO PHASE FLOW) 8"CK-04 8"BA-15

2632 SDV
TIT TE CT-2604 24"
34 MH XXX
2659 2659
LPG REPROCESS NOTE 6 TE TIT
FROM SPHERES 2632 2632
2"-LG-26060-B2AL-VA
MP-PRE-26-004-1/1
TI
3/4"BA-01

2"CK-04 2"BA-15 MH
NC 2659 24" DETAIL "B"

NGL REPROCESS NOTE 8 I ZLO ZLC

FROM TANKS NOTE 7 XXX XXX
2"-PN-89013-B2A1-VA PDI
MP-PRE-89-002-1/1 LIT LIC
2"BA-05
3/4"BA-01

2"CK-04 2"GA-15 2602A FIC

NC 35 2609 2609
GW L 2609
H
PDT PDI SEE DETAIL "I"
TI I I
2602 2602 NOTE 21 FIT BDY BDY
2609 2636
2"BA-05 FV A B
3/4"GL-01 PI 2609 C5 FROM PENTANE DRAW-OFF
NOTE 14
2604A 1½" TO AIRCOOLER HE-2615
NOTE 12 3"-NP-26045-B2A1-VA
2"MDB2A1-2

3/4"BA-01 3"-NP-26044-B2A1-VA
MP-PRE-26-007-1/1
36 4"x3" NO POCKETS NOTE 1 (TWO PHASE FLOW)
3/4"MDB2A1-1

4" 3"GA-05 3"x1½" 1½"-300# 3"x1½" 3"GA-05

ZSO ZSC

3/4"GA-01
FC
NOTE 2

THIS DOCUMENT IS PROPERTY OF TIPIEL SA IT MAY NOT BE COPIED, REPRODUCED AND/OR CIRCULATED WITHOUT AUTHORIZATION
NOTE 1 XXX XXX

ESTE DOCUMENTO ES PROPIEDAD DE TIPIEL SA Y NO DEBE SER COPIADO, REPRODUCIDO Y/O CIRCULADO SIN SU AUTORIZACIÓN.
FE
3/4"GL-01

3/4"GL-01

HH 2CI 2BM 1A11

TI TIT TE SEE DETAIL "D" BDV
41 2609 NOTE 21 OPEN / CLOSE
2631 3FF 2631 2631 PI PIT HS XXX
B2A1 B2A1 14" NOTE 2
2616 2616 3FF 2608
A2A1 A0G1
3/4"-DC-26364-A2A1-VA

2"GA-05
3/4"-VC-26365-A0G1-N

SP

3/4"MSB2A1-1
I 14"-PG-26049-B2A1-EC 1½"GA-05 1½"GL-03 NOTES 10, 23
DETAIL "A"
024-1 J (NO POCKETS)
42 12" SDV TV
DOCUMENTOS DE REFERENCIA
2608 2632 HOT OIL Reference Documents
FROM FH-0801 DOCUMENTO No. DESCRIPCIÓN
SEE DETAIL "I" HHL: 80 in 6"-OT-26058-B2A1-EC B A REF. Document No. REV. Description
NOTE 21 PU-PRE-08-002-1/1
HL: 65 in HH
LL = 27 in LI 6"300# 6"GA-05 6"X4" 6"X4" 6"GA-05
2"GA-05 TI FC C 6"OT-08003-B2A1-EC

3/4"GA-04

3/4"GA-04
LLL = 12 in
2BJ 2610A
DC VC 2633
2"GA-05 TI SEE DETAIL "I"
H NOTE 21 TIT
TO LV-2612 2661 REVISIONES
LIC LIT LG 2"GA-05 2633
MP-PRE-26-005-1/1 24" LI Revisions
2612 2612 2608 MH LI 0 29-JUN-2018 ISSUED FOR CONSTRUCTION E.GARCIA I.SANCHEZ O.SANGUINOD.MANRIQUE
2616

Calle 38 No. 8-62 Bogotá - Colombia.

L (CONTRACT 3010893)
2610B LL
TIT 2"GA-05 LL D3 26-APR-2018 DETAILED ENGINEERING FINAL ISSUE E.GARCIA I.SANCHEZ O.SANGUINOD.MANRIQUE
TE (CONTRACT 3010893)
2"GA-05 2661 NOTE 1 A2 01-FEB-2018 ISSUED FOR COMMENTS M.SANTAMARIA I.SANCHEZ O.SANGUINOD.MANRIQUE
12"-PN-26048-B2A1-EC

2633 14"x10" 14"x10"

2"GA-05

2"GA-05
2"GA-05 1½" H (CONTRACT 3010893)
LIT LI D2 29-DEC-2016 APRROVED FOR DESIGN (REVISED AHS SHOWN) C.LOPEZ H.MONTOYA O.SANGUINO A.ARRIETA
2"GA-05 TE 0.6"-EC 10" 3FF D1 15-NOV-2016 APPROVED FOR DESIGN C.LOPEZ H.MONTOYA O.SANGUINO A.ARRIETA
1oo2

2610A 2BP 10" 2611A

2661 0.6" EC L A1 28-SEP-2016 ISSUE FOR COMMENTS C.LOPEZ H.MONTOYA O.SANGUINO A.ARRIETA
6"GA-05 HE-2611 FECHA DESCRIPCIÓN PREPARÓ CHEQUEÓ APROBÓ AUTORIZÓ
LIT LI 0.6"-EC GW REV. Date Description Prepared by Checked by Approved by Authorized by
2610B 2"GA-05 NOTE 4 LIT LIT
2610A
2"GA-05 LL 2611A 2616

EXCHANGERS HE-2611 LIT 2"GA-05 SEE DETAIL "I"

TYPE KETTLE 2"GA-05 2610C 2CD NOTE 21
6"
2"GA-05

2"GA-05

SURFACE 1716 ft^2

NOTE 1 6"GA-05 SEE DETAIL "I"
OP. PRESS. SHELL/TUB. 325 psi-g / 96 psi-g
OP. TEMP. SHELL/TUB. 2"GA-05 NOTE 21
(371 / 386 °F) / (550 / 426 °F)
DES. PRESS. SHELL/TUB. FV / 360 psi-g / 300 psig 3"x2" 3"GA-05 3"CK-04 3"GA-05 LI
11 ft

DES. TEMP. SHELL/TUB. V.B LG

DUTY
(435/40 °F) / (600/59 °F)
18.20 MMBTU/hr
SP H 3/4"GA-01 2610C 2617
INGENIERÍA COMPRAS CONSTRUCCIÓN Y PUESTA EN
038 C
LL
MATERIAL
TRIM NUMBER
C.S.
PN-26093-B2A1-EC
6"-PN-26108-B2A1-EC NO POCKETS PI SERVICIO DE LA PLANTA DE ESTABILIZACIÓN DE
NOTE 22 2617 CONDENSADOS DEL CPF CUPIAGUA
2"GA-01

3/4"MSB2A1-1 3/4"GA-04

6"GA-05
3FB
OPEN /
TOWERS CT-2604 HS
TYPE TRAYS
CLOSE
2"GA-01 HOT OIL PIPING AND INSTRUMENTATION DIAGRAM
2633B 2"GA-01 3/4"GL-01 TO HE-2609
HEIGHT 111 ft 6"-OT-08001-B2A1-EC
DEBUTANIZER COLUMN
6"-300# 6"GA-05

MP-PRE-26-004-1/1
B2A1
A2A1

DIAMETER TOP/BOTTOM 78 in / 90 in
ZSO ZSC 3/4"GA-01 NOTE 11
OP. PRESSURE 178 psi-g / 183 psi-g
OP. TEMPERATURE 152 °F / 321 °F 2CD 2"-DC-09239-A2A1-VA
DC ESCALA CONTRATO PLANO No. HOJA
Scale Contract Drawing No. Sheet REV.
DES. PRESSURE 353 psi-g / 360 psi-g +HYD/FV CLOSE TE TIT TI
2"GL-03
FC

DES. TEMPERATURE 270 °F / 435 °F 3CP 2635 2635 2635 DE

MATERIAL C.S. N/A 3010893 LPG/F-PCF-MP-PRE-26-006-1/1 01 Of 01 0
TRIM NUMBER PN-26092-B2A1-EC ZSO NGL PRODUCT/RECYCLE
DETAIL "A" 1½" TO HE-2610
2633 6"-PN-26050-B2A1-EC CÓDIGO TIPIEL:
MP-PRE-26-005-1/1 1348-0000-PID-0021-06-01
ARCHIVO CAD: LPGFPCFMPPRE26006.1-1.0 PID - DEBUTANIZER COLUMN.dwg FDP ISO A1_1 : ISO A1 841x 594mm
CAD File