Material Safety Data Sheet
PERMATREAT® 2510
Version 1. Print Date 03/12/2008
Revision Date 03/12/2008
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Product name : PERMATREAT® 2510
MSDS Number : REL_70176
Company : OAKITE PRODUCTS INC
675 Central Avenue
New Providence, NJ 07974
Telephone : +18005264473
Telefax : +19084644658
Emergency telephone no : CHEMTREC - 800-424-9300
SECTION 2. HAZARDOUS COMPONENTS INFORMATION
Component CAS-No. Weight %
Chromic (VI) Acid 1333-82-0 10.00 - 20.00
Chromium (III) chromate (VI) 24613-89-6 10.00 - 20.00
Phosphoric acid 7664-38-2 10.00 - 30.00
Unidentified ingredients are considered not hazardous under Federal Hazard Communication
Standard (29CFR 1910.1200).
SECTION 3. HAZARDS IDENTIFICATION
Emergency Overview
Form : liquid
Colour : green
Odour : acrid
Hazard Summary : Harmful by inhalation.Harmful if swallowed.Causes severe
burns.May cause cancer.Oxidizing properties.
Route(s) of Entry : Inhalation Skin Ingestion
yes yes yes
Carcinogenicity:
NTP Chromic (VI) Acid This substance is listed by NTP as a Carcinogen.
Chromium (III) This substance is listed by NTP as a Carcinogen.
chromate (VI)
IARC Chromic (VI) Acid This substance is listed by IARC as a Carcinogen.
Chromium (III) This substance is listed by IARC as a Carcinogen.
chromate (VI)
OSHA No substance in this product is regulated by OSHA as a carcinogen
N.D. - Not Determined 1/6 N.A. - Not Applicable
Material Safety Data Sheet
PERMATREAT® 2510
Version 1. Print Date 03/12/2008
Revision Date 03/12/2008
SECTION 4. FIRST AID MEASURES
Inhalation : Move to fresh air If symptoms persist, call a physician If
breathing is irregular or stopped, administer artificial respiration
Skin contact : Wash off immediately with plenty of water for at least 15
minutesTake off contaminated clothing and shoes
immediatelyCall a physician if irritation develops or persists.
Eye contact : Rinse immediately with plenty of water for at least 15
minutesKeep eye wide open while rinsingGet medical attention
immediately
Ingestion : Rinse mouthDrink 1 or 2 glasses of waterNever give anything
by mouth to an unconscious personGet medical attention
immediately
SECTION 5. FIRE-FIGHTING MEASURES
Flash point : > 100 °C (> 100 °C)
Lower explosion limit : Note: Not applicable.
Upper explosion limit : Note: Not applicable.
Suitable extinguishing : dry chemical
media carbon dioxide (CO2)
foam
water spray
Special protective : In the event of fire, wear self-contained breathing apparatus.
equipment for fire-fighters
Further information : Water mist may be used to cool closed containers.
SECTION 6. ACCIDENTAL RELEASE MEASURES
Personal precautions : Ensure adequate ventilation.
Use personal protective equipment.
Methods for cleaning up : Ventilate area.
Neutralize with lime milk or soda and flush with plenty of water.
Clean up with inert absorbant material.
Keep in suitable, closed containers for disposal.
N.D. - Not Determined 2/6 N.A. - Not Applicable
Material Safety Data Sheet
PERMATREAT® 2510
Version 1. Print Date 03/12/2008
Revision Date 03/12/2008
Additional advice : Never return spills in original containers for re-use.
SECTION 7. HANDLING AND STORAGE
Handling
Handling : Add this product to surface of solution slowly to avoid
spattering
Do not add large amounts of product to solution at any one
time.
Use with adequate ventillation.
Storage
Requirements for storage : KEEP FROM FREEZING
areas and containers Store indoors in a cool, well-ventilated place
Do not allow to dry-out
Keep drum out of sun and away from heat.
Keep containers tightly closed to avoid contamination
SECTION 8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Component ACGIH OSHA
TLV PEL
(TWA) (TWA)
Chromic (VI) Acid 0.05 mg/m3 0.005 mg/m3
as CrN.D. as CrN.D.
Chromium (III) chromate (VI) 0.05 mg/m3 0.005 mg/m3
as CrN.D. as CrN.D.
Phosphoric acid 1 mg/m3 1 mg/m3
N.D. N.D.
Eye protection : Chemical resistant goggles must be worn.
face-shield
Hand protection : impervious gloves
Skin and body protection : rubber or plastic apron
Respiratory protection : If the occupational exposure limits cannot be met, suitable
respiratory equipment should be worn .
Hygiene measures : Avoid contact with skin, eyes and clothing
Wear suitable gloves and eye/face protection
Wear suitable protective clothing
Wash hands before breaks and immediately after handling the
product
Provide adequate ventilation
N.D. - Not Determined 3/6 N.A. - Not Applicable
Material Safety Data Sheet
PERMATREAT® 2510
Version 1. Print Date 03/12/2008
Revision Date 03/12/2008
Do not inhale fumes.
Keep away from food and drink
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
pH : < 2.5
Melting point/range : -15.5 °C (-15.5 °C)
Boiling point/range : Note: no data available
Vapour pressure : Note: no data available
Bulk density : 12.03 lb/gal
Water solubility : Note: completely soluble
Percent of Volatile by Weight : 0
excluding water
Relative density : 1.44
Evaporation rate : Note: (Water =1) Less than 1
SECTION 10. STABILITY AND REACTIVITY
Conditions to avoid : Avoid letting the product become dry.
Direct sources of heat.
freezing
Materials to avoid : bases
reducing agents
combustible material
organic materials
Warning! Do not use together with other products; may
release dangerous gases (chlorine).
Hazardous decomposition : carbon oxides
products chromium oxides
SECTION 11. TOXICOLOGICAL INFORMATION
Toxicity: : Mixture; Not Determined.
Acute oral toxicity
N.D. - Not Determined 4/6 N.A. - Not Applicable
Material Safety Data Sheet
PERMATREAT® 2510
Version 1. Print Date 03/12/2008
Revision Date 03/12/2008
Chromic (VI) Acid : LD50, rat
Dose: 52 mg/kg
Phosphoric acid : LD50, rat
Dose: 1,530 mg/kg
SECTION 12. ECOLOGICAL INFORMATION
Not Available
SECTION 13. DISPOSAL CONSIDERATIONS
Advice on Disposal : Refer to all federal, provincial,state and local regulation prior to
disposition of container and unused contents by reuse, recycle
or disposal.
SECTION 14. TRANSPORT INFORMATION
Refer to Bill of Lading.
SECTION 15. REGULATORY INFORMATION
TSCA Status : All components of this material comply with US TSCA
requirements.
SARA 313 Components : Chromic (VI) Acid CAS-No. 1333-82-0
: Chromium (III) CAS-No. 24613-89-6
chromate (VI)
SARA 313 Components : N.D.
CERCLA Reportable Quantity : Chromic (VI) Acid 10 Pounds
: Chromium (III) 10 Pounds
chromate (VI)
: Phosphoric acid 5,000 Pounds
California Prop. 65 : N.D
NFPA : 3 0 1 Corrosive
HMIS : 301D
WHMIS : E: Corrosive Material
D2A: Very Toxic Material Causing Other Toxic Effects
N.D. - Not Determined 5/6 N.A. - Not Applicable
Material Safety Data Sheet
PERMATREAT® 2510
Version 1. Print Date 03/12/2008
Revision Date 03/12/2008
SECTION 16. OTHER INFORMATION
Further information
Oakite Products, Inc. warrants that the products described herein will conform with its published specifications. The
products supplied by Oakite and information related to them are intended for use by buyers having necessary industrial
skill and knowledge. Buyers should undertake sufficient verification and testing to determine the suitability of the Oakite
materials for their own particular purpose. Since buyer's conditions of use of products are beyond Oakite's control,
Oakite does not warrant any recommendations and information for the use of such products. OAKITE DISCLAIMS ALL
OTHER WARRANTIES INCLUDING THE IMPLIED WARRANTY OF MERCHANTABILITY AND FITNESS FOR ANY
PARTICULAR PURPOSE IN CONNECTION WITH THE USE OF ITS PRODUCTS.
N.D. - Not Determined 6/6 N.A. - Not Applicable
