Integrated solutions for small and

medium size chiller/heat pumps

T e c h n o l o g y & E v o l u t i o n
 Integrated solutions for small and
medium size chiller/heat pumps

μC sistema setting specific parameters, for chillers, heat pumps,

This is the result of CAREL’s decades’ long experience and condensing units:
in the design and production of parametric controllers - water cooled
for HVAC units. - air cooled
- up to two circuits
μC sistema is made up of parametric controllers, in
- up to 3 steps per circuit.
both the panel mounted and DIN rail versions, user
interfaces, both local and remote, communication All controllers can be equipped with accessories to
interfaces, input/output expansions and electronic ensure maximum performance and energy savings,
expansion valve drivers. such as electronic expansion valves and ratiometric
pressure transducers.
A wide range of applications can be customised by
 comfort process std/water condensing
μC sistema software functions
chiller chiller source HP unit
Dinamic P+I control on inlet and outlet
l l
water temperature
Condenser/evaporator control l l l l
Part-winding management l
Solenoid valve control and pump
l l µC sistema
down management
Sliding defrost in HP mode l l up to 10 analogue inputs:
5 CAREL NTC,
Antifreeze electrical heater l l l
2 x 0 to 5 Vdc ratiometric transducers,
Electrical heater as support to
l 1 x 4 to 20 mA current signal,
compressors
2 CAREL NTC or 0 to 5 Vdc ratiometric
Control and warning of component
l l l l transducers, configurable via software.
operating hours
Unloading for high pressure in up to 18 digital inputs:
l l l
chiller mode 18 voltage-free contacts (not optically-isolated)
Preventive ventilation when starting with
l l l up to 6 analogue outputs:
high outside temperatures at startup
Stop compressors due to low outside 4 x 0 to 10 Vdc, 2 PWM
l l
temperature values up to 14 digital outputs:
Unloading for low pressure (HP) l l 12 electromechanical relays,
Low noise in chiller and HP mode l l 2 electromechanical relays with changeover
Set point variation and ON/OFF from contacts.
l l
time bands
Management of electronic
l l l
expansion valve
Event and data logging l l
Smart key - download logged data to PC l
Send alarms by SMS l l
Auto-tuning l
Self-diagnostics l l
Automatic changeover l
Ground source water management l l
Smart defrost l l
µe-dronic l l
Fan speed control up to 2–4–6–8–12 A,
230 Vac single phase or 6-9-12-20-40 A three
User terminals phase 400 Vac.
The wide range of user interfaces makes interaction with μC sistema Expansion board for second circuit with up
family controllers simple and effective, according to specific requirements. to 15 I/O.

Serial card for CAREL, Modbus®, LON®, GSM

Communication messaging.
All the controllers, from μC3 to μC2, are compatible with the CAREL
protocol (PlantVisor) and Modbus® RTU, for third party BMS systems.

Moreover, connection to internet/intranet networks is available via the

WebGATE gateway over Ethernet™ 10 Mb/s.

In particular, μC3 can be connected, as an alternative to RS485, to an

RS232 board for managing a GSM modem and consequently exchanging
SMS messages, or a LON board for connection to LonWorks™
supervisory systems.
Remote user terminal with LCD icons for
wall-mounting featuring a built-in temperature
μe-dronic and humidity sensor.
μAM area manager can manage one μC2 SE controller and up to 10 Service remote terminal for panel or wall
e-drofan master fan coil controllers in synergy. mounting with a graphic LCD.

Each master can in turn be connected to up to 5 slaves. Local user terminal: simple and competitive
LED display.
The μ-edronic system monitors the alarms in the installation, allows
synchronised management of the fan coils, and implements
energy-saving strategies according to the load measured and the
temperature and humidity in the room.
Headquarters

+302239366 - 1.0 - 01.03.06

CAREL S.p.A.
Via dell’Industria, 11 - 35020 Brugine - Padova (Italy)
Tel. (+39) 0499 716611 - Fax (+39) 0499 716600
[email protected] - www.carel.com

Subsidiaries Affiliated Companies:

 
CAREL Australia Pty Ltd CAREL Korea Co. Ltd.
www.carel.com.au www.carel.co.kr
[email protected] [email protected]
 
CAREL China Ltd. CAREL (Thailand) Co. Ltd.
www.carelhk.com www.carel.co.th
[email protected] [email protected]

CAREL Deutschland GmbH

www.carel.de
[email protected]

CAREL Export
www.carel.com
[email protected]

CAREL France Sas

www.carelfrance.fr
[email protected]

CAREL Italia
www.carel.it
[email protected]

CAREL Sud America Ltda.

www.carel.com.br
[email protected]

CAREL U.K. Ltd.

www.careluk.co.uk
[email protected]

CAREL USA L.L.C.

www.carelusa.com
[email protected]

All trademarks hereby referenced are

the property of their respective owners.
CAREL is a registered trademark of
CAREL S.p.A. in Italy and/or other countries.

© CAREL S.p.A. 2006 all rights reserved

www.carel.com CAREL reserves the right to make modifications

or changes to its products without prior warning.