WI-XML Стр.

1 из 20

Golf/Vento Current Flow Diagram No. 2 / 1

Edition 07.2006

1.8 l/55 kW Mono-Motronic, engine code AAM

from October 1991
1.8 l/66 kW Mono-Motronic, engine code ABS
from October 1991
Notes:

For information concerning

 Position of relays and fuses

 Multi-pin connections
 Control units and relays
 Earth connections

→ List of Fitting Locations!

For information concerning

 Fault Finding Programs

→ guided fault finding

WI-XML Стр. 2 из 20

Golf/Vento Current Flow Diagram No. 2 / 2

Alternator, battery, starter, ignition/starter switch
A - Battery
B - Starter
C - Alternator
C1 - Voltage regulator
D - Ignition/starter switch
J59 - X-contact relief relay
J226 - Starter inhibitor and reversing light relay
T1b - Single connector, near battery
T2 - 2-pin connector, behind the relay plate
T9 - 9-pin connector, on starter inhibitor and reversing light relay
- Earth strap, battery - body
1

- Earth strap, gearbox - body

2

- Earth connection 3, in headlight wiring harness

119

* - only manual gearbox

** - only automatic gearbox

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 3 из 20

Golf/Vento Current Flow Diagram No. 2 / 3

Radiator fan, fresh air blower
E9 - Fresh air blower switch
F18 - Thermal switch for radiator fan
L16 - Fresh air regulator illumination bulb
N23 - Fresh air blower series resistor
S24 - Overheating sensor
T8c - 8-pin connector, behind centre dash panel
V2 - Fresh air blower
V7 - Radiator fan
- Earth point, lower part of right A-pillar
43

- Earth connection 1, in dash panel wiring harness

80

- Earth connection 1, in headlight wiring harness

119

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 4 из 20

Golf/Vento Current Flow Diagram No. 2 / 4

Mono-Motronic control unit, intake manifold preheating, throttle
valve potentiometer
F60 - Idling speed switch
G69 - Throttle valve potentiometer
J81 - Intake manifold preheating relay
J257 - Mono-Motronic control unit
N51 - Intake manifold preheating heater element
T1d - 1-pin connector, near intake manifold
T2n - 2-pin connector, behind the relay plate
T8a - 8-pin connector, behind the relay plate
T28a - 28-pin connector, on engine
T45 - 45-pin connector
V60 - Throttle valve positioner
- Earth connection (control unit), in Mono-Motronic wiring
138
harness
- Earth connection (sender earth), in Mono-Motronic wiring
139
harness
- Positive connection 1 (15), in Mono-Motronic wiring harness
E12

* - only manual gearbox

** - only automatic gearbox

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 5 из 20

Golf/Vento Current Flow Diagram No. 2 / 5

Mono-Motronic control unit, injectors
G2 - Coolant temperature display sender
G42 - Intake air temperature sender
G62 - Coolant temperature sender
J17 - Fuel pump relay
J257 - Mono-Motronic control unit
N30 - Injector
N80 - Activated charcoal filter system solenoid valve 1 (pulsed)
T2a - 2-pin connector
T2b - 2-pin connector
T2x - 2-pin connector, behind centre dash panel - self-diagnosis
connection -*
T2z - 2-pin connector, behind centre dash panel - self-diagnosis
connection -*
T28 - 28-pin connector, on engine
T45 - 45-pin connector
TV2 - Terminal 30 wiring junction, behind the relay plate
TV14 - Self-diagnosis wiring junction, above the relay plate
- Earth point, on cylinder head
15

- Earth connection 1, in dash panel wiring harness

80

ws = white - Earth connection (control unit), in Mono-Motronic wiring

138
sw = black harness
ro = red
br = brown - Earth connection (sender earth), in Mono-Motronic wiring
139
gn = green harness
bl = blue
gr = grey
- Positive connection (30), in Mono-Motronic wiring harness
E11
li = purple
ge = yellow
or = orange
* - from model year 1994 see Current Flow Diagram self-
rs = pink diagnosis -connection bus!
WI-XML Стр. 6 из 20

Golf/Vento Current Flow Diagram No. 2 / 6

Mono-Motronic control unit, lambda probe
G39 - Lambda probe or
- Lambda probe, with heater
J257 - Mono-Motronic control unit
T2j - 2-pin connector, near intake manifold
T2r - 2-pin connector, behind the relay plate
T4 - 4-pin connector, near intake manifold
T8a - 8-pin connector, behind the relay plate
T28a - 28-pin connector, on engine
T45 - 45-pin connector
- Earth point, near exhaust manifold
29

- Earth connection (control unit), in Mono-Motronic wiring

138
harness
* - only automatic gearbox
** - Depends on equipment

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 7 из 20

Golf/Vento Current Flow Diagram No. 2 / 7

Mono-Motronic control unit, ignition system, fuel pump
G - Fuel gauge sender
G6 - Fuel pump
G40 - Hall sender
J257 - Mono-Motronic control unit
N152 - Ignition transformer
N157 - Ignition transformer output stage
O - Ignition distributor
P - Spark plug connector
Q - Spark plugs
T3a - 3-pin connector
T28a - 28-pin connector, on engine
T45 - 45-pin connector
- Earth point, on cylinder head
15

- Earth connection (control unit), in Mono-Motronic wiring

138
harness
- Earth connection, in rear wiring harness
196

- Positive connection 2 (15), in Mono-Motronic wiring harness

E13

* - Resistance cable, resistance values workshop manual

ws = white ** - Depends on equipment
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 8 из 20

Golf/Vento Current Flow Diagram No. 2 / 8

Oil pressure switch, dash panel insert, warning lamps
F1 - Oil pressure switch
F22 - Oil pressure switch (0.3 bar)
G32 - Coolant shortage indicator sender
J285 - Control unit with display in dash panel insert
K1 - Main beam warning lamp
K2 - Alternator warning lamp
K65 - Left turn signal warning lamp
K94 - Right turn signal warning lamp
L10 - Dash panel insert illumination bulb
L75 - Digital display illumination bulb
T28 - 28-pin connector, on dash panel insert
T28a - 28-pin connector, on engine
TV4 - Terminal 15 wiring junction
- Earth connection 1, in headlight wiring harness
119

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 9 из 20

Golf/Vento Current Flow Diagram No. 2 / 9

Dash panel insert, fuel gauge, coolant temperature gauge, rev.
counter, speedometer, warning lamps
G1 - Fuel gauge
G3 - Coolant temperature gauge
G5 - Rev. counter
G21 - Speedometer
J285 - Control unit with display in dash panel insert
K3 - Oil pressure warning lamp
K7 - Dual circuit brake/handbrake warning lamp
K28 - Coolant temperature/coolant shortage warning lamp
T28 - 28-pin connector, on dash panel insert
TV13 - Speed signal wiring junction, above the relay plate

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 10 из 20

Golf/Vento Current Flow Diagram No. 2 / 10

Dash panel insert, multifunction display, speedometer sender,
ambient temperature sensor, oil temperature sender
E86 - Multifunction display call-up button
E109 - Multifunction display memory switch
G8 - Oil temperature sender
G17 - Ambient temperature sensor
G22 - Speedometer sender
J119 - Multifunction display
J285 - Control unit with display in dash panel insert
L75 - Digital display illumination bulb
T1e - 1-pin connector, behind the dash panel
T4b - 4-pin connector, behind steering column switch trim
T28 - 28-pin connector, on dash panel insert
T28a - 28-pin connector, on engine
- Earth point, on cylinder head
15

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 11 из 20

Golf/Vento Current Flow Diagram No. 2 / 11

Rear interior light, rear ashtray illumination, number plate lights
F2 - Front left contact switch
F3 - Front right contact switch
F10 - Rear left door contact switch
F11 - Rear right door contact switch
L48 - Ashtray illumination bulb, rear
T1 - 1-pin connector, on left in luggage compartment
T1g - Single connector, behind the relay plate, connection for
central locking
T2c - 2-pin connector, on left C-pillar
T4a - 4-pin connector, behind the relay plate
T5e - 5-pin connector, on rear cross-panel
T5f - 5-pin connector, above the relay plate
T5g - 5-pin connector, on left in luggage compartment
TV17 - Door contact switch wiring junction, above the relay plate
W6 - Glove compartment light
W13 - Front passenger reading light
W15 - Interior light with switch-off delay
X - Number plate light
- Earth point, on left in luggage compartment
50

- Earth connection, in rear lid wiring harness

98

- Earth connection, in rear door switch wiring harness

195

ws = white - Earth connection 1, in rear wiring harness

196
sw = black
ro = red
br = brown - Connection (door contact switch), in rear door contact switch
R8
gn = green wiring harness
bl = blue
gr = grey - Connection (door contact switch), in rear wiring harness
R9
li = purple
ge = yellow
or = orange - Positive connection (58), in rear wiring harness
W2
rs = pink
- Positive connection (30), in rear wiring harness
W9

- Connection (58), in rear lid wiring harness

W11
WI-XML Стр. 12 из 20

Golf/Vento Current Flow Diagram No. 2 / 12

Handbrake warning switch and brake fluid level warning contact,
luggage compartment light, connection for radio, cigarette lighter
F5 - Luggage compartment light switch
F9 - Handbrake warning switch
F34 - Brake fluid level warning contact
L28 - Cigarette lighter illumination bulb
R - Radio
T1a - 1-pin connector, above the relay plate
T2g - 2-pin connector, on left in luggage compartment
T5e - 5-pin connector, on rear cross-panel
T5g - 5-pin connector, on left in luggage compartment
T8 - 8-pin connector, on radio
U1 - Cigarette lighter
W3 - Luggage compartment light
- Earth point, lower part of left A-pillar
44

- Earth connection 1, in dash panel wiring harness

80

- Earth connection, in rear lid wiring harness

98

- Earth connection 1, in headlight wiring harness

119

ws = white - Positive connection (58b), in dash panel wiring harness

sw = black A11
ro = red
br = brown - Positive connection -1- (30), in dash panel wiring harness
gn = green A40
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 13 из 20

Golf/Vento Current Flow Diagram No. 2 / 13

Headlight range control
E102 - Headlight range control regulator
T4 - 4-pin connector, on left in bulkhead
T19 - 19-pin connector, behind right radiator
V48 - Left headlight range control motor
V49 - Right headlight range control motor
- Earth point, on intake manifold
17

- Earth point, on engine block

18

- Earth connection 1, in headlight wiring harness

119

- Earth connection, in front lighting wiring harness

198

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 14 из 20

Golf/Vento Current Flow Diagram No. 2 / 14

Headlight, side light, headlight dipper/flasher switch
E4 - Headlight dipper/flasher switch
L1 - Left twin filament bulb
L2 - Right twin filament bulb
M1 - Left side light bulb
M3 - Right side light bulb
T5b - 5-pin connector, behind steering column switch trim
T19 - 19-pin connector, behind right radiator
- Earth connection, in front lighting wiring harness
198

- Connection (56b) 1, in front lighting wiring harness

C17

- Connection (56b) 2, in front lighting wiring harness

C18

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 15 из 20

Golf/Vento Current Flow Diagram No. 2 / 15

Turn signal system and hazard warning lights system, parking
light switch
E2 - Turn signal switch
E3 - Hazard warning light switch
E19 - Parking light switch
J2 - Hazard warning light relay
K6 - Hazard warning light system warning lamp
T4c - 4-pin connector, behind steering column switch trim
T5b - 5-pin connector, behind steering column switch trim
T7a - 7-pin connector, behind steering column switch trim

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 16 из 20

Golf/Vento Current Flow Diagram No. 2 / 16

Turn signal, tail light
M2 - Right tail light bulb
M4 - Left tail light bulb
M5 - Front left turn signal bulb
M6 - Rear left turn signal bulb
M7 - Front right turn signal bulb
M8 - Rear right turn signal bulb
T2f - 2-pin connector, behind the relay plate
T2h - 2-pin connector, behind left suspension strut
T2i - 2-pin connector, behind right suspension strut
T5d - 5-pin connector, on left rear fog light
T8d - 8-pin connector, on left rear fog light
T8e - 8-pin connector, on right rear fog light
T19 - 19-pin connector, behind right radiator
- Earth point, on left in luggage compartment
50

- Earth point, left tail light bulb holder

63

- Earth point, tail light bulb holder

64

- Earth connection 1, in headlight wiring harness

119

ws = white - Earth connection 1, in rear wiring harness

sw = black 196
ro = red
br = brown - Earth connection, in front lighting wiring harness
gn = green 198
bl = blue
gr = grey - Connection (right turn signal) in headlight wiring harness
li = purple C19
ge = yellow
or = orange - Connection (left turn signal) in headlight wiring harness
rs = pink C20
WI-XML Стр. 17 из 20

Golf/Vento Current Flow Diagram No. 2 / 17

Light switch, rear fog light
E1 - Light switch
E20 - Illumination regulators - switches and instruments
E23 - Front and rear fog light switch
K4 - Side light warning lamp
K13 - Rear fog light warning lamp
L9 - Light switch illumination bulb
L20 - Rear fog light bulb
T3 - 3-pin connector, behind left dash panel
T8d - 8-pin connector, on left rear fog light
T19 - 19-pin connector, behind right radiator
- Earth point, right tail light bulb holder
64

- Earth connection 1, in headlight wiring harness

119

- Earth connection, in front lighting wiring harness

198

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 18 из 20

Golf/Vento Current Flow Diagram No. 2 / 18

Reversing lights, heated rear window, dual tone horn
E15 - Heated rear window switch
F4 - Reversing light switch
H1 - Dual tone horn
J4 - Dual tone horn relay
K10 - Heated rear window warning lamp
L39 - Heated rear window switch illumination bulb
M16 - Left reversing light bulb
M17 - Right reversing light bulb
T1f - Single connector, in luggage compartment, rear left
T2k - 2-pin connector, behind the relay plate
T5d - 5-pin connector, on left rear fog light
T8d - 8-pin connector, on left rear fog light
T8e - 8-pin connector, on right rear fog light
T19 - 19-pin connector, behind right radiator
Z1 - Heated rear window
- Earth point, left tail light bulb holder
63

- Earth point, right tail light bulb holder

64

- Earth connection, in rear lid wiring harness

98

ws = white - Earth connection, in dual tone horn wiring harness

sw = black 129
ro = red
br = brown - Positive connection in dual tone horn wiring harness
gn = green C13
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 19 из 20

Golf/Vento Current Flow Diagram No. 2 / 19

Windscreen washer/wiper system
E22 - Intermittent wiper switch
H - Horn plate
J31 - Automatic intermittent wash and wipe relay
T2s - 2-pin connector, behind the relay plate
T4c - 4-pin connector, behind steering column switch trim
T5c - 5-pin connector, behind steering column switch trim
T7a - 7-pin connector, behind steering column switch trim
V - Windscreen wiper motor
- Connection (53a), in Mono-Motronic wiring harness
E15

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink
WI-XML Стр. 20 из 20

Golf/Vento Current Flow Diagram No. 2 / 20

Rear window wiper and washer system, brake light
F - Brake light switch
J30 - Rear window wiper and washer relay
M9 - Left brake light bulb
M10 - Right brake light bulb
T5d - 5-pin connector, on left rear fog light
T5e - 5-pin connector, on rear cross-panel
T5g - 5-pin connector, on left in luggage compartment
T8d - 8-pin connector, on left rear fog light
T8e - 8-pin connector, on right rear fog light
V12 - Rear window wiper motor
V59 - Windscreen and rear window washer pump
- Earth point, left tail light bulb holder
63

- Earth point, right tail light bulb holder

64

- Earth connection, in rear lid wiring harness

98

ws = white
sw = black
ro = red
br = brown
gn = green
bl = blue
gr = grey
li = purple
ge = yellow
or = orange
rs = pink