Parts Catalog

DGBB (Spec D–F) DGCA (Spec L–N)

DGBC (Spec C–E) DGCB (Spec L–N)

Generator Set

Printed in U.S.A. 960–0210C 11–98

Replaces 960–0210B 4–98
To avoid errors or delay in filling your parts order, The following symbols are used in Onan manuals
always give the MODEL, SPEC NO. and SERIAL to alert users to the potentially dangerous condi-
NO. from the Onan nameplate. tions relating to maintenance of equipment and re-
placement of parts. Please read and observe.
For handy reference, insert your nameplate in-
formation in the spaces below.
This symbol warns of immedi-
ate hazards which will result in
severe personal injury or death.
MODEL AND SPEC NO.
This symbol refers to a hazard
or unsafe practice which can re-
SERIAL NO. sult in severe personal injury or
death.
This symbol refers to a hazard
DIGITAL CONTROL SOFTWARE VERSION or unsafe practice which can re-
AND DATE (IF APPLICABLE) sult in severe personal injury or
product or property damage.

Service and repair of Onan equipment must be performed by trained, experienced personnel only. Im-
proper service or repair may result in property damage, severe personal injury or death. Do not use this
catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUC-
TIONS in the Service Manual appropriate for the equipment you are working on.

Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA
state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine
oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.

Contact with ASBESTOS has been identified by a United States federal agency and some USA state
agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all
necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ven-
tilation and wear protective gloves, masks and clothing!

Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified
by a United States federal agency and some USA state agencies as causing CANCER or REPRODUC-
TIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take
all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventila-
tion and wear protective gloves, masks and protective clothing!

PSP-1
 Introduction

This catalog applies to the standard generator models DGBB, DGBC, DGCA and DGCB as listed in the Gen-
erator Set Data Table. Parts are arranged in groups of related items and each illustrated part is identified by
a reference number corresponding to the same reference number in the parts list. Parts illustrations are typi-
cal. Unless otherwise mentioned in the description or page heading, parts are interchangeable between mod-
els. Throughout this catalog left and right sides are determined by facing the engine end (front) of the set.

Engine parts that have been modified or added by Onan are identified in this catalog. All other engine replace-
ment parts must be ordered from the engine manufacturer by referring to the engine manufacturer’s name-
plate and supplying all available information. Contact your nearest engine parts distributor for assistance in
ordering replacement parts.

Replacement Engine

Onan/Cummins Cummins
Generator Model Engine Model
DGBB 4B3.9–G (Spec D, E)
4B3.9–G2 (Spec F)
DGBC 4B3.9–G (Spec C, D)
4B3.9–G2 (Spec E)
DGCA 4BT3.9–G4
DGCB 4BT3.9–G4

Generator Set Data Table

Model/ Electrical Data Battery

Specification Voltage
Watts Volts Hertz Wire Phase
35DGBB* 35,000 # 60 4,6,12 1 or 3 12 VDC
28DGBB* 28,000 # 50 4,6,12 1 or 3 12 VDC
40DGBC* 40,000 # 60 4,6,12 1 or 3 12 VDC
32DGBC* 32,000 # 50 4,6,12 1 or 3 12 VDC
50DGCA* 50,000 # 60 4,6,12 1 or 3 12 VDC
40DGCA* 40,000 # 50 4,6,12 1 or 3 12 VDC
60DGCB* 60,000 # 60 4,6,12 1 or 3 12 VDC
50DGCB* 50,000 # 50 4,6,12 1 or 3 12 VDC

* – The Specification number denotes customer requested options or deviations from the standard model.
The specification letter advances with major manufacturing changes.

# – Broad Range Reconnectible.

1
 Index
Actuator, Electronic Governor – DGBB Spec D, E, DGBC Bracket, Mounting – Generator Foot, 75
Spec C, D, DGCA and DGCB Spec L, M, 60 Bracket, Over/Under Frequency Relay – DGBB Spec D,
Actuator, Linear – Sets With PowerCommand Control – DGBC Spec C, DGCA and DGCB Spec L, 108
DGBB Spec D, E, DGBC Spec C, D, DGCA and DGCB Bracket, Overflow Bottle – DGBB Spec F, DGBC Spec E,
Spec L, M, 9 DGCA and DGCB Spec N, 38
Actuator, Rotating – Sets With PowerCommand Control – Bracket, Overspeed – Mechanical, 80
DGBB Spec F, DGBC Spec E, DGCA and DGCB Spec N,
9 Bracket, Pump – Subbase Fuel Tank, 16
Adapter, Duct – Radiator, 37 Breaker, Circuit – AC – Fuel Tank Control, 18
Breaker, Circuit – DC – Fuel Tank Control, 18
Adapter, Exhaust – DGBB, DGBC, 22
Breaker, Circuit – Non–UL Listed – DGBB Spec D, DGBC
Adapter, Exhaust – DGCA, DGCB, 23 Spec C, DGCA and DGCB Spec L, 117
Adapter, Exhaust – Housed Sets – DGCA, DGCB, 24 Breaker, Circuit – Sentinel Control, 85
Adapter, Generator, 73 Breaker, Circuit – UL Listed – DGBB Spec D, DGBC Spec
Alarm, Audible, 102 C, DGCA and DGCB Spec L, 116
Alarm, Basin, 21 Breaker, Circuit – UL Listed, IEC Conformity – DGBB Spec
Alarm, Bell – DGBB Spec D, DGBC Spec C, DGCA and E, DGBC Spec D, DGCA and DGCB Spec M, 118
DGCB Spec L, 103 Breaker, Circuit – UL Listed, IEC Conformity – DGBB Spec
Alarm, Common, 100 F, DGBC Spec E, DGCA and DGCB Spec N, 120
Alarm, Fuel – DGBB Spec F, DGCA and DGCB Spec N, 104 Breaker, Circuit – Voltage Regulator – Sets With Detector
Control, 96
Alarm, Low Fuel, 20
Breaker, Circuit – Voltage Regulator – Sets With Sentinel
Alternator, 59 Control, 97
Ammeter – Detector Control, 87 Bulb, Replacement – Emergency Stop Switch, 98
Ammeter, Dual Scale – Sentinel Control, 105
Cable, Battery – Sets With Detector Control, 8
Band, Cleaner – Air – DGBB, DGBC, 12 Cable, Battery – Sets With PowerCommand Control, 9
Band, Cleaner – Air – DGCA, DGCB, 13 Cable, Battery – Sets With Sentinel Control, 7
Barrier, Sound, 55 Cable, Heater – Control Heater – Sets With Detector
Bell, End, 75 Control, 78
Block, Terminal – Generator, 73 Cable, Heater – Oil Heater, 34
Block, Terminal – Generator Heater (Quiet Site), 71 Cap, Fill – In–Skid Fuel Tank, 15
Block, Terminal – Generator Heater (Standard), 70 Cap, Fill – Subbase Fuel Tank, 14
Cap, Radiator, 37
Board, Printed Circuit – Alarm Relay, 99
Cap, Vent – Subbase Fuel Tank, 14
Board, Printed Circuit – Common Alarm, 100
Cartridge, Heater – Generator (Quiet Site), 71
Board, Printed Circuit – Engine Monitor – Sets With Detector
Control, 87 Cartridge, Heater – Generator (Standard), 70
Board, Printed Circuit – Fuel Tank Control, 18 Clamp, Stator – PMG, 83
Board, Printed Circuit – Isolation Transformer – Sets With Cleaner, Air – DGBB, DGBC, 12
Detector Control, 96 Cleaner, Air – DGCA, DGCB, 13
Board, Printed Circuit – Time Delay Start/Stop, 107 Cock, Drain – Radiator, 37
Bottle, Overflow – DGBB Spec F, DGBC Spec E, DGCA and Contact, Auxiliary – DGBB Spec D, DGBC Spec C, DGCA
DGCB Spec N, 38 and DGCB Spec L, 115
Box, Circuit Breaker (Non–UL) – DGBB Spec D, DGBC Contact, Dry – DGBB Spec F, DGCA and DGCB Spec N, 89
Spec C, DGCA and DGCB Spec L, 67 Control, Detector, 87
Box, Circuit Breaker – UL Listed – DGBB Spec D, DGBC Control, Electronic Governor – DGBB Spec D, E, DGBC
Spec C, DGCA and DGCB Spec L, 65 Spec C, D, DGCA and DGCB Spec L, M, 60
Box, Circuit Breaker – UL Listed, IEC Conformity – DGBB Control, Electronic Governor – DGBB Spec F, DGBC Spec
Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, E, DGCA and DGCB Spec N, 61
N, 69 Control, Fuel Tank – Components, 18
Box, Control – Detector Control, 87 Control, PowerCommand, 88
Box, Control – Fuel Tank, 18 Control, Sentinel, 85
Box, Terminal – Generator Heater (Quiet Site), 71 Cover, Belt Guard – Remote Radiator, 35
Box, Terminal – Generator Heater (Standard), 70 Cover, Box – Fuel Tank Control, 18
Bracket, Belt Guard – Remote Radiator, 35 Cover, End Bell – Mechanical Overspeed, 80
Bracket, Control Mounting – Control Housing, 63 Cover, Fan Guard – Radiator, 37
Bracket, Control Mounting – In–Skid Fuel Tank, 17 Cover, Float Valve, 19
Bracket, Heater – Water Heater, 33 Cover, Fuel Tank – Sound Barrier, 55
Bracket, Meter Transformer, 114 Cover, Housing – Control, 63
Bracket, Mounting – Air Cleaner – DGBB, DGBC, 12 Cover, Stator – Generator, 73
Bracket, Mounting – Air Cleaner – DGCA, DGCB, 13 Cover, Stub Up – Skidpan, 54

2
 Index
Cushion, Mounting – Vibration Isolation – Basic Skid – Harness, Wiring – Alarm Relay Board, 99
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L, Harness, Wiring – Common Alarm, 100
50
Harness, Wiring – DC – Sets With Detector Control, 87
Cushion, Mounting – Vibration Isolation – Basic Skid –
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Harness, Wiring – Dry Contact – DGBB Spec F, DGCA and
Spec M, N, 52 DGCB Spec N, 89
Cushion, Mounting – Vibration Isolation – Housing Harness, Wiring – Electric Overspeed – Sets With Detector
Ready/Fuel Tank Ready Skid – DGBB Spec D, DGBC Control, 81
Spec C, DGCA and DGCB Spec L, 51 Harness, Wiring – Electric Overspeed – Sets With Sentinel
Cushion, Mounting – Vibration Isolation – Housing Control, 82
Ready/Fuel Tank Ready Skid – DGBB Spec E, F, DGBC Harness, Wiring – Electronic Governor – DGBB Spec D, E,
Spec D, E, DGCA and DGCB Spec M, N, 53 DGBC Spec C, D, DGCA and DGCB Spec L, M, 60
Harness, Wiring – Electronic Governor – DGBB Spec F,
DGBC Spec E, DGCA and DGCB Spec N, 61
Diode – Generator, 73
Harness, Wiring – Engine to Control – Detector Control, 95
Disc, Drive – Generator, 75
Harness, Wiring – Engine to Control – Sentinel Control, 95
Door, Control – Detector Control, 87
Harness, Wiring – Engine To Control – Sets With
Drain, Oil – Extension, 11 PowerCommand Control – DGBB Spec D, E, DGBC Spec
C, D, DGCA and DGCB Spec L, M, 91
Edging – Control Housing, 63 Harness, Wiring – Engine To Control – Sets With
Element, Cleaner – Air – DGBB, DGBC, 12 PowerCommand Control – DGBB Spec F, DGBC Spec E,
DGCA and DGCB Spec N, 93
Element, Cleaner – Air – DGCA, DGCB, 13
Harness, Wiring – Fuel Alarm – DGBB Spec F, DGCA and
External Engine Parts – Sets With Detector Control, 8 DGCB Spec N, 104
External Engine Parts – Sets With PowerCommand Control, Harness, Wiring – Fuel Tank Control, 18
9
Harness, Wiring – In–Skid Fuel Tank Pump to Control, 17
External Engine Parts – Sets With Sentinel Control, 7
Harness, Wiring – Low Battery Voltage, 109
Harness, Wiring – Low Coolant Level Sender – With
Fan, Alternator, 59 Continuously Monitored Low Coolant Level, 30
Fan, Radiator, 37 Harness, Wiring – Low Coolant Level Sender – Without
Filter, Screen – Fuel – Float Valve, 19 Continuously Monitored Low Coolant Level – DGBB Spec
D, E, DGBC Spec C, D, DGCA and DGCB Spec L, M, 31
Fuse – Sentinel Control, 85
Harness, Wiring – Low Coolant Level Sender – Without
Continuously Monitored Low Coolant Level – DGBB Spec
Gasket, Cover Plate – Float Valve, 19 F, DGBC Spec E, DGCA and DGCB Spec N, 32
Gasket, Drain – Oil Pan, 11 Harness, Wiring – Meter Transformer, 114
Gasket, Exhaust – DGBB, DGBC, 22 Harness, Wiring – Over/Under Frequency Relay – DGBB
Gauge, Fuel Level – In Skid Fuel Tank, 15 Spec D, DGBC Spec C, DGCA and DGCB Spec L, 108
Gauge, Fuel Level – Subbase Fuel Tank, 14 Harness, Wiring – Over/Under Voltage – DGBB Spec D,
DGBC Spec C, DGCA and DGCB Spec L, 106
Gauge, Oil Temperature – DGBB Spec D, DGBC Spec C,
DGCA and DGCB Spec L, 112 Harness, Wiring – PMG, 83
Harness, Wiring – Subbase Fuel Tank Pump to Control, 16
Gauge, Pressure – Oil – Sets With Detector Control, 87
Harness, Wiring – Time Delay Start/Stop, 107
Gauge, Pressure – Oil – Sets With Sentinel Control, 10
Harness, Wiring – Wattmeter – DGBB Spec D, DGBC Spec
Gauge, Temperature – Water – Sets With Detector Control, C, DGCA and DGCB Spec L, 110
87
Heater Assembly, Control – Sets With PowerCommand
Gauge, Temperature – Water – Sets With Sentinel Control, Control, 79
10
Heater, Control – Sets With Detector Control, 78
Generator, 73
Heater, Engine Coolant, 33
Governor, Electronic – DGBB Spec D, E, DGBC Spec C, D,
DGCA and DGCB Spec L, M, 60 Heater, Generator – Quiet Site, 71
Governor, Electronic – DGBB Spec F, DGBC Spec E, DGCA Heater, Generator – Standard, 70
and DGCB Spec N, 61 Heater, Oil, 34
Grille, Radiator, 37 Holder, Fuse – Sentinel Control, 85
Guard, Alternator – Radiator, 37 Hose, Radiator, 37
Guard, Belt – Remote Radiator, 35 Hose, Water Heater, 33
Guard, Fan – Generator, 73 Housing, Control, 63
Guard, Fan – Radiator, 37 Housing, Generator Set – Quiet Site First Stage – DGBB
Spec D, DGBC Spec C, DGCA and DGCB Spec L, 43
Housing, Generator Set – Quiet Site First Stage – DGBB
Harness, Wiring – AC – Sets With Detector Control, 87 Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M,
Harness, Wiring – AC Auxiliary, 95 N, 47
Harness, Wiring – AC Control – Sets With Sentinel Control, Housing, Generator Set – Quiet Site Second Stage – DGBB
97 Spec D, DGBC Spec C, DGCA and DGCB Spec L, 45

3
 Index
Housing, Generator Set – Quiet Site Second Stage – DGBB Point, Overspeed – Mechanical, 80
Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, Potentiometer – Voltage Regulator – Sets With Detector
N, 49 Control, 96
Housing, Generator Set – Standard Weather Protective – Potentiometer – Voltage Regulator – Sets With Sentinel
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L, Control, 97
40
Potentiometer, Speed, 111
Housing, Generator Set – Standard Weather Protective – Pump, In–Skid Fuel Tank, 17
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB
Spec M, N, 41 Pump, Subbase Fuel Tank, 16
Hub, Drive – Generator, 73
Radiator, 37
Isolator, Vibration – Detector Control, 87 Radiator, Remote, 35
Isolator, Vibration – Sentinel Control, 85 Rectifier – Generator, 73
Rectifier, Power – Control Heater – Sets With Detector
Control, 78
Key, Exciter Rotor, 73 Rectifier, Silicon – Low Coolant Level Sender – With
Continuously Monitored Low Coolant Level, 30
Labels, Miscellaneous, 122 Regulator, Voltage – Sets With Detector Control, 96
Lamp – Detector Control, 87 Regulator, Voltage – Sets With Sentinel Control, 97
Lamp, Indicator – Replacement – Fuel Tank Control, 18 Relay – Dry Contact – DGBB Spec F, DGCA and DGCB
Lens, Indicator – Low Battery Voltage, 109 Spec N, 89
Lens, Replacement – Low Coolant Level Sender – With Relay – Fuel Tank Control, 18
Continuously Monitored Low Coolant Level, 30 Relay – Sentinel Control, 85
Light Assembly, Indicator – Fuel Tank Control, 18 Relay, Over/Under Frequency – DGBB Spec D, DGBC Spec
C, DGCA and DGCB Spec L, 108
Light, Panel – Detector Control, 87
Relay, Over/Under Voltage – DGBB Spec D, DGBC Spec C,
Line – Fuel In, Fuel Out, 122 DGCA and DGCB Spec L, 106
Line, Fuel – In–Skid Fuel Tank, 15 Relay, Timer – Sentinel Control, 85
Line, Fuel – Subbase Fuel Tank, 14 Resistor – Voltage Regulator – Sets With Detector Control,
Link, Terminal – Generator, 75 96
Lug, Breaker – Circuit Breaker – Non–UL – DGBB Spec D, Resistor, Gauge – Detector Control, 87
DGBC Spec C, DGCA and DGCB Spec L, 117 Rotor, Exciter, 73
Rotor, Generator, 73
Meter, Frequency – Detector Control, 87 Rotor, PMG, 83
Meter, Time Totalizing – Detector Control, 87
Module, Alarm, 101 Screen, Air Inlet – Generator, 73
Module, Electric Overspeed – Sets With Sentinel Control, 82 Seal, Edging – Generator, 73
Module, Frequency – Electric Overspeed – Sets With Sealant, Thread, 6
Detector Control, 81 Sender, Low Coolant Level – With Continuously Monitored
Muffler – Critical – DGBB Spec D, DGBC Spec C, DGCA Low Coolant Level, 30
and DGCB Spec L, 27 Sender, Low Coolant Level – Without Continuously
Muffler – Industrial – DGBB Spec D, DGBC Spec C, DGCA Monitored Low Coolant Level – DGBB Spec D, E, DGBC
and DGCB Spec L, 26 Spec C, D, DGCA and DGCB Spec L, M, 31
Muffler – Industrial – DGBB Spec E, F, DGBC Spec D, E, Sender, Low Coolant Level – Without Continuously
DGCA and DGCB Spec M, N, 29 Monitored Low Coolant Level – DGBB Spec F, DGBC
Spec E, DGCA and DGCB Spec N, 32
Muffler – Residential – DGBB Spec D, DGBC Spec C,
DGCA and DGCB Spec L, 25 Sender, Low Engine Temperature – Sets With
PowerCommand Control, 9
Muffler – Standard – DGBB Spec E, F, DGBC Spec D, E,
DGCA and DGCB Spec M, N, 28 Sender, Oil Pressure – Sets With Detector Control, 8
Sender, Oil Pressure – Sets With PowerCommand Control,
9
Overspeed, Electric – Sets With Detector Control, 81 Sender, Oil Temperature – Sets With PowerCommand
Overspeed, Electric – Sets With Sentinel Control, 82 Control, 9
Overspeed, Mechanical, 80 Sender, Temperature – Oil Gauge – DGBB Spec D, DGBC
Spec C, DGCA and DGCB Spec L, 112
Package, Mounting – Actuator to Injection Pump, 60 Sender, Water Temperature – Sets With Detector Control, 8
Paint, 6 Sensor, Low Battery Voltage, 109
Sensor, Speed – Electronic Governor – DGBB Spec F,
Pan, Skid, 54
DGBC Spec E, DGCA and DGCB Spec N, 61
Panel, Control – Sentinel Control, 85 Shroud, Radiator, 37
Pin, Parallel – PMG, 83 Signal, Audible, 102
Plate, Audible Signal, 102 Skid – Basic – DGBB Spec D, DGBC Spec C, DGCA and
Plate, Clamping – Remote Radiator, 35 DGCB Spec L, 50

4
 Index
Skid – Basic – DGBB Spec E, F, DGBC Spec D, E, DGCA Thermostat, Pre Water Temperature – Sets With Detector
and DGCB Spec M, N, 52 Control, 8
Skid – Housing Ready/Fuel Tank Ready – DGBB Spec D, Transducer, Watts – DGBB Spec D, DGBC Spec C, DGCA
DGBC Spec C, DGCA and DGCB Spec L, 51 and DGCB Spec L, 110
Skid – Housing Ready/Fuel Tank Ready – DGBB Spec E, F, Transformer – Voltage Regulator – Sets With Sentinel
DGBC Spec D, E, DGCA and DGCB Spec M, N, 53 Control, 97
Starter, 58 Transformer, Current, 113
Stator, Exciter, 75 Transformer, Meter, 114
Stator, Generator, 76 Tray, Battery – Standard, 56
Stator, PMG, 83 Tray, Battery – Tank Ready, 57
Strap, Ground – Detector Control, 87 Trip, Shunt – UL Listed – DGBB Spec D, DGBC Spec C,
Switch, Basin – Basin Alarm, 21 DGCA and DGCB Spec L, 116
Switch, Basin – Low Fuel Alarm, 20 Trip, Shunt – UL Listed, IEC Conformity – DGBB Spec E,
Switch, Emergency Stop, 98 DGBC Spec D, DGCA and DGCB Spec M, 119
Switch, Float – In–Skid Fuel Tank, 17 Trip, Shunt – UL Listed, IEC Conformity – DGBB Spec F,
DGBC Spec E, DGCA and DGCB Spec N, 121
Switch, Float – Subbase Fuel Tank, 16
Tube, Water Heater, 33
Switch, High Water Temperature – Sets With Detector
Control, 8
Switch, High Water Temperature – Sets With Sentinel Valve, Float, 19
Control, 7 Valve, Shutoff – Oil Drain, 11
Switch, Overspeed – Mechanical, 80 Valve, Shutoff – Radiator, 37
Switch, Pressure – Oil – Sets With Detector Control, 8 Valve, Solenoid – Float Valve, 19
Switch, Pressure – Oil – Sets With Sentinel Control, 7 Varistor – Generator, 73
Switch, Rocker – Detector Control, 87 Voltage, Over/Under – DGBB Spec D, DGBC Spec C,
Switch, Rocker – Fuel Tank Control, 18 DGCA and DGCB Spec L, 106
Switch, Rocker – Sentinel Control, 85 Voltmeter – Detector Control, 87
Switch, Rotary – Detector Control, 87
Wattmeter – DGBB Spec D, DGBC Spec C, DGCA and
Tank, Fuel – In–Skid, 15 DGCB Spec L, 110
Tank, Fuel – Subbase, 14 Wrapper, Control – Sentinel Control, 85

5
 Abbreviations

Some of the following abbreviations may be used throughout this Parts Catalog:
AC Alternating Current mm Millimeter
Amp Ampere MOH Mobile Off Highway
A/R As Required NFS Not For Sale
AVR Automatic Voltage Regulator NPT National Pipe Thread
AWG American Wire Gauge OD Outside Diameter
Deg Degree oz. Ounce
DC Direct Current PMG Permanent Magnet Generator
EFC Electronic Fuel Control Ph Phase
ET External Tooth PC Printed Circuit
EIT External/Internal Tooth RFI Radio Frequency Interference
GFI Ground Fault Interrupter RT Right
ID Inside Diameter Spec Specification
IT Internal Tooth Thk Thick
IEC International Electrotechnical UL Underwriters Laboratories Inc.
Commission UNC Union National Coarse
kW Kilowatt UNF Union National Fine
LPG Liquid Petroleum Gas VAC Volts Alternating Current
LT Left VDC Volts Direct Current
M(meter Number) Meter W/(ET, IT, EIT) With

Paint and Thread Sealant

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Onan Green Enamel 518–0601 – Sealant, Thread (6 ml Tube)

(Non-Metallic)
525–0305 – 12 oz. Pressurized
Spray Can
525–0306 – Quart Can
525–0304 – Gallon Can

6
 External Engine Parts
Generator Sets With Sentinel Control

3 5

1
4
8

1
4
6
7

H562

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 856–0013 2 Washer, Lock – EIT (1/2) 5 502–0199 1 Elbow, Male – Inverted (45°)
2 309–0554–01 1 Switch, High Water 6 416–1000 1 Cable, Battery (24”)
Temperature (S2) 7 416–0619 1 Cable, Battery (18”)
3 147–0779 1 Sleeve, Pump – Fuel 8 526–2140 2 Washer, Flat (M12)
4 800–2111 2 Screw, Cap – Hex Head 9 309–0641–19 1 Switch, Pressure – Oil (S1)
(M12 x 1.75 x 25)

7
 External Engine Parts
Generator Sets With Detector Control

14
15
16 6

4
17

10

9
13 3
2
11

1
5

7
1
5 8 H559,H560
12
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 856–0013 2 Washer, Lock – EIT (1/2) 9 309–0641–20 1 Switch, Pressure – Oil (S5)
2 800–2085 1 Screw, Cap – Hex Head 10 309–0641–19 1 Switch, Pressure – Oil (S1)
(M10 x 1.5 x 25) 11 332–2921 1 Clamp, J
3 309–0554–01 1 Switch, High Water 12 526–2140 1 Washer, Flat (M12)
Temperature (S2) 13 309–0553–01 1 Thermostat (Pre Water
4 147–0779 1 Sleeve, Pump – Fuel Temp) (S6)
5 800–2111 2 Screw, Cap – Hex Head 14 193–0375 1 Sender, Water Temperature
(M12 x 1–3/4 x 25) (E2)
6 502–0199 1 Elbow, Male – Inverted 15 526–0008 2 Washer, Flat (#10)
(45°) 16 870–0131 1 Nut, Hex (#10–32)
7 416–1000 1 Cable, Battery (24”) 17 193–0448 1 Sender, Oil Pressure (E1)
8 416–0619 1 Cable, Battery (18”)

8
 External Engine Parts
Generator Sets With PowerCommand Control

18 20
3

16
17
15

19
13

6
12

9
10 7
11 12
14

2
8

1
2
8
2 2 4 5 H530,532,555
8 8

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 856–0013 1 Washer, Lock – EIT (1/2) 13 193–0444 1 Sender, Oil Pressure (E1)
2 800–2111 4 Screw, Cap – Hex Head 14 102–1356 1 Gasket, Oil Drain
(M12 x 25) 15 098–6195–01 1 Label, Caution
3 502–0199 1 Elbow, Male – Inverted (45°) 16 526–0027 1 Washer, Flat (13/16”)
4 416–1000 1 Cable, Battery (24”) 17 332–1993 2 Terminal, Receptacle (.25)
5 416–0619 1 Cable, Battery (18”) 18 150–2331 1 Actuator, Linear – DGBB
6 505–0019 1 Bushing, Reducer Spec D, E, DGBC Spec C,
(1/2” x 3/8”) D, DGCA and DGCB Spec
7 102–1448–02 1 Adapter, Oil Drain L, M
8 526–2140 4 Washer, Flat (M12) 19 332–3196 1 Clamp, J
9 309–0269 1 Sender, Low Engine 20 150–2735–01 1 Actuator, Rotating – DGBB
Temperature (S4) Spec F, DGBC Spec E,
10 850–2008 1 Washer, Lock (M8) DGCA and DGCB Spec N
11 800–2058 1 Screw, Cap – Hex Head (Standard on Sets With
(M8 x 25) PCC Control – Also Shown
12 193–0432 2 Sender, Temperature in Electronic Governor
(E2, E4) Group)

9
 Engine Gauges
(Sentinel Control)

1
2

H563

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 193–0451 1 Gauge, Pressure – Oil 3 193–0463 1 Gauge, Temperature – Water

2 502–0053 1 Elbow, Street – Pipe

10
 Oil Drain Extension

8
7

1 6
5
2
4

3 H268

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 102–1147 1 Gasket, Drain – Oil Pan 7 800–2111 1 Screw, Cap – Hex Head
2 102–1237 1 Adapter, Oil Drain (M12 x 1.75 x 20)
3 505–0050 1 Elbow, Street (1/2NPT x 90 8 503–0197 1 Clip, Hose – Corbin
degrees) 9 503–0098 – Hose, Drain – Bulk (Order By
4 504–0011 1 Valve, Shutoff (1/2) The Foot – 2 Feet
5 505–0185 1 Nipple, Half (1/2NPT x 1.5) Required)
6 518–0548–02 1 Clamp, Hose

11
 Air Cleaner
DGBB, DGBC

3
1
2

12

5 7
11
6

4
9
10
6
13 7

CP01

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 140–3051 1 Cleaner, Air (6”) 8 800–2056 2 Screw, Cap – Hex Head

2 140–3055 1 Element, Cleaner – Air (M8 x 16)
3 140–3053 1 Band, Cleaner – Air 9 526–2140 2 Washer, Flat (M12)
4 140–3063 1 Bracket, Mounting – Air 10 503–1870–05 2 Clamp, Hose
Cleaner 11 140–1260 1 Fitting, Safety – Filter
5 503–2029 1 Elbow, Cleaner – Air 12 140–2008 1 Indicator, Service
6 850–2012 2 Washer, Lock – Spring 13 503–1870–06 1 Clamp, Hose
7 800–2111 2 Screw, Cap – Hex Head
(M12 x 1.75 x 25)

12
 Air Cleaner
DGCA, DGCB

12 11

1
2
7

10
9

8
5
9
4
5

CP01
8

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 140–3056 1 Cleaner, Air (7”) 7 503–2032 1 Elbow, Cleaner – Air

2 140–3067 1 Element, Filter – Air 8 850–2012 2 Washer, Lock – Spring (M12)
3 140–3054 1 Band, Cleaner – Air 9 800–2111 2 Screw, Cap – Hex Head
4 140–3063 1 Bracket, Mounting – Air (M12 x 1.75 x 25)
Cleaner 10 503–1870–06 2 Clamp, Hose
5 526–2140 2 Washer, Flat (M12) 11 140–1260 1 Fitting, Safety – Filter
6 800–2056 2 Screw, Cap – Hex Head 12 140–1548 1 Indicator, Service
(M8 x 16)

13
 Subbase Fuel Tank

19 6 11 7 12 9 14 13 10 8 5 3 2 6 3 2

15 4 1
16
17
18
C167,168,169

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Tank, Fuel 7 505–0110 1 Plug, Square Head (3/8”)

159–1463 1 70 gallon (Double Wall 8 505–0203 1 Coupling, Pipe (2”)
Tank) 9 505–0401 1 Nipple, Pipe (2” x 6” Long)
159–1463–01 1 80 gallon (Single Wall 10 415–0043 1 Cap, Fill – Fuel
Tank) 11 Gauge, Level – Fuel
159–1464 1 140 gallon (Double Wall 415–0565–61 1 70, 80 gallon tank
Tank) 415–0565–52 1 140 gallon tank
2 Nipple, Close (2”) 12 501–0627–03 1 Line, Fuel – In
505–0172 2 70 gallon tank 13 501–0502 1 Line, Fuel – Out
505–0172 1 80 gallon tank 14 503–0685 1 Clamp, Hose
3 Cap, Vent – Pipe 15 526–0399–66 4 Washer, Flat (M16)
159–1371–03 2 70 gallon tank (2”) 16 800–3017–73 4 Screw, Cap – Hex Head
159–1371–03 1 80 gallon tank (2”) (M16 x 2 x 45)
159–1371–05 2 140 gallon tank (3”) 17 850–0114–57 4 Washer, Lock (M16)
4 505–0027 2 Coupling, Pipe (1/4”) 18 862–0026–58 4 Nut, Hex (M16 x 2)
5 505–0007 1 Bushing, Reducer 19 159–1378 8 Shim, Tank – Fuel
(1/4” x 1/8”)
6 Plug, Square Head (1–1/4”)
505–0359 2 70, 140 gallon tank
505–0359 1 80 gallon tank

14
 In-Skid Fuel Tank

9 10 8

3 14 7 6 11
12 5 4

13

1 2

C115

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 159–1472 1 Tank, Fuel (49 Gallon) 10 503–0685 1 Clamp, Hose

2 505–0645 1 Nipple, Pipe (2” x 3” Long) 11 405–5426 1 Support, Baffle
3 415–0043 1 Cap, Fill – Fuel 12 800–2543–02 4 Screw, Cap – Hex Head
4 415–0565–61 1 Gauge, Level – Fuel (M12 x 25)
5 505–0359 1 Plug, Square Head (1-1/4”) 13 821–6003–02 2 Screw, Self-Locking – Hex
6 505–0110 1 Plug, Square Head (3/8”) Washer Head (M8 x 20)
7 505–0027 2 Coupling, Pipe (1/4”) 14 505–0007 1 Bushing, Reducer
8 501–0502 1 Line, Fuel – In (1/4” x 1/8”)
9 501–0627–03 1 Line, Fuel – Out

15
 Subbase Fuel Tank Pump and Control

8
9

11
Section A–A
2

8
6
4

12 1 8 3 10 7 5
C149

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 159–1468 1 Bracket, Pump 7 503–0183 2 Clamp, Hose

2 625–2141–02 1 Control, Fuel Tank (See 8 821–2033 12 Screw, Lock – Flange
Separate Page for (M6 x 1 x 16)
Components) 9 870–2054 4 Nut, Lock – Flange (M6 x 1)
3 399–0117–01 1 Pump 10 Switch, Float
4 502–0942 1 Elbow, Hose – 90° 308–0913–09 1 70 gallon tank
5 502–0943 1 Connector, Hose 308–0913 1 140 gallon tank
(1/2 x 5/8 hose) 11 098–5387 1 Label, Danger
6 503–1660–04 1 Hose, Fuel (Pump to Tank) 12 338–2397 1 Harness, Pump to Control

16
 In-Skid Fuel Tank Pump and Control

12

5
7

13 11 1 6 13 8
9
14 1
2 8 4

C115
10

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 159–1481 2 Bracket, Control Mounting 7 503–0183 2 Clamp, Hose

2 625–2141–02 1 Control, Fuel Tank (See 8 821–2033 8 Screw, Lock – Flange
Separate Page for (M6 x 1 x 16)
Components) 9 870–2054 4 Nut, Lock – Flange (M6 x 1)
3 399–0117–01 1 Pump 10 308–0913–09 1 Switch, Float
4 502–0942 1 Elbow, Hose – 90° 11 098–5387 1 Label, Danger
5 502–0943 1 Connector, Hose 12 338–2800 1 Harness, Pump to Control
(1/2 x 5/8 hose) 13 821–6003–02 4 Screw, Hex Head (M8 x 20)
6 503–1660–07 1 Hose, Fuel (Pump to Tank) 14 526–0399–59 4 Washer, Flat (M6)

17
 Fuel Tank Control

13 2

12

16

11
13
14
20 9
3 10

8 18

5
1 4

21 15

19

6
7
17

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

625–2141–02 1 Control, Fuel Tank – Complete 10 300–3464 1 Board, Printed Circuit

(Includes Parts Listed Below) 11 870–0458 4 Spacer, Board – Printed Circuit
1 319–0486 1 Box, Control 12 338–2382 1 Harness, Wiring – Control Box
2 319–0485 1 Cover, Box 13 815–0350 5 Screw, Self–Tapping – Slotted
3 307–2677–02 1 Relay, Pump (K130) Hex Washer Head (#10–32 x
4 322–0403–02 1 Light, Assembly, Indicator – 3/8”)
7 Light (Includes Wiring 14 812–0075 2 Screw, Machine – Round Head
Harness) (#8–32 x 1/4”)
5 322–0369–02 1 Lamp, Indicator – Replacement 15 815–0385 2 Screw, Machine – Round Head
6 308–0912 1 Switch, Rocker (On/Off/ (#6–32 x 1/2”)
Emergency Run) (S102) 16 332–2605 2 Jumper, Terminal
7 308–0852 1 Switch, Rocker (Reset/Off/Test) 17 331–0027 2 Connector, Romex
(S111) 18 331–0042 1 Connector, Knockout
8 320–1653 1 Breaker, Circuit – DC (Single 19 856–0002 1 Washer –EIT (#8)
Pole) (CB107) 20 315–0687 1 Transformer
9 320–1654 1 Breaker, Circuit – AC (Double 21 856–0002 1 Nut, Hex (8–32)
Pole) (CB101)

18
 Float Valve

19

17 16

19
18 15
14
13

12
11

4 2
7

9 6
8
5

20

10
C173

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 415–0660 1 Gasket, Cover Plate 12 502–0050 1 Bushing, Reducer

2 415–0657–01 1 Valve Assembly, Float (3/8” x 1/4”)
(Includes Parts Marked *) 13 502–0047 1 Nipple, Close (1/4”)
3 415–0650–01 1 * Body, Valve 14 307–2851 1 Valve, Solenoid – N/C
4 415–0651–19 1 * Pin, Roll 15 502–0029 1 Bushing, Reducer
5 415–0652 1 * Ball, Float 16 502–0433 1 Elbow, Male – Hose
6 864–0011 1 * Nut, Jam (1/4–20) 17 503–1837 1 Hose (125mm)
7 415–0818 1 * Arm, Float 18 149–2441 1 Filter, Screen – Fuel
8 415–0655 1 * Ball, Steel 19 503–1445–06 2 Clamp, Hose
9 415–0656–21 1 * Seal, Ring 20 159–1439 1 Cover
10 800–2010 8 Screw, Cap – Hex Head
(M5 x 20)
11 860–2006 8 Nut, Hex (M5 x 0.8) * – Parts Included in 415–0657–01 Float Valve Assembly

19
 Low Fuel Alarm

H573

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 308–0963–01 1 Switch, Basin 4 505–1050 1 Plug, Pipe – Square Head

2 505–0026 1 Coupling, Pipe (Modified)
3 Nipple. Pipe 5 332–1992 1 Terminal, Receptacle (.25)
505–0066 1 70 gallon tank (#22–18)
505–1458–14 1 140 gallon tank 6 332–2430 1 Terminal, Tab (.25) (#22–18)

20
 Basin Alarm

7
1

H574

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 308–0916–01 1 Switch, Basin 5 332–1992 1 Terminal, Receptacle (.25)

2 505–0026 1 Coupling, Pipe (#22–18)
3 Nipple, Pipe 6 332–2430 1 Terminal, Tab (.25) (#22–18)
505–0069 1 70 gallon tank 7 322–0431–06 1 Lens, Replacement
505–1458–02 1 140 gallon tank
4 505–1050 1 Plug, Pipe – Square Head
(Modified)

21
 Exhaust Adapter
DGBB, DGBC

3
4

A299
A298,379

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 155–3120–02 1 Adapter, Exhaust (For 3 850–2010 4 Washer, Lock – Spring (M10)

Threaded Exhaust Pipe) 4 800–2086 4 Screw, Cap – Hex Head
2 155–3196 1 Adapter, Exhaust (For (M10 x 1.5 x 25)
Clamped Slip On Exhaust 5 154–2708 1 Gasket, Exhaust
Pipe)

22
 Exhaust Adapter
DGCA, DGCB
Standard

A299

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 155–3116 1 Adapter, Exhaust (3”) 2 155–2565 1 Clamp, V–Band

23
 Exhaust Adapter
DGCA, DGCB
Housed Sets

3
4
7
3
4
7

2 A298,379,F182

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 155–3117 1 Adapter, Exhaust 5 155–2565 1 Clamp, V Band

2 155–3125 1 Brace, Exhaust 6 505–0180 1 Plug
3 850–2010 4 Washer, Lock – Spring (M10) 7 526–2120 4 Washer, Flat (M10)
4 800–2086 4 Screw, Cap – Hex Head
(M10 x 1.5 x 25)

24
 Muffler – Residential
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

6
7

3 14

13

7
2

8
3

12

11 10
A374

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 155–3082 1 Muffler 9 155–2565 1 Clamp, V–Band (DGCA,

2 155–3066 2 Bracket, Mounting – Muffler DGCB)
3 821–6003–02 8 Screw, Hex Head 10 154–2708 1 Gasket, Exhaust
(M8 x 1.25 x 20) (DGBB, DGBC)
4 155–2175 1 Clamp, Muffler 11 850–2010 4 Washer, Lock (M10)
5 155–3102–01 1 Shield, Rain (DGBB, DGBC)
6 155–2062–01 1 Cap, Rain 12 800–2086 4 Screw, Cap – Hex Head
7 128–0154–02 2 Insulation, Foam (M10 x 1.5 x 25)
8 Pipe, Exhaust (DGBB, DGBC)
155–3064 1 DGCA, DGCB 13 128–0251 1 Insulation, Foam
155–3086 1 DGBB, DGBC 14 503–1870–04 1 Clamp, Hose

25
 Muffler – Industrial
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

6
4
5

5
7 1

5
8
A373
1

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Adapter, Exhaust 7 155–2565 1 Clamp, V–Band

155–3120–01 1 DGBB, DGBC (DGCA, DGCB)
155–3117 1 DGCA, DGCB 8 Brace, Exhaust
2 155–3114 1 Muffler 155–3118 DGCA, DGCB Without MOH
3 155–3115 1 Pipe, Outlet 155–3125 DGCA, DGCB With MOH
4 155–2175 2 Clamp, Muffler 9 154–2708 1 Gasket (DGBB, DGBC)
5 850–2010 4 Washer, Lock – EIT (M10)
6 800–2086 4 Screw, Cap – Hex Head
(M10 x 1.5 x 25)

26
 Muffler – Critical
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

11 4

1
5

6
7

10

F172,F173

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 155–3074 1 Muffler 8 154–2708 1 Gasket, Exhaust

2 Pipe, Exhaust (DGBB, DGBC)
155–3176 1 DGBB, DGBC 9 850–2010 4 Washer, Lock – Spring (M10)
155–3177 1 DGCA, DGCB (DGBB, DGBC)
3 155–2062–10 1 Cap, Rain 10 155–2565 1 Clamp, V–Band
4 155–3102–02 1 Shield, Rain (DGCA, DGCB)
5 821–6003–02 2 Screw, Hex Head (M8 x 20) 11 503–1870–05 1 Clamp, Hose
6 155–2175 1 Clamp, Muffler
7 800–2086 4 Screw, Cap – Hex Head
(M10 x 25) (DGBB, DGBC)

27
 Muffler – Standard
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

1
7

11

11

5
6

10

F172,173

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 155–3167 1 Muffler 6 800–2086 4 Screw, Cap – Hex Head

2 Pipe, Exhaust (M10 x 25) (DGBB, DGBC)
155–3166 1 DGCA, DGCB 7 821–6003–02 2 Screw, Cap – Hex Head
155–3168 1 DGBB, DGBC (M8 x 1.25 x 20)
3 155–2175 1 Clamp, Muffler 8 155–3102–02 1 Shield, Rain (3”)
4 155–2175 1 Clamp, V-Band (DGCA, 9 155–2062–10 1 Cap, Rain (3”)
DGCB) 10 154–2708 1 Gasket, Exhaust (DGBB,
5 850–2010 4 Washer, Lock – Spring (M10) DGBC)
(DGBB, DGBC) 11 155–3219 2 Gasket, Muffler

28
 Muffler – Industrial
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

2
1

A379

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 155–3193 1 Muffler 4 155–2175 1 Clamp, Muffler

2 155–3102–02 1 Shield, Rain 5 155–3260 1 Clamp, Muffler
3 155–3115 1 Pipe, Exhaust Outlet

29
 Low Coolant Level Sender
With Continuously Monitored Low Coolant Level
Sets With 12 Light Indicator Controls

4
1

8
6

3 5

H560

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 322–0431–07 1 Lens, Replacement 6 323–1765 1 *Housing, Connector (4 Pin)

2 338–3035–01 1 Harness, Low Coolant Level – 7 323–1709 4 *Socket, Contact (Used in S3)
LCL Sender to Control 8 323–1708 4 *Seal, Cable
3 193–0468 1 Sender, Low Coolant Level
4 357–0030 1 Rectifier, Silicon
5 338–3594 1 Harness, Pigtail (Includes * – Parts Included in 338–3594 Pigtail Harness
Parts Marked *)

30
 Low Coolant Level Sender
Without Continuously Monitored Low Coolant Level
DGBB Spec D, E, DGBC Spec C, D, DGCA and DGCB Spec L, M

H389,527

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 193–0467 1 Sender, Low Coolant Level 2 338–3442 1 Harness, Low Coolant Level
Sender

31
 Low Coolant Level Sender
Without Continuously Monitored Low Coolant Level
DGBB Spec F, DGBC Spec E, DGCA and DGCB Spec N

H389,527

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 193–0468 1 Sender, Low Coolant Level 2 338–3756 1 Harness, Low Coolant Level
Sender

32
 Water Heater

3
6

5 7

10
8

4
7

8 9
8

11 3
3

2 A292,H036,074,504,505

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Heater, Engine Coolant 8 503–0183 8 Clamp, Hose

333–0588–01 1 120 volt 9 502–0943 1 Connector, Hose
333–0588–02 1 240 volt (1/2 x 5/8 hose)
2 Backet, Heater 10 Screw, Hex Head
333–0584 1 Basic Skid (M6 x 1 x 16)
333–0585 1 Housing Ready Skid 821–6002–03 2 Basic Skid
3 503–1634–02 4 Hose (5/8 x 2-1/2) 821–6002–03 4 Housing Ready Skid
4 130–4643 1 Tube, Water Heater 11 821–6003–02 2 Screw, Hex Head
5 130–4644 1 Tube, Water Heater (M8 x 1-1/4 x 20)
6 502–0942 1 Elbow, Hose – 90° – Basic Skid
7 505–0019 2 Bushing, Reducer (3/8 x 1/2)

33
 Oil Heater

H487,479

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Heater, Oil 2 Cable, Heater – Oil

333–0429–01 1 120 Volt 335–0168–01 1 120 Volt
333–0429–02 1 240 Volt 335–0168–02 1 240 Volt

34
 Remote Radiator

7 7

6
2

9 8

10

11

7
E043

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 130–4637 1 Bracket, Guard – Belt 8 800–2110 4 Screw, Cap – Hex Head

2 130–4639 1 Guard, Belt (M12 x 20)
3 130–4636 1 Bracket, Guard – Belt 9 130–3582 1 Plate, Clamping
4 130–4638 1 Guard, Belt 10 800–2058 4 Screw, Cap – Hex Head
5 130–4640 1 Cover, Guard – Belt (M8 x 25)
6 130–4635 1 Bracket, Guard – Belt 11 526–2106 4 Washer, Flat (M8)
7 821–6003–02 19 Screw, Hex Head (M8 x 20)

35
 Radiator

3 16 25
1
27 26

28

13

12

24
18

19 17
23 20 3
15

15
21

13 22 7
14
2

10 8

29

11
30
4
6

36
 Radiator

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 130–4596–02 1 Radiator 15 503–0465 2 Clamp, Hose

2 130–4757 1 Shroud 16 130–4602 1 Grille (Unhoused sets)
3 130–4759 2 Side, Housing 17 504–0028 1 Cock, Drain (3/8NPT)
4 130–4716 1 Guard, Alternator 18 502–0085 1 Nipple, Pipe
5 130–4600 1 Guard, Fan – Right Side 19 505–0117 1 Bushing, Flush (3/8 x 1/2)
6 130–4756 1 Guard, Fan – Left Side 20 504–0011 1 Valve, Shutoff (1/2)
7 130–3080 1 Fan, Radiator 21 505–0185 1 Nipple, Half
8 130–3082 1 Spacer, Fan 22 503–0098 – Hose – Bulk (Order By The
9 526–2100 4 Washer, Flat (M8) Foot – 2 Feet Required)
10 800–2068 4 Screw, Cap – Hex Head 23 503–0197 1 Clamp, Hose
(M8 x 1.25 x 65) 24 130–4623 2 Adapter, Duct – Side
11 821–6003–02 24 Screw, SEMS – Hex Head 25 130–4622 2 Adapter, Duct
(M8 x 1.25 x 20) 26 818–0231–02 4 Rivet, Pop
12 Hose, Inlet – Radiator 27 Cap, Radiator
503–2003 1 DGBB Spec D, E, DGBC 130–1788 1 Without Overflow Bottle
Spec C, D, DGCA Spec 130–3721–01 1 With Overflow Bottle
L, M, DGCB Spec L, M 28 503–0276 – Hose – Bulk (5/16” ID)
503–2003–01 1 DGBB Spec F, DGBC Spec (Order By The Foot – 4 Feet
E, DGCA Spec N, DGCB Required)
Spec N 29 818–0231–02 3 Rivet
13 503–0365 2 Clamp, Hose 30 130–4715 1 Cover, Guard – Fan
14 503–1929 1 Hose, Outlet – Radiator

37
 Overflow Bottle
DGBB Spec F, DGBC Spec E, DGCA and DGCB Spec N

5
4

F172,F173

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 130–3984 1 Bottle, Overflow 4 821–6002–03 4 Screw, Hex Head

2 130–4878 1 Bracket, Bottle (M6 x 1 x 16)
3 503–0276 – Hose, Overflow – Bulk (5/16” 5 526–0399–13 4 Washer, Flat
ID) (Order By The Foot – 6 503–0685 1 Clamp, Hose
10 Feet Required) 7 818–0231–02 4 Rivet, Pop

38
39
 Housing
Standard Weather Protective
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L
14 11
10
13

2
15
4 6

6
3

7, 8
1
6

12
5 F171

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 405–5682 2 Post, Corner – Housing 9 821–6003–02 21 Screw, Hex Head (M8 x 20)
2 405–5679 1 Roof, Housing 10 517–0132 4 Plug, Hole
3 405–5684 2 Post, Center – Housing 11 517–0245 1 Plug, Hole
4 405–5685 1 Housing, Radiator 12 508–1011 – Seal, Edge – Bulk (Order By
5 406–0831 10 Hinge, Housing The Foot – 17 Feet
6 405–5735 5 Door, Housing Required)
7 406–0835 5 Latch, Door 13 098–4730 1 Label, Warning
406–0782 5 Key, Replacement (Fits Latch 14 098–5429 1 Label, Coolant Fill
406–0835) 15 098–4732 2 Label, Warning
8 818–0231–02 40 Rivet, Pop

40
 Housing
Standard Weather Protective
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N
13 14
18 13
20
12 21
3 17
22

1
6
4

15

11 1
7

9
6 6
10
23
7 4
8
19 16
F001
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 405–5908 2 Panel, Side – Radiator 12 821–6003–02 18 Screw, Hex Head (M8 x 20)
Housing 13 155–3238 4 Cover, Exhaust
2 405–5910 1 Panel, Front – Radiator 14 818–0237–01 6 Rivet, Pop
Housing 15 098–4500 2 Label, Prototype
3 405–6018 1 Roof 16 895–0382 10 Bumper, Door
4 405–5745 2 Post, Center – Housing 17 098–4730 1 Label, Warning
5 406–0831 10 Hinge, Housing 18 098–5429 1 Label, Coolant Fill
6 405–5832 4 Door, Housing 19 405–5902 1 Door, Housing – Sets Without
7 405–5916 2 Post, Corner – Housing Window
8 405–5903 1 Door, Housing – Sets With 20 870–0504 2 Nut, Captive Floating
Window (M6 x 1.0)
9 895–0363 – Weather Strip – Window – 21 821–6002–03 2 Screw, Hex Head (M6 x 16)
Bulk (Order By The Foot – 22 128–0154–02 1 Insulation, Foam
5 Feet Required) 23 406–0835 5 Latch, Door
10 319–2653 1 Control, Window (If 406–0782 5 Key, Replacement (Fits Latch
Equipped) 406–0835)
11 818–0231–02 60 Rivet, Pop

41
 Housing
Quiet Site First Stage
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

27
28 29 41
30
31

40

26
31
21
22

24

39
20
31
21
32
18
15
23 17
14
16
25
11

10

7 19

13 9
43

8
5 6
44

1
35
1
12
38
42

37 33

3 4 F172
34 2 33
36

42
 Housing
Quiet Site First Stage
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 405–5682 2 Post, Corner – Housing 28 405–5319 1 Support, Muffler

2 406–0831 10 Hinge, Housing 29 870–2193–04 1 Nut, Hex (M8)
3 818–0231–02 103 Rivet, Pop 30 517–0132 8 Plug, Hole (.375” Hole)
4 517–0322 4 Plug, Hole 31 517–0245 3 Plug, Hole
5 405–5706 1 Roof, Extension (Rear) 32 821–6003–02 39 Screw, Hex Head (M8 x 20)
6 405–5704 1 Roof, Extension (Left Side) 33 Door, Housing
7 405–5684 2 Post, Center – Housing 405–5687 4 Sets With Window
8 405–5685 1 Radiator, Housing 405–5687 5 Sets Without Window
9 405–5707 1 Roof, Extension (Front) 34 405–5689 1 Door, Housing – Sets With
10 405–5705 1 Roof, Extension (Right Side) Window
11 405–5625 1 Panel, Housing (Right Side) 35 508–1011 – Seal, Edge – Bulk (Order By
12 405–5627 1 Panel, Housing (Left Side) The Foot – 56 Feet
13 405–5628 1 Panel, Housing (Bottom) Required)
14 405–5722 4 Insulation, Baffle 36 406–0835 5 Latch
15 405–5720 4 Baffle, Air (Top) 406–0782 5 Key, Replacement (fits Latch
16 405–5721 4 Baffle, Air (Bottom) 406–0835)
17 818–0237–01 24 Rivet, Pop 37 895–0363 – Weather Strip – Window –
18 405–5630 1 Panel, Housing (Top) Bulk (Order By The Foot –
19 405–5428 2 Retainer, Insulation 5 Feet Required)
20 405–5709 1 Baffle 38 319–2653 1 Window, Control
21 405–5710 2 Baffle (If Equipped)
22 405–5423 1 Retainer, Insulation 39 818–0237–01 30 River, Pop
23 405–5426 1 Support, Baffle 40 098–4730 1 Label, Caution
24 405–5733 1 Insulation, Inlet 41 098–5429 1 Label, Danger
25 405–5638 1 Insulation, Roof 42 098–7102–02 2 Silkscreen, Model
26 405–5679 1 Roof 43 098–4500 2 Label, Prototype
27 405–5438 1 Cover, Exhaust Outlet 44 098–4732 2 Label, Warning

43
 Housing
Quiet Site Second Stage
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

32
33 34 48
35
36

47

31 29
27
36
25

30 25 21
22

24
27
29

20 46

36
21
37
18
15
23 17
14
16 28
11
9

10

7 19
8

26 50
13

6 12
5 51

26
1 41
1
40
45
49
42
44 38
7
26

42 F173
3 4
39 2 38
43

44
 Housing
Quiet Site Second Stage
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 405–5682 2 Post, Corner – Housing 32 405–5438 1 Cover, Exhaust Outlet

2 406–0831 10 Hinge, Housing 33 405–5319 1 Support, Muffler
3 818–0231–02 111 Rivet, Pop 34 870–2193–04 1 Nut, Hex (M8)
4 517–0322 4 Plug, Hole 35 517–0132 8 Plug, Hole (.375” Hole)
5 405–5706 1 Roof, Extension (Rear) 36 517–0245 3 Plug, Hole
6 405–5704 1 Roof, Extension (Left Side) 37 821–6003–02 39 Screw, Hex Head (M8 x 20)
7 405–5684 2 Post, Center – Housing 38 Door, Housing
8 405–5685 1 Radiator, Housing 405–5687 4 Sets With Window
9 405–5707 1 Roof, Extension (Front) 405–5687 5 Sets Without Window
10 405–5705 1 Roof, Extension (Right Side) 39 405–5689 1 Door, Housing – Sets With
11 405–5625 1 Panel, Housing (Right Side) Window
12 405–5627 1 Panel, Housing (Left Side) 40 508–1011 – Seal, Edge – Bulk (Order By
13 405–5628 1 Panel, Housing (Bottom) The Foot – 56 Feet
14 405–5722 4 Insulation, Baffle Required)
15 405–5720 4 Baffle, Air (Top) 41 405–5637 4 Insulation, Support Door
16 405–5721 4 Baffle, Air (Bottom) 42 405–5734 4 Insulation, Door
17 818–0237–01 24 Rivet, Pop 43 406–0835 5 Latch
18 405–5630 1 Panel, Housing (Top) 406–0782 5 Key, Replacement (fits Latch
19 405–5428 2 Retainer, Insulation 406–0835)
20 405–5709 1 Baffle 44 895–0363 – Weather Strip – Window –
21 405–5710 2 Baffle Bulk (Order By The Foot –
22 405–5423 1 Retainer, Insulation 5 Feet Required)
23 405–5426 1 Support, Baffle 45 319–2653 1 Window, Control
24 405–5733 1 Insulation, Inlet (If Equipped)
25 405–5731 2 Insulation, Panel 46 818–0237–01 46 River, Pop
26 405–5760 4 Insulation, Post 47 098–4730 1 Label, Caution
27 405–5424 2 Retainer, Insulation 48 098–5429 1 Label, Danger
28 405–5638 1 Insulation, Roof 49 098–7102–02 2 Silkscreen, Model
29 405–5427 2 Retainer, Insulation 50 098–4500 2 Label, Prototype
30 405–5732 1 Insulation, Roof 51 098–4732 2 Label, Warning
31 405–5679 1 Roof

45
 Housing
Quiet Site First Stage
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

20, 59, 60
20 7

49
8

28
44
50
31

6 44
40
37 43
32 18
21
34 47

25 45
27 5 29
38
37
33, 58
14
48
23 26 55
26 39 10
17
4 30 9
6
57
19 24
36
56 41
22 35
12
15
3 13 15
19
12
54
46
16 42
11 4
2

51

52

52

53

1
53
F172

46
 Housing
Quiet Site First Stage
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 517–0138–07 2 Plug, Hole 30 405–5961 2 Retainer, Insulation

2 895–0385 5 Weather Seal – Side 31 405–6030 1 Tube, Fill – Radiator
3 895–0363 – Weather Strip – Window – Bulk 32 405–5966 1 Box, Muffler
(Order By The Foot – 5 Feet 33 405–5987 1 Cover, Exhaust Inlet
Required) 34 405–5996 1 Extension, Side – RH
4 895–0384 11 Weather Seal – Top & Bottom 35 405–5995 1 Extension, Side – LH
5 405–6001–01 1 Fiberglass 36 405–5997 1 Fiberglass
6 098–7470 2 Label, Model 37 405–5998 2 Support, Muffler
7 098–5429 1 Label, Coolant Fill 38 405–6000–02 1 Fiberglass
8 098–4730 1 Label, Caution 39 405–6000–03 1 Fiberglass
9 098–4500 2 Label, Prototype Tested 40 405–6109 1 Fiberglass
10 098–7451 2 Label, Caution 41 405–6000–06 2 Fiberglass
11 319–2653 1 Window, Control (if equipped) 42 406–0831 10 Hinge, Housing
12 405–5734 4 Insulation, Door 43 405–6029 1 Baffle
13 405–5745 2 Post, Housing – Center 44 405–6003 2 Box, Radiator Fill
14 405–5841 2 Fiberglass 45 405–6005 1 Fiberglass
15 Door, Housing 46 895–0386 5 Weather Seal – Side
405–5902 4 Sets W/Window 47 405–6034 1 Retainer, Insulation
405–5902 5 Sets WO/Window 48 405–6015 1 Retainer, Insulation
16 405–5903 1 Door, Housing W/Window 49 405–6018 1 Roof
Cutout 50 405–6068 1 Baffle, Recirculation – Muffler
17 405–5908 2 Panel, Side – Radiator Housing 51 406–0835 5 Latch, Door
18 405–5910 1 Panel, Front – Radiator Housing 406–0782 5 Key, Replacement (fits Latch
19 405–5916 2 Post, Corner – Housing 406–0835)
20 155–3238 4 Cover, Exhaust 52 517–0131 6 Plug, Hole
21 405–5952 1 Extension, Front 53 517–0322 4 Plug, Hole
22 405–5953 1 Extension, Rear 54 818–0231–02 105 Rivet (3/16”)
23 405–5954 1 Baffle, Air 55 818–0237–01 32 Rivet (1/8”)
24 405–5955 1 Retainer, Insulation 56 821–6003–02 47 Screw (M8 x 20)
25 405–5956 1 Support, Center 57 098–4732 2 Label, Warning
26 405–5957 2 Angle, Support 58 526–0011 2 Washer, Flat (.203)
27 405–5958 1 Retainer, Insulation 59 870–0504 2 Nut, Captive Floating (M6 x 1.0)
28 405–6035 1 Baffle, Air – Discharge 60 821–6002–03 2 Screw, Hex Head (M6 x 16)
29 405–5960 1 Retainer, Insulation

47
 Housing
Quiet Site Second Stage
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

22, 70, 71
22 9

54
60
10
38

52 37
61
33 47 44
4
30
8 52
48
43 51
34 57
23
40 56

27 53 1
29 7 31
45
43 20
35, 69 39
16
59
25 28
28 46 12
47
19
6 32 11
8 58
21 68
26
42
67 49 66
24 41
14
17 36
5 15 17
21
14 65
55
18 50
13 6
3

62

63

63

64

2
64
F173

48
 Housing
Quiet Site Second Stage
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 405–6044 2 Retainer, Insulation 36 405–5988 1 Panel, Bottom

2 517–0138–07 2 Plug, Hole 37 405–5990 1 Cover, Air Discharge
3 895–0385 5 Weather Seal – Side 38 405–5991–01 1 Side, Discharge – RH
4 405–6132 1 Retainer, Insulation 39 405–5991–02 1 Side, Discharge – LH
5 895–0363 – Weather Strip – Window – Bulk 40 405–5996 1 Extension, Side – RH
(Order By The Foot – 5 Feet 41 405–5995 1 Extension, Side – LH
Required) 42 405–5997 1 Fiberglass
6 895–0384 11 Weather Seal – Top & Bottom 43 405–5998 2 Support, Muffler
7 405–6001–01 1 Fiberglass 44 405–6000–07 1 Fiberglass
8 098–7470 2 Label, Model 45 405–6000–02 1 Fiberglass
9 098–5429 1 Label, Coolant Fill 46 405–6000–03 1 Fiberglass
10 098–4730 1 Label, Caution 47 405–6000–04 2 Fiberglass
11 098–4500 2 Label, Prototype Tested 48 405–6109 1 Fiberglass
12 098–7451 2 Label, Caution 49 405–6000–06 2 Fiberglass
13 319–2653 1 Window, Control (If Equipped) 50 406–0831 10 Hinge, Housing
14 405–5734 4 Insulation, Door 51 405–6029 1 Baffle
15 405–5745 2 Post, Housing – Center 52 405–6003 2 Box, Radiator Fill
16 405–5841 2 Fiberglass 53 405–6005 1 Fiberglass
17 Door, Housing 54 405–6010 1 Cover, Air Discharge (Top)
405–5902 4 Sets W/Window 55 895–0386 5 Weather Seal – Side
405–5902 5 Sets WO/Window 56 405–6034 1 Retainer, Insulation
18 405–5903 1 Door, Housing W/Window 57 405–6013 1 Retainer, Insulation
Cutout 58 405–6014 2 Retainer, Insulation
19 405–5908 2 Panel, Side – Radiator Housing 59 405–6015 1 Retainer, Insulation
20 405–5910 1 Panel, Front – Radiator Housing 60 405–6018 1 Roof
21 405–5916 2 Post, Corner – Housing 61 405–6068 1 Baffle, Recirculation – Muffler
22 155–3238 4 Cover, Exhaust 62 406–0835 5 Latch, Door
23 405–5952 1 Extension, Front 406–0782 5 Key, Replacement (fits Latch
24 405–5953 1 Extension, Rear 406–0835)
25 405–5954 1 Baffle, Air 63 517–0131 6 Plug, Hole
26 405–5955 1 Retainer, Insulation 64 517–0322 4 Plug, Hole
27 405–5956 1 Support, Center 65 818–0231–02 105 Rivet (3/16”)
28 405–5957 2 Angle, Support 66 818–0237–01 66 Rivet (1/8”)
29 405–5958 1 Retainer, Insulation 67 821–6003–02 63 Screw (M8 x 20)
30 405–6035 1 Baffle, Air Discharge 68 098–4732 2 Label, Warning
31 405–5960 1 Retainer, Insulation 69 526–0011 2 Washer, Flat (.203)
32 405–5961 2 Retainer, Insulation 70 870–0504 2 Nut, Captive Floating (M6 x 1.0)
33 405–6030 1 Tube, Fill – Radiator 71 821–6002–03 2 Screw, Hex Head (M6 x 16)
34 405–5966 1 Box, Muffler
35 405–5987 1 Cover, Exhaust Inlet

49
 Skid – Basic
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

10 6
7
7 12
8
5
7 8
8 3
7 10
2
4
8 5
9
11
1

11

F177

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 403–4222 1 Skid 7 800–2543–02 8 Screw, Cap – Hex Head

2 402–0706 3 Cushion, Mounting – (M12 x 1.75 x 25)
Vibration Isolation 8 526–0433 12 Washer, Hardened (M12)
3 403–2567–01 1 Support, Engine 9 526–0434 8 Washer, Hardened (5/8)
4 337–0090 1 Strap, Electrical 10 800–0599–05 3 Screw, Cap – Hex Head
5 856–0013 2 Washer, Lock – ET (M12) (Grade 8) (5/8)
6 800–2121 4 Screw, Cap – Hex Head 11 870–0547 3 Nut, Hex – Heavy (5/8)
(M12 x 1.75 x 75) 12 526–0259–02 1 Washer, Flat (5/8)

50
 Skid – Housing Ready/Fuel Tank Ready
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

10
11
6 3 12
8 7 7
8

1 14 13 2
10
2 11
9

7
8

F176,179

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Skid 8 526–0433 10 Washer, Hardened (M12)

403–4035 1 Housing Ready 9 526–0434 4 Washer, Hardened (5/8”)
403–4134 1 Fuel Tank Ready 10 800–0599–05 3 Screw, Cap – Hex Head
2 402–0706 3 Cushion, Mounting – (5/8–11 x 2.00)
Vibration Isolation 11 870–0547 3 Nut, Hex – Heavy (5/8”)
3 403–2567–01 1 Support, Engine (Housing Ready)
4 337–0090 1 Strap, Electrical 12 526–0259–02 1 Washer, Flat (11/16”)
5 Washer, Lock – EIT (1/2”) 13 403–4156 1 Skid, End (Front)
856–0013 1 Fuel Tank Ready (Fuel Tank Ready)
856–0013 2 Housing Ready 14 821–6003–02 7 Screw, Hex Head
6 800–2121 4 Screw, Cap – Hex Head (M8 x 20) (Fuel Tank
(M12 x 1.75 x 75) Ready)
7 800–2543–02 8 Screw, Cap – Hex Head
(M12 x 1.75 x 25)

51
 Skid – Basic
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

9
6
7 7
11
8

5 8
7
7 3
14
2
4
8
12
5
13 10
1
12

15

16

F177

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 403–4222 1 Skid 9 800–0599–05 1 Screw, Cap – Hex Head

2 402–0706 1 Cushion, Mounting – (Grade 8) (5/8)
Vibration Isolation 10 870–0547 1 Nut, Hex – Heavy (5/8)
3 403–2567–01 1 Support, Engine 11 526–0259–02 1 Washer, Flat (11/16”)
4 337–0090 1 Strap, Electrical 12 526–0238–01 4 Washer, Flat (5/8”)
5 856–0013 2 Washer, Lock – ET (1/2”) 13 517–0094 2 Plug, Plastic
6 800–2121 4 Screw, Cap – Hex Head 14 800–0607 2 Screw, Cap – Hex Head
(M12 x 1.75 x 75) (Grade 8) (3/4–10 x 2)
7 800–2543–02 8 Screw, Cap – Hex Head 15 402–0730 2 Cushion, Mounting –
(M12 x 1.75 x 25) Vibration Isolation
8 526–0433 10 Washer, Hardened (M12) 16 862–0044 2 Nut, Hex (3/4–10)

52
 Skid – Housing Ready/Fuel Tank Ready
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

10 12
5
5 11
4
8 4
5 5 8
14 3
4 2
6 9 7
13 1
17
6
15
16

18

F176,179

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Skid 10 800–0599–05 1 Screw, Cap – Hex Head

403–4223–01 1 Housing Ready (Grade 8) (5/8)
403–4231 1 Tank Ready 11 526–0259–02 1 Washer, Flat (11/16”)
2 402–0706 1 Cushion, Mounting – 12 800–2121 4 Screw, Cap – Hex Head
Vibration Isolation (M12 x 1.75 x 75)
3 403–2567–01 1 Support, Engine 13 517–0094 2 Plug, Plastic
4 526–0433 10 Washer, Hardened (M12) 14 800–0607 2 Screw, Cap – Hex Head
5 800–2543–02 8 Screw, Cap – Hex Head (Grade 8) (3/4–10 x 2)
(M12 x 1.75 x 25) 15 402–0730 2 Cushion, Mounting –
6 526–0238–01 4 Washer, Flat (5/8”) Vibration Isolation
7 870–0547 1 Nut, Hex – Heavy (5/8) 16 862–0044 2 Nut, Hex (3/4–10)
8 Washer, Lock – ET (1/2”) 17 403–4156 1 Skid, End (Tank Ready)
856–0013 2 Housing Ready 18 821–6003–02 7 Screw, Hex Head (M8 x 20)
856–0013 1 Tank Ready (Tank Ready)
9 337–0090 1 Strap, Electrical

53
 Skid Pan

F170

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 403–4107 1 Pan, Skid 4 821–6002–03 38 Screw, SEMS – Hex Head

2 403–4110 10 Clamp (M6 x 1 x 16)
3 403–4116 3 Cover, Stub Up

54
 Sound Barrier

1
2

F172,173

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 159–1467 1 Cover, Fuel Tank 2 821–6003–02 6 Screw, Hex Head (M8 X 20)

55
 Battery Hold Down – Standard

3 5 4

2 1
F065

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 403–4058 1 Tray, Battery 4 416–0993–02 2 Rod, Hold Down – Battery

2 821–6003–02 3 Screw, Hex Head (M8 x 20) 5 865–0030 2 Nut, Wing (M6)
3 416–1033 1 Hold Down, Battery

56
 Battery Hold Down – Tank Ready Skid

F176

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 403–4163 1 Tray, Battery 4 865–0030 2 Nut, Wing (M6)

2 416–1003–02 2 Rod, Hold Down – Battery 5 821–6003–02 4 Screw, Hex Head (M8 x 20)
3 416–1033 1 Hold Down, Battery

57
 Starter

CP01

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 191–2211 1 Starter 3 800–2089 2 Screw, Cap – Hex Head

2 850–2010 2 Washer, Lock (M10) (M10 x 40)

58
 Alternator

3 4

1 6

CP01

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 191–2209 1 Alternator 4 860–2008 1 Nut, Hex (M8 x 1.25)

2 191–1981 1 Fan, Alternator 5 850–2005 2 Washer, Lock (M5)
3 850–2008 1 Washer, Lock (M8) 6 860–2006 2 Nut, Hex (M5 x 0.8)

59
 Electronic Governor
DGBB Spec D, E, DGBC Spec C, D, DGCA and DGCB Spec L, M

4 5

A367

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 150–2578 1 Package, Mounting – 2 338–3571 1 Harness, Electronic Governor

Actuator to Injection Pump 3 526–0027 1 Washer, Flat (13/16”)
(Includes Actuator 4 150–2331–00 1 Actuator, Governor
Mounting Bracket, Actuator 5 151–0715–01 1 Control, Governor
Shaft Clevis, Clevis Jam 6 821–6001–01 4 Screw, Hex Head (M5 x 10)
Nut, Male and Female Rod 7 866–0014 1 Nut, Acorn (#10–32)
End Bearings, Magnetic
Pickup, Wire Lugs,
Mounting Hardware and
Instruction Bulletin)

60
 Electronic Governor
DGBB Spec F, DGBC Spec E, DGCA and DGCB Spec N

5
1

A366,A367

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 150–2201 1 Sensor, Speed – Magnetic 5 338–3472 1 Harness, Wiring

2 Control, Governor 6 150–2735–01 1 Actuator, Rotary (12V)
151–0754–02 1 Without Droop Capability (Optional on Sets With
151–0731–01 1 With Droop Capability Detector Control – Also
3 821–6001–01 4 Screw, Hex Head Shown in External Engine
(M5 x 0.8 x 10) Group)
4 526–0027 1 Washer, Flat (13/16)

61
 Control Housing

2
3

ÂÂ 5

4 Â 1

11

8 3

62
 Control Housing

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Panel, Housing – Control 4 Screw, Locking – Hex Head

319–3208 1 Sets With UCD22 (5/16–18 x .50)
Generator 821–0014 4 Sets With UC27
319–2967 1 Sets With UC27 Generator Generator
2 Cover, Housing – Control 821–5003–01 4 Sets With UCD22
319–2996 3 Generator Sets Without Generator
Circuit Breaker or 5 856–0008 1 Washer, Lock – ET (5/16)
Entrance Box 6 508–0305–02 .33’ Edging
319–2996 2 Generator Sets With Circuit 7 517–0135 1 Plug, Hole
Breaker or Entrance Box 8 319–3207 1 Bracket, Control Mounting –
319–2996 1 Generator Sets With Two Sets With UCD22
Circuit Breakers Generator
3 Screw, Hex Head (M6 x 16)
821–6002–03 4 Sets With UC27 Generator
821–6002–03 9 Sets With UCD22
Generator

63
 Circuit Breaker Box
(UL Listed)
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

9
8 11

12

3
16
14
15

1 6
13
17
18 4
19
10
2

10

64
 Circuit Breaker Box
(UL Listed)
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319–3072 2 * Panel, End – Circuit Breaker 8 526–0008 4 *# Washer, Flat (#10) (Used
Box with F Frame Only)
2 319–2978 2 * Panel, Side – Circuit Breaker 9 *# Nut, Lock
Box 870–0221 4 TQD E Frame (#8–32)
3 098–2304 1 *# Label, Warning 870–0131 4 F Frame (#10–32)
4 * Cover, Box – Circuit Breaker 870–0232 4 J T JD Frame (1/4–20)
319–2979–02 1 Entrance Box Only (No 10 Screw, SEMS – Hex Head
Breaker) (M6 x 1 x 16)
319–2979–01 1 Used with Circuit Breaker 821–6002–03 8 No Breaker
5 *# Cutout, Box – Circuit Breaker 821–6002–03 24 Entrance Box Only (No
319–3012 1 110–225 Amp, 3 Pole, TQD Breaker)
Frame (Hole Size 76mm 821–6002–03 28 Used with Circuit Breaker
x 32mm) 11 508–0239 – * Edging – Bulk (Order By
319–3013 1 0–100 Amp, 3 Pole, E The Foot – 2 Feet
Frame (Hole Size 98mm Required)
x 36mm) 12 319–2980 1 *# Bracket, Mounting – Circuit
319–3013 1 125–225 Amp, 3 Pole, E Breaker (UL)
Frame (Hole Size 98mm 13 332–2744–07 1 Standoff, Insulator (3 Pole
x 36mm) Only)
319–3014 1 125–225 Amp, 3 Pole, F 14 821–6003–02 1 * Screw, SEMS – Hex Head
Frame (Hole Size 98mm (M8 x 1.25 x 20)
x 76mm) 15 332–1473 1 * Lug, Solderless
319–3014 1 250–425 Amp, 2 Pole, J T 16 856–0008 1 * Washer, Lock – EIT (5/16)
TD Frame (Hole Size 17 800–0048 2 Screw, Cap – Hex Head
98mm x 76mm) (3/8–16 x .75) (3 Pole Only)
319–3014 1 250–425 Amp, 3 Pole, J T 18 850–0050 2 Washer, Lock (3/8) (3 Pole
TD Frame (Hole Size Only)
98mm x 76mm) 19 526–0029 1 Washer, Flat (3/8) (3 Pole
319–3014 1 450–600 Amp, 2 Pole, J Only)
Frame (Hole Size
98mm x 76mm)
6 818–0231–02 4 *# Rivet, Pop * Not used on sets WO/Breaker or Entrance Box
7 *# Screw, Machine – Round
Head
812–0093 4 TQD E Frame # Not used on sets W/Entrance Box Only – No Breaker
(#8–32 x 3)
813–0190 4 F Frame (#10–32 x 4)
812–0157 4 J T JD Frame (1/4–20 x
1.75)

65
 Circuit Breaker Box
(Non-UL)
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

1 2

9
11
10
7

4 12
5 13
8

14
6

15 3

16

66
 Circuit Breaker Box
(Non-UL)
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319–2978 2 Panel, Side – Circuit Breaker 12 Nut, Hex

Box 3 Pole
2 319–3072 2 Panel, End – Circuit Breaker 860–2005 2 80 Amp (M4 x 0.7)
Box 860–2006 2 100/125/160/200 Amp
3 098–2304 1 Label, Warning (M5 x 0.8)
4 319–2979–01 1 Cover, Box – Circuit Breaker 4 Pole
5 821–6002–03 28 Screw, SEMS – Hex Head 860–2005 2 80 Amp (M4 x 0.7)
(M6 x 1 x 16) 860–2006 3 100/125/160/200 Amp
6 319–2995 1 Bracket, Mounting – Circuit (M5 x 0.8)
Breaker (Non–UL) 13 Washer, Lock
7 332–2744–07 1 Standoff, Insulator (3 Pole 3 Pole
Only) 850–2004 2 80 Amp (M4)
8 098–5854–04 1 Label, Marking – Bus (3 Pole 850–2005 2 100/125/160/200 Amp
Only) (M5)
9 800–0048 2 Screw, Cap – Hex Head 4 Pole
(3/8–16 x .75) (3 Pole Only) 850–2004 2 80 Amp (M4)
10 850–0050 2 Washer, Lock (3/8) (3 Pole 850–2005 3 100/125/160/200 Amp
Only) (M5)
11 526–0029 2 Washer, Flat (3/8) (3 Pole 14 508–0239 – Edging – Bulk (Order By The
Only) Foot – 2 Feet Required)
15 319–3014 1 Cutout, Box – Circuit Breaker
16 818–0231–02 4 Rivet, Pop

67
 Circuit Breaker Box
(UL Listed, IEC Conformity)
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

17
19
18
5
4

12
13
11

15
16
7 1
10
9 6
8
14
2

14

68
 Circuit Breaker Box
(UL Listed, IEC Conformity)
DGBB Spec E, F, DGBC Spec D, E, DGCA and DGCB Spec M, N

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319–3072 2 * Panel, End – Circuit Breaker 15 *# Cutout, Box – Circuit Breaker

Box 319–3241 1 10–100 Amp, 3 Pole, CE
2 319–2978 2 * Panel, Side – Circuit Breaker (Hole Size 46mm
Box x 84mm)
3 1 *# Bracket, Mounting – Circuit 319–3242 1 70–250 Amp, 3 Pole, NS
Breaker (Hole Size 38mm
319–3149 1 Q4, KDL, NS Circuit x 90mm)
Breakers 319–3242 1 70–250 Amp, 4 Pole, NS
319–3243 1 CE, CF, CJ Circuit (Hole Size 38mm
Breakers x 90mm)
4 098–2304 1 *# Label, Warning 319–3242 1 100–250 Amp, 2 & 3 Pole,
5 508–0239 – * Edging – Bulk (Order By The KDL (Hole Size 38mm
Foot – 2 Feet Required) x 90mm)
6 * Cover, Box – Circuit Breaker 319–3304 1 125–250 Amp, 3 Pole, CF
319–2979–02 1 Entrance Box Only (No (Hole Size 70mm
Breaker) x 112mm)
319–3151 1 Used with Circuit Breaker 319–3240 1 300–400 Amp, 2 & 3 Pole,
7 332–2744–07 1 Standoff, Insulator (2 & 3 Q4 (Hole Size 75mm
Pole Only) x 100mm)
8 800–0048 2 Screw, Cap – Hex Head 319–3304 1 300–600 Amp, 3 Pole, CJ
(3/8–16 x .75) (2 & 3 Pole (Hole Size 70mm
Only) x 112mm)
9 850–0050 2 Washer, Lock (3/8) (2 & 3 319–3150 1 300–630 Amp, 4 Pole, NS
Pole Only) (Hole Size 65mm
10 526–0029 1 Washer, Flat (3/8) (2 & 3 Pole x 120mm)
Only) 16 818–0231–02 4 *# Rivet, Pop
11 332–1473 1 * Lug, Solderless 17 860–0012 4 *# Nut (Q4 Circuit Breakers
12 856–0008 1 * Washer, Lock – EIT (5/16) Only) (#12–24)
13 821–6003–02 1 * Screw, SEMS – Hex Head 18 856–0005 4 *# Washer, Lock – W/EIT (Q4
(M8 x 1.25 x 20) Circuit Breakers Only)
14 Screw, SEMS – Hex Head (#12)
(M6 x 1 x 16) 19 *# Nut, Hex – W/EIT (#8–32)
821–6002–03 8 No Breaker 870–0221 4 70–250 Amp, 3 Pole, NS
821–6002–03 24 Entrance Box Only (No 870–0221 4 100–250 Amp, 2 & 3 Pole,
Breaker) KDL
821–6002–03 28 Used with Circuit Breaker * Not used on units WO/Breaker or Entrance Box
# Not used on units W/Entrance Box Only – No Breaker

69
 Generator Heater
(Standard)

1 2
16

7 9
8
12
11

10 15
14

5 18
17

13

A292,293

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Cartridge, Heater 10 098–7281 1 Label, Warning – Heater

333–0438–07 1 110–125 Volt 11 822–3047 1 Screw, Pan Head (M3 x 20)
333–0438–08 1 220–260 Volt 12 850–2003 1 Washer, Lock (M3)
2 332–3024–11 2 Clamp, Loop 13 800–3034 1 Screw, Cap – Hex Head
3 822–3075 6 Screw, Pan Head (M4 x 16) (M4 x .7 x 12)
4 860–2005 2 Nut, Hex (M4) 14 332–3228 1 Mount, Tie – Cable
5 850–2004 4 Washer, Lock (M4) 15 870–2064–01 1 Nut, Nylon
6 526–2050 2 Washer, Flat (M4) 16 332–1389 1 Tie, Cable
7 330–0142 1 Box, Terminal – Heater 17 815–0792–04 2 Screw, Countersunk – Pan
8 332–3023 1 Block, Terminal Head (M4 x .7 x 12)
9 508–0228 1 Grommet 18 517–0021 1 Plug, Dot – Button

70
 Generator Heater
(Quiet Site)

15
7 9 3
8
12 6
11 1

2
10

5
16

13

14

17 5

A292,293

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Cartridge, Heater 9 508–0228 1 Grommet

333–0438–07 1 110–125 Volt 10 098–6142 1 Label, Heater Adjust
333–0438–08 1 220–260 Volt 11 822–3047 1 Screw, Pan Head (M3 x 20)
2 332–3024–11 2 Clamp, Loop 12 850–2003 1 Washer, Lock (M3)
3 822–3075 5 Screw, Pan Head (M4 x 16) 13 532–0474–19 1 Marker, Wire (H1)
4 860–2005 1 Nut, Hex (M4) 14 532–0474–20 1 Marker, Wire (H2)
5 850–2004 3 Washer, Lock (M4) 15 898–1254–19 1 Sleeving, Insulating
6 526–2050 1 Washer, Flat (M4) 16 815–0242 2 Screw, Thread Cutting – Pan
7 330–0142 1 Box, Terminal – Heater Head (#8–32 x .5)
8 332–3023 1 Block, Terminal 17 226–4780 2 Lead

71
 Generator

5 7
15 6
18 14
3
16 10 13
9
49 12 8 4
11
21 19
50

2 52
23 53
57 17 22
54
56
55
39
32
38 30
24 34 54
48
28 31
51 37
29
58 26

42 39

20 38
25
40
62 41

1
27

59 33 30
29
61
28

60 36

35
47 45
44
45 46 44
43

72
 Generator

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Stator, Generator (See 23 Washer, Lock

Separate Page for Part 850–0114–54 6 165, 190mm Stack Length
Numbers) 850–0114–55 6 130, 160, 180, 240, 300mm
2 Rotor Assembly, Generator Stack Length
(Includes parts marked *) 24 805–0015 8 Bolt, Place (3/8–16 x .75)
201–3557–01 1 130mm Stack Length 25 508–0139 Seal, Edging – Bulk (Order
201–3557–02 1 160mm Stack Length by the foot – 3 Feet
201–3497–01 1 165mm Stack Length Required)
201–3557–03 1 180mm Stack Length 26 Cover, Stator – Top
201–3497–02 1 190mm Stack Length 234–0937–01 1 130, 160, 165, 190mm
201–3557–04 1 240mm Stack Length Stack Length
201–3557–05 1 300mm Stack Length 234–0937–02 1 180, 240mm Stack Length
3 * Key, Exciter Rotor 234–0937–03 1 300mm Stack Length
515–0299–02 1 130, 160mm Stack Length 27 Cover, Stator – Bottom
515–0299–04 1 180, 240mm Stack Length 232–3819–01 1 130, 160mm Stack Length
515–0299–05 1 300mm Stack Length 232–3819–02 1 180, 240mm Stack Length
515–0298–02 1 165, 190mm Stack Length 232–3819–03 1 300mm Stack Length
4 * Rotor Assembly, Exciter 232–3820–01 1 165, 190 Stack Length
(Includes Parts Marked #) 28 Screw, Cap – Hex Head
201–3434–01 1 130, 160mm Stack 800–3017–54 10 165, 190mm Stack Length
Length (M12 x 30mm)
201–3434–02 1 165, 180, 190, 240, 800–3017–37 8 130, 160mm Stack Length
300mm Stack Length (M10 x 25mm)
5 *# Rectifier Assembly (Includes 800–3017–37 10 180, 240, 300mm Stack
Parts Marked +) Length (M10 x 25mm)
357–0091 1 Forward (with Positive 29 Washer, Lock – Spring
Diode) 850–0114–55 10 M10
357–0092 1 Reverse (with Negative 850–0114–56 10 M12
Diode) 30 Washer, Flat
6 *#+ Diode 526–0399–62 10 M10
358–0135–01 3 Positive 526–0399–64 10 M12
358–0135–02 3 Negative 31 508–1057 1 Grommet
7 800–3009 3 *#+ Screw, Cap – Hex Head (M4 32 232–3421 1 Block, Terminal
x 35mm) (CR1,2,3,4,5,6) 33 517–0135 1 Plug, Hole
8 860–2005 3 *#+ Nut, Hex (M4) 34 Guard, Fan
9 850–2004 3 *#+ Washer, Lock – Spring (M4) 234–0867 2 165, 190mm Stack Length
10 526–2050 3 *#+ Washer, Flat (M4) 234–0980 2 130, 160, 180, 240, 300mm
11 870–2064–01 6 *# Nut, Locking – Nylon (M4) Stack Length
12 526–2050 6 *# Washer, Flat (M4) 35 Screen, Air Inlet
13 510–0164 1 * Bearing, Ball 234–0879 2 165, 190mm Stack Length
14 518–0083 1 * Ring, Retaining 234–0878 2 130, 160, 180, 240, 300mm
15 304–0807 1 * Varistor Stack Length
16 860–2006 2 * Nut, Hex (M5) 36 Screw, SEMS
17 232–3695 1 * Hub, Drive – Generator 821–6001–01 8 165, 190mm Stack Length
(UC27 Generator) (M5 x 10mm)
18 850–2005 2 * Washer, Lock – Spring (M5) 821–6001–02 8 130, 160, 180, 240, 300mm
19 526–2060 2 * Washer, Flat (M5) Stack Length (M5 x
20 O-Ring 12mm)
509–0266–01 1 130, 160, 180, 240, 300mm
Stack Length
509–0266–02 1 165, 190mm Stack Length
21 Adapter, Generator * –Parts Included in Generator Rotor Assemblies
231–0370 1 130, 160, 180, 240, 300mm
Stack Length # –Parts Included in Exciter Rotor Assemblies
231–0325 1 165, 190mm Stack Length
22 Screw, Cap – Hex Head
800–3017–20 6 165, 190mm Stack Length + –Parts Included in Rectifier Assemblies
130, 160, 180, 240, 300mm
Stack Length Continued...

73
 Generator

5 7
15 6
18 14
3
16 10 13
9
49 12 8 4
11
21 19
50

2 52
23 53
57 17 22
54
56
55
39
32
38 30
24 34 54
48
28 31
51 37
29
58 26

42 39

20 38
25
40
62 41

1
27

59 33 30
29
61
28

60 36

35
47 45
44
45 46 44
43

74
 Generator

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Continued... 45 Screw, Cap – Hex Head

800–3017–56 8 M12
37 Bell, End 800–3017–39 8 M10
211–0423 1 165, 190mm Stack Length 46 Washer, Flat
211–0422 1 130, 160, 180, 240, 300mm 526–0399–64 4 M12
Stack Length 526–0399–62 4 M10
38 Washer, Lock 47 Spacer, Foot – Mounting
850–0114–55 6 165, 190mm Stack Length 232–3730–04 4 165, 190mm Stack Length
(M10) 232–3730–03 4 130, 160, 180, 240, 300mm
850–0114–54 6 130, 160, 180, 240, 300mm Stack Length
Stack Length (M8) 48 805–0015 8 Bolt, Place (3/8–16 x .75)
39 Screw, Cap – Hex Head 49 800–2088 12 Screw, Cap – Hex Head
800–3017–38 6 165, 190mm Stack Length (M10 x 35mm)
(M10 x 30) 50 850–2010 12 Washer, Lock – Spring (M10)
130, 160, 180, 240, 300mm 51 526–0174 8 Washer, Flat (3/8)
Stack Length 52 860–2009 8 Nut, Hex (M10)
800–3017–42 5 M10 x 50mm 53 850–2010 8 Washer, Lock – Spring (M10)
800–3017–44 1 M10 x 60mm (12 O’Clock 54 526–2120 8 Washer, Flat (M10)
Position) 55 332–2987 4 Link, Terminal
40 850–2006 4 Washer, Lock – Spring (M6) 56 821–6001–01 8 Screw, Self–Locking – Hex
41 Screw, Cap – Hex Head Washer Head (M5 x 10mm)
800–2042 4 M6 x 60mm 57 232–3959–01 1 Disc, Drive
800–2046 4 M6 x 80mm 58 720–1123 8 Screw, Cap – Hex Head
42 Stator, Exciter (M16 x 60)
220–4293–04 1 130, 160mm Stack Length 59 526–0423 12 Washer, Flat (13/32” ID x
220–4293–05 1 165, 180, 190, 240, 300mm 1–1/4” OD x 1/4” thk)
Stack Length 60 850–0114–55 6 Washer, Lock – Spring (M10)
43 Bracket, Mounting – 61 800–3017–38 6 Screw, Cap – Hex Head
Generator Foot (M10 x 30mm)
232–3925 2 165, 190mm Stack 62 231–0319 1 Adapter, Stator (UC27)
Length
232–3940 2 130, 160, 180, 240, * –Parts Included in Generator Rotor Assemblies
300mm Stack Length
44 Washer, Lock # –Parts Included in Exciter Rotor Assemblies
850–0114–56 8 M12
850–0114–55 8 M10 + –Parts Included in Rectifier Assemblies

75
 Generator Stator

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Stator, Generator 12 Lead, 416/480

60 Hertz Volt, Broad Range
150 deg. C Heat Rise Reconnectible, Full
12 Lead, Standby, 1 Phase Output
418/480 Volt 220–4447–12 1 DGBB
Upper Broad Range 220–4447–13 1 DGBC
Reconnectible 220–4447–14 1 DGCA
220–4447–11 1 DGBB, DGBC 220–4447–15 1 DGCB
220–4447–12 1 DGCA 4 Lead, 1 Phase, 240
220–4447–14 1 DGCB Volt
3 Phase, 347/600 220–4447–06 1 DGBB
Volt, Standby 220–4447–07 1 DGBC
220–4447–26 1 DGBB, DGBC 220–4447–08 1 DGCA
220–4447–27 1 DGCA 220–4447–09 1 DGCB
220–4447–28 1 DGCB 3 Phase, 347/600 Volt
12 Lead, Standby, 220–4447–26 1 DGBB, DGBC
380/416 Volt, 220–4447–27 1 DGCA
Lower Borad Range 220–4447–28 1 DGCB
Reconnectible 12 Lead, 380/416
220–4447–16 1 DGBB, DGBC Volt, Lower Broad
220–4447–17 1 DGCA Range
220–4447–19 1 DGCB Reconnectible
125 deg. C Heat Rise 220–4447–16 1 DGBB, DGBC
12 Lead, 416/480 220–4447–17 1 DGCA
Volt, Upper Broad 220–4447–19 1 DGCB
Range 105 deg. C Heat Rise
Reconnectible 12 Lead, 416/480
220–4447–11 1 DGBB, DGBC Volt, Broad
220–4447–13 1 DGCA Range
220–4447–14 1 DGCB Reconnectible, Full
1 Phase Output
220–4447–12 1 DGBB
220–4447–14 1 DGBC, DGCA
220–4448–14 1 DGCB
Continued...

76
 Generator Stator

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Continued... 125 deg. C Heat Rise

4 Lead, 1 Phase 240 12 Lead, Broad
Volt Range
220–4447–07 1 DGBB Reconnectible
220–4447–08 1 DGBC 220–4447–11 1 DGBB, DGBC
220–4447–09 1 DGCA 220–4447–13 1 DGCA
220–4447–10 1 DGCB 220–4447–14 1 DGCB
3 Phase, 347/600 Volt 12 Lead, Broad
220–4447–26 1 DGBB Range
220–4447–27 1 DGBC Reconnectible, Full
220–4447–28 1 DGCA 1 Phase Output
220–4447–29 1 DGCB 220–4447–11 1 DGBB
12 Lead, 380/416 220–4447–12 1 DGBC
Volt, Lower Broad 220–4447–13 1 DGCA
Range 220–4447–15 1 DGCB
Reconnectible 105 deg. C Heat Rise
220–4447–16 1 DGBB 12 Lead, Broad
220–4447–17 1 DGBC Range
220–4447–18 1 DGCA Reconnectible
220–4447–19 1 DGCB 220–4447–11 1 DGBB
50 Hertz, 380/440 Volt 220–4447–12 1 DGBC
150 deg. C Heat Rise 220–4447–13 1 DGCA
12 Lead, Standby, 220–4447–14 1 DGCB
Broad Range 12 Lead, Broad
Reconnectible Range
220–4447–11 1 DGBB, DGBC Reconnectible, Full
220–4447–12 1 DGCA 1 Phase Output
220–4447–14 1 DGCB 220–4447–12 1 DGBB
220–4447–13 1 DGBC
220–4447–14 1 DGCA
220–4447–15 1 DGCB

77
 Control Heater
Generator Sets With Detector Control

11
10
16 8

12

3 13 18 9
7 5
17 9
14
6
15
2

A363,363

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 332–3338 2 Mount, Tie – Cable 11 335–0110 1 * Cable

2 098–6195 1 Label, Caution 12 332–2697 1 * Terminal, Ring
3 Heater, Control 13 332–1992 1 * Terminal, Receptical
333–0550–01 1 120 Volt 14 332–2430 1 * Terminal, Tab
333–0550–02 1 240 Volt 15 332–0942 3 Tie, Cable
4 898–1195–01 A/R Sleeving, Convoluted 16 800–0024 1 Screw, Cap – Hex Head
5 357–0114 1 Rectifier, Power (5/16–18 x 3/4)
6 332–1992 1 Terminal, Receptical 17 870–0257 1 Nut, Hex – Self Locking
7 332–2430 1 Terminal, Tab (5/16–18)
8 898–0860 A/R Tubing, Heat Shrink 18 856–0008 2 Washer, Lock EIT (5/16)
9 332–1789 2 Splice, Window (18 Gauge)
10 335–0173 1 Cable, Heater – Control
(Includes Parts Marked *) * – Parts Included In 335–0173 Heater Cable

78
 Control Heater
Generator Sets With PowerCommand Control

A362,363

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Heater Assembly, Control – 100 2 357–0114 1 Rectifier (3 Amp)

Watt (Includes Rectifier) 3 332–3338 1 Mount, Cable
300–4515–01 1 120 Volt
300–4515–02 1 240 Volt

79
 Mechanical Overspeed Switch

12
13
10
8
7

11
5

6
5
1

4
9
2 3
B240

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 150–2309 1 Bracket, Overspeed 9 526–0240 1 Washer, Flat

2 150–0956 1 Switch, Overspeed (.406 x 1.5 x .125)
3 150–0723 1 Point, Overspeed 10 821–6001–01 4 Screw, Hex Head
4 870–0250 1 Nut, Insulating (1/4–20) (M5 x .08 x 10)
5 862–0001 2 Nut, Hex (1/4–20) 11 234–0875–01 1 Cover, End Bell
6 853–0013 1 Washer, Lock – ET (1/4) 12 232–3462–01 4 Spacer, Cover
7 856–0010 1 Washer, Lock – EIT (3/8) 13 526–2080 4 Washer, Flat (M8)
8 800–2088 1 Screw, Cap – Hex Head
(M10 x 35)

80
 Electric Overspeed
(Detector Control)

2
6

1
5 B184

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 305–0902–01 1 Module, Frequency 5 812–0082 4 Screw, Machine – Round

2 319–0754 1 Plate, Overspeed Head (8–32 x 3/4”)
3 338–3396 1 Harness, Overspeed 6 332–1571 2 Terminal, Tab Adapter
4 815–0388 4 Screw, Cross Recessed
Thread Forming
(6–32 x 1/2”)

81
 Electric Overspeed
(Sentinel Control)

B184

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 305–0902–01 1 Module, Electric Overspeed 3 338–3451 1 Harness, Overspeed

2 815–0388 2 Screw, Thread Cutting – 4 332–1571 2 Terminal, Tab
Cross Recessed (#6–32 x
1/2)

82
 Permanent Magnet Generator

5
11

9
3 2

10

CP01

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 775–0049 1 Pin, Parallel 7 232–3462–03 4 Spacer, Cover

2 815–0761–01 1 Bolt, Mounting – PMG 8 821–6001–01 4 Screw, Hex Head (M5 x 10)
3 201–3446 1 Rotor, PMG 9 850–2010 1 Washer, Lock (M10)
4 220–4233 1 Stator, PMG 10 338–3011 1 Harness, PMG
5 232–3972 4 Clamp, Stator 11 850–2006 4 Washer, Lock (M6)
6 234–0875–02 1 Cover, End Bell

83
 Sentinel Control

26 25
32 29 31

27
28 30
7
12
16 9
17 10

1 18

6
8
24

8
19 5
22 11
34
23
35

21
34

33
4
8

8
2 8
8
11
13
36
7
3
14 20
H562
15

84
 Sentinel Control

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319–2991 1 Wrapper, Control 22 302–1968 1 Meter, Hz/RPM

2 319–2989 1 Panel, Control 23 308–1052 1 Switch, Rotary (Volt &
3 308–1011 1 Switch, Rocker Ammeter)
4 307–2871 1 Relay, Timer 24 338–3391 1 Harness, Wiring – Meters
5 307–2677–03 1 Relay (20 Amp, 250 VAC) (Includes Parts Marked *)
6 332–2877 2 Tie, Cable 25 332–0804 9 * Terminal, Ring
7 821–6002–03 3 Screw, Hex Head (M6 x 16) 26 332–1992 2 * Socket, Contact
8 870–0183 9 Nut, Lock – Acorn (#6–32) 27 323–1644–02 1 * Housing, Cap
9 402–0527 4 Isolator, Vibration 28 332–2630 11 * Terminal, Spade
10 821–0014 4 Screw, Self-Locking – Hex 29 332–0897 1 * Terminal, Ring
Washer Head 30 323–1648 8 * Pin, Contact
(5/16–18 x .50) 31 332–2468 2 * Terminal, Faston
11 815–0388 4 Screw, Cross Recessed – 32 332–1990 2 * Socket, Contact
Thread Cutting 33 870–1220 4 Nut – W/ET (#4–40)
(#6–32 x 1/2) 34 870–0439 4 Nut, Acorn (1/4–28)
12 337–0049 1 Strap, Bond 35 815–0875–02 3 Screw, Machine – Round
13 332–2974 1 Terminal, Spade Head (M4 x 8)
14 321–0175 1 Holder, Fuse 36 Breaker, Circuit
15 321–0353 1 Fuse (20 Amp) 320–1941 1 2 Pin
16 526–0018 1 Washer, Flat (5/16) 320–1824–02 1 4 Pin (With Auxiliary
17 856–0008 1 Washer, Lock – EIT (5/16) Contacts)
18 508–0305–02 – Edging – Bulk (Order By The
Foot – 1 Foot Required)
19 856–0003 2 Washer, Lock – ET (5/16)
20 302–2002 1 Meter, Hour
21 Voltmeter, AC
302–1148 1 0–300/0–600 (600 Volt) * – Parts Included in Wiring Harness 338–3391
302–1753 1 0–750 (All except 600 Volt)

85
 Detector Control

27
33 36
39 34 9 38

3 35

51
39

4 10 41
39 11 50
30
40 31 19 17
46 25 12
42 32 24 26 18 16

53 37
43 5 (6–8)
(28,47,
54) 52 15
37
44

37
22
45
13
14

1 2 48 20 21 23
49 24

55

2 29

86
 Detector Control

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319–3030 1 Box, Control 30 406–0332 2 Receptacle, Fastener

2 402–0527 4 Isolator, Vibration 31 406–0333 2 Stud, Fastener
3 815–0388 6 Screw, Machine – Round 32 406–0334 2 Washer, Stud Retainer
Head – Cross Recessed – 33 871–0015 1 Nut, Hex (1/4–20)
Thread Cutting (#6–32 x 1/2) 34 526–0018 1 Washer, Flat (1/4)
4 821–5000–05 3 Screw, Hex Head 35 337–0049 3 Strap, Ground
(#10–32 x 1/2) 36 800–0014 7 Screw, Cap – Hex Head
5 338–3252 1 Harness – DC (Includes Parts (5/16–18 x 1/2)
Marked *) 37 870–1220 6 Nut (#4–40)
6 323–1308 1 *Housing, PCB (12 Pin) 38 856–0008 2 Washer, Lock – EIT (5/16)
7 323–1302 A/R *Pin, Contact 39 821–0004 3 Screw, Locking Head
8 332–1445 A/R *Tie, Cable (#10–32 x 5/16)
9 Board, PC – Engine Monitor 40 301–9054–01 1 Door, Control (LH)
300–4294 1 7 Light 41 338–2278 1 Harness – AC
300–4296 1 12 Light 42 322–0363 1 Lamp Assembly
10 332–0052 1 Clip, Wire (Upper/Lower Scale)
11 870–0131 1 Nut, Hex W/ET (#10–32) 43 302–1148 1 Voltmeter – AC
12 301–9055–01 1 Door, Control (RH) 44 Ammeter – AC
13 815–0385 4 Screw, Machine – Round 302–1685 1 0–200/0–400
Head (#6–32 x 1/2) (Black 302–1724 1 0–250/0–500
Zinc) 302–1725 1 0–375/0–750
14 870–0183 4 Nut, Hex – W/ET (#6–32) 45 302–1968 1 Meter, Frequency (45–65 Hz.)
15 Lamp Assembly 46 098–5298 1 Label, Panel – AC (Front)
322–0359–01 1 7 Light 47 323–1648 A/R @Socket, Terminal
322–0360–01 1 12 Light 48 853–0008 1 Washer, Lock – ET (#10)
16 098–7477 1 Label, Panel – DC (Front) 49 308–1052 1 Switch, Rotary (Volt/Ammeter)
17 322–0361 1 Light, Panel 50 332–2723 1 Strip, Marker
18 322–0004 Lamp, Pilot 51 815–0901–06 2 Screw, Cross Recessed –
19 193–0466 1 Gauge, Oil Pressure Thread Cutting (#6–32 x 5/8)
20 193–0351 1 Gauge, Water Temperature 52 355–0189 1 Capacitor
21 Voltmeter 53 338–3429 1 Harness, TB21 (Includes
302–1641 1 8–18 Volt Parts Marked @)
302–1642 1 16–36 Volt 54 323–1644–02 1 @Housing, Cap
22 302–2002 1 Meter, Time Totalizing 55 815–0875–02 3 Screw, Machine – Pan Head
23 517–0131 1 Plug, Hole (M4 x 0.7 x 8)
24 193–0250 2 Resistor, Gauge
25 308–1010 1 Switch, Rocker (W/Light)
26 308–1011 1 Switch (WO/Light)
27 853–0008 4 Washer, Lock – ET (#10) * – Parts Included in 338–3252 Wiring Harness
28 332–1445 A/R @Tie, Cable
29 508–0051 1 Grommet (2”) @ – Parts Included in 338–3429 Wiring Harness

87
 PowerCommand Control

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 — 1 Control, PowerCommand Note: For PowerCommand Control service replacement

parts, order PowerCommand Control for Generator Sets parts
catalog number 960–0205.

88
 Dry Contact
DGBB Spec F, DGCA and DGCB Spec N

1
2 13
3

12

14 6

10 8

11
9 7

H568

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319–3601–02 1 Panel, Relay 8 323–1712 A/R # Plug, Cavity

2 307–2817–01 2 Relay (K8, K9) 9 357–0030 2 # Rectifier – 6 Amp
3 821–6001–02 2 Screw, Hex Head (M5 x 12) 10 323–1709 A/R # Socket, Contact (Used in S7)
4 821–5000–05 4 Screw, Cap – Hex Head 11 323–1708 A/R # Seal, Cable
(#10–32 x 1/2”) 12 870–2204 4 Standoff, Hex (#10–32)
5 338–3731 1 Harness, Wiring – Control 13 870–0131 4 Nut, Hex – W/ET (#10–32)
6 338–3744 1 Harness, Wiring – Dry 14 332–0527 2 Terminal, Tab – 250
Contact (Includes Parts
Marked #) # – Parts Included in 338–3744 Wiring Harness
7 323–1765 1 # Housing, Connector (4 Pin)

89
 Engine Wiring Harness
Generator Sets With PowerCommand Control
DGBB Spec D, E, DGBC Spec C, D, DGCA and DGCB Spec L, M

3
8

16 9
7
10
11
17
12

20 13
28
14
27 21
22
18
5
6
19
29
4
25
30
31 15
32 26
33
24
18
23
H530

90
 Engine Wiring Harness
Generator Sets With PowerCommand Control
DGBB Spec D, E, DGBC Spec C, D, DGCA and DGCB Spec L, M

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 338–3562 1 Harness, Wiring – Engine To 18 815–0839 2 Screw, Fillister Head – Cross

Control – Generator Sets With Recessed W/ET (#10–32 x
PowerCommand Control 3/8”)
(Includes Parts Listed Below) 19 815–0538 2 Screw, Machine – Round Head
2 Plug, Connector (23 Place) – Cross Recessed W/IT
323–1605–03 1 Colored Grey (P5) (#8–32 x 1/2”)
323–1605–02 2 Colored Natural (P4, P6) 20 323–1643–01 1 Plug, Connector (6 Place) (P10)
3 323–1614–01 50 Socket, Contact (Used In P4, 21 323–1666 1 Socket, Connector (3 Place)
P5, P6) (E1)
4 319–3180 1 Bracket, Mounting 22 332–3496 2 Pin, Terminal (Used In TB1)
5 332–0604 1 Block, Terminal (5 Place) 23 Bracket, Mounting – Terminal
(TB–BAT) 319–2006–01 1 Marked ”26” (T26)
6 307–2817–01 1 Relay (K4) 319–2006–02 1 Marked ”GND” (GND–ENG)
7 323–1580 1 Housing, Connector (12 Place) 24 332–0604 2 Block, Terminal (5 Place)
(J12) 25 332–1043 8 Jumper
8 323–1581 1 Wedge (Used In J12) 26 815–0538 4 Screw, Machine – Round Head
9 323–1491 6 Pin, Contact (Used In J12) – Cross Recessed W/IT
10 323–1648 5 Socket, Contact (Used In P10) (#8–32 x 1/2”)
11 323–1624 1 Wedge (Used In P7) 27 332–0604 1 Block, Terminal (5 Place)
12 323–1623 1 Plug, Connector (6 Place) (P7) (Used On B1)
13 323–1492 6 Socket, Contact (Used In P7) 28 332–1043 3 Jumper
14 323–1615 1 Plug (Used On P4, P5, P6) 29 321–0349 1 Holder, Fuse
(Quantity Used As Required) 30 321–0307–07 1 Fuse – 20 Amp (Colored
15 402–0510 1 Isolator, Vibration Yellow)
16 323–1445 4 Seal (Used On E2, E4) 31 800–0071 1 Screw, Cap – Hex Head
17 323–1540 2 Socket, Connector (2 Place) (7/16–14 x 1”)
(E2, E4) 32 856–0012 1 Washer, Lock – EIT (7/16”)
33 526–0032 1 Washer, Flat (7/16”)

91
 Engine Wiring Harness
Generator Sets With PowerCommand Control
DGBB Spec F, DGBC Spec E, DGCA and DGCB Spec N

3
8

16 9
7
10
11
17 33
12

20 13
28
14
27 21
22
32
18
34
5
6
19
29
4
25
30
15
26
31
24
18
23
H530

92
 Engine Wiring Harness
Generator Sets With PowerCommand Control
DGBB Spec F, DGBC Spec E, DGCA and DGCB Spec N

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 338–3753 1 Harness, Wiring – Engine To 21 323–1666 1 Socket, Connector (3 Place)

Control – Generator Sets With (E1)
PowerCommand Control 22 332–3496 2 Pin, Terminal (Used In TB1)
(Includes Parts Listed Below) 23 Bracket, Mounting – Terminal
2 Plug, Connector (23 Place) 319–2006–01 1 Marked ”26” (T26)
323–1605–03 1 Colored Grey (P5) 319–2006–02 1 Marked ”GND” (GND–ENG)
323–1605–02 2 Colored Natural (P4, P6) 24 332–0604 1 Block, Terminal (5 Place)
3 323–1614–01 50 Socket, Contact (Used In P4, 25 332–1043 4 Jumper
P5, P6) 26 815–0538 2 Screw, Machine – Round Head
4 319–3180 1 Bracket, Mounting – Cross Recessed W/IT
5 332–0604 1 Block, Terminal (5 Place) (#8–32 x 1/2”)
(TB–BAT) 27 332–0604 1 Block, Terminal (5 Place)
6 307–2817–01 1 Relay (K4) (Used On B1)
7 323–1580 1 Housing, Connector (12 Place) 28 332–1043 3 Jumper
(J12) 29 321–0349 1 Holder, Fuse
8 323–1581 1 Wedge (Used In J12) 30 321–0307–07 1 Fuse – 20 Amp (Colored
9 323–1491 6 Pin, Contact (Used In J12) Yellow)
10 323–1648 5 Socket, Contact (Used In P10) 31 338–3285 1 Harness Assembly, Jumper
11 323–1624 1 Wedge (Used In P7) (Includes Parts Indented
12 323–1623 1 Plug, Connector (6 Place) (P7) Below)
13 323–1492 6 Socket, Contact (Used In P7) 323–1652 1 Socket, Connector (2 Place)
14 323–1615 1 Plug (Used On P4, P5, P6) 323–1445 2 Seal
(Quantity Used As Required) 323–1718 2 Pin, Contact
15 402–0510 1 Isolator, Vibration 32 323–1765 1 Housing, Connector (4 Pin)
16 323–1445 3 Seal (Used On E2, E4, E6) 33 323–1709 4 Socket, Contact
17 323–1540 2 Socket, Connector (2 Place) 34 323–1708 4 Seal, Cable
(E2, E4)
18 815–0839 2 Screw, Fillister Head – Cross
Recessed W/ET (#10–32 x
3/8”)
19 815–0538 2 Screw, Machine – Round Head
– Cross Recessed W/IT
(#8–32 x 1/2”)
20 323–1643–01 1 Plug, Connector (6 Place) (P10)

93
 Engine Wiring Harness
Generator Sets With Detector Control or Sentinel Control

26 2 7 8
3

28
4
27

11 13
12
9

15
10 16

14 21

23
25
17
20 18

22
19
24

H562,559,560

94
 Engine Wiring Harness
Generator Sets With Detector Control or Sentinel Control

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 338–3390 1 Harness, Wiring – Engine to 18 332–1492 3 # Socket, Contact (Used on

Control (Sentinel Control) E1)
(Includes Parts Marked *) 19 323–1591 1 # Plug, Connector (E1)
2 332–0604 1 * Block, Terminal (TB) 20 323–1548 1 # Wedge, Plug (4 Pin)
3 359–0115 1 * Diode (CR1) 21 323–1546 1 # Plug (4 Pin)
4 332–1043 1 * Jumper 22 319–2006–01 1 # Bracket, Terminal Mounting
5 332–1995 4 * Socket, Contact 23 332–0604 1 # Block, Terminal (T26)
6 357–0030 3 * Rectifier, Silicon (CR4) 24 332–1043 4 # Jumper (T26)
7 351–1599–42 1 * Resistor (24W) (R1) 25 815–0538 2 # Screw, Machine – Round
8 307–2817–01 4 * Relay (K14) Head – Cross Recessed
9 338–3380 1 Harness, Wiring – Engine to W/IT (8–32 x .50)
Control (Detector Control) 26 Harness, Wiring – AC
(Includes Parts Marked #) Auxiliary (Includes Parts
10 323–1306 1 # Housing, Connector – 8 Marked +)
Place (J1) 338–3405 1 600 Volts
11 323–1304 1 # Housing, Connector – 6 338–3403 1 Less than 600 Volts
Place (J2) 27 + Connector, Plug (9 Place)
12 323–1200 12 # Socket, Contact (Used in J1, 323–1644–01 2 600 Volts
J2) 323–1644–01 1 Less than 600 Volts
13 307–2817–01 1 # Relay (K4) 28 323–1647 A/R + Pin, Contact
14 357–0030 1 # Rectifier, Silicon (CR2)
15 351–1599–42 1 # Resistor (24W) (R1) * – Parts Included in 338–3390 Wiring Harness
16 332–2431 2 # Pin, Contact # – Parts Included in 338–3380 Wiring Harness
17 332–1995 1 # Socket, Contact (Used on + – Parts Included in 338–3405 and 338–3403 Wiring
K4) Harness

95
 Voltage Regulator
(Detector Control)

4
5

8
9

B184,240

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Potentiometer 7 305–0868 1 Board, PC – Isolation

303–0261 1 SX460 Regulator Transformer (MX321
303–0285–01 1 MX321 Regulator Regulator Only – Up to 480
2 Regulator, Voltage Volts)
305–0844 1 SX460 Regulator 8 526–0003 4 Washer (#8) (MX321
305–0823 1 MX321 Regulator Regulator Only – Up to 480
3 350–1222 1 Resistor Volts)
4 815–0905–08 4 Screw, Cross Recessed 9 815–0388 4 Screw, Pan Head – Cross
(#10–32 x 7/8) Recessed – Thread
5 332–1043 11 Jumper Forming (#6–32 x 1/2)
6 320–1688–01 1 Breaker, Circuit (MX321 Regulator Only –
Up to 480 Volts)

96
 Voltage Regulator
(Sentinel Control)

6
7
8
3

1
5

4
5
B240,184

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Regulator, Voltage 5 Screw, Pan Head – Cross

305–0844 1 SX460 Recessed (#10–32)
305–0823 1 MX321 815–0905–08 4 SX460 Regulator
2 Potentiometer (Units with 815–0905–08 4 MX321 Regulator – 600
Gauges) Volt W/Meters
303–0261 1 SX460 Regulator 815–0905–08 8 MX321 Regulator –
303–0285–01 1 MX321 Regulator except 600 Volt
3 320–1688–01 1 Breaker, Circuit W/Meters
4 305–0868 1 Transformer (MX321 6 332–1445 A/R Tie, Cable
Regulator except 600 Volt 7 Terminal, Tab – Adapter
W/Meters) 332–1571 2 SX460 Regulator
332–1571 2 MX321 Regulator W/Meters
332–1571 4 MX321 Regulator W/O
Meters
8 338–3395 1 Harness – AC Control (Less
than 600 Volt WO/Meters)

97
 Emergency Stop Switch

KL39

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 302–1723 2 Ammeter – Blank Scale 4 322–0394 1 Bulb, Replacement

2 301–6257 1 Switch – Blank
3 308–0853 1 Switch, Pushbutton –
Emergency Stop (Includes
Bulb) (S14)

98
 Alarm Relay Board

12
8

4
2
11
5 10

KJ03

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 300–4111–03 1 Board, PC – Alarm Relay 7 338–2875 1 Harness, Alarm Relay Board

2 815–0544 6 Screw, Machine – Round (Includes parts marked *)
Head – Cross Recessed 8 323–1291 2 * Plug, 9 Pin
W/IT (#6–32 x .50) 9 332–1445 A/R * Tie, Cable
3 307–1058 3 Relay (12 VDC) (K1, K2, K3) 10 323–1199 9 * Pin, Contact
4 898–0025 5 * Sleeving (1/2”) 11 323–1200 12 * Socket, Contact
5 870–0517–02 2 Standoff – Alarm Board 12 323–1292 1 * Plug, 4 Pin
(1.31 lg.)
6 870–0517–01 4 Standoff – Alarm Board
(1.25 lg.) * = Parts includes in 338–2875 Harness Assembly

99
 Common Alarm

H560

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 300–4218–01 1 Board, PC – Diode 4 332–1445 A/R Tie, Cable

2 338–3033 1 Harness, Common Alarm
3 812–0063 4 Screw, Machine – Round
Head (#6–32 x 1/2)

100
 Alarm Module

4
1

KA08

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 300–3998–02 1 Module, Alarm 3 850–0040 2 Washer, Lock (1/4)

2 800–0006 2 Screw, Cap – Hex Head 4 862–0001 2 Nut, Hex (1/4–20)
(1/4–20 x 7/8) 5 332–0942 3 Tie, Cable

101
 Audible Alarm

KL39

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 333–0133 1 Signal, Audible 4 870–0183 2 Nut, Hex W/ET (#6–32)

2 319–0898 1 Plate, Audible Signal
3 815–0385 2 Screw, Machine – Round
Head (#6–32 x 1/2)

102
 Bell Alarm
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 320–1748–12 1 Alarm, Bell

103
 Fuel Alarm
DGBB Spec F, DGCA and DGCB Spec N

H573,H574

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 338–3722 1 Harness, Wiring – Fuel Alarm 3 322–0431–06 1 Lens, Basin

2 332–2605 1 Jumper, Terminal

104
 Ammeter

1
3

H562

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Ammeter, Dual Scale 2 870–1220 2 Nut, Hex – W/ET (#4–40)

302–1147 1 0–75/0–150 3 870–0439 2 Nut, Acorn (1/4–28)
302–1683 1 0–100/0–200
302–1684 1 0–150/0–300
302–1685 1 0–200/0–400

105
 Over/Under Voltage
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

3
4

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 307–2868 1 Relay, Over/Under Voltage 4 332–1445 A/R Tie, Cable

2 338–3366 1 Harness, Over/Under Voltage 5 322–0431–03 1 Lamp, Indicating
3 815–0388 4 Screw, Pan Head – Crossed
Recessed Thread Forming
(6–32 x 1/2)

106
 Time Delay Start/Stop

5
3
4

KL39

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 815–0544 4 Screw, Machine – Round 3 332–1445 3 Tie, Cable

Head – Cross Recessed W/ 4 338–1904 1 Harness, Time Delay Start/
IT (#6–32 x 1/2) Stop
2 300–2897 1 PCB, Time Delay Start/Stop 5 332–2957 1 Terminal, Tab

107
 Over/Under Frequency Relay
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

6
3

5
11
10
8 4
2

10
10

7
11
10

10
12
9
11

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 301–6987 1 Bracket 7 402–0354 4 Mount, Shock

2 301–9941 1 Plate, Relay Mounting 8 812–0082 2 Screw, Machine – Round
3 Relay, Over/Under Frequency Head (#8–32 x 3/4)
307–2553 1 50 Hertz 9 526–0115 2 Washer, Flat (11/32)
307–2709 1 60 Hertz 10 856–0002 18 Washer, Lock – EIT (M8)
4 322–0431–04 1 Lens, Replacement 11 860–0008 10 Nut, Hex (#8–32)
5 332–0942 3 Tie, Cable 12 870–0048 2 Nut, Self-Locking (5/16–18)
6 338–2347 1 Harness, Over/Under
Frequency

108
 Low Battery Voltage Sensor

1 2

6 5

H560,543

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 322–0431–08 1 Lens, Indicator 4 812–0084 2 Screw, Machine – Round

2 338–3034 1 Harness, Low Battery Head (#8–32 x 1)
Voltage 5 870–1221 2 Nut, Hex W/ET (#8–32)
3 323–1410–03 1 Base, Relay 6 305–0901 1 Sensor, Low Battery Voltage

109
 Wattmeter
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

8 4

9
7

10

5 7

1
2
K185

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 302–1722 1 Wattmeter (Dial Not Included) 4 Transducer, Watts (A21)

(M24) 302–1982–09 1 2 Element Watt, Single Phase,
2 Dial, Wattmeter 120/240 Volt
302–1721–01 1 0–35 kW Rating 302–1982–10 1 3 Element Watt, Three Phase,
302–1721–02 1 0–50 kW Rating Reconnectable WYE
302–1721–03 1 0–70 kW Rating 302–1982–11 1 3 Element Watt, Three Phase,
302–1721–04 1 0–90 kW Rating 120/240 Volt DELTA
302–1721–05 1 0–115 kW Rating 5 301–6987 1 Bracket, Mounting
3 Harness, Wiring 6 402–0354 4 Mount, Shock
338–3310 1 Single Phase, 120/240 Volt 7 856–0002 16 Washer, Lock – W/ET (#8)
338–3309 1 Three Phase, 120/240 Volt 8 860–0008 8 Nut, Hex (#8–32)
DELTA and Reconnectable 9 821–0017 2 Screw, Self-Locking – Hex
WYE Washer Head (5/16–18 x 1/2”)
10 870–0257 2 Nut, Locking – Hex (5/16–18)

110
 Speed Potentiometer

A068

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 151–0402 1 Potentiometer, Speed 3 332–2630 4 Terminal, Spade

2 334–0116 – Cable, Shielded – Bulk (Order
By The Foot – 7 Feet
Required)

111
 Oil Temperature Gauge
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

4
3

2
K486

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 332–1445 2 Tie, Cable 3 193–0388 1 Sender, Temperature

2 193–0435 1 Gauge, Oil Temperature 4 505–1373 1 Bushing, Reducer – Modified

112
 Current Transformer

H559,560,562,530,532,555

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Transformer, Current 2 338–3561 1 Harness, AC – Sets With

Sets With Detector PCC Control (Includes
Control Parts Marked *)
302–1845–03 3 Ratio 75/5 or 150/5 3 323–1644–03 A/R * Housing, Plug & Cap – 12
302–1845–04 3 Ratio 100/5 or 200/5 Place
302–1845–05 3 Ratio 150/5 or 300/5 4 323–1648 A/R * Socket, Contact
302–1845–06 3 Ratio 200/5 or 400/5
Sets With PCC Control
302–1922–43 3 Ratio 122/1 or 244/1
302–1922–01 3 Ratio 138/1 or 276/1 * – Parts Included in 338–3561 Wiring Harness
302–1922–03 3 Ratio 173/1 or 346/1
302–1922–44 3 Ratio 209/1 or 418/1
302–1922–45 3 Ratio 243/1 or 486/1
302–1926–21 3 Ratio 122/1
302–1926–22 3 Ratio 146/1
302–1926–23 3 Ratio 170/1
302–1926–24 3 Ratio 194/1

113
 Meter Transformer

2
7
8

3
5

H559,560,562
4

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 319–1498 1 Bracket, Transformer 5 323–1648 9 Socket, Contact

2 315–0717–00 3 Transformer 6 870–0221 12 Nut, Hex – W/ET (#8–32)
3 338–3337 1 Harness, Transformer 7 821–0016 4 Screw, Self-Locking – Hex
(Includes Connector and Flange Head (5/16–18 x 1)
Socket) 8 870–0257 4 Nut, Self-Locking (5/16–18)
4 323–1644–02 1 Connector, Housing (9 Place)

114
 Auxiliary Contact
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Contact, Auxiliary
320–1747–13 1 1 Contact
320–1747–14 1 2 Contact

115
 Circuit Breaker
UL Listed
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Breaker, Circuit 320–1462–44 1 90 Amp, 600 VAC

2 Pole 320–1462–48 1 150 Amp, 600 VAC
320–1513–10 1 450 Amp, 600 VAC 320–1463–08 1 175 Amp, 600 VAC
320–1513–11 1 500 Amp, 600 VAC 320–1556–07 1 150 Amp, 240 VAC
320–1555–11 1 250 Amp, 240 VAC 320–1556–08 1 175 Amp, 240 VAC
320–1555–12 1 300 Amp, 240 VAC 320–1556–09 1 200 Amp, 240 VAC
3 Pole 320–1556–10 1 225 Amp, 240 VAC
320–1458–26 1 80 Amp, 480 VAC 320–1556–15 1 250 Amp, 240 VAC
320–1458–27 1 90 Amp, 480 VAC 2 Pole with 12 VDC Shunt
320–1458–28 1 100 Amp, 480 VAC Trip
320–1458–30 1 125 Amp, 480 VAC 320–1519–06 1 250 Amp, 600 VAC
320–1458–31 1 150 Amp, 480 VAC 320–1519–07 1 300 Amp, 600 VAC
320–1458–43 1 80 Amp, 600 VAC 3 Pole with 12 VDC Shunt
320–1458–44 1 90 Amp, 600 VAC Trip
320–1458–48 1 150 Amp, 600 VAC 320–1856–17 1 150 Amp, 240 VAC
320–1459–08 1 175 Amp, 600 VAC 320–1856–19 1 200 Amp, 240 VAC
320–1555–07 1 150 Amp, 240 VAC 3 Pole with 12 VDC Shunt
320–1555–08 1 175 Amp, 240 VAC Trip and Aux Contact
320–1555–09 1 200 Amp, 240 VAC 320–1466–26 1 80 Amp, 480 VAC
320–1555–10 1 225 Amp, 240 VAC 320–1466–27 1 90 Amp, 480 VAC
320–1555–15 1 250 Amp, 240 VAC 320–1466–28 1 100 Amp, 480 VAC
2 Pole with Aux Contact 320–1466–30 1 125 Amp, 480 VAC
320–1516–10 1 450 Amp, 600 VAC 320–1466–31 1 150 Amp, 480 VAC
320–1516–11 1 500 Amp, 600 VAC 320–1467–08 1 175 Amp, 600 VAC
320–1556–11 1 250 Amp, 240 VAC 3 Pole with 24 VDC Shunt
320–1556–12 1 300 Amp, 240 VAC Trip and Aux Contact
3 Pole with Aux Contact 320–1490–26 1 80 Amp, 480 VAC
320–1462–26 1 80 Amp, 480 VAC 320–1490–27 1 90 Amp, 480 VAC
320–1462–27 1 90 Amp, 480 VAC 320–1490–28 1 100 Amp, 480 VAC
320–1462–28 1 100 Amp, 480 VAC 320–1490–30 1 125 Amp, 480 VAC
320–1462–30 1 125 Amp, 480 VAC 320–1490–31 1 150 Amp, 480 VAC
320–1462–31 1 150 Amp, 480 VAC 320–1491–08 1 175 Amp, 600 VAC
320–1462–43 1 80 Amp, 600 VAC

116
 Circuit Breaker
Non-UL Listed
DGBB Spec D, DGBC Spec C, DGCA and DGCB Spec L

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Breaker, Circuit 2 Lug, Breaker

3 Pole 3 Pole
320–1724–11 1 80 Amp, 600 VAC 320–1755–11 3 100/125/160 Amp
320–1725–04 1 100 Amp, 660 VAC 320–1755–12 3 200 Amp
320–1725–05 1 125 Amp, 660 VAC 4 Pole
320–1725–06 1 160 Amp, 660 VAC 320–1755–11 4 100/125/160 Amp
320–1726–06 1 200 Amp, 660 VAC 320–1755–12 4 200 Amp
4 Pole
320–1724–14 1 80 Amp, 600 VAC
320–1725–10 1 100 Amp, 660 VAC
320–1725–11 1 125 Amp, 660 VAC
320–1725–12 1 160 Amp, 660 VAC

117
 Circuit Breaker
(UL Listed, IEC Conformity)
DGBB Spec E, DGBC Spec D, DGCA and DGCB Spec M

1
2
3
4
5 7

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Breaker, Circuit – Molded Case 4 Pole (IEC)

600 Volt 320–1960–08 1 630 Amp Frame/500 Amp
3 Pole (UL & IEC) 320–1960–09 1 400 Amp Frame/400 Amp
320–1963–01 1 600 Amp Frame/600 Amp 320–1960–10 1 400 Amp Frame/320 Amp
320–1963–02 1 600 Amp Frame/500 Amp 320–1959–11 1 250 Amp Frame/250 Amp
320–1963–03 1 600 Amp Frame/450 Amp 320–1959–12 1 250 Amp Frame/200 Amp
320–1963–04 1 400 Amp Frame/400 Amp 320–1959–13 1 250 Amp Frame/160 Amp
320–1963–05 1 400 Amp Frame/350 Amp 320–1959–14 1 250 Amp Frame/125 Amp
320–1963–06 1 400 Amp Frame/300 Amp 320–1959–15 1 100 Amp Frame/100 Amp
320–1970–01 1 250 Amp Frame/250 Amp 320–1959–16 1 100 Amp Frame/80 Amp
320–1970–02 1 250 Amp Frame/225 Amp 240 Volt (UL)
320–1970–03 1 250 Amp Frame/200 Amp 2 Pole
320–1970–04 1 250 Amp Frame/175 Amp 320–1962–01 1 400 Amp Frame/400 Amp
320–1970–05 1 250 Amp Frame/150 Amp 320–1962–02 1 400 Amp Frame/350 Amp
320–1970–06 1 250 Amp Frame/125 Amp 320–1962–03 1 400 Amp Frame/300 Amp
320–1975–01 1 100 Amp Frame/100 Amp 320–1961–01 1 250 Amp
320–1975–02 1 100 Amp Frame/90 Amp 320–1961–02 1 225 Amp
320–1975–03 1 100 Amp Frame/80 Amp 320–1961–03 1 200 Amp
320–1975–04 1 100 Amp Frame/70 Amp 320–1961–04 1 175 Amp
320–1975–05 1 100 Amp Frame/60 Amp 320–1961–05 1 150 Amp
320–1975–06 1 100 Amp Frame/50 Amp 320–1961–06 1 125 Amp
320–1975–07 1 100 Amp Frame/45 Amp 320–1961–07 1 100 Amp
320–1975–08 1 100 Amp Frame/40 Amp 3 Pole
320–1975–09 1 100 Amp Frame/30 Amp 320–1962–04 1 400 Amp Frame/400 Amp
320–1975–10 1 100 Amp Frame/20 Amp 320–1962–05 1 400 Amp Frame/350 Amp
320–1975–11 1 100 Amp Frame/15 Amp 320–1962–06 1 400 Amp Frame/300 Amp
320–1961–08 1 250 Amp
320–1961–09 1 225 Amp
320–1961–10 1 200 Amp
320–1961–11 1 175 Amp
320–1961–12 1 150 Amp
320–1961–13 1 125 Amp
320–1961–14 1 100 Amp

Continued...

118
 Circuit Breaker
(UL Listed, IEC Conformity)
DGBB Spec E, DGBC Spec D, DGCA and DGCB Spec M

1
2
3
4
5 7

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Continued... 7 Package, Hardware – Mounting

(Includes Screws, Nuts and
2 Switch, Disconnect (600 Volt) Lock Washers – 1 Package
320–1992–01 1 1200 Amp Frame Required Per Switch)
320–1992–02 1 800 Amp Frame 320–1986–02 1 Used with 320–1963–XX
320–1991–01 1 600 Amp Frame Circuit Breakers
320–1991–02 1 400 Amp Frame 320–1986–03 1 Used with 320–1970–XX
3 Trip, Shunt (12 VDC) (600 Volt) Circuit Breakers
3 Pole 320–1986–04 1 Used with 320–1975–XX
320–1977–02 1 300 – 1200 Amp (UL & IEC) Circuit Breakers
320–1978–02 1 125 – 250 Amp (IEC) 320–1986–05 1 Used with 320–1962–XX
320–1979–02 1 15 – 100 Amp (IEC) Circuit Breakers (Screws
4 Pole Only)
320–1981–02 1 320 – 630 Amp (IEC) 320–1986–06 1 Used with 320–1961–XX
4 Contact, Auxiliary (600 Volt) Circuit Breakers (Screws
3 Pole Only)
320–1977–01 1 300–1200 Amp (UL & IEC) 320–1986–07 1 Used with 320–1960–XX
320–1978–01 1 125 – 250 Amp (IEC) Circuit Breakers
320–1979–01 1 15 – 100 Amp (IEC) 320–1986–08 1 Used with 320–1959–XX
4 Pole Circuit Breakers
320–1981–01 2 320 – 630 Amp (IEC)
5 Alarm, Trip (600 Volt)
320–1979–04 1 15 – 250 Amp (IEC)
6 Lead (Quantity Used As
Required)
33” Leads
226–0893 1 3/8” Ring Terminal End to
3/8” Ring Terminal End
30” Leads
226–3505–01 1 3/8” Ring Terminal End to 1”
Stripped End (#4 Wire)
226–3505–02 1 3/8” Ring Terminal End to
3/4” Stripped End (#4 Wire)
226–3505–03 1 3/8” Ring Terminal End to
3/8” Ring Terminal End
(#4 Wire)
226–3505–04 1 3/8” Ring Terminal End to
3/8” Ring Terminal End
(#1 Wire)

119
 Circuit Breaker
(UL Listed, IEC Conformity)
DGBB Spec F, DGBC Spec E, DGCA and DGCB Spec N

3
4 2

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 Breaker, Circuit 320–1959–05 1 * 150 Amp (600/750 Volts)

2 Pole (UL) 320–1959–04 1 * 175 Amp (600/750 Volts)
320–1961–07 1 100 Amp (240 Volts) 320–1959–03 1 * 200 Amp (600/750 Volts)
320–1961–06 1 125 Amp (240 Volts) 320–1959–02 1 * 225 Amp (600/750 Volts)
320–1961–05 1 150 Amp (240 Volts) 320–1959–01 1 * 250 Amp (600/750 Volts)
320–1961–04 1 175 Amp (240 Volts) 320–1960–06 1 * 300 Amp (600/750 Volts)
320–1961–03 1 200 Amp (240 Volts) 320–1960–05 1 * 350 Amp (600/750 Volts)
320–1961–02 1 225 Amp (240 Volts) 320–1960–04 1 * 400 Amp (600/750 Volts)
320–1961–01 1 250 Amp (240 Volts) 4 Pole (IEC)
320–1962–03 1 * 300 Amp (240 Volts) 320–1959–16 1 * 80 Amp (750 Volts)
320–1962–02 1 * 350 Amp (240 Volts) 320–1959–15 1 * 100 Amp (750 Volts)
320–1962–01 1 * 400 Amp (240 Volts) 320–1959–14 1 * 125 Amp (750 Volts)
3 Pole (UL) 320–1959–13 1 * 160 Amp (750 Volts)
320–1961–14 1 100 Amp (240 Volts) 320–1959–12 1 * 200 Amp (750 Volts)
320–1961–13 1 125 Amp (240 Volts) 320–1959–11 1 * 250 Amp (750 Volts)
320–1961–12 1 150 Amp (240 Volts) 320–1960–10 1 * 320 Amp (750 Volts)
320–1961–11 1 175 Amp (240 Volts) 320–1960–09 1 * 400 Amp (750 Volts)
320–1961–10 1 200 Amp (240 Volts) 2 Package, Hardware – Circuit
320–1961–09 1 225 Amp (240 Volts) Breaker Mounting (Includes
320–1961–08 1 250 Amp (240 Volts) Screws, Nuts and Lock
320–1962–06 1 * 300 Amp (240 Volts) Washers)
3 Pole (UL & IEC) 320–1986–08 1 Used With 320–1959–XX
320–1959–22 1 * 10 Amp (600/750 Volts) Circuit Breakers
320–1959–21 1 * 20 Amp (600/750 Volts) 320–1986–07 1 Used With 320–1960–XX
320–1959–20 1 * 30 Amp (600/750 Volts) Circuit Breakers
320–1959–19 1 * 40 Amp (600/750 Volts) (Screws Only)
320–1959–18 1 * 50 Amp (600/750 Volts) 320–1986–05 1 Used With 320–1962–XX
320–1959–17 1 * 60 Amp (600/750 Volts) Circuit Breakers
320–1959–10 1 * 70 Amp (600/750 Volts) (Screws Only)
320–1959–09 1 * 80 Amp (600/750 Volts)
320–1959–08 1 * 90 Amp (600/750 Volts) * – Includes Mounting Hardware
320–1959–07 1 * 100 Amp (600/750 Volts)
320–1959–06 1 * 125 Amp (600/750 Volts) Continued...

120
 Circuit Breaker
(UL Listed, IEC Conformity)
DGBB Spec F, DGBC Spec E, DGCA and DGCB Spec N

3
4 2

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

Continued... 5 Lead (Quantity Used As

Required)
Accessories, Circuit 226–0893 1 3/8” Ring Terminal End to
Breaker: The following 1” Stripped End – No
are used on 320–1959–XX Markings (33”) (#1/0
and 320–1960–XX Circuit Wire)
Breakers 226–3505–01 1 3/8” Ring Terminal End to
3 320–1981–02 1 Trip, Shunt (12V) 1” Stripped End – No
4 320–1981–01 2 Switch – Used as an Markings (30”) (#4
Auxiliary Contact or Trip Wire)
Alarm 226–3505–03 1 3/8” Ring Terminal End to
3/8” Ring Terminal End
– Marked “LO” (30”) (#4
Wire)
226–3505–04 1 3/8” Ring Terminal End to
3/8” Ring Terminal End
– Marked “LO” (30”)
(#1/0 Wire)

* – Includes Mounting Hardware

121
 Miscellaneous Labels

4 14 15 2
21

5 3 12

10
11
6
7

8 22 13 17 16
19 18
CP01
20 19

REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 098–4730 2 Label, Warning (Not used 11 098–4732 2 Label, Warning

W/Remote Radiator) 12 098–6460 1 Tag, Battery
2 098–5822 1 Label, Warning 13 098–6030 1 Tag, Caution
3 098–4798 1 Label, Warning (Used W/Optional Coolant
4 098–5842 1 Label, Caution Heater Only)
5 098–5347 3 Label, Danger 14 098–2124 1 Tag, Caution
6 098–6074–02 1 Label, Warning 15 098–7048 1 Tag, Oil Fill
7 098–5759 1 Label, Warning 16 501–0502 Line, Fuel Out
8 098–6139–04 1 Label, Model Identification 17 501–0627–03 1 Line, Fuel In
(Used W/Remote Radiator 18 098–3171 1 Tag, Fuel Line
Only) 19 503–0685 2 Clamp, Hose
9 098–7047 1 Tag, Water Fill (Not used 20 098–3172 1 Tag, Fuel Line
W/Remote Radiator) 21 098–2304 1 Label, Warning (Used
10 098–6139–06 2 Label, Model Identification W/Circuit Breaker Only)
(Not used W/Remote 22 098–4500 1 Decal
Radiator)

122
 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

098–2124, 122 130–3582, 35 151–0402, 111 159–1467, 55

098–2304, 65, 67, 69, 122 130–3721–01, 37 151–0715–01, 60 159–1468, 16
098–3171, 122 130–3984, 38 151–0731–01, 61 159–1472, 15
098–3172, 122 130–4596–02, 37 151–0754–02, 61 159–1481, 17
098–4500, 41, 43, 45, 47, 130–4600, 37 154–2708, 22, 25, 26, 27, 28 191–1981, 59
49, 122
130–4602, 37 155–2062–01, 25 191–2209, 59
098–4730, 40, 41, 43, 45,
47, 49, 122 130–4622, 37 155–2062–10, 27, 28 191–2211, 58
098–4732, 40, 43, 45, 47, 130–4623, 37 155–2175, 25, 26, 27, 28, 29 193–0250, 87
49, 122 130–4635, 35 155–2565, 23, 24, 25, 26, 193–0351, 87
098–4798, 122 27, 28
130–4636, 35 193–0375, 8
098–5298, 87 155–3064, 25
130–4637, 35 193–0388, 112
098–5347, 122 155–3066, 25
130–4638, 35 193–0432, 9
098–5387, 16, 17 155–3074, 27
130–4639, 35 193–0435, 112
098–5429, 40, 41, 43, 45, 155–3082, 25
130–4640, 35 193–0444, 9
47, 49 155–3086, 25
130–4643, 33 193–0448, 8
098–5759, 122 155–3102–01, 25
130–4644, 33 193–0451, 10
098–5822, 122 155–3102–02, 27, 28, 29
130–4715, 37 193–0463, 10
098–5842, 122 155–3114, 26
130–4716, 37 193–0466, 87
098–5854–04, 67 155–3115, 26, 29
130–4756, 37 193–0467, 31
098–6030, 122 155–3116, 23
130–4757, 37 193–0468, 30, 32
098–6074–02, 122 155–3117, 24, 26
130–4759, 37 201–3434–01, 73
098–6139–04, 122 155–3118, 26
130–4878, 38 201–3434–02, 73
098–6139–06, 122 155–3120–01, 26
140–1260, 12, 13 201–3446, 83
098–6142, 71 155–3120–02, 22
140–1548, 13 201–3497–01, 73
098–6195, 78 155–3125, 24, 26
140–2008, 12 201–3497–02, 73
098–6195–01, 9 155–3166, 28
140–3051, 12 201–3557–01, 73
098–6460, 122 155–3167, 28
140–3053, 12 201–3557–02, 73
098–7047, 122 155–3168, 28
140–3054, 13 201–3557–03, 73
098–7048, 122 155–3176, 27
140–3055, 12 201–3557–04, 73
098–7102–02, 43, 45 155–3177, 27
140–3056, 13 201–3557–05, 73
098–7281, 70 155–3193, 29
140–3063, 12, 13 211–0422, 75
098–7451, 47, 49 155–3196, 22
140–3067, 13 211–0423, 75
098–7470, 47, 49 155–3219, 28
147–0779, 7, 8 220–4233, 83
098–7477, 87 155–3238, 41, 47, 49
149–2441, 19 220–4293–04, 75
102–1147, 11 155–3260, 29
150–0723, 80 220–4293–05, 75
102–1237, 11 159–1371–03, 14
150–0956, 80 220–4447–06, 76
102–1356, 9 159–1371–05, 14
150–2201, 61 220–4447–07, 76, 77
102–1448–02, 9 159–1378, 14
150–2309, 80 220–4447–08, 76, 77
128–0154–02, 25, 41 159–1439, 19
150–2331, 9 220–4447–09, 76, 77
128–0251, 25 159–1463, 14
150–2331–00, 60 220–4447–10, 77
130–1788, 37 159–1463–01, 14
150–2578, 60 220–4447–11, 76, 77
130–3080, 37 159–1464, 14
150–2735–01, 9, 61
130–3082, 37

123
 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

220–4447–12, 76, 77 300–2897, 107 302–1926–24, 113 319–0898, 102

220–4447–13, 76, 77 300–3464, 18 302–1968, 85, 87 319–1498, 114
220–4447–14, 76, 77 300–3998–02, 101 302–1982–09, 110 319–2006–01, 91, 93, 95
220–4447–16, 76, 77 300–4111–03, 99 302–1982–10, 110 319–2006–02, 91, 93
220–4447–17, 76, 77 300–4218–01, 100 302–1982–11, 110 319–2653, 41, 43, 45, 47, 49
220–4447–18, 77 300–4294, 87 302–2002, 85, 87 319–2967, 63
220–4447–19, 76, 77 300–4296, 87 303–0261, 96, 97 319–2978, 65, 67, 69
220–4447–26, 76, 77 300–4515–01, 79 303–0285–01, 96, 97 319–2979–01, 65, 67
220–4447–27, 76, 77 300–4515–02, 79 304–0807, 73 319–2979–02, 65, 69
220–4447–28, 76, 77 301–6257, 98 305–0823, 96, 97 319–2980, 65
220–4447–29, 77 301–6987, 108, 110 305–0844, 96, 97 319–2989, 85
220–4448–14, 76 301–9054–01, 87 305–0868, 96, 97 319–2991, 85
226–0893, 119, 121 301–9055–01, 87 305–0901, 109 319–2995, 67
226–3505–01, 119, 121 301–9941, 108 305–0902–01, 81, 82 319–2996, 63
226–3505–02, 119 302–1147, 105 307–1058, 99 319–3012, 65
226–3505–03, 119, 121 302–1148, 85, 87 307–2553, 108 319–3013, 65
226–3505–04, 119, 121 302–1641, 87 307–2677–02, 18 319–3014, 65, 67
226–4780, 71 302–1642, 87 307–2677–03, 85 319–3030, 87
231–0325, 73 302–1683, 105 307–2709, 108 319–3072, 65, 67, 69
231–0370, 73 302–1684, 105 307–2817–01, 89, 91, 93, 95 319–3149, 69
232–3421, 73 302–1685, 87, 105 307–2851, 19 319–3150, 69
232–3462–01, 80 302–1721–01, 110 307–2868, 106 319–3151, 69
232–3462–03, 83 302–1721–02, 110 307–2871, 85 319–3180, 91, 93
232–3695, 73 302–1721–03, 110 308–0852, 18 319–3207, 63
232–3730–03, 75 302–1721–04, 110 308–0853, 98 319–3208, 63
232–3730–04, 75 302–1721–05, 110 308–0912, 18 319–3240, 69
232–3819–01, 73 302–1722, 110 308–0913, 16 319–3241, 69
232–3819–02, 73 302–1723, 98 308–0913–09, 16, 17 319–3242, 69
232–3819–03, 73 302–1724, 87 308–0916–01, 21 319–3243, 69
232–3820–01, 73 302–1725, 87 308–0963–01, 20 319–3304, 69
232–3925, 75 302–1753, 85 308–1010, 87 319–3601–02, 89
232–3940, 75 302–1845–03, 113 308–1011, 85, 87 320–1458–26, 116
232–3959–01, 75 302–1845–04, 113 308–1052, 85, 87 320–1458–27, 116
232–3972, 83 302–1845–05, 113 309–0269, 9 320–1458–28, 116
234–0867, 73 302–1845–06, 113 309–0553–01, 8 320–1458–30, 116
234–0875–01, 80 302–1922–01, 113 309–0554–01, 7, 8 320–1458–31, 116
234–0875–02, 83 302–1922–03, 113 309–0641–19, 7, 8 320–1458–43, 116
234–0878, 73 302–1922–43, 113 309–0641–20, 8 320–1458–44, 116
234–0879, 73 302–1922–44, 113 315–0687, 18 320–1458–48, 116
234–0937–01, 73 302–1922–45, 113 315–0717–00, 114 320–1459–08, 116
234–0937–02, 73 302–1926–21, 113 319–0485, 18 320–1462–26, 116
234–0937–03, 73 302–1926–22, 113 319–0486, 18 320–1462–27, 116
234–0980, 73 302–1926–23, 113 319–0754, 81 320–1462–28, 116

124
 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

320–1462–30, 116 320–1725–04, 117 320–1960–10, 118, 120 320–1975–11, 118

320–1462–31, 116 320–1725–05, 117 320–1961–01, 118, 120 320–1977–01, 119
320–1462–43, 116 320–1725–06, 117 320–1961–02, 118, 120 320–1977–02, 119
320–1462–44, 116 320–1725–10, 117 320–1961–03, 118, 120 320–1978–01, 119
320–1462–48, 116 320–1725–11, 117 320–1961–04, 118, 120 320–1978–02, 119
320–1463–08, 116 320–1725–12, 117 320–1961–05, 118, 120 320–1979–01, 119
320–1466–26, 116 320–1726–06, 117 320–1961–06, 118, 120 320–1979–02, 119
320–1466–27, 116 320–1747–13, 115 320–1961–07, 118, 120 320–1979–04, 119
320–1466–28, 116 320–1747–14, 115 320–1961–08, 118, 120 320–1981–01, 119, 121
320–1466–30, 116 320–1748–12, 103 320–1961–09, 118, 120 320–1981–02, 119, 121
320–1466–31, 116 320–1755–11, 117 320–1961–10, 118, 120 320–1986–02, 119
320–1467–08, 116 320–1755–12, 117 320–1961–11, 118, 120 320–1986–03, 119
320–1490–26, 116 320–1824–02, 85 320–1961–12, 118, 120 320–1986–04, 119
320–1490–27, 116 320–1856–17, 116 320–1961–13, 118, 120 320–1986–05, 119, 120
320–1490–28, 116 320–1856–19, 116 320–1961–14, 118, 120 320–1986–06, 119
320–1490–30, 116 320–1941, 85 320–1962–01, 118, 120 320–1986–07, 119, 120
320–1490–31, 116 320–1959–01, 120 320–1962–02, 118, 120 320–1986–08, 119, 120
320–1491–08, 116 320–1959–02, 120 320–1962–03, 118, 120 320–1991–01, 119
320–1513–10, 116 320–1959–03, 120 320–1962–04, 118 320–1991–02, 119
320–1513–11, 116 320–1959–04, 120 320–1962–05, 118 320–1992–01, 119
320–1516–10, 116 320–1959–05, 120 320–1962–06, 118, 120 320–1992–02, 119
320–1516–11, 116 320–1959–06, 120 320–1963–01, 118 321–0175, 85
320–1519–06, 116 320–1959–07, 120 320–1963–02, 118 321–0307–07, 91, 93
320–1519–07, 116 320–1959–08, 120 320–1963–03, 118 321–0349, 91, 93
320–1555–07, 116 320–1959–09, 120 320–1963–04, 118 321–0353, 85
320–1555–08, 116 320–1959–10, 120 320–1963–05, 118 322–0004, 87
320–1555–09, 116 320–1959–11, 118, 120 320–1963–06, 118 322–0359–01, 87
320–1555–10, 116 320–1959–12, 118, 120 320–1970–01, 118 322–0360–01, 87
320–1555–11, 116 320–1959–13, 118, 120 320–1970–02, 118 322–0361, 87
320–1555–12, 116 320–1959–14, 118, 120 320–1970–03, 118 322–0363, 87
320–1555–15, 116 320–1959–15, 118, 120 320–1970–04, 118 322–0369–02, 18
320–1556–07, 116 320–1959–16, 118, 120 320–1970–05, 118 322–0394, 98
320–1556–08, 116 320–1959–17, 120 320–1970–06, 118 322–0403–02, 18
320–1556–09, 116 320–1959–18, 120 320–1975–01, 118 322–0431–03, 106
320–1556–10, 116 320–1959–19, 120 320–1975–02, 118 322–0431–04, 108
320–1556–11, 116 320–1959–20, 120 320–1975–03, 118 322–0431–06, 21, 104
320–1556–12, 116 320–1959–21, 120 320–1975–04, 118 322–0431–07, 30
320–1556–15, 116 320–1959–22, 120 320–1975–05, 118 322–0431–08, 109
320–1653, 18 320–1960–04, 120 320–1975–06, 118 323–1199, 99
320–1654, 18 320–1960–05, 120 320–1975–07, 118 323–1200, 95, 99
320–1688–01, 96, 97 320–1960–06, 120 320–1975–08, 118 323–1291, 99
320–1724–11, 117 320–1960–08, 118 320–1975–09, 118 323–1292, 99
320–1724–14, 117 320–1960–09, 118, 120 320–1975–10, 118 323–1302, 87

125
 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

323–1304, 95 332–1389, 70 335–0168–02, 34 351–1599–42, 95

323–1306, 95 332–1445, 87, 97, 99, 100, 335–0173, 78 355–0189, 87
106, 107, 112
323–1308, 87 337–0049, 85, 87 357–0030, 30, 89, 95
332–1473, 65, 69
323–1410–03, 109 337–0090, 50, 51, 52, 53 357–0091, 73
332–1571, 81, 82, 97
323–1445, 91, 93 338–1904, 107 357–0092, 73
332–1789, 78
323–1491, 91, 93 338–2278, 87 357–0114, 78, 79
332–1990, 85
323–1492, 91, 93, 95 338–2347, 108 358–0135–01, 73
332–1992, 20, 21, 78, 85
323–1540, 91, 93 338–2382, 18 358–0135–02, 73
332–1993, 9
323–1546, 95 338–2397, 16 359–0115, 95
332–1995, 95
323–1548, 95 338–2800, 17 399–0117–01, 16, 17
332–2430, 20, 21, 78
323–1580, 91, 93 338–2875, 99 402–0354, 108, 110
332–2431, 95
323–1581, 91, 93 338–3011, 83 402–0510, 91, 93
332–2468, 85
323–1591, 95 338–3033, 100 402–0527, 85, 87
332–2605, 18, 104
323–1605–02, 91, 93 338–3034, 109 402–0706, 50, 51, 52, 53
332–2630, 85, 111
323–1605–03, 91, 93 338–3035–01, 30 402–0730, 52, 53
332–2697, 78
323–1614–01, 91, 93 338–3252, 87 403–2567–01, 50, 51, 52, 53
332–2723, 87
323–1615, 91, 93 338–3285, 93 403–4035, 51
332–2744–07, 65, 67, 69
323–1623, 91, 93 338–3309, 110 403–4058, 56
332–2877, 85
323–1624, 91, 93 338–3310, 110 403–4107, 54
332–2921, 8
323–1643–01, 91, 93 338–3337, 114 403–4110, 54
332–2957, 107
323–1644–01, 95 338–3366, 106 403–4116, 54
332–2974, 85
323–1644–02, 85, 87, 114 338–3380, 95 403–4134, 51
332–2987, 75
323–1644–03, 113 338–3390, 95 403–4156, 51, 53
332–3023, 70, 71
323–1647, 95 338–3391, 85 403–4163, 57
332–3024–11, 70, 71
323–1648, 85, 87, 91, 93, 338–3395, 97 403–4222, 50, 52
113, 114 332–3196, 9
338–3396, 81 403–4223–01, 53
323–1652, 93 332–3228, 70
338–3403, 95 403–4231, 53
323–1666, 91, 93 332–3338, 78, 79
338–3405, 95 405–5319, 43, 45
323–1708, 30, 89, 93 332–3496, 91, 93
338–3429, 87 405–5423, 43, 45
323–1709, 30, 89, 93 333–0133, 102
338–3442, 31 405–5424, 45
323–1712, 89 333–0429–01, 34
338–3451, 82 405–5426, 15, 43, 45
323–1718, 93 333–0429–02, 34
338–3472, 61 405–5427, 45
323–1765, 30, 89, 93 333–0438–07, 70, 71
338–3561, 113 405–5428, 43, 45
330–0142, 70, 71 333–0438–08, 70, 71
338–3562, 91 405–5438, 43, 45
331–0027, 18 333–0550–01, 78
338–3571, 60 405–5625, 43, 45
331–0042, 18 333–0550–02, 78
338–3594, 30 405–5627, 43, 45
332–0052, 87 333–0584, 33
338–3722, 104 405–5628, 43, 45
332–0527, 89 333–0585, 33
338–3731, 89 405–5630, 43, 45
332–0604, 91, 93, 95 333–0588–01, 33
338–3744, 89 405–5637, 45
332–0804, 85 333–0588–02, 33
338–3753, 93 405–5638, 43, 45
332–0897, 85 334–0116, 111
338–3756, 32 405–5679, 40, 43, 45
332–0942, 78, 101, 108 335–0110, 78
350–1222, 96 405–5682, 40, 43, 45
332–1043, 91, 93, 95, 96 335–0168–01, 34

126
 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

405–5684, 40, 43, 45 405–5997, 47, 49 416–0993–02, 56 505–0069, 21

405–5685, 40, 43, 45 405–5998, 47, 49 416–1000, 7, 8, 9 505–0110, 14, 15
405–5687, 43, 45 405–6000–02, 47, 49 416–1003–02, 57 505–0117, 37
405–5689, 43, 45 405–6000–03, 47, 49 416–1033, 56, 57 505–0172, 14
405–5704, 43, 45 405–6000–04, 49 501–0502, 14, 15, 122 505–0180, 24
405–5705, 43, 45 405–6000–06, 47, 49 501–0627–03, 14, 15, 122 505–0185, 11, 37
405–5706, 43, 45 405–6000–07, 49 502–0029, 19 505–0203, 14
405–5707, 43, 45 405–6001–01, 47, 49 502–0047, 19 505–0359, 14, 15
405–5709, 43, 45 405–6003, 47, 49 502–0050, 19 505–0401, 14
405–5720, 43, 45 405–6005, 47, 49 502–0053, 10 505–0645, 15
405–5721, 43, 45 405–6010, 49 502–0085, 37 505–1050, 20, 21
405–5722, 43, 45 405–6013, 49 502–0199, 7, 8, 9 505–1373, 112
405–5731, 45 405–6014, 49 502–0433, 19 505–1458–02, 21
405–5732, 45 405–6015, 47, 49 502–0942, 16, 17, 33 505–1458–14, 20
405–5733, 43, 45 405–6018, 41, 47, 49 502–0943, 16, 17, 33 508–0051, 87
405–5734, 45, 47, 49 405–6029, 47, 49 503–0098, 11, 37 508–0139, 73
405–5735, 40 405–6030, 47, 49 503–0183, 16, 17, 33 508–0228, 70, 71
405–5745, 41, 47, 49 405–6034, 47, 49 503–0197, 11, 37 508–0239, 65, 67, 69
405–5760, 45 405–6035, 47, 49 503–0276, 37, 38 508–0305–02, 63, 85
405–5832, 41 405–6044, 49 503–0365, 37 508–1011, 40, 43, 45
405–5841, 47, 49 405–6068, 47, 49 503–0465, 37 508–1057, 73
405–5902, 41, 47, 49 405–6109, 47, 49 503–0685, 14, 15, 38, 122 509–0266–01, 73
405–5903, 41, 47, 49 405–6132, 49 503–1445–06, 19 509–0266–02, 73
405–5908, 41, 47, 49 406–0332, 87 503–1634–02, 33 510–0164, 73
405–5910, 41, 47, 49 406–0333, 87 503–1660–04, 16 515–0298–02, 73
405–5916, 41, 47, 49 406–0334, 87 503–1660–07, 17 515–0299–02, 73
405–5952, 47, 49 406–0782, 40, 41, 43, 45, 503–1837, 19 515–0299–04, 73
47, 49
405–5953, 47, 49 503–1870–04, 25 515–0299–05, 73
406–0831, 40, 41, 43, 45,
405–5954, 47, 49 47, 49 503–1870–05, 12, 13, 27 517–0021, 70
405–5955, 47, 49 406–0835, 40, 41, 43, 45, 503–1870–06, 12 517–0094, 52, 53
405–5956, 47, 49 47, 49 503–1929, 37 517–0131, 47, 49, 87
405–5957, 47, 49 415–0043, 14, 15 503–2003, 37 517–0132, 40, 43, 45
405–5958, 47, 49 415–0565–52, 14 503–2003–01, 37 517–0135, 63, 73
405–5960, 47, 49 415–0565–61, 14, 15 503–2029, 12 517–0138–07, 47, 49
405–5961, 47, 49 415–0650–01, 19 503–2032, 13 517–0245, 40, 43, 45
405–5966, 47, 49 415–0651–19, 19 504–0011, 11, 37 517–0322, 43, 45, 47, 49
405–5987, 47, 49 415–0652, 19 504–0028, 37 518–0083, 73
405–5988, 49 415–0655, 19 505–0007, 14, 15 518–0548–02, 11
405–5990, 49 415–0656–21, 19 505–0019, 9, 33 518–0601, 6
405–5991–01, 49 415–0657–01, 19 505–0026, 20, 21 525–0304, 6
405–5991–02, 49 415–0660, 19 505–0027, 14, 15 525–0305, 6
405–5995, 47, 49 415–0818, 19 505–0050, 11 525–0306, 6
405–5996, 47, 49 416–0619, 7, 8, 9 505–0066, 20 526–0003, 96

127
 Numerical Index

Part No. Page Part No. Page Part No. Page Part No. Page

526–0008, 8, 65 800–2068, 37 818–0231–02, 37, 38, 40, 856–0013, 7, 8, 9, 50, 51, 52,
41, 43, 45, 47, 49, 65, 67, 53
526–0011, 47, 49 800–2085, 8 69
860–0008, 18, 108, 110
526–0018, 85, 87 800–2086, 22, 24, 25, 26, 818–0237–01, 41, 43, 45,
27, 28 47, 49 860–0012, 69
526–0027, 9, 60, 61
800–2088, 75, 80 821–0004, 87 860–2005, 67, 70, 71, 73
526–0029, 65, 67, 69
800–2089, 58 821–0014, 63, 85 860–2006, 19, 59, 67, 73
526–0032, 91
800–2110, 35 821–0016, 114 860–2008, 59
526–0115, 108
800–2111, 7, 8, 9, 11, 12, 13 821–0017, 110 860–2009, 75
526–0174, 75
800–2121, 50, 51, 52, 53 821–2033, 16, 17 862–0001, 80, 101
526–0238–01, 52, 53
800–2543–02, 15, 50, 51, 821–5000–05, 87, 89 862–0026–58, 14
526–0240, 80 52, 53
821–5003–01, 63 862–0044, 52, 53
526–0259–02, 50, 51, 52, 53 800–3009, 73
821–6001–01, 60, 61, 73, 864–0011, 19
526–0399–13, 38 800–3017–20, 73 75, 80, 83 865–0030, 56, 57
526–0399–59, 17 800–3017–37, 73 821–6001–02, 73, 89 866–0014, 60
526–0399–62, 73, 75 800–3017–38, 75 821–6002–03, 33, 38, 41, 870–0048, 108
526–0399–64, 73, 75 800–3017–39, 75 47, 49, 54, 63, 65, 67, 69,
85 870–0131, 8, 65, 87, 89
526–0399–66, 14 800–3017–42, 75
821–6003–02, 15, 17, 25, 870–0183, 85, 87, 102
526–0423, 75 800–3017–44, 75 27, 28, 33, 35, 37, 40, 41,
43, 45, 47, 49, 51, 53, 55, 870–0221, 65, 69, 114
526–0433, 50, 51, 52, 53 800–3017–54, 73 56, 57, 65, 69 870–0232, 65
526–0434, 50, 51 800–3017–56, 75 822–3047, 70, 71 870–0250, 80
526–2050, 70, 71, 73 800–3017–73, 14 822–3075, 70, 71 870–0257, 78, 110, 114
526–2060, 73 800–3034, 70 850–0040, 101 870–0439, 85, 105
526–2080, 80 805–0015, 73 850–0050, 65, 67, 69 870–0458, 18
526–2100, 37 805–0018, 75 850–0114–54, 73, 75 870–0504, 41, 47, 49
526–2106, 35 812–0063, 100 850–0114–55, 73, 75 870–0517–01, 99
526–2120, 24, 75 812–0075, 18 850–0114–56, 73, 75 870–0517–02, 99
526–2140, 7, 8, 9, 12, 13 812–0082, 81, 108 850–0114–57, 14 870–0547, 50, 51, 52, 53
532–0474–19, 71 812–0084, 109 850–2003, 70, 71 870–1220, 85, 87, 105
532–0474–20, 71 812–0093, 65 850–2004, 67, 70, 71, 73 870–1221, 109
625–2141–02, 16, 17, 18 812–0157, 65 850–2005, 59, 67, 73 870–2054, 16, 17
720–1123, 75 813–0190, 65 850–2006, 75, 83 870–2064–01, 70, 73
775–0049, 83 815–0242, 71 850–2008, 9, 59 870–2193–04, 43, 45
800–0006, 101 815–0350, 18 850–2010, 22, 24, 25, 26, 870–2204, 89
800–0014, 87 815–0385, 18, 87, 102 27, 28, 58, 75, 83
871–0015, 87
800–0024, 78 815–0388, 81, 82, 85, 87, 850–2012, 12, 13
96, 106 895–0363, 41, 43, 45, 47, 49
800–0048, 65, 67, 69 853–0008, 87
815–0538, 91, 93, 95 895–0382, 41
800–0071, 91 853–0013, 80
815–0544, 99, 107 895–0384, 47, 49
800–0599–05, 50, 51, 52, 53 856–0002, 18, 108, 110
815–0761–01, 83 895–0385, 47, 49
800–0607, 52, 53 856–0003, 85
815–0792–04, 70 895–0386, 47, 49
800–2010, 19 856–0005, 69
815–0839, 91, 93 898–0025, 99
800–2042, 75 856–0008, 63, 65, 69, 78,
815–0875–02, 85, 87 85, 87 898–0860, 78
800–2046, 75
815–0901–06, 87 856–0010, 80 898–1195–01, 78
800–2056, 12, 13
815–0905–08, 96, 97 856–0012, 91 898–1254–19, 71
800–2058, 9, 35

128
  "! "$ 
 " &% 
! #
 

  
'  
'
) )

 #  "#$" $""    "! "$ 

%# #  "#$" $""  %#   !(