1A2 770D/772D MOTOR GRADER

INTRODUCTION AND CUSTOMER INFORMATION

T204231A -UN-13DEC04

RIGHT SIDE VIEW OF JOHN DEERE 770D/772D MOTOR GRADER

(MANUFACTURED 2005- )
TO THE CUSTOMER

THE PART NUMBERS IN THIS PARTS CATALOG WERE CORRECT AT THE TIME THIS CATALOG WAS
PUBLISHED. IT IS OUR POLICY TO CONSTANTLY IMPROVE OUR MACHINES AND THEREFORE, PART
NUMBERS MAY CHANGE. WHEN ORDERING PARTS, VERIFY PART NUMBERS THROUGH YOUR DEALER.

(SPECIFICATIONS AND DESIGN SUBJECT TO CHANGE WITHOUT NOTICE.)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) I-1

COPYRIGHT © 2005 DEERE & COMPANY Moline, Illinois All rights reserved PN=1
 1A3 770D/772D MOTOR GRADER

SERIAL NUMBER LOCATION

EACH 770D AND 772D MOTOR GRADER MAY HAVE EIGHT SERIAL NUMBER PLATES: ONE FOR THE
PRODUCT IDENTIFICATION NUMBER, ONE FOR THE ENGINE, ONE FOR THE TRANSMISSION, ONE FOR THE
HYDRAULIC PUMP, ONE FOR THE FRONT WHEEL DRIVE, ONE FOR THE DIFFERENTIAL AND ONE EACH FOR THE
FRONT WHEEL DRIVE MOTORS.

THE PRODUCT IDENTIFICATION NUMBER PLATE IS LOCATED BELOW THE OPERATOR’S PLATFORM ON THE
LEFT-HAND SIDE OF THE MAIN FRAME. THIS IS THE SERIAL NUMBER USED IN THIS CATALOG UNLESS
OTHERWISE NOTED IN THE SERIAL NUMBER COLUMN.

THE ENGINE SERIAL NUMBER PLATE IS LOCATED ON THE LEFT-HAND SIDE OF THE CYLINDER BLOCK
ABOVE THE STARTING MOTOR.

THE TRANSMISSION SERIAL NUMBER PLATE IS LOCATED ON THE FRONT OF THE TRANSMISSION HOUSING
ABOVE THE OUTPUT SHAFT.

THE HYDRAULIC PUMP SERIAL NUMBER PLATE IS LOCATED ON THE BOTTOM OF THE PUMP.

THE FRONT WHEEL DRIVE HYDRAULIC PUMP IS LOCATED ON THE LEFT REAR OF THE TRANSMISSION AND
THE SERIAL NUMBER PLATE IS LOCATED ON THE BOTTOM OF THE PUMP.

THE HYDRAULIC FRONT WHEEL DRIVE (HFWD) MOTOR SERIAL NUMBER PLATE IS LOCATED ON THE INSIDE
REAR OF EACH RIGHT AND LEFT HFWD MOTOR HOUSINGS.

THE DIFFERENTIAL SERIAL NUMBER PLATE IS LOCATED ON THE COVER, RIGHT LOWER, BELOW THE
DRIVESHAFT INPUT.

NOTE: IN THE TRANSMISSION SECTION, TRANSMISSION SERIAL NUMBER INFORMATION IS PROVIDED

AS FOLLOWS: (1) WHEN ASTERISKS (******) ARE LISTED IN PLACE OF A SERIAL NUMBER, A SERIAL
NUMBER NUMBER CHANGE WAS MADE AND "IT" CAN BE FOUND IN THE REMARKS COLUMN IN THE PUBLICATION.
(2) WHEN X’S (XXXXXX) ARE LISTED IN PLACE OF A SERIAL NUMBER, A SERIAL NUMBER CHANGE WAS
NOT AVAILABLE AT TIME OF PUBLICATION.

LEFT SIDE AND RIGHT SIDE, FRONT AND REAR OF THE MOTOR GRADER ARE VIEWED BY FACING IN
THE DIRECTION OF MOTOR GRADER FORWARD TRAVEL.

WHENEVER SERIAL NUMBERS ARE REQUIRED ON ALL WARRANTY CLAIMS OR CORRESPONDENCE

PERTAINING TO THIS PRODUCT, IT IS EXTREMELY IMPORTANT THAT ALL CHARACTERS BE FURNISHED.
THIS POINT CANNOT BE OVEREMPHASIZED.

I-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=2
 1A4 770D/772D MOTOR GRADER

PRODUCT IDENTIFICATION NUMBER

TP16004 -UN-01JAN94

1. DESIGNATES GRADER MANUFACTURER DW - JOHN DEERE DAVENPORT WORKS

2. DESIGNATES GRADER MODEL 770D, 772D,
3. DESIGNATES GRADER CONFIGURATION X
4. DESIGNATES GRADER SERIAL NUMBER 123456
5. DESIGNATES UNIT TYPE MOTOR GRADER

770D/772D MOTOR GRADER PC9449 (07-JAN-05) I-3

PN=3
 1A5 770D/772D MOTOR GRADER

ENGINE SERIAL NUMBER PLATE

RGP3513 -UN-01JAN94

FIRST LINE DEFINES

RG - JOHN DEERE WATERLOO ENGINE WORKS DESIGNATES ENGINE MANUFACTURER

6 DESIGNATES NUMBER OF CYLINDERS

081 (8.1 LITERS) DESIGNATES LITER DISPLACEMENT

H (AIR-TO-AIR) DESIGNATES TYPE OF AIR INTAKE SYSTEM

DW - JOHN DEERE DAVENPORT WORKS DESIGNATES USER FACTORY

XXXXXX DESIGNATES ENGINE SERIAL NUMBER

SECOND LINE APPLICATION

6081HDW13 770D/772D MOTOR GRADER

I-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=4
 1A6 770D/772D MOTOR GRADER

SERIAL NUMBER LISTING INFORMATION

SERIAL NUMBER INFORMATION IS LISTED TO SHOW ON WHICH MACHINES EACH PART CAN BE USED; FOR
EXAMPLE:

- THE PART CAN BE USED ON ALL MACHINES.

000000- THE PART CAN BE USED ON ALL MACHINES BEGINNING WITH THE SERIAL NUMBER LISTED.
-000000 THE PART CAN BE USED ON ALL MACHINES UP TO AND INCLUDING THE SERIAL NUMBER
LISTED.
000000-000000 THE PART CAN BE USED ON ALL MACHINES BETWEEN AND INCLUDING THE SERIAL NUMBERS
LISTED.

WHEN XXXXXX’S ARE LISTED IN PLACE OF A SERIAL NUMBER, A SERIAL NUMBER CHANGE WAS MADE BUT THE
EXACT SERIAL NUMBER WAS NOT AVAILABLE WHEN THE CATALOG WAS PRODUCED.

DIRECTION ARROW

ARROWS ARE USED WITH ILLUSTRATIONS TO INDICATE THE FRONT OF THE UNIT. "RIGHT-HAND" AND "LEFT-
HAND" SIDES ARE DETERMINED BY FACING IN THE DIRECTION OF MACHINE FORWARD TRAVEL.

BOX-ENCLOSED ILLUSTRATIONS
A KEY NUMBER, SHOWN IN THE PARTS LIST, IS ASSIGNED TO A BOX ENCLOSING ALL PARTS SOLD AS A
SERVICE ASSEMBLY.

COMPLETE GOODS LISTINGS

COMPLETE GOODS ARE LISTED IN BOLD FACE TYPE. ORDER SEPARATELY. DO NOT INCLUDE ON
REPLACEMENT PARTS ORDER.

SI UNITS OF MEASURE

METRIC DIMENSIONS ARE GIVEN, WHERE APPLICABLE, THROUGHOUT THIS PARTS CATALOG.

CHANGE INDICATOR LINE

CHANGES AFFECTING THE ORDERING OF PARTS ARE IDENTIFIED BY VERTICAL LINES MARKED IN THE LEFT-
HAND MARGIN OF REVISED PARTS LISTING IMAGES. A LINE IS ALSO AT THE LEFT-HAND EDGE OF THE SAME
PART NUMBER IN THE NUMERICAL INDEX TO SHOW THE LOCATION OF REVISED INFORMATION.

770D/772D MOTOR GRADER PC9449 (07-JAN-05) I-5

PN=5
 1A7 770D/772D MOTOR GRADER
ALPHABETICAL INDEX

GRID PAGE GRID PAGE

A 1C20 AXLE DRIVESHAFT.......................................................... 0225 - 2
1D14 AXLE HOUSING................................................................ 0250 - 6
2K13 A/C AND HEAT TEMPERATURE CONTROL SWITCH.. 1830 - 18 1D14 AXLE HOUSING OIL SEAL.............................................. 0250 - 6
2K13 A/C AND HEATER CONTROL CABLE............................ 1830 - 18 1C22 AXLE, FRONT (770D) ...................................................... 0230 - 2
2K13 A/C AND HEATER CONTROL KNOB ............................ 1830 - 18 1D4 AXLE, FRONT (772D) ...................................................... 0240 - 2
2K13 A/C AND HEATER FAN SPEED SWITCH ...................... 1830 - 18 1D1 AXLE, FRONT, TIE ROD (770D) .................................... 0230 - 6
2K13 A/C AND HEATER ON AND OFF SWITCH .................... 1830 - 18
2K13 A/C AND HEATER WIRING HARNESS .......................... 1830 - 18
2K9 A/C COMPRESSOR.......................................................... 1830 - 14 B
2I21 A/C CONTROL CONSOLE (CAB).................................... 1810 - 30
2K13 A/C CONTROL SWITCH .................................................. 1830 - 18 2L12 BACK-UP ALARM ............................................................ 2004 - 4
2K9 A/C MANIFOLD ................................................................ 1830 - 14 2J13 BACKREST CUSHION (AIR)............................................ 1821 - 2
2K13 A/C PRESSURE SWITCH ................................................ 1830 - 18 2J17 BACKREST CUSHION (MECHANICAL) .......................... 1821 - 6
2K9 A/C PULLEY KIT .............................................................. 1830 - 14 1I11 BASE, ENGINE OIL FILTER ............................................ 0407 - 8
2K9 A/C SERVICE KIT ............................................................ 1830 - 14 2E21 BATTERY .......................................................................... 1671 - 2
2K11 ACCUMULATOR, AIR CONDITIONING .......................... 1830 - 16 2E21 BATTERY CABLE ............................................................ 1671 - 2
3E21 ACCUMULATOR, BLADE IMPACT .................................. 3460 - 18 2E21 BATTERY CLAMP ............................................................ 1671 - 2
2D18 ACCUMULATOR, BRAKE ................................................ 1060 - 4 2K16 BATTERY COVERS.......................................................... 1910 - 2
2C17 ACCUMULATOR, SECONDARY STEERING .................. 0930 - 2 2F7 BEACON BRACKET KIT .................................................. 1673 - 8
1H10 ACCUMULATOR, TRANSMISSION ................................ 0363 - 2 2F7 BEACON LIGHT BRACKET ............................................ 1673 - 8
1J5 ADAPTER, ENGINE OIL COOLER .................................. 0419 - 1 1H24 BEARING CAPS, MAIN AND THRUST .......................... 0404 - 2
1I13 ADAPTER, ENGINE OIL COOLER BYPASS .................. 0407 - 10 1D14 BEARING, AXLE .............................................................. 0250 - 6
1I18 ADAPTER, EXHAUST ELBOW ........................................ 0410 - 2 1H23 BEARING, CONNECTING ROD ...................................... 0403 - 1
1I24 ADAPTER, TURBO OIL DRAIN LINE.............................. 0416 - 2 1H16 BEARING, ENGINE MAIN AND THRUST ...................... 0401 - 2
2G5 AGRESSIVENESS SWITCH, HFWD................................ 1674 - 18 1E1 BEARING, HFWD MOTOR .............................................. 0260 - 10
2B23 AIR CLEANER FILTER RESTRICTION SENSOR .......... 0520 - 2 1E5 BEARING, HFWD PUMP.................................................. 0260 - 14
2B23 AIR CLEANER PRE-CLEANER SUCTION HOSE 1J10 BELT TENSIONER............................................................ 0423 - 2
TO MUFFLER .............................................................. 0520 - 2 2B17 BELT TENSIONER, FAN .................................................. 0512 - 2
2B23 AIR CLEANER WITH PRE-CLEANER ............................ 0520 - 2 2E23 BELT, ENGINE ACCESSORY DRIVE ............................ 1672 - 2
2K5 AIR CONDITIONER AND HEATER COVER .................. 1830 - 10 2B17 BELT, FAN ........................................................................ 0512 - 2
2K9 AIR CONDITIONER COMPRESSOR .............................. 1830 - 14 2E23 BELT, SERPENTINE ........................................................ 1672 - 2
2K11 AIR CONDITIONING ACCUMULATOR............................ 1830 - 16 2K13 BINARY PRESSURE SWITCH, A/C ................................ 1830 - 18
2K11 AIR CONDITIONING COMPRESSOR BRACKET .......... 1830 - 16 3E21 BLADE IMPACT ACCUMULATOR .................................. 3460 - 18
2K11 AIR CONDITIONING CONDENSER ................................ 1830 - 16 3E21 BLADE IMPACT SYSTEM ................................................ 3460 - 18
2K11 AIR CONDITIONING LINES, CONDENSER, AND 3E21 BLADE IMPACT SYSTEM KIT ........................................ 3460 - 18
RECEIVER-DRYER ...................................................... 1830 - 16 3E23 BLADE IMPACT VALVE .................................................. 3460 - 20
2K11 AIR CONDITIONING RECEIVER-DRYER ...................... 1830 - 16 3E21 BLADE IMPACT VALVE MOUNTING BRACKET............ 3460 - 18
2K5 AIR FILTER, CAB FRESH................................................ 1830 - 10 3E23 BLADE IMPACT VALVE SEAL KIT.................................. 3460 - 20
1I23 AIR HEATER CONTROLLER, ENGINE .......................... 0414 - 1 3E21 BLADE IMPACT VALVE WIRING HARNESS.................. 3460 - 18
2B3 AIR HEATER, ENGINE .................................................... 0505 - 2 2J11 BLADE LIFT CONTROL LEVER ...................................... 1810 - 44
2B23 AIR PRE-CLEANER .......................................................... 0520 - 2 3E11 BLADE LIFT CYLINDER .................................................. 3460 - 8
2L12 ALARM, BACK-UP ............................................................ 2004 - 4 3E17 BLADE LIFT CYLINDER FITTINGS ................................ 3460 - 14
2E23 ALTERNATOR .................................................................. 1672 - 2 3E17 BLADE LIFT CYLINDER HYDRAULIC HOSES .............. 3460 - 14
1J10 ALTERNATOR BRACKET ................................................ 0423 - 2 3E11 BLADE LIFT CYLINDER SEAL KIT ................................ 3460 - 8
2E23 ALTERNATOR MOUNTING BRACKET .......................... 1672 - 2 3B20 BLADE LIFT VALVE RELIEF VALVE .............................. 2160 - 24
2L2 AM/FM RADIO .................................................................. 2001 - 2 3B20 BLADE LIFT VALVE SECTION ........................................ 2160 - 24
2C14 AMBIENT AIR TEMPERATURE SENSOR, ENGINE ...... 0578 - 4 2J11 BLADE SIDE SHIFT CONTROL LEVER ........................ 1810 - 44
2L2 ANTENNA, RADIO ............................................................ 2001 - 2 3B18 BLADE SIDE SHIFT VALVE SECTION .......................... 2160 - 22
2J13 ARM REST (AIR) .............................................................. 1821 - 2 3D9 BLADE SIDESHIFT CYL ROD END MOUNTING .......... 3401 - 2
2J17 ARM REST (MECHANICAL) ............................................ 1821 - 6 3E13 BLADE SLIDE CYLINDER................................................ 3460 - 10
1H18 ARMS, ENGINE ROCKER................................................ 0402 - 2 3F1 BLADE SLIDE CYLINDER HYDRAULIC HOSES............ 3460 - 22
2J9 ARTICULATION CONTROL LEVER ................................ 1810 - 42 3E13 BLADE SLIDE CYLINDER SEAL KIT .............................. 3460 - 10
2C23 ARTICULATION CYLINDER ............................................ 0960 - 6 3F1 BLADE TILT AND SLIDE CYLINDER HYRDRAULIC
2D5 ARTICULATION CYLINDER HOSES .............................. 0960 - 12 HOSES.......................................................................... 3460 - 22
2G20 ARTICULATION CYLINDER PIN...................................... 1740 - 2 3E15 BLADE TILT CYLINDER .................................................. 3460 - 12
2G20 ARTICULATION PIN ........................................................ 1740 - 2 3F1 BLADE TILT CYLINDER HYDRAULIC HOSES .............. 3460 - 22
2G7 ARTICULATION SENSOR ................................................ 1674 - 20 3E15 BLADE TILT CYLINDER SEAL KIT ................................ 3460 - 12
2G7 ARTICULATION SENSOR LINKAGE .............................. 1674 - 20 3D19 BLADE TILT FRAME ........................................................ 3440 - 4
3B14 ARTICULATION VALVE SECTION .................................. 2160 - 18 3D19 BLADE TILT FRAME WEAR INSERTS .......................... 3440 - 4
2J11 AUXILIARY CONTROL LEVER, RIGHT .......................... 1810 - 44 3B14 BLADE TILT VALVE SECTION ........................................ 2160 - 18
3C3 AUXILIARY VALVE SECTION (WITH FLOAT)................ 2160 - 32 2B17 BLADE, FAN...................................................................... 0512 - 2
3C5 AUXILIARY VALVE SECTION (WITHOUT FLOAT) ........ 2160 - 34 2H17 BLADE, FRONT WINDSHIELD WIPER .......................... 1810 - 4
3B4 AUXILLARY DRIVE, MAIN HYDRAULIC PUMP ............ 2160 - 2 2H21 BLADE, LOWER FRONT WINDSHIELD WIPER ............ 1810 - 8
1D14 AXLE AND DRIVE CHAIN................................................ 0250 - 6 2H19 BLADE, REAR WINDOW WIPER .................................... 1810 - 6
1D14 AXLE BEARING ................................................................ 0250 - 6 1I1 BLOCK ASSEMBLY, ENGINE SHORT............................ 0404 - 4
1C8 AXLE DRIVE SHAFT ........................................................ 0201 - 4 1E5 BLOCK, CYLINDER, HFWD PUMP ................................ 0260 - 14
1D14 AXLE DRIVE SPROCKET ................................................ 0250 - 6 2H7 BLOCK, PUSH .................................................................. 1747 - 2
I-2 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=6
 1A8 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

2J9 BOOT, LEFT CONTROL LEVERS .................................. 1810 - 42 C
2J11 BOOT, RIGHT CONTROL LEVERS ................................ 1810 - 44
2H1 BOTTOM GUARD (W/O RIPPER) .................................. 1746 - 2 2H15 CAB (COMPLETE) ............................................................ 1810 - 2
2H1 BOTTOM GUARD KIT (W/O RIPPER) ............................ 1746 - 2 2H15 CAB AND CANOPY (COMPLETE) .................................. 1810 - 2
2H3 BOTTOM GUARD SIDE SHIELD (W/O RIPPER) .......... 1746 - 4 2K3 CAB B-POST HEATER AND AIR CONDITIONER
2H3 BOTTOM GUARD SIDE SHIELD KIT DUCT ............................................................................ 1830 - 8
(W/O RIPPER) .............................................................. 1746 - 4 2K3 CAB B-POST HEATER AND AIR CONDITIONER
2H5 BOTTOM GUARD SIDE SHIELDS (WITH RIPPER) ...... 1746 - 6 DUCT LOUVER ............................................................ 1830 - 8
2H5 BOTTOM GUARDS AND SIDE SHIELDS (WITH 2J7 CAB CONTROL LEVER CONSOLE ................................ 1810 - 40
RIPPER)........................................................................ 1746 - 6 2J7 CAB CONTROL LEVER CONSOLE COVER .................. 1810 - 40
2H5 BOTTOM GUARDS AND SIDE SHIELDS KIT (WITH 2J9 CAB CONTROL LEVERS (LEFT) .................................... 1810 - 42
RIPPER)........................................................................ 1746 - 6 2J11 CAB CONTROL LEVERS (RIGHT) .................................. 1810 - 44
2K11 BRACKET, AIR CONDITIONING COMPRESSOR .......... 1830 - 16 2J1 CAB DOOR HOLD OPEN LATCH (LEFT) ...................... 1810 - 34
1J10 BRACKET, ALTERNATOR .............................................. 0423 - 2 2I23 CAB DOOR HOLD OPEN LATCH (RIGHT) .................... 1810 - 32
2E23 BRACKET, ALTERNATOR MOUNTING .......................... 1672 - 2 2J1 CAB DOOR, LEFT ............................................................ 1810 - 34
2L12 BRACKET, BACK-UP ALARM MOUNTING .................... 2004 - 4 2I23 CAB DOOR, RIGHT.......................................................... 1810 - 32
2F7 BRACKET, BEACON LIGHT ............................................ 1673 - 8 2I17 CAB FLOORMAT .............................................................. 1810 - 26
3E21 BRACKET, BLADE IMPACT VALVE MOUNTING .......... 3460 - 18 2K5 CAB FRESH AIR FILTER ................................................ 1830 - 10
2H1 BRACKET, BOTTOM GUARD.......................................... 1746 - 2 2K5 CAB FRESH AIR FILTER HOUSING .............................. 1830 - 10
2D16 BRACKET, BRAKE VALVE/PEDAL MOUNTING ............ 1060 - 2 2J23 CAB HEATER HOSES...................................................... 1830 - 2
2J21 BRACKET, CAB STEP .................................................... 1822 - 2 2I9 CAB INTERIOR PANELS ................................................ 1810 - 18
2I21 BRACKET, CONVERTER MOUNTING (CAB) ................ 1810 - 30 2F21 CAB INTERIOR WIRING HARNESS .............................. 1674 - 8
2I19 BRACKET, CONVERTER MOUNTING (CANOPY) ........ 1810 - 28 2H23 CAB ISOLATORS.............................................................. 1810 - 10
2L6 BRACKET, EXTERIOR MIRROR .................................... 2002 - 4 2H15 CAB KREMNUTS .............................................................. 1810 - 2
2I21 BRACKET, FLC MOUNTING (CAB) ................................ 1810 - 30 2F21 CAB MONITOR ................................................................ 1674 - 8
2I19 BRACKET, FLC MOUNTING (CANOPY) ........................ 1810 - 28 2J3 CAB MONITOR CONSOLE .............................................. 1810 - 36
3F8 BRACKET, FRONT MOUNTED SCARIFIER .................. 4240 - 2 2G13 CAB MONITOR UNIT WIRING HARNESS...................... 1674 - 26
1J6 BRACKET, FUEL FILTER ................................................ 0420 - 2 2H23 CAB MOUNT ISOLATORS .............................................. 1810 - 10
1F3 BRACKET, HFWD ENGAGEMENT MANIFOLD 2F21 CAB POWER WIRING HARNESS .................................. 1674 - 8
MOUNTING .................................................................. 0260 - 36 2I13 CAB REAR INTERIOR PANELS ...................................... 1810 - 22
3B6 BRACKET, MAIN MANIFOLD VALVE MOUNTING ........ 2160 - 4 2I13 CAB REAR WALL PANELS ............................................ 1810 - 22
2L2 BRACKET, RADIO ............................................................ 2001 - 2 2I15 CAB ROOF........................................................................ 1810 - 24
1F10 BRACKET, TRANSMISSION CONTROL UNIT 2I15 CAB ROOF COVER.......................................................... 1810 - 24
MOUNTING .................................................................. 0315 - 2 2F9 CAB ROOF LIGHTS ........................................................ 1673 - 10
3C15 BRACKETS, MAIN CONTROL VALVE MOUNTING ...... 2160 - 44 2F23 CAB ROOF WIRING HARNESS ...................................... 1674 - 10
2J13 BRACKETS, SEAT (AIR) .................................................. 1821 - 2 2I21 CAB SIDE CONSOLE ...................................................... 1810 - 30
2J17 BRACKETS, SEAT (MECHANICAL) ................................ 1821 - 6 2J3 CAB STATIONARY FRONT CONSOLE .......................... 1810 - 36
2F1 BRACKETS, SNOW LIGHTS............................................ 1673 - 2 2J3 CAB STATIONARY FRONT CONSOLE COVER ............ 1810 - 36
2D18 BRAKE ACCUMULATOR.................................................. 1060 - 4 2J21 CAB STEP BRACKET ...................................................... 1822 - 2
2D18 BRAKE ACCUMULATOR HOSES.................................... 1060 - 4 2J21 CAB STEPS ...................................................................... 1822 - 2
2D14 BRAKE DISK .................................................................... 1011 - 2 2J7 CAB TILT CONSOLE........................................................ 1810 - 40
1D12 BRAKE DISK, SECOND STAGE PINION, HFWD 2J7 CAB TILT CONSOLE GAS SHOCK ................................ 1810 - 40
MOTOR ........................................................................ 0250 - 4 2G13 CAB TILT CONSOLE WIRING HARNESS ...................... 1674 - 26
2D16 BRAKE LIGHT SWITCH .................................................. 1060 - 2 2G13 CAB TILT CONSOLE WIRING HARNESS AND
2D16 BRAKE PEDAL.................................................................. 1060 - 2 SWITCHES .................................................................. 1674 - 26
1D12 BRAKE PISTON HOUSING, HFWD MOTOR.................. 0250 - 4 2K5 CAB TRAY ........................................................................ 1830 - 10
2D14 BRAKE SEPARATOR PLATE .......................................... 1011 - 2 2F9 CAB WORK AND DRIVE LIGHTS .................................. 1673 - 10
2D16 BRAKE VALVE.................................................................. 1060 - 2 2F9 CAB WORK LIGHTS ........................................................ 1673 - 10
2D18 BRAKE VALVE HOSES.................................................... 1060 - 4 2K13 CABLE, A/C AND HEATER CONTROL .......................... 1830 - 18
2D16 BRAKE VALVE/PEDAL MOUNTING BRACKET.............. 1060 - 2 2E21 CABLE, BATTERY ............................................................ 1671 - 2
1G21 BRAKE, PARK .................................................................. 0350 - 28 2L2 CABLE, RADIO ANTENNA .............................................. 2001 - 2
1G21 BRAKE, TRANSMISSION ................................................ 0350 - 28 2K7 CABLE, TEMPERATURE CONTROL .............................. 1830 - 12
2D14 BRAKES, SERVICE .......................................................... 1011 - 2 1H17 CAMSHAFT ...................................................................... 0402 - 1
1F1 BREATHER, DIFFERENTIAL LOCK ................................ 0260 - 34 1H18 CAMSHAFT FOLLOWER.................................................. 0402 - 2
2F9 BULB, CAB ROOF LIGHT ................................................ 1673 - 10 2H15 CANOPY (COMPLETE) .................................................... 1810 - 2
2F9 BULB, CAB WORK LIGHT .............................................. 1673 - 10 2I11 CANOPY INTERIOR PANELS.......................................... 1810 - 20
2F11 BULB, FRONT DRIVE LIGHT .......................................... 1673 - 12 2I19 CANOPY SIDE CONSOLE .............................................. 1810 - 28
2F3 BULB, FRONT SIGNAL LIGHT ........................................ 1673 - 4 2C7 CAP, FUEL TANK ............................................................ 0560 - 2
2F13 BULB, MID-FRAME WORK LIGHT .................................. 1673 - 14 3D5 CAP, HYDRAULIC RESERVOIR...................................... 2164 - 4
2F13 BULB, REAR WORK LIGHT ............................................ 1673 - 14 1H24 CAP, MAIN AND THRUST BEARING.............................. 0404 - 2
2F13 BULB, UNDER CAB WORK LIGHT ................................ 1673 - 14 1H20 CARRIER, ENGINE ROCKER ARM COVER .................. 0402 - 4
2K16 BUMPER, DOOR, SERVICE ............................................ 1910 - 2 1D10 CARRIER, FIRST PLANET PINION, HFWD MOTOR .... 0250 - 2
1H17 BUSHING, CAMSHAFT .................................................... 0402 - 1 1D16 CARRIER, PLANET PINION ............................................ 0250 - 8
1I24 BUSHING, TURBO OIL DRAIN LINE .............................. 0416 - 2 1C14 CASE, DIFFERENTIAL .................................................... 0210 - 6
1G1 CASE, REAR TRANSMISSION ........................................ 0350 - 6
2L2 CD PLAYER ...................................................................... 2001 - 2
2E13 CENTRAL LUBRICATION, FRAME HINGE .................... 1370 - 2
770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-3
PN=7
 1A9 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

1D14 CHAIN, TANDEM DRIVE.................................................. 0250 - 6 2G15 CONVERTER, POWER (24 VOLT TO 12 VOLT) .......... 1674 - 28
2B11 CHARGE AIR COOLER.................................................... 0510 - 4 2E8 COOLANT CONDITIONER .............................................. 1369 - 1
2B13 CHARGE AIR COOLER.................................................... 0510 - 6 1H24 COOLANT DRAIN VALVE, ENGINE................................ 0404 - 2
1E19 CHARGE HOSES, HFWD ................................................ 0260 - 28 2B7 COOLANT HEATER.......................................................... 0505 - 8
1E17 CHARGE PUMP, HFWD .................................................. 0260 - 26 2B7 COOLANT HEATER HOSES............................................ 0505 - 8
3E1 CIRCLE DRIVE GEARBOX .............................................. 3450 - 2 2C13 COOLANT TEMPERATURE SENSOR, ENGINE ............ 0578 - 3
3E1 CIRCLE DRIVE GEARBOX MOUNTING SCREWS ........ 3450 - 2 1E21 COOLER HOSE, DIFFERENTIAL LOCK ........................ 0260 - 30
3E3 CIRCLE DRIVE GEARBOX, WITH SLIP CLUTCH ........ 3450 - 4 2B11 COOLER, CHARGE AIR .................................................. 0510 - 4
3E7 CIRCLE DRIVE MOTOR .................................................. 3460 - 4 2B13 COOLER, CHARGE AIR .................................................. 0510 - 6
3E7 CIRCLE DRIVE MOTOR HOUSING ................................ 3460 - 4 1J5 COOLER, ENGINE OIL .................................................... 0419 - 1
3E7 CIRCLE DRIVE MOTOR SEAL KIT ................................ 3460 - 4 2B15 COOLER, FUEL ................................................................ 0510 - 10
3D23 CIRCLE FRAME................................................................ 3440 - 8 2B11 COOLER, HYDRAULIC OIL ............................................ 0510 - 4
2J9 CIRCLE ROTATE CONTROL LEVER.............................. 1810 - 42 2B13 COOLER, HYDRAULIC OIL ............................................ 0510 - 6
3E7 CIRCLE ROTATE MOTOR .............................................. 3460 - 4 2K7 CORE, EVAPORATOR/HEATER...................................... 1830 - 12
3F3 CIRCLE ROTATE MOTOR HYDRAULIC HOSES .......... 3460 - 24 1E23 COUPLING, DIFF LOCK PUMP TO TRANS .................. 0260 - 32
3B16 CIRCLE ROTATE VALVE SECTION .............................. 2160 - 20 1J6 COUPLING, FUEL DIAGNOSTIC .................................... 0420 - 2
2J11 CIRCLE SIDE SHIFT CONTROL LEVER ........................ 1810 - 44 2K5 COVER, AIR CONDITIONER AND HEATER .................. 1830 - 10
3B14 CIRCLE SIDE SHIFT VALVE SECTION.......................... 2160 - 18 2J7 COVER, CAB CONTROL LEVER CONSOLE ................ 1810 - 40
3E9 CIRCLE SIDESHIFT CYLINDER ...................................... 3460 - 6 2I13 COVER, CAB REAR ........................................................ 1810 - 22
3F5 CIRCLE SIDESHIFT CYLINDER HYDRAULIC 2I15 COVER, CAB ROOF ........................................................ 1810 - 24
HOSES.......................................................................... 3460 - 26 2J3 COVER, CAB STATIONARY FRONT CONSOLE .......... 1810 - 36
3E9 CIRCLE SIDESHIFT CYLINDER SEAL KIT .................... 3460 - 6 3E1 COVER, CIRCLE DRIVE GEARBOX .............................. 3450 - 2
2E21 CLAMP, BATTERY............................................................ 1671 - 2 3E3 COVER, CIRCLE DRIVE GEARBOX, WITH SLIP
2C3 CLAMP, MUFFLER .......................................................... 0530 - 2 CLUTCH........................................................................ 3450 - 4
2B23 CLEANER, AIR, WITH PRE-CLEANER .......................... 0520 - 2 1C12 COVER, DIFFERENTIAL CASE ...................................... 0210 - 4
1G9 CLUTCH PLATE, TRANSMISSION.................................. 0350 - 16 1J3 COVER, ENGINE COOLANT THERMOSTAT HOUSING0418 - 2
1G11 CLUTCH PLATE, TRANSMISSION.................................. 0350 - 18 1H20 COVER, ENGINE ROCKER ARM.................................... 0402 - 4
1G13 CLUTCH PLATE, TRANSMISSION.................................. 0350 - 20 1H20 COVER, ENGINE VALVE ................................................ 0402 - 4
1G15 CLUTCH PLATE, TRANSMISSION.................................. 0350 - 22 2I9 COVER, FRONT WIPER (CAB) ...................................... 1810 - 18
1C18 CLUTCH PLATES, DIFFERENTIAL ................................ 0210 - 10 2I11 COVER, FRONT WIPER (CANOPY)_ ............................ 1810 - 20
3E3 CLUTCH, SLIP, CIRCLE DRIVE GEARBOX AND .......... 3450 - 4 1J10 COVER, FUEL INJECTION PUMP ACCESS .................. 0423 - 2
1J8 CLUTCH, STARTING MOTOR ........................................ 0422 - 2 2K5 COVER, HEATER AND AIR CONDITIONER .................. 1830 - 10
2F21 CMU .................................................................................. 1674 - 8 1E9 COVER, HFWD PUMP END ............................................ 0260 - 18
2G13 CMU WIRING HARNESS ................................................ 1674 - 26 3D5 COVER, HYDRAULIC RESERVOIR CLEAN OUT .......... 2164 - 4
3C11 COLD START DISCONNECT HOSES AND FITTINGS.. 2160 - 40 1F14 COVER, INCHING PEDAL .............................................. 0315 - 6
3C13 COLD START DISCONNECT SOLENOID VALVE.......... 2160 - 42 1H22 COVER, INJECTION PUMP ACCESS ............................ 0402 - 6
2B5 COLD WEATHER STARTING AID .................................. 0505 - 4 2K20 COVER, MAIN FRAME SIDE .......................................... 1913 - 2
2J5 COLUMN, STEERING ...................................................... 1810 - 38 1D10 COVER, PLANET PINION, HFWD MOTOR .................... 0250 - 2
2K9 COMPRESSOR, AIR CONDITIONER .............................. 1830 - 14 2I9 COVER, REAR WIPER (CAB) ........................................ 1810 - 18
2K9 COMPRESSOR,A/C .......................................................... 1830 - 14 2I11 COVER, REAR WIPER (CANOPY).................................. 1810 - 20
2K11 CONDENSER, AIR CONDITIONING................................ 1830 - 16 1E7 COVER, SERVO PISTON, HFWD PUMP ...................... 0260 - 16
2E8 CONDITIONER, COOLANT .............................................. 1369 - 1 2J5 COVER, STEERING WHEEL .......................................... 1810 - 38
1H23 CONNECTING ROD, ENGINE ........................................ 0403 - 1 1H22 COVER, TIMING GEAR.................................................... 0402 - 6
2I21 CONSOLE, A/C CONTROL (CAB) .................................. 1810 - 30 1F12 COVER, TRANS GEAR SELECTOR .............................. 0315 - 4
2J7 CONSOLE, CAB CONTROL LEVER .............................. 1810 - 40 1J1 COVER, WATER PUMP .................................................. 0417 - 2
2J3 CONSOLE, CAB FRONT (STATIONARY) ...................... 1810 - 36 2K16 COVERS, BATTERY ........................................................ 1910 - 2
2I21 CONSOLE, CAB SIDE...................................................... 1810 - 30 2G24 COVERS, MAIN FRAME .................................................. 1740 - 6
2J7 CONSOLE, CAB TILT ...................................................... 1810 - 40 1C6 COVERS, TANDEM HOUSING ........................................ 0201 - 2
2I19 CONSOLE, CANOPY SIDE .............................................. 1810 - 28 2G24 COWL COVER, MAIN FRAME ........................................ 1740 - 6
2I21 CONSOLE, GEAR SHIFT LEVER (CAB) ........................ 1810 - 30 1H15 CRANKSHAFT .................................................................. 0401 - 1
2I19 CONSOLE, GEARSHIFT LEVER (CANOPY) .................. 1810 - 28 2K5 CUPHOLDER .................................................................... 1830 - 10
3C9 CONTROL LEVER, ONE HAND BLADE LIFT ................ 2160 - 38 2J13 CUSHION, BACKREST (AIR) .......................................... 1821 - 2
2J9 CONTROL LEVERS (LEFT) ............................................ 1810 - 42 2J17 CUSHION, BACKREST (MECHANICAL) ........................ 1821 - 6
2J11 CONTROL LEVERS (RIGHT) .......................................... 1810 - 44 2J13 CUSHION, SEAT (AIR) .................................................... 1821 - 2
2C9 CONTROL UNIT,ENGINE ................................................ 0575 - 2 2J17 CUSHION, SEAT (MECHANICAL) .................................. 1821 - 6
3C7 CONTROL VALVE KIT, FIFTH FUNCTION .................... 2160 - 36 3D9 CUTTING EDGES AND MOLDBOARDS ........................ 3401 - 2
3C7 CONTROL VALVE KIT, FOURTH FUNCTION ................ 2160 - 36 1H24 CYLINDER BLOCK FITTINGS, ENGINE ........................ 0404 - 2
3C7 CONTROL VALVE KIT, SIXTH FUNCTION .................... 2160 - 36 1J17 CYLINDER HEAD GASKET KIT, ENGINE ...................... 0452 - 2
1H1 CONTROL VALVE MOUNTING, TRANSMISSION.......... 0350 - 32 1I14 CYLINDER HEAD, ENGINE ............................................ 0409 - 2
3B10 CONTROL VALVE, MAIN HYDRAULIC .......................... 2160 - 10 2D5 CYLINDER HOSES, ARTICULATION .............................. 0960 - 12
1H3 CONTROL VALVE, TRANSMISSION .............................. 0350 - 34 2D3 CYLINDER HOSES, FRONT STEERING ........................ 0960 - 10
1E7 CONTROL, HFWD PUMP EP .......................................... 0260 - 16 2D9 CYLINDER HOSES, WHEEL LEAN (770D) .................... 0960 - 16
3B4 CONTROL, MAIN HYDRAULIC PUMP ............................ 2160 - 2 2D7 CYLINDER HOSES, WHEEL LEAN (772D) .................... 0960 - 14
1I19 CONTROLLER, ENGINE .................................................. 0413 - 2 1H23 CYLINDER LINER, ENGINE ............................................ 0403 - 1
1I23 CONTROLLER, ENGINE AIR HEATER .......................... 0414 - 1 2C23 CYLINDER, ARTICULATION ............................................ 0960 - 6
2G5 CONTROLLER, HFWD .................................................... 1674 - 18 3E11 CYLINDER, BLADE LIFT.................................................. 3460 - 8
1F10 CONTROLLER, TRANSMISSION .................................... 0315 - 2 3E13 CYLINDER, BLADE SLIDE .............................................. 3460 - 10
I-4 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=8
 1A10 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

3E15 CYLINDER, BLADE TILT.................................................. 3460 - 12 1C8 DRIVE SHAFT, FINAL DRIVE AND TANDEM
3E9 CYLINDER, CIRCLE SIDESHIFT .................................... 3460 - 6 PIVOT............................................................................ 0201 - 4
2D1 CYLINDER, FRONT STEERING ...................................... 0960 - 8 1C8 DRIVE SPROCKET .......................................................... 0201 - 4
3F14 CYLINDER, RIPPER/REAR SCARIFIER ........................ 4240 - 8 3B4 DRIVE, AUXILLARY, MAIN HYDRAULIC PUMP ............ 2160 - 2
3F10 CYLINDER, SCARIFIER .................................................. 4240 - 4 1D16 DRIVE, TANDEM .............................................................. 0250 - 8
2C19 CYLINDER, WHEEL LEAN (770D) .................................. 0960 - 2 1D22 DRIVE, WHEEL, HFWD.................................................... 0260 - 6
2C21 CYLINDER, WHEEL LEAN (772D) .................................. 0960 - 4 1C20 DRIVESHAFT .................................................................... 0225 - 2
2B17 DRIVESHAFT, FAN .......................................................... 0512 - 2
1E7 DRIVESHAFT, HFWD PUMP .......................................... 0260 - 16
D 2G13 DRIVING LIGHT HIGH/LOW BEAM SWITCH ................ 1674 - 26
2K3 DUCT, CAB B-POST HEATER AND AIR
1F16 DAMPENER, TORSIONAL .............................................. 0325 - 2 CONDITIONER ............................................................ 1830 - 8
1J12 DAMPENER, TORSIONAL .............................................. 0429 - 1 2K3 DUCT, DISTRIBUTION, HEATER AND AIR
2E2 DECALS, ENGLISH .......................................................... 1320 - 2 CONDITIONER ............................................................ 1830 - 8
2E6 DECALS, FRENCH .......................................................... 1320 - 6 2K5 DUCTS, HEATER AND AIR CONDITIONER .................. 1830 - 10
2E4 DECALS, SPANISH .......................................................... 1320 - 4
2B21 DECELERATOR PEDAL .................................................. 0515 - 4
1J6 DIAGNOSTIC COUPLING, FUEL .................................... 0420 - 2 E
1C16 DIAGNOSTIC FITTING, DIFFERENTIAL LOCK .............. 0210 - 8
1F3 DIAGNOSTIC FITTING, HFWD ENGAGEMENT 2C9 ECU .................................................................................. 0575 - 2
MANIFOLD.................................................................... 0260 - 36 1I23 ECU, ENGINE AIR HEATER............................................ 0414 - 1
1H6 DIAGNOSTIC FITTING, TRANSMISSION CONTROL 1H20 ELBOW FITTING, ENGINE VENTILATING SYSTEM .... 0402 - 4
VALVE .......................................................................... 0360 - 2 1I18 ELBOW, EXHAUST .......................................................... 0410 - 2
2G5 DIAL, HFWD AGRESSIVENESS...................................... 1674 - 18 2G9 ELECTRICAL CENTER, VEHICLE .................................. 1674 - 22
1E23 DIFF LOCK PUMP ............................................................ 0260 - 32 1I19 ELECTRONIC ENGINE CONTROLLER .......................... 0413 - 2
1E23 DIFF LOCK PUMP MOUNTING ...................................... 0260 - 32 1I19 ELECTRONIC UNIT INJECTOR ...................................... 0413 - 2
1C18 DIFFERENTIAL ................................................................ 0210 - 10 2B23 ELEMENT, FILTER, AIR CLEANER ................................ 0520 - 2
1C14 DIFFERENTIAL CASE ...................................................... 0210 - 6 1D24 END CAP, HFWD MOTOR .............................................. 0260 - 8
1C12 DIFFERENTIAL CASE COVER ........................................ 0210 - 4 1E9 END COVER, HFWD PUMP ............................................ 0260 - 18
1C17 DIFFERENTIAL CASE OIL LINE...................................... 0210 - 9 1D1 END, TIE ROD, FRONT AXLE (770D) ............................ 0230 - 6
1C18 DIFFERENTIAL CLUTCH PLATES .................................. 0210 - 10 1D6 END, TIE ROD, FRONT AXLE (772D) ............................ 0240 - 4
1E21 DIFFERENTIAL LOCK COOLER HOSES........................ 0260 - 30 1F5 ENGAGEMENT MANIFOLD, HFWD ................................ 0260 - 38
1C16 DIFFERENTIAL LOCK DIAGNOSTIC FITTING .............. 0210 - 8 1F5 ENGAGEMENT SOLENOID, HFWD ................................ 0260 - 38
1F1 DIFFERENTIAL LOCK FILTER ........................................ 0260 - 34 2E23 ENGINE ACCESSORY DRIVE BELT .............................. 1672 - 2
1F1 DIFFERENTIAL LOCK HOSES AND FILTER ................ 0260 - 34 2B3 ENGINE AIR HEATER...................................................... 0505 - 2
1F1 DIFFERENTIAL LOCK HYDRAULIC HOSES .................. 0260 - 34 2B3 ENGINE AIR HEATER RELAY ........................................ 0505 - 2
1E21 DIFFERENTIAL LOCK OIL LINE...................................... 0260 - 30 2B3 ENGINE AIR HEATER WIRING HARNESS .................... 0505 - 2
1E23 DIFFERENTIAL LOCK PUMP .......................................... 0260 - 32 2C9 ENGINE CONTROL UNIT ................................................ 0575 - 2
1F1 DIFFERENTIAL LOCK PUMP HOSES ............................ 0260 - 34 1I19 ENGINE CONTROLLER .................................................. 0413 - 2
2G13 DIFFERENTIAL LOCK SWITCH ...................................... 1674 - 26 1J3 ENGINE COOLANT THERMOSTAT AND HOUSING .... 0418 - 2
1C16 DIFFERENTIAL LOCK VALVE ........................................ 0210 - 8 1J17 ENGINE CYLINDER HEAD GASKET KIT ...................... 0452 - 2
1C16 DIFFERENTIAL LOCK VALVE SOLENOID .................... 0210 - 8 2K16 ENGINE DOORS .............................................................. 1910 - 2
1I5 DIPSTICK, ENGINE OIL .................................................. 0407 - 1 2G22 ENGINE FRAME .............................................................. 1740 - 4
1F18 DIPSTICK, TRANSMISSION OIL .................................... 0341 - 2 2C5 ENGINE MOUNTING SUPPORTS .................................. 0540 - 2
3C13 DISCONNECT VALVE, COLD START ............................ 2160 - 42 2C5 ENGINE MOUNTS ............................................................ 0540 - 2
3C11 DISCONNECT, MAIN HYD PUMP COLD START .......... 2160 - 40 2E9 ENGINE OIL DRAIN HOSE.............................................. 1369 - 2
2D14 DISK, BRAKE .................................................................... 1011 - 2 1I3 ENGINE OVERHAUL KIT ................................................ 0404 - 6
1D12 DISK, BRAKE, SECOND STAGE PINION, HFWD 1J17 ENGINE REBUILD GASKET KIT .................................... 0452 - 2
MOTOR ........................................................................ 0250 - 4 1I1 ENGINE SHORT BLOCK ASSEMBLY ............................ 0404 - 4
2K3 DISTRIBUTION DUCT, HEATER AND AIR 2B19 ENGINE SPEED CONTROL ON/OFF SWITCH .............. 0515 - 2
CONDITIONER ............................................................ 1830 - 8 2B19 ENGINE SPEED CONTROL PEDAL AND SWITCHES .. 0515 - 2
2I9 DOMELIGHT (CAB) .......................................................... 1810 - 18 2B19 ENGINE SPEED CONTROL SET SWITCH .................... 0515 - 2
2I11 DOMELIGHT (CANOPY) .................................................. 1810 - 20 2I21 ENGINE SPEED CONTROL SWITCH LABEL
2K16 DOOR BUMPER, SERVICE ............................................ 1910 - 2 (CAB) ............................................................................ 1810 - 30
2K16 DOOR HINGE, SERVICE ................................................ 1910 - 2 2I19 ENGINE SPEED CONTROL SWITCH LABEL
2J1 DOOR LATCH, CAB (LEFT) ............................................ 1810 - 34 (CANOPY) .................................................................... 1810 - 28
2I23 DOOR LATCH, CAB (RIGHT) .......................................... 1810 - 32 2I21 ENGINE SPEED CONTROL SWITCH PANEL
2J1 DOOR, CAB LEFT ............................................................ 1810 - 34 (CAB) ............................................................................ 1810 - 30
2I23 DOOR, CAB RIGHT.......................................................... 1810 - 32 2I19 ENGINE SPEED CONTROL SWITCH PANEL
2K16 DOORS, ENGINE.............................................................. 1910 - 2 (CANOPY) .................................................................... 1810 - 28
2K16 DOORS, SERVICE............................................................ 1910 - 2 2B21 ENGINE SPEED DECELERATOR PEDAL ...................... 0515 - 4
3D17 DRAFT FRAME ................................................................ 3440 - 2 1H20 ENGINE VENTILATING SYSTEM .................................... 0402 - 4
1H24 DRAIN VALVE, ENGINE COOLANT................................ 0404 - 2 2F19 ENGINE WIRING HARNESS............................................ 1674 - 6
1I6 DRAIN VALVE, ENGINE OIL PAN .................................. 0407 - 2 2E2 ENGLISH LABELS AND TRADEMARKS ........................ 1320 - 2
1J1 DRAIN VALVE, WATER PUMP........................................ 0417 - 2 2E2 ENGLISH TRADEMARKS AND LABELS ........................ 1320 - 2
1D14 DRIVE CHAIN, TANDEM.................................................. 0250 - 6 1E7 EP CONTROL GASKET .................................................. 0260 - 16
2F11 DRIVE LIGHTS, FRONT .................................................. 1673 - 12 1E7 EP CONTROL, HFWD PUMP .......................................... 0260 - 16
770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-5
PN=9
 1A11 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

1I19 EUI .................................................................................... 0413 - 2 1F3 FITTINGS, HFWD ENGAGEMENT MANIFOLD .............. 0260 - 36
2K7 EVAPORATOR/HEATER CORE ...................................... 1830 - 12 3C23 FITTINGS, MAIN HYDRAULIC PUMP(770D) .................. 2163 - 6
1I18 EXHAUST ELBOW............................................................ 0410 - 2 3D1 FITTINGS, MAIN HYDRAULIC PUMP(772D) .................. 2163 - 8
1I17 EXHAUST MANIFOLD ...................................................... 0410 - 1 2D23 FITTINGS, PARK BRAKE VALVE.................................... 1111 - 4
1I14 EXHAUST VALVES, ENGINE .......................................... 0409 - 2 3F22 FITTINGS, RIPPER CYLINDER ...................................... 4260 - 10
2K7 EXPANSION VALVE,HEATER AND A/C ........................ 1830 - 12 3E19 FITTINGS, SADDLE LOCK PIN ...................................... 3460 - 16
3D13 EXTENSION KIT, MOLDBOARD (24" MOLDBOARD) .... 3401 - 6 3F20 FITTINGS, SCARIFIER CYLINDER (FRONT) ................ 4260 - 8
3D15 EXTENSION KIT, MOLDBOARD (27" MOLDBOARD) .... 3401 - 8 3F22 FITTINGS, SCARIFIER CYLINDER (REAR).................... 4260 - 10
3D13 EXTENSION, MOLDBOARD (24" MOLDBOARD) .......... 3401 - 6 2D16 FITTINGS, SERVICE BRAKE VALVE.............................. 1060 - 2
3D15 EXTENSION, MOLDBOARD (27" MOLDBOARD) .......... 3401 - 8 2D3 FITTINGS, STEERING CYLINDER .................................. 0960 - 10
2F1 EXTENSIONS, SNOW LIGHT .......................................... 1673 - 2 2D11 FITTINGS, STEERING VALVE ........................................ 0960 - 18
2L6 EXTERIOR MIRROR ........................................................ 2002 - 4 3B10 FIVE FUNCTION HYDRAULIC CONTROL VALVE ........ 2160 - 10
2L8 EXTINGUISHER, FIRE .................................................... 2003 - 2 2G17 FLC .................................................................................... 1675 - 2
2I19 FLC MOUNTING BRACKET (CANOPY).......................... 1810 - 28
2I21 FLC MOUNTING BRACKET(CAB) .................................. 1810 - 30
F 2G17 FLEX LOAD CENTER (FLC) ............................................ 1675 - 2
2I17 FLOORMAT, CAB ............................................................ 1810 - 26
2B17 FAN.................................................................................... 0512 - 2 2E11 FLUID SAMPLING FITTINGS .......................................... 1369 - 4
2B17 FAN AND FAN TOWER .................................................. 0512 - 2 2B5 FLUID, STARTING ............................................................ 0505 - 4
2B17 FAN BELT ........................................................................ 0512 - 2 1E9 FLUSHING PUMP, HFWD MOTOR ................................ 0260 - 18
2B17 FAN BELT IDLER PULLEY .............................................. 0512 - 2 1J14 FLYWHEEL........................................................................ 0433 - 1
2B17 FAN BELT TENSIONER .................................................. 0512 - 2 1J15 FLYWHEEL HOUSING .................................................... 0433 - 2
2B17 FAN BLADE ...................................................................... 0512 - 2 1H17 FOLLOWER, CAMSHAFT ................................................ 0402 - 1
1J13 FAN DRIVE PULLEY, FIXED .......................................... 0429 - 2 1H18 FOLLOWER, CAMSHAFT ................................................ 0402 - 2
1J13 FAN DRIVE, FIXED PULLEY .......................................... 0429 - 2 3B10 FOUR FUNCTION HYDRAULIC CONTROL VALVE ...... 2160 - 10
2B17 FAN DRIVESHAFT............................................................ 0512 - 2 1G13 FOURTH STAGE ASSEMBLY, TRANSMISSION............ 0350 - 20
2B11 FAN GUARD .................................................................... 0510 - 4 1G13 FOURTH STAGE INPUT SHAFT .................................... 0350 - 20
2B9 FAN GUARD (WITHOUT AIR CONDITIONING) ............ 0510 - 2 3D17 FRAME, DRAFT ................................................................ 3440 - 2
2B17 FAN HUB .......................................................................... 0512 - 2 2G22 FRAME, ENGINE .............................................................. 1740 - 4
2B17 FAN PULLEY .................................................................... 0512 - 2 2G20 FRAME, MAIN .................................................................. 1740 - 2
2B11 FAN SHROUD .................................................................. 0510 - 4 3F12 FRAME, REAR RIPPER/SCARIFIER .............................. 4240 - 6
2B13 FAN SHROUD .................................................................. 0510 - 6 3D19 FRAME, TILT, BLADE ...................................................... 3440 - 4
2B17 FAN TOWER .................................................................... 0512 - 2 2E6 FRENCH LABELS AND TRADEMARKS.......................... 1320 - 6
3C7 FIFTH FUNCTION CONTROL VALVE KIT...................... 2160 - 36 2E6 FRENCH TRADEMARKS AND LABELS.......................... 1320 - 6
1G15 FIFTH STAGE ASSEMBLY, TRANSMISSION ................ 0350 - 22 2K5 FRESH AIR FILTER, CAB................................................ 1830 - 10
1G15 FIFTH STAGE INPUT SHAFT.......................................... 0350 - 22 2F13 FRONT AND REAR WORK LIGHTS .............................. 1673 - 14
1J6 FILTER AND LINES, FUEL .............................................. 0420 - 2 1C22 FRONT AXLE (770D)........................................................ 0230 - 2
1F1 FILTER HEAD, DIFFERENTIAL LOCK FILTER .............. 0260 - 34 1D4 FRONT AXLE (772D)........................................................ 0240 - 2
1H6 FILTER HEAD, TRANSMISSION .................................... 0360 - 2 1D4 FRONT AXLE GUARD (772D) ........................................ 0240 - 2
3D3 FILTER RESTRICTION SWITCH, MAIN 1C22 FRONT AXLE PIVOT PIN (770D) .................................... 0230 - 2
HYDRAULIC FILTER.................................................... 2164 - 2 1D4 FRONT AXLE PIVOT PIN (772D) .................................... 0240 - 2
1H6 FILTER RESTRICTION SWITCH, TRANSMISSION ...... 0360 - 2 1D1 FRONT AXLE TIE ROD (770D) ...................................... 0230 - 6
2B23 FILTER, AIR CLEANER.................................................... 0520 - 2 1D6 FRONT AXLE TIE ROD (772D) ...................................... 0240 - 4
2K5 FILTER, CAB FRESH AIR................................................ 1830 - 10 2F11 FRONT DRIVE LIGHTS.................................................... 1673 - 12
1F1 FILTER, DIFFERENTIAL LOCK ...................................... 0260 - 34 3F18 FRONT EQUIPMENT HOSES.......................................... 4260 - 6
1I11 FILTER, ENGINE OIL ...................................................... 0407 - 8 2G3 FRONT HFWD WIRING HARNESS ................................ 1674 - 16
3D3 FILTER, MAIN HYDRAULIC ............................................ 2164 - 2 2H21 FRONT LOWER WINDSHIELD WIPER .......................... 1810 - 8
1H6 FILTER, TRANSMISSION ................................................ 0360 - 2 3F18 FRONT MOUNTED EQUIPMENT HYDRAULIC HOSES 4260 - 6
1C8 FINAL DRIVE HOUSING .................................................. 0201 - 4 3F8 FRONT MOUNTED SCARIFIER ...................................... 4240 - 2
2L8 FIRE EXTINGUISHER ...................................................... 2003 - 2 3F8 FRONT MOUNTED SCARIFIER KIT .............................. 4240 - 2
1D10 FIRST PLANET PINION, HFWD MOTOR ...................... 0250 - 2 3F8 FRONT MOUNTED SCARIFIER MOUNTING BRACKET4240 - 2
1G17 FIRST SIXTH ASSEMBLY................................................ 0350 - 24 2H9 FRONT MOUNTED WEIGHT .......................................... 1749 - 2
1G7 FIRST STAGE ASSEMBLY .............................................. 0350 - 14 1H22 FRONT OIL SEAL ............................................................ 0402 - 6
1G7 FIRST STAGE INPUT SHAFT.......................................... 0350 - 14 2F15 FRONT PLATFORM WIRING HARNESS ........................ 1674 - 2
1D10 FIRST STAGE PINION, HFWD MOTOR ........................ 0250 - 2 3F20 FRONT SCARIFIER HOSE KIT ...................................... 4260 - 8
1F3 FITTING, DIAGNOSTIC, HFWD ENGAGEMENT 3F20 FRONT SCARIFIER HYDRAULIC HOSES...................... 4260 - 8
MANIFOLD.................................................................... 0260 - 36 2F3 FRONT SIGNAL LIGHTS.................................................. 1673 - 4
3E21 FITTINGS, BLADE IMPACT VALVE ................................ 3460 - 18 2F3 FRONT SIGNAL LIGHTS, LED ........................................ 1673 - 4
3E17 FITTINGS, BLADE LIFT CYLINDER ................................ 3460 - 14 2D1 FRONT STEERING CYLINDER ...................................... 0960 - 8
3F1 FITTINGS, BLADE SLIDE CYLINDER ............................ 3460 - 22 2D3 FRONT STEERING CYLINDER HOSES ........................ 0960 - 10
3F1 FITTINGS, BLADE TILT CYLINDER ................................ 3460 - 22 1F21 FRONT TRANSMISSION HOUSING (770D) .................. 0350 - 2
3F3 FITTINGS, CIRCLE ROTATE MOTOR ............................ 3460 - 24 1F23 FRONT TRANSMISSION HOUSING (772D) .................. 0350 - 4
3F5 FITTINGS, CIRCLE SIDESHIFT CYLINDER .................. 3460 - 26 2F15 FRONT TURN/DRIVING LIGHT WIRING
1C14 FITTINGS, DIFFERENTIAL CASE .................................. 0210 - 6 HARNESS .................................................................... 1674 - 2
1H24 FITTINGS, ENGINE CYLINDER BLOCK ........................ 0404 - 2 1B12 FRONT WHEEL (10" X 24" SPLIT RIM) ........................ 0110 - 12
2E11 FITTINGS, FLUID SAMPLING.......................................... 1369 - 4 1B14 FRONT WHEEL (12" X 25") ............................................ 0110 - 14
1J6 FITTINGS, FUEL FILTER AND LINES ............................ 0420 - 2 1B10 FRONT WHEEL (14" X 25" SPLIT RIM) ........................ 0110 - 10
I-6 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=10
 1A12 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

1B16 FRONT WHEEL (16" X 24") ............................................ 0110 - 16 2E21 GROUNDING STRAPS .................................................... 1671 - 2
1B18 FRONT WHEEL (17"X 25" SPLIT RIM) .......................... 0110 - 20 2H1 GUARD, BOTTOM (W/O RIPPER) .................................. 1746 - 2
1C24 FRONT WHEEL BEARING (770D) .................................. 0230 - 4 2B11 GUARD, FAN .................................................................... 0510 - 4
1D3 FRONT WHEEL BEARING (770D) .................................. 0230 - 4 2B9 GUARD, FAN (WITHOUT AIR CONDITIONING) ............ 0510 - 2
1C24 FRONT WHEEL HUB (770D) .......................................... 0230 - 4 1D4 GUARD, FRONT AXLE (772D) ........................................ 0240 - 2
1D3 FRONT WHEEL HUB (770D) .......................................... 0230 - 4 1E11 GUARD, HFWD HOSE .................................................... 0260 - 20
2L18 FRONT WINDOW SUNVISOR ........................................ 2007 - 4 1D22 GUARD, HFWD MOTOR HOSE ...................................... 0260 - 6
2I5 FRONT WINDOWS, LOWER (OPENABLE) .................... 1810 - 14 1H8 GUARD, VALVE, TRANSMISSION .................................. 0360 - 4
2I1 FRONT WINDOWS, LOWER (STATIONARY) ................ 1810 - 12 2H5 GUARDS, BOTTOM (WITH RIPPER) .............................. 1746 - 6
2H17 FRONT WINDSHIELD WASHER PUMP.......................... 1810 - 4
2H17 FRONT WINDSHIELD WIPER ........................................ 1810 - 4
2I9 FRONT WIPER COVER (CAB) ........................................ 1810 - 18 H
2I11 FRONT WIPER COVER (CANOPY) ................................ 1810 - 20
2F15 FRONT WIRING HARNESS, MAIN.................................. 1674 - 2 2K13 HARNESS, A/C AND HEATER WIRING ........................ 1830 - 18
2F13 FRONT WORK LIGHTS.................................................... 1673 - 14 3E21 HARNESS, BLADE IMPACT VALVE WIRING ................ 3460 - 18
2B15 FUEL COOLER ................................................................ 0510 - 10 2F21 HARNESS, CAB INTERIOR WIRING .............................. 1674 - 8
2B15 FUEL COOLER HOSES .................................................. 0510 - 10 2F21 HARNESS, CAB POWER WIRING .................................. 1674 - 8
1J6 FUEL FILTER AND LINES .............................................. 0420 - 2 2F23 HARNESS, CAB ROOF WIRING .................................... 1674 - 10
1I19 FUEL INJECTION LINES.................................................. 0413 - 2 2F19 HARNESS, ENGINE WIRING .......................................... 1674 - 6
1I19 FUEL INJECTION NOZZLE.............................................. 0413 - 2 1H20 HARNESS, FUEL INJECTION WIRING .......................... 0402 - 4
1I19 FUEL INJECTION PUMP.................................................. 0413 - 2 2G3 HARNESS, HFWD WIRING.............................................. 1674 - 16
1H20 FUEL INJECTION WIRING HARNESS............................ 0402 - 4 2F15 HARNESS, MAIN WIRING (FRONT) .............................. 1674 - 2
2C7 FUEL TANK ...................................................................... 0560 - 2 2F17 HARNESS, MAIN WIRING (REAR).................................. 1674 - 4
2C7 FUEL TANK CAP .............................................................. 0560 - 2 2F1 HARNESS, SNOW LIGHT WIRING ................................ 1673 - 2
2C7 FUEL TANK SENDING UNIT .......................................... 0560 - 2 2F5 HARNESS, TAIL LIGHT WIRING .................................... 1673 - 6
2C7 FUEL TANK SUPPORT .................................................... 0560 - 2 2G1 HARNESS, TRANSMISSION WIRING ............................ 1674 - 14
2B5 FUSE, STARTING AID .................................................... 0505 - 4 2B5 HARNESS, WIRING, COLD WEATHER STARTING
AID ................................................................................ 0505 - 4
2G13 HAZARD WARNING LIGHT SWITCH.............................. 1674 - 26
G 1I14 HEAD, ENGINE CYLINDER ............................................ 0409 - 2
2I9 HEADLINER (CAB) .......................................................... 1810 - 18
1I19 G SENSOR (FUEL INJECTION PUMP) .......................... 0413 - 2 2I11 HEADLINER (CANOPY) .................................................. 1810 - 20
2J7 GAS SHOCK, CAB CONTROL LEVER CONSOLE ........ 1810 - 40 2J13 HEADREST (AIR).............................................................. 1821 - 2
1J17 GASKET KIT, ENGINE CYLINDER HEAD ...................... 0452 - 2 2J17 HEADREST (MECHANICAL) ............................................ 1821 - 6
1J17 GASKET KIT, ENGINE REBUILD .................................... 0452 - 2 2L6 HEATED EXTERIOR MIRROR ........................................ 2002 - 4
1I14 GASKET, ENGINE CYLINDER HEAD ............................ 0409 - 2 2K7 HEATER AND A/C BLOWER MOTOR ............................ 1830 - 12
1H20 GASKET, ENGINE ROCKER ARM COVER.................... 0402 - 4 2K7 HEATER AND A/C BLOWER MOTOR IMPELLER ........ 1830 - 12
1H20 GASKET, ENGINE ROCKER ARM COVER CARRIER .. 0402 - 4 2K7 HEATER AND A/C EXPANSION VALVE ........................ 1830 - 12
1E7 GASKET, HFWD PUMP EP CONTROL .......................... 0260 - 16 2K7 HEATER AND A/C HOUSING.......................................... 1830 - 12
3D5 GASKET, HYDRAULIC RESERVOIR CLEAN OUT ........ 2164 - 4 2K7 HEATER AND A/C RESISTOR ........................................ 1830 - 12
1H1 GASKET, TRANS CONTROL VALVE.............................. 0350 - 32 2K7 HEATER AND A/C THERMOSTAT.................................. 1830 - 12
1F12 GEAR SELECTOR, TRANSMISSION .............................. 0315 - 4 2K5 HEATER AND AIR CONDITIONER COVER .................. 1830 - 10
1H17 GEAR, CAMSHAFT .......................................................... 0402 - 1 2K3 HEATER AND AIR CONDITIONER DUCTS.................... 1830 - 8
1H15 GEAR, CRANKSHAFT ...................................................... 0401 - 1 2K5 HEATER AND AIR CONDITIONER DUCTS.................... 1830 - 10
1I8 GEAR, ENGINE OIL PUMP.............................................. 0407 - 4 2K5 HEATER AND AIR CONDITIONER FILTER,
1J14 GEAR, FLYWHEEL RING ................................................ 0433 - 1 FILTER HOUSING, AND COVER................................ 1830 - 10
1I19 GEAR, FUEL INJECTION PUMP .................................... 0413 - 2 2K13 HEATER AND AIR CONDITIONER LINES AND
3E1 GEARBOX ........................................................................ 3450 - 2 CONTROLS .................................................................. 1830 - 18
3E1 GEARBOX COVER, CIRCLE DRIVE .............................. 3450 - 2 2J23 HEATER HOSES, CAB .................................................... 1830 - 2
3E3 GEARBOX COVER, CIRCLE DRIVE, WITH SLIP 2B7 HEATER, COOLANT ........................................................ 0505 - 8
CLUTCH........................................................................ 3450 - 4 2G5 HFWD AGRESSIVENESS SWITCH ................................ 1674 - 18
3E1 GEARBOX, CIRCLE DRIVE ............................................ 3450 - 2 2G5 HFWD CAB COMPONENTS ............................................ 1674 - 18
3E1 GEARBOX, CIRCLE DRIVE MOUNTING SCREWS ...... 3450 - 2 1E19 HFWD CHARGE HOSES ................................................ 0260 - 28
3E3 GEARBOX, CIRCLE DRIVE, WITH SLIP CLUTCH ........ 3450 - 4 1E17 HFWD CHARGE PUMP.................................................... 0260 - 26
3E3 GEARBOX, WITH SLIP CLUTCH .................................... 3450 - 4 1E19 HFWD CHARGE PUMP HOSES...................................... 0260 - 28
1F21 GEARS, PUMP DRIVE (770D) ........................................ 0350 - 2 1E17 HFWD CHARGE PUMP SEAL KIT .................................. 0260 - 26
1F23 GEARS, PUMP DRIVE (772D) ........................................ 0350 - 4 2G5 HFWD CONTROLLER ...................................................... 1674 - 18
2I21 GEARSHIFT LEVER CONSOLE (CAB) .......................... 1810 - 30 1F5 HFWD ENGAGEMENT MANIFOLD ................................ 0260 - 38
2I19 GEARSHIFT LEVER CONSOLE (CANOPY) .................. 1810 - 28 1F3 HFWD ENGAGEMENT MANIFOLD FITTINGS AND
2E13 GREASE FITTINGS, FRAME HINGE CENTRAL TEMPERATURE SENSOR .......................................... 0260 - 36
LUBRICATION .............................................................. 1370 - 2 1F3 HFWD ENGAGEMENT MANIFOLD MOUNTING
2K22 GRILLE .............................................................................. 1921 - 2 BRACKET...................................................................... 0260 - 36
2K22 GRILLE HOUSING ............................................................ 1921 - 2 1F5 HFWD ENGAGEMENT MANIFOLD SEAL KIT................ 0260 - 38
2K22 GRILLE HOUSING, REAR................................................ 1921 - 2 1F5 HFWD ENGAGEMENT SOLENOID ................................ 0260 - 38
2K22 GRILLE, REAR.................................................................. 1921 - 2 1F5 HFWD ENGAGEMENT SOLENOID VALVE .................... 0260 - 38
2I9 GRILLE, SPEAKER (CAB)................................................ 1810 - 18 1F5 HFWD FLUSHING VALVE................................................ 0260 - 38
2I11 GRILLE, SPEAKER (CANOPY)........................................ 1810 - 20 1D18 HFWD FRONT HUB AND MOTOR (COMPLETE) .......... 0260 - 2
770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-7
PN=11
 1A13 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

1E11 HFWD HOSE GUARD ...................................................... 0260 - 20 1E7 HFWD PUMP EP CONTROL SOLENOID ...................... 0260 - 16
1E13 HFWD HOSES (BULKHEAD TO HFWD ENGAGMENT 1E7 HFWD PUMP HOUSING AND EP CONTROL ................ 0260 - 16
VALVE).......................................................................... 0260 - 22 1E7 HFWD PUMP MAIN HOUSING........................................ 0260 - 16
1E11 HFWD HOSES (HFWD ENGAGEMENT VALVE TO 1E3 HFWD PUMP MOUNTING (672CH2) .............................. 0260 - 12
HFWD MOTORS) ........................................................ 0260 - 20 1E9 HFWD PUMP OVERHAUL SEAL KIT.............................. 0260 - 18
1E15 HFWD HOSES (HFWD PUMP TO BULKHEAD) ............ 0260 - 24 1E5 HFWD PUMP PISTONS .................................................. 0260 - 14
1D18 HFWD HUB (COMPLETE)................................................ 0260 - 2 1E9 HFWD PUMP PRESSURE OVERRIDE VALVE .............. 0260 - 18
1D22 HFWD HUB AND YOKE .................................................. 0260 - 6 1F3 HFWD PUMP PRESSURE SENSOR .............................. 0260 - 36
2G5 HFWD INCHING MODE SWITCH.................................... 1674 - 18 1E7 HFWD PUMP SEAL KIT .................................................. 0260 - 16
1D18 HFWD MOTOR (COMPLETE).......................................... 0260 - 2 1E15 HFWD PUMP SUCTION HOSE ...................................... 0260 - 24
1E1 HFWD MOTOR BEARING................................................ 0260 - 10 1E13 HFWD TANK RETURN HOSE (BULKHEAD TO
1D20 HFWD MOTOR BRAKE LINE .......................................... 0260 - 4 HFWD ENGAGEMENT VALVE) .................................. 0260 - 22
1E13 HFWD MOTOR CASE DRAIN HOSE (BULKHEAD TO 1E15 HFWD TANK RETURN HOSE (HFWD PUMP TO
HFWD ENGAGEMENT VALVE) .................................. 0260 - 22 BULKHEAD) .................................................................. 0260 - 24
1E11 HFWD MOTOR CASE DRAIN HOSE (HFWD 2G3 HFWD WHEEL SPEED SENSOR WIRING
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 HARNESS .................................................................... 1674 - 16
1E15 HFWD MOTOR CASE DRAIN HOSE (HFWD PUMP TO 2G3 HFWD WIRING HARNESS .............................................. 1674 - 16
BULKHEAD) .................................................................. 0260 - 24 2G13 HIGH/LOW BEAM LIGHT SWITCH.................................. 1674 - 26
1D24 HFWD MOTOR END CAP................................................ 0260 - 8 1D24 HIGH/LOW SPEED SOLENOID, HFWD MOTOR .......... 0260 - 8
1E13 HFWD MOTOR FLUSHING HOSE (BULKHEAD 2K16 HINGE, DOOR, SERVICE ................................................ 1910 - 2
TO HFWD ENGAGEMENT VALVE) ............................ 0260 - 22 2K18 HOOD ................................................................................ 1910 - 4
1E13 HFWD MOTOR FLUSHING HOSE (BULKHEAD TO 2K18 HOOD SUPPORT ............................................................ 1910 - 4
HFWD ENGAGEMENT VALVE) .................................. 0260 - 22 2L10 HORN ................................................................................ 2004 - 2
1E11 HFWD MOTOR FLUSHING HOSE (HFWD 2G13 HORN SWITCH ................................................................ 1674 - 26
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 1D22 HOSE GUARD, HFWD MOTOR ...................................... 0260 - 6
1E11 HFWD MOTOR FLUSHING HOSE (HFWD 2B23 HOSE, AIR CLEANER PRE-CLEANER TO MUFFLER .. 0520 - 2
ENGAGEMENT VALVE TO HFWD MOTORS) .......... 0260 - 20 3E21 HOSE, BLADE IMPACT ACCUMULATOR ...................... 3460 - 18
1E15 HFWD MOTOR FLUSHING HOSE (HFWD PUMP 3E21 HOSE, BLADE IMPACT VALVE ...................................... 3460 - 18
TO BULKHEAD) .......................................................... 0260 - 24 3E17 HOSE, BLADE LIFT CYLINDER ...................................... 3460 - 14
1E15 HFWD MOTOR FLUSHING HOSE (HFWD PUMP TO 3F1 HOSE, BLADE SLIDE CYLINDER .................................. 3460 - 22
BULKHEAD) .................................................................. 0260 - 24 3F1 HOSE, BLADE TILT CYLINDER ...................................... 3460 - 22
1E9 HFWD MOTOR FLUSHING PUMP .................................. 0260 - 18 1E19 HOSE, CHARGE, HFWD.................................................. 0260 - 28
1E13 HFWD MOTOR FORWARD HOSE (BULKHEAD TO 3F3 HOSE, CIRCLE ROTATE MOTOR .................................. 3460 - 24
HFWD ENGAGEMENT VALVE) .................................. 0260 - 22 3F5 HOSE, CIRCLE SIDESHIFT CYLINDER ........................ 3460 - 26
1E11 HFWD MOTOR FORWARD HOSE (HFWD 1E21 HOSE, DIFFERENTIAL LOCK COOLER ........................ 0260 - 30
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 1E21 HOSE, DIFFERENTIAL LOCK COOLER TO
1E15 HFWD MOTOR FORWARD HOSE (HFWD PUMP TO DIFFERENTIAL LOCK VALVE .................................... 0260 - 30
BULKHEAD) .................................................................. 0260 - 24 1F1 HOSE, DIFFERENTIAL LOCK FILTER
1D20 HFWD MOTOR HYDRAULIC LINES .............................. 0260 - 4 TO DIFFERENTIAL LOCK VALVE .............................. 0260 - 34
1E1 HFWD MOTOR PISTON RINGS...................................... 0260 - 10 1F1 HOSE, DIFFERENTIAL LOCK PUMP
1D20 HFWD MOTOR PRESSURE LINE .................................. 0260 - 4 TO DIFFERENTIAL LOCK VALVE .............................. 0260 - 34
1E13 HFWD MOTOR REVERSE HOSE (BULKHEAD TO 1H20 HOSE, ENGINE VENTILATING SYSTEM ...................... 0402 - 4
HFWD ENGAGEMENT VALVE) .................................. 0260 - 22 1E19 HOSE, HFWD CHARGE PUMP ...................................... 0260 - 28
1E11 HFWD MOTOR REVERSE HOSE (HFWD 1E19 HOSE, HFWD CHARGE PUMP SUCTION .................... 0260 - 28
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 1E13 HOSE, HFWD MOTOR CASE DRAIN (BULKHEAD TO
1E15 HFWD MOTOR REVERSE HOSE (HFWD PUMP TO HFWD ENGAGEMENT VALVE) .................................. 0260 - 22
BULKHEAD) .................................................................. 0260 - 24 1E11 HOSE, HFWD MOTOR CASE DRAIN (HFWD
1D20 HFWD MOTOR RIGHT DRAIN LINE .............................. 0260 - 4 ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20
1E1 HFWD MOTOR ROTATING COMPONENTS .................. 0260 - 10 1E15 HOSE, HFWD MOTOR CASE DRAIN (HFWD PUMP
1D24 HFWD MOTOR SEAL KIT................................................ 0260 - 8 TO BULKHEAD) .......................................................... 0260 - 24
1E1 HFWD MOTOR SEAL KIT................................................ 0260 - 10 1E13 HOSE, HFWD MOTOR FLUSHING (BULKHEAD TO
1D24 HFWD MOTOR SERVO PISTON .................................... 0260 - 8 HFWD ENGAGEMENT VALVE) .................................. 0260 - 22
1D24 HFWD MOTOR SOLENOID AND SERVO PISTON........ 0260 - 8 1E11 HOSE, HFWD MOTOR FLUSHING (HFWD
1E1 HFWD MOTOR SPEED SENSOR .................................. 0260 - 10 ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20
1E1 HFWD MOTOR SWASH PLATE ...................................... 0260 - 10 1E15 HOSE, HFWD MOTOR FLUSHING (HFWD PUMP TO
2G5 HFWD ON/OFF SWITCH.................................................. 1674 - 18 BULKHEAD) .................................................................. 0260 - 24
1F5 HFWD OPERATING CHARGE PRESSURE 1E15 HOSE, HFWD PUMP SUCTION ...................................... 0260 - 24
REGULATING VALVE .................................................. 0260 - 38 1E13 HOSE, HFWD TANK RETURN (BULKHEAD TO
1E5 HFWD PUMP BEARING .................................................. 0260 - 14 HFWD ENGAGEMENT VALVE) .................................. 0260 - 22
1E5 HFWD PUMP CYLINDER BLOCK, SWASH PLATE, 1E15 HOSE, HFWD TANK RETURN (HFWD PUMP TO
AND PISTONS.............................................................. 0260 - 14 BULKHEAD) .................................................................. 0260 - 24
1E7 HFWD PUMP DRIVESHAFT ............................................ 0260 - 16 3C23 HOSE, HYDRAULIC ACCUMULATOR (770D) ................ 2163 - 6
1E9 HFWD PUMP END COVER AND HFWD MOTOR 3D1 HOSE, HYDRAULIC ACCUMULATOR (772D) ................ 2163 - 8
FLUSHING PUMP ........................................................ 0260 - 18 3C17 HOSE, HYDRAULIC LOAD SENSE ................................ 2163 - 2
1E7 HFWD PUMP EP CONTROL .......................................... 0260 - 16 3C23 HOSE, HYDRAULIC PUMP (770D) ................................ 2163 - 6
1E7 HFWD PUMP EP CONTROL GASKET .......................... 0260 - 16 3D1 HOSE, HYDRAULIC PUMP (772D) ................................ 2163 - 8
1E7 HFWD PUMP EP CONTROL SEAL KIT.......................... 0260 - 16
I-8 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=12
 1A14 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

3C11 HOSE, HYDRAULIC, MAIN HYD COLD START 2B7 HOSES, COOLANT HEATER .......................................... 0505 - 8
DISCONNECT .............................................................. 2160 - 40 1F1 HOSES, DIFFERENTIAL LOCK PUMP .......................... 0260 - 34
1E11 HOSE, LEFT HFWD MOTOR BRAKE (HFWD 2E9 HOSES, ENGINE OIL DRAIN .......................................... 1369 - 2
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 3F18 HOSES, FRONT MOUNTED EQUIPMENT .................... 4260 - 6
1E13 HOSE, LEFT HFWD MOTOR FORWARD (BULKHEAD 3F20 HOSES, FRONT SCARIFIER .......................................... 4260 - 8
TO HFWD ENGAGEMENT VALVE) ............................ 0260 - 22 2D3 HOSES, FRONT STEERING CYLINDER ........................ 0960 - 10
1E11 HOSE, LEFT HFWD MOTOR FORWARD (HFWD 2B15 HOSES, FUEL COOLER .................................................. 0510 - 10
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 3C21 HOSES, HYDRAULIC OIL COOLER (770D)
1E15 HOSE, LEFT HFWD MOTOR FORWARD (HFWD (SN 599561- ) .............................................................. 2163 - 5A
PUMP TO BULKHEAD)................................................ 0260 - 24 3C19 HOSES, HYDRAULIC OIL COOLER (772D) .................. 2163 - 4
1E13 HOSE, LEFT HFWD MOTOR REVERSE (BULKHEAD 2D23 HOSES, PARK BRAKE .................................................... 1111 - 4
TO HFWD ENGAGEMENT VALVE) ............................ 0260 - 22 3F20 HOSES, SCARIFIER (FRONT) ........................................ 4260 - 8
1E11 HOSE, LEFT HFWD MOTOR REVERSE (HFWD 2D18 HOSES, SERVICE BRAKE .............................................. 1060 - 4
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 2D11 HOSES, STEERING VALVE ............................................ 0960 - 18
1E15 HOSE, LEFT HFWD MTOR REVERSE (HFWD 1H6 HOSES, TRANSMISSION FILTER .................................. 0360 - 2
PUMP TO BULKHEAD)................................................ 0260 - 24 1H10 HOSES, TRANSMISSION OIL COOLER ........................ 0363 - 2
2D9 HOSE, MAIN CONTROL VALVE TO WHEEL LEAN 2D9 HOSES, WHEEL LEAN CYLINDER (770D) .................... 0960 - 16
CYLINDER (770D)........................................................ 0960 - 16 2D7 HOSES, WHEEL LEAN CYLINDER (772D) .................... 0960 - 14
2D5 HOSE, MAIN HYDRAULIC CONTROL VALVE 1D14 HOUSING, AXLE .............................................................. 0250 - 6
TO ARTICULATION CYLINDER .................................. 0960 - 12 2K5 HOUSING, CAB FRESH AIR FILTER.............................. 1830 - 10
2D7 HOSE, MAIN HYDRAULIC CONTROL VALVE 3E7 HOUSING, CIRCLE DRIVE MOTOR .............................. 3460 - 4
TO WHEEL LEAN CYLINDER (772D) ........................ 0960 - 14 1J3 HOUSING, ENGINE COOLANT THERMOSTAT ............ 0418 - 2
3C23 HOSE, MAIN HYDRAULIC MANIFOLD VALVE TO 1I11 HOUSING, ENGINE OIL FILTER .................................... 0407 - 8
HYDRAULIC ACCUMULATOR (770D) ........................ 2163 - 6 1C8 HOUSING, FINAL DRIVE ................................................ 0201 - 4
3D1 HOSE, MAIN HYDRAULIC MANIFOLD VALVE TO 1D10 HOUSING, FIRST PLANET PINION, HFWD MOTOR .... 0250 - 2
HYDRAULIC ACCUMULATOR (772D) ........................ 2163 - 8 1J15 HOUSING, FLYWHEEL .................................................... 0433 - 2
3C23 HOSE, MAIN HYDRAULIC MANIFOLD VALVE TO 2K22 HOUSING, GRILLE .......................................................... 1921 - 2
HYDRAULIC FILTER (770D)........................................ 2163 - 6 2K7 HOUSING, HEATER AND A/C ........................................ 1830 - 12
3C23 HOSE, MAIN HYDRAULIC MANIFOLD VALVE TO 1D22 HOUSING, HFWD MOTOR .............................................. 0260 - 6
MAIN HYDRAULIC CONTROL VALVE (770D) .......... 2163 - 6 1E7 HOUSING, MAIN, HFWD PUMP...................................... 0260 - 16
3D1 HOSE, MAIN HYDRAULIC MANIFOLD VALVE TO 1D12 HOUSING, PISTON BRAKE, HFWD MOTOR ................ 0250 - 4
MAIN HYDRAULIC CONTROL VALVE (772D) .......... 2163 - 8 1C8 HOUSING, PIVOT ............................................................ 0201 - 4
3C23 HOSE, MAIN HYDRAULIC PUMP (770D) ...................... 2163 - 6 2I9 HOUSING, RADIO (CAB) ................................................ 1810 - 18
3D1 HOSE, MAIN HYDRAULIC PUMP (772D) ...................... 2163 - 8 2I11 HOUSING, RADIO (CANOPY) ........................................ 1810 - 20
3C17 HOSE, MAIN HYDRAULIC PUMP LOAD SENSE .......... 2163 - 2 2K22 HOUSING, REAR GRILLE................................................ 1921 - 2
2D23 HOSE, PARK BRAKE VALVE TO TRANSMISSION ...... 1111 - 4 1J15 HOUSING, REAR OIL SEAL ............................................ 0433 - 2
3F22 HOSE, REAR SCARIFIER................................................ 4260 - 10 1G1 HOUSING, REAR TRANSMISSION ................................ 0350 - 6
1E11 HOSE, RIGHT HFWD MOTOR BRAKE (HFWD 1C6 HOUSING, TANDEM ........................................................ 0201 - 2
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 1G5 HOUSING, TRANSMISSION ............................................ 0350 - 12
1E13 HOSE, RIGHT HFWD MOTOR FORWARD (BULKHEAD 1H3 HOUSING, TRANSMISSION CONTROL VALVE ............ 0350 - 34
TO HFWD ENGAGEMENT VALVE) ............................ 0260 - 22 1F12 HOUSING, TRANSMISSION GEAR SHIFT .................... 0315 - 4
1E11 HOSE, RIGHT HFWD MOTOR FORWARD (HFWD 2B17 HUB, FAN.......................................................................... 0512 - 2
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 1C24 HUB, FRONT WHEEL (770D) .......................................... 0230 - 4
1E15 HOSE, RIGHT HFWD MOTOR FORWARD (HFWD 1D3 HUB, FRONT WHEEL (770D) .......................................... 0230 - 4
PUMP TO BULKHEAD)................................................ 0260 - 24 1D22 HUB, HFWD ...................................................................... 0260 - 6
1E13 HOSE, RIGHT HFWD MOTOR REVERSE (BULKHEAD 1D18 HUB, HFWD (COMPLETE) .............................................. 0260 - 2
TO HFWD ENGAGEMENT VALVE) ............................ 0260 - 22 1D12 HUB, SECOND STAGE PINION, HFWD MOTOR .......... 0250 - 4
1E11 HOSE, RIGHT HFWD MOTOR REVERSE (HFWD 2K1 HVAC POWERED PRECLEANER .................................. 1830 - 4
ENGAGEMENT VALVE TO HFWD MOTOR) ............ 0260 - 20 3C23 HYDRAULIC ACCUMULATOR HOSES (770D) .............. 2163 - 6
1E15 HOSE, RIGHT HFWD MOTOR REVERSE (HFWD 3D1 HYDRAULIC ACCUMULATOR HOSES (772D) .............. 2163 - 8
PUMP TO BULKHEAD)................................................ 0260 - 24 2J7 HYDRAULIC CONTROL LEVER PIVOT ROD ................ 1810 - 40
3F22 HOSE, RIPPER ................................................................ 4260 - 10 2J9 HYDRAULIC CONTROL LEVERS (LEFT) ...................... 1810 - 42
3E19 HOSE, SADDLE LOCK PIN ............................................ 3460 - 16 2J11 HYDRAULIC CONTROL LEVERS (RIGHT) .................... 1810 - 44
2C17 HOSE, SECONDARY STEERING.................................... 0930 - 2 2C23 HYDRAULIC CYLINDER, ARTICULATION...................... 0960 - 6
3C23 HOSE, SUCTION, MAIN HYDRAULIC PUMP 3E11 HYDRAULIC CYLINDER, BLADE LIFT............................ 3460 - 8
(770D) .......................................................................... 2163 - 6 3E13 HYDRAULIC CYLINDER, BLADE SLIDE ........................ 3460 - 10
3D1 HOSE, SUCTION, MAIN HYDRAULIC PUMP 3E15 HYDRAULIC CYLINDER, BLADE TILT............................ 3460 - 12
(772D) .......................................................................... 2163 - 8 3E9 HYDRAULIC CYLINDER, CIRCLE SIDESHIFT .............. 3460 - 6
2B23 HOSE, SUCTION, MUFFLER TO AIR CLEANER 2D1 HYDRAULIC CYLINDER, FRONT STEERING ................ 0960 - 8
PRE-CLEANER ............................................................ 0520 - 2 3F14 HYDRAULIC CYLINDER, RIPPER/REAR
1H10 HOSE, TRANSMISSION ACUMULATOR ........................ 0363 - 2 SCARIFIER .................................................................. 4240 - 8
1I24 HOSE, TURBOCHARGER BOOST CONTROL .............. 0416 - 2 3F10 HYDRAULIC CYLINDER, SCARIFIER ............................ 4240 - 4
1I24 HOSE, WASTEGATE TURBOCHARGER........................ 0416 - 2 2C19 HYDRAULIC CYLINDER, WHEEL LEAN (770D) ............ 0960 - 2
2D5 HOSES, ARTICULATION CYLINDER .............................. 0960 - 12 2C21 HYDRAULIC CYLINDER, WHEEL LEAN (772D) ............ 0960 - 4
2D18 HOSES, BRAKE ACCUMULATOR .................................. 1060 - 4 3C17 HYDRAULIC LOAD SENSE HOSES .............................. 2163 - 2
2D18 HOSES, BRAKE VALVE .................................................. 1060 - 4 3B8 HYDRAULIC MANIFOLD VALVE, MAIN.......................... 2160 - 6
2J23 HOSES, CAB HEATER .................................................... 1830 - 2 2B11 HYDRAULIC OIL COOLER .............................................. 0510 - 4
770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-9
PN=13
 1A15 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

2B13 HYDRAULIC OIL COOLER .............................................. 0510 - 6 3C7 KIT, FIFTH FUNCTION CONTROL VALVE KIT.............. 2160 - 36
3C21 HYDRAULIC OIL COOLER HOSES (770D) 3F8 KIT, FRONT MOUNTED SCARIFIER .............................. 4240 - 2
(SN 599561- ) .............................................................. 2163 - 5A 2D1 KIT, FRONT STEERING CYLINDER SEAL .................... 0960 - 8
3C19 HYDRAULIC OIL COOLER HOSES (772D) .................... 2163 - 4 1E17 KIT, HFWD CHARGE PUMP SEAL ................................ 0260 - 26
3B4 HYDRAULIC PUMP, MAIN .............................................. 2160 - 2 1D24 KIT, HFWD MOTOR SEAL .............................................. 0260 - 8
3D5 HYDRAULIC RESERVOIR................................................ 2164 - 4 1E1 KIT, HFWD MOTOR SEAL .............................................. 0260 - 10
3D5 HYDRAULIC RESERVOIR CAP ...................................... 2164 - 4 1E9 KIT, HFWD PUMP OVERHAUL SEAL ............................ 0260 - 18
3D5 HYDRAULIC RESERVOIR CLEAN OUT COVER .......... 2164 - 4 1E7 KIT, HFWD PUMP SEAL.................................................. 0260 - 16
2E2 KIT, LABEL AND TRADEMARK REPLACEMENT,
ENGLISH ...................................................................... 1320 - 2
I 3B8 KIT, MAIN MANIFOLD VALVE SEAL .............................. 2160 - 6
3D13 KIT, MOLDBOARD EXTENSION (24" MOLDBOARD) .... 3401 - 6
2B17 IDLER PULLEY, FAN BELT ............................................ 0512 - 2 3D15 KIT, MOLDBOARD EXTENSION (27" MOLDBOARD) .... 3401 - 8
2F21 IGNITION RELAY.............................................................. 1674 - 8 3C9 KIT, ONE HAND BLADE LIFT CONTROL ...................... 2160 - 38
2G13 IGNITION SWITCH .......................................................... 1674 - 26 1H23 KIT, PISTON AND CYLINDER LINER ............................ 0403 - 1
2I21 IGNITION SWITCH LABEL (CAB).................................... 1810 - 30 1H23 KIT, PISTON RING .......................................................... 0403 - 1
2I19 IGNITION SWITCH LABEL (CANOPY)............................ 1810 - 28 3F12 KIT, REAR RIPPER/SCARIFIER ...................................... 4240 - 6
3E23 IMPACT VALVE, BLADE .................................................. 3460 - 20 2E2 KIT, REPAINT, ENGLISH LABELS .................................. 1320 - 2
2K7 IMPELLER, HEATER AND A/C BLOWER MOTOR ........ 1830 - 12 3F22 KIT, RIPPER/REAR SCARIFIER HYDRAULIC
1F14 INCHING PEDAL .............................................................. 0315 - 6 HOSES.......................................................................... 4260 - 10
1F14 INCHING PEDAL COVER ................................................ 0315 - 6 3F14 KIT, RIPPER/REAR SCARIFIER SEAL KIT .................... 4240 - 8
3E19 INDICATOR SWITCH, SADDLE LOCKING PIN.............. 3460 - 16 2C1 KIT, ROTARY EJECTOR PRECLEANER ........................ 0520 - 4
1I19 INJECTION PUMP, FUEL ................................................ 0413 - 2 3E5 KIT, ROTARY MANIFOLD SEAL .................................... 3460 - 2
1I19 INJECTOR, ELECTRONIC UNIT...................................... 0413 - 2 3F10 KIT, SCARIFIER CYLINDER SEAL.................................. 4240 - 4
3B24 INLET SECTION, LEFT MAIN HYDRAULIC 3F20 KIT, SCARIFIER HYDRAULIC HOSE (FRONT).............. 4260 - 8
CONTROL VALVE........................................................ 2160 - 28 1E7 KIT, SEAL, HFWD PUMP EP CONTROL........................ 0260 - 16
3B22 INLET SECTION, RIGHT MAIN HYDRAULIC 3B4 KIT, SEAL, MAIN HYDRAULIC PUMP ............................ 2160 - 2
CONTROL VALVE........................................................ 2160 - 26 2C17 KIT, SECONDARY STEERING ........................................ 0930 - 2
1C12 INPUT QUILL .................................................................... 0210 - 4 2D16 KIT, SERVICE BRAKE VALVE SEAL .............................. 1060 - 2
1C10 INPUT YOKE .................................................................... 0210 - 2 3C7 KIT, SEVENTH FUNCTION CONTROL VALVE KIT ...... 2160 - 36
1I14 INSERT, ENGINE VALVE SEAT...................................... 0409 - 2 3C7 KIT, SIXTH FUNCTION CONTROL VALVE KIT ............ 2160 - 36
3D19 INSERTS, BLADE TILT FRAME WEAR .......................... 3440 - 4 1J8 KIT, STARTING MOTOR SOLENOID .............................. 0422 - 2
1I23 INTAKE MANIFOLD .......................................................... 0414 - 1 2D11 KIT, STEERING VALVE SEAL ........................................ 0960 - 18
1I14 INTAKE VALVE, ENGINE ................................................ 0409 - 2 1J1 KIT, WATER PUMP SEAL................................................ 0417 - 2
1I10 INTAKE, ENGINE OIL PUMP .......................................... 0407 - 6 2C19 KIT, WHEEL LEAN CYLINDER SEAL (770D) ................ 0960 - 2
2I9 INTERIOR PANELS, CAB ................................................ 1810 - 18 2C21 KIT, WHEEL LEAN CYLINDER SEAL (772D) ................ 0960 - 4
2I11 INTERIOR PANELS, CANOPY ........................................ 1810 - 20 2I3 KIT, WINDSHIELD REPAIR.............................................. 1810 - 13A
2L4 INTERIOR REARVIEW MIRROR .................................... 2002 - 2 2K9 KIT,A/C PULLEY .............................................................. 1830 - 14
1F16 ISOLATOR, TORSIONAL.................................................. 0325 - 2 2K9 KIT,A/C SERVICE ............................................................ 1830 - 14
2H23 ISOLATORS, CAB ............................................................ 1810 - 10 2K9 KIT,A/C SHAFT SEAL ...................................................... 1830 - 14
3C9 KNOB, ONE HAND BLADE LIFT CONTROL LEVER .... 2160 - 38
2H15 KREMNUTS, CAB ............................................................ 1810 - 2
J

1H24 JET, PISTON COOLING .................................................. 0404 - 2 L

1C20 JOINT, DRIVESHAFT ...................................................... 0225 - 2
2I21 LABEL, ENGINE SPEED CONTROL SWITCH
(CAB) ............................................................................ 1810 - 30
K 2I19 LABEL, ENGINE SPEED CONTROL SWITCH
(CANOPY) .................................................................... 1810 - 28
2C23 KIT, ARTICULATION CYLINDER SEAL .......................... 0960 - 6 2I21 LABEL, IGNITION SWITCH (CAB) .................................. 1810 - 30
2F7 KIT, BEACON BRACKET ................................................ 1673 - 8 2I19 LABEL, IGNITION SWITCH (CANOPY) .......................... 1810 - 28
3E21 KIT, BLADE IMPACT SYSTEM ........................................ 3460 - 18 2E2 LABELS AND TRADEMARKS, ENGLISH........................ 1320 - 2
3E23 KIT, BLADE IMPACT VALVE SEAL ................................ 3460 - 20 2E6 LABELS AND TRADEMARKS, FRENCH ........................ 1320 - 6
3E11 KIT, BLADE LIFT CYLINDER SEAL ................................ 3460 - 8 2E4 LABELS AND TRADEMARKS, SPANISH........................ 1320 - 4
3E13 KIT, BLADE SLIDE CYLINDER SEAL ............................ 3460 - 10 2E2 LABELS, ENGLISH .......................................................... 1320 - 2
3E15 KIT, BLADE TILT CYLINDER SEAL ................................ 3460 - 12 2E6 LABELS, FRENCH ............................................................ 1320 - 6
2H1 KIT, BOTTOM GUARD (W/O RIPPER) .......................... 1746 - 2 2E4 LABELS, SPANISH .......................................................... 1320 - 4
2H3 KIT, BOTTOM GUARD SIDE SHIELD KIT 2F5 LAMP, LED STOP ............................................................ 1673 - 6
(W/O RIPPER) .............................................................. 1746 - 4 2F5 LAMP, LED TAIL .............................................................. 1673 - 6
2H5 KIT, BOTTOM GUARDS AND SIDE SHIELDS 2F5 LAMP, LED TURN ............................................................ 1673 - 6
(WITH RIPPER) ............................................................ 1746 - 6 2J1 LATCH, CAB DOOR (LEFT) ............................................ 1810 - 34
3E7 KIT, CIRCLE DRIVE MOTOR SEAL ................................ 3460 - 4 2I23 LATCH, CAB DOOR (RIGHT) .......................................... 1810 - 32
3E9 KIT, CIRCLE SIDESHIFT CYLINDER SEAL .................. 3460 - 6 2J1 LATCH, CAB DOOR HOLD OPEN (LEFT)...................... 1810 - 34
3B4 KIT, CYL BLOCK, MAIN HYDRAULIC PUMP ................ 2160 - 2 2I23 LATCH, CAB DOOR HOLD OPEN (RIGHT) .................. 1810 - 32
1H23 KIT, CYLINDER LINER O-RING ...................................... 0403 - 1 2K16 LATCH, ENGINE DOOR .................................................. 1910 - 2
1I23 KIT, ENGINE AIR HEATER MANIFOLD.......................... 0414 - 1 2I5 LATCH, OPENABLE LOWER FRONT WINDOWS ........ 1810 - 14
I-10 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=14
 1A16 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

2I7 LATCH, OPENABLE SIDE WINDOWS ............................ 1810 - 16 2G17 LOAD CENTER ................................................................ 1675 - 2
2K16 LATCH, SERVICE DOORS .............................................. 1910 - 2 3C17 LOAD SENSE HOSE, MAIN HYDRAULIC PUMP .......... 2163 - 2
2L14 LATCH, TOOLBOX SPRING HOOK ................................ 2005 - 2 3C17 LOAD SENSE HOSES, HYDRAULIC .............................. 2163 - 2
1D8 LEAN BAR LINK (772D) .................................................. 0240 - 6 3E19 LOCK PIN, SADDLE ........................................................ 3460 - 16
2C19 LEAN CYLINDER, WHEEL (770D) .................................. 0960 - 2 2K16 LOCK, SERVICE DOORS ................................................ 1910 - 2
2C21 LEAN CYLINDER, WHEEL (772D) .................................. 0960 - 4 3B14 LOCKOUT VALVE, ARTICULATION VALVE
2F3 LED FRONT SIGNAL LIGHT............................................ 1673 - 4 SECTION ...................................................................... 2160 - 18
2F5 LED STOP LAMP.............................................................. 1673 - 6 3C3 LOCKOUT VALVE, AUXILIARY VALVE SECTION
2F5 LED STOP LIGHT ............................................................ 1673 - 6 (WITH FLOAT) .............................................................. 2160 - 32
2F5 LED TAIL LIGHT .............................................................. 1673 - 6 3C5 LOCKOUT VALVE, AUXILIARY VALVE SECTION
2F5 LED TURN LAMP ............................................................ 1673 - 6 (WITHOUT FLOAT) ...................................................... 2160 - 34
2F5 LED TURN LIGHT ............................................................ 1673 - 6 3B20 LOCKOUT VALVE, BLADE LIFT VALVE
3B20 LEFT BLADE LIFT VALVE SECTION.............................. 2160 - 24 SECTION ...................................................................... 2160 - 24
2J9 LEFT CONTROL LEVER BOOT ...................................... 1810 - 42 3B18 LOCKOUT VALVE, BLADE SIDE SHIFT
2J9 LEFT HYDRAULIC CONTROL LEVERS ........................ 1810 - 42 VALVE SECTION.......................................................... 2160 - 22
3B10 LEFT MAIN HYDRAULIC CONTROL VALVE.................. 2160 - 10 3B14 LOCKOUT VALVE, BLADE TILT VALVE SECTION ...... 2160 - 18
3B24 LEFT MAIN HYDRAULIC CONTROL VALVE INLET 3B14 LOCKOUT VALVE, CIRCLE SIDE SHIFT VALVE
AND OUTLET SECTIONS............................................ 2160 - 28 SECTION ...................................................................... 2160 - 18
2J1 LEFT SIDE CAB DOOR .................................................. 1810 - 34 3C1 LOCKOUT VALVE, RIPPER VALVE SECTION .............. 2160 - 30
3B24 LEFT VALVE INLET SECTION ........................................ 2160 - 28 3C3 LOCKOUT VALVE, SCARIFIER VALVE SECTION ........ 2160 - 32
3B24 LEFT VALVE OUTLET SECTION .................................... 2160 - 28 3B14 LOCKOUT VALVE, WHEEL LEAN VALVE SECTION .... 2160 - 18
2J9 LEVER, ARTICULATION CONTROL .............................. 1810 - 42 2K3 LOUVER, CAB B-POST HEATER AND AIR
2J11 LEVER, BLADE LIFT CONTROL .................................... 1810 - 44 CONDITIONER DUCT .................................................. 1830 - 8
2J11 LEVER, BLADE SIDE SHIFT CONTROL ........................ 1810 - 44 2H21 LOWER FRONT WINDSHIELD WIPER .......................... 1810 - 8
2J9 LEVER, CIRCLE ROTATE CONTROL ............................ 1810 - 42 2H21 LOWER FRONT WINDSHIELD WIPER BLADE.............. 1810 - 8
2J11 LEVER, CIRCLE SIDE SHIFT CONTROL ...................... 1810 - 44 1B14 LUBGOLT, FRONT WHEEL (12" X 25").......................... 0110 - 14
2J11 LEVER, LEFT BLADE LIFT CONTROL .......................... 1810 - 44 2E13 LUBRICATION LINES, FRAME HINGE .......................... 1370 - 2
3C9 LEVER, ONE HAND BLADE LIFT CONTROL ................ 2160 - 38 2E13 LUBRICATION, CENTRAL, FRAME HINGE.................... 1370 - 2
2J9 LEVER, RIGHT AUXILIARY CONTROL .......................... 1810 - 42 1B10 LUGBOLT, FRONT WHEEL (14" X 25").......................... 0110 - 10
2J9 LEVER, RIGHT BLADE LIFT CONTROL ........................ 1810 - 42 1B16 LUGBOLT, FRONT WHEEL (16" X 24").......................... 0110 - 16
2J11 LEVER, RIPPER CONTROL ............................................ 1810 - 44 1B2 LUGBOLT, REAR WHEEL (10" X 24") (SPLIT
2J9 LEVER, SCARIFIER CONTROL ...................................... 1810 - 42 RIM) .............................................................................. 0110 - 2
2J9 LEVER, WHEEL LEAN CONTROL .................................. 1810 - 42 1B2 LUGBOLT, WHEEL (10" X 24") (SPLIT RIM).................. 0110 - 2
2J9 LEVERS, CAB CONTROL (LEFT) .................................. 1810 - 42 1B4 LUGBOLT, WHEEL (14" X 25") (770D)
2J11 LEVERS, CAB CONTROL (RIGHT) ................................ 1810 - 44 (772D) .......................................................................... 0110 - 4
3E17 LIFT CYLINDER HOSES .................................................. 3460 - 14 1B4 LUGBOLT, WHEEL (17" X 25") (770D)
3E11 LIFT CYLINDER, BLADE.................................................. 3460 - 8 (772D) .......................................................................... 0110 - 4
1I16 LIFT STRAP, ENGINE ...................................................... 0409 - 4
2F7 LIGHT BRACKET, BEACON ............................................ 1673 - 8
2K22 LIGHT PANEL, REAR ...................................................... 1921 - 2 M
2F5 LIGHT, LED STOP............................................................ 1673 - 6
2F5 LIGHT, LED TURN............................................................ 1673 - 6 2C11 MAGNETIC PICK-UP, ENGINE........................................ 0578 - 1
2F9 LIGHTS, CAB ROOF ........................................................ 1673 - 10 1H16 MAIN BEARING, ENGINE ................................................ 0401 - 2
2F11 LIGHTS, FRONT DRIVE .................................................. 1673 - 12 3C15 MAIN CONTROL VALVE MOUNTING BRACKETS ........ 2160 - 44
2F3 LIGHTS, FRONT SIGNAL ................................................ 1673 - 4 1C8 MAIN DRIVE AXLE HOUSING ........................................ 0201 - 4
2F13 LIGHTS, FRONT WORK .................................................. 1673 - 14 2G20 MAIN FRAME .................................................................... 1740 - 2
2F13 LIGHTS, REAR WORK .................................................... 1673 - 14 2G24 MAIN FRAME COVERS .................................................. 1740 - 6
2B23 LINE, AIR CLEANER PRE-CLEANER TO MUFFLER .... 0520 - 2 2G24 MAIN FRAME COWL COVER.......................................... 1740 - 6
1C17 LINE, DIFFERENTIAL CASE OIL .................................... 0210 - 9 2K20 MAIN FRAME FRONT SIDE COVERS............................ 1913 - 2
1I19 LINE, FUEL INJECTION PUMP LUBE ............................ 0413 - 2 2G24 MAIN FRAME TOP COVER ............................................ 1740 - 6
1D20 LINE, HFWD MOTOR BRAKE ........................................ 0260 - 4 2F15 MAIN FRAME WIRING HARNESS .................................. 1674 - 2
1D20 LINE, HFWD MOTOR PRESSURE.................................. 0260 - 4 3D3 MAIN HYD FILTER MOUNTING ...................................... 2164 - 2
1D20 LINE, HFWD MOTOR RIGHT DRAIN.............................. 0260 - 4 3B10 MAIN HYDRAULIC CONTROL VALVE............................ 2160 - 10
2B23 LINE, SUCTION, MUFFLER TO AIR CLEANER 3B24 MAIN HYDRAULIC CONTROL VALVE INLET
PRE-CLEANER ............................................................ 0520 - 2 SECTION (LEFT) .......................................................... 2160 - 28
1I24 LINE, TURBOCHARGER OIL .......................................... 0416 - 2 3B22 MAIN HYDRAULIC CONTROL VALVE INLET
1H23 LINER, ENGINE CYLINDER ............................................ 0403 - 1 SECTION (RIGHT) ...................................................... 2160 - 26
1J6 LINES AND FILTER, FUEL .............................................. 0420 - 2 3B24 MAIN HYDRAULIC CONTROL VALVE OUTLET
2E13 LINES AND FITTINGS, FRAME HINGE CENTRAL SECTION (LEFT) .......................................................... 2160 - 28
LUBRICATION .............................................................. 1370 - 2 3B22 MAIN HYDRAULIC CONTROL VALVE OUTLET
2K11 LINES, AIR CONDITIONING ............................................ 1830 - 16 SECTION (RIGHT) ...................................................... 2160 - 26
1I19 LINES, FUEL INJECTION ................................................ 0413 - 2 3B12 MAIN HYDRAULIC CONTROL VALVE TIE RODS ........ 2160 - 12
1D20 LINES, HFWD MOTOR .................................................... 0260 - 4 3D3 MAIN HYDRAULIC FILTER .............................................. 2164 - 2
1D8 LINK, LEAN BAR (772D) .................................................. 0240 - 6 3B8 MAIN HYDRAULIC MANIFOLD VALVE .......................... 2160 - 6
1C22 LINK, WHEEL LEAN (770D) ............................................ 0230 - 2 3C23 MAIN HYDRAULIC MANIFOLD VALVE HOSES
1D8 LINK, WHEEL LEAN BAR (772D).................................... 0240 - 6 (770D) .......................................................................... 2163 - 6
2G7 LINKAGE, ARTICULATION SENSOR .............................. 1674 - 20
770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-11
PN=15
 1A17 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

3D1 MAIN HYDRAULIC MANIFOLD VALVE HOSES O
(772D) .......................................................................... 2163 - 8
3C23 MAIN HYDRAULIC PLUMBING (770D) .......................... 2163 - 6 1J1 O-RING, WATER PUMP .................................................. 0417 - 2
3D1 MAIN HYDRAULIC PLUMBING (772D) .......................... 2163 - 8 1H3 OIL COOLER BYPASS RELIEF VALVE.......................... 0350 - 34
3B4 MAIN HYDRAULIC PUMP ................................................ 2160 - 2 1I13 OIL COOLER BYPASS TUBES AND ADAPTER,
3C23 MAIN HYDRAULIC PUMP FITTINGS (770D).................. 2163 - 6 ENGINE ........................................................................ 0407 - 10
3D1 MAIN HYDRAULIC PUMP FITTINGS (772D).................. 2163 - 8 3C21 OIL COOLER HOSES, HYDRAULIC (770D)
3C17 MAIN HYDRAULIC PUMP LOAD SENSE HOSE............ 2163 - 2 (SN 599561- ) .............................................................. 2163 - 5A
3B4 MAIN HYDRAULIC PUMP SEAL KIT .............................. 2160 - 2 3C19 OIL COOLER HOSES, HYDRAULIC (772D) .................. 2163 - 4
3C23 MAIN HYDRAULIC PUMP SUCTION HOSE (770D) ...... 2163 - 6 1H10 OIL COOLER HOSES, TRANSMISSION ........................ 0363 - 2
3D1 MAIN HYDRAULIC PUMP SUCTION HOSE (772D) ...... 2163 - 8 1J5 OIL COOLER, ENGINE .................................................... 0419 - 1
3B8 MAIN MANIFOLD VALVE ................................................ 2160 - 6 2B11 OIL COOLER, HYDRAULIC ............................................ 0510 - 4
3B6 MAIN MANIFOLD VALVE MOUNTING BRACKET.......... 2160 - 4 2B13 OIL COOLER, HYDRAULIC ............................................ 0510 - 6
3B8 MAIN MANIFOLD VALVE SEAL KIT .............................. 2160 - 6 1I5 OIL DIPSTICK, ENGINE .................................................. 0407 - 1
2F15 MAIN WIRING HARNESS (FRONT) ................................ 1674 - 2 1F1 OIL FILTER, DIFFERENTIAL LOCK ................................ 0260 - 34
2F17 MAIN WIRING HARNESS (REAR) .................................. 1674 - 4 1I11 OIL FILTER, ENGINE ...................................................... 0407 - 8
3B8 MANIFOLD VALVE, MAIN ................................................ 2160 - 6 1H6 OIL FILTER, TRANSMISSION.......................................... 0360 - 2
1I17 MANIFOLD, EXHAUST .................................................... 0410 - 1 1C17 OIL LINE, DIFFERENTIAL CASE .................................... 0210 - 9
1I19 MANIFOLD, FUEL INJECTION ........................................ 0413 - 2 1E21 OIL LINE, DIFFERENTIAL LOCK .................................... 0260 - 30
1F5 MANIFOLD, HFWD ENGAGEMENT ................................ 0260 - 38 1I24 OIL LINE, TURBOCHARGER .......................................... 0416 - 2
1I23 MANIFOLD, INTAKE ........................................................ 0414 - 1 1I6 OIL PAN, ENGINE ............................................................ 0407 - 2
3E5 MANIFOLD, ROTARY ...................................................... 3460 - 2 1D12 OIL PLUG, HFWD ............................................................ 0250 - 4
2K9 MANIFOLD,A/C ................................................................ 1830 - 14 2C15 OIL PRESSURE SENSOR, ENGINE .............................. 0578 - 5
2F13 MID-FRAME WORK LIGHTS............................................ 1673 - 14 1I10 OIL PUMP INTAKE, ENGINE .......................................... 0407 - 6
2L6 MIRROR BRACKET, EXTERIOR .................................... 2002 - 4 1I8 OIL PUMP, ENGINE ........................................................ 0407 - 4
2L6 MIRROR, EXTERIOR........................................................ 2002 - 4 1D14 OIL SEAL, AXLE HOUSING ............................................ 0250 - 6
2L6 MIRROR, EXTERIOR HEATED........................................ 2002 - 4 1H22 OIL SEAL, FRONT............................................................ 0402 - 6
2L4 MIRROR, INTERIOR REARVIEW .................................... 2002 - 2 1J15 OIL SEAL, REAR .............................................................. 0433 - 2
1F12 MODULE, TRANSMISSION SWITCH BOX .................... 0315 - 4 1F21 OIL TROUGH, TRANS CASE (770D) .............................. 0350 - 2
1J6 MOISTURE SENSOR, FUEL............................................ 0420 - 2 1F23 OIL TROUGH, TRANS CASE (772D) .............................. 0350 - 4
2C12 MOISTURE SENSOR, FUEL............................................ 0578 - 2 3C9 ONE HAND BLADE LIFT CONTROL .............................. 2160 - 38
3D13 MOLDBOARD EXTENSION (24" MOLDBOARD) ............ 3401 - 6 2I7 OPENABLE SIDE WINDOWS .......................................... 1810 - 16
3D15 MOLDBOARD EXTENSION (27" MOLDBOARD) ............ 3401 - 8 2I5 OPENABLE WINDOWS (LOWER FRONT) .................... 1810 - 14
3D13 MOLDBOARD EXTENSION KIT (24" MOLDBOARD) .... 3401 - 6 2I7 OPENABLE WINDOWS (SIDE)........................................ 1810 - 16
3D15 MOLDBOARD EXTENSION KIT (27" MOLDBOARD) .... 3401 - 8 1F5 OPERATING CHARGE PRESSURE REGULATING
3D11 MOLDBOARD OVERLAYS .............................................. 3401 - 4 VALVE, HFWD.............................................................. 0260 - 38
3D9 MOLDBOARDS AND CUTTING EDGES ........................ 3401 - 2 1H24 ORIFICE, PISTON COOLING JET .................................. 0404 - 2
2F21 MONITOR .......................................................................... 1674 - 8 3B24 OUTLET SECTION, LEFT MAIN HYDRAULIC
2J3 MONITOR CONSOLE, CAB ............................................ 1810 - 36 CONTROL VALVE........................................................ 2160 - 28
1D22 MOTOR HOUSING, HFWD .............................................. 0260 - 6 3B22 OUTLET SECTION, RIGHT MAIN HYDRAULIC
3E7 MOTOR, CIRCLE DRIVE.................................................. 3460 - 4 CONTROL VALVE........................................................ 2160 - 26
2H17 MOTOR, FRONT WINDSHIELD WIPER.......................... 1810 - 4 1G19 OUTPUT, TRANSMISSION .............................................. 0350 - 26
2K7 MOTOR, HEATER AND A/C BLOWER .......................... 1830 - 12 1I3 OVERHAUL KIT, ENGINE ................................................ 0404 - 6
1D18 MOTOR, HFWD (COMPLETE) ........................................ 0260 - 2 3D11 OVERLAYS, MOLDBOARD .............................................. 3401 - 4
1J8 MOTOR, STARTING ........................................................ 0422 - 2
3B6 MOUNTING BRACKET, MAIN MANIFOLD VALVE ........ 2160 - 4
3C15 MOUNTING BRACKETS, MAIN CONTROL VALVE ...... 2160 - 44 P
3D9 MOUNTING PIN,BLADE SIDESHIFT CYL ROD END .... 3401 - 2
1E23 MOUNTING, DIFF LOCK PUMP ...................................... 0260 - 32 1I6 PAN, ENGINE OIL ............................................................ 0407 - 2
2C5 MOUNTING, ENGINE ...................................................... 0540 - 2 2I21 PANEL, ENGINE SPEED CONTROL SWITCH
1E3 MOUNTING, HFWD PUMP (672CH2) ............................ 0260 - 12 (CAB) ............................................................................ 1810 - 30
3D3 MOUNTING, MAIN HYD FILTER .................................... 2164 - 2 2I19 PANEL, ENGINE SPEED CONTROL SWITCH
1H1 MOUNTING, TRANSMISSION CONTROL VALVE.......... 0350 - 32 (CANOPY) .................................................................... 1810 - 28
2C5 MOUNTS, ENGINE .......................................................... 0540 - 2 2K22 PANEL, REAR LIGHT ...................................................... 1921 - 2
2C3 MUFFLER .......................................................................... 0530 - 2 2I9 PANELS, CAB INTERIOR ................................................ 1810 - 18
2B23 MUFFLER SUCTION HOSE TO AIR CLEANER 2I13 PANELS, CAB REAR INTERIOR .................................... 1810 - 22
PRE-CLEANER ............................................................ 0520 - 2 2I11 PANELS, CANOPY INTERIOR ........................................ 1810 - 20
1G21 PARK BRAKE.................................................................... 0350 - 28
2D23 PARK BRAKE HOSES...................................................... 1111 - 4
N 2D21 PARK BRAKE PRESSURE SWITCH .............................. 1111 - 2
2D21 PARK BRAKE SOLENOID VALVE .................................. 1111 - 2
1E19 NEUTRAL CHARGE PRESSURE REGULATING VALVE0260 - 28 2D21 PARK BRAKE VALVE ...................................................... 1111 - 2
2B5 NOZZLE, COLD WEATHER STARTING AID .................. 0505 - 4 2D23 PARK BRAKE VALVE FITTINGS .................................... 1111 - 4
1I19 NOZZLE, FUEL INJECTION ............................................ 0413 - 2 2D23 PARK BRAKE VALVE HOSES ........................................ 1111 - 4
2D16 PEDAL, BRAKE ................................................................ 1060 - 2
2B21 PEDAL, DECELERATOR.................................................. 0515 - 4
2B19 PEDAL, ENGINE SPEED CONTROL .............................. 0515 - 2
I-12 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=16
 1A18 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

1F14 PEDAL, INCHING.............................................................. 0315 - 6 1E23 PUMP, DIFFERENTIAL LOCK ........................................ 0260 - 32
2D16 PEDAL, SERVICE BRAKE .............................................. 1060 - 2 1I8 PUMP, ENGINE OIL ........................................................ 0407 - 4
2C11 PICK-UP, ENGINE MAGNETIC........................................ 0578 - 1 2H17 PUMP, FRONT WINDSHIELD WASHER ........................ 1810 - 4
2G20 PIN, ARTICULATION CYLINDER .................................... 1740 - 2 1I19 PUMP, FUEL INJECTION ................................................ 0413 - 2
1C22 PIN, FRONT AXLE PIVOT (770D) .................................. 0230 - 2 1I19 PUMP, FUEL INJECTION HAND PRIMER...................... 0413 - 2
1D4 PIN, FRONT AXLE PIVOT (772D) .................................. 0240 - 2 1E17 PUMP, HFWD CHARGE .................................................. 0260 - 26
1C8 PIN, PIVOT........................................................................ 0201 - 4 1E9 PUMP, HFWD MOTOR FLUSHING ................................ 0260 - 18
2G20 PIN, PIVOT, MAIN FRAME .............................................. 1740 - 2 1E7 PUMP, HFWD, MAIN HOUSING...................................... 0260 - 16
1C22 PIN, STEERING CYLINDER (770D) ................................ 0230 - 2 3B4 PUMP, MAIN HYDRAULIC .............................................. 2160 - 2
1C22 PIN, WHEEL LEAN (770D) .............................................. 0230 - 2 2H19 PUMP, REAR WINDSHIELD WASHER .......................... 1810 - 6
1D8 PIN, WHEEL LEAN BAR LINK (772D) ............................ 0240 - 6 1J1 PUMP, WATER ................................................................ 0417 - 2
1C22 PIN, WHEEL LEAN LINK (770D) .................................... 0230 - 2 2H7 PUSH BLOCK .................................................................. 1747 - 2
3D9 PIN,BLADE SIDESHIFT CYL ROD END MOUNTING .... 3401 - 2 1H18 PUSH RODS, ENGINE .................................................... 0402 - 2
1D10 PINION, FIRST PLANET, HFWD MOTOR ...................... 0250 - 2
1D10 PINION, FIRST STAGE, HFWD MOTOR ........................ 0250 - 2
1D12 PINION, SECOND STAGE, HFWD MOTOR .................. 0250 - 4 Q
2C23 PINS, ARTICULATION CYLINDER .................................. 0960 - 6
2D1 PINS, STEERING CYLINDER .......................................... 0960 - 8 1C12 QUILL, INPUT .................................................................. 0210 - 4
2C19 PINS, WHEEL LEAN CYLINDER (770D) ........................ 0960 - 2
2C21 PINS, WHEEL LEAN CYLINDER (772D) ........................ 0960 - 4
1H24 PISTON COOLING JET.................................................... 0404 - 2 R
1H23 PISTON RING, ENGINE .................................................. 0403 - 1
1E1 PISTON RINGS, HFWD MOTOR .................................... 0260 - 10 2B11 RADIATOR, CHARGE AIR COOLER AND
1H23 PISTON, ENGINE ............................................................ 0403 - 1 HYDRAULIC OIL COOLER.......................................... 0510 - 4
1D24 PISTON, HFWD MOTOR SERVO.................................... 0260 - 8 2B13 RADIATOR, CHARGE AIR COOLER AND
1E5 PISTON, HFWD PUMP .................................................... 0260 - 14 HYDRAULIC OIL COOLER.......................................... 0510 - 6
1E7 PISTON, SERVO, HFWD PUMP...................................... 0260 - 16 2L2 RADIO................................................................................ 2001 - 2
1E5 PISTONS, HFWD PUMP .................................................. 0260 - 14 2L2 RADIO ANTENNA ............................................................ 2001 - 2
1C8 PIVOT HOUSING .............................................................. 0201 - 4 2L2 RADIO ANTENNA CABLE................................................ 2001 - 2
1C8 PIVOT PIN ........................................................................ 0201 - 4 2L2 RADIO BRACKET ............................................................ 2001 - 2
2G20 PIVOT PIN, MAIN FRAME .............................................. 1740 - 2 2I9 RADIO HOUSING (CAB) .................................................. 1810 - 18
1C8 PIVOT, TANDEM .............................................................. 0201 - 4 2I11 RADIO HOUSING (CANOPY) .......................................... 1810 - 20
1D16 PLANET PINION CARRIER.............................................. 0250 - 8 2F21 RADIO SPEAKER WIRING HARNESS............................ 1674 - 8
1D10 PLANET PINION CARRIER, FIRST, HFWD MOTOR .... 0250 - 2 2L2 RADIO SPEAKERS .......................................................... 2001 - 2
1D16 PLANETARY, TANDEM DRIVE........................................ 0250 - 8 1I19 RAIL, FUEL INJECTION .................................................. 0413 - 2
2H9 PLATE, FRONT MOUNTED WEIGHT ............................ 1749 - 2 2K22 REAR GRILLE .................................................................. 1921 - 2
2D14 PLATE, SEPARATOR, BRAKE ........................................ 1011 - 2 2K22 REAR GRILLE HOUSING ................................................ 1921 - 2
1C18 PLATES, DIFFERENTIAL CLUTCH ................................ 0210 - 10 2G3 REAR HFWD WIRING HARNESS .................................. 1674 - 16
1D12 PLUG, HFWD OIL ............................................................ 0250 - 4 2E16 REAR HITCH .................................................................... 1511 - 2
2G15 POWER CONVERTER (24 VOLT TO 12 VOLT) ............ 1674 - 28 2K22 REAR LIGHT PANEL........................................................ 1921 - 2
2K1 POWERED PRECLEANER, HVAC .................................. 1830 - 4 2F17 REAR MAIN WIRING HARNESS .................................... 1674 - 4
2B23 PRE-CLEANER, AIR ........................................................ 0520 - 2 1J15 REAR OIL SEAL .............................................................. 0433 - 2
2C1 PRECLEANER .................................................................. 0520 - 4 1J15 REAR OIL SEAL HOUSING ............................................ 0433 - 2
2C1 PRECLEANER WITH SEPARATOR ................................ 0520 - 4 2F17 REAR PLATFORM WIRING HARNESS .......................... 1674 - 4
2K1 PRECLEANER, HVAC POWERED .................................. 1830 - 4 3F12 REAR RIPPER SHANK .................................................... 4240 - 6
2C1 PRECLEANER, ROTARY EJECTOR .............................. 0520 - 4 3F12 REAR RIPPER/SCARIFIER .............................................. 4240 - 6
1E9 PRESSURE OVERRIDE VALVE, HFWD CHARGE 3F12 REAR RIPPER/SCARIFIER KIT ...................................... 4240 - 6
PUMP ............................................................................ 0260 - 18 3F16 REAR SCARIFIER SHANK .............................................. 4240 - 10
3B8 PRESSURE REDUCING VALVE, SADDLE LOCK PIN .. 2160 - 6 3F16 REAR SCARIFIER TEETH .............................................. 4240 - 10
1E19 PRESSURE REGULATING VALVE, NEUTRAL 1G1 REAR TRANSMISSION CASE ........................................ 0350 - 6
CHARGE ...................................................................... 0260 - 28 1G1 REAR TRANSMISSION HOUSING .................................. 0350 - 6
3C21 PRESSURE RELIEF VALVE, HYD OIL 1B2 REAR WHEEL (10" X 24") (SPLIT RIM) ........................ 0110 - 2
COOLER HOSE (770D) (SN 599561- ) ...................... 2163 - 5A 1B4 REAR WHEEL (14" X 25") (772D) .................................. 0110 - 4
3C19 PRESSURE RELIEF VALVE, HYD OIL 1B4 REAR WHEEL (17" X 25") (772D) .................................. 0110 - 4
COOLER HOSES (772D) ............................................ 2163 - 4 2I1 REAR WINDOW................................................................ 1810 - 12
2C15 PRESSURE SENSOR, ENGINE OIL .............................. 0578 - 5 2L16 REAR WINDOW SUNVISOR............................................ 2007 - 2
1F3 PRESSURE SENSOR, HFWD PUMP.............................. 0260 - 36 2H19 REAR WINDSHIELD WASHER PUMP ............................ 1810 - 6
3D3 PRESSURE SWITCH, MAIN HYDRAULIC ...................... 2164 - 2 2H19 REAR WINDSHIELD WIPER............................................ 1810 - 6
2D21 PRESSURE SWITCH, PARK BRAKE.............................. 1111 - 2 2I9 REAR WIPER COVER (CAB) .......................................... 1810 - 18
1J12 PULLEY, CRANKSHAFT .................................................. 0429 - 1 2I11 REAR WIPER COVER (CANOPY) .................................. 1810 - 20
2B17 PULLEY, FAN.................................................................... 0512 - 2 2F13 REAR WORK LIGHTS ...................................................... 1673 - 14
2B17 PULLEY, FAN BELT IDLER ............................................ 0512 - 2 2F13 REAR, MID-FRAME, AND UNDER CAB WORK
1J13 PULLEY, FIXED FAN DRIVE .......................................... 0429 - 2 LIGHTS.......................................................................... 1673 - 14
1F21 PUMP DRIVE GEARS (770D).......................................... 0350 - 2 2L4 REARVIEW MIRROR, INTERIOR .................................... 2002 - 2
1F23 PUMP DRIVE GEARS (772D).......................................... 0350 - 4 1J17 REBUILD GASKET KIT, ENGINE .................................... 0452 - 2
1E3 PUMP MOUNTING, HFWD (672CH2) ............................ 0260 - 12 2K11 RECEIVER-DRYER, AIR CONDITIONING ...................... 1830 - 16
1E23 PUMP, DIFF LOCK .......................................................... 0260 - 32 2B3 RELAY, ENGINE AIR HEATER........................................ 0505 - 2
770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-13
PN=17
 1A19 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

2F21 RELAY, IGNITION ............................................................ 1674 - 8 3C3 ROTARY ACTUATOR, AUXLIARY VALVE SECTION
3B20 RELIEF VALVE, BLADE LIFT VALVE (WITH FLOAT) .............................................................. 2160 - 32
SECTION ...................................................................... 2160 - 24 3C5 ROTARY ACTUATOR, AUXLIARY VALVE SECTION
1H3 RELIEF VALVE, OIL COOLER BYPASS ........................ 0350 - 34 (WITHOUT FLOAT) ...................................................... 2160 - 34
3D5 RESERVOIR, HYDRAULIC .............................................. 2164 - 4 3B20 ROTARY ACTUATOR, BLADE LIFT
2H17 RESERVOIR, WINDSHIELD WASHER............................ 1810 - 4 VALVE SECTION.......................................................... 2160 - 24
2K7 RESISTOR, HEATER AND A/C ...................................... 1830 - 12 3B18 ROTARY ACTUATOR, BLADE SIDE SHIFT
1I19 RESTRICTOR, FUEL INJECTION RAIL .......................... 0413 - 2 VALVE SECTION.......................................................... 2160 - 22
1E13 RETURN HOSE, HFWD TANK (BULKHEAD TO 3B14 ROTARY ACTUATOR, BLADE TILT
HFWD ENGAGEMENT VALVE) .................................. 0260 - 22 VALVE SECTION.......................................................... 2160 - 18
1E15 RETURN HOSE, HFWD TANK (HFWD PUMP TO 3B16 ROTARY ACTUATOR, CIRCLE ROTATE
BULKHEAD) .................................................................. 0260 - 24 VALVE SECTION.......................................................... 2160 - 20
2J11 RIGHT AUXILIARY CONTROL LEVER .......................... 1810 - 44 3B14 ROTARY ACTUATOR, CIRCLE SIDE SHIFT
2J9 RIGHT AUXLIARY CONTROL LEVER ............................ 1810 - 42 VALVE SECTION.......................................................... 2160 - 18
2J11 RIGHT BLADE LIFT CONTROL ...................................... 1810 - 44 3C1 ROTARY ACTUATOR, RIPPER VALVE SECTION ........ 2160 - 30
2J9 RIGHT BLADE LIFT CONTROL LEVER.......................... 1810 - 42 3C3 ROTARY ACTUATOR, SCARIFIERVALVE
3B20 RIGHT BLADE LIFT VALVE SECTION .......................... 2160 - 24 SECTION ...................................................................... 2160 - 32
2J11 RIGHT CONTROL LEVER BOOT .................................... 1810 - 44 3B14 ROTARY ACTUATOR, WHEEL LEAN VALVE
2J11 RIGHT HYDRAULIC CONTROL LEVERS ...................... 1810 - 44 SECTION ...................................................................... 2160 - 18
3B10 RIGHT MAIN HYDRAULIC CONTROL VALVE .............. 2160 - 10 2C1 ROTARY EJECTOR PRECLEANER ................................ 0520 - 4
3B22 RIGHT MAIN HYDRAULIC CONTROL VALVE INLET 2C1 ROTARY EJECTOR PRECLEANER KIT ........................ 0520 - 4
AND OUTLET SECTIONS............................................ 2160 - 26 3E5 ROTARY MANIFOLD ........................................................ 3460 - 2
2I23 RIGHT SIDE CAB DOOR ................................................ 1810 - 32 3E5 ROTARY MANIFOLD SEAL KIT ...................................... 3460 - 2
3B22 RIGHT VALVE INLET SECTION...................................... 2160 - 26
3B22 RIGHT VALVE OUTLET SECTION.................................. 2160 - 26
1B2 RIM WHEEL (10" X 24") .................................................. 0110 - 2 S
1B12 RIM, FRONT WHEEL (10" X 24" SPLIT RIM) ................ 0110 - 12
1B14 RIM, FRONT WHEEL (12" X 25" TIRE) .......................... 0110 - 14 3D21 SADDLE FRAME .............................................................. 3440 - 6
1B10 RIM, FRONT WHEEL (14" X 25").................................... 0110 - 10 3E19 SADDLE LOCK PIN AND HYDRAULIC HOSES ............ 3460 - 16
1B16 RIM, FRONT WHEEL (16" X 24").................................... 0110 - 16 3B8 SADDLE LOCK PIN PRESSURE REDUCING VALVE .. 2160 - 6
1B2 RIM, REAR WHEEL (10" X 24") ...................................... 0110 - 2 3B8 SADDLE LOCK PIN SOLENOID ...................................... 2160 - 6
1B8 RIM, REAR WHEEL (13" X 25") ...................................... 0110 - 8 3E19 SADDLE LOCKING PIN INDICATOR SWITCH .............. 3460 - 16
1B4 RIM, REAR WHEEL (14" X 25") (772D).......................... 0110 - 4 3C3 SCARIFIER AND AUXILIARY VALVE SECTION
1B4 RIM, REAR WHEEL (17" X 25") (772D).......................... 0110 - 4 (WITH FLOAT) .............................................................. 2160 - 32
1B6 RIM, REAR WHEEL (9" X 24") ........................................ 0110 - 6 2J9 SCARIFIER CONTROL LEVER........................................ 1810 - 42
1B6 RIM, WHEEL .................................................................... 0110 - 6 3F10 SCARIFIER CYLINDER .................................................... 4240 - 4
1B8 RIM, WHEEL .................................................................... 0110 - 8 3F10 SCARIFIER CYLINDER SEAL KIT .................................. 4240 - 4
1B2 RIM, WHEEL (10" X 24").................................................. 0110 - 2 3F20 SCARIFIER HOSES, FRONT .......................................... 4260 - 8
1B4 RIM, WHEEL (14" X 25") (770D) (772D) ........................ 0110 - 4 3F20 SCARIFIER HYDRAULIC HOSE KIT (FRONT) .............. 4260 - 8
1B4 RIM, WHEEL (17" X 25") (770D) (772D) ........................ 0110 - 4 3F22 SCARIFIER HYDRAULIC HOSES (REAR)...................... 4260 - 10
1J14 RING GEAR, FLYWHEEL ................................................ 0433 - 1 3F16 SCARIFIER TEETH, REAR .............................................. 4240 - 10
1H23 RING, ENGINE PISTON .................................................. 0403 - 1 3C3 SCARIFIER VALVE SECTION ........................................ 2160 - 32
1J1 RING, WATER PUMP RETAINING.................................. 0417 - 2 3F8 SCARIFIER, FRONT MOUNTED .................................... 4240 - 2
2J11 RIPPER CONTROL LEVER ............................................ 1810 - 44 3F12 SCARIFIER, REAR .......................................................... 4240 - 6
3F22 RIPPER HYDRAULIC HOSES ........................................ 4260 - 10 1G5 SCREEN, TRANSMISSION .............................................. 0350 - 12
3F12 RIPPER TEETH ................................................................ 4240 - 6 2C23 SEAL KIT, ARTICULATION CYLINDER .......................... 0960 - 6
3C1 RIPPER VALVE SECTION .............................................. 2160 - 30 3E23 SEAL KIT, BLADE IMPACT VALVE ................................ 3460 - 20
3F14 RIPPER/REAR SCARIFIER CYLINDER .......................... 4240 - 8 3E11 SEAL KIT, BLADE LIFT CYLINDER ................................ 3460 - 8
3F14 RIPPER/REAR SCARIFIER CYLINDER 3E13 SEAL KIT, BLADE SLIDE CYLINDER ............................ 3460 - 10
SEAL KIT ...................................................................... 4240 - 8 3E15 SEAL KIT, BLADE TILT CYLINDER ................................ 3460 - 12
3F22 RIPPER/REAR SCARIFIER HYDRAULIC 3E7 SEAL KIT, CIRCLE DRIVE MOTOR ................................ 3460 - 4
HOSES.......................................................................... 4260 - 10 3E9 SEAL KIT, CIRCLE SIDESHIFT CYLINDER .................. 3460 - 6
3F22 RIPPER/REAR SCARIFIER HYDRAULIC HOSE KIT .... 4260 - 10 2D1 SEAL KIT, FRONT STEERING CYLINDER .................... 0960 - 8
3F12 RIPPER, REAR ................................................................ 4240 - 6 1E17 SEAL KIT, HFWD CHARGE PUMP ................................ 0260 - 26
1H20 ROCKER ARM COVER CARRIER, ENGINE .................. 0402 - 4 1F5 SEAL KIT, HFWD ENGAGEMENT MANIFOLD .............. 0260 - 38
1H20 ROCKER ARM COVER, ENGINE.................................... 0402 - 4 1D24 SEAL KIT, HFWD MOTOR .............................................. 0260 - 8
1H18 ROCKER ARMS, ENGINE................................................ 0402 - 2 1E1 SEAL KIT, HFWD MOTOR .............................................. 0260 - 10
2J7 ROD, CAB CONTROL LEVER PIVOT ............................ 1810 - 40 1E7 SEAL KIT, HFWD PUMP.................................................. 0260 - 16
1H23 ROD, ENGINE CONNECTING ........................................ 0403 - 1 1E7 SEAL KIT, HFWD PUMP EP CONTROL ........................ 0260 - 16
2J7 ROD, HYDRAULIC CONTROL LEVER PIVOT .............. 1810 - 40 1E9 SEAL KIT, HFWD PUMP OVERHAUL ............................ 0260 - 18
1D6 ROD, TIE, FRONT AXLE (772D) .................................... 0240 - 4 3B4 SEAL KIT, MAIN HYDRAULIC PUMP ............................ 2160 - 2
1F12 ROD, TRANSMISSION SHIFTER GEAR ........................ 0315 - 4 3B8 SEAL KIT, MAIN MANIFOLD VALVE .............................. 2160 - 6
1H18 RODS, ENGINE PUSH .................................................... 0402 - 2 3F14 SEAL KIT, RIPPER/REAR SCARIFIER SEAL
3B12 RODS, MAIN HYDRAULIC CONTROL VALVE TIE ........ 2160 - 12 KIT ................................................................................ 4240 - 8
2I15 ROOF, CAB ...................................................................... 1810 - 24 3E5 SEAL KIT, ROTARY MANIFOLD .................................... 3460 - 2
3B14 ROTARY ACTUATOR, ARTICULATION 3F10 SEAL KIT, SCARIFIER CYLINDER.................................. 4240 - 4
VALVE SECTION.......................................................... 2160 - 18 2D16 SEAL KIT, SERVICE BRAKE VALVE .............................. 1060 - 2
I-14 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=18
 1A20 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

2D11 SEAL KIT, STEERING VALVE ........................................ 0960 - 18 1H18 SHAFT, ENGINE ROCKER ARM .................................... 0402 - 2
2C19 SEAL KIT, WHEEL LEAN CYLINDER (770D) ................ 0960 - 2 1G15 SHAFT, INPUT, FIFTH STAGE........................................ 0350 - 22
2C21 SEAL KIT, WHEEL LEAN CYLINDER (772D) ................ 0960 - 4 1G7 SHAFT, INPUT, FIRST STAGE........................................ 0350 - 14
1D14 SEAL, AXLE HOUSING OIL ............................................ 0250 - 6 1G13 SHAFT, INPUT, FOURTH STAGE .................................. 0350 - 20
1H22 SEAL, FRONT OIL............................................................ 0402 - 6 1G9 SHAFT, INPUT, SECOND STAGE .................................. 0350 - 16
1J15 SEAL, REAR OIL .............................................................. 0433 - 2 1G17 SHAFT, INPUT, SIXTH STAGE ...................................... 0350 - 24
1J1 SEAL, WATER PUMP ...................................................... 0417 - 2 1G11 SHAFT, INPUT, THIRD STAGE ...................................... 0350 - 18
2G11 SEALED SWITCH MODULE (SSM) ................................ 1674 - 24 1G19 SHAFT, OUTPUT, TRANSMISSION ................................ 0350 - 26
1C10 SEALS, INPUT YOKE ...................................................... 0210 - 2 3F8 SHANK, FRONT MOUNTED SCARIFIER........................ 4240 - 2
2J13 SEAT BRACKETS (AIR) .................................................. 1821 - 2 3F12 SHANK, REAR RIPPER .................................................. 4240 - 6
2J17 SEAT BRACKETS (MECHANICAL) ................................ 1821 - 6 3F16 SHANK, REAR SCARIFIER.............................................. 4240 - 10
2J13 SEAT CUSHION (AIR)...................................................... 1821 - 2 2H3 SHIELD, SIDE, BOTTOM GUARD (W/O RIPPER) ........ 1746 - 4
2J17 SEAT CUSHION (MECHANICAL) .................................... 1821 - 6 1H3 SHIFT SOLENOID, TRANSMISSION .............................. 0350 - 34
2J13 SEAT SUSPENSION (AIR) .............................................. 1821 - 2 1F12 SHIFTER, TRANSMISSION.............................................. 0315 - 4
2J15 SEAT SUSPENSION (AIR) .............................................. 1821 - 4 1H23 SHIM, ENGINE CYLINDER LINER .................................. 0403 - 1
2J17 SEAT SUSPENSION (MECHANICAL) ............................ 1821 - 6 2J7 SHOCK, CAB CONTROL LEVER CONSOLE GAS ........ 1810 - 40
2J19 SEAT SUSPENSION (MECHANICAL) ............................ 1821 - 8 1I1 SHORT BLOCK ASSEMBLY, ENGINE............................ 0404 - 4
2J15 SEAT SUSPENSION BOOT KIT (AIR) ............................ 1821 - 4 2B11 SHROUD, FAN.................................................................. 0510 - 4
2J19 SEAT SUSPENSION BOOT KIT (MECHANICAL) .......... 1821 - 8 2B13 SHROUD, FAN.................................................................. 0510 - 6
2J15 SEAT SUSPENSION SHOCK KIT (AIR).......................... 1821 - 4 2K20 SIDE COVERS, MAIN FRAME ........................................ 1913 - 2
2J19 SEAT SUSPENSION SHOCK KIT (MECHANICAL) ........ 1821 - 8 2H3 SIDE SHIELD, BOTTOM GUARD (W/O RIPPER) .......... 1746 - 4
2J15 SEAT, SUSPENSION (AIR).............................................. 1821 - 4 2H5 SIDE SHIELDS, BOTTOM GUARD (WITH RIPPER)...... 1746 - 6
2J19 SEAT, SUSPENSION (MECHANICAL) ............................ 1821 - 8 2I7 SIDE WINDOWS (OPENABLE)........................................ 1810 - 16
1G9 SECOND STAGE ASSEMBLY ........................................ 0350 - 16 3E9 SIDESHIFT CYLINDER, CIRCLE .................................... 3460 - 6
1G9 SECOND STAGE INPUT SHAFT .................................... 0350 - 16 2F3 SIGNAL LIGHTS, FRONT ................................................ 1673 - 4
1D12 SECOND STAGE PINION, HFWD MOTOR .................... 0250 - 4 2F3 SIGNAL LIGHTS, LED FRONT ........................................ 1673 - 4
2C17 SECONDARY STEERING ................................................ 0930 - 2 3B10 SIX FUNCTION HYDRAULIC CONTROL VALVE .......... 2160 - 10
2C17 SECONDARY STEERING ACCUMULATOR .................. 0930 - 2 3C7 SIXTH FUNCTION CONTROL VALVE KIT .................... 2160 - 36
2C17 SECONDARY STEERING HOSE .................................... 0930 - 2 1G17 SIXTH STAGE INPUT SHAFT ........................................ 0350 - 24
2C17 SECONDARY STEERING KIT ........................................ 0930 - 2 3F1 SLIDE CYLINDER HOSES .............................................. 3460 - 22
2C7 SENDER, FUEL TANK .................................................... 0560 - 2 3E13 SLIDE CYLINDER, BLADE .............................................. 3460 - 10
2B23 SENSOR, AIR FILTER RESTRICTION............................ 0520 - 2 3E3 SLIP CLUTCH, CIRCLE DRIVE GEARBOX AND .......... 3450 - 4
2G7 SENSOR, ARTICULATION .............................................. 1674 - 20 2L20 SMV SIGN ........................................................................ 2008 - 2
2C14 SENSOR, ENGINE AMBIENT AIR TEMPERATURE ...... 0578 - 4 2F1 SNOW LIGHT BRACKET WIRING HARNESS................ 1673 - 2
2C13 SENSOR, ENGINE COOLANT TEMPERATURE ............ 0578 - 3 2F1 SNOW LIGHT BRACKETS .............................................. 1673 - 2
2C15 SENSOR, ENGINE OIL PRESSURE .............................. 0578 - 5 2F1 SNOW LIGHT EXTENSION BRACKETS ........................ 1673 - 2
2C11 SENSOR, ENGINE SPEED .............................................. 0578 - 1 1J8 SOLENOID KIT, STARTING MOTOR .............................. 0422 - 2
1I19 SENSOR, FUEL INJECTION PUMP POSITION ............ 0413 - 2 3C13 SOLENOID VALVE, COLD START DISCONNECT
2C12 SENSOR, FUEL MOISTURE............................................ 0578 - 2 VALVE SECTION.......................................................... 2160 - 42
1I19 SENSOR, FUEL RAIL PRESSURE.................................. 0413 - 2 2D21 SOLENOID VALVE, PARK BRAKE.................................. 1111 - 2
1I19 SENSOR, G (FUEL INJECTION PUMP) ........................ 0413 - 2 3E23 SOLENOID, BLADE IMPACT VALVE .............................. 3460 - 20
1E1 SENSOR, HFWD MOTOR SPEED .................................. 0260 - 10 3C13 SOLENOID, COLD START DISCONNECT...................... 2160 - 42
1F3 SENSOR, HFWD PUMP PRESSURE.............................. 0260 - 36 2B5 SOLENOID, COLD WEATHER STARTING .................... 0505 - 4
1G3 SENSOR, SPEED, TRANS .............................................. 0350 - 8 1C16 SOLENOID, DIFFERENTIAL LOCK VALVE .................... 0210 - 8
1G3 SENSOR, TRANS OUTPUT SHAFT SPEED .................. 0350 - 8 1F5 SOLENOID, HFWD ENGAGEMENT ................................ 0260 - 38
1H3 SENSOR, TRANS TEMPERATURE ................................ 0350 - 34 1D24 SOLENOID, HFWD MOTOR ............................................ 0260 - 8
1J6 SENSORS, FUEL TEMPERATURE AND MOISTURE.... 0420 - 2 1E7 SOLENOID, HFWD PUMP EP CONTROL ...................... 0260 - 16
2C1 SEPARATOR .................................................................... 0520 - 4 3B8 SOLENOID, SADDLE LOCK PIN .................................... 2160 - 6
2D14 SEPARATOR PLATE, BRAKE ........................................ 1011 - 2 1H3 SOLENOID, TRANS SHIFT .............................................. 0350 - 34
2E23 SERPENTINE BELT.......................................................... 1672 - 2 2E4 SPANISH LABELS AND TRADEMARKS ........................ 1320 - 4
2D18 SERVICE BRAKE ACCUMULATOR AND HOSES ........ 1060 - 4 2E4 SPANISH TRADEMARKS AND LABELS ........................ 1320 - 4
2D18 SERVICE BRAKE HOSES................................................ 1060 - 4 2I9 SPEAKER GRILLE (CAB) ................................................ 1810 - 18
2D16 SERVICE BRAKE PEDAL ................................................ 1060 - 2 2I11 SPEAKER GRILLE (CANOPY) ........................................ 1810 - 20
2D16 SERVICE BRAKE VALVE ................................................ 1060 - 2 2L2 SPEAKERS........................................................................ 2001 - 2
2D16 SERVICE BRAKE VALVE SEAL KIT .............................. 1060 - 2 2B19 SPEED CONTROL PEDAL, ENGINE .............................. 0515 - 2
2D14 SERVICE BRAKES .......................................................... 1011 - 2 1E1 SPEED SENSOR, HFWD MOTOR .................................. 0260 - 10
2K16 SERVICE DOOR LATCH.................................................. 1910 - 2 1G3 SPEED SENSOR, TRANS................................................ 0350 - 8
2K16 SERVICE DOORS ............................................................ 1910 - 2 1C24 SPINDLE, STEERING (770D) .......................................... 0230 - 4
1E7 SERVO PISTON COVER, HFWD PUMP ........................ 0260 - 16 1D3 SPINDLE, STEERING (770D) .......................................... 0230 - 4
1D24 SERVO PISTON, HFWD MOTOR.................................... 0260 - 8 1C11 SPIRAL BEVEL GEAR AND SHAFT .............................. 0210 - 3
1E7 SERVO PISTON, HFWD PUMP ...................................... 0260 - 16 1I14 SPRING, ENGINE VALVE ................................................ 0409 - 2
3B10 SEVEN FUNCTION HYDRAULIC CONTROL VALVE .... 2160 - 10 1D14 SPROCKET, AXLE DRIVE .............................................. 0250 - 6
3C7 SEVENTH FUNCTION CONTROL VALVE KIT .............. 2160 - 36 1C8 SPROCKET, DRIVE.......................................................... 0201 - 4
1C11 SHAFT AND SPIRAL BEVEL GEAR .............................. 0210 - 3 2B5 START AID SWITCH, TEMPERATURE .......................... 0505 - 4
1C8 SHAFT, AXLE DRIVE ...................................................... 0201 - 4 2B5 STARTING AID, COLD WEATHER.................................. 0505 - 4
1C8 SHAFT, DRAIVE, FINAL DRIVE AND TANDEM 2B5 STARTING FLUID ............................................................ 0505 - 4
PIVOT............................................................................ 0201 - 4 1J8 STARTING MOTOR .......................................................... 0422 - 2
770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-15
PN=19
 1A21 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

2J3 STATIONARY CONSOLE, CAB FRONT ........................ 1810 - 36 2I19 SWITCH PANEL, ENGINE SPEED CONTROL
2I1 STATIONARY LOWER FRONT WINDOWS .................... 1810 - 12 (CANOPY) .................................................................... 1810 - 28
2I1 STATIONARY SIDE WINDOWS ...................................... 1810 - 12 2K13 SWITCH, A/C AND HEAT TEMPERATURE CONTROL 1830 - 18
2I1 STATIONARY WINDOWS ................................................ 1810 - 12 2K13 SWITCH, A/C AND HEATER FAN SPEED .................... 1830 - 18
2J5 STEERING COLUMN........................................................ 1810 - 38 2K13 SWITCH, A/C AND HEATER ON/OFF ............................ 1830 - 18
2D3 STEERING CYLINDER HOSES, FRONT ........................ 0960 - 10 2K13 SWITCH, A/C PRESSURE .............................................. 1830 - 18
1C22 STEERING CYLINDER PIN (770D) ................................ 0230 - 2 2D16 SWITCH, BRAKE LIGHT .................................................. 1060 - 2
2D1 STEERING CYLINDER, FRONT ...................................... 0960 - 8 2G13 SWITCH, DIFFERENTIAL LOCK...................................... 1674 - 26
1C24 STEERING SPINDLE (770D) .......................................... 0230 - 4 2G13 SWITCH, DRIVING LIGHT HIGH/LOW BEAM
1D3 STEERING SPINDLE (770D) .......................................... 0230 - 4 SWITCH ........................................................................ 1674 - 26
2D11 STEERING VALVE............................................................ 0960 - 18 2B19 SWITCH, ENGINE SPEED CONTROL ON/OFF ............ 0515 - 2
2D11 STEERING VALVE HOSES.............................................. 0960 - 18 2B19 SWITCH, ENGINE SPEED CONTROL SET.................... 0515 - 2
2D11 STEERING VALVE SEAL KIT .......................................... 0960 - 18 3D3 SWITCH, FILTER RESTRICTION, MAIN
2J5 STEERING WHEEL .......................................................... 1810 - 38 HYDRAULIC FILTER.................................................... 2164 - 2
2J5 STEERING WHEEL COVER ............................................ 1810 - 38 2G13 SWITCH, HAZARD WARNING LIGHT ............................ 1674 - 26
1B2 STEM, VALVE WHEEL (10" X 24") ................................ 0110 - 2 2G5 SWITCH, HFWD AGRESSIVENESS................................ 1674 - 18
1B12 STEM, VALVE, FRONT WHEEL (10" X 24" 2G5 SWITCH, HFWD INCHING MODE .................................. 1674 - 18
SPLIT RIM) .................................................................. 0110 - 12 2G5 SWITCH, HFWD ON/OFF ................................................ 1674 - 18
1B14 STEM, VALVE, FRONT WHEEL (12" X 25" 2G13 SWITCH, HORN................................................................ 1674 - 26
TIRE) ............................................................................ 0110 - 14 2G13 SWITCH, IGNITION .......................................................... 1674 - 26
1B10 STEM, VALVE, FRONT WHEEL (14" X 25") .................. 0110 - 10 3D3 SWITCH, MAIN HYD FILTER PRESSURE .................... 2164 - 2
1B16 STEM, VALVE, FRONT WHEEL (16" X 24") .................. 0110 - 16 2D21 SWITCH, PARK BRAKE PRESSURE.............................. 1111 - 2
1B2 STEM, VALVE, REAR WHEEL (10" X 24") .................... 0110 - 2 3E19 SWITCH, SADDLE LOCKING PIN INDICATOR.............. 3460 - 16
1B8 STEM, VALVE, REAR WHEEL (13" X 25") .................... 0110 - 8 2B5 SWITCH, TEMPERATURE, COLD WEATHER START
1B4 STEM, VALVE, REAR WHEEL (14" X 25") AID ................................................................................ 0505 - 4
(772D) .......................................................................... 0110 - 4 1H6 SWITCH, TRANSMISSION OIL FILTER
1B4 STEM, VALVE, REAR WHEEL (17" X 25") RESTRICTION .............................................................. 0360 - 2
(772D) .......................................................................... 0110 - 4 2G13 SWITCH, TURN SIGNAL.................................................. 1674 - 26
1B6 STEM, VALVE, REAR WHEEL (9" X 24") ...................... 0110 - 6 3B8 SYSTEM RELIEF VALVE, MAIN MANIFOLD.................. 2160 - 6
1B6 STEM, VALVE, WHEEL.................................................... 0110 - 6
1B2 STEM, VALVE, WHEEL (10" X 24") ................................ 0110 - 2
1B8 STEM, VALVE, WHEEL (13" X 25") ................................ 0110 - 8 T
1B4 STEM, VALVE, WHEEL (14" X 25") (770D)
(772D) .......................................................................... 0110 - 4 2F5 TAIL LIGHT WIRING HARNESS...................................... 1673 - 6
1B4 STEM, VALVE, WHEEL (17" X 25") (770D) 2F5 TAIL LIGHTS .................................................................... 1673 - 6
(772D) .......................................................................... 0110 - 4 1D16 TANDEM DRIVE .............................................................. 0250 - 8
1C6 STEP, TANDEM HOUSING.............................................. 0201 - 2 1D14 TANDEM DRIVE CHAIN .................................................. 0250 - 6
2J21 STEPS, CAB .................................................................... 1822 - 2 1D16 TANDEM DRIVE PLANETARY ........................................ 0250 - 8
1I16 STRAP, ENGINE LIFT ...................................................... 0409 - 4 1C6 TANDEM HOUSING.......................................................... 0201 - 2
2E21 STRAPS, GROUNDING.................................................... 1671 - 2 1C6 TANDEM HOUSING COVERS ........................................ 0201 - 2
1E19 SUCTION HOSE, HFWD CHARGE PUMP .................... 0260 - 28 1C8 TANDEM PIVOT................................................................ 0201 - 4
1E15 SUCTION HOSE, HFWD PUMP ...................................... 0260 - 24 2C7 TANK, FUEL...................................................................... 0560 - 2
3C23 SUCTION HOSE, MAIN HYDRAULIC PUMP (770D) .... 2163 - 6 1F10 TCU.................................................................................... 0315 - 2
3D1 SUCTION HOSE, MAIN HYDRAULIC PUMP (772D) .... 2163 - 8 3F8 TEETH, FRONT MOUNTED SCARIFIER ........................ 4240 - 2
1G3 SUCTION SCREEN, TRANSMISSION ............................ 0350 - 8 3F16 TEETH, REAR SCARIFIER .............................................. 4240 - 10
1G3 SUCTION TUBE, TRANSMISSION .................................. 0350 - 8 3F12 TEETH, RIPPER .............................................................. 4240 - 6
2L16 SUNSHADE, REAR WINDOW ........................................ 2007 - 2 2K7 TEMPERATURE CONTROL CABLE................................ 1830 - 12
2L18 SUNSHADE, REAR WINDOW ........................................ 2007 - 4 2C14 TEMPERATURE SENSOR, ENGINE AMBIENT AIR ...... 0578 - 4
2L16 SUNVISOR, REAR WINDOW .......................................... 2007 - 2 2C13 TEMPERATURE SENSOR, ENGINE COOLANT ............ 0578 - 3
2L18 SUNVISOR, REAR WINDOW .......................................... 2007 - 4 1J6 TEMPERATURE SENSOR, FUEL.................................... 0420 - 2
2B11 SUPPORT, COOLING PACKAGE.................................... 0510 - 4 1F3 TEMPERATURE SENSOR, HFWD ENGAGEMENT
2B13 SUPPORT, COOLING PACKAGE.................................... 0510 - 6 MANIFOLD.................................................................... 0260 - 36
2C7 SUPPORT, FUEL TANK .................................................. 0560 - 2 2B5 TEMPERATURE SWITCH,COLD WEATHER STARTING
2K18 SUPPORT, HOOD ............................................................ 1910 - 4 AID ................................................................................ 0505 - 4
2B11 SUPPORT, RADIATOR .................................................... 0510 - 4 1J10 TENSIONER, BELT .......................................................... 0423 - 2
2B13 SUPPORT, RADIATOR .................................................... 0510 - 6 2B17 TENSIONER, FAN BELT .................................................. 0512 - 2
2C5 SUPPORTS, ENGINE MOUNTING .................................. 0540 - 2 1J3 THERMOSTAT, ENGINE COOLANT .............................. 0418 - 2
2J15 SUSPENSION SEAT (AIR) .............................................. 1821 - 4 2K7 THERMOSTAT, HEATER AND A/C ................................ 1830 - 12
2J19 SUSPENSION SEAT (MECHANICAL) ............................ 1821 - 8 1G11 THIRD STAGE ASSEMBLY, TRANSMISSION................ 0350 - 18
2J13 SUSPENSION, SEAT (AIR).............................................. 1821 - 2 1G11 THIRD STAGE INPUT SHAFT ........................................ 0350 - 18
2J17 SUSPENSION, SEAT (MECHANICAL) ............................ 1821 - 6 1H16 THRUST BEARING, ENGINE .......................................... 0401 - 2
1E1 SWASH PLATE, HFWD MOTOR .................................... 0260 - 10 1H16 THRUST WASHER, ENGINE .......................................... 0401 - 2
1E5 SWASH PLATE, HFWD PUMP ........................................ 0260 - 14 1D1 TIE ROD END, FRONT AXLE (770D) ............................ 0230 - 6
3B4 SWASHPLATE, MAIN HYDRAULIC PUMP .................... 2160 - 2 1D6 TIE ROD END, FRONT AXLE (772D) ............................ 0240 - 4
2I21 SWITCH PANEL, ENGINE SPEED CONTROL 1D1 TIE ROD, FRONT AXLE (770D) ...................................... 0230 - 6
(CAB) ............................................................................ 1810 - 30 1D6 TIE ROD, FRONT AXLE (772D) ...................................... 0240 - 4
3B12 TIE RODS, MAIN HYDRAULIC CONTROL VALVE ........ 2160 - 12
I-16 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=20
 1A22 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

1J10 TIGHTENER, BELT .......................................................... 0423 - 2 1H3 TRANSMISSION TEMPERATURE SENSOR .................. 0350 - 34
2J7 TILT CONSOLE, CAB ...................................................... 1810 - 40 1G11 TRANSMISSION THIRD STAGE ASSEMBLY ................ 0350 - 18
3F1 TILT CYLINDER HOSES .................................................. 3460 - 22 1G9 TRANSMISSION UNIVERSAL DRIVESHAFT.................. 0350 - 16
3E15 TILT CYLINDER, BLADE.................................................. 3460 - 12 1G11 TRANSMISSION UNIVERSAL DRIVESHAFT.................. 0350 - 18
1H22 TIMING GEAR COVER .................................................... 0402 - 6 1G13 TRANSMISSION UNIVERSAL DRIVESHAFT.................. 0350 - 20
2L14 TOOLBOX.......................................................................... 2005 - 2 1G15 TRANSMISSION UNIVERSAL DRIVESHAFT.................. 0350 - 22
2L14 TOOLBOX TRAY .............................................................. 2005 - 2 1H8 TRANSMISSION VALVE GUARD .................................... 0360 - 4
2G24 TOP COVER, MAIN FRAME ............................................ 1740 - 6 1G21 TRANSMISSION WET BRAKE ........................................ 0350 - 28
1F16 TORSIONAL DAMPENER ................................................ 0325 - 2 2G1 TRANSMISSION WIRING HARNESS .............................. 1674 - 14
1J12 TORSIONAL DAMPENER ................................................ 0429 - 1 1G23 TRANSMISSION YOKE .................................................... 0350 - 30
1F16 TORSIONAL ISOLATOR .................................................. 0325 - 2 2K5 TRAY, CAB........................................................................ 1830 - 10
2B17 TOWER, FAN .................................................................... 0512 - 2 2L14 TRAY, TOOLBOX.............................................................. 2005 - 2
2E2 TRADEMARKS AND LABELS, ENGLISH........................ 1320 - 2 1F21 TROUGH, TRANS CASE OIL (770D) .............................. 0350 - 2
2E6 TRADEMARKS AND LABELS, FRENCH ........................ 1320 - 6 1F23 TROUGH, TRANS CASE OIL (772D) .............................. 0350 - 4
2E4 TRADEMARKS AND LABELS, SPANISH........................ 1320 - 4 1J3 TUBE, ENGINE COOLANT THERMOSTAT HOUSING .. 0418 - 2
1F21 TRANS CASE OIL TROUGH (770D) .............................. 0350 - 2 1J5 TUBE, ENGINE OIL COOLER ........................................ 0419 - 1
1F23 TRANS CASE OIL TROUGH (772D) .............................. 0350 - 4 1I13 TUBE, ENGINE OIL COOLER BYPASS.......................... 0407 - 10
1H1 TRANS CONTROL VALVE GASKET .............................. 0350 - 32 1I5 TUBE, ENGINE OIL DIPSTICK ........................................ 0407 - 1
1F12 TRANS GEAR SELECTOR COVER ................................ 0315 - 4 1I11 TUBE, ENGINE OIL FILTER HOUSING .......................... 0407 - 8
1G3 TRANS OUTPUT SHAFT SPEED SENSOR .................. 0350 - 8 1F18 TUBE, TRANSMISSION OIL DIPSTICK .......................... 0341 - 2
1F20 TRANSMISSION (COMPLETE) ........................................ 0350 - 1 1I24 TURBOCHARGER AND OIL LINES ................................ 0416 - 2
1H10 TRANSMISSION ACCUMULATOR .................................. 0363 - 2 2G13 TURN SIGNAL SWITCH .................................................. 1674 - 26
1G21 TRANSMISSION BRAKE .................................................. 0350 - 28
1G3 TRANSMISSION CASE BOLTS ...................................... 0350 - 8
1G3 TRANSMISSION CASE HARDWARE .............................. 0350 - 8 U
1G1 TRANSMISSION CASE, REAR ........................................ 0350 - 6
1G9 TRANSMISSION CLUTCH PLATE .................................. 0350 - 16 2F13 UNDER CAB WORK LIGHTS .......................................... 1673 - 14
1G11 TRANSMISSION CLUTCH PLATE .................................. 0350 - 18 1G9 UNIVERSAL DRIVESHAFT, TRANSMISSION ................ 0350 - 16
1G13 TRANSMISSION CLUTCH PLATE .................................. 0350 - 20 1G11 UNIVERSAL DRIVESHAFT, TRANSMISSION ................ 0350 - 18
1G15 TRANSMISSION CLUTCH PLATE .................................. 0350 - 22 1G13 UNIVERSAL DRIVESHAFT, TRANSMISSION ................ 0350 - 20
1F10 TRANSMISSION CONTROL UNIT .................................. 0315 - 2 1G15 UNIVERSAL DRIVESHAFT, TRANSMISSION ................ 0350 - 22
1F10 TRANSMISSION CONTROL UNIT MOUNTING 1C20 UNIVERSAL JOINT, DRIVESHAFT.................................. 0225 - 2
BRACKET...................................................................... 0315 - 2
1H3 TRANSMISSION CONTROL VALVE................................ 0350 - 34
1H6 TRANSMISSION CONTROL VALVE DIAGNOSTIC V
FITTING ........................................................................ 0360 - 2
1H1 TRANSMISSION CONTROL VALVE MOUNTING .......... 0350 - 32 1H20 VALVE COVER, ENGINE ................................................ 0402 - 4
1F10 TRANSMISSION CONTROLLER...................................... 0315 - 2 1H8 VALVE GUARD, TRANSMISSION .................................. 0360 - 4
1F18 TRANSMISSION DIPSTICK TUBE .................................. 0341 - 2 3C15 VALVE MOUNTING BRACKETS, MAIN CONTROL ...... 2160 - 44
1G15 TRANSMISSION FIFTH STAGE ASSEMBLY.................. 0350 - 22 3B14 VALVE SECTION, ARTICULATION ................................ 2160 - 18
1H6 TRANSMISSION FILTER.................................................. 0360 - 2 3C3 VALVE SECTION, AUXILIARY (WITH FLOAT) .............. 2160 - 32
1H6 TRANSMISSION FILTER HEAD ...................................... 0360 - 2 3C5 VALVE SECTION, AUXILIARY (WITHOUT FLOAT) ...... 2160 - 34
1H6 TRANSMISSION FILTER HOSES.................................... 0360 - 2 3B20 VALVE SECTION, BLADE LIFT ...................................... 2160 - 24
1G7 TRANSMISSION FIRST STAGE ASSEMBLY ................ 0350 - 14 3B18 VALVE SECTION, BLADE SIDE SHIFT .......................... 2160 - 22
1G13 TRANSMISSION FOURTH STAGE ASSEMBLY ............ 0350 - 20 3B16 VALVE SECTION, CIRCLE ROTATE .............................. 2160 - 20
1F12 TRANSMISSION GEAR SELECTOR .............................. 0315 - 4 3B14 VALVE SECTION, CIRCLE SIDE SHIFT ........................ 2160 - 18
1F12 TRANSMISSION GEAR SHIFT ROD .............................. 0315 - 4 3B24 VALVE SECTION, INLET (LEFT) .................................... 2160 - 28
1F12 TRANSMISSION GEAR SHIFT SELECTOR .................. 0315 - 4 3B22 VALVE SECTION, INLET (RIGHT) .................................. 2160 - 26
1G5 TRANSMISSION HOUSING ............................................ 0350 - 12 3B24 VALVE SECTION, OUTLET (LEFT) ................................ 2160 - 28
1G1 TRANSMISSION HOUSING, REAR ................................ 0350 - 6 3B22 VALVE SECTION, OUTLET (RIGHT) .............................. 2160 - 26
1H10 TRANSMISSION OIL COOLER HOSES.......................... 0363 - 2 3C1 VALVE SECTION, RIPPER .............................................. 2160 - 30
1H10 TRANSMISSION OIL COOLER HOSES AND 3C3 VALVE SECTION, SCARIFIER ........................................ 2160 - 32
ACCUMULATOR .......................................................... 0363 - 2 3B14 VALVE SECTION, WHEEL LEAN .................................... 2160 - 18
1F18 TRANSMISSION OIL DIPSTICK AND FLYWHEEL 1B12 VALVE STEM, FRONT WHEEL (10" X 24" SPLIT
HOUSING DRAIN ........................................................ 0341 - 2 RIM) .............................................................................. 0110 - 12
1H6 TRANSMISSION OIL FILTER RESTRICTION 1B14 VALVE STEM, FRONT WHEEL (12" X 25"
SWITCH ........................................................................ 0360 - 2 TIRE) ............................................................................ 0110 - 14
1G19 TRANSMISSION OUTPUT .............................................. 0350 - 26 1B10 VALVE STEM, FRONT WHEEL (14" X 25") .................. 0110 - 10
1G19 TRANSMISSION OUTPUT SHAFT .................................. 0350 - 26 1B16 VALVE STEM, FRONT WHEEL (16" X 24") .................. 0110 - 16
1G5 TRANSMISSION SCREEN .............................................. 0350 - 12 1B2 VALVE STEM, REAR WHEEL (10" X 24")...................... 0110 - 2
1G9 TRANSMISSION SECOND STAGE ASSEMBLY ............ 0350 - 16 1B8 VALVE STEM, REAR WHEEL (13" X 25")...................... 0110 - 8
1H3 TRANSMISSION SHIFT SOLENOID................................ 0350 - 34 1B4 VALVE STEM, REAR WHEEL (14" X 25")
1F12 TRANSMISSION SHIFTER .............................................. 0315 - 4 (772D) .......................................................................... 0110 - 4
1G17 TRANSMISSION SIXTH STAGE ASSEMBLY ................ 0350 - 24 1B4 VALVE STEM, REAR WHEEL (17" X 25")
1G3 TRANSMISSION SUCTION SCREEN.............................. 0350 - 8 (772D) .......................................................................... 0110 - 4
1G3 TRANSMISSION SUCTION TUBE .................................. 0350 - 8 1B6 VALVE STEM, REAR WHEEL (9" X 24")........................ 0110 - 6
1F12 TRANSMISSION SWITCH BOX MODULE ...................... 0315 - 4 1B6 VALVE STEM, WHEEL .................................................... 0110 - 6
770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-17
PN=21
 1A23 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

1B2 VALVE STEM, WHEEL (10" X 24") ................................ 0110 - 2 1J1 VALVE, WATER PUMP DRAIN........................................ 0417 - 2
1B8 VALVE STEM, WHEEL (13" X 25") ................................ 0110 - 8 3B14 VALVE, WHEEL LEAN .................................................... 2160 - 18
1B4 VALVE STEM, WHEEL (14" X 25") (770D) 2G9 VEHICLE ELECTRICAL CENTER.................................... 1674 - 22
(772D) .......................................................................... 0110 - 4 1H20 VENTILATING SYSTEM, ENGINE .................................. 0402 - 4
1B4 VALVE STEM, WHEEL (17" X 25") (770D)
(772D) .......................................................................... 0110 - 4
3B14 VALVE, ARTICULATION .................................................. 2160 - 18 W
3C3 VALVE, AUXILIARY (WITH FLOAT) ................................ 2160 - 32
3C5 VALVE, AUXILIARY (WITHOUT FLOAT) ........................ 2160 - 34 1H16 WASHER, ENGINE THRUST .......................................... 0401 - 2
3E23 VALVE, BLADE IMPACT .................................................. 3460 - 20 1J1 WATER PUMP .................................................................. 0417 - 2
3B20 VALVE, BLADE LIFT ........................................................ 2160 - 24 2K7 WATER VALVE ................................................................ 1830 - 12
3B18 VALVE, BLADE SIDE SHIFT............................................ 2160 - 22 3D19 WEAR INSERTS, BLADE TILT FRAME .......................... 3440 - 4
3B14 VALVE, BLADE TILT ........................................................ 2160 - 18 2H9 WEIGHT, FRONT MOUNTED .......................................... 1749 - 2
2D16 VALVE, BRAKE ................................................................ 1060 - 2 1G21 WET BRAKE, TRANSMISSION........................................ 0350 - 28
3B16 VALVE, CIRCLE ROTATE................................................ 2160 - 20 1B2 WHEEL (10" X 24") (SPLIT RIM) .................................... 0110 - 2
3B14 VALVE, CIRCLE SIDE SHIFT .......................................... 2160 - 18 1B8 WHEEL (13" X 25" ONE-PIECE) .................................... 0110 - 8
3C13 VALVE, COLD START SOLENOID.................................. 2160 - 42 1B4 WHEEL (14" X 25") (770D) (772D).................................. 0110 - 4
1C16 VALVE, DIFFERENTIAL LOCK ........................................ 0210 - 8 1B4 WHEEL (17" X 25") (770D) (772D).................................. 0110 - 4
3C13 VALVE, DISCONNECT .................................................... 2160 - 42 1B6 WHEEL (9" X 24" ONE-PIECE) ...................................... 0110 - 6
1H24 VALVE, ENGINE COOLANT DRAIN................................ 0404 - 2 1B6 WHEEL (9" X 24") ............................................................ 0110 - 6
1I14 VALVE, ENGINE INTAKE AND EXHAUST .................... 0409 - 2 1C24 WHEEL BEARING, FRONT (770D) ................................ 0230 - 4
1J5 VALVE, ENGINE OIL COOLER BY-PASS ...................... 0419 - 1 1D3 WHEEL BEARING, FRONT (770D) ................................ 0230 - 4
1I11 VALVE, ENGINE OIL FILTER BYPASS .......................... 0407 - 8 1D22 WHEEL DRIVE, HFWD .................................................... 0260 - 6
1I6 VALVE, ENGINE OIL PAN DRAIN .................................. 0407 - 2 1C24 WHEEL HUB, FRONT (770D) .......................................... 0230 - 4
1I11 VALVE, ENGINE OIL PRESSURE REGULATING .......... 0407 - 8 1D3 WHEEL HUB, FRONT (770D) .......................................... 0230 - 4
1I19 VALVE, FUEL INJECTION PUMP CHECK...................... 0413 - 2 1D8 WHEEL LEAN BAR LINK (772D) .................................... 0240 - 6
1I19 VALVE, FUEL INJECTION PUMP OVERFLOW.............. 0413 - 2 2J9 WHEEL LEAN CONTROL LEVER .................................. 1810 - 42
1I19 VALVE, FUEL RAIL PRESSURE RELIEF...................... 0413 - 2 2C19 WHEEL LEAN CYLINDER (770D) .................................. 0960 - 2
1F5 VALVE, HFWD ENGAGEMENT SOLENOID .................. 0260 - 38 2C21 WHEEL LEAN CYLINDER (772D) .................................. 0960 - 4
1F5 VALVE, HFWD FLUSHING .............................................. 0260 - 38 2D9 WHEEL LEAN CYLINDER HOSES (770D) .................... 0960 - 16
1F5 VALVE, HFWD OPERATING CHARGE PRESSURE 2D7 WHEEL LEAN CYLINDER HOSES (772D) .................... 0960 - 14
REGULATING .............................................................. 0260 - 38 1C22 WHEEL LEAN LINK (770D).............................................. 0230 - 2
1E9 VALVE, HFWD PUMP PRESSURE OVERRIDE ............ 0260 - 18 1C22 WHEEL LEAN LINK PIN (770D) ...................................... 0230 - 2
3B14 VALVE, LOCKOUT, ARTICULATION VALVE 1C22 WHEEL LEAN PIN (770D)................................................ 0230 - 2
SECTION ...................................................................... 2160 - 18 3B14 WHEEL LEAN VALVE SECTION .................................... 2160 - 18
3C3 VALVE, LOCKOUT, AUXILIARY VALVE SECTION 2G3 WHEEL SPEED SENSOR WIRING HARNESS,
(WITH FLOAT) .............................................................. 2160 - 32 HFWD............................................................................ 1674 - 16
3C5 VALVE, LOCKOUT, AUXILIARY VALVE SECTION 1B4 WHEEL(14" X 25" AND 17" X 25" SPLIT RIM) .............. 0110 - 4
(WITHOUT FLOAT) ...................................................... 2160 - 34 1B12 WHEEL, FRONT (10" X 24" SPLIT RIM) ........................ 0110 - 12
3B20 VALVE, LOCKOUT, BLADE LIFT VALVE 1B14 WHEEL, FRONT (12" X 25")............................................ 0110 - 14
SECTION ...................................................................... 2160 - 24 1B10 WHEEL, FRONT (14" X 25")............................................ 0110 - 10
3B18 VALVE, LOCKOUT, BLADE SIDE SHIFT 1B16 WHEEL, FRONT (16" X 24") (772D) .............................. 0110 - 16
VALVE SECTION.......................................................... 2160 - 22 1B18 WHEEL, FRONT(17"X 25" SPLIT RIM) .......................... 0110 - 20
3B14 VALVE, LOCKOUT, BLADE TILT VALVE SECTION ...... 2160 - 18 1B2 WHEEL, REAR (10" X 24") (SPLIT RIM) ........................ 0110 - 2
3B14 VALVE, LOCKOUT, CIRCLE SIDE SHIFT VALVE 1B8 WHEEL, REAR (13" X 25") .............................................. 0110 - 8
SECTION ...................................................................... 2160 - 18 1B4 WHEEL, REAR (14" X 25") (772D).................................. 0110 - 4
3C1 VALVE, LOCKOUT, RIPPER VALVE SECTION ............ 2160 - 30 1B4 WHEEL, REAR (17" X 25") (772D).................................. 0110 - 4
3C3 VALVE, LOCKOUT, SCARIFIER VALVE SECTION........ 2160 - 32 1B6 WHEEL, REAR (9" X 24") ................................................ 0110 - 6
3B14 VALVE, LOCKOUT, WHEEL LEAN VALVE SECTION .. 2160 - 18 2J5 WHEEL, STEERING ........................................................ 1810 - 38
3B10 VALVE, MAIN HYDRAULIC CONTROL .......................... 2160 - 10 2L16 WINDOW SHADE, REAR ................................................ 2007 - 2
3B8 VALVE, MAIN HYDRAULIC MANIFOLD.......................... 2160 - 6 2J1 WINDOW, CAB DOOR (LEFT) ........................................ 1810 - 34
3B8 VALVE, MAIN MANIFOLD ................................................ 2160 - 6 2I23 WINDOW, CAB DOOR (RIGHT) ...................................... 1810 - 32
1E19 VALVE, NEUTRAL CHARGE PRESSURE 2I1 WINDOW, REAR .............................................................. 1810 - 12
REGULATING .............................................................. 0260 - 28 2I5 WINDOWS, FRONT OPENABLE .................................... 1810 - 14
1H3 VALVE, OIL COOLER BYPASS RELIEF ........................ 0350 - 34 2I5 WINDOWS, LOWER FRONT OPENABLE ...................... 1810 - 14
2D21 VALVE, PARK BRAKE...................................................... 1111 - 2 2I1 WINDOWS, LOWER FRONT STATIONARY .................. 1810 - 12
3B8 VALVE, PRESSURE REDUCING, SADDLE LOCK 2I7 WINDOWS, OPENABLE SIDE ........................................ 1810 - 16
PIN ................................................................................ 2160 - 6 2I7 WINDOWS, SIDE OPENABLE ........................................ 1810 - 16
3B20 VALVE, RELIEF, BLADE LIFT VALVE 2I1 WINDOWS, STATIONARY .............................................. 1810 - 12
SECTION ...................................................................... 2160 - 24 2I1 WINDOWS, STATIONARY SIDE...................................... 1810 - 12
3C1 VALVE, RIPPER................................................................ 2160 - 30 2I1 WINDSHIELD .................................................................... 1810 - 12
3C3 VALVE, SCARIFIER.......................................................... 2160 - 32 2I3 WINDSHIELD REPAIR KIT .............................................. 1810 - 13A
2D16 VALVE, SERVICE BRAKE................................................ 1060 - 2 2H17 WINDSHIELD WASHER RESERVOIR ............................ 1810 - 4
2D21 VALVE, SOLENOID, PARK BRAKE ................................ 1111 - 2 2H17 WINDSHIELD WIPER MOTOR, FRONT.......................... 1810 - 4
2D11 VALVE, STEERING .......................................................... 0960 - 18 2H19 WINDSHIELD WIPER MOTOR, REAR ............................ 1810 - 6
3B8 VALVE, SYSTEM RELIEF, MAIN MANIFOLD ................ 2160 - 6 2H17 WINDSHIELD WIPER, FRONT ........................................ 1810 - 4
2K7 VALVE, WATER ................................................................ 1830 - 12 2H19 WINDSHIELD WIPER, REAR .......................................... 1810 - 6
I-18 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=22
 1A24 770D/772D MOTOR GRADER
ALPHABETICAL INDEX - CONTINUED

GRID PAGE GRID PAGE

2H17 WIPER BLADE, FRONT WINDSHIELD .......................... 1810 - 4
2H21 WIPER BLADE, LOWER FRONT WINDSHIELD ............ 1810 - 8
2H19 WIPER BLADE, REAR WINDOW .................................... 1810 - 6
2H21 WIPER, WINDSHIELD LOWER FRONT.......................... 1810 - 8
2K13 WIRING HARNESS, A/C AND HEATER ........................ 1830 - 18
3E21 WIRING HARNESS, BLADE IMPACT VALVE ................ 3460 - 18
2F21 WIRING HARNESS, CAB INTERIOR .............................. 1674 - 8
2G13 WIRING HARNESS, CAB MONITOR UNIT .................... 1674 - 26
2F21 WIRING HARNESS, CAB POWER .................................. 1674 - 8
2F23 WIRING HARNESS, CAB ROOF .................................... 1674 - 10
2G13 WIRING HARNESS, CAB TILT CONSOLE .................... 1674 - 26
2G13 WIRING HARNESS, CMU ................................................ 1674 - 26
2F19 WIRING HARNESS, ENGINE .......................................... 1674 - 6
2B3 WIRING HARNESS, ENGINE AIR HEATER .................. 0505 - 2
2G3 WIRING HARNESS, FRONT HFWD................................ 1674 - 16
2F15 WIRING HARNESS, FRONT PLATFORM ...................... 1674 - 2
2F15 WIRING HARNESS, FRONT TURN/DRIVING
LIGHT............................................................................ 1674 - 2
1H20 WIRING HARNESS, FUEL INJECTION .......................... 0402 - 4
2G3 WIRING HARNESS, HFWD.............................................. 1674 - 16
2F15 WIRING HARNESS, MAIN (FRONT) .............................. 1674 - 2
2F17 WIRING HARNESS, MAIN (REAR).................................. 1674 - 4
2F21 WIRING HARNESS, RADIO SPEAKER .......................... 1674 - 8
2G3 WIRING HARNESS, REAR HFWD .................................. 1674 - 16
2F17 WIRING HARNESS, REAR PLATFORM ........................ 1674 - 4
2F1 WIRING HARNESS, SNOW LIGHT ................................ 1673 - 2
2F5 WIRING HARNESS, TAIL LIGHT .................................... 1673 - 6
2G1 WIRING HARNESS, TRANSMISSION ............................ 1674 - 14
2B5 WIRING HARNESS,COLD WEATHER STARTING AID 0505 - 4

1C20 YOKE, DRIVESHAFT........................................................ 0225 - 2

1D22 YOKE, HFWD.................................................................... 0260 - 6
1C10 YOKE, INPUT.................................................................... 0210 - 2
1G23 YOKE, TRANSMISSION .................................................. 0350 - 30

770D/772D MOTOR GRADER PC9449 (30-AUG-05) I-19

PN=23
 1B2 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
WHEEL (10" X 24" SPLIT RIM)
T200473 -UN-01JUN04

THIS PARTS LISTING IS CONTINUED

0110-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=24
 1B3 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
WHEEL (10" X 24" SPLIT RIM)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT25226 TIRE VALVE STEM 1 X X

2 AT43231 WHEEL 1 X 254MM X 610MM (10" X 24") (13-14 X 24
TIRE) (QUANTITY OF 6 PER MACHINE)
AT43231 WHEEL 1 X 254 MM X 610 MM (10" X 24") (13-14 X 24
TIRE) (QUANTITY OF 4 PER MACHINE) (USE
AS REAR WHEEL ONLY ON 772D)
3 T27183 WHEEL RING 1 X X WITH 254 MM X 610 MM (10" X 24") WHEEL
4 T59932 O-RING 1 X X 254 MM X 610 MM (10" X 24") WHEEL
5 T27184 WHEEL RING 1 X X WITH 254 MM X 610 MM (10" X 24") WHEEL
6 19H3158 CAP SCREW 14 X X 3/4" X 2"
7 T151797 WASHER 14 X X 0.812" X 1-7/8" X 0.245"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-3

PN=25
 1B4 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
WHEEL (14" X 25" AND 17" X 25" SPLIT RIM)
T200475 -UN-01JUN04

THIS PARTS LISTING IS CONTINUED

0110-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=26
 1B5 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
WHEEL (SPLIT RIM)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT25226 TIRE VALVE STEM 1 X X

2 AT68940 WHEEL 1 X X 356 MM X 635 MM (14" X 25") (17.5-25
TIRE) (QUANTITY OF 6 PER MACHINE)
AT68940 WHEEL 1 356 MM X 635 MM (14" X 25") (17.5-25
TIRE) (QUANTITY OF 4 PER MACHINE) (USE
AS REAR WHEEL ONLY ON 772D)
AT182580 RIM 1 X X 432 MM X 635 MM (17" X 25") (20.5-25
TIRE) (QUANTITY OF 6 PER MACHINE)
AT182580 RIM 1 432 MM X 635 MM (17" X 25") (20.5-25
TIRE) (QUANTITY OF 4 PER MACHINE) (USE
AS REAR WHEEL ONLY ON 772D)
3 T27193 WHEEL RING 1 X X WITH 356 MM X 635 MM (14" X 25") OR 432
MM X 635 MM (17" X 25") WHEEL
4 T59933 O-RING 1 X X WITH 356 MM X 635 MM (14"X 25") OR 432 MM
X 635 MM (17" X 25") WHEEL
5 T27194 WHEEL RING 1 X X WITH 356 MM X 635 MM (14" X 25") OR 432
MM X 635 MM (17" X 25") WHEEL
6 19H3158 CAP SCREW 14 X X 3/4" X 2"
7 T151797 WASHER 14 X X 0.812" X 1-7/8" X 0.245"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-5

PN=27
 1B6 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
WHEEL (9" X 24" ONE-PIECE)
T200485 -UN-02JUN04

THIS PARTS LISTING IS CONTINUED

0110-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=28
 1B7 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
WHEEL (9" X 24" ONE-PIECE)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT25226 TIRE VALVE STEM 1 X X

2 AT103567 WHEEL 1 X 229 MM X 610 MM (9" X 24") (13-14 X 24
TIRE) (QUANTITY OF 6 PER MACHINE)
AT103567 WHEEL 1 X 229 MM X 610 MM (9" X 24") (13 X 24 TIRE)
(QUANTITY OF 4 PER MACHINE) (FOR USE AS
REAR WHEEL ONLY ON 772D)
3 T151797 WASHER 14 X X 0.812" X 1-7/8" X 0.245"
4 19H3158 CAP SCREW 14 X X 3/4" X 2"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-7

PN=29
 1B8 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
WHEEL (13" X 25" ONE-PIECE)
T200485 -UN-02JUN04

THIS PARTS LISTING IS CONTINUED

0110-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=30
 1B9 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
WHEEL (13" X 25" ONE-PIECE)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT25226 TIRE VALVE STEM 1 X X

2 AT105608 WHEEL 1 X 330 MM X 635 MM (13" X 25") (15.5-17.5 X
25 TIRE) (QUANTITY OF 6 PER MACHINE)
AT105608 WHEEL 1 X 330 MM X 635 MM (13" X 25") (17.5-25
TIRE) (QUANTITY OF 4 PER MACHINE) (USE
AS REAR WHEEL ONLY ON 772D)
AT179099 WHEEL 1 X 406 MM X 610 MM (16" X 24") (18.4-24
TIRE) (QUANTITY OF 6 PER MACHINE)
AT179099 WHEEL 1 X 406 MM X 610 MM (16" X 24") (18.4-24
TIRE) (QUANTITY OF 4 PER MACHINE) (USE
AS REAR WHEEL ONLY ON 772D)
3 T151797 WASHER 14 X X 0.812" X 1-7/8" X 0.245"
4 19H3158 CAP SCREW 14 X X 3/4" X 2"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-9

PN=31
 1B10 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL (14" X 25" SPLIT RIM)
T200486 -UN-01JUN04

THIS PARTS LISTING IS CONTINUED

0110-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=32
 1B11 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL (14" X 25" SPLIT RIM)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT25226 TIRE VALVE STEM 1 X

2 AT190417 WHEEL 1 X 356 MM X 635 MM (14" X 25") (17.5-25
TIRE)
3 T27193 WHEEL RING 1 X
4 T59933 O-RING 1 X
5 T27194 WHEEL RING 1 X
6 19H3158 CAP SCREW 14 X 3/4" X 2"
7 T151797 WASHER 14 X 0.812" X 1-7/8" X 0.245"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-11

PN=33
 1B12 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL (10" X 24" SPLIT RIM)
T148646 -UN-03DEC01

THIS PARTS LISTING IS CONTINUED

0110-12 770D/772D MOTOR GRADER PC9449 (12-JAN-05)
PN=34
 1B13 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL (10" X 24" SPLIT RIM)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT197613 TIRE VALVE STEM 1 X

2 AT193866 WHEEL 1 X 254 MM X 610 MM (10" X 24") (13-14 X 24
TIRE)
3 T27183 WHEEL RING 1 X
4 T59932 O-RING 1 X
5 T27184 WHEEL RING 1 X
6 T151797 WASHER 14 X
7 19H3158 CAP SCREW 14 X 3/4" X 2"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-13

PN=35
 1B14 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL (10" X 24" SPLIT RIM)
T151782 -UN-22FEB02

THIS PARTS LISTING IS CONTINUED

0110-14 770D/772D MOTOR GRADER PC9449 (12-JAN-05)
PN=36
 1B15 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL (10" X 24" SPLIT RIM)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT197844 TIRE VALVE STEM 1 X WITH 305 MM X 635 MM (12" X 25") WHEEL
2 AT194842 WHEEL 1 X 305 MM X 635 MM (12" X 25") (15.5-25
TIRE)
3 T27193 WHEEL RING 1 X WITH 305 MM X 635 MM (12 X 25") WHEEL
4 T59933 O-RING 1 X WITH 305 MM X 635 MM (12" X 25") WHEEL
5 T27194 WHEEL RING 1 X WITH 305 MM X 635 MM (12" X 25") WHEEL
6 19H3158 CAP SCREW 14 X
7 T151797 WASHER 14 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-15

PN=37
 1B16 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL
T200583 -UN-03JUN04

THIS PARTS LISTING IS CONTINUED

0110-16 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=38
 1B17 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT25226 TIRE VALVE STEM 1 X

2 AT179249 WHEEL 1 X 406 MM X 610 MM (16" X 24") (18.4-24
TIRE)
3 24M7427 WASHER 16 X 15 X 24 X 2.500 MM (0.591" X 0.945" X
0.098")
4 19H1670 CAP SCREW 16 X 14.275 X 38.100 MM (9/16" X 1-1/2")

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-17

PN=39
 1B18 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL (17"X 25" SPLIT RIM)
T203377 -UN-15DEC04

THIS PARTS LISTING IS CONTINUED

0110-20 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=40
 1B19 WHEELS 1
POWERED WHEELS AND FASTENINGS 0110
FRONT WHEEL (17"X 25" SPLIT RIM)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT310377 RIM 1 X (635 MM X 602 MM) (25" X 17") RIM

2 T59933 O-RING 1 X
3 T212453 WHEEL RING 1 X
4 T212452 WHEEL RING 1 X
5 AT25226 TIRE VALVE STEM 1 X
6 R54124 WASHER 14 X
7 19H3158 CAP SCREW 14 X 3/4" X 2"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0110-21

PN=41
 1C6 AXLES AND SUSPENSION SYSTEMS 2
DRIVE AXLE HOUSING AND SUPPORT 0201
TANDEM HOUSING
T203244 -UN-17SEP04

THIS PARTS LISTING IS CONTINUED

0201-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=42
 1C7 AXLES AND SUSPENSION SYSTEMS 2
DRIVE AXLE HOUSING AND SUPPORT 0201
TANDEM HOUSING

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 H150941 CAP SCREW 32 X X

2 T158338 COVER 1 X X
3 T158340 GASKET 1 X X
4 T158514 PLATE 2 X X TOP
5 T158513 GASKET 2 X X TOP
6 AT305639 HOUSING 1 X X
7 U17409 O-RING 2 X X
8 T78662 DRAIN PLUG 4 X X (OIL DRAIN AND OIL LEVEL)
13 24M7239 WASHER 2 X X
14 T160368 STEP 1 X X
16 T158509 COVER 3 X X
17 T158511 GASKET 4 X X
18 T158510 COVER 1 X X
19 19M7402 CAP SCREW 2 X X M10 X 25
23 JD7838 ADAPTER 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0201-3

PN=43
 1C8 AXLES AND SUSPENSION SYSTEMS 2
DRIVE AXLE HOUSING AND SUPPORT 0201
FINAL DRIVE AND TANDEM PIVOT
T150727 -UN-04FEB02

THIS PARTS LISTING IS CONTINUED

0201-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=44
 1C9 AXLES AND SUSPENSION SYSTEMS 2
DRIVE AXLE HOUSING AND SUPPORT 0201
FINAL DRIVE AND TANDEM PIVOT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T157952 SNAP RING 3 X X

2 T157945 DRIVE SPROCKET 1 X X
3 JD8989 BEARING CONE 2 X X
4 JD8272 BEARING CUP 2 X X
5 19M7417 CAP SCREW 16 X X M16 X 65
6 24M7338 WASHER 16 X X
7 T157944 RETAINER 1 X X
8 T158335 SHIM AR X X .07 MM
9 T158334 SHIM AR X X .2 MM
10 T158492 THRUST WASHER 3 X X
11 T157943 PIVOT 1 X X (TANDEM)
12 T71306 ORIFICE 1 X X
13 JD7781 LUBRICATION FITTING 1 X X
14 R135543 WASHER 22 X X
15 19M7488 CAP SCREW 22 X X M16 X 40
16 T158332 BUSHING 2 X X
17 T157942 DRIVE SHAFT 1 X X (TANDEM)
18 T158492 THRUST WASHER 3 X X
19 T206434 O-RING 2 X X
20 T157941 HOUSING 1 X X (FINAL DRIVE AXLE)
21 19M8190 CAP SCREW 12 X X M16 X 180
22 R135543 WASHER 12 X X
23 U17409 O-RING 1 X X
24 T78662 DRAIN PLUG 1 X X
25 AR75527 SEAL 1 X X
26 T41677 O-RING 1 X X
27 19M7889 CAP SCREW 4 X X M24 X 80
28 24M7294 WASHER 4 X X
29 19M7892 CAP SCREW 3 X X M20 X 80
30 24M7242 WASHER 3 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0201-5

PN=45
 1C10 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
INPUT YOKE
RXP021502 -UN-12MAR97

7 7
7 7
AXLE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE45315 SEAL KIT 1 X X

R100500 SEAL 1 X X
2 RE45317 KIT 1 X X

0210-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=46
 1C11 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
SPIRAL BEVEL INPUT PINION AND RING GEAR SET
RXP6492 -UN-01JAN94

7 7
7 7
AXLE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ120662 RING GEAR AND PINION 1 X X (MARKED YZ120661 AND YZ120589) (ALSO
ORDER RE50114) (SUB YZ120595) R.H.
ASSEMBLY
YZ120167 WASHER 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0210-3

PN=47
 1C12 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
INPUT QUILL ASSEMBLY

RXP9482 -UN-01JAN94

THIS PARTS LISTING IS CONTINUED

0210-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=48
 1C13 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
INPUT QUILL ASSEMBLY

7 7
7 7
AXLE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE49486 TAPERED ROLLER BEARING 1 X X

2 R35365 SHIM AR X X
R35366 SHIM AR X X
R35367 SHIM AR X X
3 R26448 O-RING 2 X X
4 R27218 FITTING PLUG 2 X X
5 R135543 WASHER 15 X X
6 19M7409 CAP SCREW 15 X X
7 F3171R O-RING 2 X X
8 R27175 DRAIN PLUG 2 X X
9 R116261 COVER 1 X X (SUB R126117)
10 R51196 SHIM AR X X
R51197 SHIM AR X X
R51198 SHIM AR X X
R51199 SHIM AR X X
11 R56308 WASHER 1 X X
12 JD8255 BEARING CUP 1 X X
13 JD9078 BEARING CONE 1 X X
14 RE45315 SEAL KIT 1 X X
R100500 SEAL 1 X X
15 A4540R O-RING 1 X X
16 R48733 WASHER AR X X
R48734 WASHER AR X X
R48735 WASHER AR X X
17 R48776 NUT 1 X X
18 11M7032 COTTER PIN 1 X X 5 X 50 MM
.. UN7189 SEALANT 1 X X (SUB TY16021)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0210-5

PN=49
 1C14 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
DIFFERENTIAL CASE
RXP021560 -UN-30MAY96

THIS PARTS LISTING IS CONTINUED

0210-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=50
 1C15 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
DIFFERENTIAL CASE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R26375 O-RING 1 X X
2 R39112 FITTING 1 X X
3 RE62981 PRESSURE RELIEF VALVE 1 X X
4 R112210 ADAPTER 1 X X
5 U17409 O-RING 1 X X
6 R132574 STRUCTURAL TUBING 1 X X
7 15H666 PIPE PLUG 1 X X
8 U17409 O-RING 1 X X
9 R26448 O-RING 2 X X
10 R106789 BUSHING 2 X X
11 YZ120455 PLUG 2 X X
12 R21612 BLEED VALVE 2 X X
13 F3171R O-RING 1 X X
14 R116801 PIPE PLUG 1 X X
15 R27175 DRAIN PLUG 1 X X
16 F3171R O-RING 1 X X
17 R116801 PIPE PLUG 1 X X
18 F3171R O-RING 1 X X
19 R27315 DOWEL PIN 4 X X
20 R84262 FITTING PLUG 1 X X
21 F3171R O-RING 1 X X
22 R375R O-RING 2 X X
23 YZ120522 CASE 1 X X LOW PRESSURE WITH VALVE

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0210-7

PN=51
 1C16 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
DIFFERENTIAL LOCK WITH VALVE
T212903 -UN-20JUL05

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ120442 HOUSING 1 X X
2 R27175 DRAIN PLUG 1 X X
3 F3171R O-RING 1 X X
4 F37010020 O-RING 1 X X
5 24M7028 WASHER 4 X X
6 19M7328 CAP SCREW 4 X X
7 R28782 O-RING 1 X X
8 AH125760 HYD. QUICK-CONNECT COUPLER 1 X X
9 YZ120826 OIL LINE 1 X X
10 F37020153 O-RING 1 X X
11 F37010010 O-RING 1 X X
12 R26287 O-RING 1 X X
13 19M7887 SCREW 2 X X
14 AT303799 VALVE 1 X X
AT224873 SEAL KIT 1 X X
15 R77175 COVER 1 X X

0210-8 770D/772D MOTOR GRADER PC9449 (30-AUG-05)

PN=52
 1C17 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
DIFFERENTIAL CASE OIL LINE
RXP021510 -UN-13MAR97

7 7
7 7
AXLE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T80938 ADAPTER 1 X X
2 T77814 O-RING 2 X X
3 YZ120508 OIL LINE 1 X X LOW PRESSURE
4 R115176 ADAPTER 1 X X
5 R26287 O-RING 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0210-9

PN=53
 1C18 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
DIFFERENTIAL
YZ120447D -UN-22NOV04

THIS PARTS LISTING IS CONTINUED

0210-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=54
 1C19 AXLES AND SUSPENSION SYSTEMS 2
DIFFERENTIAL OR BEVEL DRIVE 0210
DIFFERENTIAL

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 400R BALL 2 X X
2 34H328 SPRING PIN 3 X X
3 YZ120398 SPRING 3 X X
4 YZ120913 HOUSING 1 X X (ALSO ORDER 34M7224) (MARKED YZ120859)
5 R34858 CLUTCH PLATE 5 X X
6 RE53823 DISK 5 X X
7 R34857 CLUTCH PLATE 1 X X
8 R60038 PACKING 2 X X
9 34M7224 SPRING PIN 1 X X USE WITH COVER MARKED YZ120858 AND
HOUSING MARKED YZ120859- ONLY
10 R95116 PISTON 1 X X
11 YZ120912 COVER 1 X X (MARKED YZ120859)
12 R116214 SCREW 12 X X
13 R93623 THRUST WASHER 2 X X
14 YZ120386 BEVEL GEAR 1 X X
15 R70111 PINION SHAFT 2 X X
16 YZ120471 RING 4 X X
17 R70113 THRUST WASHER 4 X X
18 R134726 PINION 1 X X
19 R70115 NEEDLE ROLLER 26 X X
20 R70112 THRUST WASHER 4 X X
21 R59460 THRUST WASHER 4 X X
22 YZ120909 SPRING PIN 1 X X (SUB FOR 34H171)
23 YZ120690 HOUSING 1 X X (MARKED YZ120503)
24 H871R BALL 2 X X (ALSO ORDER YZ120909) (SUB FOR H871)
25 24H1111 WASHER 8 X X
26 19H2668 CAP SCREW 8 X X
27 R59289 BEVEL GEAR 1 X X
28 R112210 ADAPTER 1 X X
29 .................. PLUG 1 X X R116373 NO LONGER AVAILABLE (FURNISH
15H563 )
30 U17409 O-RING 1 X X
31 R132574 STRUCTURAL TUBING 1 X X
32 R85226 WASHER 12 X X
33 19H3718 CAP SCREW 12 X X
34 R130036 DEFLECTOR 1 X X
35 T106596 SCREW 2 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 0210-11

PN=55
 1C20 AXLES AND SUSPENSION SYSTEMS 2
INPUT DRIVE SHAFTS AND U-JOINTS
DRIVESHAFT
T200588 -UN-02JUN04

THIS PARTS LISTING IS CONTINUED

0225-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=56
 1C21 AXLES AND SUSPENSION SYSTEMS 2
INPUT DRIVE SHAFTS AND U-JOINTS
DRIVESHAFT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3752 CAP SCREW 8 X X 1/2" X 2-1/8"

2 AT199661 DRIVE SHAFT 1 X X
3 AT199084 CROSS AND BEARING ASSEMBLY 2 X X
4 T191021 YOKE 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0225-3

PN=57
 1C22 AXLES AND SUSPENSION SYSTEMS 2
NON-POWERED WHEELS 0230
FRONT AXLE AND WHEEL LEAN LINK (770D)
T193519 -UN-07AUG03

THIS PARTS LISTING IS CONTINUED

0230-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=58
 1C23 AXLES AND SUSPENSION SYSTEMS 2
NON-POWERED WHEELS 0230
FRONT AXLE AND WHEEL LEAN LINK (770D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 40M1863 SNAP RING 4 X

2 AT101224 BUSHING 2 X
3 T33933 BUSHING 2 X
4 AT313342 FRONT AXLE SUPPORT 1 X
5 24H1595 WASHER 2 X
6 AT313362 PIN 1 X
7 28H3401 SPACER 1 X
8 T146246 WASHER 1 X
9 19M7489 CAP SCREW 1 X M16 X 45
10 T75644 ADAPTER 5 X
11 E12379 NUT 5 X
12 JD7759 LUBRICATION FITTING 4 X
13 24H1595 WASHER 2 X
14 JD7797 LUBRICATION FITTING 5 X
15 AT193885 LINK 1 X
16 T41961 BUSHING 2 X
17 T152859 PIN 2 X
18 JD7798 LUBRICATION FITTING 2 X
19 AT314624 PIN 1 X
20 T209581 SHIM 3 X
21 28H3401 SPACER 1 X
22 T146246 WASHER 1 X
23 T152862 PIN 1 X
24 19H1912 CAP SCREW 1 X 3/8" X 3-1/2"
25 19M7489 CAP SCREW 1 X M16 X 45
26 T11234 LOCK NUT 1 X
27 JD7781 LUBRICATION FITTING 1 X
28 JD7759 LUBRICATION FITTING 1 X
29 H80936 ELBOW FITTING 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0230-3

PN=59
 1C24 AXLES AND SUSPENSION SYSTEMS 2
NON-POWERED WHEELS 0230
FRONT WHEEL HUBS (770D)
T204046 -UN-12DEC04

THIS PARTS LISTING IS CONTINUED

0230-4 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=60
 1C25 AXLES AND SUSPENSION SYSTEMS 2
NON-POWERED WHEELS 0230
FRONT WHEEL HUBS (770D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7489 CAP SCREW 1 X

2 19H1912 CAP SCREW 1 X
3 19M7489 CAP SCREW 1 X M16 X 45
4 28H3401 SPACER 1 X
7 AT198517 PIN FASTENER 1 X
8 11H251 COTTER PIN 1 X
9 12M7065 LOCK WASHER 1 X 8 MM
10 14H927 NUT 1 X 1-1/4"
11 19H1905 CAP SCREW 3 X
12 19H3065 CAP SCREW 8 X
13 24M7239 WASHER 8 X
14 AT169875 PIVOT 1 X
15 T41953 BUSHING 2 X
16 AT317542 SPINDLE 1 X (SUB FOR AT303854)
17 T41963 BUSHING 2 X
18 JD9048 BEARING CONE 1 X
19 JD9082 BEARING CONE 1 X
20 JD9113 BEARING CUP 1 X
21 JD9141 BEARING CUP 1 X
22 R59074 OIL CUP 1 X
23 RE31702 SEAL 1 X
24 T162428 HUB 1 X
25 T184404 SPINDLE 1 X
26 T41982 CAP 1 X
27 T41983 GASKET 1 X
28 T41984 WASHER 1 X
29 U42462 WASHER 1 X
30 H80936 ELBOW FITTING 2 X
31 JD7781 LUBRICATION FITTING 2 X
32 T11234 LOCK NUT 1 X
33 T146246 WASHER 1 X (SUB FOR 11M7017)
34 AT169874 PIVOT 1 X
35 AT317543 SPINDLE 1 X (SUB FOR AT303855)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0230-5

PN=61
 1D1 AXLES AND SUSPENSION SYSTEMS 2
NON-POWERED WHEELS 0230
FRONT AXLE TIE ROD (770D)
T200608 -UN-02JUN04

THIS PARTS LISTING IS CONTINUED

0230-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=62
 1D2 AXLES AND SUSPENSION SYSTEMS 2
NON-POWERED WHEELS 0230
FRONT AXLE TIE ROD (770D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT304615 TIE ROD 1 X

2 14H875 NUT 1 X 7/8"
3 T159656 BOOT 1 X
4 AT191260 TIE ROD END 1 X (RH THREAD)
7 AT191739 CLAMP 1 X
8 AT191299 CLAMP 1 X
9 AT199999 TIE ROD 1 X
10 11M7023 COTTER PIN 2 X 4 X 32 MM
11 AT191261 TIE ROD END 1 X (LH THREAD)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0230-7

PN=63
 1D3 AXLES AND SUSPENSION SYSTEMS 2
NON-POWERED WHEELS 0230
FRONT WHEEL HUBS (770D)
T204046 -UN-12DEC04

THIS PARTS LISTING IS CONTINUED

0230-4 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=64
 AXLES AND SUSPENSION SYSTEMS 2
POWERED WHEEL AXLE 0240
MEMORANDA

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0240-1

PN=65
 1D4 AXLES AND SUSPENSION SYSTEMS 2
POWERED WHEEL AXLE 0240
FRONT AXLE AND MOUNTING PIN (772D)
T201043 -UN-16AUG04

THIS PARTS LISTING IS CONTINUED

0240-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=66
 1D5 AXLES AND SUSPENSION SYSTEMS 2
POWERED WHEEL AXLE 0240
FRONT AXLE AND MOUNTING PIN (772D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7489 CAP SCREW 1 X M16 X 45

2 24H1595 WASHER 2 X 1/4"
3 28H3401 SPACER 1 X
4 AT194405 HYDRAULIC HOSE 2 X
5 AT313340 AXLE 1 X
6 40M1863 SNAP RING 4 X
7 AT101224 BUSHING 2 X
8 T33933 BUSHING 2 X
9 AT313362 PIN 1 X
10 E12379 NUT 5 X
11 JD7759 LUBRICATION FITTING 4 X
12 JD7797 LUBRICATION FITTING 5 X
13 T146246 WASHER 1 X
14 T209581 SHIM 3 X
15 T75644 ADAPTER 5 X
16 AT57326 HYDRAULIC HOSE 3 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0240-3

PN=67
 1D6 AXLES AND SUSPENSION SYSTEMS 2
POWERED WHEEL AXLE 0240
FRONT AXLE TIE ROD (772D)
T200624 -UN-07JUN04

THIS PARTS LISTING IS CONTINUED

0240-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=68
 1D7 AXLES AND SUSPENSION SYSTEMS 2
POWERED WHEEL AXLE 0240
FRONT AXLE TIE ROD (772D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT193805 TIE ROD 1 X

2 AT191739 CLAMP 1 X
3 AT280508 LINE 1 X
4 AT191299 CLAMP 1 X
5 11M7023 COTTER PIN 2 X 4 X 32 MM
6 24M7359 WASHER 2 X
7 AT191261 TIE ROD END 1 X (LH THREAD)
8 T159656 BOOT 1 X
9 14H875 NUT 1 X 22.225 MM
10 AT191260 TIE ROD END 1 X (RH THREAD)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0240-5

PN=69
 1D8 AXLES AND SUSPENSION SYSTEMS 2
POWERED WHEEL AXLE 0240
WHEEL LEAN BAR (772D)
T145721 -UN-23OCT01

THIS PARTS LISTING IS CONTINUED

0240-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=70
 1D9 AXLES AND SUSPENSION SYSTEMS 2
POWERED WHEEL AXLE 0240
WHEEL LEAN BAR (772D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T187561 PIN 2 X
2 JD7759 LUBRICATION FITTING 2 X
3 AT195880 LINK 1 X LEAN BAR
4 T187566 BUSHING 2 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0240-7

PN=71
 1D10 AXLES AND SUSPENSION SYSTEMS 2
AXLE SHAFT, BEARINGS, REDUCTION GEARS 0250
HFWD FIRST STAGE PINION, CARRIER AND HOUSING (RIGHT SIDE ILLUSTRATED)
T146114 -UN-07NOV01

THIS PARTS LISTING IS CONTINUED

0250-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=72
 1D11 AXLES AND SUSPENSION SYSTEMS 2
AXLE SHAFT, BEARINGS, REDUCTION GEARS 0250
HFWD FIRST STAGE PINION, CARRIER AND HOUSING (RIGHT SIDE ILLUSTRATED)

7 7
7 7
MOTOR 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 40M1837 SNAP RING 1 X

2 T166928 THRUST WASHER 2 X
3 T166927 PLANET PINION 1 X
4 40M7187 SNAP RING 1 X
5 T166922 PLANET PINION 1 X
6 T166934 BEARING RACE 2 X
7 19M7844 SCREW 12 X
8 19M8554 SCREW 3 X
9 T166930 SHAFT 3 X
10 T166929 PLANET PINION 3 X
11 T166932 PLANET PINION CARRIER 1 X SECOND STAGE
12 T166931 RETAINER 3 X
13 T166925 RETAINER 3 X
14 T166923 PLANET PINION 3 X
15 T166926 PLANET PINION CARRIER 1 X
16 T166924 SHAFT 3 X
17 19M8335 SCREW 3 X M8 X 55
18 AT193864 HOUSING 1 X (INCLUDES THREE R26650 DOWEL PINS)
R26650 DOWEL PIN 3 X (NOT ILLUSTRATED)
19 AT187119 THRUST BEARING RACE 1 X
20 AT187117 TAPERED ROLLER BEARING 3 X
21 DE18970 BEARING 3 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0250-3

PN=73
 1D12 AXLES AND SUSPENSION SYSTEMS 2
AXLE SHAFT, BEARINGS, REDUCTION GEARS 0250
HFWD HUB, BRAKE PISTON HOUSING AND SECOND STAGE PINION (RIGHT SIDE ILLUSTRATED)
T155072 -UN-22MAY02

THIS PARTS LISTING IS CONTINUED

0250-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=74
 1D13 AXLES AND SUSPENSION SYSTEMS 2
AXLE SHAFT, BEARINGS, REDUCTION GEARS 0250
HFWD HUB, BRAKE PISTON HOUSING AND SECOND STAGE PINION (RIGHT SIDE ILLUSTRATED)

7 7
7 7
MOTOR 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M8451 CAP SCREW 3 X M10 X 14

2 24M7028 WASHER 3 X
3 T78662 DRAIN PLUG 2 X
4 U17409 O-RING 2 X
5 19M7807 SCREW 30 X M10 X 60
6 T186956 COVER 1 X
7 T166933 PACKING 1 X
8 T188745 CAP SCREW 24 X
9 T186989 PLATE 1 X
10 T166921 SNAP RING 1 X
11 AT187115 BRAKE DISK 3 X
12 T166916 PLATE 3 X
13 T166920 RING GEAR 1 X
14 T186988 PISTON 1 X
15 T186655 PACKING 2 X
16 T186656 PLANET PINION CARRIER 1 X
17 T183810 SHIM 3 X (.1)
18 T183811 SHIM 2 X (.15)
19 T183812 SHIM 1 X (.5)
20 T166919 PLATE 1 X
21 19M7791 BOLT 12 X M12 X 40
22 T166917 SPRING 12 X
23 T188352 RING 1 X
24 JD10423 BEARING CUP 1 X
25 AT187114 BEARING CONE 1 X
26 24M7346 WASHER 24 X 11 X 20 X 2 MM

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0250-5

PN=75
 1D14 AXLES AND SUSPENSION SYSTEMS 2
AXLE SHAFT, BEARINGS, REDUCTION GEARS 0250
AXLE AND DRIVE CHAIN
T203245 -UN-17SEP04

THIS PARTS LISTING IS CONTINUED

0250-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=76
 1D15 AXLES AND SUSPENSION SYSTEMS 2
AXLE SHAFT, BEARINGS, REDUCTION GEARS 0250
AXLE AND DRIVE CHAIN

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 11M7085 COTTER PIN 1 X X

2 T158600 NUT 1 X X
3 T158599 WASHER 1 X X
4 T158248 CHAIN SPROCKET 1 X X
5 R48437 SHIM 1 X X .202 MM (.008")
6 JD9080 BEARING CONE 1 X X
7 JD9138 BEARING CUP 1 X X
8 JD9120 BEARING CUP 1 X X
9 JD8962 BEARING CONE 1 X X
10 AT72157 SEAL 1 X X
11 T158250 HALF AXLE 1 X X
12 19M7300 CAP SCREW 1 X X M6 X 10
13 11M7021 COTTER PIN 2 X X 4 X 25 MM
14 AT44582 LINK 4 X X CONNECTING
15 AT44583 CHAIN LINK AR X X ROLLER
16 AT40729 ROLLER CHAIN 1 X X
17 T159985 PLATE 1 X X (USE ON FRONT AXLE ONLY)
18 T159984 OIL CUP 1 X X (USE ON REAR AXLE ONLY)
19 T158249 HOUSING 1 X X
20 T158339 O-RING 1 X X
21 R135543 WASHER 16 X X
22 19M7489 CAP SCREW 16 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0250-7

PN=77
 1D16 AXLES AND SUSPENSION SYSTEMS 2
AXLE SHAFT, BEARINGS, REDUCTION GEARS 0250
TANDEM DRIVE AND PLANETARY
T204201 -UN-16OCT04

THIS PARTS LISTING IS CONTINUED

0250-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=78
 1D17 AXLES AND SUSPENSION SYSTEMS 2
AXLE SHAFT, BEARINGS, REDUCTION GEARS 0250
TANDEM DRIVE AND PLANETARY

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R77664 SHAFT 3 X X
2 R112079 THRUST WASHER 6 X X
3 R108997 PLANET PINION 3 X X
4 R63575 NEEDLE ROLLER 144 X X
5 R71929 WASHER 3 X X
6 R72430 SNAP RING 1 X X
7 R131113 PLANET PINION CARRIER 1 X X
8 R94546 SPACER 1 X X
9 R81162 BOLT 1 X X
10 R94545 LOCK PLATE 1 X X
11 F3171R O-RING 3 X X
12 R131114 PINION SHAFT 1 X X
13 R93937 GEAR 1 X X
14 R54380 DOWEL PIN 2 X X
15 R27315 DOWEL PIN 2 X X
16 R52389 SHIM 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0250-9

PN=79
 1D18 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD FRONT HUB AND MOTOR (COMPLETE)
T205141 -UN-03DEC04

THIS PARTS LISTING IS CONTINUED

0260-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=80
 1D19 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD FRONT HUB AND MOTOR (COMPLETE)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT188625 WHEEL 1 X (CONVENIENCE ASSEMBLY)(RH HFWD HUB AND

MOTOR) (COMPONENTS LISTED ON SEPARATE
PAGES)
2 AT188624 WHEEL 1 X (CONVENIENCE ASSEMBLY)(LH HFWD HUB AND
MOTOR) (COMPONENTS LISTED ON SEPARATE
PAGES)
3 AT194472 HYDRAULIC MOTOR 1 X (HFWD MOTOR)(COMPLETE) (COMPONENTS LISTED
ON SEPARATE PAGES)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-3

PN=81
 1D20 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD MOTOR HYDRAULIC LINES
T205102 -UN-29DEC04

THIS PARTS LISTING IS CONTINUED

0260-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=82
 1D21 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD MOTOR HYDRAULIC LINES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT191729 LINE 1 X (LEFT FRONT PRESSURE)

2 19M7844 SCREW 4 X M16 X 45
3 R26448 O-RING 4 X
4 38H1004 ELBOW FITTING 2 X
5 T59014 O-RING 4 X
6 AT191725 LINE 1 X (RIGHT FRONT PRESSURE)
7 19H3750 SCREW 16 X 3/8" X 1-3/4"
9 T77613 O-RING 4 X
10 T77858 O-RING 6 X
11 19M7784 SCREW 6 X M10 X 20
12 T185959 CLAMP 4 X
13 R28782 O-RING 2 X
14 38H1160 ADAPTER 2 X
15 AT191506 LINE 1 X (RIGHT BRAKE)
16 T185960 CLAMP 2 X
17 19M7865 SCREW 2 X M8 X 16
18 AT192114 LINE 1 X (RIGHT DRAIN)
19 38H1163 ADAPTER 2 X
20 U12547 O-RING 2 X
21 AT191724 LINE 1 X (RIGHT REAR PRESSURE)
22 AT191505 LINE 1 X (LEFT BRAKE)
23 AT191730 LINE 1 X (LEFT DRAIN)
24 AT191728 LINE 1 X (LEFT REAR PRESSURE)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-5

PN=83
 1D22 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD HUB AND YOKE
T205081 -UN-21DEC04

THIS PARTS LISTING IS CONTINUED

0260-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=84
 1D23 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD HUB AND YOKE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7792 SCREW 1 X M16 X 30

2 JD7771 LUBRICATION FITTING 1 X
3 T184460 PLATE 1 X
4 T183816 KINGPIN 1 X
5 CE17368 SHAFT KEY 1 X
6 AT188662 TAPERED ROLLER BEARING 2 X
7 T75447 ELBOW FITTING 2 X
8 28H3401 SPACER 1 X
9 T146246 WASHER 1 X
10 19M7489 CAP SCREW 1 X M16 X 45
11 19M7938 CAP SCREW 1 X M10 X 20
12 24M7296 WASHER 1 X
13 T188984 STRAP 1 X (BUMPER)
14 AT198516 PIN FASTENER 1 X (SUB FOR AT196745)
15 T183821 YOKE 1 X (RIGHT)
16 T41953 BUSHING 2 X
17 T183818 SHIM 3 X (.1)
18 T183819 SHIM 2 X (.15)
19 T183820 SHIM 2 X (.5)
20 T183817 KINGPIN 1 X
21 19M7791 BOLT 8 X M12 X 40
22 JD7798 LUBRICATION FITTING 1 X
23 19M7791 BOLT 4 X M12 X 40
24 AT326599 ISOLATOR 1 X (SUB FOR AT198028)
25 14M7299 FLANGE NUT 4 X M12
26 T186658 O-RING 2 X
27 T186657 STRUCTURAL TUBING 1 X (CONNECTOR)
28 19M7789 SCREW 3 X M12 X 30
29 T185370 GUARD 1 X
30 T166907 HOUSING 1 X
31 T188856 SCREW 2 X
32 T188857 SCREW 4 X
33 T187196 RETAINER 2 X
34 T183822 WEAR RING 1 X
35 T186659 SEALING TRIM 2 X
36 34M5564 SPRING PIN 1 X
37 DE19507 WHEEL SEAL O-RING 1 X (CONTAINS SET OF TWO SEAL HALVES - BOTH
HALVES REQUIRED FOR ONE WHEEL DRIVE)
38 AT187114 BEARING CONE 2 X
41 R26448 O-RING 1 X
42 38H1160 ADAPTER 1 X
43 R28782 O-RING 1 X
44 38H1415 FITTING 1 X
45 T183823 YOKE 1 X (LEFT)
46 AT326600 ISOLATOR 1 X (SUB FOR AT198029)
47 T183824 HOUSING 1 X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0260-7

PN=85
 1D24 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD MOTOR SOLENOID AND SERVO PISTON
T204743 -UN-30NOV04

THIS PARTS LISTING IS CONTINUED

0260-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=86
 1D25 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD MOTOR SOLENOID AND SERVO PISTON

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T162854 RING 1 X
2 T155757 O-RING 1 X
3 AN208022 PISTON 1 X
4 AT184868 FITTING PLUG 4 X
5 M74600 O-RING 6 X
6 AT180814 PLUG 2 X
7 T214109 SCREW 2 X
8 T158241 O-RING 1 X
9 T155988 O-RING 5 X
10 N306882 GASKET 1 X
11 M74877 PLUG 2 X
12 M45387 O-RING 2 X
13 AT196462 PLATE 1 X
14 T176405 SPOOL 1 X
15 AT184869 PLUG 4 X
16 T165535 O-RING 4 X
18 T214110 SCREW 4 X
19 AT319117 SEAL KIT 1 X
20 T214145 HYDRAULIC CYLINDER CAP 1 X
21 AT195921 SOLENOID VALVE 1 X
22 AT195922 HYD ACTUATED CONTROL VALVE 1 X
23 AT192055 SOLENOID VALVE COIL 1 X
24 T181306 NUT 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-9

PN=87
 1E1 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD MOTOR SWASH PLATE, BEARINGS, AND SPEED SENSOR
T204742 -UN-22NOV04

THIS PARTS LISTING IS CONTINUED

0260-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=88
 1E2 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD MOTOR SWASH PLATE, BEARINGS, AND SPEED SENSOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 N306880 VALVE 1 X
2 R726R DOWEL PIN 2 X
3 AT214801 PLUG 2 X
4 T59014 O-RING 2 X
5 F37030250 O-RING 1 X
7 N306881 PLATE 1 X
8 AT173174 SEAL 1 X
9 T187896 O-RING 1 X
10 N306885 SNAP RING 2 X
11 N306886 SNAP RING 1 X
12 N306887 GASKET 1 X
13 AT195723 SEAL 1 X
14 AN208024 SHAFT 1 X (SUB FOR AT196745)
15 AT319115 PISTON RING KIT 1 X
16 AT194596 GROUND SPEED SENSOR 1 X
17 M74600 O-RING 1 X
18 T214111 SCREW 1 X
19 AT319117 SEAL KIT 1 X
22 AT195922 HYD ACTUATED CONTROL VALVE 1 X
23 AT192055 SOLENOID VALVE COIL 1 X
24 T181306 NUT 1 X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0260-11

PN=89
 1E3 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD PUMP
T203978 -UN-23NOV04

THIS PARTS LISTING IS CONTINUED

0260-12 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=90
 1E4 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD PUMP

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7402 CAP SCREW 2 X M10 X 25

2 19M7403 CAP SCREW 1 X M12 X 35
3 19M7791 BOLT 4 X M12 X 40
4 19M7946 CAP SCREW 2 X M20 X 40
5 19M8011 CAP SCREW 2 X M12 X 30
6 19M8313 CAP SCREW 2 X M12 X 55
7 24M7099 WASHER 2 X
8 24M7240 WASHER 5 X
9 24M7296 WASHER 4 X
10 38H1435 ELBOW FITTING 1 X
11 R28782 O-RING 1 X
12 T77613 O-RING 1 X
13 AT191214 ADAPTER 1 X
14 AT194555 SUPPORT 1 X
15 AT194815 PRESSURE SWITCH 1 X (BRAKE RIGHT)
16 AT307760 HYDRAULIC PUMP 1 X (FRONT AND REAR HFWD PUMP) (COMPONENTS ON
SEPARATE PAGES)
17 14M7296 FLANGE NUT 2 X M10
18 19M7662 CAP SCREW 2 X M10 X 30
19 AT307775 BRACKET 1 X
20 AT317887 PUMP 1 X (REAR HFWD PUMP)
21 AT317891 PUMP 1 X (FRONT HFWD PUMP)
22 F37020159 O-RING 1 X
23 R26286 O-RING 1 X
24 T187206 SHIM 1 X
25 T29342 WASHER 4 X
26 T206048 BRACKET 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-13

PN=91
 1E5 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD PUMP CYLINDER BLOCK, SWASH PLATE, AND PISTONS
T148543 -UN-29NOV01

THIS PARTS LISTING IS CONTINUED

0260-14 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=92
 1E6 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD PUMP CYLINDER BLOCK, SWASH PLATE, AND PISTONS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

12 AT195063 HYDRAULIC PUMP REPAIR KIT 1 X SWASH / ROTATING GROUP

14 T187714 PLATE 1 X
26 AT195062 PISTON 1 X SERVO
44 AT195057 BEARING 2 X
45 T162211 PIN 2 X
46 T187726 LINK 2 X
47 T187721 LINK 1 X SLIDE BLOCK
53 T162212 SPRING 2 X
54 T162213 WASHER 2 X
56 T162215 DOWEL PIN 3 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-15

PN=93
 1E7 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD PUMP HOUSING AND EP CONTROL
T205107 -UN-05JAN05

THIS PARTS LISTING IS CONTINUED

0260-16 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=94
 1E8 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD PUMP HOUSING AND EP CONTROL

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T187734 HOUSING 1 X (REAR PUMP)

T190814 HOUSING 1 X (FRONT PUMP)
2 T187719 DRIVE SHAFT 1 X (FRONT PUMP)
T187736 DRIVE SHAFT 1 X (REAR PUMP)
3 T187733 TUBE 1 X
4 T187741 CAP SCREW 1 X
6 AT195066 CONTROL 1 X (EP CONTROL-24 VOLT)
7 T187729 GASKET 1 X
8 AT198322 SOLENOID VALVE COIL 1 X
9 T187745 O-RING 1 X
10 T187744 NUT 1 X
11 T187731 LINK 1 X
12 T187711 ORIFICE 1 X
13 AT317889 KIT 1 X (PUMP OVERHAUL SEAL KIT)
27 T187772 O-RING 2 X
28 T187722 RING 2 X
29 T187720 COVER 1 X
30 T187728 COVER 1 X
31 T187769 BOLT 8 X
32 T187774 O-RING AR X
40 T187713 BEARING CUP 1 X
48 AT195065 PRESSURE RELIEF VALVE 1 X
61 AT195068 PLUG 1 X
62 T162216 PLUG 1 X
66 AT180965 PLUG 3 X
67 AT180966 PLUG 1 X
87 T187723 SEAL 1 X
88 T187712 SNAP RING 1 X USED ON FRONT PUMP ONLY.
96 AT195125 KIT 1 X (EP SEAL KIT)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-17

PN=95
 1E9 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD PUMP END COVER AND HFWD MOTOR FLUSHING PUMP
T205108 -UN-15DEC04

THIS PARTS LISTING IS CONTINUED

0260-18 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=96
 1E10 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD PUMP END COVER AND HFWD MOTOR FLUSHING PUMP

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

3 T187738 COVER 1 X (FRONT PUMP)

T187737 COVER 1 X (REAR PUMP)
4 T187767 BOLT 8 X
5 T187724 GASKET 1 X
6 AT195073 KIT 1 X (HFWD CHARGE PUMP HARDWARE KIT) (INCLUDES
4 SOCKET HEAD CAP SCREWS)
13 T187735 PLATE 1 X
21 AT195074 KIT 1 X (HFWD MOTOR FLUSHING PUMP REPAIR KIT)
22 T162157 PLATE 1 X
23 T162155 SNAP RING 1 X (RETAINING RING)
24 T162152 O-RING 1 X
25 AT180935 SEAL KIT 1 X (INCLUDES 4 SEALS)
26 N126638 PIN 1 X
27 T187716 ROTATOR 1 X
28 T187717 RING 1 X (FRONT PUMP)
T187716 ROTATOR 1 X (REAR PUMP)
29 T187727 SHAFT 1 X
30 AT180936 COVER 1 X
41 AT195075 KIT 1 X (HFWD PUMP DRIVESHAFT SHIM KIT)
42 AT195060 BEARING 1 X
55 T187715 PIN 2 X
56 T162215 DOWEL PIN 3 X
57 T187730 SEAL 4 X
59 T187740 RING 2 X
60 T187725 RING 1 X
63 AT180964 FITTING 2 X
64 AT195069 PLUG 1 X (FRONT PUMP)
66 AT180965 PLUG 2 X
67 AT180966 PLUG 2 X
76 AT317886 PRESSURE RELIEF VALVE 2 X (PRESSURE OVERRIDE VALVE)
79 AT195064 PRESSURE RELIEF FITTING 2 X
95 AT317889 KIT 1 X (PUMP OVERHAUL SEAL KIT-FRONT PUMP)
AT195124 KIT 1 X (COVER SEAL KIT-REAR PUMP)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-19

PN=97
 1E11 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD HOSES (HFWD ENGAGEMENT VALVE TO HFWD MOTORS)
T203261 -UN-09NOV04

THIS PARTS LISTING IS CONTINUED

0260-20 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=98
 1E12 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD HOSES (HFWD ENGAGEMENT VALVE TO HFWD MOTORS)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT196253 HYDRAULIC HOSE - FABRICATE 1 X (RIGHT HFWD MOTOR FORWARD)

2 AT196249 HYDRAULIC HOSE - FABRICATE 1 X (LEFT HFWD MOTOR FORWARD)
3 AT196254 HYDRAULIC HOSE - FABRICATE 1 X (RIGHT HFWD MOTOR REVERSE)
4 AR21839 CLAMP 1 X (LEFT HFWD MOTOR REVERSE) (SUB FOR
AT196250, THIS APPLICATION)
5 AT197098 HYDRAULIC HOSE - FABRICATE 2 X (HFWD MOTOR CASE DRAIN)
6 AT308073 HYDRAULIC HOSE - FABRICATE 2 X (RIGHT AND LEFT HFWD MOTOR FLUSHING HOSE)
7 AT196256 HYDRAULIC HOSE - FABRICATE 1 X (RIGHT HFWD BRAKE HOSE)
8 AT196252 HYDRAULIC HOSE - FABRICATE 1 X (LEFT HFWD BRAKE HOSE)
9 38H1094 ELBOW FITTING 2 X
10 T77613 O-RING 9 X
11 38H1205 TEE FITTING 1 X
12 T188182 HOSE GUARD 2 X (PROTECTIVE SLEEVE FOR HFWD HOSES) (NOT
ILLUSTRATED)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0260-21

PN=99
 1E13 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD HOSES (BULKHEAD TO HFWD ENGAGEMENT VALVE)
T203262 -UN-09NOV04

THIS PARTS LISTING IS CONTINUED

0260-22 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=100
 1E14 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD HOSES (BULKHEAD TO HFWD ENGAGEMENT VALVE)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT305512 HYDRAULIC HOSE - FABRICATE 1 X (HFWD MOTOR FLUSHING)

2 AT305505 HYDRAULIC HOSE 4 X (HFWD MOTOR FORWARD/REVERSE)
3 AT305510 HYDRAULIC HOSE 1 X (HFWD MOTOR TANK)
4 AT305509 HYDRAULIC HOSE - FABRICATE 1 X (HFWD MOTOR CASE DRAIN)
5 19M7788 SCREW 2 X
6 T210043 BRACKET 1 X
7 T78707 NUT 4 X
8 T78715 NUT 1 X
9 .................. PAD 1 X (MAKE FROM T61861) (CUT TO LENGTH)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-23

PN=101
 1E15 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD HOSES (HFWD PUMP TO BULKHEAD)
T204637 -UN-09DEC04

THIS PARTS LISTING IS CONTINUED

0260-24 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=102
 1E16 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD HOSES (HFWD PUMP TO BULKHEAD)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT309957 HYDRAULIC HOSE - FABRICATE 2 X (LEFT FORWARD AND REVERSE)

2 AT305507 HYDRAULIC HOSE - FABRICATE 1 X (RIGHT FORWARD)
3 19H2563 CAP SCREW 16 X 7/16" X 1-3/4"
4 24M7240 WASHER 16 X
5 H122182 FLANGE FITTING 8 X
6 T78313 O-RING 4 X
7 AT309959 HYDRAULIC HOSE - FABRICATE 1 X (HFWD MOTOR CASE DRAIN HOSE)
8 T77858 O-RING 9 X
9 38H1019 TEE FITTING 2 X
10 U12547 O-RING 5 X
11 AH75162 FITTING 1 X
12 AT302098 TUBE 1 X
13 AT145650 HOSE CLAMP 2 X
14 AT310272 HOSE 1 X
15 19M7938 CAP SCREW 1 X M10 X 20
16 T149597 CLAMP 1 X
17 24M7239 WASHER 1 X
18 AT223584 FITTING 1 X
19 AT305508 HYDRAULIC HOSE - FABRICATE 1 X (HFWD MOTOR TANK HOSE)
20 38H1598 TEE FITTING 1 X
21 T77613 O-RING 1 X
22 38H1095 ELBOW FITTING 1 X
23 T77857 O-RING 4 X
24 AT197488 CHECK VALVE 1 X
25 AT305513 HYDRAULIC HOSE - FABRICATE 1 X (HFWD MOTOR FLUSHING HOSE)
26 AT193948 HYDRAULIC HOSE - FABRICATE 1 X
27 38H1033 TEE FITTING 1 X
28 38H1007 ELBOW FITTING 2 X
29 H77698 TIE BAND 1 X
30 AT305506 HYDRAULIC HOSE - FABRICATE 1 X (RIGHT REVERSE)
31 38H1161 ADAPTER 1 X
32 R26375 O-RING 1 X
33 AT312998 HOSE SUPPORT 1 X
34 19M8029 CAP SCREW 2 X M16 X 30
35 AT317166 HYDRAULIC HOSE - FABRICATE 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-25

PN=103
 1E17 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD CHARGE PUMP
T209458 -UN-22MAR05

THIS PARTS LISTING IS CONTINUED

0260-26 770D/772D MOTOR GRADER PC9449 (30-MAR-05)
PN=104
 1E18 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD CHARGE PUMP

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT317637 HYDRAULIC PUMP 1 X (HFWD CHARGE PUMP)

AT317595 SEAL KIT 1 X (HFWD CHARGE PUMP SEAL KIT)
2 E55662 FLANGE NUT 2 -597330 X 3/8"
3A T20052 STUD 2 -597330 X
3B 19H3771 SCREW 2 597331- X
4 U42702 O-RING 1 X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 0260-27

PN=105
 1E19 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD CHARGE PUMP HOSES
T203846 -UN-09NOV04

THIS PARTS LISTING IS CONTINUED

0260-28 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=106
 1E20 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD CHARGE PUMP HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1007 ELBOW FITTING 1 X

2 T77858 O-RING 4 X
3 U12547 O-RING 4 X
4 38H1024 TEE FITTING 1 X
5 R26375 O-RING 2 X
6 T77857 O-RING 3 X
7 38H1052 ELBOW FITTING 1 X
8 R29936 O-RING 3 X
9 38H1161 ADAPTER 1 X
10 38H1163 ADAPTER 2 X
11 AH75162 FITTING 1 X
12 AR21839 CLAMP 2 X (SUB FOR AT145650, THIS APPLICATION)
13 AT188217 HYDRAULIC HOSE - FABRICATE 1 X
14 AT191879 HYDRAULIC HOSE - FABRICATE 1 X
15 AT312910 HYDRAULIC HOSE - FABRICATE 1 X
16 AT312912 HYDRAULIC HOSE - FABRICATE 1 X
17 AT83306 ADAPTER 1 X
18 T186987 SUCTION HOSE 1 X
19 AT194980 PRESSURE RELIEF VALVE 1 X (NEUTRAL CHARGE PRESSURE REGULATING
VALVE)
AT194982 HYD ACTUATED CONTROL VALVE 1 X (NOT ILLUSTRATED)
AT194983 SHIM 1 X (NOT ILLUSTRATED)
AZ42092 GANG 1 X (NOT ILLUSTRATED)
T187664 HOUSING 1 X (NOT ILLUSTRATED)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0260-29

PN=107
 1E21 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
DIFFERENTIAL LOCK COOLER HOSES
T211055 -UN-16MAY05

THIS PARTS LISTING IS CONTINUED

0260-30 770D/772D MOTOR GRADER PC9449 (09-JUN-05)
PN=108
 1E22 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
DIFFERENTIAL LOCK COOLER HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7274 NUT 1 -598033 X X M10

2 19M7938 CAP SCREW 2 -598033 X X M10 X 20
24M7239 WASHER 2 -598033 X X
3A 38H1046 ELBOW FITTING 1 -598033 X X
3B 38H1161 ADAPTER 1 598034- X X
4 R26375 O-RING 2 X X
5 T77857 O-RING 7 X X
6 38H1161 ADAPTER 1 X X
7 38H1175 ADAPTER 2 X X
8 U12547 O-RING 2 X X
9 38H1176 ADAPTER 1 X X
10 R29936 O-RING 1 X X
11 AT303539 HYDRAULIC HOSE - FABRICATE 1 X X
12 AT305832 HYDRAULIC HOSE - FABRICATE 1 X X
13 AT305833 OIL LINE 1 X X
14 T38377 CLAMP 2 -598033 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0260-31

PN=109
 1E23 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
DIFFERENTIAL LOCK PUMP, HYDRAULIC FITTINGS AND MOUNTING
T200634 -UN-07JUN04

THIS PARTS LISTING IS CONTINUED

0260-32 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=110
 1E24 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
DIFFERENTIAL LOCK PUMP, HYDRAULIC FITTINGS AND MOUNTING

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T76938 O-RING 1 X X
2 24M7239 WASHER 2 X X
3 19M7576 SCREW 2 X X M10 X 30
4 AT191095 PUMP 1 X X (DIFFERENTIAL LOCK)
5 38H1174 ADAPTER 1 X X
6 R26906 O-RING 1 X X
7 T77857 O-RING 1 X X
8 T160541 O-RING 1 X X
9 YZ103042 SLEEVE 1 X X (DIFF LOCK PUMP TO TRANSMISSION)
10 U12547 O-RING 1 X X
11 38H1305 ELBOW FITTING 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-33

PN=111
 1F1 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
DIFFERENTIAL LOCK HYDRAULIC HOSES AND FILTER
T202051 -UN-12DEC04

THIS PARTS LISTING IS CONTINUED

0260-34 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=112
 1F2 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
DIFFERENTIAL LOCK HYDRAULIC HOSES AND FILTER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7867 SCREW 1 X X M8 X 25
2 38H1013 ELBOW FITTING 2 X X
3 T77857 O-RING 3 X X
4 U12547 O-RING 3 X X
5 38H1161 ADAPTER 1 X X
6 R26375 O-RING 1 X X
7 38H1305 ELBOW FITTING 1 X X
8 T76938 O-RING 1 X X
9 19M7938 CAP SCREW 1 X X
10 AH77714 CLIP 1 X X
11 AT101565 AIR FILTER 1 X X
12 AT191160 HYDRAULIC HOSE - FABRICATE 1 X X
13 AT305831 HYDRAULIC HOSE - FABRICATE 1 X X
14 AT305834 HYDRAULIC HOSE - FABRICATE 1 X X
15 .................. BULK HOSE 2 X X (MAKE FROM M87571) (CUT TO LENGTH)
16 E69975 CLAMP 1 X X
17 H77698 TIE BAND 2 X X (NOT ILLUSTRATED)
18 24M7239 WASHER 1 X X
19 AT309711 HOSE SUPPORT 1 X X
20 19M7783 SCREW 6 X X M10 X 16
21 AT305053 FILTER HEAD 1 X X
22 AT306605 HYDRAULIC FILTER 1 X X (DIFFERENTIAL LOCK FILTER)
23 T205883 BRACKET 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0260-35

PN=113
 1F3 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD ENGAGEMENT MANIFOLD FITTINGS AND TEMPERATURE SENSOR
T206131 -UN-18DEC04

THIS PARTS LISTING IS CONTINUED

0260-36 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=114
 1F4 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD ENGAGEMENT MANIFOLD FITTINGS AND TEMPERATURE SENSOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7662 CAP SCREW 2 X X M10 X 30

2 19M8011 CAP SCREW 2 X X M12 X 30
3 24M7226 WASHER 2 X X
4 24M7266 WASHER 2 X X
5 38H1007 ELBOW FITTING 2 X X
6 T77858 O-RING 8 X X
7 U12547 O-RING 10 X X
8 38H1070 FITTING 1 X X
9 38H1161 ADAPTER 1 X X
10 R26375 O-RING 1 X X
11 T77857 O-RING 1 X X
12 38H1163 ADAPTER 6 X X
13 T77932 O-RING 2 X X
14 AH125760 HYD. QUICK-CONNECT COUPLER 4 X X
15 AT191639 ELBOW FITTING 2 X X
16 AT195285 TEE FITTING 2 X X
17 AT302927 TRANSDUCER 2 X X (HFWD PUMP PRESSURE SENSOR)
18 R26287 O-RING 1 X X
19 AT307707 SWITCH 1 X X (HFWD TEMPERATURE SWITCH) (INCLUDES
O-RING)
20 AT310959 BRACKET 1 X X
21 R26448 O-RING 6 X X
22 R77175 COVER 4 X X
23 T77613 O-RING 4 X X
24 38H1577 ELBOW FITTING 2 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0260-37

PN=115
 1F5 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD ENGAGEMENT MANIFOLD
T206902 -UN-12JAN05

THIS PARTS LISTING IS CONTINUED

0260-38 770D/772D MOTOR GRADER PC9449 (02-FEB-05)
PN=116
 1F6 AXLES AND SUSPENSION SYSTEMS 2
HYDRAULIC SYSTEM 0260
HFWD ENGAGEMENT MANIFOLD

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT194986 CYLINDER BLOCK 1 X

2 AT194988 PRESSURE RELIEF VALVE 2 X
3 AT194990 HYD ACTUATED CONTROL VALVE 2 X
4 AT194991 HYD ACTUATED CONTROL VALVE 2 X
5 AT320199 PLUG 8 X
6 AT320198 PLUG 5 X
7 AT320179 PLUG 2 X
8 AT194983 SHIM 2 X (NOT ILLUSTRATED)
9 AT194989 STEEL 4 X
10 R30903 O-RING 8 X
11 R26286 O-RING 5 X
12 U12547 O-RING 2 X
13 R26375 O-RING 1 X
14 AT199626 FLOW CONTROL HYD. VALVE 1 X (HFWD ENGAGEMENT MANIFOLD)
AZ42092 GANG 1 X (SEAL KIT)
15 AT320176 FITTING PLUG 1 X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 0260-39

PN=117
 1F10 TRANSMISSION 3
CONTROLS 0315
TRANSMISSION CONTROL UNIT
T201735 -UN-30JUL04

THIS PARTS LISTING IS CONTINUED

0315-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=118
 1F11 TRANSMISSION 3
CONTROLS 0315
TRANSMISSION CONTROL UNIT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7897 SCREW 2 X X M8 X 35
2 19M8145 SCREW 4 X X M6 X 80
3 AH77714 CLIP 2 X X
4 AT312607 BRACKET 1 X X
5 T196077 NUT 4 X X M6
6 T196079 NUT 2 X X
7 YZ105856 TRANSMISSION CONTROLLER 1 X X (TCU) (PREPROGRAMMED)

770D/772D MOTOR GRADER PC9449 (20-APR-05) 0315-3

PN=119
 1F12 TRANSMISSION 3
CONTROLS 0315
TRANSMISSION GEAR SELECTOR
T201740 -UN-08NOV04

THIS PARTS LISTING IS CONTINUED

0315-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=120
 1F13 TRANSMISSION 3
CONTROLS 0315
TRANSMISSION GEAR SELECTOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7296 FLANGE NUT 2 X X M10

2 19M7784 SCREW 4 X X M10 X 20
3 19M7866 BOLT 3 X X M8 X 20
4 19M7868 SCREW 2 X X M8 X 30
5 24M7298 WASHER 2 X X
6 AT302388 SHIFTER 1 X X
7 21M7399 SCREW 6 X X M6 X 16
8 24M7238 WASHER 2 X X
9 34H280 SPRING PIN 1 X X
10 AT174935 MODULE 1 X X
11 AT180923 CRADLE 1 X X
12 AT184684 TRANSMISSION CONTROLLER 1 X X
13 AT302104 BRACKET 1 X X
14 AT302105 FRAME 1 X X
15 AT304327 LEVER 1 X X
16 AT305398 PLATE 1 X X
17 T163333 CAP SCREW 1 X X
18 T16464 LOCK NUT 1 X X
19 T201461 BUSHING 1 X X
20 T201462 SHAFT 1 X X
21 T201481 BUSHING 3 X X
22 T201482 BUSHING 3 X X
23 19M7796 SCREW 3 X X M6 X 30
24 19M7775 SCREW 9 X X M6 X 16
25 AT305433 BRACKET 1 X X
26 24H1821 WASHER 4 X X
27 21M7310 SCREW 4 X X M6 X 25
28 T140922 COMPRESSION SPRING 1 X X
29 T162876 KNOB 1 X X
30 T164264 LOCKING COLLAR 1 X X
31 T196079 NUT 3 X X
32 T202792 BRACKET 1 X X (ALSO ORDER (3) T196077 AND (2) T196079)
33 T120536 CLAMP 1 X X (SUB FOR T78787, THIS APPLICATION)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0315-5

PN=121
 1F14 TRANSMISSION 3
CONTROLS 0315
INCHING PEDAL
T207178 -UN-28JAN05

THIS PARTS LISTING IS CONTINUED

0315-6 770D/772D MOTOR GRADER PC9449 (02-FEB-05)
PN=122
 1F15 TRANSMISSION 3
CONTROLS 0315
INCHING PEDAL

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7865 SCREW 3 X X M8 X 16
2 AT307200 PEDAL 1 X X
3 21M7292 SCREW 1 X X M6 X 16
4 T209947 COVER 1 X X
5 24H1821 WASHER 1 X X

770D/772D MOTOR GRADER PC9449 (02-FEB-05) 0315-7

PN=123
 1F16 TRANSMISSION 3
INPUT DRIVE SHAFTS 0325
TORSIONAL ISOLATOR
T155122 -UN-23MAY02

THIS PARTS LISTING IS CONTINUED

0325-2 770D/772D MOTOR GRADER PC9449 (12-JAN-05)
PN=124
 1F17 TRANSMISSION 3
INPUT DRIVE SHAFTS 0325
TORSIONAL ISOLATOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT199018 ABSORBER 1 X X
2 T185424 WASHER 12 X X
3 19H3219 CAP SCREW 12 X X 3/8" X 1-3/8"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0325-3

PN=125
 1F18 TRANSMISSION 3
HOUSINGS AND COVERS 0341
TRANSMISSION OIL DIPSTICK AND FLYWHEEL HOUSING DRAIN
T212758 -UN-19JUL05

THIS PARTS LISTING IS CONTINUED

0341-2 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=126
 1F19 TRANSMISSION 3
HOUSINGS AND COVERS 0341
TRANSMISSION OIL DIPSTICK AND FLYWHEEL HOUSING DRAIN

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7139 CAP SCREW 2 X X M8 X 20

2 19H3239 CAP SCREW 12 X X 3/8" X 1-1/4"
3 19M7938 CAP SCREW 1 X X M10 X 20
4 24M7239 WASHER 1 X X
5 AH77714 CLIP 1 X X
6 AR21836 CLAMP 2 X X
7 .................. BULK HOSE 2 X X (MAKE FROM T168383) (CUT TO LENGTH)
8 P50631 O-RING 1 X X 50.394 X 3.531 MM
9 YZ104048 DIPSTICK TUBE 1 X X
10 YZ105042 DIPSTICK 1 X X
11 YZ105419 CLAMP 1 X X
12 R26375 O-RING 2 X X
13 T38282 HOSE FITTING 2 X X
19 AA31281 CLAMP 1 X X
20 19M8029 CAP SCREW 1 X X M16 X 30
21 YZ105419 CLAMP 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0341-3

PN=127
 TRANSMISSION 3
HOUSINGS AND COVERS 0341
MEMORANDA

0341-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=128
 1F20 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION (COMPLETE)
T206634 -UN-05JAN05

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT317808 TRANSMISSION 1 X REMANUFACTURED (COMPONENT EXCHANGE) (NON-

HFWD)(YZ19068 ORIGINAL TRANSMISSION)
AT317809 TRANSMISSION 1 X REMANUFACTURED (COMPONENT EXCHANGE)(HFWD)
(YZ19067 ORIGINAL TRANSMISSION)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0350-1

PN=129
 1F21 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
FRONT TRANSMISSION CASE (770D)
YZ105133PCD01 -UN-23AUG04

THIS PARTS LISTING IS CONTINUED

0350-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=130
 1F22 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
FRONT TRANSMISSION CASE (770D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105385 HOUSING 1 X FRONT HOUSING, (INCLUDES (2) F2710616,

(2) F85004 AND (2) R28782)
2 YZ101474 SHAFT 2 X
3 YZ103148 BALL BEARING 2 X
4 F40111 BALL BEARING 1 X
5 YZ105096 GEAR 1 X
6 YZ105097 GEAR 1 X
7 YZ103146 BEARING CUP 2 X
8 B3690R O-RING 2 X (SUB FOR F37030226)
9 F85120 FITTING PLUG 1 X
10 .................. HOSE FITTING 1 X (F3310305 NO LONGER AVAILABLE)
11 YZ105375 TROUGH 1 X (SUB FOR YZ103405)
12 .................. CAP SCREW 2 X ( 19M2900 NO LONGER AVAILABLE)
13 F2710616 DOWEL PIN 2 X
14 F2310018 PLUG 1 X
15 F37030219 O-RING 1 X
16 YZ100100 BALL BEARING 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-3

PN=131
 1F23 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
FRONT TRANSMISSION CASE (772D)
YZ105123PCD01 -UN-24AUG04

THIS PARTS LISTING IS CONTINUED

0350-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=132
 1F24 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
FRONT TRANSMISSION CASE (772D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105385 HOUSING 1 X (INCLUDES (2) F2710616, (2) U44115, (2)

R28782, F85108, YZ105538, (2) 24M1604,
(2) 19M3115, YZ105539) FRONT HOUSING
KIT
2 YZ101474 SHAFT 2 X
3 YZ105094 GEAR 1 X
4 YZ103148 BALL BEARING 2 X
5 F40111 BALL BEARING 1 X
6 F40211R BALL BEARING 1 X
7 YZ105320 SPACER 1 X
8 N131806 SNAP RING 1 X
9 YZ105319 GEAR 1 X
10 YZ105096 GEAR 1 X
11 YZ105097 GEAR 1 X
12 YZ103146 BEARING CUP 2 X
13 P50631 O-RING 2 X (SUB FOR F37030226)
14 F85120 FITTING PLUG 1 X
15 YZ105122 CYLINDRICAL ROLLER BEARING 2 X
16 .................. 1 X HOSE FITTING, (F3310305 NO LONGER
AVAILABLE)
17 YZ105375 TROUGH 1 X (SUB FOR YZ103405)
18 .................. 2 X CAPSCREW, (19M2900 NO LONGER AVAILABLE)
19 F2710616 DOWEL PIN 2 X
20 F2310018 PLUG 1 X
21 YZ103455 BEARING 1 X
22 F37030219 O-RING 1 X
23 F39000315 SNAP RING 1 X
24 YZ100100 BALL BEARING 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-5

PN=133
 1G1 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
REAR TRANSMISSION HOUSING
YZ105125PCD02 -UN-26JUL05

THIS PARTS LISTING IS CONTINUED

0350-6 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=134
 1G2 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
REAR TRANSMISSION HOUSING

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105533 HOUSING 1 X X REAR

2 4008024 SLEEVE 1 X X
3 4008023 SLEEVE 4 X X
4 YZ103146 BEARING CUP 1 X X
5 YZ104280 BEARING CUP 1 X X
6 F85112 DRAIN PLUG 1 X X
F37060912 O-RING 1 X X
7 F7400014D BALL 1 X X
8 YZ250262 PRESSURE RELIEF VALVE 1 X X (SUB FOR YZ102752)
9 YZ101353 PLUG 1 X X (SUB FOR YZ105851)
10 YZ104087 BEARING CUP 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0350-7

PN=135
 1G3 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION CASE HARDWARE
YZ105131 -UN-27JUL05

THIS PARTS LISTING IS CONTINUED

0350-8 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=136
 1G4 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION CASE HARDWARE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 .................. HOUSING 1 X X FRONT HOUSING

2 .................. HOUSING 1 X X REAR HOUSING
3 19M2905 CAP SCREW 2 X X M12 X 120
4 19M7289 CAP SCREW 1 X X M12 X 110, (SUB FOR 19M2903)
5 19M7758 CAP SCREW 18 X X M12 X 130, (SUB FOR 19M2906)
6 YZ102234 DEFLECTOR 1 X X BAFFLE
7 YZ104125 SCREEN 1 X X
8 P50631 O-RING 1 X X (SUB FOR F37030226)
9 YZ105259 OIL LINE 1 X X
10 19M3129 CAP SCREW 2 X X M8 X 20, (SUB FOR 19M9064)
11 RE12119 WHEEL SPEED SENSOR 1 X X
12 F37020114 O-RING 3 X X
13 R67230 COVER 2 X X
14 19M3118 CAP SCREW 4 X X M6 X 20
15 12H302 LOCK WASHER 4 X X 1/4"
16 24H1287 WASHER 4 X X 9/32" X 5/8" X 0.065"
17 YZ104746 SENSOR 2 X X
18 YZ104678 LOCK WASHER 1 X X (SUB FOR YZ104114)
19 F39000175 SNAP RING 1 X X (SUB FOR YZ104121)
20 YZ105354 SEAL 1 X X
21 YZ105724 PLATE 1 X X
22 F37020159 O-RING 1 X X
23 YZ250086 SERIAL NUMBER PLATE 1 X X
24 F310063 SCREW 2 X X
25 YZ104140 RETAINER 1 X X
26 F37030239 O-RING 1 X X
27 YZ104170 SHIM 1 X X
28 19M3131 CAP SCREW 5 X X M8 X 25
29 F85108 FITTING PLUG 1 X X
30 YZ104280 BEARING CUP 1 X X
31 .................. PLUG 1 X X ( R66405 NO LONGER AVAILABLE)
32 19M3160 CAP SCREW 4 X X
33 19M6458 CAP SCREW 1 X X
34 F23303 PLUG 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0350-9

PN=137
 1G5 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION SCREEN
YZ105123A -UN-25AUG04

THIS PARTS LISTING IS CONTINUED

0350-12 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=138
 1G6 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION SCREEN

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ106205 HOUSING 1 X X (SUB FOR YZ105575) FRONT

2 YZ101474 SHAFT 1 X X
3 P50631 O-RING 1 X X (SUB FOR F37030226)
4 F85120 FITTING PLUG 1 X X
F37060920 O-RING 1 X X (USE WITH F85120) (NOT ILLUSTRATED)
5 U44115 FITTING PLUG 2 X X
R28782 O-RING 2 X X (USE WITH U44115) (NOT ILLUSTRATED)
6 F37030219 O-RING 1 X X
7 YZ105538 SCREEN 1 X X
8 24M7088 WASHER 1 X X
9 19M3115 CAP SCREW 2 X X M6 X 12
10 YZ105539 MAGNET 1 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 0350-13

PN=139
 1G7 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION FIRST STAGE ASSEMBLY
YZ103673PCD01 -UN-14DEC04

THIS PARTS LISTING IS CONTINUED

0350-14 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=140
 1G8 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION FIRST STAGE ASSEMBLY

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ106202 SHAFT 1 X X INPUT, (SUB FOR YZ103847)

2 YZ103188 BEARING CONE 1 X X
3 YZ104281 BEARING CUP 1 X X
4 YZ250161 SEAL 2 X X (SUB FOR 40B1113)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-15

PN=141
 1G9 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION SECOND STAGE ASSEMBLY
(YZ105413)
T148929A -UN-27AUG04

THIS PARTS LISTING IS CONTINUED

0350-16 770D/772D MOTOR GRADER PC9449 (02-FEB-05)
PN=142
 1G10 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION SECOND STAGE ASSEMBLY

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105508 UNIVERSAL DRIVESHAFT 1 X X SECOND STAGE

2 YZ150119 SEAL 2 X X
3 F37020144 O-RING 2 X X
4 YZ105689 PISTON 2 X X (SUB FOR 4008520)
5 4008521 WASHER 2 X X
6 4003725 DISK SPRING 12 X X
7 4009711 RETAINER 2 X X
8 F81743 SNAP RING 2 X X
9 YZ106211 SEPARATOR 20 X X (SUB YZ104908)
10 YZ105493 CLUTCH PLATE 18 X X (SUB FOR YZ105892)
11 YZ105454 RETAINER 2 X X
12 YZ105465 SNAP RING 2 X X
13 YZ105059 GEAR 1 X X 59 T
14 YZ103113 GEAR 1 X X 51 T
15 YZ105415 BALL BEARING 2 X X
16 YZ106078 BALL BEARING 2 X X (SUB FOR F40110)
17 YZ106184 BALL BEARING 2 X X (SUB FOR YZ150041)
18 YZ105485 SNAP RING 2 X X (SUB FOR F81696)
19 YZ250161 SEAL 3 X X
20 F37030244G O-RING 2 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 0350-17

PN=143
 1G11 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION THIRD STAGE ASSEMBLY
T148930A -UN-30AUG04

THIS PARTS LISTING IS CONTINUED

0350-18 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=144
 1G12 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION THIRD STAGE ASSEMBLY

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105509 UNIVERSAL DRIVESHAFT 1 X X THIRD STAGE, (SUB FOR YZ102996)

2 YZ150119 SEAL 2 X X
3 F37020144 O-RING 2 X X
4 YZ105689 PISTON 2 X X (SUB FOR 4008520)
5 4008521 WASHER 2 X X
6 4003725 DISK SPRING 12 X X
7 4009711 RETAINER 2 X X
8 F81743 SNAP RING 2 X X
9 YZ106211 SEPARATOR 20 X X (SUB YZ104908)
10 YZ105493 CLUTCH PLATE 18 X X (SUB FOR YZ105892)
11 YZ105454 RETAINER 2 X X
12 YZ105465 SNAP RING 2 X X
13 YZ103111 GEAR 1 X X 59 T
14 YZ103112 GEAR 1 X X 51 T
15 YZ105415 BALL BEARING 2 X X
16 YZ106078 BALL BEARING 2 X X (SUB FOR F40110)
17 YZ106185 BALL BEARING 2 X X (SUB FOR YZ103129)
18 YZ105485 SNAP RING 2 X X (SUB FOR F81696)
19 YZ250161 SEAL 3 X X
20 F37030244G O-RING 2 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 0350-19

PN=145
 1G13 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION FOURTH STAGE ASSEMBLY
T148933 -UN-10DEC01

THIS PARTS LISTING IS CONTINUED

0350-20 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=146
 1G14 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION FOURTH STAGE ASSEMBLY

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105464 UNIVERSAL DRIVESHAFT 1 X X FOURTH STAGE, (SUB FOR YZ105464)

2 YZ150119 SEAL 2 X X
3 F37020144 O-RING 2 X X
4 YZ105689 PISTON 2 X X (SUB FOR 4008520)
5 4008521 WASHER 2 X X
6 4003725 DISK SPRING 12 X X
7 F81743 SNAP RING 2 X X
8 4009711 RETAINER 2 X X
9 YZ106212 SEPARATOR 20 X X (SUB YZ150185)
10 YZ105891 CLUTCH PLATE 20 X X (SUB FOR YZ105494)
11 YZ150217 RETAINER 2 X X (SUB FOR YZ100356)
12 YZ105982 SNAP RING 2 X X (SUB FOR YZ103040)
13 YZ105443 GEAR 1 X X 38/39 T
14 YZ103100 GEAR 1 X X 38 T
16 YZ106163 BALL BEARING 2 X X (SUB FOR YZ103876)
17 YZ103875 BALL BEARING 1 X X
18 YZ105485 SNAP RING 2 X X (SUB FOR F81696)
19 YZ250161 SEAL 3 X X
20 YZ103144 BALL BEARING 1 X X
21 YZ104733 BEARING 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-21

PN=147
 1G15 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION FIFTH STAGE ASSEMBLY
T148939 -UN-10DEC01

THIS PARTS LISTING IS CONTINUED

0350-22 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=148
 1G16 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION FIFTH STAGE ASSEMBLY

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105463 UNIVERSAL DRIVESHAFT 1 X X FIFTH STAGE, (SUB FOR YZ103130)

2 YZ150119 SEAL 2 X X
3 F37020144 O-RING 2 X X
4 YZ105689 PISTON 2 X X (SUB FOR 4008520)
5 4008521 WASHER 2 X X
6 4003725 DISK SPRING 12 X X
7 F81743 SNAP RING 2 X X
8 4009711 RETAINER 2 X X
9 YZ106212 SEPARATOR 20 X X (SUB YZ150185)
10 YZ105891 CLUTCH PLATE 20 X X (SUB FOR YZ105494)
11 YZ150217 RETAINER 2 X X (SUB FOR YZ100356)
12 YZ105982 SNAP RING 2 X X (SUB FOR YZ103040)
13 YZ103102 GEAR 2 X X 75 T
15 YZ105415 BALL BEARING 2 X X
16 YZ106078 BALL BEARING 2 X X (SUB FOR F40110)
17 YZ106185 BALL BEARING 2 X X (SUB FOR YZ103129)
18 YZ105485 SNAP RING 2 X X (SUB FOR F81696)
19 YZ250161 SEAL 3 X X

770D/772D MOTOR GRADER PC9449 (02-FEB-05) 0350-23

PN=149
 1G17 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION SIXTH STAGE ASSEMBLY
T148940 -UN-10DEC01

THIS PARTS LISTING IS CONTINUED

0350-24 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=150
 1G18 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION SIXTH STAGE ASSEMBLY

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ104653 SHAFT 1 X X
2 YZ104281 BEARING CUP 1 X X
3 YZ104088 BEARING CONE 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-25

PN=151
 1G19 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION OUTPUT
TP48791 -UN-09MAY96

THIS PARTS LISTING IS CONTINUED

0350-26 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=152
 1G20 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION OUTPUT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ104154 SHAFT 1 X X
2 YZ103188 BEARING CONE 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-27

PN=153
 1G21 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
PARK BRAKE
T148941C -UN-30AUG04

THIS PARTS LISTING IS CONTINUED

0350-28 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=154
 1G22 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
PARK BRAKE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ104052 COVER 1 X X
2 YZ103067 HOUSING 1 X X
3 YZ103185 PISTON 1 X X
4 YZ103115 DISK SPRING 1 X X PISTON RETURN
5 F37030275 O-RING 1 X X
6 YZ101349 SEAL 1 X X OUTER PISTON
7 YZ101350 SEAL 1 X X INNER PISTON
8 YZ100952 CLUTCH PLATE 9 X X SEPARATOR
9 RE234261 BRAKE DISK 8 X X (SUB FOR AR94517)
10 19M7289 CAP SCREW 4 X X M12 X 110, (SUB FOR 19M2903)
11 YZ105386 HUB 1 X X
12 19M7716 CAP SCREW 10 X X
13 .................. PLUG 1 X X ( R66405 NO LONGER AVAILABLE)
14 19M3187 CAP SCREW 1 X X
15 4005234 WASHER 1 X X
16 YZ104871 GASKET 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-29

PN=155
 1G23 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION YOKE
YZ105897PCD01 -UN-20AUG04

THIS PARTS LISTING IS CONTINUED

0350-30 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=156
 1G24 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION YOKE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105685 YOKE 1 X
YZ105685 YOKE 1 X
2 YZ105914 SEAL 1 X X (SUB YZ104237)
3 YZ101905 CAP 1 X X EXPANSION
4 YZ105893 SEAL 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-31

PN=157
 1H1 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION CONTROL VALVE MOUNTING
YZ104586PCD01 -UN-30AUG04

THIS PARTS LISTING IS CONTINUED

0350-32 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=158
 1H2 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION CONTROL VALVE MOUNTING

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ104198 HOUSING 1 X X
2 YZ104179 GASKET 1 X X (TRANS HOUSING TO PLATE)
3 YZ104180 GASKET 1 X X (VALVE HOUSING TO PLATE)
4 YZ104959 PLATE 1 X X
5 19M2972 CAP SCREW 5 X X M8 X 45
6 19M9050 CAP SCREW 13 X X M8 X 75
7 19M9066 CAP SCREW 9 X X M8 X 90
8 RE38310 SENSOR 1 X X
9 R26286 O-RING 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0350-33

PN=159
 1H3 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION CONTROL VALVE
YZ07026 -UN-26JUL05

THIS PARTS LISTING IS CONTINUED

0350-34 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=160
 1H4 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION CONTROL VALVE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ104198 HOUSING 1 X X (SUB FOR YZ103114)

2 YZ250249 REGULATOR 1 X X TRANSMISSION PRESSURE, (SUB FOR YZ501639)
3 YZ106316 PRESSURE RELIEF VALVE 1 X X OIL COOLER BYPASS, (SUB YZ105065)
YZ105486 SEAL KIT 1 X X
4 YZ501931 VALVE 8 X X (SUB FOR YZ150141)
5 U44115 FITTING PLUG 12 X X TEST PORT
6 F85006 FITTING PLUG 2 X X TEST PORT
F37060906 O-RING 2 X X
7 RE38310 SENSOR 1 X X TRANS TEMPERATURE
8 R26286 O-RING 1 X X
9 R28782 O-RING 12 X X
10 F37060910 O-RING 1 X X (ONE USED ON EACH SOLENOID VALVE)
11 F37010016 O-RING 1 X X (ONE USED ON EACH SOLENOID VALVE)
12 YZ101612 O-RING 1 X X (ONE USED ON EACH SOLENOID VALVE)
13 F37020122 O-RING 1 X X (ONE USED ON EACH SOLENOID VALVE)
14 F37020123 O-RING 1 X X (ONE USED ON EACH SOLENOID VALVE)
15 F37020124 O-RING 1 X X (ONE USED ON EACH SOLENOID VALVE)
16 YZ502169 NUT 1 X X (SUB FOR YZ150204)
17 W37636 O-RING 2 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0350-35

PN=161
 1H5 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
TRANSMISSION CHARGE PUMP
(YZ105130)
YZ105129PCD02 -UN-26JUL05

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 YZ105258 OIL PUMP 1 X X 50CC

2 F37020159 O-RING 1 X X
3 19M6754 CAP SCREW 3 X X
4 38H1165 ADAPTER 1 X X FITTING, FLAT FACE
5 U13639 O-RING 1 X X
6 T78612 O-RING 1 X X

0350-36 770D/772D MOTOR GRADER PC9449 (30-AUG-05)

PN=162
 TRANSMISSION 3
GEARS, SHAFTS, BEARINGS AND POWER SHIFT CLUTCH 0350
MEMORANDA

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0350-37

PN=163
 1H6 TRANSMISSION 3
HYDRAULIC SYSTEM 0360
TRANSMISSION FILTER AND HOSES
T202000 -UN-29NOV04

THIS PARTS LISTING IS CONTINUED

0360-2 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=164
 1H7 TRANSMISSION 3
HYDRAULIC SYSTEM 0360
TRANSMISSION FILTER AND HOSES

7 7
7 7
TRANSMISSION 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7402 CAP SCREW 5 X X M10 X 25

2 24M7239 WASHER 5 X X
3 T204678 PLATE 1 X X
4 38H1007 ELBOW FITTING 2 X X
5 T77858 O-RING 6 X X
6 U12547 O-RING 3 X X
7 38H1052 ELBOW FITTING 1 X X
8 R29936 O-RING 2 X X
9 38H1163 ADAPTER 1 X X
10 38H1438 TEE FITTING 1 X X
11 AT307581 HYDRAULIC HOSE - FABRICATE 1 X X
12 AT307582 HYDRAULIC HOSE - FABRICATE 1 X X
13 AT307588 HYDRAULIC HOSE - FABRICATE 1 X X
14 AT305048 FILTER HEAD 1 X X
15 AT307045 PRESSURE SWITCH 1 X X
16 P46051 O-RING 1 X X
17 AT305049 HYDRAULIC FILTER 1 X X (TRANSMISSION FILTER)
18 AT180119 FITTING 2 X X
19 R77175 COVER 2 X X
20 R28782 O-RING 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0360-3

PN=165
 1H8 TRANSMISSION 3
HYDRAULIC SYSTEM 0360
TRANSMISSION VALVE GUARDS
T202316 -UN-02SEP04

THIS PARTS LISTING IS CONTINUED

0360-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=166
 1H9 TRANSMISSION 3
HYDRAULIC SYSTEM 0360
TRANSMISSION VALVE GUARDS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7865 SCREW 6 X X M8 X 16
2 AT226446 DUST SHIELD 3 X X .75" HEAT SHRINK, HIGH RATIO
3 AT226447 DUST SHIELD 1 X X 1.3" HEAT SHRINK, HIGH RATIO
4 AT312106 SHIELD 1 X X TRANSMISSION VALVE GUARD, LEFT
5 AT312107 SHIELD 1 X X TRANSMISSION VALVE GUARD, RIGHT

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0360-5

PN=167
 1H10 TRANSMISSION 3
TRANSMISSION OIL LINES 0363
TRANSMISSION OIL COOLER HOSES AND ACCUMULATOR
T208489 -UN-18FEB05

THIS PARTS LISTING IS CONTINUED

0363-2 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=168
 1H11 TRANSMISSION 3
TRANSMISSION OIL LINES 0363
TRANSMISSION OIL COOLER HOSES AND ACCUMULATOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1097 ELBOW FITTING 1 X X

2 T77858 O-RING 4 X X
3 38H1194 ADAPTER 3 X X
4 R29936 O-RING 3 X X
5 AT307165 HYDRAULIC HOSE - FABRICATE 1 X X
6 AT320242 HYDRAULIC HOSE - FABRICATE 1 X X
7 38H1026 TEE FITTING 1 X X
8 AT320243 HYDRAULIC HOSE - FABRICATE 1 X X
9 19M7938 CAP SCREW 2 X X M10 X 20
10 24M7239 WASHER 2 X X
11 AT313425 HYDRAULIC ACCUMULATOR 1 X X
12 T126204 CLAMP 2 X X
13 U12547 O-RING 2 X X
14 T155572 SAFETY SIGN 1 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 0363-3

PN=169
 TRANSMISSION 3
TRANSMISSION OIL LINES 0363
MEMORANDA

0363-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=170
 1H15 ENGINE 4
CRANKSHAFT AND MAIN BEARINGS 0401
CRANKSHAFT
RGP8789 -UN-13MAY02

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 34M7089 DOWEL PIN 1 X X 4 X 12 MM

2 R41934 DOWEL PIN 1 X X
3 R120752 KEY 1 X X 1/8" X 0.625"
4 R104587 GEAR 1 X X
5 RE505124 CRANKSHAFT 1 X X (MARKED R120030 AND RE505124)
6 R116311 KEY 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0401-1

PN=171
 1H16 ENGINE 4
CRANKSHAFT AND MAIN BEARINGS 0401
MAIN BEARINGS
RGP1272 -UN-01JAN94

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE61253 THRUST WASHER 1 X X STD, (INCLUDES (3) R124381)

RE61851 THRUST WASHER 1 X X 0.18 MM (.007") OS, (INCLUDES (3)
R124842)
2 RE504198 THRUST BEARING 1 X X STD, (INCLUDES R502127 AND R502128)
RE504199 THRUST BEARING 1 X X 0.292 MM (.011") US, (INCLUDES R502315
AND R502319)
RE504200 THRUST BEARING 1 X X 0.552 MM (.022") US, (INCLUDES R502316
AND R502320)
3 RE504195 BEARING 6 X X STD, (INCLUDES R502125 AND R502126)
RE504196 BEARING 6 X X 0.292 MM (.011") US, (INCLUDES R502317
AND R502321)
RE504197 BEARING 6 X X 0.552 MM (.022") US, (INCLUDES R502318
AND R502322)

0401-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=172
 1H17 ENGINE 4
CAMSHAFT AND VALVE ACTUATING MEANS 0402
CAMSHAFT AND GEARS
RGP3752 -UN-01JAN94

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R87561 BUSHING 4 X X
2 R110126 FOLLOWER 12 X X
3 RE57054 CAMSHAFT 1 X X (MARKED R120872)
4 26H91 SHAFT KEY 1 X X 3/16" X 1-1/4"
5 R504811 WASHER 2 X X
6 R104589 GEAR 1 X X FUEL INJECTION DRIVE
7 R518212 GEAR 1 X X CAMSHAFT

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0402-1

PN=173
 1H18 ENGINE 4
CAMSHAFT AND VALVE ACTUATING MEANS 0402
ROCKER ARMS, SHAFT AND PUSH RODS
RGP8223 -UN-26SEP01

THIS PARTS LISTING IS CONTINUED

0402-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=174
 1H19 ENGINE 4
CAMSHAFT AND VALVE ACTUATING MEANS 0402
ROCKER ARMS, SHAFT AND PUSH RODS

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3833 SCREW 12 X X 5/16" X 1-3/4"

2 U17408 RING 2 X X
3 24H1384 WASHER 2 X X 49/64" X 1-1/16" X 0.036"
4 R27443 SET SCREW 2 X X
5 14H1080 NUT 2 X X 3/8"
6 RE24046 ROCKER ARM 1 X X (A) (1I, 2E, 3I, 4E, 5I, 6E) (LH)
7 RE24045 ROCKER ARM 1 X X (A) (1E, 2I, 3E, 4I, 5E, 6I) (RH)
8 RE521278 KIT 6 X X
9 R85027 PUSH ROD 12 X X
10 R110126 FOLLOWER 12 X X
11 .................. CYLINDER HEAD 1 X X

(A) - E (EXHAUST VALVE) - I (INTAKE VALVE)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0402-3

PN=175
 1H20 ENGINE 4
CAMSHAFT AND VALVE ACTUATING MEANS 0402
ROCKER ARM COVER AND VENTILATING SYSTEM
RGP10897 -UN-14DEC04

THIS PARTS LISTING IS CONTINUED

0402-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=176
 1H21 ENGINE 4
CAMSHAFT AND VALVE ACTUATING MEANS 0402
ROCKER ARM COVER AND VENTILATING SYSTEM

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2151 CAP SCREW 2 X X 1/4" X 3"

2 24H1286 WASHER 15 X X 9/32" X 1/2" X 1/16"
3 19H1914 CAP SCREW 7 X X 1/4" X 1"
4 R72328 O-RING 1 X X 0.737" X 0.103"
5 R120467 ELBOW FITTING 1 X X
6 R504093 SEAL 4 X X
7 R502598 SEAL 1 X X
8 37H26 SCREW 5 X X 0.116" X 1/4"
9 RE505094 VALVE COVER 1 X X
10 19H2334 CAP SCREW 6 X X 1/4" X 2-1/2"
11 R502695 HOUSING 1 X X
12 RE509048 WIRING HARNESS 1 X X (INCLUDES R520373)
R520373 SEAL 1 X X
13 24H1287 WASHER 2 X X 9/32" X 5/8" X 0.065"
14 19H2036 CAP SCREW 2 X X 1/4" X 7/8"
15 R502719 SEAL 1 X X
16 RE509265 HOUSING 1 X X
17 R134920 NUT 12 X X M7
18 TY22467 CLAMP 1 X X
19 .................. BULK HOSE 1 X X (MAKE FROM TY22450) (CUT TO LENGTH)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0402-5

PN=177
 1H22 ENGINE 4
CAMSHAFT AND VALVE ACTUATING MEANS 0402
TIMING GEAR COVER AND FRONT OIL SEAL
RGP10908 -UN-17DEC04

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AR49025 SEAL 1 X X (INCLUDES R32617)

2 R119384 GASKET 1 X X
3 R115129 CAP SCREW 3 X X
4 R502083 COVER 1 X X W/O AUX DRIVE
5 R104859 SCREW 3 X X
6 R11086 DOWEL PIN 2 X X
7 RE517059 WASHER 2 X X
8 19H3693 SCREW 1 X X 3/8" X 1-1/4"
9 R131890 COVER 1 X X INJECTION PUMP ACCESS
10 R112268 SCREW 1 X X
11 19H3300 CAP SCREW 5 X X 5/16" X 3-3/4"
12 24H1136 WASHER 5 X X 11/32" X 11/16" X 0.065"
13 R502011 GASKET 1 X X
14 R504811 WASHER 1 X X
15 51M7044 O-RING 1 X X 17.300 X 2.200 MM
16 RE517370 FITTING PLUG 1 X X M20X1.5
17 R98527 FILTER 1 X X
18 F1743R DOWEL PIN 2 X X
.. R32617 RETAINER 1 X X WEAR

0402-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=178
 1H23 ENGINE 4
CONNECTING RODS AND PISTONS 0403
PISTONS, CONNECTING RODS AND CYLINDER LINERS
RGP9618 -UN-06JUN03

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 E1343FN SNAP RING 12 X X

2 R57771 PISTON PIN 6 X X
3 R74008 BUSHING 6 X X
4 R501035 CAP SCREW 12 X X
5 RE501513 CONNECTING ROD 6 X X (MARKED R501034)
6 R93948 SHIM AR X X 0.05MM (.002") (2 MAXIMUM)
7 R116081 BEARING 12 X X STD
RE57167 BEARING 12 X X 0.292MM (.011") US, (INCLUDES (2)
R121338)
8 RE503528 PISTON RING 6 X X
9 AR98850 O-RING KIT 6 X X
10 RE64509 PISTON-LINER KIT 6 X X (PISTON MARKED RE70688)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0403-1

PN=179
 ENGINE 4
CONNECTING RODS AND PISTONS 0403
MEMORANDA

0403-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=180
 ENGINE 4
CYLINDER BLOCK 0404
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0404-1

PN=181
 1H24 ENGINE 4
CYLINDER BLOCK 0404
CYLINDER BLOCK FITTINGS AND BEARING CAPS
RGP4339 -UN-01JAN94

THIS PARTS LISTING IS CONTINUED

0404-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=182
 1H25 ENGINE 4
CYLINDER BLOCK 0404
CYLINDER BLOCK FITTINGS AND BEARING CAPS

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R43409 PLUG 2 X X
2 R515224 STUD 4 X X 3/8" X 1.929"
3 R121765 DIPSTICK TUBE 1 X X 141.5 MM
4 AT13740 DRAIN VALVE 1 X X 1/4"-18NPT
5 RE57836 PIPE PLUG 4 X X 1/2"-14NPT
6 R39741 DRAIN PLUG 1 X X NO ENGINE HEATER
7 U13639 O-RING 1 X X 1.475" X 0.118"
8 15H690 PIPE PLUG 2 X X 3/4"-14NPT
9 R42340 BUSHING 2 X X
10 R1612R DOWEL PIN 2 X X
11 F1743R DOWEL PIN 2 X X
12 RE71255 PIPE PLUG 6 X X 1/8"-27NPT
13 R43621 ORIFICE 6 X X PISTON COOLING JET
14 T35390 PLUG 1 X X OIL FILL HOLE
15 R500642 BUSHING 2 X X
16 R27149 O-RING 1 X X 0.921" X 0.139"
17 AR61533 PLUG 1 X X
18 A4365R O-RING 1 X X 0.239" X 0.070"
19 AR61589 PLUG 1 X X
20 R519287 CAP SCREW 14 X X
21 R120953 BEARING CAP 6 X X MAIN
R120954 BEARING CAP 1 X X THRUST
22 R82007 PLUG 1 X X
23 R87561 BUSHING 4 X X CAMSHAFT
24 R61288 DOWEL PIN 1 X X 5/8" X 0.472"
25 15H686 PIPE PLUG 1 X X 1"
.. 37H44 SCREW 2 X X NO. 7 X 3/8" TYPE U, ENG. SERIAL NO.
PLATE (NOT SHOWN)
.. R501255 PLUG 1 X X AUXILARY DRIVE IDLER GEAR HOLE (NOT
SHOWN)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0404-3

PN=183
 1I1 ENGINE 4
CYLINDER BLOCK 0404
SHORT BLOCK ASSEMBLY
RGP4577 -UN-02NOV95

THIS PARTS LISTING IS CONTINUED

0404-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=184
 1I2 ENGINE 4
CYLINDER BLOCK 0404
SHORT BLOCK ASSEMBLY

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE506660 SHORT BLOCK ASSEMBLY 1 X X (PISTON MARKED RE70688) (ALSO ORDER

R121765)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0404-5

PN=185
 1I3 ENGINE 4
CYLINDER BLOCK 0404
OVERHAUL KIT
RGP10202 -UN-08SEP03

THIS PARTS LISTING IS CONTINUED

0404-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=186
 1I4 ENGINE 4
CYLINDER BLOCK 0404
OVERHAUL KIT

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE521154 ENGINE OVERHAUL KIT 1 X X (CONTAINS (6) RE64509 PISTON/LINERS,

RE521058 GASKET KIT, STD BEARINGS,
FRONT/REAR SEALS, AND SNAP RINGS) (ALSO
ORDER (6) R57771 PISTON PINS, (6)
RE501513 CONNECTING RODS MARKED
R501034, AND R520583 OIL PAN GASKET)
(PISTON MARKED RE70688)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0404-7

PN=187
 ENGINE 4
CYLINDER BLOCK 0404
MEMORANDA

0404-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=188
 1I5 ENGINE 4
OILING SYSTEM 0407
OIL DIPSTICK AND TUBE
RGP4446 -UN-03MAR95

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE500216 DIPSTICK 1 X X
2 R121765 DIPSTICK TUBE 1 X X 141.5MM

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0407-1

PN=189
 1I6 ENGINE 4
OILING SYSTEM 0407
OIL PAN AND DRAIN VALVE
RGP10895 -UN-05JAN05

THIS PARTS LISTING IS CONTINUED

0407-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=190
 1I7 ENGINE 4
OILING SYSTEM 0407
OIL PAN AND DRAIN VALVE

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R27474 DRAIN PLUG 1 X X 7/8"-14UNF

2 R47151 O-RING 1 X X 0.755" X 0.097"
3 15H690 PIPE PLUG 1 X X 3/4"-14NPTF
4 RE522649 OIL PAN 1 X X
5 R520583 GASKET 1 X X
6 R26906 O-RING 1 X X 0.755" X 0.097"
7 AT152180 DRAIN VALVE 1 X X 7/8"-14UNF
8 24M7239 WASHER 22 X X 10.700 X 21 X 2.500 MM
9 19H3565 CAP SCREW 2 X X 3/8" X 6-1/8"
10 R135895 WASHER 2 X X 13.500 X 27 X 3.400 MM
11 19H2473 CAP SCREW 2 X X 1/2" X 1-3/4"
12 19H2633 CAP SCREW 16 X X 3/8" X 1-1/2"
13 19H3485 CAP SCREW 4 X X 3/8" X 2"
14 R89441 GASKET 1 X X REAR

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0407-3

PN=191
 1I8 ENGINE 4
OILING SYSTEM 0407
OIL PUMP
RGP4450 -UN-03MAR95

THIS PARTS LISTING IS CONTINUED

0407-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=192
 1I9 ENGINE 4
OILING SYSTEM 0407
OIL PUMP

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R500642 BUSHING 2 X X
2 R502773 GEAR 1 X X Z= 48
3 T21242 WASHER 1 X X
4 14H826 NUT 1 X X 1/2"
5 R57696 WASHER 4 X X
6 19H3759 CAP SCREW 2 X X 3/8" X 1-7/8"
7 19H3219 CAP SCREW 2 X X 3/8" X 1-3/8"
8 22H1040 SET SCREW 1 X X 5/16" X 1-1/4"
9 14H785 NUT 1 X X 5/16"
10 R100569 GASKET 1 X X
11 R71732 O-RING 1 X X
12 R116718 OIL TUBE 1 X X
13 R71732 O-RING 1 X X
14 R104628 SCREW 5 X X
15 SE500877 OIL PUMP 1 X X (REMANUFACTURED) (MARKED R504028)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0407-5

PN=193
 1I10 ENGINE 4
OILING SYSTEM 0407
OIL PUMP INTAKE
RGP3629 -UN-01JAN94

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R100569 GASKET 1 X X
2 RE520585 OIL PUMP INTAKE 1 X X
3 R104628 SCREW 3 X X

0407-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=194
 ENGINE 4
OILING SYSTEM 0407
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0407-7

PN=195
 1I11 ENGINE 4
OILING SYSTEM 0407
OIL FILTER AND HOUSING
RGP10903 -UN-16DEC04

THIS PARTS LISTING IS CONTINUED

0407-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=196
 1I12 ENGINE 4
OILING SYSTEM 0407
OIL FILTER AND HOUSING

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE57561 ADAPTER 1 X X
2 R128694 BASE 1 X X
3 R500055 VALVE 1 X X
4 R98064 SPRING 1 X X
5 U17409 O-RING 1 X X
6 R117073 FITTING PLUG 1 X X
7 R47153 O-RING 4 X X
8 R86063 TUBE 2 X X
9 R43660 PACKING 1 X X
10 RE521420 OIL FILTER 1 X X (MARKED RE520628)
11 19H3239 CAP SCREW 1 X X 3/8" X 1-1/4"
12 R119847 GASKET 1 X X
13 R124186 PRESSURE RELIEF VALVE 1 X X
14 R500330 SPRING 1 X X
15 U17409 O-RING 1 X X
16 R129821 FITTING PLUG 1 X X
17 19H3445 CAP SCREW 2 X X 3/8" X 3-3/4"
18 R129820 HOUSING 1 X X
19 R518382 ADAPTER 1 X X
20 19H3104 CAP SCREW 1 X X 7/16" X 1-1/4"
19H3205 CAP SCREW 1 X X 7/16" X 1-1/2"
21 24H1886 WASHER 1 X X 15/32" X 1-1/8" X 0.180", (USE WITH
19H3205)
22 RE71255 PIPE PLUG 2 X X 1/8"-27NPT
23 RE504581 ELBOW FITTING 1 X X 45°

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0407-9

PN=197
 1I13 ENGINE 4
OILING SYSTEM 0407
OIL COOLER BYPASS TUBES AND ADAPTER
RGP10904 -UN-16DEC04

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R504669 SEAL 2 X X
2 R71732 O-RING 4 X X
3 RE524007 ADAPTER 1 X X
4 24M7346 WASHER 2 X X 11 X 20 X 2 MM
5 R40236 CAP SCREW 2 X X
6 R116718 OIL TUBE 1 X X
7 R518376 OIL TUBE 1 X X

0407-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=198
 ENGINE 4
CYLINDER HEAD AND VALVES 0409
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0409-1

PN=199
 1I14 ENGINE 4
CYLINDER HEAD AND VALVES 0409
CYLINDER HEAD
RGP11115 -UN-28FEB05

THIS PARTS LISTING IS CONTINUED

0409-2 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=200
 1I15 ENGINE 4
CYLINDER HEAD AND VALVES 0409
CYLINDER HEAD

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T20129 CAP 12 X X
2 T20077 RETAINER 24 X X
3 R500098 CAP 12 X X
4 R502187 SPRING 12 X X
5 R121491 CAP SCREW 7 X X (A) (9/16" X 8.0")
6 R121490 CAP SCREW 8 X X (A) (9/16" X 6.9")
7 R502911 CAP SCREW 6 X X (A) (9/16" X 5.3")
8 R502912 CAP SCREW 5 X X (A) (9/16" X 5.9")
9 RE506501 KIT 1 X X (A)
10 15H690 PIPE PLUG 11 X X 3/4"-14NPT
11 R121193 VALVE SEAT INSERT 6 X X (B) I STD
R93350 VALVE SEAT INSERT 6 X X (B) I 0.25MM (.010") OS
12 R84618 INTAKE VALVE 6 X X STD
R93308 INTAKE VALVE 6 X X 0.08MM (.003") OS
R93312 INTAKE VALVE 6 X X 0.38MM (.015") OS
R93314 INTAKE VALVE 6 X X 0.76MM (.030") OS
13 R119132 VALVE SEAT INSERT 6 X X (B) E STD
R93349 VALVE SEAT INSERT 6 X X (B) E 0.25MM (.010") OS
14 R84619 EXHAUST VALVE 6 X X STD
R93311 EXHAUST VALVE 6 X X 0.08MM (.003") OS
R93313 EXHAUST VALVE 6 X X 0.38MM (.015) OS
R93315 EXHAUST VALVE 6 X X 0.76MM (.030") OS
15 RE519894 CYLINDER HEAD 1 X X (MARKED R517486)
16 RE55475 ENGINE CYLINDER HEAD GASKET 1 X X
17 19H2367 CAP SCREW 1 X X 5/8" X 3/4"
18 R501640 SHIELD 6 X X
19 R515575 PLUG 2 X X
.. R504327 DOWEL PIN 1 X X 9.525MM X 8MM, (NOT SHOWN)

(A) SPECIAL HEAD BOLTS

(B) E - (EXHAUST VALVE) I - (INTAKE VALVE)

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 0409-3

PN=201
 1I16 ENGINE 4
CYLINDER HEAD AND VALVES 0409
LIFT STRAPS
RGP3009 -UN-01JAN94

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R61497 STRAP 1 X X
2 R86571 ANGLE 1 X X
3 19H1756 CAP SCREW 2 X X 5/8" X 1-1/2"

0409-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=202
 1I17 ENGINE 4
EXHAUST MANIFOLD 0410
EXHAUST MANIFOLD
RGP4065 -UN-01JAN94

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R127425 EXHAUST MANIFOLD 1 X X REAR

2 R122595 RING 2 X X
3 R127426 EXHAUST MANIFOLD 1 X X FRONT
4 R521438 GASKET 2 X X OUTER
5 R521437 GASKET 2 X X INNER
6 R63845 WASHER 8 X X
7 19H3031 CAP SCREW 4 X X 3/8" X 2-1/2", UPPER
19H3267 CAP SCREW 4 X X 3/8" X 1-5/8", LOWER

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0410-1

PN=203
 1I18 ENGINE 4
EXHAUST MANIFOLD 0410
EXHAUST ELBOW
RGP5900 -UN-23FEB00

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R127563 ELBOW FITTING 1 X X

2 15H604 PIPE PLUG 1 X X 1/4"
3 24H1305 WASHER 4 X X 13/32" X 13/16" X 0.065"
4 R54500 SCREW 4 X X
5 RE40048 CLAMP 1 X X
6 R133307 ADAPTER 1 X X

0410-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=204
 ENGINE 4
FUEL INJECTION SYSTEM 0413
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0413-1

PN=205
 1I19 ENGINE 4
FUEL INJECTION SYSTEM 0413
FUEL INJECTION SYSTEM
RGP10893 -UN-14DEC04

THIS PARTS LISTING IS CONTINUED

0413-2 770D/772D MOTOR GRADER PC9449 (09-JUN-05)
PN=206
 1I20 ENGINE 4
FUEL INJECTION SYSTEM 0413
FUEL INJECTION SYSTEM

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3218 CAP SCREW 6 X X 3/8" X 1-3/4"

2 R63845 WASHER 6 X X
3 R502602 CLAMP 6 X X
4 R134920 NUT 12 X X
5 RE518726 INJECTION NOZZLE 6 X X (HPCR G2 1800) (BLUE DOT)
6 R503578 PACKING 6 X X
7 R131051 WASHER 6 X X
8 R505570 O-RING 8 X X 0.339" X 0.094"
9 RE509416 FITTING 6 X X
10 RE515524 FUEL LINE 1 X X (NO.6)
11 RE504017 FUEL LINE 1 X X (NO.5)
12 RE504016 FUEL LINE 1 X X (NO.4)
13 RE504015 FUEL LINE 1 X X (NO.3)
14 RE504014 FUEL LINE 1 X X (NO.2)
15 RE504013 FUEL LINE 1 X X (NO.1)
16 RE502655 CLAMP 2 X X (INCLUDES (2) 19M7502 AND (2) 24M7027)
17 RE509012 CLAMP 1 X X (INCLUDES (3) 19M7502 AND (3) 24M7027)
18 RE509013 CLAMP 1 X X (INCLUDES (4) 19M7502 AND (4) 24M7027)
19 RE502650 FITTING 6 X X 1/2"-24UNS X 1/8"-27NPT
20 R51936 SEALING WASHER 8 X X
21 R51937 TUBE NUT 6 X X
22 R63548 O-RING AR X X 0.364" X 0.070"
23 RE521476 MANIFOLD 1 X X
24 38H1415 FITTING AR X X 11/16"-16UN
25 RE521477 FUEL LINE 1 X X LEAK-OFF
26 RE507003 LINE 1 X X
27 RE506624 ADAPTER 1 X X M10X1.0 X 1/2"-24UNS
28 R515454 SHIM 1 X X
29 RE516335 PRESSURE RELIEF VALVE 1 X X M10X1.0 X M18X1.5, (MARKED 0161)
30 RE515636 RESTRICTOR 6 X X M14X1.5 X M18X1.5, (MARKED 0220)
31 RE520930 SENSOR 1 X X M22X1.5, (MARKED 6140)
32 RE521433 RAIL 1 X X (MARKED 0273)
33 19H2699 CAP SCREW 2 X X 7/16" X 2-1/4"
34 RE502654 CLAMP 1 X X (INCLUDES 19M7502 AND 24M7027)
35 RE505155 FUEL LINE 1 X X
36 RE505154 FUEL LINE 1 X X
37 R519759 O-RING 1 X X
38 RE522834 VALVE 1 X X M14X1.5 X (2) 11/16"-16ORFS, (INCLUDES
R77175)
39 RE503059 ADAPTER 1 X X M10X1.0 X 7/16"-24UNS

THIS PARTS LISTING IS CONTINUED

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0413-3
PN=207
 1I21 ENGINE 4
FUEL INJECTION SYSTEM 0413
FUEL INJECTION SYSTEM
RGP10893 -UN-14DEC04

THIS PARTS LISTING IS CONTINUED

0413-4 770D/772D MOTOR GRADER PC9449 (09-JUN-05)
PN=208
 1I22 ENGINE 4
FUEL INJECTION SYSTEM 0413
FUEL INJECTION SYSTEM

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

40 R67264 PACKING 2 X X
41 RE504156 OIL LINE 1 X X
42 R76822 FITTING 1 X X 7/16"-24UNS X 1/8"-27NPT
43 19M7783 SCREW 3 X X M10 X 16
44 R504089 BEVEL GEAR DRIVE 1 X X Z= 30
45 24M7239 WASHER 3 X X 10.700 X 21 X 2.500 MM
46 14H1090 NUT 3 X X 3/8"
47 24H1652 WASHER 1 X X 13/32" X 11/16" X 7/64"
48 19H3124 SCREW 1 X X 3/8" X 1-1/2"
49 51M7095 O-RING 3 X X 0.445" X 0.087"
50 RE520978 CHECK VALVE 1 X X M14X1.5 X 11/16"-16UN
51 RE522616 FITTING 2 X X M14X1.5 X 11/16"-16UN
52 R515456 WASHER 1 X X
53 RE515638 KIT 1 X X
54 R515457 O-RING 1 X X 99 X 3 MM
55 RE524660 KIT 1 X X (G SENSOR)
56 RE521423 FUEL INJECTION PUMP 1 X X (DENSO HPCR HPO 24V)
57 RE522515 ENGINE CONTROLLER 1 X X (ORDER WITH ESN) (12/24V)
58 RE523825 ADAPTER 1 X X 11/16"-16ORFS X 1/2", FUEL LINE
59 AR77962 HOSE CLAMP 1 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0413-5

PN=209
 ENGINE 4
FUEL INJECTION SYSTEM 0413
MEMORANDA

0413-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=210
 1I23 ENGINE 4
INTAKE MANIFOLD 0414
INTAKE MANIFOLD
RGP10894 -UN-17DEC04

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2633 CAP SCREW 6 X X 3/8" X 1-1/2"

2 24H1682 WASHER 6 X X 13/32" X 7/8" X 0.120"
3 51M7041 O-RING 1 X X 11.300 X 2.200 MM
4 RE46684 PLUG 1 X X M14X1.5, (W/O AIR HEATER)
5 R130573 GASKET 3 X X
6 RE71255 PIPE PLUG 1 X X 1/8"-27NPT
7 15H623 PIPE PLUG 1 X X 3/8"-18NPT
8 R504823 INTAKE MANIFOLD 1 X X (W/O AIR HEATER) (MARKED R504823)
RE515331 INTAKE MANIFOLD 1 X X (WITH AIR HEATER) (MARKED R515064)
(INCLUDES (2) RE66693)
.. RE66693 CABLE 2 X X (WITH AIR HEATER) (NOT SHOWN)
.. RE500882 AIR HEATER CONTROLLER 1 X X 24V, (NOT SHOWN)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0414-1

PN=211
 ENGINE 4
INTAKE MANIFOLD 0414
MEMORANDA

0414-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=212
 ENGINE 4
TURBOCHARGER 0416
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0416-1

PN=213
 1I24 ENGINE 4
TURBOCHARGER 0416
TURBOCHARGER AND OIL LINES
RGP4675 -UN-21JAN97

THIS PARTS LISTING IS CONTINUED

0416-2 770D/772D MOTOR GRADER PC9449 (09-JUN-05)
PN=214
 1I25 ENGINE 4
TURBOCHARGER 0416
TURBOCHARGER AND OIL LINES

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R54500 SCREW 4 X X 3/8" X 1"

2 24H1305 WASHER 4 X X 13/32" X 13/16" X 0.065"
3 T11180 ELBOW FITTING 1 X X
4 RE501669 TURBOCHARGER 1 X X (REMANUFACTURED) (SCHWITZER) (MARKED
RE520910)
R134028 HOSE 1 X X BOOST CONTROL (WASTEGATE)
5 RE20230 OIL LINE 1 X X
6 AH89486 CLIP 1 X X
7 .................. WASHER NA X X
8 .................. NUT NA X X
9 RE504581 ELBOW FITTING 1 X X 45°, (NOT SHOWN)
RE57561 ADAPTER 1 X X
10 R89879 GASKET 1 X X
11 R105346 GASKET 1 X X
12 R122618 SCREW 2 X X
13 RE69328 OIL LINE 1 X X
14 TY22467 CLAMP 2 X X
15 R500723 HOSE 1 X X
16 R126812 ELBOW FITTING 1 X X 1/2"-14NPT, 90°
RE524764 THREADED NIPPLE 1 256768- X X (TURBO OIL DRAIN LINE ADAPTER)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0416-3

PN=215
 ENGINE 4
TURBOCHARGER 0416
MEMORANDA

0416-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=216
 ENGINE 4
WATER PUMP 0417
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0417-1

PN=217
 1J1 ENGINE 4
WATER PUMP 0417
WATER PUMP AND COVER
RGP10902 -UN-15DEC04

THIS PARTS LISTING IS CONTINUED

0417-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=218
 1J2 ENGINE 4
WATER PUMP 0417
WATER PUMP AND COVER

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R119383 GASKET 1 X X
2 R503427 COVER 1 X X
3 AT13740 DRAIN VALVE 1 X X 1/4"-18NPT
4 RE57836 PIPE PLUG 1 X X 1/2"-14NPT
5 RE521496 SEAL KIT 1 X X
6 RE509463 KIT 1 X X SEAL
7 RE39134 SEAL 1 X X
8 RE521502 WATER PUMP 1 X X (LOW FLOW W/ 16 TOOTH GEAR) (MARKED
R503501)
9 R121316 RING 1 X X
10 R11086 DOWEL PIN 2 X X 0.127" X 0.380"
11 24M7096 WASHER 3 X X 10.500 X 18 X 1.600 MM
12 19H3445 CAP SCREW 3 X X 3/8" X 3-3/4"
13 19H3411 SCREW 2 X X 3/8" X 1-1/8"
14 24H1136 WASHER 1 X X 11/32" X 11/16" X 0.065"
15 19H1897 CAP SCREW 1 X X 5/16" X 3-3/4"
16 R39503 FITTING 1 X X 1/2"-14NPT

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0417-3

PN=219
 ENGINE 4
WATER PUMP 0417
MEMORANDA

0417-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=220
 ENGINE 4
THERMOSTATS, HOUSINGS AND WATER PIPING 0418
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0418-1

PN=221
 1J3 ENGINE 4
THERMOSTATS, HOUSINGS AND WATER PIPING 0418
THERMOSTAT HOUSING AND COVER
RGP10899 -UN-05JAN05

THIS PARTS LISTING IS CONTINUED

0418-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=222
 1J4 ENGINE 4
THERMOSTATS, HOUSINGS AND WATER PIPING 0418
THERMOSTAT HOUSING AND COVER

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R136151 SEAL 1 X X
2 RE502570 COVER 1 X X
3 T53268 SCREW 3 X X 3/8" X 0.870"
4 AR48675 THERMOSTAT 1 X X 82°C (180°F)
5 R100671 PLUG 1 X X
6 R519578 MANIFOLD 1 X X
7 RE57836 PIPE PLUG 2 X X 1/2"-14NPT
8 R133998 SCREW 2 X X 3/8" X 3.635"
9 19H3772 SCREW 1 X X 3/8" X 1-3/4"
10 R72328 O-RING 1 X X 0.737" X 0.103"
11 R504810 O-RING 1 X X 47/64" X 0.139"
12 RE509095 TUBE 1 X X
13 34H329 SPRING PIN 1 X X 5/16" X 1-1/4"
14 R86062 GASKET 1 X X
15 15H690 PIPE PLUG 1 X X 3/4"-14NPT

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0418-3

PN=223
 ENGINE 4
THERMOSTATS, HOUSINGS AND WATER PIPING 0418
MEMORANDA

0418-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=224
 1J5 ENGINE 4
OIL COOLER 0419
OIL COOLER
RGP10522 -UN-07APR04

7 7
7 7
ENGINE 0 0
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3768 SCREW 7 X X 5/16" X 1-3/8"

2 19H3769 SCREW 1 X X 5/16" X 2-1/2"
3 R504289 COVER 1 X X
4 R500055 VALVE 1 X X
5 R98064 SPRING 1 X X
6 R504670 RETAINER 1 X X
7 R518804 PACKING 4 X X
8 RE515781 OIL TUBE 2 X X
9 R504667 ADAPTER 1 X X
10 R504669 SEAL 2 X X
11 19H3771 SCREW 2 X X 3/8" X 1"
12 RE524105 GASKET 1 X X
13 AR55394 OIL COOLER 1 X X
14 R504668 SEAL 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0419-1

PN=225
 ENGINE 4
OIL COOLER 0419
MEMORANDA

0419-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=226
 ENGINE 4
FUEL FILTER 0420
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0420-1

PN=227
 1J6 ENGINE 4
FUEL FILTER 0420
FUEL FILTER AND LINES
RGP10900 -UN-01MAR05

THIS PARTS LISTING IS CONTINUED

0420-2 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=228
 1J7 ENGINE 4
FUEL FILTER 0420
FUEL FILTER AND LINES

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R504516 STUD 2 X X 7/16" X 2.638"

2 14H1059 NUT 2 X X 7/16"
3 R518524 BRACKET 1 X X
4 RE509668 CLAMP 1 X X
5 19H1791 CAP SCREW 2 X X 1/4" X 1-1/4"
6 R518563 HOSE GUARD 3 X X
7 R519483 PACKING 2 X X
8 RE520975 FUEL LINE 1 X X (INCLUDES R518563)
9 RE520981 FUEL LINE 1 X X (INCLUDES R518563)
10 RE520969 FILTER HEAD 1 X X FINAL FILTER
11 51M7096 O-RING 1 X X 13.300 X 2.200 MM
12 RE522518 FITTING 1 X X (INCLUDES 51M7096 AND R63548)
13 R63548 O-RING 1 X X 0.364" X 0.070"
14 51M7096 O-RING 1 X X 13.300 X 2.200 MM
15 RE522145 ADAPTER 1 X X (INCLUDES 51M7096 AND R63548)
16 R63548 O-RING 1 X X 0.364" X 0.070"
17 RE522688 FUEL FILTER 1 X X (2 MICRON) FINAL
18 51M7095 O-RING 1 X X 11.300 X 2.200 MM
19 57M7254 ELECTRICAL CONNECTOR ASSY 1 X X (ALSO ORDER 57M7258, 57M7289 AND (2)
R104846)
20 RE522685 MOISTURE SENSOR 1 X X
21 RE522686 DRAIN VALVE 1 X X
22 RE522687 FUEL FILTER 1 X X (10 MICRON) PRE-FILTER
23 19H3693 SCREW 4 X X 3/8" X 1-1/4"
24 51M7041 O-RING 1 X X 11.300 X 2.200 MM
25 RE48419 FUEL TEMPERATURE SENSOR 1 X X (INCLUDES 51M7041)
26 RE520971 CONTROL VALVE 1 X X (INCLUDES 51M7096 AND R63548)
27 51M7096 O-RING 1 X X 13.300 X 2.200 MM
28 R63548 O-RING 1 X X 0.364" X 0.070"
29 RE521473 FUEL LINE 1 X X
30 51M7096 O-RING 1 X X 13.300 X 2.200 MM
31 R63548 O-RING 2 X X 0.364" X 0.070"
32 RE522143 ADAPTER 1 X X (INCLUDES 51M7096 AND (2) R63548)
33 RE520972 FUEL LINE 1 X X (INCLUDES R518563)
34 RE523578 DIAGNOSTIC COUPLING 1 X X (INCLUDES 51M7096)
35 51M7096 O-RING 1 X X 13.300 X 2.200 MM
36 RE520967 FILTER HEAD 1 X X PRE-FILTER
37 RE520968 CHECK VALVE 1 X X (INCLUDES 51M7096 AND R63548)
38 R63548 O-RING 1 X X 0.364" X 0.070"
39 51M7096 O-RING 1 X X 13.300 X 2.200 MM
40 .................. CHECK VALVE 1 X X
41 .................. FUEL INJECTION PUMP 1 X X
42 RE522144 DRAIN PLUG 1 X X (INCLUDES 51M7095)
43 51M7095 O-RING 1 X X 11.300 X 2.200 MM
44 R505515 BRACKET 3 X X
45 19H2284 CAP SCREW 3 X X 3/8" X 7/8"

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 0420-3

PN=229
 ENGINE 4
FUEL FILTER 0420
MEMORANDA

0420-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=230
 ENGINE 4
STARTING MOTOR AND FASTENINGS 0422
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0422-1

PN=231
 1J8 ENGINE 4
STARTING MOTOR AND FASTENINGS 0422
STARTING MOTOR (24-VOLT DENSO)
RGP10898 -UN-14DEC04

THIS PARTS LISTING IS CONTINUED

0422-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=232
 1J9 ENGINE 4
STARTING MOTOR AND FASTENINGS 0422
STARTING MOTOR (24-VOLT DENSO)

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R135509 SEAL 1 X X
2 R135510 O-RING 1 X X 47.200 X 2.400 MM (1.858" X 0.094")
3 RE70678 SOLENOID 1 X X
4 RE70682 CLUTCH 1 X X
5 RE12362 ELECTRICAL CONNECTOR ASSY 1 X X
57M7271 ELEC. CONNECTOR TERMINAL 1 X X
6 RE505399 WIRING LEAD 1 X X TERMINAL M
7 .................. STARTER MOTOR 1 X X 24V
8 .................. COVER 1 X X TERMINAL 50
9 R96703 TIE BAND 1 X X
10 T146102 LABEL 1 X X BYPASS START (ENGLISH)
11 RE70756 KIT 1 X X SOLENOID COVER
12 RE506103 STARTER MOTOR KIT 1 X X 24V, (MARKED RE504245)
13 19H3219 CAP SCREW 2 X X 3/8" X 1-3/8"
14 24M7096 WASHER 1 X X 10.500 X 18 X 1.600 MM
15 R516315 STUD 1 X X (USE WITH RE506103)
16 E55662 FLANGE NUT 1 X X
17 R515224 STUD 1 X X
18 R53108 GASKET 1 X X
.. RE71256 SCREW WITH WASHER 1 X X M5X0.8, TERMINAL 50 (NOT SHOWN)
.. R136052 STUD 1 X X M12X1.75, TERMINAL G (NOT SHOWN)

770D/772D MOTOR GRADER PC9449 (02-FEB-05) 0422-3

PN=233
 ENGINE 4
STARTING MOTOR AND FASTENINGS 0422
MEMORANDA

0422-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=234
 ENGINE 4
ALTERNATOR AND GENERATOR MOUNTING 0423
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0423-1

PN=235
 1J10 ENGINE 4
ALTERNATOR AND GENERATOR MOUNTING 0423
ALTERNATOR MOUNTING BRACKET AND BELT TENSIONER
RGP4957 -UN-22AUG97

THIS PARTS LISTING IS CONTINUED

0423-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=236
 1J11 ENGINE 4
ALTERNATOR AND GENERATOR MOUNTING 0423
ALTERNATOR MOUNTING BRACKET AND BELT TENSIONER

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R98250 BOLT 1 X X
2 RE505264 IDLER 1 X X
3 R114837 DUST SHIELD 1 X X
4 RE68715 TIGHTENER 1 X X
5 19M7810 SCREW 1 X X M10 X 80
6 .................. STRAP NA X X
7 .................. CAP SCREW NA X X
8 19H3300 CAP SCREW 5 X X 5/16" X 3-3/4"
24H1136 WASHER 5 X X 11/32" X 11/16" X 0.065"
9 .................. SCREW NA X X
10 .................. BRACKET NA X X
11 .................. BUSHING NA X X
12 R131002 SUPPORT 1 X X
13 19H3771 SCREW 2 X X 3/8" X 1"
14 .................. BUSHING NA X X
15 R502011 GASKET 1 X X
16 R131890 COVER 1 X X
17 R112268 SCREW 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0423-3

PN=237
 ENGINE 4
ALTERNATOR AND GENERATOR MOUNTING 0423
MEMORANDA

0423-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=238
 1J12 ENGINE 4
FAN DRIVE 0429
CRANKSHAFT PULLEY AND DAMPENER
RGP4708 -UN-12JUL96

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 .................. CRANKSHAFT 1 X X
2 R116311 KEY 1 X X
3 RE57603 TORSIONAL DAMPER 1 X X
4 R26333 WASHER 1 X X
5 R79846 CAP SCREW 1 X X
6 .................. SPACER NA X X
7 R106998 PULLEY 1 X X OD 206.5MM
8 19H3219 CAP SCREW 6 X X 3/8" X 1-3/8"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0429-1

PN=239
 1J13 ENGINE 4
FAN DRIVE 0429
FIXED FAN DRIVE PULLEY
RGP10896 -UN-14DEC04

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R131001 SHAFT 1 X X
2 AT211041 IDLER 1 X X
3 R502079 SLEEVE 1 X X
4 19M8292 SCREW 1 X X M10 X 50

0429-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=240
 1J14 ENGINE 4
FLYWHEEL, HOUSING AND FASTENERS 0433
FLYWHEEL
RGP198 -UN-01JAN94

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R112883 CAP SCREW 6 X X 1/2" X 1-3/4"

2 T23891 WASHER 6 X X
3 R28811 RING GEAR 1 X X
4 AR68167 FLYWHEEL 1 X X (MARKED R56962)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0433-1

PN=241
 1J15 ENGINE 4
FLYWHEEL, HOUSING AND FASTENERS 0433
FLYWHEEL HOUSING AND CRANKSHAFT OIL SEAL HOUSING
RGP10891 -UN-24NOV04

THIS PARTS LISTING IS CONTINUED

0433-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=242
 1J16 ENGINE 4
FLYWHEEL, HOUSING AND FASTENERS 0433
FLYWHEEL HOUSING AND CRANKSHAFT OIL SEAL HOUSING

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R39112 FITTING 1 X X 3/4"-16UNF

2 R47150 O-RING 1 X X 0.644" X 0.087"
3 R121694 HOUSING 1 X X
4 R518995 GASKET 1 X X
R89441 GASKET 1 X X OIL PAN REMOVAL (LOWER PORTION ONLY) (NOT
SHOWN)
5 R27149 O-RING 1 X X 0.921" X 0.139"
6 AR61533 PLUG 1 X X
7 A4365R O-RING 1 X X 0.239" X 0.070"
8 AR61589 PLUG 1 X X
9 H79910 DOWEL PIN 2 X X 0.502" X 1.752"
10 24M7240 WASHER 2 X X 13 X 25 X 3 MM
11 19H2473 CAP SCREW 2 X X 1/2" X 1-3/4"
12 24M7239 WASHER 4 X X 10.700 X 21 X 2.500 MM
13 19H2633 CAP SCREW 4 X X 3/8" X 1-1/2"
14 RE57836 PIPE PLUG 1 X X 1/2"-14NPT
15 24M7353 WASHER 6 X X 20 X 34 X 3 MM
16 19H2001 CAP SCREW 4 X X 3/4" X 5-1/2"
17 19H2117 CAP SCREW 6 X X 5/16" X 1-1/8"
18 T27860 WASHER 6 X X 0.344" X 0.689" X 0.066"
19 R125027 HOUSING 1 X X
20 R520504 GASKET 1 X X
21 RE520036 SEAL 1 X X
22 19H1862 CAP SCREW 2 X X 3/4" X 2-1/2"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0433-3

PN=243
 ENGINE 4
FLYWHEEL, HOUSING AND FASTENERS 0433
MEMORANDA

0433-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=244
 ENGINE 4
GASKET REPLACEMENT KITS 0452
MEMORANDA

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0452-1

PN=245
 1J17 ENGINE 4
GASKET REPLACEMENT KITS 0452
GASKET KITS
RGP10184 -UN-11MAR04

THIS PARTS LISTING IS CONTINUED

0452-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=246
 1J18 ENGINE 4
GASKET REPLACEMENT KITS 0452
GASKET KITS

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R83021 GASKET 2 X X OUTER

2 R83020 GASKET 2 X X INNER
3 R92097 GASKET 1 X X
R89879 GASKET 1 X X
4 R105346 GASKET 1 X X
5 R130573 GASKET 3 X X
6 R72328 O-RING 1 X X
7 R502598 SEAL 1 X X COVER
R502719 SEAL 1 X X CARRIER
8 R504093 SEAL 4 X X
9 R501640 SHIELD 6 X X
10 RE55475 ENGINE CYLINDER HEAD GASKET 1 X X
11 R505570 O-RING 6 X X
12 R131051 WASHER 6 X X
R503578 PACKING 6 X X
13 R136063 SEAL 1 X X
14 R504810 O-RING 1 X X
15 R119383 GASKET 1 X X
16 R515457 O-RING 1 X X
17 RE521059 GASKET KIT 1 X X CYLINDER HEAD, (INCLUDES (8) R51936,
RE516171 AND (8) R63551) (DOES NOT
INCLUDE (4) R504093)
18 R132396 GASKET 1 X X
19 R47153 O-RING 4 X X
20 R50424 GASKET 1 X X
21 U17409 O-RING 1 X X
22 AR58952 GASKET 1 X X
23 U13639 O-RING 1 X X
24 R119384 GASKET 1 X X
25 R502011 GASKET 1 X X
26 R109625 GASKET 1 X X
27 RE504822 GASKET 1 X X
28 R100569 GASKET 1 X X
29 R26058 GASKET 1 X X
30 RE521058 GASKET KIT 1 X X ENGINE REBUILD
.. R51936 SEALING WASHER 8 X X
.. R63551 SEALING WASHER 8 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0452-3

PN=247
 2B3 ENGINE AUXILIARY SYSTEMS 5
COLD WEATHER STARTING AIDS 0505
ENGINE AIR HEATER
T201622 -UN-12JUL04

THIS PARTS LISTING IS CONTINUED

0505-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=248
 2B4 ENGINE AUXILIARY SYSTEMS 5
COLD WEATHER STARTING AIDS 0505
ENGINE AIR HEATER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT196516 WIRING HARNESS 1 X X (ENGINE AIR HEATER)

2 H77698 TIE BAND AR X X
3 AT145341 RELAY 1 X X (AIR HEATER) (24 VOLT)
4 AT184618 WIRE 1 X X (AIR HEATER) (FUSE TO RELAY)
5 AT203566 FUSE 1 X X (125 AMP) (AIR HEATER)
6 AT206818 FUSE HOLDER 1 X X
7 14M7303 FLANGE NUT 2 X X M6
8 AT191008 WIRE 1 X X (ENGINE AIR HEATER GROUND TERMINAL TO
STARTER GROUND STUD)
9 RE515331 INTAKE MANIFOLD 1 X X (AIR INTAKE)
10 R130573 GASKET 3 X X
11 T160333 NUT 4 X X
12 19M7862 SCREW 4 X X M6 X 20
13 24M7139 WASHER 2 X X
14 RE66693 CABLE 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0505-3

PN=249
 2B5 ENGINE AUXILIARY SYSTEMS 5
COLD WEATHER STARTING AIDS 0505
COLD WEATHER STARTING AID
T201627 -UN-10DEC04

THIS PARTS LISTING IS CONTINUED

0505-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=250
 2B6 ENGINE AUXILIARY SYSTEMS 5
COLD WEATHER STARTING AIDS 0505
COLD WEATHER STARTING AID

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T160334 NUT 4 X X
2 T206515 ANGLE 1 X X
4 14M7274 NUT 3 X X M10
5 24M7239 WASHER 6 X X
6 19M7402 CAP SCREW 2 X X M10 X 25
7 24M7238 WASHER 4 X X
8 19M7407 CAP SCREW 4 X X M8 X 25
9 AR21842 CLAMP 1 X X
10 AT171539 CAP (HAT) 1 X X
11 AT181582 ELBOW FITTING 1 X X
12 AT183422 SOLENOID 1 X X
13 .................. TUBE 1 X X (MAKE FROM T78593 BULK MATERIAL, CUT TO
LENGTH)
14 AT183417 NOZZLE 1 X X
15 15H511 PIPE BUSHING 1 X X 1/8"
16 R44302 TIE BAND AR X X
17 AT190836 WIRING HARNESS 1 X X (INCLUDES (1) 57M7121 FUSE)
57M7121 FUSE 1 X X
18 AT183485 TEMPERATURE SWITCH 1 X X
19 19H1648 CAP SCREW 1 X X 3/8" X 3/4"
20 T76252 CLAMP 1 X X
22 AT183423 STARTING FLUID 1 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 0505-5

PN=251
 2B7 ENGINE AUXILIARY SYSTEMS 5
COLD WEATHER STARTING AIDS 0505
COOLANT HEATER
T203938 -UN-10NOV04

THIS PARTS LISTING IS CONTINUED

0505-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=252
 2B8 ENGINE AUXILIARY SYSTEMS 5
COLD WEATHER STARTING AIDS 0505
COOLANT HEATER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7528 LOCK NUT 4 X X M6

2 19M7862 SCREW 4 X X M6 X 20
3 19M7938 CAP SCREW 2 X X M10 X 20
4 24M7139 WASHER 4 X X
5 24M7239 WASHER 2 X X
6 AT306681 COOLANT HEATER 1 X X
7 AT306682 COOLANT HEATER 1 X X
8 T205065 BLOCK CLAMP 2 X X
9 AT307054 TEE FITTING 1 X X
10 AT307279 TEE FITTING 1 X X
11 .................. BULK HOSE 1 X X (MAKE FROM T60811) (CUT TO LENGTH)
12 H77698 TIE BAND 1 X X
13 L100913 FITTING 2 X X
14 M87683 ADAPTER 2 X X
15 R117721 CLAMP 4 X X
16 T205452 BRACKET 1 X X
17 T77857 O-RING 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0505-9

PN=253
 2B9 ENGINE AUXILIARY SYSTEMS 5
COOLING SYSTEMS 0510
FAN GUARD (WITHOUT AIR CONDITIONING)
T203916 -UN-05NOV04

THIS PARTS LISTING IS CONTINUED

0510-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=254
 2B10 ENGINE AUXILIARY SYSTEMS 5
COOLING SYSTEMS 0510
FAN GUARD (WITHOUT AIR CONDITIONING)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7938 CAP SCREW 4 X X

2 24M7239 WASHER 4 X X
3 AT312995 GUARD 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0510-3

PN=255
 2B11 ENGINE AUXILIARY SYSTEMS 5
COOLING SYSTEMS 0510
RADIATOR, CHARGE AIR COOLER AND HYDRAULIC OIL COOLER
T204313 -UN-18DEC04

THIS PARTS LISTING IS CONTINUED

0510-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=256
 2B12 ENGINE AUXILIARY SYSTEMS 5
COOLING SYSTEMS 0510
RADIATOR, CHARGE AIR COOLER AND HYDRAULIC OIL COOLER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7274 NUT 5 X X M10

2 14M7313 LOCK NUT 2 X X M12
3 19M7363 CAP SCREW 3 X X M12 X 60
4 19M7662 CAP SCREW 8 X X M10 X 30
5 19M7835 SCREW 2 X X M10 X 35
6 19M7938 CAP SCREW 19 X X M10 X 20
7 19M8637 CAP SCREW 2 X X M10 X 40
8 24H1346 WASHER 6 X X
9 24M7239 WASHER 25 X X
10 24M7240 WASHER 3 X X
11 24M7296 WASHER 22 X X
12 AT307031 SHROUD 1 X X
13 AT307061 BRACKET 1 X X
14 19M7402 CAP SCREW 12 X X M10 X 25
15 24M7345 WASHER 8 X X
16 AT306034 PLATE 1 X X
17 AT306035 CHANNEL 1 X X
18 AT306967 AFTERCOOLER 1 X X (CHARGE AIR COOLER)
19 AT306968 OIL COOLER 1 X X (HYDRAULIC OIL COOLER)
20 AT311872 RADIATOR 1 X X
21 AT318649 ISOLATOR 3 X X
22 T205474 ANGLE 2 X X
23 T205711 SEAL 1 X X
24 T206558 ISOLATOR 2 X X
25 T212467 GUARD 1 X X
26 T212468 GUARD 1 X X
27 T213647 ISOLATOR 1 X X
28 U42208 ISOLATOR 3 X X
29 19M7807 SCREW 1 X X
30 19M7786 SCREW 2 X X
31 19M7784 SCREW 2 X X
32 AT320484 BRACKET 1 X X
33 T214426 BUSHING 1 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 0510-5

PN=257
 2B13 ENGINE AUXILIARY SYSTEMS 5
COOLING SYSTEMS 0510
RADIATOR AND CHARGE AIR COOLER HOSES AND TUBES
T209452 -UN-18MAR05

THIS PARTS LISTING IS CONTINUED

0510-6 770D/772D MOTOR GRADER PC9449 (30-MAR-05)
PN=258
 2B14 ENGINE AUXILIARY SYSTEMS 5
COOLING SYSTEMS 0510
RADIATOR AND CHARGE AIR COOLER HOSES AND TUBES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 15H625 PIPE BUSHING 1 X X

2 19H1900 CAP SCREW 1 X X
3 19M7402 CAP SCREW 1 X X M10 X 25
4 19M8600 CAP SCREW 1 X X M10 X 50
5 24M7238 WASHER 1 X X
6 AH89557 CLIP 1 X X
7 AR21836 CLAMP 2 X X
8 AR21839 CLAMP 2 X X
9 AR21841 CLAMP 2 X X
10 14M7274 NUT 4 X X M10
11 AR40418 HOSE CLAMP 6 X X
12 AT173610 FILLER CAP 3 X X
13 AT181162 TANK 1 X X
T107141 O-RING 1 X X (NOT ILLUSTRATED)
T162965 SIGHT PLUG 1 X X (NOT ILLUSTRATED)
14 AT307083 AIR FLOW TUBE 1 X X
15 R164193 HOSE 2 X X
16 AT307343 TUBE 1 X X
17 19M7662 CAP SCREW 8 X X M10 X 30
18 19M7938 CAP SCREW 4 X X M10 X 20
19 24M7239 WASHER 17 X X
20 .................. BULK HOSE 17 X X (MAKE FROM T79477) (CUT TO LENGTH)
21 .................. BULK HOSE 4 X X (MAKE FROM T139131) (CUT TO LENGTH)
22 H77698 TIE BAND 1 X X (MAKE FROM T79477) (CUT TO LENGTH)
23 M40509 SPACER 1 X X (MAKE FROM T139131) (CUT TO LENGTH)
24 R43583 FITTING 1 X X
25 RE52702 CLAMP 8 X X
26 T13254 CLAMP 5 X X
27 T158436 SPACER 1 X X
28 T160608 CLAMP 7 X X
29 T160609 CLAMP 2 X X
30 T162575 CLAMP 1 X X
31 T164031 BRACKET 1 X X
32 T185030 HOSE 1 X X
33 T202242 TUBE 1 X X
34 T202634 HOSE 1 X X
35 T202768 RADIATOR HOSE 1 X X
36 T205480 RADIATOR HOSE 1 X X
37 T205652 FITTING 1 X X
38 T205818 RADIATOR HOSE 1 X X
39 T206005 RADIATOR HOSE 1 X X
40 T206594 TUBE 1 X X
41 T210550 TUBE 1 X X
42 T217194 HOSE 1 X X (SUB FOR T210564)
43 T72856 HOSE 1 X X
44 19M8977 SCREW 1 X X M10 X 85
45 28H3399 SPACER 1 X X
46 AH77714 CLIP 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0510-7

PN=259
 2B15 ENGINE AUXILIARY SYSTEMS 5
COOLING SYSTEMS 0510
FUEL COOLER
T204388 -UN-13NOV04

THIS PARTS LISTING IS CONTINUED

0510-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=260
 2B16 ENGINE AUXILIARY SYSTEMS 5
COOLING SYSTEMS 0510
FUEL COOLER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7274 NUT 4 X X M10

2 19H1813 CAP SCREW 1 X X 5/16" X 5/8"
3 19M7938 CAP SCREW 7 X X M10 X 20
4 24M7238 WASHER 1 X X
5 24M7239 WASHER 7 X X
6 24M7296 WASHER 4 X X
7 AT124317 ELBOW FITTING 1 X X
8 AT176011 HAND OPERATED VALVE 1 X X
9 AT223493 FUEL FILTER 1 X X
10 AT307668 FITTING 1 X X
11 AT309911 FUEL COOLER 1 X X
12 T77613 O-RING 1 X X
13 .................. BULK HOSE 1 X X (MAKE FROM T168383) (CUT TO LENGTH)
14 .................. CONDUIT 1 X X (MAKE FROM T107029) (CUT TO LENGTH)
15 E69975 CLAMP 1 X X
16 RE523825 ADAPTER 2 X X
17 R184863 HOSE CLAMP 8 X X
18 R26286 O-RING 1 X X
19 R26375 O-RING 1 X X
20 T74416 CLAMP 2 X X
21 T32854 CLAMP 1 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0510-11

PN=261
 2B17 ENGINE AUXILIARY SYSTEMS 5
FAN 0512
FAN AND FAN TOWER
T204675 -UN-22NOV04

THIS PARTS LISTING IS CONTINUED

0512-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=262
 2B18 ENGINE AUXILIARY SYSTEMS 5
FAN 0512
FAN AND FAN TOWER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7313 LOCK NUT 1 X X M12

2 14M7520 LOCK NUT 2 X X M10
3 19M7364 CAP SCREW 1 X X M12 X 80
4 19M7489 CAP SCREW 4 X X M16 X 45
5 19M7550 CAP SCREW 1 X X M10 X 35
6 19M7662 CAP SCREW 14 X X M10 X 30
7 19M7835 SCREW 2 X X M10 X 35
8 19M8008 CAP SCREW 1 X X M8 X 35
9 19M8183 CAP SCREW 1 X X M10 X 90
10 19M7658 CAP SCREW 4 X X M10 X 50
11 19M8600 CAP SCREW 6 X X M10 X 50
12 24M7238 WASHER 13 X X
13 24M7239 WASHER 26 X X
14 24M7240 WASHER 2 X X
15 24M7241 WASHER 4 X X
16 24M7296 WASHER 4 X X
17 AT194587 TIGHTENER 1 X X
18 AT194588 HUB 1 X X
19 AE53905 TAPERED ROLLER BEARING 2 X X
20 R31291 SNAP RING 1 X X
21 T158400 HUB 1 X X
22 T159052 ADJUSTER 2 X X
23 T159883 SHAFT 1 X X
24 T187386 PULLEY 1 X X
25 T24513 RING 2 X X
26 AT194773 FAN BLADE 1 X X
27 AT194965 IDLER 1 X X
28 AT305057 SUPPORT 1 X X
29 19M2870 CAP SCREW 1 X X
32 AT308399 UNIVERSAL DRIVESHAFT 1 X X
33 19M7881 SCREW 12 X X M8 X 20
34 T213775 FLAT BELT 1 X X
35 AT309043 HUB 1 X X
36 T187416 BUSHING 1 X X
37 T187818 PLATE 1 X X
38 AT313691 SUPPORT 1 X X
39 T187387 PULLEY 1 X X
40 T159884 HUB 1 X X
41 T207072 SHAFT 1 X X
42 T187477 COVER 1 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0512-3

PN=263
 2B19 ENGINE AUXILIARY SYSTEMS 5
SPEED CONTROLS 0515
ENGINE SPEED CONTROL PEDAL AND SWITCHES
T202482 -UN-03SEP04

THIS PARTS LISTING IS CONTINUED

0515-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=264
 2B20 ENGINE AUXILIARY SYSTEMS 5
SPEED CONTROLS 0515
ENGINE SPEED CONTROL PEDAL AND SWITCHES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7897 SCREW 4 X X M8 X 35
2 AT302731 SWITCH 1 X X (ENGINE SPEED CONTROL SET SWITCH)
3 AT302732 TOGGLE/ROCKER SWITCH 1 X X (ENGINE SPEED CONTROL ON/OFF SWITCH)
4 RE519877 ACCELERATOR 1 X X
5 T196079 NUT 4 X X M8

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0515-3

PN=265
 2B21 ENGINE AUXILIARY SYSTEMS 5
SPEED CONTROLS 0515
ENGINE SPEED DECELERATOR PEDAL
T203067 -UN-28OCT04

THIS PARTS LISTING IS CONTINUED

0515-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=266
 2B22 ENGINE AUXILIARY SYSTEMS 5
SPEED CONTROLS 0515
ENGINE SPEED DECELERATOR PEDAL

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M8092 SCREW 3 X X M6 X 50
2 AT314814 KIT 1 X X
3 T196077 NUT 1 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 0515-5

PN=267
 2B23 ENGINE AUXILIARY SYSTEMS 5
INTAKE SYSTEM 0520
AIR CLEANER WITH PRE-CLEANER
T153236 -UN-09APR02

THIS PARTS LISTING IS CONTINUED

0520-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=268
 2B24 ENGINE AUXILIARY SYSTEMS 5
INTAKE SYSTEM 0520
AIR CLEANER WITH PRE-CLEANER

8 8
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7785 SCREW 4 X X M10 X 25, (SUB FOR 19M7402, THIS

APPLICATION)
2 24M7296 WASHER 4 X X 10.500 X 30 X 2.500 MM (0.413" X 1.181" X
0.098")
3 RE19429 CLAMP 1 X X
4 T164303 SUCTION HOSE 1 X X
5 TT208828 CLAMP 1 X X (SUB FOR AT53440)
6 T76691 HOSE 1 X X
7 AR21839 CLAMP 2 X X
8 AT189052 CLAMP 1 X X (NO LONGER REQUIRED)
10 AT183636 COVER 1 X X
11 RE51630 FILTER ELEMENT 1 X X SECONDARY
12 RE51629 FILTER ELEMENT 1 X X PRIMARY
13 AT211206 BAND 2 X X (SUB FOR AT202864)
14 AR44361 FITTING 1 X X
15 AT178542 AIR RESTRICTION SENSOR 1 X X
16 AT183375 AIR CLEANER 1 X X
17 AT183377 PRECLEANER 1 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 0520-3

PN=269
 2C1 ENGINE AUXILIARY SYSTEMS 5
INTAKE SYSTEM 0520
ROTARY EJECTOR PRECLEANER
T204404 -UN-03DEC04

THIS PARTS LISTING IS CONTINUED

0520-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=270
 2C2 ENGINE AUXILIARY SYSTEMS 5
INTAKE SYSTEM 0520
ROTARY EJECTOR PRECLEANER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7274 NUT 4 X X
2 19M7662 CAP SCREW 4 X X M10 X 30
3 24M7296 WASHER 8 X X
4 AT189052 CLAMP 1 X X
5 AT184015 PRECLEANER 1 X X
AT184016 SEPARATOR 1 X X
6 T208503 CAP 1 X X
7 AT53440 CLAMP 1 X X
8 AT317539 KIT 1 X X
9 AT310939 KIT 1 X X (WHOLEGOODS)(ROTARY EJECTOR PRECLEANER
KIT)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0520-5

PN=271
 2C3 ENGINE AUXILIARY SYSTEMS 5
EXTERNAL EXHAUST SYSTEMS 0530
MUFFLER
T155667 -UN-06JUN02

THIS PARTS LISTING IS CONTINUED

0530-2 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=272
 2C4 ENGINE AUXILIARY SYSTEMS 5
EXTERNAL EXHAUST SYSTEMS 0530
MUFFLER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT182063 MUFFLER 1 X X
2 AR43705 CLAMP 2 X X
3 M142955 LOCK NUT 2 X X
4 24M7213 WASHER 4 X X 10.500 X 25 X 4 MM, (SUB FOR 24M7239)
5 19M7328 CAP SCREW 2 X X M10 X 70, (SUB FOR 19M8081, 19M7875, THIS
APPLICATION)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 0530-3

PN=273
 2C5 ENGINE AUXILIARY SYSTEMS 5
MOUNTING FRAME 0540
ENGINE AND TRANSMISSION MOUNTING
T201666 -UN-29JUL04

THIS PARTS LISTING IS CONTINUED

0540-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=274
 2C6 ENGINE AUXILIARY SYSTEMS 5
MOUNTING FRAME 0540
ENGINE AND TRANSMISSION MOUNTING

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7969 CAP SCREW 4 X X M20 X 110

2 T158949 WASHER 8 X X
3 AT178586 BRACKET 1 X X REAR LEFT
4 AT107738 ISOLATOR 4 X X
5 AT161176 BRACKET 1 X X REAR RIGHT
6 24M7240 WASHER 8 X X
7 19H2993 CAP SCREW 8 X X 1/2" X 1-1/2"
8 19M8485 CAP SCREW 2 X X M16 X 90
9 T179952 WASHER 4 X X (SUB FOR T160825)
10 AT170854 ISOLATOR 2 X X
11 AT302821 SUPPORT 1 X X FRONT LEFT
12 24M7241 WASHER 6 X X
13 19H3107 CAP SCREW 8 X X 5/8" X 2-3/4", (WITHOUT AIR CONDITIONING)
19H3208 CAP SCREW 2 X X (WITH AIR CONDITIONING)
19H3107 CAP SCREW 6 X X (WITH AIR CONDITIONING)
14 AT302818 SUPPORT 1 X X FRONT RIGHT
15 T72414 BUSHING 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0540-3

PN=275
 2C7 ENGINE AUXILIARY SYSTEMS 5
EXTERNAL FUEL SUPPLY SYSTEMS 0560
FUEL TANK AND FUEL TANK HOSES
T209453 -UN-21MAR05

THIS PARTS LISTING IS CONTINUED

0560-2 770D/772D MOTOR GRADER PC9449 (30-MAR-05)
PN=276
 2C8 ENGINE AUXILIARY SYSTEMS 5
EXTERNAL FUEL SUPPLY SYSTEMS 0560
FUEL TANK AND FUEL TANK HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7274 NUT 4 X X M10

2 19M7938 CAP SCREW 14 X X M10 X 20
3 19M8078 CAP SCREW 5 X X M4 X 16
4 24M7239 WASHER 14 X X
5 AT219974 BUMPER 4 X X
6 AT301133 FUEL SENDER 1 X X
7 R81596 GASKET 1 X X
8 AT307361 FUEL TANK 1 X X
9 AT185695 CAP 1 X X
10 T165992 BREATHER 1 X X
11 AT318171 SUPPORT 2 X X
12 T162343 PLATE 1 X X
13 T201999 PLATE 1 X X
14 24M7241 WASHER 1 X X
15 19M8035 CAP SCREW 4 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 0560-3

PN=277
 2C9 ENGINE AUXILIARY SYSTEMS 5
AUTOMATIC CONTROL CIRCUITS 0575
ENGINE CONTROL UNIT
T202532 -UN-03SEP04

THIS PARTS LISTING IS CONTINUED

0575-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=278
 2C10 ENGINE AUXILIARY SYSTEMS 5
AUTOMATIC CONTROL CIRCUITS 0575
ENGINE CONTROL UNIT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M8786 SCREW 4 X X M6 X 70
2 24M7250 WASHER 4 X X
3 RE522516 ENGINE CONTROLLER 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0575-3

PN=279
 ENGINE AUXILIARY SYSTEMS 5
AUTOMATIC CONTROL CIRCUITS 0575
MEMORANDA

0575-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=280
 2C11 ENGINE AUXILIARY SYSTEMS 5
SENSORS 0578
MAGNETIC PICK-UP
RGP8972 -UN-19JUL02

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE519144 SENSOR 1 X X M20X1.5

2 51M7044 O-RING 1 X X 17.300 X 2.200 MM

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0578-1

PN=281
 2C12 ENGINE AUXILIARY SYSTEMS 5
SENSORS 0578
WATER IN FUEL SENSOR
RGP10901 -UN-27JAN05

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 57M7254 ELECTRICAL CONNECTOR ASSY 1 X X (ALSO ORDER 57M7258, 57M7289 AND (2)
R104846)
2 51M7095 O-RING 1 X X 11.300 X 2.200 MM
3 RE522685 MOISTURE SENSOR 1 X X WATER IN FUEL

0578-2 770D/772D MOTOR GRADER PC9449 (03-MAR-05)

PN=282
 2C13 ENGINE AUXILIARY SYSTEMS 5
SENSORS 0578
COOLANT TEMPERATURE SENSOR
RGP10905 -UN-17DEC04

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE151433 COOLANT TEMPERATURE SENSOR 1 X X

2 R77673 O-RING 1 X X 0.414" X 0.072"
3 .................. MANIFOLD 1 X X THERMOSTAT HOUSING

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0578-3

PN=283
 2C14 ENGINE AUXILIARY SYSTEMS 5
SENSORS 0578
AMBIENT TEMPERATURE SENSOR (WITH AIR HEATER)
RGP10906 -UN-17DEC04

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE61812 SENSOR 1 X X M14X1.5

2 51M7041 O-RING 1 X X 11.300 X 2.200 MM
3 .................. MANIFOLD 1 X X INTAKE

0578-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=284
 2C15 ENGINE AUXILIARY SYSTEMS 5
SENSORS 0578
OIL PRESSURE SENSOR
RGP10907 -UN-17DEC04

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE167207 PRESSURE SENSOR 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0578-5

PN=285
 2C17 STEERING SYSTEMS 9
EMERGENCY STEERING 0930
SECONDARY STEERING
T202623 -UN-20OCT04

THIS PARTS LISTING IS CONTINUED

0930-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=286
 2C18 STEERING SYSTEMS 9
EMERGENCY STEERING 0930
SECONDARY STEERING

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7786 SCREW 2 X X M10 X 30

2 38H1418 FITTING 1 X X
3 38H1005 ELBOW FITTING 1 X X
4 R26375 O-RING 1 X X
5 T77857 O-RING 2 X X
6 38H1037 ELBOW FITTING 1 X X
7 R29936 O-RING 1 X X
8 T76938 O-RING 2 X X
9 38H1096 ELBOW FITTING 1 X X
10 T77932 O-RING 2 X X
11 38H1098 ELBOW FITTING 1 X X
12 38H1483 REDUCER 1 X X
13 T77858 O-RING 2 X X
14 AT186653 CLAMP 2 X X
15 AT227717 HYDRAULIC ACCUMULATOR 1 X X
16 AT313352 PRESSURE SWITCH 1 X X
17 AT313541 HYDRAULIC HOSE - FABRICATE 1 X X
18 AT313542 HYDRAULIC HOSE - FABRICATE 1 X X
19 RE211000 CHECK VALVE 1 X X
20 T72414 BUSHING 2 X X
21 T164124 LABEL 1 X X
22 AT313338 KIT 1 X X (WHOLEGOODS) (SECONDARY STEERING)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0930-3

PN=287
 2C19 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
WHEEL LEAN CYLINDER (770D)
T201465 -UN-08DEC04

THIS PARTS LISTING IS CONTINUED

0960-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=288
 2C20 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
WHEEL LEAN CYLINDER (770D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AH139128 HYDRAULIC CYLINDER ROD 1 X

2 H145104 BUSHING 1 X
3 AH146557 SEAL 1 X
4 H180080 SNAP RING 1 X
5 H180094 SNAP RING 1 X
6 R81862 BACK-UP RING 1 X
7 F950R O-RING 1 X
8 H208987 WEAR RING 1 X
9 H152203 SEAL 1 X
10 AH146561 SEAL 1 X
11 AH205062 PISTON 1 X
12 H168248 WASHER 1 X
13 H168249 WASHER 1 X
14 .................. O-RING 1 X (ORDER AH212101)
15 H170539 NUT 1 X
16 AH210484 HYDRAULIC CYLINDER KIT 1 X (ROD SEAL KIT)
17 AH212102 HYDRAULIC CYLINDER KIT 1 X (BORE SEAL KIT)
20 AH212494 HYDRAULIC CYLINDER 1 X (WHEEL LEAN)
21 19H1912 CAP SCREW 1 X 3/8" X 3-1/2"
22 19M7489 CAP SCREW 1 X M16 X 45
23 28H3401 SPACER 1 X
25 AT314624 PIN 1 X
26 JD7759 LUBRICATION FITTING 1 X
27 T11234 LOCK NUT 1 X
28 T146246 WASHER 1 X
29 T152862 PIN 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0960-3

PN=289
 2C21 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
WHEEL LEAN CYLINDER (772D)
T201466 -UN-19JUL04

THIS PARTS LISTING IS CONTINUED

0960-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=290
 2C22 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
WHEEL LEAN CYLINDER (772D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7517 LOCK NUT 1 X M10

2 19M7489 CAP SCREW 1 X M16 X 45
3 19M8081 CAP SCREW 1 X M10 X 80
4 28H3401 SPACER 1 X
5 AH208859 HYDRAULIC CYLINDER 1 X (WHEEL LEAN) (HFWD)
6 AT314624 PIN 1 X
7 H80936 ELBOW FITTING 1 X
8 JD7798 LUBRICATION FITTING 1 X
9 T146256 LABEL 1 X
10 T185047 PIN FASTENER 1 X
11 H145104 BUSHING 1 X
12 AH168200 ROD 1 X
13 AH146557 SEAL 1 X
14 H208987 WEAR RING 1 X
15 .................. HYDR. CYLINDER ROD GUIDE 1 X (SUB AH212102)
16 H180080 SNAP RING 1 X
17 .................. O-RING 1 X (SUB AH212102)
18 H180094 SNAP RING 1 X
19 R81862 BACK-UP RING 1 X
20 F950R O-RING 1 X
21 H152203 SEAL 1 X
22 AH146561 SEAL 1 X
23 AH205062 PISTON 1 X
24 H170539 NUT 1 X
25 AH212500 HYDRAULIC CYLINDER BARREL 1 X
26 H154856 WEAR RING 1 X (NOT ILLUSTRATED)(WIPER INSTALLATION
TOOLS)
27 AH210484 HYDRAULIC CYLINDER KIT 1 X (ROD SEAL KIT)
28 AH212102 HYDRAULIC CYLINDER KIT 1 X (BORE SEAL KIT)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0960-5

PN=291
 2C23 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
ARTICULATION CYLINDER
T201468 -UN-27JUL04

THIS PARTS LISTING IS CONTINUED

0960-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=292
 2C24 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
ARTICULATION CYLINDER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2133 CAP SCREW 1 X X 5/8" X 4-1/2"

2 19M7843 SCREW 1 X X M16 X 35
3 24M7315 WASHER 1 X X
4 28H3401 SPACER 1 X X
5 H154856 WEAR RING 1 X X
6 AT175953 PIN 1 X X
7 JD7799 LUBRICATION FITTING 1 X X
8 T42217 PIN FASTENER 1 X X
9 U44915 LOCK NUT 1 X X
10 RE37693 HYDRAULIC CYLINDER ROD 1 X X
11 R98953 BUSHING 1 X X
12 AH146557 SEAL 1 X X
13 H208987 WEAR RING 1 X X
14 H208995 HYDR. CYLINDER ROD GUIDE 1 X X
15 .................. O-RING 1 X X (SUB AH212102)
16 H180094 SNAP RING 1 X X
17 R81862 BACK-UP RING 1 X X
18 F950R O-RING 1 X X
19 H152203 SEAL 1 X X
20 AH146561 SEAL 1 X X
21 AH205062 PISTON 1 X X
22 H170539 NUT 1 X X M30
23 AH212545 HYDRAULIC CYLINDER BARREL 1 X X
24 H180080 SNAP RING 1 X X
25 AH212473 HYDRAULIC CYLINDER 1 X X (ARICULATION CYLINDER)
27 AH210484 HYDRAULIC CYLINDER KIT 1 X X (ROD SEAL KIT)
28 AH212102 HYDRAULIC CYLINDER KIT 1 X X (BORE SEAL KIT)
29 24H1595 WASHER 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0960-7

PN=293
 2D1 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
FRONT STEERING CYLINDER
T201469 -UN-29NOV04

THIS PARTS LISTING IS CONTINUED

0960-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=294
 2D2 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
FRONT STEERING CYLINDER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7517 LOCK NUT 1 X X M10

2 19M8081 CAP SCREW 1 X X M10 X 80
3 AH215390 HYDRAULIC CYLINDER 1 X X (FRONT STEERING)
4 T184629 SPACER 1 X X
5 T204711 PIN FASTENER 1 X X
6 AH140072 PISTON 1 X X
7 AH147976 SEAL 1 X X
8 AH150452 SEAL 1 X X
9 H154514 SEAL 1 X X
10 H155964 O-RING 1 X X
11 H156058 WEAR RING 1 X X
12 H164204 SNAP RING 1 X X
13 H164205 SNAP RING 1 X X
14 H171332 HYDR. CYLINDER ROD GUIDE 1 X X
15 M44162 O-RING 1 X X
16 R78393 BACK-UP RING 1 X X
17 H150956 HYDRAULIC CYLINDER ROD 1 X X
18 H170535 NUT 1 X X
19 AH215391 HYDRAULIC CYLINDER BARREL 1 X X
20 AH161589 HYDRAULIC CYLINDER KIT 1 X X (ROD SEAL KIT)
21 AH164325 HYDRAULIC CYLINDER KIT 1 X X (BORE SEAL KIT)
22 AT169864 TIE ROD END 1 X X
23 24M7359 WASHER 1 X X
24 14H875 NUT 1 X X
25 11M7023 COTTER PIN 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0960-9

PN=295
 2D3 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
FRONT STEERING CYLINDER HYDRAULIC HOSES
T208052 -UN-12FEB05

THIS PARTS LISTING IS CONTINUED

0960-10 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=296
 2D4 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
FRONT STEERING CYLINDER HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1023 TEE FITTING 2 X X

2 R26448 O-RING 3 X X
3 T77613 O-RING 9 X X
4 38H1045 ELBOW FITTING 1 X X
5 38H1046 ELBOW FITTING 1 X X
6 R26375 O-RING 1 X X
7 T77857 O-RING 1 X X
8 38H1160 ADAPTER 2 X X
10 AT180301 HYDRAULIC HOSE - FABRICATE 2 X
AT192380 HYDRAULIC HOSE - FABRICATE 2 X
11 AT304794 HYDRAULIC HOSE - FABRICATE 2 X X
12 AT305768 HYDRAULIC HOSE - FABRICATE 1 X X
13 AT309952 HYDRAULIC HOSE - FABRICATE 1 X X
14 38H1094 ELBOW FITTING 2 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 0960-11

PN=297
 2D5 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
ARTICULATION CYLINDER HOSES
T202582 -UN-08SEP04

THIS PARTS LISTING IS CONTINUED

0960-12 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=298
 2D6 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
ARTICULATION CYLINDER HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1024 TEE FITTING 2 X X

2 R26375 O-RING 6 X X
3 T77857 O-RING 6 X X
4 38H1161 ADAPTER 2 X X
5 38H1171 ADAPTER 2 X X
6 T77613 O-RING 2 X X
7 AT306154 HYDRAULIC HOSE - FABRICATE 2 X X
8 AT306155 HYDRAULIC HOSE - FABRICATE 1 X X
9 AT306156 HYDRAULIC HOSE - FABRICATE 1 X X
10 C16054 CLAMP 2 X X
11 T105773 GUIDE 2 X X
12 H77698 TIE BAND AR X X (NOT ILLUSTRATED)

770D/772D MOTOR GRADER PC9449 (20-APR-05) 0960-13

PN=299
 2D7 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
WHEEL LEAN CYLINDER HOSES (772D)
T202583 -UN-19OCT04

THIS PARTS LISTING IS CONTINUED

0960-14 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=300
 2D8 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
WHEEL LEAN CYLINDER HOSES (772D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1171 ADAPTER 3 X
2 R26375 O-RING 4 X
3 T77613 O-RING 4 X
4 38H1522 ELBOW FITTING 1 X
5 AT305624 HYDRAULIC HOSE - FABRICATE 1 X
6 AT305625 HYDRAULIC HOSE - FABRICATE 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0960-15

PN=301
 2D9 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
WHEEL LEAN CYLINDER HYDRAULIC HOSES (770D)
T202584 -UN-19OCT04

THIS PARTS LISTING IS CONTINUED

0960-16 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=302
 2D10 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
WHEEL LEAN CYLINDER HYDRAULIC HOSES (770D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1010 ELBOW FITTING 1 X X

2 R26375 O-RING 4 X X
3 T77613 O-RING 4 X X
4 38H1171 ADAPTER 1 X X
5 AT305991 HYDRAULIC HOSE - FABRICATE 1 X X
6 AT305992 HYDRAULIC HOSE - FABRICATE 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0960-17

PN=303
 2D11 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
STEERING VALVE AND STEERING VALVE HOSES
T203906 -UN-08DEC04

THIS PARTS LISTING IS CONTINUED

0960-18 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=304
 2D12 STEERING SYSTEMS 9
HYDRAULIC SYSTEM 0960
STEERING VALVE AND STEERING VALVE HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1046 ELBOW FITTING 1 X X

2 R26375 O-RING 4 X X
3 T77857 O-RING 1 X X
4 38H1435 ELBOW FITTING 1 X X
5 R28782 O-RING 1 X X
6 T77613 O-RING 4 X X
7 38H1522 ELBOW FITTING 3 X X
8 AT302166 HYDRAULIC HOSE - FABRICATE 3 X X
9 AT302175 HYDRAULIC HOSE - FABRICATE 1 X X
10 AT309953 HYDRAULIC HOSE - FABRICATE 1 X X
11 T78716 NUT 1 X X
12 T81029 NUT 4 X X
13 AT303489 CONTROL VALVE 1 X X (STEERING VALVE)
AT316249 SEAL KIT 1 X X (STEERING VALVE SEAL KIT)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 0960-19

PN=305
 2D14 SERVICE BRAKES 10
ACTIVE ELEMENTS 1011
SERVICE BRAKES
TP57409 -UN-13MAR98

THIS PARTS LISTING IS CONTINUED

1011-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=306
 2D15 SERVICE BRAKES 10
ACTIVE ELEMENTS 1011
SERVICE BRAKES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R131225 PLATE 1 X X
2 R129628 DOWEL PIN 2 X X
3 40M7042 SNAP RING 2 X X
4 R27315 DOWEL PIN 2 X X 15.875 X 28.575 MM (5/8" X 1-1/8")
5 RE65008 BRAKE DISK 5 X X
6 R150895 PLATE 6 X X SEPARATOR

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1011-3

PN=307
 2D16 SERVICE BRAKES 10
HYDRAULIC SYSTEM 1060
SERVICE BRAKE PEDAL AND VALVE
T201823 -UN-02SEP04

THIS PARTS LISTING IS CONTINUED

1060-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=308
 2D17 SERVICE BRAKES 10
HYDRAULIC SYSTEM 1060
SERVICE BRAKE PEDAL AND VALVE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7657 SCREW 2 X X
2 19M7863 SCREW 3 X X
3 24M7313 WASHER 2 X X
4 38H1094 ELBOW FITTING 2 X X
5 T77613 O-RING 4 X X
6 AT150024 SWITCH 1 X X
7 AT181313 CHECK VALVE 2 X X
8 AT187021 MANUAL HYDRAULIC VALVE 1 X X (SERVICE BRAKE VALVE)
AT150112 SEAL KIT 1 X X (SERVICE BRAKE VALVE SEAL KIT)
10 AT207529 CHECK VALVE 1 X X
11 AT314827 SWITCH 1 X X (BRAKE LIGHT SWITCH)
12 AT317654 PEDAL 1 X X
13 AT317655 PUSH ROD 1 X X
14 T157212 CLIP 2 X X
15 T157258 PIN 1 X X
16 T174634 BOOT 1 X X
17 AT304479 PACKAGE OF PARTS 1 X X
18 R53317 LOCK NUT 2 X X
19 T157211 PIN 1 X X
20 T157220 CLAMP 1 X X
21 T170180 SNAP RING 2 X X
22 T170181 LOCK WASHER 2 X X
23 AT304480 KIT 1 X X
24 T157212 CLIP 2 X X
25 T157223 BEARING 2 X X
26 T157257 PIN 1 X X
27 T175236 ROLLER 1 X X
28 R26287 O-RING 1 X X
29 R26375 O-RING 1 X X
30 R26448 O-RING 1 X X
31 R28782 O-RING 1 X X
32 T172927 GASKET 2 X X
33 T176108 SPRING 1 X X
34 T196077 NUT 3 X X
35 T38282 HOSE FITTING 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1060-3

PN=309
 2D18 SERVICE BRAKES 10
HYDRAULIC SYSTEM 1060
SERVICE BRAKE ACUMULATOR AND HOSES
T202006 -UN-03AUG04

THIS PARTS LISTING IS CONTINUED

1060-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=310
 2D19 SERVICE BRAKES 10
HYDRAULIC SYSTEM 1060
SERVICE BRAKE ACUMULATOR AND HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1094 ELBOW FITTING 6 X X

2 38H1160 ADAPTER 5 X X
3 R26448 O-RING 5 X X
4 T77613 O-RING 11 X X
5 AR21836 CLAMP 2 X X
6 AT124317 ELBOW FITTING 1 X X
7 AT305627 HYDRAULIC HOSE - FABRICATE 1 X X
8 AT305739 HYDRAULIC HOSE - FABRICATE 1 X X
9 AT305740 HYDRAULIC HOSE - FABRICATE 2 X X
10 AT305741 HYDRAULIC HOSE - FABRICATE 2 X X
11 .................. BULK HOSE 1 X X (MAKE FROM T168383) (CUT TO LENGTH)
12 R26375 O-RING 1 X X
13 14M7274 NUT 2 X X M10
14 19M8162 SCREW 2 X X M10 X 40
15 24M7239 WASHER 2 X X
16 AT306749 HYDRAULIC ACCUMULATOR 1 X X
17 AT225573 CHECK VALVE 1 X X
18 T126204 CLAMP 1 X X
19 T164124 LABEL 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1060-5

PN=311
 2D21 PARKING BRAKES 11
PARK BRAKE VALVE 1111
PARK BRAKE VALVE
T201054 -UN-22JUN04

THIS PARTS LISTING IS CONTINUED

1111-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=312
 2D22 PARKING BRAKES 11
PARK BRAKE VALVE 1111
PARK BRAKE VALVE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M9150 SCREW 2 X X
2 AT224863 CHECK VALVE 1 X X
3 AT224864 SEAL KIT 1 X X
4 AT224576 SOLENOID VALVE 1 X X
5 AT224497 FLOW CONTROL HYD. VALVE 1 X X (PARK BRAKE VALVE)
6 19M7875 CAP SCREW 2 X X
7 AT224873 SEAL KIT 1 X X
8 R26287 O-RING 1 X X
9 24M7239 WASHER 2 X X
10 AT223537 PRESSURE SWITCH 1 X X (PARK BRAKE PRESSURE SWITCH)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1111-3

PN=313
 2D23 PARKING BRAKES 11
PARK BRAKE VALVE 1111
PARK BRAKE HYDRAULIC HOSES
T203307 -UN-02NOV04

THIS PARTS LISTING IS CONTINUED

1111-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=314
 2D24 PARKING BRAKES 11
PARK BRAKE VALVE 1111
PARK BRAKE HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1416 FITTING 1 X X
2 38H1005 ELBOW FITTING 1 X X
3 R26375 O-RING 3 X X
4 T77857 O-RING 4 X X
5 38H1055 TEE FITTING 1 X X
6 R29936 O-RING 1 X X
7 T77858 O-RING 2 X X
8 38H1161 ADAPTER 2 X X
9 AH61472 HOSE FITTING 1 X X
10 AT177142 FITTING 1 X X
11 AT183612 PRESSURE RELIEF VALVE 1 X X
12 AT304974 HYDRAULIC HOSE - FABRICATE 1 X X
13 AT304996 HYDRAULIC HOSE - FABRICATE 1 X X
14 AT79195 CLAMP 2 X X
15 .................. BULK HOSE 1 X X (MAKE FROM T78497) (CUT TO LENGTH)
16 R53540 HOSE FITTING 1 X X
17 R77175 COVER 1 X X
18 T78716 NUT 1 X X
19 U12547 O-RING 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1111-5

PN=315
 2E2 MISCELLANEOUS VEHICLE 13
VEHICLE FINISH AND TRIM 1320
TRADEMARKS AND LABELS (ENGLISH)
T204405 -UN-15DEC04

THIS PARTS LISTING IS CONTINUED

1320-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=316
 2E3 MISCELLANEOUS VEHICLE 13
VEHICLE FINISH AND TRIM 1320
TRADEMARKS AND LABELS (ENGLISH)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 H21259 MAT 4 X X (15.5" X 6" ANTI-SKID)

2 JD5756 LABEL 1 X X (LEAPING DEERE FOR MAIN FRAME COWL COVER)
3 JD5822 LABEL 2 X X (LEAPING DEERE FOR REAR GRILLE)
4 JD5921 REFLECTOR 8 X X (YELLOW REFLECTIVE LABEL)
5 M118611 LABEL 1 X X (HOT SURFACE)
6 T103395 MAT 4 X X (8" X 6" ANTI-SKID)
7 T146605 LABEL 1 X X (AIR CLEANER SERVICE)
8 T153680 LABEL 6 X X (TIE DOWN LOCATION)
9 T155572 SAFETY SIGN 1 X X (ACCUMULATOR SAFETY)
10 T161674 LABEL 1 X X (HYDRAULIC RESERVOIR/FUEL TANK CAPS)
11 T162050 LABEL 1 X X (BRAKE COVER REMOVAL WARNING)
12 T163658 LABEL 1 X X (TRANSMISSION OIL LEVEL CHECK)
13 T175744 LABEL 1 X X (ISO 9001 REGISTERED)
14 T186793 LABEL 2 X X (GRAY CIRCULAR COVER)
15 T187757 LABEL 2 X X (WARNING-FAN)
16 T190212 LABEL 1 X X (OIL DESCRIPTION)
17 T215268 LABEL 1 X X BRAKE COVER
18 T206088 LABEL 1 X X (PERIODIC MAINTENANCE)
19 T206091 LABEL 2 X X
20 T206095 LABEL 2 X
21 T206096 LABEL 2 X
22 T206289 SAFETY SIGN 2 X X (CAUTION-PARK BRAKE)
23 T210871 SAFETY SIGN 1 X X (ARTICULATION LOCK)
24 T210933 SAFETY SIGN 2 X X (WARNING-ARTICULATION)
25 T182184 LABEL 1 X X (SUNSCREEN)
26 T206295 LABEL 1 X X (START/STOP PROCEDURE)
27 T205368 LABEL 1 X X (ROPS/FOPS CERTIFICATION)
28 T205367 LABEL 1 X X (SHIFT PATTERN)
29 T160152 LABEL 1 X X (CAUTION-SHUTDOWN)
30 T146097 LABEL 1 X X (MULTIPLE HAZARDS)
31 JD5938 REFLECTOR 2 X X (RED REFLECTOR)

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 1320-3

PN=317
 2E4 MISCELLANEOUS VEHICLE 13
VEHICLE FINISH AND TRIM 1320
TRADEMARKS AND LABELS (SPANISH)
T205367 -UN-30NOV04

THIS PARTS LISTING IS CONTINUED

1320-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=318
 2E5 MISCELLANEOUS VEHICLE 13
VEHICLE FINISH AND TRIM 1320
TRADEMARKS AND LABELS (SPANISH)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T146106 SAFETY SIGN 1 X X

2 T146606 LABEL 1 X X
3 T155579 SAFETY SIGN 1 X X
4 T214972 SAFETY SIGN 2 X X
5 T162052 LABEL 1 X X
6 T163660 LABEL 1 X X
7 T164692 LABEL 1 X X
8 T187759 LABEL 4 X X
9 T190533 LABEL 1 X X
10 T205723 LABEL 1 X X
11 T205920 LABEL 1 X X
12 T206291 SAFETY SIGN 1 X X
13 T206297 LABEL 1 X X
14 T206346 LABEL 1 X X
15 T215270 LABEL 1 X X
16 T63225 LABEL 1 X X
17 T146098 SAFETY SIGN 1 X X
18 T160154 LABEL 1 X X
19 T213215 LABEL 1 X
20 T213209 LABEL 1 X
21 T206090 LABEL 1 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1320-5

PN=319
 2E6 MISCELLANEOUS VEHICLE 13
VEHICLE FINISH AND TRIM 1320
TRADEMARKS AND LABELS (FRENCH)
T205375 -UN-30NOV04

THIS PARTS LISTING IS CONTINUED

1320-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=320
 2E7 MISCELLANEOUS VEHICLE 13
VEHICLE FINISH AND TRIM 1320
TRADEMARKS AND LABELS (FRENCH)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T145453 LABEL 1 X X
2 T146104 SAFETY SIGN 1 X X
3 T146607 LABEL 1 X X
4 T155581 SAFETY SIGN 1 X X
5 T214971 SAFETY SIGN 2 X X
6 T162051 LABEL 1 X X
7 T163659 LABEL 1 X X
8 T164691 LABEL 1 X X
9 T187758 LABEL 4 X X
10 T190534 LABEL 1 X X
11 T205722 LABEL 1 X X
12 T205919 LABEL 1 X X
13 T206290 LABEL 1 X X
14 T206296 LABEL 1 X X
15 T206345 LABEL 1 X X
16 T215269 LABEL 1 X X
17 T63224 LABEL 1 X X
18 T146099 SAFETY SIGN 1 X X
19 T160153 LABEL 1 X
20 T213210 LABEL 1 X
21 T206089 LABEL 1 X X
22 T213207 LABEL 1 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1320-7

PN=321
 MISCELLANEOUS VEHICLE 13
VEHICLE FINISH AND TRIM 1320
MEMORANDA

1320-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)

PN=322
 2E8 MISCELLANEOUS VEHICLE 13
GREASES, OIL, FUELS AND COOLANTS 1369
ENGINE COOLANT CONDITIONER
RGP9624 -UN-26JUN03

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 TY16004 ENGINE COOLANT CONDITIONER 1 X X 16 OZ (473 ML)

2 TY16005 ENGINE COOLANT CONDITIONER 1 X X 1/2 GAL (1.89 L)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1369-1

PN=323
 2E9 MISCELLANEOUS VEHICLE 13
GREASES, OIL, FUELS AND COOLANTS 1369
ENGINE OIL DRAIN
T202063 -UN-03DEC04

THIS PARTS LISTING IS CONTINUED

1369-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=324
 2E10 MISCELLANEOUS VEHICLE 13
GREASES, OIL, FUELS AND COOLANTS 1369
ENGINE OIL DRAIN

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H1833 CAP SCREW 1 X X 5/8" X 1-1/4"

2 AR21837 CLAMP 2 X X
3 .................. BULK HOSE 1 X X (MAKE FROM T60811) (CUT TO 2FT LENGTH)

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1369-3

PN=325
 2E11 MISCELLANEOUS VEHICLE 13
GREASES, OIL, FUELS AND COOLANTS 1369
FLUID SAMPLING FITTINGS
T205807 -UN-12DEC04

THIS PARTS LISTING IS CONTINUED

1369-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=326
 2E12 MISCELLANEOUS VEHICLE 13
GREASES, OIL, FUELS AND COOLANTS 1369
FLUID SAMPLING FITTINGS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M8600 CAP SCREW 4 X X M10 X 50

2 T147891 BUSHING 4 X X
3 AT306111 FITTING 3 X X (HYDRAULIC OIL, TRANSMISSION OIL, AND
DIFFERENTIAL OIL)
4 R26448 O-RING 3 X X
5 15H518 PIPE BUSHING 1 X X
6 T213462 TEE FITTING 1 X X
7 T77857 O-RING 1 X X
9 AT306133 FITTING 2 X X (COOLANT AND ENGINE OIL)
13 T210739 TEE FITTING 1 X X
14 T77858 O-RING 1 X X
15 U12547 O-RING 1 X X
16 R63016 ADAPTER 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1369-5

PN=327
 2E13 MISCELLANEOUS VEHICLE 13
LUBRICATION SYSTEMS 1370
FRAME HINGE CENTRAL LUBRICATION LINES AND FITTINGS
T201046 -UN-18JUN04

THIS PARTS LISTING IS CONTINUED

1370-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=328
 2E14 MISCELLANEOUS VEHICLE 13
LUBRICATION SYSTEMS 1370
FRAME HINGE CENTRAL LUBRICATION LINES AND FITTINGS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT112769 HYDRAULIC HOSE 1 X X (TO BOTTOM FRAME HINGE PIN)

2 AT62699 HYDRAULIC HOSE 1 X X (TO TOP FRAME HINGE PIN)
3 AT62703 HYDRAULIC HOSE 2 X X (TO ARTICULATION CYLINDER PINS)
4 E12379 NUT 4 X X
5 H80936 ELBOW FITTING 4 X X
6 JD7797 LUBRICATION FITTING 4 X X
7 T75644 ADAPTER 4 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1370-3

PN=329
 2E16 EQUIPMENT ATTACHING 15
DRAWBAR 1511
REAR HITCH
T202478 -UN-03SEP04

THIS PARTS LISTING IS CONTINUED

1511-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=330
 2E17 EQUIPMENT ATTACHING 15
DRAWBAR 1511
REAR HITCH

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT316746 KIT 1 X X (WHOLEGOODS) (REAR HITCH KIT)

2 19M7597 CAP SCREW 5 X X M20 X 50
3 24M7242 WASHER 5 X X
4 AR83396 QUICK LOCK PIN 1 X X
5 AT186723 PIN FASTENER 1 X X
6 34H358 SPRING PIN 1 X X
7 34H363 SPRING PIN 1 X X
8 AT187234 HITCH 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1511-3

PN=331
 2E21 ELECTRICAL SYSTEMS 16
BATTERIES, SUPPORT AND CABLES 1671
BATTERIES, CABLES, CLAMPS AND GROUNDING STRAPS
T213473 -UN-24AUG05

THIS PARTS LISTING IS CONTINUED

1671-2 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=332
 2E22 ELECTRICAL SYSTEMS 16
BATTERIES, SUPPORT AND CABLES 1671
BATTERIES, CABLES, CLAMPS AND GROUNDING STRAPS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7166 LOCK NUT 2 X X M8

3 19H1648 CAP SCREW 3 X X 3/8" X 3/4"
4 19M7938 CAP SCREW 3 X X M10 X 20
5 24H1305 WASHER 3 X X
6 24M7239 WASHER 6 X X
7 TY25803 DRY CHARGED BATTERY 2 X X 750 COLD CRANKING AMPS AT 0°F (-18°C),
265-MINUTE RESERVE CAPACITY AT 25 AMPS
TY23020 DRY CHARGED BATTERY 2 X X 1400 COLD CRANKING AMPS AT 0°F (-18°C),
440-MINUTE RESERVE CAPACITY AT 25 AMPS
8 AH77869 CLIP 3 X X
9 AT175548 BATTERY CABLE 1 X X 2 749.550 MM (108-1/4")
10 AT175549 BATTERY CABLE 1 X X 1 974.850 MM (77-3/4")
11 AT175550 BATTERY CABLE 1 X X 2 274.875 MM (89-9/16")
12 AT191007 BATTERY CABLE 1 X X 1 150 MM (45.276")
13 AT38449 GROUND CABLE 1 X X 609.600 MM (24")
14 AT41188 SWITCH 1 X X
15 .................. BARRIER 1 X X (MAKE FROM T66419) (CUT TO LENGTH)
16 R36545 GROUND CABLE 2 X X 406.400 MM (16")
18 T161376 HOOK BOLT 2 X X
19 T174530 NUT 1 X X M12
20 T208242 PLATE 2 X X
21 T42199 LABEL 1 X X
22 19M7938 CAP SCREW 2 -XXXXXX X X M10 X 20
19M8637 CAP SCREW 2 XXXXXX- X X M10 X 40
23 14M7296 FLANGE NUT 2 XXXXXX- X X M10

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1671-3

PN=333
 2E23 ELECTRICAL SYSTEMS 16
ALTERNATOR, REGULATOR AND CHARGING SYSTEM WIRING 1672
ALTERNATOR AND ALTERNATOR BRACKETS
T212837 -UN-20JUL05

THIS PARTS LISTING IS CONTINUED

1672-2 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=334
 2E24 ELECTRICAL SYSTEMS 16
ALTERNATOR, REGULATOR AND CHARGING SYSTEM WIRING 1672
ALTERNATOR AND ALTERNATOR BRACKETS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7296 FLANGE NUT 1 X X M10

2 14M7298 FLANGE NUT 1 X X M8
3 14M7299 FLANGE NUT 2 X X M12
4 14M7303 FLANGE NUT 1 X X M6
5 19H2676 CAP SCREW 1 X X 3/8" X 1"
6 19H3772 SCREW 2 X X 3/8" X 1-3/4"
7 19M7180 CAP SCREW 1 X X M10 X 45
8 19M7791 BOLT 1 X X M12 X 40
9 24M7238 WASHER 2 X X
10 24M7239 WASHER 1 X X
11 24M7240 WASHER 1 X X
12 19M7818 SCREW 1 X X
13 AT300167 ALTERNATOR 1 X X (100 AMP)
14 AT300684 WIRING HARNESS 1 X X (NOT ILLUSTRATED) (ALTERNATOR WIRING
HARNESS)
15 R123459 V-BELT 1 X X (WITHOUT A/C)
R135608 V-BELT 1 X X (WITH A/C)
16 R132968 STRAP 1 X X
17 T201537 CAP 1 X X
18 T205161 STRAP 1 X X
19 T205235 BRACKET 1 X X
20 T201538 PULLEY 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1672-3

PN=335
 2F1 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
SNOW LIGHT BRACKETS
T208054 -UN-12FEB05

THIS PARTS LISTING IS CONTINUED

1673-2 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=336
 2F2 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
SNOW LIGHT BRACKETS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7313 LOCK NUT 4 X X M12

2 14H1058 NUT 4 X X 3/4"
3 19M3167 CAP SCREW 4 X X M12 X 60
4 19M7949 CAP SCREW 4 X X M12 X 100
5 24M7047 WASHER 8 X X
6 T83426 WASHER 8 X X
7 AT306612 BRACKET 1 X X (RH)
8 AT306632 BRACKET 1 X X (LH)
9 AT307780 WIRING HARNESS 2 X X (FRONT WORKLIGHT EXTENSION)
10 M86690 GROMMET 2 X X
11 28H3387 BUSHING 4 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 1673-3

PN=337
 2F3 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
FRONT SIGNAL LIGHTS
T202181 -UN-14SEP04

THIS PARTS LISTING IS CONTINUED

1673-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=338
 2F4 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
FRONT SIGNAL LIGHTS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT206878 LAMP 2 X X (STANDARD)

2 AT210333 BULB 2 X X
3 T176372 LENS 4 X X
4 U44537 BULB 4 X X
6 AT307090 LAMP 2 X X (LED)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1673-5

PN=339
 2F5 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
TAIL LIGHTS
T202186 -UN-12DEC04

THIS PARTS LISTING IS CONTINUED

1673-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=340
 2F6 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
TAIL LIGHTS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T178948 RETAINER 4 X X
2 T180074 TURN SIGNAL LAMP 2 X X (AMBER LED)
T178947 TURN SIGNAL LAMP 2 X X (AMBER STANDARD)
3 T180075 TAIL LAMP 2 X X (RED LED)
T178946 TAIL LAMP 2 X X (RED STANDARD)
4 AT305935 WIRING HARNESS 1 X X (USE WITH LED LIGHTS)
AT305934 WIRING HARNESS 1 X X (USE WITH STANDARD LIGHTS)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 1673-7

PN=341
 2F7 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
BEACON LIGHT BRACKET
T210192 -UN-14APR05

THIS PARTS LISTING IS CONTINUED

1673-8 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=342
 2F8 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
BEACON LIGHT BRACKET

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7296 FLANGE NUT 3 X X M10

2 19M7806 SCREW 3 X X M10 X 50
3 24M7296 WASHER 3 X X
4 H140461 BUSHING 4 X X
5 AT304295 BRACKET 1 X X
6 03M7184 BOLT 1 X X M8 X 20
7 14M7396 LOCK NUT 3 X X M8
8 19M7868 SCREW 3 X X M8 X 30
9 24M7298 WASHER 4 X X
10 AT227063 LEVER 1 X X
11 T131169 WASHER 3 X X
12 R52921 WASHER 3 X X
13 AT318620 KIT 1 X X (WHOLEGOODS) (BEACON BRACKET KIT)
14 R44302 TIE BAND 3 X X
15 T187394 ANCHOR 3 X X
16 T185769 SCREW 3 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1673-9

PN=343
 2F9 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
CAB WORK AND DRIVE LIGHTS
T209115 -UN-04MAR05

THIS PARTS LISTING IS CONTINUED

1673-10 770D/772D MOTOR GRADER PC9449 (30-MAR-05)
PN=344
 2F10 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
CAB WORK AND DRIVE LIGHTS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7400 LOCK NUT 8 X X M10

2 19M7875 CAP SCREW 2 X X M10 X 70
3 24M7296 WASHER 10 X X
5 AT305931 FLOODLAMP 6 X X
6 R44302 TIE BAND 16 X X
7 19M8637 CAP SCREW 4 X X M10 X 40
8 AT306335 FLOODLAMP 2 X X
9 AT135758 BULB 1 X X
10 T80394 SCREW 4 X X
11 T185769 SCREW 10 X X
12 T187394 ANCHOR 10 X X
13 H140461 BUSHING 2

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1673-11

PN=345
 2F11 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
FRONT DRIVING LIGHTS
T203343 -UN-28OCT04

THIS PARTS LISTING IS CONTINUED

1673-12 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=346
 2F12 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
FRONT DRIVING LIGHTS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7275 NUT 4 X X M12

2 19M7403 CAP SCREW 4 X X M12 X 35
3 24M7240 WASHER 8 X X
4 AT305932 FLOODLAMP 4 X X
5 19M7550 CAP SCREW 1 X X M10 X 35
6 AT135758 BULB 1 X X
7 T80394 SCREW 4 X X
8 AT315249 BRACKET 1 X X
9 AT315250 BRACKET 1 X X
10 24M7239 WASHER 4 X X
11 14M7274 NUT 4 X X M10

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1673-13

PN=347
 2F13 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
REAR, MID-FRAME, AND UNDER CAB WORK LIGHTS
T203344 -UN-20OCT04

THIS PARTS LISTING IS CONTINUED

1673-14 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=348
 2F14 ELECTRICAL SYSTEMS 16
LIGHTING SYSTEM 1673
REAR, MID-FRAME, AND UNDER CAB WORK LIGHTS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7166 LOCK NUT 2 X X M8

2 14M7274 NUT 8 X X M10
3 19M7402 CAP SCREW 8 X X M10 X 25
4 19M7881 SCREW 2 X X M8 X 20
5 24M7238 WASHER 2 X X
6 24M7239 WASHER 8 X X
7 AT305926 FLOODLAMP 2 X X
8 AT135758 BULB 1 X X (USE FOR FRONT AND REAR WORK LIGHT)
9 AT305931 FLOODLAMP 4 X X
10 T75276 CLAMP 4 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1673-15

PN=349
 2F15 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
MAIN WIRING HARNESS (FRONT)
T208809 -UN-25FEB05

THIS PARTS LISTING IS CONTINUED

1674-2 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=350
 2F16 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
MAIN WIRING HARNESS (FRONT)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7298 FLANGE NUT 1 X X M8

2 14M7274 NUT 1 X X M10
3 19M7402 CAP SCREW 1 X X M10 X 25
4 19M7513 CAP SCREW 1 X X M8 X 30
5 19M7513 CAP SCREW 1 X X M8 X 30
6 19M7932 CAP SCREW 1 X X M8 X 16
7 19M7938 CAP SCREW 2 X X M10 X 20
8 24M7238 WASHER 3 X X
9 24M7239 WASHER 3 X X
10 AT305927 WIRING HARNESS 1 X X (FRONT PLATFORM)
11 AT307807 WIRING HARNESS 1 X X (RIGHT FRONT DRIVE/TURN)
12 AT307807 WIRING HARNESS 1 X X (LEFT FRONT DRIVE/TURN)
13 T102934 CLAMP 1 X X
14 T74412 CLAMP 3 X X
15 T74416 CLAMP 1 X X
T78787 CLAMP 1 597629- X X
16 T75276 CLAMP 1 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 1674-3

PN=351
 2F17 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
MAIN WIRING HARNESS (REAR)
T208810 -UN-25FEB05

THIS PARTS LISTING IS CONTINUED

1674-4 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=352
 2F18 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
MAIN WIRING HARNESS (REAR)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7881 SCREW 1 X X M8 X 20
2 19M7938 CAP SCREW 3 X X M10 X 20
3 24M7239 WASHER 3 X X
4 AT305936 WIRING HARNESS 1 X X (REAR PLATFORM HARNESS)
5 T209889 COVER 3 X X
6 T74412 CLAMP 3 X X
7 T74416 CLAMP 3 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1674-5

PN=353
 2F19 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
ENGINE WIRING HARNESS
T203941 -UN-29DEC04

THIS PARTS LISTING IS CONTINUED

1674-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=354
 2F20 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
ENGINE WIRING HARNESS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7303 FLANGE NUT 2 X X M6

2 19M7407 CAP SCREW 3 X X M8 X 25
3 19M7862 SCREW 2 X X M6 X 20
4 19M7932 CAP SCREW 1 X X M8 X 16
5 19M7938 CAP SCREW 4 X X M10 X 20
6 24M7139 WASHER 2 X X
7 24M7238 WASHER 4 X X
8 24M7239 WASHER 4 X X
9 AT145341 RELAY 1 X X
10 AT306366 WIRING HARNESS 1 X X (ENGINE WIRING HARNESS)
11 H77698 TIE BAND 4 X X
12 N189220 TIE BAND 4 X X (NOT ILLUSTRATED)
13 R44302 TIE BAND 5 X X (NOT ILLUSTRATED)
14 T102934 CLAMP 2 X X
15 T160333 NUT 2 X X
16 T162675 CLAMP 3 X X
17 T78787 CLAMP 3 X X
18 19M7513 CAP SCREW 1 X X M8 X 30
19 T74410 CLAMP 1 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1674-7

PN=355
 2F21 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
CAB INTERIOR WIRING HARNESS
T213494 -UN-25AUG05

THIS PARTS LISTING IS CONTINUED

1674-8 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=356
 2F22 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
CAB INTERIOR WIRING HARNESS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7863 SCREW 4 X X M6 X 25
2 19M7865 SCREW 2 X X M8 X 16
3 19M7867 SCREW 4 X X M8 X 25
4 19M7868 SCREW 2 X X M8 X 30
5 19M9224 CAP SCREW 1 X X M4 X 14, (SUB FOR 21M7250)
6 24M7087 WASHER 7 X X
7 37M7095 SCREW 2 X X
8 37M7218 SCREW 2 X X
9 57M8035 NUT 4 X X
10 AT317063 RELAY 1 X X (IGNITION-100 AMP)
11 T200363 BRACKET 2 X X
12 AT302638 MONITOR 1 X X (CMU)
13 AT304953 BRACKET 1 X X
14 AT305385 CAB WIRING HARNESS 1 X (INTERIOR HARNESS)
AT305386 CAB WIRING HARNESS 1 X (INTERIOR HARNESS HFWD)
15 AT306180 RADIO SPEAKER WRG HARNESS 1 X X
16 AT307810 CAB WIRING HARNESS 1 X X (CAB POWER HARNESS)
17 .................. ISOLATOR 1 X X (MAKE FROM T63019 BULK MATERIAL, CUT TO
LENGTH)
18 GY20126 SOCKET OUTLET 2 X X (12 VOLT)
19 L155075 PLATE 1 X X
20 R44302 TIE BAND 10 X X
H77698 TIE BAND 7 X X
21 T182909 CLIP 2 X X
22 T185769 SCREW 1 X X
23 T187394 ANCHOR 1 X X
24 T196077 NUT 5 X X
25 T196079 NUT 6 X X
26 T205819 TIE BAND 5 X X
27 T205829 COVER 1 X X
28 T206106 LABEL 3 X X
29 T210672 BRACKET 1 X X
30 T82791 SCREW 4 X X
31 T82792 NUT 4 X X
32 T186793 LABEL 1 ( T186973 NOT ILLISTRATED)
33 N198631 CLAMP 1 X (6-WD HARNESS)
34 57M7477 ELECTRICAL CONNECTOR ASSY 1 X X (COVER FOR SERVICE EXPERT CONNECTOR)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1674-9

PN=357
 2F23 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
CAB ROOF WIRING HARNESS
T201539 -UN-30JUL04

THIS PARTS LISTING IS CONTINUED

1674-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=358
 2F24 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
CAB ROOF WIRING HARNESS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 57M8035 NUT 1 X X
2 AT305387 CAB WIRING HARNESS 1 X X (CAB ROOF HARNESS)
3 R44302 TIE BAND 22 X X
4 T185769 SCREW 22 X X
5 T187394 ANCHOR 22 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1674-11

PN=359
 2G1 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
TRANSMISSION WIRING HARNESS
T210302 -UN-15APR05

THIS PARTS LISTING IS CONTINUED

1674-14 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=360
 2G2 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
TRANSMISSION WIRING HARNESS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7274 NUT 1 X X M10

2 19M7402 CAP SCREW 1 X X M10 X 25
3 19M7513 CAP SCREW 3 X X M8 X 30
4 19M7932 CAP SCREW 3 X X M8 X 16
5 19M7938 CAP SCREW 1 X X M10 X 20
6 24M7238 WASHER 6 X X
7 24M7239 WASHER 1 X X
8 28H3385 BUSHING 2 X X
9 AH89557 CLIP 2 X X
10 AT305928 WIRING HARNESS 1 X X (TRANSMISSION WIRING HARNESS)
11 H77698 TIE BAND 10 X X (NOT ILLUSTRATED)
12 T102934 CLAMP 2 X X
13 T74412 CLAMP 1 X X
14 19M7513 CAP SCREW 1 X X M8 X 30
15 T76252 CLAMP 2 X X
16 T74416 CLAMP 2 X X
17 T120536 CLAMP 1 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1674-15

PN=361
 2G3 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
HFWD WIRING HARNESS
T201551 -UN-10NOV04

THIS PARTS LISTING IS CONTINUED

1674-16 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=362
 2G4 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
HFWD WIRING HARNESS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7938 CAP SCREW 1 X M10 X 20

2 24M7239 WASHER 3 X
3 AT280296 WIRING HARNESS 1 X (LEFT WHEEL SPEED SENSOR)
4 AT280297 WIRING HARNESS 1 X (RIGHT WHEEL SPEED SENSOR)
5 AT305929 WIRING HARNESS 1 X (HFWD FRONT)
6 AT305930 WIRING HARNESS 1 X (HFWD REAR)
7 R44302 TIE BAND 16 X (NOT ILLUSTRATED)
8 T102934 CLAMP 1 X
9 T78787 CLAMP 1 X
10 T75276 CLAMP 2 X
11 14M7274 NUT 1 X M10
12 19M7402 CAP SCREW 1 X M10 X 25
13 57M8736 ELEC. CONNECTOR ACCESSORY 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1674-17

PN=363
 2G5 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
HFWD CONTROL UNIT AND SWITCHES
T201552 -UN-28JUL04

THIS PARTS LISTING IS CONTINUED

1674-18 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=364
 2G6 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
HFWD CONTROL UNIT AND SWITCHES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M8827 SCREW 4 X M6 X 130

2 24M7347 WASHER 4 X
3 AL58295 KNOB 1 X
4 AT303859 ROTARY SWITCH 1 X (HFWD AGRESSIVENESS)
5 AT304023 SWITCH 1 X (HFWD ON/OFF)
6 AT304024 SWITCH 1 X (HFWD INCHING MODE)
7 AT314667 ELECTRONIC CONTROL UNIT 1 X (HFWD CONTROLLER)
8 T203912 INSTRUMENT PANEL 1 X (HFWD CONTROLS)
9 T203987 LABEL 1 X (HFWD AGRESSIVENESS DIAL)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1674-19

PN=365
 2G7 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
ARTICULATION SENSOR AND LINKAGE
T206900 -UN-28JAN05

THIS PARTS LISTING IS CONTINUED

1674-20 770D/772D MOTOR GRADER PC9449 (02-FEB-05)
PN=366
 2G8 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
ARTICULATION SENSOR AND LINKAGE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 12M7060 WASHER 2 X
2 14H778 NUT 2 X
3 19H2036 CAP SCREW 2 X
4 21H1401 SCREW 2 X
5 RE56489 LINK END 2 X (SUB FOR RE39224)
6 T203646 LEVER 1 X
7 M82772 WASHER 1 X
8 R72655 SNAP RING 1 X
9 RE56165 POTENTIOMETER 1 X
10 T215784 ARM 1 X
11 T82861 BUSHING 1 X
12 14H649 NUT 2 X 6.350 MM

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1674-21

PN=367
 2G9 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
VEHICLE ELECTRICAL CENTER (VEC)
T201875 -UN-30JUL04

THIS PARTS LISTING IS CONTINUED

1674-22 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=368
 2G10 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
VEHICLE ELECTRICAL CENTER (VEC)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7897 SCREW 2 X X M8 X 35
2 19M9224 CAP SCREW 4 X X M4 X 14, (SUB FOR 21M7250)
3 24M7087 WASHER 4 X X
4 AT304788 VEHICLE CONTROLLER 1 X X (VEC)(INCLUDES ALL FUSES, DIODES, AND
RELAYS)
5 AT308628 BRACKET 1 X X (VEC MOUNTING)
6 T196079 NUT 2 X X
7 T120536 CLAMP 1 X X
8 57M7688 FUSE 10 X X 5 AMP, (NOT ILLUSTRATED)
9 57M7690 FUSE 3 X X 15 AMP, (NOT ILLUSTRATED)
10 AT305389 RELAY 5 X X (NOT ILLUSTRATED)
11 57M7691 FUSE 1 X X 20 AMP, (NOT ILLUSTRATED)
12 57M7689 FUSE 15 X X 10 AMP, (NOT ILLUSTRATED)
13 57M8623 FUSE 1 X X 25 AMP, (NOT ILLUSTRATED)
14 57M8641 DIODE 5 X X (NOT ILLUSTRATED)

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1674-23

PN=369
 2G11 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
SEALED SWITCH MODULE (SSM)
T202038 -UN-13AUG04

THIS PARTS LISTING IS CONTINUED

1674-24 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=370
 2G12 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
SEALED SWITCH MODULE (SSM)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7360 LOCK NUT 4 X X M5

2 24M7139 WASHER 4 X X
3 AT303896 PUSH SWITCH 1 X X (SSM)
4 T206344 LABEL 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1674-25

PN=371
 2G13 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
CAB TILT CONSOLE WIRING HARNESS AND SWITCHES
T202039 -UN-28JAN05

THIS PARTS LISTING IS CONTINUED

1674-26 770D/772D MOTOR GRADER PC9449 (02-FEB-05)
PN=372
 2G14 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
CAB TILT CONSOLE WIRING HARNESS AND SWITCHES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT305384 INSTRUMENT PNL WRG HARNESS 1 X X (CMU WIRING HARNESS)

2 AT307628 MONITOR WIRING HARNESS 1 X X (CAB TILT CONSOLE WIRING HARNESS)
3 57M8131 ELEC. CONNECTOR TERMINAL 1 X X
4 R44302 TIE BAND 2 X X
5 AT106154 TOGGLE/ROCKER SWITCH 1 X X (DIFFERENTIAL LOCK SWITCH)
6 AT160480 ALARM SYSTEM 1 X X
7 AT302730 TOGGLE/ROCKER SWITCH 1 X X (TURN SIGNAL SWITCH)
8 AT302769 SWITCH 1 X X (DRIVING LIGHT HIGH/LOW BEAM SWITCH)
9 AT304026 SWITCH 1 X X (HAZARD WARNING LIGHT SWITCH)
10 M115279 PLUG 1 X X
11 R39554 SWITCH 1 X X (HORN)
12 T205821 LABEL 1 X X
13 T55501 CAP 1 X X
14 24H1441 WASHER 1 X X
15 AT195301 SWITCH 1 X X (IGNITION SWITCH)
16 AT195302 KEY 1 X X
17 R44302 TIE BAND 1 X X

770D/772D MOTOR GRADER PC9449 (02-FEB-05) 1674-27

PN=373
 2G15 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
POWER CONVERTER (24 VOLT TO 12 VOLT)
T202054 -UN-05AUG04

THIS PARTS LISTING IS CONTINUED

1674-28 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=374
 2G16 ELECTRICAL SYSTEMS 16
WIRING HARNESS AND SWITCHES 1674
POWER CONVERTER (24 VOLT TO 12 VOLT)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M9224 CAP SCREW 3 X X M4 X 14, (SUB FOR 21M7250)

2 24M7087 WASHER 3 X X
3 AT224894 CONVERTER 1 X X (10 AMP)
AT302797 CONVERTER 1 X X (25 AMP)

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1674-29

PN=375
 2G17 ELECTRICAL SYSTEMS 16
SYSTEM CONTROLS 1675
FLEX LOAD CENTER (FLC)
T201879 -UN-29JUL04

THIS PARTS LISTING IS CONTINUED

1675-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=376
 2G18 ELECTRICAL SYSTEMS 16
SYSTEM CONTROLS 1675
FLEX LOAD CENTER (FLC)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT305854 VEHICLE CONTROLLER 1 X X (FLEX LOAD CENTER) (FLC) (SOFTWARE MUST

BE DOWNLOADED FROM SDS SERVER BY
VEHICLE SERIAL NO.)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1675-3

PN=377
 2G20 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME INSTALLATION 1740
MAIN FRAME
T201886 -UN-29JUL04

THIS PARTS LISTING IS CONTINUED

1740-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=378
 2G21 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME INSTALLATION 1740
MAIN FRAME

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7489 CAP SCREW 1 X X M16 X 45

2 T146246 WASHER 1 X X
3 28H3401 SPACER 1 X X
4 AT320496 PIN 1 X X
5 AT302401 MAIN FRAME 1 X X (CONVENIENCE ASSEMBLY)
6 T158102 BUSHING 2 X X
7 T72414 BUSHING 1 X X
8 T82886 BUSHING 4 X X
9 T158229 BUSHING 2 X X
10 T157829 BUSHING 1 X X
11 T157828 BUSHING 1 X X
12 14H991 NUT 1 X X 1-1/2"
13 11H251 COTTER PIN 1 X X 1/4" X 3"
14 T157827 WASHER 2 X X
15 AT173971 PIN FASTENER 1 X X
17 .................. ISOLATOR AR X X (CUT TO LENGTH FROM T176644 BULK
MATERIAL) (NOT ILLUSTRATED)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1740-3

PN=379
 2G22 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME INSTALLATION 1740
ENGINE FRAME
T203055 -UN-22OCT04

THIS PARTS LISTING IS CONTINUED

1740-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=380
 2G23 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME INSTALLATION 1740
ENGINE FRAME

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT303670 FRAME 1 X X (CONVENIENCE ASSEMBLY)

2 14M7291 FLANGE NUT 1 X X M16
3 T72414 BUSHING 10 X X
4 T42843 BUSHING 1 X X
5 T42844 BUSHING 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1740-5

PN=381
 2G24 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME INSTALLATION 1740
MAIN FRAME COVERS
T210079 -UN-11APR05

THIS PARTS LISTING IS CONTINUED

1740-6 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=382
 2G25 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME INSTALLATION 1740
MAIN FRAME COVERS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7396 LOCK NUT 2 X X M8

2 19M7938 CAP SCREW 8 X X M10 X 20
3 24H1308 WASHER 6 X X
4 24H1657 WASHER 4 X X
5 24M7028 WASHER 2 X X
6 AT307275 COVER 1 X X
8 T204556 COVER 1 X X
9 T206293 COVER 1 X X
10 T77706 WASHER 4 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1740-7

PN=383
 2H1 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME BOTTOM GUARDS 1746
BOTTOM GUARD (WITHOUT RIPPER)
T201048 -UN-16AUG04

THIS PARTS LISTING IS CONTINUED

1746-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=384
 2H2 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME BOTTOM GUARDS 1746
BOTTOM GUARD (WITHOUT RIPPER)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT306846 KIT 1 X X (WHOLEGOODS)(BOTTOM GUARD WITHOUT RIPPER)

2 14M7277 NUT 2 X X M20
3 19M8002 CAP SCREW 6 X X M20 X 55
4 19M8638 CAP SCREW 2 X X M20 X 65
5 24M7242 WASHER 8 X X
6 AT306816 GUARD 1 X X
7 14M7443 FLANGE NUT 8 X X M12
8 T151797 WASHER 2 X X
9 T160698 BRACKET 2 X X
10 19M7597 CAP SCREW 2 X X M20 X 50

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1746-3

PN=385
 2H3 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME BOTTOM GUARDS 1746
BOTTOM GUARD SIDE SHIELDS (WITHOUT RIPPER)
T208599 -UN-18FEB05

THIS PARTS LISTING IS CONTINUED

1746-4 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=386
 2H4 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME BOTTOM GUARDS 1746
BOTTOM GUARD SIDE SHIELDS (WITHOUT RIPPER)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT306847 KIT 2 X X (WHOLEGOODS)(BOTTOM GUARD SIDE SHIELDS

WITHOUT RIPPER)
2 19M7790 SCREW 8 X X M12 X 35
4 T205202 PLATE 2 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1746-5

PN=387
 2H5 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME BOTTOM GUARDS 1746
BOTTOM GUARDS AND SIDE SHIELDS (WITH RIPPER)
T208600 -UN-18FEB05

THIS PARTS LISTING IS CONTINUED

1746-6 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=388
 2H6 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
FRAME BOTTOM GUARDS 1746
BOTTOM GUARDS AND SIDE SHIELDS (WITH RIPPER)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7790 SCREW 2 X X M12 X 35

2 19M7788 SCREW 8 X X M12 X 25
5 AT312431 KIT 1 X X
6 T205317 PLATE 2 X X
7 T205547 PLATE 1 X X
8 AT306944 KIT 1 X X (WHOLEGOODS) (RIPPER GUARD KIT)

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1746-7

PN=389
 2H7 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
BUMPERS,VEHICLE 1747
PUSH BLOCK

T200685 -UN-12DEC04

THIS PARTS LISTING IS CONTINUED

1747-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=390
 2H8 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
BUMPERS,VEHICLE 1747
PUSH BLOCK

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT164240 FRAME 1 X X (PUSH BLOCK)

2 19H3307 CAP SCREW 10 X X 3/4" X 6"
3 T83426 WASHER 20 X X
4 14H1058 NUT 10 X X
5 T10510 WASHER 10 X X
6 AT158292 KIT 1 X X (WHOLEGOODS) (FRONT PUSH BLOCK KIT)

THIS PARTS LISTING IS CONTINUED

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1747-3
PN=391
 2H9 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
CHASSIS WEIGHTS 1749
FRONT MOUNTED WEIGHT

T200684 -UN-07JUN04

THIS PARTS LISTING IS CONTINUED

1749-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=392
 2H10 FRAMES, CHASSIS OR SUPPORTING STRUCTURE 17
CHASSIS WEIGHTS 1749
FRONT MOUNTED WEIGHT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3307 CAP SCREW 2 X X 3/4" X 6", (SUB FOR 19H1988, THIS

APPLICATION) (WITH 550 POUND FRONT
WEIGHT WITH FRONT EQUIPMENT)
19H3307 CAP SCREW 10 X X 3/4" X 6", (SUB FOR 19H1988, THIS
APPLICATION) (WITH 550 POUND FRONT
WEIGHT)
2 19H3740 CAP SCREW 4 X X 3/4" X 7-1/2", (WITHOUT FRONT MOUNTED
EQUIPMENT)
19H3740 CAP SCREW 10 X X 3/4" X 7-1/2", (WITH 550 POUND FRONT
WEIGHT WITH FRONT EQUIPMENT)
19H3234 CAP SCREW 10 X X 3/4" X 8-1/2", (WITH 500 POUND FRONT
WEIGHT WITH PUSH BLOCK)
3 19H3415 CAP SCREW 3 X X 3/4" X 5-1/2", (WITH 550 POUND FRONT
WEIGHT WITH FRONT EQUIPMENT)
19H2826 CAP SCREW 1 X X 3/4" X 4-1/2", (SUB FOR 19H3105, THIS
APPLICATION) (WITH FRONT MOUNTED
EQUIPMENT)
4 T83426 WASHER 8 X X (SUB FOR T17776) (WITHOUT FRONT MOUNTED
EQUIPMENT)
T83426 WASHER 20 X X (SUB FOR T17776) (WITH 550 POUND FRONT
WEIGHT)
T83426 WASHER 4 X X (SUB FOR T17776) (WITH 550 POUND FRONT
WEIGHT WITH FRONT EQUIPMENT)
5 14H1058 NUT 4 X X 3/4", (WITHOUT FRONT MOUNTED EQUIPMENT)
14H1058 NUT 2 X X 3/4", (WITH 550 POUND FRONT WEIGHT WITH
FRONT EQUIPMENT)
14H1058 NUT 10 X X 3/4", (WITH 550 POUND FRONT WEIGHT)
6 T103590 PLATE 1 X X
7 R64283 LOCK WASHER 1 X X (WITH 550 POUND FRONT WEIGHT WITH FRONT
EQUIPMENT)
8 19H3415 CAP SCREW 3 X X 3/4" X 5-1/2", (WITH 550 POUND FRONT
WEIGHT WITH FRONT EQUIPMENT)

THIS PARTS LISTING IS CONTINUED

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1749-3
PN=393
 2H15 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB AND CANOPY FRAME
T203066 -UN-17SEP04

THIS PARTS LISTING IS CONTINUED

1810-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=394
 2H16 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB AND CANOPY FRAME

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT308196 CAB 1 X X (LOW PROFILE)(INCLUDES DOORS AND WINDOWS)

AT308197 CAB 1 X X (FULL HEIGHT)(INCLUDES DOORS AND WINDOWS)
AT310373 CAB 1 X X (LOW PROFILE W/OPENABLE WINDOWS)(INCLUDES
DOORS AND WINDOWS)
AT310374 CAB 1 X X (FULL HEIGHT WITH OPENABLE
WINDOWS)(INCLUDES DOORS AND WINDOWS)
AT310375 CANOPY 1 X X (LOW PROFILE CANOPY-NOT ILLUSTRATED)
(INCLUDES REAR WINDOW)
2 T196077 NUT 24 X X M6, (CAB OR CANOPY)(KREMNUT-NOT
ILLUSTRATED) (M6 FOR 2.5 TO 5.0 MM
THICKNESS)
T196079 NUT 65 X X M8, (CAB)(KREMNUT-NOT ILLUSTRATED) (M8
FOR 2.5 TO 5.0 MM THICKNESS)
T196079 NUT 48 X X M8, (CANOPY)(KREMNUT-NOT ILLUSTRATED) (M8
FOR 2.5 TO 5.0 MM THICKNESS)
T196080 NUT 8 X X M8, (CAB OR CANOPY)(KREMNUT-NOT
ILLUSTRATED) (M8 FOR 5.0 TO 7.0 MM
THICKNESS)
H173411 NUT 22 X X M10, (CAB)(KREMNUT-NOT ILLUSTRATED) (M10
FOR 3.0 TO 4.5 MM THICKNESS)
H173411 NUT 19 X X M10, (CANOPY)(KREMNUT-NOT ILLUSTRATED)
(M10 FOR 3.0 TO 4.5 MM THICKNESS)
T148409 NUT 8 X X (CAB OR CANOPY)(KREMNUT-NOT ILLUSTRATED)
(M10 FOR 5.0 TO 7.0 MM THICKNESS)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1810-3

PN=395
 2H17 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
FRONT WINDSHIELD WIPER
T208500 -UN-18FEB05

THIS PARTS LISTING IS CONTINUED

1810-4 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=396
 2H18 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
FRONT WINDSHIELD WIPER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7775 SCREW 1 X X M6 X 16
2 19M7868 SCREW 4 X X M8 X 30
4 AL153661 WIPER BLADE 1 X X (USE WITH FULL HEIGHT CAB)
AL153660 WIPER BLADE 1 X X (USE WITH LOW PROFILE CAB)
5 AT116970 ELBOW FITTING 1 X X
6 AT106413 CAP 1 X X
7 T125860 TANK 1 X X
8 T127280 GROMMET 1 X X
9 AT173192 PUMP 1 X X
10 AT304630 WIPER MOTOR 1 X X (USE WITH FULL HEIGHT CAB)
AT304635 WIPER MOTOR 1 X X (USE WITH LOW PROFILE CAB)
11 AT304633 WIPER ARM 1 X X (USE WITH FULL HEIGHT CAB)
AT304634 WIPER ARM 1 X X (USE WITH LOW PROFILE CAB)
12 B2976R PLUG 1 X X
13 .................. BULK HOSE 1 X X (MAKE FROM R120653) (CUT TO LENGTH)
14 T126400 HOSE FITTING 1 X X
15 T182909 CLIP 8 X X
16 T196079 NUT 4 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1810-5

PN=397
 2H19 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
REAR WINDSHIELD WIPER
T208501 -UN-18FEB05

THIS PARTS LISTING IS CONTINUED

1810-6 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=398
 2H20 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
REAR WINDSHIELD WIPER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7775 SCREW 1 X X M6 X 16
3 AL153661 WIPER BLADE 1 X X (USE WITH FULL HEIGHT CAB)
AL153660 WIPER BLADE 1 X X (USE WITH LOW PROFILE CAB)
4 AT116970 ELBOW FITTING 1 X X (USE WITH FULL HEIGHT CAB)
5 AT173192 PUMP 1 X X
6 AT304630 WIPER MOTOR 1 X X (USE WITH FULL HEIGHT CAB)
AT304635 WIPER MOTOR 1 X X (USE WITH LOW PROFILE CAB)
7 AT304633 WIPER ARM 1 X X (USE WITH FULL HEIGHT CAB)
AT304634 WIPER ARM 1 X X (USE WITH LOW PROFILE CAB)
8 .................. BULK HOSE 1 X X (CUT TO LENGTH) (MAKE FROM R120653)
9 T182909 CLIP 1 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1810-7

PN=399
 2H21 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
LOWER FRONT WINDSHIELD WIPER
T207943 -UN-12FEB05

THIS PARTS LISTING IS CONTINUED

1810-8 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=400
 2H22 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
LOWER FRONT WINDSHIELD WIPER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AL114275 CHECK VALVE 1 X X

2 AT188681 KIT 1 X X
3 AT173192 PUMP 1 X X
4 AT303926 WIPER MOTOR 1 X X
5 AT305663 WIPER ARM 2 X X
6 AT305698 WIPER BLADE 2 X X
7 .................. BULK HOSE 1 X X (MAKE FROM R120653) (CUT TO LENGTH)
8 M47566 CLIP 1 X X
9 T182909 CLIP 1 X X
10 T58542 FITTING 1 X X
11 AT307779 SENSOR 2 X X
12 T208283 PLATE 2 X X
13 37M7314 SCREW 4 X X M4 X 16
14 T215218 PLATE 2 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1810-9

PN=401
 2H23 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB ISOLATORS
T202057 -UN-02SEP04

THIS PARTS LISTING IS CONTINUED

1810-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=402
 2H24 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB ISOLATORS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7277 NUT 2 X X M20

2 19M7781 CAP SCREW 2 X X M24 X 150
3 19M7883 SCREW 2 X X M20 X 120
4 24M7242 WASHER 2 X X
5 24M7243 WASHER 2 X X
6 AT165288 ISOLATOR 2 X X
7 AT170005 ISOLATOR 2 X X
8 T101807 WASHER 2 X X
9 T153535 WASHER 2 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1810-11

PN=403
 2I1 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
STATIONARY WINDOWS
T202649 -UN-08DEC04

THIS PARTS LISTING IS CONTINUED

1810-12 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=404
 2I2 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
STATIONARY WINDOWS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T135675 STAND-OFF AR X X (USED BETWEEN WINDOW AND CAB)

2 T202076 WINDOWPANE 1 X X LH FRONT LOWER
3 T202077 WINDOWPANE 1 X X RH FRONT LOWER
4 T202074 WINDOWPANE 2 X X SIDE-LOW PROFILE CAB,64"(1629MM)TALL
T202131 WINDOWPANE 2 X X SIDE-FULL HEIGHT CAB,72.5"(1854MM)TALL
5 T202075 WINDOWPANE 1 X X REAR-LOW PROFILE CANOPY AND
CAB,34"(858MM) TALL
T202132 WINDOWPANE 1 X X REAR-FULL HEIGHT CAB,42.5"(1083MM)TALL
6 .................. WINDSHIELD 1 X X LOW PROFILE CAB,26"(652 MM)TALL, (SUB
AT325943) ( T202078 NO LONGER
AVAILABLE)
.................. WINDSHIELD 1 X X FULL HEIGHT CAB,34.5"(878MM)TALL, (SUB
AT325944) ( T202133 NO LONGER
AVAILABLE)
7 T214023 ISOLATOR 1 X X (FRONT WINDOW EDGE PROTECTOR 17’ LONG)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1810-13

PN=405
 2I3 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
WINDSHIELD REPAIR KIT
T213677 -UN-25AUG05

THIS PARTS LISTING IS CONTINUED

1810-13A 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=406
 2I4 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
WINDSHIELD REPAIR KIT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R83066 ISOLATOR 1 X X CUT INTO TWO 40 MM (1.5 IN) STRIPS

2 T135675 STAND-OFF 10 X X
3 .................. WINDSHIELD 1 X X (SUB AT325943) FULL HEIGHT CAB
.................. WINDSHIELD 1 X X (SUB AT325944) LOW PROFILE HEIGHT CAB
4 T214023 ISOLATOR 1 X X
5 AT325943 WINDSHIELD KIT 1 X X (FULL HEIGHT CAB)
AT325944 WINDSHIELD KIT 1 X X (LOW PROFILE HEIGHT CAB)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1810-13B

PN=407
 2I5 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
OPENABLE WINDOWS (LOWER FRONT)
T208146 -UN-12FEB05

THIS PARTS LISTING IS CONTINUED

1810-14 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=408
 2I6 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
OPENABLE WINDOWS (LOWER FRONT)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT304098 WINDOW 1 X X LH LOWER OPENABLE-COMPLETE

2 24H1288 WASHER 1 X X
3 AT196522 LATCH 1 X X
4 A48970 DUAL LOCK FASTENER 2 X X
5 T119153 LATCH 1 X X
6 AT315903 GAS OPERATED CYLINDER 1 X X
7 AT315906 HINGE 1 X X
8 AT315909 WINDOW 1 X X
9 T188806 SCREW 1 X X
10 T211943 ISOLATOR 1 X X
11 T213917 BUSHING 1 X X
12 T76833 WASHER 1 X X
13 AT304099 WINDOW 1 X X RH LOWER OPENABLE-COMPLETE
14 AT315910 WINDOW 1 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1810-15

PN=409
 2I7 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
OPENABLE WINDOWS (SIDE)
T202929 -UN-20OCT04

THIS PARTS LISTING IS CONTINUED

1810-16 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=410
 2I8 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
OPENABLE WINDOWS (SIDE)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT305416 WINDOW 2 X X (FULL HEIGHT)

AT305414 WINDOW 2 X X (LOW PROFILE)
2 AT315844 LATCH 1 X X
3 AT315896 WINDOWPANE 1 X X (FULL HEIGHT AND LOW PROFILE)
4 AT316267 LATCH 2 X X
5 T211868 WINDOWPANE 1 X X (FULL HEIGHT)
T211864 WINDOWPANE 1 X X (LOW PROFILE)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1810-17

PN=411
 2I9 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB INTERIOR PANELS
T211691 -UN-03JUN05

THIS PARTS LISTING IS CONTINUED

1810-18 770D/772D MOTOR GRADER PC9449 (09-JUN-05)
PN=412
 2I10 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB INTERIOR PANELS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7298 FLANGE NUT 1 X X M8

2 19M7799 SCREW 2 X X M8 X 45
3 19M7808 SCREW 6 X X M10 X 65
4 19M7868 SCREW 3 X X M8 X 30
5 19M8403 CAP SCREW 1 X X M8 X 75
6 24H1296 WASHER 2 X X
7 H140461 BUSHING 6 X X (SUB FOR 28H3436)
8 28H3450 SPACER 2 X X
9 AT305406 GRILLE 2 X X (SPEAKER GRILLE)
10 AT307650 COVER 1 X X (REAR WIPER COVER)
11 AT314363 BRACKET 1 X X (ALSO ORDER (2) T196077)
12 AT314364 BRACKET 1 X X (ALSO ORDER (2) T196077)
13 .................. ISOLATOR 1 X X (MAKE FROM T63019) (CUT TO LENGTH)
14 H173411 NUT 6 X X
15 L102023 HOOK 1 X X
16 R53528 NUT 8 X X
17 R77915 HOLDER 1 X X (OPERATOR’S MANUAL HOLDER)
18 R79033 RIVET 6 X X
19 21M7292 SCREW 2 X X M6 X 16
20 24H1821 WASHER 10 X X 9/32" X 47/64" X 1/16"
21 21M7403 SCREW 5 X X M6 X 40
22 21M7310 SCREW 2 X X M6 X 25
23 T148409 NUT 8 X X
24 T186793 LABEL 7 X X
25 T196077 NUT 7 X X
26 T196079 NUT 11 X X
27 T202687 HEADLINER 1 X X (LOW PROFILE CAB)
T205243 HEADLINER 1 X X (FULL HEIGHT CAB)
28 T202799 HOUSING 1 X X (FRONT WIPER COVER)
29 T202921 HOUSING 1 X X (RADIO HOUSING)
30 T203390 BRACKET 1 X X
31 T203950 PLUG 4 X X
32 T204645 COVER 1 X X
33 T82791 SCREW 4 X X
34 T82792 NUT 4 X X
35 37M7218 SCREW 2 X X
36 T212073 PLATE 1 X X
37 TT206940 LAMP 1 X X (DOMELIGHT)
38 24H1695 WASHER 1 X X
39 24M7298 WASHER 2 X X 8.400 X 25 X 2 MM
40 U43012 STRIKER 4 X X
41 19M7881 SCREW 1 X X (USED TO PLUG HOLE IN CAB)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 1810-19

PN=413
 2I11 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CANOPY INTERIOR PANELS
T211693 -UN-03JUN05

THIS PARTS LISTING IS CONTINUED

1810-20 770D/772D MOTOR GRADER PC9449 (09-JUN-05)
PN=414
 2I12 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CANOPY INTERIOR PANELS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7298 FLANGE NUT 1 X X M8

2 19M7799 SCREW 2 X X M8 X 45
3 19M7808 SCREW 3 X X M10 X 65
4 19M7868 SCREW 3 X X M8 X 30
5 19M8403 CAP SCREW 1 X X M8 X 75
6 24H1296 WASHER 2 X X
7 H140461 BUSHING 3 X X (SUB FOR 28H3436)
8 28H3450 SPACER 2 X X
9 AT305406 GRILLE 2 X X
10 AT307650 COVER 1 X X
11 AT308941 SUPPORT 1 X X
12 AT314364 KIT 1 X X
14 H173411 NUT 3 X X
15 L102023 HOOK 1 X X
16 R53528 NUT 8 X X
17 R77915 HOLDER 1 X X
18 R79033 RIVET 6 X X
19 21M7292 SCREW 2 X X M6 X 16
20 24H1821 WASHER 11 X X 9/32" X 47/64" X 1/16"
21 21M7403 SCREW 5 X X M6 X 40
22 21M7310 SCREW 3 X X
23 T148409 NUT 8 X X
24 T186793 LABEL 4 X X
25 T196077 NUT 7 X X
26 T196079 NUT 13 X X
27 T202687 HEADLINER 1 X X (LOW PROFILE CAB)
28 T202799 HOUSING 1 X X
29 T202921 HOUSING 1 X X
30 19M7897 SCREW 2 X X
32 T204645 COVER 1 X X
33 T82791 SCREW 4 X X
34 T82792 NUT 4 X X
35 T166297 GROMMET 1 X X
36 T206985 SEAL 1 X X
37 T207637 BRACKET 1 X X
38 19M7775 SCREW 1 X X
39 T215319 CLAMP 1 X X
40 24H1695 WASHER 1 X X
41 24M7298 WASHER 2 X X
42 U43021 BUMPER 4 X X
43 19M7881 SCREW 1 X X (USED TO PLUG HOLE IN CAB)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 1810-21

PN=415
 2I13 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB REAR INTERIOR PANELS
T203161 -UN-01NOV04

THIS PARTS LISTING IS CONTINUED

1810-22 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=416
 2I14 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB REAR INTERIOR PANELS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 R134098 NUT 2 X X
2 24H1821 WASHER 7 X X
3 21M7310 SCREW 7 X X M6 X 25
4 T196077 NUT 4 X X
5 T202793 COVER 1 X X
6 T205354 COVER 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1810-23

PN=417
 2I15 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB ROOF
T209064 -UN-04MAR05

THIS PARTS LISTING IS CONTINUED

1810-24 770D/772D MOTOR GRADER PC9449 (30-MAR-05)
PN=418
 2I16 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB ROOF

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7296 FLANGE NUT 4 X X M10

2 19M7805 SCREW 4 X X M10 X 45
3 19M7807 SCREW 7 X X M10 X 60, (SUB FOR 19M7808)
4 19M7810 SCREW 1 X X M10 X 80
5 19M7866 BOLT 6 X X M8 X 20
6 24M7296 WASHER 4 X X
7 H140461 BUSHING 11 X X (SUB FOR 28H3436)
8 AT317562 PLATE 1 X X
9 H173411 NUT 8 X X
10 T185664 SEALING WASHER 3 X X
11 T203896 ROOF 1 X X
12 T204319 PLATE 1 X X
13 T205066 ISOLATOR 1 X X
14 T205068 SEALING WASHER 5 X X
15 24H1334 WASHER 4

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1810-25

PN=419
 2I17 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB FLOORMAT
T201842 -UN-29JUL04

THIS PARTS LISTING IS CONTINUED

1810-26 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=420
 2I18 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB FLOORMAT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 21M7310 SCREW 4 X X M6 X 25
2 T196077 NUT 1 X X
3 T202357 MAT 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1810-27

PN=421
 2I19 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CANOPY SIDE CONSOLE
T203909 -UN-19NOV04

THIS PARTS LISTING IS CONTINUED

1810-28 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=422
 2I20 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CANOPY SIDE CONSOLE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7863 SCREW 1 X X M6 X 25
2 19M7868 SCREW 6 X X M8 X 30
3 19M8092 SCREW 2 X X M6 X 50
4 24M7139 WASHER 1 X X
5 24M7298 WASHER 2 X X
6 AT306848 BRACKET 1 X X (FLC AND POWER CONVERTER MOUNTING
BRACKET)
8 H113924 PLUG 3 X X
9 M115279 PLUG 1 X X
10 R134098 NUT 9 X X
11 21M7292 SCREW 1 X X M6 X 16
12 24H1646 WASHER 9 X X (SUB FOR T134530)
13 21M7310 SCREW 8 X X M6 X 25
14 T157172 LABEL 1 X X
15 T196077 NUT 2 X X
16 T196079 NUT 6 X X
17 T202800 INSTRUMENT PANEL 1 X X
18 T203961 INSTRUMENT PANEL 1 X X
19 T205661 HOUSING 1 X X
20 T205662 HOUSING 1 X X
21 T205671 BRACKET 1 X X (ALSO ORDER (2) T196077)
22 T213199 LABEL 1 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 1810-29

PN=423
 2I21 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB SIDE CONSOLE
T203914 -UN-18DEC04

THIS PARTS LISTING IS CONTINUED

1810-30 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=424
 2I22 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB SIDE CONSOLE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7303 FLANGE NUT 1 X X M6

2 19M7863 SCREW 2 X X M6 X 25
3 19M7868 SCREW 6 X X M8 X 30
4 19M8092 SCREW 2 X X M6 X 50
5 24M7139 WASHER 2 X X
6 24M7298 WASHER 2 X X
7 AT306848 BRACKET 1 X X (FLC AND POWER CONVERTER MOUNTING
BRACKET)
10 21M7292 SCREW 1 X X M6 X 16
11 24H1821 WASHER 5 X X
12 21M7310 SCREW 4 X X M6 X 25
13 T157172 LABEL 1 X X
14 T196077 NUT 3 X X
15 T196079 NUT 6 X X
16 T201564 CONTROL CONSOLE 1 X X (GEARSHIFT LEVER CONSOLE)
17 T201571 CONSOLE 1 X X (A/C CONSOLE)
18 T203961 INSTRUMENT PANEL 1 X X
19 T205671 BRACKET 1 X X (ALSO ORDER (2) T196077)
20 T213140 BRACKET 1 X X (ALSO ORDER T196077)
21 T213199 LABEL 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1810-31

PN=425
 2I23 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
RIGHT SIDE CAB DOOR
T204838 -UN-11NOV04

THIS PARTS LISTING IS CONTINUED

1810-32 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=426
 2I24 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
RIGHT SIDE CAB DOOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H786 NUT 2 X X
2 14M7165 LOCK NUT 4 X X M6
3 14M7298 FLANGE NUT 2 X X M8
4 19M7933 CAP SCREW 12 X X M6 X 25
5 21M7289 SCREW 4 X X M6 X 40
6 21M7326 SCREW 4 X X M6 X 20
7 24H1646 WASHER 4 X X
8 24M7293 WASHER 12 X X
9 37M7059 SCREW 4 X X M5 X 12
10 AT306181 HANDLE 2 X X
11 AT317981 BELLCRANK 2 X X
13 AT317983 LATCH 1 X X
15 AT317985 LATCH 1 X X
16 H110232 WASHER 2 X X
17 T160017 SPACER 4 X X
18 T160020 PIN 8 X X
19 T175675 WASHER 8 X X
20 T202653 WINDOWPANE 1 X X (RH LOW PROFILE)
T202655 WINDOWPANE 1 X X (RH FULL HEIGHT)
22 T204599 GASKET 2 X X
23 T205901 WASHER 2 X X
24 T205902 SPACER 2 X X
25 T210101 YOKE 2 X X
26 T210102 PIN FASTENER 2 X X
27 T210103 RING 2 X X
28 T210106 SPRING 2 X X
29 T213167 LEVER 1 X X
31 T213443 ROD 2 X X
32 T213444 CLEVIS 2 X X
33 T213445 GROMMET 2 X X
34 L152397 GROMMET 6 X X (SUB FOR T213447)
35 T213448 STRAP 2 X X
36 T213450 ROD 2 X X (LOW PROFILE)
T213449 ROD 2 X X (FULL HEIGHT)
37 T213451 ROD 2 X X
38 T213452 COVER 2 X X
39 14M7274 NUT 2 X X M10
40 14M7275 NUT 2 X X M12
41 19M7402 CAP SCREW 8 X X M10 X 25
42 24M7296 WASHER 10 X X
43 AT303744 DOOR 1 X X (RH LOW PROFILE)
AT303748 DOOR 1 X X (RH FULL HEIGHT)
45 AT307096 STRIKER 2 X X
46 T201880 STUD 2 X X
47 AT322428 ISOLATOR 2 X X
48 AT317979 BUMPER 2 X X
49 AT317980 BUMPER 2 X X
50 R70663 WASHER 2 X X
51 T196079 NUT 4 X X
52 T205499 GUARD 2 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 1810-33

PN=427
 2J1 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
LEFT SIDE CAB DOOR
T204307 -UN-18DEC04

THIS PARTS LISTING IS CONTINUED

1810-34 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=428
 2J2 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
LEFT SIDE CAB DOOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H786 NUT 2 X X
2 14M7165 LOCK NUT 4 X X M6
3 14M7298 FLANGE NUT 2 X X M8
4 19M7933 CAP SCREW 12 X X M6 X 25
5 21M7289 SCREW 4 X X M6 X 40
6 21M7326 SCREW 4 X X M6 X 20
7 24H1646 WASHER 4 X X
8 24M7293 WASHER 12 X X
9 37M7059 SCREW 4 X X M5 X 12
10 AT306181 HANDLE 2 X X
11 AT317981 BELLCRANK 2 X X
12 AT317982 LATCH 1 X X
14 AT317984 LATCH 1 X X
16 H110232 WASHER 2 X X
17 T160017 SPACER 4 X X
18 T160020 PIN 8 X X
19 T175675 WASHER 8 X X
21 T202654 WINDOWPANE 1 X X (LH LOW PROFILE)
T202656 WINDOWPANE 1 X X (LH FULL HEIGHT)
22 T204599 GASKET 2 X X
23 T205901 WASHER 2 X X
24 T205902 SPACER 2 X X
25 T210101 YOKE 2 X X
26 T210102 PIN FASTENER 2 X X
27 T210103 RING 2 X X
28 T210106 SPRING 2 X X
30 T213167 LEVER 1 X X
31 T213443 ROD 2 X X
32 T213444 CLEVIS 2 X X
33 T213445 GROMMET 2 X X
34 T213447 GROMMET 6 X X
35 T213448 STRAP 2 X X
36 T213450 ROD 2 X X (LOW PROFILE)
T213449 ROD 2 X X (FULL HEIGHT)
37 T213451 ROD 2 X X
38 T213452 COVER 2 X X
39 14M7274 NUT 2 X X M10
40 14M7275 NUT 2 X X M12
41 19M7402 CAP SCREW 8 X X M10 X 25
42 24M7296 WASHER 10 X X
44 AT303745 DOOR 1 X X (LH LOW PROFILE)
AT303749 DOOR 1 X X (LH FULL HEIGHT)
45 AT307096 STRIKER 2 X X
46 T201880 STUD 2 X X
47 AT322428 ISOLATOR 2 X X
48 AT317979 BUMPER 2 X X
50 R70663 WASHER 2 X X
51 T196079 NUT 4 X X
52 T205499 GUARD 2 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1810-35

PN=429
 2J3 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB STATIONARY FRONT CONSOLE
T204497 -UN-12NOV04

THIS PARTS LISTING IS CONTINUED

1810-36 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=430
 2J4 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB STATIONARY FRONT CONSOLE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7799 SCREW 4 X X M8 X 45
2 19M7867 SCREW 2 X X M8 X 25
3 24H1296 WASHER 6 X X
4 28H3393 BUSHING 2 X X
5 28H3450 SPACER 4 X X
6 37M7333 SCREW 4 X X
7 21M7292 SCREW 4 X X M6 X 16
8 24H1646 WASHER 4 X X (SUB FOR T134530)
9 T196079 NUT 6 X X
10 T201565 AIR DUCT 1 X X
11 T202746 SEAL 2 X X
12 T202797 COVER 1 X X
13 T212947 LOUVER 1 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 1810-37

PN=431
 2J5 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
STEERING WHEEL
T205167 -UN-29NOV04

THIS PARTS LISTING IS CONTINUED

1810-38 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=432
 2J6 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
STEERING WHEEL

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7785 SCREW 4 X X M10 X 25

2 M142218 STEERING WHEEL 1 X X
3 M142219 COVER 1 X X
4 AT322881 STEERING COLUMN 2 X X
5 T213896 NUT 1 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1810-39

PN=433
 2J7 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB CONTROL LEVER CONSOLE
T212873 -UN-21JUL05

THIS PARTS LISTING IS CONTINUED

1810-40 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=434
 2J8 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB CONTROL LEVER CONSOLE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7805 SCREW 4 X X M10 X 45

2 37M7131 SCREW 6 X X
3 11M7078 COTTER PIN 2 X X
4 14M7296 FLANGE NUT 9 X X M10
5 19M7804 SCREW 8 X X M10 X 40
6 21M7497 SCREW 1 X X M10 X 50
7 22M7111 SET SCREW 5 X X M6 X 6
9 24M7296 WASHER 9 X X
10 34M7044 SPRING PIN 1 X X
11 AT305051 CONTROL SUPPORT 1 X X
12 AT305052 CONTROL SUPPORT 1 X X
13 AT305070 BRACKET 1 X X (ALSO ORDER (4) T196078)
14 AT305018 CONTROL SUPPORT 1 X X
15 T203544 BUSHING 8 X X
16 AT305297 BRACKET 1 X X
17 T204643 PLATE 1 X X
18 T203545 BUSHING 8 X X
19 AT305310 BRACKET 1 X X
20 T205401 PLATE 2 X X
21 T206080 COVER 1 X X
22 AT305397 LEVER 1 X X
24 14M7500 NUT 1 X X M10
25 T104220 WASHER 4 X X
26A .................. ADAPTER 1 X X (SUB T217649, T217650, R69166) ( T210698
NO LONGER AVAILABLE)
26B T217649 ADAPTER 1 X X
27A .................. LEVER 1 X X (SUB T217649, T217650, R69166) ( T210699
NO LONGER AVAILABLE)
27B T217650 LEVER 1 X X
28 .................. PIN FASTENER 1 X X (SUB T217649, T217650, R69166) ( T210700
NO LONGER AVAILABLE)
29 M145875 EXTENSION SPRING 2 X X
32 T203569 SHAFT 1 X X
33 T203576 SPACER 5 X X
34 T203871 SPACER 1 X X
35 T210711 GROMMET 1 X X
36 T81012 CAP 1 X X
37 Z21059 PIN FASTENER 1 X X
37A Z21059 PIN FASTENER 1 X X
37B R69166 PIN 1 X X
38 .................. ISOLATOR 1 X X (MAKE FROM T59938) (CUT TO LENGTH)
39 H173411 NUT 4 X X
40 M84972 NUT 4 X X
41 T133674 SELF-LOCKING SCREW 4 X X
42 T134895 SELF-LOCKING SCREW 4 X X
43 T185769 SCREW 4 X X
44 T196078 NUT 4 X X
45 T203589 COVER 1 X X
46 T204301 COVER 1 X X
47 AT305734 WIRING HARNESS 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1810-41

PN=435
 2J9 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB CONTROL LEVERS (LEFT)
T210167 -UN-14APR05

THIS PARTS LISTING IS CONTINUED

1810-42 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=436
 2J10 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB CONTROL LEVERS (LEFT)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H882 NUT 14 X X
2 19H2127 CAP SCREW 14 X X
3 19M7868 SCREW 4 X X M8 X 30
4 N278790 SCREW 16 X X
5 19M7865 SCREW 2 X X M8 X 16, (USE WITH FOUR LEVERS)
19M7800 SCREW 1 X X M8 X 50, (USE WITH FIVE LEVERS)
19M7913 SCREW 1 X X M8 X 90, (USE WITH SIX LEVERS)
19M8006 SCREW 1 X X M8 X 120, (USE WITH SEVEN LEVERS)
6 24H1296 WASHER 1 X X
7 AT317737 KNOB 1 X X (CIRCLE ROTATE)
AT317739 KNOB 1 X X (ARTICULATION)
AT317740 KNOB 1 X X (WHEEL LEAN)
AT317741 KNOB 1 X X (RIGHT BLADE LIFT)
AT317744 KNOB 1 X X (AUXILIARY)
AT317742 KNOB 1 X X (SCARIFIER)
8 T213242 SET SCREW 1 X X
9 T104220 WASHER 32 X X
10 T202160 CONTROL LEVER 1 X X
11 T202161 CONTROL LEVER 1 X X
12 T202162 CONTROL LEVER 1 X X
13 T202163 CONTROL LEVER 1 X X
14 AT305667 BOOT 1 X X
15 AT305939 BOOT 1 X X
16 AT317778 LINK END 14 X X
17 T196079 NUT 11 X X
18 T202586 LEVER 7 X X
19 T204044 PLATE 2 X X
20 T204457 SPACER 1 X X
21 T202164 CONTROL LEVER 1 X X
22 T202159 CONTROL LEVER 2 X X
23 T196080 NUT 2 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1810-43

PN=437
 2J11 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB CONTROL LEVERS (RIGHT)
T210168 -UN-14APR05

THIS PARTS LISTING IS CONTINUED

1810-44 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=438
 2J12 OPERATOR’S STATION 18
OPERATOR ENCLOSURE 1810
CAB CONTROL LEVERS (RIGHT)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H882 NUT 14 X X
2 19H2127 CAP SCREW 14 X X
3 19M7868 SCREW 4 X X M8 X 30
4 N278790 SCREW 16 X X
5 19M7865 SCREW 2 X X M8 X 16, (USE WITH FOUR LEVERS)
19M7800 SCREW 1 X X M8 X 50, (USE WITH FIVE LEVERS)
19M7913 SCREW 1 X X M8 X 90, (USE WITH SIX LEVERS)
19M8006 SCREW 1 X X M8 X 120, (USE WITH SEVEN LEVERS)
6 24H1296 WASHER 1 X X
7 AT317734 KNOB 1 X X (LEFT BLADE LIFT)
AT317735 KNOB 1 X X (BLADE SIDE SHIFT)
AT317736 KNOB 1 X X (BLADE TILT)
AT317738 KNOB 1 X X (CIRCLE SIDE SHIFT)
AT317743 KNOB 1 X X (RIPPER)
AT317744 KNOB 1 X X (AUXILIARY)
8 T213242 SET SCREW 1 X X
9 T104220 WASHER 32 X X
10 T202160 CONTROL LEVER 1 X X
11 T202161 CONTROL LEVER 1 X X
12 T202162 CONTROL LEVER 1 X X
13 T202163 CONTROL LEVER 1 X X
14 AT305667 BOOT 1 X X
15 AT305939 BOOT 1 X X
16 AT317778 LINK END 14 X X
17 T196079 NUT 11 X X
18 T202586 LEVER 7 X X
19 T204044 PLATE 2 X X
20 T204457 SPACER 1 X X
21 T202164 CONTROL LEVER 1 X X
22 T202159 CONTROL LEVER 2 X X
23 T196080 NUT 2 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1810-45

PN=439
 2J13 OPERATOR’S STATION 18
SEAT AND SEAT BELTS 1821
AIR SUSPENSION SEAT
T204097 -UN-10NOV04

THIS PARTS LISTING IS CONTINUED

1821-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=440
 2J14 OPERATOR’S STATION 18
SEAT AND SEAT BELTS 1821
AIR SUSPENSION SEAT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7866 BOLT 4 X X
2 19H3569 CAP SCREW 2 X X
3 AT308199 SEAT BELT 1 X X
4 T105740 WASHER 4 X X
5 T163962 COVER 1 X X
6 AT224248 SEAT 1 X X GRAY CLOTH
7 AT195441 ARMREST KIT 1 X X (R.H.)
AT315715 PAD 1 X X
8 AT195442 ARMREST KIT 1 X X (L.H.)
AT315761 PAD 1 X X
9 AT209020 KIT 1 X X SLIDE PUCK KIT
10 AT209021 KIT 1 X X SLIDE SPRING KIT
11 R72655 SNAP RING 4 X X
12 T163334 SPRING 1 X X
13 T163335 SPRING 1 X X
14 T163336 TORSION SPRING 1 X X
15 AT209022 KIT 1 X X SLIDE CONTROL KIT
17 AT209024 KIT 1 X X LUMBAR KNOB KIT
18 34H262 SPRING PIN 1 X X
19 AT209025 KIT 1 X X RECLINER KNOB KIT
20 37H121 SCREW 1 X X
21 AT209026 KIT 1 X X LUMBAR SERVICE KIT
22 34H387 SPRING PIN 2 X X
23 AT209225 KIT 1 X X RECLINER SERVICE KIT (INCLUDES RECLINER
KNOB KIT AND TORSION SPRING)
24 M453T LOCK NUT 3 X X
25 AT308795 CUSHION 1 X X (SUB FOR AT221019) GRAY CLOTH
26 AT308796 CUSHION 1 X X (SUB FOR AT221020) GRAY CLOTH
27 T171686 CLIP 4 X X
28 AT308797 CUSHION 1 X X (SUB FOR AT221021) GRAY CLOTH
29 N119177 GROMMET 1 X X (NOT ILLUSTRATED)
30 AT208531 SEAT SUSPENSION 1 X X (AIR)(COMPONENTS ON SEPARATE PAGE)
31 .................. CONTROL 1 X X
32 AT305437 PEDESTAL 1 X X
33 H173411 NUT 4 X X
34 19M7805 SCREW 4 X X M10 X 45

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1821-3

PN=441
 2J15 OPERATOR’S STATION 18
SEAT AND SEAT BELTS 1821
AIR SEAT SUSPENSION COMPONENTS
T195125 -UN-25SEP03

THIS PARTS LISTING IS CONTINUED

1821-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=442
 2J16 OPERATOR’S STATION 18
SEAT AND SEAT BELTS 1821
AIR SEAT SUSPENSION COMPONENTS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT208531 SEAT SUSPENSION 1 X X

2 AT173313 SHAFT 1 X X
3 AT173314 SEAT BEARING ROLLER KIT 1 X X
4 AT173315 KIT 1 X X TETHER BELT SERVICE KIT
5 AT208483 HOUSING 1 X X
6 AT208484 HOUSING 1 X X
7 AT208485 ARM 1 X X
8 AT208486 SPRING 1 X X (AIR BLADDER SPRING)
9 AT208487 KIT 1 X X SUSPENSION SHOCK SERVICE KIT
10 AT208490 SELECTIVE CONTROL VALVE 1 X X
11 AT208491 KIT 1 X X BOOT SERVICE KIT (INCLUDES AT173321)
12 AT173321 SEAT SUSPENSION BOOT KIT 1 X X
13 AT209469 KIT 1 X X BUMPER SERVICE KIT
14 AT226676 COMPRESSOR 1 X X
15 AT208488 WIRING HARNESS 1 X X
16 T55224 BUMPER 1 X X
17 .................. SHAFT 2 X X (SUB AT173313)
18 .................. LOCK NUT 2 X X (SUB AT173313)
19 .................. BUSHING 4 X X (SUB AT173313)
20 .................. SHOCK ABSORBER 1 X X (SUB AT208487)
21 .................. BEARING 1 X X (SUB AT208487)
22 .................. ECCENTRIC LOCKING COLLAR 1 X X (SUB AT208487)
23 .................. PUSH NUT 1 X X (SUB AT208487)
24 .................. SPACER 1 X X (SUB AT208487)
25 .................. HYD ACTUATED CONTROL VALVE 1 X X (SUB AT208490)
26 .................. KNOB 1 X X (SUB AT208490)
27 .................. NUT 1 X X (SUB AT208490)
28 .................. LOCK WASHER 1 X X (SUB AT208490)
29 .................. CLIP 23 X X (SUB AT173321)
30 .................. RIVET 3 X X (SUB AT173321)
31 .................. RIVET 3 X X (SUB AT173321)
32 .................. BOOT 1 X X (SUB AT208491)
33 .................. BUMPER 2 X X (SUB AT209469)
34 .................. LOCK NUT 2 X X (SUB AT209469)
35 .................. SCREW 2 X X (SUB AT209469)
36 .................. WIRING HARNESS 1 X X (SUB AT208488)
37 .................. TIE BAND 4 X X (SUB AT208488)
38 .................. COMPRESSOR 1 X X (SUB AT226676)
39 .................. SPRING PIN 2 X X (SUB AT226676)
40 .................. RIVET 6 X X (SUB AT173321)
41 .................. CLAMP 1 X X (SUB AT226676)
42 .................. PIPE ELBOW 1 X X (SUB AT226676)
43 .................. TAB CONNECTOR BODY 1 X X (SUB AT226676)
44 AT208493 FITTING KIT 1 X X (AIRLINE HOSE AND FITTING KIT) (NOT
ILLUSTRATED)

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 1821-5

PN=443
 2J17 OPERATOR’S STATION 18
SEAT AND SEAT BELTS 1821
MECHANICAL SUSPENSION SEAT
T204659 -UN-21DEC04

THIS PARTS LISTING IS CONTINUED

1821-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=444
 2J18 OPERATOR’S STATION 18
SEAT AND SEAT BELTS 1821
MECHANICAL SUSPENSION SEAT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H785 NUT 4 X X 5/16"

2 19H3569 CAP SCREW 2 X X
3 AT308199 SEAT BELT 1 X X
4 T105740 WASHER 4 X X
5 T163962 COVER 1 X X
6 AT195440 SEAT 1 X X GRAY CLOTH
7 AT195441 ARMREST KIT 1 X X (R.H.)
AT315715 PAD 1 X X
8 AT195442 ARMREST KIT 1 X X (L.H.)
AT315761 PAD 1 X X
9 AT209020 KIT 1 X X SLIDE PUCK KIT
10 AT209021 KIT 1 X X SLIDE SPRING KIT
11 R72655 SNAP RING 4 X X
12 T163334 SPRING 1 X X
13 T163335 SPRING 1 X X
14 T163336 TORSION SPRING 1 X X
15 AT209022 KIT 1 X X SLIDE CONTROL KIT
17 AT209024 KIT 1 X X LUMBAR KNOB KIT
18 34H262 SPRING PIN 1 X X
19 AT209025 KIT 1 X X RECLINER KNOB KIT
20 37H121 SCREW 1 X X
21 AT209026 KIT 1 X X LUMBAR SERVICE KIT
22 34H387 SPRING PIN 2 X X
23 AT209225 KIT 1 X X RECLINER SERVICE KIT (INCLUDES RECLINER
KNOB KIT AND TORSION SPRING)
24 M453T LOCK NUT 3 X X
25 AT308795 CUSHION 1 X X (SUB FOR AT221019) GRAY CLOTH
26 AT308796 CUSHION 1 X X (SUB FOR AT221020) GRAY CLOTH
27 T171686 CLIP 4 X X
28 AT308797 CUSHION 1 X X (SUB FOR AT221021) GRAY CLOTH
29 N119177 GROMMET 1 X X (NOT ILLUSTRATED)
30 AT180126 SEAT SUSPENSION 1 X X (MECHANICAL)(COMPONENTS ON SEPARATE PAGE)
31 .................. CONTROL 1 X X
32 AT303518 PEDESTAL 1 X X
33 H173411 NUT 4 X X
34 19M7805 SCREW 4 X X M10 X 45
35 AT280583 PAN 1 X X
36 AT181392 KIT 2 X X
37 14M7296 FLANGE NUT 2 X X M10
38 19M7804 SCREW 2 X X M10 X 40
39 24H1887 WASHER 4 X X
40 28H3425 SPACER 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1821-7

PN=445
 2J19 OPERATOR’S STATION 18
SEAT AND SEAT BELTS 1821
MECHANICAL SEAT SUSPENSION COMPONENTS
T206425 -UN-29DEC04

THIS PARTS LISTING IS CONTINUED

1821-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=446
 2J20 OPERATOR’S STATION 18
SEAT AND SEAT BELTS 1821
MECHANICAL SEAT SUSPENSION COMPONENTS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT106397 BEARING KIT 1 X X

2 AT125801 SPRING 1 X X
3 T55210 SPRING 1 X X
4 AT125805 KIT 1 X X (ADJUSTING KNOB KIT)
5 34H266 SPRING PIN 1 X X
6 AT125829 KNOB 1 X X
7 AT175436 KIT 1 X X (SHOCK ABSORBER KIT)
8 T55222 BUSHING 2 X X
9 AT180126 SEAT SUSPENSION 1 X X (MECHANICAL SEAT SUSPENSION)
10 AT180135 SEAT SUSPENSION 1 X X (BOOT AND CLIP KIT)
11 T63798 PLUG 25 X X
12 T55224 BUMPER 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1821-9

PN=447
 2J21 OPERATOR’S STATION 18
STEPS 1822
CAB STEPS
T202320 -UN-02SEP04

THIS PARTS LISTING IS CONTINUED

1822-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=448
 2J22 OPERATOR’S STATION 18
STEPS 1822
CAB STEPS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7517 LOCK NUT 28 X X M10

2 19M8600 CAP SCREW 8 X X M10 X 50
3 19M8637 CAP SCREW 28 X X M10 X 40
4 24M7296 WASHER 16 X X
5 T173779 STRAP 12 X X
6 T176870 STEP 6 X X
7 T201673 BRACKET 2 X X
8 T202374 STRAP 4 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1822-3

PN=449
 2J23 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
CAB HEATER HOSES
T204121 -UN-12NOV04

THIS PARTS LISTING IS CONTINUED

1830-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=450
 2J24 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
CAB HEATER HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7865 SCREW 1 X X M8 X 16
2 AH77869 CLIP 1 X X
3 R41985 FITTING 1 X X
4 R117721 CLAMP 4 X X
5 .................. BULK HOSE 1 X X (MAKE FROM T60811) (CUT TO LENGTH)
6 R44302 TIE BAND 4 X X
7 T27077 HOSE FITTING 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1830-3

PN=451
 2K1 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HVAC POWERED PRECLEANER
T202492 -UN-28OCT04

THIS PARTS LISTING IS CONTINUED

1830-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=452
 2K2 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HVAC POWERED PRECLEANER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7862 SCREW 4 X X M6 X 20
2 AT302794 PRECLEANER 1 X X
3 T185326 ISOLATOR 1 X X
4 T185769 SCREW 2 X X
5 T213349 PLATE 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1830-5

PN=453
 2K3 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HEATER AND AIR CONDITIONER DUCTS
T212742 -UN-15JUL05

THIS PARTS LISTING IS CONTINUED

1830-8 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=454
 2K4 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HEATER AND AIR CONDITIONER DUCTS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7298 FLANGE NUT 1 X X M8

2 19M7774 SCREW 2 X X M6 X 12
3 19M7775 SCREW 4 X X M6 X 16
4 19M7799 SCREW 1 X X M8 X 45
5 19M7867 SCREW 1 X X M8 X 25
6 19M7897 SCREW 2 X X M8 X 35
8 19M8403 CAP SCREW 1 X X M8 X 75
9 T196079 NUT 1 X X
10 24H1296 WASHER 2 X X
11 24M7100 WASHER 3 X X
14 28H3450 SPACER 2 X X
15 37M7333 SCREW 32 X X
16 AR62936 CLAMP 4 X X
19 AT227668 LOUVER 10 X X
20 AT227669 LOUVER 3 X X
22 AT308017 AIR DUCT 1 X X
23 AT305524 GATE 1 X X
24 AT305869 DOOR 1 X X
25 T184345 RIVET 3 X X
32 AT308314 HOSE SUPPORT 1 X X
33 AT308935 ISOLATOR 1 X X
34 AT309837 BRACKET 1 X X
39 N189220 TIE BAND 2 X X
41 21M7292 SCREW 1 X X M6 X 16
42 24H1646 WASHER 3 X X (SUB FOR T134530)
46 T196079 NUT 9 X X
47 T201561 AIR DUCT 1 X X
48 T201562 AIR DUCT 1 X X
49 T201566 AIR DUCT 1 X X
50 T201568 AIR DUCT 1 X X
54 T202743 ISOLATOR 1 X X
55 T202744 ISOLATOR 1 X X
60 T203560 AIR DUCT 1 X X
66 T206718 PLATE 1 X X
69 T206985 SEAL 1 X X
70 T215319 CLAMP 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1830-9

PN=455
 2K5 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HEATER AND AIR CONDITIONER FILTER, FILTER HOUSING, AND COVER
T207941 -UN-12FEB05

THIS PARTS LISTING IS CONTINUED

1830-10 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=456
 2K6 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HEATER AND AIR CONDITIONER FILTER, FILTER HOUSING, AND COVER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

3 19M7775 SCREW 11 X X M6 X 16
4 19M7799 SCREW 5 X X M8 X 45
7 19M8290 SCREW 3 X X M6 X 35
10 24H1296 WASHER 6 X X 11/32" X 1-3/8" X 0.134"
11 24M7100 WASHER 10 X X 6.600 X 22 X 2 MM
12 24M7139 WASHER 2 X X 6.400 X 18 X 1.600 MM
13 24M7296 WASHER 1 X X 10.500 X 30 X 2.500 MM
14 28H3450 SPACER 6 X X 0.364" X 0.540" X 1/2"
17 AR83434 KNOB 1 X X
18 AT191102 AIR FILTER 1 X X
21 AT307501 AIR FILTER 1 X X
26 AT308283 HOUSING 1 X X
27 .................. SUPPORT 1 X X ( AT309672 NO LONGER AVAILABLE)
28 T206616 PLATE 1 X X
29 R79033 RIVET 5 X X
30 T184345 RIVET 4 X X
31 T206813 BRACKET 1 X X
37 AT315465 KIT 1 X X
38 H131531 PUSH NUT 1 X X
40 R134098 NUT 3 X X
42 24H1646 WASHER 3 X X 17/64" X 3/4" X 0.060", (SUB FOR T134530)
43 21M7310 SCREW 3 X X M6 X 25
44 T164945 SPACER 3 X X
45 T196077 NUT 1 X X
46 T196079 NUT 9 X X
51 T201570 AIR DUCT 1 X X
56 T202745 ISOLATOR 1 X X
57 T203143 COVER 1 X X
58 T203494 SEAL 1 X X
59 T203495 ISOLATOR 1 X X
61 T204278 COVER 1 X X
62 T206624 PLUG 1 X X
63 T206625 BRACKET 1 X X
64 T206626 BRACKET 1 X X
65 T206627 STRAP 1 X X (ALSO ORDER (2) T196077)
67 T206809 RETAINER 1 X X
68 T206812 RETAINER 1 X X
69 24M7298 WASHER 4 X X 8.400 X 25 X 2 MM
70 19M7867 SCREW 2 X X M8 X 25

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1830-11

PN=457
 2K7 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HEATER/AIR CONDITIONING MODULE ASSEMBLY
T212380 -UN-28JUN05

THIS PARTS LISTING IS CONTINUED

1830-12 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=458
 2K8 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HEATER/AIR CONDITIONING MODULE ASSEMBLY
7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 24M7100 WASHER 2 X X
2 19M8553 SCREW 2 X X M6 X 16
3 R125223 PLATE 1 X X
4 H85092 SCREW 2 X X
5 RE198074 TEMPERATURE SWITCH 1 X X
6 37M7073 SCREW 6 X X
7 AT318987 RESISTOR 1 X X
8 AT302953 BLOWER MOTOR 1 X X
9 M74782 NUT 4 X X
10 19M7775 SCREW 4 X X M6 X 16
11 M84972 NUT 4 X X
12 R162769 SEAL 1 X X
13 R50279 NUT 2 X X
14 R190722 HOUSING 1 X X
15 R96248 CLIP 11 X X
16 RE187311 EVAPORATOR 1 X X
17 PT11778 BOLT 2 X X
18 L77943 PLATE 1 X X
19 R113050 O-RING 1 X X
20 R33259 O-RING 1 X X
21 RE174764 VALVE 1 X X
22 RE177967 HEATER 1 X X
23 R190723 HOUSING 1 -XXXXXX X X
23A R244664 HOUSING 1 XXXXXX- X X
24 R163985 GROMMET 2 X X
25 T184924 HOSE CLAMP 1 X X
26 R125454 RADIATOR HOSE 1 X X
27 AT193500 HAND OPERATED VALVE 1 X X
35 37M7104 SCREW 3 X X
36 AT191178 LINE 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1830-13

PN=459
 2K9 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
AIR CONDITIONING COMPRESSOR,PULLEY AND SERVICE KITS
T204668 -UN-19NOV04

THIS PARTS LISTING IS CONTINUED

1830-14 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=460
 2K10 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
AIR CONDITIONING COMPRESSOR,PULLEY AND SERVICE KITS

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 RE52506 FLOW CONTROL HYD. VALVE 1 X X

2 R115742 SEAL 1 X X
3 RE55423 MANIFOLD 1 X X
4 RE52454 COMPRESSOR 1 X X WITHOUT CLUTCH
6 AT163872 KIT 1 X X STATOR
7 RE52508 KIT 1 X X 8 RIBBED PULLEY
8 R115743 COVER 1 X X
9 RE12363 ELECTRICAL CONNECTOR ASSY 1 X X (NOT ILLUSTRATED)
R78057 ELEC. CONNECTOR TERMINAL 2 X X (NOT ILLUSTRATED)
R78059 ELECTRICAL CONNECTOR ASSY 2 X X (NOT ILLUSTRATED)
14M7273 NUT 1 X X M8
10 RE52507 KIT 1 X X HARDWARE
11 RE52509 SEAL KIT 1 X X SHAFT SEAL
12 AT168543 COMPRESSOR 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1830-15

PN=461
 2K11 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
AIR CONDITIONING LINES, CONDENSER, AND RECEIVER-DRYER
T210170 -UN-14APR05

THIS PARTS LISTING IS CONTINUED

1830-16 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=462
 2K12 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
AIR CONDITIONING LINES, CONDENSOR, AND RECEIVER-DRYER

7 7
7 7
ENGINE 0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7298 FLANGE NUT 2 X X M8

2 14M7517 LOCK NUT 2 X X M10
3 19H3124 SCREW 1 X X 3/8" X 1-1/2"
4 19H3750 SCREW 2 X X 3/8" X 1-3/4"
5 19M7296 CAP SCREW 3 X X M8 X 100
6 19M7662 CAP SCREW 2 X X M10 X 30
7 19M7800 SCREW 1 X X M8 X 50
8 19M7938 CAP SCREW 7 X X M10 X 20
9 24M7239 WASHER 8 X X
10 24M7296 WASHER 4 X X
11 24M7298 WASHER 4 X X
12 34M7247 SPRING PIN 2 X X
13 AT162848 RECEIVER-DRYER 1 X X
14 AT190809 PNEUMATIC ACCUMULATOR 1 X X
15 AT191741 REFRIGERANT HOSE 1 X X
16 AT280631 REFRIGERANT HOSE 1 X X
18 AT307062 BRACKET 1 X X
19 AT307847 BRACKET 1 X X
20 AT307888 REFRIGERANT HOSE 1 X X
21 AT307889 REFRIGERANT HOSE 1 X X
22 AT312058 VAPOR CONDENSER 1 X X
23 AT318798 REFRIGERANT HOSE 1 X X
24 H114865 CLAMP 2 X X
25 H77698 TIE BAND 1 X X
26 N275650 SCREW 2 X X
27 R10093 O-RING 4 X X
28 R33259 O-RING 3 X X
29 R53436 WASHER 1 X X
30 R56397 WASHER 3 X X
31 R98250 BOLT 1 X X
32 R99590 COVER 1 X X
33 RE505265 IDLER 1 X X
34 T138914 LABEL 1 X X
35 T143169 O-RING 1 X X
36 T162477 WASHER 3 X X
37 T164030 CLAMP 2 X X
38 T190513 CLAMP 2 X X
39 T204493 SUPPORT 1 X X
40 R113050 O-RING 2 X X
41 19H3208 CAP SCREW 2 X X 5/8" X 3"

770D/772D MOTOR GRADER PC9449 (20-APR-05) 1830-17

PN=463
 2K13 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HEATER AND AIR CONDITIONER LINES AND CONTROLS
T212743 -UN-15JUL05

THIS PARTS LISTING IS CONTINUED

1830-18 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=464
 2K14 OPERATOR’S STATION 18
HEATING AND AIR CONDITIONING 1830
HEATER AND AIR CONDITIONER LINES AND CONTROLS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7298 FLANGE NUT 1 X X M8

2 19M7774 SCREW 2 X X M6 X 12
3 19M8403 CAP SCREW 2 X X M8 X 75
4 19M9224 CAP SCREW 2 X X M4 X 14, (SUB FOR 21M7250)
5 24M7087 WASHER 2 X X 5.500 X 10 X 1 MM
6 24M7298 WASHER 4 X X 8.400 X 25 X 2 MM
7 37M7131 SCREW 1 X X M6 X 20
8 AL76568 KNOB 3 X X
9 AT303467 LINE 1 X X
10 AT303469 LINE 1 X X
11 AT303865 TOGGLE/ROCKER SWITCH 1 X X (A/C AND HEATER ON/OFF)
12 AT305547 AC COMPRESSOR WRG HARNESS 1 X X
13 AT306056 SWITCH 1 X X
14 AT310795 PUSH PULL CABLE 1 X X
15 AT310810 PUSH PULL CABLE 1 X X
16 .................. WEATHERSTRIP 4 X X (MAKE FROM T58056) (CUT TO LENGTH)
17 E46066 NUT 2 X X
18 R10093 O-RING 2 X X
19 R117721 CLAMP 2 X X
20 R125223 PLATE 1 X X
21 R192109 PUSH NUT 1 X X
22 R31654 CLAMP 1 X X
23 RE157329 SWITCH 1 X X
24 RE43497 ROTARY SWITCH 1 X X
25 RE46742 TEMPERATURE SWITCH 1 X X (A/C AND HEAT TEMPERATURE)
12H292 LOCK WASHER 1 X X 1/2"
14H934 NUT 1 X X 7/16"
26 RE46743 CONTROL 1 X X (FAN SPEED)
27 24H1646 WASHER 4 X X 17/64" X 3/4" X 0.060", (SUB FOR T134530)
28 21M7310 SCREW 4 X X M6 X 25
29 T143169 O-RING 1 X X
30 T160492 ELEC. CONNECTOR ACCESSORY 2 X X
31 T166297 GROMMET 1 X X
32 T184924 HOSE CLAMP 2 X X
33 T196079 NUT 2 X X
34 T202034 HOSE 1 X X
35 T202035 HOSE 1 X X
36 T202800 INSTRUMENT PANEL 1 X X
37 T204124 PAD 1 X X
38 T204274 ARM 1 X X
39 T205370 LABEL 1 X X
40 12H325 LOCK WASHER 2 X X (NO LONGER REQUIRED)
41 14H934 NUT 2 X X (NO LONGER REQUIRED)
42 L57881 CLIP 1 X X
43 24M7100 WASHER 3 X X 6.600 X 22 X 2 MM
44 37M7104 SCREW 3 X X M6 X 30
45 19M8553 SCREW 1 X X M6 X 16
46 R203687 NUT 2 X X
47 T202742 SEAL 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1830-19

PN=465
 2K16 SHEET METAL AND STYLING 19
HOOD OR ENGINE ENCLOSURE 1910
SERVICE DOORS
T210142 -UN-06APR05

THIS PARTS LISTING IS CONTINUED

1910-2 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=466
 2K17 SHEET METAL AND STYLING 19
HOOD OR ENGINE ENCLOSURE 1910
SERVICE DOORS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7517 LOCK NUT 2 X X M10

2 19M7167 CAP SCREW 2 X X M10 X 25
3 19M7784 SCREW 8 X X M10 X 20
4 19M7788 SCREW 6 X X M12 X 25
5 24H1330 WASHER 2 X X
6 24M7226 WASHER 6 X X
7 AT312053 ROD 2 X X
8 AT311438 KIT 1 X X (RIGHT BATTERY BOX COVER)
9 AT311431 KIT 1 X X (LEFT BATTERY BOX COVER)
10 AT228826 SHIELD 2 X X
11 AT311915 KIT 1 X X (LEFT ENGINE DOOR)
12 AT221696 LATCH 4 X X
13 H85233 RIVET 16 X X
14 AT311916 KIT 1 X X (RIGHT ENGINE DOOR)
15 AT306771 DOOR 1 X X (RIGHT RADIATOR COMPARTMENT DOOR)
16 AT306772 DOOR 1 X X (LEFT RADIATOR COMPARTMENT DOOR)
17 J16931 PIN 4 X X
18 R96753 SPACER 6 X X
19 T161531 MOLDING 2 X X
20 T162238 GROMMET 2 X X
21 T173591 BUMPER 2 X X
22 T188651 LATCH 2 X X
23 T21387 BUMPER 2 X X
24 T27260 WASHER 1 X X
25 T204009 SHEAR PIN 1 X X
26 N279068 COTTER PIN 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1910-3

PN=467
 2K18 SHEET METAL AND STYLING 19
HOOD OR ENGINE ENCLOSURE 1910
HOOD
T203940 -UN-18DEC04

THIS PARTS LISTING IS CONTINUED

1910-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=468
 2K19 SHEET METAL AND STYLING 19
HOOD OR ENGINE ENCLOSURE 1910
SERVICE DOORS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7273 NUT 4 X X M8
2 19M7572 CAP SCREW 2 X X M10 X 45
3 19M7784 SCREW 9 X X M10 X 20
6 19M7881 SCREW 4 X X M8 X 20
7 19M7938 CAP SCREW 6 X X M10 X 20
8 19M8035 CAP SCREW 4 X X M16 X 35
9 24H1653 WASHER 6 X X
10 24M7207 WASHER 8 X X
11 AT191541 ISOLATOR 1 X X
12 AT306539 HOOD 1 X X
13 AT316715 SUPPORT 1 X X
14 AT317581 HOOD 1 X X
15 AT38176 LOCK 1 X X
16 R117879 BUSHING 2 X X (SUB FOR (2) AT320236)
14M7296 FLANGE NUT 2 X X M10, (SUB FOR (2) AT320236)
17 T187863 COVER 1 X X
18 T208184 COVER 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1910-5

PN=469
 2K20 SHEET METAL AND STYLING 19
MISCELLANEOUS SHIELDS 1913
MAIN FRAME FRONT SIDE COVERS
T203248 -UN-28OCT04

THIS PARTS LISTING IS CONTINUED

1913-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=470
 2K21 SHEET METAL AND STYLING 19
MISCELLANEOUS SHIELDS 1913
MAIN FRAME FRONT SIDE COVERS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7938 CAP SCREW 2 X X M10 X 20

2 24H1308 WASHER 2 X X 13/32" X 1" X 0.134", (SUB FOR 24M7028,
THIS APPLICATION)
3 AT316321 COVER 1 X
4 AT316322 COVER 1 X
5 .................. CONDUIT 1 X X (MAKE FROM T157991) (CUT TO LENGTH)(NOT
ILLUSTRATED)
6 H77698 TIE BAND 3 X X
7 AT316323 COVER 1 X
8 AT316324 COVER 1 X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 1913-3

PN=471
 2K22 SHEET METAL AND STYLING 19
GRILLE AND GRILLE HOUSING 1921
GRILLE AND GRILLE HOUSING
T201156 -UN-05AUG04

THIS PARTS LISTING IS CONTINUED

1921-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=472
 2K23 SHEET METAL AND STYLING 19
GRILLE AND GRILLE HOUSING 1921
GRILLE AND GRILLE HOUSING

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7662 CAP SCREW 14 X X M10 X 30

2 19M8011 CAP SCREW 6 X X M12 X 30
3 19M8035 CAP SCREW 10 X X M16 X 35
4 24M7239 WASHER 14 X X
5 24M7240 WASHER 6 X X
6 24M7241 WASHER 10 X X
7 AT306536 FRAME 1 X X (GRILLE HOUSING)
8 AT306953 GRILLE 1 X X (LOWER)
9 AT306973 ANGLE 1 X X
11 AT306974 ANGLE 1 X X
12 AT307723 GRILLE 1 X X (UPPER)
13 AT309380 HINGE 1 X X (LEFT RADIATOR COMPARTMENT DOOR)
14 AT308110 GRILLE 1 X X (MIDDLE)
15 AT309379 HINGE 1 X X (RIGHT RADIATOR COMPARTMENT DOOR)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 1921-3

PN=473
 2L2 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
RADIO 2001
RADIO AND SPEAKERS
T201726 -UN-30JUL04

THIS PARTS LISTING IS CONTINUED

2001-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=474
 2L3 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
RADIO 2001
RADIO AND SPEAKERS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7296 FLANGE NUT 1 X X M10

2 14M7375 FLANGE NUT 1 X X M5
3 19M7805 SCREW 1 X X M10 X 45
4 24M7100 WASHER 1 X X
5 24M7296 WASHER 1 X X
6 H140461 BUSHING 1 X X
7 AT188759 SPEAKER 2 X X (5 1/4")
8 AT199388 ANTENNA 1 X X
9 AT302520 ANTENNA CABLE 1 X X
10 R28193 GROMMET 1 X X
11 R44302 TIE BAND 3 X X
12 RE227953 RADIO 1 X X (AM/FM WITH CD)
RE190139 RADIO 1 X X (AM/FM WITH WEATHERBAND)
RE190140 RADIO 1 X X (AM/FM WITH WEATHERBAND AND CASSETTE)
13 T185769 SCREW 4 X X
14 T187394 ANCHOR 4 X X
15 T203389 BRACKET 1 X X
16 T204635 BRACKET 1 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 2001-3

PN=475
 2L4 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
MIRROR 2002
INTERIOR REARVIEW MIRROR
T203162 -UN-01NOV04

THIS PARTS LISTING IS CONTINUED

2002-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=476
 2L5 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
MIRROR 2002
INTERIOR REARVIEW MIRROR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7298 FLANGE NUT 2 X X M8

2 19M7897 SCREW 2 X X M8 X 35
3 24M7239 WASHER 1 X X
4 24M7298 WASHER 2 X X
5 28H3450 SPACER 2 X X
6 AT157226 REAR VIEW MIRROR 1 X X
7 T11234 LOCK NUT 2 X X
8 T145360 PLATE 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2002-3

PN=477
 2L6 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
MIRROR 2002
EXTERIOR MIRROR
T208065 -UN-12FEB05

THIS PARTS LISTING IS CONTINUED

2002-4 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=478
 2L7 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
MIRROR 2002
EXTERIOR MIRROR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H732 NUT 1 X X
2 19H1726 CAP SCREW 1 X X 3/8" X 2-1/4"
3 24M7239 WASHER 1 X X
4 AT157226 REAR VIEW MIRROR 1 X X
5 T11234 LOCK NUT 2 X X 3/8"
6 T115030 HALF CLAMP 2 X X
7 T115031 RIB 1 X X
8 T119564 CLAMP 1 X X
9 T128437 CAP 1 X X
10 AT304638 REAR VIEW MIRROR 1 X X
11 R44302 TIE BAND AR X X
12 T185769 SCREW 2 X X
13 T187394 ANCHOR 2 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 2002-5

PN=479
 2L8 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
FIRE EXTINGUISHER 2003
FIRE EXTINGUISHER
T202720 -UN-03SEP04

THIS PARTS LISTING IS CONTINUED

2003-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=480
 2L9 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
FIRE EXTINGUISHER 2003
FIRE EXTINGUISHER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7863 SCREW 2 X X M6 X 25
2 AT189390 BRACKET 1 X X
3 AT189487 FIRE EXTINGUISHER 1 X X
4 T196078 NUT 2 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 2003-3

PN=481
 2L10 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
HORN AND WARNING DEVICES 2004
HORN

TP15206 -UN-01JAN94

THIS PARTS LISTING IS CONTINUED

2004-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=482
 2L11 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
HORN AND WARNING DEVICES 2004
HORN

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT226282 HORN 1 X X
2 19H2664 CAP SCREW 1 X X 5/16" X 3/4"
3 R46791 BRACKET 1 X X
4 14H785 NUT 1 X X 5/16"
5 19H2676 CAP SCREW 1 X X 3/8" X 1"
6 14H812 NUT 1 X X 3/8"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2004-3

PN=483
 2L12 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
HORN AND WARNING DEVICES 2004
BACK-UP ALARM
T202061 -UN-05AUG04

THIS PARTS LISTING IS CONTINUED

2004-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=484
 2L13 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
HORN AND WARNING DEVICES 2004
BACK-UP ALARM

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7402 CAP SCREW 2 X X M10 X 25

2 19M7932 CAP SCREW 2 X X M8 X 16
3 24H1822 WASHER 2 X X
4 24M7239 WASHER 2 X X
5 AT120461 TRAVEL WARNING ALARM 1 X X
6 AT307351 BRACKET 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2004-5

PN=485
 2L14 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
TOOLBOX 2005
TOOLBOX

T200761 -UN-09JUN04

THIS PARTS LISTING IS CONTINUED

2005-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=486
 2L15 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
TOOLBOX 2005
TOOLBOX

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 99M7039 HOOK 1 X X
2 AT22070 TOOLBOX 1 X X
3 AT22073 HOLDER 1 X X
4 T23027 PIN 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2005-3

PN=487
 2L16 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
SUNVISOR 2007
REAR WINDOW SUNVISOR
T203172 -UN-01NOV04

THIS PARTS LISTING IS CONTINUED

2007-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=488
 2L17 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
SUNVISOR 2007
REAR WINDOW SUNVISOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7862 SCREW 2 X X M6 X 20
2 AT305193 SHADE CURTAIN 1 X X
3 .................. WEATHERSTRIP 1 X X (MAKE FROM T63019) (CUT TO LENGTH)
4 24H1821 WASHER 2 X X
5 21M7403 SCREW 2 X X M6 X 40
6 T196077 NUT 4 X X
7 T204938 BRACKET 1 X X (ALSO ORDER (2) T196077)
8 T205088 BRACKET 1 X X (ALSO ORDER (2) T196077)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2007-3

PN=489
 2L18 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
SUNVISOR 2007
FRONT WINDOW SUNVISOR
T205801 -UN-12DEC04

THIS PARTS LISTING IS CONTINUED

2007-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=490
 2L19 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
SUNVISOR 2007
FRONT WINDOW SUNVISOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7303 FLANGE NUT 3 X X M6

2 AT306350 SUN VISOR 1 X X
3 24H1821 WASHER 3 X X
4 21M7403 SCREW 3 X X M6 X 40

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2007-5

PN=491
 2L20 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
SMV SIGN 2008
SMV SIGN
T202479 -UN-18DEC04

THIS PARTS LISTING IS CONTINUED

2008-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=492
 2L21 SAFETY, CONVENIENCE AND MISCELLANEOUS 20
SMV SIGN 2008
SMV SIGN

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT315341 KIT 1 X X (WHOLEGOODS) (SMV SIGN KIT)

2 19M7932 CAP SCREW 2 X X M8 X 16
3 21M7344 SCREW 2 X X M6 X 25
4 24M7100 WASHER 2 X X
5 24M7238 WASHER 2 X X
6 AT315334 BRACKET 1 X X
9 JD5929 SMV EMBLEM 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2008-3

PN=493
 3B4 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN HYDRAULIC PUMP
T201567 -UN-10DEC04

THIS PARTS LISTING IS CONTINUED

2160-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=494
 3B5 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN HYDRAULIC PUMP

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7496 CAP SCREW 4 X X M12 X 45

2 T29342 WASHER 4 X X
3 .................. O-RING 1 X (USED WITH AUXILIARY DRIVE)
4 19M8440 SCREW 4 X M10 X 25, (USED WITH AUXILIARY DRIVE)
5 .................. PLATE 1 X ADAPTER (USED WITH AUXILIARY DRIVE)
6 T188690 HYDR.QUICK COUPLER SOCKET 1 X (USED WITH AUXILIARY DRIVE)
7 T176425 PLUG 3 X X
8 .................. SCREW 4 X (USED WITH AUXILIARY DRIVE)
9 AT305110 SEAL KIT 1 X X
10 T54904 FITTING PLUG 2 X X
11 N203952 O-RING 1 X X
12 AT191366 BEARING KIT 1 X X
13 T188686 PLATE 1 X X
14 AT196346 KIT 1 X X (CONTAINS PUMP PISTONS AND HOUSING)
15 T185138 DRIVE SHAFT 1 X (USED WITH AUXILIARY DRIVE)
T188698 SHAFT 1 X (USED WITHOUT AUXILIARY DRIVE)
16 AT280244 MOUNTING PARTS 1 X X SWASHPLATE ASSEMBLY, (SUB FOR AT197420)
17 AT191367 BEARING KIT 1 X X
18 AT191369 PISTON REPLACEMENT KIT 1 X X
19 AT191368 BEARING 2 X X SWASHPLATE
20 .................. PLUG 1 X X (SUB AT305110)
21 F37020159 O-RING 1 X X
22 R28782 O-RING 6 X X
23 4001456 SLEEVE 1 X X
24 T185183 SEAL 1 X X
25 T185254 SNAP RING 1 X X
26 F39000106 SNAP RING 1 X X
30 T24212 O-RING 1 X X
40 T185185 BACK-UP RING 1 X X
41 T76938 O-RING 1 X X
42 T24212 O-RING 1 X X
48 AT199076 KIT 1 X X CONTROL
49 T188687 SCREW 1 X X
52 T190243 SPOOL 1 X X CONTROL
53 .................. O-RING 1 X X
54 T185181 RING 4 X X
55 T185186 SCREW 4 X X
57 T185184 RING 2 X X
58 T54904 FITTING PLUG 2 X X
59 M45387 O-RING 2 X X
60 M74877 PLUG 2 X X
61 T185135 SPRING 1 X X
62 T42302 O-RING 1 X (WITH AUXILIARY DRIVE)
63 E65288 O-RING 1 X (WITH AUXILIARY DRIVE)
70 AT302661 HYDRAULIC PUMP 1 X (MAIN HYDRAULIC PUMP) (WITH AUXILIARY
DRIVE)
AT302662 HYDRAULIC PUMP 1 X (MAIN HYDRAULIC PUMP) (WITHOUT AUXILIARY
DRIVE)
71 AT191371 SEAL KIT 1 X X PUMP OVERHAUL

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-3

PN=495
 3B6 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN MANIFOLD VALVE MOUNTING BRACKET
T202314 -UN-02SEP04

THIS PARTS LISTING IS CONTINUED

2160-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=496
 3B7 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN MANIFOLD VALVE MOUNTING BRACKET

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7402 CAP SCREW 5 X X M10 X 25

2 24M7239 WASHER 5 X X
3 T205720 PLATE 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-5

PN=497
 3B8 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN HYDRAULIC MANIFOLD VALVE
T202315 -UN-01SEP04

THIS PARTS LISTING IS CONTINUED

2160-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=498
 3B9 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN HYDRAULIC MANIFOLD VALVE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT307811 VALVE 1 X X (SADDLE LOCK PIN PRESSURE REDUCING VALVE)

2 AT196943 SEAL KIT 1 X X
3 AT302907 PRESSURE RELIEF VALVE 1 X X (SYSTEM RELIEF VALVE)
4 AT224864 SEAL KIT 1 X X
5 AT302908 SOLENOID VALVE 1 X X
6 AH209121 SEAL KIT 1 X X
7 AT224574 SOLENOID VALVE COIL 1 X X (SADDLE LOCK PIN SOLENOID)
8 N223292 NUT 1 X X
9 AT302150 MANIFOLD 1 X X (MAIN MANIFOLD VALVE)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-7

PN=499
 3B10 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN HYDRAULIC CONTROL VALVE (RIGHT AND LEFT COMPLETE)
T204802 -UN-09NOV04

THIS PARTS LISTING IS CONTINUED

2160-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=500
 3B11 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN HYDRAULIC CONTROL VALVE (RIGHT AND LEFT COMPLETE)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT302284 CONTROL VALVE 1 X X (LEFT 4 FUNCTION)(COMPONENTS ON SEPARATE

PAGES)
2 AT302283 CONTROL VALVE 1 X X (RIGHT 4 FUNCTION)(COMPONENTS ON SEPARATE
PAGES)
3 AT302286 CONTROL VALVE 1 X X (LEFT 5 FUNCTION)(COMPONENTS ON SEPARATE
PAGES)
4 AT302285 CONTROL VALVE 1 X X (RIGHT 5 FUNCTION)(COMPONENTS ON SEPARATE
PAGES)
5 AT309235 CONTROL VALVE 1 X X (LEFT 6 FUNCTION)(COMPONENTS ON SEPARATE
PAGES)
6 AT309234 CONTROL VALVE 1 X X (RIGHT 6 FUNCTION)(COMPONENTS ON SEPARATE
PAGES)
7 AT302288 CONTROL VALVE 1 X X (LEFT 7 FUNCTION)(COMPONENTS ON SEPARATE
PAGES)
8 AT302287 CONTROL VALVE 1 X X (RIGHT 7 FUNCTION)(COMPONENTS ON SEPARATE
PAGES)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-11

PN=501
 3B12 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN HYDRAULIC CONTROL VALVE TIE RODS
T204807 -UN-16NOV04

THIS PARTS LISTING IS CONTINUED

2160-12 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=502
 3B13 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN HYDRAULIC CONTROL VALVE TIE RODS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3920 SCREW 2 X X 5/16" X 1-1/4", (4 FUNCTION)

2 19H3921 SCREW 1 X X 3/8" X 1-1/4", (4 FUNCTION)
3 T213026 STUD 2 X X
4 T213029 STUD 1 X X
5 T213030 STUD 1 X X (5 FUNCTION)
T76128 STUD 1 X X (6 FUNCTION)
T213031 STUD 1 X X (7 FUNCTION)
6 T213027 STUD 2 X X (5 FUNCTION)
T76127 STUD 2 X X (6 FUNCTION)
T213028 STUD 2 X X (7 FUNCTION)
7 14H1080 NUT 1 X X 3/8", (4 FUNCTION)
14H1080 NUT 2 X X 3/8", (5,6,7 FUNCTION)
8 14H1042 NUT 2 X X 5/16", (4 FUNCTION)
14H1042 NUT 4 X X 5/16", (5,6,7 FUNCTION)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-13

PN=503
 3B14 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
BLADE TILT, ARTICULATION, CIRCLE SIDE SHIFT AND WHEEL LEAN VALVE SECTIONS
T203404 -UN-09NOV04

THIS PARTS LISTING IS CONTINUED

2160-18 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=504
 3B15 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
BLADE TILT, ARTICULATION, CIRCLE SIDE SHIFT AND WHEEL LEAN VALVE SECTIONS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2924 SCREW 2 X X 1/4" X 3/4"

2 AT317328 CHECK VALVE 2 X X
3 R111238 SPRING 1 X X
4 R76578 O-RING 3 X X
5 R95493 DISK 1 X X
6 T118712 SCREW 2 X X
7 T190767 SPRING 1 X X
8 T213022 O-RING 2 X X
9 T213023 O-RING 2 X X
10 T213025 O-RING 1 X X
11 T213031 STUD 2 X X
12 T213033 HOUSING 1 X X
13 AT317305 ACTUATOR 1 X X (USE WITH BLADE TILT VALVE SECTION)
AT317304 ACTUATOR 1 X X (USE WITH ARTICULATION, CIRCLE SIDE
SHIFT, AND WHEEL LEAN VALVE SECTIONS)
14 AT317315 CONTROL VALVE 1 X X (BLADE TILT VALVE SECTION)
AT317316 CONTROL VALVE 1 X X (ARTICULATION VALVE SECTION)
AT317317 CONTROL VALVE 1 X X (CIRCLE SIDE SHIFT VALVE SECTION)
AT317318 CONTROL VALVE 1 X X (WHEEL LEAN VALVE SECTION)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-19

PN=505
 3B16 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
CIRCLE ROTATE VALVE SECTION
T203405 -UN-09NOV04

THIS PARTS LISTING IS CONTINUED

2160-20 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=506
 3B17 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
CIRCLE ROTATE VALVE SECTION

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2924 SCREW 2 X X 1/4" X 3/4"

2 AT317820 FITTING 2 X X
3 R26906 O-RING 1 X X
4 R111238 SPRING 1 X X
5 R76578 O-RING 3 X X
6 R95493 DISK 1 X X
7 T118712 SCREW 2 X X
8 T190767 SPRING 1 X X
9 T213022 O-RING 2 X X
10 T213023 O-RING 2 X X
11 T213025 O-RING 1 X X
12 T213031 STUD 2 X X
13 T213033 HOUSING 1 X X
14 AT317305 ACTUATOR 1 X X
15 AT317314 CONTROL VALVE 1 X X (CIRCLE ROTATE VALVE SECTION)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-21

PN=507
 3B18 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
BLADE SIDE SHIFT VALVE SECTION
T203406 -UN-09NOV04

THIS PARTS LISTING IS CONTINUED

2160-22 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=508
 3B19 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
BLADE SIDE SHIFT VALVE SECTION

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2924 SCREW 2 X X 1/4" X 3/4"

2 AT317328 CHECK VALVE 2 X X
3 R111238 SPRING 1 X X
4 R76578 O-RING 3 X X
5 R95493 DISK 1 X X
6 T118712 SCREW 2 X X
7 T190767 SPRING 1 X X
8 T213022 O-RING 2 X X
9 T213023 O-RING 2 X X
10 T213025 O-RING 1 X X
11 T213031 STUD 2 X X
12 T213033 HOUSING 2 X X
13 AT317305 ACTUATOR 1 X X
14 AT317313 CONTROL VALVE 1 X X (BLADE SIDE SHIFT VALVE SECTION)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-23

PN=509
 3B20 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
BLADE LIFT VALVE SECTION
T203541 -UN-09NOV04

THIS PARTS LISTING IS CONTINUED

2160-24 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=510
 3B21 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
BLADE LIFT VALVE SECTION

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2924 SCREW 2 X X 1/4" X 3/4"

2 AT301226 PRESSURE RELIEF VALVE 1 X X
3 AT301227 SEAL KIT 1 X X
4 AT317328 CHECK VALVE 2 X X
5 AT317822 DETENT 1 X X
6 R111238 SPRING 1 X X
7 R76578 O-RING 3 X X
8 R95493 DISK 1 X X
9 T190767 SPRING 1 X X
10 T213022 O-RING 3 X X
11 T213023 O-RING 2 X X
12 T213025 O-RING 1 X X
13 T213031 STUD 2 X X
14 T213033 HOUSING 1 X X
15 T213318 HOUSING 1 X X
16 AT317305 ACTUATOR 1 X X (LEFT)
AT317304 ACTUATOR 1 X X (RIGHT)
17 R47150 O-RING 1 X X
18 T183756 SEAL 1 X X
19 R63548 O-RING 1 X X
20 .................. O-RING 1 X X
21 .................. SPRING 1 X X
22 AT317308 CONTROL VALVE 1 X X (LEFT BLADE LIFT VALVE SECTION)
AT317309 CONTROL VALVE 1 X X (RIGHT BLADE LIFT VALVE SECTION)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-25

PN=511
 3B22 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
RIGHT MAIN HYDRAULIC CONTROL VALVE INLET AND OUTLET SECTIONS
T203556 -UN-16NOV04

THIS PARTS LISTING IS CONTINUED

2160-26 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=512
 3B23 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
RIGHT MAIN HYDRAULIC CONTROL VALVE INLET AND OUTLET SECTIONS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT317306 HOUSING 1 X X
2 R76578 O-RING 4 X X
3 T213025 O-RING 2 X X
4 RE49624 PLUG 4 X X
5 T213032 COMPRESSION SPRING 1 X X
6 R95493 DISK 2 X X
7 AT317329 HOUSING 1 X X
8 AT317331 HOUSING 1 X X
9 38H1160 ADAPTER 3 X X
10 T77613 O-RING 3 X X
11 R26448 O-RING 3 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-27

PN=513
 3B24 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
LEFT MAIN HYDRAULIC CONTROL VALVE INLET AND OUTLET SECTIONS
T203544 -UN-08DEC04

THIS PARTS LISTING IS CONTINUED

2160-28 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=514
 3B25 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
LEFT MAIN HYDRAULIC CONTROL VALVE INLET AND OUTLET SECTIONS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT317323 PRESSURE RELIEF VALVE 1 X X

2 T150961 O-RING 2 X X
3 T183756 SEAL 1 X X
4 R76578 O-RING 4 X X
5 R95493 DISK 2 X X
6 T213025 O-RING 1 X X
7 AT317330 HOUSING 1 X X
8 AT317331 HOUSING 1 X X
9 T77613 O-RING 3 X X
10 38H1160 ADAPTER 3 X X
11 R26448 O-RING 3 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-29

PN=515
 3C1 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
RIPPER VALVE SECTION
T210408 -UN-15APR05

THIS PARTS LISTING IS CONTINUED

2160-30 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=516
 3C2 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
RIPPER VALVE SECTION

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2924 SCREW 2 X X 1/4" X 3/4"

2 AT317328 CHECK VALVE 2 X X
3 AT317822 DETENT 1 X X
4 AT78527 PLUG 2 X X
5 T183756 SEAL 1 X X
6 R111238 SPRING 1 X X
7 R76578 O-RING 3 X X
8 R95493 DISK 1 X X
9 T190767 SPRING 1 X X
10 T213022 O-RING 3 X X
11 T213023 O-RING 2 X X
12 T213025 O-RING 1 X X
13 T213031 STUD 2 X X
14 T213033 HOUSING 1 X X
15 T213318 HOUSING 1 X X
16 AT317304 ACTUATOR 1 X X
17 T118712 SCREW 2 X X
18 AT317321 CONTROL VALVE 1 X X (RIPPER VALVE SECTION)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-31

PN=517
 3C3 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
SCARIFIER AND AUXILIARY VALVE SECTION (WITH FLOAT)
T210407 -UN-15APR05

THIS PARTS LISTING IS CONTINUED

2160-32 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=518
 3C4 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
SCARIFIER AND AUXILIARY VALVE SECTION (WITH FLOAT)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2924 SCREW 2 X X 1/4" X 3/4"

2 AT317328 CHECK VALVE 2 X X
3 AT317822 DETENT 1 X X
4 AT78527 PLUG 2 X X
5 T183756 SEAL 1 X X
6 R111238 SPRING 1 X X
7 R76578 O-RING 3 X X
8 R95493 DISK 1 X X
9 RE49624 PLUG 2 X X
10 R26375 O-RING 1 X X
11 R39112 FITTING 2 X X
12 T190767 SPRING 1 X X
13 T213022 O-RING 3 X X
14 T213023 O-RING 1 X X
15 T213025 O-RING 1 X X
16 T213031 STUD 1 X X
17 T213033 HOUSING 1 X X
18 T213318 HOUSING 1 X X
19 AT317304 KIT 1 X X (USE WITH LEFT AUXILIARY VALVE SECTION)
AT317305 KIT 1 X X (USE WITH SCARIFIER AND RIGHT AUX.
SECTION)
20 AT317322 CONTROL VALVE 1 X X (LEFT AUXILIARY VALVE SECTION WITH FLOAT)
AT317319 CONTROL VALVE 1 X X (SCARIFIER VALVE SECTION)
21 AT319023 CONTROL VALVE 1 X X (RIGHT AUXILIARY SECTION WITH FLOAT)

770D/772D MOTOR GRADER PC9449 (20-APR-05) 2160-33

PN=519
 3C5 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
AUXILIARY VALVE SECTION (WITHOUT FLOAT)
T210409 -UN-15APR05

THIS PARTS LISTING IS CONTINUED

2160-34 770D/772D MOTOR GRADER PC9449 (20-APR-05)
PN=520
 3C6 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
AUXILIARY VALVE SECTION (WITHOUT FLOAT)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H2924 SCREW 2 X X 1/4" X 3/4"

2 AT317328 CHECK VALVE 2 X X
3 AT78527 PLUG 2 X X
4 T183756 SEAL 1 X X
5 R111238 SPRING 1 X X
6 R76578 O-RING 3 X X
7 R95493 DISK 1 X X
8 RE49624 PLUG 2 X X
9 R26375 O-RING 1 X X
10 R39112 FITTING 1 X X
11 T118712 SCREW 2 X X
12 T190767 SPRING 1 X X
13 T213022 O-RING 3 X X
14 T213023 O-RING 1 X X
15 T213025 O-RING 1 X X
16 T213031 STUD 1 X X
17 T213033 HOUSING 1 X X
18 AT317304 ACTUATOR 1 X X
19 AT317310 CONTROL VALVE 1 X X (LEFT AUXILIARY VALVE SECTION WITHOUT
FLOAT)
AT317312 CONTROL VALVE 1 X X (RIGHT AUXILIARY VALVE SECTION WITHOUT
FLOAT)

770D/772D MOTOR GRADER PC9449 (20-APR-05) 2160-35

PN=521
 3C7 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
ADDITIONAL HYDRAULIC CONTROL VALVE KIT
T204997 -UN-18NOV04

THIS PARTS LISTING IS CONTINUED

2160-36 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=522
 3C8 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
ADDITIONAL HYDRAULIC CONTROL VALVE KIT

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT317287 KIT 1 X X (RIGHT 5TH FUNCTION CONTROL VALVE KIT)

AT317288 KIT 1 X X (LEFT 5TH FUNCTION CONTROL VALVE KIT)
AT317289 KIT 1 X X (RIGHT 6TH FUNCTION CONTROL VALVE KIT)
AT317290 KIT 1 X X (LEFT 6TH FUNCTION CONTROL VALVE KIT)
AT317291 KIT 1 X X (RIGHT 7TH FUNCTION CONTROL VALVE KIT)
AT317293 KIT 1 X X (LEFT 7TH FUNCTION CONTROL VALVE KIT)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-37

PN=523
 3C9 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
ONE HAND BLADE LIFT CONTROL
T211056 -UN-16MAY05

THIS PARTS LISTING IS CONTINUED

2160-38 770D/772D MOTOR GRADER PC9449 (09-JUN-05)
PN=524
 3C10 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
ONE HAND BLADE LIFT CONTROL

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H1042 NUT 2 X X
2 14H1080 NUT 1 X X
3 14H882 NUT 2 X X
4 19H2127 CAP SCREW 2 X X
5 19M7801 SCREW 1 X X M8 X 60
6 24H1296 WASHER 4 X X
8 T213242 SET SCREW 1 X X
9 AT317742 KNOB 1 X X
10 T213030 STUD 1 X X
11 AT317778 LINK END 2 X X
12 T104220 WASHER 2 X X
13 T202162 CONTROL LEVER 1 X X
14 T202586 LEVER 1 X X
15 T204457 SPACER 1 X X
16 AT319023 CONTROL VALVE 1 X X
17 T213027 STUD 2 X X
18 AT302544 KIT 1 X X (WHOLEGOODS) (ONE HAND BLADE LIFT CONTROL
LEVER KIT)
19 AT317339 KIT 1 X X (WHOLEGOODS) (ONE HAND BLADE LIFT CONTROL
LEVER AND VALVE KIT)
20 AT322617 HYDRAULIC HOSE - FABRICATE 4 X X (NOT ILLUSTRATED)
21 R26375 O-RING 2 X X
22 R39112 FITTING 2 X X
23 AT78527 PLUG 2 X X
24 T183756 SEAL 2 X X

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 2160-39

PN=525
 3C11 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
COLD START DISCONNECT HOSES AND FITTINGS
T205433 -UN-29NOV04

THIS PARTS LISTING IS CONTINUED

2160-40 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=526
 3C12 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
COLD START DISCONNECT HOSES AND FITTINGS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT195917 HYDRAULIC HOSE - FABRICATE 1 X X

2 T77613 O-RING 4 X X
3 38H1023 TEE FITTING 1 X X
4 R26448 O-RING 2 X X
5 38H1480 REDUCER 1 X X
6 T77814 O-RING 1 X X
7 RE60700 DIAGNOSTIC COUPLING 1 X X DIAGNOSTIC
8 R77175 COVER 1 X X
9 38H1004 ELBOW FITTING 1 X X
10 AT195918 HYDRAULIC HOSE - FABRICATE 1 X X
12 24M7139 WASHER 2 X X
13 19M8786 SCREW 2 X X M6 X 70
14 38H1309 ADAPTER 1 X X
15 R28782 O-RING 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-41

PN=527
 3C13 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
COLD START DISCONNECT SOLENOID VALVE
T205434 -UN-29NOV04

THIS PARTS LISTING IS CONTINUED

2160-42 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=528
 3C14 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
COLD START DISCONNECT SOLENOID VALVE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT195900 SOLENOID VALVE 1 X X

2 AT147011 SOLENOID 1 X X
3 R109691 NUT 1 X X
4 AT216348 SEAL KIT 1 X X
5 AT195860 ELEC.PROPORTIONAL VALVE 1 X X (COLD START DISCONNECT SOLENOID VALVE)
6 AT195898 MOUNTING PARTS 1 X X
7 AT139434 KIT 1 X X
8 T188288 HOUSING 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-43

PN=529
 3C15 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN CONTROL VALVE MOUNTING BRACKETS
T203168 -UN-01NOV04

THIS PARTS LISTING IS CONTINUED

2160-44 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=530
 3C16 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC SYSTEM 2160
MAIN CONTROL VALVE MOUNTING BRACKETS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7785 SCREW 6 X X M10 X 25

2 19M7800 SCREW 6 X X M8 X 50
3 24M7024 WASHER 12 X X
4 AT303129 BRACKET 1 X X
5 AT303678 BRACKET 1 X X
6 T196080 NUT 6 X X
7 U42208 ISOLATOR 6 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2160-45

PN=531
 3C17 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
HYDRAULIC LOAD SENSE HOSES
T208053 -UN-12FEB05

THIS PARTS LISTING IS CONTINUED

2163-2 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=532
 3C18 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
HYDRAULIC LOAD SENSE HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7932 CAP SCREW 1 X X M8 X 16

2 19M7938 CAP SCREW 4 X X M10 X 20
3 24M7239 WASHER 5 X X
4 38H1434 TEE FITTING 1 X X
5 R28782 O-RING 1 X X
6 T77613 O-RING 2 X X
9 AH97280 CLIP 4 X X
10 AT305628 HYDRAULIC HOSE - FABRICATE 2 X X
11 AT305630 HYDRAULIC HOSE - FABRICATE 1 X X
12 AT305738 HYDRAULIC HOSE - FABRICATE 1 X X
13 R77175 COVER 1 X X
14 RE60701 DIAGNOSTIC COUPLING 1 X X
15 T76719 CLAMP 3 X X

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 2163-3

PN=533
 3C19 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
HYDRAULIC OIL COOLER HOSES (772D)
T213394 -UN-25AUG05

THIS PARTS LISTING IS CONTINUED

2163-4 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=534
 3C20 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
HYDRAULIC OIL COOLER HOSES (772D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

2 U12547 O-RING 3 X
U12547 O-RING 5 X
3 38H1033 TEE FITTING 1 X
4 T77858 O-RING 6 X
5 38H1048 ELBOW FITTING 1 X
6 AT307263 HYDRAULIC HOSE - FABRICATE 2 X
7 38H1163 ADAPTER 2 X
8 38H1609 ADAPTER 1 X
9 AT175957 PRESSURE RELIEF VALVE 1 X
10 AT307220 HYDRAULIC HOSE - FABRICATE 1 X
11 AT307231 HYDRAULIC HOSE - FABRICATE 1 X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 2163-5

PN=535
 3C21 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
HYDRAULIC OIL COOLER HOSES (770D) (SN 599561- )
T213388 -UN-25AUG05

THIS PARTS LISTING IS CONTINUED

2163-5A 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=536
 3C22 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
HYDRAULIC OIL COOLER HOSES (770D) (SN 599561- )

6 6
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1014 ELBOW FITTING 1 X

2 U12547 O-RING 4 X
3 38H1033 TEE FITTING 1 X
4 T77858 O-RING 7 X
5 38H1048 ELBOW FITTING 1 X
6 AT326525 HYDRAULIC HOSE - FABRICATE 1 X
7 38H1163 ADAPTER 2 X
8 38H1609 ADAPTER 1 X
9 AT175957 PRESSURE RELIEF VALVE 1 X
10 AT307220 HYDRAULIC HOSE - FABRICATE 1 X
11 AT307231 HYDRAULIC HOSE - FABRICATE 1 X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 2163-5B

PN=537
 3C23 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
MAIN HYDRAULIC PLUMBING (770D)
T213419 -UN-24AUG05

THIS PARTS LISTING IS CONTINUED

2163-6 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=538
 3C24 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
MAIN HYDRAULIC PLUMBING (770D)

6 6
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 12H301 LOCK WASHER 4 X

2 12H304 LOCK WASHER 4 X 9.525 MM
3 19H2993 CAP SCREW 4 X
4 19H3239 CAP SCREW 4 X
5 38H1006 ELBOW FITTING 1 -599560 X
6 38H1007 ELBOW FITTING 1 X
7 38H1047 ELBOW FITTING 1 X
8 38H1048 ELBOW FITTING 1 X
9 38H1052 ELBOW FITTING 1 X
10 38H1093 ELBOW FITTING 1 X
11 38H1159 ADAPTER 1 X
12 38H1162 ADAPTER 2 X
13 38H1163 ADAPTER 5 X
14 38H1194 ADAPTER 1 X
15 38H1215 ADAPTER 1 X
16 38H1329 ADAPTER 2 X
17 38H1447 ADAPTER 1 -599560 X
18 38H1609 ADAPTER 1 X
19 H61354 FLANGE FITTING 2 X
20 R26906 O-RING 6 X
21 R28782 O-RING 1 X
22 R37023 FLANGE FITTING 2 X
23 T77814 O-RING 2 X
24 T77858 O-RING 11 X
25 T77932 O-RING 7 X
26 T78313 O-RING 1 X
27 U12547 O-RING 13 X
28 U46457 O-RING 1 X
29 14M7296 FLANGE NUT 2 X M10
30 19M7938 CAP SCREW 1 X M10 X 20
31 19M8002 CAP SCREW 1 X M20 X 55
32 R29936 O-RING 4 -599560 X
R29936 O-RING 5 599561-
33 19M8637 CAP SCREW 2 X M10 X 40
34 24M7239 WASHER 1 X
35 24M7240 WASHER 2 X
36 24M7242 WASHER 1 X
37 24M7296 WASHER 2 X
38 AH64349 HOSE FITTING 1 X
39 AT300859 ATTENUATOR 1 X
40 AT304144 HYDRAULIC HOSE - FABRICATE 1 X
41 AT304147 HYDRAULIC HOSE - FABRICATE 1 X
42 AT304888 HYDRAULIC HOSE - FABRICATE 1 X
43 AT305277 HYDRAULIC HOSE - FABRICATE 1 X
44 AT305916 HYDRAULIC HOSE - FABRICATE 1 X
45 AT307299 HYDRAULIC HOSE - FABRICATE 1 X
46 AT307300 HYDRAULIC HOSE - FABRICATE 1 X
47 AT308909 HYDRAULIC HOSE - FABRICATE 1 -599560 X
48 AT309711 HOSE SUPPORT 2 X
49 AT311425 HYDRAULIC HOSE 1 X
50 AT37477 HOSE CLAMP 1 X
51 RE52702 CLAMP 1 X
52 .................. BULK HOSE 1 X (MAKE FROM T78497) (CUT TO LENGTH)
53 R27175 DRAIN PLUG 3 X
54 R27474 DRAIN PLUG 1 X
55 R36636 FITTING PLUG 1 -599560 X
R36636 FITTING PLUG 2 599561- X
56 R77175 COVER 1 X
57 RE60700 DIAGNOSTIC COUPLING 1 X
58 T158298 LINE 1 X
59 AH77714 CLIP 1 X
60 T164030 CLAMP 2 X
61 T185826 CLAMP 2 X
62 T187526 SUCTION HOSE 1 X
63 T190892 HOSE FITTING 1 X
64 H134114 SPACER 1 X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 2163-7

PN=539
 3D1 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
MAIN HYDRAULIC PLUMBING (772D)
T203903 -UN-03DEC04

THIS PARTS LISTING IS CONTINUED

2163-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=540
 3D2 MAIN HYDRAULIC SYSTEM 21
HYDRAULIC LINES AND HOSES 2163
MAIN HYDRAULIC PLUMBING (772D)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 12H301 LOCK WASHER 4 X

2 12H304 LOCK WASHER 4 X
3 19H2993 CAP SCREW 4 X
4 19H3239 CAP SCREW 4 X
5 38H1006 ELBOW FITTING 1 X
6 38H1007 ELBOW FITTING 1 X
7 38H1047 ELBOW FITTING 1 X
8 38H1048 ELBOW FITTING 1 X
10 38H1093 ELBOW FITTING 1 X
11 38H1159 ADAPTER 1 X
12 38H1162 ADAPTER 2 X
13 38H1163 ADAPTER 5 X
15 38H1215 ADAPTER 1 X
16 38H1329 ADAPTER 2 X
17 38H1447 ADAPTER 1 X
18 38H1609 ADAPTER 1 X
19 H61354 FLANGE FITTING 2 X
20 R26906 O-RING 6 X
21 R28782 O-RING 1 X
22 R37023 FLANGE FITTING 2 X
23 T77814 O-RING 2 X
24 T77858 O-RING 9 X
25 T77932 O-RING 7 X
26 T78313 O-RING 1 X
27 U12547 O-RING 11 X
28 U46457 O-RING 1 X
29 14M7296 FLANGE NUT 2 X M10
31 19M8002 CAP SCREW 1 X M20 X 55
32 R29936 O-RING 1 X
33 19M8637 CAP SCREW 2 X M10 X 40
35 24M7240 WASHER 2 X 13 X 25 X 3 MM
36 24M7242 WASHER 1 X 21.400 X 42 X 5 MM
37 24M7296 WASHER 2 X 10.500 X 30 X 2.500 MM
38 AH64349 HOSE FITTING 1 X
39 AT300859 ATTENUATOR 1 X
40 AT304144 HYDRAULIC HOSE - FABRICATE 1 X
41 AT304147 HYDRAULIC HOSE - FABRICATE 1 X
42 AT304888 HYDRAULIC HOSE - FABRICATE 1 X
43 AT304967 HYDRAULIC HOSE - FABRICATE 1 X
45 AT307299 HYDRAULIC HOSE - FABRICATE 1 X
46 AT307300 HYDRAULIC HOSE - FABRICATE 1 X
47 AT308909 HYDRAULIC HOSE - FABRICATE 1 X
48 AT309711 HOSE SUPPORT 2 X
49 AT311425 HYDRAULIC HOSE 1 X
50 AT37477 HOSE CLAMP 1 X
51 AT56659 HOSE CLAMP 1 X
52 .................. BULK HOSE 1 X (MAKE FROM T78497) (CUT TO LENGTH)
54 R27474 DRAIN PLUG 1 X
56 R77175 COVER 1 X
57 RE60700 DIAGNOSTIC COUPLING 1 X
58 T158298 LINE 1 X
60 T164030 CLAMP 2 X
61 T185826 CLAMP 2 X
62 T187526 SUCTION HOSE 1 X
63 T190892 HOSE FITTING 1 X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 2163-9

PN=541
 3D3 MAIN HYDRAULIC SYSTEM 21
HYD RESERVOIR, FILTER AND COOLER
MAIN HYDRAULIC FILTER
T212747 -UN-15JUL05

THIS PARTS LISTING IS CONTINUED

2164-2 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=542
 3D4 MAIN HYDRAULIC SYSTEM 21
HYD RESERVOIR, FILTER AND COOLER
MAIN HYDRAULIC FILTER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7402 CAP SCREW 4 X X M10 X 25

2 24M7239 WASHER 1 X X
4 AT302906 FILTER HEAD 1 X X
5 AT307045 PRESSURE SWITCH 1 X X (MAIN HYDRAULIC FILTER RESTRICTION)
6 P46051 O-RING 1 X X
7 AT308274 OIL FILTER 1 X X (MAIN HYDRAULIC FILTER)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 2164-3

PN=543
 3D5 MAIN HYDRAULIC SYSTEM 21
HYD RESERVOIR, FILTER AND COOLER
HYDRAULIC RESERVOIR
T209696 -UN-21MAR05

THIS PARTS LISTING IS CONTINUED

2164-4 770D/772D MOTOR GRADER PC9449 (30-MAR-05)
PN=544
 3D6 MAIN HYDRAULIC SYSTEM 21
HYD RESERVOIR, FILTER AND COOLER
HYDRAULIC RESERVOIR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT305981 HYDRAULIC RESERVOIR 1 X X

2 AT161638 STRAINER 1 X X
3 AT177950 FILLER CAP 1 X X
4 H148166 WASHER 1 X X
5 AT227279 LEVEL GAUGE 1 X X
6 AT227441 COVER 1 X X
7 AT307292 GASKET KIT 1 X X
8 T195587 O-RING 1 X X
9 .................. HOSE 1 X X (MAKE FROM M87571) (CUT TO LENGTH)
10 E69975 CLAMP 1 X X
11 RE38310 SENSOR 1 -599560 X X
AH156145 SENSOR 1 599561- X X
12 T13254 CLAMP 3 X X
13 AT101565 AIR FILTER 1 X X
14 AT176384 ELBOW FITTING 1 X X
15 19M7784 SCREW 1 X X M10 X 20
16 24M7296 WASHER 1 X X
17 19M7938 CAP SCREW 2 X X
18 24M7239 WASHER 2 X X
19 AH89557 CLIP 1 X X

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 2164-5

PN=545
 3D9 GRADING DEVICE 34
BLADES 3401
MOLDBOARDS AND CUTTING EDGES (FIVE HOLE END BIT)
T201129 -UN-25JUN04

THIS PARTS LISTING IS CONTINUED

3401-2 770D/772D MOTOR GRADER PC9449 (12-JAN-05)
PN=546
 3D10 GRADING DEVICE 34
BLADES 3401
MOLDBOARDS AND CUTTING EDGES (FIVE HOLE END BIT)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T66702 DURA-MAX TM CUTTING EDGE AR X X DURA-MAX THROUGH HARDENED DOUBLE BEVEL

EDGE, 16 MM X 152 MM X 1 829 MM (5/8" X
6" X 6’)
T66707 DURA-MAX TM CUTTING EDGE AR X X DURA-MAX THROUGH HARDENED DOUBLE BEVEL
EDGE, 16 MM X 152 MM X 2 134 MM (5/8" X
6" X 7’)
T66703 DURA-MAX TM CUTTING EDGE AR X X DURA-MAX THROUGH HARDENED DOUBLE BEVEL
EDGE, 19 MM X 203 MM X 1 829 MM (3/4" X
8" X 6’)
T66704 DURA-MAX TM CUTTING EDGE AR X X DURA-MAX THROUGH HARDENED DOUBLE BEVEL
EDGE, 19 MM X 203 MM X 2 134 MM (3/4" X
8" X 7’)
2 T202876 CUTTING EDGE 2 X X (RECOMMENDED WITH 16 MM (5/8") CUTTING
EDGE)
3 AT303240 MOLDBOARD 1 X X 22 MM X 3648 MM (7/8" X 12’ X 24")
AT303282 MOLDBOARD 1 X X 22 MM X 4 268 MM (7/8" X 14’ X 24")
AT303296 MOLDBOARD 1 X X 22 MM X 3 963 MM (7/8" X 13’ X 27")
AT310278 MOLDBOARD 1 X X 25 MM X 3648 MM (1" X 12’ X 27")
AT303301 MOLDBOARD 1 X X 25MM X4268MM (1" X 14’ X 27")
4 09H1759 BOLT 40 X X 5/8" X 2-1/4", (WITH 14’ MOLDBOARD)
09H1759 BOLT 38 X X 5/8" X 2-1/4", (WITH 13’ MOLDBOARD)
09H1759 BOLT 36 X X 5/8" X 2-1/4", (WITH 12’ MOLDBOARD)
5 14H800 NUT 40 X X 5/8", (WITH 14" MOLDBOARD)
14H800 NUT 38 X X 5/8", (WITH 13’ MOLDBOARD)
14H800 NUT 36 X X 5/8", (WITH 12’ MOLDBOARD)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3401-3

PN=547
 3D11 GRADING DEVICE 34
BLADES 3401
MOLDBOARD OVERLAYS
T201130 -UN-24JUN04

THIS PARTS LISTING IS CONTINUED

3401-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=548
 3D12 GRADING DEVICE 34
BLADES 3401
MOLDBOARD OVERLAYS

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 09H1773 BOLT 10 X X DURA-MAX THROUGH HARDENED DOUBLE BEVEL

EDGE, 16 MM X 152 MM X 1 829 MM (5/8" X
6" X 6’)
2 T202940 OVERLAY END BIT 2 X X (8" CUTTING EDGE)
T202938 OVERLAY END BIT 2 X X (6" CUTTING EDGE)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3401-5

PN=549
 3D13 GRADING DEVICE 34
BLADES 3401
MOLDBOARD EXTENSION (24" MOLDBOARD)
T201131 -UN-05JAN05

THIS PARTS LISTING IS CONTINUED

3401-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=550
 3D14 GRADING DEVICE 34
BLADES 3401
MOLDBOARD EXTENSION (24" MOLDBOARD)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT307731 KIT 1 X X (WHOLEGOODS) RH EXTENSION FOR 24"

MOLDBOARD
AT307730 KIT 1 X X (WHOLEGOODS) LH EXTENSION FOR 24"
MOLDBOARD
2 09H1759 BOLT 8 X X 5/8" X 2-1/4"
3 09H1773 BOLT 9 X X 5/8" X 3-1/4"
4 R73290 WASHER 14 X X 0.641" X 1.063" X 0.105"
5 14H760 NUT 17 X X 5/8"
6 19M8035 CAP SCREW 1 X X M16 X 35
7 24H1367 WASHER 3 X X 21/32" X 1-1/4" X 1/4"
8 AT306162 SUPPORT 1 X X RH (UPPER MOLDBOARD STIFFENER)
AT306163 SUPPORT 1 X X LH (UPPER MOLDBOARD STIFFENER)
9 T204543 BRACKET 2 X X
10 AT47241 REINFORCEMENT 1 X X (LOWER MOLDBOARD STIFFENER)
11 T43726 SUPPORT 1 X X
12 T66709 DURA-MAX TM CUTTING EDGE 1 X X (5/8 X 6 X 2 FT)
T66708 DURA-MAX TM CUTTING EDGE 1 X X (3/4 X 8 X 2 FT)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3401-7

PN=551
 3D15 GRADING DEVICE 34
BLADES 3401
MOLDBOARD EXTENSION (27" MOLDBOARD)
T211356 -UN-02JUN05

THIS PARTS LISTING IS CONTINUED

3401-8 770D/772D MOTOR GRADER PC9449 (09-JUN-05)
PN=552
 3D16 GRADING DEVICE 34
BLADES 3401
MOLDBOARD EXTENSION (27" MOLDBOARD)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT307732 KIT 1 X X (WHOLEGOODS) LH EXTENSION FOR 27"

MOLDBOARD
AT307733 KIT 1 X X (WHOLEGOODS) RH EXTENSION FOR 27"
MOLDBOARD
2 09H1759 BOLT 4 X X 5/8" X 2-1/4"
3 09H1764 BOLT 4 X X 5/8" X 2-1/2"
4 09H1773 BOLT 9 X X 5/8" X 3-1/4"
5 R73290 WASHER 14 X X 0.641" X 1.063" X 0.105"
6 14H760 NUT 17 X X 5/8"
7 19M8035 CAP SCREW 1 X X M16 X 35
8 24H1367 WASHER 3 X X 21/32" X 1-1/4" X 1/4"
9 24M7241 WASHER 9 X X 17 X 34 X 4 MM, (SUB FOR (4) 24H1378,
THIS APPLICATION)
10 AT306163 SUPPORT 1 X X LH (UPPER MOLDBOARD STIFFENER)
AT306162 SUPPORT 1 X X RH (UPPER MOLDBOARD STIFFENER)
11 T204543 BRACKET 2 X X
12 AT47241 REINFORCEMENT 1 X X (LOWER MOLDBOARD STIFFENER)
13 T43726 SUPPORT 1 X X
14 T66709 DURA-MAX TM CUTTING EDGE 1 X X (5/8 X 6 X 2 FT)
T66708 DURA-MAX TM CUTTING EDGE 1 X X (3/4 X 8 X 2 FT)

770D/772D MOTOR GRADER PC9449 (09-JUN-05) 3401-9

PN=553
 3D17 GRADING DEVICE 34
FRAMES 3440
DRAFT FRAME
T201050 -UN-22JUN04

THIS PARTS LISTING IS CONTINUED

3440-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=554
 3D18 GRADING DEVICE 34
FRAMES 3440
DRAFT FRAME

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 12H294 LOCK WASHER 10 X X 5/8"

2 14H793 NUT 12 X X 3/4"
3 19H2368 CAP SCREW 2 X X 3/4" X 3/4"
4 19H2641 CAP SCREW 10 X X 5/8" X 3-1/4"
5 19M8639 CAP SCREW 6 X X M20 X 70
6 19H2913 CAP SCREW 12 X X 3/4" X 2-3/4"
7 AT305363 FRAME 1 X X (CONVENIENCE ASSEMBLY) (DRAFT FRAME)
8 T59974 BALL 3 X X .914 MM (.036")
9 JD7781 LUBRICATION FITTING 1 X X
10 N231749 WASHER 6 X X
11 R69629 CAP SCREW 6 X X 90°, 1/8"
12 T188075 BUSHING 12 X X
13 T188076 WASHER 6 X X 3/8" X 1"
14 T33372 BOLT 12 X X
15 T213516 RETAINER 1 X X
16 T213579 RETAINER 1 X X
17 T42243 WASHER 8 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3440-3

PN=555
 3D19 GRADING DEVICE 34
FRAMES 3440
BLADE TILT FRAME
T201052 -UN-05JAN05

THIS PARTS LISTING IS CONTINUED

3440-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=556
 3D20 GRADING DEVICE 34
FRAMES 3440
BLADE TILT FRAME

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3255 CAP SCREW 6 X X 7/8" X 4"

2 AT226520 FRAME 1 X X (BLADE TILT FRAME)
3 T143929 BUSHING 4 X X
4 T124382 STRAP 6 X X
5 T212793 KIT 2 X X
6 T19572 WASHER 6 X X
7 T158027 STRAP 2 X X
8 T183474 INSERT 8 X X (EXTENDED LIFE INSERTS)(IF REPLACING
T185579 STD. INSERTS, ALSO ORDER 24
19M7572)
T185579 INSERT 8 X X (STANDARD INSERTS)
9 19M7572 CAP SCREW 24 X X M10 X 45, (USE WITH EXTENDED LIFE
INSERTS)
19M7662 CAP SCREW 24 X X M10 X 30, (USE WITH STANDARD INSERTS)
10 24M7239 WASHER 24 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3440-5

PN=557
 3D21 GRADING DEVICE 34
FRAMES 3440
SADDLE FRAME
T203298 -UN-08DEC04

THIS PARTS LISTING IS CONTINUED

3440-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=558
 3D22 GRADING DEVICE 34
FRAMES 3440
SADDLE FRAME

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H1058 NUT 4 X X 3/4"

2 14H786 NUT 1 X X 1/4"
3 19H1731 CAP SCREW 4 X X 3/8" X 1"
4 19H1800 CAP SCREW 8 X X 3/8" X 1-1/2"
5 19H2993 CAP SCREW 4 X X 1/2" X 1-1/2"
6 19H3225 CAP SCREW 2 X X 3/4" X 6-1/2"
7 19H3307 CAP SCREW 2 X X 3/4" X 6"
8 19H3740 CAP SCREW 8 X X 3/4" X 7-1/2"
9 24H1625 WASHER 4 X X
10 24H1864 WASHER 8 X X
11 24M7239 WASHER 4 X X
12 AT307326 BRACKET 1 X X
14 AT315712 ANGLE 1 X X
15 AT317482 ARM 1 X X
16 T186350 BUSHING 1 X X
17 AT317483 ARM 1 X X
18 AT317484 KIT 1 X X
20 T42589 BUSHING 2 X X
21 AT317485 YOKE 2 X X
22 12H294 LOCK WASHER 4 X X
23 19H2641 CAP SCREW 4 X X
24 JD7759 LUBRICATION FITTING 2 X X
25 JD7781 LUBRICATION FITTING 8 X X
26 JD7782 LUBRICATION FITTING 2 X X
27 T103453 POINTER 1 X X
28 T10510 WASHER 8 X X
29 T152169 PIN 2 X X
30 T83426 WASHER 4 X X
31 T207483 RETAINER 2 X X
32 T208102 PIN FASTENER 1 X X
33 T208103 PIN FASTENER 1 X X
34 T213096 FRAME 1 X X
35 T213102 BRACKET 1 X X
36 T24510 WASHER 4 X X
37 T42574 BUSHING 4 X X
38 T42582 PIN FASTENER 1 X X
39 T42583 BALL 1 X X
40 T60260 SHIM 4 X X
41 T81674 THRUST WASHER 2 X X
42 T82855 CAP SCREW 4 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3440-7

PN=559
 3D23 GRADING DEVICE 34
FRAMES 3440
CIRCLE FRAME
T204655 -UN-03DEC04

THIS PARTS LISTING IS CONTINUED

3440-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=560
 3D24 GRADING DEVICE 34
FRAMES 3440
CIRCLE FRAME

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 08H4845 CAP SCREW 2 X X 7/8" X 13-1/2"

2 19H2329 CAP SCREW 18 X X 1" X 5-1/2"
3 19H2553 CAP SCREW 12 X X 3/8" X 2-5/8"
4 24H1671 WASHER 10 X X
5 24M7213 WASHER 12 X X
6 AT301673 CIRCLE 1 X X
7 T143929 BUSHING 1 X X
8 K40017 LOCK NUT 2 X X 7/8"
9 N237603 WASHER 4 X X
10 T128502 PLATE 6 X X
11 T129981 SHIM 18 X X
12 T129982 SHIM 24 X X
13 T150614 SUPPORT 6 X X
14 T152721 WASHER 18 X X
15 T203381 BUSHING 2 X X
16 T203388 BUSHING 4 X X
17 T208792 SHIM 4 X X
18 T141732 INSERT 6 X X (STANDARD WITH OR WITHOUT SLIP CLUTCH)
T163748 INSERT 6 X X (EXTENDED LIFE WITH OR WITHOUT SLIP
CLUTCH)
19 T141733 INSERT 15 X X (STANDARD WITHOUT SLIP CLUTCH)
T184082 INSERT 15 X X (EXTENDED LIFE WITHOUT SLIP CLUTCH,
STANDARD WITH SLIP CLUTCH)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3440-9

PN=561
 3E1 GRADING DEVICE 34
CIRCLE GEAR BOX 3450
CIRCLE DRIVE GEARBOX

T201069 -UN-24JUN04

THIS PARTS LISTING IS CONTINUED

3450-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=562
 3E2 GRADING DEVICE 34
CIRCLE GEAR BOX 3450
CIRCLE DRIVE GEARBOX

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT169451 BEARING CONE 1 X X

2 AT169452 SEAL 1 X X
3 E14814 PRESSURE RELIEF FITTING 1 X X
4 JD10024 BEARING CONE 1 X X
5 JD10144 BEARING CONE 2 X X
6 JD8240 BEARING CUP 2 X X
7 JD9021 BEARING CUP 1 X X
8 JD9134 BEARING CUP 1 X X
9 R37287 O-RING 1 X X
10 T151485 HOUSING 1 X X
11 T152876 PINION SHAFT 1 X X
12 T152877 COVER 1 X X
13 T167010 SHAFT 1 X X (USE WITH T167011)
14 T152879 FLANGE 1 X X
15 T167011 WORM GEAR 1 X X (USE WITH T167010)
16 T152881 SHIM AR X X (.1 MM)
T152882 SHIM AR X X (.2 MM)
T152883 SHIM AR X X (.5 MM)
19 T152990 SHIM AR X X (.1 MM)
T152991 SHIM AR X X (.2 MM)
T152992 SHIM AR X X (.5 MM)
22 T152993 PLUG 1 X X
23 T152994 WASHER 1 X X HS, SAE 8, 1/2" X 2"
24 T152995 THRUST WASHER 2 X X
25 T42302 O-RING 1 X X
26 Z40239 CAP 1 X X
27 R39112 FITTING 1 X X
28 R26448 O-RING 2 X X
29 R27218 FITTING PLUG 1 X X
30 T10510 WASHER 5 X X
31 19M7790 SCREW 4 X X M12 X 35
32 19M7835 SCREW 15 X X M10 X 35
33 CE17879 ADAPTER 1 X X
34 U42702 O-RING 1 X X
35 T150942 SPLINED COUPLING 1 X X
36 AT190539 GEAR CASE 1 X X
37 19H3026 CAP SCREW 2 X X 3/4" X 3-1/2"
38 19H2991 CAP SCREW 1 X X 3/4" X 2-1/4", (FRONT MOUNTING SCREW)
39 14H1046 NUT 2 X X 3/4"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3450-3

PN=563
 3E3 GRADING DEVICE 34
CIRCLE GEAR BOX 3450
CIRCLE DRIVE GEARBOX (WITH SLIP CLUTCH)
T201073 -UN-04DEC04

THIS PARTS LISTING IS CONTINUED

3450-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=564
 3E4 GRADING DEVICE 34
CIRCLE GEAR BOX 3450
CIRCLE DRIVE GEARBOX (WITH SLIP CLUTCH)

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT169451 BEARING CONE 1 X X

2 AT169452 SEAL 1 X X
3 E14814 PRESSURE RELIEF FITTING 1 X X
4 JD9082 BEARING CONE 1 X X
5 JD10144 BEARING CONE 2 X X
6 JD8240 BEARING CUP 2 X X
7 JD9141 BEARING CUP 1 X X
8 JD9134 BEARING CUP 1 X X
9 R37287 O-RING 1 X X
10 T165055 HOUSING 1 X X
11 T165061 PINION SHAFT 1 X X
12 T165056 CAP 1 X X
13 T167010 SHAFT 1 X X
14 T152879 FLANGE 1 X X
15 T184228 WORM GEAR 1 X X
16 T152881 SHIM AR X X 0.1 MM
T152882 SHIM AR X X 0.15 MM
T152883 SHIM AR X X 0.5 MM
17 T10510 WASHER 5 X X 0.15 MM
18 14H1046 NUT 2 X X 3/4", 0.5 MM
19 T165072 SHIM AR X X 0.1 MM
T165073 SHIM AR X X 0.15 MM
T165074 SHIM AR X X 0.5 MM
20 T165073 SHIM 1 X X 0.15 MM
21 T165074 SHIM 6 X X 0.5 MM
22 T152993 PLUG 1 X X
23 T165062 WASHER 1 X X HS, SAE 8, 1/2" X 2"
24 T165063 THRUST WASHER 2 X X
25 T42302 O-RING 1 X X
26 T165077 COVER 1 X X
27 R39112 FITTING 1 X X
28 R26448 O-RING 2 X X
29 R27218 FITTING PLUG 2 X X
30 19M7835 SCREW 12 X X M10 X 35
31 19M7790 SCREW 4 X X M12 X 35
32 T165075 SCREW 3 X X
33 CE17879 ADAPTER 1 X X
34 R26375 O-RING 1 X X
35 T165064 HUB 1 X X
36 T165065 PLATE 1 X X
37 T165066 PLATE 1 X X
38 T165067 SLEEVE 1 X X
39 T165068 SHIM 5 X X 0.1 MM
T165069 SHIM AR X X 0.15 MM
T165069 SHIM AR X X 0.5 MM
40 T165069 SHIM 1 X X 0.15 MM
41 T165070 SHIM 3 X X 0.5 MM
42 T80123 O-RING 1 X X
43 19M7866 BOLT 6 X X
44 T165791 DISK SPRING 1 X X
45 T164986 PLATE 13 X X
46 AT184409 CLUTCH DISK 14 X X
47 T165071 SCREW 3 X X
48 U42702 O-RING 1 X X
49 T150942 SPLINED COUPLING 1 X X ( T150942 IS NOT INCLUDED IN AT184413)
50 AT184413 GEAR CASE 1 X X (CONVENIENCE ASSEMBLY)
51 19H2991 CAP SCREW 1 X X 3/4" X 2-1/4", (SUB FOR 19H1388, THIS
APPLICATION) (FRONT MOUNTING SCREW)
52 19H3026 CAP SCREW 2 X X 3/4" X 3-1/2"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3450-5

PN=565
 3E5 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
ROTARY MANIFOLD

T201027 -UN-18JUN04

THIS PARTS LISTING IS CONTINUED

3460-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=566
 3E6 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
ROTARY MANIFOLD

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3771 SCREW 4 X X 3/8" X 1"

2 24M7296 WASHER 4 X X
3 AT169948 MANIFOLD 1 X X (ROTARY)
AT169949 SEAL KIT 1 X X
4 12H301 LOCK WASHER 2 X X 1/2"
5 19H2676 CAP SCREW 2 X X 3/8" X 1"

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3460-3

PN=567
 3E7 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
CIRCLE DRIVE MOTOR
T201064 -UN-04DEC04

THIS PARTS LISTING IS CONTINUED

3460-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=568
 3E8 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
CIRCLE DRIVE MOTOR

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT197057 MOTOR 1 X X (CIRCLE DRIVE)

2 T190610 SEAL 4 X X
3 T190611 SEAL 1 X X
4 T190612 SEAL 1 X X
5 T190613 BACK-UP RING 1 X X
6 T190614 BEARING HOUSING W/ BEARING 1 X X
7 T190615 SEAL 1 X X
8 T190616 WEAR PLATE 1 X X
9 T190617 DRIVE 1 X X
10 AT197907 MOUNTING PARTS 1 X X
11 T190639 PLATE 1 X X
12 T190640 FLOW CONTROL HYD. VALVE 1 X X
13 T190641 FLOW CONTROL HYD. VALVE 1 X X
14 T190642 PLATE 1 X X
15 T190643 PIN 2 X X
16 T190644 SPRING 2 X X
17 T190645 SEAL 1 X X
18 T190646 SEAL 1 X X
19 T190647 HOUSING 1 X X
20 AT197906 SHAFT 1 X X
21 AT197908 MOUNTING PARTS 1 X X
22 T190648 CAP SCREW 1 X X
23 AT197924 SEAL KIT 1 X X
24 R28782 O-RING 1 X X
25 12H301 LOCK WASHER 2 X X 1/2"
26 14H809 NUT 2 X X 1/2"
27 19H3033 SCREW 2 X X 1/2" X 2"
28 T150942 SPLINED COUPLING 1 X X
29 U42702 O-RING 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3460-5

PN=569
 3E9 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
CIRCLE SIDESHIFT CYLINDER

T201164 -UN-02OCT04

THIS PARTS LISTING IS CONTINUED

3460-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=570
 3E10 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
CIRCLE SIDESHIFT CYLINDER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AH141183 PISTON 1 X X
2 AH146557 SEAL 1 X X
3 F1430R O-RING 1 X X
4 H152203 SEAL 1 X X
5 H180103 SNAP RING 1 X X
6 H206859 SNAP RING 1 X X
7 H208987 WEAR RING 1 X X
8 R79101 BACK-UP RING 1 X X
9 .................. SEAL 1 X X (SUB AH210184)
10 .................. RING 1 X X (SUB AH210184)
11 .................. O-RING 1 X X (SUB AH212097)
12 AH212503 HYDRAULIC CYLINDER BARREL 1 X X
13 H142036 END 2 X X
14 H170539 NUT 1 X X
15 RE37331 HYDRAULIC CYLINDER ROD 1 X X
16 19H1440 CAP SCREW 4 X X 3/4" X 3"
17 H154856 WEAR RING 1 X X (WIPER INSTALLATION TOOL) (NOT
ILLUSTRATED)
18 AH210484 HYDRAULIC CYLINDER KIT 1 X X (ROD SEAL KIT)
19 AH212097 HYDRAULIC CYLINDER KIT 1 X X (BORE SEAL KIT)
20 AH208873 HYDRAULIC CYLINDER 1 X X (CIRCLE SIDESHIFT CYLINDER)
21 H208631 HYDR. CYLINDER ROD GUIDE 1 X X
22 T147623 SHIM 3 X X
23 T148164 SHIM 4 X X
24 JD7844 LUBRICATION FITTING 2 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 3460-7

PN=571
 3E11 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE LIFT CYLINDER

T201280 -UN-09DEC04

THIS PARTS LISTING IS CONTINUED

3460-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=572
 3E12 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE LIFT CYLINDER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AH141183 PISTON 1 X X
2 AH146557 SEAL 1 X X
3 F1430R O-RING 1 X X
4 H152203 SEAL 1 X X
5 H180103 SNAP RING 1 X X
6 H206859 SNAP RING 1 X X
7 H208987 WEAR RING 1 X X
8 R79101 BACK-UP RING 1 X X
9 .................. SEAL 1 X X (SUB AH210184)
10 .................. RING 1 X X (SUB AH210184)
11 .................. O-RING 1 X X (SUB AH212097)
12 AH212502 HYDRAULIC CYLINDER BARREL 1 X X
13 H142036 END 1 X X
14 H170539 NUT 1 X X
15 RE37382 HYDRAULIC CYLINDER ROD 1 X X
16 19H1440 CAP SCREW 2 X X 3/4" X 3"
17 H154856 WEAR RING 1 X X (WIPER INSTALLATION TOOL) (NOT
ILLUSTRATED)
18 AH210484 HYDRAULIC CYLINDER KIT 1 X X (ROD SEAL KIT)
19 AH212097 HYDRAULIC CYLINDER KIT 1 X X (BORE SEAL KIT)
20 AH208875 HYDRAULIC CYLINDER 1 X X (BLADE LIFT CYLINDER)
21 H208631 HYDR. CYLINDER ROD GUIDE 1 X X
22 T147623 SHIM 8 X X
23 T148164 SHIM 4 X X
24 JD7798 LUBRICATION FITTING 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3460-9

PN=573
 3E13 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE SLIDE CYLINDER

T201378 -UN-30JUN04

THIS PARTS LISTING IS CONTINUED

3460-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=574
 3E14 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE SLIDE CYLINDER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AH146556 SEAL 1 X X
2 AH146560 SEAL 1 X X
3 H155629 SEAL 1 X X (WIPER INSTALLATION TOOL) (NOT
ILLUSTRATED)
4 F1430R O-RING 1 X X
5 H152202 SEAL 1 X X
6 H157898 WEAR RING 1 X X
7 H180103 SNAP RING 1 X X
8 .................. O-RING 1 X X (SUB AH212097)
9 H206859 SNAP RING 1 X X
10 H208999 HYDR. CYLINDER ROD GUIDE 1 X X
11 R79101 BACK-UP RING 1 X X
12 AH212901 HYDRAULIC CYLINDER BARREL 1 X X
13 R89940 BUSHING 1 X X
14 H170538 NUT 1 X X M27
15 RE36349 HYDRAULIC CYLINDER ROD 1 X X
16 R89940 BUSHING 1 X X
17 AH136453 PISTON 1 X X
18 AH149813 HYDRAULIC CYLINDER KIT 1 X X (ROD SEAL KIT)
19 AH212097 HYDRAULIC CYLINDER KIT 1 X X (BORE SEAL KIT)
20 AH212900 HYDRAULIC CYLINDER 1 X X (BLADE SLIDE CYLINDER)
21 19H2898 CAP SCREW 1 X X 1/2" X 1-1/4"
22 24H1349 WASHER 1 X X
23 28H3418 WASHER 1 X X
24 40M7180 SNAP RING 2 X X
25 AT41245 PIN 1 X X
26 T124495 PIN FASTENER 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3460-11

PN=575
 3E15 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE TILT CYLINDER

T201392 -UN-02JUL04

THIS PARTS LISTING IS CONTINUED

3460-12 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=576
 3E16 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE TILT CYLINDER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AH205062 PISTON 1 X X
2 AH146557 SEAL 1 X X
3 AH146561 SEAL 1 X X
4 H208995 HYDR. CYLINDER ROD GUIDE 1 X X
5 F950R O-RING 1 X X
6 H152203 SEAL 1 X X
7 H180080 SNAP RING 1 X X
8 H180094 SNAP RING 1 X X
9 H208987 WEAR RING 1 X X
10 .................. O-RING 1 X X (SUB AH212102)
11 R81862 BACK-UP RING 1 X X
12 AH212812 HYDRAULIC CYLINDER BARREL 1 X X
13 R81968 BUSHING 1 X X
14 H145175 WASHER 1 X X
15 RE28364 HYDRAULIC CYLINDER ROD 1 X X
16 R82960 BUSHING 1 X X
17 19M8353 CAP SCREW 1 X X M30 X 80
18 H168248 WASHER 1 X X
19 H168249 WASHER 1 X X
20 AH210484 HYDRAULIC CYLINDER KIT 1 X X (ROD SEAL KIT)
21 AH212102 HYDRAULIC CYLINDER KIT 1 X X (BORE SEAL KIT)
22 H154856 WEAR RING 1 X X (WIPER INSTALLATION TOOL) (NOT
ILLUSTRATED)
23 AH212811 HYDRAULIC CYLINDER 1 X X (BLADE TILT)
24 40M7166 SNAP RING 2 X X
25 40M7180 SNAP RING 2 X X
26 JD7798 LUBRICATION FITTING 1 X X
27 JD7799 LUBRICATION FITTING 1 X X
28 T151953 PIN 1 X X
29 T77067 PIN FASTENER 1 X X

770D/772D MOTOR GRADER PC9449 (30-MAR-05) 3460-13

PN=577
 3E17 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE LIFT CYLINDER HYDRAULIC HOSES
T201521 -UN-29JUL04

THIS PARTS LISTING IS CONTINUED

3460-14 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=578
 3E18 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE LIFT CYLINDER HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1010 ELBOW FITTING 2 X X

2 R26375 O-RING 8 X X
3 T77613 O-RING 8 X X
4 38H1171 ADAPTER 6 X X
5 AT304148 HYDRAULIC HOSE - FABRICATE 2 X X (HEAD END)
6 AT304149 HYDRAULIC HOSE - FABRICATE 2 X X (ROD END)
7 C16054 CLAMP 2 X X
10 T105773 GUIDE 2 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 3460-15

PN=579
 3E19 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
SADDLE LOCK PIN AND HYDRAULIC HOSES
T201523 -UN-28OCT04

THIS PARTS LISTING IS CONTINUED

3460-16 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=580
 3E20 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
SADDLE LOCK PIN AND HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1003 ELBOW FITTING 1 X X

2 R28782 O-RING 2 X X
3 T77814 O-RING 2 X X
4 38H1159 ADAPTER 1 X X
5 38H1160 ADAPTER 2 X X
6 R26448 O-RING 2 X X
7 T77613 O-RING 2 X X
8 AT304150 HYDRAULIC HOSE - FABRICATE 1 X X
9 AT304151 HYDRAULIC HOSE - FABRICATE 1 X X
10 19H3700 CAP SCREW 6 X X 1" X 2"
11 AT303325 SPRING LOCKING PIN 1 X X
AT303536 SEAL KIT 1 X X
12 AT303600 SWITCH 1 X X
13 T42598 SHIM 2 X X
14 T70438 SHIM 3 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3460-17

PN=581
 3E21 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE IMPACT SYSTEM
T204683 -UN-19NOV04

THIS PARTS LISTING IS CONTINUED

3460-18 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=582
 3E22 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE IMPACT SYSTEM

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14M7272 NUT 4 X X M6
2 14M7274 NUT 2 X X M10
3 19M7785 SCREW 1 X X M10 X 25
4 19M7786 SCREW 8 X X M10 X 30
5 19M8321 SCREW 4 X X M6 X 45
6 24M7139 WASHER 4 X X
7 24M7239 WASHER 1 X X
8 38H1054 TEE FITTING 2 X X
9 R26375 O-RING 6 X X
10 T77613 O-RING 6 X X
11 38H1171 ADAPTER 4 X X
12 AT196351 HYDRAULIC ACCUMULATOR 2 X X
AT196760 KIT 2 X X (ACCUMULATOR GAS VALVE-NOT ILLUSTRATED)
13 AT305055 WIRING HARNESS 1 X X (BLADE IMPACT VALVE WIRING HARNESS)
14 AT302918 SOLENOID VALVE 2 X X (COMPONENTS LISTED ON SEPARATE PAGE)
15 AT306340 HYDRAULIC HOSE - FABRICATE 2 X X
16 AT306341 HYDRAULIC HOSE - FABRICATE 2 X X
17 AT312997 BRACKET 1 X X
18 AT315980 HYDRAULIC HOSE - FABRICATE 2 X X
19 T164124 LABEL 2 X X (ENGLISH)
T164128 LABEL 2 X X (FRENCH)
T164129 LABEL 2 X X (SPANISH)
20 T166761 CLAMP 4 X X
21 T203984 PLATE 2 X X
22 T211465 PLATE 2 X X
23 T28862 CLAMP 1 X X
24 AT305054 TOGGLE/ROCKER SWITCH 1 X X
25 AT315881 KIT 1 X X (WHOLEGOODS)(BLADE IMPACT SYSTEM)

770D/772D MOTOR GRADER PC9449 (20-APR-05) 3460-19

PN=583
 3E23 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE IMPACT VALVE
T202312 -UN-01SEP04

THIS PARTS LISTING IS CONTINUED

3460-20 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=584
 3E24 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE IMPACT VALVE

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AT302919 SOLENOID VALVE 1 X X

2 AT224703 SOLENOID VALVE COIL 1 X X
3 T181306 NUT 1 X X
4 AT224864 SEAL KIT 1 X X
5 AT302918 SOLENOID VALVE 2 X X (BLADE IMPACT VALVE)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3460-21

PN=585
 3F1 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE TILT AND SLIDE CYLINDER HYDRAULIC HOSES
T202729 -UN-19OCT04

THIS PARTS LISTING IS CONTINUED

3460-22 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=586
 3F2 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
BLADE TILT AND SLIDE CYLINDER HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19H3136 CAP SCREW 1 X X 1/2" X 5-3/4"

2 24M7240 WASHER 2 X X
3 38H1004 ELBOW FITTING 2 X X
4 R26448 O-RING 8 X X
5 T77613 O-RING 13 X X
6 38H1094 ELBOW FITTING 1 X X
7 38H1160 ADAPTER 4 X X
8 38H1161 ADAPTER 2 X X
9 R26375 O-RING 8 X X
10 T77857 O-RING 4 X X
11 38H1171 ADAPTER 4 X X
12 38H1173 ADAPTER 2 X X
13 AT166150 HYDRAULIC HOSE - FABRICATE 2 X X
14 AT179875 HYDRAULIC HOSE - FABRICATE 1 X X
15 AT304373 GUARD 1 X X
16 AT306446 HYDRAULIC HOSE - FABRICATE 2 X X
17 AT307845 HYDRAULIC HOSE - FABRICATE 2 X X
18 AT309961 HYDRAULIC HOSE - FABRICATE 1 X X
19 K40014 LOCK NUT 1 X X
20 M40509 SPACER 2 X X
21 T151806 U-BOLT 1 X X
22 T16464 LOCK NUT 2 X X
23 T82612 ADAPTER 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3460-23

PN=587
 3F3 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
CIRCLE ROTATE MOTOR HYDRAULIC HOSES
T202731 -UN-08SEP04

THIS PARTS LISTING IS CONTINUED

3460-24 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=588
 3F4 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
CIRCLE ROTATE MOTOR HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1006 ELBOW FITTING 1 X X

2 R26906 O-RING 2 X X
3 T77932 O-RING 3 X X
4 38H1096 ELBOW FITTING 1 X X
5 38H1161 ADAPTER 2 X X
6 R26375 O-RING 2 X X
7 T77857 O-RING 2 X X
8 38H1162 ADAPTER 1 X X
9 AT304862 HYDRAULIC HOSE - FABRICATE 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 3460-25

PN=589
 3F5 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
CIRCLE SIDESHIFT CYLINDER HYDRAULIC HOSES
T202733 -UN-07SEP04

THIS PARTS LISTING IS CONTINUED

3460-26 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=590
 3F6 GRADING DEVICE 34
HYDRAULIC SYSTEM 3460
CIRCLE SIDESHIFT CYLINDER HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1010 ELBOW FITTING 1 X X

2 R26375 O-RING 4 X X
3 T77613 O-RING 4 X X
4 38H1171 ADAPTER 3 X X
5 AT305548 HYDRAULIC HOSE - FABRICATE 1 X X
6 AT305769 HYDRAULIC HOSE - FABRICATE 1 X X
7 C16054 CLAMP 2 X X
8 T105773 GUIDE 3 X X

770D/772D MOTOR GRADER PC9449 (20-APR-05) 3460-27

PN=591
 3F8 GROUND CONDITIONING TOOL 42
FRAME 4240
FRONT MOUNTED SCARIFIER

T204191 -UN-19NOV04

THIS PARTS LISTING IS CONTINUED

4240-2 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=592
 3F9 GROUND CONDITIONING TOOL 42
FRAME 4240
FRONT MOUNTED SCARIFIER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 14H1058 NUT 10 X X 3/4"

2 19H3586 CAP SCREW 4 X X 1/2" X 4-1/4", (WHOLEGOODS)
3 19H2411 CAP SCREW 3 X X 3/4" X 2-1/2"
4 19H3196 CAP SCREW 10 X X 3/4" X 4"
5 24H1571 WASHER 16 X X
6 T114792 SHANK 1 X X
7 T6Y5230 TOOTH 1 X X
8 AT162731 SCARIFIER BOOM 1 X X
9 T59506 BUSHING 4 X X
10 AT168327 SCARIFIER ATTACHMENT 1 X X
11 AT302889 LINK 2 X X
12 T25875 BUSHING 4 X X
13 19H3535 CAP SCREW 1 X X 1/2" X 6"
14 24H1679 WASHER 2 X X
15 40M7066 SNAP RING 2 X X
16 AH212650 HYDRAULIC CYLINDER 1 X X (COMPONENTS ON SEPARATE PAGE)
17 JD7799 LUBRICATION FITTING 2 X X
19 T125945 PIN FASTENER 1 X X
20 T142485 PIN 1 X X
21 JD7781 LUBRICATION FITTING 8 X X
22 K40014 LOCK NUT 4 X X
23 T104223 RETAINER 5 X X
24 T147700 BRACKET 1 X X
25 T152047 PIN 4 X X
26 T17776 WASHER 23 X X
27 U12167 SNAP RING 8 X X
28 U41528 PIN FASTENER 1 X X
29 AT317749 KIT 1 X X (WHOLEGOODS) (FRONT MOUNTED SCARIFIER
KIT)

770D/772D MOTOR GRADER PC9449 (30-AUG-05) 4240-3

PN=593
 3F10 GROUND CONDITIONING TOOL 42
FRAME 4240
SCARIFIER CYLINDER
T204186 -UN-10NOV04

THIS PARTS LISTING IS CONTINUED

4240-4 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=594
 3F11 GROUND CONDITIONING TOOL 42
FRAME 4240
SCARIFIER CYLINDER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AH168884 PISTON 1 X X
2 AH146558 SEAL 1 X X
3 AH146562 SEAL 1 X X
4 H152204 SEAL 1 X X
5 H152795 WEAR RING 1 X X
6 R83578 O-RING 1 X X
7 H179659 SNAP RING 1 X X
8 H180100 SNAP RING 1 X X
9 H210841 HYDR. CYLINDER ROD GUIDE 1 X X
10 R79001 BACK-UP RING 1 X X
11 U10746 O-RING 1 X X
12 AH212657 HYDRAULIC CYLINDER BARREL 1 X X
13 R82075 BUSHING 1 X X
14 .................. ROD 1 X X (SUB AH212650)
15 R82076 BUSHING 1 X X
16 H170541 LOCK NUT 1 X X
17 H155630 SEAL 1 X X (WIPER INSTALLATION TOOL)(NOT
ILLUSTRATED)
18 AH149814 HYDRAULIC CYLINDER KIT 1 X X (ROD SEAL KIT)
19 AH212650 HYDRAULIC CYLINDER 1 X X (SCARIFIER CYLINDER)
20 JD7799 LUBRICATION FITTING 2 X X
21 24H1697 WASHER 2 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 4240-5

PN=595
 3F12 GROUND CONDITIONING TOOL 42
FRAME 4240
REAR RIPPER/SCARIFIER AND RIPPER TEETH
T204198 -UN-03DEC04

THIS PARTS LISTING IS CONTINUED

4240-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=596
 3F13 GROUND CONDITIONING TOOL 42
FRAME 4240
REAR RIPPER/SCARIFIER AND RIPPER TEETH

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7489 CAP SCREW 8 X X M16 X 45

2 19M7719 CAP SCREW 2 X X M16 X 70
3 19M8002 CAP SCREW 16 X X M20 X 55
4 19M8224 CAP SCREW 6 X X M20 X 60
5 24M7242 WASHER 22 X X
6 28H3401 SPACER 8 X X
7 28H3415 BUSHING 2 X X
8 AT166094 PIN 4 X X
9 AT166095 PIN 6 X X
10 AT175786 BRACKET 2 X X
11 E52817 SNAP RING 8 X X
12 JD7798 LUBRICATION FITTING 10 X X
13 JD7799 LUBRICATION FITTING 6 X X
14 T146246 WASHER 10 X X (SUB AH212650)
15 T149818 PLATE 4 X X
16 T149822 PIN 4 X X
17 T153019 SPACER 2 X X (WIPER INSTALLATION TOOL)(NOT
ILLUSTRATED)
18 T204905 PLATE 2 X X (ROD SEAL KIT)
19 AT306509 FRAME 1 X X (SCARIFIER CYLINDER)
21 AR83396 QUICK LOCK PIN 1 X X
22 T211749 SHANK 3 X X
23 T6Y0309 TOOTH 3 X X
24 T8E6359 RETAINER 3 X X
25 T9W2668 PIN 3 X X
26 AT186723 PIN FASTENER 1 X X
27 34H358 SPRING PIN 1 X X
28 34H363 SPRING PIN 1 X X
29 JD5920 REFLECTOR 2 X X
30 JD5921 REFLECTOR 2 X X
31 T108521 PIN 3 X X
32 T108524 PIN 3 X X
33 AH212649 HYDRAULIC CYLINDER 2 X X
34 AT306503 SIDEBOOM 1 X X
35 AT160581 KIT 1 X X
36 AT306505 KIT 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 4240-7

PN=597
 3F14 GROUND CONDITIONING TOOL 42
FRAME 4240
REAR RIPPER/SCARIFIER HYDRAULIC CYLINDER
T201463 -UN-06JUL04

THIS PARTS LISTING IS CONTINUED

4240-8 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=598
 3F15 GROUND CONDITIONING TOOL 42
FRAME 4240
REAR RIPPER/SCARIFIER HYDRAULIC CYLINDER

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 AH144879 HYDRAULIC CYLINDER ROD 1 X X

2 R81971 BUSHING 1 X X
3 AH205062 PISTON 1 X X
4 AH146557 SEAL 1 X X
5 AH146561 SEAL 1 X X
6 F950R O-RING 1 X X
7 H152203 SEAL 1 X X
8 H180080 SNAP RING 1 X X
9 H180094 SNAP RING 1 X X
10 H208987 WEAR RING 1 X X
11 R81862 BACK-UP RING 1 X X
12 H208995 HYDR. CYLINDER ROD GUIDE 1 X X
13 .................. O-RING 1 X X (SUB AH212102)
14 H154856 WEAR RING 1 X X (NOT ILLUSTRATED)
15 H208987 WEAR RING 1 X X
16 AH212656 HYDRAULIC CYLINDER BARREL 1 X X
17 R81968 BUSHING 1 X X
18 H170539 NUT 1 X X
19 AH210484 HYDRAULIC CYLINDER KIT 1 X X (ROD SEAL KIT)
20 AH212102 HYDRAULIC CYLINDER KIT 1 X X (BORE SEAL KIT)
21 AH212649 HYDRAULIC CYLINDER 1 X X (RIPPER CYLINDER)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 4240-9

PN=599
 3F16 GROUND CONDITIONING TOOL 42
FRAME 4240
REAR SCARIFIER TEETH
T204200 -UN-28OCT04

THIS PARTS LISTING IS CONTINUED

4240-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=600
 3F17 GROUND CONDITIONING TOOL 42
FRAME 4240
REAR SCARIFIER TEETH

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 T114792 SHANK 9 X X
2 T6Y5230 TOOTH 9 X X
3 T150347 PLUG 18 X X
4 T204018 RETAINER 6 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 4240-11

PN=601
 3F18 GROUND CONDITIONING TOOL 42
HYDRAULIC SYSTEM 4260
FRONT MOUNTED EQUIPMENT HYDRAULIC HOSES

T202723 -UN-07SEP04

THIS PARTS LISTING IS CONTINUED

4260-6 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=602
 3F19 GROUND CONDITIONING TOOL 42
HYDRAULIC SYSTEM 4260
FRONT MOUNTED EQUIPMENT HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1171 ADAPTER 2 X X
2 R26375 O-RING 2 X X
3 T77613 O-RING 4 X X
4 38H1278 UNION FITTING 1 X X
5 AT305770 HYDRAULIC HOSE - FABRICATE 1 X X
6 AT305771 HYDRAULIC HOSE - FABRICATE 1 X X

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 4260-7

PN=603
 3F20 GROUND CONDITIONING TOOL 42
HYDRAULIC SYSTEM 4260
FRONT SCARIFIER HYDRAULIC HOSES
T203169 -UN-19NOV04

THIS PARTS LISTING IS CONTINUED

4260-8 770D/772D MOTOR GRADER PC9449 (03-MAR-05)
PN=604
 3F21 GROUND CONDITIONING TOOL 42
HYDRAULIC SYSTEM 4260
FRONT SCARIFIER HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 38H1010 ELBOW FITTING 1 X X

2 R26375 O-RING 2 X X
3 T77613 O-RING 3 X X
4 38H1171 ADAPTER 3 X X
5 38H1278 UNION FITTING 1 X X
6 AT305770 HYDRAULIC HOSE - FABRICATE 1 X X
7 AT305771 HYDRAULIC HOSE - FABRICATE 1 X X
8 AT318528 KIT 1 X X (WHOLEGOODS) (FRONT SCARIFIER HYDRAULIC
HOSE KIT)

770D/772D MOTOR GRADER PC9449 (03-MAR-05) 4260-9

PN=605
 3F22 GROUND CONDITIONING TOOL 42
HYDRAULIC SYSTEM 4260
REAR RIPPER/REAR SCARIFIER HYDRAULIC HOSES
T204377 -UN-22NOV04

THIS PARTS LISTING IS CONTINUED

4260-10 770D/772D MOTOR GRADER PC9449 (07-JAN-05)
PN=606
 3F23 GROUND CONDITIONING TOOL 42
HYDRAULIC SYSTEM 4260
REAR RIPPER/REAR SCARIFIER HYDRAULIC HOSES

7 7
7 7
0 2
KEY PART NO. PART NAME QTY SERIAL NO. D D REMARKS

1 19M7550 CAP SCREW 2 X X M10 X 35

2 24M7239 WASHER 2 X X
3 38H1010 ELBOW FITTING 2 X X
4 R26375 O-RING 6 X X
5 T77613 O-RING 12 X X
6 38H1171 ADAPTER 4 X X
7 38H1291 TEE FITTING 2 X X
8 AH97280 CLIP 1 X X
9 AT306388 HYDRAULIC HOSE - FABRICATE 2 X X
10 AT307458 HYDRAULIC HOSE - FABRICATE 2 X X
11 AT307459 HYDRAULIC HOSE - FABRICATE 2 X X
12 C16054 CLAMP 2 X X
13 H77698 TIE BAND 2 X X
14 T105773 GUIDE 2 X X
15 T205713 BRACKET 1 X X
16 T81029 NUT 2 X X
17 19M7938 CAP SCREW 1 X X M10 X 20
18 AT318529 KIT 1 X X (WHOLEGOODS)(RIPPER/REAR SCARIFIER
PLUMBING)

770D/772D MOTOR GRADER PC9449 (07-JAN-05) 4260-11

PN=607
 GROUND CONDITIONING TOOL 42
HYDRAULIC SYSTEM 4260
MEMORANDA

4260-12 770D/772D MOTOR GRADER PC9449 (30-AUG-05)

PN=608
 1L7 770D/772D MOTOR GRADER
NUMERICAL INDEX

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
AA31281 1F19 19 0341 - 3 AH212102 2C24 28 0960 - 7 AR55394 1J5 13 0419 - 1
AE53905 2B18 19 0512 - 3 AH212102 3E16 10 3460 - 13 AR58952 1J18 22 0452 - 3
AH125760 1C16 8 0210 - 8 AH212102 3E16 21 3460 - 13 AR61533 1H25 17 0404 - 3
AH125760 1F4 14 0260 - 37 AH212102 3F15 13 4240 - 9 AR61533 1J16 6 0433 - 3
AH136453 3E14 17 3460 - 11 AH212102 3F15 20 4240 - 9 AR61589 1H25 19 0404 - 3
AH139128 2C20 1 0960 - 3 AH212473 2C24 25 0960 - 7 AR61589 1J16 8 0433 - 3
AH140072 2D2 6 0960 - 9 AH212494 2C20 20 0960 - 3 AR62936 2K4 16 1830 - 9
AH141183 3E10 1 3460 - 7 AH212500 2C22 25 0960 - 5 AR68167 1J14 4 0433 - 1
AH141183 3E12 1 3460 - 9 AH212502 3E12 12 3460 - 9 AR75527 1C9 25 0201 - 5
AH144879 3F15 1 4240 - 9 AH212503 3E10 12 3460 - 7 AR77962 1I22 59 0413 - 5
AH146556 3E14 1 3460 - 11 AH212545 2C24 23 0960 - 7 AR83396 2E17 4 1511 - 3
AH146557 2C20 3 0960 - 3 AH212649 3F13 33 4240 - 7 AR83396 3F13 21 4240 - 7
AH146557 2C22 13 0960 - 5 AH212649 3F15 21 4240 - 9 AR83434 2K6 17 1830 - 11
AH146557 2C24 12 0960 - 7 AH212650 3F9 16 4240 - 3 AR94517 1G22 9 0350 - 29
AH146557 3E10 2 3460 - 7 AH212650 3F11 14 4240 - 5 AR98850 1H23 9 0403 - 1
AH146557 3E12 2 3460 - 9 AH212650 3F11 19 4240 - 5 AT101224 1C23 2 0230 - 3
AH146557 3E16 2 3460 - 13 AH212650 3F13 14 4240 - 7 AT101224 1D5 7 0240 - 3
AH146557 3F15 4 4240 - 9 AH212656 3F15 16 4240 - 9 AT101565 1F2 11 0260 - 35
AH146558 3F11 2 4240 - 5 AH212657 3F11 12 4240 - 5 AT101565 3D6 13 2164 - 5
AH146560 3E14 2 3460 - 11 AH212811 3E16 23 3460 - 13 AT103567 1B7 2 0110 - 7
AH146561 2C20 10 0960 - 3 AH212812 3E16 12 3460 - 13 AT105608 1B9 2 0110 - 9
AH146561 2C22 22 0960 - 5 AH212900 3E14 20 3460 - 11 AT106154 2G14 5 1674 - 27
AH146561 2C24 20 0960 - 7 AH212901 3E14 12 3460 - 11 AT106397 2J20 1 1821 - 9
AH146561 3E16 3 3460 - 13 AH215390 2D2 3 0960 - 9 AT106413 2H18 6 1810 - 5
AH146561 3F15 5 4240 - 9 AH215391 2D2 19 0960 - 9 AT107738 2C6 4 0540 - 3
AH146562 3F11 3 4240 - 5 AH61472 2D24 9 1111 - 5 AT112769 2E14 1 1370 - 3
AH147976 2D2 7 0960 - 9 AH64349 3C24 38 2163 - 7 AT116970 2H18 5 1810 - 5
AH149813 3E14 18 3460 - 11 AH64349 3D2 38 2163 - 9 AT116970 2H20 4 1810 - 7
AH149814 3F11 18 4240 - 5 AH75162 1E16 11 0260 - 25 AT120461 2L13 5 2004 - 5
AH150452 2D2 8 0960 - 9 AH75162 1E20 11 0260 - 29 AT124317 2B16 7 0510 - 11
AH156145 3D6 11 2164 - 5 AH77714 1F2 10 0260 - 35 AT124317 2D19 6 1060 - 5
AH161589 2D2 20 0960 - 9 AH77714 1F11 3 0315 - 3 AT125801 2J20 2 1821 - 9
AH164325 2D2 21 0960 - 9 AH77714 1F19 5 0341 - 3 AT125805 2J20 4 1821 - 9
AH168200 2C22 12 0960 - 5 AH77714 2B14 46 0510 - 7 AT125829 2J20 6 1821 - 9
AH168884 3F11 1 4240 - 5 AH77714 3C24 59 2163 - 7 AT135758 2F10 9 1673 - 11
AH205062 2C20 11 0960 - 3 AH77869 2E22 8 1671 - 3 AT135758 2F12 6 1673 - 13
AH205062 2C22 23 0960 - 5 AH77869 2J24 2 1830 - 3 AT135758 2F14 8 1673 - 15
AH205062 2C24 21 0960 - 7 AH89486 1I25 6 0416 - 3 AT13740 1H25 4 0404 - 3
AH205062 3E16 1 3460 - 13 AH89557 2B14 6 0510 - 7 AT13740 1J2 3 0417 - 3
AH205062 3F15 3 4240 - 9 AH89557 2G2 9 1674 - 15 AT139434 3C14 7 2160 - 43
AH208859 2C22 5 0960 - 5 AH89557 3D6 19 2164 - 5 AT145341 2B4 3 0505 - 3
AH208873 3E10 20 3460 - 7 AH97280 3C18 9 2163 - 3 AT145341 2F20 9 1674 - 7
AH208875 3E12 20 3460 - 9 AH97280 3F23 8 4260 - 11 AT145650 1E16 13 0260 - 25
AH209121 3B9 6 2160 - 7 AL114275 2H22 1 1810 - 9 AT145650 1E20 12 0260 - 29
AH210184 3E10 9 3460 - 7 AL153660 2H18 4 1810 - 5 AT147011 3C14 2 2160 - 43
AH210184 3E10 10 3460 - 7 AL153660 2H20 3 1810 - 7 AT150024 2D17 6 1060 - 3
AH210184 3E12 9 3460 - 9 AL153661 2H18 4 1810 - 5 AT150112 2D17 8 1060 - 3
AH210184 3E12 10 3460 - 9 AL153661 2H20 3 1810 - 7 AT152180 1I7 7 0407 - 3
AH210484 2C20 16 0960 - 3 AL58295 2G6 3 1674 - 19 AT157226 2L5 6 2002 - 3
AH210484 2C22 27 0960 - 5 AL76568 2K14 8 1830 - 19 AT157226 2L7 4 2002 - 5
AH210484 2C24 27 0960 - 7 AN208022 1D25 3 0260 - 9 AT158292 2H8 6 1747 - 3
AH210484 3E10 18 3460 - 7 AN208024 1E2 14 0260 - 11 AT160480 2G14 6 1674 - 27
AH210484 3E12 18 3460 - 9 AR21836 1F19 6 0341 - 3 AT160581 3F13 35 4240 - 7
AH210484 3E16 20 3460 - 13 AR21836 2B14 7 0510 - 7 AT161176 2C6 5 0540 - 3
AH210484 3F15 19 4240 - 9 AR21836 2D19 5 1060 - 5 AT161638 3D6 2 2164 - 5
AH212097 3E10 11 3460 - 7 AR21837 2E10 2 1369 - 3 AT162731 3F9 8 4240 - 3
AH212097 3E10 19 3460 - 7 AR21839 1E12 4 0260 - 21 AT162848 2K12 13 1830 - 17
AH212097 3E12 11 3460 - 9 AR21839 1E20 12 0260 - 29 AT163872 2K10 6 1830 - 15
AH212097 3E12 19 3460 - 9 AR21839 2B14 8 0510 - 7 AT164240 2H8 1 1747 - 3
AH212097 3E14 8 3460 - 11 AR21839 2B24 7 0520 - 3 AT165288 2H24 6 1810 - 11
AH212097 3E14 19 3460 - 11 AR21841 2B14 9 0510 - 7 AT166094 3F13 8 4240 - 7
AH212101 2C20 14 0960 - 3 AR21842 2B6 9 0505 - 5 AT166095 3F13 9 4240 - 7
AH212102 2C20 17 0960 - 3 AR40418 2B14 11 0510 - 7 AT166150 3F2 13 3460 - 23
AH212102 2C22 15 0960 - 5 AR43705 2C4 2 0530 - 3 AT168327 3F9 10 4240 - 3
AH212102 2C22 17 0960 - 5 AR44361 2B24 14 0520 - 3 AT168543 2K10 12 1830 - 15
AH212102 2C22 28 0960 - 5 AR48675 1J4 4 0418 - 3 AT169451 3E2 1 3450 - 3
AH212102 2C24 15 0960 - 7 AR49025 1H22 1 0402 - 6 AT169451 3E4 1 3450 - 5
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-1
PN=609
 1L8 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
AT169452 3E2 2 3450 - 3 AT183377 2B24 17 0520 - 3 AT191730 1D21 23 0260 - 5
AT169452 3E4 2 3450 - 5 AT183417 2B6 14 0505 - 5 AT191739 1D2 7 0230 - 7
AT169864 2D2 22 0960 - 9 AT183422 2B6 12 0505 - 5 AT191739 1D7 2 0240 - 5
AT169874 1C25 34 0230 - 5 AT183423 2B6 22 0505 - 5 AT191741 2K12 15 1830 - 17
AT169875 1C25 14 0230 - 5 AT183485 2B6 18 0505 - 5 AT191879 1E20 14 0260 - 29
AT169948 3E6 3 3460 - 3 AT183612 2D24 11 1111 - 5 AT192055 1D25 23 0260 - 9
AT169949 3E6 3 3460 - 3 AT183636 2B24 10 0520 - 3 AT192055 1E2 23 0260 - 11
AT170005 2H24 7 1810 - 11 AT184015 2C2 5 0520 - 5 AT192114 1D21 18 0260 - 5
AT170854 2C6 10 0540 - 3 AT184016 2C2 5 0520 - 5 AT192380 2D4 10 0960 - 11
AT171539 2B6 10 0505 - 5 AT184409 3E4 46 3450 - 5 AT193500 2K8 27 1830 - 13
AT173174 1E2 8 0260 - 11 AT184413 3E4 49 3450 - 5 AT193805 1D7 1 0240 - 5
AT173192 2H18 9 1810 - 5 AT184413 3E4 50 3450 - 5 AT193864 1D11 18 0250 - 3
AT173192 2H20 5 1810 - 7 AT184618 2B4 4 0505 - 3 AT193866 1B13 2 0110 - 13
AT173192 2H22 3 1810 - 9 AT184684 1F13 12 0315 - 5 AT193885 1C23 15 0230 - 3
AT173313 2J16 2 1821 - 5 AT184868 1D25 4 0260 - 9 AT193948 1E16 26 0260 - 25
AT173313 2J16 17 1821 - 5 AT184869 1D25 15 0260 - 9 AT194405 1D5 4 0240 - 3
AT173313 2J16 18 1821 - 5 AT185695 2C8 9 0560 - 3 AT194472 1D19 3 0260 - 3
AT173313 2J16 19 1821 - 5 AT186653 2C18 14 0930 - 3 AT194555 1E4 14 0260 - 13
AT173314 2J16 3 1821 - 5 AT186723 2E17 5 1511 - 3 AT194587 2B18 17 0512 - 3
AT173315 2J16 4 1821 - 5 AT186723 3F13 26 4240 - 7 AT194588 2B18 18 0512 - 3
AT173321 2J16 11 1821 - 5 AT187021 2D17 8 1060 - 3 AT194596 1E2 16 0260 - 11
AT173321 2J16 12 1821 - 5 AT187114 1D13 25 0250 - 5 AT194773 2B18 26 0512 - 3
AT173321 2J16 29 1821 - 5 AT187114 1D23 38 0260 - 7 AT194815 1E4 15 0260 - 13
AT173321 2J16 30 1821 - 5 AT187115 1D13 11 0250 - 5 AT194842 1B15 2 0110 - 15
AT173321 2J16 31 1821 - 5 AT187117 1D11 20 0250 - 3 AT194965 2B18 27 0512 - 3
AT173321 2J16 40 1821 - 5 AT187119 1D11 19 0250 - 3 AT194980 1E20 19 0260 - 29
AT173610 2B14 12 0510 - 7 AT187234 2E17 8 1511 - 3 AT194982 1E20 19 0260 - 29
AT173971 2G21 15 1740 - 3 AT188217 1E20 13 0260 - 29 AT194983 1E20 19 0260 - 29
AT174935 1F13 10 0315 - 5 AT188624 1D19 2 0260 - 3 AT194983 1F6 8 0260 - 39
AT175436 2J20 7 1821 - 9 AT188625 1D19 1 0260 - 3 AT194986 1F6 1 0260 - 39
AT175548 2E22 9 1671 - 3 AT188662 1D23 6 0260 - 7 AT194988 1F6 2 0260 - 39
AT175549 2E22 10 1671 - 3 AT188681 2H22 2 1810 - 9 AT194989 1F6 9 0260 - 39
AT175550 2E22 11 1671 - 3 AT188759 2L3 7 2001 - 3 AT194990 1F6 3 0260 - 39
AT175786 3F13 10 4240 - 7 AT189052 2B24 8 0520 - 3 AT194991 1F6 4 0260 - 39
AT175953 2C24 6 0960 - 7 AT189052 2C2 4 0520 - 5 AT195057 1E6 44 0260 - 15
AT175957 3C20 9 2163 - 5 AT189390 2L9 2 2003 - 3 AT195060 1E10 42 0260 - 19
AT175957 3C22 9 2163 - 5B AT189487 2L9 3 2003 - 3 AT195062 1E6 26 0260 - 15
AT176011 2B16 8 0510 - 11 AT190417 1B11 2 0110 - 11 AT195063 1E6 12 0260 - 15
AT176384 3D6 14 2164 - 5 AT190539 3E2 36 3450 - 3 AT195064 1E10 79 0260 - 19
AT177142 2D24 10 1111 - 5 AT190809 2K12 14 1830 - 17 AT195065 1E8 48 0260 - 17
AT177950 3D6 3 2164 - 5 AT190836 2B6 17 0505 - 5 AT195066 1E8 6 0260 - 17
AT178542 2B24 15 0520 - 3 AT191007 2E22 12 1671 - 3 AT195068 1E8 61 0260 - 17
AT178586 2C6 3 0540 - 3 AT191008 2B4 8 0505 - 3 AT195069 1E10 64 0260 - 19
AT179099 1B9 2 0110 - 9 AT191095 1E24 4 0260 - 33 AT195073 1E10 6 0260 - 19
AT179249 1B17 2 0110 - 17 AT191102 2K6 18 1830 - 11 AT195074 1E10 21 0260 - 19
AT179875 3F2 14 3460 - 23 AT191160 1F2 12 0260 - 35 AT195075 1E10 41 0260 - 19
AT180119 1H7 18 0360 - 3 AT191178 2K8 36 1830 - 13 AT195124 1E10 95 0260 - 19
AT180126 2J18 30 1821 - 7 AT191214 1E4 13 0260 - 13 AT195125 1E8 96 0260 - 17
AT180126 2J20 9 1821 - 9 AT191260 1D2 4 0230 - 7 AT195285 1F4 16 0260 - 37
AT180135 2J20 10 1821 - 9 AT191260 1D7 10 0240 - 5 AT195301 2G14 15 1674 - 27
AT180301 2D4 10 0960 - 11 AT191261 1D2 11 0230 - 7 AT195302 2G14 16 1674 - 27
AT180814 1D25 6 0260 - 9 AT191261 1D7 7 0240 - 5 AT195440 2J18 6 1821 - 7
AT180923 1F13 11 0315 - 5 AT191299 1D2 8 0230 - 7 AT195441 2J14 7 1821 - 3
AT180935 1E10 25 0260 - 19 AT191299 1D7 4 0240 - 5 AT195441 2J18 7 1821 - 7
AT180936 1E10 30 0260 - 19 AT191366 3B5 12 2160 - 3 AT195442 2J14 8 1821 - 3
AT180964 1E10 63 0260 - 19 AT191367 3B5 17 2160 - 3 AT195442 2J18 8 1821 - 7
AT180965 1E8 66 0260 - 17 AT191368 3B5 19 2160 - 3 AT195723 1E2 13 0260 - 11
AT180965 1E10 66 0260 - 19 AT191369 3B5 18 2160 - 3 AT195860 3C14 5 2160 - 43
AT180966 1E8 67 0260 - 17 AT191371 3B5 71 2160 - 3 AT195880 1D9 3 0240 - 7
AT180966 1E10 67 0260 - 19 AT191505 1D21 22 0260 - 5 AT195898 3C14 6 2160 - 43
AT181162 2B14 13 0510 - 7 AT191506 1D21 15 0260 - 5 AT195900 3C14 1 2160 - 43
AT181313 2D17 7 1060 - 3 AT191541 2K19 11 1910 - 5 AT195917 3C12 1 2160 - 41
AT181392 2J18 36 1821 - 7 AT191639 1F4 15 0260 - 37 AT195918 3C12 10 2160 - 41
AT181582 2B6 11 0505 - 5 AT191724 1D21 21 0260 - 5 AT195921 1D25 21 0260 - 9
AT182063 2C4 1 0530 - 3 AT191725 1D21 6 0260 - 5 AT195922 1D25 22 0260 - 9
AT182580 1B5 2 0110 - 5 AT191728 1D21 24 0260 - 5 AT195922 1E2 22 0260 - 11
AT183375 2B24 16 0520 - 3 AT191729 1D21 1 0260 - 5 AT196249 1E12 2 0260 - 21
II-2 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=610
 1L9 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
AT196250 1E12 4 0260 - 21 AT209021 2J18 10 1821 - 7 AT25226 1B11 1 0110 - 11
AT196252 1E12 8 0260 - 21 AT209022 2J14 15 1821 - 3 AT25226 1B17 1 0110 - 17
AT196253 1E12 1 0260 - 21 AT209022 2J18 15 1821 - 7 AT25226 1B19 5 0110 - 21
AT196254 1E12 3 0260 - 21 AT209024 2J14 17 1821 - 3 AT280244 3B5 16 2160 - 3
AT196256 1E12 7 0260 - 21 AT209024 2J18 17 1821 - 7 AT280296 2G4 3 1674 - 17
AT196346 3B5 14 2160 - 3 AT209025 2J14 19 1821 - 3 AT280297 2G4 4 1674 - 17
AT196351 3E22 12 3460 - 19 AT209025 2J18 19 1821 - 7 AT280508 1D7 3 0240 - 5
AT196462 1D25 13 0260 - 9 AT209026 2J14 21 1821 - 3 AT280583 2J18 35 1821 - 7
AT196516 2B4 1 0505 - 3 AT209026 2J18 21 1821 - 7 AT280631 2K12 16 1830 - 17
AT196522 2I6 3 1810 - 15 AT209225 2J14 23 1821 - 3 AT300167 2E24 13 1672 - 3
AT196745 1D23 14 0260 - 7 AT209225 2J18 23 1821 - 7 AT300684 2E24 14 1672 - 3
AT196745 1E2 14 0260 - 11 AT209469 2J16 13 1821 - 5 AT300859 3C24 39 2163 - 7
AT196760 3E22 12 3460 - 19 AT209469 2J16 33 1821 - 5 AT300859 3D2 39 2163 - 9
AT196943 3B9 2 2160 - 7 AT209469 2J16 34 1821 - 5 AT301133 2C8 6 0560 - 3
AT197057 3E8 1 3460 - 5 AT209469 2J16 35 1821 - 5 AT301226 3B21 2 2160 - 25
AT197098 1E12 5 0260 - 21 AT210333 2F4 2 1673 - 5 AT301227 3B21 3 2160 - 25
AT197420 3B5 16 2160 - 3 AT211041 1J13 2 0429 - 2 AT301673 3D24 6 3440 - 9
AT197488 1E16 24 0260 - 25 AT211206 2B24 13 0520 - 3 AT302098 1E16 12 0260 - 25
AT197613 1B13 1 0110 - 13 AT214801 1E2 3 0260 - 11 AT302104 1F13 13 0315 - 5
AT197844 1B15 1 0110 - 15 AT216348 3C14 4 2160 - 43 AT302105 1F13 14 0315 - 5
AT197906 3E8 20 3460 - 5 AT219974 2C8 5 0560 - 3 AT302150 3B9 9 2160 - 7
AT197907 3E8 10 3460 - 5 AT22070 2L15 2 2005 - 3 AT302166 2D12 8 0960 - 19
AT197908 3E8 21 3460 - 5 AT22073 2L15 3 2005 - 3 AT302175 2D12 9 0960 - 19
AT197924 3E8 23 3460 - 5 AT221019 2J14 25 1821 - 3 AT302283 3B11 2 2160 - 11
AT198028 1D23 24 0260 - 7 AT221019 2J18 25 1821 - 7 AT302284 3B11 1 2160 - 11
AT198029 1D23 46 0260 - 7 AT221020 2J14 26 1821 - 3 AT302285 3B11 4 2160 - 11
AT198322 1E8 8 0260 - 17 AT221020 2J18 26 1821 - 7 AT302286 3B11 3 2160 - 11
AT198516 1D23 14 0260 - 7 AT221021 2J14 28 1821 - 3 AT302287 3B11 8 2160 - 11
AT198517 1C25 7 0230 - 5 AT221021 2J18 28 1821 - 7 AT302288 3B11 7 2160 - 11
AT199018 1F17 1 0325 - 3 AT221696 2K17 12 1910 - 3 AT302388 1F13 6 0315 - 5
AT199076 3B5 48 2160 - 3 AT223493 2B16 9 0510 - 11 AT302401 2G21 5 1740 - 3
AT199084 1C21 3 0225 - 3 AT223537 2D22 10 1111 - 3 AT302520 2L3 9 2001 - 3
AT199388 2L3 8 2001 - 3 AT223584 1E16 18 0260 - 25 AT302544 3C10 18 2160 - 39
AT199626 1F6 14 0260 - 39 AT224248 2J14 6 1821 - 3 AT302638 2F22 12 1674 - 9
AT199661 1C21 2 0225 - 3 AT224497 2D22 5 1111 - 3 AT302661 3B5 70 2160 - 3
AT199999 1D2 9 0230 - 7 AT224574 3B9 7 2160 - 7 AT302662 3B5 70 2160 - 3
AT202864 2B24 13 0520 - 3 AT224576 2D22 4 1111 - 3 AT302730 2G14 7 1674 - 27
AT203566 2B4 5 0505 - 3 AT224703 3E24 2 3460 - 21 AT302731 2B20 2 0515 - 3
AT206818 2B4 6 0505 - 3 AT224863 2D22 2 1111 - 3 AT302732 2B20 3 0515 - 3
AT206878 2F4 1 1673 - 5 AT224864 2D22 3 1111 - 3 AT302769 2G14 8 1674 - 27
AT207529 2D17 10 1060 - 3 AT224864 3B9 4 2160 - 7 AT302794 2K2 2 1830 - 5
AT208483 2J16 5 1821 - 5 AT224864 3E24 4 3460 - 21 AT302797 2G16 3 1674 - 29
AT208484 2J16 6 1821 - 5 AT224873 1C16 14 0210 - 8 AT302818 2C6 14 0540 - 3
AT208485 2J16 7 1821 - 5 AT224873 2D22 7 1111 - 3 AT302821 2C6 11 0540 - 3
AT208486 2J16 8 1821 - 5 AT224894 2G16 3 1674 - 29 AT302889 3F9 11 4240 - 3
AT208487 2J16 9 1821 - 5 AT225573 2D19 17 1060 - 5 AT302906 3D4 4 2164 - 3
AT208487 2J16 20 1821 - 5 AT226282 2L11 1 2004 - 3 AT302907 3B9 3 2160 - 7
AT208487 2J16 21 1821 - 5 AT226446 1H9 2 0360 - 5 AT302908 3B9 5 2160 - 7
AT208487 2J16 22 1821 - 5 AT226447 1H9 3 0360 - 5 AT302918 3E22 14 3460 - 19
AT208487 2J16 23 1821 - 5 AT226520 3D20 2 3440 - 5 AT302918 3E24 5 3460 - 21
AT208487 2J16 24 1821 - 5 AT226676 2J16 14 1821 - 5 AT302919 3E24 1 3460 - 21
AT208488 2J16 15 1821 - 5 AT226676 2J16 38 1821 - 5 AT302927 1F4 17 0260 - 37
AT208488 2J16 36 1821 - 5 AT226676 2J16 39 1821 - 5 AT302953 2K8 8 1830 - 13
AT208488 2J16 37 1821 - 5 AT226676 2J16 41 1821 - 5 AT303129 3C16 4 2160 - 45
AT208490 2J16 10 1821 - 5 AT226676 2J16 42 1821 - 5 AT303240 3D10 3 3401 - 3
AT208490 2J16 25 1821 - 5 AT226676 2J16 43 1821 - 5 AT303282 3D10 3 3401 - 3
AT208490 2J16 26 1821 - 5 AT227063 2F8 10 1673 - 9 AT303296 3D10 3 3401 - 3
AT208490 2J16 27 1821 - 5 AT227279 3D6 5 2164 - 5 AT303301 3D10 3 3401 - 3
AT208490 2J16 28 1821 - 5 AT227441 3D6 6 2164 - 5 AT303325 3E20 11 3460 - 17
AT208491 2J16 11 1821 - 5 AT227668 2K4 19 1830 - 9 AT303467 2K14 9 1830 - 19
AT208491 2J16 32 1821 - 5 AT227669 2K4 20 1830 - 9 AT303469 2K14 10 1830 - 19
AT208493 2J16 44 1821 - 5 AT227717 2C18 15 0930 - 3 AT303489 2D12 13 0960 - 19
AT208531 2J14 30 1821 - 3 AT228826 2K17 10 1910 - 3 AT303518 2J18 32 1821 - 7
AT208531 2J16 1 1821 - 5 AT25226 1B3 1 0110 - 3 AT303536 3E20 11 3460 - 17
AT209020 2J14 9 1821 - 3 AT25226 1B5 1 0110 - 5 AT303539 1E22 11 0260 - 31
AT209020 2J18 9 1821 - 7 AT25226 1B7 1 0110 - 7 AT303600 3E20 12 3460 - 17
AT209021 2J14 10 1821 - 3 AT25226 1B9 1 0110 - 9 AT303670 2G23 1 1740 - 5
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-3
PN=611
 1L10 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
AT303678 3C16 5 2160 - 45 AT305385 2F22 14 1674 - 9 AT306034 2B12 16 0510 - 5
AT303744 2I24 43 1810 - 33 AT305386 2F22 14 1674 - 9 AT306035 2B12 17 0510 - 5
AT303745 2J2 44 1810 - 35 AT305387 2F24 2 1674 - 11 AT306056 2K14 13 1830 - 19
AT303748 2I24 43 1810 - 33 AT305389 2G10 10 1674 - 23 AT306111 2E12 3 1369 - 5
AT303749 2J2 44 1810 - 35 AT305397 2J8 22 1810 - 41 AT306133 2E12 9 1369 - 5
AT303799 1C16 14 0210 - 8 AT305398 1F13 16 0315 - 5 AT306154 2D6 7 0960 - 13
AT303854 1C25 16 0230 - 5 AT305406 2I10 9 1810 - 19 AT306155 2D6 8 0960 - 13
AT303855 1C25 35 0230 - 5 AT305406 2I12 9 1810 - 21 AT306156 2D6 9 0960 - 13
AT303859 2G6 4 1674 - 19 AT305414 2I8 1 1810 - 17 AT306162 3D14 8 3401 - 7
AT303865 2K14 11 1830 - 19 AT305416 2I8 1 1810 - 17 AT306162 3D16 10 3401 - 9
AT303896 2G12 3 1674 - 25 AT305433 1F13 25 0315 - 5 AT306163 3D14 8 3401 - 7
AT303926 2H22 4 1810 - 9 AT305437 2J14 32 1821 - 3 AT306163 3D16 10 3401 - 9
AT304023 2G6 5 1674 - 19 AT305505 1E14 2 0260 - 23 AT306180 2F22 15 1674 - 9
AT304024 2G6 6 1674 - 19 AT305506 1E16 30 0260 - 25 AT306181 2I24 10 1810 - 33
AT304026 2G14 9 1674 - 27 AT305507 1E16 2 0260 - 25 AT306181 2J2 10 1810 - 35
AT304098 2I6 1 1810 - 15 AT305508 1E16 19 0260 - 25 AT306335 2F10 8 1673 - 11
AT304099 2I6 13 1810 - 15 AT305509 1E14 4 0260 - 23 AT306340 3E22 15 3460 - 19
AT304144 3C24 40 2163 - 7 AT305510 1E14 3 0260 - 23 AT306341 3E22 16 3460 - 19
AT304144 3D2 40 2163 - 9 AT305512 1E14 1 0260 - 23 AT306350 2L19 2 2007 - 5
AT304147 3C24 41 2163 - 7 AT305513 1E16 25 0260 - 25 AT306366 2F20 10 1674 - 7
AT304147 3D2 41 2163 - 9 AT305524 2K4 23 1830 - 9 AT306388 3F23 9 4260 - 11
AT304148 3E18 5 3460 - 15 AT305547 2K14 12 1830 - 19 AT306446 3F2 16 3460 - 23
AT304149 3E18 6 3460 - 15 AT305548 3F6 5 3460 - 27 AT306503 3F13 34 4240 - 7
AT304150 3E20 8 3460 - 17 AT305624 2D8 5 0960 - 15 AT306505 3F13 36 4240 - 7
AT304151 3E20 9 3460 - 17 AT305625 2D8 6 0960 - 15 AT306509 3F13 19 4240 - 7
AT304295 2F8 5 1673 - 9 AT305627 2D19 7 1060 - 5 AT306536 2K23 7 1921 - 3
AT304327 1F13 15 0315 - 5 AT305628 3C18 10 2163 - 3 AT306539 2K19 12 1910 - 5
AT304373 3F2 15 3460 - 23 AT305630 3C18 11 2163 - 3 AT306605 1F2 22 0260 - 35
AT304479 2D17 17 1060 - 3 AT305639 1C7 6 0201 - 3 AT306612 2F2 7 1673 - 3
AT304480 2D17 23 1060 - 3 AT305663 2H22 5 1810 - 9 AT306632 2F2 8 1673 - 3
AT304615 1D2 1 0230 - 7 AT305667 2J10 14 1810 - 43 AT306681 2B8 6 0505 - 9
AT304630 2H18 10 1810 - 5 AT305667 2J12 14 1810 - 45 AT306682 2B8 7 0505 - 9
AT304630 2H20 6 1810 - 7 AT305698 2H22 6 1810 - 9 AT306749 2D19 16 1060 - 5
AT304633 2H18 11 1810 - 5 AT305734 2J8 47 1810 - 41 AT306771 2K17 15 1910 - 3
AT304633 2H20 7 1810 - 7 AT305738 3C18 12 2163 - 3 AT306772 2K17 16 1910 - 3
AT304634 2H18 11 1810 - 5 AT305739 2D19 8 1060 - 5 AT306816 2H2 6 1746 - 3
AT304634 2H20 7 1810 - 7 AT305740 2D19 9 1060 - 5 AT306846 2H2 1 1746 - 3
AT304635 2H18 10 1810 - 5 AT305741 2D19 10 1060 - 5 AT306847 2H4 1 1746 - 5
AT304635 2H20 6 1810 - 7 AT305768 2D4 12 0960 - 11 AT306848 2I20 6 1810 - 29
AT304638 2L7 10 2002 - 5 AT305769 3F6 6 3460 - 27 AT306848 2I22 7 1810 - 31
AT304788 2G10 4 1674 - 23 AT305770 3F19 5 4260 - 7 AT306944 2H6 8 1746 - 7
AT304794 2D4 11 0960 - 11 AT305770 3F21 6 4260 - 9 AT306953 2K23 8 1921 - 3
AT304862 3F4 9 3460 - 25 AT305771 3F19 6 4260 - 7 AT306967 2B12 18 0510 - 5
AT304888 3C24 42 2163 - 7 AT305771 3F21 7 4260 - 9 AT306968 2B12 19 0510 - 5
AT304888 3D2 42 2163 - 9 AT305831 1F2 13 0260 - 35 AT306973 2K23 9 1921 - 3
AT304953 2F22 13 1674 - 9 AT305832 1E22 12 0260 - 31 AT306974 2K23 11 1921 - 3
AT304967 3D2 43 2163 - 9 AT305833 1E22 13 0260 - 31 AT307031 2B12 12 0510 - 5
AT304974 2D24 12 1111 - 5 AT305834 1F2 14 0260 - 35 AT307045 1H7 15 0360 - 3
AT304996 2D24 13 1111 - 5 AT305854 2G18 1 1675 - 3 AT307045 3D4 5 2164 - 3
AT305018 2J8 14 1810 - 41 AT305869 2K4 24 1830 - 9 AT307054 2B8 9 0505 - 9
AT305048 1H7 14 0360 - 3 AT305916 3C24 44 2163 - 7 AT307061 2B12 13 0510 - 5
AT305049 1H7 17 0360 - 3 AT305926 2F14 7 1673 - 15 AT307062 2K12 18 1830 - 17
AT305051 2J8 11 1810 - 41 AT305927 2F16 10 1674 - 3 AT307083 2B14 14 0510 - 7
AT305052 2J8 12 1810 - 41 AT305928 2G2 10 1674 - 15 AT307090 2F4 6 1673 - 5
AT305053 1F2 21 0260 - 35 AT305929 2G4 5 1674 - 17 AT307096 2I24 45 1810 - 33
AT305054 3E22 24 3460 - 19 AT305930 2G4 6 1674 - 17 AT307096 2J2 45 1810 - 35
AT305055 3E22 13 3460 - 19 AT305931 2F10 5 1673 - 11 AT307165 1H11 5 0363 - 3
AT305057 2B18 28 0512 - 3 AT305931 2F14 9 1673 - 15 AT307200 1F15 2 0315 - 7
AT305070 2J8 13 1810 - 41 AT305932 2F12 4 1673 - 13 AT307220 3C20 10 2163 - 5
AT305110 3B5 9 2160 - 3 AT305934 2F6 4 1673 - 7 AT307220 3C22 10 2163 - 5B
AT305110 3B5 20 2160 - 3 AT305935 2F6 4 1673 - 7 AT307231 3C20 11 2163 - 5
AT305193 2L17 2 2007 - 3 AT305936 2F18 4 1674 - 5 AT307231 3C22 11 2163 - 5B
AT305277 3C24 43 2163 - 7 AT305939 2J10 15 1810 - 43 AT307263 3C20 6 2163 - 5
AT305297 2J8 16 1810 - 41 AT305939 2J12 15 1810 - 45 AT307275 2G25 6 1740 - 7
AT305310 2J8 19 1810 - 41 AT305981 3D6 1 2164 - 5 AT307279 2B8 10 0505 - 9
AT305363 3D18 7 3440 - 3 AT305991 2D10 5 0960 - 17 AT307292 3D6 7 2164 - 5
AT305384 2G14 1 1674 - 27 AT305992 2D10 6 0960 - 17 AT307299 3C24 45 2163 - 7
II-4 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=612
 1L11 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
AT307299 3D2 45 2163 - 9 AT309911 2B16 11 0510 - 11 AT315906 2I6 7 1810 - 15
AT307300 3C24 46 2163 - 7 AT309952 2D4 13 0960 - 11 AT315909 2I6 8 1810 - 15
AT307300 3D2 46 2163 - 9 AT309953 2D12 10 0960 - 19 AT315910 2I6 14 1810 - 15
AT307326 3D22 12 3440 - 7 AT309957 1E16 1 0260 - 25 AT315980 3E22 18 3460 - 19
AT307343 2B14 16 0510 - 7 AT309959 1E16 7 0260 - 25 AT316249 2D12 13 0960 - 19
AT307351 2L13 6 2004 - 5 AT309961 3F2 18 3460 - 23 AT316267 2I8 4 1810 - 17
AT307361 2C8 8 0560 - 3 AT310272 1E16 14 0260 - 25 AT316321 2K21 3 1913 - 3
AT307458 3F23 10 4260 - 11 AT310278 3D10 3 3401 - 3 AT316322 2K21 4 1913 - 3
AT307459 3F23 11 4260 - 11 AT310373 2H16 1 1810 - 3 AT316323 2K21 7 1913 - 3
AT307501 2K6 21 1830 - 11 AT310374 2H16 1 1810 - 3 AT316324 2K21 8 1913 - 3
AT307581 1H7 11 0360 - 3 AT310375 2H16 1 1810 - 3 AT316715 2K19 13 1910 - 5
AT307582 1H7 12 0360 - 3 AT310377 1B19 1 0110 - 21 AT316746 2E17 1 1511 - 3
AT307588 1H7 13 0360 - 3 AT310795 2K14 14 1830 - 19 AT317063 2F22 10 1674 - 9
AT307628 2G14 2 1674 - 27 AT310810 2K14 15 1830 - 19 AT317166 1E16 35 0260 - 25
AT307650 2I10 10 1810 - 19 AT310939 2C2 9 0520 - 5 AT317287 3C8 1 2160 - 37
AT307650 2I12 10 1810 - 21 AT310959 1F4 20 0260 - 37 AT317288 3C8 1 2160 - 37
AT307668 2B16 10 0510 - 11 AT311425 3C24 49 2163 - 7 AT317289 3C8 1 2160 - 37
AT307707 1F4 19 0260 - 37 AT311425 3D2 49 2163 - 9 AT317290 3C8 1 2160 - 37
AT307723 2K23 12 1921 - 3 AT311431 2K17 9 1910 - 3 AT317291 3C8 1 2160 - 37
AT307730 3D14 1 3401 - 7 AT311438 2K17 8 1910 - 3 AT317293 3C8 1 2160 - 37
AT307731 3D14 1 3401 - 7 AT311872 2B12 20 0510 - 5 AT317304 3B15 13 2160 - 19
AT307732 3D16 1 3401 - 9 AT311915 2K17 11 1910 - 3 AT317304 3B21 16 2160 - 25
AT307733 3D16 1 3401 - 9 AT311916 2K17 14 1910 - 3 AT317304 3C2 16 2160 - 31
AT307760 1E4 16 0260 - 13 AT312053 2K17 7 1910 - 3 AT317304 3C4 19 2160 - 33
AT307775 1E4 19 0260 - 13 AT312058 2K12 22 1830 - 17 AT317304 3C6 18 2160 - 35
AT307779 2H22 11 1810 - 9 AT312106 1H9 4 0360 - 5 AT317305 3B15 13 2160 - 19
AT307780 2F2 9 1673 - 3 AT312107 1H9 5 0360 - 5 AT317305 3B17 14 2160 - 21
AT307807 2F16 11 1674 - 3 AT312431 2H6 5 1746 - 7 AT317305 3B19 13 2160 - 23
AT307807 2F16 12 1674 - 3 AT312607 1F11 4 0315 - 3 AT317305 3B21 16 2160 - 25
AT307810 2F22 16 1674 - 9 AT312910 1E20 15 0260 - 29 AT317305 3C4 19 2160 - 33
AT307811 3B9 1 2160 - 7 AT312912 1E20 16 0260 - 29 AT317306 3B23 1 2160 - 27
AT307845 3F2 17 3460 - 23 AT312995 2B10 3 0510 - 3 AT317308 3B21 22 2160 - 25
AT307847 2K12 19 1830 - 17 AT312997 3E22 17 3460 - 19 AT317309 3B21 22 2160 - 25
AT307888 2K12 20 1830 - 17 AT312998 1E16 33 0260 - 25 AT317310 3C6 19 2160 - 35
AT307889 2K12 21 1830 - 17 AT313338 2C18 22 0930 - 3 AT317312 3C6 19 2160 - 35
AT308017 2K4 22 1830 - 9 AT313340 1D5 5 0240 - 3 AT317313 3B19 14 2160 - 23
AT308073 1E12 6 0260 - 21 AT313342 1C23 4 0230 - 3 AT317314 3B17 15 2160 - 21
AT308110 2K23 14 1921 - 3 AT313352 2C18 16 0930 - 3 AT317315 3B15 14 2160 - 19
AT308196 2H16 1 1810 - 3 AT313362 1C23 6 0230 - 3 AT317316 3B15 14 2160 - 19
AT308197 2H16 1 1810 - 3 AT313362 1D5 9 0240 - 3 AT317317 3B15 14 2160 - 19
AT308199 2J14 3 1821 - 3 AT313425 1H11 11 0363 - 3 AT317318 3B15 14 2160 - 19
AT308199 2J18 3 1821 - 7 AT313541 2C18 17 0930 - 3 AT317319 3C4 20 2160 - 33
AT308274 3D4 7 2164 - 3 AT313542 2C18 18 0930 - 3 AT317321 3C2 18 2160 - 31
AT308283 2K6 26 1830 - 11 AT313691 2B18 38 0512 - 3 AT317322 3C4 20 2160 - 33
AT308314 2K4 32 1830 - 9 AT314363 2I10 11 1810 - 19 AT317323 3B25 1 2160 - 29
AT308399 2B18 32 0512 - 3 AT314364 2I10 12 1810 - 19 AT317328 3B15 2 2160 - 19
AT308628 2G10 5 1674 - 23 AT314364 2I12 12 1810 - 21 AT317328 3B19 2 2160 - 23
AT308795 2J14 25 1821 - 3 AT314624 1C23 19 0230 - 3 AT317328 3B21 4 2160 - 25
AT308795 2J18 25 1821 - 7 AT314624 2C20 25 0960 - 3 AT317328 3C2 2 2160 - 31
AT308796 2J14 26 1821 - 3 AT314624 2C22 6 0960 - 5 AT317328 3C4 2 2160 - 33
AT308796 2J18 26 1821 - 7 AT314667 2G6 7 1674 - 19 AT317328 3C6 2 2160 - 35
AT308797 2J14 28 1821 - 3 AT314814 2B22 2 0515 - 5 AT317329 3B23 7 2160 - 27
AT308797 2J18 28 1821 - 7 AT314827 2D17 11 1060 - 3 AT317330 3B25 7 2160 - 29
AT308909 3C24 47 2163 - 7 AT315249 2F12 8 1673 - 13 AT317331 3B23 8 2160 - 27
AT308909 3D2 47 2163 - 9 AT315250 2F12 9 1673 - 13 AT317331 3B25 8 2160 - 29
AT308935 2K4 33 1830 - 9 AT315334 2L21 6 2008 - 3 AT317339 3C10 19 2160 - 39
AT308941 2I12 11 1810 - 21 AT315341 2L21 1 2008 - 3 AT317482 3D22 15 3440 - 7
AT309043 2B18 35 0512 - 3 AT315465 2K6 37 1830 - 11 AT317483 3D22 17 3440 - 7
AT309234 3B11 6 2160 - 11 AT315712 3D22 14 3440 - 7 AT317484 3D22 18 3440 - 7
AT309235 3B11 5 2160 - 11 AT315715 2J14 7 1821 - 3 AT317485 3D22 21 3440 - 7
AT309379 2K23 15 1921 - 3 AT315715 2J18 7 1821 - 7 AT317539 2C2 8 0520 - 5
AT309380 2K23 13 1921 - 3 AT315761 2J14 8 1821 - 3 AT317542 1C25 16 0230 - 5
AT309672 2K6 27 1830 - 11 AT315761 2J18 8 1821 - 7 AT317543 1C25 35 0230 - 5
AT309711 1F2 19 0260 - 35 AT315844 2I8 2 1810 - 17 AT317562 2I16 8 1810 - 25
AT309711 3C24 48 2163 - 7 AT315881 3E22 25 3460 - 19 AT317581 2K19 14 1910 - 5
AT309711 3D2 48 2163 - 9 AT315896 2I8 3 1810 - 17 AT317595 1E18 1 0260 - 27
AT309837 2K4 34 1830 - 9 AT315903 2I6 6 1810 - 15 AT317637 1E18 1 0260 - 27
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-5
PN=613
 1L12 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
AT317654 2D17 12 1060 - 3 AT325944 2I2 6 1810 - 13 F1743R 1H25 11 0404 - 3
AT317655 2D17 13 1060 - 3 AT325944 2I4 3 1810 - 13B F2310018 1F22 14 0350 - 3
AT317734 2J12 7 1810 - 45 AT325944 2I4 5 1810 - 13B F2310018 1F24 20 0350 - 5
AT317735 2J12 7 1810 - 45 AT326525 3C22 6 2163 - 5B F23303 1G4 34 0350 - 9
AT317736 2J12 7 1810 - 45 AT326599 1D23 24 0260 - 7 F2710616 1F22 1 0350 - 3
AT317737 2J10 7 1810 - 43 AT326600 1D23 46 0260 - 7 F2710616 1F22 13 0350 - 3
AT317738 2J12 7 1810 - 45 AT37477 3C24 50 2163 - 7 F2710616 1F24 1 0350 - 5
AT317739 2J10 7 1810 - 43 AT37477 3D2 50 2163 - 9 F2710616 1F24 19 0350 - 5
AT317740 2J10 7 1810 - 43 AT38176 2K19 15 1910 - 5 F310063 1G4 24 0350 - 9
AT317741 2J10 7 1810 - 43 AT38449 2E22 13 1671 - 3 F3171R 1C13 7 0210 - 5
AT317742 2J10 7 1810 - 43 AT40729 1D15 16 0250 - 7 F3171R 1C15 13 0210 - 7
AT317742 3C10 9 2160 - 39 AT41188 2E22 14 1671 - 3 F3171R 1C15 16 0210 - 7
AT317743 2J12 7 1810 - 45 AT41245 3E14 25 3460 - 11 F3171R 1C15 18 0210 - 7
AT317744 2J10 7 1810 - 43 AT43231 1B3 2 0110 - 3 F3171R 1C15 21 0210 - 7
AT317744 2J12 7 1810 - 45 AT44582 1D15 14 0250 - 7 F3171R 1C16 3 0210 - 8
AT317749 3F9 29 4240 - 3 AT44583 1D15 15 0250 - 7 F3171R 1D17 11 0250 - 9
AT317778 2J10 16 1810 - 43 AT47241 3D14 10 3401 - 7 F37010010 1C16 11 0210 - 8
AT317778 2J12 16 1810 - 45 AT47241 3D16 12 3401 - 9 F37010016 1H4 11 0350 - 35
AT317778 3C10 11 2160 - 39 AT53440 2B24 5 0520 - 3 F37010020 1C16 4 0210 - 8
AT317808 1F20 1 0350 - 1 AT53440 2C2 7 0520 - 5 F37020114 1G4 12 0350 - 9
AT317809 1F20 1 0350 - 1 AT56659 3D2 51 2163 - 9 F37020122 1H4 13 0350 - 35
AT317820 3B17 2 2160 - 21 AT57326 1D5 16 0240 - 3 F37020123 1H4 14 0350 - 35
AT317822 3B21 5 2160 - 25 AT62699 2E14 2 1370 - 3 F37020124 1H4 15 0350 - 35
AT317822 3C2 3 2160 - 31 AT62703 2E14 3 1370 - 3 F37020144 1G10 3 0350 - 17
AT317822 3C4 3 2160 - 33 AT68940 1B5 2 0110 - 5 F37020144 1G12 3 0350 - 19
AT317886 1E10 76 0260 - 19 AT72157 1D15 10 0250 - 7 F37020144 1G14 3 0350 - 21
AT317887 1E4 20 0260 - 13 AT78527 3C2 4 2160 - 31 F37020144 1G16 3 0350 - 23
AT317889 1E8 13 0260 - 17 AT78527 3C4 4 2160 - 33 F37020153 1C16 10 0210 - 8
AT317889 1E10 95 0260 - 19 AT78527 3C6 3 2160 - 35 F37020159 1E4 22 0260 - 13
AT317891 1E4 21 0260 - 13 AT78527 3C10 23 2160 - 39 F37020159 1G4 22 0350 - 9
AT317979 2I24 48 1810 - 33 AT79195 2D24 14 1111 - 5 F37020159 1H5 2 0350 - 36
AT317979 2J2 48 1810 - 35 AT83306 1E20 17 0260 - 29 F37020159 3B5 21 2160 - 3
AT317980 2I24 49 1810 - 33 AZ42092 1E20 19 0260 - 29 F37030219 1F22 15 0350 - 3
AT317981 2I24 11 1810 - 33 AZ42092 1F6 14 0260 - 39 F37030219 1F24 22 0350 - 5
AT317981 2J2 11 1810 - 35 A4365R 1H25 18 0404 - 3 F37030219 1G6 6 0350 - 13
AT317982 2J2 12 1810 - 35 A4365R 1J16 7 0433 - 3 F37030226 1F22 8 0350 - 3
AT317983 2I24 13 1810 - 33 A4540R 1C13 15 0210 - 5 F37030226 1F24 13 0350 - 5
AT317984 2J2 14 1810 - 35 A48970 2I6 4 1810 - 15 F37030226 1G4 8 0350 - 9
AT317985 2I24 15 1810 - 33 B2976R 2H18 12 1810 - 5 F37030226 1G6 3 0350 - 13
AT318171 2C8 11 0560 - 3 B3690R 1F22 8 0350 - 3 F37030239 1G4 26 0350 - 9
AT318528 3F21 8 4260 - 9 CE17368 1D23 5 0260 - 7 F37030244G 1G10 20 0350 - 17
AT318529 3F23 18 4260 - 11 CE17879 3E2 33 3450 - 3 F37030244G 1G12 20 0350 - 19
AT318620 2F8 13 1673 - 9 CE17879 3E4 33 3450 - 5 F37030250 1E2 5 0260 - 11
AT318649 2B12 21 0510 - 5 C16054 2D6 10 0960 - 13 F37030275 1G22 5 0350 - 29
AT318798 2K12 23 1830 - 17 C16054 3E18 7 3460 - 15 F37060906 1H4 6 0350 - 35
AT318987 2K8 7 1830 - 13 C16054 3F6 7 3460 - 27 F37060910 1H4 10 0350 - 35
AT319023 3C4 21 2160 - 33 C16054 3F23 12 4260 - 11 F37060912 1G2 6 0350 - 7
AT319023 3C10 16 2160 - 39 DE18970 1D11 21 0250 - 3 F37060920 1G6 4 0350 - 13
AT319115 1E2 15 0260 - 11 DE19507 1D23 37 0260 - 7 F39000106 3B5 26 2160 - 3
AT319117 1D25 19 0260 - 9 E12379 1C23 11 0230 - 3 F39000175 1G4 19 0350 - 9
AT319117 1E2 19 0260 - 11 E12379 1D5 10 0240 - 3 F39000315 1F24 23 0350 - 5
AT320176 1F6 15 0260 - 39 E12379 2E14 4 1370 - 3 F40110 1G10 16 0350 - 17
AT320179 1F6 7 0260 - 39 E1343FN 1H23 1 0403 - 1 F40110 1G12 16 0350 - 19
AT320198 1F6 6 0260 - 39 E14814 3E2 3 3450 - 3 F40110 1G16 16 0350 - 23
AT320199 1F6 5 0260 - 39 E14814 3E4 3 3450 - 5 F40111 1F22 4 0350 - 3
AT320236 2K19 16 1910 - 5 E46066 2K14 17 1830 - 19 F40111 1F24 5 0350 - 5
AT320242 1H11 6 0363 - 3 E52817 3F13 11 4240 - 7 F40211R 1F24 6 0350 - 5
AT320243 1H11 8 0363 - 3 E55662 1E18 2 0260 - 27 F7400014D 1G2 7 0350 - 7
AT320484 2B12 32 0510 - 5 E55662 1J9 16 0422 - 3 F81696 1G10 18 0350 - 17
AT320496 2G21 4 1740 - 3 E65288 3B5 63 2160 - 3 F81696 1G12 18 0350 - 19
AT322428 2I24 47 1810 - 33 E69975 1F2 16 0260 - 35 F81696 1G14 18 0350 - 21
AT322428 2J2 47 1810 - 35 E69975 2B16 15 0510 - 11 F81696 1G16 18 0350 - 23
AT322617 3C10 20 2160 - 39 E69975 3D6 10 2164 - 5 F81743 1G10 8 0350 - 17
AT322881 2J6 4 1810 - 39 F1430R 3E10 3 3460 - 7 F81743 1G12 8 0350 - 19
AT325943 2I2 6 1810 - 13 F1430R 3E12 3 3460 - 9 F81743 1G14 7 0350 - 21
AT325943 2I4 3 1810 - 13B F1430R 3E14 4 3460 - 11 F81743 1G16 7 0350 - 23
AT325943 2I4 5 1810 - 13B F1743R 1H22 18 0402 - 6 F85004 1F22 1 0350 - 3
II-6 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=614
 1L13 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
F85006 1H4 6 0350 - 35 H170539 3E10 14 3460 - 7 H871 1C19 24 0210 - 11
F85108 1F24 1 0350 - 5 H170539 3E12 14 3460 - 9 H871R 1C19 24 0210 - 11
F85108 1G4 29 0350 - 9 H170539 3F15 18 4240 - 9 JD10024 3E2 4 3450 - 3
F85112 1G2 6 0350 - 7 H170541 3F11 16 4240 - 5 JD10144 3E2 5 3450 - 3
F85120 1F22 9 0350 - 3 H171332 2D2 14 0960 - 9 JD10144 3E4 5 3450 - 5
F85120 1F24 14 0350 - 5 H173411 2H16 2 1810 - 3 JD10423 1D13 24 0250 - 5
F85120 1G6 4 0350 - 13 H173411 2I10 14 1810 - 19 JD5756 2E3 2 1320 - 3
F950R 2C20 7 0960 - 3 H173411 2I12 14 1810 - 21 JD5822 2E3 3 1320 - 3
F950R 2C22 20 0960 - 5 H173411 2I16 9 1810 - 25 JD5920 3F13 29 4240 - 7
F950R 2C24 18 0960 - 7 H173411 2J8 39 1810 - 41 JD5921 2E3 4 1320 - 3
F950R 3E16 5 3460 - 13 H173411 2J14 33 1821 - 3 JD5921 3F13 30 4240 - 7
F950R 3F15 6 4240 - 9 H173411 2J18 33 1821 - 7 JD5929 2L21 9 2008 - 3
GY20126 2F22 18 1674 - 9 H179659 3F11 7 4240 - 5 JD5938 2E3 31 1320 - 3
H110232 2I24 16 1810 - 33 H180080 2C20 4 0960 - 3 JD7759 1C23 12 0230 - 3
H110232 2J2 16 1810 - 35 H180080 2C22 16 0960 - 5 JD7759 1C23 28 0230 - 3
H113924 2I20 8 1810 - 29 H180080 2C24 24 0960 - 7 JD7759 1D5 11 0240 - 3
H114865 2K12 24 1830 - 17 H180080 3E16 7 3460 - 13 JD7759 1D9 2 0240 - 7
H122182 1E16 5 0260 - 25 H180080 3F15 8 4240 - 9 JD7759 2C20 26 0960 - 3
H131531 2K6 38 1830 - 11 H180094 2C20 5 0960 - 3 JD7759 3D22 24 3440 - 7
H134114 3C24 64 2163 - 7 H180094 2C22 18 0960 - 5 JD7771 1D23 2 0260 - 7
H140461 2F8 4 1673 - 9 H180094 2C24 16 0960 - 7 JD7781 1C9 13 0201 - 5
H140461 2F10 13 1673 - 11 H180094 3E16 8 3460 - 13 JD7781 1C23 27 0230 - 3
H140461 2I10 7 1810 - 19 H180094 3F15 9 4240 - 9 JD7781 1C25 31 0230 - 5
H140461 2I12 7 1810 - 21 H180100 3F11 8 4240 - 5 JD7781 3D18 9 3440 - 3
H140461 2I16 7 1810 - 25 H180103 3E10 5 3460 - 7 JD7781 3D22 25 3440 - 7
H140461 2L3 6 2001 - 3 H180103 3E12 5 3460 - 9 JD7781 3F9 21 4240 - 3
H142036 3E10 13 3460 - 7 H180103 3E14 7 3460 - 11 JD7782 3D22 26 3440 - 7
H142036 3E12 13 3460 - 9 H206859 3E10 6 3460 - 7 JD7797 1C23 14 0230 - 3
H145104 2C20 2 0960 - 3 H206859 3E12 6 3460 - 9 JD7797 1D5 12 0240 - 3
H145104 2C22 11 0960 - 5 H206859 3E14 9 3460 - 11 JD7797 2E14 6 1370 - 3
H145175 3E16 14 3460 - 13 H208631 3E10 21 3460 - 7 JD7798 1C23 18 0230 - 3
H148166 3D6 4 2164 - 5 H208631 3E12 21 3460 - 9 JD7798 1D23 22 0260 - 7
H150941 1C7 1 0201 - 3 H208987 2C20 8 0960 - 3 JD7798 2C22 8 0960 - 5
H150956 2D2 17 0960 - 9 H208987 2C22 14 0960 - 5 JD7798 3E12 24 3460 - 9
H152202 3E14 5 3460 - 11 H208987 2C24 13 0960 - 7 JD7798 3E16 26 3460 - 13
H152203 2C20 9 0960 - 3 H208987 3E10 7 3460 - 7 JD7798 3F13 12 4240 - 7
H152203 2C22 21 0960 - 5 H208987 3E12 7 3460 - 9 JD7799 2C24 7 0960 - 7
H152203 2C24 19 0960 - 7 H208987 3E16 9 3460 - 13 JD7799 3E16 27 3460 - 13
H152203 3E10 4 3460 - 7 H208987 3F15 10 4240 - 9 JD7799 3F9 17 4240 - 3
H152203 3E12 4 3460 - 9 H208987 3F15 15 4240 - 9 JD7799 3F11 20 4240 - 5
H152203 3E16 6 3460 - 13 H208995 2C24 14 0960 - 7 JD7799 3F13 13 4240 - 7
H152203 3F15 7 4240 - 9 H208995 3E16 4 3460 - 13 JD7838 1C7 23 0201 - 3
H152204 3F11 4 4240 - 5 H208995 3F15 12 4240 - 9 JD7844 3E10 24 3460 - 7
H152795 3F11 5 4240 - 5 H208999 3E14 10 3460 - 11 JD8240 3E2 6 3450 - 3
H154514 2D2 9 0960 - 9 H210841 3F11 9 4240 - 5 JD8240 3E4 6 3450 - 5
H154856 2C22 26 0960 - 5 H21259 2E3 1 1320 - 3 JD8255 1C13 12 0210 - 5
H154856 2C24 5 0960 - 7 H61354 3C24 19 2163 - 7 JD8272 1C9 4 0201 - 5
H154856 3E10 17 3460 - 7 H61354 3D2 19 2163 - 9 JD8962 1D15 9 0250 - 7
H154856 3E12 17 3460 - 9 H77698 1E16 29 0260 - 25 JD8989 1C9 3 0201 - 5
H154856 3E16 22 3460 - 13 H77698 1F2 17 0260 - 35 JD9021 3E2 7 3450 - 3
H154856 3F15 14 4240 - 9 H77698 2B4 2 0505 - 3 JD9048 1C25 18 0230 - 5
H155629 3E14 3 3460 - 11 H77698 2B8 12 0505 - 9 JD9078 1C13 13 0210 - 5
H155630 3F11 17 4240 - 5 H77698 2B14 22 0510 - 7 JD9080 1D15 6 0250 - 7
H155964 2D2 10 0960 - 9 H77698 2D6 12 0960 - 13 JD9082 1C25 19 0230 - 5
H156058 2D2 11 0960 - 9 H77698 2F20 11 1674 - 7 JD9082 3E4 4 3450 - 5
H157898 3E14 6 3460 - 11 H77698 2F22 20 1674 - 9 JD9113 1C25 20 0230 - 5
H164204 2D2 12 0960 - 9 H77698 2G2 11 1674 - 15 JD9120 1D15 8 0250 - 7
H164205 2D2 13 0960 - 9 H77698 2K12 25 1830 - 17 JD9134 3E2 8 3450 - 3
H168248 2C20 12 0960 - 3 H77698 2K21 6 1913 - 3 JD9134 3E4 8 3450 - 5
H168248 3E16 18 3460 - 13 H77698 3F23 13 4260 - 11 JD9138 1D15 7 0250 - 7
H168249 2C20 13 0960 - 3 H79910 1J16 9 0433 - 3 JD9141 1C25 21 0230 - 5
H168249 3E16 19 3460 - 13 H80936 1C23 29 0230 - 3 JD9141 3E4 7 3450 - 5
H170535 2D2 18 0960 - 9 H80936 1C25 30 0230 - 5 J16931 2K17 17 1910 - 3
H170538 3E14 14 3460 - 11 H80936 2C22 7 0960 - 5 K40014 3F2 19 3460 - 23
H170539 2C20 15 0960 - 3 H80936 2E14 5 1370 - 3 K40014 3F9 22 4240 - 3
H170539 2C22 24 0960 - 5 H85092 2K8 4 1830 - 13 K40017 3D24 8 3440 - 9
H170539 2C24 22 0960 - 7 H85233 2K17 13 1910 - 3 L100913 2B8 13 0505 - 9
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-7
PN=615
 1L14 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
L102023 2I10 15 1810 - 19 RE174764 2K8 21 1830 - 13 RE505154 1I20 36 0413 - 3
L102023 2I12 15 1810 - 21 RE177967 2K8 22 1830 - 13 RE505155 1I20 35 0413 - 3
L152397 2I24 34 1810 - 33 RE187311 2K8 16 1830 - 13 RE505264 1J11 2 0423 - 3
L155075 2F22 19 1674 - 9 RE190139 2L3 12 2001 - 3 RE505265 2K12 33 1830 - 17
L57881 2K14 42 1830 - 19 RE190140 2L3 12 2001 - 3 RE505399 1J9 6 0422 - 3
L77943 2K8 18 1830 - 13 RE19429 2B24 3 0520 - 3 RE506103 1J9 12 0422 - 3
M115279 2G14 10 1674 - 27 RE198074 2K8 5 1830 - 13 RE506103 1J9 15 0422 - 3
M115279 2I20 9 1810 - 29 RE20230 1I25 5 0416 - 3 RE506501 1I15 9 0409 - 3
M118611 2E3 5 1320 - 3 RE211000 2C18 19 0930 - 3 RE506624 1I20 27 0413 - 3
M142218 2J6 2 1810 - 39 RE227953 2L3 12 2001 - 3 RE506660 1I2 1 0404 - 5
M142219 2J6 3 1810 - 39 RE234261 1G22 9 0350 - 29 RE507003 1I20 26 0413 - 3
M142955 2C4 3 0530 - 3 RE24045 1H19 7 0402 - 3 RE509012 1I20 17 0413 - 3
M145875 2J8 29 1810 - 41 RE24046 1H19 6 0402 - 3 RE509013 1I20 18 0413 - 3
M40509 2B14 23 0510 - 7 RE28364 3E16 15 3460 - 13 RE509048 1H21 12 0402 - 5
M40509 3F2 20 3460 - 23 RE31702 1C25 23 0230 - 5 RE509095 1J4 12 0418 - 3
M44162 2D2 15 0960 - 9 RE36349 3E14 15 3460 - 11 RE509265 1H21 16 0402 - 5
M453T 2J14 24 1821 - 3 RE37331 3E10 15 3460 - 7 RE509416 1I20 9 0413 - 3
M453T 2J18 24 1821 - 7 RE37382 3E12 15 3460 - 9 RE509463 1J2 6 0417 - 3
M45387 1D25 12 0260 - 9 RE37693 2C24 10 0960 - 7 RE509668 1J7 4 0420 - 3
M45387 3B5 59 2160 - 3 RE38310 1H2 8 0350 - 33 RE515331 1I23 8 0414 - 1
M47566 2H22 8 1810 - 9 RE38310 1H4 7 0350 - 35 RE515331 2B4 9 0505 - 3
M74600 1D25 5 0260 - 9 RE38310 3D6 11 2164 - 5 RE515524 1I20 10 0413 - 3
M74600 1E2 17 0260 - 11 RE39134 1J2 7 0417 - 3 RE515636 1I20 30 0413 - 3
M74782 2K8 9 1830 - 13 RE39224 2G8 5 1674 - 21 RE515638 1I22 53 0413 - 5
M74877 1D25 11 0260 - 9 RE40048 1I18 5 0410 - 2 RE515781 1J5 8 0419 - 1
M74877 3B5 60 2160 - 3 RE43497 2K14 24 1830 - 19 RE516171 1J18 17 0452 - 3
M82772 2G8 7 1674 - 21 RE45315 1C10 1 0210 - 2 RE51629 2B24 12 0520 - 3
M84972 2J8 40 1810 - 41 RE45315 1C13 14 0210 - 5 RE51630 2B24 11 0520 - 3
M84972 2K8 11 1830 - 13 RE45317 1C10 2 0210 - 2 RE516335 1I20 29 0413 - 3
M86690 2F2 10 1673 - 3 RE46684 1I23 4 0414 - 1 RE517059 1H22 7 0402 - 6
M87571 1F2 15 0260 - 35 RE46742 2K14 25 1830 - 19 RE517370 1H22 16 0402 - 6
M87571 3D6 9 2164 - 5 RE46743 2K14 26 1830 - 19 RE518726 1I20 5 0413 - 3
M87683 2B8 14 0505 - 9 RE48419 1J7 25 0420 - 3 RE519144 2C11 1 0578 - 1
N119177 2J14 29 1821 - 3 RE49486 1C13 1 0210 - 5 RE519877 2B20 4 0515 - 3
N119177 2J18 29 1821 - 7 RE49624 3B23 4 2160 - 27 RE519894 1I15 15 0409 - 3
N126638 1E10 26 0260 - 19 RE49624 3C4 9 2160 - 33 RE520036 1J16 21 0433 - 3
N131806 1F24 8 0350 - 5 RE49624 3C6 8 2160 - 35 RE520585 1I10 2 0407 - 6
N189220 2F20 12 1674 - 7 RE500216 1I5 1 0407 - 1 RE520628 1I12 10 0407 - 9
N189220 2K4 39 1830 - 9 RE500882 1I23 .. 0414 - 1 RE520910 1I25 4 0416 - 3
N198631 2F22 33 1674 - 9 RE50114 1C11 1 0210 - 3 RE520930 1I20 31 0413 - 3
N203952 3B5 11 2160 - 3 RE501513 1H23 5 0403 - 1 RE520967 1J7 36 0420 - 3
N223292 3B9 8 2160 - 7 RE501513 1I4 1 0404 - 7 RE520968 1J7 37 0420 - 3
N231749 3D18 10 3440 - 3 RE501669 1I25 4 0416 - 3 RE520969 1J7 10 0420 - 3
N237603 3D24 9 3440 - 9 RE502570 1J4 2 0418 - 3 RE520971 1J7 26 0420 - 3
N275650 2K12 26 1830 - 17 RE502650 1I20 19 0413 - 3 RE520972 1J7 33 0420 - 3
N278790 2J10 4 1810 - 43 RE502654 1I20 34 0413 - 3 RE520975 1J7 8 0420 - 3
N278790 2J12 4 1810 - 45 RE502655 1I20 16 0413 - 3 RE520978 1I22 50 0413 - 5
N279068 2K17 26 1910 - 3 RE503059 1I20 39 0413 - 3 RE520981 1J7 9 0420 - 3
N306880 1E2 1 0260 - 11 RE503528 1H23 8 0403 - 1 RE521058 1I4 1 0404 - 7
N306881 1E2 7 0260 - 11 RE504013 1I20 15 0413 - 3 RE521058 1J18 30 0452 - 3
N306882 1D25 10 0260 - 9 RE504014 1I20 14 0413 - 3 RE521059 1J18 17 0452 - 3
N306885 1E2 10 0260 - 11 RE504015 1I20 13 0413 - 3 RE521154 1I4 1 0404 - 7
N306886 1E2 11 0260 - 11 RE504016 1I20 12 0413 - 3 RE521278 1H19 8 0402 - 3
N306887 1E2 12 0260 - 11 RE504017 1I20 11 0413 - 3 RE521420 1I12 10 0407 - 9
PT11778 2K8 17 1830 - 13 RE504156 1I22 41 0413 - 5 RE521423 1I22 56 0413 - 5
P46051 1H7 16 0360 - 3 RE504195 1H16 3 0401 - 2 RE521433 1I20 32 0413 - 3
P46051 3D4 6 2164 - 3 RE504196 1H16 3 0401 - 2 RE521473 1J7 29 0420 - 3
P50631 1F19 8 0341 - 3 RE504197 1H16 3 0401 - 2 RE521476 1I20 23 0413 - 3
P50631 1F24 13 0350 - 5 RE504198 1H16 2 0401 - 2 RE521477 1I20 25 0413 - 3
P50631 1G4 8 0350 - 9 RE504199 1H16 2 0401 - 2 RE521496 1J2 5 0417 - 3
P50631 1G6 3 0350 - 13 RE504200 1H16 2 0401 - 2 RE521502 1J2 8 0417 - 3
RE12119 1G4 11 0350 - 9 RE504245 1J9 12 0422 - 3 RE522143 1J7 32 0420 - 3
RE12362 1J9 5 0422 - 3 RE504581 1I12 23 0407 - 9 RE522144 1J7 42 0420 - 3
RE12363 2K10 9 1830 - 15 RE504581 1I25 9 0416 - 3 RE522145 1J7 15 0420 - 3
RE151433 2C13 1 0578 - 3 RE504822 1J18 27 0452 - 3 RE522515 1I22 57 0413 - 5
RE157329 2K14 23 1830 - 19 RE505094 1H21 9 0402 - 5 RE522516 2C10 3 0575 - 3
RE167207 2C15 1 0578 - 5 RE505124 1H15 5 0401 - 1 RE522518 1J7 12 0420 - 3
II-8 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=616
 1L15 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
RE522616 1I22 51 0413 - 5 R100569 1J18 28 0452 - 3 R120752 1H15 3 0401 - 1
RE522649 1I7 4 0407 - 3 R100671 1J4 5 0418 - 3 R120872 1H17 3 0402 - 1
RE522685 1J7 20 0420 - 3 R10093 2K12 27 1830 - 17 R120953 1H25 21 0404 - 3
RE522685 2C12 3 0578 - 2 R10093 2K14 18 1830 - 19 R120954 1H25 21 0404 - 3
RE522686 1J7 21 0420 - 3 R104587 1H15 4 0401 - 1 R121193 1I15 11 0409 - 3
RE522687 1J7 22 0420 - 3 R104589 1H17 6 0402 - 1 R121316 1J2 9 0417 - 3
RE522688 1J7 17 0420 - 3 R104628 1I9 14 0407 - 5 R121338 1H23 7 0403 - 1
RE522834 1I20 38 0413 - 3 R104628 1I10 3 0407 - 6 R121490 1I15 6 0409 - 3
RE523578 1J7 34 0420 - 3 R104846 1J7 19 0420 - 3 R121491 1I15 5 0409 - 3
RE523825 1I22 58 0413 - 5 R104846 2C12 1 0578 - 2 R121694 1J16 3 0433 - 3
RE523825 2B16 16 0510 - 11 R104859 1H22 5 0402 - 6 R121765 1H25 3 0404 - 3
RE524007 1I13 3 0407 - 10 R105346 1I25 11 0416 - 3 R121765 1I2 1 0404 - 5
RE524105 1J5 12 0419 - 1 R105346 1J18 4 0452 - 3 R121765 1I5 2 0407 - 1
RE52454 2K10 4 1830 - 15 R106789 1C15 10 0210 - 7 R122595 1I17 2 0410 - 1
RE524660 1I22 55 0413 - 5 R106998 1J12 7 0429 - 1 R122618 1I25 12 0416 - 3
RE524764 1I25 16 0416 - 3 R108997 1D17 3 0250 - 9 R123459 2E24 15 1672 - 3
RE52506 2K10 1 1830 - 15 R109625 1J18 26 0452 - 3 R124186 1I12 13 0407 - 9
RE52507 2K10 10 1830 - 15 R109691 3C14 3 2160 - 43 R124381 1H16 1 0401 - 2
RE52508 2K10 7 1830 - 15 R110126 1H17 2 0402 - 1 R124842 1H16 1 0401 - 2
RE52509 2K10 11 1830 - 15 R110126 1H19 10 0402 - 3 R125027 1J16 19 0433 - 3
RE52702 2B14 25 0510 - 7 R11086 1H22 6 0402 - 6 R125223 2K8 3 1830 - 13
RE52702 3C24 51 2163 - 7 R11086 1J2 10 0417 - 3 R125223 2K14 20 1830 - 19
RE53823 1C19 6 0210 - 11 R111238 3B15 3 2160 - 19 R125454 2K8 26 1830 - 13
RE55423 2K10 3 1830 - 15 R111238 3B17 4 2160 - 21 R126117 1C13 9 0210 - 5
RE55475 1I15 16 0409 - 3 R111238 3B19 3 2160 - 23 R126812 1I25 16 0416 - 3
RE55475 1J18 10 0452 - 3 R111238 3B21 6 2160 - 25 R127425 1I17 1 0410 - 1
RE56165 2G8 9 1674 - 21 R111238 3C2 6 2160 - 31 R127426 1I17 3 0410 - 1
RE56489 2G8 5 1674 - 21 R111238 3C4 6 2160 - 33 R127563 1I18 1 0410 - 2
RE57054 1H17 3 0402 - 1 R111238 3C6 5 2160 - 35 R128694 1I12 2 0407 - 9
RE57167 1H23 7 0403 - 1 R112079 1D17 2 0250 - 9 R129628 2D15 2 1011 - 3
RE57561 1I12 1 0407 - 9 R112210 1C15 4 0210 - 7 R129820 1I12 18 0407 - 9
RE57561 1I25 9 0416 - 3 R112210 1C19 28 0210 - 11 R129821 1I12 16 0407 - 9
RE57603 1J12 3 0429 - 1 R112268 1H22 10 0402 - 6 R130036 1C19 34 0210 - 11
RE57836 1H25 5 0404 - 3 R112268 1J11 17 0423 - 3 R130573 1I23 5 0414 - 1
RE57836 1J2 4 0417 - 3 R112883 1J14 1 0433 - 1 R130573 1J18 5 0452 - 3
RE57836 1J4 7 0418 - 3 R113050 2K8 19 1830 - 13 R130573 2B4 10 0505 - 3
RE57836 1J16 14 0433 - 3 R113050 2K12 40 1830 - 17 R131001 1J13 1 0429 - 2
RE60700 3C12 7 2160 - 41 R114837 1J11 3 0423 - 3 R131002 1J11 12 0423 - 3
RE60700 3C24 57 2163 - 7 R115129 1H22 3 0402 - 6 R131051 1I20 7 0413 - 3
RE60700 3D2 57 2163 - 9 R115176 1C17 4 0210 - 9 R131051 1J18 12 0452 - 3
RE60701 3C18 14 2163 - 3 R115742 2K10 2 1830 - 15 R131113 1D17 7 0250 - 9
RE61253 1H16 1 0401 - 2 R115743 2K10 8 1830 - 15 R131114 1D17 12 0250 - 9
RE61812 2C14 1 0578 - 4 R116081 1H23 7 0403 - 1 R131225 2D15 1 1011 - 3
RE61851 1H16 1 0401 - 2 R116214 1C19 12 0210 - 11 R131890 1H22 9 0402 - 6
RE62981 1C15 3 0210 - 7 R116261 1C13 9 0210 - 5 R131890 1J11 16 0423 - 3
RE64509 1H23 10 0403 - 1 R116311 1H15 6 0401 - 1 R132396 1J18 18 0452 - 3
RE64509 1I4 1 0404 - 7 R116311 1J12 2 0429 - 1 R132574 1C15 6 0210 - 7
RE65008 2D15 5 1011 - 3 R116718 1I9 12 0407 - 5 R132574 1C19 31 0210 - 11
RE66693 1I23 8 0414 - 1 R116718 1I13 6 0407 - 10 R132968 2E24 16 1672 - 3
RE66693 1I23 .. 0414 - 1 R116801 1C15 14 0210 - 7 R133307 1I18 6 0410 - 2
RE66693 2B4 14 0505 - 3 R116801 1C15 17 0210 - 7 R133998 1J4 8 0418 - 3
RE68715 1J11 4 0423 - 3 R117073 1I12 6 0407 - 9 R134028 1I25 4 0416 - 3
RE69328 1I25 13 0416 - 3 R117721 2B8 15 0505 - 9 R134098 2I14 1 1810 - 23
RE70678 1J9 3 0422 - 3 R117721 2J24 4 1830 - 3 R134098 2I20 10 1810 - 29
RE70682 1J9 4 0422 - 3 R117721 2K14 19 1830 - 19 R134098 2K6 40 1830 - 11
RE70688 1H23 10 0403 - 1 R117879 2K19 16 1910 - 5 R134726 1C19 18 0210 - 11
RE70688 1I2 1 0404 - 5 R119132 1I15 13 0409 - 3 R134920 1H21 17 0402 - 5
RE70688 1I4 1 0404 - 7 R119383 1J2 1 0417 - 3 R134920 1I20 4 0413 - 3
RE70756 1J9 11 0422 - 3 R119383 1J18 15 0452 - 3 R135509 1J9 1 0422 - 3
RE71255 1H25 12 0404 - 3 R119384 1H22 2 0402 - 6 R135510 1J9 2 0422 - 3
RE71255 1I12 22 0407 - 9 R119384 1J18 24 0452 - 3 R135543 1C9 14 0201 - 5
RE71255 1I23 6 0414 - 1 R119847 1I12 12 0407 - 9 R135543 1C9 22 0201 - 5
RE71256 1J9 .. 0422 - 3 R120030 1H15 5 0401 - 1 R135543 1C13 5 0210 - 5
R100500 1C10 1 0210 - 2 R120467 1H21 5 0402 - 5 R135543 1D15 21 0250 - 7
R100500 1C13 14 0210 - 5 R120653 2H18 13 1810 - 5 R135608 2E24 15 1672 - 3
R100569 1I9 10 0407 - 5 R120653 2H20 8 1810 - 7 R135895 1I7 10 0407 - 3
R100569 1I10 1 0407 - 6 R120653 2H22 7 1810 - 9 R136052 1J9 .. 0422 - 3
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-9
PN=617
 1L16 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
R136063 1J18 13 0452 - 3 R26448 3C12 4 2160 - 41 R35367 1C13 2 0210 - 5
R136151 1J4 1 0418 - 3 R26448 3E2 28 3450 - 3 R36545 2E22 16 1671 - 3
R150895 2D15 6 1011 - 3 R26448 3E4 28 3450 - 5 R36636 3C24 55 2163 - 7
R1612R 1H25 10 0404 - 3 R26448 3E20 6 3460 - 17 R37023 3C24 22 2163 - 7
R162769 2K8 12 1830 - 13 R26448 3F2 4 3460 - 23 R37023 3D2 22 2163 - 9
R163985 2K8 24 1830 - 13 R26650 1D11 18 0250 - 3 R37287 3E2 9 3450 - 3
R164193 2B14 15 0510 - 7 R26906 1E24 6 0260 - 33 R37287 3E4 9 3450 - 5
R184863 2B16 17 0510 - 11 R26906 1I7 6 0407 - 3 R375R 1C15 22 0210 - 7
R190722 2K8 14 1830 - 13 R26906 3B17 3 2160 - 21 R39112 1C15 2 0210 - 7
R190723 2K8 23 1830 - 13 R26906 3C24 20 2163 - 7 R39112 1J16 1 0433 - 3
R192109 2K14 21 1830 - 19 R26906 3D2 20 2163 - 9 R39112 3C4 11 2160 - 33
R203687 2K14 46 1830 - 19 R26906 3F4 2 3460 - 25 R39112 3C6 10 2160 - 35
R21612 1C15 12 0210 - 7 R27149 1H25 16 0404 - 3 R39112 3C10 22 2160 - 39
R244664 2K8 23A 1830 - 13 R27149 1J16 5 0433 - 3 R39112 3E2 27 3450 - 3
R26058 1J18 29 0452 - 3 R27175 1C13 8 0210 - 5 R39112 3E4 27 3450 - 5
R26286 1E4 23 0260 - 13 R27175 1C15 15 0210 - 7 R39503 1J2 16 0417 - 3
R26286 1F6 11 0260 - 39 R27175 1C16 2 0210 - 8 R39554 2G14 11 1674 - 27
R26286 1H2 9 0350 - 33 R27175 3C24 53 2163 - 7 R39741 1H25 6 0404 - 3
R26286 1H4 8 0350 - 35 R27218 1C13 4 0210 - 5 R40236 1I13 5 0407 - 10
R26286 2B16 18 0510 - 11 R27218 3E2 29 3450 - 3 R41934 1H15 2 0401 - 1
R26287 1C16 12 0210 - 8 R27218 3E4 29 3450 - 5 R41985 2J24 3 1830 - 3
R26287 1C17 5 0210 - 9 R27315 1C15 19 0210 - 7 R42340 1H25 9 0404 - 3
R26287 1F4 18 0260 - 37 R27315 1D17 15 0250 - 9 R43409 1H25 1 0404 - 3
R26287 2D17 28 1060 - 3 R27315 2D15 4 1011 - 3 R43583 2B14 24 0510 - 7
R26287 2D22 8 1111 - 3 R27443 1H19 4 0402 - 3 R43621 1H25 13 0404 - 3
R26333 1J12 4 0429 - 1 R27474 1I7 1 0407 - 3 R43660 1I12 9 0407 - 9
R26375 1C15 1 0210 - 7 R27474 3C24 54 2163 - 7 R44302 2B6 16 0505 - 5
R26375 1E16 32 0260 - 25 R27474 3D2 54 2163 - 9 R44302 2F8 14 1673 - 9
R26375 1E20 5 0260 - 29 R28193 2L3 10 2001 - 3 R44302 2F10 6 1673 - 11
R26375 1E22 4 0260 - 31 R28782 1C16 7 0210 - 8 R44302 2F20 13 1674 - 7
R26375 1F2 6 0260 - 35 R28782 1D21 13 0260 - 5 R44302 2F22 20 1674 - 9
R26375 1F4 10 0260 - 37 R28782 1D23 43 0260 - 7 R44302 2F24 3 1674 - 11
R26375 1F6 13 0260 - 39 R28782 1E4 11 0260 - 13 R44302 2G4 7 1674 - 17
R26375 1F19 12 0341 - 3 R28782 1F22 1 0350 - 3 R44302 2G14 4 1674 - 27
R26375 2B16 19 0510 - 11 R28782 1F24 1 0350 - 5 R44302 2G14 17 1674 - 27
R26375 2C18 4 0930 - 3 R28782 1G6 5 0350 - 13 R44302 2J24 6 1830 - 3
R26375 2D4 6 0960 - 11 R28782 1H4 9 0350 - 35 R44302 2L3 11 2001 - 3
R26375 2D6 2 0960 - 13 R28782 1H7 20 0360 - 3 R44302 2L7 11 2002 - 5
R26375 2D8 2 0960 - 15 R28782 2D12 5 0960 - 19 R46791 2L11 3 2004 - 3
R26375 2D10 2 0960 - 17 R28782 2D17 31 1060 - 3 R47150 1J16 2 0433 - 3
R26375 2D12 2 0960 - 19 R28782 3B5 22 2160 - 3 R47150 3B21 17 2160 - 25
R26375 2D17 29 1060 - 3 R28782 3C12 15 2160 - 41 R47151 1I7 2 0407 - 3
R26375 2D19 12 1060 - 5 R28782 3C18 5 2163 - 3 R47153 1I12 7 0407 - 9
R26375 2D24 3 1111 - 5 R28782 3C24 21 2163 - 7 R47153 1J18 19 0452 - 3
R26375 3C4 10 2160 - 33 R28782 3D2 21 2163 - 9 R48437 1D15 5 0250 - 7
R26375 3C6 9 2160 - 35 R28782 3E8 24 3460 - 5 R48733 1C13 16 0210 - 5
R26375 3C10 21 2160 - 39 R28782 3E20 2 3460 - 17 R48734 1C13 16 0210 - 5
R26375 3E4 34 3450 - 5 R28811 1J14 3 0433 - 1 R48735 1C13 16 0210 - 5
R26375 3E18 2 3460 - 15 R29936 1E20 8 0260 - 29 R48776 1C13 17 0210 - 5
R26375 3E22 9 3460 - 19 R29936 1E22 10 0260 - 31 R500055 1I12 3 0407 - 9
R26375 3F2 9 3460 - 23 R29936 1H7 8 0360 - 3 R500055 1J5 4 0419 - 1
R26375 3F4 6 3460 - 25 R29936 1H11 4 0363 - 3 R500098 1I15 3 0409 - 3
R26375 3F6 2 3460 - 27 R29936 2C18 7 0930 - 3 R500330 1I12 14 0407 - 9
R26375 3F19 2 4260 - 7 R29936 2D24 6 1111 - 5 R500642 1H25 15 0404 - 3
R26375 3F21 2 4260 - 9 R29936 3C24 32 2163 - 7 R500642 1I9 1 0407 - 5
R26375 3F23 4 4260 - 11 R29936 3D2 32 2163 - 9 R500723 1I25 15 0416 - 3
R26448 1C13 3 0210 - 5 R30903 1F6 10 0260 - 39 R501034 1H23 5 0403 - 1
R26448 1C15 9 0210 - 7 R31291 2B18 20 0512 - 3 R501034 1I4 1 0404 - 7
R26448 1D21 3 0260 - 5 R31654 2K14 22 1830 - 19 R501035 1H23 4 0403 - 1
R26448 1D23 41 0260 - 7 R32617 1H22 1 0402 - 6 R501255 1H25 .. 0404 - 3
R26448 1F4 21 0260 - 37 R32617 1H22 .. 0402 - 6 R501640 1I15 18 0409 - 3
R26448 2D4 2 0960 - 11 R33259 2K8 20 1830 - 13 R501640 1J18 9 0452 - 3
R26448 2D17 30 1060 - 3 R33259 2K12 28 1830 - 17 R502011 1H22 13 0402 - 6
R26448 2D19 3 1060 - 5 R34857 1C19 7 0210 - 11 R502011 1J11 15 0423 - 3
R26448 2E12 4 1369 - 5 R34858 1C19 5 0210 - 11 R502011 1J18 25 0452 - 3
R26448 3B23 11 2160 - 27 R35365 1C13 2 0210 - 5 R502079 1J13 3 0429 - 2
R26448 3B25 11 2160 - 29 R35366 1C13 2 0210 - 5 R502083 1H22 4 0402 - 6
II-10 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=618
 1L17 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
R502125 1H16 3 0401 - 2 R518563 1J7 6 0420 - 3 R69166 2J8 27A 1810 - 41
R502126 1H16 3 0401 - 2 R518563 1J7 8 0420 - 3 R69166 2J8 28 1810 - 41
R502127 1H16 2 0401 - 2 R518563 1J7 9 0420 - 3 R69166 2J8 37B 1810 - 41
R502128 1H16 2 0401 - 2 R518563 1J7 33 0420 - 3 R69629 3D18 11 3440 - 3
R502187 1I15 4 0409 - 3 R518804 1J5 7 0419 - 1 R70111 1C19 15 0210 - 11
R502315 1H16 2 0401 - 2 R518995 1J16 4 0433 - 3 R70112 1C19 20 0210 - 11
R502316 1H16 2 0401 - 2 R519287 1H25 20 0404 - 3 R70113 1C19 17 0210 - 11
R502317 1H16 3 0401 - 2 R51936 1I20 20 0413 - 3 R70115 1C19 19 0210 - 11
R502318 1H16 3 0401 - 2 R51936 1J18 17 0452 - 3 R70663 2I24 50 1810 - 33
R502319 1H16 2 0401 - 2 R51936 1J18 .. 0452 - 3 R70663 2J2 50 1810 - 35
R502320 1H16 2 0401 - 2 R51937 1I20 21 0413 - 3 R71732 1I9 11 0407 - 5
R502321 1H16 3 0401 - 2 R519483 1J7 7 0420 - 3 R71732 1I9 13 0407 - 5
R502322 1H16 3 0401 - 2 R519578 1J4 6 0418 - 3 R71732 1I13 2 0407 - 10
R502598 1H21 7 0402 - 5 R519759 1I20 37 0413 - 3 R71929 1D17 5 0250 - 9
R502598 1J18 7 0452 - 3 R520373 1H21 12 0402 - 5 R72328 1H21 4 0402 - 5
R502602 1I20 3 0413 - 3 R520504 1J16 20 0433 - 3 R72328 1J4 10 0418 - 3
R502695 1H21 11 0402 - 5 R520583 1I7 5 0407 - 3 R72328 1J18 6 0452 - 3
R502719 1H21 15 0402 - 5 R521437 1I17 5 0410 - 1 R72430 1D17 6 0250 - 9
R502719 1J18 7 0452 - 3 R521438 1I17 4 0410 - 1 R726R 1E2 2 0260 - 11
R502773 1I9 2 0407 - 5 R52389 1D17 16 0250 - 9 R72655 2G8 8 1674 - 21
R50279 2K8 13 1830 - 13 R52921 2F8 12 1673 - 9 R72655 2J14 11 1821 - 3
R502911 1I15 7 0409 - 3 R53108 1J9 18 0422 - 3 R72655 2J18 11 1821 - 7
R502912 1I15 8 0409 - 3 R53317 2D17 18 1060 - 3 R73290 3D14 4 3401 - 7
R503427 1J2 2 0417 - 3 R53436 2K12 29 1830 - 17 R73290 3D16 5 3401 - 9
R503501 1J2 8 0417 - 3 R53528 2I10 16 1810 - 19 R74008 1H23 3 0403 - 1
R503578 1I20 6 0413 - 3 R53528 2I12 16 1810 - 21 R76578 3B15 4 2160 - 19
R503578 1J18 12 0452 - 3 R53540 2D24 16 1111 - 5 R76578 3B17 5 2160 - 21
R504028 1I9 15 0407 - 5 R54124 1B19 6 0110 - 21 R76578 3B19 4 2160 - 23
R504089 1I22 44 0413 - 5 R54380 1D17 14 0250 - 9 R76578 3B21 7 2160 - 25
R504093 1H21 6 0402 - 5 R54500 1I18 4 0410 - 2 R76578 3B23 2 2160 - 27
R504093 1J18 8 0452 - 3 R54500 1I25 1 0416 - 3 R76578 3B25 4 2160 - 29
R504093 1J18 17 0452 - 3 R56308 1C13 11 0210 - 5 R76578 3C2 7 2160 - 31
R50424 1J18 20 0452 - 3 R56397 2K12 30 1830 - 17 R76578 3C4 7 2160 - 33
R504289 1J5 3 0419 - 1 R56962 1J14 4 0433 - 1 R76578 3C6 6 2160 - 35
R504327 1I15 .. 0409 - 3 R57696 1I9 5 0407 - 5 R76822 1I22 42 0413 - 5
R504516 1J7 1 0420 - 3 R57771 1H23 2 0403 - 1 R77175 1C16 15 0210 - 8
R504667 1J5 9 0419 - 1 R57771 1I4 1 0404 - 7 R77175 1F4 22 0260 - 37
R504668 1J5 14 0419 - 1 R59074 1C25 22 0230 - 5 R77175 1H7 19 0360 - 3
R504669 1I13 1 0407 - 10 R59289 1C19 27 0210 - 11 R77175 1I20 38 0413 - 3
R504669 1J5 10 0419 - 1 R59460 1C19 21 0210 - 11 R77175 2D24 17 1111 - 5
R504670 1J5 6 0419 - 1 R60038 1C19 8 0210 - 11 R77175 3C12 8 2160 - 41
R504810 1J4 11 0418 - 3 R61288 1H25 24 0404 - 3 R77175 3C18 13 2163 - 3
R504810 1J18 14 0452 - 3 R61497 1I16 1 0409 - 4 R77175 3C24 56 2163 - 7
R504811 1H17 5 0402 - 1 R63016 2E12 16 1369 - 5 R77175 3D2 56 2163 - 9
R504811 1H22 14 0402 - 6 R63548 1I20 22 0413 - 3 R77664 1D17 1 0250 - 9
R504823 1I23 8 0414 - 1 R63548 1J7 12 0420 - 3 R77673 2C13 2 0578 - 3
R505515 1J7 44 0420 - 3 R63548 1J7 13 0420 - 3 R77915 2I10 17 1810 - 19
R505570 1I20 8 0413 - 3 R63548 1J7 15 0420 - 3 R77915 2I12 17 1810 - 21
R505570 1J18 11 0452 - 3 R63548 1J7 16 0420 - 3 R78057 2K10 9 1830 - 15
R51196 1C13 10 0210 - 5 R63548 1J7 26 0420 - 3 R78059 2K10 9 1830 - 15
R51197 1C13 10 0210 - 5 R63548 1J7 28 0420 - 3 R78393 2D2 16 0960 - 9
R51198 1C13 10 0210 - 5 R63548 1J7 31 0420 - 3 R79001 3F11 10 4240 - 5
R51199 1C13 10 0210 - 5 R63548 1J7 32 0420 - 3 R79033 2I10 18 1810 - 19
R515064 1I23 8 0414 - 1 R63548 1J7 37 0420 - 3 R79033 2I12 18 1810 - 21
R515224 1H25 2 0404 - 3 R63548 1J7 38 0420 - 3 R79033 2K6 29 1830 - 11
R515224 1J9 17 0422 - 3 R63548 3B21 19 2160 - 25 R79101 3E10 8 3460 - 7
R515454 1I20 28 0413 - 3 R63551 1J18 17 0452 - 3 R79101 3E12 8 3460 - 9
R515456 1I22 52 0413 - 5 R63551 1J18 .. 0452 - 3 R79101 3E14 11 3460 - 11
R515457 1I22 54 0413 - 5 R63575 1D17 4 0250 - 9 R79846 1J12 5 0429 - 1
R515457 1J18 16 0452 - 3 R63845 1I17 6 0410 - 1 R81162 1D17 9 0250 - 9
R515575 1I15 19 0409 - 3 R63845 1I20 2 0413 - 3 R81596 2C8 7 0560 - 3
R516315 1J9 15 0422 - 3 R64283 2H10 7 1749 - 3 R81862 2C20 6 0960 - 3
R517486 1I15 15 0409 - 3 R66405 1G4 31 0350 - 9 R81862 2C22 19 0960 - 5
R518212 1H17 7 0402 - 1 R66405 1G22 13 0350 - 29 R81862 2C24 17 0960 - 7
R518376 1I13 7 0407 - 10 R67230 1G4 13 0350 - 9 R81862 3E16 11 3460 - 13
R518382 1I12 19 0407 - 9 R67264 1I22 40 0413 - 5 R81862 3F15 11 4240 - 9
R518524 1J7 3 0420 - 3 R69166 2J8 26A 1810 - 41 R81968 3E16 13 3460 - 13
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-11
PN=619
 1L18 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
R81968 3F15 17 4240 - 9 TY22467 1H21 18 0402 - 5 T133674 2J8 41 1810 - 41
R81971 3F15 2 4240 - 9 TY22467 1I25 14 0416 - 3 T134530 2I20 12 1810 - 29
R82007 1H25 22 0404 - 3 TY23020 2E22 7 1671 - 3 T134530 2J4 8 1810 - 37
R82075 3F11 13 4240 - 5 TY25803 2E22 7 1671 - 3 T134530 2K4 42 1830 - 9
R82076 3F11 15 4240 - 5 T101807 2H24 8 1810 - 11 T134530 2K6 42 1830 - 11
R82960 3E16 16 3460 - 13 T102934 2F16 13 1674 - 3 T134530 2K14 27 1830 - 19
R83020 1J18 2 0452 - 3 T102934 2F20 14 1674 - 7 T134895 2J8 42 1810 - 41
R83021 1J18 1 0452 - 3 T102934 2G2 12 1674 - 15 T135675 2I2 1 1810 - 13
R83066 2I4 1 1810 - 13B T102934 2G4 8 1674 - 17 T135675 2I4 2 1810 - 13B
R83578 3F11 6 4240 - 5 T103395 2E3 6 1320 - 3 T138914 2K12 34 1830 - 17
R84262 1C15 20 0210 - 7 T103453 3D22 27 3440 - 7 T139131 2B14 21 0510 - 7
R84618 1I15 12 0409 - 3 T103590 2H10 6 1749 - 3 T139131 2B14 23 0510 - 7
R84619 1I15 14 0409 - 3 T104220 2J8 25 1810 - 41 T140922 1F13 28 0315 - 5
R85027 1H19 9 0402 - 3 T104220 2J10 9 1810 - 43 T141732 3D24 18 3440 - 9
R85226 1C19 32 0210 - 11 T104220 2J12 9 1810 - 45 T141733 3D24 19 3440 - 9
R86062 1J4 14 0418 - 3 T104220 3C10 12 2160 - 39 T142485 3F9 20 4240 - 3
R86063 1I12 8 0407 - 9 T104223 3F9 23 4240 - 3 T143169 2K12 35 1830 - 17
R86571 1I16 2 0409 - 4 T10510 2H8 5 1747 - 3 T143169 2K14 29 1830 - 19
R87561 1H17 1 0402 - 1 T10510 3D22 28 3440 - 7 T143929 3D20 3 3440 - 5
R87561 1H25 23 0404 - 3 T10510 3E2 30 3450 - 3 T143929 3D24 7 3440 - 9
R89441 1I7 14 0407 - 3 T10510 3E4 17 3450 - 5 T145360 2L5 8 2002 - 3
R89441 1J16 4 0433 - 3 T105740 2J14 4 1821 - 3 T145453 2E7 1 1320 - 7
R89879 1I25 10 0416 - 3 T105740 2J18 4 1821 - 7 T146097 2E3 30 1320 - 3
R89879 1J18 3 0452 - 3 T105773 2D6 11 0960 - 13 T146098 2E5 17 1320 - 5
R89940 3E14 13 3460 - 11 T105773 3E18 10 3460 - 15 T146099 2E7 18 1320 - 7
R89940 3E14 16 3460 - 11 T105773 3F6 8 3460 - 27 T146102 1J9 10 0422 - 3
R92097 1J18 3 0452 - 3 T105773 3F23 14 4260 - 11 T146104 2E7 2 1320 - 7
R93308 1I15 12 0409 - 3 T106596 1C19 35 0210 - 11 T146106 2E5 1 1320 - 5
R93311 1I15 14 0409 - 3 T107029 2B16 14 0510 - 11 T146246 1C23 8 0230 - 3
R93312 1I15 12 0409 - 3 T107141 2B14 13 0510 - 7 T146246 1C23 22 0230 - 3
R93313 1I15 14 0409 - 3 T108521 3F13 31 4240 - 7 T146246 1C25 33 0230 - 5
R93314 1I15 12 0409 - 3 T108524 3F13 32 4240 - 7 T146246 1D5 13 0240 - 3
R93315 1I15 14 0409 - 3 T11180 1I25 3 0416 - 3 T146246 1D23 9 0260 - 7
R93349 1I15 13 0409 - 3 T11234 1C23 26 0230 - 3 T146246 2C20 28 0960 - 3
R93350 1I15 11 0409 - 3 T11234 1C25 32 0230 - 5 T146246 2G21 2 1740 - 3
R93623 1C19 13 0210 - 11 T11234 2C20 27 0960 - 3 T146246 3F13 14 4240 - 7
R93937 1D17 13 0250 - 9 T11234 2L5 7 2002 - 3 T146256 2C22 9 0960 - 5
R93948 1H23 6 0403 - 1 T11234 2L7 5 2002 - 5 T146605 2E3 7 1320 - 3
R94545 1D17 10 0250 - 9 T114792 3F9 6 4240 - 3 T146606 2E5 2 1320 - 5
R94546 1D17 8 0250 - 9 T114792 3F17 1 4240 - 11 T146607 2E7 3 1320 - 7
R95116 1C19 10 0210 - 11 T115030 2L7 6 2002 - 5 T147623 3E10 22 3460 - 7
R95493 3B15 5 2160 - 19 T115031 2L7 7 2002 - 5 T147623 3E12 22 3460 - 9
R95493 3B17 6 2160 - 21 T118712 3B15 6 2160 - 19 T147700 3F9 24 4240 - 3
R95493 3B19 5 2160 - 23 T118712 3B17 7 2160 - 21 T147891 2E12 2 1369 - 5
R95493 3B21 8 2160 - 25 T118712 3B19 6 2160 - 23 T148164 3E10 23 3460 - 7
R95493 3B23 6 2160 - 27 T118712 3C2 17 2160 - 31 T148164 3E12 23 3460 - 9
R95493 3B25 5 2160 - 29 T118712 3C6 11 2160 - 35 T148409 2H16 2 1810 - 3
R95493 3C2 8 2160 - 31 T119153 2I6 5 1810 - 15 T148409 2I10 23 1810 - 19
R95493 3C4 8 2160 - 33 T119564 2L7 8 2002 - 5 T148409 2I12 23 1810 - 21
R95493 3C6 7 2160 - 35 T120536 1F13 33 0315 - 5 T149597 1E16 16 0260 - 25
R96248 2K8 15 1830 - 13 T120536 2G2 17 1674 - 15 T149818 3F13 15 4240 - 7
R96703 1J9 9 0422 - 3 T120536 2G10 7 1674 - 23 T149822 3F13 16 4240 - 7
R96753 2K17 18 1910 - 3 T124382 3D20 4 3440 - 5 T150347 3F17 3 4240 - 11
R98064 1I12 4 0407 - 9 T124495 3E14 26 3460 - 11 T150614 3D24 13 3440 - 9
R98064 1J5 5 0419 - 1 T125860 2H18 7 1810 - 5 T150942 3E2 35 3450 - 3
R98250 1J11 1 0423 - 3 T125945 3F9 19 4240 - 3 T150942 3E4 49 3450 - 5
R98250 2K12 31 1830 - 17 T126204 1H11 12 0363 - 3 T150942 3E8 28 3460 - 5
R98527 1H22 17 0402 - 6 T126204 2D19 18 1060 - 5 T150961 3B25 2 2160 - 29
R98953 2C24 11 0960 - 7 T126400 2H18 14 1810 - 5 T151485 3E2 10 3450 - 3
R99590 2K12 32 1830 - 17 T127280 2H18 8 1810 - 5 T151797 1B3 7 0110 - 3
SE500877 1I9 15 0407 - 5 T128437 2L7 9 2002 - 5 T151797 1B5 7 0110 - 5
TT206940 2I10 37 1810 - 19 T128502 3D24 10 3440 - 9 T151797 1B7 3 0110 - 7
TT208828 2B24 5 0520 - 3 T129981 3D24 11 3440 - 9 T151797 1B9 3 0110 - 9
TY16004 2E8 1 1369 - 1 T129982 3D24 12 3440 - 9 T151797 1B11 7 0110 - 11
TY16005 2E8 2 1369 - 1 T131169 2F8 11 1673 - 9 T151797 1B13 6 0110 - 13
TY16021 1C13 .. 0210 - 5 T13254 2B14 26 0510 - 7 T151797 1B15 7 0110 - 15
TY22450 1H21 19 0402 - 5 T13254 3D6 12 2164 - 5 T151797 2H2 8 1746 - 3
II-12 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=620
 1L19 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
T151806 3F2 21 3460 - 23 T158340 1C7 3 0201 - 3 T163336 2J18 14 1821 - 7
T151953 3E16 28 3460 - 13 T158400 2B18 21 0512 - 3 T163658 2E3 12 1320 - 3
T152047 3F9 25 4240 - 3 T158436 2B14 27 0510 - 7 T163659 2E7 7 1320 - 7
T152169 3D22 29 3440 - 7 T158492 1C9 10 0201 - 5 T163660 2E5 6 1320 - 5
T152721 3D24 14 3440 - 9 T158492 1C9 18 0201 - 5 T163748 3D24 18 3440 - 9
T152859 1C23 17 0230 - 3 T158509 1C7 16 0201 - 3 T163962 2J14 5 1821 - 3
T152862 1C23 23 0230 - 3 T158510 1C7 18 0201 - 3 T163962 2J18 5 1821 - 7
T152862 2C20 29 0960 - 3 T158511 1C7 17 0201 - 3 T164030 2K12 37 1830 - 17
T152876 3E2 11 3450 - 3 T158513 1C7 5 0201 - 3 T164030 3C24 60 2163 - 7
T152877 3E2 12 3450 - 3 T158514 1C7 4 0201 - 3 T164030 3D2 60 2163 - 9
T152879 3E2 14 3450 - 3 T158599 1D15 3 0250 - 7 T164031 2B14 31 0510 - 7
T152879 3E4 14 3450 - 5 T158600 1D15 2 0250 - 7 T164124 2C18 21 0930 - 3
T152881 3E2 16 3450 - 3 T158949 2C6 2 0540 - 3 T164124 2D19 19 1060 - 5
T152881 3E4 16 3450 - 5 T159052 2B18 22 0512 - 3 T164124 3E22 19 3460 - 19
T152882 3E2 16 3450 - 3 T159656 1D2 3 0230 - 7 T164128 3E22 19 3460 - 19
T152882 3E4 16 3450 - 5 T159656 1D7 8 0240 - 5 T164129 3E22 19 3460 - 19
T152883 3E2 16 3450 - 3 T159883 2B18 23 0512 - 3 T164264 1F13 30 0315 - 5
T152883 3E4 16 3450 - 5 T159884 2B18 40 0512 - 3 T164303 2B24 4 0520 - 3
T152990 3E2 19 3450 - 3 T159984 1D15 18 0250 - 7 T16464 1F13 18 0315 - 5
T152991 3E2 19 3450 - 3 T159985 1D15 17 0250 - 7 T16464 3F2 22 3460 - 23
T152992 3E2 19 3450 - 3 T160017 2I24 17 1810 - 33 T164691 2E7 8 1320 - 7
T152993 3E2 22 3450 - 3 T160017 2J2 17 1810 - 35 T164692 2E5 7 1320 - 5
T152993 3E4 22 3450 - 5 T160020 2I24 18 1810 - 33 T164945 2K6 44 1830 - 11
T152994 3E2 23 3450 - 3 T160020 2J2 18 1810 - 35 T164986 3E4 45 3450 - 5
T152995 3E2 24 3450 - 3 T160152 2E3 29 1320 - 3 T165055 3E4 10 3450 - 5
T153019 3F13 17 4240 - 7 T160153 2E7 19 1320 - 7 T165056 3E4 12 3450 - 5
T153535 2H24 9 1810 - 11 T160154 2E5 18 1320 - 5 T165061 3E4 11 3450 - 5
T153680 2E3 8 1320 - 3 T160333 2B4 11 0505 - 3 T165062 3E4 23 3450 - 5
T155572 1H11 14 0363 - 3 T160333 2F20 15 1674 - 7 T165063 3E4 24 3450 - 5
T155572 2E3 9 1320 - 3 T160334 2B6 1 0505 - 5 T165064 3E4 35 3450 - 5
T155579 2E5 3 1320 - 5 T160368 1C7 14 0201 - 3 T165065 3E4 36 3450 - 5
T155581 2E7 4 1320 - 7 T160492 2K14 30 1830 - 19 T165066 3E4 37 3450 - 5
T155757 1D25 2 0260 - 9 T160541 1E24 8 0260 - 33 T165067 3E4 38 3450 - 5
T155988 1D25 9 0260 - 9 T160608 2B14 28 0510 - 7 T165068 3E4 39 3450 - 5
T157172 2I20 14 1810 - 29 T160609 2B14 29 0510 - 7 T165069 3E4 39 3450 - 5
T157172 2I22 13 1810 - 31 T160698 2H2 9 1746 - 3 T165069 3E4 40 3450 - 5
T157211 2D17 19 1060 - 3 T160825 2C6 9 0540 - 3 T165070 3E4 41 3450 - 5
T157212 2D17 14 1060 - 3 T161376 2E22 18 1671 - 3 T165071 3E4 47 3450 - 5
T157212 2D17 24 1060 - 3 T161531 2K17 19 1910 - 3 T165072 3E4 19 3450 - 5
T157220 2D17 20 1060 - 3 T161674 2E3 10 1320 - 3 T165073 3E4 19 3450 - 5
T157223 2D17 25 1060 - 3 T162050 2E3 11 1320 - 3 T165073 3E4 20 3450 - 5
T157257 2D17 26 1060 - 3 T162051 2E7 6 1320 - 7 T165074 3E4 19 3450 - 5
T157258 2D17 15 1060 - 3 T162052 2E5 5 1320 - 5 T165074 3E4 21 3450 - 5
T157827 2G21 14 1740 - 3 T162152 1E10 24 0260 - 19 T165075 3E4 32 3450 - 5
T157828 2G21 11 1740 - 3 T162155 1E10 23 0260 - 19 T165077 3E4 26 3450 - 5
T157829 2G21 10 1740 - 3 T162157 1E10 22 0260 - 19 T165535 1D25 16 0260 - 9
T157941 1C9 20 0201 - 5 T162211 1E6 45 0260 - 15 T165791 3E4 44 3450 - 5
T157942 1C9 17 0201 - 5 T162212 1E6 53 0260 - 15 T165992 2C8 10 0560 - 3
T157943 1C9 11 0201 - 5 T162213 1E6 54 0260 - 15 T166297 2I12 35 1810 - 21
T157944 1C9 7 0201 - 5 T162215 1E6 56 0260 - 15 T166297 2K14 31 1830 - 19
T157945 1C9 2 0201 - 5 T162215 1E10 56 0260 - 19 T166761 3E22 20 3460 - 19
T157952 1C9 1 0201 - 5 T162216 1E8 62 0260 - 17 T166907 1D23 30 0260 - 7
T157991 2K21 5 1913 - 3 T162238 2K17 20 1910 - 3 T166916 1D13 12 0250 - 5
T158027 3D20 7 3440 - 5 T162343 2C8 12 0560 - 3 T166917 1D13 22 0250 - 5
T158102 2G21 6 1740 - 3 T162428 1C25 24 0230 - 5 T166919 1D13 20 0250 - 5
T158229 2G21 9 1740 - 3 T162477 2K12 36 1830 - 17 T166920 1D13 13 0250 - 5
T158241 1D25 8 0260 - 9 T162575 2B14 30 0510 - 7 T166921 1D13 10 0250 - 5
T158248 1D15 4 0250 - 7 T162675 2F20 16 1674 - 7 T166922 1D11 5 0250 - 3
T158249 1D15 19 0250 - 7 T162854 1D25 1 0260 - 9 T166923 1D11 14 0250 - 3
T158250 1D15 11 0250 - 7 T162876 1F13 29 0315 - 5 T166924 1D11 16 0250 - 3
T158298 3C24 58 2163 - 7 T162965 2B14 13 0510 - 7 T166925 1D11 13 0250 - 3
T158298 3D2 58 2163 - 9 T163333 1F13 17 0315 - 5 T166926 1D11 15 0250 - 3
T158332 1C9 16 0201 - 5 T163334 2J14 12 1821 - 3 T166927 1D11 3 0250 - 3
T158334 1C9 9 0201 - 5 T163334 2J18 12 1821 - 7 T166928 1D11 2 0250 - 3
T158335 1C9 8 0201 - 5 T163335 2J14 13 1821 - 3 T166929 1D11 10 0250 - 3
T158338 1C7 2 0201 - 3 T163335 2J18 13 1821 - 7 T166930 1D11 9 0250 - 3
T158339 1D15 20 0250 - 7 T163336 2J14 14 1821 - 3 T166931 1D11 12 0250 - 3
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-13
PN=621
 1L20 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
T166932 1D11 11 0250 - 3 T184345 2K4 25 1830 - 9 T187712 1E8 88 0260 - 17
T166933 1D13 7 0250 - 5 T184345 2K6 30 1830 - 11 T187713 1E8 40 0260 - 17
T166934 1D11 6 0250 - 3 T184404 1C25 25 0230 - 5 T187714 1E6 14 0260 - 15
T167010 3E2 13 3450 - 3 T184460 1D23 3 0260 - 7 T187715 1E10 55 0260 - 19
T167010 3E2 15 3450 - 3 T184629 2D2 4 0960 - 9 T187716 1E10 27 0260 - 19
T167010 3E4 13 3450 - 5 T184924 2K8 25 1830 - 13 T187716 1E10 28 0260 - 19
T167011 3E2 13 3450 - 3 T184924 2K14 32 1830 - 19 T187717 1E10 28 0260 - 19
T167011 3E2 15 3450 - 3 T185030 2B14 32 0510 - 7 T187719 1E8 2 0260 - 17
T168383 1F19 7 0341 - 3 T185047 2C22 10 0960 - 5 T187720 1E8 29 0260 - 17
T168383 2B16 13 0510 - 11 T185135 3B5 61 2160 - 3 T187721 1E6 47 0260 - 15
T168383 2D19 11 1060 - 5 T185138 3B5 15 2160 - 3 T187722 1E8 28 0260 - 17
T170180 2D17 21 1060 - 3 T185181 3B5 54 2160 - 3 T187723 1E8 87 0260 - 17
T170181 2D17 22 1060 - 3 T185183 3B5 24 2160 - 3 T187724 1E10 5 0260 - 19
T171686 2J14 27 1821 - 3 T185184 3B5 57 2160 - 3 T187725 1E10 60 0260 - 19
T171686 2J18 27 1821 - 7 T185185 3B5 40 2160 - 3 T187726 1E6 46 0260 - 15
T172927 2D17 32 1060 - 3 T185186 3B5 55 2160 - 3 T187727 1E10 29 0260 - 19
T173591 2K17 21 1910 - 3 T185254 3B5 25 2160 - 3 T187728 1E8 30 0260 - 17
T173779 2J22 5 1822 - 3 T185326 2K2 3 1830 - 5 T187729 1E8 7 0260 - 17
T174530 2E22 19 1671 - 3 T185370 1D23 29 0260 - 7 T187730 1E10 57 0260 - 19
T174634 2D17 16 1060 - 3 T185424 1F17 2 0325 - 3 T187731 1E8 11 0260 - 17
T175236 2D17 27 1060 - 3 T185579 3D20 8 3440 - 5 T187733 1E8 3 0260 - 17
T175675 2I24 19 1810 - 33 T185664 2I16 10 1810 - 25 T187734 1E8 1 0260 - 17
T175675 2J2 19 1810 - 35 T185769 2F8 16 1673 - 9 T187735 1E10 13 0260 - 19
T175744 2E3 13 1320 - 3 T185769 2F10 11 1673 - 11 T187736 1E8 2 0260 - 17
T176108 2D17 33 1060 - 3 T185769 2F22 22 1674 - 9 T187737 1E10 3 0260 - 19
T176372 2F4 3 1673 - 5 T185769 2F24 4 1674 - 11 T187738 1E10 3 0260 - 19
T176405 1D25 14 0260 - 9 T185769 2J8 43 1810 - 41 T187740 1E10 59 0260 - 19
T176425 3B5 7 2160 - 3 T185769 2K2 4 1830 - 5 T187741 1E8 4 0260 - 17
T176644 2G21 17 1740 - 3 T185769 2L3 13 2001 - 3 T187744 1E8 10 0260 - 17
T176870 2J22 6 1822 - 3 T185769 2L7 12 2002 - 5 T187745 1E8 9 0260 - 17
T17776 2H10 4 1749 - 3 T185826 3C24 61 2163 - 7 T187757 2E3 15 1320 - 3
T17776 3F9 26 4240 - 3 T185826 3D2 61 2163 - 9 T187758 2E7 9 1320 - 7
T178946 2F6 3 1673 - 7 T185959 1D21 12 0260 - 5 T187759 2E5 8 1320 - 5
T178947 2F6 2 1673 - 7 T185960 1D21 16 0260 - 5 T187767 1E10 4 0260 - 19
T178948 2F6 1 1673 - 7 T186350 3D22 16 3440 - 7 T187769 1E8 31 0260 - 17
T179952 2C6 9 0540 - 3 T186655 1D13 15 0250 - 5 T187772 1E8 27 0260 - 17
T180074 2F6 2 1673 - 7 T186656 1D13 16 0250 - 5 T187774 1E8 32 0260 - 17
T180075 2F6 3 1673 - 7 T186657 1D23 27 0260 - 7 T187818 2B18 37 0512 - 3
T181306 1D25 24 0260 - 9 T186658 1D23 26 0260 - 7 T187863 2K19 17 1910 - 5
T181306 1E2 24 0260 - 11 T186659 1D23 35 0260 - 7 T187896 1E2 9 0260 - 11
T181306 3E24 3 3460 - 21 T186793 2E3 14 1320 - 3 T188075 3D18 12 3440 - 3
T182184 2E3 25 1320 - 3 T186793 2F22 32 1674 - 9 T188076 3D18 13 3440 - 3
T182909 2F22 21 1674 - 9 T186793 2I10 24 1810 - 19 T188182 1E12 12 0260 - 21
T182909 2H18 15 1810 - 5 T186793 2I12 24 1810 - 21 T188288 3C14 8 2160 - 43
T182909 2H20 9 1810 - 7 T186956 1D13 6 0250 - 5 T188352 1D13 23 0250 - 5
T182909 2H22 9 1810 - 9 T186973 2F22 32 1674 - 9 T188651 2K17 22 1910 - 3
T183474 3D20 8 3440 - 5 T186987 1E20 18 0260 - 29 T188686 3B5 13 2160 - 3
T183756 3B21 18 2160 - 25 T186988 1D13 14 0250 - 5 T188687 3B5 49 2160 - 3
T183756 3B25 3 2160 - 29 T186989 1D13 9 0250 - 5 T188690 3B5 6 2160 - 3
T183756 3C2 5 2160 - 31 T187196 1D23 33 0260 - 7 T188698 3B5 15 2160 - 3
T183756 3C4 5 2160 - 33 T187206 1E4 24 0260 - 13 T188745 1D13 8 0250 - 5
T183756 3C6 4 2160 - 35 T187386 2B18 24 0512 - 3 T188806 2I6 9 1810 - 15
T183756 3C10 24 2160 - 39 T187387 2B18 39 0512 - 3 T188856 1D23 31 0260 - 7
T183810 1D13 17 0250 - 5 T187394 2F8 15 1673 - 9 T188857 1D23 32 0260 - 7
T183811 1D13 18 0250 - 5 T187394 2F10 12 1673 - 11 T188984 1D23 13 0260 - 7
T183812 1D13 19 0250 - 5 T187394 2F22 23 1674 - 9 T190212 2E3 16 1320 - 3
T183816 1D23 4 0260 - 7 T187394 2F24 5 1674 - 11 T190243 3B5 52 2160 - 3
T183817 1D23 20 0260 - 7 T187394 2L3 14 2001 - 3 T190513 2K12 38 1830 - 17
T183818 1D23 17 0260 - 7 T187394 2L7 13 2002 - 5 T190533 2E5 9 1320 - 5
T183819 1D23 18 0260 - 7 T187416 2B18 36 0512 - 3 T190534 2E7 10 1320 - 7
T183820 1D23 19 0260 - 7 T187477 2B18 42 0512 - 3 T190610 3E8 2 3460 - 5
T183821 1D23 15 0260 - 7 T187526 3C24 62 2163 - 7 T190611 3E8 3 3460 - 5
T183822 1D23 34 0260 - 7 T187526 3D2 62 2163 - 9 T190612 3E8 4 3460 - 5
T183823 1D23 45 0260 - 7 T187561 1D9 1 0240 - 7 T190613 3E8 5 3460 - 5
T183824 1D23 47 0260 - 7 T187566 1D9 4 0240 - 7 T190614 3E8 6 3460 - 5
T184082 3D24 19 3440 - 9 T187664 1E20 19 0260 - 29 T190615 3E8 7 3460 - 5
T184228 3E4 15 3450 - 5 T187711 1E8 12 0260 - 17 T190616 3E8 8 3460 - 5
II-14 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=622
 1L21 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
T190617 3E8 9 3460 - 5 T196079 2K4 46 1830 - 9 T202744 2K4 55 1830 - 9
T190639 3E8 11 3460 - 5 T196079 2K6 46 1830 - 11 T202745 2K6 56 1830 - 11
T190640 3E8 12 3460 - 5 T196079 2K14 33 1830 - 19 T202746 2J4 11 1810 - 37
T190641 3E8 13 3460 - 5 T196080 2H16 2 1810 - 3 T202768 2B14 35 0510 - 7
T190642 3E8 14 3460 - 5 T196080 2J10 23 1810 - 43 T202792 1F13 32 0315 - 5
T190643 3E8 15 3460 - 5 T196080 2J12 23 1810 - 45 T202793 2I14 5 1810 - 23
T190644 3E8 16 3460 - 5 T196080 3C16 6 2160 - 45 T202797 2J4 12 1810 - 37
T190645 3E8 17 3460 - 5 T200363 2F22 11 1674 - 9 T202799 2I10 28 1810 - 19
T190646 3E8 18 3460 - 5 T20052 1E18 3A 0260 - 27 T202799 2I12 28 1810 - 21
T190647 3E8 19 3460 - 5 T20077 1I15 2 0409 - 3 T202800 2I20 17 1810 - 29
T190648 3E8 22 3460 - 5 T20129 1I15 1 0409 - 3 T202800 2K14 36 1830 - 19
T190767 3B15 7 2160 - 19 T201461 1F13 19 0315 - 5 T202876 3D10 2 3401 - 3
T190767 3B17 8 2160 - 21 T201462 1F13 20 0315 - 5 T202921 2I10 29 1810 - 19
T190767 3B19 7 2160 - 23 T201481 1F13 21 0315 - 5 T202921 2I12 29 1810 - 21
T190767 3B21 9 2160 - 25 T201482 1F13 22 0315 - 5 T202938 3D12 2 3401 - 5
T190767 3C2 9 2160 - 31 T201537 2E24 17 1672 - 3 T202940 3D12 2 3401 - 5
T190767 3C4 12 2160 - 33 T201538 2E24 20 1672 - 3 T203143 2K6 57 1830 - 11
T190767 3C6 12 2160 - 35 T201561 2K4 47 1830 - 9 T203381 3D24 15 3440 - 9
T190814 1E8 1 0260 - 17 T201562 2K4 48 1830 - 9 T203388 3D24 16 3440 - 9
T190892 3C24 63 2163 - 7 T201564 2I22 16 1810 - 31 T203389 2L3 15 2001 - 3
T190892 3D2 63 2163 - 9 T201565 2J4 10 1810 - 37 T203390 2I10 30 1810 - 19
T191021 1C21 4 0225 - 3 T201566 2K4 49 1830 - 9 T203494 2K6 58 1830 - 11
T195587 3D6 8 2164 - 5 T201568 2K4 50 1830 - 9 T203495 2K6 59 1830 - 11
T19572 3D20 6 3440 - 5 T201570 2K6 51 1830 - 11 T203544 2J8 15 1810 - 41
T196077 1F11 5 0315 - 3 T201571 2I22 17 1810 - 31 T203545 2J8 18 1810 - 41
T196077 1F13 32 0315 - 5 T201673 2J22 7 1822 - 3 T203560 2K4 60 1830 - 9
T196077 2B22 3 0515 - 5 T201880 2I24 46 1810 - 33 T203569 2J8 32 1810 - 41
T196077 2D17 34 1060 - 3 T201880 2J2 46 1810 - 35 T203576 2J8 33 1810 - 41
T196077 2F22 24 1674 - 9 T201999 2C8 13 0560 - 3 T203589 2J8 45 1810 - 41
T196077 2H16 2 1810 - 3 T202034 2K14 34 1830 - 19 T203646 2G8 6 1674 - 21
T196077 2I10 11 1810 - 19 T202035 2K14 35 1830 - 19 T203871 2J8 34 1810 - 41
T196077 2I10 12 1810 - 19 T202074 2I2 4 1810 - 13 T203896 2I16 11 1810 - 25
T196077 2I10 25 1810 - 19 T202075 2I2 5 1810 - 13 T203912 2G6 8 1674 - 19
T196077 2I12 25 1810 - 21 T202076 2I2 2 1810 - 13 T203950 2I10 31 1810 - 19
T196077 2I14 4 1810 - 23 T202077 2I2 3 1810 - 13 T203961 2I20 18 1810 - 29
T196077 2I18 2 1810 - 27 T202078 2I2 6 1810 - 13 T203961 2I22 18 1810 - 31
T196077 2I20 15 1810 - 29 T202131 2I2 4 1810 - 13 T203984 3E22 21 3460 - 19
T196077 2I20 21 1810 - 29 T202132 2I2 5 1810 - 13 T203987 2G6 9 1674 - 19
T196077 2I22 14 1810 - 31 T202133 2I2 6 1810 - 13 T204009 2K17 25 1910 - 3
T196077 2I22 19 1810 - 31 T202159 2J10 22 1810 - 43 T204018 3F17 4 4240 - 11
T196077 2I22 20 1810 - 31 T202159 2J12 22 1810 - 45 T204044 2J10 19 1810 - 43
T196077 2K6 45 1830 - 11 T202160 2J10 10 1810 - 43 T204044 2J12 19 1810 - 45
T196077 2K6 65 1830 - 11 T202160 2J12 10 1810 - 45 T204124 2K14 37 1830 - 19
T196077 2L17 6 2007 - 3 T202161 2J10 11 1810 - 43 T204274 2K14 38 1830 - 19
T196077 2L17 7 2007 - 3 T202161 2J12 11 1810 - 45 T204278 2K6 61 1830 - 11
T196077 2L17 8 2007 - 3 T202162 2J10 12 1810 - 43 T204301 2J8 46 1810 - 41
T196078 2J8 13 1810 - 41 T202162 2J12 12 1810 - 45 T204319 2I16 12 1810 - 25
T196078 2J8 44 1810 - 41 T202162 3C10 13 2160 - 39 T204457 2J10 20 1810 - 43
T196078 2L9 4 2003 - 3 T202163 2J10 13 1810 - 43 T204457 2J12 20 1810 - 45
T196079 1F11 6 0315 - 3 T202163 2J12 13 1810 - 45 T204457 3C10 15 2160 - 39
T196079 1F13 31 0315 - 5 T202164 2J10 21 1810 - 43 T204493 2K12 39 1830 - 17
T196079 1F13 32 0315 - 5 T202164 2J12 21 1810 - 45 T204543 3D14 9 3401 - 7
T196079 2B20 5 0515 - 3 T202242 2B14 33 0510 - 7 T204543 3D16 11 3401 - 9
T196079 2F22 25 1674 - 9 T202357 2I18 3 1810 - 27 T204556 2G25 8 1740 - 7
T196079 2G10 6 1674 - 23 T202374 2J22 8 1822 - 3 T204599 2I24 22 1810 - 33
T196079 2H16 2 1810 - 3 T202586 2J10 18 1810 - 43 T204599 2J2 22 1810 - 35
T196079 2H18 16 1810 - 5 T202586 2J12 18 1810 - 45 T204635 2L3 16 2001 - 3
T196079 2I10 26 1810 - 19 T202586 3C10 14 2160 - 39 T204643 2J8 17 1810 - 41
T196079 2I12 26 1810 - 21 T202634 2B14 34 0510 - 7 T204645 2I10 32 1810 - 19
T196079 2I20 16 1810 - 29 T202653 2I24 20 1810 - 33 T204645 2I12 32 1810 - 21
T196079 2I22 15 1810 - 31 T202654 2J2 21 1810 - 35 T204678 1H7 3 0360 - 3
T196079 2I24 51 1810 - 33 T202655 2I24 20 1810 - 33 T204711 2D2 5 0960 - 9
T196079 2J2 51 1810 - 35 T202656 2J2 21 1810 - 35 T204905 3F13 18 4240 - 7
T196079 2J4 9 1810 - 37 T202687 2I10 27 1810 - 19 T204938 2L17 7 2007 - 3
T196079 2J10 17 1810 - 43 T202687 2I12 27 1810 - 21 T205065 2B8 8 0505 - 9
T196079 2J12 17 1810 - 45 T202742 2K14 47 1830 - 19 T205066 2I16 13 1810 - 25
T196079 2K4 9 1830 - 9 T202743 2K4 54 1830 - 9 T205068 2I16 14 1810 - 25
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-15
PN=623
 1L22 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
T205088 2L17 8 2007 - 3 T206718 2K4 66 1830 - 9 T213025 3B17 11 2160 - 21
T205161 2E24 18 1672 - 3 T206809 2K6 67 1830 - 11 T213025 3B19 10 2160 - 23
T205202 2H4 4 1746 - 5 T206812 2K6 68 1830 - 11 T213025 3B21 12 2160 - 25
T205235 2E24 19 1672 - 3 T206813 2K6 31 1830 - 11 T213025 3B23 3 2160 - 27
T205243 2I10 27 1810 - 19 T206985 2I12 36 1810 - 21 T213025 3B25 6 2160 - 29
T205317 2H6 6 1746 - 7 T206985 2K4 69 1830 - 9 T213025 3C2 12 2160 - 31
T205354 2I14 6 1810 - 23 T207072 2B18 41 0512 - 3 T213025 3C4 15 2160 - 33
T205367 2E3 28 1320 - 3 T207483 3D22 31 3440 - 7 T213025 3C6 15 2160 - 35
T205368 2E3 27 1320 - 3 T207637 2I12 37 1810 - 21 T213026 3B13 3 2160 - 13
T205370 2K14 39 1830 - 19 T208102 3D22 32 3440 - 7 T213027 3B13 6 2160 - 13
T205401 2J8 20 1810 - 41 T208103 3D22 33 3440 - 7 T213027 3C10 17 2160 - 39
T205452 2B8 16 0505 - 9 T208184 2K19 18 1910 - 5 T213028 3B13 6 2160 - 13
T205474 2B12 22 0510 - 5 T208242 2E22 20 1671 - 3 T213029 3B13 4 2160 - 13
T205480 2B14 36 0510 - 7 T208283 2H22 12 1810 - 9 T213030 3B13 5 2160 - 13
T205499 2I24 52 1810 - 33 T208503 2C2 6 0520 - 5 T213030 3C10 10 2160 - 39
T205499 2J2 52 1810 - 35 T208792 3D24 17 3440 - 9 T213031 3B13 5 2160 - 13
T205547 2H6 7 1746 - 7 T209581 1C23 20 0230 - 3 T213031 3B15 11 2160 - 19
T205652 2B14 37 0510 - 7 T209581 1D5 14 0240 - 3 T213031 3B17 12 2160 - 21
T205661 2I20 19 1810 - 29 T209889 2F18 5 1674 - 5 T213031 3B19 11 2160 - 23
T205662 2I20 20 1810 - 29 T209947 1F15 4 0315 - 7 T213031 3B21 13 2160 - 25
T205671 2I20 21 1810 - 29 T210043 1E14 6 0260 - 23 T213031 3C2 13 2160 - 31
T205671 2I22 19 1810 - 31 T210101 2I24 25 1810 - 33 T213031 3C4 16 2160 - 33
T205711 2B12 23 0510 - 5 T210101 2J2 25 1810 - 35 T213031 3C6 16 2160 - 35
T205713 3F23 15 4260 - 11 T210102 2I24 26 1810 - 33 T213032 3B23 5 2160 - 27
T205720 3B7 3 2160 - 5 T210102 2J2 26 1810 - 35 T213033 3B15 12 2160 - 19
T205722 2E7 11 1320 - 7 T210103 2I24 27 1810 - 33 T213033 3B17 13 2160 - 21
T205723 2E5 10 1320 - 5 T210103 2J2 27 1810 - 35 T213033 3B19 12 2160 - 23
T205818 2B14 38 0510 - 7 T210106 2I24 28 1810 - 33 T213033 3B21 14 2160 - 25
T205819 2F22 26 1674 - 9 T210106 2J2 28 1810 - 35 T213033 3C2 14 2160 - 31
T205821 2G14 12 1674 - 27 T210550 2B14 41 0510 - 7 T213033 3C4 17 2160 - 33
T205829 2F22 27 1674 - 9 T210564 2B14 42 0510 - 7 T213033 3C6 17 2160 - 35
T205883 1F2 23 0260 - 35 T210672 2F22 29 1674 - 9 T213096 3D22 34 3440 - 7
T205901 2I24 23 1810 - 33 T210698 2J8 26A 1810 - 41 T213102 3D22 35 3440 - 7
T205901 2J2 23 1810 - 35 T210699 2J8 27A 1810 - 41 T213140 2I22 20 1810 - 31
T205902 2I24 24 1810 - 33 T210700 2J8 28 1810 - 41 T213167 2I24 29 1810 - 33
T205902 2J2 24 1810 - 35 T210711 2J8 35 1810 - 41 T213167 2J2 30 1810 - 35
T205919 2E7 12 1320 - 7 T210739 2E12 13 1369 - 5 T213199 2I20 22 1810 - 29
T205920 2E5 11 1320 - 5 T210871 2E3 23 1320 - 3 T213199 2I22 21 1810 - 31
T206005 2B14 39 0510 - 7 T210933 2E3 24 1320 - 3 T213207 2E7 22 1320 - 7
T206048 1E4 26 0260 - 13 T211465 3E22 22 3460 - 19 T213209 2E5 20 1320 - 5
T206080 2J8 21 1810 - 41 T211749 3F13 22 4240 - 7 T213210 2E7 20 1320 - 7
T206088 2E3 18 1320 - 3 T211864 2I8 5 1810 - 17 T213215 2E5 19 1320 - 5
T206089 2E7 21 1320 - 7 T211868 2I8 5 1810 - 17 T213242 2J10 8 1810 - 43
T206090 2E5 21 1320 - 5 T211943 2I6 10 1810 - 15 T213242 2J12 8 1810 - 45
T206091 2E3 19 1320 - 3 T212073 2I10 36 1810 - 19 T213242 3C10 8 2160 - 39
T206095 2E3 20 1320 - 3 T21242 1I9 3 0407 - 5 T213318 3B21 15 2160 - 25
T206096 2E3 21 1320 - 3 T212452 1B19 4 0110 - 21 T213318 3C2 15 2160 - 31
T206106 2F22 28 1674 - 9 T212453 1B19 3 0110 - 21 T213318 3C4 18 2160 - 33
T206289 2E3 22 1320 - 3 T212467 2B12 25 0510 - 5 T213349 2K2 5 1830 - 5
T206290 2E7 13 1320 - 7 T212468 2B12 26 0510 - 5 T213443 2I24 31 1810 - 33
T206291 2E5 12 1320 - 5 T212793 3D20 5 3440 - 5 T213443 2J2 31 1810 - 35
T206293 2G25 9 1740 - 7 T212947 2J4 13 1810 - 37 T213444 2I24 32 1810 - 33
T206295 2E3 26 1320 - 3 T213022 3B15 8 2160 - 19 T213444 2J2 32 1810 - 35
T206296 2E7 14 1320 - 7 T213022 3B17 9 2160 - 21 T213445 2I24 33 1810 - 33
T206297 2E5 13 1320 - 5 T213022 3B19 8 2160 - 23 T213445 2J2 33 1810 - 35
T206344 2G12 4 1674 - 25 T213022 3B21 10 2160 - 25 T213447 2I24 34 1810 - 33
T206345 2E7 15 1320 - 7 T213022 3C2 10 2160 - 31 T213447 2J2 34 1810 - 35
T206346 2E5 14 1320 - 5 T213022 3C4 13 2160 - 33 T213448 2I24 35 1810 - 33
T206434 1C9 19 0201 - 5 T213022 3C6 13 2160 - 35 T213448 2J2 35 1810 - 35
T206515 2B6 2 0505 - 5 T213023 3B15 9 2160 - 19 T213449 2I24 36 1810 - 33
T206558 2B12 24 0510 - 5 T213023 3B17 10 2160 - 21 T213449 2J2 36 1810 - 35
T206594 2B14 40 0510 - 7 T213023 3B19 9 2160 - 23 T213450 2I24 36 1810 - 33
T206616 2K6 28 1830 - 11 T213023 3B21 11 2160 - 25 T213450 2J2 36 1810 - 35
T206624 2K6 62 1830 - 11 T213023 3C2 11 2160 - 31 T213451 2I24 37 1810 - 33
T206625 2K6 63 1830 - 11 T213023 3C4 14 2160 - 33 T213451 2J2 37 1810 - 35
T206626 2K6 64 1830 - 11 T213023 3C6 14 2160 - 35 T213452 2I24 38 1810 - 33
T206627 2K6 65 1830 - 11 T213025 3B15 10 2160 - 19 T213452 2J2 38 1810 - 35
II-16 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=624
 1L23 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
T213462 2E12 6 1369 - 5 T41961 1C23 16 0230 - 3 T72414 2C18 20 0930 - 3
T213516 3D18 15 3440 - 3 T41963 1C25 17 0230 - 5 T72414 2G21 7 1740 - 3
T213579 3D18 16 3440 - 3 T41982 1C25 26 0230 - 5 T72414 2G23 3 1740 - 5
T213647 2B12 27 0510 - 5 T41983 1C25 27 0230 - 5 T72856 2B14 43 0510 - 7
T213775 2B18 34 0512 - 3 T41984 1C25 28 0230 - 5 T74410 2F20 19 1674 - 7
T21387 2K17 23 1910 - 3 T42199 2E22 21 1671 - 3 T74412 2F16 14 1674 - 3
T213896 2J6 5 1810 - 39 T42217 2C24 8 0960 - 7 T74412 2F18 6 1674 - 5
T213917 2I6 11 1810 - 15 T42243 3D18 17 3440 - 3 T74412 2G2 13 1674 - 15
T214023 2I2 7 1810 - 13 T42302 3B5 62 2160 - 3 T74416 2B16 20 0510 - 11
T214023 2I4 4 1810 - 13B T42302 3E2 25 3450 - 3 T74416 2F16 15 1674 - 3
T214109 1D25 7 0260 - 9 T42302 3E4 25 3450 - 5 T74416 2F18 7 1674 - 5
T214110 1D25 18 0260 - 9 T42574 3D22 37 3440 - 7 T74416 2G2 16 1674 - 15
T214111 1E2 18 0260 - 11 T42582 3D22 38 3440 - 7 T75276 2F14 10 1673 - 15
T214145 1D25 20 0260 - 9 T42583 3D22 39 3440 - 7 T75276 2F16 16 1674 - 3
T214426 2B12 33 0510 - 5 T42589 3D22 20 3440 - 7 T75276 2G4 10 1674 - 17
T214971 2E7 5 1320 - 7 T42598 3E20 13 3460 - 17 T75447 1D23 7 0260 - 7
T214972 2E5 4 1320 - 5 T42843 2G23 4 1740 - 5 T75644 1C23 10 0230 - 3
T215218 2H22 14 1810 - 9 T42844 2G23 5 1740 - 5 T75644 1D5 15 0240 - 3
T215268 2E3 17 1320 - 3 T43726 3D14 11 3401 - 7 T75644 2E14 7 1370 - 3
T215269 2E7 16 1320 - 7 T43726 3D16 13 3401 - 9 T76127 3B13 6 2160 - 13
T215270 2E5 15 1320 - 5 T53268 1J4 3 0418 - 3 T76128 3B13 5 2160 - 13
T215319 2I12 39 1810 - 21 T54904 3B5 10 2160 - 3 T76252 2B6 20 0505 - 5
T215319 2K4 70 1830 - 9 T54904 3B5 58 2160 - 3 T76252 2G2 15 1674 - 15
T215784 2G8 10 1674 - 21 T55210 2J20 3 1821 - 9 T76691 2B24 6 0520 - 3
T217194 2B14 42 0510 - 7 T55222 2J20 8 1821 - 9 T76719 3C18 15 2163 - 3
T217649 2J8 26A 1810 - 41 T55224 2J16 16 1821 - 5 T76833 2I6 12 1810 - 15
T217649 2J8 26B 1810 - 41 T55224 2J20 12 1821 - 9 T76938 1E24 1 0260 - 33
T217649 2J8 27A 1810 - 41 T55501 2G14 13 1674 - 27 T76938 1F2 8 0260 - 35
T217649 2J8 28 1810 - 41 T58056 2K14 16 1830 - 19 T76938 2C18 8 0930 - 3
T217650 2J8 26A 1810 - 41 T58542 2H22 10 1810 - 9 T76938 3B5 41 2160 - 3
T217650 2J8 27A 1810 - 41 T59014 1D21 5 0260 - 5 T77067 3E16 29 3460 - 13
T217650 2J8 27B 1810 - 41 T59014 1E2 4 0260 - 11 T77613 1D21 9 0260 - 5
T217650 2J8 28 1810 - 41 T59506 3F9 9 4240 - 3 T77613 1E4 12 0260 - 13
T23027 2L15 4 2005 - 3 T59932 1B3 4 0110 - 3 T77613 1E12 10 0260 - 21
T23891 1J14 2 0433 - 1 T59932 1B13 4 0110 - 13 T77613 1E16 21 0260 - 25
T24212 3B5 30 2160 - 3 T59933 1B5 4 0110 - 5 T77613 1F4 23 0260 - 37
T24212 3B5 42 2160 - 3 T59933 1B11 4 0110 - 11 T77613 2B16 12 0510 - 11
T24510 3D22 36 3440 - 7 T59933 1B15 4 0110 - 15 T77613 2D4 3 0960 - 11
T24513 2B18 25 0512 - 3 T59933 1B19 2 0110 - 21 T77613 2D6 6 0960 - 13
T25875 3F9 12 4240 - 3 T59938 2J8 38 1810 - 41 T77613 2D8 3 0960 - 15
T27077 2J24 7 1830 - 3 T59974 3D18 8 3440 - 3 T77613 2D10 3 0960 - 17
T27183 1B3 3 0110 - 3 T6Y0309 3F13 23 4240 - 7 T77613 2D12 6 0960 - 19
T27183 1B13 3 0110 - 13 T6Y5230 3F9 7 4240 - 3 T77613 2D17 5 1060 - 3
T27184 1B3 5 0110 - 3 T6Y5230 3F17 2 4240 - 11 T77613 2D19 4 1060 - 5
T27184 1B13 5 0110 - 13 T60260 3D22 40 3440 - 7 T77613 3B23 10 2160 - 27
T27193 1B5 3 0110 - 5 T60811 2B8 11 0505 - 9 T77613 3B25 9 2160 - 29
T27193 1B11 3 0110 - 11 T60811 2E10 3 1369 - 3 T77613 3C12 2 2160 - 41
T27193 1B15 3 0110 - 15 T60811 2J24 5 1830 - 3 T77613 3C18 6 2163 - 3
T27194 1B5 5 0110 - 5 T61861 1E14 9 0260 - 23 T77613 3E18 3 3460 - 15
T27194 1B11 5 0110 - 11 T63019 2F22 17 1674 - 9 T77613 3E20 7 3460 - 17
T27194 1B15 5 0110 - 15 T63019 2I10 13 1810 - 19 T77613 3E22 10 3460 - 19
T27260 2K17 24 1910 - 3 T63019 2L17 3 2007 - 3 T77613 3F2 5 3460 - 23
T27860 1J16 18 0433 - 3 T63224 2E7 17 1320 - 7 T77613 3F6 3 3460 - 27
T28862 3E22 23 3460 - 19 T63225 2E5 16 1320 - 5 T77613 3F19 3 4260 - 7
T29342 1E4 25 0260 - 13 T63798 2J20 11 1821 - 9 T77613 3F21 3 4260 - 9
T29342 3B5 2 2160 - 3 T66419 2E22 15 1671 - 3 T77613 3F23 5 4260 - 11
T32854 2B16 21 0510 - 11 T66702 3D10 1 3401 - 3 T77706 2G25 10 1740 - 7
T33372 3D18 14 3440 - 3 T66703 3D10 1 3401 - 3 T77814 1C17 2 0210 - 9
T33933 1C23 3 0230 - 3 T66704 3D10 1 3401 - 3 T77814 3C12 6 2160 - 41
T33933 1D5 8 0240 - 3 T66707 3D10 1 3401 - 3 T77814 3C24 23 2163 - 7
T35390 1H25 14 0404 - 3 T66708 3D14 12 3401 - 7 T77814 3D2 23 2163 - 9
T38282 1F19 13 0341 - 3 T66708 3D16 14 3401 - 9 T77814 3E20 3 3460 - 17
T38282 2D17 35 1060 - 3 T66709 3D14 12 3401 - 7 T77857 1E16 23 0260 - 25
T38377 1E22 14 0260 - 31 T66709 3D16 14 3401 - 9 T77857 1E20 6 0260 - 29
T41677 1C9 26 0201 - 5 T70438 3E20 14 3460 - 17 T77857 1E22 5 0260 - 31
T41953 1C25 15 0230 - 5 T71306 1C9 12 0201 - 5 T77857 1E24 7 0260 - 33
T41953 1D23 16 0260 - 7 T72414 2C6 15 0540 - 3 T77857 1F2 3 0260 - 35
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-17
PN=625
 1L24 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
T77857 1F4 11 0260 - 37 T82886 2G21 8 1740 - 3 YZ101612 1H4 12 0350 - 35
T77857 2B8 17 0505 - 9 T83426 2F2 6 1673 - 3 YZ101905 1G24 3 0350 - 31
T77857 2C18 5 0930 - 3 T83426 2H8 3 1747 - 3 YZ102234 1G4 6 0350 - 9
T77857 2D4 7 0960 - 11 T83426 2H10 4 1749 - 3 YZ102752 1G2 8 0350 - 7
T77857 2D6 3 0960 - 13 T83426 3D22 30 3440 - 7 YZ102996 1G12 1 0350 - 19
T77857 2D12 3 0960 - 19 T9W2668 3F13 25 4240 - 7 YZ103040 1G14 12 0350 - 21
T77857 2D24 4 1111 - 5 UN7189 1C13 .. 0210 - 5 YZ103040 1G16 12 0350 - 23
T77857 2E12 7 1369 - 5 U10746 3F11 11 4240 - 5 YZ103042 1E24 9 0260 - 33
T77857 3F2 10 3460 - 23 U12167 3F9 27 4240 - 3 YZ103067 1G22 2 0350 - 29
T77857 3F4 7 3460 - 25 U12547 1D21 20 0260 - 5 YZ103100 1G14 14 0350 - 21
T77858 1D21 10 0260 - 5 U12547 1E16 10 0260 - 25 YZ103102 1G16 13 0350 - 23
T77858 1E16 8 0260 - 25 U12547 1E20 3 0260 - 29 YZ103111 1G12 13 0350 - 19
T77858 1E20 2 0260 - 29 U12547 1E22 8 0260 - 31 YZ103112 1G12 14 0350 - 19
T77858 1F4 6 0260 - 37 U12547 1E24 10 0260 - 33 YZ103113 1G10 14 0350 - 17
T77858 1H7 5 0360 - 3 U12547 1F2 4 0260 - 35 YZ103114 1H4 1 0350 - 35
T77858 1H11 2 0363 - 3 U12547 1F4 7 0260 - 37 YZ103115 1G22 4 0350 - 29
T77858 2C18 13 0930 - 3 U12547 1F6 12 0260 - 39 YZ103129 1G12 17 0350 - 19
T77858 2D24 7 1111 - 5 U12547 1H7 6 0360 - 3 YZ103129 1G16 17 0350 - 23
T77858 2E12 14 1369 - 5 U12547 1H11 13 0363 - 3 YZ103130 1G16 1 0350 - 23
T77858 3C20 4 2163 - 5 U12547 2D24 19 1111 - 5 YZ103144 1G14 20 0350 - 21
T77858 3C22 4 2163 - 5B U12547 2E12 15 1369 - 5 YZ103146 1F22 7 0350 - 3
T77858 3C24 24 2163 - 7 U12547 3C20 2 2163 - 5 YZ103146 1F24 12 0350 - 5
T77858 3D2 24 2163 - 9 U12547 3C22 2 2163 - 5B YZ103146 1G2 4 0350 - 7
T77932 1F4 13 0260 - 37 U12547 3C24 27 2163 - 7 YZ103148 1F22 3 0350 - 3
T77932 2C18 10 0930 - 3 U12547 3D2 27 2163 - 9 YZ103148 1F24 4 0350 - 5
T77932 3C24 25 2163 - 7 U13639 1H5 5 0350 - 36 YZ103185 1G22 3 0350 - 29
T77932 3D2 25 2163 - 9 U13639 1H25 7 0404 - 3 YZ103188 1G8 2 0350 - 15
T77932 3F4 3 3460 - 25 U13639 1J18 23 0452 - 3 YZ103188 1G20 2 0350 - 27
T78313 1E16 6 0260 - 25 U17408 1H19 2 0402 - 3 YZ103405 1F22 11 0350 - 3
T78313 3C24 26 2163 - 7 U17409 1C7 7 0201 - 3 YZ103405 1F24 17 0350 - 5
T78313 3D2 26 2163 - 9 U17409 1C9 23 0201 - 5 YZ103455 1F24 21 0350 - 5
T78497 2D24 15 1111 - 5 U17409 1C15 5 0210 - 7 YZ103847 1G8 1 0350 - 15
T78497 3C24 52 2163 - 7 U17409 1C15 8 0210 - 7 YZ103875 1G14 17 0350 - 21
T78497 3D2 52 2163 - 9 U17409 1C19 30 0210 - 11 YZ103876 1G14 16 0350 - 21
T78593 2B6 13 0505 - 5 U17409 1D13 4 0250 - 5 YZ104048 1F19 9 0341 - 3
T78612 1H5 6 0350 - 36 U17409 1I12 5 0407 - 9 YZ104052 1G22 1 0350 - 29
T78662 1C7 8 0201 - 3 U17409 1I12 15 0407 - 9 YZ104087 1G2 10 0350 - 7
T78662 1C9 24 0201 - 5 U17409 1J18 21 0452 - 3 YZ104088 1G18 3 0350 - 25
T78662 1D13 3 0250 - 5 U41528 3F9 28 4240 - 3 YZ104114 1G4 18 0350 - 9
T78707 1E14 7 0260 - 23 U42208 2B12 28 0510 - 5 YZ104121 1G4 19 0350 - 9
T78715 1E14 8 0260 - 23 U42208 3C16 7 2160 - 45 YZ104125 1G4 7 0350 - 9
T78716 2D12 11 0960 - 19 U42462 1C25 29 0230 - 5 YZ104140 1G4 25 0350 - 9
T78716 2D24 18 1111 - 5 U42702 1E18 4 0260 - 27 YZ104154 1G20 1 0350 - 27
T78787 1F13 33 0315 - 5 U42702 3E2 34 3450 - 3 YZ104170 1G4 27 0350 - 9
T78787 2F16 15 1674 - 3 U42702 3E4 48 3450 - 5 YZ104179 1H2 2 0350 - 33
T78787 2F20 17 1674 - 7 U42702 3E8 29 3460 - 5 YZ104180 1H2 3 0350 - 33
T78787 2G4 9 1674 - 17 U43012 2I10 40 1810 - 19 YZ104198 1H2 1 0350 - 33
T79477 2B14 20 0510 - 7 U43021 2I12 42 1810 - 21 YZ104198 1H4 1 0350 - 35
T79477 2B14 22 0510 - 7 U44115 1F24 1 0350 - 5 YZ104237 1G24 2 0350 - 31
T8E6359 3F13 24 4240 - 7 U44115 1G6 5 0350 - 13 YZ104280 1G2 5 0350 - 7
T80123 3E4 42 3450 - 5 U44115 1H4 5 0350 - 35 YZ104280 1G4 30 0350 - 9
T80394 2F10 10 1673 - 11 U44537 2F4 4 1673 - 5 YZ104281 1G8 3 0350 - 15
T80394 2F12 7 1673 - 13 U44915 2C24 9 0960 - 7 YZ104281 1G18 2 0350 - 25
T80938 1C17 1 0210 - 9 U46457 3C24 28 2163 - 7 YZ104653 1G18 1 0350 - 25
T81012 2J8 36 1810 - 41 U46457 3D2 28 2163 - 9 YZ104678 1G4 18 0350 - 9
T81029 2D12 12 0960 - 19 W37636 1H4 17 0350 - 35 YZ104733 1G14 21 0350 - 21
T81029 3F23 16 4260 - 11 YZ100100 1F22 16 0350 - 3 YZ104746 1G4 17 0350 - 9
T81674 3D22 41 3440 - 7 YZ100100 1F24 24 0350 - 5 YZ104871 1G22 16 0350 - 29
T82612 3F2 23 3460 - 23 YZ100356 1G14 11 0350 - 21 YZ104908 1G10 9 0350 - 17
T82791 2F22 30 1674 - 9 YZ100356 1G16 11 0350 - 23 YZ104908 1G12 9 0350 - 19
T82791 2I10 33 1810 - 19 YZ100952 1G22 8 0350 - 29 YZ104959 1H2 4 0350 - 33
T82791 2I12 33 1810 - 21 YZ101349 1G22 6 0350 - 29 YZ105042 1F19 10 0341 - 3
T82792 2F22 31 1674 - 9 YZ101350 1G22 7 0350 - 29 YZ105059 1G10 13 0350 - 17
T82792 2I10 34 1810 - 19 YZ101353 1G2 9 0350 - 7 YZ105065 1H4 3 0350 - 35
T82792 2I12 34 1810 - 21 YZ101474 1F22 2 0350 - 3 YZ105094 1F24 3 0350 - 5
T82855 3D22 42 3440 - 7 YZ101474 1F24 2 0350 - 5 YZ105096 1F22 5 0350 - 3
T82861 2G8 11 1674 - 21 YZ101474 1G6 2 0350 - 13 YZ105096 1F24 10 0350 - 5
II-18 770D/772D MOTOR GRADER PC9449 (30-AUG-05)
PN=626
 1L25 770D/772D MOTOR GRADER
NUMERICAL INDEX - CONTINUED

PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE PART NO. GRID KEY PAGE
YZ105097 1F22 6 0350 - 3 YZ106211 1G10 9 0350 - 17 4008521 1G14 5 0350 - 21
YZ105097 1F24 11 0350 - 5 YZ106211 1G12 9 0350 - 19 4008521 1G16 5 0350 - 23
YZ105122 1F24 15 0350 - 5 YZ106212 1G14 9 0350 - 21 4009711 1G10 7 0350 - 17
YZ105258 1H5 1 0350 - 36 YZ106212 1G16 9 0350 - 23 4009711 1G12 7 0350 - 19
YZ105259 1G4 9 0350 - 9 YZ106316 1H4 3 0350 - 35 4009711 1G14 8 0350 - 21
YZ105319 1F24 9 0350 - 5 YZ120167 1C11 1 0210 - 3 4009711 1G16 8 0350 - 23
YZ105320 1F24 7 0350 - 5 YZ120386 1C19 14 0210 - 11
YZ105354 1G4 20 0350 - 9 YZ120398 1C19 3 0210 - 11
YZ105375 1F22 11 0350 - 3 YZ120442 1C16 1 0210 - 8
YZ105375 1F24 17 0350 - 5 YZ120455 1C15 11 0210 - 7
YZ105385 1F22 1 0350 - 3 YZ120471 1C19 16 0210 - 11
YZ105385 1F24 1 0350 - 5 YZ120503 1C19 23 0210 - 11
YZ105386 1G22 11 0350 - 29 YZ120508 1C17 3 0210 - 9
YZ105415 1G10 15 0350 - 17 YZ120522 1C15 23 0210 - 7
YZ105415 1G12 15 0350 - 19 YZ120589 1C11 1 0210 - 3
YZ105415 1G16 15 0350 - 23 YZ120595 1C11 1 0210 - 3
YZ105419 1F19 11 0341 - 3 YZ120661 1C11 1 0210 - 3
YZ105419 1F19 21 0341 - 3 YZ120662 1C11 1 0210 - 3
YZ105443 1G14 13 0350 - 21 YZ120690 1C19 23 0210 - 11
YZ105454 1G10 11 0350 - 17 YZ120826 1C16 9 0210 - 8
YZ105454 1G12 11 0350 - 19 YZ120859 1C19 4 0210 - 11
YZ105463 1G16 1 0350 - 23 YZ120859 1C19 11 0210 - 11
YZ105464 1G14 1 0350 - 21 YZ120909 1C19 22 0210 - 11
YZ105465 1G10 12 0350 - 17 YZ120909 1C19 24 0210 - 11
YZ105465 1G12 12 0350 - 19 YZ120912 1C19 11 0210 - 11
YZ105485 1G10 18 0350 - 17 YZ120913 1C19 4 0210 - 11
YZ105485 1G12 18 0350 - 19 YZ150041 1G10 17 0350 - 17
YZ105485 1G14 18 0350 - 21 YZ150119 1G10 2 0350 - 17
YZ105485 1G16 18 0350 - 23 YZ150119 1G12 2 0350 - 19
YZ105486 1H4 3 0350 - 35 YZ150119 1G14 2 0350 - 21
YZ105493 1G10 10 0350 - 17 YZ150119 1G16 2 0350 - 23
YZ105493 1G12 10 0350 - 19 YZ150141 1H4 4 0350 - 35
YZ105494 1G14 10 0350 - 21 YZ150185 1G14 9 0350 - 21
YZ105494 1G16 10 0350 - 23 YZ150185 1G16 9 0350 - 23
YZ105508 1G10 1 0350 - 17 YZ150204 1H4 16 0350 - 35
YZ105509 1G12 1 0350 - 19 YZ150217 1G14 11 0350 - 21
YZ105533 1G2 1 0350 - 7 YZ150217 1G16 11 0350 - 23
YZ105538 1F24 1 0350 - 5 YZ250086 1G4 23 0350 - 9
YZ105538 1G6 7 0350 - 13 YZ250161 1G8 4 0350 - 15
YZ105539 1F24 1 0350 - 5 YZ250161 1G10 19 0350 - 17
YZ105539 1G6 10 0350 - 13 YZ250161 1G12 19 0350 - 19
YZ105575 1G6 1 0350 - 13 YZ250161 1G14 19 0350 - 21
YZ105685 1G24 1 0350 - 31 YZ250161 1G16 19 0350 - 23
YZ105689 1G10 4 0350 - 17 YZ250249 1H4 2 0350 - 35
YZ105689 1G12 4 0350 - 19 YZ250262 1G2 8 0350 - 7
YZ105689 1G14 4 0350 - 21 YZ501639 1H4 2 0350 - 35
YZ105689 1G16 4 0350 - 23 YZ501931 1H4 4 0350 - 35
YZ105724 1G4 21 0350 - 9 YZ502169 1H4 16 0350 - 35
YZ105851 1G2 9 0350 - 7 Z21059 2J8 37 1810 - 41
YZ105856 1F11 7 0315 - 3 Z21059 2J8 37A 1810 - 41
YZ105891 1G14 10 0350 - 21 Z40239 3E2 26 3450 - 3
YZ105891 1G16 10 0350 - 23 40B1113 1G8 4 0350 - 15
YZ105892 1G10 10 0350 - 17 400R 1C19 1 0210 - 11
YZ105892 1G12 10 0350 - 19 4001456 3B5 23 2160 - 3
YZ105893 1G24 4 0350 - 31 4003725 1G10 6 0350 - 17
YZ105914 1G24 2 0350 - 31 4003725 1G12 6 0350 - 19
YZ105982 1G14 12 0350 - 21 4003725 1G14 6 0350 - 21
YZ105982 1G16 12 0350 - 23 4003725 1G16 6 0350 - 23
YZ106078 1G10 16 0350 - 17 4005234 1G22 15 0350 - 29
YZ106078 1G12 16 0350 - 19 4008023 1G2 3 0350 - 7
YZ106078 1G16 16 0350 - 23 4008024 1G2 2 0350 - 7
YZ106163 1G14 16 0350 - 21 4008520 1G10 4 0350 - 17
YZ106184 1G10 17 0350 - 17 4008520 1G12 4 0350 - 19
YZ106185 1G12 17 0350 - 19 4008520 1G14 4 0350 - 21
YZ106185 1G16 17 0350 - 23 4008520 1G16 4 0350 - 23
YZ106202 1G8 1 0350 - 15 4008521 1G10 5 0350 - 17
YZ106205 1G6 1 0350 - 13 4008521 1G12 5 0350 - 19
770D/772D MOTOR GRADER PC9449 (30-AUG-05) II-19
PN=627