Copperfield

Troubleshooting Guides
Copperfield EE Team
Date

2015 Lenovo Confidential. All rights reserved.

 TABLE OF CONTENTS
1. Snapshots of Antennas …………………………..…………………………………..
2. Snapshots of Main Board .……………………….………………………………….
3. LTE/WCDMA/CDMA/GSM Troubleshooting ………………………………………
4. GPS Troubleshooting ………………………………………………………………
5. WLAN / BT / FM / DTV Troubleshooting …………………………………………
6. Charging Troubleshooting …………………………………………………………
7. LED/Prox & IR Sensor/uSIM Troubleshooting ……..…………………………..
8. Vibrator and Sensors Troubleshooting ………………………………………….
9. Touch Troubleshooting …………………………………………………………....
10. Display Troubleshooting …………………………………………………….…..
11. Camera Troubleshooting …………………………………………………………
12. Audio Troubleshooting …………………………………………………………..

2015 Lenovo Confidential. All rights reserved.

 SNAPSHOTS OF ANTENNAS

2015 Lenovo Confidential. All rights reserved.

2015 Lenovo Confidential. All rights reserved.
 SNAPSHOTS OF MAIN BOARD

2015 Lenovo Confidential. All rights reserved.

2015 Lenovo Confidential. All rights reserved.
 LTE/WCDMA/CDMA/GSM
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

RF BLOCK

2015 Lenovo Confidential. All rights reserved.

 FDD Band
Several FDD Band（WCDMA LTE and CDMA）have the shared path below：
WCDMA band1 and LTE band1；
WCDMA band2,LTE band2,band25 and CDMA BC1；
WCDMA band5,B19,LTE band5,band26 and CDMA BC0,BC10；
WCDMA band8 and LTE band8.

Mainly devices on FDD path about :

Two PA:U6100（SKY77651）band support B5（B19，B26）,B8，B12，B13,B17，B20，B28；U6200（SKY77652）band
support B1，B2（B25），B3，B4，B7，B38，B40，B41；Antenna Switch and GSM PA module:U6000（SKY77928）.

Now taking an example of Middle Band LTE band1（WCDMA band1）and High Band7 to introduce RF Path：

2015 Lenovo Confidential. All rights reserved.

 LTE/WCDMA B1 Tx and Rx

2015 Lenovo Confidential. All rights reserved.

 LTE/WCDMA B1 Tx Check Chart – No Tx
START

WTR2965 FAIL CHECK & REPLACE

Voltage CHECK ? R5506,R5503,R5505
OK

FAIL
TX VOLTAGE
CHECK & REPLACE
CHECK?
C6290,C6291,C6294,C6292,C6293,C6295,C6297,
OK

FAIL
PA MODE & MATCH
CHECK? CHECK & REPLACE
L6202,C6207,C6205,FL6200,C6204,L6201,C6003,C6004
OK

FAIL
DUPLEXER & SP16T CHECK & REPLACE
CHECK ? C6421,FL6403,C6422,C6425,C6426,C6428,C6415,C6439,L6414
OK

FAIL
COUPLE R & RF CHECK & REPLACE
CONNECTOR CHECK ? C8000,L8000,J8000,C8002,R8001,R8002,C8001
OK

FAIL
TX LEVEL 2 Go to TX CHECK CHART- Low TX
CHECK ?
OK

2015 Lenovo Confidential. All rights reserved. END

 LTE/WCDMA B1 Tx Check Chart – Low Tx
2

OK

WTR2965 FAIL
CHECK & REPLACE
TX Level L6202,C6207,C6205,FL6200,C62
CHECK ? 04,L6201,C6003,C6004
OK

PAM GAIN FAIL CHECK & REPLACE

& DPX
C6419,C6421,FL6403,L6409,C642
LOSS
2,C6425
CHECK ?
OK

SP16T FAIL
LOSS CHECK & REPLACE
CHECK ? U6000
OK

COUPLER
& RF FAIL
CHECK & REPLACE
CONNECT
C8000,L8000,J8000
OR
CHECK
OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE/WCDMA B1 PRx Check Chart
START

XO FAIL CHECK & REPLACE

Frequency C5500,R5510,C5502
CHECK ?
OK

WTR2965 FAIL CHECK & REPLACE

Voltage R5506,R5503,R5505
CHECK ?
OK

DPX & FAIL

CHECK & REPLACE
MATCHIN C6426,C6428,C6415,C6439,L6414,L
G CHECK 6413,C6430
?
OK

SP16T,
FAIL
COUPLER, CHECK & REPLACE
RF
OK CON. U6000,C8000,L8000,J8000
CHECK ?
OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE/WCDMA B1 DRx Check Chart
START

XO FAIL CHECK & REPLACE

Frequency C5500,R5510,C5502
CHECK ?
OK

WTR2965 FAIL CHECK & REPLACE

Voltage R5506,R5503,R5505
CHECK ?
OK

Filter & FAIL CHECK & REPLACE

MATCHIN L6816,C6842,C6805,L6817,L6802,FL68
G CHECK 00,C6815,L6809,R6802,C6822
?
OK

CHECK & REPLACE

FAIL
SP12T C6792,C6793,C6794,C6795,C6729,C
CHECK
OK ? 6727,FL6704,C6735,L6719,L8010,J8
010
OK

END

2015 Lenovo Confidential. All rights reserved.

 B1 TRx Circuits

2015 Lenovo Confidential. All rights reserved.

 B1 DRx Circuits

2015 Lenovo Confidential. All rights reserved.

 B1 TRx Circuits (WTR+PA+DPX+SP16T) Layout

2015 Lenovo Confidential. All rights reserved.

 B1 DRx Circuits (WTR+SP12T) Layout

2015 Lenovo Confidential. All rights reserved.

 LTE B7 Tx and Rx

2015 Lenovo Confidential. All rights reserved.

 LTE B7 TX Check Chart – No TX(NA SKU)
START

CHECK & REPLACE

WTR2965 FAIL
Voltage CHECK ? R5506,R5503,R5505
OK

TX VOLTAGE FAIL
CHECK & REPLACE
CHECK?
C6290,C6291,C6294,C6292,C6293,C6295,C6297,
OK

PA MODE & FAIL

MATCH CHECK? CHECK & REPLACE
C6200,L6200,L6210,C6201,C6202
OK

DUPLEXER & FAIL

CHECK & REPLACE
SP16T CHECK ? L6300,C6300,FL6300,L6301,C6302
OK

COUPLE R & RF FAIL

CHECK & REPLACE
CON. CHECK ?
C8003,L8001,J8001
OK
FAIL Go to TX CHECK CHART- Low TX
TX LEVEL 2
CHECK ?
OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE B7 TX Check Chart – Low TX(NA SKU)
2

OK

WTR2965 FAIL CHECK & REPLACE

TX Level C6290,C6291,C6294,C6292,C6293,C6295,C62
CHECK ?
97,
OK

PAM GAIN & FAIL

CHECK & REPLACE
DPX LOSS
U6000,L6300,C6300,FL6300,L6301,C6302
CHECK ?

OK

SP16T LOSS FAIL

CHECK & REPLACE
CHECK ? U6000

OK

COUPLER & RF FAIL

CHECK & REPLACE
CONNECTOR
C8003,L8001,J8001
CHECK ?
OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE B7 RX Check Chart – (NA SKU)

START

CHECK & REPLACE

XO Frequency FAIL
C5500,R5510,C5502
CHECK ?

OK
CHECK & REPLACE
WTR2965 FAIL
Voltage CHECK R5506,R5503,R5505
?

OK

FAIL CHECK & REPLACE

DPX &
C6302,L6301,FL6300,L6302,C6305,C6325,U6301,C6
MATCHING
328,L6304,L6303,C6307
CHECK ?

OK

SP16T,
COUPLER FAIL CHECK & REPLACE
RF CON. U6000,C8003,L8001,J8001
OK
CHECK ?

OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE B7 DRX Check Chart – (NA SKU)

START

CHECK & REPLACE

XO Frequency FAIL
C5500,R5510,C5502
CHECK ?

OK

WTR2965 CHECK & REPLACE

FAIL
Voltage CHECK R5506,R5503,R5505
?

OK

FAIL CHECK & REPLACE

FILTER &
C6726,C6715,C6717,FL6703,C6718,C6721,U6701,C
MATCHING
6723,C6720,,L6710,C6725,L6711
CHECK ?

OK

SP12T FAIL CHECK & REPLACE

RF CON. U6700,C6729,FL6704,L6719,C6735,L8010,J8010,C8
OK
CHECK ? 030,R8027,R8028.

OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE B7 TRX Path for NA

2015 Lenovo Confidential. All rights reserved.

 LTE B7 TRX Path for NA
bottom side top side

2015 Lenovo Confidential. All rights reserved.

 LTE B7 DRX Path for NA

2015 Lenovo Confidential. All rights reserved.

 LTE B7 DRX Path for NA
bottom side

2015 Lenovo Confidential. All rights reserved.

 TDD Band
TDD-LTE support Band38,Band40 and Band41.Band38 and Band41 have the
shared path；
As for Band41，NA SKU support band41 full band（2496~2690Mhz），
EMEA+APAC SKU are narrow band41（2555Mhz~2655Mhz），
now the following will introduce B38/41 TDD Frequency Path.

2015 Lenovo Confidential. All rights reserved.

 LTE B38/41 TX Check Chart – No TX(NA SKU)
START

CHECK & REPLACE

WTR2965 FAIL
Voltage CHECK ? R5506,R5503,R5505
OK

TX VOLTAGE FAIL
CHECK & REPLACE
CHECK?
C6290,C6291,C6294,C6292,C6293,C6295,C6297,
OK

PA MODE & FAIL

MATCH CHECK? CHECK & REPLACE
U6200,C6200,L6200,L6210,C6201,C6202
OK

DUPLEXER & FAIL

CHECK & REPLACE
SP16T CHECK ? C6331,L6321,FL6302,L6326,C6335,L6331,C6341,L6330,C6340
OK

COUPLE R & RF FAIL

CHECK & REPLACE
CON. CHECK ?
C8003,L8001,J8001
OK
FAIL Go to TX CHECK CHART- Low TX
TX LEVEL 2
CHECK ?
OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE B38/41 TX Check Chart – Low TX(NA SKU)
2

OK

WTR2965 FAIL CHECK & REPLACE

TX Level C6290,C6291,C6294,C6292,C6293,C6295,C62
CHECK ?
97,
OK

PAM GAIN & FAIL CHECK & REPLACE

DPX LOSS C6331,L6321,FL6302,L6326,C6335,L6331,C6341,L6330,C6
CHECK ? 340

OK

SP16T LOSS FAIL

CHECK & REPLACE
CHECK ? U6000

OK

COUPLER & RF FAIL

CHECK & REPLACE
CONNECTOR
C8003,L8001,J8001
CHECK ?
OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE B38/41 RX Check Chart – (NA SKU)

START

CHECK & REPLACE

XO Frequency FAIL
C5500,R5510,C5502
CHECK ?

OK
CHECK & REPLACE
WTR2965 FAIL
Voltage CHECK R5506,R5503,R5505
?

OK

FAIL CHECK & REPLACE

DPX &
C6331,L6321,FL6302,L6326,C6335,L6331,C6341,L6
MATCHING
330,C6340,C6323,L6319,C6326,U6301,C6328,L6304
CHECK ?
,L6303,C6307

OK

SP16T,
COUPLER FAIL CHECK & REPLACE
RF CON. U6000,C8003,L8001,J8001
OK
CHECK ?

OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE B38/41 DRX Check Chart – (NA SKU)

START

CHECK & REPLACE

XO Frequency FAIL
C5500,R5510,C5502
CHECK ?

OK

WTR2965 CHECK & REPLACE

FAIL
Voltage CHECK R5506,R5503,R5505
?

OK

FAIL CHECK & REPLACE

FILTER &
C6707,L6707,FL6701,C6708,C6712,U6701,C6723,C
MATCHING
6720,L6711,L6710,C6725
CHECK ?

OK

SP12T FAIL CHECK & REPLACE

RF CON. U6700,C6729,FL6704,L6719,C6735,L8010,J8010,C8
OK
CHECK ? 030,R8027,R8028.

OK

END

2015 Lenovo Confidential. All rights reserved.

 LTE B38/41 TRx Circuits

2015 Lenovo Confidential. All rights reserved.

 LTE B38/41 DRX Path

2015 Lenovo Confidential. All rights reserved.

 LTE B38/41 TRx Path

2015 Lenovo Confidential. All rights reserved.

 LTE B38/41 DRx Path

2015 Lenovo Confidential. All rights reserved.

 GSM Section
Transmitter Path
GSM850/GSM900 mainly devices on GSM_LB transmitter path：U5500（Transceiver）,U6000（PA）
,C6003,C6004.
DCS1800/PCS1900 mainly devices on GSM_HB transmitter path：U5500（Transceiver）,U6000（PA）,
C6006,C6007

Receiver Path
GSM850 WCDMA and LTE band5；GSM900 WCDMA and LTE band8；
For NA SKU，DCS1800 WCDMA and LTE band3；PCS1900 WCDMA and LTE band2；
For other SKUs（Latam，Brazil，EMEA+APAC and India）,DCS1800 and PCS1900 have the same receiver
path.

2015 Lenovo Confidential. All rights reserved.

 GSM RX

2015 Lenovo Confidential. All rights reserved.

 GSM RX Check Chart

START

CHECK & REPLACE

XO Frequency FAIL
C5500,R5510,C5502
CHECK ?

OK

WTR2965 CHECK & REPLACE

FAIL
Voltage CHECK R5506,R5503,R5505
?

OK

CHECK & REPLACE

FAIL PCS:C6522,L6513,FL6501,C6514,C6516,C6519,C6520,C6524,L6516,C6530
DPX &
DCS:C6502,C6501,L6502,FL6500,L6504,C6527,C6505,C6507,L6506,L6505,C6509
MATCHING
EGSM:C6671,L6672,FL6670,L6674,C6674,C6676,L6675
CHECK ?
G850:L6680,L6679,FL6671,C6679,L6681,L6682,C6680

OK

SP16T,
COUPLER FAIL CHECK & REPLACE
RF CON. U6000,C8000,L8000,J8000,R8001,R8002,C8001,
OK
CHECK ?

OK

END

2015 Lenovo Confidential. All rights reserved.

 GSM G850 / G900 RX

2015 Lenovo Confidential. All rights reserved.

 GSM DCS/PCS RX-NA SKU

2015 Lenovo Confidential. All rights reserved.

 GSM DCS/PCS RX-Other SKU（Latam，Brazil，EMEA+APAC and India）

2015 Lenovo Confidential. All rights reserved.

 GSM RX-NASKU

2015 Lenovo Confidential. All rights reserved.

 GSM DCS/PCS RX-Other SKU（Latam，Brazil，EMEA+APAC and India）

SKY77928-21

Ant Connector

2015 Lenovo Confidential. All rights reserved.

 GSM Quad Band Tx Check Chart
START

CHECK & REPLACE

WTR2965 FAIL
Voltage CHECK ? R5506,R5503,R5505
OK

TX VOLTAGE FAIL
CHECK & REPLACE
CHECK?
C6290,C6291,C6294,C6292,C6293,C6295,C6297,
OK

CHECK & REPLACE

DUPLEXER & FAIL
SP16T PCS1900:C6512,L6512,FL6501,L6513,C6522,C6530
SP16T CHECK
CHECK ?
? CHECK & REPLACE
DCS1800;C6500,L6500,FL6500,L6502,C6501,C6502,
c6003,c6004,c6006,c6007,u6000
EGSM:C6670,L6623,FL6670,C6671,L6672
OK
GSM850:C6678,FL6671,L6679,L6680:
COUPLE FAIL
COUPLE R
R&& RF
RF FAIL
CON.
CON. CHECK
CHECK ?? CHECK
CHECK && REPLACE
REPLACE
U6000,C8000,L8000,J8000,R8001,R8002,C8001
U6000,C8000,L8000,J8000,R8001,R8002,C8001
OK
FAIL
FAIL Go to
to TX
TX CHECK
CHECK CHART-
CHART- Low
Low TX
TX
TX
TX LEVEL
LEVEL 2
2 Go
CHECK
CHECK ??
OK

END

2015 Lenovo Confidential. All rights reserved.

 GSM Quad Band Tx Schematics

GSM850/GSM900 PA Input

DCS1800/PCS1900 PA Input

GSM850,GSM900,DCS1800,PCS1900
PA Output

2015 Lenovo Confidential. All rights reserved.

 GSM Quad Band Tx
wtr2965

sky77928-21

ANT Connector

2015 Lenovo Confidential. All rights reserved.

 GPS/WLAN/BT/FM/DTV
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 GPS TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 GPS Troubleshoot Flow Chart
Start

GPS Voltage
Check Check VREG_L4_1P8 and
replace U1002 (PM8953)
Ok
check the
GPS eLNA
enable

Ok GPS
Front/Inter- Check and replace
stage filter FL7000/FL7001
check

Ok
External LNA
gain check Check and replace U7000

Ok
End
2015 Lenovo Confidential. All rights reserved.
 GPS Front End Block

GPS front
end SAW GPS
FL7000 External GPS Interstage
LNA U7000 SAW FL7001

2015 Lenovo Confidential. All rights reserved.

 WLAN / BT
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 Bluetooth/WiFi power-on failure

WLAN/BT power-on failure Symptoms:

WLAN DL test firmware test commands fail
Bluetooth power-on test commands fail

2015 Lenovo Confidential. All rights reserved.

 Step 1 for BT/Wi-Fi 2.4GHz power-on failure
– Check if the other functionality fails as well, e.g. check WLAN
“power on” if Bluetooth can not be powered on. Check Bluetooth
“power on” if WLAN can not be powered on.

– Both WLAN and Bluetooth share the same IC and most of the
circuit, so if one of the BT/Wi-Fi fails, the other should fail as well.
If only one of them fails, it is highly likely that it is not a hardware
problem and it could just that the BT/Wi-Fi is turned on through
the UI already and the test commands can not turn it on again.

2015 Lenovo Confidential. All rights reserved.

 Step 2 for BT/Wi-Fi power-on failure
If both BT and WLAN fails, it is highly indicative of a hardware failure.
Location of the Bluetooth and WLAN circuit (Shown on the next few pages)
Check for any visible damage around the BT/WLAN antenna/IC area.

2015 Lenovo Confidential. All rights reserved.

 BT/2.4GWi-Fi & GPS Antenna Schematic

2015 Lenovo Confidential. All rights reserved.

 5GHz Wi-Fi Antenna Schematic

2015 Lenovo Confidential. All rights reserved.

 RF & 48MHz TCXO input Schematic

2015 Lenovo Confidential. All rights reserved.

Power supply Schematic

2015 Lenovo Confidential. All rights reserved.

 Power supply Schematic

2015 Lenovo Confidential. All rights reserved.

BT/2.4GHz & 5GHz WiFi RF/Antenna Part placement

2.4GHZ WIFI
5 GHZ WIFI

2015 Lenovo Confidential. All rights reserved.

 Step 3 for BT/Wi-Fi power-on failure
• If no visible damage can be seen, open up the shield and check for any
visible damage on the IC and components. Look for misplaced or damaged
components.

2015 Lenovo Confidential. All rights reserved.

 Debugging BT / WLAN Power-up Failure
• Check clock supplies

– 48 MHz Clock: check at component C8504

• Check DC Voltages:

– Typical DC voltages in WCN3660B (U8510)area

• 1.3V
• 3.3V
• 1.8V

2015 Lenovo Confidential. All rights reserved.

 Debugging BT / WLAN Power-up Failure
• Check connections WCN3660 and MSM8952

– WLAN: no probing point – use x-ray or other means to make sure

following is soldered properly
• Pins 51, 57, 58 and 64 of U8510 (these are connection points of IQ
lines)
• Pins 70, 71 and 77 of U8510(these are connection points of DATA
lines)

– Bluetooth: no probing point – use x-ray or other means to make sure

following is soldered properly
• Pins 19, 24 and 29 of U8510 (these are connection points of control,
SSBI and data lines)

2015 Lenovo Confidential. All rights reserved.

 Debugging BT/WLAN low TX power
• Probe and measure the output power at the antenna
contact area and see in a spectrum analyzer if you see
if the phone is transmitting any power
• Please measure the output power in BP-tools mode
using the latest QRCT and procedures described in the
following link

• https://drive.google.com/drive/u/0/folders/0B_CJcTa8m_
DpS0d4R29iaW5qT3c

2015 Lenovo Confidential. All rights reserved.

 Bluetooth/WiFi TX/RX RF failure
– BT/Wi-Fi TX/RX RF failure
• Symptoms:
– Wi-Fi Radiated TX test value out of limits
– Bluetooth radiated TX test value out of limits
– Wi-Fi scan test fails
– Bluetooth ping test fails

2015 Lenovo Confidential. All rights reserved.

 Step 1 for BT/Wi-Fi TX/RX RF failure
• Look for visible damage of
the BT/WiFi Antenna,
Antenna Contacts and
BT/WiFi circuits
5 GHZ WIFI

2.4GHZ WIFI

2015 Lenovo Confidential. All rights reserved.

 Step 2 for BT/Wi-Fi TX/RX RF failure
– If there is no visible sign of antenna damage and antenna contacts
damage, it's most likely something wrong in the BT/Wi-Fi chips or
circuits.
– Open up the shield and look for misplaced or damaged RF front-end
components. Please refer to the previous slide describing the layout of
the WLAN circuit.
– It is recommended to probe the amplitude of the TX signal along the RF
path to look for the failure component.

2015 Lenovo Confidential. All rights reserved.

 FM TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 Debugging FM RSSI failure

•If FM RSSI is out of limits

1. Check whether the headset connection between the phone and the FM signal generator
are correctly done
2. Check and make sure that the headset jack is not damaged
3. Check there is no damage on audio flex, and audio flex is well inserted into connector
J1471
4. Then check for any visible damage around the FM antenna/Antenna matching
components
5. (For non-DTV variant) Open up the DTV shield and check whether R4755 placed correctly
(For DTV variant) Open up DTV shied and check whether C4763, C4764, L4750, S4750,
placed correctly, and check S4750 voltage 2.85V

2015 Lenovo Confidential. All rights reserved.

 Debugging FM RSSI failure
•If FM RSSI is out of limits
6. Then open up the WIFI/BT shield and check whether the FM Rx matching components
placed correctly/damaged
7. Then Check connections between WCN3660B and MSM8953:
FM: no probing point – use x-ray or other means to make sure following is soldered
properly
•Pins 61 of U8510 (FM Rx RF line)
•Pins 48 and 41 of U8510(these are connection points of SSBI and DATA lines)

2015 Lenovo Confidential. All rights reserved.

FM frontend, NA,LatAm,EMEA+APAC,India and China SKU - NO DTV version

2015 Lenovo Confidential. All rights reserved.

 FM frontend, Brazil DTV version

2015 Lenovo Confidential. All rights reserved.

 FM Rx matching FM Rx
matching/WAN
filtering
components

2015 Lenovo Confidential. All rights reserved.

 FM part placement/routing Matching
components
BOTTOM SIDE
TOP SIDE

Frontend
components

2015 Lenovo Confidential. All rights reserved.

 DTV TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 DTV schematic – Brazil SKU only

2015 Lenovo Confidential. All rights reserved.

 Debugging DTV RSSI failure
If DTV RSSI is out of limits
1.Check if the headset connection between the phone and the DTV signal generator are
correctly done
2.Check and make sure if the headset jack is not damaged and the flex is correctly inserted
into J1471.
3.Probe the amplitude of the TX signal along the RF path to look for the failure component
4.Check 37.4MHz XO output
5.Check the voltage
• DTV_LDO_1P2 : C1710,C1712,C1713,C1714 pin B2 should be 1.2v
• VREG_L6_1P8 : C1715,C1711 should be 1.8v

7. Check X-ray if any solder issue under U1700(DTV MMIC:FC8300W)

2015 Lenovo Confidential. All rights reserved.

 CHARGING
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 Charging Path – Schematics
Micro USB (J1400) ⇾ Charger IC (PMI8952, U1003 ⇾ Switch Regulator Circuit including L1321⇾ Battery FET (PMI8952, U1003) ⇾ Battery Pack (P1420)

2015 Lenovo Confidential. All rights reserved.

 Charging Path – PCB Layout
Micro USB (J1400) ⇾ Charger IC (PMI8952, U1003 ⇾ Switch Regulator Circuit including L1321⇾ Battery FET (PMI8952, U1003) ⇾ Battery Pack (P1420)

2015 Lenovo Confidential. All rights reserved.

 Charging Path – Troubleshooting
In the event of charging issues :
1.Do visual inspection on micro USB connector, battery connector and battery pack.

2.Check charging voltages along the charging path.

● Measure USB_PWR charger input voltage at C1401. The voltage should be around 5V with regular chargers
and around 9V with turbo chargers.
● Check VPH_PWR voltage at C1325. It should be higher than 2.1V and lower than 4.35V.
● Check the battery voltage at C1422. It should be higher than 2.1V and lower than 4.35V. If the battery is below
2.1V, there maybe a short in the circuit somewhere and the battery protection circuit has been triggered.

3.Check battery thermistor

● Do visual inspection on Camera Flash Flex connection. It has battery thermistor on it.
● Battery temperature should be in the range of 0ºC ~ 45ºC to be fully charged. Check the thermistor voltage at
the test point (BAT_CON_TEMP). It should be around 1.35V at room temperature (25ºC).

2015 Lenovo Confidential. All rights reserved.

 ALL SENSORS
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 Light sensor and proximity sensor

2015 Lenovo Confidential. All rights reserved.

 Light sensor and proximity sensor
1. Check the inspection of the sensor whether it was damaged in physical.
2. Check the rubber of the sensor whether it was assembled in the right place.
3. Measure the power of the sensor at C2505. It should be around 2.8V.
If the power is not correct, then check PM8953 (U1002).
4. Measure the power of the sensor at C2506. It should be same to VPH_PWR.
If there is no power at C2506, the PCB trace may damaged.
5. Check the resistace and voltage of R2520,R2526 and R2502. Their resistance should be 2.2K 2.2K and 10K
respectively, and their voltage should be around 1.8V.
If the power is not correct, then check PM8953 (U1002).
6. Measure the I2C signal of the sensor at VR2500 and VR2501.
Resolder a new sensor to check the function if the I2C signal was right.
If nothing captured, Check the Sensorhub(U2520).

2015 Lenovo Confidential. All rights reserved.

 Light sensor and proximity sensor

Inspection of sensor without rubber Inspection of sensor with rubber PCB print

2015 Lenovo Confidential. All rights reserved.

 Acceleration sensor

2015 Lenovo Confidential. All rights reserved.

 Acceleration sensor
1. Measure the power of the sensor at C2501. It should be around 1.8V.
If the power is equal or close to 0 V. We should take off the sensor and measure the power again. In case a short
circuit of the IC is presented.
Check PM8953 if the power is still 0V.
2. Measure the I2C signal of the sensor at R2525 and R2526.
Resolder a new sensor to check the function if the I2C signal was right.
If nothing captured, Check the Sensorhub(U2520).

2015 Lenovo Confidential. All rights reserved.

 Acceleration sensor

2015 Lenovo Confidential. All rights reserved.

 uSIM & VIBRATOR
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 SIM Path

2015 Lenovo Confidential. All rights reserved.

 SIM Schematic
SIM1&SIM2

2015 Lenovo Confidential. All rights reserved.

 SIM Path – Troubleshooting
In the event of SIM issues :
● Do a through visual check on SIM connector J1801 for any sign of mechanical contact issues
● Inspect all SIM circuit components on PCB
● Do visual inspection on SIM FPC
● Check SIM power at J1801 pin 18/13
● Check SIM bus interface signal activities during SIM access (UIMx_RST, UIMx_CLK, UIMx_DATA)

2015 Lenovo Confidential. All rights reserved.

 Vibrator Schematics

2015 Lenovo Confidential. All rights reserved.

 Vibrator Layout

2015 Lenovo Confidential. All rights reserved.

 Debugging Vibrator Failure
1. Check and make sure that the vibrator is not damaged.

2. Check the signal across R1413/R1423 close to Vibrator connector, it should be a PWM signal, higher
than 2.0V and lower than 3.6V.

2015 Lenovo Confidential. All rights reserved.

 SD
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 SD Card Schematics

2015 Lenovo Confidential. All rights reserved.

 SD Card
1. Check all the pins of the SD card connector whether they were
soldered well.
2. Measure the voltage at C1816, it should be low (around 0V) when
a sd card inserted, and high (around 1.8V) when no SD card
inserted.
If the voltage is wrong, then check R1815 and SD card connector.
3. Measure the voltage at C1805, it should be around 2.85V when a
SD card is inserted.
If the voltage is wrong, then check SD card connector and
PM8953.
4. Measure all signals DATA0~DATA4, CLK and CMD through E1800
to E1805 with Oscilloscope.
If either of the signal was abnormal, then check the SD card
connector and corresponding bead form E1800 to E1805.

2015 Lenovo Confidential. All rights reserved.

 DISPLAY & TOUCH
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 Structure

1080 x 1920 LCD

Touch control IC

2015 Lenovo Confidential. All rights reserved.

 Display connection

2015 Lenovo Confidential. All rights reserved.

 Schematic
LCM connector:

2015 Lenovo Confidential. All rights reserved.

 Schematic
LCD power supply from PMI8952

2015 Lenovo Confidential. All rights reserved.

 Display & Touch panel Path – Troubleshooting
In the event of Dispay & Touch panel issues :
1.Do visual inspection on LCM & Touch panel, LCM & Touch connector, EMI filter.

2.Check LCM voltages along the Dispay panel path.

● Measure LED_A voltage at C2012. It should be higher than 12V and lower than 18V.

● Check LCD_VSP and LCD_VSN voltage at C2008 and C2009. It should be between 5.4V and 5.6V.
● Check LCD VDDIO voltage at C2011. It should be higher than 1.5V and lower than 2V.
● Check DISP_PWM_OUT waveform at R2006. VP-P should be higher than 1.5V and lower than
2.5V.
3.Check Touch Panel voltages along the Touch panel path.
● Check TP AVDD voltage at C2013. It should be higher than 2.6V and lower than 3.6V.
● Check TP DVDD voltage at C2014. It should be higher than 1.5V and lower than 2V.

2015 Lenovo Confidential. All rights reserved.

 CAMERA, DUAL CCT FLASH &
LASER FOCUS
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 Rear Camera Schematic

2015 Lenovo Confidential. All rights reserved.

 Front Camera Schematic

2015 Lenovo Confidential. All rights reserved.

 Rear / Front Camera PCB

2015 Lenovo Confidential. All rights reserved.

 Rear / Front Camera Troubleshooting
1.Reinstall Rear / Front camera module .
2.Replace Rear / Front camera module .
3.Do visual inspection on Rear / Front camera connector .
4.Check the voltage of AVDD ,DVDD ,DOVDD
Ø Measure AVDD for Rear camera at R2112 , AVDD for Front camera at R2113 . The
voltage is around 2.8V .
Ø Measure AVDD for Rear camera at C2163 .The voltage is around 1.8V .
Ø Measure DVDD for Rear camera at C2115 .The voltage is around 1.05V .
Ø Measure DVDD for Front camera at C2113 .The voltage is around 1.2V .
Ø Measure DOVDD for Rear / Front camera at C2151/C2103 ( The side nearby the connector
or IC ) .The voltage is around 1.8V .
5. Check the Rear / Front camera MIPI pathway
Ø Check Rear camera MIPI pathway through FL2150 & FL2151 & FL2152 & FL2153 &
FL2154 , make sure them have no solder or other issue
Ø Check Front camera MIPI pathway through FL2101 & FL2102 & FL2103 , make sure
them have no solder or other issue
2015 Lenovo Confidential. All rights reserved.
 Flash&Laser Focus Schematic

2015 Lenovo Confidential. All rights reserved.

 Flash&Laser Focus PCB

2015 Lenovo Confidential. All rights reserved.

 Flash&Laser Focus Troubleshooting
1.Do visual inspection on flash&Laser focus PCB to make sure the Flash LED SMT is
OK.
2.Check the voltage of VDD_FLASH at C1324, the voltage should be in the range of
2.5V~5.5V .
3.Replace Flash LED .

2015 Lenovo Confidential. All rights reserved.

 AUDIO
TROUBLESHOOTING

2015 Lenovo Confidential. All rights reserved.

 Audio IC(PM8953) Schematics

2015 Lenovo Confidential. All rights reserved.

 MIC/Speaker Schematics

2015 Lenovo Confidential. All rights reserved.

 Earphone Schematic

2015 Lenovo Confidential. All rights reserved.

 Audio Layout

2015 Lenovo Confidential. All rights reserved.

 Debugging Audio Failure
1. Speaker
lCheck and make sure that the Speaker is not damaged.
lCheck if the connection between the phone and the Speaker are correctly done.
lCheck for any visible damage around the Speaker matching components.
2. MIC
lCheck and make sure that the MIC is not damaged.
lCheck for any visible damage around the MIC.
lCheck MIC_bias voltage is between 1.60 V and 2.85 V.

2015 Lenovo Confidential. All rights reserved.

 Debugging Audio Failure
3. Earphone
lCheck and make sure that Earphone jack is not damaged.
lCheck if the connection between the phone and the Earphone are correctly done.
lCheck for any visible damage around the Earphone jack.
lCheck for any visible damage around the U1002 and its matching components.

2015 Lenovo Confidential. All rights reserved.

 NOTE: This is a mandatory slide. Please include at the end of all presentations and remove this note.

Note:
(1) Products shown are developed, designed,
and made by Motorola Mobility LLC;
(2) Products using legacy Lenovo design
language have significant input from and
made by Motorola Mobility LLC.

2015 Lenovo Confidential. All rights reserved.

2015 Lenovo Confidential. All rights reserved.
2015 Lenovo Confidential. All rights reserved.
2015 Lenovo Confidential. All rights reserved.