Component Identifiers (CID¹) Wire Description Component Location for Volume 1 Electrical Schematic Symbols And Definitions

Module Identifier (MID²) Wire

Wire Color Description
Wire
Wire Color Description Component
Schematic Machine
Component
Schematic Machine
RENR7853
Machine ECM Number Number Location Location Location Location
Power Circuits Accessory Circuits (Continued) Alarm - Backup F-13 1 Relay - Front/Rear Washer #1 B-12 34
October 2003
(MID No. 079) T
101 RD Bat (+) 527 GN Wiper - Right Door (Low) Alternator C-1 2 Relay - Front/Rear Washer #2 C-12 34
CID Component
0017 Solenoid Valve (Fuel Shutoff) 102 BU Lighting #1 Fuse 528 PK Not Used Arc Suppressor - A/C E-1 21 Relay - High Speed E-10 40 Pressure Temperature Level Flow Circuit Breaker
0041 Sensor Power Supply (8 DCV) 103 YL Lighting #2 Fuse 529 WH Washer - Left Door Arc Suppressor #1 - (Front & Rear Washer) D-14 30 Relay - Horn E-10 38 Symbol Symbol Symbol Symbol Symbol
0070 Rocker Switch (Parking Brake) 104 YL Start Aid Relay 530 OR Washer - Right Door Arc Suppressor #2 - (Front & Rear Washer) D-14 30 Relay - Hydraulic Filter Bypass B-4 A

0110 Temperature Sensor (Engine Coolant) 105 RD Key SW 567 WH A/C Mode SW to Blower Speed SW Arc Suppressor - Hydraulic Filter Bypass Rly B-4 A Relay - Inlet Air Heater E-1 12
106 WH Detent 589 GN A/C Pressure SW to A/C Clutch Solenoid Arc Suppressor - Valve Manifold C-2 19 Relay - Lift Pump I-14 15 Normally Open switch that will close with an increase of a specific condition (temp-press-etc.).
0133 Solenoid Valve (Transmission Pilot Pressure)
108 BU Dome Lamp C546 WH High Speed Fan Relay Battery #1 H-12 5 Relay - Main H-14 15 The circle indicates that the component has screw terminals and a wire can be disconnected from it.
0153 Speed Sensor (Right Track)
109 RD Alt Output (+) Term. C547 OR High Speed Fan Relay to Blower Motor Battery #2 H-13 5 Relay - Start I-14 15
0154 Speed Sensor (Left Track) Normally Closed switch that will open with an increase of a specific condition.
112 PU Main Power Relay Output C556 BU Condenser Motor #2 to Relay #2 Breaker - A/C D-10 40 Relay - Start Aid E-11 38
0168 Electrical System No circle indicates that the wire cannot be disconnected from the component.
0190 Engine Speed Sensor 114 RD Warning Horn (Forward) C557 OR Condenser Motor #1 to Relay #1 Breaker - Alternator I-13 15 Resistor - A/C Blower D-11 40
115 RD Alternator Breaker Lighting Circuits Breaker - Main I-13 15 Resistor - MSS B-6 A
0444 Magnetic Switch (Start Relay)
119 PK Front/Rear Wiper 607 PK Flood Lamp - Front Coil - MSS Exciter A-6 A Resistor - Term Main #1 I-12 38 This indicates that the component has a wire connected to it that is connected to ground.
0468 Position Sensor (Service Brake Pedal)
0617 Relay (Inlet Air Heater) 120 YL Left Wiper 614 PU Park/Tail/Dash/Lamp Control - Machine ECM G-11,I-11 38 Sender - Coolant Temperature C-1 2
122 BU Right Wiper Control Circuits Control - MSS A-5 A Sender - Engine Oil Pressure E-2 23
0637 Backup Alarm
123 WH Monitoring Fuse 709 OR 10V Sensor Supply Detent - Winch Brake F-13 C Sender - Fuel Level G-14 6 This indicates that the component does not have a wire connected to ground. It is grounded by
0650 Harness Code being fastened to the machine.
0681 Solenoid Valve (Parking Brake) 124 GN A/C 769 BU Left Track Speed Sensor Detent - Winch Spool F-13 C Sender - Hydraulic Temperature F-15 11

0817 ECM Internal Backup Battery 125 OR A/C Breaker 770 GN Right Track Speed Sensor Fuse Panel H-2,H-6 28 Sensor - Coolant Temperature G-1 18

1482 Sensor Power Supply (10 DCV) 126 PK Machine ECM C703 BR Joystick Steering Sensor Gauges - Coolant Temperature D-4 A Sensor - CTR Brake B-7 32
Reed Switch - A switch whose contacts are controlled by a magnet. A magnet closes the
129 BU Power Port F711 GN MSS Can Data Link (+) Gauges - Engine Oil Pressure D-5 A Sensor - Decel Pedal A-7 33
1693 Position Sensor (Deceleration Pedal) contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
1699 Position Sensor (Forward/Neutral/Reverse) 135 BU Lift Pump F712 GY MSS Can Data Link (-) Gauges - Fuel Level D-5 A Sensor - Engine Speed E-2 23

1700 Position Sensor (Joystick) 148 WH Air Inlet Heater Relay F773 OR Accel SW (N.O.) Gauges - Hydraulic Oil Temperature D-4 A Sensor - Left Track Speed G-14 10

1701 Position Sensor (Accelerate Switch for Joystick) 158 BR A/C Condenser Relay #1 F774 WH Decel SW (N.O.) Gauges - Max Speed D-5 A Sensor - Right Track Speed G-14 9
Sender - A component that is used with a temperature or pressure gauge. The sender measures
159 BU A/C Condenser Relay #2 F798 YL Air Restricted Indicator Ground - Case Gnd #1 (LH Side) E-7 5 Sensor - Water in Fuel G-14 14
1702 Position Sensor (Decelerate Switch for Joystick) the temperature or pressure. Its resistance changes to give an indication to the gauge of the
1703 Proportional Solenoid Valve (Forward Left Drive Pump) 177 RD Main Breaker G742 GN Hyd Filter Bypass Relay Ground - Case Gnd #2 (RH Side) H-13 13 Solenoid - A/C Clutch F-1 3 T temperature or pressure.
1704 Proportional Solenoid Valve (Reverse Left Drive Pump) 183 GY Rear Wiper Washer Switch G745 PK Brake Pedal Sensor Ground - Case Ground #4 (LH Side) D-2 47 Solenoid - Engine Shutdown F-2 24

1705
1706
Proportional Solenoid Valve (Forward Right Drive Pump)
Proportional Solenoid Valve (Reverse Right Drive Pump)
184
185
BU
YL
Front/Rear Washer Arc Suppressor (1&2)
Front Wiper Washer Switch
J764
M730
BR
YL
10V Sensor Return
Decel Pedal Sensor
Ground - Engine Block
Ground - Frame Ground #2 D-3
E-2 47
12
Solenoid - Left Motor
Solenoid - Left Pump Forward
G-14
E-1
8
19
D3G, D4G, and D5G HYSTAT Relay (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
A101 GN Grade Control #1 (B+) T744 WH Power Supply Module (Return) Ground - Platform F-7 16 Solenoid - Left Pump Reverse D-1 19 It has a coil that makes an electromagnet when current flows through it. The electromagnet can
1707
1708
1960
Proportional Solenoid Valve (Left Drive Motor)
Proportional Solenoid Valve (Right Drive Motor)
ECM Cannot Communicate with the Electronic Key Reader
A102
A103
BU
YL
Grade Control #2 (B+)
Grade Control #3 (B+)
T745
T748
YL
PK
Power Supply Module (Return)
Power Supply Module (Return)
Heater - Inlet Air
Horn - Forward G-1
E-2 41
17
Solenoid - Lift Pump
Solenoid - Park Brake
H-13
D-2
14
19
Track-Type Tractors open or close the switch part of the relay.

¹ The CID is a diagnostic code that indicates which circuit is faulty.

² The MID is a diagnostic code that indicates which electronic control module
200 BK
Ground Circuits
Main Chassis
T776
833
GY
GY
Lift Pump Relay
Right Track Speed Sensor
Indicator - Air Restriction
Joystick - Controller
G-1
H-8
18
B
Solenoid - Pilot Override
Solenoid - Right Motor
D-2
G-14
19
7
Electrical System Solenoid - A solenoid is an electrical component that is activated by electricity. It has a coil that
makes an electromagnet when current flows through it. The electromagnet can open or close
diagnosed the fault. 202 BK Machine ECM 835 PU Left Track Speed Sensor Lamp - Dome C-13 25 Solenoid - Right Pump Forward D-1 20 a valve or move a piece of metal that can do work.
221 BK Engine Coolant Temperature Sensor 892 BR CAT Data Link (-) Lamp - Fault G-8 28 Solenoid - Right Pump Reverse D-1 20 D3G: D4G: D5G:
276 BK Harness Code 0 893 GN CAT Data Link (+) LED - MSS A-6 A Solenoid - Start Aid G-1 3
277 BK Harness Code 1 899 BU Max Speed Gauge LED - Panel Light/ with Alarm C-5 A Stud - Power #2 G-12 16 JMH1-UP HYD1-UP WGB1-UP Component, Connector, Harness And Wire Symbols
Failure Mode Identifiers (FMI)¹ 278 BK Harness Code 2 F846 PU MSS LED (Red) LED - Restricted Air Filter B-5 A Switch - A/C H-7 B BYR1-UP TLX1-UP RKG1-UP
FMI No. Failure Description 279 BK Harness Code 3 F853 BR Joystick F/N/R Sensor LED - Water in the Fuel B-5 A Switch - A/C Pressure F-1 3
Harness Identification Letter(s):
0 Data valid but above normal operational range. Basic Machine Circuits G848 GN MSS LED (Green) Meter - Hour H-8 28 Switch - Blower Speed H-7 B Wire, Cable, or Harness Assembly Identification:
(A, B, C, ..., AA, AB, AC, ...)
1 Data valid but below normal operational range. 304 WH Starter Relay No. 1 Output H801 PU Proportional Driver Return (1-4) Motor - A/C Blower D-11 40 Switch - CTR Brake Pedal B-7 32 Includes Harness Identification Letters and Harness
Connector Serialization Codes
2 Data erratic, intermittent, or incorrect. 306 GN Key SW to Machine ECM H802 GY Proportional Driver Return (5-8) Motor - Condenser #1 B-15 35 Switch - Disconnect H-13 4
Harness identification code Harness Connector Serialization Code:
3 Voltage above normal or shorted high. 308 YL Main Power Relay Coil H803 BU Proportional Driver Return (9-12) Motor - Condenser #2 A-15 37 Switch - Engine Oil Pressure F-2 22
This example indicates The "C" stands for "Connector" and the number
4 Voltage below normal or shorted low. 310 PU Air Inlet Heater Relay H807 YL On/Off Driver Return (1-8) Motor - Front Wiper D-12 27 Switch - Hydraulic Filter Bypass #1 F-15 11 wire 135 in harness "AG". indicates which connector in the harness. (C1, C2, C3, .....)
Part Number for
5 Current below normal or open circuit. 314 PU Start Aid Relay H899 OR Not Used Motor - Starter D-3 12 Switch - Hydraulic Filter Bypass #2 F-15 11 Connector Plug
320 OR Horn Relay J847 GN Action Alarm Motor - Washer (Front & Rear) C-15 31 Switch - Hydraulic Filter Bypass #3 F-15 11 Part Number For
6 Current above normal or grounded circuit. C-C4 AG-C3 AG-C4 L-C12 Connector Recepticle
7 Mechanical system not responding properly. 321 BR Backup Alarm J848 BU LED Panel Motor - Washer (LH Door) C-15 31 Switch - Key B-4 A 130-6795 130-6795 111-7898 3E-5179
8 Abnormal frequency, pulse width, or period. 322 GY Warning Horn (Forward) L854 YL Grade Control CAN 0 (+) Motor - Washer (RH Door) C-15 31 Switch - Light B-5 A 325-AL135 PK-14
325-AG135 PK-14 1 5A
9 Abnormal update. 327 PK Engine Shutdown Solenoid L855 GN Grade Control CAN 0 (-) Motor - Wiper (LH Door) B-13 28 Switch - Low Park Brake Pressure F-15 39
10 Abnormal rate of change. 374 PK Motor Start Relay L856 YL Grade Control CAN 1 (+) Motor - Wiper (RH Door) B-13 29 Switch - Park Brake G-8 B Socket
Pin
11 Failure mode not identifiable. 382 PK Start Aid Solenoid L857 GN Grade Control CAN 1 (-) Motor - Rear Wiper D-15 30 Switch - Thermostat D-10 40 Wire Color Wire Gauge Receptacle Fuse (5 Amps)
12 Bad device or component. A314 OR Park Brake SW (N.C.) L860 YL Grade Control SW 0 Power Port A-7 49 Switch - Wiper/Washer (LH Door) D-12 34
Single Wire Circuit Plug
13 Out of calibration. A315 WH Park Brake SW (N.O.) L861 PK Grade Control SW 1 Radio E-12 26 Switch - Wiper/Washer (RH Door) C-12 34 Connector Ground
Identification
Monitoring Circuits L862 PU Grade Control SW 2 Relay - Condenser #1 B-15 36 Switch - Wiper/Washer Front C-12 34 Connection 2
14 Parameter failures. Number 200-L32 BK-14
15 Parameter failures. 403 GN Alternator (R) Term. L863 BU Grade Control SW 3 Relay - Condenser #2 A-15 36 Switch - Wiper/Washer Rear B-12 34 Component
Pin or Socket Part Number
16 Parameter not available. 406 PU Engine Coolant Temperature Sensor L864 GY Grade Control SW 4 Machine locations are repeated for components located close together.
Number 105-9344
17 Module not responding. 410 WH Opr Mon Action Alarm L865 GN Grade Control SW 5 A = Located inside or on dash.
18 Sensor supply fault. 441 OR Eng Coolant Temp Gauge L866 PK Grade Control SW (Ground) B = Located inside or on left console.
1 Deutsch connector: Sure-Seal connector:
19 Condition not met. 443 YL Hyd Oil Temp Gauge L870 YL Power Supply Module to Display C = Located inside or on right console. 1
The plug contains all sockets The plug and receptacle contain
20 Parameter failures. 447
450
PK
YL
Fuel Level Gauge
Engine Speed Sensor (+)
L871
L872
BU
BU
Power Supply Module to Display
Switched Power #1
Volume 1: Electrical Schematic 2 and the receptacle contains all pins. 2 both pins and sockets.
¹The FMI is a diagnostic code that indicates what type of failure has occurred.
451 BR Engine Speed Sensor (-) L873 GY Switched Power #2
© 2003 Caterpillar Printed in U.S.A.
464 GY Engine Oil Pressure Gauge L874 OR Switched Power #3
All Rights Reserved
497 BU 8V Sensor Supply 915 GN Pilot Override Solenoid
C444 YL Alternator Indicator Lamp A958 WH Park Brake Solenoid
C446 PK Hyd Filter Bypass Lamp C920 GY Fault Lamp
C491 PU Parking Brake Lamp C958 BU Right Motor Solenoid
F400 GY Engine Oil Pressure Lamp C959 BR Left Motor Solenoid
H451 GN Water in Fuel Sensor C992 PU Service Brake Pedal SW
H456 PU Air Inlet Heater Lamp E953 GY Accel SW (N.C.)
Event Codes Accessory Circuits F931 PK Service Brake Pedal SW
Machine Control 500 BR Wiper - Front (Park) K943 OR Left Pump Reverse Solenoid
39
Event Code Condition 501 GN Wiper - Front (Low) K944 YL Left Pump Forward Solenoid
1
Connector Location for Volume 1 A B C D
42 B 44
503 BR Wiper - Rear (Park) K946 OR Right Pump Reverse Solenoid 14 15 A-B Tap
E188 Service Brake Pedal Not Actuating Parking Brake 43 Schematic Machine A-C Tap
504 YL Wiper - Rear (Low) K947 YL Right Pump Forward Solenoid
5 25 28 Connector Number A-D Tap
E190 Engine Overspeed Condition Location Location
38 46
506 PU Washer - Front N957 PK Not Used CONN 1 B-15 37
E395 Transmission Stall Condition
508 PU Radio Speaker - Left N958 PK Not Used 10 16 CONN 2 C-15 37
E482 Unexpected Left Track Forward Movement Detected 6
509 WH Radio Speaker - Left (Common) N959 PK Not Used 47
18 50 CONN 3 D-14,E-14 30
41 21
E483 Unexpected Right Track Forward Movement Detected 511 BR Radio Speaker - Right N960 OR Not Used 17
20 19 24 CONN 4 B-14 28
E484 Unexpected Left Track Reverse Movement Detected 35 3
512 GN Radio Speaker - Right (Common) N961 OR Not Used 22 23 Blower Unit Resistor 139-3900
8 CONN 5 B-14 29
36 32
E485 Unexpected Right Track Reverse Movement Detected 515 GY Blower Motor (HI) N963 OR Not Used

RENR7853-00 VOL. 1
30
40 A 26 27 48 CONN 6 A-14,B-11 38
516 GN Blower Motor (Medium) N967 GY Not Used 37
33 CONN 7 C-13 44
517 BU Blower Motor (Low) N976 PU Not Used Resistor, Sender and Solenoid Specifications
7 CONN 8 F-13 42
521 YL A/C SW To Refrigerant SW N979 GN Not Used Part No. Component Description Resistance (Ohms)¹
CONN 9 F-13 43
522 WH A/C Clutch To Thermostat SW N980 GN Not Used 12 2 3E-1908 Solenoid - A/C Clutch 3.50 ± 0.15
CONN 10 G-13 43
523 BR Wiper - Left Door (Park) N981 GN Not Used 560 to 716 @ 54.4°C (129.9°F)
CONN 11 I-12 38 7W-9943 Sender - Hydraulic Temperature
9 72.1 to 81.8 @ 110°C (230.0°F)
524 BU Wiper - Left Door (Low) R981 YL Decel SW (N.C.) 49 CONN 12 A-12,A-11 44
Term Resistor Main #1
525 GY Not Used T901 YL MSS Exciter Coil (Signal) 13 CONN 13 A-12,A-11 45
31 11 29 134-2540 Resistor - MSS Term 120
526 YL Wiper - Right Door (Park) T902 PK MSS Exciter Coil (Return) CONN 14 C-11 48
Term Resistors 1-4 Grade Control
C 4 34 45 CONN 15 C-11 48
Winch Brake (Detent)
CONN 16 E-10 38 137-9754 Solenoid - 17.47 ± 1.00
Winch Spool (Detent)
CONN 17 D-10 46
138-2622 Solenoid - Start Aid 1.2
CONN 18 B-10 43
A-B Tap 0.25 ± 0.025
CONN 19 B-10 47
139-3900 Resistor - A/C Blower Unit (See Illustration Above) A-C Tap 0.5 ± 0.05
CONN 20 A-10 48

20 Page, REM
A-D Tap 1.0 ± 0.1
CONN 21 G-8 28
227 to 257 @ 0 to 21 kPa (0 to 3 psi)
CONN 22 G-8 28
26 192 ± 27.5 @ 48.3 kPa (7 psi)
25 34 CONN 23 A-8 16 155-4032 Sender - Engine Oil Pressure
30 27 48 102 ± 11 @ 276 kPa (40 psi)
35 36 37 44 45 CONN 24 A-7 C
21.5 to 49.5 @ 552 kPa (80 psi)
CONN 25 B-7 32
179-9390 Solenoid - Pilot Override 10.3 ± .6
CONN 26 C-7 A
Left Pump Forward
CONN 27 F-7 43
Left Pump Reverse
CONN 28 G-7 43 192-4370 Solenoid - 4.5 ± .3
Right Pump Forward
CONN 29 G-7 B
Right Pump Reverse
CONN 30 B-6 A
201-2171 Solenoid - Park Brake 10.16 ± .20
CONN 31 A-6 A
653 ± 78 @ 54.4°C (129.9°F)
CONN 32 E-3 43 208-2964 Sender - Coolant Temperature
92 ± 8 @ 110°C (230°F)
CONN 33 E-3 43
Left Motor
CONN 34 E-3 43 214-6343 Solenoid - 4.5 ± .3
49 Right Motor
A CONN 35 F-3 43
C B Empty: 240 to 250
CONN 36 G-3 43 224-8597 Sender - Fuel Level
6 15 18 Full: 28 to 33
1 42
38 28 CONN 37 G-2 50
¹ At room temperature unless otherwise noted.
29 CONN 38 F-2 21
14 11 41 21 3
The connectors shown in this chart are for harness to harness connectors.
31 Connectors that join a harness to a component are generally located at or near
4 the component. See the Component Location Chart.
32 33
22 23 24 2
5
13 16
Off Machine Switch Specification
40 46 43
Part No. Function Actuate Deactuate Contact Position
12 17 -1.1 ± 0.8°C 2.2 ± 0.8°C
3E-5464 Thermostat Normally Closed
(30 ± 1.4°F) (36 ± 1.4°F)
20 19 47 Related Electrical Service Manuals 500 kPa 500 kPa
094-6997 Engine Oil Pressure Normally Closed
Title Form Number (72.5 psi) (72.5 psi)
50
7 8
Accugrade - Laser System: SEBU7803 276 kPa 207 kPa
9 10 134-0404 Hydraulic Filter Bypass ( #1,#2, and #3) Normally Open
39 (40.0 psi) (30.0 psi)
Electric Starting Motor: 105-3133 SENR3828
400 kPa Max 350 ± 20 kPa
Machine Control: RENR7313 201-4159 Low Park Brake Pressure Normally Closed
(58 psi Max) (50.8 ± 3.0 psi)
MSS Control: RENR7950 275 to 1750 kPa -
236-6923 A/C Pressure Normally Open¹
Systems Operation: RENR7314 (40 to 255 psi) -
¹ With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained
down to 170 kpa (25psi).

Machine Harness Connector And Component Locations

 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
H1 H1 H1 H1
H1 H1
H2 H2 H2
H2 H2
H3 H3 H3
H3 H3
H4 H4 H4
H4
H5 H5 H5
H5
CBL-FF3 RD-00 CBL-FF3 RD-00 CBL-FF3 RD-00 CBL-FF3 RD-00 CBL-FF3 RD-00 CBL-FF3 RD-00 CBL-FF3 RD-00
H807-T11 YL-18 H6 H6

374-T20 PK-18 H6 C-C14 C-C14A TERM RESIST MAIN 1 H6

T-C1 H5
9X1054 2 5 1740502 3E3370 1342540
F711-C173 GN-18 A
I 4 F712-C174 GY-18 B FUSE PANEL I
109-T4 RD-12 1 C
3 304-T15 WH-12 C-C20 C-C10 Y-C1
BREAKER PLATFORM CONN 11 MACHINE ECM C-C21 1249636 1249636 1249636
F711-C175 GN-18 C-C3 228-0382 C-C2 1552273
MOTOR START RELAY RD
115-1615 1471445 J1 J2 1471446 709-C105 OR-18 1 BATTERY
H4 BK
177-T17 RD-4 308-C158 YL-18 1 Key Switch Run Key Switch Start 1 306-C57 GN-18 J764-C98 BR-18 2 GROUND FUSES FUSES
2 2 3 GN
447-T9 PK-18 109-T4 RD-12 F711-C178 GN-18 Unused MSS LED Red F846-C82 PU-18 F853-C13 BR-18 LONGITUDE 113-8490 10A 113-8490 10A 120-Y6 YL-16
3 3 4 RD
H451-T2 GN-18 109-TA1 RD-4 F712-C177 GY-18 Unused MSS LED Green G848-C90 GN-18 709-C106 OR-18 BATTERY 113-8491 15A 113-8491 15A
H9 4 4 5 BK
Unused On/Off Drvr Rtn 1 - 4 H807-C85 YL-18 J764-C100 BR-18 GROUND 159-Y35 BU-14
5 5 6 YL 113-8492 20A 113-8492 20A
135-T21 BU-18 T776-T18 GY-18 Unused Air Inlet Heater 310-C155 PU-18 C703-C14 BR-18 LATITUDE 112-Y28 PU-10
135-T12 BU-18 F712-C176 GY-18 6 Unused Engine Shutdown Solenoid 6 327-C129 PK-18 104-C120 YL-16 113-8493 25A

CBL-FF3 RD-00
H8 115-T13 RD-14 7 Unused Starter Relay 7 374-C156 PK-18 135-C154 BU-14
T-C5 105A 105A A9 A8 A7 A6 A5 A4 A3 A2 A1
109-T1 RD-4 126-C22 PK-16 8 Unused Unused 8 106-C70 WH-18 15A 20A A9 A8 A7 20A A6 A5 15A A4 A3 A2 A1
9X1054 2 5 MAIN BREAKER
ALTERNATOR BREAKER 126-C119 PK-16 9 Unused LED panel #3 9 J848-C31 BU-18
171-2212 A9 A8 A7 15A A6 A5 A4 A3 A2 A1 SPARE 1 SPARE 2 CONDENSOR 2 LEFT WIPER
4 171-2212 202-C151 BK-18 893-C134 GN-18 10 CAT Data Link + Ether Aid 10 314-C47 PU-18 10A 15A 15A 108-Y11 BU-18
NOTE C 113-8491 113-8492 113-8492 113-8491
135-T16 BU-14 NOTE C 202-C152 BK-18 NOTE F 11 Unused Action Alarm 11 J847-C29 GN-18 119-Y23 PK-14
H9 1 221-C99 BK-18 321-C40 BR-18 12 Backup Alarm 12 410-C51 WH-18 769-C39 BU-18 C-C13 112-C133 PU-10 120-Y6 YL-16
3 Alarm Disarm
308-C158 YL-18 202-C152 BK-18 13 Ground Fault Lamp 13 C920-C2 GY-18 770-C75 GN-18 1552264 DETENT FUSE LIFT PUMP FUSE START AID GRADE CONTROL #1 122-Y16 BU-16
H11 BK 113-8491
LIFT PUMP RELAY 321-C40 BR-18 14 Unused R Terminal 14 403-C28 GN-18 833-C41 GY-18 J764-C19 BR-18 1 ACCEL/DECEL COMMON 113-8490 113-8491 113-8491 H1 158-Y34 BR-14 158-Y34 BR-14
15 15 2 GN
115-1615 406-C49 PU-18 Unused Unused 835-C45 PU-18 E953-C17 GY-18 ACCELERATE 159-Y35 BU-14 112-Y26 PU-10
16 16 3 BR N.O.
CBL-FF2 RD-2 450-C67 YL-18 Unused Unused 320-C11 OR-18
17 17 4 WH COMMON
135-T6 BU-14 451-C68 BR-18 450-C67 YL-18 Engine Speed + Unused 200-C132 BK-18 114-C93 RD-18
18 18 5 YL
135-T12 BU-18 497-C76 BU-18 451-C68 BR-18 Engine Speed - Unused R981-C18 YL-18 DECELERATE 105-C87 RD-18 B9 B8 B7 20A B6 B5 B4 B3 B2 B1
19 19 6 BU
135-T7 BU-14 CBL-CC BK-00 709-C118 OR-18 Do Not Use Lift Pump Relay Coil (-) T776-C157 GY-18 F773-C124 OR-18 ACCELERATE N.O. 126-C111 PK-16 CONDENSOR 1
20 20 7 RD B9 B8 B7 B6 B5 B4 B3 B2 B1
109-T1 RD-4 892-C8 BR-18 892-C8 BR-18 CAT Data Link - Max Speed Display 899-C30 BU-18 276-C3 BK-18 F774-C125 WH-18 DECELERATE N.O. 115-C150 RD-14 10A 25A
113-8492
115-T13 RD-14 893-C134 GN-18 221-C99 BK-18 21 5 Volt Sensor Return Unused 21 277-C121 BK-18 8 BLOWER SPEED SW
200-T22 BK-14 DISCONNECT SW 915-C58 GN-18 406-C49 PU-18 22 Engine Coolant Temp Sensor Do Not Use 22 278-C9 BK-18 200-Y49 BK-18 157-1361 B9 15A B8 B7 10A B6 B5 10A B4 B3 B2 B1 SPARE 3 SPARE 4
JOYSTICK CONTROLLER 113-8490
7N-0718 A314-C73 OR-18 202-C151 BK-18 23 Ground Serv Brk Pedal Sw (N/C) 23 F931-C37 PK-18 279-C10 BK-18 124-P9 GN-14 P-C6 113-8493 119-Y23 PK-14
230-1024 1
112-C164 PU-4 A315-C123 WH-18 24 Unused Decel Pedal Sensor 24 M730-C44 YL-18 306-C57 GN-18 200-P15 BK-18 1552273
CBL-HH2 BK-00 25 Unused 25 1 BK-14 MACHINE ECM
A958-C66 WH-18 Joystick Steering Sensor C703-C14 BR-18 310-C155 PU-18 200-P13 BK-18 124-P9 GN-14 6 H3 KEY FWD HORN 112-Y32 PU-10
T-C9 26 Unused 26 6 WH-14 113-8491
C491-C115 PU-18 Joystick FNR Sensor F853-C13 BR-18 314-C47 PU-18 200-C108 BK-18 C546-P6 WH-16 113-8490 113-8490
3E3364 5
CBL-HH1 BK-00 C958-C89 BU-18 27 Unused Serv Brake Pedal Sensor 27 G745-C83 PK-18 327-C129 PK-18 515-P2 GY-14 515-P2 GY-14 5 GY-14 H6 112-Y24 PU-10
4
WH-18 1 308-T5 YL-18 C959-C53 BR-18 28 Unused Serv Brk Pedal Sw (N/O) 28 C992-C48 PU-18 374-C156 PK-18 516-P3 GN-14 516-P3 GN-14 4 GN-14 112-Y32 PU-10 C9 C8 C7 C6 C5 25A C4 C3 C2 C1
NEG POS NEG POS 3
WH-18 2 200-T3 BK-18 E953-C17 GY-18 29 Unused Unused 29 403-C28 GN-18 517-P4 BU-14 517-P4 BU-14 3 BU-14 112-Y28 PU-10 FRONT REAR WIPER

CBL-FF3 RD-00
C9
H 177-T17 RD-4 F773-C124 OR-18 30 Unused Unused 30 410-C51 WH-18 567-P10 WH-18 2 BR-14
2 123-C60 WH-16 112-C16 PU-10 10A C8 C7 C6 C5 C4 C3 C2 C1 112-Y26 PU-10 113-8493 H
MAIN POWER RELAY F774-C125 WH-18 126-C22 PK-16 31 Battery + (Unswitched) Unused 31 899-C30 BU-18 521-Y31 YL-18 102-C63 BU-18
168-7908 BATTERY 2 BATTERY 1 H801-C126 PU-18 32 Do Not Use 32 C703-C14 BR-18 567-P10 WH-18 SPARE 5
Unused
9X-3404 9X-3404 33 Park Brake N/C 33 113-8490
CASE GND 2 H802-C54 GY-18 A314-C73 OR-18 Unused C920-C2 GY-18 521-Y31 YL-18
RH SIDE CBL-FF1 RD-00 H803-C61 BU-18 A315-C123 WH-18 34 Park Brake N/O Unused 34 C992-C48 PU-18 614-P12 PU-18 614-Y48 PU-18 C9 C8 C7 10A C6 C5 10A C4 C3 20A C2 C1 122-Y16 BU-16
NOTE C J764-C114 BR-18 E953-C17 GY-18 35 Accel Switch N/C Unused 35 F846-C82 PU-18 614-P14 PU-18 H2 108-Y11 BU-18
RELAY BLOCK BATTERIES K943-C139 OR-18 36 Unused Unused 36 F853-C13 BR-18 614-C107 PU-18 8 1 3 4 6 10 112-C153 PU-10 112-Y24 PU-10
K944-C131 YL-18 37 Unused Unused 37 F931-C37 PK-18 A314-C73 OR-18 A/C MODE SW LIGHTING 1 MONITORING GRADE CONTROL #2
K946-C59 OR-18 38 Unused Unused 38 G745-C83 PK-18 A315-C123 WH-18 2022284 113-8490 113-8490 113-8492 D9 D8 D7 10A D6 D5 15A D4 D3 D2 D1
K947-C130 YL-18 126-C119 PK-16 39 Battery + Unswitched Unused 39 G848-C90 GN-18 C546-P6 WH-16
R981-C18 YL-18 F773-C124 OR-18 40 Accel Switch N/O Right Speed Sensor A 40 770-C75 GN-18 H807-C85 YL-18 J764-C74 BR-18 Y-C8 115-C15 RD-18 RADIO FUSE RIGHT WIPER
H3 R981-C18 YL-18 41 Decel Switch N/C Right Speed Sensor B 41 833-C41 GY-18 J847-C29 GN-18 614-Y48 PU-18 1429117 129-C24 BU-18 D9 10A D8 D7 D6 D5 D4 D3 D2 D1 113-8490 113-8491
7 2 5 9
H2 T-C8 F774-C125 WH-18 42 Decel Switch N/O Left Speed Sensor A 42 769-C39 BU-18 J848-C31 BU-18 103-C65 YL-18
H1 1552269 H11 SPARE 6
LIFT PUMP SOLENOID C491-C115 PU-18 43 Park Brake Pressure Sw Left Speed Sensor B 43 835-C45 PU-18 L854-C55 YL-18 105-C122 RD-18 1 2 200-Y49 BK-18 124-C143 GN-14
A-C6 113-8490
1552272
203-7848 BK-18 1 135-T6 BU-14 H6 497-C76 BU-18 44 8 Volt Sensor Supply Unused 44 L855-C62 GN-18 3 A/C ATCH D9 D8 D7 D6 D5 D4 D3 D2 D1
BK-18 2 200-T8 BK-14 45 8 Volt Sensor Return Unused 45 M730-C44 YL-18 403-C71 GN-18 20A 10A 10A 15A
497-A1 BU-18 1 RD-18 + BATTERY 112-C164 PU-4 46 Unused Unused 46 T776-C157 GY-18 200-C72 BK-18 P-C7 Y-C7
J764-A2 BR-18 2 BK-18 GROUND LEFT TRACK SPEED SENSOR 47 Unused Unused 47 HOUR METER 1552269 3E3364 112-C146 PU-10
112-Y24 PU-10 161-3932
769-A3 BU-18 3 GN-18 SIGNAL A 183-4584 200-T3 BK-18 112-C133 PU-10 K944-C131 YL-18 48 Left Pump Fwd Solenoid Unused 48 F711-C175 GN-18 567-P10 WH-18 1 567-Y50 WH-18 BLOWER LIGHTING 2 POWER PORT FUSE GRADE CONTROL #3
112-Y32 PU-10
835-A4 PU-18 4 WH-18 SIGNAL B K943-C139 OR-18 49 Left Pump Rev Solenoid Unused 49 F712-C176 GY-18 2 113-8492 113-8490 113-8490 113-8491
BLOCK B BLOCK C (ATCH)
H801-C126 PU-18 50 Prop Drvr Return 1 - 4 Unused 50
CONN 29 BLOCK A
112-C146 PU-10 112-Y26 PU-10 K947-C130 YL-18 51 Right Pump Fwd Solenoid Unused 51
A-C9 200-T22 BK-14
FUEL LEVEL SENDER 112-C153 PU-10 112-Y28 PU-10 K946-C59 OR-18 52 Right Pump Rev Solenoid Unused 52 C920-C2 GY-18 P-C4
1552269 T-C2 53 Do Not Use Unused 53 FAULT LAMP 3T3158
224-8597
C959-A11 BR-18 1 BK-18 LEFT MOTOR SOLENOID 1552269 112-C16 PU-10 112-X2 PU-4 54 Unused Unused 54 3E-8679 614-P12 PU-18 A103-C172 YL-14 FA-C2 FA-C2A
BACKLIGHT 1
H802-A27 GY-18 2 BK-18 214-6343 PK-18 1 447-T9 PK-18 H803-C61 BU-18 55 Prop Drvr Return 11- 12 Harness Code 0 55 276-C3 BK-18 308-C1 YL-18 200-P13 BK-18 1552269 3E3364
9G-0012
BK-18 2 200-T10 BK-18 56 Unused MSS Key + 56 A102-C171 BU-14 382-FA2 PK-16 1 WH-16
57 Unused MSS Key - 57 P-C5 200-FA1 BK-16 2 BK-16
A-C7 C959-C53 BR-18 58 Left Motor Solenoid Harness Code 1 58 277-C121 BK-18 C-C11 CAP 3T3158 A101-C170 GN-14
1552269 PWR STUD 2 9W1951 START AID SOL
C958-C89 BU-18 59 Right Motor solenoid Harness Code 2 59 278-C9 BK-18 8C-6354 614-P14 PU-18 BACKLIGHT 2 200-FA4 BK-16
187-8674 138-2622
C958-A9 BU-18 1 BK-18 RIGHT MOTOR SOLENOID H802-C54 GY-18 60 Prop Drvr Return 5 - 6 Harness Code 3 60 279-C10 BK-18 126-C6 PK-18 A 200-P15 BK-18 9G-0012 200-FA1 BK-16
H8 NOTE C
H802-A10 GY-18 2 BK-18 214-6343 61 Unused Unused 61 202-C4 BK-18 B 200-FA5 BK-18 START AID ATCH
WATER IN FUEL SENSOR T-C6 62 Unused Unused 62 C A315-C123 WH-18 H4 AE-C2 FA-C1
192-7875 1552267 63 Unused Unused 63 893-C7 GN-18 D SERVICE A314-C73 OR-18 1552273 3E3382
A-C8 +12 VOLTS OR-18 A 135-T21 BU-18 64 Unused Grade Control CAN + 64 L854-C55 YL-18 892-C95 BR-18 E CONNECTOR 614-C107 PU-18 H7 322-AE5 GY-18 1 322-FA3 GY-18 322-FA3 GY-18
G 1552272 GROUND BK-18 B 200-T14 BK-18 65 Unused 65 L855-C62 GN-18 126-C119 PK-16 L855-C180 GN-18 F 382-AE4 PK-16 2 382-FA2 PK-16
FORWARD HORN G
Grade Control CAN - 240-6934
497-A5 BU-18 1 RD-18 + BATTERY LAMP WH-18 C H451-T2 GN-18 66 Unused Unused 66 126-C22 PK-16 L854-C182 YL-18 G 200-AE3 BK-16 3 200-FA4 BK-16
J764-A6 BR-18 2 BK-18 GROUND RIGHT TRACK SPEED SENSOR 915-C58 GN-18 67 Override Solenoid MSS CAN + 67 F711-C175 GN-18 202-C151 BK-18 H F798-AE6 YL-18 4 F798-FA6 YL-18
770-A7 GN-18 3 GN-18 SIGNAL A 183-4584 A958-C66 WH-18 68 Parking Brake Solenoid MSS CAN - 68 F712-C176 GY-18 202-C152 BK-18 J 8 1 3 4 6 10 406-AE7 PU-18 5 406-FA7 PU-18
4 WH-18 69 69 6 FA-C3 AIR RESTRICT IND
833-A8 GY-18 SIGNAL B 709-C118 OR-18 10 Volt Sensor Supply Unused 221-C99 BK-18 221-AE8 BK-18 221-FA8 BK-18
J764-C114 BR-18 70 10 Volt Sensor Return Unused 70 308-C158 YL-18 NOTE F CONN 21 SW PARK BK C-C6 C-C6A 1166158 187-2868
A-C1 C-C17 406-C49 PU-18
190-8478 3E5179 1552252 CONN 37 F798-FA6 YL-18 1 BK-18
3E5179 1552252 450-C67 YL-18 C-C5 CP-C1 C-C4 A101-C170 GN-14 1 200-FA5 BK-18 2 BK-18
497-A5 BU-18 443-A17 YL-18 106-A20 WH-18 1 106-C70 WH-18 451-C68 BR-18 1552264 1958730 1429117 200-C167 BK-14 2
7 2 5 9
497-A1 BU-18 497-A5 BU-18 497-A26 BU-18 200-A23 BK-18 2 200-C43 BK-18 497-C76 BU-18 276-C3 BK-18 1 200-CP1 BK-18 A102-C171 BU-14 3
769-A3 BU-18 497-A1 BU-18 H802-A28 GY-18 3 H802-C54 GY-18 709-C118 OR-18 202-C5 BK-18 2 200-CP2 BK-18 200-C168 BK-14 4
770-A7 GN-18 769-A3 BU-18 443-A17 YL-18 4 443-C33 YL-18 892-C8 BR-18 277-C121 BK-18 3 200-CP3 BK-18 200-C108 BK-18 AE-C1 C-C27 A103-C172 YL-14 5 NOTE L
COOL. TEMP SENSOR
833-A8 GY-18 770-A7 GN-18 497-A26 BU-18 5 497-C42 BU-18 893-C134 GN-18 278-C9 BK-18 4 200-CP4 BK-18 J764-C74 BR-18 1552273 3E3382 200-C102 BK-10 200-C169 BK-14 6 TO GRADE CONT GR HARNESS FA-C4 191-6587
835-A4 PU-18 833-A8 GY-18 769-A3 BU-18 6 769-C39 BU-18 MACHINE ECM 915-C58 GN-18 279-C10 BK-18 5 322-AE5 GY-18 1 322-C64 GY-18 893-C166 GN-18 7 (SH 2 I-9) 3E3364
LOW PARK BRAKE PRESS SW A-C4
201-4159 C958-A9 BU-18 835-A4 PU-18 770-A7 GN-18 7 770-C75 GN-18 A314-C73 OR-18 6 HARNESS 382-AE4 PK-16 2 382-C91 PK-16 892-C165 BR-18 8 406-FA7 PU-18 1 BK-18
1552269
C959-A11 BR-18 C446-A18 PK-18 C446-A29 PK-18 833-A8 GY-18 8 833-C41 GY-18 H11 A315-C123 WH-18 7 CODE PLUG H7 200-AE3 BK-16 3 200-C103 BK-16 200-C103 BK-16 9 221-FA8 BK-18 2 BK-18
BK-18 1 C491-A25 PU-18 J764-A2 BR-18 C446-A19 PK-18 835-A4 PU-18 9 835-C45 PU-18 A958-C66 WH-18 8 F798-AE6 YL-18 4 F798-C35 YL-18 115-C12 RD-14 10 T°
BK-18 2 J764-A24 BR-18 J764-A6 BR-18 C491-A25 PU-18 C446-A29 PK-18 10 C446-C32 PK-18 C491-C115 PU-18 406-AE7 PU-18 5 406-C49 PU-18 135-C154 BU-14 L854-C181 YL-18 11
CONN 22
H802-A10 GY-18 C958-A9 BU-18 C491-A25 PU-18 11 C491-C141 PU-18 E953-C17 GY-18 LEFT HAND CONSOLE 221-AE8 BK-18 6 221-C99 BK-18 221-C99 BK-18 L855-C179 GN-18 12 HOOD
H802-A27 GY-18 C959-A11 BR-18 C958-A9 BU-18 12 C958-C89 BU-18 F711-C178 GN-18 308-C128 YL-18
H802-A10 GY-18 H802-A28 GY-18
H11
F712-C177 GY-18
CONN 28 322-C64 GY-18
CONN 36
443-A17 YL-18 H802-A27 GY-18
CONN 10 F773-C124 OR-18 102-C63 BU-18 374-C156 PK-18
CBL-FF3 RD-00 CBL-FF3 RD-00
HYD TEMP SENDER C-C19 T-C3 C-C1
C446-A19 PK-18 J764-A24 BR-18 A-C11 F774-C125 WH-18 103-C65 YL-18 382-C91 PK-16
7W-9943 3E3370 3E3388 1552264 NOTE F
C446-A18 PK-18 J764-A6 BR-18 1552267 H801-C126 PU-18 105-C87 RD-18 105-C122 RD-18 406-C49 PU-18
443-A17 YL-18 C491-A25 PU-18 J764-A2 BR-18 J764-A16 BR-18 C959-A11 BR-18 A C959-C53 BR-18 H803-C61 BU-18 124-P9 GN-14 374-T20 PK-18 1 374-C156 PK-18 447-C34 PK-18
J764-A24 BR-18 J764-A16 BR-18 B J764-C113 BR-18 J764-C114 BR-18 105-C122 RD-18 126-C6 PK-18 308-T5 YL-18 2 308-C128 YL-18
T° 200-A23 BK-18 C 769-C39 BU-18 K943-C139 OR-18 105-C142 RD-18 200-C72 BK-18 H451-T2 GN-18 3 H451-C163 GN-18 F798-C35 YL-18 PLUG AS. END CAP
106-A20 WH-18 770-C75 GN-18 K944-C131 YL-18 105-C88 RD-18 200-C108 BK-18 H807-T11 YL-18 4 H807-C50 YL-18 H451-C163 GN-18 155-2269
HYD FILTER BYPASS SW 1 A-C10 CONN 9 K946-C59 OR-18 200-C132 BK-18 447-T9 PK-18 5 447-C34 PK-18 H807-C50 YL-18 F-C15 N-C1
134-0404 1552269 6 3E3364 1552269
BACKUP ALARM C-C18A C-C18 833-C41 GY-18 K947-C130 YL-18 105-C140 RD-18 200-P15 BK-18 H5 115-T13 RD-14 115-C12 RD-14
C446-A19 PK-18 106-A22 WH-18 1 RD-20 220-0230 3E3364 1552269 835-C45 PU-18 R981-C18 YL-18 200-P13 BK-18 135-T7 BU-14 7 135-C154 BU-14 T776-C157 GY-18 521-F16 YL-18 521-F16 YL-18 1 1 521-N2 YL-18
200-A13 BK-18 2 RD-20 106-C70 WH-18 200-Y49 BK-18 T776-T18 GY-18 8 T776-C157 GY-18 200-C79 BK-18 522-F17 WH-18 522-F17 WH-18 2 2 522-N7 WH-18 N-C3
RD-16 1 321-C40 BR-18 1684999
321-C40 BR-18 321-C40 BR-18 106-C70 WH-18 114-C93 RD-18 202-C4 BK-18 CONN 27 115-C12 RD-14 308-C56 YL-18 CONN TO N-C1
WINCH SPOOL DETENT BK-16
NOTE L
2 H807-C94 YL-18
C958-C89 BU-18 C958-C89 BU-18 126-C22 PK-16 114-C93 RD-18 202-C5 BK-18 135-C154 BU-14 310-C155 PU-18 AT LOC SH 1 F-2
CONN 38 521-N2 YL-18 1 3
F HYD FILTER BYPASS SW 2 137-9754 CONN 8 NOTE L F
C959-C53 BR-18 C959-C53 BR-18 126-C119 PK-16 115-C12 RD-14 276-C3 BK-18 221-C99 BK-18 327-C129 PK-18 C-C9 F-C5 589-N5 GN-18 2 2
134-0404 200-T22 BK-14 1
102-C63 BU-18 112-C16 PU-10 H802-C54 GY-18 H802-C54 GY-18 200-C43 BK-18 277-C121 BK-18 308-C128 YL-18 403-C69 GN-18 1552254 1907613
C446-A18 PK-18 103-C65 YL-18 112-C146 PU-10 202-C152 BK-18 278-C9 BK-18 322-C64 GY-18 441-C78 OR-18 310-C155 PU-18 1 310-F14 PU-18
C446-HF1 PK-18 106-A20 WH-18 104-C120 YL-16 112-C153 PU-10 106-C70 WH-18 308-C158 YL-18 115-C15 RD-18 279-C10 BK-18 450-C67 YL-18 451-C68 BR-18 2 451-F11 BR-18 F400-F10 GY-18 ENG OIL PRESS SW A/C PRESSURE SW
A-C2 105-C87 RD-18 112-C133 PU-10 200-C43 BK-18 314-C47 PU-18 115-C150 RD-14 308-C1 YL-18 374-C156 PK-18 451-C68 BR-18 450-C67 YL-18 3 450-F12 YL-18 094-6997 236-6923
1552269 106-C70 WH-18 443-C33 YL-18 106-C70 WH-18 314-C47 PU-18 123-C60 WH-16 320-C11 OR-18 382-C91 PK-16 464-C46 GY-18 521-C21 YL-18 4 521-F16 YL-18 NOTE E
HYD FILTER BYPASS SW 3 1 RD-20 5
106-A21 WH-18 112-C133 PU-10 497-C42 BU-18 200-C43 BK-18 497-C42 BU-18 124-C143 GN-14 406-C49 PU-18 521-C21 YL-18 522-C127 WH-18 522-F17 WH-18
134-0404 2 RD-20 6
200-A23 BK-18 200-A14 BK-18 112-C146 PU-10 C446-C32 PK-18 443-C33 YL-18 497-C76 BU-18 126-C111 PK-16 447-C34 PK-18 327-C129 PK-18 327-F21 PK-18
C446-HF1 PK-18 112-C153 PU-10 H807-C94 YL-18 497-C42 BU-18 114-C93 RD-18 126-C6 PK-18 403-C71 GN-18 F798-C35 YL-18 522-C127 WH-18 F400-C36 GY-18 7 F400-F10 GY-18 N-C2
WINCH BRAKE DETENT 8 F-C17 1552269
114-C93 RD-18 J764-C113 BR-18 C446-C32 PK-18 202-C151 BK-18 126-C111 PK-16 515-P2 GY-14 H451-C163 GN-18 915-C58 GN-18 H801-C126 PU-18 H801-F30 PU-18
137-9754 2364701
115-C150 RD-14 C491-C141 PU-18 C491-C141 PU-18 221-C99 BK-18 516-P3 GN-14 H807-C50 YL-18 A958-C66 WH-18 K944-C131 YL-18 9 K944-F22 YL-18 589-N4 GN-18 1 BK-14
H3 CASE H3 123-C60 WH-16 102-C63 BU-18 H807-C94 YL-18 276-C3 BK-18 517-P4 BU-14 T776-C157 GY-18 C444-C77 YL-18 K943-C139 OR-18 10 K943-F23 OR-18 327-F21 PK-18 1 ENG SHUTDOWN SOL 522-N1 WH-18 2 BK-14
124-C143 GN-14 103-C65 YL-18 320-C11 OR-18 J764-C113 BR-18 277-C121 BK-18 126-C22 PK-16 521-Y31 YL-18 200-C112 BK-12 F400-C36 GY-18 K947-C130 YL-18 11 K947-F24 YL-18 237-5396
126-C111 PK-16 104-C120 YL-16 114-C92 RD-18 278-C9 BK-18 126-C119 PK-16 614-C107 PU-18 200-P7 BK-14 H456-C162 PU-18 K946-C59 OR-18 12 K946-F25 OR-18 A/C COMPR CLUTCH SOL
C-C7 3E-1908
129-C24 BU-18 105-C87 RD-18 279-C10 BK-18 614-P14 PU-18 202-C116 BK-14 H801-C126 PU-18 CONN 35
9X1054 2 5
135-C154 BU-14 106-C70 WH-18 306-C57 GN-18 129-C24 BU-18 614-P12 PU-18 200-X3 BK-10 200-C52 BK-16 H803-C61 BU-18
H2 114-C93 RD-18 4 310-C155 PU-18 129-C145 BU-18 614-Y48 PU-18 200-Y21 BK-8 200-C79 BK-18 H807-C161 YL-18 C-C29 F-C14
112-C16 PU-10 115-C15 RD-18 114-C93 RD-18 114-C93 RD-18 320-C11 OR-18 129-C27 BU-18 709-C105 OR-18 200-Y8 BK-16 308-C56 YL-18 K943-C139 OR-18 1907612 1552253 N-C4
H2 115-C15 RD-18 115-C150 RD-14 1 314-C47 PU-18 322-C64 GY-18 135-C154 BU-14 709-C106 OR-18 200-Y14 BK-16 310-C155 PU-18 K944-C131 YL-18 H456-C162 PU-18 1 H456-F15 PU-18 1552269
3
H1 H1 123-C60 WH-16 320-C11 OR-18 327-C129 PK-18 200-C132 BK-18 202-C151 BK-18 327-C129 PK-18 K946-C59 OR-18 464-C46 GY-18 2 464-F6 GY-18 589-N6 GN-18 1
124-C143 GN-14 314-AF1 PU-18 HORN RELAY 322-C64 GY-18 374-C156 PK-18 200-C108 BK-18 709-C118 OR-18 PLATFORM A958-C66 WH-18 3 A958-F35 WH-18 522-N3 WH-18 2
126-C111 PK-16 115-1615 382-C91 PK-16 382-C91 PK-16 200-C23 BK-18 709-C117 OR-18 CBL-KK2 BK-4 GND 403-C69 GN-18 K947-C130 YL-18 915-C58 GN-18 4 915-F31 GN-18 A/C ARC SUPPRESSOR
Y-C4 AF-C2 104-AF2 YL-18
J-C10 129-C24 BU-18 403-C28 GN-18 200-C25 BK-14 NOTE C 441-C78 OR-18 H803-C61 BU-18 5 H803-F32 BU-18 106-8704
1673692 9X1054 2 5 6
1673693 105-J27 RD-18 135-C154 BU-14 104-C120 YL-16 406-C49 PU-18 200-C38 BK-16 450-C67 YL-18 308-C56 YL-18 308-F1 YL-18
105-Y10 RD-18 1 105-J20 RD-18 105-J20 RD-18 105-J36 RD-18 4 322-C64 GY-18 410-C51 WH-18 L854-C182 YL-18 451-C68 BR-18 403-C69 GN-18 7 403-F2 GN-18
2 104-AF3 YL-16 8
EROPS 200-Y15 BK-14 200-J9 BK-14 108-J37 BU-18
1
443-C33 YL-18 200-C144 BK-16 L855-C180 GN-18 464-C46 GY-18 C444-C77 YL-18 C444-F3 YL-18
(ATCH)
200-Y9 BK-16 3 200-J35 BK-16 119-J3 PK-16 105-J36 RD-18 3 AF-C1 C-C30A C-C30 450-C67 YL-18 200-C72 BK-18 892-C95 BR-18 200-T22 BK-14 521-C21 YL-18 441-C78 OR-18 9 441-F4 OR-18 A/C COMPRESSOR(ATCH)
108-Y11 BU-18 4 108-J37 BU-18 119-J8 PK-14 119-J30 PK-16 108-J37 BU-18 3E3376 3E3376 1552272 104-C160 YL-18 451-C68 BR-18 200-C112 BK-12 893-C7 GN-18 CBL-KK2 BK-4 522-C127 WH-18 200-C79 BK-18 10 200-F9 BK-18
5 119-J68 PK-16 119-J24 PK-16 START AID RELAY 1 1 314-C47 PU-18 104-C159 YL-16 200-C25 BK-14 A314-C73 OR-18 915-C58 GN-18 H807-C161 YL-18 11 H807-F5 YL-18
119-Y23 PK-14 6 119-J8 PK-14 119-J24 PK-16 119-J30 PK-16 ANTENNA AS 115-1615 2 2 104-C160 YL-18 200-C52 BK-16 A315-C123 WH-18 200-C102 BK-10 A958-C66 WH-18 12
ENG OIL PRESS SENDER
120-Y7 YL-16 7 120-J23 YL-16 119-J68 PK-16 3 3 104-C159 YL-16 709-C118 OR-18 C546-P6 WH-16 C444-C77 YL-18 464-F6 GY-18
122-Y19 BU-16 8 122-J1 BU-16 120-J23 YL-16 120-J23 YL-16
8E-1118
382-AF4 PK-16 4 4 382-C91 PK-16 892-C8 BR-18 200-C43 BK-18 C703-C14 BR-18 F400-C36 GY-18
CONN 34 155-4032
T-C7 F-C1
9 122-J1 BU-16 122-J1 BU-16 CONN 16 893-C134 GN-18 200-X3 BK-10 C920-C2 GY-18 H456-C162 PU-18 1275483 1275484
10 184-J73 BU-18 ANTENNA LEAD NOTE L 899-C30 BU-18 200-Y8 BK-16 E953-C17 GY-18 115-C12 RD-14 109-T1 RD-4 1 109-F8 RD-4
E 11 184-J74 BU-18 184-J73 BU-18 J-C2 9U-8746 ETHER AID ATCH 915-C58 GN-18 200-Y14 BK-16 F773-C124 OR-18 135-C154 BU-14 CASE GND 1 H801-C126 PU-18 E
12 184-J75 BU-16 184-J74 BU-18 1552264 RECP AS. END CAP ANTENNA A314-C73 OR-18 200-Y21 BK-8 F774-C125 WH-18 200-C52 BK-16 LH SIDE H803-C61 BU-18
H4 CONN 33 101-F38 RD-4
13 184-J76 BU-18 184-J75 BU-16 509-J11 WH-18 1 3E-3385 WH/BK FLH SP - A315-C123 WH-18 200-Y49 BK-18 F853-C13 BR-18 221-C99 BK-18 NOTE C H807-C161 YL-18 T-C4 F-C2 F-C3
506-Y12 PU-18 14 506-J34 PU-18 184-J78 BU-16 184-J76 BU-18 508-J10 PU-18 2 NOTE L WH FLH SP + A958-C66 WH-18 202-C86 BK-18 J764-C100 BR-18 308-C56 YL-18 K943-C139 OR-18 1779641 1779646 1552269
523-Y36 BR-16 15 523-J21 BR-16 184-J77 BU-18 184-J77 BU-18 200-J14 BK-18 3 BK GROUND C446-C32 PK-18 202-C116 BK-14 J764-C98 BR-18 308-C128 YL-18 K944-C131 YL-18 304-T15 WH-12 1 304-F7 WH-12 451-F11 BR-18 1 BK-18 ENG SPEED SENSOR
524-Y2 BU-16 16 524-J40 BU-16 184-J65 BU-18 184-J78 BU-16 4 NC C491-C115 PU-18 J764-C104 BR-18 310-C155 PU-18 K946-C59 OR-18 2 450-F12 YL-18 2 WH-18 189-5746
17 105-J36 RD-18 5 YL B+ MEM(NOTE D) H10 C491-C141 PU-18 J764-C101 BR-18 322-C64 GY-18 K947-C130 YL-18
526-Y37 YL-16 18 526-J53 YL-16 108-J37 BU-18 6 3A RD B+(12V) C703-C14 BR-18 202-C152 BK-18 J764-C74 BR-18 327-C129 PK-18
CONN 32 310-F14 PU-18 310-F14 PU-18 AIR INLET HTR RELAY
527-Y39 GN-16 19 527-J22 GN-16 184-J80 BU-18 512-J17 GN-18 7 GY/BK FRH SP - 112-X2 PU-4 C920-C2 GY-18 202-C109 BK-18 374-C156 PK-18 H807-F5 YL-18 H807-F5 YL-18 209-5152
20 184-J81 BU-18 511-J16 BR-18 8 GY FRH SP + 102-C63 BU-18 C992-C48 PU-18 202-C110 BK-18 382-C91 PK-16 H456-F15 PU-18
529-Y40 WH-18 21 529-J43 WH-18 200-J2 BK-16 200-J14 BK-18 GN/BK RLH SP - 200-X5 BK-16 103-C65 YL-18 E953-C17 GY-18 202-C4 BK-18 403-C69 GN-18 H456-F15 PU-18
530-Y45 OR-18 22 530-J32 OR-18 200-J2 BK-16 200-J18 BK-18 GN RLH SP + X-C1 105-C87 RD-18 F711-C178 GN-18 202-C5 BK-18 J764-C74 BR-18 148-F39 WH-4 148-F39 WH-4
607-Y44 PK-18 23 607-J12 PK-18 200-J14 BK-18 200-J19 BK-18 VI/BK RRH SP - 85 86 3E5519 106-C70 WH-18 F712-C177 GY-18 202-C151 BK-18 J764-C19 BR-18 406-C49 PU-18
614-Y1 PU-16 24 614-J13 PU-16 200-J9 BK-14 200-J15 BK-18 200-J26 BK-16 VI RRH SP + 87 114-C93 RD-18 F773-C124 OR-18 221-C99 BK-18 R981-C18 YL-18 441-C78 OR-18 CBL-MM1 BK-4 F-C9
25 200-J26 BK-16 200-J38 BK-18 RADIO C547-X11 OR-12 115-C15 RD-18 F774-C125 WH-18 276-C3 BK-18 447-C34 PK-18 1552269
26 200-J38 BK-18 200-J45 BK-18 30 115-C150 RD-14 F846-C82 PU-18 277-C121 BK-18 114-C93 RD-18 450-C67 YL-18 304-F7 WH-12 148-F39 WH-4 CBL-NN1 BK-4 K944-F22 YL-18 1
173-6532
27 200-J18 BK-18 200-J46 BK-18 87A 123-C60 WH-16 F853-C13 BR-18 278-C9 BK-18 451-C68 BR-18 H801-F18 PU-18 2
CONN 3 28 200-J19 BK-18 200-J50 BK-18 J-C3 GND MOTOR L HIGH SPEED FAN RELAY 124-C143 GN-14 F931-C37 PK-18 279-C10 BK-18 115-C12 RD-14 464-C46 GY-18 ENG OIL PRESS GAGE
G S 101-F38 RD-4
MAX SPEED GAGE COOLANT TEMP GAGE AIR INLET HEATER LEFT PUMP FWD SOL
29 200-J35 BK-16 200-J50 BK-18 200-J55 BK-18 1552272 3E-9362 126-C111 PK-16 G745-C83 PK-18 306-C57 GN-18 124-C143 GN-14 521-C21 YL-18 154-7488 166-6114 ENGINE BLOCK GROUND
191-0538 201-2408 192-4370
30 200-J70 BK-18 200-J66 BK-18 200-J66 BK-18 200-J26 BK-16 1 BK T° 129-C24 BU-18 G848-C90 GN-18 308-C1 YL-18 522-C127 WH-18 123-E19 WH-18 E-C1 E-C10 E-C3 MTR BAT CBL-FF3 RD-00
31 200-J45 BK-18 119-J24 PK-16 4 YL P 125-X13 OR-12 135-C154 BU-14 H801-C126 PU-18 308-C128 YL-18 126-C111 PK-16 915-C58 GN-18 LAMP 3 1141749 LAMP 2 1141749 LAMP 4 1141749 NOTE C
B+ IGN IGN IGN
200-J46 BK-18 500-J61 BR-16 2 GN H803-C61 BU-18 308-C56 YL-18 A958-C66 WH-18 189-3610 189-3610 189-3610
J-C8 3 RD MOTOR F-C7
200-J55 BK-18 501-J71 GN-16 H807-C94 YL-18 308-C138 YL-18 135-C154 BU-14 C444-C77 YL-18 614-E16 PU-18 SEND SEND SEND STARTER
1552269 112-X2 PU-4 H807-C85 YL-18 200-C25 BK-14 F400-C36 GY-18 H801-F30 PU-18 1552269
ROOF(ATCH) 1
FR WIPER MOTOR 30A 105-3133
1
506-J82 PU-18 503-J63 BR-16 179-4809 HVAC BKR 105-C140 RD-18 J764-C113 BR-18 308-C158 YL-18 F798-C35 YL-18 GND GND GND K946-F25 OR-18
2 184-J80 BU-18 504-J58 YL-16 503-J63 BR-16 200-C144 BK-16 J764-C114 BR-18 310-C155 PU-18 200-C52 BK-16 H451-C163 GN-18 H801-F26 PU-18 H801-F28 PU-18 2
X-C3 147-1773 CASE GND 4
FR RR WASHER ARC SUPPR 1 504-J58 YL-16 200-Y8 BK-16 J847-C29 GN-18 320-C11 OR-18 200-P7 BK-14 200-E11 BK-18 H801-F18 PU-18
1779646 LH SIDE RIGHT PUMP REV SOL
506-J34 PU-18 523-J21 BR-16 524-J29 BU-18 200-Y14 BK-16 J848-C31 BU-18 322-C64 GY-18 200-X3 BK-10 H456-C162 PU-18 464-E21 GY-18 H801-F28 PU-18

CBL-GG BK-00
106-8704 192-4370
1 NOTE C
506-J82 PU-18 524-J40 BU-16 529-J43 WH-18 WH/RD-12 H10 200-Y21 BK-8 K943-C139 OR-18 327-C129 PK-18 200-Y8 BK-16 H801-C126 PU-18 H801-F29 PU-18
J-C15 506-J83 PU-18 526-J53 YL-16 120-J28 YL-16 MOTOR BK-12 2 200-Y49 BK-18 K944-C131 YL-18 374-C156 PK-18 200-Y14 BK-16 H803-C61 BU-18 614-E50 PU-18
1552269 523-J21 BR-16 527-J22 GN-16 523-J21 BR-16 521-C21 YL-18 K946-C59 OR-18 382-C91 PK-16 200-Y21 BK-8 K943-C139 OR-18 J764-E54 BR-18 K946-F25 OR-18
1 506-J83 PU-18 524-J40 BU-16 529-J43 WH-18 614-J33 PU-18 521-Y31 YL-18 K947-C130 YL-18 403-C28 GN-18 200-C112 BK-12 H807-C161 YL-18 200-E48 BK-18 K947-F24 YL-18 F-C10
2 184-J81 BU-18 526-J53 YL-16 530-J32 OR-18 607-C26 PK-18 L854-C55 YL-18 202-C116 BK-14 H807-C50 YL-18 899-E34 BU-18 K943-F23 OR-18 1552269
FR RR WASHER ARC SUPPR 2 527-J22 GN-16 8 1 3 4 6 10 BLOWER C547-X4 OR-14 614-Y48 PU-18 L855-C62 GN-18 403-C147 GN-18 202-C151 BK-18 K944-C131 YL-18 102-E49 BU-18 709-E52 OR-18 K944-F22 YL-18 K943-F23 OR-18 1
106-8704 529-J43 WH-18 SW LH WIPER WASHER 168-2313 614-C20 PU-16 M730-C44 YL-18 403-C69 GN-18 221-C99 BK-18 K946-C59 OR-18 103-E9 YL-18 H801-F26 PU-18 2
D L MOTOR
GND
J-C4 530-J32 OR-18 607-J12 PK-18 237-9158 R981-C18 YL-18 403-C71 GN-18 308-C56 YL-18 K947-C130 YL-18 105-E28 RD-18 614-E17 PU-18 614-E17 PU-18
D
1552272 LEFT PUMP REV SOL
614-J33 PU-18 T776-C157 GY-18 406-C49 PU-18 308-C128 YL-18 T776-C157 GY-18 123-E18 WH-18 200-E13 BK-18 200-E13 BK-18 192-4370
T° BK 1 200-J2 BK-16 614-J41 PU-18 J-C14 410-C51 WH-18 310-C155 PU-18 123-E61 WH-18 441-E23 OR-18 441-E23 OR-18
GN 2 1429117
RENR7853-00 VOL. 1

P 503-J63 BR-16 607-J12 PK-18 614-J52 PU-18 7 2 5 9 X-C2 P-C2 443-C33 YL-18 322-C64 GY-18 123-E20 WH-18 123-E45 WH-18 123-E20 WH-18 123-E20 WH-18
B+ RD 3 504-J58 YL-16 614-J62 PU-18 BLOWER UNIT RESISTOR 3E3382 1552273 450-C67 YL-18 327-C129 PK-18 892-C165 BR-18 123-E58 WH-18 102-E49 BU-18 F-C11 F-C8
YL 4 119-J3 PK-16 614-J41 PU-18 614-J64 PU-18 200-J39 BK-18 139-3900 C546-X6 WH-16 1 C546-P6 WH-16 103-C65 YL-18 451-C68 BR-18 374-C156 PK-18 893-C166 GN-18 103-E9 YL-18 200-E6 BK-18 200-E6 BK-18 1552267 1552269
614-J33 PU-18 200-J38 BK-18 2 105-C87 RD-18 497-C80 BU-18 382-C91 PK-16 L854-C181 YL-18 105-E28 RD-18 443-E22 YL-18 443-E22 YL-18 FRAME GND 2 915-F31 GN-18 A RD-18 K947-F24 YL-18 1
614-J62 PU-18 524-J29 BU-18 515-X9 GY-14 3 515-P2 GY-14 105-C140 RD-18 497-C81 BU-18 403-C69 GN-18 L855-C179 GN-18 123-E43 WH-16 123-E4 WH-18 123-E18 WH-18 123-E18 WH-18 H803-F13 BU-18 B RD-18 H801-F29 PU-18 2
RR WIPER MOTOR 4 C
614-J85 PU-18 524-J40 BU-16 200-X10 BK-18 516-X8 GN-14 516-P3 GN-14 106-C70 WH-18 406-C49 PU-18 123-E57 WH-16 123-E18 WH-18 614-E15 PU-18 614-E15 PU-18 NOTE C
179-4812 PILOT OVERRIDE SOL RIGHT PUMP FWD SOL
614-J13 PU-16 614-J52 PU-18 120-J28 YL-16 517-X7 BU-14 5 517-P4 BU-14 102-C63 BU-18 450-C67 YL-18 123-E19 WH-18 A958-F35 WH-18
6 179-9390 192-4370
614-J64 PU-18 120-J23 YL-16 200-X12 BK-12 522-X1 WH-18 522-P5 WH-18 114-C93 RD-18 497-C42 BU-18 451-C68 BR-18 123-E45 WH-18 123-E20 WH-18 915-F31 GN-18
H803-F32 BU-18 F-C12
200-J15 BK-18 200-J39 BK-18 115-C15 RD-18 497-C76 BU-18 521-C21 YL-18 123-E4 WH-18 123-E29 WH-18 447-E5 PK-18 H803-F32 BU-18
105-J27 RD-18 527-J54 GN-18 CONN 17 115-C150 RD-14 521-C21 YL-18 522-C127 WH-18 123-E19 WH-18 123-E44 WH-18 123-E4 WH-18 1552269
C-C16 E-C8 1
105-Y10 RD-18 530-J32 OR-18 123-C60 WH-16 521-Y31 YL-18 L854-C181 YL-18 123-E44 WH-18 123-E58 WH-18 E-C4 A958-F35 WH-18 A958-F33 WH-18 GN-18
T° 1673692 1673693
108-Y11 BU-18 122-J42 BU-16 124-C143 GN-14 607-C26 PK-18 L855-C179 GN-18 123-E29 WH-18 123-E61 WH-18 LAMP 1 E-C2 LAMP 5 1141749 H803-F34 BU-18 2 GN-18

-
+
119-Y23 PK-14 526-J53 YL-16 THERMOSTAT SW 200-C144 BK-16 614-Y48 PU-18 892-C165 BR-18 102-C63 BU-18 1 102-E49 BU-18 200-E41 BK-16 200-E2 BK-18 189-3610 IGN 1141749 189-3610 IGN 403-F2 GN-18
Y-C2 3E-5464 2 F-C13 PARK.BK SOL
120-Y43 YL-16 614-J52 PU-18 614-C107 PU-18 893-C166 GN-18 103-C65 YL-18 103-E9 YL-18 200-E6 BK-18 614-E3 PU-18 SEND SEND 308-F1 YL-18
1552269 3 1552269 201-2171
120-Y43 YL-16 200-X3 BK-10 126-C111 PK-16 614-C149 PU-18 915-C58 GN-18 105-C88 RD-18 105-E28 RD-18 200-E6 BK-18 200-E7 BK-18 C444-F3 YL-18
BK-16 1 607-Y41 PK-18 120-Y7 YL-16 8 1 3 4 6 10 200-X3 BK-10 614-C148 PU-18 A958-C66 WH-18 H451-C163 GN-18 4 H451-E38 GN-18 200-E13 BK-18 200-E11 BK-18 A958-F37 WH-18 1
GND GND
BK-16 2 200-Y13 BK-18 120-Y6 YL-16 SW RH WIPER WASHER HVAC BOX(ATCH) 200-Y8 BK-16 H801-C126 PU-18 123-C60 WH-16 5 123-E43 WH-16 200-E48 BK-18 200-E13 BK-18 H803-F19 BU-18 2 F-C4
120-Y6 YL-16 237-9158 200-Y14 BK-16 614-C20 PU-16 H803-C61 BU-18 200-C38 BK-16 6 200-E41 BK-16 200-E7 BK-18 200-E2 BK-18 L1 L2 L3 HYD OIL TEMP GAGE ARC SUPPRESSOR 1073134
REAR FLOOD LAMP 122-Y19 BU-16 200-Y21 BK-8 709-C117 OR-18 H807-C50 YL-18 306-C57 GN-18 7 306-E26 GN-18 200-E48 BK-18 FUEL LEVEL GAGE 154-7487 106-8704

1
2
3
201-1423 122-Y20 BU-16 HEADLINER (ATCH) J-C13 200-Y49 BK-18 H807-C161 YL-18 308-C138 YL-18 8 308-E24 YL-18 200-E53 BK-18 153-0455 L I R
122-Y16 BU-16 7 2 5 9 1429117 129-C24 BU-18 709-C118 OR-18 K943-C139 OR-18 F798-C35 YL-18 9 F798-E39 YL-18 200-E64 BK-18 200-E55 BK-18
Y-C11 122-Y16 BU-16 DOME LAMP 200-J51 BK-18 135-C154 BU-14 892-C95 BR-18 K944-C131 YL-18 441-C78 OR-18 10 441-E23 OR-18 200-E56 BK-16 306-E26 GN-18 VALVE MANIFOLD
1237615 122-Y20 BU-16 4M-3601 200-J50 BK-18 521-C21 YL-18 892-C97 BR-18 K946-C59 OR-18 443-C33 YL-18 11 443-E22 YL-18 200-E53 BK-18 308-E63 YL-18 ALTERNATOR 110A B
1 506-Y12 PU-18 200-Y8 BK-16 521-Y31 YL-18 892-C165 BR-18 K947-C130 YL-18 447-C34 PK-18 12 447-E5 PK-18 200-E2 BK-18 410-E12 WH-18 L4 L5 L6 203-5492
MOTOR G
VC-C1 VC-C3
20 Page, Color 2, REM

2 200-Y33 BK-18 200-Y8 BK-16 108-LA1 BU-18 WH 527-J54 GN-18 607-C26 PK-18 892-C8 BR-18 T776-C157 GY-18 464-C46 GY-18 13 464-E21 GY-18 200-E11 BK-18 441-E23 OR-18
200-Y9 BK-16 200-LA2 BK-18 BK 527-J22 GN-16 3E3364 1552269 614-C20 PU-16 441-C78 OR-18 G848-C90 GN-18 14 G848-E8 GN-18 200-E55 BK-18 443-E22 YL-18 LAMP COLOR FUNCTION 109-F8 RD-4
FRONT REAR WASHER PUMP 200-Y15 BK-14 122-J42 BU-16 1 607-VC1 PK-18 607-VC1 PK-18 1 BK-16 614-Y48 PU-18 893-C96 GN-18 447-C34 PK-18 607-C26 PK-18 15 607-E36 PK-18 447-E5 PK-18 E-C7
6T-1375 200-Y25 BK-16 LA-C1 J-C1 122-J1 BU-16 TO CONNECTOR M-C2 2 200-VC2 BK-18 200-VC6 BK-18 2 BK-16 893-C7 GN-18 464-C46 GY-18 614-C148 PU-18 16 614-E42 PU-18 1552252
1552273 L1 RED ENGINE OIL PRESSURE
200-Y25 BK-16 3E3382 200-J51 BK-18 LOC SH1 B-10 893-C166 GN-18 C444-C77 YL-18 899-C30 BU-18 17 899-E34 BU-18 123-E29 WH-18 1 RD 200-F9 BK-18
Y-C13 523-Y36 BR-16 108-LA1 BU-18 1 105-J27 RD-18 200-J46 BK-18
CONN 15 FR LH FLOOD LAMP F400-C36 GY-18 C444-C77 YL-18 18 C444-E32 YL-18 306-E26 GN-18 464-E21 GY-18 J848-E31 BU-18 10 DKBU
1237615 2 J-C5 201-1422 19 4 L2 RED HYSTAT FILTER BY PASS
524-Y2 BU-16 200-LA2 BK-18 200-J15 BK-18 2 5 893-C134 GN-18 F798-C35 YL-18 C446-C32 PK-18 C446-E33 PK-18 308-E24 YL-18 607-E36 PK-18 H456-E40 PU-18 308-F1 YL-18
C 1 3 3E5519 20 3 C
529-Y40 WH-18 526-Y37 YL-16 511-LA3 BR-18 511-J16 BR-18 184-J74 BU-18 899-C30 BU-18 H451-C163 GN-18 C491-C137 PU-18 C491-E14 PU-18 614-E1 PU-18 G742-E59 GN-18 BU 403-F2 GN-18
MOTOR
2 200-Y22 BK-18 527-Y39 GN-16 512-LA4 GN-18 4 512-J17 GN-18 4 915-C58 GN-18 H456-C162 PU-18 F400-C36 GY-18 21 F400-E30 GY-18 308-E63 YL-18 614-E3 PU-18 C444-E32 YL-18 7 PK L3 RED ACTION LAMP 441-F4 OR-18
5 VC-C2 VC-C4 22 5 109-F8 RD-4
607-Y44 PK-18 508-LA5 PU-18 508-J10 PU-18 184-J75 BU-16 A314-C73 OR-18 441-C78 OR-18 F712-C177 GY-18 F712-E47 GY-18 614-E15 PU-18 F400-E30 GY-18 WH C444-F3 YL-18
614-Y1 PU-16 509-LA6 WH-18 6 509-J11 WH-18 185-J84 YL-16 1 3E3364 1552269 A315-C123 WH-18 447-C34 PK-18 F711-C178 GN-18 23 F711-E46 GN-18 308-E62 YL-18 614-E16 PU-18 C491-E14 PU-18 6 GN
LH DOOR WASHER PUMP L4 RED PARKING BRAKE
530-Y45 OR-18 3 1 614-VC3 PU-18 614-VC3 PU-18 1 BK-16 A958-C66 WH-18 464-C46 GY-18 F846-C82 PU-18 24 F846-E25 PU-18 410-E12 WH-18 614-E17 PU-18 J847-E35 GN-18 8 YL 441-F4 OR-18
6T-1375
529-Y40 WH-18
CONN 7 501-J71 GN-16 TO CONNECTOR M-C3 2 200-VC4 BK-18 200-VC5 BK-18 2 BK-16 C446-C32 PK-18 C444-C77 YL-18 H456-C162 PU-18 25 H456-E40 PU-18 441-E23 OR-18 614-E50 PU-18 9 PU 200-F9 BK-18
LED PANEL W/ ALARM
Y-C12 26 11 L5 RED ALTERNATOR
506-Y12 PU-18 509-LA6 WH-18 + FR RR WASHER 2 LOC SH1 B-10 CONN 14 C491-C137 PU-18 F400-C36 GY-18 J847-C29 GN-18 J847-E35 GN-18 443-E22 YL-18 614-E51 PU-18 410-E12 WH-18 GY 223-6538
1237615 506-Y12 PU-18 508-LA5 PU-18 - 185-J86 YL-18 115-1615 FR RH FLOOD LAMP F798-C35 YL-18 J848-C31 BU-18 27 J848-E31 BU-18 447-E5 PK-18 709-E52 OR-18 200-E7 BK-18 2 BK NOTE J L6 AMBER AIH
1 530-Y45 OR-18 529-Y40 WH-18 184-J73 BU-18 201-1422 H451-C163 GN-18 202-C86 BK-18 28 202-E37 BK-18 464-E21 GY-18 899-E34 BU-18 12
MOTOR LH SPEAKER F-C6 COOLANT TEMP SENDER
2 200-Y30 BK-18 530-Y45 OR-18 119-J44 PK-16 C491-C115 PU-18 H456-C162 PU-18 410-C51 WH-18 29 410-E12 WH-18 607-E36 PK-18 C444-E32 YL-18
6T-7695 1552269 208-2964
158-Y34 BR-14 500-J61 BR-16 OROPS SWEEPS LIGHTING (ATCH) C491-C141 PU-18 102-C63 BU-18 709-C117 OR-18 30 709-E52 OR-18 614-E42 PU-18 C446-E33 PK-18 123-E61 WH-18
E-C12
THIS SCHEMATIC IS FOR THE D3G-D5G
31 1 BK-18
RH DOOR WASHER PUMP 159-Y35 BU-14 614-J62 PU-18 C703-C14 BR-18 103-C65 YL-18 J764-C104 BR-18 J764-E54 BR-18 C491-E14 PU-18 C446-E33 PK-18
1552269 178-3984 CHG 02 2 BK-18
6T-1375 200-Y3 BK-14 512-LA4 GN-18 + C920-C2 GY-18 105-C88 RD-18 614-E15 PU-18 F400-E30 GY-18 123-E58 WH-18 T°
200-Y4 BK-14 511-LA3 BR-18 - 8 1 3 4 6 10 C992-C48 PU-18 123-C60 WH-16 NOTE F CONN 26 614-E17 PU- 18 F798-E39 YL-18 200-E55 BK-18 123-E61 WH-18 1
COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE
200-Y13 BK-18 SW FR WIPER WASHER E953-C17 GY-18 200-C38 BK-16 614-E50 PU-18 H451-E38 GN-18 G742-E59 GN-18 C446-E27 PK-18 2 MACHINE WITH THE KEY AND ENGINE OFF, XMSN
W-C1 Y-C6 200-Y22 BK-18 RH SPEAKER F711-C178 GN-18 202-C86 BK-18 614-E10 PU-18 H456-E40 PU-18 614-E51 PU-18 ARC SUPPRESSOR
1779649 6T-7695 237-9154 SHIFTER IN NEUTRAL,AND PARK BRAKE IN THE OFF POSITION.
1779654 200-Y30 BK-18
M-C1
F712-C177 GY-18 306-C57 GN-18 J764-E54 BR-18 607-E36 PK-18 C446-E60 PK-18 106-8704 ENGINE
158-W8 BR-12 1 158-Y34 BR-14 200-Y33 BK-18 J-C12 F773-C124 OR-18 308-C138 YL-18 614-E3 PU-18 J847-E35 GN-18 614-E1 PU-18 123-E58 WH-18
200-W10 BK-14 2 200-Y3 BK-14 521-Y5 YL-18 1429117 3E3382 M-C2 F774-C125 WH-18 410-C51 WH-18 614-E16 PU-18 J848-E31 BU-18 SH1 F-3 NOTE A: SWITCH SHOWN AT OPERATING TEMPERATURE
7 2 5 9 E-C13
159-W9 BU-12 3 159-Y35 BU-14 607-Y41 PK-18 1 1552269 F846-C82 PU-18 443-C33 YL-18 614-E51 PU-18 SWITCH WILL CLOSE WHEN THE TEMPERATURE
200-W11 BK-14 4 200-Y4 BK-14 2 1 9X1054 5 IS LESS THAN 45 DEGREES F
200-J55 BK-18 200-M1 BK-16 607-M4 PK-18 BK-16 F853-C13 BR-18 607-C26 PK-18 614-E1 PU-18 2
CONN TO C-C8 3 2 8 1 3 4 6 10 SW LIGHT
CONN 2 108-Y11 BU-18 200-J72 BK-18
LOC SH1 A-14)
200-M5 BK-18 BK-16 F931-C37 PK-18 614-C148 PU-18 709-E52 OR-18
180-6615
4
SH1 VARIOUS NOTE C: ASSEMBLE TERMINALS TO STUD
SYMBOLS
119-Y23 PK-14 H1 185-J86 YL-18 4 607-M2 PK-18 G745-C83 PK-18 709-C117 OR-18 899-E34 BU-18 200-E55 BK-18
W-C6 Y-C5 120-Y6 YL-16 185-J84 YL-16 5 614-M3 PU-18
CONN 15 OROPS FR LH FLOOD G848-C90 GN-18 899-C30 BU-18 C444-E32 YL-18
1
ABBREV COLOR
3E3364 1552269 3 HARNESS ASSEMBLIES
1 122-Y16 BU-16 G-C1 L 119-J44 PK-16 6 201-1422 H801-C126 PU-18 C446-C32 PK-18 C446-E33 PK-18 SH1 F-1 NOTE E: NORMALLY OPEN BEFORE REFRIGERANT CHARGE
158-Y34 BR-14 1552273 119-J30 PK-16 H803-C61 BU-18 C491-C137 PU-18 C491-E14 PU-18 E-C6 G742-E59 GN-18 IDENT PART NO. CHG LOC DESCRIPTION NOTE
521-W12 YL-18 2 521-Y5 YL-18
159-Y35 BU-14 1
GND
H 200-J72 BK-18
CONN 6 H807-C50 YL-18 F712-C177 GY-18 F400-E30 GY-18 1429117 HYD BYPASS FILTER RELAY SH1, 2 VARIOUS NOTE F: WIRE PAIRS ARE TO BE TWISTED TOGETHER AT LEAST A 180-8701 03 SH1 F-14 CASE RD RED
CONN 1 G-C2 200-G1 BK-16 2 BK-16
MOTOR
200-J45 BK-18 M-C4 M-C3 H807-C161 YL-18 F711-C178 GN-18 F798-E39 YL-18
7 2 5 9
115-1615 ONE TURN PER 25 mm WH WHITE
Y-C10 J-C6 C 210-4611 03 SH1 D-8 PLATFORM
521-W12 YL-18 1552273 CONN 4 3E3382 523-G2 BR-16 3 BR-16 T°
3E5519 2 5
1552269 1552269 F846-C82 PU-18 H451-E38 GN-18 2 LIGHT PANEL
OR ORANGE
200-W10 BK-14 524-Y2 BU-16 1 524-G3 BU-16 524-G3 BU-16 4 GN-16 184-J77 BU-18 BK-16 1 607-M7 PK-18 614-M3 PU-18 1 BK-16 G848-C90 GN-18 H456-E40 PU-18 SH1 A-12 NOTE H: EROPS LIGHTING HARNESS IS OMITTED WHEN MACHINE IS E 210-4612 02 SH1 C-5 DASH YL YELLOW
B+ P 144-9933
159-W9 BU-12 2 525-G4 GY-16 5 OR-16 BK-16 2 200-M8 BK-18 200-M6 BK-18 2 BK-16 H807-C94 YL-18 J764-C104 BR-18 J847-E35 GN-18 200-E53 BK-18 EQUIPPED WITH SWEEPS ATTACHMENT F 210-4614 03 SH1 D-3 ENGINE PK PINK
4
200-W11 BK-14 200-Y8 BK-16 3 200-G1 BK-16 120-G5 YL-16 6 GY-16 184-J78 BU-16 H807-C85 YL-18 J847-C29 GN-18 J848-E31 BU-18 103-E9 YL-18 E-C5 BK BLACK
158-W8 BR-12 120-Y43 YL-16 4 120-G5 YL-16 183-J79 GY-16 1 CONN 14 OROPS FR RH FLOOD J764-C104 BR-18 J848-C31 BU-18 J764-E54 BR-18 102-E49 BU-18 E-C9 1552272 R SH1 C-5 NOTE J: THIS A SIMPLIFIED SCHEMATIC SYMBOL FOR GENERAL
G 177-5280 02 SH1 B-13 LEFT WIPER ATCH
GY GRAY
NOTE K LH DOOR WIPER MOTOR OROPS REAR FLOOD H 177-5279 02 SH1 A-13 RIGHT WIPER ATCH
523-Y36 BR-16 5 523-G2 BR-16 3 201-1422 1552272 308-E63 YL-18 1 YL-16 REFERENCE OF PART FUNCTIONALITY PU PURPLE
179-4810 201-1423 LAMP COLOR FUNCTION BU-4 C OFF
C-C12 AC-C1 J 245-2730 00 SH1 E-14 ROOF ATCH BR BROWN
B 2 5
6 525-G4 GY-16 504-J58 YL-16 J764-C136 BR-18
1552272 3E3376
123-E45 WH-18 1
BU-3
2 PU-16 S ON SH1 B-14 NOTE K: LH AND RH HARNESSES REQUIRE INSERTION OF SOCKETS INTO GN GREEN
B
W-C2 FR RR WASHER 1 J764-C84 BR-18 J764-AC3 BR-18 L1 AMBER WIF H451-E38 GN-18 2 306-E26 GN-18 3 OR-16 LA 177-5277 01 SH1 C-13 HEADLINER ATCH
YL-2 B ST PLUG AS. CONNECTORS PER SCHEMATIC AFTER ASSEMBLY INTO
4 9X1054 Y-C9 H-C1 183-J87 GY-18 115-1615 OROPS LIGHTING GP (ATCH) J764-C135 BR-18 J764-C84 BR-18 1
NC COM L1 AMBER AIR RESTRICTION
123-E44 WH-18 3
YL-1
105-E28 RD-18 4 BR-16 M 180-8704 01 SH1 B-11 OROPS LIGHTING ATCH
BU BLUE
1 158-W8 BR-12
1552273 CONN 5 3E3382 H-C2 184-J76 BU-18 J764-C101 BR-18 F931-C37 PK-18 2 F931-AC2 PK-18 NO F798-E39 YL-18 4 KEY SWITCH
DOORS.
527-Y39 GN-16 1 527-H3 GN-16 1552273 NOTE K 119-J69 PK-16 J764-C19 BR-18 C992-C48 PU-18 3 C992-AC1 PU-18 142-8858 MA 207-2851 00 SH1 B-10 NO ROPS REAR LTG ATCH SYMBOL DESCRIPTION
3 GND SH1 VARIOUS NOTE L: REMOVE SPECIFIED CONNECTOR CAP TO ADD APPROPRIATE
2 1 H 503-J63 BR-16 4 F711-E46 GN-18 308-E63 YL-18 MC 206-3558 00 SH1 B-11 NO ROPS FRONT LTG ATCH
MOTOR CTR BK PEDAL SW ATTACHMENT.
RELAY 1 200-Y25 BK-16 3 200-H1 BK-16 200-H1 BK-16 2 BK-16 614-J64 PU-18 CONN 25 F711-E67 GN-18 306-E26 GN-18 MH 206-3559 00 SH1 B-10 NO ROPS MIDDLE LTG HARNESS ATCH
132-7077 BLADE, SPADE, RING,
115-1615 122-Y20 BU-16 4 122-H5 BU-16 526-H2 YL-16 3 BR-16 T° J764-C113 BR-18 C-C23 105-E28 RD-18
8 1 3 4 6 10 MA-C1 MC-C2 1552267 SH2 VARIOUS NOTE M: FOR FUTURE USE. MR 210-6212 01 SH1 A-5 MSS HARNESS ATCH OR SCREW TERMINAL
521-W12 YL-18 526-Y37 YL-16 5 526-H2 YL-16 527-H3 GN-16 4 GN-16 P J764-C114 BR-18
B+ 3E3382 1552269 497-C81 BU-18 A OR-18 + BATTERY
6 528-H4 PK-16 528-H4 PK-16 5 OR-16 J847-C29 GN-18 N 210-6213 00 SH1 F-1 A/C COMPRESSOR ATCH
SW RR WIPER WASHER J764-C135 BR-18 B BK-18 GROUND E-C14 E-C14A SH2, H-9 NOTE N: FOR SERVICE REPAIR OF CONN GR-C2 OR GR-C3 CUT WIRES TO CONN CIRCUIT CONNECTED
122-H5 BU-16 6 GY-16 1 607-MC1 PK-18 1 BK-16 J848-C31 BU-18 MSS TERM RESIST P 194-3836 02 SH1 G-8 HEATER ATCH
237-9157 MA-C2 MH-C1 MH-C2 MC-C1 G745-C83 PK-18 C WH-18 SIGNAL 1740502 3E3370 TERMINATE WIRES WITH SOCKETS PROVIDED IN SERVICE REPAIR HARNESS
521-W4 YL-16 105-Y10 RD-18 RH DOOR WIPER MOTOR 2 200-MA1 BK-16 200-MC2 BK-18 2 BK-16 K943-C139 OR-18 F712-E47 GY-18 1342540
3 1552272 3E3376 1552272 3E3376 CTR BK PEDAL SENSOR A ASSEMBLE TERMINATED WIRES INTO DT PLUG AS. T 210-4613 00 SH1 F-6 STARTING/CHARGING
200-W1 BK-16 200-Y8 BK-16 179-4811 J-C11 CONN TO C-C8 K944-C131 YL-18 F712-E68 GY-18 F711-E65 GN-18 CIRCUIT NOT CONNECTED
4 1 1 160-2443 B CONNECT DT PLUG AS. TO SERVICE REPAIR HARNESS V 180-8707 01 SH1 B-12 E-ROPS FRONT LIGHTING (LH) ATCH
C557-W5 OR-12 200-Y3 BK-14 7 2 5 9 1429117 LOC SH1 A-14 607-MA2 PK-18 607-MA4 PK-18 607-MH1 PK-18 NO ROPS FR LH FLOOD K946-C59 OR-18 F712-E66 GY-18
CONNECT SERVICE REPAIR HARNESS TO POWER SUPPLY MODULE
200-Y4 BK-14 5 614-MA3 PU-18 200-MA5 BK-18 2 200-MH2 BK-18 2 201-1422 K947-C130 YL-18 C V 180-8707 01 SH1 B-12 E-ROPS FRONT LIGHTING (RH) ATCH ELECTRICAL CONNECTION
W-C4 6 3 3 C-C24
200-J4 BK-18 614-MA3 PU-18 614-MH3 PU-18 L854-C181 YL-18 CONN 30 VA 208-9944 00 SH1 A-11 EROPS SWEEPS LTG (INSIDE) ATCH TO MACHINE STRUCTURE
1779646 1552267
200-Y29 BK-12 200-Y21 BK-8 200-J66 BK-18 CONN 6 200-MA6 BK-18 4 200-MH4 BK-18 4
MC-C3
L854-C182 YL-18
497-C80 BU-18 A OR-18 + BATTERY WIRE GROUP COLOR DESCRIPTIONS VF 208-9945 00 SH1 A-10 EROPS SWEEPS LTG (OUTSIDE) ATCH
1 C557-W5 OR-12 200-W10 BK-14 200-Y46 BK-12 183-J87 GY-18 INTERNAL ELECTRICAL
MOTOR
2 200-W7 BK-14 200-Y15 BK-14 183-J79 GY-16 MA-C4 CONN 18 CONN 19 1552269 L854-C55 YL-18 J764-C136 BR-18 B BK-18 GROUND E-C11 E-C11A MR-C1 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF. VC 208-9946 00 SH1 C-11 OROPS SWEEPS LTG CONNECTION TO SURFACE
W-C7 200-Y13 BK-18 119-J69 PK-16 1552269 614-MC3 PU-18 1 BK-16 L855-C179 GN-18 M730-C44 YL-18 C WH-18 SIGNAL 1552264 3E3388 3E3388 OF COMPONENT
1552269
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON. W 185-4303 02 SH1 C-15 A/C CONDENSOR ATCH
CONDENSER MOTOR 1 119-J68 PK-16 BK-16 1 607-MA7 PK-18 200-MC4 BK-18 2 BK-16 L855-C180 GN-18 DECEL PEDAL SENSOR 308-E62 YL-18 1 1 308-MR15 YL-18
521-W14 YL-16 1 200-J4 BK-18 BK-16 2 200-MA8 BK-18 160-2443 NOTE F 202-E37 BK-18 2 2 202-MR2 BK-18 STARTING CIRCUIT. X 185-4305 00 SH1 D-10 HVAC BOX ATCH CONNECTOR
180-5928
200-W13 BK-14 2 200-Y22 BK-18 L855-C62 GN-18 F711-E67 GN-18 3 3 F711-MR6 GN-18 202-MR2 BK-18 MR-C4 MSS ECM GROUND CIRCUIT. Y 238-7417 02 SH1 D-15 EROPS ATCH
NO ROPS FR RH FLOOD
V-C1 V-C2 4 4 1552264 218-0404
AC DIODE 200-Y25 BK-16 200-Y14 BK-16 J-C7
1552272 1552269
NO ROPS REAR FLOOD 201-1422 M730-C44 YL-18 F712-E68 GY-18 CONN 31 F712-MR17 GY-18 308-MR15 YL-18
STARTING AID CIRCUIT. AC 210-4619 00 SH1 B-7 CENTER BRAKE PEDAL ASSEMBLY ATCH WIRE, CABLE,
106-8704 200-Y30 BK-18 200-Y49 BK-18 1965330 201-1423 R981-C18 YL-18 200-E64 BK-18 5 NOTE L 5 200-MR13 BK-18 F846-MR1 PU-18 308-MR15 YL-18 1 KEYSWITCH ON COMPONENT
521-W3 YL-16 1 1 6 6 2 MACHINE ECM CIRCUIT AE 210-4617 00 SH1 G-7 FRONT FRAME
200-Y33 BK-18 607-J12 PK-18 V1 WH-18 BK-16 T776-C157 GY-18 202-MR2 BK-18 GND
W-C3 200-W2 BK-16 200-Y9 BK-16 200-J18 BK-18 2 V2 WH-18 2 BK-16 NO ROPS LIGHTING GP (JAPAN ONLY) (ATCH) G848-E8 GN-18 7 7 G848-MR4 GN-18 F711-MR6 GN-18 3 CAN DATA LINK + AF 210-6209 00 SH1 E-10 ETHER AID RELAY ATCH CIRCUIT GROUPING
MACHINE SECURITY CONTROL CIRCUIT.
9X1054 2 5
521-Y5 YL-18 521-Y31 YL-18 3 NOTE H F846-E25 PU-18 8 8 F846-MR1 PU-18 200-MR13 BK-18 F712-MR17 GY-18 4 CAN DATA LINK - FA 210-4616 01 SH1 G-1 HOOD
H#
DESIGNATION
4 FRONT LH FLOOD LAMP + 5 BLADE CONTROL CIRCUIT.
4 521-Y42 YL-18 129-C27 BU-18 T901-MR16 YL-18 EXCITER COIL SIGNAL WIRE ASSEMBLIES
201-1422 - 6
159-W9 BU-12 607-Y41 PK-18 607-Y27 PK-18 CONN 12 200-C23 BK-18 T902-MR7 PK-18 EXCITER COIL RETURN HEATER AND AIR CONDITIONER CIRCUIT. SPLICE
1 607-Y44 PK-18 614-Y48 PU-18 V-C2 T901-MR16 YL-18 7 UNUSED CP 195-8730 00 SH1 G-8 CODE PLUG WIRE AS.
3 J-C9 V-C1 TURN SIGNAL/WIPER/WASHER CIRCUIT.
614-Y1 PU-16 614-Y47 PU-16 1965330 1552272 1552269 NOTE F T902-MR7 PK-18 8 UNUSED HF 203-3986 00 SH1 F-15 HYDRAULIC FILTER WIRE AS. ATCH
VA-C1 VF-C2 POWER PORT MR-C5
RELAY 2 614-J41 PU-18 1 V1 WH-18 1 BK-16 178-7539 G848-MR4 GN-18 TA 213-6309 00 SH1 I-13 ALT BRKR/MAIN BRKR WIRE AS.
115-1615 200-J19 BK-18 2 V2 WH-18 2 BK-16 1552272 1552269 105-C142 RD-18 1552267
RED NOTE F HARNESS ASSEMBLIES CABLE ASSEMBLIES
3 NOTE H CONN TO J-C7 1 607-VA1 PK-18 607-VF1 PK-18 1 BK-16 124-P9 GN-14 129-C27 BU-18 RD A F846-MR1 PU-18 F711-MR6 GN-18 NOTE F
A C556-W6 BU-12 200-Y8 BK-16 200-Y8 BK-16 4 FRONT RH FLOOD LAMP LOC SH1 A-12 2 200-VA2 BK-18 VA-C2 VF-C1 200-VF6 BK-18 2 BK-16 129-C145 BU-18 GN B G848-MR4 GN-18 F712-MR17 GY-18 IDENT PART NO. CHG LOC DESCRIPTION NOTE AA 180-8709 02 SH1 G-12 BATTERY + TO PWR STUD A
201-1422 1965330 1552272 P-C1 C-C26 C-C25 C-C25A GREEN
200-Y14 BK-16 200-Y14 BK-16 3 NOTE L 200-C23 BK-18 BK C 200-MR13 BK-18 GF 227-3036 00 SH2 D-6 GRADE CONTROL FRONT ATCH CC 180-8711 01 SH1 H-13 DISCONNECT SW TO FRAME GND
W-C5 200-Y21 BK-8 200-Y21 BK-8
CONN 13 4 607-VA1 PK-18 1 607-VF1 PK-18 FR LH FLOOD 3E3370 1552267 202-C110 BK-18 1552273 3E3382 BI COLOR LED
1779646 GV 210-6216 02 SH2 G-10 GRADE CONTROL VALVE ATCH EE 180-8710 01 SH1 H-13 DISCONNECT SW TO BATTERY
200-Y49 BK-18 200-Y49 BK-18 EROPS FRONT LIGHTING GP (ATCH) CONN 12 200-VA6 BK-18 2 200-VF2 BK-18 201-1422 124-P9 GN-14 A 124-C143 GN-14 403-C147 GN-18 105-C142 RD-18 1 165-5655
1 C556-W6 BU-12 521-Y31 YL-18 521-Y31 YL-18 614-VA3 PU-18 3 614-VF3 PU-18 522-P5 WH-18 B 522-C127 WH-18 893-C96 GN-18 202-C110 BK-18 2 GH 210-6210 02 SH2 C-6 GRADE CONTROL HOOD ATCH FF 180-8713 03 SH1 H-12 BATTERY +
MOTOR VA-C3 MR-C3 NOTE F
2 200-W11 BK-14 614-Y48 PU-18 614-Y48 PU-18 H1 200-VA5 BK-18 4 200-VF4 BK-18 614-P36 PU-18 C 614-C149 PU-18 892-C97 BR-18 129-C145 BU-18 3 PRODUCT LINK EXCITER COIL GC 227-3039 00 SH2 G-9 GRADE CONTROL CASE ATCH GG 180-8717 01 SH1 D-13 STARTER TO FRAME GND
H1 1552272 VF-C3 403-C147 GN-18 4 NOTE L 206-5203 1552269
CONN TO J-C9 1 614-VA3 PU-18 CONN 20 1552269 CONN 23614-P12 PU-18 893-C96 GN-18 5 BK 1 T901-MR16 YL-18
GR 227-3035 00 SH2 E-6 GRADE CONTROL REAR ATCH HH 180-8714 01 SH1 H-13 DISC SW TO BATT.
CONDENSER MOTOR 2
Y-C3 C-C8A C-C8 2 1 6 2 LH 227-3037 01 SH2 B-5 GRADE CONTROL LEFT BULKHEAD ATCH KK 187-4489 01 SH1 E-7 CASE GND TO PLATFORM GND
180-5928 NOTE L H10 LOC SH1 A-12 200-VA4 BK-18 614-VF3 PU-18 BK-16 614-P36 PU-18 614-P14 PU-18 892-C97 BR-18 BK T902-MR7 PK-18
3E3382 3E3382 1552273 3 200-VF8 BK-18 2 BK-16 200-P15 BK-18 RH 210-6211 01 SH2 B-9 GRADE CONTROL RIGHT BULKHEAD ATCH MM 140-0860 00 SH1 E-2 ENGINE BLOCK TO GND
105-Y10 RD-18 1 1 105-C140 RD-18 H10 4 200-P13 BK-18
CONN 24 MSS (ATCH)
NOTE F GA 210-6214 00 SH2 H-12 SRV ADAPTER INPUT PM400 ATCH NN 207-2853 00 SH1 E-2 AIH TO ENGINE BLOCK
CONDENSER (ATCH) 200-Y9 BK-16 2 2 200-C144 BK-16 CONN 13 FR RH FLOOD 200-P7 BK-14
GJ 210-6215 00 SH2 I-12 SRV ADAPTER OUTPUT PM400 ATCH - 9U-8746 01 SH1 E-12 CABLE AS. - COAXIAL ATCH
521-Y42 YL-18 3 CONN 6 3 521-C21 YL-18 201-1422 515-P2 GY-14 DASH
607-Y27 PK-18 4 4 607-C26 PK-18 516-P3 GN-14
614-Y47 PU-16 5 5 614-C20 PU-16 EROPS SWEEPS LIGHTING (ATCH) 517-P4 BU-14 RIGHT HAND CONSOLE
6 6 C546-P6 WH-16
EROPS (ATCH)
15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
 Wire Description Electrical Schematic Symbols And Definitions
Wire Wire
Wire Color Description Wire Color Description RENR7853
Number Number
Power Circuits Accessory Circuits (Continued)
October 2003
101 RD Bat (+) 527 GN Wiper - Right Door (Low) T

102 BU Lighting #1 Fuse 528 PK Not Used Pressure Temperature Level Flow Circuit Breaker
103 YL Lighting #2 Fuse 529 WH Washer - Left Door Symbol Symbol Symbol Symbol Symbol
104 YL Start Aid Relay 530 OR Washer - Right Door
105 RD Key SW 567 WH A/C Mode SW to Blower Speed SW
43 106 WH Detent 589 GN A/C Pressure SW to A/C Clutch Solenoid Normally Open switch that will close with an increase of a specific condition (temp-press-etc.).
108 BU Dome Lamp C546 WH High Speed Fan Relay The circle indicates that the component has screw terminals and a wire can be disconnected from it.
109 RD Alt Output (+) Term. C547 OR High Speed Fan Relay to Blower Motor
Normally Closed switch that will open with an increase of a specific condition.
112 PU Main Power Relay Output C556 BU Condenser Motor #2 to Relay #2
No circle indicates that the wire cannot be disconnected from the component.
60 55 114 RD Warning Horn (Forward) C557 OR Condenser Motor #1 to Relay #1
115 RD Alternator Breaker Lighting Circuits
119 PK Front/Rear Wiper 607 PK Flood Lamp - Front This indicates that the component has a wire connected to it that is connected to ground.
120 YL Left Wiper 614 PU Park/Tail/Dash/Lamp
58 61
64 122 BU Right Wiper Control Circuits
123 WH Monitoring Fuse 709 OR 10V Sensor Supply This indicates that the component does not have a wire connected to ground. It is grounded by
57 54
124 GN A/C 769 BU Left Track Speed Sensor
being fastened to the machine.
125 OR A/C Breaker 770 GN Right Track Speed Sensor
126 PK Machine ECM C703 BR Joystick Steering Sensor
Reed Switch - A switch whose contacts are controlled by a magnet. A magnet closes the
129 BU Power Port F711 GN MSS Can Data Link (+)
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
135 BU Lift Pump F712 GY MSS Can Data Link (-)
148 WH Air Inlet Heater Relay F773 OR Accel SW (N.O.)
51 63
56 53 158 BR A/C Condenser Relay #1 F774 WH Decel SW (N.O.)
Sender - A component that is used with a temperature or pressure gauge. The sender measures
159 BU A/C Condenser Relay #2 F798 YL Air Restricted Indicator
the temperature or pressure. Its resistance changes to give an indication to the gauge of the
177 RD Main Breaker G742 GN Hyd Filter Bypass Relay T temperature or pressure.
59 62
183 GY Rear Wiper Washer Switch G745 PK Brake Pedal Sensor
184
185
BU
YL
Front/Rear Washer Arc Suppressor (1&2)
Front Wiper Washer Switch
J764
M730
BR
YL
10V Sensor Return
Decel Pedal Sensor
D3G, D4G, and D5G HYSTAT Relay (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
A101 GN Grade Control #1 (B+) T744 WH Power Supply Module (Return) It has a coil that makes an electromagnet when current flows through it. The electromagnet can
A102
A103
BU
YL
Grade Control #2 (B+)
Grade Control #3 (B+)
T745
T748
YL
PK
Power Supply Module (Return)
Power Supply Module (Return)
Track-Type Tractors open or close the switch part of the relay.

200 BK
Ground Circuits
Main Chassis
T776
833
GY
GY
Lift Pump Relay
Right Track Speed Sensor
Electrical System Solenoid - A solenoid is an electrical component that is activated by electricity. It has a coil that
makes an electromagnet when current flows through it. The electromagnet can open or close
202 BK Machine ECM 835 PU Left Track Speed Sensor a valve or move a piece of metal that can do work.
221 BK Engine Coolant Temperature Sensor 892 BR CAT Data Link (-) D3G: D4G: D5G:
276 BK Harness Code 0 893 GN CAT Data Link (+)
61
277 BK Harness Code 1 899 BU Max Speed Gauge JMH1-UP HYD1-UP WGB1-UP Component, Connector, Harness And Wire Symbols
278 BK Harness Code 2 F846 PU MSS LED (Red) BYR1-UP TLX1-UP RKG1-UP
62 279 BK Harness Code 3 F853 BR Joystick F/N/R Sensor
Harness Identification Letter(s):
Basic Machine Circuits G848 GN MSS LED (Green) Wire, Cable, or Harness Assembly Identification:
(A, B, C, ..., AA, AB, AC, ...)
304 WH Starter Relay No. 1 Output H801 PU Proportional Driver Return (1-4) Includes Harness Identification Letters and Harness
Connector Serialization Codes
306 GN Key SW to Machine ECM H802 GY Proportional Driver Return (5-8)
Harness identification code Harness Connector Serialization Code:
308 YL Main Power Relay Coil H803 BU Proportional Driver Return (9-12)
This example indicates The "C" stands for "Connector" and the number
58
310 PU Air Inlet Heater Relay H807 YL On/Off Driver Return (1-8) wire 135 in harness "AG". indicates which connector in the harness. (C1, C2, C3, .....)
Part Number for
51 59 314 PU Start Aid Relay H899 OR Not Used Connector Plug
320 OR Horn Relay J847 GN Action Alarm Part Number For
C-C4 AG-C3 AG-C4 L-C12 Connector Recepticle
321 BR Backup Alarm J848 BU LED Panel 130-6795 130-6795 111-7898 3E-5179
322 GY Warning Horn (Forward) L854 YL Grade Control CAN 0 (+) 325-AL135 PK-14
325-AG135 PK-14 1 5A
327 PK Engine Shutdown Solenoid L855 GN Grade Control CAN 0 (-)
374 PK Motor Start Relay L856 YL Grade Control CAN 1 (+) Socket
Pin
63 382 PK Start Aid Solenoid L857 GN Grade Control CAN 1 (-) Wire Color Wire Gauge Receptacle Fuse (5 Amps)
A314 OR Park Brake SW (N.C.) L860 YL Grade Control SW 0
53 Single Wire Circuit Plug
57 54 A315 WH Park Brake SW (N.O.) L861 PK Grade Control SW 1 Connector Ground
Identification
Monitoring Circuits L862 PU Grade Control SW 2 Connection 2
Number 200-L32 BK-14
403 GN Alternator (R) Term. L863 BU Grade Control SW 3 Component
Pin or Socket Part Number
56 406 PU Engine Coolant Temperature Sensor L864 GY Grade Control SW 4
Number 105-9344
410 WH Opr Mon Action Alarm L865 GN Grade Control SW 5
441 OR Eng Coolant Temp Gauge L866 PK Grade Control SW (Ground)
1 Deutsch connector: Sure-Seal connector:
43
443 YL Hyd Oil Temp Gauge L870 YL Power Supply Module to Display 1
The plug contains all sockets The plug and receptacle contain
447
450
PK
YL
Fuel Level Gauge
Engine Speed Sensor (+)
L871
L872
BU
BU
Power Supply Module to Display
Switched Power #1
Volume 2: AccuGrade - Laser System 2 and the receptacle contains all pins. 2 both pins and sockets.

451 BR Engine Speed Sensor (-) L873 GY Switched Power #2

© 2003 Caterpillar Printed in U.S.A.
464 GY Engine Oil Pressure Gauge L874 OR Switched Power #3
60 All Rights Reserved
55 497 BU 8V Sensor Supply 915 GN Pilot Override Solenoid
64
C444 YL Alternator Indicator Lamp A958 WH Park Brake Solenoid
C446 PK Hyd Filter Bypass Lamp C920 GY Fault Lamp
C491 PU Parking Brake Lamp C958 BU Right Motor Solenoid
F400 GY Engine Oil Pressure Lamp C959 BR Left Motor Solenoid
H451 GN Water in Fuel Sensor C992 PU Service Brake Pedal SW
H456 PU Air Inlet Heater Lamp E953 GY Accel SW (N.C.)
Accessory Circuits F931 PK Service Brake Pedal SW Component Identifiers (CID¹)
500 BR Wiper - Front (Park) K943 OR Left Pump Reverse Solenoid Module Identifier (MID²)
A B C D
501 GN Wiper - Front (Low) K944 YL Left Pump Forward Solenoid Machine ECM A-B Tap
503 BR Wiper - Rear (Park) K946 OR Right Pump Reverse Solenoid A-C Tap
(MID No. 079) A-D Tap
504 YL Wiper - Rear (Low) K947 YL Right Pump Forward Solenoid CID Component
506 PU Washer - Front N957 PK Not Used
Machine Harness Connector And Component Locations 508 PU Radio Speaker - Left N958 PK Not Used
0017
0041
Solenoid Valve (Fuel Shutoff)
Sensor Power Supply (8 DCV)
509 WH Radio Speaker - Left (Common) N959 PK Not Used 0070 Rocker Switch (Parking Brake)
511 BR Radio Speaker - Right N960 OR Not Used 0110 Temperature Sensor (Engine Coolant) Blower Unit Resistor 139-3900
512 GN Radio Speaker - Right (Common) N961 OR Not Used 0133 Solenoid Valve (Transmission Pilot Pressure)
515 GY Blower Motor (HI) N963 OR Not Used 0153 Speed Sensor (Right Track)

RENR7853-00 VOL. 2
516 GN Blower Motor (Medium) N967 GY Not Used 0154 Speed Sensor (Left Track) Resistor, Sender and Solenoid Specifications
61 517 BU Blower Motor (Low) N976 PU Not Used 0168 Electrical System
Part No. Component Description Resistance (Ohms)¹
521 YL A/C SW To Refrigerant SW N979 GN Not Used 0190 Engine Speed Sensor 3E-1908 Solenoid - A/C Clutch 3.50 ± 0.15
522 WH A/C Clutch To Thermostat SW N980 GN Not Used 0444 Magnetic Switch (Start Relay)
560 to 716 @ 54.4°C (129.9°F)
523 BR Wiper - Left Door (Park) N981 GN Not Used 0468 Position Sensor (Service Brake Pedal) 7W-9943 Sender - Hydraulic Temperature
72.1 to 81.8 @ 110°C (230.0°F)
62
524 BU Wiper - Left Door (Low) R981 YL Decel SW (N.C.) 0617 Relay (Inlet Air Heater) Term Resistor Main #1
Connector Location for Volume 2 525 GY Not Used T901 YL MSS Exciter Coil (Signal) 0637 Backup Alarm 134-2540 Resistor - MSS Term 120
58
526 YL Wiper - Right Door (Park) T902 PK MSS Exciter Coil (Return) 0650 Harness Code
Schematic Machine Term Resistors 1-4 Grade Control
Connector Number 0681 Solenoid Valve (Parking Brake)
Location Location Winch Brake (Detent)
137-9754 Solenoid - 17.47 ± 1.00
CONN 36 I-9 43 0817 ECM Internal Backup Battery Winch Spool (Detent)
59
CONN 39 H-13 53 51 1482 Sensor Power Supply (10 DCV) 138-2622 Solenoid - Start Aid 1.2
1693 Position Sensor (Deceleration Pedal)
CONN 40 I-13 53 Component Location for Volume 2 A-B Tap 0.25 ± 0.025
CONN 41 I-12,H-9 53 1699 Position Sensor (Forward/Neutral/Reverse) 139-3900 Resistor - A/C Blower Unit (See Illustration Above) A-C Tap 0.5 ± 0.05
Schematic Machine Schematic Machine
Component Component 1700 Position Sensor (Joystick) A-D Tap 1.0 ± 0.1

20 Page, REM
CONN 42 H-12,H-10 53 Location Location Location Location
CONN 43 B-9 54 1701 Position Sensor (Accelerate Switch for Joystick) 227 to 257 @ 0 to 21 kPa (0 to 3 psi)
Display F-4 51 Resistor - Term #1 C-6 57
CONN 44 C-9 55 1702 Position Sensor (Decelerate Switch for Joystick) 192 ± 27.5 @ 48.3 kPa (7 psi)
Mast - Electronic (LH) A-6,B-6 58 Resistor - Term #2 C-6 57 155-4032 Sender - Engine Oil Pressure
CONN 45 D-9 43 1703 Proportional Solenoid Valve (Forward Left Drive Pump) 102 ± 11 @ 276 kPa (40 psi)
63 Mast - Electronic (RH) B-11 59 Resistor - Term #3 G-6 53
CONN 46 G-9 56 1704 Proportional Solenoid Valve (Reverse Left Drive Pump) 21.5 to 49.5 @ 552 kPa (80 psi)
Module - Interface (Valve) G-10 60 Resistor - Term #4 H-6 53
CONN 47 H-6 53 53 1705 Proportional Solenoid Valve (Forward Right Drive Pump) 179-9390 Solenoid - Pilot Override 10.3 ± .6
Module - Power Supply H-9 53 Switch - Remote E-6 63
CONN 48 G-6 53 1706 Proportional Solenoid Valve (Reverse Right Drive Pump) Left Pump Forward
54 57 Receiver - Laser (LH) A-5 61 Valve - Grade Control G-12 64
CONN 49 F-6 53 1707 Proportional Solenoid Valve (Left Drive Motor) Left Pump Reverse
Receiver - Laser (RH) B-11 62 192-4370 Solenoid - 4.5 ± .3
CONN 50 E-6 53 1708 Proportional Solenoid Valve (Right Drive Motor) Right Pump Forward
Machine locations are repeated for components located close together.
CONN 51 D-6 55 1960 ECM Cannot Communicate with the Electronic Key Reader Right Pump Reverse
CONN 52 D-6 57 ¹ The CID is a diagnostic code that indicates which circuit is faulty. 201-2171 Solenoid - Park Brake 10.16 ± .20
CONN 53 C-6 57 ² The MID is a diagnostic code that indicates which electronic control module 653 ± 78 @ 54.4°C (129.9°F)
diagnosed the fault. 208-2964 Sender - Coolant Temperature
CONN 54 B-5 54 92 ± 8 @ 110°C (230°F)
CONN 55 B-10 54 Related Electrical Service Manuals 214-6343 Solenoid -
Left Motor
4.5 ± .3
The connectors shown in this chart are for harness to harness connectors. Title Form Number Failure Mode Identifiers (FMI)¹ Right Motor
Connectors that join a harness to a component are generally located at or near Accugrade - Laser System: SEBU7803 FMI No. Failure Description Empty: 240 to 250
224-8597 Sender - Fuel Level
the component. See the Component Location Chart. 0 Data valid but above normal operational range. Full: 28 to 33
Electric Starting Motor: 105-3133 SENR3828
1 Data valid but below normal operational range. ¹ At room temperature unless otherwise noted.
Machine Control: RENR7313
2 Data erratic, intermittent, or incorrect.
MSS Control: RENR7950
3 Voltage above normal or shorted high.
Systems Operation: RENR7314 4 Voltage below normal or shorted low.
5 Current below normal or open circuit.
Off Machine Switch Specification
Part No. Function Actuate Deactuate Contact Position
6 Current above normal or grounded circuit.
-1.1 ± 0.8°C 2.2 ± 0.8°C
7 Mechanical system not responding properly. 3E-5464 Thermostat Normally Closed
(30 ± 1.4°F) (36 ± 1.4°F)
8 Abnormal frequency, pulse width, or period.
500 kPa 500 kPa
9 Abnormal update. 094-6997 Engine Oil Pressure Normally Closed
Event Codes (72.5 psi) (72.5 psi)
10 Abnormal rate of change.
276 kPa 207 kPa
Machine Control 11 Failure mode not identifiable. 134-0404 Hydraulic Filter Bypass ( #1,#2, and #3) Normally Open
(40.0 psi) (30.0 psi)
Event Code Condition 12 Bad device or component. 400 kPa Max 350 ± 20 kPa
201-4159 Low Park Brake Pressure Normally Closed
E188 Service Brake Pedal Not Actuating Parking Brake 13 Out of calibration. (58 psi Max) (50.8 ± 3.0 psi)
E190 Engine Overspeed Condition 14 Parameter failures. 275 to 1750 kPa -
236-6923 A/C Pressure Normally Open¹
E395 Transmission Stall Condition 15 Parameter failures. (40 to 255 psi) -
16 Parameter not available. ¹ With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained
E482 Unexpected Left Track Forward Movement Detected
17 Module not responding. down to 170 kpa (25psi).
E483 Unexpected Right Track Forward Movement Detected
18 Sensor supply fault.
E484 Unexpected Left Track Reverse Movement Detected
19 Condition not met.
E485 Unexpected Right Track Reverse Movement Detected 20 Parameter failures.
¹The FMI is a diagnostic code that indicates what type of failure has occurred.
 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

200-GR89 BK-14
NOTE F
200-GR91 BK-14 L854-GR101 YL-18 L854-GR28 YL-18
GR-C4
1552252 L854-GR56 YL-18
1 A101-GR100 GN-14 L854-GR64 YL-18 L854-GR59 YL-18
GJ-C1 2 200-GR99 BK-14
3E3388 GJ-C2 3 A102-GR92 BU-14
1 A101-GJ1 GN-14 3R9965 4 200-GR91 BK-14 L854-GR50 YL-18
2 200-GJ2 BK-14 A101-GJ1 GN-14 A 5 A103-GR90 YL-14 L854-GR46 YL-18
3 A102-GJ3 BU-14 200-GJ2 BK-14 B TO PLATFORM HARNESS C-C6 6 200-GR89 BK-14
4 200-GJ4 BK-14 A102-GJ3 BU-14 C (LOC SH1 G-3) 7 893-GR23 GN-18 L854-GR101 YL-18
NOTE N 5 A103-GJ5 YL-14 200-GJ4 BK-14 D 8 892-GR22 BR-18 L854-GR96 YL-18
6 200-GJ6 BK-14 E
CONN 36 9 L860-GR98 YL-18
7 F 10 L866-GR97 PK-18
I 8 A103-GJ5 YL-14 G 11 L854-GR96 YL-18 L854-GR78 YL-18 L854-GR2 YL-18 I
200-GJ6 BK-14 H 12 L855-GR95 GN-18 L854-GR80 YL-18
CONN 40
CONN 41 L854-GR84 YL-18
L870-GR30 YL-18 L854-GR81 YL-18
SERVICE REPAIR HARNESS FOR CONNECTOR GR-C3 L871-GR29
L872-GR88
BU-18
BU-14
L855-GR49 GN-18
L855-GR45 GN-18
L873-GR74 GY-14

L874-GR86 OR-14 L855-GR63 GN-18 L855-GR60 GN-18

T744-GR87 WH-14 L855-GR55 GN-18
T745-GR73 YL-14
T748-GR85 PK-14 L855-GR27 GN-18
L855-GR102 GN-18
L855-GR95 GN-18

L855-GR77 GN-18 L855-GR1 GN-18

L855-GR79 GN-18

L855-GR83 GN-18
L855-GR82 GN-18 N967-GR32 GY-18

A102-GR92 BU-14 N957-GR34 PK-18 NOTE F

GA-C2 GA-C1 GR-C5 GR-C5A

A103-GR90 YL-14
3E3388 6D5257 NOTE F 1552253 1907612
1 L872-GA1 BU-14 A L872-GR58 BU-14 1
2 T744-GA2 WH-14 B L856-GR52 YL-18 T744-GR57 WH-14 2
3 L873-GA3 GY-14 C NOTE N NOTE N L856-GR147 YL-18 L856-GR53 YL-18 N960-GR35 OR-18 3
4 T745-GA4 YL-14 D POWER SUPPLY MODULE L854-GR56 YL-18 4
5 E GR-C2 2269169 GR-C3 5
NOTE N L870-GA5 YL-18 L855-GR55 GN-18 NOTE M
6D5257 B A 3R9965
6 L871-GA6 BU-18 F N957-GR34 PK-18 6
7 L874-GA7 OR-14 G L872-GR88 BU-14 A SWITCHED PWR 1 BLADE CONT B+ 1 A A101-GR94 GN-14 L856-GR43 YL-18 N976-GR33 PU-18 7
CONN 47
H 8 T748-GA8 PK-14 H T744-GR87 WH-14 B SWITCHED PWR 1 RTN GND 1 B 200-GR93 BK-14 L856-GR66 YL-18 L857-GR54 GN-18 8 H
L873-GR74 GY-14 C SWITCHED PWR 2 BLADE CONT B+ 2 C A102-GR92 BU-14 L856-GR53 YL-18 9
CONN 39 CONN 42 T745-GR73 YL-14 D SWITCHED PWR 2 RTN GND 2 D 200-GR91 BK-14 N967-GR32 GY-18 10
L870-GR30 YL-18 E AWAKE E H899-GR103 OR-18 L856-GR76 YL-18 L856-GR21 YL-18 N979-GR31 GN-18 11
L871-GR29 BU-18 F AWAKE GND F 12
SERVICE REPAIR HARNESS FOR CONNECTOR GR-C2 L874-GR86
T748-GR85
OR-14
PK-14
G
H
SWITCHED PWR
SWITCHED PWR
3
3 RTN
BLADE CONT B+ 3
GND 3
G
H
A103-GR90 YL-14
200-GR89 BK-14

CONN 42 CONN 41 NOTE M

L857-GR51 GN-18
NOTE F L857-GR54 GN-18 GR-C6
1740502
L857-GR44 GN-18 L856-GR52 YL-18 A
TERM RESIST 4
L857-GR148 GN-18 L857-GR65 GN-18 L857-GR51 GN-18 B 1342540
C

Distance between the

GRADE CONTROL VALVE GV-C2 connector and the CAN
L857-GR75 GN-18 L857-GR20 GN-18 NOTE F
225-9595 1667656 splices not to exceed
150mm
POWER 1 RD-1-GV1 GY
CONTROL 2 WH-2-GV3 GY
FAULT 3 BK-2-GV4 GY GR-C7
GROUND 4 BK-1-GV2 GY L872-GR62 BU-14 L872-GR48 BU-14 1740502
NOTE F L872-GR58 BU-14 L854-GR50 YL-18 A TERM RESIST 3
L855-GR49 GN-18 B 1342540
INTERFACE MODULE (VALVE) L872-GR88 BU-14 C
GV-C1 226-0357 GC-C1 GC-C2 GR-C1 L872-GR72 BU-14
2302567 B A 6D8149 1552272 3E3376 L872-GR70 BU-14 L872-GR37 BU-14 NOTE F
RD-1-GV1 A VALVE PWR 1 SWITCHED PWR 3 A L874-GC1 OR-14 1 L874-GR86 OR-14
BK-1-GV2 B VALVE GND 1 B 2 T748-GR85 PK-14 L872-GR68 BU-14 GR-C8 GR-C8A
WH-2-GV3 C VALVE SIG 1 CAN0 (+) C L854-GC3 YL-18 3 L854-GR84 YL-18 L872-GR7 BU-14 1552254 1907613
BK-2-GV4 D VALVE FAULT 1 CAN0 (-) D L855-GC4 GN-18 4 L855-GR83 GN-18 L872-GR48 BU-14 1
RD-3-GV5 E VALVE PWR 2 E T744-GR47 WH-14 2
G BK-3-GV6 F VALVE GND 2 SWITCHED PWR 3 RTN F T748-GC2 PK-14
CONN 46 A101-GR100 GN-14 N961-GR26 OR-18 3
G
WH-4-GV7 G VALVE SIG 2 G A101-GR94 GN-14 A101-GR39 GN-14 L854-GR46 YL-18 4
BK-4-GV8 H VALVE FAULT 2 H L855-GR45 GN-18 5 NOTE M
I I N958-GR25 PK-18 6 CONN 48
J J NOTE F L854-GR81 YL-18 N980-GR24 GN-18 7
L855-GR82 GN-18 L857-GR44 GN-18 8 NOTE F
L856-GR76 YL-18 L856-GR43 YL-18 9
L857-GR75 GN-18 N963-GR42 OR-18 10
GV-C3 T744-GR57 WH-14 N959-GR41 PK-18 11
1667656 L872-GR72 BU-14 T744-GR61 WH-14 T744-GR47 WH-14 N981-GR40 GN-18 12
POWER 1 RD-3-GV5 L873-GR74 GY-14
CONTROL 2 WH-4-GV7 T744-GR71 WH-14 T744-GR36 WH-14 NOTE F
FAULT 3 BK-4-GV8 T745-GR73 YL-14
GROUND 4 BK-3-GV6 T744-GR67 WH-14 GR-C9 CB-C1
T744-GR6 WH-14 9X1343 2269261
A101-GR39 GN-14 1
T744-GR69 WH-14 200-GR38 BK-14 2
T744-GR87 WH-14 L872-GR37 BU-14 3 SW PWR1 BU-18
T744-GR71 WH-14 T744-GR36 WH-14 4 PWRGND1 BK-18 CB-C2
N958-GR25 PK-18 NOTE F 5 GND BK-18 2269261 DISPLAY
N960-GR35 OR-18 6 226-9253
N957-GR34 PK-18 7 BU-18 A SWITCHED POWER 1
N961-GR26 OR-18 N976-GR33 PU-18 8 B
N967-GR32 GY-18 9 YL-18 C CAN HIGH
N979-GR31 GN-18 10 GN-18 D CAN LOW
L870-GR30 YL-18 11 AWAKE YL-18 YL-18 E AWAKE
L871-GR29 BU-18 12 AWAKE GND BK-18 BK-18 F GND
L854-GR28 YL-18 13 CAN0 H YL-18
L855-GR27 GN-18 14 CAN0 L GN-18
200-GR38 BK-14 H899-GR103 OR-18 15
200-GR93 BK-14 L861-GR13 PK-18 N961-GR26 OR-18 16
200-GR99 BK-14 N958-GR25 PK-18 17
892-GR22 BR-18 N980-GR24 GN-18 18
893-GR23 GN-18 NOTE F 19
F N963-GR5 OR-14 20 CONN 49 F
N963-GR42 OR-18 893-GR23 GN-18 21
N963-GR19 OR-18 892-GR22 BR-18 22
L856-GR21 YL-18 23
L857-GR20 GN-18 24
N959-GR18 PK-18 25
N959-GR41 PK-18 N963-GR19 OR-18 26
N959-GR4 PK-18 N959-GR18 PK-18 27
H899-GR103 OR-18 N981-GR17 GN-18 28
L860-GR16 YL-18 29 SWITCH 0 YL-18
L860-GR14 YL-18 L861-GR13 PK-18 30 SWITCH 1 PK-18
31 CB-C3

GRADE CONTROL ATTACHMENT

L860-GR16 YL-18 32 2269261
L860-GR98 YL-18 33
L862-GR12 PU-18 34 PK-18 A SWITCH 1
L862-GR12 PU-18 35 SWITCH 2 PU-18 PU-18 B SWITCH 2
L863-GR11 BU-16 L863-GR11 BU-16 36 SWITCH 3 BU-18 BU-18 C SWITCH 3
L864-GR10 GY-18 37 SWITCH 4 GY-18 GY-18 D SWITCH 4
L864-GR10 GY-18 38 YL-18 E SWITCH 0
L865-GR9 GN-18 39 PK-18 F SWITCH GND
L865-GR9 GN-18 L866-GR15 PK-18 40 SWITCH GND PK-18

L866-GR97 PK-18
L866-GR15 PK-18 GR-C10
L866-GR8 PK-18 1552264
L870-GR30 YL-18 L860-GR14 YL-18 1 BLADE CONT-SWITCH 0
GRADE CONTROL ATTACHMENT

L871-GR29 BU-18 L861-GR13 PK-18 2 BLADE CONT-SWITCH 1

L862-GR12 PU-18 3 BLADE CONT-SWITCH 2
L873-GR74 GY-14 L863-GR11 BU-16 4 BLADE CONT-SWITCH 3
L874-GR86 OR-14 L864-GR10 GY-18 5 BLADE CONT-SWITCH 4
L865-GR9 GN-18 6 BLADE CONT-SWITCH 5
N960-GR35 OR-18 7 UNUSED
L866-GR8 PK-18 8 BLADE CONT-SWITCH GND
TOGGLE SWITCH (AUTO/MANUAL)
E N976-GR33 PU-18
NOTE F 226-9254 E

N979-GR31 GN-18 GR-C11 GR-C11A

N980-GR24 GN-18 1552264 3E3388
L872-GR7 BU-14 1
N981-GR3 GN-18 T744-GR6 WH-14 2
N981-GR40 GN-18 N963-GR5 OR-14 3 NOTE M
N981-GR17 GN-18 N959-GR4 PK-18 4
NOTE F NOTE F N981-GR3 GN-18 5 CONN 50
T745-GR73 YL-14 L854-GR2 YL-18 6 NOTE F
L855-GR1 GN-18 7
T748-GR85 PK-14 NOTE F 8

GR-C12 GF-C2 GF-C1 GH-C1

1552264 3E3388 1552264 3E3388
L854-GR81 YL-18 1 L854-GF1 YL-18 L854-GF15 YL-18 1 L854-GH43 YL-18
L855-GR82 GN-18 2 L855-GF2 GN-18 L855-GF16 GN-18 2 L855-GH42 GN-18
L856-GR76 YL-18 3 L856-GF4 YL-18 L856-GF4 YL-18 3 L856-GH4 YL-18
L857-GR75 GN-18 4 L857-GF5 GN-18 L857-GF5 GN-18 4 L857-GH3 GN-18
L873-GR74 GY-14 5 L873-GF6 GY-14 L854-GF1 YL-18 L854-GF15 YL-18 L873-GF6 GY-14 5 L873-GH6 GY-14
T745-GR73 YL-14 6 T745-GF7 YL-14 L854-GF12 YL-18 T745-GF7 YL-14 6 T745-GH5 YL-14
L872-GR72 BU-14 7 L872-GF3 BU-14 L872-GF8 BU-14 7 L872-GH40 BU-14
T744-GR71 WH-14 8 T744-GF10 WH-14 T744-GF9 WH-14 8 T744-GH41 WH-14
SYMBOLS
L855-GF11 GN-18 L855-GF16 GN-18
CONN 45 L855-GF2 GN-18 L854-GF15 YL-18 CONN 51
ABBREV COLOR
L855-GF16 GN-18
L856-GF4 YL-18 L856-GF4 YL-18
L857-GF5 GN-18
RD RED
L857-GF5 GN-18 WH WHITE
OR ORANGE
L872-GF8 BU-14 YL YELLOW
L873-GF6 GY-14 PK PINK
L872-GF3 BU-14 L872-GF8 BU-14 T744-GF9 WH-14 NOTE F BK BLACK
L872-GF14 BU-14 T745-GF7 YL-14
D GH-C2 GH-C2A
GY GRAY D
PU PURPLE
L873-GF6 GY-14 L854-GH43 YL-18 1552252 3E5179
BR BROWN
L855-GH42 GN-18 L872-GH32 BU-14 1 GN GREEN
L856-GH4 YL-18 T744-GH31 WH-14 2 BU BLUE
RENR7853-00 VOL. 2

L857-GH3 GN-18 3
L854-GH30 YL-18 4
SYMBOL DESCRIPTION
T744-GF10 WH-14 T744-GF9 WH-14 L855-GH29 GN-18 5
T744-GF13 WH-14 L872-GH40 BU-14 6 NOTE M
L873-GH6 GY-14 7 BLADE, SPADE, RING,
NOTE F T745-GF7 YL-14 T744-GH41 WH-14 L857-GH28 GN-18 8 OR SCREW TERMINAL
T745-GH5 YL-14 L856-GH27 YL-18 9
10 CIRCUIT CONNECTED
T745-GH26 YL-14 11
GF-C3A GF-C3 L873-GH25 GY-14 12
1046871 6D8149 CIRCUIT NOT CONNECTED
A L872-GF14 BU-14
CONN 52
NOTE F ELECTRICAL CONNECTION
B
TO MACHINE STRUCTURE
C L854-GF12 YL-18
D L855-GF11 GN-18 GH-C3
NOTE M 1740502 INTERNAL ELECTRICAL
E
CONNECTION TO SURFACE
F T744-GF13 WH-14 L854-GH24 YL-18 A TERM RESIST 1 OF COMPONENT
G L855-GH23 GN-18 B 1342540
H C
CONNECTOR
I
J
ATCH WIRE, CABLE,
CONN 44 NOTE F
NOTE F
COMPONENT
Distance between the
20 Page, Color 2, REM

connector and the CAN CIRCUIT GROUPING

H#
splices not to exceed DESIGNATION
L854-GH43 YL-18
150mm
L854-GH39 YL-18
SPLICE
L854-GH47 YL-18

L854-GH14 YL-18 GH-C4

C L854-GH19 YL-18 1740502 C
L856-GH22 YL-18 A TERM RESIST 2
L857-GH21 GN-18 B 1342540
L854-GH24 YL-18 C
L854-GH30 YL-18
NOTE F
L855-GH42 GN-18
L855-GH34 GN-18
L855-GH48 GN-18 GH-C5 LH-C1
1552252 3E5179
L855-GH13 GN-18 L872-GH16 BU-14 1 L872-LH1 BU-14
T744-GH15 WH-14 2 T744-LH2 WH-14 THIS SCHEMATIC IS FOR THE D3G-D5G
L855-GH20 GN-18 3
L855-GH23 GN-18 L854-GH14 YL-18 4 L854-LH3 YL-18 178-3984 CHG 02
L855-GH29 GN-18 L855-GH13 GN-18 5 L855-LH4 GN-18
NOTE F COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE
6 T744-LH5 WH-14
MACHINE WITH THE KEY AND ENGINE OFF, XMSN
L856-GH4 YL-18 7 T744-LH6 WH-14 SHIFTER IN NEUTRAL,AND PARK BRAKE IN THE OFF POSITION.
L856-GH36 YL-18 L857-GH12 GN-18 8 L857-LH7 GN-18
L856-GH51 YL-18 L856-GH11 YL-18 9 L856-LH8 YL-18
RH COILED CABLE 10 WIRE RH-C2 RH-C1 GH-C6 10 SH1 F-3 NOTE A: SWITCH SHOWN AT OPERATING TEMPERATURE
231-0049 2302566 1907612 1552253 L856-GH11 YL-18 T745-GH10 YL-14 11 T745-LH9 YL-14 SWITCH WILL CLOSE WHEN THE TEMPERATURE
PWR A RD-14 A L872-RH1 BU-14 L872-RH1 BU-14 1 L872-GH45 BU-14 L873-GH9 GY-14 12 L873-LH10 GY-14 IS LESS THAN 45 DEGREES F
NO TERM REQ B BU-20 B T744-RH5 WH-14 T744-RH2 WH-14 2 T744-GH46 WH-14 L856-GH7 YL-18
CAN H C GN-20 C L854-RH3 YL-18 3 L856-GH27 YL-18 CONN 53 SH1 VARIOUS NOTE C: ASSEMBLE TERMINALS TO STUD
CAN L D WH-20 D L855-RH4 GN-18 L854-RH3 YL-18 4 L854-GH47 YL-18 L856-GH22 YL-18
PWR ON REQ E BR-20 E T744-RH6 WH-14 L855-RH4 GN-18 5 L855-GH48 GN-18 SH1 F-1 NOTE E: NORMALLY OPEN BEFORE REFRIGERANT CHARGE
PWR GND F BK-14 F T744-RH2 WH-14 T744-RH5 WH-14 6 T744-GH49 WH-14
PWR GND G GY-14 G T745-RH9 YL-14 T744-RH6 WH-14 7 L857-GH3 GN-18 SH1, 2 VARIOUS NOTE F: WIRE PAIRS ARE TO BE TWISTED TOGETHER AT LEAST
PWR H OR-14 H L873-RH10 GY-14 L857-RH7 GN-18 8 L857-GH50 GN-18 L857-GH35 GN-18 ONE TURN PER 25 mm
NC I I L856-RH8 YL-18 L856-RH8 YL-18 9 L856-GH51 YL-18 L857-GH50 GN-18
ELECTRIC MAST (RIGHT HAND) NC J J L857-RH7 GN-18 10 SH1 A-12 NOTE H: EROPS LIGHTING HARNESS IS OMITTED WHEN MACHINE IS
226-2333 T745-RH9 YL-14 11 T745-GH2 YL-14 EQUIPPED WITH SWEEPS ATTACHMENT
CONN 55 L873-RH10 GY-14 12 L873-GH1 GY-14 L857-GH12 GN-18
SH1 C-5 NOTE J: THIS A SIMPLIFIED SCHEMATIC SYMBOL FOR GENERAL
L857-GH18 GN-18
B CONN 43 REFERENCE OF PART FUNCTIONALITY
B
PWR A RD-20 A PWR (+)
NO TERM REQ B B TERMINATION CONT SH1 B-14 NOTE K: LH AND RH HARNESSES REQUIRE INSERTION OF SOCKETS INTO
BU-20 L857-GH21 GN-18
CAN H C C CAN HIGH PLUG AS. CONNECTORS PER SCHEMATIC AFTER ASSEMBLY INTO
GN-20 L857-GH28 GN-18
DOORS.
CAN L D WH-20 D CAN LOW
PWR ON REQ E BR-20 E PWR CONT L872-GH40 BU-14 SH1 VARIOUS NOTE L: REMOVE SPECIFIED CONNECTOR CAP TO ADD APPROPRIATE
PWR GND F BK-20 F PWR (-) L872-GH17 BU-14 ATTACHMENT.
RH COILED CABLE 6 WIRE RH LASER RECEIVER L872-GH45 BU-14
226-9270 226-2334 LH-C2
COILED CABLE 10 WIRE LH 230-2566 SH2 VARIOUS NOTE M: FOR FUTURE USE.
L872-GH32 BU-14 231-0049
PWR A RD-14 A L872-LH1 BU-14 SH2, H-9 NOTE N: FOR SERVICE REPAIR OF CONN GR-C2 OR GR-C3 CUT WIRES TO
NO TERM REQ B BU-20 B T744-LH2 WH-14 TERMINATE WIRES WITH SOCKETS PROVIDED IN SERVICE REPAIR
L872-GH16 BU-14 CAN H C GN-20 C L854-LH3 YL-18 ASSEMBLE TERMINATED WIRES INTO DT PLUG AS.
CAN L D WH-20 D L855-LH4 GN-18 CONNECT DT PLUG AS. TO SERVICE REPAIR HARNESS
L873-GH9 GY-14 PWR ON REQ E BR-20 E T744-LH5 WH-14 CONNECT SERVICE REPAIR HARNESS TO POWER SUPPLY MODULE.
L873-GH25 GY-14 PWR GND F BK-14 F T744-LH6 WH-14
L873-GH38 GY-14 PWR GND G GY-14 G T745-LH9 YL-14
L873-GH1 GY-14 PWR H OR-14 H L873-LH10 GY-14
NC I I L856-LH8 YL-18
NC J J L857-LH7 GN-18
ELECTRIC MAST (LEFT HAND)
L873-GH6 GY-14 226-2333
T744-GH15 WH-14 CONN 54
T744-GH31 WH-14
T744-GH33 WH-14 WIRE GROUP COLOR DESCRIPTIONS
PWR A RD-20 A PWR (+)
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.
NO TERM REQ B BU-20 B TERMINATION CONT HARNESS ASSEMBLIES
CAN H C GN-20 C CAN HIGH WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.
CAN L D D CAN LOW IDENT PART NO. CHG LOC DESCRIPTION NOTE
WH-20 STARTING CIRCUIT.
T744-GH41 WH-14 PWR ON REQ E BR-20 E PWR CONT GF 227-3036 00 SH2 D-6 GRADE CONTROL FRONT ATCH
T744-GH44 WH-14 PWR GND F BK-20 F PWR (-) GROUND CIRCUIT.
GV 210-6216 02 SH2 G-10 GRADE CONTROL VALVE ATCH
T744-GH49 WH-14 COILED CABLE 6 WIRE LH LASER RECEIVER LH STARTING AID CIRCUIT.
GH 210-6210 02 SH2 C-6 GRADE CONTROL HOOD ATCH
T744-GH46 WH-14 226-9270 226-2334
GC 227-3039 00 SH2 G-9 GRADE CONTROL CASE ATCH MACHINE ECM CIRCUIT
T745-GH5 YL-14
T745-GH37 YL-14 GR 227-3035 00 SH2 E-6 GRADE CONTROL REAR ATCH MACHINE SECURITY CONTROL CIRCUIT.
A T745-GH2 YL-14 BLADE CONTROL CIRCUIT.
A
LH 227-3037 01 SH2 B-5 GRADE CONTROL LEFT BULKHEAD ATCH
T745-GH10 YL-14 RH 210-6211 01 SH2 B-9 GRADE CONTROL RIGHT BULKHEAD ATCH HEATER AND AIR CONDITIONER CIRCUIT.
T745-GH26 YL-14 GA 210-6214 00 SH2 H-12 SRV ADAPTER INPUT PM400 ATCH TURN SIGNAL/WIPER/WASHER CIRCUIT.
GJ 210-6215 00 SH2 I-12 SRV ADAPTER OUTPUT PM400 ATCH

GRADE CONTROL ATTACHMENT

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1