June TO SERVICE MANUAL 4-CHANNEL RECEIVER SANSUI ORX-7001 Sansui. SANSUI ELECTRIC CO., LTD.701 This service manual is designed for service engineers to repair, adjust, maintain and order the replacement parts of the QRX-7001 correctly. When @rdering the parts, use the stock number and parts name specific- ally referring to the Parts Locations & Parts Lists For gesleral usage and maintenance of the ut , please refer to the Operating Instructions attached with the unit. TABLE OF CONTENTS Section Title 1, SPECIFICATIONS 2. BLOCK DIAGRAM. 3. ALIGNMENTS AND ADJUSTMENTS 341, Driver Circuit Boart! Adjustment 3-2. FMIF Alignment 3-3. FM Dial Calibration and RF Alignment 3-4, FM Signal Meter, Mono Distortion and Page Mating Adjustment. 7.8 355. MPX Alignment 8 36 AMF, Dial Calibration, RF and Signal Metet Alignment 9,10 4. THREADING OF DIAL CORD rt 5. TROUBLESHOOTING CHART az 5:1, Troubleshooting of Power Supply Section....12 5-2. Troubleshooting of Main Circuit Section ....12 5-3. Troubleshooting on Tone Control Circuit Section --.cseseesetsesseserereen ceed. 5:4, Troubleshooting o& Phono Circuit Section....12 5, Troubleshooting om Tuner Circuit Section ....13 PARTS LOCATION AND PARTS LIST ........14 6-1. F-1519C FM Frontend Pack cd 6-2, FHIS07C Tuner Cirquit Board 15,16 63.2458 Equalizer Circuit Board... 17 6-4, 2425 Tone Contr6l Circuit Board ay Section Title Page 65. F-2431 Power Supply Circuit Board for Tuner Section 7 6-6, F-2436A Driver Circuit Board 18 67. F-2090 CD-4 Sub Channel Circuit Board .-19, 20 68. F:2086 CO-4 Main Circuit Board. nest 69, F-2087 QS Matrix Circuit Board 21 6-10. F-2088 QS Phase Control Circuit Board... 22 6-11. FAH461A Protector Circuit Board, 22 6-12. F°2427 Power Circuit Board......... 23 6-13, F-2428 Filter & Power Supply Circuit Board . 23 6-14. F-2423 Filter & Switch Circuit Board 23 615. Interchangeability of Transistor and Diode ..24 6-16, Other Parts (Top Side) 24 6-17. Other Parts (Bottom Side) 24 6-18, Other Parts (Front Side) Section 1 25 6519. Other Parts (Front Side) Section 2 .2........26 7. SCHEMATIC DIAGRAM OF TUNER SECTION. 27 8. SCHEMATIC DIAGRAM OF ‘AUDIO SECTION 2a 9. SCHEMATIC DIAGRAM OF 4.CH SECTION ..29 10. SCHENATIC DIAGRAM OF POWER SUPPLY ‘SECTION 30 11, PACKING LIST back cover 12, ACCESSORY PARTS LIST back cover1, SPECIFICATIONS AUDIO SECTION CONTINUOUS RMS POWER OUTPUT 35W per channel x4 (four channels driven) 80 LOAD IMPEDANCE « POWER BAND... TOTAL HARMONIC DIST Music powerHP).. 260W (401,000) ow\ga 100K) aw ul 000%) {2022 Gwo channel riven, aa hoor INTERMODULATION DISTORTION (at rated power out- ‘put 70Hz:7,000H2—4!1 SMPTE method) eee «less than 0.4% (from AUX) FREQUENCY RESPONSE (dt 7 Watt output) 115 to 30,000H2 +148 RIAA curve) Continuous rms power outa} EQUALIZATION. 30 to 15,000Hz 1B DAMPING FACTOR . 10 (6) INPUT SENSITIVITY At EDANCE (1,000Hz, for rated output) 2-CHANNEL PHONO... ..2.5mV 50KA (max. input capability; more than 150mV ‘at 05% distortion) ACH/2-CH. AUX «|. -.100mV 50KA 4-CH./2-CH. TAPE-1 PLAY Pin Jacks. 100m S0KQ REC/PLAY DIN Socke} ..100mV 50KQ. 4-CH/2-CH, TAPE-2 PLAY Pin jacks «-..4...100mV SOKO, RECORDING OUTPUT ACH 2-CH. TAPE REC Pin Jacks 100mV REC/PLAY DIN Socke| --30mV 4-CH)2-CH. TAPE-2 REC Pin Jacks ......J...100mv CHANNEL SEPARATION (ft 1,000Hz) 2sCH. PHONO ‘better than S0d8 4-CH/2-CH, AUX = better than 50d8 HUM AND NOISE (IHF) 2-CH. PHONO better than 7048, 4-CH/2-CH. AUX SWITCHES AND CONTRGLS BASS . TREBLE LOUDNESS: better than 8008 11048, —70dB, at SOHz +10dB, —1048, at 10,000Hz +848 at SOHZ +348 at 10,000H2 FILTERS. LOW (front & back) HIGH (front & back) =10d8 at SOHz (6dB/act.) —1048 at 10,0002 (6dB/oct.) QS SYNTHESIZER/DECOTER se : +-QS regular matrix system with QS Vario-Matrix circuit (CD-4 DEMODULATOR 25mV (1 to 10mV adjustable) Input Impedance . Separation (standar aK signal at 1,000Hz) “agg 10M) eft to Right «+++ Front to Back .......+..25dB Frequency Response standard test signal at REC output) 30 to 15,000Hz (main-channel) TUNER SECTION TUNING RANGE. .... SENSITIVITY (IHF) «022. 2.1.92V (max. input capability: more than 120d8) TOTAL HARMONIC DISTORTION. MONO. soevee ale than 0.39% STEREO. sseless than 0.5% SIGNAL TO NOISE RATIO (mono) better than 7008, better then 7048 sles than 1548 better than 75dB 88 to 108MHz SeLECTIVITY - CAPTURE RATIO (IHF) IMAGE REJECTION IF REJECTION. better than 9048 SPURIOUS RESPONSE... better than 8048 STEREO SEPARATION (at 7,000Hz) : better than 4048 FREQUENCY RESPONSE ....30 to 15,000H2 "3 dB FM DEEMPHASIS ..........50,5, 7548 "ANTENNA INPUT IMPEDANCE +3000, Balanced, 7521 Unbalanced TUNING RANGE SENSITIVITY (bar antenna) - 535 to 1,605KHz 53d8/m_ SELECTIVITY. better than 3048 IMAGE REIECTION better than 8048/m IF REJECTION «+++ better than 80d8/m OTHERS ‘SEMICONDUCTORS Transistors +. FETs - Diodes. Zener Diodes Ics... POWER REQUIREMENTS Voltage. +100, 117, 220, 240V 50/60H2 Consumption =-220W (rated) DIMENSIONS . 540mm 2196") W. aeimm (64")H 403mm (15547) D WEIGHT 23.8Kg (525 lbs) net, 26.5 kg (584 Ibs) packed * Design and specications subject to change without notien for Irmprovemente.er QRX-7001 2. BLOCK DI GRAM crore BOCK Trane thse |, [ras] [rae] S208 1 Cra) (rz 1 Pre | Fal te TR ae oy | Bc ER || Sr || ER || ieee | | seo fw FF m4 pfeeom | cat Lo cl} ae at = jp ete { rec cnucoronerreumenfconcnnt ate ee ta 2ec8y ge ' yee re SQ lea trade mark of CBS, INE" 3 ‘S701: SELECTOR part) 2 ATO 22 ton gew mar, oF) ci S01: FUNCTION 2 Searmesce su 5 Semmes MAL og 95.50 ‘6. cbamecr(CD-4/4.CH DIRECT BLOPK DIAGRAM (f Seis, [Tort nr EERE Teron 208 £ Bangsar apowno ia 2 Baromece | an FifaQRX-7001 a SS 3. ALIGNMENTS AND ADJUSTMENTS Abbreviation Equipment Others AM FM Generator Oscillogcope Genescope Clockwise... AM Standard Signal Generptor AM SSG. Counterclockwise . CCW. FM Standard Signal Generpto FM SSG Antenna... fee ee eANT. FM Stereo Generator Stereo SG Modulation .... ~-MOD, Oscilloscope. Scope Audio Oscillator ..- “Audio Ose. Distortion Meter Dist. Meter 3-1. Driver Circuit Board Adjustment (See Figs. 3-1 and 3-2) Note: 1. Master Volume -Minimum 2 Speaker Selector...}...... SYSTEM (A) 3. Make the SP terminfs free (no lose, 4 Confitm the AC por Supply voltage 5. Niter adjustment, rd the unit for more than 5 minutes, then check and readjust necessary 6. Room temperature hould be 18~28° (65~83°F) for bias current adjustment. step) SUBIECT FQUIPMENT | saeASURE OUTPUT) ADjusr | ADJUST FOR CONDITION 1 [DEov Front | Dclvalt meter | Speaker terminal | F206 _ | OV 2 tmV “Step down meter’ range Cer Front L-cH Vaan accordingly Fig 34 Fig. 3-2 *Change lead’s polarity if eter swings backward 2 | covFront | Dclvott meter | Speaker terminal | F-2406_ | ov 10mv same as above RCH Front &-cH Vage Oy fest rpse 3 |DcovRea | oclvott meter | Speaker terminal | 2436 | ov 10mV Same a8 above LeH Rea cH Ron Feat fig. 32 4 | pcovRear | Ddlvolt meter | Speaker serminal | Fas | ov 10mv same as above RCH Rear ec ‘vao2 fg ot Fig d2 S| Biascurrent | oq milliammeter | £-2427 £2436, | 30 £3ma same as above Front L-CH For vege 04 Fig32 Figs 6 | Biascurrent | Dmniliammeter | F-2427 F-2096 | 30 3mA Same as above Front RCH fa Vaow 0: Fig a2 Figo 7 | Biss current | DG milliammeter | F-2427 £2006 | 30 =3ma Same as above Rear UCH fos. ads Fig 32 Fig 32 8 | Biaseurrent | Dg milliammeter | F-2427 2996 | 30 3ma Same as above Rear RCH Fos Ros Fig 32 ig 32 Fig. 34 SPEAKER TERMINAL PMP N (Eo EOC + volt meter ® - volt meter)Fig. 22 F:2436 Driver Circuit (Rear) O Doz OO} [O 2427 ZZ LLL LLL Ll R03) vRO1 vvRo2\ fiers - 4 sayy. 3 am uy Ss", vros\ LLL Se oS ius 3-2, FM IF Alignnfent (See Figs. 3-6, 3-7 and 3-9 on page 10) ¥-2436 Oriver Circuit(Front) Note: 1. Selector. -sFM MONO. 6. Connection « +-Connect the output of 2. Master Volume cess eMinimum genescope t0 TP.01 through 100pF ceramic cap 3. Output level of genkescope ......After attenuator 4. Sweepwidth. . Ss 1S\2em/150KH2 5. Frequency band + SSS115MHe ene score DETECTOR PROBE BLOCK Oo * SI pom our] See, 2 yore FEED SIGNAL MEASURE ster | susject > +o MEASURE | ApjusT | ADJUST FOR CONDITION 1 | iFcoll | Outpdt 658 F519 1507 Fsi9 | Max. IF wave- Genescope Trot Por Los form 1 a8 Fig. 3-8 Use Detector Fig. 3-6 Probe 2 | Detcriminar| ured 7088 Same as | F-1507 F-1507 | Max. linearity tor coil Genesope above TP.03 Tor of S curve Direct from Set the center Genescope | TO2 ciScuveroor waveform 3 35BE cex700 RF Alignment (See Fig. 3-8 on page 10) 1 Calibration and 4 Selector vs «FM MONO 2 Master Volume “Minimum 3. Confirm start pin of Gal pointer before alignment NTVM_ SCOPE FM sg unr oro Ta oO lant REC, y 8 }___ FEED Si MEASURE 7 |e cole Tat ——Jaccoutter [ras | Mex ouput | Set Di on Sone BE Ewravion | Rpuc oss | Minar | RES toe BSE Mooy| Seon | Yi scope mS 2 | sears ie sameas |sameas | 519 | same asabove | eet Dil on tome Bet ation [Hur coge | Soret | 58 es! Bo MoD) mee 3 | Confirm some |Saheasstept | Sameas | same as above conten | a not epeat fom | Senge Stowe Seti | Hes eaten 4 | Confirm Safne as Step 2 Same as | Same as above Confirm «lf not, repeat from Suse Sone SBR ot | ees BS Eieation cr 5 | some ne adh. | sokais Sameas |sameasabove fio | Max ouput Tune FM Ss Ratout sous | Shove lhe, wos Dus Mona Meter JODHz (100% MOD) APES 6 | rooms ne Ad). | sobite Sameas | sSameas above | fst | Same as above | Same as above eiiteue sous | Sone Timmer Rtas OD) Teor on 1683 3-4, FM Signal jeter, Mono Distortion (See Fig. 3-7|on page 10) Note: 1. Selector . 2 Master Volume. and Muting Adjustment FM MONO Minimum FM ss UNIT ae Te TAPE| ov [ANT REC, | P tf 1 DIST. METERa TaD ERAT MEARE ‘nowst | ADWUSTFOR | CONDITION svee] susject inom To ‘ourrur in Nn 1 | Signal Meter | 98M "ANT terminal | Signal Meter | VRO2 ‘A3on meter | oTune FM SSG (Max. 5 (8 Moos | 79 See a ABE stele. adustent if metering gu at cro or see se esate pom 2 | Distortion Same as above ‘Same as REC OUTL | TO2 ‘Min. distortion =Tune FM SSG (Max. in above or Rech ication of signal meter) Bit meter | Oops > |runemeter | sampasatove | same | TUNE nter | vaor | centr on Tune| Tune the Tune Meteo itor fice Gener even a ‘4 | Muting Level | ¢8MHz ‘Same as RECOUTL | VRO4 Audio signal station noise Billing |e” | BRC. ft Ff0% Moo) frit imo Kove 3-5. MPX Alignment (See Fig. 3-7 on page 10) Note: Selector 2 Master volume | srencosa ci vat score Le ee = [este ib oft far BEF 9 0g y Set ABE oos.wereer 2 TEED ERAT Pre vee) sonxer sta] sumer | — aan — 'SARIE | aowsr | aowsrron | conomon 7 oe | ae wat, [iecout [ics [Max oupot | Tupe fi 556 on a ce ed atonal aise Sua” / Raa met Poth Sets Sie slob) Cees eset, fens Moo) secb s 2 |seption |samfarabove | sameas gcc our | vans | ain outut wa Sipe over han 085 3 | Confirm | Samdas abov same as off over than 05% slight- Sateen bre | Boe” | BG OUT Wada Us ESope 4 | conten | gate sme as | pee our “ss thn 00 as Sepwaton | AR Papwoos | BO" | EG vss fot Viva Pt Se ove (10% MOD) Lene oo) Eehfute * (45%|MOD) ‘sc _ Ster7001 3-6. AM IF, Dial C4lidration, RF and Signal Meter Alignmeut (See Figs. 3-4] 3-5, 3-7 and 3-8 on page 10) Selector. 1 2. Master Volume : 3. Confirm start point bf dial pointer before alignment. 4 AM S-Minimum 1. The loop antenna if required to obtain complete adjustment for AM RF circuit. In this case, as the electro-magnetic field is attenuated Hy the distance between the loop antenna and BAR ANT, increase more 26d8 by attenuator of AM 'SSG than each ANT/input level show in the following steps. (See Fig. 33) 5. Alter adjustment of signal meter, confirm the meter’s swing on FM. (If meter swang out oF not enough, reacjust VRO2) (See Page 7,8) Fig. 3-3 round aan anit Peotm ae) AM S36, LOOP ANT out TEED SNAL MEADE [a sient om ser] sumecr aoe Zo WOBAE | sowsr | aowsrroe —conomion 7 | weot | Outer 7048 | oscrnmmer] Tpoe Tor | ax i waves otura core Toba Tos Senfecope” | apc teas™ | Tiga) fommastiga CEN! Fig. 3-8 | 2; oot | ungur sods Same as | trot vem — | sax te wayes | otf not readjust 1&2 Senficope | Sve form dies | Sdhgly 3 | 535kHr S35kHz_ ANT terminal | REC OUTL | TO3 Max. output | olf broadcasting station Baal Shite | AN fut cous ee iSean mig be used fon Rosa SD) Siva | AM so Scope a | swe ete Sameas Same as | Trimmer | Same as above | _ same a shove Bint) Weingut cogs | Bove” Soe | Fa on ‘oon ease No) Prd it 5 | coniem — | sips sameas | sameas Gontim | olf not, repeat from SNe | RePour cous | Sore" | Se SR | Step BiatCaio- | Sfete'MiGoy Gitta ton BSS 6 | Contim — | “vodote sameas | ssmeas Contim | olf not, repeat from Fea | Mp cous | Soe | Sone SOMME ow | Steps Sua Cala- | Soo Moo) ition fon mee 7 | confiem — | ‘ott Same as | same as Confirm | olfnotrepeattromstep Some | ANP npur cous | $800" — | $S0ve Gomi oat | 8 Barer | SolatBih MSO Eiibation ton ATES 0 | sonktes | ote same as | Same as | garant | Max output trade — | Nf Input sous | ove” — | Bove” — | Bar ‘Soputbo% MoD) Eg 9 | saoctte Ne Sameas [Same ae | Trimmer | same as above a Tneusois | sbow'* | bove"” | Fe ‘ool ox Mo) ing Ser[| {_ 9) @ i 2 © @), fo Z|701 4, THREADING OF DIAL CORD 4. Threading of Dial Cqrd Thread dial cord in elumerical order from 1 to 11 as @To strengthen the dial cord tension, hold around shown in Fig. 3+. the end of cord and pull it toward the Front 1) Close the variable fapacitor completely (Max. ca- Panel pacitance) and tie cord to number ® screw of the @Then, turn tuning shaft counterclockwise, a6 the dial pulley. cord tension will be more constantly obtained 2) Thread cord in-the Hlirection of arrow from 1 to & @Tie the cord to dial spring of the dial pulley (same then wind cord three turns around the tuning shaft as procedure 4). counterclockwise. 5) Alter procedures, lock the knots of cord with paint. 3) Thread cord Inthe flrection of artow from 7 t0 8 then wind it 1}4 turps on the dial pulley from to 11. Description 4) After 11 te cord to fal spring of the dial pulley ‘When you perfofm procedure 4) successtlly, 5036050 Dial Cord (0.6mme) please refer to thelfollowings. 906041 Spring (@) "5. TROUBLESHOOTING CHART 5-1. Troubleshoot Symptom 4. Each lamp not lighted ———_———_—_—. 2. Each indicator lamp not lighted 5-2. Troubleshoo} 1. Both channels in: 1-1. +37V Supplied to te ting on Power Supply Section ‘Check Point 2. One channel inoperative 2-1, Quick acting fuse on [—1) DC bias Cu 3. Quick acting fuse on F-2427 not opens 5-3. Troubleshoo| 1. Both channels in 1-1. +38V not supplied t 2. One channel ino} 2-1, Reverse two lead wir terminals of [05] and 1) Inoperative L__2) inoperative 5-4. Troubleshoo 1, Both channels in 41. +36V not supplied t 2. One channel ino| 2-1. Reverse two lead wir} terminal of [04] and [—1) Inoperative| {1 inoperative 2) DC bias cur} 2 [—s. L_« 5. Lie ing on Main Circuit Section erative rrinal (13), [06] on F436 — —s Lo 2427 opens rent not adjustable 40. re —n Lon ent adjustable 13, 44 perative emitter of TROT on F-2428 1 erative nnections from the output ‘on F-2425, hhannel reverses: hannel not reverses 3, fing on Phono Circuit Section perative terminals of [G5], [G6] on F-24881 perative connections from the input [07] on F-2458 Khannel reverses ——_______», 3. channel not reverses Cause & What to Do Imperfect contact of power supply plug Power fuse, F701 opens . Defective power switch, $11 {. FOS on F-2456 opens Defective diode, D06 on F-2427 Defective FUNCTION switch, $01 (i j) Defective Relay, $01 (a, b) on F-1461 |. Defective TROT, TRO2 on F-1461 FO6 on F-2456 opens Defective Power transistor, TR701, TR705 (TR702, TR706) Defective TR11, TR13 (TR12, TR14) on F-2436 Defective TROT (TROB) on F-2436 Change quick acting fuse Defective TRO1, TRO3, TROS, TRO (TRO2, ‘TRO4, TROG, TRI0) on F-2436 ing on Tone Control Circuit Section Defective TRO1~TRO3 on F-2428 2. Defective main circuit section Defective TRO1, TROS, TRO (TRO2, TRO6, TR10) on F-2425 Defective power supply section Imperfect contact of turntable output cord Defective turntable Defective TROT, TRO3, TROS (TRO2, TRO4, TRO6) on F-2458Cause & What to Do Defective TRO1 on F-2431 . Defective ZD01 on F-2431 Defective ICOS on F-1507 Defective LP. on F-1507 2. FM inoperative 2-1, 412V not supplied tp terminal of IZ] on F-15075. Defective C03, 04, C07, C11, C15 on F1507 2:2. +12V not supplied tp terminal on F-1507 6. Defective frontend pack, F-1519 2-3. +12V supplied to te{minals of on F-1507 |) Signal meter inoperative 7, Incorrect adjustment of frontend pack, F-1516 (Meter circhit on F-1507 is normally operative) | —8. Defective frontend pack, F-1519 | —2. Defective TRO1~TRO4 on F-1507 L40. Defective CFO1, CFO2 on F-1507 {_2) Signal metfr operative —————_—1. Defective IC01~1C03 on F-1507 [—12. Defective diode, 001, DO2 on F-1507 43, Defective discriminator coil, TO1, 702, or out of adjustment 3. Inoperative MPX circuit 3-1. FM reception inopefative when setting SELECTOR switch——'4. Poor sensitivity due to incorrect tracking IF to FM AOUT adjustment L145, incorrect adjustment of muting volume, VRO4 3-2, FM muting function inoperative 16, Defective Selector, $701 (f) L_47. Defective muting volume, VRO4 3-3, MPX signal including R and L-ch not supplied to points: 48. Defective ICO4 on F-1507 fa, 34, No channe separatlon and stereo indicator not lighted ——-—19. Defective 105, LCIN on 4507 or out of adjustment [—20. Defective separation volume, VRO3 [—21. Incorrect adjustment of muting volume, VRO4 [—22. Defective muting volume, VRO# (23. Defective Selector, $701 (g) [—24. Defective 1C05 on F-1507 |25. Defective TRO2 on F-2431 ‘26. Defective stereo indicator, PL701 4. Signal meter cifcuit inoperative 4-1. FM or AM sound dan be heard 27. Defective transistor, TRO5 TRO6 on F-1507 —28. Defective diode, D03~D07 on F-1507 |29. Defective meter volume, VRO2 or out of adjustment ‘20, Defective signal meter 5. AM inoperativ] 5-1. Signal meter operttive 3, shorted transistor, TRO9 on F-1507 (AM sound can ngt be herad) [—22. Defective 1C05 on F-1507 ‘33, Defective low pass filter, LPFOT:on F-1507 5-2, Signal meter inopprative 34, Defective 106 on F-1507 (AM sound can ngt be heard) (35. Bar antenna coil, L701 opened or out of adjustment ‘36. Opened OSC ceil 103, IF coil TO4 or LCO2 on F-15076. PARTS LOCATION AND PARTS LIST 6-1. F-1519C FM Conductor ‘rontend Pack (stock No. 7510650 Complete Circuit Board F-1519C) Porition —-~ParkaNo._ Stock No, Deserletion Paitin he sess cp (4m) a Cia 6601211 209F a TRea —0305790,1 2scspo(c,0)} Wmsor—g Cu 0657223 0.0724 a ie 0660931 a06F a FETor —ox70131,295K9p (LK) FT . 0659018 22008F 5 Cia 0557223 072 a or 200640 aM ANT Colt, 5 Civ 0569250 NSF FOV cs A ex 4210220 RL Call ° Cm ossriaz —10009F a tea ator Call A Cx 69369 a Lo a290110 choth Cot a Cn ossraa3 * les k235910 Fico 4 Cm oseva2i a les 4220430 ra cB Cat A Cu 0467203 2200068 5 Tou 1290090 Tung Copector A Roost. MAW CREEL) 8 fon 113106 1etKA 8 Vetta ave Cpctr — te thatoe ten} HSE orosion —YooacssKant. 8) 8 cn oun ah : tm Goon — antseanco) MW C% Goa 06s7i02 sober . fos nesta? aD A Ce ass ooze Seay ce. fos 1061231} MW CR a Co sents ‘azar ‘ Ror 01092 ak. a Cos 08685s ther . foo 0113121 TOD vy gy 5 Cos 06 79023-——0.3PpF_ $00V. Gimmick. C. Rew 0113271 zog} “” * a Cor 0465345 afr a Rio o104s92 aka. a Cou 0sesz10 the a Ry otosi2 208, a Coo 0687102 100g a Rn oraessa in Siw a a Gio 0661720 ep ev CC a Ris oloezea 2k. a Cn 0669003 afee a Ru 10618218. a Ce _(06s7228 wel ; ms oso YW Sa . 14CRETE ORX-7001 6-2. F-1507C Tundr Circuit Board (stock no. 7521000 Complete Circuit Board F-1507C) Parts List ParteNo, Stock, Doseripton Position PartNo, Stock Wo, Description TRor—_0306112.3. 25C7qp (C.0) 1A Co 0s12100—«topF Mav EC. 10 TRea 030611213. 25074 (C'0) 1A Cn ostaa79 a7 25 .C. 10 TRos —0306112,3. 25C748 (C:D) 18 Ca 0660101 100pF ie Hee gaa. 25crf (60) 7 rem Ca gesransoontat 1. es 0906112,3. 25748 CC.) TRos 0306112,3 28C748 (C.D) & cearzza a.aipf a Thor 0308731.2 28¢7{1 (7) a wen ze R " cu 0687223 mH ay ce 1 Ic oneoi29—_prcshsi Cv 0661330 pF 7 1.20 em 0340120 prcspsi Cu a6sia70 ae 2 Ices oneoi20prcsbsa |, Co c4s7220 nang 28 teow esusogo ai tbo cesar ek 2 Cu ces7a23 camp 28 Cos o2601s0 HATIST cu 0812100 Oy 16V EC. 28 Do ostt060—aNhor ce nwa 08H oy co 28 De asti060 Nhe ou 0457229 ocamp 7 1 De asian Cs asisaay—a2yt SOV EC. 10 Du amass Neo Sa Go si201—T00mF tev EC. 1D Dee ganas No Gu 0429001 6t009F SOV F.C. 20 Bo cosy Ses 7H sey gc, 2 Do garosoy Neo a asia? (A 10 cease or be 20 Te) fete 1c Ca osision apt] SY EC 1 Teo 4238760, {eriminator 1 Co 0600187 O.01SuF Sov MAC. 2c Ta 4220550 Aupsc con an Cu 0600157 aisyt 1c Tod 0910270 Cergmie iter 12a Co Moose oboe. ro mac. a or 4900200 10H indctor Cot 13 Cus 0600685 0048p ie lex 4900200 Yop Inductor Cal 1B.c Co 0si2i01 100 vay ee 16,0 ss 4900200° 104 Idector Cot ie CS Saco tgteh ney ee. tc Lee 4900100 3.34) Inductor Cott 1 Cu osisioe te 28 Los 4240720 19HIE MPK Coll 20 Cs 0818339 «tat ie ler Aaw0011 asf Peaking Co 2A ce ONS Haw ec. ae ‘LCor 4240710 MP Coil Block + 2.0 co 0515109 Jae ac Lc 4230620 AMF col 1aA8 Cu osizi00 tor 16, 26 Co osis102. aur SOv@INJEC. IC LPFoy 0910210 Low Poss Filer Naec Co 0601686 —0.0068uF SOV MC. 1c fom 0710150 Cobmie 1A Co 0819102 aur SOV@INJEC, IC Eton —ant0iso cof rnee 1A Cea 0601486 o.008ayF SOV MKC. 1c Ca 0420361 606F SOV PC. 2A Yao sstso anny 2 Cs tass2isagr SOV 2A VES Teasure “IAG senvoibie Resistor 36 Cu osizi0n—togk 16 EC. 2A Vow 1038190 roolnis)) Sel vee) 2 co sera seal 2A Ca 0487223 ozzy Sov cx 2A cor 06s7223 0.422 uF iA Cow 0657223 0.022¢F 1.28 Cea cssrez3 ofa A co 0601107 0.01 pe 2A Ceo 687278 aaa 18 cn sotioe ant) SOY 20 Cou 0687223 far 18 cn osisior 1a 2A Cos 0457229 faze 1 Ga obststey aden} SOY EC a Com 0487223 OfzzuF Sov Cc. 18 Gr 0601107 a.01 uF Sov MMC. 2A Cr 0687223 opaaye 18 Gs 0sizi01 tour tev EC. 2A Ce oasrand Ofna 18 0601337 0.033 4 2a Cio casraan ozzy 1 Ge ovoizay “o.onzer on Cn 0687223 obzapF, 1 Co 0st0470 ATH 6 EC. 28 Cx 0657223 ozzy 16 cases e Cia 0687223 opaape 1 Gor 0818109 Tur} SO BC Cu cas7a29— ozzy 1c Cis ossr203 obazat bay og 1c Ru annaist 1800) 1A is 0657223 ozape 1c Res 0173391900 1A Cy 0660101 1006F te Ros onts4s1 aa DW a, 1A Cis 0660101 10¢F 10 Ry onnsiss 18 ry Cir 966010110096 1 Re 0113109 10k. 1A6-3. F-2458 Equalizer Circuif Board (Stok No. BSD Compete Cire Board F248) Conductor Side 6-4. F-2425 Tone Control Conductor Side A I ‘ Conductor Side BRE go 3 gy6-6. F-2436A Drivér Circuit Board (stock No. 7570960 Complete Circuit Board F-24364) Conductor Side Parte, Stook No. Description Position © i Tao. 0306070 2sci}i9® 6) 28 Ths. 0308070 28Ci}19B G. 6) 28 Ld TRes.05 0300381,2 2547463. (2,3) 1.1.24 ne TRer.cs 0308871,2 2SCH}4 (@,C)_[ Teansstor IC. 1A ee Thes.19 o308901.2 asci]2e (23) 11a Bet Tan os084so-2 2s03fs (0.8 1261.28 saa Wa. Stock N crotion TRis.ne o803280-2 258646 (C0. 8 N26.1124 “ Peveripta Daves 09407 05-49) og 18 fw ols? . 4 KW .CR. Dos.o« a540090 —0s-4a0} Pid 18 Raz 010 1.840 Dosses 0340120 VD-42I2- Vorsor 1C.tA as.25 010712412080 Ra. 9107353 2001.02 0315850 EGAPI-OP Zaner Diode = 18 fen ome led VRoi.ce 1088350 4710 {8)) Senivorable Resistor 18 si. 107390390) Rea.ce 1035310 14a} old Type) 1.1 A Ro. 0107332 33k Corea 0519101 yt SOVCRN) EC. 28 Rae owa7isa 1b iw ca, Crs.or 0660470 28 Ros varia) 1800. Gre tees ae} ey ce. 7 Re, ol07i0g 1002 Cores 0590101 toduk av EC. 28 2 1a7ist 1500 Cin.i2osision —toduk_ Sov. Ec. 20.24 Re. 10710010 Cine 0657223 Ozu SOV CC. 1201.24 Bing o1o7iY 160 Cis.t6 9601198 uF SOV. MAC. 28 Rew ora 470 Reo 0107479470 Cire 0640101 tbr Sov Coc 1c.1A Ron tonne anke is Rss 0171100 «10 WR IBC2A8 fue Glonae agin 2 Resist 0138228 0221 BW Ca. ree plaioe aja 8 Ru, o107274 270 HW GR 26.24 fo. o107ees sald bbreviations— Ros.t0 0107223 A MW Ce ER. + Carbon Resistor BPE: 8:-Poln Electrolytic Rn ooo? «ta. Sm. Soi Restate Cooactor Rave 0107s ad Gait. | cer neatnr Eeramle Capacitor Rew oem clay tases Fm + Mica Capeetor Rm 0107332 saha Mc. + lplarcapactor | Pelyatrene Cavacttor E.G. } Electrolytic Capacitor 1 Tantalum CapaeterQRX.7001 6-7. F-2090 CD-4 Sub Channel Circuit Board (stock No. 7650200 Complete Circuit Board F-2090) Parts List 0306090.1 2SC131P @(F,G) Ci 0515109 la 1E.2E o30sore 28192 (F.C) Cas.96 © OS01IS7 —OOISF SOV MAC. 10.20 TRust —0305951-3 28C945(Q.P-x) TRica —0308951-3 25C945(Q.".x) Co7,8 0573688 Os8nF 35. TC. ry Coco 0600150 ansye 2A TRan —0305981-3a5c9}s(@.F. 8) ac Cire 0600686 0.0068 1Al2a TRem —9s05951-3 28C9}5(0."14) Cove os004es 00040HF| oy yy 142K Canes os0020s — O0nayt 1al2a Peto vrs 204.0) veae Goce 0601227 0.022) 1Al2a Fefen.oe osroiso — 23K3}(0) |g, 16.20 Conm 260147600067 VAl2a FETos.0s 0970181 -28K34(C) | 1D.2A Cr.7%2 0512100 Nout eV EC, TAB2A8 FETor,08 0370151 3sK3f(C) TAL2A 73,74 0600127 0.01 2yF 1 tco.ea ossei10 coed 1c Cir 400187 OisyF} Se MC 1.38 Crm c600is7 — oansyrh vee Dov.ea 0nrn140 S247 Ceo 0573338 0syt 1AaA Dev attieo 82079 Cher tease assa lar re. re Dos c¢ 0310400 INa4a Chu 0579398 02ayt 1.28 Doce oa10400 wnaeal | 3, Geese estas af 10v ec. vas Dov.1® 0910400 INO4A Cem 05100 arnt 63 EC than Drie 0310400 1N34A| Gum Rm ml ayy ge 1Co.rco Danser 0310330 NGO Gaus osisio: oop) 28% BC rere Dea 091116015207 Clos 066022) 09H 13 cov tase “amg YS Bo ge gut i ES Mr ce 18 ; Ciu 9813079 a7F 28 EC. 20 Vro.er 1038090 a.2tafs) 1.20 Ciot—0si2390 «Sap 2c Wins iio Ena |seunatmverteiae "Se Hasty wel ce ‘VRo,10 1035150 22kQf8)( (Solid Type) TA2A ‘Coot 0512330 33pF | VRii,i2 103siso 22408) 18.28 Rin 1092520,1 100628). Sen-Vorisblefesior 10.20 Roe 0106108 = leze Lor.c2 4900191 100nH Fer-lndvetor 18.28 fee giasnoe aa eae ves fi Rove o10sia 1h tele LPFioy 0910240 ¥SL-200r6 Low Pox Fil Nee Ror, 10 0106272 BAY AW CR(ELR) 16.26 Hori onto2eo —vseado gp Fos Fier wae Rive o1osaa 80 Riu o10saee ar Co.ca o6orr0s —wa|yt sov me. reze Rosie o1osiee 180402 Coxe 0560509 oF SOY lege Rete 010672 AAD. cue asin |i) oy 1e2e Riv oio7i0e okt Yew Ca. Cones osision fat lee Ram gress) 3300, onto o6etseo ot lee rau ower snabyw cac 1°ss a5, 4e oa, sere ‘pis soyonpuo>6-8. F-2086 CO-4 Main Circuit Board 6-9. F-2087 QS Matrix Circuit Board ‘soctNo. 700 compos Circuit Bond Fat (Sok Na 7 Compete Cu Bond 28 arts Lit Conductor Side ww ce, kw cen kw cxceun6-10. F-2088 QS Ahase Control Circuit Board (stock no. 7650270 Complete Circuit Board F-2008) Conductor Side aa we weno RSS BASE Es Parts List arts No. Stock No, Deseription Position —-—PartaNo, Stock No. Description cor 0360080-1 Harsh 1A ca osisioy a) 1c tee, tno ahr bre 1 Gx Setsto fpr} SOY. 1 Icio 3600100 HDIp9@ 126 Ces 0600867 o.056uF 18 Cos 0400567 0.056 pF 18 Dor oa11140 1524400 128 Co 0600587 Boseut 1s Dex 0311160 ts24fa0 ir Cm aos? aakink te Dis osteo 1524430 1c w 9g00107 0.01 at Diode ie 0600107 ODI aF 1a Du oatites 1824420 1¢ ce gamete ala re Dos oanit40 _s24f20 18 or roe amy cooed Pen 2s Dos oai1140 1524430, 1.28 Go osonzas | onze 28c cu 0600726 0.002278 1c VRot 1035490 18 Cas 0600226 0.0022 y1F 1s Rez 1035490 Resistor 18 Cou 0600226 0.0022 uF 2c Vites 1035490 1¢ cw 0600187 O.018uF 2c VRo4 1035490 ic Ce 0600187 a.) aye 2c Gs osivion 2.2 . 2C Cor 0600106 24 Go osisiog ag] SOV EC.) 3G (9600106 A Coo1 0660101 100pF SOV CC. 069391 2 Cece 0600337 0.0334) gay yy 2A 0620331 a5 Coos 0600337 0.0334} 5 Nc. 2A (9600396 vA Cat 0620471, ‘A70pF SOV PC. 2A 0600396 aa Coos 0600687 = 0.068 #F) 2a 620681 2A Caos 600687 0.068] SOV MC 2a ‘0620681 20 2a 0620681 separ | S°Y PC: 2A ce emer piel Sov PC. 1A 062068) epee 1A Coon 0513330 83 pF) 2c ose 44a 1A av EC. osisa7e 1s Gu 0519390 tu 2c 0513479 a Jat 28 Con 0660151 ‘150pF SOV C.C. 2c telsos iG nm Coz osisto2 22uF SOY EC. (EL. 18 " sc 1 ss AL ce 1A Gos 0513100 «Ta 28 c Osis dae 7 1A Ror 010622422040) 2A 0sisa79 kus 1.28 Rn nora 22010) 28 osisas dae 1h fos 0108684 6800 | yyy 2a 0513330 ‘Shar TA Row 0106684 680k) Ww Ca (ee) 28 ostaax0 dpe 2 Ros o7ssz 330802 240 06006870064) Soy aac. 1A Roe onosaae 3080 28 (0600687 068 “ 8 Ry 0107684 © 58K. AW CR, 2AParteNo. Stock No. Roe Re Rio Ri Rie Ri Ru is Rw Ri Rie or0s6e6 o10sa74 0106274 106334 0106334 106124 106124 0106126 106124 0106334 0106334 106394 104994 0108124 06124 orogi24 ora 107124 o1o7i24 0107563 0107563 107869 107569 0106563 0106563 106474 o10gar4 ‘0106564 0106664 onr3225 0113225 o1t3s5 o1t3iss 106334 0107334 106105 casos 106105 o107i0s o106i04 106104 106104 106104 0106123 0106123 0106159 0106189 106861 106561 0106333 0106333 106224 106682 106882 0106933 o106se2 o1asse2 106683 0106683 106472 0106272 0106223 0106103 0107272 10704 e080, 27040) 27040. 320K, 33080, 120K, 120K 12060, 1200, 33060 33040 39040. 39049 12040 12080 1200 12049 120K 120K 5610. 56K san 5a 5640. ry 470460 4700 6000 e010 22M0 22M0 1a 13MQ 32060 3000. ™a. ™a. ma. ma. 1004 10049 10080, 100k 140 1240 150 15K 5600, 5600, 3320 3310 2209 ea oak 300 680 6a. 480, 4a, ang ana 2240 1040 270 100%. Deserijtion yaw] cr (ELR) } YW, CR. (EAR) yw ce MW ce ELE) My se. yw ce eta) My ce. YY cR(ELa Uw ce Hy cx (eu) UW cr (LR) uw CR 6-11. F-1461A Protector Circuit Board (Stock No, 7592220 Complete Circuit Board F-145¥A) Conductor Side 1 iN ta s is Parts List tA 14 Pantene, Stock No Deseretion “ TRor — 0906132.9° 25C1964 0. 8) acne ® Ro 0306182,3. 28C1344 (7,8), the 1s Dor oa10n40 100-1 Der aatoaeo 002 " Ds oatoana Nea Dov atodoa—_INBeA 1B Dos 310400 Naan | Died™ 18 Bor bat0e00 Nea 1c Dor 0310400 INS4A 1c Die 0310400. INA 1 Lor 4290210 2.5ylH Inductor Coil re boa 4290210 2.54iH Induct 2 iS faponio pt ines 2 te asoato 2p nc 2 2 Ror 11s0101—_MY40054 Ralay ie Gor ostsas0 33yF $0 EC. 8 Ce bsiounh ont av BS 16 Go sision “apn “sv Cu stow ara 1c en Co hac Cu osision “Tn wv are.c. ae co osoti08 oy . Coo ostiog ato 1c Com 0601108 ote (SV MC. 2c Gio econo Oe a Me for orosieo ton KW CR ELD 2c Ros o1T100 02 ac Re O1tTt0D ot, 28.C Ros 0111100 roa ( AW CR 2c Re pritte0 ton 2c aw 0163 2¢ Re 01073 an ze Re 010673 tn Re lows aD 2c be Rn o10ess2 akg / MWR CELA) ze Re ossaa Shy Bo lostaa SL an Ru 0106332 390 a” Ris 0111689 60 Reon 2A Ry o1ni6e9 3a f 4W CR 2A fe obits 2A Riv 010656258. KW CR 2A 2A te Abbroviatlons— 1 Carbon Resistor BP-E.C. Bi-Polar Electrolytic: 26 1 Soh Restor Gxpacor hae Simoni Renuor 6.6. : Cen apache 22 { Motaad stor” Rb. | Sc Cope fetter Oe | Shearecner 28 + Mitr Eopgetor + Pagans capacor * jelectroiie Capacitor TG.EB oxx7001 6-12, £-2427 Power 6-13, F-2426 Filter & Power Supply Circuit Board «ms no. 7210 comple Conductor side fet tonto 6-14. F-2423 Filter & Switch Circuit Board Conductor Si aa6-15. Interchangeability of 6-16. Other Parts (Top Side) Transistor and Diode Parts List ‘ORIGINAL SUBSTITUTES Parts No, Stock Na Desoription Name [use | flame | stookne [Figure Tere 0908830-2 C1111 (R.0.¥) ze ba | cao | 7 Te Hane} Ben 0) 3sc7in 308880 2 Tre 0308880-2 2501111 @.0.9) (4, asc o30s4s0 3 Tres 0908830-2 28ci111 (@.0.¥) ( Monetor ascii | F266 308900 4 Tere 0308830-2 25C1!11 @O.¥) woos | F-2090 0305880 2 TRror 0308830-2 25C1111 (2.0) acre | e200 c00ses0 2 Tres 0305690-228C1111 (8.0.¥) 2sciit | Power os0ses0 3 tru {E2680 Fel te da nse | r1so7 | tha4acvet)} ostoeo1 ‘ 4200680 Bor Antemna (ARS-28A) ts2073 | F2088 | dos5 0311080 ‘ Goa srua 08H yg, too — | eraser | sfi.s.02 | ostovso 7 Crm assv960 10000 res 0859590 10008 IV EC. pt vez] fs ne PTor 4002150 Power Tromfornar p | [2410080 Voltage Saiactor. socket i “wf 2800820 Power Cord It yeh 2426 Protector Creuit Board Wy Ts7e1 0320110 153-85 Thermistor fig. 5 Fis.6 Fig. Ror 0107223 2k. i te tio ban) 4 oe + at ? 6-17. Other Parts (Bottom Side) Parts List + Carbon Resistor ! Solid Resistor Cement Resistor Metallized Film Resistor Mylar Capacitor Elactraifie Capacitor {Mica Capacitor £ Oil Capacitor Parte No, Stock No. Description Lea 4290021 78:3000 FM Balun Cm 0608337 0.033 Gro teasers over} OY Moe Rr o1o7t2? YW CR Rr 171391 «3800 Ro omission Roe —orrisst sso f |W MR Rs o1viget 3900. fon 010724 «220k wn —o1o7 = aoa, Rs orien | MC Rou aro7i0s 100K 0491900,2 7A.(100~1179) ) po ae fy Fron} 0431270,2 44 (220~240y) J Power Fuse 2300060 Fuse Holder CO 2480060 com fuses } ACO 2430040 DIN Connector 2200350 10P Input Terninol 2200400 3P Input Terminal 2210190 Antenna Terminal 2290100 Speaker Terminal 2230080 Ground TerminalTop Side Power Cor 2 Bottom Side Arsonne- 3P Input Terminal 10P input Terminal ‘Speaker Terminal ston A oun — Sy 701 Some . 0701,c0702 702 IN. R701~R714. a 4 R702~R705 MtEERE ow.r00: 6-18. Other Parts (Front Side)6-19, Other Parts (Front Side) Parts List ection 2) Parte No. stock Ne, | Ontorinton feat Bescon 1 si01061bnafy noe Sr, axe 17 S14440 Wa Had Toning Som 0 2 Siolost_ thy Heed Sw, nace 1 640010 teal Fypw toep OV 10008, 3 Stotos! aug Head Screw bas iM STEKO INCATOR 4 Sioioet—Baahy hed Seve, Mace 190400240 Lae Type Lond (HOA), HALL ffssteono en Sheu 20040060 Lend Type ono 1a) SURROUND seaae0 Dal fomer 210480 Lend Type toma 7V 100m) 8 & surat eae 22 400s? Led ype Lona OV 10000 350 7 Siaoad todd Typo Seon, 38 22 0400290 sod Ton ton (6 S0mn), C4 @ Steaua ud Hed Tong Se, 38 2a Saat inact ton 9 Sicsuad Vind Heed Top srw, 38 26 Slonii2_atng hed Tops Screw, 38 10 Stussy 27 Siosin tad eod Tossing Screw 8 1 Sauna 28 S246tld Halder gl nd 12 Smeo,1 2? Mud Dgielinicowe 13 fatooo 30 S10r122 Bing ead Toning Sem, 38 14 Prue 3) Staniat dog Hed Taping Sco 958 15 Geto vefyeLonp 30004) 32 faatead ado, orn Cea Bord 18 Siete Waslereed opting Sow, 98 33 Greet Dut aly (Ou) 267. SCHEMATIC DIAGRAM OF TUNER SECTIONta OILWWSHOS “8 NOILOAS O1GNY 4O WUD!FR oxx.700110. SCHEMATIC DIAGRAM OF POWER SUPPLY SECTION ‘2SCI211(C,0,€) 28C1364(8,6,7) 3011.PACKING LIST 01 HE A Ee RA 12. ACCESSORY PARTS LIST Parte No, Stock Ne. Desc Stock No. Desoription 1 9027831 _Stylofoom Pecking 3820091 FM inrenna 2 9116431 Vinyl Cover (0433630 4A PSOY Quick Acting Fuse a 008170. Corton Case 9208400 Opdrating Instructions 4 5996080 Cur Stopper 9228400 Ondrating Instruction Sheet 9416010 Cols Adjustment Record t es AMINE AAR SANSUI ELECTRIC CO., LTD. LA, 2.chome, zum, Suginam-tu, Tokyo 168, Japan ‘TELEPHONE! (03) 325-11 11/TELEX. 232-2076 ‘SMOaT Printed im Japan (047306)