SAFETY DATA SHEET
TURBOMASTER LD 10W-40
Section 1. Identification
Material name: TURBOMASTER LD 10W-40
Product Code 5530
SDS no. SDS 5530-1
Relevant identified uses of the substance or mixture and uses advised against
Use of the substance/ Automotive engine crankcase lubricant.
mixture For specific application advice see appropriate Technical Data Sheet or consult
our company representative
Manufacturer Petromin Corporation
Supplier P.O.BOX: 1432, Jeddah 21431
Prince Sultan Road, Ayah Mall
www.petromin.com
Tel: +966 12 60 8300
Fax: +966 12 608 2545
Emergency Telephone Technical Services Department
Number Telephone: +966 12 215 7000
Section 2. Hazard(s) identification
Classification of the Not classified
substance or mixture
GHS label elements:
Hazard Pictograms: No hazard pictogram is used
Signal word: No signal word is used
Hazard statement: Not applicable
Precautionary statement:
Prevention: Not applicable
Response: Not applicable
Storage: Not applicable
Disposal: Not applicable
Other hazards which do
Not applicable
not result in classification
Product Name: Turbomaster LD 10W-40 Version#: 2.0
Product code#: 5530 Page 1 of 6 Date of issue: 28/07/2019
SAFETY DATA SHEET
Section 3. Composition and ingredient information
Substance/ mixture Mixture
Components CAS No. Percent
Hydrotreated heavy paraffinic 64742-54-7 80-90%
Performance Additives Mixture <20%
Section 4. First aid measures
Description of necessary first aid measures
Eye contact In case of contact, immediately flush eyes with plenty of water for at least 15
minutes. Eyelids should be held away from the eyeball to ensure through
rinsing. Check and remove any contact lenses. Get medical attention
Skin contact No specific first aid measures are required. As a precaution, remove clothing
and shoes if contaminated. To remove the material from skin, use soap and
water.
Inhalation If inhaled, remove the person to fresh air. Get medical attention if symptoms
Ingestion Do not induce vomiting. As a precaution, get medical advice.
Symptoms caused by
Not available
exposure
Special Treatment No special treatment
Section 5. Fire-fighting measures
Extinguishing media
Suitable extinguishing mediaIn case of fire, use Foams, dry chemicals, CO2, nylons and powders
unsuitable extinguishing Do not use water
media
Protection Equipment Heat resistant suit and gloves, Self-contained breathing apparatus
Special Risks None
Special Measures Not required
Combustion Products CO2, H2O, CO (in defect of air), nitrogen, sulfur and phosphorus oxides
Section 6. Accidental release measure
Precautions for the Hazard of physical fouling to coasts, soils, etc. due to low solubility and high
Environment viscosity of the oils. Avoid the material entering water intakes
Clean-up Method Treat as an accidental oil spill or leak; avoid dispersion of the material with
mechanical barriers. Remove with physical or chemical treatment
Personal Precautions Avoid prolonged contact with contaminated clothes or with the product
Personal Protection Gloves and goggles or face shield
Product Name: Turbomaster LD 10W-40 Version#: 2.0
Product code#: 5530 Page 2 of 6 Date of issue: 28/07/2019
SAFETY DATA SHEET
Section 7. Handling and storage
Precautions for safe
handling
General Precautions Avoid prolonged contact and inhalation of mists and vapors
Specific conditions Safety goggles and gloves should be used
Precautions for safe
storage
Storage condition Containers properly labeled and sealed, placed in cool and
Incompatible materials Strong oxidants
Dangerous practices Not available
Section 8. Exposure control/ Personal protection
Control parameters:
Exposure Level Not available
Inhalation Low vapor pressures: The product is slightly volatile at room temperature and
does not present special risks. In presence of heated oils, wear protective
masks to avoid vapor inhalation
Skin Gloves
Eye Safety goggles
Other Showers and eye-washers in the working area
Specific Hygiene measure Good work practices to minimize exposure and adoption of good Personal hygiene measures avoid
Exposure Level
TLV (typical base oil) = 0.016 PPM at 20ºC (saturated vapor Concentration);
TLV/TWA (ACGIH) = 5mg/m3 (oil mist); TLV/STEL (ACGIH) = 10mg/m3 (oil mist)
Section 9. Physical and chemical properties
Information on basic physical and chemical properties:
Appearance:
Physical state: Liquid
Color: Brownish Oil
Specific Gravity (at 15ºC): 0.858 (typical)
Flash point: 240 ºC
Explosive Properties: Not available
Oxidizing Properties: Not available
Water Solubility: Insoluble (100 PPM max. H2O)
Solubility: Organic solvents
Vapor Density: Not available
Vapor Pressure: Not available
Viscosity at 100ºC: 14.9 cSt (typical)
Pour Point: -30 ºC (typical)
Boiling Point: Not available
Product Name: Turbomaster LD 10W-40 Version#: 2.0
Product code#: 5530 Page 3 of 6 Date of issue: 28/07/2019
SAFETY DATA SHEET
Section 10. Stability and reactivity
Reactivity Stable under recommended transport storage conditions
Chemical stability Stable under normal temperature pressures
Polymerization Risk Not available
Materials to Avoid Strong oxidants react with oils and organic materials
Hazardous Decomposition Not available
products
Condition to Avoid Exposure to open flames
Section 11. Toxicological information
Routes of Exposure Contact with skin, eyes and inhalation. Ingestion is not frequent.
Acute and chronic EffectsNo malignant acute effects are known. Chronic effects due to repeated
exposures are irritation, dermatitis and acne
Carcinogenicity Not available
Reproductive Toxicity No evidences
Medical Conditions which Respiratory tract deficiencies and dermatological problems
increase Hazard to
Exposure
Section 12. Ecological information
Pollutant Potential:
Persistence and the material is oily and viscous and floats on water. It presents a high physical
Degradability fouling potential, mainly in sea-spills; by contact, destroys small aquatic
organisms and makes living difficult for upper organisms, not allowing the
sunlight to reach underlying marine ecosystems, affecting its normal
development.
Mobility/Bioaccumulative it does not present bioaccumulative problems in living organisms or incidence in
Potential the tropic food chain, although it may cause long-term adverse effects in the
aquatic environment, due to its high physical fouling potential
Eco toxicological Effect: Dangerous for aquatic life in high concentrations (spills).
Section 13. Disposal consideration
Disposal Methods (surplus) Recycling and recovery of base oils when possible
Disposal (waste) Only in specific prepared and controlled areas. Avoid releasing oils to sewers
because they can destroy water treatment plant Microorganisms. Do not
attempt to clean containers since residue is difficult to remove; dispose in a safe
way.
Handling (waste) Labeled and sealed containers. Avoid direct contact with waste oils.
Product Name: Turbomaster LD 10W-40 Version#: 2.0
Product code#: 5530 Page 4 of 6 Date of issue: 28/07/2019
SAFETY DATA SHEET
Section 14. Transport information
Special Precautions Stable at room temperature and during transport. Store in cool well ventilated
areas.
UN Number Not regulated
Road (ADR)/ Rail (RID) Not regulated
/River (ADNR)
Airline (IATA-ACAO) Not regulated
Marine (IMO-IMDG) Not regulated
Special precautions for Not available
user
Section 15. Regulatory information
Regulation CERCLA/SARA - Section 302 Extremely Hazardous Substances and TPQs (in pounds):
This material does not contain any chemicals subject to the reporting requirements of
SARA 302 and 40 CFR 372.
CERCLA/SARA - Section Acute Health: No
311/312 (Title III Hazard Chronic Health: No
Categories) Fire Hazard: No
Pressure Hazard: No
Reactive Hazard: No
CERCLA/SARA - Section 313 This material does not contain any chemicals subject to the reporting
and 40 CFR 372 requirements of SARA 313 and 40 CFR 372
EPA (CERCLA) Reportable This material does not contain any chemicals with CERCLA Reportable
Quantity (in pounds) Quantities
California Proposition 65 This material does not contain any chemicals which are known to the State of
California to cause cancer, birth defects or other reproductive harm at
concentrations that trigger the warning requirements of California Proposition
65
Canadian This product has been classified in accordance with the hazard criteria of the
Regulation Controlled Products Regulations (CPR) and the MSDS contains all the
information required by the Regulations. WHMIS Hazard Class: None
National Chemical All components are either listed on the US TSCA Inventory, or are not regulated
Inventories under TSCA. All components are either on the DSL, or are exempt from DSL
listing requirements
U.S. Export Control EAR99
Classification Number
Product Name: Turbomaster LD 10W-40 Version#: 2.0
Product code#: 5530 Page 5 of 6 Date of issue: 28/07/2019
SAFETY DATA SHEET
Section 16. Other information
History:
Date of Issue 10/29/2018
Revision Version Version 2.0
Status: Final
Previous Issue Date
Guide to Abbreviations CAS Chemical Abstracts Service
ACGIH American Conference of Governmental Industrial Hygienists
CASRN Chemical Abstracts Service Registry Number
CEILING Ceiling Limit (15 minutes)
CERCLA The Comprehensive Environmental Response, Compensation, and
Liability Act
EPA Environmental Protection Agency
IARC International Agency for Research on Cancer
LEL Lower Explosive Limit
NE Not Established
NFPA National Fire Protection Association
NTP National Toxicology Program
OSHA Occupational Safety and Health Administration
PEL Permissible Exposure Limit (OSHA)
SARA Superfund Amendments and Reauthorization Act
STEL Short Term Exposure Limit (15 minutes)
TLV Threshold Limit Value (ACGIH)
TWA Time Weighted Average (8 hours)
UEL Upper Explosive Limit
WHMIS Worker Hazardous Materials Information System (Canada)
Disclaimer of Expressed This information relates only to the specific material designated and may not be
and implied Warranties valid for such material used in combination with any other materials or in any
process. Such information is to the best of our knowledge and belief, accurate
and reliable as of the date indicated. However no representation, warranty or
guarantee is made as to its accuracy, reliability or completeness.
It is the user's responsibility to satisfy himself as to the suitability and
completeness of such information for his own particular use.
Product Name: Turbomaster LD 10W-40 Version#: 2.0
Product code#: 5530 Page 6 of 6 Date of issue: 28/07/2019
