Volvo C30 S40 04 V50 C70 06 2010 Wiring Diagram

Full download: http://manualplace.com/download/volvo-c30-s40-04-v50-c70-06-2010-wiring-diagram/

VOLVO C30, S40 (04-), V50 & C70 (06-)

WIRING DIAGRAM 2010

TP 39150201

This is the cut pages sample. Download all 220 page(s) at: ManualPlace.com
 Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.

Is the vehicle equipped with SRS/SIPS bag/IC?

Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).

General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B posts, the B and C posts, and the C
and D posts.

Test terminal
Data link connector in the passenger compartment.

Changes introduced up to and including December 2008

Any changes made to the vehicles after this date are not included in the manual. If necessary
refer to service bulletins.

Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.

Ordering:
Electronic Wiring Diagrams (EWD) can be ordered from Technical Information Shop (TIS) at
w ww.volvocarstechinfo.ford.com/vss
We retain the right to make modifications.

© Volvo Car Corporation

Table of Contents 1:3

Vehicles with SRS (Airbag)/SIPS bag/IC Group 23 Fuel system

(Inflatable Curtain) ......................................................... 2 Engine management system, 4-Cyl. 1.6l 1:2 ............... 52
Abbreviations ................................................................. 6 Engine management system, 4-Cyl. 1.8l & 2.0l 1:2 ..... 54
How to use the wiring diagrams 1:2............................... 7 Engine management system, 5-Cyl. 1:2 ...................... 56
Electrical distribution 1:2................................................ 9 Engine management system, 5-Cyl. Turbo 1:2............ 58
Engine management system Diesel, 4-Cyl. 1.6l 1:2 .... 60
Fuses Engine management system Diesel, 4-Cyl. 2.0l 1:2 .... 62
Engine compartment distribution box F1-F7................. 11 Engine management system Diesel, 4-Cyl. 2.0l
Distribution box in engine compartment F8-F16........... 12 MPS6 1:2 ..................................................................... 64
Distribution box in engine compartment F17-F25......... 13 Engine management system Diesel, 5-Cyl. 2.4l 1:3 .... 66
Distribution box in engine compartment F26-F32......... 14 Emission control 4-Cyl. 1.6l ......................................... 69
Distribution box in engine compartment F33-F34......... 15 Emission control, 4-Cyl. 1.8l & 2.0l .............................. 70
Engine compartment distribution box F35-FH1 ............ 16 Emission control 5-Cyl. ................................................ 71
Main fuse box battery ................................................... 17 Emission control 5-Cyl. Turbo...................................... 72
Fuse holder midi ........................................................... 18
Central Electronic Module (CEM) F43-F48................... 19 Group 26 Cooling system
Central Electronic Module (CEM) F49-F61................... 20 Cooling fan................................................................... 73
Central Electronic Module (CEM) F62-F69................... 21
Central Electronic Module (CEM) F73-F85................... 22
Central Electronic Module (CEM) F86 .......................... 23
Group 27 Engine controls
Battery PF1-PF2 ........................................................... 24 Cruise control 4-Cyl. ..................................................... 74
Cruise control 5-Cyl. ..................................................... 75
Start/stop function ......................................................... 76
Relays
Ignition switch and relays............................................. 25
Distribution box in engine compartment R1-R14 ......... 26 Group 32 Alternator and voltage regulator
Engine compartment.................................................... 27 Power supply 4-Cyl. ..................................................... 77
Central electronic module (CEM) R15-R18 ................. 28 Power supply 5-Cyl. ..................................................... 78
Central electronic module (CEM) R1-R11B................. 29
Other relays ................................................................. 30 Group 33 Starting system
Starting system 4-Cyl................................................... 79
Ground connections Starting system 5-Cyl................................................... 80
Overview...................................................................... 31
31/3 - 31/10 cont.......................................................... 32 Group 35 Lighting
31/10 - 31/11 ............................................................... 33 High and low beam ...................................................... 81
31/12 - 31/66 cont........................................................ 34 Active headlights, (Dual Xenon) S40/V50.................... 82
31/66 - 31/80 ............................................................... 35 High and low beam, (Dual Xenon) C30/C70................ 83
31/83 - 31/102 ............................................................. 36 Running/Parking lights, Tail lights S40/V50 ................. 84
31/107 - 31/114 ........................................................... 37 Running/Parking lights, Tail lights (Dual Xenon)
31/115 - 31/160 ........................................................... 38 S40/V50 ....................................................................... 85
Ground connections in chassis.................................... 39 Running/Parking lights, Tail lights C30/C70................. 86
Running/Parking lights, Tail lights (Dual Xenon)
Control modules C30/C70....................................................................... 87
Overview locations....................................................... 40 Brake lights S40/V50 ................................................... 88
Overview designations................................................. 41 Brake lights C30/C70 ................................................... 89
Central electronic module (CEM) 1:2........................... 42 Reversing lights S40/V50............................................. 90
Data communication, Low speed CAN 1:2 .................. 44 Reversing lights C30/C70 ............................................ 91
Data communication, High speed CAN ....................... 46 Fog lights S40/V50 ...................................................... 92
Data communication MOST......................................... 47 Fog lights C30/C70 ...................................................... 93
Data communication LIN 1:2 ....................................... 48 Fog lights LHD Japan S40/V50.................................... 94
Ignition switch (SCU) ................................................... 50 Fog lights LHD Japan C30/C70 ................................... 95
Accessory electronic module (AEM)............................ 51 Follow-me-home lighting.............................................. 96
Interior lighting C30/S40/V50 1:2 ................................. 97
Interior lighting C70 1:2................................................ 99
Instrument and control illumination ............................ 101
Auxiliary lights ............................................................ 102

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 3

Table of Contents 2:3

Group 36 Additional electrical equipment Cellular phone 1:2...................................................... 143

Direction indicators and hazard warning flashers Multimedia & Traffic information ................................ 145
S40/V50 ..................................................................... 103 Satellite radio ............................................................. 146
Direction indicators and hazard warning flashers Subwoofer.................................................................. 147
(Dual Xenon) S40/V50............................................... 104 Portable navigation system........................................ 148
Direction indicators and hazard warning flashers Bluetooth.................................................................... 149
C30/C70..................................................................... 105 Bluetooth Handsfree, internal amplifier...................... 150
Direction indicators and hazard warning flashers Bluetooth Handsfree, external amplifier..................... 151
(Dual Xenon) C30/C70 .............................................. 106 Bluetooth Handsfree & AUU, internal amplifier.......... 152
Wiper/washer windshield ........................................... 107 Bluetooth Handsfree & AUU, external amplifier......... 153
Washer headlights ..................................................... 108 Bluetooth Handsfree with AEM, internal amplifier,
Wiper/washer rear window C30/V50 ......................... 109 LHD ...................................................................... 154
Rain sensor................................................................ 110 Bluetooth Handsfree with AEM, internal amplifier,
Keyless vehicle C30/S40/V50 1:2.............................. 111 RHD ...................................................................... 155
Keyless vehicle C70 1:2 ............................................ 113 Bluetooth Handsfree with AEM, external amplifier,
Parking assistance..................................................... 115 LHD ...................................................................... 156
Immobilizer/Steering column lock module (SCL)....... 116 Bluetooth Handsfree with AEM, external amplifier,
Horn ...................................................................... 117 RHD ...................................................................... 157
Anti-theft alarm C30................................................... 118
Anti-theft alarm S40/V50............................................ 119 Group 43 Transmission
Anti-theft alarm C70................................................... 120 Automatic transmission AW55-51.............................. 158
Alcolock ..................................................................... 121 Transmission M66...................................................... 159
Accessory Electronic Module (AEM) C30.................. 122 Automatic transmission MPS6 ................................... 160
Accessory Electronic Module (AEM), Differential Electronic Module (DEM) S40/V50 .......... 161
S40/V50/C70 ............................................................ 123
Group 59 Brake system
Group 37 Wiring and fuses Brake control system & STC...................................... 162
12V outlet C30/S40/V50 ............................................ 124 Brake control system & DSTC ................................... 163
12V outlet, C70 .......................................................... 125
Diagnostics system.................................................... 126
Group 64 Steering
Cable harness towbar/tow hitch 4-pin S40/V50......... 127
Cable harness towbar/tow hitch 4-pin C30/C70 ........ 128 Speed dependent power steering .............................. 164
Cable harness towbar/tow hitch 7-pin S40/V50......... 129
Cable harness towbar/tow hitch 7-pin C30/C70 ........ 130 Group 83 Doors and openings
Cable harness towbar/tow hitch 13-pin Central locking front doors C30/S40/V50................... 165
S40/V50/C70 ............................................................. 131 Central locking rear doors S40/V50 ........................... 166
Cable harness towbar/tow hitch 13-pin C30 .............. 132 Central locking C70.................................................... 167
USB unit (AUU).......................................................... 133 Central locking trunk lid/tailgate C30 ......................... 168
Central locking trunk lid/tailgate S40/V50 .................. 169
Group 38 Instruments Central locking trunk lid/tailgate C70 ......................... 170
Central locking storage compartment C70................. 171
Driver information module.......................................... 134
Child safety lock S40/V50 .......................................... 172
Seat belt reminder C30/S40/V50 ............................... 135
Central locking fuel filler flap ...................................... 173
Seat belt reminder C70.............................................. 136
Signal receiver central locking C30/S40/V50............. 174
Signal receiver central locking C70............................ 175
Group 39 Other Power windows front doors C30/S40/V50 ................. 176
Audio C30/S40/V50 ................................................... 137 Power windows C70 .................................................. 177
Audio C70 .................................................................. 138 Power windows rear doors S40/V50.......................... 178
Audio High Performance/Premium Sound Power sunroof C30/S40/V50 ..................................... 179
C30/S40/V50 1:2 ....................................................... 139 Power roof C70 .......................................................... 180
Audio High Performance/Premium Sound C70 1:2 ... 141

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 4

Table of Contents 3:3

Group 84 Exterior decorative elements, etc. Power passenger seat RHD S40/V50........................ 195
Power door mirrors C30/S40/V50.............................. 181 Heated seats.............................................................. 196
Power door mirrors C70............................................. 182
Heated door mirrors................................................... 183 Group 87 Climate control system
Rear window defroster............................................... 184 Climate control system, 4-Cyl. Gasoline 1:2 .............. 197
Blind spot information system.................................... 185 Climate control system, Diesel 1.6l & 2.0l 1:2............ 199
Climate control system, 5-Cyl. 1:2 ............................. 201
Group 85 Interior equipment Climate control system PTC-elements....................... 203
Power driver’s seat with memory function LHD Parking heater, auxiliary heater ................................. 204
S40/V50 ..................................................................... 186 Relay, electric engine heater ..................................... 205
Power driver’s seat with memory function RHD Electric engine heater Flexifuel.................................. 206
S40/V50 ..................................................................... 187
Power driver’s seat with memory function LHD Group 88 Internal equipment
C30/C70..................................................................... 188 Supplemental restraint system C30/S40/V50 1:2 ...... 207
Power driver’s seat with memory function RHD Supplemental restraint system C70 1:2 ..................... 209
C30/C70..................................................................... 189 Remote controlled garage door opening.................... 211
Power passenger seat with memory function LHD Rear-view mirror with automatic dimming.................. 212
C30/C70..................................................................... 190
Power passenger seat with memory function RHD
Index 1:2 ....................................................213
C30/C70..................................................................... 191
Power driver’s seat LHD S40/V50 ............................. 192
Power driver’s seat RHD S40/V50............................. 193 List of components 1:6 ............................215
Power passenger seat LHD S40/V50 ........................ 194

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 5

Explanations
Abbreviations
Groups Other
Group 23 = Fuel system ACC = Accessories
Group 26 = Cooling system Ag = Silver plated
Group 27 = Engine controls Au = Gold plated
Group 32 = Alternator and voltage regulator AUTO = Automatic transmission
Group 33 = Starting system AWD = All wheel drive
Group 35 = Lighting CAN = CAN communication
Group 36 = Additional electrical equipment D = Diesel
Group 37 = Wiring and fuses DPY = Display
Group 38 = Instruments ECC = Electronic climate control system
Group 39 = Other ETA = Throttle unit
Group 43 = Transmission EXT. X = Extended X-feed
Group 59 = Brake system GDL = Gas discharge lamp
Group 64 = Steering HISPEED = High speed data bus
Group 83 = Doors and openings IR = Infrared sensor
Group 84 = Exterior decorative elements, etc. LIN = LIN communication
Group 85 = Interior equipment LHD = Left-hand drive
Group 87 = Climate control system LOSPEED = Low speed data bus
Group 88 = Internal equipment MAN = Manual transmission
MEMORY = Memory driver’s seat
Designations ignition switch MMS = Mass Movement Sensor
X = Accessories (audio position) PETROL = Gasoline
S = Powered upon insertion of key RHD = Right-hand drive
15 = Contact remains connected during SCR = Screened
start SRS = Airbag
15l = Contact is broken while starting T = Turbocharged engine
30 = Constant power from the battery W/O = Without
50 = Start 2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
Countries/Markets 5CYL, I5 = 5-cylinder engine
A = Austria
Colors
AUS = Australia
B = Belgium BK, SB = Black
CDN = Canada BN = Brown
CH = Switzerland BU, BL = Blue
D = Germany GN = Green
DK = Denmark GY, GR = Gray
E = Spain LGN = Light Green
EU/OS = Markets outside USA and Canada OG, OR = Orange
FIN = Finland PK, P = Pink
GB = Great Britain RD, R = Red
ISR = Israel VT, VO = Violet
J = Japan WH, W = White
KOR = Korea YE, Y = Yellow
N = Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 6

How to use the wiring diagrams 1:2

The descriptions below apply in general

to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.

A. Component designation B. Branching points

Every component has a component designation that The wiring diagrams contain numbered junction
consists of two parts. points, e.g. 63/352.

The first part is a type number that describes the This manual contains a section with a list of branch-
type of component in question, for example 3/xx. ing points. This list shows all the components that
are connected to each branching point.
The second part of the designation is a serial num-
ber, e.g. x/2. The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
Together, this constitutes a component designation,
e.g. 3/2. C. Connectors
Connectors provide a bridge between two cable har-
At the end of the manual is a list of components,
nesses and are described in the
where, with the help of the component designation,
"Connectors" section.
you can read off the name of the component, for
example, 3/2 = light switch.
D. Electrical distribution
List of type numbers Operation of the fuses and relays is shown in the
"Electrical distribution" section.
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
E. Data communication
Today’s cars contain CAN and MOST networks that
1 Battery transfer information. Connections to these networks
2 Relay are not shown in their entirety in the respective wir-
3 Switch ing diagram. Complete information on CAN and
4 Control module MOST communication is found in the section "Con-
5 Driver information module trol modules".
6 Electric motor
7 Sensor F. Abbreviations
8 Actuator A number of different abbreviations are used in the
9 Heating element manual. These are explained in the section "Abbre-
10 Light viations".
11 Fuse
15 Electrical distribution rail/box G. Component location
16 Audio
17 Service/diagnostics There is a section at the end of the manual in which
18 Contact reel the appearance and location of components is
19 Meter described in numerical order.
20 Ignition component/shunt
27 Optics
31 Ground connection
63 Branching point
64 Connector

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 7

How to use the wiring diagrams 2:2

Explanation of symbols
= System voltage

= Ground connection via wiring

= Ground connection in compo-

nent/chassis
= Screened wire

= Junction point

= Twisted cable

= Electrical connection

= Variant

= CAN communication

= CAN high data signal (CAN

H)

= CAN low data signal (CAN L)

= LIN communication

= LIN communication

= DIN cable, coaxial cable, etc.

= Data communication

= CAN communication

= MOST communication

= MOST communication

= Connection with distribution

box

= Further connection to...

= Connector between cable

harnesses
= Connector connected in com-
ponent

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 8

Electrical distribution 1:2
Overview

1/1
12V BK A:1
6/25
50
31/3

1 1
BK M 30 B:1

31/4 31

PF2 PF1

2 2 RD

RD 6/26 B:1

B+ ACM

G
RD

31
LIN

15/31
2/82
R10 64/113
GN-BU 6
RD-OG 3
5

F12 1 2

RD-OG

F14
F17 64/90=
31
F10 15/31A

I5 GN-BU
F13 I4
2/35
1 2 R13 BK-RD
RD-GN 4 64/90=
5 GY 11 15/31A
3
GN-YE
7/51:6

2/32 64/90=15/31A
RD-OG R14 1 2 BK-BU
21
5
3
F9 F36 GN-BU
41
F34 GN-BU
12
RD-OG F33 I4 Diesel 6

F35
F32
5 cyl

GN-YE
RD-OG

1 2 8/84:1
GN-YE
GN-YE

5 6/114:1
3
GN-OG

2/133 64/90=15/31A
R3
63/13

GN-YE 35

GN-YE
40
2/14 GN-BU
14
R12
GN-YE
F6 1 2
39
BK-YE
2
RD WH-BU
16
3 5
BK-WH
BK-RD

GN-BU

64/91
BK-RD
1
G030184

A B CD F
TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 9
Electrical distribution 2:2
Overview

A B CDF
15/31

64/113
WH-BK 7

2/142 R5 RD 13
WH-BK 3
5
64/90=15/31A
BK BK BK
F24 1 2
63/121 63/120
GN-WH 31/114
RD-OG

2/17
RD-BU R2 1 2 BK-BU

5 OG-BU

I4
16/10
F20 3 16/11

BK-WH

GN-BU
BK-RD
RD-OG
64/111
F26 RD
5
F3 RD-OG

F30 RD
13
F31 64/90=15/31A

RD
F2 63/231
C70 RD-WH
F16 S40/V50 RD-WH

3/1 B:7
RD-WH

64/90=15/31A 30
F23 5
RD 23

F4 50 S B:1 X 15
B:2
B:5

B:3

F18
2/22
GN-WH
RD-GN
GY-BK

R11 1 2 BK-YE 17
YE

5 GN-YE 18
RD-BU

F27
A:42
A:15
A:30
A:17

3
RD-BU 64/90=15/31A

2/34 4/56
R4 E:29
E:20
RD-OG 1 2
E:23 G:18
CEM
5 GN-WH
10/5:1 E:22
3 10/6:1
RD-YE E:21 E:9
F29 CAN
2/182
R9 BK-YE G:9
RD-GN E:30
G:11 LIN
RD-BK 1 2 BK-RD

5 GN-YE
RD-WH F11 6/104:1
3

F8
F7
F1
64/861
F5 RD 1
F21

F28
F22
F15
G030186

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 10

Fuses
Engine compartment distribution box F1-F7

15/31 Distribution box in engine compartment

No. Fuse function via A
F1 4/71 Cooling fan control module - 50
F2 6/71 Electrical power steering module (EPS) - 80
F3 2/193 Relay, comfort functions - 60
4/56 Central electronic module (CEM) 2/193
F45 Fuse in the Central Electronic Module (CEM) 2/193
F48-F49 Fuses in the Central Electronic Module (CEM) 2/193
F60-F61 Fuses in the Central Electronic Module (CEM) 2/193
F62-F63 Fuses in the Central Electronic Module (CEM) -
F68-F69 Fuses in the Central Electronic Module (CEM) 2/193
F80 Fuse in the Central Electronic Module (CEM) 2/193
F84-F85 Fuses in the Central Electronic Module (CEM) -
F4 2/63 Relay, high beam - 60
4/56 Central electronic module (CEM) -
F55 Fuses in the Central Electronic Module (CEM) -
F58-F59 Fuses in the Central Electronic Module (CEM) 2/63
F74 Fuses in the Central Electronic Module (CEM) -
F77 Fuses in the Central Electronic Module (CEM) -
F5 9/41 PTC-element - 80
F6 4/109 Glow plug control module (GCU), 5-Cyl. Diesel - 70
20/23-26 Glow plug, 4-Cyl. Diesel 2/14 60
F7 4/16 Brake Control Module (BCM), pump - 30
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 11

Fuses
Distribution box in engine compartment F8-F16

15/31 Distribution box in engine compartment

No. Fuse function via A
F8 4/16 Brake Control Module (BCM), valves - 20
F9 2/32 Main relay, engine management system - 30
F32-F36 Fuses in the engine compartment distribution box 2/32
F10 4/31 Fan control module - 40
F11 2/182 Relay, headlight washer motor - 20
4/59 Convertible Roof Module (CRM), C70 -
6/104 Pump, high pressure headlight washer 2/182
F12 2/82 Relay, heated rear window - 30
9/2 Rear window defroster 2/82, 16/141
F13 6/25 Starter motor 2/35 30
F14 4/110 Trailer module (TRM) - 40
F15 4/59 Convertible Roof Module (CRM), C70 30
F16 2/159 Infotainment relay, S40/V50/C30 - 30
16/105 Audio module (AUD), S40/V50/C30 -
F22 Fuse, engine compartment distribution box, S40/V50/C30 -
F43 Fuse in the Central Electronic Module (CEM), S40/V50/C30 -
F64 Fuse in the Central Electronic Module (CEM), S40/V50/C30 -
F65-F67 Fuses in the Central Electronic Module (CEM), S40/V50/C30 2/159
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 12

Fuses
Distribution box in engine compartment F17-F25

15/31 Distribution box in engine compartment

No. Fuse function via A
F17 6/1 Wiper motor module (WMM) - 30
F18 2/80 Relay, reversing light - 40
2/89 Relay, interior lighting -
4/56 Central electronic module (CEM) -
F46-F47 Fuses in the Central Electronic Module (CEM) 2/89
F56-F57 Fuses in the Central Electronic Module (CEM) -
F79 Fuse in the Central Electronic Module (CEM) 2/80
F81-F83 Fuses in the Central Electronic Module (CEM) -
F86 Fuse in the Central Electronic Module (CEM) 2/89
F20 2/17 Relay, horn - 15
16/10 Horn 1 2/17
16/11 Horn 2 2/17
F21 4/7 Combustion preheater module (CPM) - 20
F22 16/79 Subwoofer module (SUB) - 25
F23 4/28 Transmission Control Module (TCM), MPS6 - 15
4/28 Transmission Control Module (TCM), 5-Cyl. - 10
4/46 Engine Control Module (ECM), 5-Cyl. -
F24 9/32 PTC resistor, crankcase ventilation, 5-Cyl. Diesel 2/142 20
9/38 Heated fuel filter, 5-Cyl. Diesel 2/142
F25 4/56 Central Electronic Module (CEM), 1.6l Diesel - 10
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 13

Fuses
Distribution box in engine compartment F26-F32

15/31 Distribution box in engine compartment

No. Fuse function via A
F26 2/35 Relay, starter motor 3/1 15
3/1 Start control module (SCU) -
4/56 Central electronic module (CEM) 3/1
F44 Fuse in the Central Electronic Module (CEM) 3/1
F51-F54 Fuses in the Central Electronic Module (CEM) 3/1
F73 Fuse in the Central Electronic Module (CEM) 3/1
F27 8/3 Electromagnetic clutch, climate control system 2/22 10
F29 2/34 Relay, front fog lights - 15
10/5 Fog light, front left 2/34
10/6 Fog light, front right 2/34
F30 4/46 Engine Control Module (ECM), 2.0l Diesel, 1.6l Gasoline - 3
6/73 Coolant pump, 1.6l Diesel 2/239 10
F31 6/26 Alternator, 4-Cyl. - 10
F32 2/14 Relay, glow plug system - 10
6/143 Regulator motor, Turbo -
7/15 Front heated oxygen sensor, 4-Cyl. -
7/17 Mass air flow sensor (MAF), 5-Cyl. Diesel -
7/82 Rear heated oxygen sensor, 4-Cyl. -
8/6-8/10 Injection valves, 5-Cyl. -
8/121 Coolant valve, 2.0l Diesel -
8/122 Bypass valve, intercooler, 1.6l Diesel -
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 14

Fuses
Distribution box in engine compartment F33-F34

15/31 Distribution box in engine compartment

No. Fuse function via A
F33 2/133 Relay vacuum pump - 20
4/46 Engine control module (ECM), 5-Cyl. Diesel -
6/114 Vacuum pump, 5-Cyl. 2/133
7/15 Front heated oxygen sensor, 5-Cyl. -
7/82 Rear heated oxygen sensor, 5-Cyl. Turbo -
7/186 Heated oxygen sensor, rear, 5-Cyl. without Turbo -
7/187 Heated oxygen sensor, center, 5-Cyl. without Turbo -
8/84 Switch, vacuum pump -
9/32 PTC resistor, crankcase ventilation, 2.0l. Diesel -
9/38 Heated fuel filter, 4-Cyl. Diesel -
F34 2/35 Relay starter motor, 1.6l Diesel - 10
2/242 Relay isolator battery, 1.6l Diesel -
2/243 Relay isolator secondary battery, 1.6l Diesel -
2/239 Relay coolant pump, 1.6l Diesel -
4/46 Engine control module (ECM), 1.6l Diesel -
4/109 Glow plug control module (GCU), 5-Cyl. Diesel -
8/6-8/9 Injection valves, 1.6l. -
8/77 Fuel volume control valve, 2.0l Diesel -
8/111 Fuel flow control valve, 1.6l Diesel -
8/119 Pressure monitor, climate control system, 5-Cyl. -
8/120 EGR valve, 5-Cyl. Diesel -
8/133 Control valve fuel pressure -
20/3 -20/7 Spark plug and ignition coil -
20/17 Transformer, ignition coils, 1.6l -
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 15

Fuses
Engine compartment distribution box F35-FH1

15/31 Distribution box in engine compartment

No. Fuse function via A
F35 2/22 Relay, climate control system - 15
4/46 Engine control module (ECM), 5-Cyl. Diesel -
6/67 Fuel leakage control pump, 5-Cyl. 2/22
6/99 EGR motor, 1.6l Diesel, 1.8l Gasoline -
7/17 Mass air flow sensor (MAF), 5-Cyl. Gasoline, 4-Cyl. Diesel -
7/192 Water detection sensor, 4-Cyl. Diesel -
8/6-8/9 Injection valves, 1.8l. -
8/18 EVAP valve, Gasoline -
8/19 Solenoid, variable valve timing, intake, 5-Cyl. Gasoline -
8/28 Turbocharger control valve, 2.5l Turbo -
8/45 Vacuum valve, variable intake manifold, 1.8l -
8/65 Pressure switch, power steering, 1.6l -
8/77 Fuel volume control valve, 2.0l Diesel -
8/81 Solenoid, variable valve timing, exhaust, 2.5l Turbo -
8/82 Solenoid, variable turbo geometry, 4-Cyl. Diesel -
8/114 Valve, air/fuel mixing, 1.8l -
8/132 Control valve, intake, 2.0l Diesel -
9/32 PTC resistor, crankcase ventilation 5-Cyl. Gasoline -
F36 4/46 Engine control module (ECM) - 10
7/15 Front heated oxygen sensor, 5-Cyl. Diesel -
7/51 Accelerator pedal sensor -
FH1 10/65 Auxiliary lights, front right 2/64 20
10/69 Auxiliary lights, front left 2/64

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 16

Fuses
Main fuse box battery

15/34 Main fuse box battery

No. Fuse function via A
11M/1 6/26 Alternator 2/242 125
15/31 Distribution box in engine compartment -
11M/2 7/240 Sensor battery monitoring - 15

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 17

Fuses
Fuse holder midi

15/37 Fuse holder midi

No. Fuse function via A
Cable fuse by secondary battery - 70
Cable fuse in distribution box in engine compartment - 70

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 18

Fuses
Central Electronic Module (CEM) F43-F48

4/56 Central Electronic Module (CEM)

No. Fuse function via A
F43 4/124 Accessory USB unit (AUU) - 15
16/1 Integrated Audio Module (IAM) -
16/46 RTI Display -
16/60 Phone module (PHM) -
16/108 Multimedia module (MMM) -
16/147 Bluetooth phone module (BPM) -
17/42 USB-port
F44 4/46 Engine Control Module (ECM), 5-Cyl. - 10
4/9 Supplemental restraint system module (SRS) -
F45 9/1 Front 12V outlet - 15
9/25 Rear 12V outlet -
F46 3/111 Switch unit, lights - 5
5/1 Driver Information Module (DIM) -
10/1 Lamp housing, front left -
10/2 Lamp housing, front right -
10/29 Glove compartment lighting -
10/97 Courtesy lighting, left -
10/102 Courtesy lighting, right -
Alcolock -
F47 4/76 Remote control unit for garage door opener - 5
10/22 Ceiling light -
10/150 Rear reading light -
10/114 Vanity mirror lighting, left, not C70 -
10/115 Vanity mirror lighting, right -
F48 2/16 Relay, rear window wiper - 15
2/92 Relay, windshield washer motor -
2/93 Relay, rear window washer motor -
6/2 Washer pump 2/92
6/32 Rear window wiper motor 2/16
continues

TP 39150201 C30/S40 (04-)/V50/C70 (06-) 2010 19

Volvo C30 S40 04 V50 C70 06 2010 Wiring Diagram
Fuses
Full download: http://manualplace.com/download/volvo-c30-s40-04-v50-c70-06-2010-wiring-diagram/
Central Electronic Module (CEM) F49-F61

4/56 Central Electronic Module (CEM)

No. Fuse function via A
F49 4/9 Supplemental restraint system module (SRS) - 10
7/93 Occupant Weight Sensor (OWS), USA/CDN -
F51 2/142 Fuel filter preheater relay - 10
4/82 Differential electronic module (DEM) -
9/41 PTC-element -
F52 4/16 Brake control module (BCM) - 5
4/28 Transmission control module (TCM) -
F53 6/71 Electrical power steering module (EPS) - 10
F54 4/46 Engine Control Module (ECM), 5-Cyl. - 10
4/86 Parking assistance module (PAM) -
4/112 Gas Discharge Lamp Module (GDL), master, left -
4/113 Gas Discharge Lamp Module (GDL), slave, right -
4/114 Headlamp Control Module (HCM) -
10/1 Lamp housing, front left -
10/2 Lamp housing, front right -
F55 4/93 Keyless vehicle module (KVM) - 20
F56 4/119 Remote Keyless Entry (RKE)/Remote Receiver Module (RRX) - 10
16/35 Siren control module (SCM) -
F57 3/9 Contact brake light - 15
17/13 Data link connector -
F58 2/64 Relay auxiliary lights 3/60 7.5
4/113 Gas Discharge Lamp Module (GDL), slave, right -
10/2 Lamp housing, front right -
F59 4/112 Gas Discharge Lamp Module (GDL), master, left - 7.5
10/1 Lamp housing, front left -
F60 9/12 Seat Heating Module (SHM), driver’s side - 15
F61 9/13 Seat Heating Module (SHM), passenger side - 15
continues

This is the cut pages sample. DownloadTP

all39150201 C30/S40 (04-)/V50/C70 (06-) 2010
220 page(s) at: ManualPlace.com 20