Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner
Version No. 13406NZ-21A Date of Preparation: 29-April-2021 Supersedes: 18-October-2018
Meets requirements of Hazardous Substances (Safety Data Sheets) Notice 2017
Section 1: PRODUCT & COMPANY IDENTIFICATION
Product Name: Extreme Simple Green® Aircraft & Precision Cleaner
Additional Names:
Manufacturer’s Part Number: Please refer to section 16
Supplier: CIPL Pty (2021) Ltd Telephone: 0800 826 470
5 Greenmount Drive Email:
[email protected] East Tamaki, Auckland, New Zealand Website: www.simplegreennz.com
Emergency Phone: 0800 764 766
Recommended Uses: Heavy Duty Degreaser
Section 2: HAZARDS IDENTIFICATION
HSNO Classification: 6.4A – Causes eye irritation
GHS Classification: Eye Corrosive/Irritation – 2B
Signal Word: Warning
Pictogram: None required
Hazard Statement: H320 - Causes Eye Irritation.
Precautionary Statements: P103 – Read label before use.
P264 – Wash hands thoroughly after handling.
P305 + P351 + P338 – IF IN EYES: Rinse cautiously with water for several minutes. Remove contact
lenses, if present and easy to do. Continue rinsing.
P337 + P313 – If eye irritation persists: Get medical advice/attention.
Section 3: COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient CAS Number Percent Range
Water 7732-18-5 ≥ 78%*
Triethanolamine 102-71-6 ≤ 10%*
Ethoxylated Alcohol 68439-46-3 ≤ 5%*
Propylene Glycol n-butyl ether 5131-66-8 ≤ 5%*
Tetrapotassium Pyrophosphate 7320-34-5 ≤ 1%*
Potassium Silicate 1312-76-1 ≤ 1%*
*exact percentage of ingredients are commercially confidential
Section 4: FIRST AID MEASURES
If Inhaled: If adverse effect occurs, move to fresh air.
If on skin: If adverse effect occurs, rinse skin with water.
If in eyes: IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do.
Continue rinsing. If eye irritation persists: Get medical advice/attention.
If ingested: Drink plenty of water to dilute. Mild stomach or intestinal upset may occur due to detersive properties. For advice,
contact a Poisons Information Centre on 0800 734 607 or a doctor.
Workplace First Aid Facilities: Eye Wash Station or treatment recommended.
Advice to Doctor: Treat symptomatically.
Page 1 of 5
Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner
Version No. 13406NZ-21A Date of Preparation: 29-April-2021 Supersedes: 18-October-2018
Meets requirements of Hazardous Substances (Safety Data Sheets) Notice 2017
Section 5: FIRE FIGHTING MEASURES
Suitable Extinguishing Media: Use dry chemical, CO2, water spray or “alcohol” foam. Avoid high volume jet water.
Hazards from combustion products: None known.
Specific hazards arising from chemical: In event of fire created carbon oxides may be formed.
Precautions for fire-fighters and special protective clothing: Firefighters should wear self-contained breathing apparatus and full
fire-fighting turn-out gear.
Section 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions: Use Personal Protection Recommended in Section 8
Environmental Precautions: Prevent runoff from entering drains, sewers or waterways.
Method for Containment of large and small releases: Dike or soak up with inert absorbent material.
Method for Clean Up of large and small releases: Dilute with water and rinse into sanitary sewer system or dispose into suitable
container.
Hazardous Substance (Emergency Management) Regulations 2001 requirements: none.
Section 7: HANDLING AND STORAGE
Precautions for safe handling: Before use carefully read the product label. Use of safe work practices are recommended to avoid
eyes or skin contact and inhalation. Observe good personal hygiene, including washing hands before eating. Prohibit eating, drinking
and smoking in contaminated area (eg. If container is damaged). Ensure adequate ventilation. Keep out of reach of children. Keep
away from heat, sparks, open flame and direct sunlight. Do not pierce any part of the container.
Conditions for safe storage: Store in cool, dry, well-ventilated area, removed from oxidizing agents, acids and foodstuffs. Ensure
containers are adequately labeled and protected from physical damage when not in use. Do not store at temperatures above 115oF
(46oC). If separation occurs, mix the product for reconstitution.
Section 8: EXPOSURE CONTROLS / PERSONAL PROTECTION
Workplace Exposure Standards: TWA
Triethanolamine 102-71-6 5 mg/m3
Tetrapotassium Pyrophosphate 7320-34-5 5 mg/m3
Engineering Controls: Not applicable
Individual Protection Measures / Personal Protective Equipment (PPE)
Eye Contact: Use any type of protective glasses or eyewear if splashing or spray-back is likely.
Respiratory: Use in well ventilated areas with adequate airflow.
Skin Contact: Prolonged exposure or dermal sensitive individuals should use any type of protective gloves such as nitrile.
General Hygiene Considerations: Wash thoroughly after handling and before eating or drinking.
Section 9: PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Colorless liquid Odour: No added odour
Physical State: Liquid Odour Threshold: Not determined
Boiling Point: 110oC (223oF) Flash Point: Non flammable
Freezing Point: -9oC (15.8oF) Flammability: Non flammable
Specific Gravity: 1.01 – 1.03 Autoignition Temperature: Non flammable
Evaporation Rate: Not determined Decomposition Temperature: 115oF / 46oC
Page 2 of 5
Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner
Version No. 13406NZ-21A Date of Preparation: 29-April-2021 Supersedes: 18-October-2018
Meets requirements of Hazardous Substances (Safety Data Sheets) Notice 2017
Section 9: PHYSICAL AND CHEMICAL PROPERTIES - continued
Vapor Pressure: 20.7 mmHg Density: 1.024 g/L; 8.546 lb/gal
Vapor Density: Not determined Water Solubility: 100%
pH: 10.0 – 11.5 Partial Coefficient: not determined
VOCs: SCAQMD 304-91 / EPA 24: Not tested
CARB Method 310**: 20 g/L 2.0% **Water & fragrance exemption in calculation
SCAQMD Method 313: Not tested
Nutrient Content: < 0.25% by formula
Information on flammable materials: Volume of ingredients in product prevent it from becoming flammable
Section 10: STABILITY AND REACTIVITY
Chemical Stability: Stable under normal conditions 21oC (70oF) and 14.7 psig (760 mmHg)
Reactivity: Non-reactive
Conditions to avoid: Excessive heat or cold.
Incompatible materials: Do not mix with oxidizers, acids, bathroom cleaners or disinfecting agents.
Hazardous decomposition products: Normal products of combustion – CO, CO2.
Possibility of hazardous reactions: None known
Section 11: TOXICOLOGICAL INFORMATION
Acute
Acute Toxicity: Oral LD50 (rat) > 5 g/kg body weight
Dermal LD50 (rabbit) > 5 g/kg body weight
Calculated via OECD Harmonized Integrated Classification System for Human Health & Environmental Hazards of Chemical Substances and Mixtures
Chronic There have been no reports of health effects arising from long term exposure to the ingredients found within this product.
Possible Routes of exposure –
Skin corrosion/irritation: Non-irritant per Dermal Irritection® assay modeling. No animal testing performed.
Eye damage/irritation: Minimal irritant per Ocular Irritection® assay modeling. No animal testing performed
Germ Cell Mutagenicity: No ingredients trigger or classify under this category.
Carcinogenicity: No ingredients trigger or classify under this category.
Reproductive toxicity: No ingredients trigger or classify under this category.
STOT-Single Exposure: No ingredients trigger or classify under this category.
STOT-repeated exposure: No ingredients trigger or classify under this category.
Aspiration hazard: No ingredients trigger or classify under this category.
Likely routes of exposure: Inhalation – Overexposure may cause headache.
Skin contact – not expected to cause irritation.
Eye contact – may cause minimal eye irritation.
Ingestion – May cause upset stomach.
Symptoms related to the physical, chemical and toxicological characteristics: no symptoms expected under typical use conditions.
Delayed and immediate effects and or chronic effects from short term exposure: no symptoms expected under typical use conditions.
Delayed and immediate effects and or chronic effects from long term exposure: headache, dry skin, or skin irritation may occur.
Interactive effects: Not known.
Section 12: ECOLOGICAL INFORMATION
Acute Ecotoxicity: Does not classify under the criteria of HSNO or GHS
Chronic Ecotoxicty: Does not classify under the criteria of HSNO or GHS
Page 3 of 5
Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner
Version No. 13406NZ-21A Date of Preparation: 29-April-2021 Supersedes: 18-October-2018
Meets requirements of Hazardous Substances (Safety Data Sheets) Notice 2017
Section 12: ECOLOGICAL INFORMATION - continued
Environmental Effect Levels: None
Aquatic Toxicity: Low, based on OECD 201, 202, 203 + Microtox: EC50 & IC50 ≥100 mg/L
Terrestrial Toxicity: Low, based on toxicology profile
Persistence and degradability: Readily Biodegradable per OECD 301D, Closed Bottle Test
Mobility: No data
Bioaccumulation: No data
Section 13: DISPOSAL CONSIDERATIONS
Unused Product: Deposit product in a landfill (if solidified), incinerator, or a sewage facility for treatment and disposal; or,
discharge product into the environment so that, after reasonable mixing, the concentration of the substance in
an environmental medium does not exceed any tolerable exposure limits.
Used Product: Used product may contain chemicals that will classify this waste as hazardous. Be sure to assess used product
contaminants. Deposit used product in a landfill (if solidified), incinerator, or a sewage facility for treatment and
disposal; or, discharge product into the environment so that, after reasonable mixing, the concentration of the
substance in an environmental medium does not exceed any tolerable exposure limits.
Contaminated objects : Rinseable-recyclable objects can be rinsed and offered for recycling or disposed of in landfills. Non-
rinseable objects should be disposed of to landfills.
Empty Containers: Triple-rinse with water and offer for recycling if available in your area.
Never dispose of used degreasing rinsates into lakes, streams, and open bodies of water or storm drains.
Section 14: TRANSPORT INFORMATION
NZTA: Not classified as dangerous good according to the Transport of Dangerous Goods on Land (NZS5433).
IMO / IDMG: Not classified as Dangerous
ICAO/ IATA: Not classified as Dangerous
ADR/RID: Not classified as Dangerous
U.N. Number None Allocated Proper Shipping Name: Cleaning Compound, Liquid NOI
DG Class None Allocated Marine Pollutant: No
Subsidiary Risks None Allocated HAZCHEM Code: None
Packing Group None Allocated Special Precautions for Users: None.
Section 15: REGULATORY INFORMATION
Group Standard Classification Cleaning Products (Subsidiary Hazard) HSNO HSR002530
Ingredient HSNO Approval Number
Water
Triethanolamine HSNO approval HSR002785
Ethoxylated Alcohol HSNO approval HSR003338
Quaternary Amine mixture Proprietary
Propylene Glycol n-butyl ether HSNO approval HSR001419
Tetrapotassium Pyrophosphate
Potassium Silicate HSNO approval HSR004068
Page 4 of 5
Safety Data Sheet: Extreme Simple Green® Aircraft & Precision Cleaner
Version No. 13406NZ-21A Date of Preparation: 29-April-2021 Supersedes: 18-October-2018
Meets requirements of Hazardous Substances (Safety Data Sheets) Notice 2017
Section 15: REGULATORY INFORMATION – continued
In accordance with CLEANING PRODUCTS (SUBSIDIARY HAZARD) GROUP STANDARD 2006, as amended 2010, the product label
need not meet the labeling requirements of this group standard if it complies with the relevant current labeling requirements of
Australia, USA or EU when it is imported.
NZIoC: All chemicals registered on New Zealand Inventory of Chemicals
Section 16: OTHER INFORMATION
Manufacturer’s Part Numbers
13405 – 20 Litre 13412 – 946 Milliiltre 13475 – 1041 Litre
13406 – 3.78 Litre 13455 – 208 Litre
Prepared / Revised By: CIPL Pty (2021) Ltd
Date of Preparation: 29-April-2021
Reason for Revision: Company information updated
DISCLAIMER: The information provided with this SDS is furnished in good faith and without warranty of any kind. Personnel handling this material must make
independent determinations of the suitability and completeness of information from all sources to assure proper use and disposal of this material and the safety and
health of employees and customers. Sunshine Makers, Inc. assumes no additional liability or responsibility resulting from the use of, or reliance on this information.
Page 5 of 5
