SENR4236-02

Component Location
June 2022 Harness And Wire Electrical Schematic Symbols
Component
Schematic
Location
Machine
Location
Component
Schematic
Location
Machine
Location
Symbols
Alarm - Backup D-9 1 Solenoid - Start Aid E-2 12
Alarm - Fault D-8 C Switch - Backup Alarm D-6 13
Alternator B-2 2 Switch - Blower A/C B-4 A T

Batteries E-5 3 Switch - Blower Heater A-3 A Pressure Temperature Level Flow Circuit Breaker
Breaker - Alternator E-7 E Switch - Disconnect E-4 14 Symbol Symbol Symbol Symbol Symbol
6
Breaker - Blower Motor E-6 E Switch - Dome Lamp A-7 D
Gauge - Engine Coolant Temp B-5 A Switch - Engine Coolant Temp (EMS) C-2 15 Symbols and Definitions
3 Gauge - Hydraulic Oil Temp A-5 A Switch - Engine Coolant Temp (S Aid) C-2 16
Fuse: A component in an electrical circuit that will open the circuit if too much current flows
14 Gauge - Power Train Temp B-5 A Switch - Engine Oil Pressure (EMS) C-2 17 through it.
Horns - Forward E-2 4 Switch - Engine Oil Pressure (S Aid) C-2 18
Meter - Service B-5 A Switch - Flood Lamp B-6 A Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
E circle indicates that the component has screw terminals and a wire can be disconnected from it.
Monitor - Operator (EMS) D-5 A Switch - Forward Horn A-5 B
Motor - Blower B-3 A Switch - Front & Dash Lamp B-6 A
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
14 Motor - Front Wiper C-4 D Switch - Front Wiper B-7 D No circle indicates that the wire cannot be disconnected from the component.
1 C
Motor - Left Wiper D-8 D Switch - Fuel Pressure (EMS) B-2 19

26 12 Motor - Rear Wiper C-8 D Switch - Hydraulic Oil Temp (EMS) A-6 20 Ground (Wired): This indicates that the component is connected to a grounded wire. The
21 13 grounded wire is fastened to the machine.
Motor - Right Wiper B-6 D Switch - Key Start C-6 A

17 4 Motor - Starter A-2 5 Switch - Left Wiper B-7 D

18 8 Ground (Case): This indicates that the component does not have a wire connected to ground.
7 6 Motor - Washer A-8 6 Switch - Neutral/Start Diff Steer D-7 21 It is grounded by being fastened to the machine.
15 16 A-3 A B-9 22
Motors - Blower Switch- Neutral/Start Direct Drive

D6H And D6H Series II Tractors

22 Relay - Main E-8 E Switch - Operator Monitor Test C-6 A Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
13 Relay - Start E-6 E Switch - Power Train Filter Pressure A-7 23
12
D

Electrical System
Resistor - Blower Motor Speed A/C A-4 A Switch - Power Train Filter Temp (EMS) B-3 24
A Sender: A component that is used with a temperature or pressure gauge. The sender
11 Resistor - Blower Motor Speed Heater A-3 A Switch - Power Train Oil Temp (EMS) B-3 25 measures the temperature or pressure. Its resistance changes to give an indication to
T
2 4 Resistor - Starter To Diagnostic Conn A-2 7 Switch - Rear Wiper B-8 D the gauge of the temperature or pressure.
Sender - Engine Coolant Temp B-2 8 Switch - Refrigerant A/C E-2 26
8 10 4RC2445-5499 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
Sender - Hydraulic Oil Temp A-6 9 Switch - Right Wiper B-8 D
24 6FC692-5499 It has a coil that makes an electromagnet when current flows through it. The
Sender - Power Train Oil Temp B-3 10 Switch - Start Aid C-6 A electromagnet can open or close the switch part of the relay.
10 8FC4000-5499
Solenoid - A/C Clutch B-2 11 Switch - Thermostat A/C B-4 A
25 5 11 1KD4000-5499
7 Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
B 5 3 A - COMPONENTS IN OPER COMPARTMENT - FRONT DASH 2KD4000-5499 coil that makes an electromagnet when current flows through it. The electromagnet
19
16
2 B - COMPONENTS IN OPER COMPARTMENT - RIGHT CONSOLE 3ED4000-5499 can open or close a valve or move a piece of metal that can do work.
1
9
C - COMPONENTS IN OPER COMPARTMENT - LEFT CONSOLE 3ZF1-5499
15
E - RELAY PANEL 4YF1-5499 Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
5HF1-5499 activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
6CF1-5499
the latch coil circuit open at the time the coil latches.
23 2TG525-5499
3YG1-5499 Harness and Wire Symbols
4GG1-5499
9
Off Machine Switch Specification Wire, Cable, or Harness Harness Identification Letter(s):
20 4LG935-5499
Part No. Function Actuate Deactuate Contact Position Assembly Identification: Includes (A, B, C, ..., AA, AB, AC, ...)
110.0 ± 2.8°C 101 .7°C MIN 1FJ482-5499 Harness Identification Letters and
Harness Connector Serialization Code:
9G1300 Hydraulic Oil Temp. (EMS) N.C. Harness Connector Serialization
(230 ± 5°F) (215°F MIN) 2DK1-5499 Codes (see sample).
The "C" stands for "Connector" and the
51.7 ± 2.8°C 43.0°C MIN number indicates which connector in the
9G3341 Power Train Oil Temp. (Filter) (EMS) N.C. AG-C4 L-C12 harness (C1, C2, C3, ...).
(125 ± 5°F) (110°F MIN) L-C12
107.2 ± 2.8°C 91.0°C MIN
111-7898 3E-5179 3E-5179
7N9785 Engine Coolant Temp. (EMS) N.C.
(225 ± 5°F) (1 96°F MIN) Part Number: for Connector Plug 1
37.8 ± 2.8°C 26.7°C MIN Part Number: for Connector Receptacle
8N1693 Engine Coolant Temp. (Start Aid) N.C.
(100 ± 5°F) (80°F MIN) 2
87.78 ± 2.8°C 79.44°C MIN 5A
3T0190 Hydraulic Oil Temperature (EMS) N.C. Plug
(190 ± 5°F) (175°F MIN) Receptacle Component
Pin or Socket Number Fuse (5 Amps) 9X-1123 Part Number
129.4 ± 2.8°C 118.3°C MIN
3T5825 Power Train Oil Temp. (EMS) N.C.
(265 ± 5°F) (245°F MIN) Deutsch connector: Typical representation
1 325-AG135 PK-14
MAX HYD 31 O3kPa FORCE 66.7 N of a Deutsch connector. The plug contains all
3T9343 Power Train Filter Bypass Pressure (EMS) N.O. 2 Harness identification code:
MAX BYPASS SPOOL MAX ACT 8.9 N sockets and the receptacle contains all pins.
Engine Oil Pressure (EMS) 62 ± 21 kPa 38 ± 21 kPa
For D6H Series II, See the included additional illustrations This example indicates wire group 325,
wire 135 in harness "AG".
Wire Gauge*
Wire Color
7T0988 N.O. Sure-Seal connector: Typical representation
Engine Oil Pressure (S. Meter) (9.0 ± 3.0 psi) (5.0 ± 3.0 psi) 1 *Wire gauge is shown in AWG (American Wire Gauge)
of a Sure-Seal connector. The plug and receptacle
9W3187 Fuel Pressure (EMS)
93 ± 21kPa 69 ± 21kPa
N.C. PUBLICATIONS.CAT.COM 2 contain both pins and sockets. but could also be shown in metric denoted with mm
(13.5 ± 3.0 psi) (10.0 ± 3.0 psi)
N.O. = NORMALLY OPEN NC. = NORMALLY CLOSED © 2022 Caterpillar. All Rights Reserved. CAT, CATERPILLAR, LET’S DO THE WORK, their respective logos, “Caterpillar Corporate Yellow”, the
“Power Edge” and Cat “Modern Hex” trade dress as well as corporate and product identity used herein, are trademarks of Caterpillar and may not
5 3 13 be used without permission.

16 REAR OF TRANSMISSION

TO KEY START SWITCH

Wire Description
Wire Wire Wire Wire
Description Description
Number Color Number Color TO KEY START SWITCH TO START RELAY
Power Circuits Monitoring Circuits (Continued)

306-GN

306-GN
101 RD BAT 410 WH OPR MON FAULT ALARM
TO START RELAY
102 BU HD LMP 411 PK OPR MON MASTER FAULT LAMP

306-GN

306-GN
105 BR KEY SW 413 BR OPR MON FUEL PRESS. W
A A A

1
2

1
2
108 BU AUX CKT 415 GN OPR MON TEST SW A 200-BK 1 200-BK TO FRAME GROUND
UU WW 321-BR 2 321-BR
109 OR ALT OUTPUT (+)TERM. 424 GY OPR MON POWER TRAIN TEMP BK/PK 1 200-BK TO FRAME GROUND UU WW 321-BR
A A BK/PK 2 321-BR TO BACK UP ALARM
112 PU MAIN POWER RELAY OUTPUT 426 BR OPR MON POWER TRAIN OIL FILTER

1
2

1
2
TO BACK UP ALARM BACKUP
12 11 113 OR OPR MON PANEL VMIS B+ SWITCHED 441 OR ENG COOLANT TEMP GAGE RR RR ALARM SW
9N1750
14 114 GN WARNING HORN (FORWARD) 442 GY HYD SYSTEM TEMP GAGE BACK UP
15 ALARM SW

307-OR

306-GN
2 4
116 BR AUX CKT 443 YL POWER TRAIN TEMP GAGE 7T8744
WW WW
8 10 307-OR
121 YL BACKUP ALARM TO LAMP Accessory Circuits
RR NEUTRAL
20 START SW

306-GN
123 WH AUX CKT 500 BR WIPER - FRONT (PARK) 306-GN
9W1581 NEUTRAL
124 GN A/C 501 GN WIPER - FRONT (LO) START SW
9 9N1750
4

(Dimensions: 39 inches x 24 inches)

1
3 1 13 14 Ground Circuits 502 OR WIPER - FRONT (HI) 306-GN 2 306-GN
6
200 BK MAIN CHASSIS 503 BR WIPER - REAR (PARK) UU WW
21
9 23 201 BK OPR MON PANEL VMIS CMS 504 YL WIPER - REAR (LO)
DIFF STEER
TILLER

SENR4236-02
203 BK CHASSIS DIAGNOSTIC 505 BU WIPER - REAR (HI)
D6H Series II With Power Shift And Differential Steering CONTROL
207 BK STARTER DIAGNOSTIC 510 YL WASHER - PRIMER Harness A is Part No. 8E0841.
Basic Machine Circuits 513 OR A/C COMPRESSOR/REFRIGERANT PRESS. SW
Harness UU is Part No. 8E3007. Connector Location
22 Harness WW is Part No. 8E1538.
REAR OF TRANSMISSION LEFT CONSOLE Harness And/Or Schematic
2 301 BU STARTER NO.1 SOL 515 GY BLOWER MOTOR (HI) Connector Ident.
1 15 Components Location
302 OR STARTER NO.1 RESISTOR TO DIAGNOSTIC 516 GN BLOWER MOTOR (MEDIUM)
7 6 16 A - 5G9497
8 304 WH STARTER RELAY NO.1 OUTPUT 517 BU BLOWER MOTOR (LO) 1 E-7
Diagnostic Connector
19 STARTER RELAY COIL TO NEUT START SW OR 20 CONTACTS
306 GN 521 YL A/C SW TO REFRIGERANT SW D6H Series II With Power Shift And Clutch/Brake Steering
KEY SW 2 A - 5G9497 D-5
Harness A is Part No. 8E0841.
Operator Monitor (EMS)
308 YL MAIN POWER RELAY COIL 522 WH A/C CLUTCH TO THERMOSTAT SW Harness RR is Part No. 3W9383.
310 PU START AID SW TO START AID SOL 523 BR WIPER - LEFT (PARK) G - 7T9222
10 CONTACTS 3 B-7
24 311 WH START AID SOL TO TEMP SW 524 BU WIPER - LEFT (LO) H - 7T9218
10
321 BR BCKP ALARM LAMP TRAVEL ALARM 525 GY WIPER - LEFT (HI) A - 5G9497
25 9 CONTACTS 4 D-6
322 GY WARNING HORN (FORWARD) 526 YL WIPER - RIGHT (PARK) C - 7T8326

Monitoring Circuits 527 GN WIPER - RIGHT (LO) G - 7T9222

TO KEY START SWITCH 8 CONTACTS 5 B-8
400 GN SERVICE METER SW 528 PK WIPER - RIGHT (HI) H - 7T9218
17 18 12
403 GN ALTERNATOR (R)TERM. Lighting Circuits A - 5G9497
6

20 Page,
TO START RELAY D-3
7 5 26 11 B - 6T6074
404 YL OPR MON HYD OIL TEMP 600 BR DASH LAMP BASIC 7 CONTACTS

307-OR

306-GN
405 GY OPR MON OIL PRESS. (LO SETTING) 608 GN FLOOD LAMP - REAR A - 5G9497
7 C-3
406 PU OPR MON COOLANT TEMP 609 YL FLOOD LAMP - SIDE B - 6T6074

610 OR HEAD LAMP BASIC A - 5G9497

A A
8 C-5
C - 7T8326

1
2

1
2
A
T T BK/PK 200-BK TO FRAME GROUND A - 5G9497
BK/PK
1
2 321-BR
9 A-6
E - 3W4902
TO BACK UP ALARM
10 A - 5G9497 B-4
M - 3T7147
NEUTRAL
START SW BACKUP A - 5G9497
9P9520 ALARM SW 11 C-3
7T8744 N - 9W1816

306-GN 306-GN A - 5G9497

4 CONTACTS 12 A-3
T W - 6Y3416
LEFT CONSOLE G - 7T9222
13 Front Wiper Motor
C-4

G - 7T9222
14 Left Wiper Motor
D-8
REAR OF TRANSMISSION
D6H Series II With Direct Drive And Clutch/Brake Steering G - 7T9222 B-6
Harness A is Part No. 8E0841. 15 Right Wiper Motor
HARNESS CONNECTOR AND COMPONENT LOCATIONS Harness T is Part No. 3T8636.
16 J - 3T6373
Rear Wiper Motor
C-8
 TERMINAL BLOCK
6T0751

109-OR-6 RD-OO

AA BK-OO BB BK-OO
CC
POS NEG POS NEG
(14) DISCONNECT SW

203-BK
7N0718
12V BATTERY
RELAY PANEL 12V BATTERY
3T5760 STD 3T5760 STD
9G4247 ATCH 9G4247 ATCH

BK-OO
(3) BATTERIES
304-WH
DD
12 112-PU 112-PU-14 124-GN-14 203-BK
20A (26) REFRIGERANT SW
8 308-YL (E) BLOWER MOTOR 311-WH
203-BK 109-OR-6 304-WH-8 TO FRAME (NOTE A)
3 BREAKER 310-PU 9D6888
11 311-WH (E) START RELAY
124-GN-14

DIAGNOSTIC CONNECTOR
310-PU 9F3099 3T8728
10 306-GN 306-GN
2 302-OR 308-YL-14
7 207-BK 200-BK
308-YL-14 105-BR-14
4 304-WH 102-BU-14 (4) FORWARD HEAD LAMP

322-GY
513-OR-14
20 HORN

521-YL-14
8C5512

610-OR-14
FLOOD LAMP 19 302-OR 7T0970 2S4788
18 207-BK (OROPS ONLY)
8C5582 306-GN
6 304-WH-8
1M1882 112-PU-14 105-BR 105-BR-14
5 101-RD-6
(OROPS ONLY)
17
109-OR-6
112-PU 109-OR-6 16 KEY (12) START AID
15 FUSE SOLENOID
109-OR-6 14 9G4365 NN

10A
3K8782 (4) FORWARD

102-BU-14
308-YL 200-BK

200-BK

1
2
13
308-YL 1 101-RD 200-BK HORN
9 200-BK-14 200-BK-14 7T0969 D

112-PU-14
112-PU-14
112-PU-14
112-PU-14
112-PU-14
112-PU-14
(E) MAIN RELAY
3T0376 112-PU-14 114-GN
10A FORWARD HORN 114-GN

101-RD-14
(REPLACES TERMINAL

BK-18
BK-18
FRONT 121-YL
BLOCK AT F-6 WHEN

109-OR
(E) ALT 116-BR-14

10A
LOAD CURRENT EXCEEDS DASH 112-PU-14 10A BACK-UP ALARM 121-YL
BREAKER 113-OR
10 AMPS) DOME
608-GN-14

123-WH
9S0173 FUSE NOTE D

1
2
112-PU-14 10A SIDE & REAR FLOOD LAMPS 116-BR-14 108-BU-14
3K8782 410-WH
B

610-OR-14
101-RD-14 112-PU-14 10A 113-OR 201-BK
60A OPERATOR MONITOR

322-GY
321-BR

200-BK
311-WH
101-RD-6

310-PU
RELAY PANEL
112-PU-14 123-WH

113-OR
10A GAGES & SERVICE METER

410-WH

201-BK
123-WH
200-BK-14
108-BU-14
116-BR-14

114-GN
121-YL
321-BR
109-OR-6
112-PU-14 15A WIPER MOTORS 108-BU-14 D
FUSE HOLDER

1
2
FUSE

3
4K5122 NOTE C
B

521-YL-14
RELAY PANEL 108-BU-14 322-GY
116-BR-14 306-GN 610-OR-14
102-BU-14 102-BU-14
105-BR-14 105-BR-14
308-YL-14 308-YL-14
306-GN 124-GN-14
310-PU 310-PU
610-OR-14 311-WH
608-GN-14

A B
OPERATOR STATION OPERATOR STATION 200-BK 6
KK A 311-WH 2
BK-14 2 310-PU 3
BK/PK-14 (21) NEUTRAL/ 610-OR-14
1 7
START SW A 201-BK
521-YL-14 1
(1) BACKUP ALARM
321-BR

522-WH-14
121-YL

(D) LEFT WIPER (DIFF STEER ONLY) 200-BK A 4

3T1815 BK/PK 1
6T5856 9W1581 322-GY 5
BK/PK 2 321-BR ALARM 10 410-WH
410-WH
201-BK

L + BATTERY 1 113-OR
H 16
MOTOR 20
G (13) BACK UP 9
A T
GN 1 ALARM SW
1
2

12 201-BK
GY 3 7T8744
OPERATOR STATION

14 201-BK
BR 4

306-GN
306-GN

522-WH-14
201-BK

513-OR-14

610-OR-14
(A) OPERATOR GROUND 2
RD

OR
BK

2 MONITOR
G A 8 201-BK
3T9100
1 102-BU-14 18 201-BK
2 108-BU-14 108-BU-14
19 201-BK
525-GN-14
523-BR-14
108-BU-14
524-BU-14

102-BU-14 102-BU-14 PWR TN FLTR 17 426-BR

1
116-BR-14 8 116-BR-14 COOL TEMP 6 406-PU
(C) FAULT ALARM 610-OR-14 4 610-OR-14 ENG OIL PR 5 405-GY
608-GN-14 5 608-GN-14
9G9813 609-YL-14 FUEL PR 13 413-BR
9

RD-OO
105-BR 2 105-BR-14 ALTERNATOR 3 403-GN
306-GN 6 306-GN
HYD TEMP 4 404-YL

200-BK
308-YL 3 308-YL-14

608-GN-14
200-BK-14
310-PU 7 310-PU PWR TN TEMP 7 424-GY

306-GN
442-GY

322-GY
114-GN
426-BR

321-BR
201-BK
404-YL

121-YL
C A LAMP 11 411-PK
TEST 15 415-GN

201-BK 415-GN

(A) OPERATOR MONITOR 200-BK-14 403-GN 2

200-BK-14 405-GY

415-GN

201-BK
200-BK
4

411-PK

311-WH
311-WH

400-GN

441-OR
403-GN
405-GY
406-PU

413-BR
201-BK
TEST SW

200-BK
413-BR 7
7N8001
200-BK 406-PU 6

201-BK
400-GN 3
441-OR 5
A 201-BK 1 (16) COOLANT SW

1
4
3
2
MASTER 8N1693
200-BK-8 A B
FAULT
BASE LAMP C 200-BK 200-BK-14
3T0304 7N1996 T
MODULE
411-PK GROUND

201-BK

A B
123-WH 109-OR-6
WIRE GROUP COLOR DESCRIPTIONS
OPERATOR STATION

442-GY 101-OR-6
400-GN
(A) START AID SW 302-OR GROUND CIRCUIT
441-OR 207-BK
3T3453
MM 443-YL 304-WH-8 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
1
2

310-PU 308-YL WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
A (18) ENGINE
R STARTING CIRCUIT
308-YL OIL SW
7T0988 START AID CIRCUIT
608-GN-14

C OFF

304-WH-8
MONITOR CIRCUIT

200-BK-8
200-BK
S ON

302-OR
207-BK
306-GN B ST
105-BR PANEL LAMP CIRCUIT
321-BR
(D) FRONT WIPER
(17) ENGINE
GAUGE CIRCUIT
121-YL (A) KEY START SW
102-BU-14
108-BU-14

6T6216
9G7641 OIL SW AIR CONDITIONER CIRCUIT
608-GN-14 L 7T0988
200-BK-14 WIPER/WASHER CIRCUIT
306-GN MOTOR
A OTHER COLOR DESCRIPTIONS

1
T

2
4
3
(D) REAR WIPER
306-GN 201-BK
GN HIGHWAYS

RD-00
6T6216 501-GN-14 1
N

610-OR-14
108-BU-14 3 GY T

441-OR
403-GN
OPERATOR STATION

413-BR
201-BK

522-WH-14
500-BR-14 BR

513-OR-14
L 4
608-GN-14
200-BK-14

502-OR-14 OR (15) COOLANT SW

2

522-WH-14
124-GN-14

200-BK-14
7N9785

521-YL-14
H
WITH POWER SHIFT MOTOR
PANEL LAMP G CALLOUT FORMAT IF APPLICABLE
7N9967
CONNECT PLUG A TO A A
J (19) FUEL SW Callout Number Component

1
1
RECEPTACLE A.

2
2
3
T
GN 1
9W3187 (Machine Location from (52) VALVE GP - CONTROL Name
GY 3 F P Component Locations Table)
A WITH DIRECT DRIVE BR 4
BASE
7G9730
138-1234 Part Number

600-BR
200-BK
1
2

OR 2

424-GY
CONNECT WIRE AS. T

201-BK
443-YL
102-BU-14

426-BR
201-BK
TO HARNESS AS. A 600-BR M
102-BU-14

2 1
C
SYMBOL DESCRIPTION ABBREV COLOR
WITH DIFF STEER
CONNECT WIRE AS. RR (24) POWER TRAIN (8) COOLANT SENDER CIRCUIT CONNECTED RD RED
505-BU-14
503-BR-14
108-BU-14
504-YL-14

4 FILTER SW 6N5926
TO HARNESS AS. A 610-OR-14 OPERATOR MONITOR
5 9G3341 WH WHITE
A A PANEL MOUNTING BOLT CIRCUIT NOT CONNECTED
522-WH-14
1

(A) FRONT &

2

T
OR ORANGE
ELECTRICAL CONNECTION TO

123-WH
DASH

441-OR
400-GN

442-GY

443-YL
LAMP SW BK-14 MACHINE STRUCTURE
YL YELLOW
1

1
2

7N805 (25) POWER TRAIN

(A) BLOWER INTERNAL ELECTRICAL CONNECTION
116-BR-14

610-OR
MOTOR OIL SW
RR T T RR 9G8697 3T5825 TO SURFACE OF COMPONENT PK PINK
200-BK-14
306-GN

306-GN
306-GN

306-GN

600-BR
200-BK
201-BK
CONNECTOR BK BLACK
G G T
A (11) AIR CONDITIONER
10
1
6
4
7
8
3
5

WH/RD-14 GY GRAY
7
6
5
4
3
2
1
9
8

T CLUTCH SOLENOID H# CIRCUIT GROUPING DESIGNATION

1
4

2
3
H H 608-GN-14 424-GY 7N4287
M (A) THERMOSTAT SW PU PURPLE
PANEL LAMP
609-YL-14 ATCH WIRE, CABLE, COMPONENT

1
(A) POWERTRAIN

2
K (A) FLOOD 7N9967 9P3498
501-GN-14

108-BU-14
527-GN-14

502-OR-14
500-BR-14
523-BR-14
108-BU-14
102-BU-14
108-BU-14

525-GY-14
528-PK-14

(22) NEUTRAL/
524-BU-14

BR BROWN
526-YL-14

108-BU-14

TEMP GAGE (10) POWERTRAIN R ALT +

(Dimensions: 39 inches x 24 inches)

START SW LAMP SW BASE N OIL SENDER

443-YL
4W0485 / SPLICE
7N8000 (2) ALTERNATOR
116-BR-14

8N3844

610-OR
9P9520 NOTE D 7G9730 GN GREEN
200-BK-14

124-GN-14
H

521-YL-14
610-OR 443-YL 5S9088 STD
200-BK-14 BLADE, SPADE, RING OR SCREW
D BU BLUE
306-GN C Q IGN (A) BLOWER SW T HH TERMINAL

304-WH-8
515-GY-14

1
2
306-GN

302-OR
200-BK-8
Q BK-6

207-BK
306-GN SEND 6P3236
SENR4236-02

N NN

1
2
NOTE D LAMP

610-OR-14
GRD
510-YL-14
510-YL-14

(A) SERVICE METER

6T7337 5D0019 109-OR-6 IDENT PART NO. CHG
1 HARNESS AS.
WH/RD-14 A

441-OR
400-GN (A) COOLANT 5G9497 01

610-OR
RED
L H L H L H L H TEMP GAGE 2 B 6T6074 07
4W0483 BLK (A) BLOWER C 7T8326 02
(D) RIGHT WIPER IGN 5 MOTOR 9G8693 D 5G9496 00
123-WH Q BLU
P
B
P P P
B
6T5855 SEND 4 E 3W4902 02
527-GN-14

B B
108-BU-14
528-PK-14
526-YL-14

W B W B W B B
GRN F 3T8624 02
W

200-BK
L OR BK-14 G
LAMP 7T9222 00
GRD 3 H
H 5D0019 OROPS 7T9218 00
K MOTOR J
HEATER 3T6373 01

516-GN-14

101-RD-6
517-BU-14
(D) REAR WIPER SW

515-GY-14
515-GY-14
G
1

(D) RIGHT WIPER SW

2

302-OR
(D) LEFT WIPER SW (D) FRONT WIPER SW 7T0303 02
3T6655 T HEAD
3T6655 3T6655 3T6655 GN M 3T7147 02

123-WH
123-WH
442-GY
L 1 (B) FORWARD HORN SW (7) RESISTOR LAMP
3 GY A 6T2217 A N 9W1816 02
3T2357 8C5511

4
2

3
4 BR BK-14 1 2S4787 P 6T2934 01
(A) HYDRAULIC
OR U

123-WH
2 W 2 (OROPS ONLY) 5G9494 00
(A) BLOWER

610-OR
108-BU-14 108-BU-14 108-BU-14 TEMP GAGE
108-BU-14 DOME LAMP 9G8697 W 6Y3416 00
4W0484

301-BU
510-YL-14 510-YL-14 510-YL-14 MOTOR X 7X2041 00

124-GN-14

200-BK-14
7X6398
IGN
322-GY
114-GN

510-YL-14 Q (A) RESISTOR

304-WH-8
SEND WIRE AS.
GG 9G1950
LAMP WH/RD-14 K 3T7983 03
102-BU-14 102-BU-14 5D0019 Q 9W3623 00
GRD
Do not operate or work on this product unless you have T

RD-OO
(D) DOME LAMP SW 3T8636 03
20 Page,

7N8000 read and understood the instruction and warnings in the GG 9G7285 01

2
1
W HH
G S 4D6565 01
relevant Operation and Maintenance Manuals and

1
2
X JJ 9F4337 07
OPERATOR STATION OPERATOR STATION X MTR BAT
relevant service literature. Failure to follow the instruc- KK 9G6259 02
200-BK-14 (5) STARTER tions or heed the warnings could result in injury or MM 5G9493 00
510-YL-14 4N3181 STD death. Proper care is your responsibility. NN 5G9492 01

515-GY-14
3T8946 ATCH MOTOR RR 3W9383 00
200-BK-14 - MOTOR +
322-GY

124-GN-14
114-GN CABLE AS.
(6) WASHER 200-BK-14 AA 5G8921 01
7T8891 608-GN-14 (A) BLOWER SW
200-BK-14

BB 9V2098 01

BK-OO
306-GN
608-GN-14

1V6652 BB 3P2179 03

BK-6
321-BR
(9) HYDRAULIC 121-YL 515-GY-14 UNLESS OTHERWISE SPECIFIED ALL WIRE IS 16 GAGE CC 8S1078 01
SENDER 442-GY 1 442-GY (A) RESISTOR DD 3P2182 03
(23) POWERTRAIN 517-BU-14
8N3844 404-YL 2 404-YL 2G4013 NOTE A: NORMALLY OPEN BEFORE REFRIGERANT CHARGE EE 7P6682 01
FILTER SW T
201-BK 3 201-BK NOTE B: NORMALLY OPEN BEFORE INSTALLATION
(NOTE B) TO ENG
426-BR 4 426-BR EE JJ NOTE C: FUSES 10A - 3K8782 15A - 8M8948
3T9343 201-BK TO FRAME BLK
NOTE D: TERMINAL NOT USED FOR THIS VEHICLE
T E A
TO FUEL TANK (20) HYDRAULIC SW
9G1300
3T0190 THIS SCHEMATIC IS FOR THE D6H AND D6H SERIES II TRACTORS ELECTRICAL SYSTEM
(DIFF STER ONLY)

FLOOD LAMP MEDIA NUMBER: SENR4236-02

8C5582
1M1882
(OROPS ONLY) SCHEMATIC PART NUMBER: 6T-3295, CHANGE: 04, VERSION: -
306-GN 306-GN
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
Refer to the Parts Manual using a specific serial number prefix in SIS before ordering parts from this schematic.