0% found this document useful (0 votes)
711 views11 pagesSuburban - Water Heater Model SW12D, SW12DE, SW12DEM, SW16D, SW16DE, SW16DEM Operation Manual
Suburban RV hot water heater manual
Uploaded by
Heather Stephanie SchweitzerCopyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF or read online on Scribd
0% found this document useful (0 votes)
711 views11 pagesSuburban - Water Heater Model SW12D, SW12DE, SW12DEM, SW16D, SW16DE, SW16DEM Operation Manual
Suburban RV hot water heater manual
Uploaded by
Heather Stephanie SchweitzerCopyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF or read online on Scribd
/ 11
INSTALLATION AND OPERATION MANUAL
ser DIRECT VENT
GAS WATER HEATER
DIRECT SPARK IGNITION (DSI)
Se) MODELS
SW12D @ SW12DE eSW12DEM
SW16D © SW16DE @ SW16DEM
FOR INSTALLATION IN RECREATIONAL
VEHICLES AND MOBILE HOUSING
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
© DO NOT TRY TO LIGHT ANY APPLIANCE.
@ DO NOT TOUCH ANY ELECTRIC SWITCH: DO NOT USE ANY PHONE IN YOUR
VEHICLE.
IMMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR'S PHONE. FOLLOW
THE GAS SUPPLIER'S INSTRUCTIONS.
IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT.
FREEZE WARNING
DRAIN HEATER IF SUBJECT TO FREEZING TEMPERATURES.
WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR
MAINTENANCE GAN CAUSE !NJURY OR PROPERTY DAMAGE. REFER TO THIS MANUAL.
FOR ASSISTANCE OR ADDITIONAL INFORMATION, CONSULT A QUALIFIED INSTALLER,
SERVICE AGENCY OR THE GAS SUPPLIER,
FOR YOUR SAFETY
DO NOT STORE OR USE GASOLINE OR OTHER COMBUSTIBLE MATERIALS OR LIQUIDS
NEAR OR ADJACENT TO THIS HEATER OR ANY OTHER APPLIANCE, THIS APPLIANCE.
SHALL NOT BE INSTALLED IN ANY LOCATION WHERE FLAMMAGLE LIQUIDS OR VAPORS
ARE LIKELY TO BE PRESENT.
AN ODORANT IS ADDE:, TO THE GAS USED BY THIS WATER HEATER
INSTALLER: AFFIX THESE INSTRUCTIONS TO OR ADJACENT TO WATER HEATER,
OWNER: RETAIN THESE INSTRUCTIONS AND WARRANTY FOR FUTURE REFERENCE.
ALL TECHNICAL AND WARRANTY QUESTIONS SHOULO 8E DIRECTED TO THE COMPANY
LISTED ON THE WARRANTY, OR RATING PLATE WHICH CAME WITH YOUR WATER HEATER.
Suburban rae erepr tee
Manufacturing Company boytor, Tonneseao 321
sano ARBEE t ere nia
rox a2s 70018 INSTALLATION REQUIREMENTS
WARNING! nstalation this appliance must be made n accordance with
the writen instructions provided inthis manual No agent representative
or employee of Suburben or ther person has the ator Yo change
reaity or waive any provision of the Instructlons contained In ths
mania
‘CAUTION: possible, do not inal the water heater fo where the vont. can
be covered of obstructed wien ay door on the Wale fs opened. thse
ible, then the travel of be door must be reacted In order to
provides trnmmomclesrance between te water Reser von ana 309 Soar
‘whenever the doors opened,
CAUTION: Due to he aiferences in vinyl sing, tis appliance should not
Beata vig sing wut rat consulng whe maufactrerf
the ing x ctng the ig away fom the ate round the appance
‘CAUTION: In any installation in which the vent ofthis appliance can be
overedue tohe constuction af he RV or some special feature of the RY
‘Sch as slide ot popup ete, always insure thatthe appliance cannot be
‘Spud sting hernia to he poate FF positon and
Shatig off al electieal and ges suppl tothe appliance.
‘CAUTION: Do not instal this appance to where the vent terminates below
S tlie-out This appliance ls ncto be installa under any overang must
Be oe and clear oF any type overhang.
“ng intaaion must conor wh the requremerts ofthe auton navng
Juetcton orm ba sosenca of such rquremerts rh he awe eaton of he
asonl fuel Goo Code Ant 2223 ana be stat eaton ofthe Amerean
Nasonal Standard fer Reroalorl VenciesS0%C. Im Canad Ne Iason
how canter wh he flowing ansarde
|. Forirstalaionin Recrestoral Veni
4 Gas CSA standard CSA 2240.42 netalsbon Requcemens fr Propane
-Appisnens one Equpmenin Raceaons Vehies
2, Clete CSA sandr C222 No. 1487224052 Eletial Roquremants
tor Rocrestons! Vendles,
2, Plumbing = CSA standard CSA 2240.2 Plumbing Requirements fr
Recreatona Yhies
. Foristataton in Maile Housing
4. Gas CSA stands CSA 2240.41 instalation Recirements for as
Buin Appliances and Eaupmentn Mable Homes.
2, Elecical “CSA stnderd CSA C22 1 Canadian Elecrcl Coxe Pat.
3, Plumbing CSA stansardCSA 224031 Pumbing RequemertsforMetle
‘Tha appance al be daconneced tom me ges suply pag system dng
any ores esog cf he syste
The applance and ts gas conoactons shat be atk tested! before placig the
2pplatbe nope
[A ate combustion must ba supplied fom oun the suse At fr
‘Combustion must not be supped rom ocrped spaces
INSTALLATION INSTRUCTIONS
aim exarane tom combustbe consusion 9 es, tp, Soe and
fart inches Prewe rumor acess ter of eater Sein
Prowse an opening hush ern cute allot coach s shown Well ofcoach
Shouse amas se snow n gure Main ae amerators sted Seow
Botton cant nes a capt cea ata ot won st
‘Stay carpet fom neo Tanai
INSTALLATION USING FLUSH MOUNT FRAME & DOOR
S00 Figure 2 for luster)
{A Poston hese ino ramedepening as ust Sie unt opening unt
‘hea athe conv nove ash win he entre cosa sk.
INNER COACH WALL
TE
16 yet
Hehe
Figure +
8, Secure te contl reusing the coach wa (ames opening a he op are
seta sn ra.ang compare sing Sen o er stab asters
Fecess ne sem or ener back ar eth fom ie rt edpe conta
rowan apeonmaty 11/2) morgeta eae fangecn Sor or, T Soo
tare enc ta, must oor om erew rcerenner haa Fee
{Sine wallcinecs hot pounbe secure wter nese witout coreg
the vasener head wth he Sect ame, te mporant not over tgrion De
{tener and asthe cotalheusng. Ger ghtewngct etasorer may cauce
water heater eats Belwcen ta corti hour and door fame
NOTE: Cauk sound sre or fasiene ead oar water ght oa
6. fst ences, oe on cn ce fw eat, as ure in gue A
1. Onmess or yode pe scewals,taten he wal atea around the openieg
. Caulk arcu raed open ater kn as lustated
F. Gas rarer tare ig 2 beads ot sicnecauking uate
‘uke one on fange to sea eco hawsing and one curd ack ste of
fame't seat marnn (See Seman tisaon)
6, inset dcr rae it conte! Peusng ane secure wth four (4) No. 845.
Si hews ones
H. Totnsta door, ace he wo oles e baton ofthe dor over he doors
hte ame, Clue te dorsi teach proves Proust be
Soar "Tum ich 20 dees fo fasten doo
1 The module board on modes SW120, SW16D and SW120E, SWI5DE int
ered ihe water neta Fis be pomanerty eure he stair
“The module ard must be mounted here t's access Bef: servcn yt out
afwaycfenicen tau be ocnesina ace were t carole uneced ©
‘rostirecesing hemes, nate opr and Kags
Te tard an at ing oe oat us be preted ore prevent
{hturie wth to @) No 6.38 sews or oer sutabe Noavare.
MAKING WATER CONNECTIONS.
‘A Water comectan are made st ne rea of ba nator eal. Roe Fue
‘itisoceisosce SVTaDEM. SWISCEM For SHTSDEM SWEDEN tr
ib Figue 8. Comet ine ot and cols water Ine ote 1/2 female Bp ting
Brovced en raft. These ings e mated HOT and ‘COLB” NOTE
FRovercacndtirg a ese fe ta purpose toerhance wal rculbon,
Do NOT REMOVE PLASTIC FILL TUBE.
IVPORTANT: Use a pipe tread compound sutobe for potable water er pce
{ead tape on a comnecsos fo ache ey wi ot ak
1. Farease ofremoval. tis sugpestedthatapipe unionbeirtalledin gach water
{CF tank vi mater Open both Not and old wats faucots fo expla tom
{Shc When lars led ar woter fons fom ove, cee bth faucets Sod
eck al connorions or aks
‘CAUTION: you uso ar proscurto check or leaks, the pressure must not
Gneeed a0 Poi tn accordance with £9.1 oF ANSI AVE,
NOTE: Afro tstng, dan water fom an
MAKING GAS CONNECTIONS,
[A Connect 21 g38 sree ne 3 ae fitng st ga wave lcatdin be
Corteinouing. When mana tie gan conection ralnegasitngon De vs
‘itv mreehinen tens he ave nok Fire e hols tg secure could
Tesul i's gas ak co ong eng comeged NOTE Rw 9 neces
‘Shove fe grommet om the contol hous rake Be gas connecon a Pe
ate en mina gemma
[WARNING is imperative that grommet and ge Ine through grommet be
evutked si ight W not tight seals metatre an potential Rar! Roe
reuets coula vent through opening and int ang are of alr (See
Figure 3)
2, Turnon ga and onack a ings and cormectons er leaks using a soap and
‘ater sluson, Covet oven he sightet leak medal
[WARNING! Do not use an open flame to check fr teak
WATER HEATER AS VIEW FROM INSIDE Rw.
£0 OPENING
LouR
Figure 18 MAKING ELECTRICAL CONNECTIONS.
12 VOLTS D.C.
‘A Replicabl to olowng models: S120, SW1ED, SWI20E, SWEDE,
SwiZOEM ane Swi
Refer to Flgue 2 fr locaton of D.C. ncton tox on models SW120.
SWi60.SWI2DE and SWISDE Refer oHaure for locabanof B.C. uncbon
Boxon moselSWvi2DEM or SWieDENt
C. Theelecies connectors mustbe mageinaccoréance it oval cages ant
Feguatons. nthe absence o lea codes ond veqatons, eer te blest
‘hon of he National Eectieal Cade ANSINFPA No 7,
In Canada, the electrical istaiaton shoud confor wth CSA standard CSA
(6227 No’ iaai2249 62 Ecol Requreronts or Recreational Voce
(G5a. C221 Canadan Elecreal Coe Part t amen Petsling he unt
‘eorestonal vanes na mobie name respec
. Make me 12 Vor D.C. eleceat conneconsflloang the wing agra
‘tuted n Figure” ae AEE
ite power supys tobe tom aconvena, we recommend bat he converte
ftom be wired ih paral wih the batery Thc wil swe bo purposes
4. Provides constant votage svpoHy
2 Ftreny AC. spkes ovel surges
we reconmend insted trminal ba usd al elece! connections
2V.56. ONLY
TF ANY OF THE ORIGNAL WIRE AS SUPPUED WITH THE WATER
HEATER MUST BE REPLACED. IT MUST BE REPLACED WITH 18,
| tos'c WIRE OR ITS EGUVALENT.
; (— cron anc)
3 (Tet wrest
| DISCONNECT POWER SUPPLY GEFORE SERVICING THERMOSTAT
[ANS HLLMIT UNDER ACCESS COVER.
CAUTION: 00 NOT HL-POT (OIELEC TIC HIGH VOLTAGE TES THIS
UNITAFTER INSTALLATION. TO 00 SO MAY CAUSE COMPONENT
DAMAGE AND VOIDS WARRANTY OF WATER HEATER.
10861
Figue7
MAKING ELECTRICAL CONNECTIONS.
120 VOLTS AC.
‘A Applicable to foning models SWIZOE, SWIBDE, SWI2DEM and
1B, Reter 0 Foue 2 for lcafon of AC. jncton box on mals SW/120E of
'SWiebe. Rotr'o Figue 3 for AC funsson box oo moses SWT2OEM or
Wisden,
Cc. Thesecincalconnctons mustbemace nsccortance wilocalcaget an
Feguaters. ne aoseroe of local codes ana equation, etre le!
‘aon of he Nationa locie’ Code ANSINFPA No 70,
In Canada, he egciealnetason shoud cerform ith CSA standard CSA
(Gea No 42/2200 62 Elciea requremen fr Recreional Vanes and
ESk.C24% Conadan Eectical Cade Pan | wron inating the unt
Tesresoral vances ans mobie noms respect.
, Check tng pate and ie dagram (Faure 8) aloe proceeing nts
2 isos softy rch orev beater of aaeauste capac Sebween heat
Src lect! power sure. Alach ne lck ae wate nes form te ed
Schr breaker tocarespondingcokredwresinnoat! ureter box Arey
tare fom a wol iounded source Musi be aached fo the groan tf the
‘CAUTION: Before appyingtne 120 VAC powertothe watereaterjunction
box, be sure the snitch for elect leant isin the OFF" poston,
WARNING! Before the onion forthe cists coments tumnedtote"ON
positon, the nator beater tank must be filed win water See “Stay
Fiamings
VAC OMY
‘DISCONNECT POWER SUPPLY BEFORE REMOVING COVER
a BK
ewes Le. ox]
oe crownone screw ELEMENT
Be REPLACED, IT MUST BE REPLACED WITH 14 GA. "05°C WIRE OR_TS|
EQUUALENT.
‘SUN Obs FS ELECTIOUES LWRES AVECTE CHAUFEEAUOOT —]
[ETRE REMPLACE. UTILISER A CET EFFET UNF. 14 GA. 105° OU
INSTALLATION OF MOTOR AID HEAT EXCHANGER,
1A. Place copper "Y' in eater ss shown Figue
B. Secure hess 10's win hee camps.
Catach hse tom mots neat excnangerto Ye
. Seo hess lo moter-sié and Y's win amps
. Check a conectons for wae aks and pepe war crust troush
rota heat exchange, wi engre "ung.
“The system shoud be checked snaby fr deterioration of heats hove and
fase nnectons Replace os necsea,
ES
waren
HEATER 2
fLOIIrirn a
Loor
6
HEAT ExcHANGER
cou.
Figur 8
MAINTENANCE
[WARNING Fhe user of his aplancs fal to maniain Kin the condition
Inutnen rt ehippe tram te factory ore appuance ie not used
sblely for te intended purpose or f oplance is not maintained |
[Secordance with tho inertons inthe manual, then the rik off
cior the, production of carvon Monenida exists whieh can caUss|
personal inary, property damage o Toss of
[WARNING: Foryour safety, alrpaire shouldbe porlormedby your dealer]
[ora quale service person,
{Win Bure Do not aw the burner fo burn wh yotow Tame because
Scctng wl oss" (See Sey Warnes)
tthe burner tmeisylow anc has aneratic pater, sutunt coun and contact
5 busied server agency Ds rer cartnuecperng unt wh prope Sure!
Fae "Sou igure 1 ore and ncorec amet Fame appearance) '. Peredicaby inspect nt for otf soot present ayer cn water hee,
Irimediatly shatunit down andeantat our cea ra quaifed sence peraon
‘Satis sgh ol campetecmbeston and must be corecesbeoreaprahag
waterhester Aves o eck woud nude
1. Cheek eran cbs ber or Mu bo.
2, Check te screen ne dor ose ttt ro forign matarilhas accumulated
fe revem sow of combuston aed voriaing a
3. Check tobe suremerelen tare present turer ator burner whenever
mmomgss ave coses The canbe checked by tung tne OPFON such
Tre OeF poston Pa
.Froquert checks enould te made ofthe grommet on he gas net to ae8u6
{gm seat (Gee" Malang Gas Connections)
D.Peredienty check wing ane wie cernecten 19 be sue wins i nat
damagedtayed and that el terns and cernectors ave taht and
‘omplance mt cades (See Msking Wee Connectors)
‘SAFETY WARNINGS
[WARWING! Ris imperative tat he wter neater tank be ited wth water
before operating the woler Rear: Operation ofthe water heater without
water ne tank may result n damoge toe tank endor contol. This
[pe of eamage ls nat covered by the ied warranty.
[WARNING! Hyarogen gas may result you Rave not used the heater for]
tv wooks or mort HYDROGEN GAS 16 EXTREMELY FLAMMABLE To
feds tha nak otnjuy undartresesontions, open the et water sues
eee min te cer sin eee Yu ear eta
probebly wil near an uncevsl sound such se a escaping through te
pipe bathe water begin to fw.
Hydrogen gas maybe present even afer water hasbeen drained rom the
tank Ope faucet a sink and allow system to vont for several mites
famines).
00 not smoke or have any open fame near the open faucet. Do net
Stomp to ight pit or man burmerOn DS! modes, be sure the ste
[Should overheating occur or the gas supply fale shut of shut of te]
onualgaevalvetathe applanceteloreshuting Mine elecal soppy
Bo not use this appliance if any part has been submerged under water
rnmedatay cain quaifed sarce technician to napect the appliance
atrelace any par ofthe conte system and any gos contra at hes
eon submerged under water.
for RV products which we 60 not recommend: Fer your
only fetory authorized pars are to be used on your water Heater,
Perioaicayinapectina vento obtracons or provence of aoct Soot]
formed whenever combustion Incompet, This is Your visual warning
tnt tne water neater opersng in an unesle manne’ cool ie presen
Immacatly svt the wor host down ane contact your desis or 3
valid serie person,
Wen considering add-on roms, patch o alla, atention must be given]
tothe vening ot your mater heater For your stay, do mot torminate a
ent on your wator heater inside ada-on rooms teen porch or ont
petios. Doing so wil esut in preducts of combustion elng vented Int
fre racms of sceupied areas
Never operate the heater yaa smell gos. Donat asaune that he eal
et get your RV is oral hry Ure ou detect te odor ett to
Seonsidored ite threstning ai corwcted immediately xtrvish any
open ames including cigaates and evacuate ai persone from the
ohicie. Shutoff gas suppy st LP gas bots. (See Safety nates on Wart
over ofthis manual)
The thermostat on your water heater ie not adjustable. Ri a tomperatir
Jenaing limit deaigned to maintain a water teomperatre of 0° (660),
Water temperatures ever 125° (49°C) can cause severe burns Insanty
lor death from sealds, Weefore, be careful when using Ret water
hukeon disabled and elder are at highest isk of beg salded Aways
fel water betore bathing or showering,
connect Iyconsecr
awe opsueromance
HE BEARERS,
ix \y
\yhy i!
We,
.
Ye uow on vewwow
| PRR parten
Figure 10,
HIGH ALTITUDE DERATION
Subuar's water healers ate cented by natal. recognized testing
isborataes fr speston nth! moctcatons at stsides pt S00 feet
‘Gperatonatove is eeahon may requre aerating hy «pen reer 090
{eet above seatoval Asan cramps, 218,00 fet, Be waar Pete shoud be
‘erated spprxmatey 2 percent
ime ut nt propecy deratod lek feutsentcxygn or combustion may
‘rosuse meroper burr eparshen. Plot ouage eavaea by bumer ier ef
Exotng fom yolom sumer may ceeur deat the persay of ctbon
‘monsiae: You may also nose 8 asst efcency hes he mer oocaue>
CFinzampetecomecston of he burer at ese higher ates
Gone wth te local 98+ company, your dealer an RV senee agency oF
‘Scbursan Manulacurs Compan pope deratng tun Changecutot
the onfe (grate) snovls be one y be Sea ora qalied sevice gency
NOTE: ts important nat once ne unt has eure ower elevation fon
11Soa ie tne hgh attuse deraion and pict agusiments (@equeeed) Be
Teversedfor prope’ operation ote unt
ANODE PROTECTION
The tn this water heaters protected by 3 magnesiom or aluminum anodeto
procng ne le fe are by absorb the caret acon oft water Unc
‘arma ee, tv anode os we deeroste and becauee of fv, we resort
replaced yea NOTE” Water wih hg levels of Fon andor sulfate wil
‘Ferme the neo dleroratonherelore more frequent eplacerren ay Se
‘eaured arcce rod ls mes eaten away repace tha new ane (See
Fagwe)
“To preven! a water eak when replacing the anode ro, a pipe ved sealant
oproce or prae water even se Tefen Tage) mst te apgedo be Breads
Fhe sce oc Fraveropeh sane” stead seman wi neers wen Oe
‘hose tank ptweson,
(Operating re water heater wtnout popes acc protection wil decreas tank te
Stas. vod your waranyy on he the NOTE, Tare e ane by remowng
_ ross (See Dra a Storage raters)
aryenonsed tne Son use winter intake manned Ave
‘io, orto secon on ween.
NOTE: Aiwaye open both te cold and hot water faucet when ting]
venice watertanto allow a pockats ob tereed out ofthe waterheste
nan water flows trom the hestrfsuset, close Boh faves
[WARNING Do not store or ure combuatble materials or iquds near or]
acjaconttotnsheatsr. Ths oppiance shal nctbe stated any tcaton
sere flammable igus or vapor eka tobe preset.
[sure the ponria “OFF” to the watorheatr ignition ayatom during a
pool rebiling awhile vehicle fn maion or beng town.
[WARNING! Do not replace the anode roa with any_nen Suburban]
accessory par, such as an“ac-on" let heating element tee such
3s\thece are not approves to be installa in Suburban products They
Zocld creat sv uneate condition an wi als vod al warrantee
NEW ANODE ROD
> prone Roo 78% CORRODED ANODE ROD PRESSURE RELIEF VALVE
‘Te emparature an pressure rete valve cesgned open te tonperatire
fhe woe atin tne ator ronenes 216° or heater essurein east
‘Races opens Resear vehi se acon go an
{ag howerneaingoyse ne pecs bold up.n ne wat yea wi a
153 pounds Wan te posaure reached, ts pieturetlel alve wh ope
Ate ldap tome wae Ths cpr wit Sorin ule preseure
Fesuee lo belon 80 pounds, rhe ae oes, The consis rormal and
(oes ot noaat 9 alaae iat aie
WARING! Do not pace a valve bebwaen the ait valve andthe ork, 09]
not pg here vale under snycreumetances.
WATER WEEPING OR DRIPPING FROM PRESSURE
RELIEF VALVE
‘Youay experience water weeping of ping tom you water hates Pressixe
{na Temperature (P81 Reet Vale when yurwnterheate operating. Waar
‘teepna or drppg sam he P&T Varo oss nota mean he F a7 valve
ISaateive As waters neste, K expands. The wale sytem fa reenter
Vide ss cosessyten ar doos not alow tr te exgesion ef Meat wale,
linen he pease fe mate’ system exceeds De elewag sito he P&T
Vata, the vve wil elo the excess peste
‘Suturoan recommends hat check valve ro be nstaleddrecty at ne nt to
‘te wor ester tank Ths id eres weeping of he pessute ee! valve.
(WARRING! Do not remove or pug te
valve
(re way 6 reduce the requency ef is coxurence io malian an ar pocket
he top afthaeater estar lank. a poo! vl tne tak by oh
ewever. twos reduced oer rm by the overyday use of your water Pater
Torplensh i i poet
4: Tumof water neater
2 Tint Skala ie.
4 Pullout on he handle the Pressure Relet(P & 7 Va and aw water
toa tomtne ve unt seg,
‘Release hone on P&T vate = shod sap cosas
6: Close suc ar um on clgwate supp 35 thet Ms, he ar pocket
wo.
Repeats procedure as ten as reoceso rede the Fequency ofthe weeing
Site P&T Vaio fhe weeping sete afar fobowrg Ib possase, ou Tay
Sectional an egpansion of acarraoankinthe coda ine tesaeen ne
{ane and check vale i eleve he pressure caused by Dermal expansion
[eas yout neal Sole starch
THERMOSTAT AND MANUAL RESET
MODELS: S4v420, SYAZ0E, and SHEDEM
‘SWi60, SWEDE, ane SWIEDEM
‘The model ater haters list ove are aad with ahigh mparat.caint
Gre cata dever Temperature above *00'F wa cause manual eet Duos
{puting doo miss bare
Toactateburrer te water emperatte st betow 110, push ese buon
RESET BUTTON
‘THERMOSTAT AND MANUAL RESET
MORES SWAIDE and SwHQ0E
‘SINSDE and SWISDEM
‘Te medel aerate ste above are equipped wih high emperatur it
Sbsnier devce: Temperaveaoove Te0°F wi cause manval esl buon
trp sting down ine eee element
To acivae lement the water temperature must be blow 110°, push reset
ow
leo vac,
HI-LINIT
T-stat
Figure 13
DRAINING AND STORAGE INSTRUCTIONS
FRY foe stored during weer months, he water eater mus be ame to
Srovent eamoge tors eesing
4. Tum ot eecrcal poner owatr hater ana ate sch Yom eee
Slemancora sreahee
2. Shutof ga supply to water ester
3. Tum ot ratcure pump on water system.
4. Folow RV manulaciue’s nstuctere er stanng ance water eytem
NOTE: Be certain rt waterheterwin water srarenoveal ai tem
thes below reightng bear tung on eacrcal power
‘ODOR FROM HOT WATER SYSTEM
der romin ot wat yates no ase pater rieny wae supa
‘chen eage ana 'sahenvoseved to 29 uiphr ae = ne harm = ery
{isesunt fe snel Suphur ater canbe ens a enemcnl aebon ory
Satiera The sclston fo cimanatis chonationo water aye Aas aout
Sc ()sunces ot sornatag comme novsehals squid seaenia each *o salons
‘Se mal Then re ornate water fvoughot ne ser, ape59
‘ochfouset ne atasmeurtsyousral ne coins Lathe RV sites fow ay
[Indine chore shoud tke cae of he aobion Then you wi eee ake care
Ste cionne Remove te Cline ty fushing Hegytom nih Feshate Ths
‘ray lake saveal aterpls. You ay conser sdang 9 faetng sytem that
‘emoves chcrme and provers spr water the suhur olen egg smell
Coninues tushinesjiem once apar asdescrBed aboyeansteplacearedered
Serecssary
REMOVING WATER HEATER
1. shut 9 sup and alsonnect as upp Ine rm water heater.
2. Ona let Hedi, eseonnact 120 AC. supply jrcton tox mounted
3. On af DS! Modes, cissomect 12 VDC. poner supply at uneton box on
4. 07 Mogae SW12D, S150, SWI2DE and SHADE esconnedt at wes 2
5, Shuto wate supply rain water fom tank flowing iarotons under
‘raning and Srsoe™
6. Dissomect net and cae walr ine Hom sta eat
7. Remove screws errs soca como nousng a tamed opening
8 Sige aatr ov. To cnet folow nauonsin manual under nsatston
Fosters"
WINTERIZING
tysurwaterhesterhbing system equpped win a byoass i, use tioccce
cfinowate neater arate woterheae comply a eave waar est!
(ese af (ut of ho sytem) inthe bypess poston pareuly You ate
Intodecingntteere ioe puro sytem Artfecce conte vey coraae
{Sihe anode ro creebag premalure leuteanabeatysedementnhetank. ihe
Dung sys snot ecu ide bipasski ard you mie owrterize by
[Sng suvecce lobe sytem, fomovo the anode fod lengtor he wis]
andrepace twin 6 eanphs WEE, FOR YOUR SAFETY READ BEFORE LIGHTING
[stearoon monoxide exists whlch ean ease pereonal ur
[WARNNG! the use of ie appliance als to rantain Kn the condon in which was shippea fom the factory or ifthe appliance not weed eoley
orks letended! purpose orf applonce fs et melnaind in accordance with he ntructon ln his manual, ten he sk of fie ander tHe preduton|
ocloas of He
‘OPERATING AND LIGHTING INSTRUCTIONS
‘OPERATING INSTRUCTIONS.
[WARNING you do not folow 1
eptstnny resi asin prove
Inatractions exact, « re or
ge, personal injury orless of
4. STOP! Rend the sae intanation proces
2, Tusnatal elect powet tothe arpience
(WARNING: Gofore operating water heater, be sure tank ls Wed with
water See "Salty Warnings"
23. Tuen-OF Fg supp
4. iat fe minutes fr gas ces ne aces you mel gas en STOP!
[A.This appance does aot hve lt Ie enuipped wit an ition deve
‘tach aulematesby igh he burner Oo ne yet he brnat y nan
. BEFORE LIGHTING amet a aun e appance are for 933 Be seo
‘Sell sel he foo! because some gosisheevr hen a an ste on he
WHAT To 00 F YOU SMELL GAS
Do nt bat ay apace
Be natiovch ay eect stn
De nat ae ay prem your ulin
met ny a peor a ears pane Felon We ost
+ you emer rs out
supple, cal te tre depanmen
“This a automate gas vae, no adjustments ae necessary Do na
Stem to repar ie ga ve. The may resut nave or evpioson
De nous Ws arlance ary part has ose under wae. mediate
