Mạch điện hệ thống điều khiển phun dầu động cơ D6CE trên các

dòng Hyundai tải

EC
U
PR
O
C
EN
TE
R
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (1) SD313-11

ETC Terminal Information

1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24
2 6 10 14 18 22 26 30 34 38 42 46 50 54
2 6 10 14 18 22 26 30 34 38 42 46 50 54 58 61 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47
57 61 3 7 11 15 19 23 27 31 35 39 43 47 51 55 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70
3 7 11 15 19 23 27 31 35 39 43 47 51 55
58 62 4 8 12 16 20 24 28 32 36 40 44 48 52 56 59 62
4 8 12 16 20 24 28 32 36 40 44 48 52 56

C101-4 E100-E1 E100-E2

PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION
1 - - 47 - -
1 Br ON Input 32 - - 1 B Injector #1 (NCV LO) 32 R Injector #4 (SCV LO)
2 - - 48 - -
2 Br Start Relay Control (Start Inhibit) 33 - - 2 G Injector #1 (NCV HI) 33 B Injector #5 (SCV LO) 3 Y Remote PTO DEC Switch 49 - -
3 Br ENG ECU Relay Control 34 L PTO Safety Switch 3 G/B Injector #2 (NCV HI) 34 Y Injector #5 (SCV HI) 4 - - 50 - -
4 Br Check Engine 35 - - 4 L Injector #2 (NCV LO) 35 R Injector #6 (SCV HI) 5 B/O Remote PTO INC Switch 51 - -
6 - - 52 - -
5 P/B Power Mode Switch 36 - - 5 O Injector #3 (NCV LO) 36 W Injector #6 (SCV LO)
7 G/R Remote Pedal Sensor (SIG) 53 B/O Remote Pedal Sensor (Supply)
6 - - 37 - - 6 P Injector #3 (NCV HI) 37 - - 8 G Auto Cooling Fan (SIG) 54 G Auto Cooling Fan (5V)
7 B Ground (GC11) 38 R Pedal Sensor (Power) 7 R Injector #4 (NCV HI) 38 O 0V Fuel Pressure 9 - - 55 B/W Air Heater Monitor
8 G/B High Coolant Temp. Lamp 39 - - 8 W Injector #4 (NCV LO) 39 W 0V Boost 10 R EGRT (Signal) 56 B/O AMS Air Temp. (0V)
9 W P/S Oil Temp. Switch 40 W Vehicle Speed 9 Y Injector #5 (NCV LO) 40 B Exh. Brake, Jake #3/#4 11 - - 57 - -
12 G/R Exh. Temp. (Signal) 58 - -
10 Br Cruise/Engine PTO SwitcH (Enable) 41 Gr Pedal Switch (N/C) 10 B Injector #5 (NCV HI) 41 - - 13 - - 59 - -
11 - - 42 B Pedal Sensor (Ground) 11 G/B Injector #6 (NCV HI) 42 Y Fuel Temp. 14 - - 60 - -
12 G Engine Speed 43 - - 12 L Injector #6 (NCV LO) 43 R/B Boost Temp. 15 - - 61 - -
13 G/W Cruise/Engine PTO Switch (RES/DEC) 44 - - 13 O Jake #5/#6 (+) 44 Y Exh. Press Sensor (0V) 16 - - 62 - -
17 - - 63 - -
14 P Neutral Switch 45 L/B Pedal Switch (N/O) 14 P Jake #5/#6 (-) 45 - - 18 - 64 Diagnostic Switch
- G
15 - - 46 - - 15 - - 46 G/W 5V Fuel Pressure 19 G/W ECTS (+) 65 - -
16 B/O Start Relay Control (Sub Start) 47 Y CAN1 (High) 16 Y Air Heater Lamp 47 B 5V Boost Pressure 20 - - 66 - -
EC

17 L Cruise/Engine PTO SwitcH (SET/INC) 48 Y CAN2 (High) 17 O Jake #1/#2 (+) 48 G Exh. Press Sensor (5V) 21 - - 67 - -
22 - - 68 - -
18 Gr Stop Signal Relay Control 49 W Pedal Sensor (Demend) 18 P Jake #1/#2 (-) 49 - -
23 - - 69 - -
19 - - 50 - - 19 - - 50 Y Fuel Pressure 24 - - 70 - -
20 - - 51 - - 20 G Not Used 51 Br Boost Pressure 25 - - 71 - -
21 W/B Engine Brake #2 52 - - 21 R CRS/PTO/RSG Lamp 52 B Exh. Press Sensor (SIG) 26 - - 72 - -
U

27 - - 73 - -
22 - - 53 - - 22 - - 53 L CMPS (+)
28 - - 74 G/R Auto Cooling Fan (Fan Drive I)
23 G/W Check Engine (IND.) 54 - - 23 G Jake #3/#4 (-) 54 R CMPS (-) 29 Lg Remote Pedal Sensor (0V) 75 - -
24 - - 55 G CAN1 (Low) 24 G/W Engine Brake Lamp 55 O CKPS (-) 30 G Auto Cooling Fan (0V) 76 B/W Air Heater Relay Control
PR

25 L/R Clutch Switch 56 G CAN2 (Low) 25 G/B Injector #1 (SCV LO) 56 G CKPS (+) 31 - - 77 - -
32 B/O EGRT (0V) 78 O AMS Air Temp. (Signal)
26 G Parking Switch 57 B Ground (GC11) 26 L Injector #1 (SCV HI) 57 - -
33 - - 79 - -
27 - - 58 B Ground (GC11) 27 B Injector #2 (SCV HI) 58 - - 34 Y/R Exh. Temp. (0V) 80 - -
28 - - 59 B Ground (GC11) 28 G Injector #2 (SCV LO) 59 - - 35 - - 81 - -
29 - - 60 R ENG ECU Relay ON Input 29 P Injector #3 (SCV LO) 60 - - 36 - - 82 - -
O

37 - - 83 - -
30 W Engine Brake #1 61 P ENG ECU Relay ON Input 30 O Injector #3 (SCV HI) 61 - -
38 - - 84 R/O Remote PTO Enable Switch
31 - - 62 Y ENG ECU Relay ON Input 31 W Injector #4 (SCV HI) 62 - - 39 - - 85 - -
40 - - 86 - -
41 - - 87 - -
C

42 G/R ECTS (-) 88 - -

43 - - 89 - -
44 - - 90 - -
45 - - 91 - -
EN

46 - - 92 - -
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (2) SD313-12

HOT IN ON HOT AT ALL TIMES
SMART
JUNCTION
BLOCK
ENG ENG
ECU ECU
5A 20A

ENG
ECU
RELAY AIR
HTR
5A

ENG
ECU
5A

Y B L(ZF A/T) O
L(M/T-DYMOS) INSTRUMENT
W/B(M/T-FSO) CLUSTER R/W R R R Gr O Y
Gr(M/T-ZF) 15
M01-A
C30-A(ZF A/T) ENGINE
C30-D(M/T-DYMOS) CAMSHAFT COOLANT
C30-F(M/T-FSO) (9) (C116-1) INSTRUMENT POSITION TEMPERATURE
E113 2 E13(M/T-ZF) 1 C104 [1] [C116-2] 3 M27 5 M14 5 M80 1 5 M61 M01-B CLUSTER SENSOR SENSOR
2 AUTO NEUTRAL POWER SPECIAL CLUTCH STEERING AUTO POWER AIR 11
COOLING SWITCH STEERING CONNECTOR SWITCH WHEEL CRUISE MODE HTR
FAN OIL ( ) : W/O Mixer High REMOTE SWITCH SWITCH RELAY
TEMPERATURE [ ] : With Mixer High CONTROL
4 5 1 3 SWITCH SWITCH 30 29 33 31 34
1 C30-A(ZF A/T) 2 3 M61
E113 (RIGHT) M01-B 2 1 E108 1 3 E102
C30-D(M/T-DYMOS) 2 C104 4 M27 7 M14 7 M80
(8) (7) (3) (2) (5) (1) (10) (C116-1) (4) (C116-1)
C30-F(M/T-FSO)
[2] [C116-2]
E13(M/T-ZF) L/W
CLOCK
G G SPRING
See Easy Hill Start 1 E103
(EHS) System See P.T.O 4 3 M23 AIR
Control HEATER
System RELAY &
MONITORING
See Starting See Data See Vehicle See See Assist
System Link Details Speed Parking See Stop Brake System 2 E103
System Brakes L/R L/R Lamps

With W/O
EC

Y Br R P Y G/R G G G B/O Br Y G Y G P W W G G L B/O Y G/R B/O Lg R/O PTO PTO Gr L G/W W W/B Br P/B B/W B/W G/B G/W Br Y G/W R L R G/R G/W

C101-4 E100-E2 C101-4 E100-E2 C101-4 E100-E2 C101-4 E100-E1 E100-E2

1 3 60 61 62 74 54 30 8 16 2 47 55 48 56 14 9 40 26 12 34 5 3 7 53 29 84 25 18 17 13 30 21 10 5 55 76 8 23 4 16 24 21 53 54 42 19

ETC
U

29 53 7 32 10 34 12 56 78 64 43 39 51 47 50 38 42 46 44 48 52 38 49 42 41 45 7 59 58 57 40 14 13 18 17 23 40 56 55 26 25 2 1 27 28 3 4 30 29 6 5 31 32 7 8 34 33 10 9 35 36 11 12
E100-E2 E100-E1 C101-4 E100-E1

Lg B/O G/R B/O R Y/R G/R B/O O G R/B W Br B Y O Y G/W Y G B R W B Gr L/B B B B B B P O P O G B G O L G/B G B B G G/B L O P P O W R R W Y B B Y R W G/B L
PR

2 M16-E
ETC W R
CHECK
1 2 E111 SWITCH 2 C119 1 E123-1 1 2 E109 1 2 3 4 E121-2 1 2 3 4 E121-4 1 2 3 4 E121-6
EXHAUST JAKE
MAGNETIC BRAKE
1 M16-E VALVE SOLENOID
#2 SCV NCV SCV NCV SCV NCV
EGR CRANKSHAFT
TEMPERA- B 1 C119 1 E123-2 POSITION INJECTOR INJECTOR INJECTOR
O

TURE SENSOR #2 #4 #6
SENSOR
B B
GM01
3 4 1 2 E104 2 1 3 4 E105
M01-B
2 3 1 C103 1 2 3 E112 3 1 2 5 4 6 M18
35
E111(EGR) 1 E122-1 1 E124-1 1 2 3 4 E121-1 1 2 3 4 E121-3 1 2 3 4 E121-5
1 2 E115 1 2 C121(OBD) JAKE JAKE
C

BRAKE BRAKE
INSTRU- SOLENOID SOLENOID
MENT #1 #3 SCV NCV SCV NCV SCV NCV
CLUSTER
ENGINE RPM EXHAUST AIR BOOST FUEL EXHAUST GAS ACCEL PEDAL 1 E122-2 1 E124-2 INJECTOR INJECTOR INJECTOR
CONTROL GAS TEMPERATURE PRESSURE TEMPERATURE PRESSURE POSITION SENSOR #1 #3 #5
With Mixer High TEMPERA- SENSOR SENSOR & PRESSURE SENSOR
EN

TURE SENSOR GC11

SENSOR
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (3) SD313-13

HOT IN ON HOT AT ALL TIMES
SMART
See Power Distribution See Power Distribution JUNCTION
(SD110-5) (SD110-4) To AIR BLOCK
A HTR 5A
ENG ENG (SD313-15) P.43
ECU ECU C.90-7/8/9
5A 20A ENG
ECU
See Passenger 5A
Compartment Fuse Details
(SD120-14)
ENG
ECU See Passenger To EDU
RELAY Compartment Fuse Details B Relay
(SD120-14) (SD313-15)

48 28 31 33 32 34 I/P-J 47 I/P-K 47 I/P-L 9 6 I/P-J

M/T ZF A/T
0.85Y 0.85Br 0.85R 0.85P 0.85Y 0.85L/B
0.85R/W
ZF DYMOS/FSO
36 EC501
P.66 C
0.5B 0.5B 0.5B 0.85L(ZF A/T) 0.85O
0.75Y 0.5Gr(ZF) To Special
11 EC04 0.85L(DYMOS) Connector
0.5W/B(FSO) (SD313-17)
P.121
0.5B
C30-D (DYMOS)
2 E113 2 E13 2 C30-F (FSO) 2 C30-A 1 C104
Supply AUTO NEUTRAL NEUTRAL NEUTRAL POWER
COOLING SWITCH SWITCH SWITCH STEERING OIL
EC

FAN P.119/ P.137/ P.204 TEMPERATURE

Fan Speed P.58 202 139/206 C.30-6 SWITCH
C.20-7 C.24-1 C.30-7 C.32-5
PWM 5V 0V Signal
1 E13 1 C30-D (DYMOS) 1 C30-A 2 C104
4 5 1 3 E113 C30-F (FSO)
0.5W/B
U

10 EC04 P.121

0.85P 0.85W
PR

0.5G/R 0.5G 0.5G 0.5G 0.5Gr 0.85L(DYMOS 0.85L

0.5W/B(FSO)

ZF DYMOS/FSO

M/T ZF A/T
O

See Easy Hill Start

(EHS) System
1 3 60 61 62 C101-4 74 54 30 8 E100-E2 (SD956-2) 14 9 C101-4
ON ENG ECU Fan Drive 5V 0V Signal Neutral P/S Oil ETC
C

Input Relay I (PWM) Switch Temp. CONTROL

ENG ECU Relay MODULE
Control ON Input Switch
Auto Cooling Fan P.60/70
C.20-4/32-4
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (4) SD313-14

+ BATTERY Not Used

AIR
HEATER
RELAY &
12V MONITORING 35 EC501
P.66
- FUSE
0.5R/B

60R 60R 2 E102

N/A ENGINE EGR EXHAUST GAS
SENDER COOLANT TEMPERATURE TEMPERATURE
+ BATTERY SENSOR TEMPERATURE SENSOR SENSOR
2 1 E103 SENSOR P.186 P.190
P.58 C.20-6 C.20-7
12V P.59 C.20-5
C.20-5 1 2 E111 1 2 E115
- 0.5B/W 0.75L/W 1 3 E102

60B AIR D
HEATER From AIR 0.5G/R 0.5G/W 0.5B/O 0.5R 0.5Y/R 0.5G/R
HTR Relay
(SD313-15)
BODY START
GROUND MOTOR 55 42 19 32 10 34 12 E100-E2

Air Heater (-) (+) 0V Signal 0V Signal ETC

CONTROL
EC

Monitor
MODULE
ECTS EGRT Exh. Temp.
C.60
C.20-3/4
CMPS CKPS Exh. Press Sensor
Boost 0V Boost Vref Vref Fuel 0V Fuel Fuel
Temp. Boost Pressure (5V) (5V) Temp. Pressure Pressure (+) (-) (+) (-) 0V Signal 5V
U

43 39 51 47 46 42 38 50 53 54 56 55 44 52 48 E100-E1

0.5R/B 0.5W 0.5Br 0.5B 0.5G/W 0.5Y 0.5O 0.5Y 0.5L 0.5R 0.5G 0.5O 0.75Y 0.75B 0.75G
PR

3 4 1 2 E104 4 3 1 2 E105
O

BOOST FUEL
PRESSURE TEMPERATURE
SENSOR & PRESSURE 2 1 E108 1 2 E109 1 3 2 E112
P.59/188 SENSOR
CAMSHAFT CRANKSHAFT EXHAUST
C

C.20-5 P.61/62 POSITION POSITION GAS

C.20-5 SENSOR SENSOR PRESSURE
P.63 P.63 SENSOR
C.20-6 C.20-6 P.189
EN

C.20-6
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (5) SD313-15

HOT AT ALL TIMES
SMART
See Power Distribution JUNCTION
(SD110-4) From ENG
ECU Relay A BLOCK
(SD313-13) P.31
EDU AIR C.90-2/3/5
From ENG To Clock 15A HTR
ECU 5A B E Spring 5A
(SD313-13) (SD313-16)

25 I/P-D 39 I/P-C 38 I/P-F

0.85W 1.25R 0.85O 0.85Gr

4 1 M66-1 5 1 M61 SUB

RELAY
EDU AIR BLOCK
RELAY HTR
P.30 RELAY
C.10-22 P.30
C.10-21
2 5 M66-1 3 2 M61

0.85B 1.25R 0.85L 0.85O

See Data Link Details
23 MC91 (SD200-4) 20 19 MC91
P.42 (SD200-5) P.42
1.25R 0.85L 0.85O

1 EC501 9 34 EC501
P.66 P.66
EC

0.75Br 0.85Y 0.85G 0.85Y 0.85G 0.5B/W 0.75L/W

GM04 P.22
13 E101 48 56 47 55 C101-4 76 E100-E2

EDU Relay EDU High Low High Low Air Heater ETC
ON Input CONTROL Relay CONTROL
MODULE CAN2 CAN1 Control MODULE
U

P.60/187 P.60/70
C.20-5 Start Relay Control C.20-3/
Position Sensor Motor Torque 20-4/32-4
Shield Selection Sub Start Vehicle Parking
Ground U V W PWR GND W V U Ground Lamp Start Inhibitot Speed Switch
PR

5 1 2 3 8 4 12 11 10 14 E101 20 E100-E1 16 2 40 26 C101-4

D
N/A 0.5R/B 0.5W 0.5Br 0.5R 0.5B 0.5B 0.5G 0.5Br 0.75Br/B 0.5G 0.85B/O 0.85Br 0.85W 0.85G
To Air Heater
15 6 EC501 Relay & Monitoring
P.66 (SD313-14)
O

1.25B See Ground

0.5R/B 0.5W 0.5Br Distribution
(SD130-14) See Vehicle See Parking
1.25B Not Used
4 3 2 1 5 6 7 8 E107 See Starting Speed System Brakes
EGR System (SD436-1) (SD597-1)
C

U V W PWR GND W V U (SD360-1)

ACTUATOR
Position Sensor Motor P.68
C.20-6
EN

GC11
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (6) SD313-16

SMART
JUNCTION
From ENG To Instrument BLOCK
ECU 5A E F Cluster
(SD313-15) (SD313-19) P.31
C.90-3

13 26 I/P-D
See Illuminations
(SD941-5)

See Illuminations 0.85R 0.5Br 0.5G/O 0.5B 0.5R See Illuminations 0.85R
(SD941-5) (SD941-2)
12 5 6 M23
CLOCK
SPRING
0.5G/O P.10 0.5G/O
C.10-12
10 5 M80 5 10 M14 3 M27
POWER STEERING AUTO CLUTCH
MODE 8 1 7 WHEEL CRUISE SWITCH
SWITCH STEERING SWITCH P.5
ILL. IND. P.19 COM (+) (-) IND. ILL. P.19
WHEEL C.10-13
C.10-27 REMOTE C.10-9
SET RES CONTROL
SWITCH 4 M27
8 1 4 7 M80 (RIGHT) 7 4 1 8 M14
ILL.

0.5B 0.5B 0.5Lg 0.5Br/O 0.5B/O 0.5B 0.85L/R See P.T.O

Control System
4 3
EC

(SD471-1)
See See
Illuminations CLOCK Illuminations
(SD941-5) 0.85P/B SPRING (SD941-2)
0.85L/R
P.10
C.10-12 See Ground
U

Distribution UMB
(SD130-2) W/O With
4 3 M23
PTO PTO

See Ground
PR

Distribution UMB 0.5L 0.5G/W 0.5Br 2.0B See Stop

(SD130-2) Lamps
(SD927-1)
11 MC81 10 11 9 MC91 1 MC81
P.42 P.42 P.42
O

2.0B 0.5P/B 0.5L 0.5G/W 0.5Br 0.85Gr 0.85L/R

GM01 P.22
5 17 13 10 18 25 C101-4
Power SET/INC RES/DEC Enable Stop Signal Clutch ETC
CONTROL
C

Mode Relay Switch

Switch Control MODULE
Cruise/Engine PTO Switch
P.60/70
GM01 P.22 C.32-4
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (7) SD313-17

W/O MIXER HIGH With MIXER HIGH

SPECIAL
S P E C I A L C O N N E C T O R CONNECTOR
ENGINE
8 7 9 4 3 2 5 1 10 C116-1 1 2 C116-2 RPM
CONTROL
C.32-7 C.32-7 C.32-5
0.85G 0.85L 0.85R/W 0.85Y 0.85O 0.85Gr 0.85B 0.85R 0.85W 0.85R/W 0.5Y
1 3 2 C103
0.85G 0.85G C C
18 MC81 FromENG FromENG 0.85B 0.85R 0.85W
ECU 5A ECU 5A
P.42 (SD313-13) (SD313-13)
0.5G

G 18 13 14 12 21 11 EC501 18 12 21 11 EC501
P.66 P.66
To Instrument 0.5R/O 0.5B/O 0.5Y 0.5G/R 0.5B/O 0.5Lg 0.5R/O 0.5G/R 0.5B/O 0.5Lg
Cluster
(SD313-19)
12 34 C101-4 84 5 3 7 53 29 E100-E2 84 7 53 29 E100-E2

Engine PTO Enable INC DEC Signal Supply 0V Remote PTO Signal Supply 0V ETC
Speed Safety Switch Switch Switch Enable CONTROL
Switch Remote Pedal Sensor Switch Remote Pedal Sensor MODULE
Remote PTO P.60/70
C.20-3/
Pedal Sensor Pedal Switch 20-4/32-4
Ground Exhaust Diagnostic
Power Demend Ground N/C N/O Brake Switch

38 49 42 41 45 7 57 58 59 C101-4 40 E100-E1 64 E100-E2

0.85B 0.5G
EC

0.85R 0.85W 0.85B 0.85Gr 0.85L/B

3 24 EC501
P.66
0.85R 0.5Br
7 6 8 17 16 21 MC81
P.42 5 MC81
P.42
U

0.85R 0.85R 0.5Br

0.85R 0.85W 0.85B 0.85Gr 0.85L/B 0.85B 0.85B 0.85B 0.85B 0.85B 0.85B 2 C119 2 MC91 2 M16-E
PR

EXHAUST P.42 ETC CHECK

MAGNETIC 0.5W SWITCH
VALVE
UCG P.6
P.134/175/177 C.10-10
C.32-9 H
1 C119 1 M16-E
To Instrument
0.5B
O

3 1 2 5 4 6 M18 0.85B Cluster

See Ground (SD313-19)
ACCEL See Ground
PEDAL Distribution
(SD130-14) Distribution UMA
POSITION 2.0B 2.0B (SD130-2)
SENSOR
C

P.11 2.0B
C.10-11
EN

GC11 GM01 P.22

TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (8) SD313-18

1 3 E121-1 1 3 E121-3 1 3 E121-5

INJECTOR INJECTOR INJECTOR
SCV NCV #1 SCV NCV #3 SCV NCV #5
C.64/190 C.64/190 C.64/190
P.20-8 P.20-8 P.20-8

2 4 E121-1 2 4 E121-3 2 4 E121-5

0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W

2 3 4 1 6 7 12 9 10 11 20 17 EE01
C.64/190

0.85G 0.85L 0.85G/B 0.85B 0.85P 0.85O 0.85P 0.85O 0.85B 0.85Y 0.85B 0.85Y

2 26 25 1 6 30 29 5 10 34 33 9 E100-E1

NCV SCV SCV NCV NCV SCV SCV NCV NCV SCV SCV NCV ETC
HI HI LO LO HI HI LO LO HI HI LO LO CONTROL
MODULE
Injector #1 Injector #3 Injector #5 P.60
C.20-3
Injector #2 Injector #4 Injector #6

NCV SCV SCV NCV NCV SCV SCV NCV NCV SCV SCV NCV
HI HI LO LO HI HI LO LO HI HI LO LO
EC

3 27 28 4 7 31 32 8 11 35 36 12 E100-E1

0.85G/B 0.85B 0.85G 0.85L 0.85R 0.85W 0.85R 0.85W 0.85G/B 0.85R 0.85W 0.85L
U

14 15 8 5 18 19 16 13 22 23 24 21 EE01
C.64/190
PR

0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W

2 4 E121-2 2 4 E121-4 2 4 E121-6

INJECTOR INJECTOR INJECTOR
SCV NCV #2 SCV NCV #4 SCV NCV #6
O

C.64/190 C.64/190 C.64/190

P.20-8 P.20-8 P.20-8
C

1 3 E121-2 1 3 E121-4 1 3 E121-6

EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (9) SD313-19

HOT AT ALL TIMES HOT IN ON OR START
See Power Distribution See Power Distribution SMART
(SD110-4) (SD110-3) JUNCTION
BLOCK
FUSE
SWITCH P.31
ROOM C.90-2/3/5
CLUSTER
LAMP
10A
10A
To Water From ENG
J Level Sensor ECU 5A F See Passenger See Passenger
(SD313-20) (SD313-16) Compartment Fuse Details Compartment Fuse Details
(SD120-16) (SD120-3)

34 31 I/P-D 32 I/P-C 27 I/P-F

0.5R
0.5Y 0.5P 0.5Y/B
0.5R
11 M01-B 18 21 31 M01-A
Over INSTRUMENT
Heat CLUSTER
EXH JNKE PRE CHECK OVER ENG P.7
BRAKE BRAKE HEAT'G ENG OBD HEAT IMMO PTO/ C.10-1
IG2
CRUISE
MONO LCD MOLO
(CRUISE/PTO LCD
5V REG ENABLE)
General

MICOM
IG2 IG2 IG1
IG2 IG2 IG2
EC

I/F CAN1 TRANSCEIVER

Check Pre Jake Cruise/ Oil Exh. P_ S_

OBD ENG P_GND Heating P_GND Brake P_GND ENG PTO B/Pass P_GND Brake High Low GND GND

30 29 33 31 34 4 35 M01-B 15 34 35 22 28 M01-A
U

0.5W 0.5G 0.5Y 0.5G 0.5B 0.5B

0.5G/W 0.5G/W 0.5Br 0.5G 0.5L/O 0.5G
PR

16 17 MC91 19 14 MC81 18 13 MC91 0.5G 0.5L

P.42 P.42 P.42 See Data
Link Details
0.5Br 0.5G 0.5P/O (SD200-3)
H G
7 4 5 EC501 Not Used From Exhaust From Special
P.66 Magnetic Valve Connector 10 MR01
O

(SD313-17) (SD313-17) P.4

0.5G/W 0.5Br 0.5Y 0.5G/W 0.5R
0.5L
23 4 C101-4 16 24 21 E100-E1
ETC 10 R16
C

Check Check Air Heater Engine CRS/PTO

Engine Engine Lamp Brake /RSG CONTROL DIGITAL
MODULE RPM
(IND.) Lamp Lamp Signal TACHOGRAPH
P.60/70 In P.94/96 GM02 GM10
EN

C.20-3/32-4 C.60-3 P.22 P.33

TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
22/2/2020 Global Service Way - Technical Information

2017 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (10) SD313-20

SMART
JUNCTION
From Instrument BLOCK
Cluster J
(SD313-19) P.43
C.90-7/8

2 I/P-J 4 I/P-K

0.5G/B 0.85Y/R

EGR Type OBD Type

1 E122-2 1 E123-2 1 E124-2 2 C38
AIR AIR JAKE JAKE JAKE WATER
TEMPERA- TEMPERA- BRAKE BRAKE BRAKE LEVEL
TURE TURE SOLENOID SOLENOID SOLENOID SENSOR
SENSOR SENSOR #1 #2 #3 P.46
C.30-9

1 2 E116 1 2 C121 1 E122-1 1 E123-1 1 E124-1 1 C38

P.67 P.215 C.64/190 C.64/190 C.64/190
P.20-9 P.20-9 P.20-9
EC

C.20-7 C.32-10
0.85B

See Assist
Brake System
0.5P 0.5O 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W (SD598-2) See Ground
(SD598-4) Distribution UCC
(SD130-10)
U

(SD598-7)

17 16 EC501 26 25 28 27 29 30 EE01
0.85B
PR

P.66 P.64/190

0.5B/O 0.5O 0.5B/O 0.5O 0.85P 0.85O 0.85P 0.85O 0.85G 0.85B 0.5W 0.5W/B
GC01 P.155
O

56 78 E100-E2 56 78 E100-E2 14 13 18 17 23 40 E100-E1 30 21 8 C101-4

0V Signal 0V Signal (-) (+) (-) (+) (-) (+) Engine Engine High ETC
Brake Brake Coolant CONTROL
AMS Air Temp. AMS Air Temp. Jake #5/#6 Jake #1/#2 Jake #3/#4 #1 #2 Temp. MODULE
C

Lamp P.60/70
C.20-3/20-4/32-4
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (1) SD313-11

ETC Terminal Information

1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24
2 6 10 14 18 22 26 30 34 38 42 46 50 54
2 6 10 14 18 22 26 30 34 38 42 46 50 54 58 61 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47
57 61 3 7 11 15 19 23 27 31 35 39 43 47 51 55 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70
3 7 11 15 19 23 27 31 35 39 43 47 51 55
58 62 4 8 12 16 20 24 28 32 36 40 44 48 52 56 59 62
4 8 12 16 20 24 28 32 36 40 44 48 52 56

C101-4 E100-E1 E100-E2

PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION
1 - - 47 - -
1 Br ON Input 32 - - 1 B Injector #1 (NCV LO) 32 R Injector #4 (SCV LO)
2 - - 48 - -
2 Br Start Relay Control (Start Inhibit) 33 - - 2 G Injector #1 (NCV HI) 33 B Injector #5 (SCV LO) 3 Y Remote PTO DEC Switch 49 - -
3 Br ENG ECU Relay Control 34 L PTO Safety Switch 3 G/B Injector #2 (NCV HI) 34 Y Injector #5 (SCV HI) 4 - - 50 - -
4 Br Check Engine 35 - - 4 L Injector #2 (NCV LO) 35 R Injector #6 (SCV HI) 5 B/O Remote PTO INC Switch 51 - -
6 - - 52 - -
5 P/B Power Mode Switch 36 - - 5 O Injector #3 (NCV LO) 36 W Injector #6 (SCV LO)
7 G/R Remote Pedal Sensor (SIG) 53 B/O Remote Pedal Sensor (Supply)
6 - - 37 - - 6 P Injector #3 (NCV HI) 37 - - 8 G Auto Cooling Fan (SIG) 54 G Auto Cooling Fan (5V)
7 B Ground (GC11) 38 R Pedal Sensor (Power) 7 R Injector #4 (NCV HI) 38 O 0V Fuel Pressure 9 - - 55 B/W Air Heater Monitor
8 G/B High Coolant Temp. Lamp 39 - - 8 W Injector #4 (NCV LO) 39 W 0V Boost 10 R EGRT (Signal) 56 B/O AMS Air Temp. (0V)
9 W P/S Oil Temp. Switch 40 W Vehicle Speed 9 Y Injector #5 (NCV LO) 40 B Exh. Brake, Jake #3/#4 11 - - 57 - -
12 G/R Exh. Temp. (Signal) 58 - -
10 Br Cruise/Engine PTO SwitcH (Enable) 41 Gr Pedal Switch (N/C) 10 B Injector #5 (NCV HI) 41 - - 13 - - 59 - -
11 - - 42 B Pedal Sensor (Ground) 11 G/B Injector #6 (NCV HI) 42 Y Fuel Temp. 14 - - 60 - -
12 G Engine Speed 43 - - 12 L Injector #6 (NCV LO) 43 R/B Boost Temp. 15 - - 61 - -
13 G/W Cruise/Engine PTO Switch (RES/DEC) 44 - - 13 O Jake #5/#6 (+) 44 Y Exh. Press Sensor (0V) 16 - - 62 - -
17 - - 63 - -
14 P Neutral Switch 45 L/B Pedal Switch (N/O) 14 P Jake #5/#6 (-) 45 - - 18 - 64 Diagnostic Switch
- G
15 - - 46 - - 15 - - 46 G/W 5V Fuel Pressure 19 G/W ECTS (+) 65 - -
16 B/O Start Relay Control (Sub Start) 47 Y CAN1 (High) 16 Y Air Heater Lamp 47 B 5V Boost Pressure 20 - - 66 - -
EC

17 L Cruise/Engine PTO SwitcH (SET/INC) 48 Y CAN2 (High) 17 O Jake #1/#2 (+) 48 G Exh. Press Sensor (5V) 21 - - 67 - -
22 - - 68 - -
18 Gr Stop Signal Relay Control 49 W Pedal Sensor (Demend) 18 P Jake #1/#2 (-) 49 - -
23 - - 69 - -
19 - - 50 - - 19 - - 50 Y Fuel Pressure 24 - - 70 - -
20 - - 51 - - 20 G Not Used 51 Br Boost Pressure 25 - - 71 - -
21 W/B Engine Brake #2 52 - - 21 R CRS/PTO/RSG Lamp 52 B Exh. Press Sensor (SIG) 26 - - 72 - -
U

27 - - 73 - -
22 - - 53 - - 22 - - 53 L CMPS (+)
28 - - 74 G/R Auto Cooling Fan (Fan Drive I)
23 G/W Check Engine (IND.) 54 - - 23 G Jake #3/#4 (-) 54 R CMPS (-) 29 Lg Remote Pedal Sensor (0V) 75 - -
24 - - 55 G CAN1 (Low) 24 G/W Engine Brake Lamp 55 O CKPS (-) 30 G Auto Cooling Fan (0V) 76 B/W Air Heater Relay Control
PR

25 L/R Clutch Switch 56 G CAN2 (Low) 25 G/B Injector #1 (SCV LO) 56 G CKPS (+) 31 - - 77 - -
32 B/O EGRT (0V) 78 O AMS Air Temp. (Signal)
26 G Parking Switch 57 B Ground (GC11) 26 L Injector #1 (SCV HI) 57 - -
33 - - 79 - -
27 - - 58 B Ground (GC11) 27 B Injector #2 (SCV HI) 58 - - 34 Y/R Exh. Temp. (0V) 80 - -
28 - - 59 B Ground (GC11) 28 G Injector #2 (SCV LO) 59 - - 35 - - 81 - -
29 - - 60 R ENG ECU Relay ON Input 29 P Injector #3 (SCV LO) 60 - - 36 - - 82 - -
O

37 - - 83 - -
30 W Engine Brake #1 61 P ENG ECU Relay ON Input 30 O Injector #3 (SCV HI) 61 - -
38 - - 84 R/O Remote PTO Enable Switch
31 - - 62 Y ENG ECU Relay ON Input 31 W Injector #4 (SCV HI) 62 - - 39 - - 85 - -
40 - - 86 - -
41 - - 87 - -
C

42 G/R ECTS (-) 88 - -

43 - - 89 - -
44 - - 90 - -
45 - - 91 - -
EN

46 - - 92 - -
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (2) SD313-12

HOT IN ON HOT AT ALL TIMES
SMART
JUNCTION
BLOCK
ENG ENG
ECU ECU
5A 20A

ENG
ECU
RELAY AIR
HTR
5A

ENG
ECU
5A

Y B L(ZF A/T) O
L(M/T-DYMOS) INSTRUMENT
W/B(M/T-FSO) CLUSTER R/W R R R Gr O Y
Gr(M/T-ZF) 15
M01-A
C30-A(ZF A/T) ENGINE
C30-D(M/T-DYMOS) CAMSHAFT COOLANT
C30-F(M/T-FSO) (9) (C116-1) INSTRUMENT POSITION TEMPERATURE
E113 2 E13(M/T-ZF) 1 C104 [1] [C116-2] 3 M27 5 M14 5 M80 1 5 M61 M01-B CLUSTER SENSOR SENSOR
2 AUTO NEUTRAL POWER SPECIAL CLUTCH STEERING AUTO POWER AIR 11
COOLING SWITCH STEERING CONNECTOR SWITCH WHEEL CRUISE MODE HTR
FAN OIL ( ) : W/O Mixer High REMOTE SWITCH SWITCH RELAY
TEMPERATURE [ ] : With Mixer High CONTROL
4 5 1 3 SWITCH SWITCH 30 29 33 31 34
1 C30-A(ZF A/T) 2 3 M61
E113 (RIGHT) M01-B 2 1 E108 1 3 E102
C30-D(M/T-DYMOS) 2 C104 4 M27 7 M14 7 M80
(8) (7) (3) (2) (5) (1) (10) (C116-1) (4) (C116-1)
C30-F(M/T-FSO)
[2] [C116-2]
E13(M/T-ZF) L/W
CLOCK
G G SPRING
See Easy Hill Start 1 E103
(EHS) System See P.T.O 4 3 M23 AIR
Control HEATER
System RELAY &
MONITORING
See Starting See Data See Vehicle See See Assist
System Link Details Speed Parking See Stop Brake System 2 E103
System Brakes L/R L/R Lamps

With W/O
EC

Y Br R P Y G/R G G G B/O Br Y G Y G P W W G G L B/O Y G/R B/O Lg R/O PTO PTO Gr L G/W W W/B Br P/B B/W B/W G/B G/W Br Y G/W R L R G/R G/W

C101-4 E100-E2 C101-4 E100-E2 C101-4 E100-E2 C101-4 E100-E1 E100-E2

1 3 60 61 62 74 54 30 8 16 2 47 55 48 56 14 9 40 26 12 34 5 3 7 53 29 84 25 18 17 13 30 21 10 5 55 76 8 23 4 16 24 21 53 54 42 19

ETC
U

29 53 7 32 10 34 12 56 78 64 43 39 51 47 50 38 42 46 44 48 52 38 49 42 41 45 7 59 58 57 40 14 13 18 17 23 40 56 55 26 25 2 1 27 28 3 4 30 29 6 5 31 32 7 8 34 33 10 9 35 36 11 12
E100-E2 E100-E1 C101-4 E100-E1

Lg B/O G/R B/O R Y/R G/R B/O O G R/B W Br B Y O Y G/W Y G B R W B Gr L/B B B B B B P O P O G B G O L G/B G B B G G/B L O P P O W R R W Y B B Y R W G/B L
PR

2 M16-E
ETC W R
CHECK
1 2 E111 SWITCH 2 C119 1 E123-1 1 2 E109 1 2 3 4 E121-2 1 2 3 4 E121-4 1 2 3 4 E121-6
EXHAUST JAKE
MAGNETIC BRAKE
1 M16-E VALVE SOLENOID
#2 SCV NCV SCV NCV SCV NCV
EGR CRANKSHAFT
TEMPERA- B 1 C119 1 E123-2 POSITION INJECTOR INJECTOR INJECTOR
O

TURE SENSOR #2 #4 #6
SENSOR
B B
GM01
3 4 1 2 E104 2 1 3 4 E105
M01-B
2 3 1 C103 1 2 3 E112 3 1 2 5 4 6 M18
35
E111(EGR) 1 E122-1 1 E124-1 1 2 3 4 E121-1 1 2 3 4 E121-3 1 2 3 4 E121-5
1 2 E115 1 2 C121(OBD) JAKE JAKE
C

BRAKE BRAKE
INSTRU- SOLENOID SOLENOID
MENT #1 #3 SCV NCV SCV NCV SCV NCV
CLUSTER
ENGINE RPM EXHAUST AIR BOOST FUEL EXHAUST GAS ACCEL PEDAL 1 E122-2 1 E124-2 INJECTOR INJECTOR INJECTOR
CONTROL GAS TEMPERATURE PRESSURE TEMPERATURE PRESSURE POSITION SENSOR #1 #3 #5
With Mixer High TEMPERA- SENSOR SENSOR & PRESSURE SENSOR
EN

TURE SENSOR GC11

SENSOR
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (3) SD313-13

HOT IN ON HOT AT ALL TIMES
SMART
See Power Distribution See Power Distribution JUNCTION
(SD110-5) (SD110-4) ToAIR
BLOCK
A HTR 5A
ENG ENG (SD313-15) P.43
ECU ECU C.90-7/8/9
5A 20A ENG
ECU
See Passenger 5A
Compartment Fuse Details
(SD120-14)
ENG
ECU See Passenger To EDU
RELAY Compartment Fuse Details B Relay
(SD120-14) (SD313-15)

48 28 31 33 32 34 I/P-J 47 I/P-K 47 I/P-L 9 6 I/P-J

M/T ZF A/T
0.85Y 0.85Br 0.85R 0.85P 0.85Y 0.85L/B
0.85R/W
ZF DYMOS/FSO
36 EC501
P.66 C
0.5B 0.5B 0.5B 0.85L(ZF A/T) 0.85O
0.75Y 0.5Gr(ZF) To Special
11 EC04 0.85L(DYMOS) Connector
0.5W/B(FSO) (SD313-17)
P.121
0.5B
C30-D (DYMOS)
2 E113 2 E13 2 C30-F (FSO) 2 C30-A 1 C104
EC

Supply AUTO NEUTRAL NEUTRAL NEUTRAL POWER

COOLING SWITCH SWITCH SWITCH STEERING OIL
FAN P.119/ P.137/ P.204 TEMPERATURE
Fan Speed P.58 202 139/206 C.30-6 SWITCH
C.20-7 C.24-1 C.30-7 C.32-5
PWM 5V 0V Signal
1 E13 1 C30-D (DYMOS) 1 C30-A 2 C104
4 5 1 3 E113 C30-F (FSO)
U

0.5W/B

10 EC04 P.121
PR

0.5G/R 0.5G 0.5G 0.5G 0.5Gr 0.85L(DYMOS 0.85L 0.85P 0.85W

0.5W/B(FSO)

ZF DYMOS/FSO

M/T ZF A/T
O

See Easy Hill Start

(EHS) System
1 3 60 61 62 C101-4 74 54 30 8 E100-E2 (SD956-2) 14 9 C101-4
ETC
C

ON ENG ECU Fan Drive 5V 0V Signal Neutral P/S Oil

Input Relay I (PWM) Switch Temp. CONTROL
ENG ECU Relay MODULE
Control ON Input Switch
Auto Cooling Fan P.60/70
EN

C.20-4/32-4
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (4) SD313-14

+ BATTERY Not Used

AIR
HEATER
RELAY &
12V MONITORING 35 EC501
P.66
- FUSE
0.5R/B

60R 60R 2 E102

N/A ENGINE EGR EXHAUST GAS
SENDER COOLANT TEMPERATURE TEMPERATURE
+ BATTERY SENSOR TEMPERATURE SENSOR SENSOR
2 1 E103 SENSOR P.186 P.190
P.58 C.20-6 C.20-7
12V P.59 C.20-5
C.20-5 1 2 E111 1 2 E115
- 0.5B/W 0.75L/W 1 3 E102

60B AIR D
HEATER From AIR 0.5G/R 0.5G/W 0.5B/O 0.5R 0.5Y/R 0.5G/R
HTR Relay
(SD313-15)
BODY START
GROUND MOTOR 55 42 19 32 10 34 12 E100-E2

Air Heater (-) (+) 0V Signal 0V Signal ETC

CONTROL
EC

Monitor
MODULE
ECTS EGRT Exh. Temp.
C.60
C.20-3/4
CMPS CKPS Exh. Press Sensor
Boost 0V Boost Vref Vref Fuel 0V Fuel Fuel
Temp. Boost Pressure (5V) (5V) Temp. Pressure Pressure (+) (-) (+) (-) 0V Signal 5V
U

43 39 51 47 46 42 38 50 53 54 56 55 44 52 48 E100-E1

0.5R/B 0.5W 0.5Br 0.5B 0.5G/W 0.5Y 0.5O 0.5Y 0.5L 0.5R 0.5G 0.5O 0.75Y 0.75B 0.75G
PR

3 4 1 2 E104 4 3 1 2 E105
O

BOOST FUEL
PRESSURE TEMPERATURE
SENSOR & PRESSURE 2 1 E108 1 2 E109 1 3 2 E112
P.59/188 SENSOR
CAMSHAFT CRANKSHAFT EXHAUST
C

C.20-5 P.61/62 POSITION POSITION GAS

C.20-5 SENSOR SENSOR PRESSURE
P.63 P.63 SENSOR
C.20-6 C.20-6 P.189
EN

C.20-6
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

EC
U
PR
O
C
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (6) SD313-16

SMART
JUNCTION
From ENG To Instrument BLOCK
ECU 5A E F Cluster
(SD313-15) (SD313-19) P.31
C.90-3

13 26 I/P-D
See Illuminations
(SD941-5)

See Illuminations 0.85R 0.5Br 0.5G/O 0.5B 0.5R See Illuminations 0.85R
(SD941-5) (SD941-2)
12 5 6 M23
CLOCK
SPRING
0.5G/O P.10 0.5G/O
C.10-12
10 5 M80 5 10 M14 3 M27
POWER STEERING AUTO CLUTCH
MODE 8 1 7 WHEEL CRUISE SWITCH
SWITCH STEERING SWITCH P.5
ILL. IND. P.19 COM (+) (-) IND. ILL. P.19
WHEEL C.10-13
C.10-27 REMOTE C.10-9
SET RES CONTROL
SWITCH 4 M27
8 1 4 7 M80 (RIGHT) 7 4 1 8 M14
ILL.

0.5B 0.5B 0.5Lg 0.5Br/O 0.5B/O 0.5B 0.85L/R See P.T.O

Control System
4 3
EC

(SD471-1)
See See
Illuminations CLOCK Illuminations
(SD941-5) 0.85P/B SPRING (SD941-2)
0.85L/R
P.10
C.10-12 See Ground
U

Distribution UMB
(SD130-2) W/O With
4 3 M23
PTO PTO

See Ground
PR

Distribution UMB 0.5L 0.5G/W 0.5Br 2.0B See Stop

(SD130-2) Lamps
(SD927-1)
11 MC81 10 11 9 MC91 1 MC81
P.42 P.42 P.42
O

2.0B 0.5P/B 0.5L 0.5G/W 0.5Br 0.85Gr 0.85L/R

GM01 P.22
5 17 13 10 18 25 C101-4
Power SET/INC RES/DEC Enable Stop Signal Clutch ETC
CONTROL
C

Mode Relay Switch

Switch Control MODULE
Cruise/Engine PTO Switch
P.60/70
GM01 P.22 C.32-4
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (7) SD313-17

W/O MIXER HIGH With MIXER HIGH

SPECIAL
S P E C I A L C O N N E C T O R CONNECTOR
ENGINE
8 7 9 4 3 2 5 1 10 C116-1 1 2 C116-2 RPM
CONTROL
C.32-7 C.32-7 C.32-5
0.85G 0.85L 0.85R/W 0.85Y 0.85O 0.85Gr 0.85B 0.85R 0.85W 0.85R/W 0.5Y
1 3 2 C103
0.85G 0.85G C C
18 MC81 FromENG FromENG 0.85B 0.85R 0.85W
ECU 5A ECU 5A
P.42 (SD313-13) (SD313-13)
0.5G

G 18 13 14 12 21 11 EC501 18 12 21 11 EC501
P.66 P.66
To Instrument 0.5R/O 0.5B/O 0.5Y 0.5G/R 0.5B/O 0.5Lg 0.5R/O 0.5G/R 0.5B/O 0.5Lg
Cluster
(SD313-19)
12 34 C101-4 84 5 3 7 53 29 E100-E2 84 7 53 29 E100-E2

Engine PTO Enable INC DEC Signal Supply 0V Remote PTO Signal Supply 0V ETC
Speed Safety Switch Switch Switch Enable CONTROL
Switch Remote Pedal Sensor Switch Remote Pedal Sensor MODULE
Remote PTO P.60/70
C.20-3/
Pedal Sensor Pedal Switch 20-4/32-4
Ground Exhaust Diagnostic
Power Demend Ground N/C N/O Brake Switch

38 49 42 41 45 7 57 58 59 C101-4 40 E100-E1 64 E100-E2

0.85B 0.5G
EC

0.85R 0.85W 0.85B 0.85Gr 0.85L/B

3 24 EC501
P.66
0.85R 0.5Br
7 6 8 17 16 21 MC81
P.42 5 MC81
P.42
U

0.85R 0.85R 0.5Br

0.85R 0.85W 0.85B 0.85Gr 0.85L/B 0.85B 0.85B 0.85B 0.85B 0.85B 0.85B 2 C119 2 MC91 2 M16-E
PR

EXHAUST P.42 ETC CHECK

MAGNETIC 0.5W SWITCH
VALVE
UCG P.6
P.134/175/177 C.10-10
C.32-9 H
1 C119 1 M16-E
To Instrument
0.5B
O

3 1 2 5 4 6 M18 0.85B Cluster

See Ground (SD313-19)
ACCEL See Ground
PEDAL Distribution
(SD130-14) Distribution UMA
POSITION 2.0B 2.0B (SD130-2)
SENSOR
C

P.11 2.0B
C.10-11
EN

GC11 GM01 P.22

TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

EC
U
PR
O
C
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (9) SD313-19

HOT AT ALL TIMES HOT IN ON OR START
See Power Distribution See Power Distribution SMART
(SD110-4) (SD110-3) JUNCTION
BLOCK
FUSE
SWITCH P.31
ROOM C.90-2/3/5
CLUSTER
LAMP
10A
10A
To Water From ENG
J Level Sensor ECU 5A F See Passenger See Passenger
(SD313-20) (SD313-16) Compartment Fuse Details Compartment Fuse Details
(SD120-16) (SD120-3)

34 31 I/P-D 32 I/P-C 27 I/P-F

0.5R
0.5Y 0.5P 0.5Y/B
0.5R
11 M01-B 18 21 31 M01-A
Over INSTRUMENT
Heat CLUSTER
EXH JNKE PRE CHECK OVER ENG P.7
BRAKE BRAKE HEAT'G ENG OBD HEAT IMMO PTO/ C.10-1
IG2
CRUISE
MONO LCD MOLO
(CRUISE/PTO LCD
5V REG ENABLE)
General

MICOM
IG2 IG2 IG1
IG2 IG2 IG2
EC

I/F CAN1 TRANSCEIVER

Check Pre Jake Cruise/ Oil Exh. P_ S_

OBD ENG P_GND Heating P_GND Brake P_GND ENG PTO B/Pass P_GND Brake High Low GND GND

30 29 33 31 34 4 35 M01-B 15 34 35 22 28 M01-A
U

0.5W 0.5G 0.5Y 0.5G 0.5B 0.5B

0.5G/W 0.5G/W 0.5Br 0.5G 0.5L/O 0.5G
PR

16 17 MC91 19 14 MC81 18 13 MC91 0.5G 0.5L

P.42 P.42 P.42 See Data
Link Details
0.5Br 0.5G 0.5P/O (SD200-3)
H G
7 4 5 EC501 Not Used From Exhaust From Special
P.66 Magnetic Valve Connector 10 MR01
O

(SD313-17) (SD313-17) P.4

0.5G/W 0.5Br 0.5Y 0.5G/W 0.5R
0.5L
23 4 C101-4 16 24 21 E100-E1
ETC 10 R16
C

Check Check Air Heater Engine CRS/PTO

Engine Engine Lamp Brake /RSG CONTROL DIGITAL
MODULE RPM
(IND.) Lamp Lamp Signal TACHOGRAPH
P.60/70 In P.94/96 GM02 GM10
EN

C.20-3/32-4 C.60-3 P.22 P.33

TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
25/6/2021 Global Service Way - Technical Information

2018 > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System > Schematic
Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (10) SD313-20

SMART
JUNCTION
From Instrument BLOCK
Cluster J
(SD313-19) P.43
C.90-7/8

2 I/P-J 4 I/P-K

0.5G/B 0.85Y/R

EGR Type OBD Type

1 E122-2 1 E123-2 1 E124-2 2 C38
AIR AIR JAKE JAKE JAKE WATER
TEMPERA- TEMPERA- BRAKE BRAKE BRAKE LEVEL
TURE TURE SOLENOID SOLENOID SOLENOID SENSOR
SENSOR SENSOR #1 #2 #3 P.46
C.30-9

1 2 E116 1 2 C121 1 E122-1 1 E123-1 1 E124-1 1 C38

P.67 P.215 C.64/190 C.64/190 C.64/190
P.20-9 P.20-9 P.20-9
EC

C.20-7 C.32-10
0.85B

See Assist
Brake System
0.5P 0.5O 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W (SD598-2) See Ground
(SD598-4) Distribution UCC
(SD130-10)
U

(SD598-7)

17 16 EC501 26 25 28 27 29 30 EE01
0.85B
PR

P.66 P.64/190

0.5B/O 0.5O 0.5B/O 0.5O 0.85P 0.85O 0.85P 0.85O 0.85G 0.85B 0.5W 0.5W/B
GC01 P.155
O

56 78 E100-E2 56 78 E100-E2 14 13 18 17 23 40 E100-E1 30 21 8 C101-4

0V Signal 0V Signal (-) (+) (-) (+) (-) (+) Engine Engine High ETC
Brake Brake Coolant CONTROL
AMS Air Temp. AMS Air Temp. Jake #5/#6 Jake #1/#2 Jake #3/#4 #1 #2 Temp. MODULE
C

Lamp P.60/70
C.20-3/20-4/32-4
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:29, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (1) SD313-11

ETC Terminal Information

1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
1 5 9 13 17 21 25 29 33 37 41 45 49 53 57 60 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24
2 6 10 14 18 22 26 30 34 38 42 46 50 54
2 6 10 14 18 22 26 30 34 38 42 46 50 54 58 61 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47
57 61 3 7 11 15 19 23 27 31 35 39 43 47 51 55 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70
3 7 11 15 19 23 27 31 35 39 43 47 51 55
58 62 4 8 12 16 20 24 28 32 36 40 44 48 52 56 59 62
4 8 12 16 20 24 28 32 36 40 44 48 52 56

C101-4 E100-E1 E100-E2

PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION PIN COLOR DESCRIPTION
1 - - 47 - -
1 Br ON Input 32 - - 1 B Injector #1 (NCV LO) 32 R Injector #4 (SCV LO)
2 - - 48 - -
2 Br Start Relay Control (Start Inhibit) 33 - - 2 G Injector #1 (NCV HI) 33 B Injector #5 (SCV LO) 3 Y Remote PTO DEC Switch 49 - -
3 Br ENG ECU Relay Control 34 L PTO Safety Switch 3 G/B Injector #2 (NCV HI) 34 Y Injector #5 (SCV HI) 4 - - 50 - -
4 Br Check Engine 35 - - 4 L Injector #2 (NCV LO) 35 R Injector #6 (SCV HI) 5 B/O Remote PTO INC Switch 51 - -
6 - - 52 - -
5 P/B Power Mode Switch 36 - - 5 O Injector #3 (NCV LO) 36 W Injector #6 (SCV LO)
7 G/R Remote Pedal Sensor (SIG) 53 B/O Remote Pedal Sensor (Supply)
6 - - 37 - - 6 P Injector #3 (NCV HI) 37 - - 8 G Auto Cooling Fan (SIG) 54 G Auto Cooling Fan (5V)
7 B Ground (GC11) 38 R Pedal Sensor (Power) 7 R Injector #4 (NCV HI) 38 O 0V Fuel Pressure 9 - - 55 B/W Air Heater Monitor
8 G/B High Coolant Temp. Lamp 39 - - 8 W Injector #4 (NCV LO) 39 W 0V Boost 10 R EGRT (Signal) 56 B/O AMS Air Temp. (0V)
9 W P/S Oil Temp. Switch 40 W Vehicle Speed 9 Y Injector #5 (NCV LO) 40 B Exh. Brake, Jake #3/#4 11 - - 57 - -
12 G/R Exh. Temp. (Signal) 58 - -
10 Br Cruise/Engine PTO SwitcH (Enable) 41 Gr Pedal Switch (N/C) 10 B Injector #5 (NCV HI) 41 - - 13 - - 59 - -
11 - - 42 B Pedal Sensor (Ground) 11 G/B Injector #6 (NCV HI) 42 Y Fuel Temp. 14 - - 60 - -
12 G Engine Speed 43 - - 12 L Injector #6 (NCV LO) 43 R/B Boost Temp. 15 - - 61 - -
13 G/W Cruise/Engine PTO Switch (RES/DEC) 44 - - 13 O Jake #5/#6 (+) 44 Y Exh. Press Sensor (0V) 16 - - 62 - -
17 - - 63 - -
14 P Neutral Switch 45 L/B Pedal Switch (N/O) 14 P Jake #5/#6 (-) 45 - - 18 - 64 Diagnostic Switch
- G
15 - - 46 - - 15 - - 46 G/W 5V Fuel Pressure 19 G/W ECTS (+) 65 - -
16 B/O Start Relay Control (Sub Start) 47 Y CAN1 (High) 16 Y Air Heater Lamp 47 B 5V Boost Pressure 20 - - 66 - -
EC

17 L Cruise/Engine PTO SwitcH (SET/INC) 48 Y CAN2 (High) 17 O Jake #1/#2 (+) 48 G Exh. Press Sensor (5V) 21 - - 67 - -
22 - - 68 - -
18 Gr Stop Signal Relay Control 49 W Pedal Sensor (Demend) 18 P Jake #1/#2 (-) 49 - -
23 - - 69 - -
19 - - 50 - - 19 - - 50 Y Fuel Pressure 24 - - 70 - -
20 - - 51 - - 20 G Not Used 51 Br Boost Pressure 25 - - 71 - -
21 W/B Engine Brake #2 52 - - 21 R CRS/PTO/RSG Lamp 52 B Exh. Press Sensor (SIG) 26 - - 72 - -
U

27 - - 73 - -
22 - - 53 - - 22 - - 53 L CMPS (+)
28 - - 74 G/R Auto Cooling Fan (Fan Drive I)
23 G/W Check Engine (IND.) 54 - - 23 G Jake #3/#4 (-) 54 R CMPS (-) 29 Lg Remote Pedal Sensor (0V) 75 - -
24 - - 55 G CAN1 (Low) 24 G/W Engine Brake Lamp 55 O CKPS (-) 30 G Auto Cooling Fan (0V) 76 B/W Air Heater Relay Control
PR

25 L/R Clutch Switch 56 G CAN2 (Low) 25 G/B Injector #1 (SCV LO) 56 G CKPS (+) 31 - - 77 - -
32 B/O EGRT (0V) 78 O AMS Air Temp. (Signal)
26 G Parking Switch 57 B Ground (GC11) 26 L Injector #1 (SCV HI) 57 - -
33 - - 79 - -
27 - - 58 B Ground (GC11) 27 B Injector #2 (SCV HI) 58 - - 34 Y/R Exh. Temp. (0V) 80 - -
28 - - 59 B Ground (GC11) 28 G Injector #2 (SCV LO) 59 - - 35 - - 81 - -
29 - - 60 R ENG ECU Relay ON Input 29 P Injector #3 (SCV LO) 60 - - 36 - - 82 - -
O

37 - - 83 - -
30 W Engine Brake #1 61 P ENG ECU Relay ON Input 30 O Injector #3 (SCV HI) 61 - -
38 - - 84 R/O Remote PTO Enable Switch
31 - - 62 Y ENG ECU Relay ON Input 31 W Injector #4 (SCV HI) 62 - - 39 - - 85 - -
40 - - 86 - -
41 - - 87 - -
C

42 G/R ECTS (-) 88 - -

43 - - 89 - -
44 - - 90 - -
45 - - 91 - -
EN

46 - - 92 - -
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:31, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (2) SD313-12

HOT IN ON HOT AT ALL TIMES
SMART
JUNCTION
BLOCK
ENG ENG
ECU ECU
5A 20A

ENG
ECU
RELAY AIR
HTR
5A

ENG
ECU
5A

Y B L(ZF A/T) O
L(M/T-DYMOS) INSTRUMENT
W/B(M/T-FSO) CLUSTER R/W R R R Gr O Y
Gr(M/T-ZF) 15
M01-A
C30-A(ZF A/T) ENGINE
C30-D(M/T-DYMOS) CAMSHAFT COOLANT
C30-F(M/T-FSO) (9) (C116-1) INSTRUMENT POSITION TEMPERATURE
E113 2 E13(M/T-ZF) 1 C104 [1] [C116-2] 3 M27 5 M14 5 M80 1 5 M61 M01-B CLUSTER SENSOR SENSOR
2 AUTO NEUTRAL POWER SPECIAL CLUTCH STEERING AUTO POWER AIR 11
COOLING SWITCH STEERING CONNECTOR SWITCH WHEEL CRUISE MODE HTR
FAN OIL ( ) : W/O Mixer High REMOTE SWITCH SWITCH RELAY
TEMPERATURE [ ] : With Mixer High CONTROL
4 5 1 3 SWITCH SWITCH 30 29 33 31 34
1 C30-A(ZF A/T) 2 3 M61
E113 (RIGHT) M01-B 2 1 E108 1 3 E102
C30-D(M/T-DYMOS) 2 C104 4 M27 7 M14 7 M80
(8) (7) (3) (2) (5) (1) (10) (C116-1) (4) (C116-1)
C30-F(M/T-FSO)
[2] [C116-2]
E13(M/T-ZF) L/W
CLOCK
G G SPRING
See Easy Hill Start 1 E103
(EHS) System See P.T.O 4 3 M23 AIR
Control HEATER
System RELAY &
MONITORING
See Starting See Data See Vehicle See See Assist
System Link Details Speed Parking See Stop Brake System 2 E103
System Brakes L/R L/R Lamps

With W/O
EC

Y Br R P Y G/R G G G B/O Br Y G Y G P W W G G L B/O Y G/R B/O Lg R/O PTO PTO Gr L G/W W W/B Br P/B B/W B/W G/B G/W Br Y G/W R L R G/R G/W

C101-4 E100-E2 C101-4 E100-E2 C101-4 E100-E2 C101-4 E100-E1 E100-E2

1 3 60 61 62 74 54 30 8 16 2 47 55 48 56 14 9 40 26 12 34 5 3 7 53 29 84 25 18 17 13 30 21 10 5 55 76 8 23 4 16 24 21 53 54 42 19

ETC
U

29 53 7 32 10 34 12 56 78 64 43 39 51 47 50 38 42 46 44 48 52 38 49 42 41 45 7 59 58 57 40 14 13 18 17 23 40 56 55 26 25 2 1 27 28 3 4 30 29 6 5 31 32 7 8 34 33 10 9 35 36 11 12
E100-E2 E100-E1 C101-4 E100-E1

Lg B/O G/R B/O R Y/R G/R B/O O G R/B W Br B Y O Y G/W Y G B R W B Gr L/B B B B B B P O P O G B G O L G/B G B B G G/B L O P P O W R R W Y B B Y R W G/B L
PR

2 M16-E
ETC W R
CHECK
1 2 E111 SWITCH 2 C119 1 E123-1 1 2 E109 1 2 3 4 E121-2 1 2 3 4 E121-4 1 2 3 4 E121-6
EXHAUST JAKE
MAGNETIC BRAKE
1 M16-E VALVE SOLENOID
#2 SCV NCV SCV NCV SCV NCV
EGR CRANKSHAFT
TEMPERA- B 1 C119 1 E123-2 POSITION INJECTOR INJECTOR INJECTOR
O

TURE SENSOR #2 #4 #6
SENSOR
B B
GM01
3 4 1 2 E104 2 1 3 4 E105
M01-B
2 3 1 C103 1 2 3 E112 3 1 2 5 4 6 M18
35
E111(EGR) 1 E122-1 1 E124-1 1 2 3 4 E121-1 1 2 3 4 E121-3 1 2 3 4 E121-5
1 2 E115 1 2 C121(OBD) JAKE JAKE
C

BRAKE BRAKE
INSTRU- SOLENOID SOLENOID
MENT #1 #3 SCV NCV SCV NCV SCV NCV
CLUSTER
ENGINE RPM EXHAUST AIR BOOST FUEL EXHAUST GAS ACCEL PEDAL 1 E122-2 1 E124-2 INJECTOR INJECTOR INJECTOR
CONTROL GAS TEMPERATURE PRESSURE TEMPERATURE PRESSURE POSITION SENSOR #1 #3 #5
With Mixer High TEMPERA- SENSOR SENSOR & PRESSURE SENSOR
EN

TURE SENSOR GC11

SENSOR
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:32, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CE(Euro-5) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CE : L-ENG (EURO 5)) (3) SD313-13

HOT IN ON HOT AT ALL TIMES
SMART
See Power Distribution See Power Distribution JUNCTION
(SD110-5) (SD110-4) ToAIR
BLOCK
A HTR 5A
ENG ENG (SD313-15) P.43
ECU ECU C.90-7/8/9
5A 20A ENG
ECU
See Passenger 5A
Compartment Fuse Details
(SD120-14)
ENG
ECU See Passenger To EDU
RELAY Compartment Fuse Details B Relay
(SD120-14) (SD313-15)

48 28 31 33 32 34 I/P-J 47 I/P-K 47 I/P-L 9 6 I/P-J

M/T ZF A/T
0.85Y 0.85Br 0.85R 0.85P 0.85Y 0.85L/B
0.85R/W
ZF DYMOS/FSO
36 EC501
P.66 C
0.5B 0.5B 0.5B 0.85L(ZF A/T) 0.85O
0.75Y 0.5Gr(ZF) To Special
11 EC04 0.85L(DYMOS) Connector
0.5W/B(FSO) (SD313-17)
P.121
0.5B
C30-D (DYMOS)
2 E113 2 E13 2 C30-F (FSO) 2 C30-A 1 C104
EC

Supply AUTO NEUTRAL NEUTRAL NEUTRAL POWER

COOLING SWITCH SWITCH SWITCH STEERING OIL
FAN P.119/ P.137/ P.204 TEMPERATURE
Fan Speed P.58 202 139/206 C.30-6 SWITCH
C.20-7 C.24-1 C.30-7 C.32-5
PWM 5V 0V Signal
1 E13 1 C30-D (DYMOS) 1 C30-A 2 C104
4 5 1 3 E113 C30-F (FSO)
U

0.5W/B

10 EC04 P.121
PR

0.5G/R 0.5G 0.5G 0.5G 0.5Gr 0.85L(DYMOS 0.85L 0.85P 0.85W

0.5W/B(FSO)

ZF DYMOS/FSO

M/T ZF A/T
O

See Easy Hill Start

(EHS) System
1 3 60 61 62 C101-4 74 54 30 8 E100-E2 (SD956-2) 14 9 C101-4
ETC
C

ON ENG ECU Fan Drive 5V 0V Signal Neutral P/S Oil

Input Relay I (PWM) Switch Temp. CONTROL
ENG ECU Relay MODULE
Control ON Input Switch
Auto Cooling Fan P.60/70
EN

C.20-4/32-4
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:39, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (4) SD313-4

Not Used

+ BATTERY AIR 35 EC101

HEATER
RELAY & P.66
12V MONITORING 0.5R/B
- FUSE 2 E102
ENGINE EGR PRESSURE
SENDER COOLANT TEMPERATURE SENSOR
60R 60R TEMPERATURE SENSOR EURO 4
SENSOR SENSOR EURO 4
P.58 P.79
N/A C.23-2
BATTERY C.20-5
+
2 1 E111 3 2 1 E07
2 1 E103 1 C110 P.186
12V P.59 P.65 1 3 E102 C.20-6 0.5G/B 0.5G 0.5G/O
C.20-5 C.32-6
-
0.5Y 0.75L/W 0.85O 3 2 1 EC12
P.82
EURO 4 EURO 2/3 0.5G/R 0.5Y/R 0.5R 0.5G 0.5G/B 0.5G 0.5G/O
60B AIR
HEATER 11 20 21 EC101
B P.66
From AIR HTR Relay 0.5Br 0.5L 0.5L
BODY START (SD313-3)
GROUND MOTOR 39 42 41 29 43 34 33 30 E100-2

Air Heater 0V Signal Signal 0V 0V Signal 5V ETC

CONTROL
EC

Monitor
Coolant Temp. EGR Temp. Delta Pressure MODULE
P.187
C.20-1/2
Boost CMPS CKPS AMS Air Temp. Air Mass Flow
Inlet Air 0V Boost 5V_I_ 5V Fuel Fuel 0V Fuel Fuel
Temp. Boost Pressure Boost Pressure Temp. Pressure Pressure (+) (-) (+) (-) Ambient 0V Signal 14V 0V
U

34 27 30 28 42 41 46 45 53 54 49 50 E100-1 25 26 13 9 10 E100-2

0.5R/B 0.5B 0.5Br 0.5R 0.5R/B 0.5Y 0.5G/W 0.5Y 0.5R 0.5L 0.5G 0.5O 0.5L/B 0.5Lg 0.5G/O 0.5G/B 0.5G/O
PR
O

3 4 1 2 E104 4 3 1 2 E105 2 1 E108 1 2 E109 5 4 1 3 2 E119

BOOST FUEL CAMSHAFT CRANK- MASS AIR
PRESSURE TEMPERA- POSITION SHAFT FLOW
SENSOR TURE & SENSOR POSITION ATS AMS SENSOR
C

EURO 4 PRESSURE P.63 SENSOR EURO 4

SENSOR C.20-6 P.63
P.59/188 EURO 4 C.20-6 P.67
C.20-5 C.20-7
EN

P.61/62
C.20-5
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:40, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (5) SD313-5

HOT AT ALL TIMES
SMART
See Power Distribution JUNCTION
(SD110-4) BLOCK
P.31
EDU C.90-2/3
15A From ENG To Clock
ECU 5A A D Spring
(SD313-3) (SD313-6)

39 I/P-C 25 I/P-D

1.25R 0.85W
SUB
1 4 M66-1 RELAY
EDU BLOCK
RELAY
P.30
C.10-22

5 2 M66-1
See Data Link Details
1.25R 0.85B (SD200-4)
(SD200-5)
23 MC91
P.42
1.25R

1 EC101
P.66 GM04 P.22 0.5B 0.5Y 0.85Y/W 0.85G/W 0.85Y 0.85Y 0.85G 0.85G
0.75Br
EC

13 15 16 E101 45 53 27 42 46 54 50 35 C101-1

EDU Relay High Low EDU High Low ETC

ON Input CONTROL CONTROL
MODULE CAN1_High CAN1_Low MODULE
CAN2 CAN2
P.60/187 Start Relay Control P.187
Position Sensor Motor C.20-5 Engine Torque C.20-1/
Shield 20-2/32-1
U

Service Selection Sub Start Vehicle Engine Parking

Ground U V W PWR GND W V U Ground Mode Lamp Start Inhibitot Speed Speed Switch
5 1 2 3 8 4 12 11 10 14 E101 19 E100-2 48 E100-1 9 7 48 1 21 C101-1
PR

N/A 0.5R/B 0.5W 0.5Br 0.5R 0.5B 0.5B 0.5G 0.5Br 0.75Br/B 0.5G/W 0.5Y/O 0.85B/O 0.85Br 0.85W 0.85G 0.85G

15 9 6 EC101
P.66
1.25B
O

See Ground
0.5R/B 0.5W 0.5Br Distribution
(SD130-14) See Parking
Not Used See Starting See Vehicle Brakes
4 3 2 1 5 6 7 8 E107 1.25B System Speed System (SD597-1)
EGR (SD360-1) (SD436-1)
C

U V W PWR GND W V U ACTUATOR

Position Sensor Motor P.68
C.20-6
EN

GC11
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:40, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (6) SD313-6

SMART
JUNCTION
From ENG To Instrument BLOCK
ECU 5A D E Cluster
(SD313-5) (SD313-9) P.31
C.90-3

13 26 I/P-D
See Illuminations
(SD941-5)

0.5G/O 0.5B 0.5Br 0.5R See Illuminations 0.85R

(SD941-2)
5 6 12 M23
CLOCK
SPRING
P.10 0.5G/O
C.10-12
5 10 M14 3 M27
STEERING AUTO CLUTCH
1 7 8 WHEEL CRUISE SWITCH
STEERING SWITCH P.5
(+) (-) COM IND. ILL. P.19
WHEEL C.10-13
REMOTE C.10-9
SET RES CONTROL
SWITCH 4 M27
(RIGHT) 7 4 1 8 M14
ILL.
See P.T.O
0.5Br/O 0.5B/O 0.5B Control System
4 3 (SD471-1)
EC

See Illuminations
(SD941-2)
CLOCK 0.85L/R 0.85L/R
SPRING
P.10 See Ground
C.10-12 Distribution UMB W/O With
U

(SD130-2) PTO PTO

4 3 M23
See Assist See A/C
Brake System Control System
PR

0.5L 0.5G/W 0.5Br 2.0B

(SD598-1) See Stop (SD971-3)
(SD598-7) Lamps (SD971-5)
(SD927-1) (SD971-7)
10 11 9 MC91 1 MC81
P.42 P.42

0.5L 0.5G/O 0.5Br 0.5W 0.5W/B 0.5L/R 0.85Gr 0.5Br/O

O

GM01 P.22
20 16 11 4 8 36 32 24 C101-1
SET/INC RES/DEC Enable Engine Engine Clutch Stop Signal A/C Thermo ETC
CONTROL
C

Brake #1 Brake #2 Switch Relay High

Control MODULE
Cruise/Engine PTO Switch
P.187
C.32-1
EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:41, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (7) SD313-7

W/O MIXER HIGH With MIXER HIGH

SPECIAL
S P E C I A L C O N N E C T O R CONNECTOR
ENGINE
8 7 4 9 3 2 5 1 10 C116-1 1 2 C116-2 RPM
CONTROL
C.32-7 C.32-7 C.32-5
0.85G 0.85L 0.85R 0.85R/W 0.85O 0.85Gr 0.85B 0.85R 0.85W 0.85R/W 0.85R/Y
1 3 2 C103
0.85G 0.85G C C
18 MC81 FromENG FromENG 0.85B 0.85R 0.85W
ECU 5A ECU 5A
P.42 (SD313-3) (SD313-3)
0.5G

F 18 17 14 13 12 EC101 14 12 13 EC101
P.66 P.66
To Instrument 0.5Y 0.5R/O 0.5Br/O 0.5Br/W 0.5B/W 0.5Br/O 0.5B/W 0.5Br/W
Cluster
(SD313-9)
1 39 29 C101-1 45 49 5 6 7 E100-2 29 C101-1 5 7 6 E100-2

Engine PTO Enable INC DEC Signal Power Ground Remote PTO Signal Ground Power ETC
Speed Safety Switch Switch Switch Enable CONTROL
Switch Remote Pedal Sensor Switch Remote Pedal Sensor MODULE
Remote PTO P.187
C.20-1/
Pedal Sensor Pedal Switch 20-2/32-1
Ground Exhaust Diagnostic
Power Demend Ground N/C N/O Brake Switch

34 33 37 41 40 57 58 59 C101-1 36 E100-1 47 C101-1

0.85B 0.5Br
EC

3 EC101 5 MC81
0.85R 0.85W 0.85B 0.85Gr 0.85L/B P.66 P.42
0.85R

7 6 8 17 16 21 MC81
U

0.5Br
P.42 0.85R 0.85R
2 C105 2 MC91 2 M16-E
PR

EXHAUST P.42 ETC CHECK

MAGNETIC 0.5W SWITCH
0.85R 0.85W 0.85B 0.85Gr 0.85L/B 0.85B 0.85B 0.85B 0.85B 0.85B VALVE P.6
P.134/175/177 C.10-10
C.32-5 G
1 C105 1 M16-E
To Instrument 0.5B
O

3 1 2 5 4 6 M18 UCG Cluster

0.85B
See Ground (SD313-9)
ACCEL See Ground
PEDAL Distribution
(SD130-14) Distribution UMA
POSITION 2.0B 1.25B (SD130-2)
SENSOR
C

P.11 2.0B
C.10-11
EN

GC11 GM01 P.22

TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:42, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (8) SD313-8

1 3 E121-1 1 3 E121-3 1 3 E121-5

INJECTOR INJECTOR INJECTOR
SCV NCV #1 SCV NCV #3 SCV NCV #5
P.64/190 P.64/190 P.64/190
C.20-8 C.20-8 C.20-8

2 4 E121-1 2 4 E121-3 2 4 E121-5

0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W

2 3 4 1 6 7 12 9 10 11 20 17 EE01
P.64/190

0.85G 0.85L 0.85G/B 0.85B 0.85P 0.85O 0.85P 0.85O 0.85B 0.85Y 0.85B 0.85Y

2 3 4 1 6 7 12 9 10 11 20 17 E100-1

NCV SCV SCV NCV NCV SCV SCV NCV NCV SCV SCV NCV ETC
HI HI LO LO HI HI LO LO HI HI LO LO CONTROL
MODULE
Injector #1 Injector #3 Injector #5 P.187
C.20-1
Injector #2 Injector #4 Injector #6

NCV SCV SCV NCV NCV SCV SCV NCV NCV SCV SCV NCV
HI HI LO LO HI HI LO LO HI HI LO LO
EC

14 15 8 5 18 19 16 13 22 23 24 21 E100-1

0.85G/B 0.85B 0.85G 0.85L 0.85R 0.85W 0.85R 0.85W 0.85G/B 0.85R 0.85W 0.85L
U

14 15 8 5 18 19 16 13 22 23 24 21 EE01
P.64/190
PR

0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W 0.85W

2 4 E121-2 2 4 E121-4 2 4 E121-6

INJECTOR INJECTOR INJECTOR
SCV NCV #2 SCV NCV #4 SCV NCV #6
O

P.64/190 P.64/190 P.64/190

C.20-8 C.20-8 C.20-8
C

1 3 E121-2 1 3 E121-4 1 3 E121-6

EN
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:44, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (9) SD313-9

HOT AT ALL TIMES HOT IN ON OR START
See Power Distribution See Power Distribution SMART
(SD110-4) (SD110-3) JUNCTION
BLOCK
FUSE
SWITCH P.31
ROOM C.90-2/
CLUSTER
LAMP 3/5
10A
10A
To Water From ENG
H Level Sensor ECU 5A E See Passenger See Passenger
(SD313-10) (SD313-6) Compartment Fuse Details Compartment Fuse Details
(SD120-16) (SD120-3)

34 31 I/P-D 32 I/P-C 27 I/P-F

0.5R
0.5Y 0.5P 0.5Y/B
0.5R
11 M01-B 18 21 31 M01-A
Over INSTRUMENT
Heat CLUSTER
EXH JNKE PRE CHECK OVER ENG P.7
BRAKE BRAKE HEAT'G ENG OBD HEAT IMMO PTO/ C.10-1
IG2
CRUISE
MONO LCD MOLO
(CRUISE/PTO LCD
5V REG ENABLE)
General

MICOM
IG2 IG2 IG1
IG2 IG2 IG2
EC

I/F CAN1 TRANSCEIVER

Check Pre Jake Cruise/ Oil Exh. P_ S_

OBD ENG P_GND Heating P_GND Brake P_GND ENG PTO B/Pass P_GND Brake High Low GND GND

30 29 33 31 34 4 35 M01-B 15 34 35 22 28 M01-A
EURO 2/3 EURO 4
U

0.5Br 0.5G 0.5L/O 0.5G 0.5W 0.5G 0.5Y 0.5G 0.5B 0.5B
0.5G/W 0.5G/W 0.5Br
19 14 MC81 18 13 MC91
PR

EURO 4 EURO 2/3 P.42 P.42 0.5G 0.5L

17 16 MC91 See Data
0.5Br 0.5G 0.5P/O 0.5G Link Details
P.42
0.5Br (SD200-3)
G F
10 5 7 4 32(EURO 2/3) EC101 From Exhaust From Special
36(EURO 4) P.66 Magnetic Valve Connector 10 MR01
O

(SD313-7) (SD313-7) P.4

0.5G/W 0.5O 0.5B 0.5G 0.5G
Not Used 0.5L
18 C101-1 27 E100-2 52 40 56 E100-1
ETC 10 R16
C

Check Check Air Heater Engine CRS/PTO

Engine Engine Lamp Brake /RSG CONTROL DIGITAL
MODULE RPM
Lamp Lamp Signal TACHOGRAPH
P.187 In P.94/96
EN

C.20-1/20-2/32-1 C.60-3
GM02 P.22 GM10 P.30
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1
16:46, 14/09/2021 Global Service Way - Technical Information

2020 > Engine > D6CC(Eur0-4) > Schematic Diagrams > Engine Electrical System > Engine Control System >
Schematic Diagrams

Engine Control System (D6CA/D6CB/D6CC : L-ENG (EURO 2/3/4)) (10) SD313-10

SMART
JUNCTION
From Instrument BLOCK
Cluster H
(SD313-9) P.43
C.90-7/8

2 I/P-J 4 I/P-K

0.5G/B 0.85Y/R

1 E122-2 1 E123-2 1 E124-2 2 C38

JAKE JAKE JAKE WATER
BRAKE BRAKE BRAKE LEVEL
SOLENOID SOLENOID SOLENOID SENSOR
#1 #2 #3 P.46
C.30-9
1 E122-1 1 E123-1 1 E124-1 1 C38
P.64/190 P.64/190 P.64/190
C.20-9 C.20-9 C.20-9
EC

0.85B
0.85W 0.85W 0.85W 0.85W 0.85W 0.85W
U

See Ground
26 25 27 28 29 30 EE01 Distribution UCC
PR

P.64/190 (SD130-10)

0.85G 0.85B 0.85G 0.85B 0.85G 0.85B

0.85B
O

26 25 35 36 43 44 E100-1 22 C101-1
GND MED/HI 1 GND LO/HI GND MED/HI 2 High Coolant ETC
Temp. Lamp CONTROL
Jake Solenoid MODULE
C

P.187
C.20-1/32-1
EN

GC01 P.155
TE
R

https://service.hyundai-motor.com/manualV2/content/view?printFlag=1&oriMnuKCd=ETM&imgMethod=original&popupVehlTypeCd=CA 1/1