Service Manual

Model: MAXIDRIVE3.4
3-WAY STEREO DIGITAL CROSSOVER

www.altoproaudio.com
Version: 1.1
CONTENTS

1. Specification…………………………………………. 2

2. Block Diagram………………………….…………… 1

3. Schematic Diagram..………………….,……..……. 9

4. Printed Circuit Board………………………………. 8

5. Wiring Diagram…………………………………..…. 1

6. Test Procedure………………………………….…… 0

7. Electrical Parts List………………………………… 18

8. Exploded Views & Mechanical Parts List………… 1

9. Troubleshooting………………………………..……. 0

10. Notes…………………………………………….…… 0
2/ Tqfdjgjdbujpot

General specifications:

INPUT section
Connectors 2 x COMBO
Nominal input sensitivity 0dB(0.775v)
Input Impedance 30KOhm
Max.Input level +20dBu
Input Gain –30/+6 dB step 0.5dB
Digital input AES/EBU, XLR-F
Digital input sample rate 32kHz/48kHz
Output section
Connectors 6 x XLR-M
Output Impedance 600Ohm
Nominal Output level 0dBu
Maximum Output level +20dBu
Output Gain –30/+6dB step 0.5dB
DSP Section
A/D converters 20bit
D/A converters 20bit
Internal dynamics 40bit
Sampling fequency 48kHz
Features
Configuration 2-WAY STEREO, 3-WAY STEREO,
2,3,4,5,6-WAY MONO
Crossover Filters Type Bessel , Butter worth or Linkwitz-Riley
Crossover Filters Slope 6, 12, 18, 24, or 48dB per octave
Delay Step 21 microseconds minimum
Max Delay time 2621 ms (inputs), 291 ms(output)
EQ filters Up to 40 maximum (depending on the
crossover slope)
EQ Type Peak, 6dB Lo-Shelf, 12dB Lo-Shelf, 6dB Hi-Shelf,
12dB Hi-Shelf, Notch +/-15dB, variable in 0.05
steps
EQ Gain +/-15dB, variable in 0.5dB steps
EQ Bandwidth 0.05 to 3.00 octaves, variable in 0.05 steps
EQ freq 15.6Hz to 16kHz
Dynamics Digital limiter on all the output
Memories FACTORY PRESETS are 10+128 USER PRESETS
+128 CARD PRESETs
 Communications 9-pin RS232, XLR-F RS485 IN, XLR-M RS485 OUT
General Performance(with filters out)
Frequency Response 20Hz-20KHz, 0.25dB
Dynamic range >117dB 20Hz to 20KHz
>120dB 20Hz to 20KHz on AES/EBU input
Channel Separation >100dB 20Hz to 20KHz
Distortion(THD) 0.05%, 20Hz to 20KHz
Input Meter -24dB, -18dB, -12dB, -6dB, CLIP relative to Clip
point(+20dBu)
Outpur Meter -24dB, -12dB, -6dB, LIMIT relative to limiter
threshold setting, CLIP
General
Dimensions 483 x 44 x 300mm
Weight 4.0kg
 2.Block Diagram

IN A ADC

R
O
U
T
I
N
G

IN A
B ADC
 1 2 3 4
CN1
CN2*4-2 TO DISPLAY +5VD
+5VD SD_OUT
C14

1
3
5
7
1
3
5
7
9
10
1 104P R20
2 DL42 RED 1K2
+5VD+5VD
3 C4 DELAY

QS
QS'
4
AR4 AR1
10U 4K7*4 4K7*4 R22 11
D 5 C15 IC6A DL44 RED 1K2 D7 D
R13 R8 74HC165D R31 R6 12
6 220U UTILITY D6
3K9 1K 10K 10K 13
7 R18 D5

2
4
6
8
2
4
6
8
11 9 14
8 MUTE3 SW11 A QH DL41 RED 1K2 D4
12 7 7
9 MUTE4 SW12 B QH PRESET D3
13 6
IC3A

10 MUTE5 SW13 C R21 D2

HCF4094

14 5
11 MUTE6 SW14 D DL43 RED 1K2 D1
9 8 IC1D 3 15 4
3.Schematic Diagram

12 MUTE2 SW10 E CI EDIT D0

74HC14D 4 2
13 MUTE1 SW9 F CK
5 1
EO
STR
CP
D

14 ENTER SW3 G S/L

1 2 IC1A 6 10
ESC SW8 H SIN
CN2 74HC14D
1
3
2

CN2*10 +5VD
15

5 6 IC1C R25

1
3
5
7
1
3
5
7
TO CPU 74HC14D 1K2
1 DL45 RED
3 4 IC1B MUTE1
2
9
10

AR3 AR2 R26

3 74HC14D 1K2
4K7*4 4K7*4 DL46 RED
4 IC2A
3 4 IC4B MUTE2
C 5 74HC165D R28 C
QS
QS'

6 74HC04D 1K2
DL47 RED

2
4
6
8
2
4
6
8
11 9 11
7 MODE SW4 A QH MUTE3 D7
12 7 12
8 B QH R27 D6
PAG UP 13 13
9 SW2 C DL48 RED 1K2 D5
+5VD GIU 14 14
10 SW7 SW6 D MUTE4 D4
3 15 7
11 PAG DW SW1 E CI R29 D3
30P-ENCODER 4 2 6
IC5A

12 SU SW5 F CK DL49 RED 1K2 D2

+5VD 5 1 5
HCF4094

13 G S/L MUTE5 D1
6 10 4
14 H SIN R30 D0
15 DL50 RED 1K2
R24
EO
STR
CP
D

16 IC1F R7 MUTE6
17 R3 10K
74HC14D IC4C IC4A 10K
18 5K6 74HC04D 74HC04D
1
3
2

12 13 +5VD +5VD
15

19
20
5 6 1 2
R5 R23 D1
10 11 5K6 +5VD +5VD 100K 4148
B IC1E IC4D IC4E B
74HC04D 74HC04D C9 C8
74HC14D CLOCK1 47P 47P
9 8 11 10 R14 R19 C17
R12 10R C2 R2 C1 R1 OUT EN
103P 5K6 103P 5K6 10K 10K 10U
R10 10R
R15 10R
R11 10R
R16 10R 13 12
CLOCK
R17 10R IC4F C10 C7 C16
74HC04D 47P 47P 47P
STROBE LED P80
R4 P80 P80 Display front board
4R7 1/2W MAXIFP2.SCH
+5VD P90
P90

14
16
16
16
16
14

C18 1 CN4
A 10U 2 2P2.5 Titel A
MAXIDRIVE
P90

7
8
8
8
8
7

Size Model No: Revision

C11 IC4G C6 IC3B C12 IC5B C13 IC6B C5 IC2B C3 IC1G A4 Display front board VER020610
104P 74HC04D 104P HCF4094 104P HCF4094 104P 74HC165D 104P 74HC165D 104P 74HC14D
Date: 27-Aug-2002 Sheet 0 of 0
File: MAXIFP1.Sch Drawn By: C.C.LIN
1 2 3 4
 1 2 3 4

+5VD

16
16
C19 C20
2 10 2 10 104P 104P
D QS' D QS'
3 3
D CLOCK1 CP IC10A CP IC11A D

8
8
1 1
STR STR IC7B IC8B
HCF4094BM 9 HCF4094BM 9
QS QS HCF4094BM HCF4094BM
15 15
EO EO

D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
+5VD

16
16

4
5
6
7
4
5
6
7

14
13
12
11
14
13
12
11
C21 C22
104P 104P
8
8

R56 R57 R58 R59 R60 R61 R62 R63 R64 R65 R66 R67 R68 R69 R70 R71 IC9B IC10B
1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 HCF4094BM HCF4094BM
DL3 DL5 DL8 DL12 DL11 DL7 DL4 DL16 DL14 DL15 DL22 DL26 DL19 DL23 DL27 DL31
+5VD
16

CLIP -6dB -12dB -18dB -24dB -18dB -12dB -24dB LIMIT -6dB -12dB -24dB LIMIT -6dB -12dB -24dB
C C23 C
B B B B A A A B OUT2 OUT2 OUT2 OUT2 OUT3 OUT3 OUT3 OUT3
104P
OUT EN
8

IC11B
CLOCK HCF4094BM
STROBE LED
SD_OUT
R72
2 10 0R 2 10 2 10
D QS' D QS' D QS'
3 3 3
CP IC7A CP IC8A CP IC9A
1 1 1
STR HCF4094BM STR HCF4094BM STR HCF4094BM
9 9 9
QS QS QS
15 15 15
EO EO EO

D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7
D0
D1
D2
D3
D4
D5
D6
D7

4
5
6
7
4
5
6
7
4
5
6
7

14
13
12
11
14
13
12
11
14
13
12
11

B B

R32 R33 R34 R35 R36 R37 R38 R39 R40 R41 R42 R43 R44 R45 R46 R47 R48 R49 R50 R51 R52 R53 R54 R55
1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2 1K2
DL1 DL2 DL6 DL9 DL10 DL21 DL17 DL13 DL18 DL20 DL24 DL28 DL29 DL25 DL32 DL35 DL33 DL36 DL38 DL40 DL30 DL34 DL37 DL39

CLIP -6dB CLIP LIMIT CLIP -24dB -12dB -6dB CLIP CLIP LIMIT -6dB LIMIT CLIP -12dB -24dB -6dB -12dB -24dB -24dB LIMIT CLIP -6dB -12dB
A A OUT1 OUT1 OUT2 OUT1 OUT1 OUT1 OUT3 OUT4 OUT4 OUT4 OUT5 OUT5 OUT4 OUT4 OUT5 OUT5 OUT5 OUT6 OUT6 OUT6 OUT6 OUT6

A Titel A
MAXIDRIVE

Size Model No: Revision

A4 Display front board VER020610
Date: 27-Aug-2002 Sheet 2 of 2
File: MAXIFP2.Sch Drawn By: C.C.LIN
1 2 3 4
 1 2 3 4

D D
DSP CPU MAIN A/D INTPUT
DSP-CPU.SCH AD-IN.SCH

DIGITAL I/O BUS DIGITAL I/O BUS

RXP RXP

RXN RXN

MUTE

C C

DSP CPU POWER D/A CONVERTER OUTPUT

DSP-PS.SCH DA-CONV.SCH

DIGITAL I/O BUS

MUTE
B B

Title
A DX26 CPU & AD/DA BOARD A
PCB# F313072
F313072.PRJ (F3130372 MAIN PROJECT)
Size Number Revision
A4
Date: 20-Oct-2002 Sheet of
File: D:\zhong\PRODUCT\DX26\SCHPCB\DX26.ddb
Drawn By: SHUNZA
1 2 3 4
 1 2 3 4 5 6 7 8

DSP DATA BUS

CN9 CN2*10 +5VD AR35 +5VD DSP ADDR BUS

IC33A 74HC374DW IC20B MMS-REDLG
SD_IN 100R*4
1 2
SD_CLK SD_OUT 2 1 DB0 DB0 7 8 2 3 AD0 1 2 DD0 DD0 201 35 7 8 DA0 IC14 GM71C18163CJ-6 IC27D
3 4 Q0 D0 D_D0 D_A0
STBLED 4 3 DB1 DB1 5 6 5 4 AD1 AR3 3 4 DD1 DD1 202 36 5 6 DA1 DA0
17 2 DD0 9 8
PRG
5 6
DB0 AR36 DB2 DB2
Q1 D1
AD2 DD2 DD2
D_D1 D_A1
DA2 DA1
A0 DD0
DD1 74HC04D
7 8
6 5 3 4 6
Q2 D2
7 4.7K*4 5 6 203
D_D2 D_A2
39 3 4 AR21 18
A1 DD1
3
DB1 DB2 4.7K*4 8 7 DB3 DB3 1 2 9 8 AD3 7 8 DD3 DD3 204 40 1 2 DA3 100R*4 DA2
19 4 DD2
9 10 Q3 D3 D_D3 D_A3 A2 DD2
DB3 DB4 8 7 DB4 DB4 1 2 12 13 AD4 1 2 DD4 DD4 205 41 7 8 DA4 AR25 DA3
20 5 DD3 IC27E
11 12 Q4 D4 AR2 D_D4 D_A4 A3 DD3
DB5 DB6 6 5 DB5 DB5 3 4 15 14 AD5 3 4 DD5 DD5 206 42 5 6 DA5 100R*4 DA4
23 7 DD4 11 10
13 14 AR34 Q5 D5 4.7K*4 D_D5 D_A5 A4 DD4 74HC04D
DB7 DE 4.7K*4 4 3 DB6 DB6 5 6 16 17 AD6 5 6 DD6 DD6 207 43 3 4 DA6 DA5
24 8 DD5
D DCS2
15 16
DRST 2 1 DB7 DB7 7 8 19
Q6 D6
18 AD7 7 8 DD7 DD7 1
D_D6 D_A6
44 1 2 DA7 R65 DA6
25
A5 DD5
9 DD6 D

DRAM 1M*16
17 18 Q7 D7 D_D7 D_A7 100R A6 DD6
DIAL0 DIAL1 1 11 1 2 DD8 DD8 2 45 DA8 R68 DA7
26 10 DD7 IC27F
19 20 AR33 OE CP D_D8 D_A8 A7 DD7
AR11 3 4 DD9 DD9 3 46 DA9 100R +5VD DA8
27 33 DD8 13 12
100R*4 LGND 4.7K*4 5 6 DD10 DD10 4
D_D9 D_A9
49 DD16 DD16 2 1 DA9
28
A8 DD8
34 DD9 74HC04D
D_D10 D_A10 A9 DD9
7 8 DD11 DD11 5 50 DD17 DD17 4 3 11 35 DD10
STBSWT IC34A 74HC374DW 1 2 DD12 DD12 6
D_D11 D_A11
51 DD18 DD18 6 AR18
5 4.7K*4 12
NC DD10
36 DD11
PWM DIS R96 4K7 DE DE R95 100R 2 3 AD8 3 4 DD13 DD13 7
D_D12 D_A12
52 DD19 DD19 8 7 15
NC DD11
38 DD12
Q0 D0 AR15 D_D13 D_A13 NC DD12 IC30A
RXRST 5 4 AD9 4.7K*4 5 6 DD14 DD14 8 53 DD20 DD20 2 1 DWR 13 39 DD13 1 2
8 7 D/I D/I 6
Q1 D1
7 AD10 7 8 DD15 DD15 11
D_D14 D_A14
54 DD21 DD21 4 AR17
3 4.7K*4 DRAS 14
WR DD13
40 DD14 74HC04D
Q2 D2 D_D15 D_A15 RAS DD14
6 5 DCS1 DCS1 9 8 AD11 55 DD22 DD22 6 5 30 41 DD15
AR37 Q3 D3 D_A16 OCAS DD15
4.7K*4 4 3 DCS2 DCS2 12 13 AD12 56 DD23 DD23 8 7 AR28A DCAS 31 32 IC30D
Q4 D4 AR28C D_A17 CCAS NC
2 1 DRST DRST 15 14 AD13 4.7K*4 5 6 DD26 DD26 71 57 DD24 DD24 2 1 4.7K*4 DOE 29 16 9 8
Q5 D5
DD27 DD27
P04/D26 D_A18
DD25 DD25 3 AR28B
OE NC 74HC04D
16
Q6 D6
17 AR28D 7 8 72
P05/D27 D_A19
58 4
19 18 4.7K*4 1 2 DD28 DD28 73 4.7K*4
Q7 D7 P06/D28
1 11 AR29 3 4 DD29 DD29 74 30 7 8 DRAS IC30E
OE CP P07/D29 D_CS0
LGND 4.7K*4 5 6 DD30 DD30 75 31 5 6 DCAS 11 10
IC32A MAX485E P30/A30 LGND 7 8 DD31 DD31 80
P08/D30 D_CS1
32 3 4 DWR 74HC04D
P09/D31 D_CA5
Re 2 34 1 2 DOE
D_OE
33 IC30F
D_WR
6 Ro 1 MD0_I A_CS0 9 AR22 EN29F800B-70T 13 12
1
IC5C 8 RAS 100R*4 IC10A ( AM29F800BB-90EC ) 74HC04D
2 74HC08D
De 3 P00 10 25 29 AD0
3 RXP A0 D0
AA2 24 31 AD1
4 RXN A1 D1
RSRX 7 Di 4 MD0_O W0 1 AA3 23 33 AD2
5 A2 D2
RSTX IC5A 3 LCAS AA4 22 35 AD3
6 74HC08D A3 D3
2 IC28A AA5 21 38 AD4
A4 D4
CN7 TRANSCEIVER 74HC32D AA1 16 2 AD0 AA6 20 40 AD5 9
A0 DD0 A5 D5
CN2*3 4 P23 2 AA2 17 3 AD1 AA7 19 42 AD6 8 IC28C
A1 DD1 A6 D6 74HC32D
IC5B 6 UCAS 3 AA3 18 4 AD2 AA8 18 44 AD7 10

256K*16 DYNAMIC RAM

74HC08D A2 DD2 A7 D7
W1 5 1 AA4 19 5 AD3 AA9 8 30 AD8
C IC36F A3 DD3 A8 D8 C
IC27C 74HC04D AA5 22 7 AD4 AA10 7 32 AD9
+5VD R106 74HC14DT AA1 AA6 23
A4 DD4
8 AD5 AA11 6
A9 D9
34 AD10 12
DIAL1 33K 13 12 INT_1 P01 5 6 4 AA7 24
A5 DD5
9 AD6 AA12 5
A10 D10
36 AD11 11 IC28D
A6 DD6 A11 D11 74HC32D
IC28B 6 OE-R AA8 25 10 AD7 AA13 4 39 AD12 13
1 74HC32D A7 DD7 A12 D12
5 AA9 26 31 AD8 AA14 3 41 AD13
2 R107 OE 15
A8 DD8
32 AD9 AA15 2
A13 D13
43 AD14
3 33K NC DD9 A14 D14
DIAL0 5 6 INT_0 12 33 AD10 AA16 1 45 AD15
4 NC DD10 A15 D15
11 34 AD11 AA17 48 12
5 IC36C NC DD11 A16
R39 R38 R29 30 36 AD12 AA18 17 15 11 IC5D
6 C184 C181 74HC14DT C149 NC DD12 A17 RY/BY
BIR6 104P 4K7 4K7 4K7 WR 13 37 AD13 AA19 16 9 13 74HC08D
7 104P 220P WR DD13 A18 NC
BIR5 RAS 14 38 AD14 26 10
8 RAS DD14 CS NC
BIR1 R71 UCAS 28 39 AD15 WO 11 13
9 OCAS DD15 WE NC
BIR0 LGND +5VD 4K7 LGND LGND LGND LGND LCAS 29 OE 28 14 LGND
10 CCAS OE NC
MD2_O DE-R 27 12 47
OE +5VD RST BYTE +5VD

A_CS3
CN2
CN2*5 LGND PRG
IC6A AS4C256K16F0-60JC CPU DATA BUS
D1 ( Fast page mode DRAM )
RLS4148
DIGITAL I/O BUS
IC35 +5VD IC36A IC36B
MAX709 74HC14DT 74HC14DT CPU ADDR BUS
1 2
4
NC VCC
7 1 23 4 INT_3 IC20C MMS-REDLG +5VD
NC RST IC20A MMS-REDLG
5 3 83 21
NC GND P12/BIR0 CK256FS AR16 100R*4
6 8 84 AA0 7 8 182 105 AD0 AD0 2 1
NC NC R105 PWM DIS P13/BIR1 AR19 100R*4 A_A0 A_D0
85 12 7 8 DATA/OUT1 AR12 AA1 5 6 181 106 AD1 AD1 4 3 AR31
10K 86
P14/BIR2 DAC0
13 5 6 DATA/OUT2 +5VD AA2 3 4 180
A_A1 A_D1
109 AD2 AD2 6 5 4.7K*4
AR32 100R*4 P15/BIR3 DAC1 J1B 100R*4 A_A2 A_D2
IC30C 1 2 87 14 3 4 DATA/OUT3 AA3 1 2 179 110 AD3 AD3 8 7
P16/BIR4 DAC2 IDC4 R45 1K AA20 A_A3 A_D3
B LGND 74HC04D LGND LGND R88 3 4 88 15 1 2 DATA/OUT4 3 4 AA4 1 2 178 111 AD4 AD4 2 1 B
P17/BIR5 DAC3 AR13 A_A4 A_D4
100R 5 6 89 16 7 8 DATA/OUT5 AA5 3 4 160 112 AD5 AD5 4 3 AR26
P18/BIR6 DAC4 J1A R41 1K AA19 100R*4 A_A5 A_D5
5 6 3 4 7 8 90 17 5 6 DATA/OUT6 1 2 AA6 5 6 159 113 AD6 AD6 6 5 4.7K*4
P19/BIR7 DAC5 A_A6 A_D6
91 20 3 4 LRCK (48KHZ) IDC4 AA7 7 8 158 114 AD7 AD7 8 7
IC30B P20/BIR8 CK64FS A_A7 A_D7
R86 22 1 2 BB_LE AA8 1 2 151 115 AD8 AD8 2 1
47K 74HC04D MD0_O 64
BB_LE
176 BCLK R44 4K7 AA23 AR14 AA9 3 4 152
A_A8 A_D8
116 AD9 AD9 4 3 AR27
MD0_O BB_LA (3.072MHZ) 100R*4 A_A9 A_D9
MD0_I 59 19 R69 100R 2 1 AA22 AA10 5 6 153 117 AD10 AD10 6 5 4.7K*4
MD0_I FSYNC_O A_A10 A_D10
XT1 R85 RSTX 65 18 AR6 4 3 AA21 AA11 7 8 154 118 AD11 AD11 8 7
MD1_O FSYNC_I +5VD A_A11 A_D11
24.576MHZ 220R RSRX 60 82 R92 220R 4K7*4 6 5 AA12 1 2 155 121 AD12 AD12 2 1
R87 MD2_O 66
MD1_I P11/CK32
81 R91 220R
STBSWT
8 7 AA16 AR9 AA13 3 4 156
A_A12 A_D12
122 AD13 AD13 4 3 AR24
100R MD2_O P10/CK32 STBLED 100R*4 A_A13 A_D13
61 7 8 4 3 AA18 AA14 5 6 162 123 AD14 AD14 6 5 4.7K*4
R73 220R MD2_I
196 5 6 6 5 AA17 AA15 7 8 163
A_A14 A_D14
124 AD15 AD15 8 7
C165 C164 R74 220R ADC0 AR8 A_A15 A_D15
15P 15P SD_IN 98 197 3 4 2 1 AA16 1 2 164
P25/SDI ADC1 LGND 4K7*4 AR7 A_A16 AR20 100R*4
SD_OUT 99 198 1 2 8 7 AA15 AA17 3 4 165 135 7 8 WR
LGND LGND SD_CLK 100
P26/SDO ADC2
199 8 7 AA14 100R*4 AA18 5 6 166
A_A17 A_WEB
136 5 6 OE
R70 P27/SCK ADC3 AR4 100R*4 A_A18 A_DE
+5VD 100R R75 220R DIGIT IN 6 5 AA13 AA19 7 8 167 139 3 4 W0
AR10 A_A19 A_LCAS_W0
INT_0 94 195 LRCK L/R 4K7*4 4 3 AA12 AA20 168 140 1 2 W1
P21/AD0 M4_WS A_A20 A_UCAS_W1
IC26B INT_1 95 194 2 1 AA11 AA21 169
IC26A AR5 100R*4 AR23 33R*4
10

P22/AD1 M4_LA A_A21

74HC74D AA10 AA22 A_CS0
4

74HC74D C84 220P MOD0

186 7 8 170
A_A22 A_CS0
125 7 8
149 187 5 6 R40 4K7 AA9 AA23 171 132 5 6 P30/A30
ADCIN MOD1 A_A23 A_CS1
12 9 2 5 183 188 3 4 R47 4K7 133 3 4
SD

SD

D Q D Q TESTE MOD2 LGND R77 4K7 A_CS2

LGND 189 1 2 LGND 96 134 1 2 A_CS3
MOD3 P23/ALE A_CS3
11 3 177 190 D0_L/R 1 2 67 103 R76 10K
CLK CLK REFCLK MOD4 P00/D28 P30/A30 +5VD
REFCLK 173 191 D1_L/R 3 4 68 104 1 2 BIR0
REFOUT MOD5 P01/D29 P31/A31
D2_L/R BIR1
CD

CD

8 6 29 192 5 6 69 97 7 8
Q Q RST MOD6 P02/D30 P24/ACK
R43 100R 193 D3_L/R 7 8 70
MOD7 P03/D31 AR39A 100R*4
LGND 24 126 INT_0 AR39D 100R*4
25
XTIN
101 5 AR39C 100R*4 6 BIR5 AR30 INT0
127 INT_1
1

4K7*4
13

XTOUT P28/STB0 INT1

102 3 4 BIR6 LGND 128 ERROR
D2 P29/STB1 R72 100R INT2
129 INT_3
R97 RLS4148 AR39B 100R*4 MUTE INT3

P23
P00
P01
A SYSCLK A
560R IC36E IC36D 12.288MHZ
74HC14DT 74HC14DT
R98
10K
11 10 9 8
DX26 DSP-CPU BOARD (PCB#F313072)
C150
Title
DX26 CPU & AD/DA BOARD PCB# F313072
C182 C183 220P DSP-CPU.SCH (F3130372 DSP MAIN)
1U
Size Number Revision
LGND LGND LGND
A3
Date: 20-Oct-2002 Sheet of
File: D:\zhong\PRODUCT\DX26\SCHPCB\DX26.ddb
Drawn By: SHUNZA
1 2 3 4 5 6 7 8
 1 2 3 4

D D

LRCK
RXRST
C51 R31 IC8A PCM1760U
+5VD 1K2
IC31A AD1892JR R94 1N8 1
4K7 Out-2R AR1 100R*4
21 3 23 1 2 D0_L/R
CA CS D0
20 2 2 24 3 4 D1_L/R
C171 CB CCLK In-2R D1
104P 19 4 R30 1K2 25 5 6 D2_L/R
CC SDI C50 D2
18 5 R22 C49 26 7 8 D3_L/R
CD SDO 1N8 R20 D3
17 6 560R 2N2 3
CE QDFS R93 470R Out-1R
LGND 15 12 19 SYSCLK
CON/PRO NDSIG 100R 256F
16 11 ERROR C48 4 18
CSCLK ERROR R21 2K2 In-1R STB
23 10 R/IN AGND 2N2
SYNC INT C167 R42 100R
27 9 C38 17 LRCK L/R
MUTE U/CBIT 103P R16 1K2 LRCK
C175 TF2 1 8 R19 1N8 14
103P PD/RST SFCLK Out-2L
LT-0806M LGND 47K C39

1
3
13 26 R90 LGND 1N8 13 27
C RXP RXP BCLK 100R In-2L BpOOCR C
24 DIGIT IN R17 1K2 16
SDATA BpOOCL
25 AGND C45
LRCLK R18 2N2
R89 R11 470R 12 15
Out-1L NC C74 C77
110R 1% 28 REFCLK 560R 28
MCLK NC 10U 10U
14 11 10
RXN RXN In-1L NC

2
4
L/IN AGND
C40 2N2 AGND AGND
R12 DUAL 20BIT MODULATOR
R13 2K2
47K

AGND

DIGITAL I/O BUS

CN3
CN2*2
B B
1
+5VD +5VA
2
3
4

C47

22
5
6
22
1U
C76 AGND
1U IC8B IC8C
IC31B C176
AD1892 104P PCM1760U PCM1760U

C75 C56
C46

7
8
9
7
1U 10U

20
21
1U

C55
LGND 10U AGND
-5VA Title
A DX26 CPU & AD/DA BOARD A
PCB# F313072
AD-IN.SCH (F3130372 A/D INPUT)
Size Number Revision
A4
Date: 20-Oct-2002 Sheet of
File: D:\zhong\PRODUCT\DX26\SCHPCB\DX26.ddb
Drawn By: SHUNZA
1 2 3 4
 1 2 3 4

+5VD +5VD +5VD +5VD

R46 L1 R50 R49 R53

D BLM21 D
C83 C96 C139 C141 C151 C153 C142 C140 C98 C100 C78 C60 C97 C152 C82 2K2 820R 1K8 220R
104P 104P 104P 104P 104P 104P 104P 104P 104P 104P 104P 104P 104P 104P 104P 1V5 3V5

C85 R51 R54 R52 +5VD

LGND 220P 220R 820R 1K5
IC20D +5VD C57
104P Rxx
MMS-REDLG L2
LGND LGND LGND LGND BLM21

147
9
23
37
47
62
78
92
107
119
137
157
172
200
184
131
77
28
COLLEGARE TRA
PIN 147 E 148

146
144
143
141

IC20E
MMS-REDLG
C102 C86 IC20F
C79 C101 10U 104P MMS-REDLG
104P 10U

10
26
38
48
63
79
93
76
27

148
108
120
138
161
174
208
185
130
175
C99 C104 C105 C103 C107 C106 IC20G
104P 10U 104P 10U 10U 104P

150
145
142

LGND MMS-REDLG
C C

+12V +5VD +5VD LGND

+5VD
D3
+5VA +12V
RLS4148
TR1 R35
BC327 1K2 CN5

37
1
6
21
1
6
20
TR2 R36 6P2.5
BC337 22K C163 C162
104P 10U 1 +12V(BATTERY)
IC10B IC14B IC6B

R33
R32
560R 1/4W
2 +5VA

560R 1/4W
EN29F800B-70T GM71C18163CJ-6 M11B416256A-35J
FLASH 8MBit DRAM 1M*16 DRAM 256K*16 3
C58 C59 C80 C81 C36 4
AGND
10U 104P 10U 104P 104P R34 C160 C161 5
R37 C53 104P

27
46
22
37
42
40
35
21
330R 1/4W C35 10U 6 -5VA
B1 10U 4K7 104P
4.8V
LGND AD/DA SUPPLY
B B
-5VA AGND FROM POWER SUPPLY BOARD CN6
LGND LGND

+5VD

20
20
14
14
14
14
14
14
8

CN6
2P3.9
1 IC33B IC34B IC28E IC27G IC36G IC5E IC26C IC30G IC30B
2 74HC374DW 74HC374DW 74HC32D 74HC04D 74HC14D 74HC08D 74HC74D 74HC04D 74HC04D
C174 C52
220/25V 104P C178 C179 C169 C168 C108 C180 C34 C148 C166 C172

7
7
7
7
7
7
5

104P 104P 104P 104P 104P 104P 104P 104P 104P 104P

10
10
CPU SUPPLY
FROM POWER SUPPLY BOARD CN1 LGND

Title
A DX26 CPU & AD/DA BOARD A
PCB# F313072
DSP-PS.SCH (F3130372 DSP,RAM,ROM POWER)
Size Number Revision
A4
Date: 20-Oct-2002 Sheet of
File: D:\zhong\PRODUCT\DX26\SCHPCB\DX26.ddb
Drawn By: SHUNZA
1 2 3 4
 1 2 3 4

DIGITAL I/O BUS

D IC18A PCM1702U C133 IC13A PCM1702U C21 D

BCLK 2 14 220P C129 BCLK 2 14 220P C31
CLK OUT C123 R81 CLK OUT C30 R83
DATA/OUT1 1 R62 6 100U DATA/OUT4 1 R9 6 100U
DATA 102P R59 4.7K DATA 102P R14 4.7K
BB_LE 7 2 2.7K 7 OUT1 BB_LE 7 2 2.7K 7 OUT4
LE 6.8K LE 6.8K
1 5 1 5
17 3 R61 17 3 R10
SRV R60 22K TR6 SRV R15 22K TR8
C125 19 6.8K IC24B C43 19 IC4B
RFE IC24A C130 J176 RFE IC4A 6.8K C29 J176
100U C124 12 2068DD 470P 2068DD 100U C28 12 2068DD 470P 2068DD
22U BPO AGND AGND R102 22U BPO AGND AGND R104
220K 220K
C115 MUTE C44 MUTE
47/25V AGND AGND 47/25V AGND AGND
C158 C173
-5VA -5VA AGND -5VA -5VA AGND

IC19A PCM1702U C147 AGND IC11A PCM1702U C2 AGND

BCLK 2 14 220P C143 BCLK 2 14 220P C7
CLK OUT C134 R82 CLK OUT C6 R80
DATA/OUT2 1 R67 6 100U DATA/OUT6 1 R1 6 100U
DATA 102P R63 4.7K DATA 102P R3 4.7K
BB_LE 7 2 2.7K 7 OUT2 BB_LE 7 2 2.7K 7 OUT6
LE 6.8K LE 6.8K
1 5 1 5
17 3 R66 17 3 R2
SRV R64 22K TR5 SRV R4 22K TR3
C136 19 IC25B C12 19 IC2B
RFE IC25A 6.8K C144 J176 RFE IC2A 6.8K C5 J176
100U C135 12 2068DD 470P 2068DD 100U C3 12 2068DD 470P 2068DD
22U BPO AGND AGND R101 22U BPO AGND AGND R99
C 220K 220K C
C126 MUTE MUTE
47/25V AGND AGND C13 AGND AGND
C157 47/25V C155
-5VA -5VA AGND -5VA -5VA AGND

IC17A PCM1702U C122 AGND IC12A PCM1702U C9 AGND

BCLK 2 14 220P C118 BCLK 2 14 220P C19
CLK OUT C112 R84 CLK OUT C18 R79
DATA/OUT3 1 R58 6 100U DATA/OUT5 1 R5 6 100U
DATA 102P R55 4.7K DATA 102P R7 4.7K
BB_LE 7 2 2.7K 7 OUT3 BB_LE 7 2 2.7K 7 OUT5
LE 6.8K LE 6.8K
1 5 1 5
17 3 R57 17 3 R6
SRV R56 22K TR7 SRV R8 22K TR4
C114 19 IC23B 19 IC3B
RFE IC23A 6.8K C119 J176 C24 C15 RFE IC3A 6.8K C17 J176
100U C113 12 2068DD 470P 2068DD 12 2068DD 470P 2068DD
BPO AGND AGND R103 100U 22U BPO AGND AGND R100
22U
220K 220K
C109 MUTE C25 MUTE
47/25V AGND AGND AGND AGND
C159 47/25V C156
-5VA -5VA AGND -5VA -5VA AGND

AGND AGND
+5VA
B B

11
4
11
4
11
4
11
4
11
4
11
4

C71 C92 C116 C88 C94 C127 C64 C67 C27 C61 C62 C14 C66 C90 C110 C54 C72 C69
104P IC18B 10U 104P 104P IC19B 10U 104P 104P IC12B 10U 104P 104P IC11B 10U 104P 104P IC17B 10U 104P 104P IC13B 10U 104P
PCM1702U PCM1702U PCM1702U PCM1702U PCM1702U PCM1702U
C70 C91 C117 C87 C93 C128 C22 C23 C63 C10 C11 C65 C89 C111 C42 C41 C73
104P 10U 104P 104P 10U 104P C68 10U 104P 104P 10U 104P 104P 10U 104P 104P 10U 104P
104P

6
5
6
5
6
5
6
5
6
5
6
5

15
16
20
15
16
20
15
16
20
15
16
20
15
16
20
15
16
20

AGND AGND AGND AGND AGND AGND AGND AGND AGND AGND AGND AGND AGND

-5VA

+5VA

8
8
8
8
8
8

C131 C145 C20 C120 C1 C8 CN4 CN2*7

104P IC24C 104P IC25C 104P IC4C 104P IC23C 104P IC2C 104P IC3C 1 2
OUT6
2068DD 2068DD 2068DD 2068DD 2068DD 2068DD 3 4
OUT5
A C132 C146 C26 C121 C4 C16 5 6 A
104P 104P 104P 104P 104P 104P OUT4
7 8 Title
OUT3

4
4
4
4
4
4

9 10 DX26 CPU & AD/DA BOARD

OUT2 PCB# F313072
OUT1 11 12 DA-CONV.SCH (F3130372 D/A CONVERTER OUTPUT)
-5VA 13 14 Size Number Revision
A4
AGND AGND AGND
Date: 20-Oct-2002 Sheet of
File: D:\zhong\PRODUCT\DX26\SCHPCB\DX26.ddb
Drawn By: SHUNZA
1 2 3 4
 1 2 3 4

D D

+5VD IC1 +3.3V

LM117

14
3 2
IN OUT
4
GND
C1 C2 C4 C3 C5
104P 10U 104P 10U 104P

1
7
LGND IC2E LGND
74LVC125D

C IC2A C
74LVC125D R6
68R
2 3

1
+3.3V
IC2B
74LVC125D R5 CS 1
68R DATA IN 2
CN1 +5VD 5 6 GND 3
CN-2*5 VCC 4
VCC CLK 5
1

4
VCC GND 6
2
VCC DATA OUT 7
3
GND IC2C
4
GND 74LVC125D R4
5
GND 68R LGND
6
MOS_I 12 11
B 7 B
MOS_O
8
CS +5VD +3.3V
9
CLK

13
10

R1 IC2D R3
LGND 10K 74LVC125D 56K R2
68R
8 9

LGND

10

Title
A A
DX26 MULTI-MEDIA-CARD BOARD PCB# F313085
Size Number Revision
A4
Date: 20-Oct-2002 Sheet of
File: D:\zhong\PRODUCT\DX26\SCHPCB\DX26.ddb
Drawn By: SHUNZA
1 2 3 4
 1 2 3 4 5 6 7 8

+12V
C55 IC11C CN8
22P C59 MAX202E L3
S13 CN-RS232
22P FL5R
CN4 12 13
R 1 6
X1 CN2*3
L21 D12 D9 R35 R26 C56 R29 2 7
FL5R 4148 4148 15.0K 15.0K 47/25V 39.2K R28 3 8
X3 2 10.0K C4 11 14
1 T 4 9
X2 1 6 47/25V
2 L4 5
1 3 7
3 FL5R
2 5 IC11A L5
L20 R36 IC10A R8 4
D 3 MAX202E FL5R D
FL5R 15.0K 2068DD 5 C71
4 C57 AGND R37 IC10B 100R
R27 22P 10K 2068DD 4 6 104P
5
D11 D10 15.0K 3
6
4148 4148 2
AGNDAGND 1 LGND
1
IN LEFT -12V +12V 3 S4 1
C33 R30 L1 S3
10R J5MM 2 BAL(M) 3
22P C54 4 2
CN6 BAL(FM)
S12 22P D16 4
CN2*2 D3 R31 L2
10R J5MM 6.2V 1W D15
X1 10V 1W 1
L19 D8 D5 R32 R22 6.2V 1W
C35 R25 R24 C3 D4 3
FL5R 4148 4148 15.0K 15.0K 47/25V 10.0K 10V 1W D14 D13
X3 2 39.2K 47/25V D2 2
X2 1 6 D1 4 6.2V 1W 6.2V 1W
6.8V 1W
1 3 7 6.8V 1W
2 5 S5
L18 R33 IC9A R7
3 BAL(FM)
FL5R 15.0K 2068DD IC9B 100R
4 C34 AGND R34 2068DD
5 R23 10K
D7 D6 22P
6 15.0K
4148 4148 AGNDAGND
IN RIGHT -12V
CN2 +12V +5V IC2 +12V
2P2.5 7805
1

16
IC11B CN5

4
CN7 IC11D 2
MAX202E MAX202E 6P2.5 CN1
CN2*7
C IC11E C10 C9 C38 C37 1 C
10 7 8 9 CN3
1 T R MAX202E 1 104P 10U 104P 2
2 C63 C64 C41 C40 C39 2P2.5 C2 2 3
LGND LGND
3 104P 104P 104P 104P 104P 104P 3 C24 C8 C6 4
C5

15
4 1 4 5

5
104P 1000/25V 104P
5 2 5 2200/25V 6
6 6
7 6P3.9
LGND C1 IC1
8
7905 -12V LGND
9 R9
LGND AGND
10 JP10MM
11
12
13
14

R6 R5 R4 R3 R2 R1
100R IC8A 100R IC7A 100R IC6A 100R IC5A 100R IC4A 100R IC3A
C30 HYB102004 C29 HYB102004 C28 HYB102004 C27 HYB102004 C26 HYB102004 C25 HYB102004
22P 4 C60 22P 4 C51 22P 4 C49 22P 4 C47 22P 4 C45 22P 4 C43
IN+ 47/25V IN+ 47/25V IN+ 47/25V IN+ 47/25V IN+ 47/25V IN+ 47/25V
5 5 5 5 5 5
IN- IN- IN- IN- IN- IN-
6 11 6 11 6 11 6 11 6 11 6 11
OUT OUT+ OUT OUT+ OUT OUT+ OUT OUT+ OUT OUT+ OUT OUT+
7 12 7 12 7 12 7 12 7 12 7 12
IN+ SENS1 IN+ SENS1 IN+ SENS1 IN+ SENS1 IN+ SENS1 IN+ SENS1
R20 R18 R16 R14 R12 R10
8 13 8 13 8 13 8 13 8 13 8 13
IN- SENS2 IN- SENS2 IN- SENS2 IN- SENS2 IN- SENS2 IN- SENS2
R21 22K 9 15 R19 22K 9 15 R17 22K 9 15 R15 22K 9 15 R13 22K 9 15 R11 22K 9 15
B OUT OUT- OUT OUT- OUT OUT- OUT OUT- OUT OUT- OUT OUT- B
10 C70 10 C69 10 C68 10 C67 10 C66 10 C65
IN 47/25V IN IN IN IN IN
47/25V 47/25V 47/25V 47/25V 47/25V
C52 C50 C48 C46 C44 C42
47/25V 47/25V 47/25V 47/25V 47/25V 47/25V
R58 R54 R50 R46 R42 R38 R40
AGND 330R AGND 330R AGND 330R AGND 330R AGND 330R AGND 330R 330R
R59 R55 R51 R47 R43 R39
R60 R56 R52 R48 R44
10K 10K 10K 10K 10K 10K
330R 330R 330R 330R 330R
R61 R57 R53 R49 R45 R41
10K 10K 10K 10K 10K 10K
S11 S10 S9 S8 S7 S6
AGND AGND AGND AGND AGND AGND
BAL(M) BAL(M) BAL(M) BAL(M) BAL(M) BAL(M)
1 1 1 1 1 1
L16 L14 L12 L10 L9 L7
3 3 3 3 3 3
FL5R FL5R FL5R FL5R FL5R FL5R
2 2 2 2 2 2
4 L17 4 L15 4 L13 4 L11 4 L8 4 L6
OUT1 FL5R OUT2 FL5R OUT3 FL5R OUT4 FL5R OUT5 FL5R OUT6 FL5R

C31 C23 C36 C58 C16 C14 C12 C18 C20 C22
1000/25V 104P 104P 104P 104P 104P 104P 104P 104P
8

1
+12V
P2
A A

P1
Title
-12V
4

DX26 IN/OUT BOARD

S2
C53 C32 IC9C C61 IC10C C62 IC5B C15 IC4B C13 IC3B C11 IC6B C17 IC7B C19 IC8B C21 AGND Size Number Revision
1000/25V 2068DD 104P 2068DD 104P HYB102004 104P HYB102004 104P HYB102004 104P HYB102004 104P HYB102004 104P HYB102004 104P PCB# F313067
A3
Date: 20-Oct-2002 Sheet of
File: D:\zhong\PRODUCT\DX26\SCHPCB\DX26.ddb Drawn By: SHUNZA
1 2 3 4 5 6 7 8
4.Printed Circuit Diagram

MAXIFP2 Top Scilkscreen

MAXIFP2 Top Layer

MAXIFP2 Top Solder Mask

MAXIFP2 Bottom Layer

MAXIFP2 Bottom Solder Mask

MAXIFP2 Drill Drawing

Tool Hole Size Hole Count Plated
---------------------------------------------------------------------------
T1 20mil (0.508mm) 184
T2 31mil (0.7874mm) 130
T3 35mil (0.889mm) 14
T4 39mil (0.9906mm) 59
T5 59mil (1.4986mm) 1
T6 87mil (2.2098mm) 1
T7 98mil (2.4892mm) 4
T8 126mil (3.2004mm) 6
T9 280mil (7.112mm) 1
---------------------------------------------------------------------------
Totals 400
PCB:F313072
PCB:F313067
PCB:MAXIFP2
PCB:F313085
 white

white

green

Wiring Diagram
white white

black

black
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 1 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

├0001--------------------------------- MA03541 1.0000 2002/11/17

││ panel PCS 1 Y
││ MAXIDRIVE3.4 0.00 %
│└0001------------------------------- MA03539 1.0000 2002/12/14
│ │ panel PCS 1 N
│ │ MAXIDRIVE3.4 0.00 %
│ └0001------------------------------ MA03538 1.0000 2002/07/19
│ │ panel PCS 1 N
│ │ MAXIDRIVE3.4 0.00 %
│ └0001----------------------------- MA03537 1.0000 2002/07/19
│ │ panel PCS 1 N
│ │ MAXIDRIVE3.4 0.00 %
│ └0001---------------------------- MI01380 1.0000 2002/07/19
│ panel PCS 1 N
│ 44.2*6.5*483 0.00 %
├0002--------------------------------- MB02386 1.0000 2002/11/17
││ rear board PCS 1 Y
││ MAXIDRIVE3.4 0.00 %
│└0001------------------------------- MB02384 1.0000 2002/12/14
│ │ rear boardd PCS 1 N
│ │ MAXIDRIVE3.4 0.00 %
│ └0001------------------------------ MB02383 1.0000 2002/07/19
│ │ rear board PCS 1 N
│ │ MAXIDRIVE3.4 0.00 %
│ └0001----------------------------- MJ00058 1.0000 2002/07/19
│ iron board PCS 80 N
│ 1*2135*1220 20.45kg KG 0.00 %
├0003--------------------------------- MC00441 1.0000 2002/11/17
││ top cover PCS 1 Y
││ MAXIDIRVE3.4 0.00 %
│└0001------------------------------- MC00416 1.0000 2003/02/08
│ │ top cover PCS 1 N
│ │ MAXIDIRVER3.4 0.00 %
│ └0001------------------------------ MJ00059 1.0000 2003/04/02
│ iron board PCS 16 N
│ 1.2*2135*1220 24.54kg KG 0.00 %
├0004--------------------------------- MI00237 1.0000 2002/11/17
│ heat-sink PCS 1 Y
│ 4*34.5*16.5*34.5 FX22 0.00 %
├0005--------------------------------- MI00409 1.0000 2002/11/17
│ fixed piece PCS 1 Y
│ FX22 0.00 %
├0006--------------------------------- NI02245 1.0000 2002/11/17
│ heat conduction rubber PCS 1 Y
│ 25*25*0.25 white (3M #9890) 0.00 %
├0007--------------------------------- NI00828 13.0000 2002/11/17
│ knob PCS 1 Y
│ 12*7*10.7 072C blue 0.00 %
├0008--------------------------------- NI02223 6.0000 2002/11/17
│ light piller PCS 1 Y
│ 9*5*2.5 0.00 %
├0009--------------------------------- NI02238 7.0000 2002/11/17
│ knob PCS 1 Y
│ φ3*W6*25.5 072C 0.00 %
├0010--------------------------------- NI01542 8.0000 2002/11/17
│ LED spacer support PCS 1 Y
│ φ3*9.5 0.00 %
├0011--------------------------------- NI02117 1.0000 2002/11/17
│ knob PCS 1 Y
│ φ30*12.5 0.00 %
├0012--------------------------------- NI02217 1.0000 2002/11/17
││ lacid plastic panel PCS 1 Y
││ MAXIDRIVE2.3,3.4 0.00 %
│└0001------------------------------- NI00830 1.0000 2002/12/24
│ lacid plastic panel PCS 1 N
│ 3.5*106*33mm CONTROL60 0.00 %
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 2 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

├0013--------------------------------- HA00860 1.0000 2002/11/17

│ alimentation line PCS 1 Y
│ LT-322+0.75*3C(H05VV-F) 6FT+LT-501 0.00 %
├0014--------------------------------- HI00030 1.0000 2002/11/17
│ power switch PCS 1 Y
│ 4P R9D2KKFT0F(SHOW 1/0) 0.00 %
├0015--------------------------------- HC00008 1.0000 2002/11/17
│ AC outlet PCS 1 Y
│ 3515 A TYPE(RF-2004-C-4.8) 0.00 %
├0016--------------------------------- NC00089 1.0000 2002/11/17
││ wood washer PCS 1 Y
││ φ4*φ10*1 0.00 %
│└0001------------------------------- NC00088 1.0000 2003/02/25
│ │ insulation KG 1 N
│ │ φ10*1 0.00 %
│ └0001------------------------------ NC00014 100.0000 2002/04/04
│ insulator KG 39000000 N
│ 0.65M*60M*1t 0.00 %
├0017--------------------------------- NI00252 7.0000 2002/11/17
││ sleeve PCS 1 Y
││ φ4*20mm 0.00 %
│└0001------------------------------- NI00248 20.0000 2002/06/04
│ sleeve M 1000 N
│ φ4*1000mm 0.00 %
├0018--------------------------------- NI00254 1.0000 2002/11/17
││ sleeve PCS 1 Y
││ φ4*40mm 0.00 %
│└0001------------------------------- NI00248 40.0000 2002/06/04
│ sleeve M 1000 N
│ φ4*1000mm 0.00 %
├0019--------------------------------- MG00167 7.0000 2002/11/17
│ screw PCS 1 Y
│ M3*10 0.00 %
├0020--------------------------------- MG00042 2.0000 2002/11/17
│ screw PCS 1 Y
│ M3*10 0.00 %
├0021--------------------------------- MG00061 18.0000 2002/11/17
│ screw PCS 1 Y
│ M3*10 0.00 %
├0022--------------------------------- MG00027 4.0000 2002/11/17
│ screw PCS 1 Y
│ M3*12 0.00 %
├0023--------------------------------- MF00037 1.0000 2002/11/17
│ washer PCS 1 Y
│ φ3*φ5*1t 0.00 %
├0024--------------------------------- ME00016 1.0000 2002/11/17
│ colour nut PCS 1 Y
│ 4m/m 0.00 %
├0025--------------------------------- MF00038 1.0000 2002/11/17
│ washer PCS 1 Y
│ φ4*φ7*1t 0.00 %
├0026--------------------------------- MF00048 3.0000 2002/11/17
│ washer PCS 1 Y
│ φ4*φ8*0.5t 0.00 %
├0027--------------------------------- MF00014 9.0000 2002/11/17
│ washer PCS 1 Y
│ φ3*φ6.5*0.5t 0.00 %
├0028--------------------------------- HA01174 1.0000 2002/11/17
│ signle terminal wiring CF:W146 PCS 1 Y
│ 80 green/yellow 0.00 %
├0029--------------------------------- HA02190 2.0000 2002/11/17
│ wire PCS 1 Y
│ 150mm 0.00 %
├0030--------------------------------- HA02191 1.0000 2002/11/17
│ wire PCS 1 Y
│ 170mm 0.00 %
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 3 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

├0031--------------------------------- HA01502 1.0000 2002/11/17

│ header wiring PCS 1 Y
│ 6P-6P 120 0.00 %
├0032--------------------------------- HA02248 1.0000 2002/11/17
│ wire PCS 1 Y
│ 2P-2P 250mm UL1007 24AWG 0.00 %
├0033--------------------------------- HA01651 1.0000 2002/11/17
│ header wiring FL-0462A PCS 1 Y
│ 4P-4P PH1.27 50 0.00 %
├0034--------------------------------- HA01652 1.0000 2002/11/17
│ header wiring FL-0463A PCS 1 Y
│ 6P-6P PH1.27 30 0.00 %
├0035--------------------------------- HA01653 1.0000 2002/11/17
│ header wiring FL-0464A PCS 1 Y
│ 14P-14P PH1.27 50 0.00 %
├0036--------------------------------- HA01654 1.0000 2002/11/17
│ header wiring FL-0465A PCS 1 Y
│ 10P-10P PH1.27 250 0.00 %
├0037--------------------------------- HA01655 1.0000 2002/11/17
│ header wiring FL-0466A PCS 1 Y
│ 20P-20P PH1.27 300 0.00 %
├0038--------------------------------- HA01696 1.0000 2002/11/17
│ header wiring IF:W40 PCS 1 Y
│ 3P 350 0.00 %
├0039--------------------------------- HA01697 1.0000 2002/11/17
│ header wiring IF:W41 PCS 1 Y
│ 6P-6P 100 0.00 %
├0040--------------------------------- HA01699 1.0000 2002/11/17
│ header wiring PCS 1 Y
│ 2P-2P 120 0.00 %
├0041--------------------------------- NI01594 2.0000 2002/11/17
│ MOUNT PCS 1 Y
│ TH-1 0.00 %
├0042--------------------------------- NI01627 2.0000 2002/11/17
│ fixed bracket PCS 1 Y
│ CM-19S 0.00 %
├0043--------------------------------- NI00218 4.0000 2002/11/17
│ cable tie-black PCS 1 Y
│ ALT-102SB 0.00 %
├0044--------------------------------- NI00217 1.0000 2002/11/17
││ insulator PCS 1 Y
││ CONTROL30 0.00 %
│└0001------------------------------- NI00216 1.0000 2003/02/25
│ │ insulator PCS 1 N
│ │ 0.5*130*100 0.00 %
│ └0001------------------------------ NI00375 1.0000 2002/04/06
│ film PCS 1 N
│ 45*60.5*0.5mm 0.00 %
├0045--------------------------------- NI00200 1.0000 2002/11/17
││ insulator PCS 1 Y
││ 0.5*100*130(DX24) 0.00 %
│└0001------------------------------- NI00375 1.0000 2003/02/25
│ film PCS 1 N
│ 45*60.5*0.5mm 0.00 %
├0046--------------------------------- TG00029 1.0000 2002/11/17
│ voltagetransformer PCS 1 Y
│ SNP-9541 40W(AC-DC) 0.00 %
├0047--------------------------------- NI00501 4.0000 2002/11/17
│ foot cushion PCS 1 Y
│ 12.7*9*3t(SF-004) 0.00 %
├0048--------------------------------- NA00137 1.0000 2002/11/17
│ clip-chain bag PCS 1 Y
│ 5*7 0.00 %
├0049--------------------------------- NA00123 1.0000 2002/11/17
│ PE bag PCS 1 Y
│ 300*580*0.04 KG 0.00 %
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 4 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

├0050--------------------------------- HJ00006 1.0000 2002/11/17

│ desiccant PCS 1 Y
│ 30g 0.00 %
├0051--------------------------------- NF00061 1.0000 2002/11/17
│ assurance card PCS 1 Y
│ ▲LTO 0.00 %
├0052--------------------------------- NB02177 1.0000 2003/01/06
│ box PCS 1 Y
│ MAXIDRIVE3.4 0.00 %
├0053--------------------------------- NB02161 1.0000 2003/01/15
│ barrier PCS 1 Y
│ MAXIDRIVE3.4 0.00 %
├0054--------------------------------- NB02162 1.0000 2003/01/15
│ barrier PCS 1 Y
│ MAXIDRIVE3.4 0.00 %
├0055--------------------------------- NB02088 1.0000 2003/01/07
│ box PCS 4 Y
│ (1H) ALTO 19" 0.00 %
├0056--------------------------------- NE05004 4.0000 2002/11/17
│ label PCS 1 Y
│ ALTO 0.00 %
├0057--------------------------------- NE10542 4.0000 2002/11/17
││ label PCS 1 Y
││ MAXIDRIVE3.4 0.00 %
│├0001------------------------------- NH00012 1.0000 2003/02/16
││ bond paper M 80 N
││ 0.04*1M 0.00 %
│└0002------------------------------- NI00014 1.0000 2003/02/16
│ membrane M 80 N
│ 0.035*1M 0.00 %
├0058--------------------------------- MI01466 1.0000 2002/11/17
││ front board PCS 1 Y
││ MAXIDRIVE3.4 0.00 %
│├0001------------------------------- MJ00063 1.0000 2003/02/25
││ Zn-plated board PCS 95 N
││ 1.2*2135*1220 24.54kg KG 0.00 %
│└0002------------------------------- ME00040 9.0000 2003/02/25
│ iron pillar PCS 1 N
│ hexagon6.35*M3*10.1 0.00 %
├0059--------------------------------- MB01413 1.0000 2002/11/17
││ bottom board PCS 1 Y
││ MAXIDRIVE3.4 0.00 %
│└0001------------------------------- MB01411 1.0000 2003/01/12
│ │ bottom board PCS 1 N
│ │ MAXIDRIVE3.4 0.00 %
│ └0001------------------------------ MB01409 1.0000 2002/07/11
│ │ rear board PCS 1 N
│ │ MAXIDRIVE3.4 0.00 %
│ └0001----------------------------- MJ00059 1.0000 2002/07/11
│ iron board PCS 12 N
│ 1.2*2135*1220 24.54kg KG 0.00 %
├0060--------------------------------- HK02943 1.0000 2002/11/17
││ PC board PCS 1 Y
││ P-MAXIFP2-2-DIP 0.00 %
│├0001------------------------------- HK02942 1.0000 2002/10/03
│││ PC board PCS 1 Y
│││ P-MAXIFP2-2-SMD 0.00 %
││├0001----------------------------- HB00779 1.0000 2002/10/03
│││ PC board PCS 1 Y
│││ MAXIFP2(1*4)_VER020826 0.00 %
││├0002----------------------------- RD00059 1.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 0Ω ±5% 0603 0.00 %
│││ R72
│││
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 5 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││├0003----------------------------- RD00061 6.0000 2002/10/03

│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 10Ω ±5% 0603 0.00 %
│││ R10,R11,R12,R15,R16,R17
│││
││├0004----------------------------- RD00083 1.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 1.0KΩ ±5% 0603 0.00 %
│││ R8
│││
││├0005----------------------------- RD00084 50.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 1.2KΩ ±5% 0603 0.00 %
│││ R18,R20,R21,R22,R25,R26,R27,R28,R29,R30,R32,R33,R34,
│││ R35,R36,R37,R38,R39,R40,R41,R42,R43,R44,R45,R46,R47,
│││ R48,R49,R50,R51,R52,R53,R54,R55,R56,R57,R58,R59,R60,
│││ R61,R62,R63,R64,R65,R66,R67,R68,R69,R70,R71
│││
││├0006----------------------------- RD00092 1.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 3.9KΩ ±5% 0603 0.00 %
│││ R13
│││
││├0007----------------------------- RD00095 4.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 5.6KΩ ±5% 0603 0.00 %
│││ R1,R2,R3,R5
│││
││├0008----------------------------- RD00101 6.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 10KΩ ±5% 0603 0.00 %
│││ R14,R19,R24,R31,R6,R7
│││
││├0009----------------------------- RD00116 1.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 100KΩ ±5% 0603 0.00 %
│││ R23
│││
││├0010----------------------------- CI00055 5.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 47PF/50V NPO ±5% 0.00 %
│││ C10,C16,C7,C8,C9
│││
││├0011----------------------------- CI00071 2.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 0.01uF/50V X7R ±10% 0.00 %
│││ C1,C2
│││
││├0012----------------------------- CI00075 12.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 0.1uF/50V Y5V +80,-20% 0.00 %
│││ C11,C12,C13,C14,C19,C20,C21,C22,C23,C3,C5,C6
│││
││├0013----------------------------- RE00008 4.0000 2002/10/03
│││ SMDrow resistor1/16W PCS 1 Y
│││ 4.7KΩ*4 ±5% 8P 0603 0.00 %
│││ AR1,AR2,AR3,AR4
│││
││├0014----------------------------- SE00011 1.0000 2002/10/03
│││ SMD rectifier diode PCS 1 Y
│││ RLS4148 0.5A (LL-34) 0.00 %
│││ D1
│││
││├0015----------------------------- SG00067 1.0000 2002/10/03
│││ SMD integraded circuit PCS 1 Y
│││ 74HC04DT 0.00 %
│││ IC4
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 6 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

│││
││├0016----------------------------- SG00068 1.0000 2002/10/03
│││ SMD integraded circuit PCS 1 Y
│││ 74HC14DT 0.00 %
│││ IC1
│││
││├0017----------------------------- SG00071 2.0000 2002/10/03
│││ SMD integraded circuit PCS 1 Y
│││ 74HC165DT 0.00 %
│││ IC2,IC6
│││
││└0018----------------------------- SG00008 7.0000 2002/10/03
││ SMD integratd circuit PCS 1 Y
││ MC14094BDR2(S&T HCF4094BM1) 0.00 %
││ IC10,IC11,IC3,IC5,IC7,IC8,IC9
││
│├0002------------------------------- HA01918 2.0000 2002/10/03
││ jumper wire PCS 1 Y
││ 4mm 0.00 %
││ P80,P90
││
│├0003------------------------------- RA00155 1.0000 2002/10/03
││ fixed resistor 1/2W PCS 1 Y
││ 4.7Ω M type 0.00 %
││ R4
││
│├0004------------------------------- HC00263 1.0000 2003/03/04
││ row-wire header PCS 1 Y
││ 2P 2.5mm 90° 0.00 %
││ CN4
││
│├0005------------------------------- HC00051 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 20PIN A28b-20B.T.6 0.00 %
││ CN2
││
│├0006------------------------------- HI00107 1.0000 2002/10/03
││ switch PCS 1 Y
││ RE111-20B3-15F-15P 0.00 %
││ SW7
││
│├0007------------------------------- HC00458 1.0000 2003/03/04
││ label PCS 1 Y
││ 2.54 180° 3P5/7.5mm 0.00 %
│├0008------------------------------- HI00041 13.0000 2002/10/03
││ buttom swith PCS 1 Y
││ 6*6*5 0.00 %
││ SW1,SW10,SW11,SW12,SW13,SW14,SW2,SW3,SW4,SW5,SW6,SW8,
││ SW9
││
│├0009------------------------------- SA00072 18.0000 2002/11/20
││ L.E.D PCS 1 Y
││ φ3 red LI2340/A 0.00 %
││ DL1,DL10,DL18,DL20,DL3,DL41,DL42,DL43,DL44,DL45,DL46,
││ DL47,DL48,DL49,DL50,DL6,DL25,DL30
││
│├0010------------------------------- SA00071 24.0000 2002/11/20
││ L.E.D PCS 1 Y
││ φ3 green LVG2340/A 0.00 %
││ DL11,DL12,DL13,DL15,DL16,DL17,DL21,DL22,DL23,DL26,
││ DL27,DL28,DL31,DL32,DL35,DL4,DL7,DL8,DL33,DL36,DL37,
││ DL38,DL39,DL40
││
│├0011------------------------------- SA00073 8.0000 2002/11/20
││ L.E.D PCS 1 Y
││ φ3 yellow LVY2340/A 0.00 %
││ DL14,DL19,DL2,DL24,DL5,DL9,DL29,DL34
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 7 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││
│├0012------------------------------- CB00021 3.0000 2002/10/03
││ electrotytic capacitor PCS 1 Y
││ 10uF/16V ψ4*5 0.00 %
││ C17,C18,C4
││
│├0013------------------------------- CB00062 1.0000 2002/10/03
││ electrotytic capacitor PCS 1 Y
││ 220uF/6.3V ψ6*7 0.00 %
││ C15
││
│├0014------------------------------- HE00009 1.0000 2002/10/03
││ LCD PCS 1 Y
││ WH1602D-YGB-JPR6(WINSTAR) 0.00 %
│├0015------------------------------- HC00157 1.0000 2002/10/03
││ row-pin(double)#2200 PCS 1 Y
││ 2.54 180° 2*7P(gold-plated) 6/11.6mm 0.00 %
│├0016------------------------------- MG00153 4.0000 2002/10/03
││ screw PCS 1 Y
││ M2*8 0.00 %
│├0017------------------------------- ME00009 4.0000 2002/10/03
││ Ni-plated nut PCS 1 Y
││ 2*4*1.5 0.00 %
│├0018------------------------------- HA02076 1.0000 2002/10/03
││ header wiring PCS 1 Y
││ 14P-14P 30mm PH=1.27mm 0.00 %
│├0019------------------------------- NI01779 4.0000 2002/11/13
││ LED spacer support PCS 1
││ LEDS-1 1mm 0.00 %
│└0020------------------------------- NI01876 1.0000 2003/03/29
│ LED spacer support PCS 1
│ 7.6*4.5*184 0.00 %
├0061--------------------------------- HK02941 1.0000 2002/11/17
││ PC board PCS 1 Y
││ P-MAXICPU-2-DIP 0.00 %
│├0001------------------------------- HK02940 1.0000 2002/10/03
│││ PC board PCS 1 Y
│││ P-MAXICPU-2-SMD 0.00 %
││├0001----------------------------- HB00371 1.0000 2002/10/03
│││ PCB PCS 1 Y
│││ f313072(DX26) 0.00 %
││├0002----------------------------- CI00049 2.0000 2002/12/16
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 15PF/50V NPO ±5% 0.00 %
│││ C164,C165
│││
││├0003----------------------------- CI00061 10.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 220PF/50V NPO ±5% 0.00 %
│││ C122,C133,C147,C149,C150,C2,C21,C84,C85,C9
│││
││├0004----------------------------- CI00063 6.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 470PF/50V NPO ±5﹪ 0.00 %
│││ C119,C130,C144,C17,C29,C5
│││
││├0005----------------------------- CI00065 6.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 0.001uF/50V X7R ±10% 0.00 %
│││ C112,C123,C134,C18,C30,C6
│││
││├0006----------------------------- CI00066 4.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 0.0018uF/50V X7R ±10% 0.00 %
│││ C38,C39,C50,C51
│││
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 8 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││├0007----------------------------- CI00067 4.0000 2002/10/03

│││ SMDceramic capacitor0603 PCS 1 Y
│││ 0.0022uF/50V X7R ±10% 0.00 %
│││ C40,C45,C48,C49
│││
││├0008----------------------------- CI00071 2.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 0.01uF/50V X7R ±10% 0.00 %
│││ C167,C175
│││
││├0009----------------------------- CI00075 79.0000 2002/10/03
│││ SMDceramic capacitor0603 PCS 1 Y
│││ 0.1uF/50V Y5V +80,-20% 0.00 %
│││ C1,C100,C105,C106,C108,C11,C110,C111,C116,C117,C120,
│││ C121,C127,C128,C131,C132,C139,C14,C140,C141,C184,C20,
│││ C23,C26,C27,C34,C36,C37,C4,C42,C52,C53,C54,C57,C59,
│││ C60,C61,C63,C64,C65,C66,C68,C69,C70,C71,C73,C78,C79,
│││ C8,C81,C82,C83,C86,C87,C88,C96,C97,C98,C99,C142,C145,
│││ C146,C148,C151,C152,C153,C16,C160,C163,C166,C168,C169,
│││ C171,C172,C176,C178,C179,C180,C181
│││
││├0010----------------------------- CI00046 5.0000 2002/10/03
│││ SMDceramic capacitor1206 PCS 1 Y
│││ 1uF/16V Y5V-1206(3216) 0.00 %
│││ C182,C46,C47,C75,C76
│││
││├0011----------------------------- CL00006 26.0000 2002/10/03
│││ SMD tantalum capacitor PCS 1 Y
│││ 10uF/16V case B2 0.00 %
│││ C10,C101,C102,C103,C104,C107,C161,C162,C22,C35,C41,
│││ C55,C56,C58,C62,C67,C72,C74,C77,C80,C89,C90,C91,C92,
│││ C93,C94
│││
││├0012----------------------------- RD00068 12.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 100Ω ±5% 0603 0.00 %
│││ R42,R43,R65,R68,R69,R70,R72,R87,R88,R90,R93,R95
│││
││├0013----------------------------- RD00073 8.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 220Ω ±5% 0603 0.00 %
│││ R51,R53,R73,R74,R75,R85,R91,R92
│││
││├0014----------------------------- RD00078 2.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 470Ω ±5% 0603 0.00 %
│││ R18,R20
│││
││├0015----------------------------- RD00079 3.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 560Ω ±5% 0603 0.00 %
│││ R11,R22,R97
│││
││├0016----------------------------- RD00082 2.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 820Ω ±5% 0603 0.00 %
│││ R50,R54
│││
││├0017----------------------------- RD00083 2.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 1.0KΩ ±5% 0603 0.00 %
│││ R41,R45
│││
││├0018----------------------------- RD00084 5.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 1.2KΩ ±5% 0603 0.00 %
│││ R16,R17,R30,R31,R35
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 9 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

│││
││├0019----------------------------- RD00085 1.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 1.5KΩ ±5% 0603 0.00 %
│││ R52
│││
││├0020----------------------------- RD00086 1.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 1.8KΩ ±5% 0603 0.00 %
│││ R49
│││
││├0021----------------------------- RD00088 3.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 2.2KΩ ±5% 0603 0.00 %
│││ R12,R21,R46
│││
││├0022----------------------------- RD00089 6.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 2.7KΩ ±5% 0603 0.00 %
│││ R1,R5,R58,R62,R67,R9
│││
││├0023----------------------------- RD00093 17.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 4.7KΩ ±5% 0603 0.00 %
│││ R29,R37,R38,R39,R40,R44,R47,R71,R77,R79,R80,R81,R82,
│││ R83,R84,R94,R96
│││
││├0024----------------------------- RD00097 12.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 6.8KΩ ±5% 0603 0.00 %
│││ R14,R15,R3,R4,R55,R56,R59,R60,R63,R64,R7,R8
│││
││├0025----------------------------- RD00101 3.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 10KΩ ±5% 0603 0.00 %
│││ R105,R76,R98
│││
││├0026----------------------------- RD00105 7.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 22KΩ ±5% 0603 0.00 %
│││ R10,R2,R36,R57,R6,R61,R66
│││
││├0027----------------------------- RD00108 2.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 33KΩ ±5% 0603 0.00 %
│││ R106,R107
│││
││├0028----------------------------- RD00111 3.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 47KΩ ±5% 0603 0.00 %
│││ R13,R19,R86
│││
││├0029----------------------------- RD00119 6.0000 2002/10/03
│││ SMDfixed resistor 1/10W PCS 1 Y
│││ 220KΩ ±5% 0603 0.00 %
│││ R100,R101,R102,R103,R104,R99
│││
││├0030----------------------------- RE00005 1.0000 2002/10/03
│││ SMDrow resistor1/16W PCS 1 Y
│││ 33Ω*4 ±5% 8P 0603 0.00 %
│││ AR23
│││
││├0031----------------------------- RE00006 18.0000 2002/10/03
│││ SMDrow resistor1/16W PCS 1 Y
│││ 100Ω*4 ±5% 8P 0603 0.00 %
│││ AR1,AR12,AR13,AR14,AR16,AR19,AR20,AR21,AR22,AR25,AR32,
│││ AR33,AR35,AR39,AR4,AR5,AR7,AR9
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 10 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

│││
││├0032----------------------------- RE00008 19.0000 2002/10/03
│││ SMDrow resistor1/16W PCS 1 Y
│││ 4.7KΩ*4 ±5% 8P 0603 0.00 %
│││ AR10,AR11,AR15,AR17,AR18,AR2,AR24,AR26,AR27,AR28,AR29,
│││ AR3,AR30,AR31,AR34,AR36,AR37,AR6,AR8
│││
││├0033----------------------------- SE00011 3.0000 2002/10/03
│││ SMD rectifier diode PCS 1 Y
│││ RLS4148 0.5A (LL-34) 0.00 %
│││ D1,D2,D3
│││
││├0034----------------------------- SG00067 2.0000 2002/10/03
│││ SMD integraded circuit PCS 1 Y
│││ 74HC04DT 0.00 %
│││ IC27,IC30
│││
││├0035----------------------------- SG00073 1.0000 2002/10/03
│││ SMD integrated circuit PCS 1 Y
│││ 74HC08DT 0.00 %
│││ IC5
│││
││├0036----------------------------- SG00068 1.0000 2002/10/03
│││ SMD integraded circuit PCS 1 Y
│││ 74HC14DT 0.00 %
│││ IC36
│││
││├0037----------------------------- SG00074 1.0000 2002/10/03
│││ SMD integrated circuit PCS 1 Y
│││ 74HC32DT 0.00 %
│││ IC28
│││
││├0038----------------------------- SG00066 1.0000 2002/10/03
│││ SMD integraded circuit PCS 1 Y
│││ 74HC74DT 0.00 %
│││ IC26
│││
││├0039----------------------------- SG00079 2.0000 2002/10/03
│││ SMD integrated circuit PCS 1 Y
│││ SN74HC374DW(TI) 0.00 %
│││ IC33,IC34
│││
││├0040----------------------------- SG00126 6.0000 2002/10/03
│││ integrated circuit PCS 1 Y
│││ PCM1702U 0.00 %
│││ IC11,IC12,IC13,IC17,IC18,IC19
│││
││├0041----------------------------- SG00127 1.0000 2002/10/03
│││ integrated circuit PCS 1 Y
│││ PCM1760U 0.00 %
│││ IC8
│││
││├0042----------------------------- SG00012 1.0000 2002/10/03
│││ SMD integrated circuit PCS 1 Y
│││ AD1892JR 0.00 %
│││ IC31
│││
││├0043----------------------------- SG00047 1.0000 2002/10/03
│││ SMD integrated circuit PCS 1 Y
│││ MAX485EESA 0.00 %
│││ IC32
│││
││├0044----------------------------- SG00121 1.0000 2002/10/29
│││ integrated circuit DRAM(FP)1M* PCS 1 Y
│││ HM5118160LJ-6 0.00 %
│││ IC7
│││
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 11 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││├0045----------------------------- SG00060 1.0000 2002/10/03

│││ SMD integraded circuit dram 1m PCS 1 Y
│││ GM71C18163CJ-6 0.00 %
│││ IC14
│││
││├0046----------------------------- SG00137 1.0000 2002/10/05
│││ integrated circuit PCS 1 Y
│││ AM29F800BB-90EC MD34 E594 0.00 %
│││ IC10
│││
││├0047----------------------------- SG00027 1.0000 2002/10/03
│││ program PCS 1 Y
│││ 8M FLASH 0.00 %
││├0048----------------------------- SG00128 1.0000 2002/10/03
│││ integrated circuit PCS 1 Y
│││ RED 208(LEM NO#105008) 0.00 %
│││ IC20
│││
││├0049----------------------------- SG00021 6.0000 2002/10/03
│││ SMD integraded circuit PCS 1 Y
│││ NJM2068M-TE1(LM833D) 0.00 %
│││ IC2,IC23,IC24,IC25,IC3,IC4
│││
││├0050----------------------------- SG00069 1.0000 2002/10/03
│││ SMD integraded circuit PCS 1 Y
│││ MAX709L-CSA 0.00 %
│││ IC35
│││
││└0051----------------------------- CO00006 2.0000 2002/10/03
││ SMD inductor PCS 1 Y
││ BLM21A102SPT 0.00 %
││ L1,L2
││
│├0002------------------------------- RA00453 1.0000 2002/10/03
││ precise resistor 1/4W PCS 1 Y
││ 110Ω M type 0.00 %
││ R89
││
│├0003------------------------------- RA00200 1.0000 2002/10/03
││ fixed resistor 1/4W PCS 1 Y
││ 330Ω M type 0.00 %
││ R34
││
│├0004------------------------------- RA00678 2.0000 2002/10/03
││ resistor PCS 1 Y
││ 560Ω M type 0.00 %
││ R32,R33
││
│├0005------------------------------- SB00059 1.0000 2002/10/03
││ transistor PCS 1 Y
││ BC327-25 0.00 %
││ TR1
││
│├0006------------------------------- SB00062 1.0000 2002/10/03
││ transistor PCS 1 Y
││ BC337-25 0.00 %
││ TR2
││
│├0007------------------------------- SB00009 6.0000 2002/10/03
││ field effect transistor PCS 1 Y
││ J176(VISHAY) 0.00 %
││ TR3,TR4,TR5,TR6,TR7,TR8
││
│├0008------------------------------- CB00031 6.0000 2002/10/03
││ electrotytic capacitor PCS 1 Y
││ 22uF/50V ψ5*11 0.00 %
││ C113,C124,C135,C15,C28,C3
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 12 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││
│├0009------------------------------- CB00040 6.0000 2002/10/03
││ electrotytic capacitor PCS 1 Y
││ 47uF/25V 0.00 %
││ C109,C115,C126,C13,C25,C44
││
│├0010------------------------------- CB00048 12.0000 2002/10/03
││ electrotytic capacitor PCS 1 Y
││ 100uF/25V 5mm 0.00 %
││ C114,C118,C12,C125,C129,C136,C143,C19,C24,C31,C43,C7
││
│├0011------------------------------- CB00056 1.0000 2002/10/03
││ electrolytic capacitor PCS 1 Y
││ 220uF/25V 0.00 %
││ C174
││
│├0012------------------------------- SC00102 1.0000 2002/10/03
││ quartz crystalloid PCS 1 Y
││ 24.576MHZ HC-49/U1.2S±20PPM 0.00 %
││ XT1
││
│├0013------------------------------- HJ00007 1.0000 2002/10/03
││ 鎳鎘電池 PCS 1 Y
││ 4.8V 280mAh(VI-4N280BC(V2)) 0.00 %
│├0014------------------------------- HC00080 1.0000 2002/10/03
││ row-wire header PCS 1 Y
││ 6P 2.5mm 180° 0.00 %
││ CN5
││
│├0015------------------------------- HC00046 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 4PIN A28b-4B.T.6 0.00 %
││ CN3
││
│├0016------------------------------- HC00047 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 6PIN A28b-6B.T.6 0.00 %
││ CN7
││
│├0017------------------------------- HC00049 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 10PIN A28b-10B.T.6 0.00 %
││ CN2
││
│├0018------------------------------- HC00050 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 14PIN A28b-14B.T.6 0.00 %
││ CN4
││
│├0019------------------------------- HC00051 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 20PIN A28b-20B.T.6 0.00 %
││ CN9
││
│├0020------------------------------- HC00170 1.0000 2002/10/03
││ row-wire header PCS 1 Y
││ 2P 3.96mm 180° 0.00 %
││ CN6
││
│├0021------------------------------- TB00018 1.0000 2002/10/03
││ transformer PCS 1 Y
││ LT-0806M(D/A Data Transmission 0.00 %
││ TF2
││
│├0022------------------------------- HC00156 1.0000 2002/10/03
││ row pin (double) PCS 1 Y
││ 2.54 180° 2*2P(gold-plated) 6/11.6mm 0.00 %
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 13 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││ J1
││
│└0023------------------------------- NI00220 1.0000 2002/10/03
│ cable tie PCS 1 Y
│ ALT-180L 0.00 %
├0062--------------------------------- HK02204 1.0000 2002/11/17
││ PC board PCS 1 Y
││ P-F313085-DIP 0.00 %
│├0001------------------------------- HC00049 1.0000 2002/09/11
││ row-wire stock PCS 1 N
││ 10PIN A28b-10B.T.6 0.00 %
││ CN1
││
│└0002------------------------------- HK02205 1.0000 2002/09/11
│ │ PC board PCS 1 N
│ │ P-F313085-SMD 0.00 %
│ ├0001------------------------------ HB00373 1.0000 2002/09/11
│ │ PCB PCS 1 N
│ │ F313085(1*8) 0.00 %
│ ├0002------------------------------ CI00075 3.0000 2002/09/11
│ │ SMDceramic capacitor0603 PCS 1 N
│ │ 0.1uF/50V Y5V +80,-20% 0.00 %
│ │ C4,C1,C5
│ │
│ ├0003------------------------------ CL00006 2.0000 2002/09/11
│ │ SMD tantalum capacitor PCS 1 N
│ │ 10uF/16V case B2 0.00 %
│ │ C2,C3
│ │
│ ├0004------------------------------ RD00066 4.0000 2002/09/11
│ │ SMDfixed resistor 1/10W PCS 1 N
│ │ 68Ω ±5% 0603 0.00 %
│ │ R2,R4,R5,R6
│ │
│ ├0005------------------------------ RD00101 1.0000 2002/09/11
│ │ SMDfixed resistor 1/10W PCS 1 N
│ │ 10KΩ ±5% 0603 0.00 %
│ │ R1
│ │
│ ├0006------------------------------ RD00112 1.0000 2002/09/11
│ │ SMDfixed resistor 1/10W PCS 1 N
│ │ 56KΩ ±5% 0603 0.00 %
│ │ R3
│ │
│ ├0007------------------------------ SG00072 1.0000 2002/09/11
│ │ SMD integrated circuit PCS 1 N
│ │ 74LVC125AD 0.00 %
│ │ IC2
│ │
│ ├0008------------------------------ SG00037 1.0000 2002/09/11
│ │ SMD integrated circuit PCS 1 N
│ │ LD1117DT33C 0.00 %
│ │ IC1
│ │
│ └0009------------------------------ HC00462 1.0000 2002/10/30
│ mmc PCS 1 N
│ PLS007-3003-0(YAMAICHI) 0.00 %
├0063--------------------------------- HK02944 1.0000 2002/11/17
││ K-PC板 PCS 1 Y
││ P-MAXIPU-2 0.00 %
│├0001------------------------------- HB00324 1.0000 2002/10/03
││ PCB PCS 1 Y
││ F313067 0.00 %
│├0002------------------------------- CA00009 12.0000 2002/10/03
││ ceramic capacitor PCS 1 Y
││ 22PF/50V NPO 0.00 %
││ C25,C26,C27,C28,C29,C30,C33,C34,C54,C55,C57,C59
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 14 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││
│├0003------------------------------- CH00017 29.0000 2002/10/03
││ heap-layer capacitor (stand) PCS 1 Y
││ 0.1uF/50V Y5V PH5 0.00 %
││ C10,C11,C12,C13,C14,C15,C16,C17,C18,C19,C2,C20,C21,
││ C22,C24,C31,C36,C38,C39,C40,C41,C53,C58,C6,C61,C62,
││ C63,C64,C71
││
│├0004------------------------------- CB00025 1.0000 2002/10/03
││ electrolytic capacitor PCS 1 Y
││ 10uF/50V ψ6.3*7 0.00 %
││ C9
││
│├0005------------------------------- CB00040 22.0000 2002/10/03
││ electrotytic capacitor PCS 1 Y
││ 47uF/25V 0.00 %
││ C3,C35,C4,C42,C43,C44,C45,C46,C47,C48,C49,C50,C51,C52,
││ C56,C60,C65,C66,C67,C68,C69,C70
││
│├0006------------------------------- CB00072 3.0000 2002/10/03
││ electrotytic capacitor PCS 1 Y
││ 1000uF/25V φ10*20 0.00 %
││ C23,C32,C8
││
│├0007------------------------------- CB00080 1.0000 2002/10/03
││ electrotytic capacitor PCS 1 Y
││ 2200uF/25V φ16*25 0.00 %
││ C5
││
│├0008------------------------------- RA00515 2.0000 2002/10/03
││ precise resistor 1/4W PCS 1 Y
││ 10.0KΩ M type 0.00 %
││ R24,R28
││
│├0009------------------------------- RA00524 8.0000 2002/10/03
││ precise resistor 1/4W PCS 1 Y
││ 15.0kΩ M type 0.00 %
││ R22,R23,R26,R27,R32,R33,R35,R36
││
│├0010------------------------------- RA00549 2.0000 2002/10/03
││ precise resistor 1/4W PCS 1 Y
││ 39.2KΩ M type 0.00 %
││ R25,R29
││
│├0011------------------------------- RA00159 3.0000 2002/10/03
││ fixed resistor 1/4W PCS 1 Y
││ 10Ω Mr type 0.00 %
││ R30,R31,J16
││
│├0012------------------------------- RA00165 1.0000 2002/10/03
││ fixed resistor 1/4W PCS 1 Y
││ 22Ω M type 0.00 %
││ J10
││
│├0013------------------------------- RA00184 6.0000 2002/10/03
││ fixed resistor 1/4W PCS 1 Y
││ 100Ω M type 0.00 %
││ R1,R2,R3,R4,R5,R6
││
│├0014------------------------------- RA00671 2.0000 2002/10/03
││ resistor PCS 1 Y
││ 100Ω M type 0.00 %
││ R7,R8
││
│├0015------------------------------- RA00676 12.0000 2002/10/03
││ resistor PCS 1 Y
││ 330Ω M type 0.00 %
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 15 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││ R38,R40,R42,R44,R46,R48,R50,R52,R54,R56,R58,R60
││
│├0016------------------------------- RA00651 14.0000 2002/10/03
││ resistor PCS 1 Y
││ 10KΩ M type 0.00 %
││ R34,R37,R39,R41,R43,R45,R47,R49,R51,R53,R55,R57,R59,
││ R61
││
│├0017------------------------------- RA00655 6.0000 2002/10/03
││ resistor PCS 1 Y
││ 22KΩ M type 0.00 %
││ R11,R13,R15,R17,R19,R21
││
│├0018------------------------------- SA00093 8.0000 2002/10/03
││ rectifier diode PCS 1 Y
││ 1N4148 0.5A 0.00 %
││ D10,D11,D12,D5,D6,D7,D8,D9
││
│├0019------------------------------- SA00100 4.0000 2002/10/03
││ zener diode PCS 1 Y
││ 1W 6.2V 1N4735 0.00 %
││ D13,D14,D15,D16
││
│├0020------------------------------- SA00101 2.0000 2002/10/03
││ zener diode PCS 1 Y
││ 1W 6.8V 1N4736 0.00 %
││ D1,D2
││
│├0021------------------------------- SA00104 2.0000 2002/10/03
││ zener diode PCS 1 Y
││ 1W 10V 1N4740 0.00 %
││ D3,D4
││
│├0022------------------------------- SD00074 1.0000 2002/10/03
││ integrated circuit PCS 1 Y
││ 7805(TO-220) 0.00 %
││ IC2
││
│├0023------------------------------- SD00083 1.0000 2002/10/03
││ integrated circuit PCS 1 Y
││ 7905(TO-220) 0.00 %
││ IC1
││
│├0024------------------------------- SD00019 1.0000 2002/10/03
││ integrated circuit PCS 1 Y
││ MAX202ECPE 0.00 %
││ IC11
││
│├0025------------------------------- SD00119 2.0000 2002/10/03
││ integrated circuit PCS 1 Y
││ JRC NJM2068DD(LM833N) 0.00 %
││ IC10,IC9
││
│├0026------------------------------- HE00024 6.0000 2002/11/13
││ IC PCS 1 Y
││ GM HYBRID IC.GM CODE:102004 0.00 %
││ IC3,IC4,IC5,IC6,IC7,IC8
││
│├0027------------------------------- HC00324 1.0000 2002/10/03
││ wire terminal PCS 1 Y
││ 6.5m/m (PC250) 0.00 %
││ S1
││
│├0028------------------------------- HC00080 1.0000 2002/10/03
││ row-wire header PCS 1 Y
││ 6P 2.5mm 180° 0.00 %
││ CN5
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 16 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

││
│├0029------------------------------- HC00400 1.0000 2002/10/03
││ jack PCS 1 Y
││ D-SHB-9P 0.00 %
││ CN8
││
│├0030------------------------------- HC00046 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 4PIN A28b-4B.T.6 0.00 %
││ CN6
││
│├0031------------------------------- HC00047 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 6PIN A28b-6B.T.6 0.00 %
││ CN4
││
│├0032------------------------------- HC00050 1.0000 2002/10/03
││ row-wire stock PCS 1 Y
││ 14PIN A28b-14B.T.6 0.00 %
││ CN7
││
│├0033------------------------------- HC00437 1.0000 2003/04/04
││ row-wire stock PCS 1 Y
││ 6P 3.96mm 180° 0.00 %
││ CN1
││
│├0034------------------------------- HC00170 1.0000 2002/10/03
││ row-wire header PCS 1 Y
││ 2P 3.96mm 180° 0.00 %
││ CN3
││
│├0035------------------------------- HC00265 1.0000 2002/10/03
││ row-wire header JST2.5(S) PCS 1 Y
││ 2P 2.5mm 180° 0.00 %
││ CN2
││
│├0036------------------------------- HC00111 7.0000 2002/10/03
││ MIC jack for balance PCS 1 Y
││ 99M-108SP1 0.00 %
││ S10,S11,S4,S6,S7,S8,S9
││
│├0037------------------------------- HC00112 2.0000 2002/10/03
││ MIC jack for balance PCS 1 Y
││ 99M-107SP-1-2 90° PUSH 0.00 %
││ S3,S5
││
│├0038------------------------------- HC00113 2.0000 2002/10/03
││ combined balanced jack PCS 1 Y
││ 97M-1007P-H 90° 0.00 %
││ S12,S13
││
│├0039------------------------------- HA01925 14.0000 2002/10/03
│││ jumper wire PCS 1 Y
│││ 10mm 0.00 %
│││ J11,J17,J18,J19,J20,J21,J22,J23,J24,J25,J7,J8,J9,R9
│││
││└0001----------------------------- HA02249 0.0200 2002/09/19
││ wire M 1 N
││ φ0.6 KG 0.00 %
│├0040------------------------------- HA01928 1.0000 2002/10/03
│││ jumper wire PCS 1 Y
│││ 12mm 0.00 %
│││ J26
│││
││└0001----------------------------- HA02249 0.0220 2002/09/19
││ wire M 1 N
││ φ0.6 KG 0.00 %
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 17 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

│├0041------------------------------- HA01937 10.0000 2002/10/03

│││ jumper wire PCS 1 Y
│││ 18mm 0.00 %
│││ J1,J12,J13,J14,J15,J2,J3,J4,J5,J6
│││
││└0001----------------------------- HA02249 0.0280 2002/09/20
││ wire M 1 Y
││ φ0.6 KG 0.00 %
│├0042------------------------------- MI00257 1.0000 2002/10/03
││ heat-sink PCS 1 Y
││ 25*34.6*12*1.5 DX26 0.00 %
│├0043------------------------------- CG00018 21.0000 2002/10/03
││ filter-EMI FILTER PCS 1 Y
││ LF-22UH(WAH TAYI) 0.00 %
││ L1,L10,L11,L12,L13,L14,L15,L16,L17,L18,L19,L2,L20,L21,
││ L3,L4,L5,L6,L7,L8,L9
││
│├0044------------------------------- NC00005 2.0000 2002/10/03
││ silicone insulator PCS 1 Y
││ TO-220 square type 0.00 %
││ IC1,IC2
││
│├0045------------------------------- NI00863 1.0000 2002/10/03
││ insulate bean PCS 1 Y
││ TO220B 0.00 %
││ IC1
││
│├0046------------------------------- MG00027 1.0000 2002/10/03
││ screw PCS 1 Y
││ M3*12 0.00 %
│├0047------------------------------- MF00037 1.0000 2002/10/03
││ washer PCS 1 Y
││ φ3*φ5*1t 0.00 %
│└0048------------------------------- ME00015 1.0000 2002/10/03
│ colour nut PCS 1 Y
│ 3m/m 0.00 %
├0064--------------------------------- HD00006 1.0000 2002/11/17
│ fuse TSD PCS 1
│ 315mA 250V φ5.2*20mm CSA/S/UL/VDE 0.00 %
├0065--------------------------------- MG00025 18.0000 2002/11/17
│ screw PCS 1
│ M3*6 0.00 %
├0066--------------------------------- MG00041 18.0000 2003/04/11
│ screw PCS 1
│ M3*6 0.00 %
├0067--------------------------------- HA01733 2.0000 2002/11/17
│ P.V.C single wave wired UL1617 PCS 1
│ 130 blue 0.00 %
├0068--------------------------------- NI02249 1.0000 2002/11/17
│ caushion PCS 1
│ TW-1(TO-220) 0.00 %
├0069--------------------------------- NE02717 2.0000 2002/11/17
││ label PCS 1 Y
││ MADE IN CHINA 0.00 %
│├0001------------------------------- NI00067 1.0000 2003/01/30
││ R-25#透明龍 M 700 N
││ cellophane paper 0.00 %
│└0002------------------------------- NI00027 1.0000 2003/01/30
│ membrane M 700 N
│ 0.105*1M 0.00 %
├0070--------------------------------- NE10964 1.0000 2002/12/24
││ label PCS 1
││ MAXIDRIVE3.4 0.00 %
│├0001------------------------------- NH00012 1.0000 2002/12/21
││ bond paper M 80 N
││ 0.04*1M 0.00 %
 SEKAKU ELECTRON INDUSTRY CO.,LTD

Multi-Level BOM Structure Listing

Report No.: IEBO_P02 Date 2003/04/12
Prepared by 980029[廖芙蓉] Page No.: 18 / 18
Item No. PF00755 Version UNIT: PCS
DESCRIPTION: MAXIDRIVE3.4 Date:
2002/11/17
MAXIDRIVE3.4_ALTO_85 264V_歐規_CHINA
Version Item No Loss % Ver. Unit Cardinal Effective Date
Item Descri Usage Rate @:Phantom Layer
Component Remark Attrition Rate

│└0002------------------------------- NI00014 1.0000 2002/12/21

│ membrane M 80 N
│ 0.035*1M 0.00 %
├0071--------------------------------- NF01131 1.0000 2003/01/24
││ instruction PCS 1
││ MAXIDRIVE3.4 ALTO 0.00 %
│└0001------------------------------- NH00149 2.7500 2002/12/05
│ paper 張 1 Y
│ 889*640mm 令 0.00 %
└0072--------------------------------- MG00281 6.0000 2003/04/05
screw PCS 1
M3*6 0.00 %
8.Exploded Views