Transporter Fitting Locations No.

801 / 1
1 -Fitting Locations: Control units

No. Function/component Location Figure on page

1 - Radiator fan control unit -J293- - In engine compartment - Low or medium blower output: ⇒ page 13
Increased blower output ⇒ page 12
2 - Mechatronic unit for dual clutch gearbox -J743- - In engine compartment - ⇒ page 10
3 - Heated front seats control unit -J774- - behind dash panel, near relay carrier cockpit - ⇒ page 40

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
4 - Mobile telephone operating electronics control unit -J412- - Behind the glove compartment - ⇒ page 41
5 - Auxiliary heater control unit -J364- - Under models, behind right A-pillar - ⇒ page 72
6 - Tachograph -G24- - depends on equipment - ⇒ page 70
- Radio -R- - Dash panel - centre - ⇒ page 74
- Control unit with display for radio and navigation system
-J503-
- Climatronic control unit -J255- - Dash panel - centre - ⇒ page 64
- Air conditioning system control unit -J301-
7 - Headlight range control, control unit -J431- - behind dash panel, near relay carrier cockpit - ⇒ page 72
- Data bus diagnostic interface -J533- (only models with stop/
start system)
8 - Control unit in dash panel insert -J285- - In dash panel insert - ⇒ page 30
9 - Sliding sunroof adjustment control unit -J245- - On sliding/tilting sunroof - ⇒ page 40
10 - Front passenger door control unit -J387- - In the front right door - ⇒ page 35
11 - Trailer detector control unit -J345- - Under the seat on front right - ⇒ page 53
- Voice amplification control unit -J656-
- Amplifier -R12-
- TV tuner -R78-
- Reversing camera system control unit -J772-
- CD changer -R41-
12 - Operating and display unit for camping equipment -E153- - on rear right of roof - ⇒ page 62
13 - Right sliding door control unit -J731- - On right D-pillar - with electric sliding door ⇒ page 47
- without electric sliding door ⇒ page 49
14 - Lane change assist control unit 2 -J770- - On right D-pillar - ⇒ page 73
15 - Lane change assist control unit -J769- - On left D-pillar - ⇒ page 73
16 - Left sliding door control unit -J558- - On left D-pillar - with electric sliding door ⇒ page 43
- without electric sliding door ⇒ page 45
-
Rear lid control unit -J605- - On left D-pillar - ⇒ page 51
17 -
Interior monitor send and receive module 2 -G305- - In rear headliner - ⇒ page 39
18 -
Four-wheel drive control unit -J492- - On the rear axle final drive, in front left area - ⇒ page 60
19 -
Operating and display unit for rear Climatronic -E265- - In centre headliner - ⇒ page 67
-
Rear fresh air blower switch -E179-
20 -
Interior monitor send and receive module 1 -G303- with Anti- - On the roof console - ⇒ page 39
theft and tilt system control unit -J529-
21 - Airbag control unit -J234- - Below the centre dash panel - ⇒ page 37
22 - Roof display unit -J702- - On the roof console - ⇒ page 74
23 - Driver door control unit -J386- - In the front left door - ⇒ page 35

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
24 - Multifunction steering wheel control unit -J453- - On multifunction steering wheel - Without figure
25 - Parking aid control unit -J446- - Behind the dash panel, left - ⇒ page 33
26 - Onboard supply control unit -J519- - Left under dash panel - ⇒ page 14
27 - Heater control unit -J162- - Under models, behind left A-pillar - ⇒ page 75
28 - Battery monitor control unit -J367- - In left engine compartment, on the battery - ⇒ page 9
29 - ABS control unit -J104- - in left engine compartment - ⇒ page 7
30 - Voltage stabiliser -J532- - in left engine compartment - ⇒ page 9
- Engine control unit -J623- - in left engine compartment - ⇒ page 4
31 - Left gas discharge light control unit -J343- - On left and right headlight - ⇒ page 75
- Right gas discharge light control unit -J344-
32 - Control unit for left daytime running light and side light -J860- - On left and right headlight - ⇒ page 76
- Control unit for right daytime running light and side light
-J861-
- - Alarm system control unit -J85- - see Fitting Locations Relay - Without figure
- - Automatic glow period control unit -J179- - see Fitting Locations Relay - Without figure
- - Differential lock control unit -J187- - see Fitting Locations Relay - Without figure
- - Immobilizer control unit -J362- - in control unit in dash panel insert -J285- - Without figure
integrated
- - Taxi alarm system 2 control unit -J430- - see Fitting Locations Relay - Without figure
- - Radio controlled clock receiver -J489- - in right engine compartment, near horn/ dual - ⇒ Workshop Manual
tone
- - Power steering control unit -J500- - see Fitting Locations Relay - Without figure
- - Data bus diagnostic interface -J533- (only models without stop/ - in onboard supply control unit -J519- integrated - Without figure
start system)
- - Taxi alarm remote control, control unit -J601- - see Fitting Locations Relay - Without figure
- - Engine continues to run without key control unit -J905- - Under the seat on front left - Without figure

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.1 Engine compartment

1 - Electronics box, in engine compartment

2 - Fuse holder D -SD- , in engine compartment
3 - Fuse holder A -SA- , in electronics box
4 - Upper housing half for fuse holder, in engine compartment
5 - Pin connectors on engine control unit -J623- , in electronics box
6 - Engine control unit -J623- , in electronics box

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.1.1 Connector assigment:

A - Engine control unit -J623-

Pin connector:

B - 94-pin connector -T94-

C - 60-pin connector -T60-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.1.2 Connector assigment:

A - Engine control unit -J623-

Pin connector:

B - 81-pin connector -T121-

C - 40-pin connector -T121-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1

Note

The 40-pin connector -T40- and the 81-pin connector -T81- are in the Current Flow Diagram as 121-pin connector -T121-
designated.
.

– Back to overview ⇒ page 1

1.2 ABS control unit -J104-

1.2.1 Location:
in left engine compartment

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.2.2 Connector assigment of ABS control unit -J104-

A - ABS control unit -J104-

Pin connector:

B - 47-pin connector -T47-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.3 Voltage stabiliser -J532-

1.3.1 Location:
Electronics box, in engine compartment -arrow-
– Back to overview ⇒ page 1

1.4 Battery monitor control unit -J367-

1.4.1 Location:
In left engine compartment, on the battery -A-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.5 Mechatronic unit for dual clutch gearbox -J743-
1.5.1 Location:
On gearbox -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.5.2 Connector assigment Mechatronic unit for dual clutch gearbox -J743-

A - Mechatronic unit for dual clutch gearbox -J743-

Pin connector:

B - 16-pin connector -T16m-

c - 2-pin connector -T2-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.6 Radiator fan control unit -J293-

1.6.1 Radiator fan control unit -J293- with increased blower output

A - Radiator fan control unit -J293-

Note

only for models with increased blower output

Pin connector:

B - 4-pin connector -T4ax-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.6.2 Radiator fan control unit -J293- with low or medium blower output

A - Radiator fan control unit -J293-

Note

only models with low or medium blower output

Pin connector:

B - 4-pin connector -T4ak-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.7 Onboard supply control unit -J519-
1.7.1 Location:
Under dash panel -arrow-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.7.2 Onboard supply control unit -J519-

A - Onboard supply control unit -J519-

B - 73-pin connector -T73a- (black)
C - 73-pin connector -T73b- (white)

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1

Note

♦ The data bus diagnostic interface -J533- in control unit onboard supply control unit -J519-
integrated (only models without stop/start system).
♦
♦ Data bus diagnostic interface -J533- only models with stop/start system ⇒ page 72

– Back to overview ⇒ page 1

1.7.3 Connector assigment of onboard supply

control unit -J519-

1.7.4 73-pin connector -T73a-

Pin Assignment/Component Input/Output Terminal
1 - Headlight main beam relay -J12- Output 56a
- Fuse 1 on fuse holder F -SF1- 4)
- Fuse 12 on fuse holder F -SF12- 4)
2 - Left headlight twin filament bulb -L1- Output 56b
- Left dipped beam bulb -M29-
- Left gas discharge light control unit -J343- 9)
- ♦ Left gas discharge (xenon) bulb -L13- 9)

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
3 - Battery isolation relay -J7- Output 85
- Second battery charging circuit relay -J713-
- Operating and display unit for camping equipment -E153-
4 - Front interior light -W1- Output 31
- Interior lighting central switch button -E390-
- Interior light switch (taxi) -E115- 10)
- Interior monitor deactivation switch -E183-
- Button for deactivating interior monitoring and vehicle inclination sensor -E616-
- 3-pin connector -T3am-
- 3-pin connector -T3an-
- Rear interior light
- Illuminated entry strip
5 - Right headlight twin filament bulb -L2- Output TFL
- Right day driving light bulb -L175-
- Control unit for right daytime running light and side light -J861- 9)
- ♦ Right LED module for daytime running light and side light -L177- 9)

6 - Rear left fog light bulb -L46- Output RFL

- Rear right fog light bulb -L47-
7 - Front and rear fog light switch -E23- (T10bb/5) Input FL
- Front and rear fog light switch -E23- (T17/8)
- ♦ Fuse 5 on fuse holder F -SF5- 4)

8 - Drive train CAN bus isolation relay -J788- Output 85

9 - Vacant - -
10 - Rear lid release motor -V139- 2) Output -
11 - Right sliding door contact strip -F352- 2) Output -
- Left sliding door contact strip -F353- 2)
- Driver door central locking motor -V56- 2)
-
-V57- 2)
- Front passenger door central locking motor 2)
- Rear right door central locking motor -V97-
- Rear left door central locking motor -V115- 2)
Rear lid lock motor -V120- 2)
12 - Driver door central locking motor -V56- Output -
13 - Vacant - -
14 - Earth for central locking Input 31

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
15 - Right sliding door contact strip -F352- 2) Output -
- Left sliding door contact strip -F353- 2)
- Front passenger door central locking motor -V57- 2)
- 2)
- Rear right door central locking motor -V97- 2)
- Rear left door central locking motor -V115-
Rear lid lock motor -V120- 2)
16 - Fuse 8 on fuse holder B -SB8- (Terminal 30, central locking) Input 30ZV
- ♦ Alarm horn -H12-
-
- ♦ Left sliding door control unit -J558-
- ♦ Rear lid control unit -J605-

♦ Right sliding door control unit -J731-

17 - Left sliding door contact strip -F353- 2) Input -

- Rear left central locking lock unit -F222- 2) , 7)
18 - Right sliding door contact strip -F352- 2) Input -
- Rear right central locking lock unit -F223- 2) , 7)
19 - Driver door contact switch -F2- Input -
- Driver side central locking lock unit -F220-
20 - Front passenger door contact switch -F3- Input -
- Front passenger side central locking lock unit -F221-
21 - Front passenger side central locking lock unit -F221- Input -
22 - Driver side central locking lock unit -F220- Input -
23 - Rear lid handle release button -E234- Input -
- Childproof lock button -E318-
- Release button for rear lid lock cylinder -F248-
24 - Driver side central locking lock unit -F220- Input -
25 - Driver side interior locking switch -E150- Input -
26 - Right sliding door control unit -J731- Input -
- Dual signal inverter relay -J741-
- Rear right door contact switch -F11-
- Rear right central locking lock unit -F223- 7)
27 - Bonnet contact switch -F266- Input -
28 - Hazard warning light switch -E3- Input -
29 - Steering column electronics control unit -J527- Input -
- ♦ Airbag coil connector and return spring with slip ring -F138-
-
♦ Horn plate -H-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
30 - Rear lid contact switch -F111- Input -
- ♦ Rear lid control unit -J605-

31 - Luggage compartment light switch -F5- Input -

- ♦ Centre interior light -W7-
-
- ♦ Rear left reading light -W11-
- ♦ Rear right reading light -W12-
-
♦ Luggage compartment light on left -W18-
♦ Right luggage compartment light -W35-

32 - 10-pin connector -T10bj- 4) Input -

- Accident data memory -J754-
- Steering column electronics control unit -J527-
- ♦ Turn signal switch -E2-

33 - 10-pin connector -T10bj- 4) Input -

- Accident data memory -J754-
- Steering column electronics control unit -J527-
- ♦ Turn signal switch -E2-

34 - Left sliding door control unit -J558- Input -

- Dual signal inverter relay -J741-
- Rear left door contact switch -F10-
- Rear left central locking lock unit -F222- 7)
35 - Sliding sunroof adjustment control unit -J245- Output -
36 - Heated front seats control unit -J774- Output -
37 - Light switch -E1- (T10bb/2) Input AFL
38 - Suppression filter -C10- Output -
- Driver side heated exterior mirror -Z4-
- Front passenger side heated exterior mirror -Z5-
39 - Vacant - -
40 - Right tail light bulb -M2- 7) Output 58r
- Right side light bulb -M3-
- Right brake and tail light bulb -M22-
41 - Left side light bulb -M1- Output 58l
- Left tail light bulb -M4- 7)
- Left brake and tail light bulb -M21-
- 6-pin connector -T6bn-
- 10-pin connector -T10bh- 4)

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
42 - Fuse 19 on fuse holder B -SB19- Input -
- ♦ Operating and display unit for camping equipment -E153-
-
- ♦ Roof hydraulics control unit -J768-
- ♦ 10-pin connector -T10bh- 4)
♦ 10-pin connector -T10bj- 4)

43 - Brake light switch -F- Input -

- ♦ ABS control unit -J104-
-
- ♦ Trailer detector control unit -J345-
♦ Engine control unit -J623-

44 - Fuse 16 on fuse holder B -SB16- Input -

- ♦ Stop/start system button -E693- 11)
-
- ♦ Voltage stabiliser -J532- 11)
♦ Data bus diagnostic interface -J533- 11)

45 - Light switch -E1- (T10bb/3) Input 58

- Light switch -E1- (T17/16)
- ♦ Switches and instruments illumination regulator -E20-
-
- ♦ Fuse 11 on fuse holder B -SB11-
♦ Fuse 35 on fuse holder B -SB35-

46 - Vacant - -
47 - Vacant - -
48 - Sliding sunroof adjustment control unit -J245- Output -
49 - Headlight washer system relay -J39- Output -
50 - Vacant Output -
51 - Entry and footwell light relay -J348- Output -
52 - Electric fuel pump 2 relay -J49- Output -
53 - Vacant -
54 - X-contact relief relay -J59- Output 75X
55 - Engine control unit -J623- Output 50
- Starter inhibitor relay -J207-
- 10-pin connector -T10bj- 4)
56 - Hazard warning light switch -E3- Output -

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
57 - Interior monitor deactivation switch -E183- Output -
- Button for deactivating interior monitoring and vehicle inclination sensor -E616-
58 - Central locking deadlock function warning lamp -SAFE- -K133- Output -
59 - Vacant - -
60 - Heated rear window switch -E15- Output -
61 - Vacant - -
62 - Headlight dipper/flasher switch -E4- Input -
- ♦ Alarm system control unit -J85- 10)
-
- ♦ Control unit in dash panel insert -J285-
-
- ♦ Front left headlight -MX1-
- ♦ Front right headlight -MX2-
-
- ♦ Fuse 6 on fuse holder B -SB6-
♦ Fuse 28 on fuse holder B -SB28-
♦ Fuse 3 on fuse holder F -SF3- 4)
♦ Fuse 4 on fuse holder F -SF4- 4)

63 - Fuse 12 on fuse holder C -SC12- (left dipped headlight/main beam) Input 30

64 - Fuse 20 on fuse holder C -SC20- Input -
- ( Driver side heated exterior mirror -Z4- )
- ( Front passenger side heated exterior mirror -Z5- )
65 - Fuse 17 on fuse holder C -SC17- 3) Output 30G
- Fuse 24 on fuse holder C -SC24- 3)
- ♦ Front and rear interior lights
-
- ♦ Luggage compartment lights -W18- , -W35-
-
- ♦ Illuminated entry strip -W31- , -W32- , -W33- , -W34-
- ♦ Glove compartment light -W6-
♦ Illuminated vanity mirror -W14- , -W20-
♦ Automatic anti-dazzle interior mirror -Y7-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
66 - Fuse 7 on fuse holder B -SB7- 3) Input 30
- Fuse 17 on fuse holder C -SC17- 3)
- ♦ Side light
-
- ♦ Front and rear interior lights
-
- ♦ Luggage compartment lights -W18- , -W35-
- ♦ Illuminated entry strip -W31- , -W32- , -W33- , -W34-
-
♦ Glove compartment light -W6-
♦ Illuminated vanity mirror -W14- , -W20-
♦ Automatic anti-dazzle interior mirror -Y7-

67 - Vacant - -
68 - Fuse 32 on fuse holder B -SB32- ( windscreen wiper motor -V- ) Input 30
69 - Windscreen wiper motor -V- Output -
70 - Earth for windscreen wiper motor -V- Input 31
71 - Windscreen wiper motor -V- Output -
72 - Horn or dual tone horn -H1- Output
- Bass tone horn -H7-
- Horn relay -J413-
- 10-pin connector -T10bj- 4)
73 - Fuse 31 on fuse holder B -SB31- ( horn or dual tone horn -H1- , bass tone horn -H7- ) Input 30

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1

Note

♦ 1) for models with dual clutch gearbox only

♦ 2) for models with central locking only

♦ 3) see interior light Current Flow Diagram

♦ 4) only models with interface, for external use

♦ 5) for models without central locking only

♦ 6) for models with mechanical sliding door and without anti-theft alarm system only

♦ 7) for models with double cab/ plank bed only

♦ 8) for models with anti-theft alarm system only (DWA) and anti-theft alarm system horn

♦ 9) for models with GDL in headlight only

♦ 10) for models with taxi equipment only

♦ 11) only models with stop/start system

♦ 12) applicable up to November 2009

– Back to overview ⇒ page 1

1.7.5 73-pin connector -T73b-

Pin Assignment/Component Input/Output Terminal
1 - Switches and instruments illumination regulator -E20- Output 58
- Fuse 35 on fuse holder B -SB35-
- Onboard supply control unit -J519- (T73b/34)
2 - Right dipped beam bulb -M31- Output 56b
- Right headlight twin filament bulb -L2-
- Right gas discharge light control unit -J344- 9)
- ♦ Right gas discharge (xenon) bulb -L14- 9)

3 - Left headlight twin filament bulb -L1- Output TFL

- Left day driving light bulb -L174-
- Control unit for left daytime running light and side light -J860- 9)
- ♦ Left LED module for daytime running light and side light -L176- 9)

4 - Vacant - -

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
5 - Control unit for left daytime running light and side light -J860-
9) - 58l
- ♦ Left LED module for daytime running light and side light -L176- 9)

6 - Control unit for right daytime running light and side light -J861- 9) - 58r
- ♦ Right LED module for daytime running light and side light -L177- 9)

7 - Number plate light -X- Output 58

- Number plate left light -X4- 7)
- Number plate right light -X5- 7)
8 - Vacant -
9 - Left fog light bulb -L22- Output FL
- Fuse 5 on fuse holder F -SF5- 4)
10 - Right fog light bulb -L23- Output FL
11 - Fuse 35 on fuse holder C -SC35- Input 30
- ( Left reversing light bulb -M16- )
- ( Right reversing light bulb -M17- )
- ( Left fog light bulb -L22- (Turning light))
- ( Right fog light bulb -L23- (Turning light))
12 - Accident data memory -J754- Output RFL
- Reversing light bulb -M16- , -M17-
- 10-pin connector -T10bh- 4)
- Trailer socket -U10-
- Automatic anti-dazzle interior mirror -Y7-
13 - Fuse 36 on fuse holder B -SB36- (Brake light and turn signal) Input 30
14 - Blocking diode -J29- 10) Output BLL
- Front left turn signal bulb -M5-
- Rear left turn signal bulb -M6-
- Left side mounted turn signal bulb -M18-
- Left roof turn mounted signal bulb -M23-
15 - Blocking diode -J29- 10) Output BLR
- Front right turn signal bulb -M7-
- Rear right turn signal bulb -M8-
- Right side mounted turn signal bulb -M19-
- Right roof mounted turn signal bulb -M24-
16 - Accident data memory -J754- Output 54
- Left brake light bulb -M9- 7)
- Right brake light bulb -M10- 7)
- Left brake and tail light bulb -M21-
- Right brake and tail light bulb -M22-
- High level brake light bulb -M25-
- 6-pin connector -T6bn- 4)

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
17 - Driver door control unit -J386- Input/Output LIN
- Front passenger door control unit -J387-
- Steering column electronics control unit -J527-
- ♦ Airbag coil connector and return spring with slip ring -F138-
-
♦ Multifunction steering wheel control unit -J453-

18 - B390 Connection 1 (drive train CAN bus, low), in main wiring harness Input/Output CAN-low
19 - B383 Connection 1 (drive train CAN bus, high), in main wiring harness Input/Output CAN-high
20 - B397 Connection 1 (convenience CAN bus, high), in main wiring harness Input/Output CAN-high
21 - B406 Connection 1 (convenience CAN bus, low), in main wiring harness Input/Output CAN-low
22 - 16-pin connector -T16/14- (diagnosis connection) Input/Output CAN-low
- Data bus diagnostic interface -J533- (T20f/9) 11)
23 - 16-pin connector -T16/6- (diagnosis connection) Input/Output CAN-high
- Data bus diagnostic interface -J533- (T20f/19) 11)
24 - Rain sensor -G213- Input/Output LIN
- Interior monitor send and receive module 1 -G303 -
- Vehicle inclination sender -G384-
25 - Left sliding door contact strip -F353- 2) Input -
- ♦ Rear left central locking lock unit -F222- 2)

26 - Right sliding door contact strip -F352- 2) Input -

- ♦ Rear right central locking lock unit -F223- 2)

27 - Steering column electronics control unit -J527- Input -

- ♦ Intermittent wiper switch -E22-

28 - Vacant - -
29 - Light switch -E1- (T10bb/9) Input TFL
30 - Interior monitor deactivation switch -E183- Input -
- Button for deactivating interior monitoring and vehicle inclination sensor -E616-
31 - Heated rear window switch -E15- Input -
32 - Windscreen wiper motor -V- Input -
33 - Vacant -
34 - Switches and instruments illumination regulator -E20- Input 58d
- Fuse 35 on fuse holder B -SB35-
- Onboard supply control unit -J519- (T73b/1)
35 - Vacant - -
36 - Alarm horn -H12- 8) - LIN

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
37 - Diagnostic connection -U31- - K
- ♦ 16-pin connector -T16/7-
-
- ♦ Auxiliary heater control unit -J364-
♦ Engine control unit -J623-

38 - Earth (internal supply) Input 31

39 - Fuse 3 on fuse holder B -SB3- (internal supply) Input 30
40 - Vacant - -
41 - Vacant - -
42 - Vacant - -
43 - Rear fog light switch -E18- (T10bb/7) Input RFL
- Front and rear fog light switch -E23- (T10bb/7)
44 - Steering column electronics control unit -J527- Input -
- ♦ Cruise control system (CCS) SET button -E227-

45 - Steering column electronics control unit -J527- Input -

- ♦ Cruise control system switch -E45-
-
♦ Engine control unit -J623-

46 - Steering column electronics control unit -J527- Input -

- ♦ Cruise control system (CCS) SET button -E227-

47 - Steering column electronics control unit -J527- Input -

- ♦ Cruise control system switch -E45-

48 - Reversing light switch -F4- Input RFL

- ♦ Accident data memory -J754-
-
- ♦ Reversing light bulb -M16- , -M17-
- ♦ 10-pin connector -T10bh- 4)
-
♦ Trailer socket -U10-
♦ Automatic anti-dazzle interior mirror -Y7-

49 - Alternator -C- Input 61

- Engine control unit -J623-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
50 - Blocking diode -J29- 12) Input 50
- Starter inhibitor relay -J433-
- Voltage stabiliser -J532- 11)
- Engine control unit -J623-
- Ignition/starter switch -D-
- ♦ X-contact relief relay -J59-
-
- ♦ Fuse 21 on fuse holder B -SB21-
♦ Fuse 23 on fuse holder B -SB23-

51 - Ignition/starter switch -D- Input 75X

- X-contact relief relay -J59-
- ♦ Horn relay -J413-
-
- ♦ Terminal 75 voltage supply relay 1 -J680-
- ♦ Fuse 5 on fuse holder C -SC5- 4)
♦ 12-pin connector -T12y-

52 - Light switch -E1- (T10bb/1) Input FL

- Light switch -E1- (T17/11) Input HWS
53 - Steering column electronics control unit -J527- Input S2
- ♦ Intermittent wiper switch -E22-

54 - Vacant - -
55 - Mechatronic unit for dual clutch gearbox -J743- 1) Input 50
56 - Rear lid lock unit -F256- Input -
57 - Vacant - -
58 - Exterior mirror heater button -E231- Input -
59 - Fuse 34 on fuse holder D -SD34- (reference battery voltage) Input 30
60 - Reference battery voltage Input 31

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
Pin Assignment/Component Input/Output Terminal
61 - Steering column electronics control unit -J527- Input -
- ♦ Rear wiper switch -E34-
-
- ♦ Washer pump switch (automatic wash/wipe and headlight washer system) -E44-
- ♦ Fuse 7 on fuse holder D -SD7-
-
- ♦ Washer pump -V5-
-
♦ Rear window wiper motor -V12-
♦ Windscreen and rear window washer pump -V59-
♦ Rear left wing door window wiper motor -V92-

62 - Steering column electronics control unit -J527- Input INT

- ♦ Intermittent wiper switch -E22-
-
♦ Intermittent wiper regulator -E38-

63 - Heated rear window -Z1- Output -

- Left wing door heated rear window -Z26-
- Right wing door heated rear window -Z27-
64 - Vacant - -
65 - Vacant - -
66 - Vacant - -
67 - Fuse 9 on fuse holder B -SB9- Input 30
- ( Heated rear window -Z1- )
- ( Left wing door heated rear window -Z26- )
- ( Right wing door heated rear window -Z27- )
68 - Fuse 14 on fuse holder C -SC14- (right dipped headlight/main beam) Input 30
69 - Vacant - -
70 - Vacant - -
71 - Vacant - -
72 - Vacant - -
73 - Vacant - -

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1

Note

♦ 1) for models with dual clutch gearbox only

♦ 2) for models with central locking only

♦ 3) see interior light Current Flow Diagram

♦ 4) only models with interface, for external use

♦ 5) for models without central locking only

♦ 6) for models with mechanical sliding door and without anti-theft alarm system only

♦ 7) for models with double cab/ plank bed only

♦ 8) for models with anti-theft alarm system only (DWA) and anti-theft alarm system horn

♦ 9) for models with GDL in headlight only

♦ 10) for models with taxi equipment only

♦ 11) only models with stop/start system

♦ 12) applicable up to November 2009

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.8 Control unit in dash panel insert -J285-

A - Control unit in dash panel insert -J285-

- 32-pin connector -T32- (blue)

Note

The immobilizer control unit -J362- in control unit in dash panel insert -J285- integrated.

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.8.1 32-pin connector -T32-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1 - Fuel gauge sender (full)
2 - Fuel gauge sender (empty)
3 - Vacant
4 - Vacant
5 - Vacant
6 - Vacant
7 - Immobilizer reader coil -D2- (1)
8 - Immobilizer reader coil -D2- (2)
9 - Speedometer, output
10 - Vacant
11 - Oil level and oil temperature sender -G266-
12 - Vacant
13 - Rear fog light warning lamp
14 - Main beam warning lamp
15 - Front left brake pad wear sender -G34- / Rear right brake pad wear sender -G37-
16 - Terminal 31
17 - Windscreen washer fluid level sender -G33-
18 - Coolant shortage indicator sender -G32-
19 - Ambient temperature sensor -G17-
20 - Terminal 31, sensor earth
21 - Multifunction display call-up button -E86- (MFI+)
22 - Multifunction display call-up button -E86- (MFI-)
23 - Multifunction display memory switch -E109- (MFI-R)
24 - Vacant
25 - Handbrake warning switch -F9-
26 - Brake fluid level warning contact -F34-
27 - Oil pressure switch -F1-
28 - Diagnostic interface for combi CAN data bus, high
29 - Diagnostic interface for combi CAN data bus, low
30 - Vacant
31 - Voltage supply, terminal 15
32 - Voltage supply, terminal 30 Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
– Back to overview ⇒ page 1

1.9 Parking aid control unit -J446-

1.9.1 Location:
Behind left dash panel -arrow A-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.9.2 Connector assigment of parking aid control unit -J446-

A - Parking aid control unit -J446-

Pin connector:

B - 12-pin connector -T12s- (black)

C - 12-pin connector -T12r- (brown)
D - 16-pin connector -T16h- (brown)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.10 Driver door control unit -J386- , front passenger door control unit -J387-
1.10.1 Location:
In the front left door -position A-

Note

The illustration shows the right side. The left side is similar.

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.10.2 Connector assigment of driver side door control unit -J386- , front passenger door control unit -J387-

A - Driver door control unit -J386- , front passenger door control unit -J387-
B - 16-pin connector -T16k- (black) / 16-pin connector -T16l- (black)

Note

The illustration shows the right side. The left side is similar.

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
– Back to overview ⇒ page 1

1.11 Airbag control unit -J234-

1.11.1 Location:
Under centre dash panel -arrow-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.11.2 Connector assigment of airbag control unit -J234-

A - Airbag control unit -J234-

Pin connector:

B - 50-pin connector -T50-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.12 Interior monitor send and receive module 1 -G303- with Anti-theft and tilt system control
unit -J529-
1.12.1 Location:
On the roof console -position 2-
Roof console -position 1-
– Back to overview ⇒ page 1

1.13 Interior monitor send and receive module 2 -G305-

1.13.1 Location:
In rear headliner -position 1-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.14 Heated front seats control unit -J774-
1.14.1 Fitting Locations:
behind dash panel, near relay carrier cockpit -arrow A-
– Back to overview ⇒ page 1

1.15 Sliding sunroof adjustment control unit -J245-

1.15.1 Location:
on sliding/tilting sunroof -position 1-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.16 Mobile telephone operating electronics control unit -J412-
1.16.1 Location:
Behind the glove compartment -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.16.2 Connector assigment Mobile telephone operating electronics control unit -J412-

A - Mobile telephone operating electronics control unit -J412-

Pin connector:

B - 54-pin connector -T54-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.17 Left sliding door control unit -J558-
1.17.1 Location:
on left D-pillar -position 1-

Note

Electric sliding door with power latching system

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.17.2 Connector assigment Left sliding door control unit -J558-

A - Left sliding door control unit -J558-

B - 6-pin connector -T6ah- (light-brown)
C - 10-pin connector -T10aw- (black)
D - 12-pin connector -T12k- (black)
E - 6-pin connector -T6ag- (black)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.18 Left sliding door control unit -J558-
1.18.1 Location:
on left D-pillar -position A-

Note

♦ Mechanical sliding door with power latching system

♦ The illustration shows the right side. The left side is similar.

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.18.2 Connector assigment Left sliding door control unit -J558-

A - Left sliding door control unit -J558-

B - 8-pin connector -T8x- (black)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.19 Right sliding door control unit -J731-
1.19.1 Location:
on right D-pillar -position 1-

Note

Electric sliding door with power latching system

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.19.2 Connector assigment Right sliding door control unit -J731-

A - Right sliding door control unit -J731-

B - 6-pin connector -T6ak- (light-brown)
C - 10-pin connector -T10ax- (black)
D - 12-pin connector -T12l- (black)
E - 6-pin connector -T6aj- (black)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.20 Right sliding door control unit -J731-
1.20.1 Location:
on right D-pillar -position A-

Note

mechanical sliding door with power latching system or only power

latching system

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.20.2 Connector assigment Right sliding door control unit -J731-

A - Right sliding door control unit -J731-

B - 8-pin connector -T8y- (black)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.21 Rear lid control unit -J605-
1.21.1 Location:
on left D-pillar -position B-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.21.2 Connector assigment of rear lid control unit -J605-

A - Rear lid control unit -J605-

B - 8-pin connector -T8w- (black)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.22 Right seat box

A - Reversing camera system control unit -J772-

❑ Connector assigment ⇒ page 58
B - Trailer detector control unit -J345-
❑ Connector assigment ⇒ page 59
C - Voice amplification control unit -J656-
❑ Connector assigment ⇒ page 57
D - TV tuner -R78-
❑ Connector assigment ⇒ page 54
D - CD changer -R41-
D - Amplifier -R12-
❑ Connector assigment ⇒ page 55

1.22.1 Location:
Under the seat on front right
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.22.2 Connector assigment TV tuner -R78-

A - TV tuner -R78-
B - 2-pin connector -T2cl-
C - 54-pin connector -T54a-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.22.3 Connector assigment Amplifier -R12-

A - Amplifier -R12-
B - 38-pin connector -T38-

Note

for models without digital sound package control unit only

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
– Back to overview ⇒ page 1

1.22.4 Connector assigment Amplifier -R12-

A - Amplifier -R12-
B - 23-pin connector -T23a-
C - 24-pin connector -T24d-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1

Note

for models with digital sound package control unit only

– Back to overview ⇒ page 1

1.22.5 Connector assigment of voice amplification control unit -J656-

A - Voice amplification control unit -J656-

B - 23-pin connector -T23b- (black)
C - 24-pin connector -T24e- (black)

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
– Back to overview ⇒ page 1

1.22.6 Connector assigment of reversing camera system control unit -J772-

A - Reversing camera system control unit -J772-

B - 54-pin connector -T54b-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.22.7 Connector assigment of trailer detector control unit -J345-

A - Trailer detector control unit -J345-

B - Vacant
C - 12-pin connector -T12ac- (red)
D - 16-pin connector -T16n- (black)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.23 Four-wheel drive control unit -J492-
1.23.1 Location:
On the rear axle final drive, in front left area -position 1-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.23.2 Connector assigment of four-wheel drive control unit -J492-

A - Four-wheel drive control unit -J492-

B - 8-pin connector -T8ad-
C - 2-pin connector -T2aa-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.24 Operating and display unit for camping
equipment -E153-

1.24.1 Location:
On rear right of roof -position A-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.24.2 Connector assigment of operating and display unit for camping equipment -E153-

A - Operating and display unit for camping equipment -E153-

B - 6-pin connector -T6ap-
C - 32-pin connector -T32b-
D - 2-pin connector -T2p-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.25 Climatronic control unit -J255- / Air
conditioning system control unit -J301-

1.25.1 Location:
Centre dash panel-position B-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.25.2 Connector assigment of Climatronic control unit -J255-

A - Climatronic control unit -J255-

B - 20-pin connector -T20e-
C - 16-pin connector -T16o-
D - 16-pin connector -T16p-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.25.3 Connector assigment of air conditioning system control unit -J301-

A - Air conditioning system control unit -J301-

B - 20-pin connector -T20c-
C - 16-pin connector -T16q-
D - 5-pin connector -T5r-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.26 Rear fresh air blower switch -E179- /
Operating and display unit for rear
Climatronic -E265-

1.26.1 Location:
Centre roof -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.26.2 Connector assigment of rear fresh air blower switch -E179-

A - Rear fresh air blower switch -E179-

B - 16-pin connector -T16e-
C - 5-pin connector -T5e-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.26.3 Connector assigment of operating and display unit for rear Climatronic -E265-

A - Operating and display unit for rear Climatronic -E265-

B - 20-pin connector -T20d-

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.27 Tachograph -G24-

1.27.1 Location:
On centre dash panel -arrow A-

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.27.2 Connector assigment of tachograph -G24-

A - Tachograph -G24-
B - 8-pin connector -T8o- (white)
C - 8-pin connector -T8p- (yellow)
D - Vacant
E - 8-pin connector -T8q- (brown)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.28 Headlight range control, control unit
-J431- and data bus diagnostic interface
-J533-

1.28.1 Location:
Headlight range control, control unit -J431- behind dash panel, near relay carrier cockpit -arrow A- 26-pin connector -T26c- ,
black
Data bus diagnostic interface -J533- behind dash panel, near relay carrier cockpit -arrow B- 20-pin connector -T20f- , red 1)

Note

1) only models with stop/start system

– Back to overview ⇒ page 1

1.29 Auxiliary heater control unit -J364-

1.29.1 Location:
behind the right underbody trim -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.30 Lane change assist control unit -J769-

1.30.1 Location:
On left D-pillar -arrow-
– Back to overview ⇒ page 1

1.31 Lane change assist control unit 2 -J770-

1.31.1 Location:
On right D-pillar -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.32 Radio -R- / Control unit with display for radio and navigation system -J503-
1.32.1 Location:
In centre dash panel -arrow A-
– Back to overview ⇒ page 1

1.33 Roof display unit -J702-

1.33.1 Location:
On the roof console -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.34 Heater control unit -J162-
1.34.1 Location:
behind the left underbody trim -arrow-
– Back to overview ⇒ page 1

1.35 Left gas discharge light control unit -J343- and right gas discharge light control unit
-J344-
1.35.1 Location:
on left and right headlight -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 801 / 1
1.36 Control unit for left daytime running light and side light -J860- and control unit for right
daytime running light and side light -J861-
1.36.1 Location:
on left and right headlight -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1 -Fitting Locations: Earth points

1.1 Overview of earth points

12 - Earth point, on left in engine compartment

❑ Location ⇒ page 2
13 - Earth point, on right in engine compartment
❑ Location ⇒ page 3
14 - Earth point, on gearbox
❑ Location ⇒ page 3
15 - Earth point, on cylinder head
❑ Location ⇒ page 3
18 - Earth point on engine block
❑ Location ⇒ page 5
34 - Earth point, under driver seat
❑ Location ⇒ page 5
35 - Earth point, under front passenger seat
❑ Location ⇒ page 5
49 - Earth point, near bulkhead
❑ Location ⇒ page 6
605 - Earth point, on top end of steering column
❑ Location ⇒ page 6
607 - Earth point, on left in plenum chamber
❑ Location ⇒ page 4
610 - Earth point (audio), under centre console, front
❑ Location ⇒ page 6
624 - Earth point, starter battery
❑ Location ⇒ page 4
636 - Earth point, onboard supply control unit
❑ Location ⇒ page 6
637 - Earth point, airbag control unit
❑ Location ⇒ page 6

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
638 - Earth point, right A-pillar
❑ Location ⇒ page 7
639 - Earth point, left A-pillar
❑ Location ⇒ page 7
640 - Earth point 2, on left in engine compartment
❑ Location ⇒ page 4
642 - Earth point, electronically controlled fan
❑ Location ⇒ page 4
653 - Earth point, left D-pillar
❑ Location for short wheel base ⇒ page 8
❑ Location for long wheel base ⇒ page 8
654 - Earth point, right D-pillar
❑ Location for short wheel base ⇒ page 9
❑ Location for long wheel base ⇒ page 9
734 - Earth point in the front left door
❑ Location ⇒ page 7
735 - Earth point in the front right door
❑ Location ⇒ page 8
740 - Earth point 2 in the front left door
❑ Location ⇒ page 7

1.1.1 Location:
12 - Earth point, in engine compartment, left -arrow A-

Note

♦ In electronics box

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.1.2 Location:
13 - Earth point, in engine compartment, right -arrow-

Note

♦ near horn or dual tone horn

– Back to overview ⇒ page 1

1.1.3 Location:
14 - Earth point, on gearbox -arrow-

Note

♦ near starter

– Back to overview ⇒ page 1

1.1.4 Location:
15 - Earth point, on cylinder head -arrow A-

Note

for models with engine code CJKA only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.1.5 Location:
642 - Earth point, electronically controlled fan -arrow A-
640 - Earth point 2, in engine compartment, left -arrow B-

Note

♦ on longitudinal member

– Back to overview ⇒ page 1

1.1.6 Location:
607 - Earth point, on left in plenum chamber -arrow-

Note

♦ near windscreen wiper motor

– Back to overview ⇒ page 1

1.1.7 Location:
624 - Earth point, starter battery -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.1.8 Location:
18 - Earth point on engine block -arrow-
– Back to overview ⇒ page 1

1.1.9 Location:
34 - Earth point, under driver seat -arrow-
– Back to overview ⇒ page 1

1.1.10 Location:
35 - Earth point, under front passenger seat -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.1.11 Location:
49 - Earth point, near bulkhead -arrow D- 1)
610 - Earth point (audio), under centre console, front -arrow B-
636 - Earth point, onboard supply control unit -arrow C-
637 - Earth point, airbag control unit -arrow A-

Note

1) no longer fitted, phased

– Back to overview ⇒ page 1

1.1.12 Location:
605 - Earth point, on top end of steering column -arrow-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.1.13 Location:
638 - Earth point, right A-pillar -arrow-
– Back to overview ⇒ page 1

1.1.14 Location:
639 - Earth point, left A-pillar -arrow-
– Back to overview ⇒ page 1

1.1.15 Location:
734 - Earth point in the front left door -arrow A-
740 - Earth point 2 in the front left door -arrow B-
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.1.16 Location:
735 - Earth point in the front right door -arrow A-
– Back to overview ⇒ page 1

1.1.17 Location:
653 - Earth point, left D-pillar -arrow-

Note

♦ for models with short wheel base only

– Back to overview ⇒ page 1

1.1.18 Location:
653 - Earth point, left D-pillar -arrow-

Note

♦ for models with long wheel base only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.1.19 Location:
654 - Earth point, on right D-pillar -arrow-

Note

♦ for models with short wheel base only

– Back to overview ⇒ page 1

1.1.20 Location:
654 - Earth point, on right D-pillar -arrow-

Note

♦ for models with long wheel base only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.2 Earth points platform/double cab

68 - Earth point, on left of rear cross member

❑ Location ⇒ page 11

Edition 04.2011
 Transporter Fitting Locations No. 802 / 1
1.2.1 Location:
68 - Earth point, on left of rear cross member -arrow A-
– Back to overview ⇒ page 10

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1 -Fitting Locations: Fuses

1.1 Overview of fuse carrier

1 - Fuse holder A -SA- , in left engine compartment

❑ Location: ⇒ page 2
❑ Fuse location for fuse -SA- : ⇒ page 2
2 - Fuse holder B -SB- , in centre dash panel
❑ Location: ⇒ page 10
❑ Fuse location for fuse -SB- : ⇒ page 10
- Fuse holder C -SC- , in centre dash panel
❑ Location: ⇒ page 13
❑ Fuse location for fuse -SC- : ⇒ page 14
3 - Fuse holder F -SF- , under left seat box
❑ Location: ⇒ page 17
❑ Fuse location for fuse -SF1- up to -SF39- on fuse holder F -SF- : ⇒ page 17
❑ Fuse location for fuse -S131- up to -S133- on fuse holder F -SF- : ⇒ page 19
- Coupling station on left of seat box (10-pin)
❑ Location: ⇒ page 20
❑ Fuse location for fuse -SF50- : ⇒ page 21
- Fuse holder for special vehicles, under left seat box
❑ Location: ⇒ page 24
❑ Fuse location for fuse -S291- up to -S305- (UF4/UF5): ⇒ page 25
❑ Fuse location for fuse -S306- up to -S318- (UF7): ⇒ page 26
4 - Relay carrier cockpit (8-pin), in centre dash panel
❑ Location: ⇒ page 21
❑ Fuse location for fuse -SF51- up to -SF55- on relay carrier (1) cockpit (8-pin): ⇒ page 21
❑ Fuse location for fuse -SF56- on relay carrier (2) cockpit (8-pin): ⇒ page 22
5 - Fuse holder D -SD- , in left engine compartment
❑ Location: ⇒ page 3
❑ Fuse location for fuse -SD- from August 2009: ⇒ page 4
❑ Fuse location for fuse -SD- from May 2011: ⇒ page 6

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
- Relay carrier electronics box, in left engine compartment
❑ Location, from August 2009: ⇒ page 23
❑ Position of fuses on relay carrier electronics box, from August 2009: ⇒ page 23
❑ Position of fuses on relay carrier electronics box, from June 2010: ⇒ page 23
❑ Location, from November 2010: ⇒ page 24
❑ Position of fuses on relay carrier electronics box, from November 2010: ⇒ page 24

1.2 Fuse holder A -SA-

1.2.1 Location:
♦ In electronics box, in left engine compartment
– Back to overview ⇒ page 1

1.2.2 Fuse location for fuse -SA- :

No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1 - Fuse 1 on fuse holder A -SA1- 175 A - Alternator -C- 30
or
225 A
2 - Fuse 2 on fuse holder A -SA2- 125 A - X-contact relief relay -J59- 30
- B298 Positive connection 2 (30), in main wiring harness
- B301 Positive connection 5 (30), in main wiring harness
- B302 Positive connection 6 (30), in main wiring harness
- B303 Positive connection 7 (30), in main wiring harness
- B304 Positive connection 8 (30), in main wiring harness
- B305 Positive connection 9 (30), in main wiring harness
- Fuse 9 on fuse holder B -SB9-
- Fuse 14 on fuse holder B -SB14-
3 - Fuse 3 on fuse holder A -SA3- 50 A - Battery isolation relay -J7- 30
100 A - Second battery charging circuit relay -J713-
- B310 Positive connection 14 (30), in main wiring harness
- B311 Positive connection 15 (30), in main wiring harness

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
4 - Fuse 4 on fuse holder A -SA4- 70 A - D50 Positive connection (30), in engine compartment wiring harness 30
5 - Fuse 5 on fuse holder A -SA5- 50 A - ABS control unit fuse 1 -S123- 30
- Fuse 6 on fuse holder D -SD6-
6 - Fuse 6 on fuse holder A -SA6- 60 A - Automatic glow period control unit -J179- 30
50 A - Secondary air pump relay -J299-
7 - Fuse 7 on fuse holder A -SA7- 100 A - Radiator fan control unit -J293- 30
8 - Fuse 8 on fuse holder A -SA8- 40 A - B169 Positive connection 1 (30), in interior wiring harness 30
50 A - B170 Positive connection 2 (30), in interior wiring harness
100 A - Fuse 9 on fuse holder F -SF9-
- Fuse 14 on fuse holder F -SF14-
- Fuse 22 on fuse holder F -SF22-
- Fuse 23 on fuse holder F -SF23-
- Fuse 24 on fuse holder F -SF24-
9 - Fuse 9 on fuse holder A -SA9- 100 A - B272 Positive connection (30), in main wiring harness 30
- B299 Positive connection 3 (30), in main wiring harness

– Back to overview ⇒ page 1

1.3 Fuse holder D -SD-

1.3.1 Location:
♦ In electronics box in engine compartment
Fuse colours
40 A - blue
30 A - green
25 A - white
20 A - yellow
15 A - blue
10 A - red
7.5 A - brown
5 A - beige
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1.3.2 Fuse locations on fuse holder D -SD- from August 2009
No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1 - Fuse 1 on fuse holder D -SD1- 5A - Radiator fan control unit -J293- 87
2 - Fuse 2 on fuse holder D -SD2- 5A - Additional coolant pump relay -J496- 30
- ♦ Residual heat relay -J708-
-
♦ Circulation pump -V55-

3 - Fuse 3 on fuse holder D -SD3- 5A - Heater element for crankcase breather -N79- 15
4 - Fuse 4 on fuse holder D -SD4- - Vacant
5 - Fuse 5 on fuse holder D -SD5- 15 A - Mechatronic unit for dual clutch gearbox -J743- 30
- Selector lever lock solenoid -N110-
- Selector lever -E313-
6 - Fuse 6 on fuse holder D -SD6- 30 A - ABS control unit -J104- 30
7 - Fuse 7 on fuse holder D -SD7- - - Vacant 5) -
7,5 A - Washer pump -V5- 6) 53c
- Windscreen and rear window washer pump -V59- 6)
8 - Fuse 8 on fuse holder D -SD8- - Vacant
9 - Fuse 9 on fuse holder D -SD9- 5A - Engine control unit -J623- 30
10 - Fuse 10 on fuse holder D -SD10- 5A - Secondary air pump relay -J299- 2) 87
- Activated charcoal filter system solenoid valve 1 -N80- 2)
15 A - Charge pressure control solenoid valve -N75- 1) , 3)
- Exhaust flap valve -N220- 3)
- Exhaust gas recirculation cooler change-over valve -N345- 1) , 3)

11 - Fuse 11 on fuse holder D -SD11- 30 A - Headlight dipper/flasher switch -E4- 30

- Headlight main beam relay -J12-
12 - Fuse 12 on fuse holder D -SD12- 10 A - Fuel pressure regulating valve -N276- 1) , 3) 87
- Fuel metering valve -N290- 1) , 3)
13 - Fuse 13 on fuse holder D -SD13- 10 A - Left gas discharge light control unit -J343- 15
14 - Fuse 14 on fuse holder D -SD14- 5A - Fuel pump relay -J17- 1) , 2) , 3) 15 2)
- Electric fuel pump 2 relay -J49- 1) , 3) 87 1) , 3)
15 - Fuse 15 on fuse holder D -SD15- 10 A - Reversing light switch -F4- 15
16 - Fuse 16 on fuse holder D -SD16- 5A - Brake light switch -F- 15
- Air mass meter -G70- 2)
17 - Fuse 17 on fuse holder D -SD17- 5A - TCS and ESP button -E256- 15
- Tyre pressure monitor display button -E492-
- ABS control unit -J104-

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
18 - Fuse 18 on fuse holder D -SD18- 5A - Power steering control unit -J500- 15
19 - Fuse 19 on fuse holder D -SD19- 5A - Clutch pedal switch -F36- 15 2)
- Clutch position sender -G476- 87 1) , 3)
- Air mass meter -G70- 1) , 3)
20 - Fuse 20 on fuse holder D -SD20- 5A - Engine control unit -J623- 15
21 - Fuse 21 on fuse holder D -SD21- 5A - Exhaust gas recirculation valve -N18- 2) 87
22 - Fuse 22 on fuse holder D -SD22- 10 A - Injector, cylinder 1 -N30- 2) 87
- Injector, cylinder 2 -N31- 2)
- Injector, cylinder 3 -N32- 2)
-
Injector, cylinder 4 -N33- 2)
23 - Fuse 23 on fuse holder D -SD23- 10 A - Right gas discharge light control unit -J344- 15
24 - Fuse 24 on fuse holder D -SD24- 5A - Mechatronic unit for dual clutch gearbox -J743- 15
- Selector lever -E313-
25 - Fuse 25 on fuse holder D -SD25- 30 A - Engine control unit -J623- 2) 87
- Ignition transformer -N152- 2)
26 - Fuse 26 on fuse holder D -SD26- 5A - Front left headlight -MX1- 30
27 - Fuse 27 on fuse holder D -SD27- 10 A - Continued coolant circulation pump -V51- 1) , 3) 87
28 - Fuse 28 on fuse holder D -SD28- 15 A - Treble tone horn -H2- 4) 30
29 - Fuse 29 on fuse holder D -SD29- 5A - Front right headlight -MX2- 30
30 - Fuse 30 on fuse holder D -SD30- 20 A - Fuel pump relay -J17- 1) , 3) 30
- ♦ Fuel system pressurisation pump -G6- 1) , 3)
-
- Electric fuel pump 2 relay -J49- 1) , 3)
♦ Supplementary fuel pump -V393- 1) , 3)

- Fuel system pressurisation pump -G6- 2) 87

31 - Fuse 31 on fuse holder D -SD31- 15 A - Lambda probe heater -Z19- 87
- Lambda probe 1 heater after catalytic converter -Z29- 2)
32 - Fuse 32 on fuse holder D -SD32- 5A - Electric fuel pump 2 relay -J49- 2) 30
30 A - Engine control unit -J623- 1) , 3) 87
33 - Fuse 33 on fuse holder D -SD33- 5A - Automatic glow period control unit -J179- 1) , 3) 87
- Additional coolant pump relay -J496-
34 - Fuse 34 on fuse holder D -SD34- 5A - Onboard supply control unit -J519- (T73b/59) 30
35 - Fuse 35 on fuse holder D -SD35- - Vacant
36 - Fuse 36 on fuse holder D -SD36- 30 A - Starter -B- 30
- Starter inhibitor relay -J207-

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1

Note

♦ 1) for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB only

♦ 2) for engine code AXA only

♦ 3) for engine code CFCA only

♦ 4) for models with taxi equipment only

♦ 5) applicable up to May 2010

♦ 6) applicable from June 2010

– Back to overview ⇒ page 1

1.3.3 Fuse locations on fuse holder D -SD- from May 2011

No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1 - Fuse 1 on fuse holder D -SD1- 5A - Radiator fan control unit -J293- 87
2 - Fuse 2 on fuse holder D -SD2- 5A - Additional coolant pump relay -J496- 30
- ♦ Residual heat relay -J708-
-
♦ Circulation pump -V55-

3 - Fuse 3 on fuse holder D -SD3- 5A - Heater element for crankcase breather -N79- 15
4 - Fuse 4 on fuse holder D -SD4- 30 A - Voltage stabiliser -J532-7) 30
- ♦ Control unit with display for radio and navigation system -J503- 7)
-
- ♦ Radio -R- 7)
-
- ♦ Fuse 18 on fuse holder B -SB18- 7)
♦ Fuse 15 on fuse holder C -SC15- 7)
♦ Fuse 16 on fuse holder C -SC16- 7)

5 - Fuse 5 on fuse holder D -SD5- 15 A - Mechatronic unit for dual clutch gearbox -J743- 30
- Selector lever lock solenoid -N110-
- Selector lever -E313-
6 - Fuse 6 on fuse holder D -SD6- 30 A - ABS control unit -J104- 30

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
7 - Fuse 7 on fuse holder D -SD7- 7,5 A - Washer pump -V5- 53c
- Windscreen and rear window washer pump -V59-
8 - Fuse 8 on fuse holder D -SD8- - Vacant
9 - Fuse 9 on fuse holder D -SD9- 5A - Engine control unit -J623- 30
10 - Fuse 10 on fuse holder D -SD10- 5A - Secondary air pump relay -J299- 2) 87
- Activated charcoal filter system solenoid valve 1 -N80- 2)
15 A - Charge pressure control solenoid valve -N75- 1) , 3)
- Exhaust flap valve -N220- 3)
- Exhaust gas recirculation cooler change-over valve -N345- 1) , 3)

10 A - Charge pressure control solenoid valve -N75- 5)

- Activated charcoal filter system solenoid valve 1 -N80- 5)
- Inlet camshaft control valve 1 -N205- 5)
-
- Turbocharger air recirculation valve -N249- 5)
Intake manifold flap valve -N316- 5)

11 - Fuse 11 on fuse holder D -SD11- 30 A - Headlight dipper/flasher switch -E4- 30

- Headlight main beam relay -J12-
12 - Fuse 12 on fuse holder D -SD12- 10 A - Fuel pressure regulating valve -N276- 1) , 3) 87
- Fuel metering valve -N290- 1) , 3)
13 - Fuse 13 on fuse holder D -SD13- - Vacant
14 - Fuse 14 on fuse holder D -SD14- 5A - Fuel pump relay -J17- 1) , 2) , 3) 15 2)
- Electric fuel pump 2 relay -J49- 1) , 3) 87 1) , 3)
15 - Fuse 15 on fuse holder D -SD15- 10 A - Reversing light switch -F4- 15
16 - Fuse 16 on fuse holder D -SD16- 5A - Brake light switch -F- 87
- Air mass meter -G70- 2)
17 - Fuse 17 on fuse holder D -SD17- 5A - TCS and ESP button -E256- 15
- Tyre pressure monitor display button -E492-
- ABS control unit -J104-
18 - Fuse 18 on fuse holder D -SD18- 5A - Power steering control unit -J500- 15
19 - Fuse 19 on fuse holder D -SD19- 5A - Clutch pedal switch -F36- 87
- Clutch position sender -G476-
- Air mass meter -G70- 1) , 3)
20 - Fuse 20 on fuse holder D -SD20- 5A - Engine control unit -J623- 15
- Air mass meter -G70- 5)
21 - Fuse 21 on fuse holder D -SD21- 5A - Exhaust gas recirculation valve -N18- 2) 87
22 - Fuse 22 on fuse holder D -SD22- 10 A - Injector, cylinder 1 -N30- 2) 87
- Injector, cylinder 2 -N31- 2)
- Injector, cylinder 3 -N32- 2)
- 2)
Injector, cylinder 4 -N33-

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
23 - Fuse 23 on fuse holder D -SD23- - Vacant
24 - Fuse 24 on fuse holder D -SD24- 5A - Mechatronic unit for dual clutch gearbox -J743- 15
- Selector lever -E313-
25 - Fuse 25 on fuse holder D -SD25- 30 A - Engine control unit -J623- 2) 87
- Ignition transformer -N152- 2)
20 A - Actuator 1 for camshaft adjustment -F366- 5) up to 87
- Actuator 8 for camshaft adjustment -F373- 5)
26 - Fuse 26 on fuse holder D -SD26- - Vacant
27 - Fuse 27 on fuse holder D -SD27- 10 A - Continued coolant circulation pump -V51- 1) , 3) 87
28 - Fuse 28 on fuse holder D -SD28- 15 A - Treble tone horn -H2- 4) 30
29 - Fuse 29 on fuse holder D -SD29- - Vacant
30 - Fuse 30 on fuse holder D -SD30- 20 A - Fuel pump relay -J17- 1) , 3) 30
- ♦ Fuel system pressurisation pump -G6- 1) , 3)
-
- Electric fuel pump 2 relay -J49- 1) , 3)
♦ Supplementary fuel pump -V393- 1) , 3)

- Fuel system pressurisation pump -G6- 2) 87

- Fuel pump control unit -J538- 5)
- ♦ Fuel system pressurisation pump -G6- 5)

31 - Fuse 31 on fuse holder D -SD31- 15 A - Lambda probe heater -Z19- 87

- Lambda probe 1 heater after catalytic converter -Z29- 2) , 5)
32 - Fuse 32 on fuse holder D -SD32- 5A - Electric fuel pump 2 relay -J49- 2) 30
30 A - Engine control unit -J623- 1) , 3) 87
30 A - Engine control unit -J623- 5) 30
- Ignition coil 1 with output stage -N70- 5)
- Ignition coil 2 with output stage -N127- 5)
- 5)
- Ignition coil 3 with output stage -N291- 5)
Ignition coil 4 with output stage -N292-
33 - Fuse 33 on fuse holder D -SD33- 5A - Automatic glow period control unit -J179- 1) , 3) 87
- Fuel shut-off valve switch-off relay -J335- 5)
- Additional coolant pump relay -J496-
- Coolant pump relay -J235- 5)
- ♦
Continued coolant circulation pump -V51- 5)

34 - Fuse 34 on fuse holder D -SD34- 5A - Onboard supply control unit -J519- (T73b/59) 30

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
35 - Fuse 35 on fuse holder D -SD35- 15 A - Fuel shut-off valve switch-off relay -J335- 5) 87
- ♦ Fuel pressure regulating valve -N276- 5)

5A - Battery monitor control unit -J367- 7) 30

36 - Fuse 36 on fuse holder D -SD36- 30 A - Starter -B- 6) 30
- Starter inhibitor relay -J207- 6)
5A - Data bus diagnostic interface -J533- 7) 30

Note

♦ 1) for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB only

♦ 2) for engine code AXA only

♦ 3) for engine code CFCA only

♦ 4) for models with taxi equipment only

♦ 5) for engine code CJKA only

♦ 6) only models without stop/start system

♦ 7) only models with stop/start system

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1.4 Fuse holder B -SB-

1.4.1 Location:
♦ In the upper fuse box on centre of dash panel
Fuse colours
40 A - blue
30 A - green
25 A - white
20 A - yellow
15 A - blue
10 A - red
7.5 A - brown
5 A - beige
– Back to overview ⇒ page 1

1.4.2 Fuse location for fuse -SB- :

No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1 - Fuse 1 on fuse holder B -SB1- 30 A - Terminal 15 voltage supply relay -J329- 30
2 - Fuse 2 on fuse holder B -SB2- 5 A - Steering angle sender -G85- 30

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
3 - Fuse 3 on fuse holder B -SB3- 10 A - Onboard supply control unit -J519- (T73b/39) 30
4 - Fuse 4 on fuse holder B -SB4- 5A - Lane change assist control unit 2 -J770- 15
- Lane change assist control unit -J769-
5 - Fuse 5 on fuse holder B -SB5- 15 A - Front left headlight -MX1- 56b
6 - Fuse 6 on fuse holder B -SB6- 15 A - Front left headlight -MX1- 56a
7 - Fuse 7 on fuse holder B -SB7- 15 A - Onboard supply control unit -J519- (T73a/66)1) 30
8 - Fuse 8 on fuse holder B -SB8- 15 A - Rear lid control unit -J605- 30
20 A - Alarm horn -H12- 30
- Onboard supply control unit -J519- (T73a/16)
- Left sliding door control unit -J558-
- Rear lid control unit -J605-
- Right sliding door control unit -J731-
9 - Fuse 9 on fuse holder B -SB9- 30A - Onboard supply control unit -J519- (T73b/67) 30
10 - Fuse 10 on fuse holder B -SB10- 10 A - Intermittent wiper switch -E22- 15
- Rear wiper switch -E34-
- Intermittent wiper regulator -E38-
- Washer pump switch (automatic wash/wipe and headlight washer system)
-E44-
11 - Fuse 11 on fuse holder B -SB11- 5A - Number plate light -X- 58
12 - Fuse 12 on fuse holder B -SB12- 5A - Light switch -E1- (T10bb/8) 30
30 A - Light switch -E1- (T17/15)
13 - Fuse 13 on fuse holder B -SB13- 10 A - Airbag control unit -J234- 15
- Front passenger side airbag deactivated warning lamp -K145-
14 - Fuse 14 on fuse holder B -SB14- 25 A - Headlight dipper/flasher switch -E4- 30
15 - Fuse 15 on fuse holder B -SB15- 7,5 A - Fresh air blower switch -E9- 75X
- Rear fresh air blower switch -E179-
- Fresh air blower isolation relay -J487-
16 - Fuse 16 on fuse holder B -SB16- 5A - Onboard supply control unit -J519- (T73a/44) 15
17 - Fuse 17 on fuse holder B -SB17- 5A - Rear fog light cut-out contact switch -F216- RFL
- Control unit in dash panel insert -J285- (T32/16)
- Rear left fog light bulb -L46-
18 - Fuse 18 on fuse holder B -SB18- 5A - Control unit in dash panel insert -J285- 30
19 - Fuse 19 on fuse holder B -SB19- 5A - Operating and display unit for camping equipment -E153- 86s
- Onboard supply control unit -J519-
- 10-pin connector -T10bh/6- 2)
20 - Fuse 20 on fuse holder B -SB20- 5A - Diagnostic connection -U31- (T16/16) 30
- Differential lock control unit -J187- 4)

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
21 - Fuse 21 on fuse holder B -SB21- 5A - Starter motor relay -J53- 50
- Engine control unit -J623-
- 10-pin connector -T10bj- (T10bj/4) 2)
- 10-pin connector -T10bj- (T10bj/8) 2)
22 - Fuse 22 on fuse holder B -SB22- 7,5 A - Light switch -E1- (T10bb/4) 15
- Control unit in dash panel insert -J285- (T32/31)
- Trailer detector control unit -J345-
- Diagnostic connection -U31- (T16/1)
23 - Fuse 23 on fuse holder B -SB23- 5A - Starter inhibitor relay -J207- 2) 50
- Onboard supply control unit -J519- (T73a/55) 2)
- Engine control unit -J623- 2)
-
- 10-pin connector -T10bj- (T10bj/4) 2)
10-pin connector -T10bj- (T10bj/8) 2)
30 A - Starter -B- 50
- Starter inhibitor relay -J207-
- Engine control unit -J623-
30 A - Starter inhibitor relay -J433- 15
- Starter inhibitor relay, clutch pedal switch -J434-
24 - Fuse 24 on fuse holder B -SB24- 5A - Steering angle sender -G85- 15
25 - Fuse 25 on fuse holder B -SB25- 7,5 A - Fresh air blower switch -E9- 30
- Front blower Bitron regulation sender -G462-
- Climatronic control unit -J255-
- Air conditioning system control unit -J301-
26 - Fuse 26 on fuse holder B -SB26- 30 A - Light switch -E1- 75X
27 - Fuse 27 on fuse holder B -SB27- 15 A - Front right headlight -MX2- 56b
28 - Fuse 28 on fuse holder B -SB28- 15 A - Front right headlight -MX2- 56a
- Control unit in dash panel insert -J285- (T32/14)
29 - Fuse 29 on fuse holder B -SB29- 10 A - Dual signal inverter relay -J741- 3) 30
30 - Fuse 30 on fuse holder B -SB30- 10 A - Left washer jet heater element -Z20- 75X
- Right washer jet heater element -Z21-
- Rear window wiper motor -V12-
- Rear right wing door window wiper motor -V93-
- Rear left wing door window wiper motor -V92-
31 - Fuse 31 on fuse holder B -SB31- 30 A - Onboard supply control unit -J519- (T73b/73) 30
32 - Fuse 32 on fuse holder B -SB32- 30 A - Onboard supply control unit -J519- (T73a/68) 30
33 - Fuse 33 on fuse holder B -SB33- 30 A - Radio -R- 30
- Control unit with display for radio and navigation system -J503-
34 - Fuse 34 on fuse holder B -SB34- 25 A - Fuse 14 on fuse holder D -SD14- 15
- Fuse 17 on fuse holder D -SD17-
- Fuse 20 on fuse holder D -SD20-
- Fuse 24 on fuse holder D -SD24-

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
35 - Fuse 35 on fuse holder B -SB35- 5A - B270Connection (58s), in roof wiring harness 58
- B340 Connection 1 (58d), in main wiring harness or
- B341 Connection 2 (58d), in main wiring harness 58d
- B342 Connection 3 (58d), in main wiring harness
- R51Connection (58b), in driver side door wiring harness
36 - Fuse 36 on fuse holder B -SB36- 25 A - Onboard supply control unit -J519- (T73a/13) 30

Note

♦ 1) see interior light Current Flow Diagram

♦ 2) only models with electric interface, for external use

♦ 3) applicable up to October 2009

♦ 4) applicable from May 2011

– Back to overview ⇒ page 1

1.5 Fuse holder C -SC-

1.5.1 Location:
♦ In the lower fuse box on centre of dash panel

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
Fuse colours
40 A - blue
30 A - green
25 A - white
20 A - yellow
15 A - blue
10 A - red
7.5 A - brown
5 A - beige
– Back to overview ⇒ page 1

1.5.2 Fuse location for fuse -SC- :

No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1 - Fuse 1 on fuse holder C -SC1- 15 A - 10-pin connector -T10bh/1- 2) 75X
2 - Fuse 2 on fuse holder C -SC2- 5 A - Interior monitor send and receive module 1 -G303- 30
- Interior monitor send and receive module 2 -G305-
3 - Fuse 3 on fuse holder C -SC3- 10 A - Red Cross light switch -E10- 30
- Red Cross light warning lamp -K100-
15 A - Taxi meter -G41- 15
- Taxi alarm remote control, control unit -J601-
4 - Fuse 4 on fuse holder C -SC4- 10 A - Rear differential lock switch -E121- 15
- Rear differential lock vacuum switch -F363-
- Differential lock control unit -J187-
- Four-wheel drive control unit -J492-
5 - Fuse 5 on fuse holder C -SC5- 10A - 6-pin connector -T6bn/5- 75X
6 - Fuse 6 on fuse holder C -SC6- 5 A - Oil level and oil temperature sender -G266- 15
7 - Fuse 7 on fuse holder C -SC7- 10 A - Rotating light switch -E162- 30
30 A - Alarm system control unit -J85-
8 - Fuse 8 on fuse holder C -SC8- 5 A - Parking aid control unit -J446- 15
9 - Fuse 9 on fuse holder C -SC9- 5 A - Cruise control system switch -E45- 15
10 - Fuse 10 on fuse holder C -SC10- 10 A - Switches and instruments illumination regulator -E20- 15
- Headlight range control, control unit -J431-
- Left headlight range control motor -V48-
- Right headlight range control motor -V49-

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
11 - Fuse 11 on fuse holder C -SC11- 15 A - Taxi meter -G41- 30
- Taxi alarm system 2 control unit -J430-
- Alarm system relay 1 -J460-
- Taxi alarm remote control, control unit -J601-
- Two-way radio -R8-
12 - Fuse 12 on fuse holder C -SC12- 5A - Front left headlight -MX1- TFL
30 A - Onboard supply control unit -J519- (T73a/63) 30
13 - Fuse 13 on fuse holder C -SC13- 5A - Drive train CAN bus isolation relay -J788- 30
14 - Fuse 14 on fuse holder C -SC14- 5A - Front right headlight -MX2- TFL
30A - Onboard supply control unit -J519- (T73b/68) 30
15 - Fuse 15 on fuse holder C -SC15- 5A - Mobile telephone operating electronics control unit -J412- 30
- Voice amplification control unit -J656- 4)
16 - Fuse 16 on fuse holder C -SC16- 7,5 A - Interface for external multimedia unit -R215- 30
- TV tuner -R78-
17 - Fuse 17 on fuse holder C -SC17- 7,5 A - Onboard supply control unit -J519- (T73/66) 1) 30 1)
- Interior light and luggage compartment light 1) 30g 1)
- Interior monitor deactivation switch -E183- 1)
-
Automatic anti-dazzle interior mirror -Y7- 1)
18 - Fuse 18 on fuse holder C -SC18- 5A - Rear fresh air blower switch -E179- 75X
5A - Operating and display unit for rear Climatronic -E265- 30
- Rear blower regulation sender -G463-
19 - Fuse 19 on fuse holder C -SC19- 5A - Automatic anti-dazzle interior mirror -Y7- 15
20 - Fuse 20 on fuse holder C -SC20- 10 A - Onboard supply control unit -J519- (T73a/64) 30
21 - Fuse 21 on fuse holder C -SC21- 5A - Rain sensor -G213- 30
22 - Fuse 22 on fuse holder C -SC22- 10 A - High pressure sender -G65- 15
- Air quality sensor -G238-
- Air conditioning system relay -J32-
- Coolant shut-off valve relay -J541-
23 - Fuse 23 on fuse holder C -SC23- 7,5 A - Operating and display unit for camping equipment -E153- 30
or - Roof display unit -J702-
10 A - Residual heat relay -J708-
- Remote control receiver for auxiliary heating -R64-
- Remote control receiver for auxiliary coolant heater -R149-
24 - Fuse 24 on fuse holder C -SC24- 7,5 A - Interior light and luggage compartment light 1) 30G 1)
25 - Fuse 25 on fuse holder C -SC25- 25 A - Heated front seats control unit -J774- 75X
26 - Fuse 26 on fuse holder C -SC26- 10 A - Tachograph -G24- 30
27 - Fuse 27 on fuse holder C -SC27- 30 A - Terminal 15 voltage supply relay 2 -J681- 30
28 - Fuse 28 on fuse holder C -SC28- 5A - Mirror adjustment switch -E43- 15
- Mirror adjustment change-over switch -E48-

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
29 - Fuse 29 on fuse holder C -SC29- 20 A - Heater control unit -J162- 30
30 - Fuse 30 on fuse holder C -SC30- 5A - Operating and display unit for camping equipment -E153- 15
5A - Auxiliary coolant heater relay -J493- 75X
31 - Fuse 31 on fuse holder C -SC31- 5A - Onboard supply charger unit -A11- 30
25 A - Sliding sunroof adjustment control unit -J245- 30
32 - Fuse 32 on fuse holder C -SC32- 20 A - Headlight washer system relay -J39- 30
33 - Fuse 33 on fuse holder C -SC33- 5A - Tachograph -G24- 15
34 - Fuse 34 on fuse holder C -SC34- 5A - Airbag coil connector and return spring with slip ring -F138- 30
- Multifunction steering wheel control unit -J453-
35 - Fuse 35 on fuse holder C -SC35- 20 A - Onboard supply control unit -J519- (T73b/11) 30
36 - Fuse 36 on fuse holder C -SC36- 5A - Operating and display unit for camping equipment -E153- 15
- 10-pin connector -T10bh/9- 2)
- 10-pin connector -T10bj/10- 3)

Note

♦ 1) see interior light Current Flow Diagram

♦ 2) only models with electric interface, for external use

♦ 3) for optimal equipment police (UF4/UF5) only

♦ 4) applicable from June 2010

– Back to overview ⇒ page 1

1.6 Fuse holder F -SF- ( -SF1- up to

-SF39- and -S131- up to -S133- )

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1.6.1 Location:
♦ On left in seat box
Fuse colours
40 A - blue
30 A - green
25 A - white
20 A - yellow
15 A - blue
10 A - red
7.5 A - brown
5 A - beige
– Back to overview ⇒ page 1

1.6.2 Fuse location for fuse -SF1- up to -SF39- on fuse holder F -SF- :
No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1 - Fuse 1 on fuse holder F -SF1- 5 A - 10-pin connector -T10bh/5- 1) 56b
- 6-pin connector -T6bn/2- 5)
2 - Fuse 2 on fuse holder F -SF2- 3 A - 10-pin connector -T10bh/7- 1) 58/58d
- 10-pin connector -T10bj/9- 5)
3 - Fuse 3 on fuse holder F -SF3- 15 A - 10-pin connector -T10bh/8- 1) 56a
- 10-pin connector -T10bj/5- 5)
- Accident data memory -J754- 5)
5 A - Accident data memory -J754- 6) 56a
4 - Fuse 4 on fuse holder F -SF4- 15 A - 10-pin connector -T10bj/1- 1) , 5) 56a
5 - Fuse 5 on fuse holder F -SF5- 5A - 10-pin connector -T10bh/2- 1) FL
- 10-pin connector -T10bj/3- 5)
6 - Fuse 6 on fuse holder F -SF6- 25 A - 6-pin connector -T6bn/3- 1) , 5) 15
7 - Fuse 7 on fuse holder F -SF7- 15 A - 12 V socket -U5- 30
30 A - Transformer with socket, 12 V - 230 V -U13- 7) or 30
- Transformer with socket, 12 V - 115 V -U27- 7)
8 - Fuse 8 on fuse holder F -SF8- 20 A - Heater control unit -J162- 30
25 A - Auxiliary heater control unit -J364- 30

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
9 - Fuse 9 on fuse holder F -SF9- 25 A - Rear fresh air blower switch -E179- 30
- Fresh air blower isolation relay -J487-
30 A - Rear fresh air blower switch -E179- 30
- Fresh air blower isolation relay -J487-
- Rear fresh air blower -V80-
10 - Fuse 10 on fuse holder F -SF10- 15 A 3) - Fresh air blower switch -E9- 30
30 A 4) - Auxiliary heater relay -J8-
- Air conditioning system control unit -J301-
- Fresh air blower series resistor with overheating fuse -N24-
11 - Fuse 11 on fuse holder F -SF11- 15 A - Cigarette lighter -U1- 30
12 - Fuse 12 on fuse holder F -SF12- 5A - 10-pin connector -T10bh/4- 1) 56b
- 6-pin connector -T6bn/1- 5)
- Accident data memory -J754- 5) , 6)
13 - Fuse 13 on fuse holder F -SF13- - - See -Fitting Locations: Relay -
14 - Fuse 14 on fuse holder F -SF14- - - See -Fitting Locations: Relay -
15 - Fuse 15 on fuse holder F -SF15- - - See -Fitting Locations: Relay -
16 - Fuse 16 on fuse holder F -SF16- 30 A - Onboard supply charger unit -A11- 7) 30
17 - Fuse 17 on fuse holder F -SF17- 30 A - Roof hydraulics control unit -J768- 7) 30
18 - Fuse 18 on fuse holder F -SF18- 10 A - Map reading light bulb -L34- 7) 30
- Rear right reading light -W12- 7)
- Right interior light -W17- 7)
-
- Luggage compartment light on left -W18- 7)
Kitchenette light 1 -W57- 7)
-
- Kitchenette light 2 -W58- 7)
Kitchenette light 3 -W59- 7)
19 - Fuse 19 on fuse holder F -SF19- 10 A - Refrigerator box -J698- 7) 30
20 - Fuse 20 on fuse holder F -SF20- 5A - Water pump switch -E80- 7) 30
- Water pump -V36- 7)
21 - Fuse 21 on fuse holder F -SF21- 5A - Operating and display unit for camping equipment -E153- 7) 30
22 - Fuse 22 on fuse holder F -SF22- 15 A - 12 V socket 2 -U18- 30
23 - Fuse 23 on fuse holder F -SF23- 15 A - 12 V socket 3 -U19- 30
24 - Fuse 24 on fuse holder F -SF24- 10 A - Switch-over relay 1 for roof ventilator -J180- 30
- Switch-over relay 2 for roof ventilator -J181-
- Switch for roof ventilator to ventilate load area -E534-
- Switch for roof ventilator to extract air from load area -E535-
15A - 12 V socket 4 -U20- 30
25 - Fuse 25 on fuse holder F -SF25- 15 A - Trailer detector control unit -J345- 30
26 - Fuse 26 on fuse holder F -SF26- 20 A - Trailer detector control unit -J345- 30

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
27 - Fuse 27 on fuse holder F -SF27- 20 A - Trailer detector control unit -J345- 30
28 - Fuse 28 on fuse holder F -SF28- 7,5 A - Reversing camera system control unit -J772- 30
29 - Fuse 29 on fuse holder F -SF29- - - Vacant -
30 - Fuse 30 on fuse holder F -SF30- 5A - Voice amplification control unit -J656- 3) 30
31 - Fuse 31 on fuse holder F -SF31- - - Vacant -
32 - Fuse 32 on fuse holder F -SF32- - - Vacant -
33 - Fuse 33 on fuse holder F -SF33- 15 A - Driver seat lumbar support adjustment switch -E176- 30
34 - Fuse 34 on fuse holder F -SF34- 40 A - Right sliding door control unit -J731- 30
35 - Fuse 35 on fuse holder F -SF35- 80 A - Battery isolation relay -J7- 30
- Second battery charging circuit relay -J713-
36 - Fuse 36 on fuse holder F -SF36- 40 A - Left sliding door control unit -J558- 30
37 Fuse 37 on fuse holder F -SF37- 40 A - Fresh air blower -V2- 2) 30
38 Fuse 38 on fuse holder F -SF38- 40 A - 6-pin connector -T6bn/4- 1) , 5) 30
39 Fuse 39 on fuse holder F -SF39- - - Vacant -

Note

♦ 1) only models with electric interface, for external use

♦ 2) models with second battery only

♦ 3) applicable up to May 2010

♦ 4) applicable from June 2010

♦ 5) for optimal equipment police (UF4/UF5) only

♦ 6) for optimal equipment police (UF7) only

♦ 7) for optimal equipment camper only, not for camper Beach

– Back to overview ⇒ page 1

1.6.3 Fuse location for fuse -S131- up to -S133- on fuse holder F -SF- :
No. Current Flow Diagram designation Nomina Function/component Terminal
l value

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1-2 Fuse 1 -S131- 10 A - Right interior light -W17- 1) 30
12) Rear right interior light -W48- 1)
Kitchenette light 1 -W57- 1)
Kitchenette light 3 -W59- 1)
Fuse 2 -S132- 10 A3) - 12 V socket -U5- 1) 30
15 A4) - 12 V socket -U5- 1) 30
Fuse 3 -S133- 15 A4) - 12 V socket 5 -U26- 1) 30
Rear left reading light -W11- 1)
Kitchenette light 2 -W58- 1)

Note

♦ 1) for optimal equipment camper Beach only

♦ 2) Plug position freely selectable

♦ 3) applicable up to May 2010

♦ 4) applicable from June 2010

– Back to overview ⇒ page 1

1.7 Coupling station on left of seat box (10-pin)

1.7.1 Location:
♦ On left in seat box
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1.7.2 Fuse location for fuse -SF50- :
N Current Flow Diagram No Function/component Ter
o designation mi mina
. nal l
val
ue
1 - See -Fitting Locations: - - -
- Coupling stations
1
0
A - Vacant - - -
B - See -Fitting Locations: - - -
- Coupling stations
C
D - Fuse 50 on fuse holder F 30 - Amplifier -R12- 30
-SF50- A
– Back to overview ⇒ page 1

1.8 Relay carrier cockpit (8-pin)

1.8.1 Location:
♦ Under dash panel (centre, under the fuses)
– Back to overview ⇒ page 1

1.8.2 Fuse location for fuse -SF51- up to -SF55- on relay carrier (1) cockpit (8-pin):
No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1-5 - See -Fitting Locations: Relay - - -
6 - Fuse 51 on fuse holder F -SF51- 15 A - Alarm system control unit -J85- 1) 49R
- Fuse 52 on fuse holder F -SF52- 15 A - Alarm system control unit -J85- 1) 49L
- Fuse 53 on fuse holder F -SF53- 10 A - Taxi alarm system 2 control unit -J430- DZ

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
7-8 - See -Fitting Locations: Relay - - -
A - Vacant - - -
B - Fuse 55 on fuse holder F -SF55- 30 A - Driver door control unit -J386- 30
- Front passenger door control unit -J387-
C - Vacant - - -

Note

1) for models with taxi equipment only

– Back to overview ⇒ page 1

1.8.3 Fuse location for fuse -SF56- on relay carrier (2) cockpit (8-pin):
No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1-8 - See -Fitting Locations: Relay - - -
A - Vacant - - -
B - Vacant - - -
C - Fuse 56 on fuse holder F -SF56- 40 A - Fresh air blower switch -E9- 75X
- Air conditioning system control unit -J301-
40 A - Fresh air blower switch -E9- 30
- Air conditioning system control unit -J301-
- Auxiliary coolant heater relay -J493- 1)
- Fresh air blower -V2-

Note

1) for models with auxiliary heating only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1.9 Relay carrier electronics box (8-pin)
1.9.1 Location, from August 2009:
♦ In electronics box in engine compartment
– Back to overview ⇒ page 1

1.9.2 Position of fuses on relay carrier electronics box, from August 2009:
No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1-8 - See -Fitting Locations: Relay - - -
A - See -Fitting Locations: Relay - - -
B - See -Fitting Locations: Relay - - -
C - ABS control unit fuse 1 -S123- 40A - ABS control unit -J104- 30

– Back to overview ⇒ page 1

1.9.3 Position of fuses on relay carrier electronics box, from June 2010:
No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1-8 - See -Fitting Locations: Relay - - -
A.1 - ABS control unit fuse 1 -S123- 40A - ABS control unit -J104- 30
A.2 - See -Fitting Locations: Relay - - -
B - Vacant - - -
C - See -Fitting Locations: Relay - - -

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1.9.4 Location, from November 2010:
♦ In electronics box in engine compartment
– Back to overview ⇒ page 1

1.9.5 Position of fuses on relay carrier electronics box, from November 2010:
No. Current Flow Diagram designation Nomina Function/component Terminal
l value
1-1 - See -Fitting Locations: Relay - - -
1
A - See -Fitting Locations: Relay - - -
B - ABS control unit fuse 1 -S123- 40A - ABS control unit -J104- 30

– Back to overview ⇒ page 1

1.10 Fuse holder for special vehicles

1.10.1 Location:
♦ On left in seat box
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1
1.10.2 Fuse location for fuse -S291- up to -S305- (UF4/UF5)
Item Connector/designation Nom
inal
valu
e
1 - Special vehicle fuse 1 -S291- 15 A
- Special vehicle fuse 2 -S292- 15 A
- Special vehicle fuse 3 -S293- 15 A
2 - Special vehicle fuse 4 -S294- 20 A
- Special vehicle fuse 5 -S295- 15 A
- Special vehicle fuse 6 -S296- 15 A
3 - See -Fitting Locations: Relay -
4 - See -Fitting Locations: Relay -
- Special vehicle fuse 7 -S297- 1) 10 A
- Special vehicle fuse 8 -S298- 15 A
- Special vehicle fuse 9 -S299- 10 A
6 - Special vehicle fuse 10 -S300- 1) 5A
- Special vehicle fuse 11 -S301- 1) 7,5 A
- Special vehicle fuse 12 -S302- 1) 7,5 A
7 - Special vehicle fuse 13 -S303- 1) 10 A
2)
15 A
3)

- Special vehicle fuse 14 -S304- 1) , 2) 10 A

Vacant 1) , 3)
- Special vehicle fuse 15 -S305- 1) 15 A
8 - See -Fitting Locations: Relay -
A - Vacant -
B - Vacant -
C - Vacant -

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1

Note

♦ 1) for optimal equipment police (UF5) only

♦ 2) applicable up to October 2010

♦ 3) applicable from November 2010

– Back to overview ⇒ page 1

1.10.3 Fuse location for fuse -S306- up to -S318- (UF7)

Item Connector/designation Nom
inal
valu
e
1 - Special vehicle fuse 16 -S306- 10 A
- Special vehicle fuse 17 -S307- 25 A
- Special vehicle fuse 18 -S308- 15 A
2 - Vacant -
3 - See -Fitting Locations: Relay -
4 - See -Fitting Locations: Relay -
5 - Special vehicle fuse 19 -S309- 10 A
- Special vehicle fuse 20 -S310- 10 A
- Special vehicle fuse 21 -S311- 10 A
6 - Special vehicle fuse 22 -S312- 5A
- Special vehicle fuse 23 -S313- 25 A
- Special vehicle fuse 24 -S314- 15 A
7 - Special vehicle fuse 25 -S315- 10 A
- Special vehicle fuse 26 -S316- 10 A
- Special vehicle fuse 27 -S317- 10 A
8 - See -Fitting Locations: Relay -
A - Special vehicle fuse 28 -S318- 40 A
B - Vacant -
C - Vacant -

Edition 04.2011
 Transporter Fitting Locations No. 803 / 1

Note

♦ Following relays are located under driver seat:

♦ Flashing lights relay -J630- (53)
♦ Flashing lights relay 2 -J890- (53)
♦ Horn relay 2 -J899- (53)
♦ Flashing lights relay 3 -J900- (53)
♦ Flashing lights relay 4 -J901- (53)
♦ Relay for front 'stop' command light -J902- (53)
♦ Engine continues to run without key relay 1 -J903- (96)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1 -Fitting Locations: Relay

1.1 Overview of relay carrier

1 - Relay carrier electronics box

❑ Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from August 2009 ⇒ page 2
❑ Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from June 2010 ⇒ page 3
❑ Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from November 2010
⇒ page 4
❑ Relay carrier electronics box (8-pin), for 2.0 l petrol engine, AXA , from May 2011
⇒ page 5
❑ Relay carrier electronics box (8-pin), for 2.0 l petrol engine, CJKA , from May 2011
⇒ page 6
❑ Relay carrier electronics box (8-pin), for 2.0 l Diesel engine, from August 2009 ⇒ page 7
❑ Relay carrier electronics box (8-pin), for 2.0 l Diesel engine, from June 2010 ⇒ page 8
❑ Relay carrier electronics box (8-pin), for 2.0 l Diesel engine, from November 2010
⇒ page 9
❑ Relay carrier electronics box (8-pin), for 2.0 l Diesel engine, from May 2011 ⇒ page 10
2 - Relay carrier 1, cockpit
❑ Location ⇒ page 13
3 - Relay carrier 2, cockpit
❑ Location ⇒ page 14
4 - Relay carrier on left of seat box
❑ Location ⇒ page 11
- Relay carrier for special vehicles (UF4/UF5) ⇒ page 15
- Relay carrier for special vehicles (UF7) ⇒ page 16

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.2 Relay carrier electronics box (8-pin), for 2.0 l petrol engine,
from August 2009
♦ In electronics box in engine compartment
♦ For engine code AXA

Ite Connector/designation
m
1 - Secondary air pump relay -J299- (100)
2.1 - Vacant
2.2 - Electric fuel pump 2 relay -J49- (449)
3 - Vacant
4 - Fuel pump relay -J17- (643)
5.1 - Vacant
5.2 - Starter inhibitor relay -J207- (449)
6 - Terminal 30 voltage supply relay -J317- (643)
7.1 - Vacant
7.2 - Additional coolant pump relay -J496- (449)
8.1 - Coolant shut-off valve relay -J541- (449)1)
8.2 - Air conditioning system relay -J32- (449)
A - Power steering control unit -J500- (476)
B - Headlight main beam relay -J12- (53)
C - See -Fitting Locations: Fuses

Note

1) for countries with hot climate only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.3 Relay carrier electronics box (8-pin), for 2.0 l petrol engine,
from June 2010
♦ In electronics box in engine compartment
♦ For engine code AXA

Ite Connector/designation
m
1 - Secondary air pump relay -J299- (100)
2.1 - Vacant
2.2 - Electric fuel pump 2 relay -J49- (449)
3 - Vacant
4 - Fuel pump relay -J17- (643)
5.1 - Vacant
5.2 - Starter inhibitor relay -J207- (449)
6 - Terminal 30 voltage supply relay -J317- (643)
7.1 - Vacant
7.2 - Additional coolant pump relay -J496- (449)
8.1 - Coolant shut-off valve relay -J541- (449)1)
8.2 - Air conditioning system relay -J32- (449)
A.1 - See -Fitting Locations: Fuses
A.2 - Power steering control unit -J500- (476/503)
B - Vacant
C - Headlight main beam relay -J12- (53/643)

Note

1) for countries with hot climate only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.4 Relay carrier electronics box (8-pin), for 2.0 l petrol engine,
from November 2010
♦ In electronics box in engine compartment
♦ For engine code AXA

Ite Connector/designation
m
1.A - Electric fuel pump 2 relay -J49- (646)
1.B - Vacant
2 - Secondary air pump relay -J299- (644)
3 - Vacant
4 - Headlight main beam relay -J12- (645)
5 - Terminal 30 voltage supply relay -J317- (645)
6.A - Starter inhibitor relay -J207- (646)
6.B - Vacant
7.A - Air conditioning system relay -J32- (646)
7.B - Coolant shut-off valve relay -J541- (646) 1)
8.A - Additional coolant pump relay -J496- (646)
8.B - Vacant
9 - Fuel pump relay -J17- (645)
10 - Vacant
11 - Vacant
A - Power steering control unit -J500- (476/503)
B - See -Fitting Locations: Fuses

Note

1) for countries with hot climate only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.5 Relay carrier electronics box (8-pin), for 2.0 l petrol engine,
AXA , from May 2011
♦ In electronics box in engine compartment
♦ For engine code AXA

Ite Connector/designation
m
1.A - Electric fuel pump 2 relay -J49- (646)
1.B - Vacant
2 - Secondary air pump relay -J299- (644)
3 - Power steering control unit -J500- (503)
4 - Headlight main beam relay -J12- (645)
5 - Terminal 30 voltage supply relay -J317- (645)
6.A - Starter inhibitor relay -J207- (646)
6.B - Vacant
7.A - Air conditioning system relay -J32- (646)
7.B - Coolant shut-off valve relay -J541- (646) 1)
8.A - Additional coolant pump relay -J496- (646)
8.B - Vacant
9 - Fuel pump relay -J17- (645)
10 - Vacant
11 - Vacant
A - Vacant
B - See -Fitting Locations: Fuses

Note

1) for countries with hot climate only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.6 Relay carrier electronics box (8-pin), for 2.0 l petrol engine,
CJKA , from May 2011
♦ In electronics box in engine compartment
♦ for engine code CJKA

Ite Connector/designation
m
1.A - Fuel shut-off valve switch-off relay -J335- (646)
1.B - Coolant pump relay -J235- (646)
2 - Starter inhibitor relay -J433- (507)
3 - Power steering control unit -J500- (503)
4 - Headlight main beam relay -J12- (645)
5 - Terminal 30 voltage supply relay -J317- (645)
6 - Vacant
7.A - Vacant
7.B - Coolant shut-off valve relay -J541- (646) 1)
8.A - Additional coolant pump relay -J496- (646)
8.B - Vacant
9 - Starter inhibitor relay, clutch pedal switch -J434- (645)
10 - Vacant
11 - Vacant
A - Vacant
B - See -Fitting Locations: Fuses

Note

1) for countries with hot climate only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.7 Relay carrier electronics box (8-pin), for 2.0 l diesel engine,
from August 2009
♦ In electronics box in engine compartment
♦ for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB, CFCA

Ite Connector/designation
m
1 - Automatic glow period control unit -J179- (457)
2 - Vacant
3 - Starter inhibitor relay, clutch pedal switch -J434- (100) 2)
4 - Starter inhibitor relay -J433- (433) 2)
5.1 - Vacant
5.2 - Starter inhibitor relay -J207- (449) 3)
6 - Terminal 30 voltage supply relay -J317- (643)
7.1 - Fuel pump relay -J17- (449)
7.2 - Additional coolant pump relay -J496- (449)
8.1 - Coolant shut-off valve relay -J541- (449) 1)
8.2 - Electric fuel pump 2 relay -J49- (449)
A - Power steering control unit -J500- (476)
B - Headlight main beam relay -J12- (53)
C - See -Fitting Locations: Fuses

♦ In electronics box in engine compartment

♦ for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB, CFCA

Note

♦ 1) for countries with hot climate only

♦ 2) for engine code CFCA only

♦ 3) for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.8 Relay carrier electronics box (8-pin), for 2.0 l diesel engine,
from June 2010
♦ In electronics box in engine compartment
♦ for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB, CFCA

Ite Connector/designation
m
1 - Automatic glow period control unit -J179- (457)
2 - Starter inhibitor relay, clutch pedal switch -J434- (100) 2)
3 - Vacant
4 - Starter inhibitor relay -J433- (433) 2)
5.1 - Vacant
5.2 - Starter inhibitor relay -J207- (449) 3)
6 - Terminal 30 voltage supply relay -J317- (643)
7.1 - Fuel pump relay -J17- (449)
7.2 - Additional coolant pump relay -J496- (449)
8.1 - Coolant shut-off valve relay -J541- (449) 1)
8.2 - Electric fuel pump 2 relay -J49- (449)
A.1 - See -Fitting Locations: Fuses
A.2 - Power steering control unit -J500- (476/503)
B - Vacant
C - Headlight main beam relay -J12- (53/643)

Note

♦ 1) for countries with hot climate only

♦ 2) for engine code CFCA only

♦ 3) for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.9 Relay carrier electronics box (8-pin), for 2.0 l diesel engine,
from November 2010
♦ In electronics box in engine compartment
♦ for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB, CFCA

Ite Connector/designation
m
1 - Automatic glow period control unit -J179- (457/510)
2 - Starter inhibitor relay -J433- (507) 2)
3 - Vacant
4 - Headlight main beam relay -J12- (645)
5 - Terminal 30 voltage supply relay -J317- (645)
6.A - Starter inhibitor relay -J207- (646) 3)
6.B - Vacant
7.A - Electric fuel pump 2 relay -J49- (646)
7.B - Coolant shut-off valve relay -J541- (646) 1)
8.A - Additional coolant pump relay -J496- (646)
8.B - Fuel pump relay -J17- (646)
9 - Starter inhibitor relay, clutch pedal switch -J434- (645) 2)
10 - Vacant
11 - Vacant
A - Power steering control unit -J500- (476/503)
B - See -Fitting Locations: Fuses

Note

♦ 1) for countries with hot climate only

♦ 2) for engine code CFCA only

♦ 3) for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.10 Relay carrier electronics box (8-pin), for 2.0 l diesel engine,
from May 2011
♦ In electronics box in engine compartment
♦ for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB, CFCA

Ite Connector/designation
m
1 - Automatic glow period control unit -J179- (457/510)
2 - Starter inhibitor relay -J433- (507) 2)
3 - Power steering control unit -J500- (503)
4 - Headlight main beam relay -J12- (645)
5 - Terminal 30 voltage supply relay -J317- (645)
6.A - Starter inhibitor relay -J207- (646) 3)
6.B - Vacant
7.A - Electric fuel pump 2 relay -J49- (646)
7.B - Coolant shut-off valve relay -J541- (646) 1)
8.A - Additional coolant pump relay -J496- (646)
8.B - Fuel pump relay -J17- (646)
9 - Starter inhibitor relay, clutch pedal switch -J434- (645) 2)
10 - Vacant
11 - Vacant
A - Vacant
B - See -Fitting Locations: Fuses

Note

♦ 1) for countries with hot climate only

♦ 2) for engine code CFCA only

♦ 3) for engine codes CAAA, CAAB, CAAC, CAAD, CAAE, CCHA, CCHB only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.11 Relay carrier, left seat box (8-pin)
♦ On left in seat box

Item Connector/designation
SF1 -
SF2 - See -Fitting Locations: Fuses
SF3 -
SF4 -
SF5 - See -Fitting Locations: Fuses
SF6 -
SF7 -
SF8 - Terminal 75 voltage supply relay 1 -J680 - (53) 3) , 4)

SF9 -
SF10 -
SF11 - See -Fitting Locations: Fuses
SF12 -
SF13 -
SF14 - Battery isolation relay -J7- (100) 2)
SF15 -
SF16 - Rotating light relay -J326- (486)
SF17 - Alarm system relay 1 -J460- (53/643) 1)
SF18 -
SF19 - Taxi alarm remote control, control unit -J601- 1)
SF20 - Terminal 75 voltage supply relay 1 -J680 - (53/643) 3) , 5)

SF21 -
SF22 - See -Fitting Locations: Fuses
-
SF39

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1

Note

♦ 1) only models with taxi equipment

♦ 2) only models with second battery

♦ 3) for optimal equipment police (UF5) only

♦ 4) applicable up to October 2010

♦ 5) applicable from November 2010

– Back to overview ⇒ page 1

1.11.1 Second battery charging circuit relay

-J713-

1.11.2 Location:
in driver seat box

Note

for models with battery for special vehicles only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.12 Relay carrier (1) cockpit (8-pin)
♦ Under dash panel (centre, under the fuses)

Ite Connector/designation
m
1 - Auxiliary heater relay -J8- (404)
Residual heat relay -J708- (404)
2 - Headlight washer system relay -J39- (53)
3 - X-contact relief relay 2 -J339- (100)
4 - Vacant
5 - X-contact relief relay -J59- (100)
6 - See -Fitting Locations: Fuses
7 - Dual signal inverter relay -J741- (472) 1)
- Drive train CAN bus isolation relay -J788- (479) 2)
8 - Auxiliary coolant heater relay -J493- (53/643)
A - See -Fitting Locations: Fuses
B - See -Fitting Locations: Fuses
C - See -Fitting Locations: Fuses

Note

♦ 1) applicable up to October 2009

♦ 2) applicable from November 2009

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.13 Relay carrier (2) cockpit (8-pin)
♦ Under dash panel (centre, under the fuses)

Ite Connector/designation
m
1 - Starter motor relay -J53- (53/643)
2.1 - Terminal 15 voltage supply relay 2 -J681- (404)
2.2 - Entry and footwell light relay -J348- 2) (449)
3 - Terminal 15 voltage supply relay -J329- (53/643)
4 - Differential lock control unit -J187- (468)
5 - Alarm system control unit -J85- (73) 1)
- Drive train CAN bus isolation relay -J788- (479) 3)
6 - Alarm system control unit -J85- (73) 1)
7 - Switch-over relay 1 for roof ventilator -J180- (504)
- Taxi alarm system 2 control unit -J430- (53) 1)
8 - Fresh air blower isolation relay -J487- (53/643)
A - See -Fitting Locations: Fuses
B - See -Fitting Locations: Fuses
C - See -Fitting Locations: Fuses

Note

♦ 1) only models with taxi equipment

♦ 2) applicable up to October 2009

♦ 3) applicable up to October 2009, models from November 2009: see relay carrier (1)
cockpit (8-pin) ⇒ page 13

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.14 Relay carrier for special vehicles (UF4/UF5)
♦ On left in seat box

Item Connector/designation
1 - See -Fitting Locations: Fuses
2 - See -Fitting Locations: Fuses
3.1 - Horn relay -J413- (449)
3.2 - Flashing lights relay 3 -J900- (449) 1)
4.1 - Rotating light relay -J326- (449) 1)
4.2 - Flashing lights relay -J630- (449) 1)
5 - See -Fitting Locations: Fuses
6 - See -Fitting Locations: Fuses
7 - See -Fitting Locations: Fuses
8.1 - Flashing lights relay 2 -J890- (449) 1)
8.2 - Two-way radio cut-off relay -J84- (449) 1)
A - Vacant
B - Vacant
C - Vacant

Note

1) for optimal equipment police (UF5) only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 804 / 1
1.15 Relay carrier for special vehicles (UF7)
♦ On left in seat box

Item Connector/designation
1 - See -Fitting Locations: Fuses
2 - Vacant
3 - Engine continues to run without key relay 2 -J904- (79)
4 - Horn relay -J413- (79)
5 - See -Fitting Locations: Fuses
6 - See -Fitting Locations: Fuses
7 - See -Fitting Locations: Fuses
8 - Terminal 75 voltage supply relay 1 -J680- (53)
A - See -Fitting Locations: Fuses
B - Vacant
C - Vacant

Note

♦ Following relays are located under driver seat:

♦ Flashing lights relay -J630- (53)
♦ Flashing lights relay 2 -J890- (53)
♦ Horn relay 2 -J899- (53)
♦ Flashing lights relay 3 -J900- (53)
♦ Flashing lights relay 4 -J901- (53)
♦ Relay for front 'stop' command light -J902- (53)
♦ Engine continues to run without key relay 1 -J903- (96)

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1 -Fitting Locations: Coupling stations and pin connectors from wiring harness set

1.1 Overview of coupling stations

1 - Coupling station on fuel filter

❑ Location ⇒ page 3
2 - Coupling station near alternator
❑ Location ⇒ page 4
3 - Coupling station right in engine compartment
❑ Location ⇒ page 4
4 - Coupling station near horn or dual tone horn
❑ Location ⇒ page 5
5 - Coupling station on right of A-pillar
❑ Location ⇒ page 7
6 - Coupling station in right of A-pillar
❑ Location ⇒ page 7
7 - Coupling station behind the glove compartment
❑ Location ⇒ page 7
8 - Coupling station in right door
❑ Fitting Locations ⇒ page 8
9 - Coupling station on right of seat box
❑ Fitting Locations ⇒ page 8
10 - Coupling station in right B-pillar
❑ Location ⇒ page 9
11 - Coupling station on right B-pillar
❑ Location ⇒ page 10
12 - Coupling station in right sliding door
❑ Location ⇒ page 10
13 - Coupling station on right C-pillar
❑ Location ⇒ page 11
14 - Coupling station in rear right side panel
❑ Location ⇒ page 11

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
15 - Coupling station in right side panel
❑ Location ⇒ page 11
16 - Coupling station right D-pillar
❑ Location ⇒ page 12
17 - Coupling station in rear lid
❑ Location ⇒ page 12
18 - Coupling station on rear of roof
❑ Location ⇒ page 12
19 - Coupling station reversing camera
❑ Location ⇒ page 13
20 - Coupling station on left of D-pillar
❑ Location ⇒ page 13
21 - Coupling station on left C-pillar
❑ Location ⇒ page 13
22 - Coupling station in left B-pillar
❑ Location ⇒ page 14
23 - Coupling stations on left of seat box
❑ Fitting Locations ⇒ page 15
24 - Coupling station auxiliary heater
❑ Location ⇒ page 16
25 - Coupling station on underbody
❑ Location ⇒ page 17
26 - Coupling station central locking deadlock function warning lamp
❑ Location ⇒ page 17
27 - Coupling station for interior light
❑ Location ⇒ page 18
28 - Coupling station in left door
❑ Location ⇒ page 18
29 - Coupling station on left of A-pillar
❑ Fitting Locations for coupling station in left of A-pillar ⇒ page 18
❑ Fitting Locations for coupling station on left of A-pillar, from August 2009 ⇒ page 19
❑ Fitting Locations for coupling station on left of A-pillar, from May 2011 ⇒ page 20

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
30 - Coupling station on front of engine
❑ Location ⇒ page 5
31 - Coupling station electronics box
❑ Location ⇒ page 6
32 - Coupling station on radiator fan
❑ Location ⇒ page 3

1.2 Coupling stations engine compartment

1.2.1 Coupling station on radiator fan
Pfeil - 4-pin connector -T4ak,T4ax-
, black, in engine compartment near radiator fan

Note

T4ak increased blower output, T4ax low and medium blower

output

– Back to overview ⇒ page 1

1.2.2 Coupling station on fuel filter

Pfeil - 2-pin connector -T2dp-
, black, in engine compartment near fuel filter

Note

Illustration made with coolant tank removed.

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.2.3 Coupling station near alternator
Pfeil - 3-pin connector -T3bf-
, black, in engine compartment near alternator
– Back to overview ⇒ page 1

1.2.4 Coupling station right in engine

compartment
Pfeil A - 2-pin connector -T2ah- , black, in right engine
compartment
Pfeil B - 6-pin connector -T6a- , black, in right engine
compartment

Note

for models with diesel engine only

– Back to overview ⇒ page 1

Pfeil - 6-pin connector -T6ax- , black, in right engine compartment

Note

for models with petrol engine only

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.2.5 Coupling station near horn or dual tone
horn
Pfeil A - 10-pin connector -T10bl- , black, near horn or dual tone
horn -H1-
Pfeil B - 14-pin connector -T14- , black, near horn or dual tone
horn -H1-
– Back to overview ⇒ page 1

1.2.6 Coupling station on front of engine

1 - 14-pin connector -T14d- , black, on front of engine
2 - 3-pin connector -T3be- , green, on front of engine

Note

for models with engine code CJKA only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.2.7 Coupling station on electronics box (15-pin)

♦ In electronics box, in left engine compartment

Item Connector/designation Connector colour

1 - 10-pin connector -T10g- grey
2 - 10-pin connector -T10a- brown
3 - 10-pin connector -T10b- red
4 - 10-pin connector -T10m- 1) , 3) light-pink
- 6-pin connector -T6g- 2) brown
5 - 10-pin connector -T10e- white
6 - 10-pin connector -T10l- light-green
7 - Vacant -
8 - 17-pin connector -T17g- black
9 - 10-pin connector -T10c- yellow
10 - 10-pin connector -T10d- blue
11 - 10-pin connector -T10h- orange
12 - 10-pin connector -T10f- green
13 - 10-pin connector -T10- black
14 - 10-pin connector -T10k- purple
15 - 10-pin connector -T10j- dark brown

Note

♦ 1) for models with diesel engine only

♦ 2) for models with engine code AXA only

♦ 3) for models with engine code CJKA only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.3 Coupling stations near A pillar
1.3.1 Coupling stations on right of A-pillar

♦ On right A-pillar

Item Connector/designation Connector colour

1 - 10-pin connector -T10ak- black
2 - Vacant -
3 - 10-pin connector -T10al- red
– Back to overview ⇒ page 1

1.3.2 Coupling station in right of A-pillar

Pfeil A - Single connector -T1an- , black, in right of A-pillar
Pfeil B - Single connector -T1e- , yellow, in right of A-pillar
Pfeil C - Single connector -T1c- , brown, in right of A-pillar
Pfeil D - Single connector -T1d- , blue, in right of A-pillar
– Back to overview ⇒ page 1

1.4 Coupling station behind the glove

compartment
Pfeil A - Single connector -T1ar- , black, behind the glove
compartment (only for Climatic)
Pfeil B - 17-pin connector -T17a- , black, behind the glove
compartment
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.5 Coupling station in right door
Pfeil A - Single connector -T1al- , blue, in right door
Pfeil B - Single connector -T1am- , yellow, in right door
Pfeil C - Single connector -T1ao- , black, in right door
Pfeil D - Single connector -T1ak- , brown, in right door
Pfeil E - 12-pin connector -T12o- , brown, in right door
– Back to overview ⇒ page 1

1.6 Coupling station on right of seat box

1.6.1 Coupling station on right in seat box

♦ On right in seat box

Item Connector/designation Connector colour

1 - Vacant -
2 - 6-pin connector -T6v- red
3 - 6-pin connector -T6x- purple
4 - 10-pin connector -T10ba- blue
5 - 10-pin connector -T10bk- grey
6 - 6-pin connector -T6bc- 1) black
7 - 6-pin connector -T6w- light-pink
8 - 10-pin connector -T10ay- red
9 - 10-pin connector -T10be- green
10 - 10-pin connector -T10av- brown
B - Vacant -

Note

1) for optimal equipment police (UF5) only

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.6.2 Coupling station under front passenger
seat
Pfeil - 3-pin connector -T3r- , yellow, under front passenger seat

Note

A further coupling point is located under front passenger seat. The

8-pin connector -T8u- , black, is not shown in the illustration.

– Back to overview ⇒ page 1

1.6.3 Coupling station 12 V socket

Pfeil - 2-pin connector -T2x- , black, under front passenger seat
– Back to overview ⇒ page 1

1.7 Coupling station in right B-pillar

Pfeil - 3-pin connector -T3m- , yellow, in B-pillar, near belt
tensioner
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.8 Coupling station on right B-pillar
Pfeil - 2-pin connector -T2an- , black, under roof, near B-pillar
upper right
– Back to overview ⇒ page 1

1.9 Coupling station in right sliding door

Pfeil A - 2-pin connector -T2dj- , black, in right sliding door
Pfeil B - 2-pin connector -T2dk- , black, in right sliding door

Note

A further coupling point is located on upper right sliding door. The

3-pin connector -T3x- , black, is not shown in the illustration.

Note

♦ The coupling point for left sliding door must be derived from
the illustration.
♦ 2-pin connector -T2dl- , black, in left sliding door
♦ 2-pin connector -T2dm- , black, in left sliding door
♦ A further coupling point is located on upper left sliding door.
The 3-pin connector -T3w- , black, is not shown in the
illustration.

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.10 Coupling station on right C-pillar
Pfeil - 2-pin connector -T2dt-
Coupling station on right C-pillar

Note

behind the side trim, right

– Back to overview ⇒ page 1

1.11 Coupling station in rear right side panel

Pfeil - 8-pin connector -T8g- , black, in rear right side panel

Note

The 8-pin connector -T8f- , black, in rear left side panel must be
derived from the illustration.

– Back to overview ⇒ page 1

1.12 Coupling station in right side panel

Pfeil - 4-pin connector -T4am- , black, on right C-pillar

Note

The 4-pin connector -T4al- , black, on left C-pillar must be derived

from the illustration.

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.13 Coupling station right D-pillar
Pfeil - 17-pin connector -T17d- , black
♦ On right D-pillar
– Back to overview ⇒ page 1

1.14 Coupling station in rear lid

Pfeil - 2-pin connector -T2bd- , black, in rear lid
– Back to overview ⇒ page 1

1.15 Coupling station on rear of roof

Pfeil - Single connector -T1as- , grey, under roof trim between left
and right D-pillar
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.16 Coupling station reversing camera
Pfeil A - Single connector -T1at- , grey, in rear lid
Pfeil B - 2-pin connector -T2cu- , black, in rear lid
– Back to overview ⇒ page 1

1.17 Coupling station on left of D-pillar

Pfeil A - 17-pin connector -T17c- , black, coupling station left D-
pillar
Pfeil B - 12-pin connector -T12v- , black, coupling station left D-
pillar
Pfeil C - 8-pin connector -T8af- , black, coupling station left D-pillar
– Back to overview ⇒ page 1

1.18 Coupling station on left C-pillar

Pfeil - 2-pin connector -T2ds- , Coupling station on left C-pillar

Note

behind the side trim, left

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.19 Coupling station in left B-pillar
Pfeil - 3-pin connector -T3q- , yellow, in B-pillar, near belt
tensioner
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.20 Coupling stations on left of seat box
1.20.1 Coupling station on left in seat box

♦ under left seat box

Item Connector/designation Connector colour

1 - 10-pin connector -T10aa- dark brown
2 - 17-pin connector -T17f- brown
3 - 6-pin connector -T6j- red
4 - 6-pin connector -T6bn- 1) grey
5 - 10-pin connector -T10t- black
6 - 10-pin connector -T10u- blue
7 - 10-pin connector -T10o- light-green
8 - 10-pin connector -T10bj- 1) yellow
9 - 6-pin connector -T6h- purple
10 - 10-pin connector -T10q- grey
A - Vacant -
B - 17-pin connector -T17j- white
C - 10-pin connector -T10bh- 1) purple
D - See -Fitting Locations: Fuses -

Note

1) only models with electric interface, for external use

– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.20.2 Coupling station under driver seat
Pfeil A - 2-pin connector -T2dd- , black, under driver seat
Pfeil B - 3-pin connector -T3k- , yellow, under driver seat

Note

A further coupling point is located under driver seat. The 8-pin

connector -T8s- , black, is not shown in the illustration.

– Back to overview ⇒ page 1

1.20.3 Coupling stations for special vehicles

♦ under left seat box

Item Connector/designation Connector colour

1 - 10-pin connector -T10bp- green
2 - 10-pin connector -T10bq- orange
3 - 10-pin connector -T10br- blue
– Back to overview ⇒ page 1

1.21 Coupling station auxiliary heater

Pfeil A - 8-pin connector -T8d- , black, on underbody, next to the
auxiliary heater
Pfeil B - 8-pin connector -T8aj- , black, on underbody, next to the
auxiliary heater
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.22 Coupling station on underbody
Pfeil A - 2-pin connector -T2dn- , black, on underbody, near apron
Pfeil B - 2-pin connector -T2cr- , brown, on underbody, near apron
Pfeil C - 2-pin connector -T2cq- , orange, on underbody, near
apron
Pfeil D - 3-pin connector -T3bc- , black, on underbody, near apron

Note

for models with diesel engine only

– Back to overview ⇒ page 1

Pfeil - 4-pin connector -T4k- , black, on underbody, next to the
auxiliary heater

Note

for models with petrol engine only

– Back to overview ⇒ page 1

1.23 Coupling station central locking

deadlock function warning lamp
Pfeil - 2-pin connector -T2do- , black, in driver door
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.24 Coupling station for interior light
Pfeil A - 2-pin connector -T2r- , black, behind interior light1)
Pfeil B - 8-pin connector -T8al- , black, behind interior light2)

Note

♦ 1) only models with telephone

♦ 2) only models with roof console

– Back to overview ⇒ page 1

1.25 Coupling station in left door

Pfeil A - Single connector -T1af- , green, in left door
Pfeil B - Single connector -T1ad- , purple, in left door
Pfeil C - Single connector -T1ae- , white, in left door
Pfeil D - 12-pin connector -T12n- , brown, in left door
– Back to overview ⇒ page 1

1.26 Coupling stations on left of A-pillar

1.26.1 Coupling station in left of A-pillar
Pfeil A - Single connector -T1ab- , white, in left A-pillar
Pfeil B - Single connector -T1ac- , green, in left of A-pillar
Pfeil C - Single connector -T1aa- , purple, in left of A-pillar
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.26.2 Coupling station on left of A-pillar, from August 2009

♦ On left A-pillar

Item Connector/designation Connector colour

1 - 10-pin connector -T10ad- red
2 - Vacant -
3 - Vacant -
4 - 10-pin connector -T10ab- white
5 - 17-pin connector -T17k- green
6 - 17-pin connector -T17l- black
7 - 10-pin connector -T10ag- brown
8 - 17-pin connector -T17m- red
9 - 10-pin connector -T10af- blue
10 - Vacant -
A-D - Vacant -
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 805 / 1
1.26.3 Coupling station on left of A-pillar, from May 2011

♦ On left A-pillar

Item Connector/designation Connector colour

1 - 17-pin connector -T17l- black
2 - 10-pin connector -T10ab- white
3 - 17-pin connector -T17k- green
4 - Vacant -
5 - Vacant -
6 - 10-pin connector -T10ad- red
7 - 10-pin connector -T10ag- brown
8 - 17-pin connector -T17m- red
9 - 10-pin connector -T10af- blue
10 - Vacant -
A-D - Vacant -
– Back to overview ⇒ page 1

Edition 04.2011
 Transporter Fitting Locations No. 806 / 1
1 -Fitting Locations: Multivan business

1.1 Overview:

1 - Multimedia system operating unit -E380-

⇒ page 3
2 - Internet access control unit -J666-
⇒ page 2
3 - GSM aerial 2 -R267- and GPS aerial 2 -R268-
⇒ page 12
4 - Rear TV and video display unit -R97- , Display unit control unit -J146- and open and close display
motor -V301- ⇒ page 4
5 - Control unit for right seat, row 3 -J784- and digital TV tuner -R171-
⇒ page 11
6 - Control unit 2 for rear seat adjustment -E576- and control unit for heated right seat, row 3
-J785-
⇒ page 10
7 - Multimedia control unit -J650- ⇒ page 5
8 - 40Earth point, under rear right seat ⇒ page 20
9 - Refrigerator box -J698-
⇒ page 7
10 - Fuse holder H -SH- , rear left
♦ Location: ⇒ page 15
♦ Fuse locations: ⇒ page 15
11 - Relay carrier, rear left
♦ Location: ⇒ page 18
♦ Relay positions: ⇒ page 19
12 - Wiring junction -TV1- , rear left
⇒ page 19
13 - 39Earth point, under rear left seat ⇒ page 21
14 - Control unit 1 for rear seat adjustment -E575- and control unit for heated left seat, row 3 -J783-
⇒ page 10
15 - 4-pin connector -T4xd- and 42-pin connector -T42xa-

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
⇒ page 13
16 - Control unit for left seat, row 3 -J782-
⇒ page 9
17 - Rear cigarette lighter -U9- ⇒ page 7
- DVD player -R7- ⇒ page 8
- Multimedia system operating unit 2 -E499- ⇒ page 6
18 - Fuse holder F -SF- , under left seat box
♦ Location: ⇒ page 13
♦ Fuse location for fuse -SF16- up to -SF31- on fuse holder F -SF- : ⇒ page 14

1.2 Control units and operational controls

1.2.1 Internet access control unit -J666-

1 - Internet access control unit -J666-

♦ on glove compartment upper right
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.2 Multimedia system operating unit -E380-

A - Multimedia system operating unit -E380- 1)

♦ in centre dash panel

Note

1) depends on equipment

– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.3 Rear TV and video display unit -R97- , Display unit control unit -J146- and open and close display motor -V301-

1 - Rear TV and video display unit -R97- 1)

2 - Display unit control unit -J146- 1)
3 - Open and close display motor -V301- 1)
4 - Connector1)
♦ on roof

Note

1) depends on equipment

– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.4 Multimedia control unit -J650-

A - Multimedia control unit -J650- 1)

♦ under the right seat, row 3
♦ behind the trim
♦ view from rear

Note

1) depends on equipment

– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.5 Multimedia system operating unit 2 -E499-

B - Multimedia system operating unit 2 -E499- 1)

♦ between the seats, row 3
♦ view from front

Note

1) depends on equipment

– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.6 Refrigerator box -J698- and rear cigarette lighter -U9-

1 - Refrigerator box -J698-

2 - Rear cigarette lighter -U9-
♦ between the seats, row 3
♦ view from front
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.7 DVD player -R7-

1 - DVD player -R7- 1)

♦ between the seats, row 3
♦ view from front

Note

1) depends on equipment

– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.8 Control unit for left seat, row 3 -J782-

A - Control unit for left seat, row 3 -J782-

♦ under the left seat, row 3
♦ behind the trim
♦ view from front
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.9 Control unit 1 for rear seat adjustment -E575- , control unit 2 for rear seat adjustment -E576- , control unit for heated left
seat, row 3 -J783- and control unit for heated right seat, row 3 -J785-

1 - Control unit for heated left seat, row 3 -J783-

2 - Control unit 1 for rear seat adjustment -E575-
♦ in outer right/left armrest, 3. seat row
♦ behind the trim
♦ view from front

Note

♦ The seat heating switch -E73- are in control unit for heated
left seat, row 3 -J783- and control unit for heated right seat,
row 3 -J785- integrated.
♦ Shown is the left side. The control unit 2 for rear seat
adjustment -E576- or the control unit for heated right seat,
row 3 -J785- is similar.

– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.2.10 Control unit for right seat, row 3 -J784- and digital TV tuner -R171-

A - Control unit for right seat, row 3 -J784-

B - Digital TV tuner -R171- 1)
♦ under the right seat, row 3
♦ behind the trim
♦ view from front

Note

1) depends on equipment

– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.3 GSM aerial 2 -R267- and GPS aerial 2 -R268-

1 - GSM aerial 2 -R267- and GPS aerial 2 -R268-

♦ on front roof
♦ The GSM aerial 2 -R267- and GPS aerial 2 -R268- form a unit.
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.4 4-pin connector -T4xd- and 42-pin connector -T42xa-

A - 4-pin connector -T4xd-

B - 42-pin connector -T42xa-
♦ under the left seat, row 3
♦ behind the trim
♦ view from front
– Back to overview ⇒ page 1

1.5 Fuse carrier, on front left in seat box

1.5.1 Location:
♦ On front left in seat box
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.5.2 Fuse locations:
It Current Flow Diagram No Connector/designation Termi
e designation mi nal
m nal
val
ue
1 - Fuse 16 on fuse holder F - - Vacant -
6 -SF16-
1 - Fuse 17 on fuse holder F 1 A - Loudspeaker change-over box, on 30
7 -SF17- right in seat box
1 - Fuse 18 on fuse holder F 10 - Auxiliary amplifier on right in seat box 30
8 -SF18- A
1 - Fuse 19 on fuse holder F 30 - Voltage supply relay 1 -J701- 30
9 -SF19- A
2 - Fuse 20 on fuse holder F 30 - Terminal 75x voltage supply relay 30
0 -SF20- A -J694-
2 - Fuse 21 on fuse holder F 30 - Wiring junction -TV1- 30
1 -SF21- A
2 - Fuse 22 on fuse holder F 2 A - Internet access control unit -J666- 86s
2 -SF22- 1)
2 - Fuse 23 on fuse holder F
3 -SF23- 1)
2 - Fuse 25 on fuse holder F
5 -SF25- 1)
3 - Fuse 31 on fuse holder F 2 A - Internet access control unit -J666- 30
1 -SF31-

Note

1) The fuse location depends on equipment!

– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.6 Fuse holder H -SH- , rear left
1.6.1 Location:
♦ under the right seat, row 3
♦ behind the trim
♦ view from rear
– Back to overview ⇒ page 1

1.6.2 Fuse locations:

It Current Flow Diagram No Connector/designation Termi
e designation mi nal
m nal
val
ue
1 - Fuse 1 in fuse holder H - - Vacant -
-SH1-
2 - Fuse 2 in fuse holder H - - Vacant -
-SH2-
3 - Fuse 3 in fuse holder H - - Vacant -
-SH3-
4 - Fuse 4 in fuse holder H - - Vacant -
-SH4-
5 - Fuse 5 in fuse holder H - - Vacant -
-SH5-
6 - Fuse 6 in fuse holder H - - Vacant -
-SH6-
7 - Fuse 7 in fuse holder H - - Vacant -
-SH7-
8 - Fuse 8 in fuse holder H - - Vacant -
-SH8-
9 - Fuse 9 in fuse holder H - - Vacant -
-SH9-
1 - Fuse 10 in fuse holder H - - Vacant -
0 -SH10-

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
It Current Flow Diagram No Connector/designation Termi
e designation mi nal
m nal
val
ue
1 - Fuse 11 in fuse holder H - - Vacant -
1 -SH11-
1 - Fuse 12 in fuse holder H - - Vacant -
2 -SH12-
1 - Fuse 13 in fuse holder H 2 A - 8-pin connector -T8xo- , digital TV 87
3 -SH13- tuner -R171- 1)
1 - Fuse 14 in fuse holder H 2 A - 2-pin connector -T2xc- , Interface for 87
4 -SH14- external multimedia unit -R215- 1)
1 - Fuse 15 in fuse holder H 5 A - DVD player fan -V531- 1) 87
5 -SH15-
1 - Fuse 16 in fuse holder H 10 - 42-pin connector -T42xa- , Display unit 87
6 -SH16- A control unit -J146- 1)
1 - Fuse 17 in fuse holder H 5 A - 6-pin connector -T6xe- , Multimedia 87
7 -SH17- control unit -J650- 1)
1 - Fuse 18 in fuse holder H 10 - Rear cigarette lighter -U9- 30
8 -SH18- A
1 - Fuse 19 in fuse holder H - - 42-pin connector -T42xa- 30
9 -SH19-
2 - Fuse 20 in fuse holder H 3 A - 8-pin connector -T8xo- , digital TV 30
0 -SH20- tuner -R171- 1)
2 - Fuse 21 in fuse holder H 2 A - 42-pin connector -T42xa- , preparation 30
1 -SH21- for telephone CC9045
2 - Fuse 22 in fuse holder H 5 A - preparation for telephone CC9045 1) 30
2 -SH22-
2 - Fuse 23 in fuse holder H - - Vacant 30
3 -SH23-
2 - Fuse 24 in fuse holder H - - Vacant -
4 -SH24-
2 - Fuse 25 in fuse holder H 2 A - 42-pin connector -T42xa- , preparation 86s
5 -SH25- for telephone CC9045
2 - Fuse 26 in fuse holder H - - Vacant 86s
6 -SH26-
2 - Fuse 27 in fuse holder H 10 - 6-pin connector -T6xo- , Multimedia 86s
7 -SH27- A system operating unit 2 -E499- 1)

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
It Current Flow Diagram No Connector/designation Termi
e designation mi nal
m nal
val
ue
2 - Fuse 28 in fuse holder H 10 - 42-pin connector -T42xa- , Multimedia 86s
8 -SH28- A system operating unit -E380-
2 - Fuse 29 in fuse holder H 5 A - 42-pin connector -T42xa- , Display unit 86s
9 -SH29- control unit -J146- 1)
3 - Fuse 30 in fuse holder H - - Vacant -
0 -SH30-
3 - Fuse 31 in fuse holder H - - Vacant 75x
1 -SH31-
3 - Fuse 32 in fuse holder H - - Vacant 75x
2 -SH32-
3 - Fuse 33 in fuse holder H - - Vacant 75x
3 -SH33-
3 - Fuse 34 in fuse holder H - - Vacant 75x
4 -SH34-
3 - Fuse 35 in fuse holder H 10 - Refrigerator box -J698- 30
5 -SH35- A
3 - Fuse 36 in fuse holder H 2 A - preparation for telephone CC9045 1) 30
6 -SH36-
3 - Fuse 37 in fuse holder H 10 - 6-pin connector -T6xe- , Multimedia 30
7 -SH37- A control unit -J650- 1)
3 - Fuse 38 in fuse holder H 5 A - Halogen-lights above the 2nd rear 30
8 -SH38- bench seat 1)
3 - Fuse 39 in fuse holder H - - Vacant 30
9 -SH39-
4 - Fuse 40 in fuse holder H 5 A - preparation for telephone CC9045 1) 30
0 -SH40-
4 - Fuse 41 in fuse holder H 10 - 42-pin connector -T42xa- , Folding 86s
1 -SH41- A table motor -V250- 1)
4 - Fuse 42 in fuse holder H 15 - Control unit 1 for rear seat adjustment 86s
2 -SH42- A -E575-
4 - Fuse 43 in fuse holder H 15 - Control unit 2 for rear seat adjustment 86s
3 -SH43- A -E576-
4 - Fuse 44 in fuse holder H - - Vacant 86s
4 -SH44-

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
It Current Flow Diagram No Connector/designation Termi
e designation mi nal
m nal
val
ue
4 - Fuse 45 in fuse holder H - - Vacant 86s
5 -SH45-
4 - Fuse 46 in fuse holder H 3 A - Halogen-lights above the 2nd rear 86s
6 -SH46- bench seat 1)
4 - Fuse 47 in fuse holder H - - Vacant 30
7 -SH47-
4 - Fuse 48 in fuse holder H 15 - Control unit for heated left seat, row 3 75x
8 -SH48- A -J783-
4 - Fuse 49 in fuse holder H 15 - Control unit for heated right seat, row 3 75x
9 -SH49- A -J785-
5 - Fuse 50 in fuse holder H - - Vacant 75x
0 -SH50-
5 - Fuse 51 in fuse holder H - - Vacant 75x
1 -SH51-

Note

1) preparation for optimal equipment

– Back to overview ⇒ page 1

1.7 Relay carrier, rear left:

1.7.1 Location:
♦ under the left seat, row 3
♦ behind the trim
♦ view from rear
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.7.2 Relay positions:
Item Current Flow Diagram designation Code
1 - Interior light relay -J602- (right) KDN HOR
90064A
2 - Interior light relay -J602- (left) KDN HOR
90064A
3 - Voltage supply relay 2 -J710- KDN HOR
90057
4 - Telephone relay 3B0 035 731
5 - Switch illumination relay -J141- 96
6 - Terminal 75x voltage supply relay -J694- 96
7 - Voltage supply relay 1 -J701- 96
8 - vacant -
– Back to overview ⇒ page 1

1.8 Wiring junction -TV1-

♦ under the left seat, row 3
♦ behind the trim
♦ view from rear
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.9 Earth points

1.9.1 40Earth point, under rear right seat

1 - 40Earth point, under rear right seat

♦ under the right seat, row 3
♦ behind the trim
♦ view from rear
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 806 / 1
1.9.2 39Earth point, under rear left seat

1 - 39Earth point, under rear left seat

♦ under the left seat, row 3
♦ behind the trim
♦ view from front
– Back to overview ⇒ page 1

Edition 09.2011
 Transporter Fitting Locations No. 807 / 1
1 -Fitting locations: camping equipment

1.1 Component overview

1 - Convertible roof actuation hydraulic pump -V118- ⇒ page 2

2 - Torch -R280- (not shown)
♦ below, on rear passenger seat
3 - Fresh air blower switch, rear -E179- or operating and display unit for rear air conditioning system
-E265- (not shown, see -Fitting locations: control units)
4 - Water pump switch for shower -E134- and warning lamp -K96- (not shown)
♦ in rear left side cupboard
5- 653 Earth point on left D-pillar (not shown, see -Fitting locations: earth points)
6 - 220 V Automatic person protection circuit -S59- ⇒ page 2
7- 721 Earth point 1 for special constructions ⇒ page 5
8 - On-board charger -A11- ⇒ page 2
9 - 729 Earth point, on left rear wheel housing and battery charge control measuring resistor
-N162- ⇒ page 3
10 - Battery for special vehicle -A24- ⇒ page 3
11 - Ambient temperature sender 2 -G249- ⇒ page 6
12 - 17-pin connector -T17b- ⇒ page 5
13 - 724 Earth point 4 for special constructions ⇒ page 5
14 - DC/AC converter with socket, 12 V - 230 V -U13- and DC/AC converter with socket, 12 V - 115
V -U27- ⇒ page 4
15 - 725 Earth point 5 for special constructions ⇒ page 5
16 - Second battery charging circuit relay -J713- ⇒ page 4
17 - 34 Earth point below driver's seat (not shown, see -Fitting locations: earth points)
18 - Roof hydraulics control unit -J768- ⇒ page 2
19 - Operating and display unit for camping equipment -E153- (not shown, see -Fitting locations:
control units)

Edition 10.2014
 Transporter Fitting Locations No. 807 / 2
1.1.1 Roof hydraulics control unit -J768- and
convertible roof operation hydraulic
pump -V118-
1 - Roof hydraulics control unit -J768-
2 - Convertible roof actuation hydraulic pump -V118-
♦ on the front of the roof, behind the headliner

1.1.2 220 V Automatic person protection

circuit -S59-
A - 220 V Automatic person protection circuit -S59-
♦ in rear cupboard, in middle shelf of kitchenette

1.1.3 On-board charger -A11-

A - On-board charger -A11-

Note

The on-board charger -A11- is, from the 33rd calendar week of
2014, installed over the third battery in the rear cupboard.

Edition 10.2014
 Transporter Fitting Locations No. 807 / 3
1.1.4 Battery for special vehicle -A24-
1 - Cover
2 - Nut
3 - Battery retaining plate

1.1.5 Battery charge control measuring

resistor -N162- and 729 earth point on
left rear wheel housing
729 - Earth point on left rear wheel housing

Note

The battery charge control measuring resistor -N162- is shown

without an -arrow-

Edition 10.2014
 Transporter Fitting Locations No. 807 / 4
1.1.6 Second battery charging circuit relay
-J713-
A - Second battery charging circuit relay -J713-
♦ In driver seat box

1.1.7 DC/AC converter with socket, 12 V - 230

V -U13- and DC/AC converter with
socket, 12 V - 115 V -U27-
A - DC/AC converter with socket, 12 V - 230 V -U13-
- DC/AC converter with socket, 12 V - 115 V -U27-
♦ On B-pillar, behind the trim

1.2 Overview of pin connectors and earth

points in fitted kitchen
A- 725 Earth point 5 for special constructions
B- 724 Earth point 4 for special constructions
C- 721 Earth point 1 for special constructions
D - Not assigned
E - 17-pin connector -T17b- , black, lower part of front cupboard
F - Not assigned

Edition 10.2014
 Transporter Fitting Locations No. 807 / 5
1.2.1 724Earth point 4 for special
constructions and 725 Earth point 5 for
special constructions
A- 725 Earth point 5 for special constructions
B- 724 Earth point 4 for special constructions

1.2.2 721Earth point 1 for special

constructions
A- 721 Earth point 1 for special constructions

Note

View of kitchenette from rear

1.2.3 17-pin connector -T17b-

A - 17-pin connector -T17b-

Note

View of kitchenette from bottom and rear

Edition 10.2014
 Transporter Fitting Locations No. 807 / 6
1.2.4 Ambient temperature sender 2 -G249-
4 - Ambient temperature sender 2 -G249-
♦ on underbody at rear left

Edition 10.2014