Page 1/6

Safety data sheet

according to 1907/2006/EC, Article 31
Printing date 05.06.2015 Version number 1 Revision: 05.06.2015

SECTION 1: Identification of the substance/mixture and of the

company/undertaking
· 1.1 Product identifier
· Trade name: COOL-X
· 1.2 Relevant identified uses of the substance or mixture and uses advised against
No further relevant information available.
· Application of the substance / the mixture
Anticorrosion additive
Only for proper handling.
· 1.3 Details of the supplier of the safety data sheet
· Manufacturer/Supplier:
MOTOREX AG LANGENTHAL
Schmiertechnik
Bern-Zürich-Strasse 31
CH-4901 Langenthal
Tel. +41 (0)62 919 74 74
· Only representative in EU:
MOTOREX Deutschland AG, Bismarckstrasse 28, D-69198 Schriesheim
· Further information obtainable from: [email protected]
· 1.4 Emergency telephone number:
Toxicological Information Centre, CH-8028 Zurich,
[email protected],
T. +41 (0) 44 251 51 51

SECTION 2: Hazards identification

· 2.1 Classification of the substance or mixture
· Classification according to Regulation (EC) No 1272/2008
The product is not classified according to the CLP regulation.
· 2.2 Label elements
· Labelling according to Regulation (EC) No 1272/2008 Void
· Hazard pictograms Void
· Signal word Void
· Hazard statements Void
· Additional information:
Safety data sheet available on request.
· 2.3 Other hazards
· Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.

SECTION 3: Composition/information on ingredients

· 3.2 Chemical characterisation: Mixtures
· Description: Mixture of substances listed below with nonhazardous additions.
· Dangerous components:
CAS: 107-21-1 ethanediol 2.5-7.5%
EINECS: 203-473-3 Acute Tox. 4, H302
Reg.nr.: 01-2119456816-28
(Contd. on page 2)
GB

40.1.3
 Page 2/6
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 05.06.2015 Version number 1 Revision: 05.06.2015

Trade name: COOL-X

(Contd. of page 1)
CAS: 3164-85-0 potassium 2-ethylhexanoate 1-2.5%
EINECS: 221-625-7 Skin Irrit. 2, H315; Eye Irrit. 2, H319
CAS: 122-99-6 2-Phenoxyethanol 0.25-1%
EINECS: 204-589-7 Acute Tox. 4, H302; Eye Irrit. 2, H319
Reg.nr.: 01-2119488943-21
· Additional information: For the wording of the listed risk phrases refer to section 16.

SECTION 4: First aid measures

· 4.1 Description of first aid measures
· General information: No special measures required.
· After inhalation: Supply fresh air; consult doctor in case of complaints.
· After skin contact: Remove residues with soap and water.
· After eye contact: Rinse opened eye for several minutes under running water.
· After swallowing: Do not induce vomitting. Do not take in resorption stimulating agents.
· 4.2 Most important symptoms and effects, both acute and delayed
No further relevant information available.
· 4.3 Indication of any immediate medical attention and special treatment needed
No further relevant information available.

SECTION 5: Firefighting measures

· 5.1 Extinguishing media
· Suitable extinguishing agents:
CO2, powder or water spray. Fight larger fires with water spray or alcohol resistant foam.
· 5.2 Special hazards arising from the substance or mixture
No further relevant information available.
· 5.3 Advice for firefighters
· Protective equipment: No special measures required.

SECTION 6: Accidental release measures

· 6.1 Personal precautions, protective equipment and emergency procedures
Not required.
· 6.2 Environmental precautions:
Dilute with plenty of water.
Do not allow to enter sewers/ surface or ground water.
· 6.3 Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders,
sawdust).
· 6.4 Reference to other sections
No dangerous substances are released.
See Section 7 for information on safe handling.
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.

SECTION 7: Handling and storage

· 7.1 Precautions for safe handling No special measures required.
· Information about fire - and explosion protection: No special measures required.
(Contd. on page 3)
GB

40.1.3
 Page 3/6
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 05.06.2015 Version number 1 Revision: 05.06.2015

Trade name: COOL-X

(Contd. of page 2)

· 7.2 Conditions for safe storage, including any incompatibilities

· Storage:
· Requirements to be met by storerooms and receptacles: No special requirements.
· Information about storage in one common storage facility: Not required.
· Further information about storage conditions:
Store containers closed and protect against rain, dust, heat and other atmospheric
influences.
Avoid freezing.
· Storage class: 12
· 7.3 Specific end use(s) No further relevant information available.

SECTION 8: Exposure controls/personal protection

· Additional information about design of technical facilities: No further data; see item 7.
· 8.1 Control parameters
· Ingredients with limit values that require monitoring at the workplace:
107-21-1 ethanediol
WEL Short-term value: 104** mg/m³, 40** ppm
Long-term value: 10* 52** mg/m³, 20** ppm
Sk *particulate **vapour
· Additional information: The lists valid during the making were used as basis.
· 8.2 Exposure controls
· Personal protective equipment:
· General protective and hygienic measures:
The usual precautionary measures are to be adhered to when handling chemicals.
· Respiratory protection: Not required.
· Protection of hands:
The glove material has to be impermeable and resistant to the product/ the substance/ the
preparation.
Due to missing tests no recommendation to the glove material can be given for the product/
the preparation/ the chemical mixture.
Selection of the glove material on consideration of the penetration times, rates of diffusion
and the degradation
· Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on
further marks of quality and varies from manufacturer to manufacturer. As the product is a
preparation of several substances, the resistance of the glove material can not be
calculated in advance and has therefore to be checked prior to the application.
· Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective
gloves and has to be observed.
· Eye protection: Goggles recommended during refilling

SECTION 9: Physical and chemical properties

· 9.1 Information on basic physical and chemical properties
· General Information
· Appearance:
Form: Fluid
Colour: Green fluorescent
(Contd. on page 4)
GB

40.1.3
 Page 4/6
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 05.06.2015 Version number 1 Revision: 05.06.2015

Trade name: COOL-X

(Contd. of page 3)

· Odour: Characteristic
· Odour threshold: Not determined.
· pH-value at 20 °C: 8.6 (DIN 51369)
· Change in condition
Melting point/Melting range: Undetermined.
Boiling point/Boiling range: 100 °C (DIN EN ISO 3405)
· Flash point: Not applicable.
· Flammability (solid, gaseous): Not applicable.
· Ignition temperature:
Decomposition temperature: Not determined.
· Self-igniting: Product is not selfigniting.
· Danger of explosion: Product does not present an explosion hazard.
· Explosion limits:
Lower: Not determined.
Upper: Not determined.
· Vapour pressure at 20 °C: 23 hPa
· Density at 20 °C: 1.01 g/cm³ (ASTM D 4052)
· Relative density Not determined.
· Vapour density Not determined.
· Evaporation rate Not determined.
· Solubility in / Miscibility with
water: Fully miscible.
· Partition coefficient (n-octanol/water): Not determined.
· Viscosity:
Dynamic: Not determined.
Kinematic: Not determined.
· 9.2 Other information No further relevant information available.

SECTION 10: Stability and reactivity

· 10.1 Reactivity
· 10.2 Chemical stability
· Thermal decomposition / conditions to be avoided:
No decomposition if used according to specifications.
· 10.3 Possibility of hazardous reactions No dangerous reactions known.
· 10.4 Conditions to avoid No further relevant information available.
· 10.5 Incompatible materials: No further relevant information available.
· 10.6 Hazardous decomposition products: No dangerous decomposition products known.

SECTION 11: Toxicological information

· 11.1 Information on toxicological effects
· Acute toxicity:
· Primary irritant effect:
· on the skin: No irritant effect.
· on the eye: No irritating effect.
(Contd. on page 5)
GB

40.1.3
 Page 5/6
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 05.06.2015 Version number 1 Revision: 05.06.2015

Trade name: COOL-X

(Contd. of page 4)
· Sensitisation: No sensitising effects known.
· Additional toxicological information:
The product is not subject to classification according to the calculation method of the
General EU Classification Guidelines for Preparations as issued in the latest version.
When used and handled according to specifications, the product does not have any harmful
effects to our experience and the information provided to us.

SECTION 12: Ecological information

· 12.1 Toxicity
· Aquatic toxicity: No further relevant information available.
· 12.2 Persistence and degradability No further relevant information available.
· 12.3 Bioaccumulative potential No further relevant information available.
· 12.4 Mobility in soil No further relevant information available.
· Additional ecological information:
· General notes:
Water hazard class 1 (German Regulation) (Self-classification according VwVwS,
17.05.1999): slightly hazardous for water
Do not allow undiluted product or large quantities of it to reach ground water, water course
or sewage system.
· 12.5 Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.
· 12.6 Other adverse effects No further relevant information available.

SECTION 13: Disposal considerations

· 13.1 Waste treatment methods
· Recommendation Smaller quantities can be disposed of with household waste.
· European waste catalogue
12 01 09* machining emulsions and solutions free of halogens
· Uncleaned packaging:
· Recommendation: Disposal must be made according to official regulations.
· Recommended cleansing agents: Water, if necessary together with cleansing agents.

SECTION 14: Transport information

· 14.1 UN-Number
· ADR,ADN, ADN, IMDG, IATA Void
· 14.2 UN proper shipping name
· ADR,ADN, ADN, IMDG, IATA Void
· 14.3 Transport hazard class(es)
· ADR,ADN, ADN, IMDG, IATA
· Class Void
· 14.4 Packing group
· ADR,ADN, IMDG, IATA Void
· 14.5 Environmental hazards:
· Marine pollutant: No
(Contd. on page 6)
GB

40.1.3
 Page 6/6
Safety data sheet
according to 1907/2006/EC, Article 31
Printing date 05.06.2015 Version number 1 Revision: 05.06.2015

Trade name: COOL-X

(Contd. of page 5)

· 14.6 Special precautions for user Not applicable.

· 14.7 Transport in bulk according to Annex
II of MARPOL73/78 and the IBC Code Not applicable.
· UN "Model Regulation": -

SECTION 15: Regulatory information

· 15.1 Safety, health and environmental regulations/legislation specific for the
substance or mixture
No further relevant information available.
· 15.2 Chemical safety assessment:
A Chemical Safety Assessment has not been carried out.

SECTION 16: Other information

This information is based on our present knowledge. However, this shall not constitute a
guarantee for any specific product features and shall not establish a legally valid contractual
relationship.
· Relevant phrases
H302 Harmful if swallowed.
H315 Causes skin irritation.
H319 Causes serious eye irritation.
· Department issuing MSDS: Abteilung Produktsicherheit
· Abbreviations and acronyms:
Acute Tox. 4: Acute toxicity, Hazard Category 4
Skin Irrit. 2: Skin corrosion/irritation, Hazard Category 2
Eye Irrit. 2: Serious eye damage/eye irritation, Hazard Category 2
GB

40.1.3