AN UNDERGROUND GREENHOUSE YOU CAN GROW IN ALL YEAR

If eating Fresh Vegetables and Fruits Year Round is important to You and Your
Family, you might consider building an Underground Greenhouse. It will keep the
temperatures warmer in the Winter and help prevent overheating in the Summer;
making it possible to grow your garden vegetables year round.
For the vast majority of the country, 4 feet below the surface will stay between
50° to 60°F even if the weather above the ground gets to 10°F or colder. This is
what they call the thermal constant, and what the Underground Greenhouse is based
on.
The original design for an Underground Greenhouse was invented in Bolivia, and was
called a Walipini, an Aymara Indian word which means “a warm place.” A Walipini is
a rectangular shaped Greenhouse that is dug down 6-8 feet deep in the ground. The
longest area of the rectangle will face towards the south (in the Northern
Hemisphere) to take advantage of the most sunlight.
The design of the Underground Greenhouse isn’t that complicated, as it can be as
simple as a hole with plastic sheets laid on top. The roof seals in the heat and
insulates the area to keep a warm, moist environment for your fruits and
vegetables.
The location of your Walipini will depend on how big you want it to be. You’ll need
enough space to grow your plants and have a small area to walk into your
greenhouse. The bottom of the Greenhouse will need to be at least 5 feet above the
water table in your area. The recommended size for an Underground Greenhouse is 8 x
12 feet.
When planning where your Greenhouse will be located, remember that your roof will
need to receive light during the winter, also. This means that you will have to
make sure that trees or buildings don't block it during the winter time when the
sun is in the South. In most cases, your Underground Greenhouse should be set up
East to West, with the roof facing South to take advantage of the Winter Sun.
Once it's decided where your Underground Greenhouse will be located, you can start
digging. Plot out the area above ground to keep track of where you should be
digging. While you’re excavating, dig at least 2 feet deeper than your desired
depth. Keep your soil close by to help prop up the roof.
The walls of your Underground Greenhouse should have a minimum 6-inch slope from
the roof to the floor. This will greatly reduce the amount of crumbling and caving
that will occur with the soil. You can also layer the walls with a clay to prevent
erosion, or use bricks to stabilize the walls of the building.
While you’re digging the hole, dig an extra 2 feet below the desired depth. You’ll
fill this area with stone or gravel and then 8 inches of soil. Ideally, you’d lay
larger stones and gravel on the bottom layer and the gravel would become
progressively smaller until you reach the soil.
The bottom of the greenhouse should be slightly sloped from the center to the
edges. Along the perimeter, you should leave a space of 2-3 feet just filled with
gravel. This is designed to help the water drain more easily. Many people have also
created open gravel wells in the corners of the greenhouses that allows them to
collect the water. This will allow you to draw a bucket into the hole and pull out
water if you find you have too much.
Once the floor is filled in with the drainage system, and the soil required for
growing, the doors can be installed. Place the door frame at the base of the ramp
and fill in the areas around the door as much as possible with dirt and clay.
Filling in these gaps will prevent heat loss in your greenhouse.
Many times, people will use 2-inch door frames that have holes drilled into the top
middle and bottom of each side. They will then use wooden stakes, dowels or rebar
to secure the door frame into the soil wall.
The angle of the roof will make a big difference on the sun’s ability to heat your
greenhouse. Ideally, the roof should be facing directly at the winter solstice at a
90 angle. This angle will maximize the heat during the winter solstice and minimize
the heat during the summer solstice.
Now, you can use that extra soil that you have left over to create a berm. The berm
is basically an extension of the north wall of the greenhouse. This allows you to
control the angle of the roof by adding or taking away dirt. Build up the berm to
continue the slope that you used on the wall. If you’re using bricks – continue
using them on the berm.
The most economical, durable material for your roof is 4-inch PVC pipe. Using PVC
elbow pieces, joiners, etc, you can create a flat roof frame that will cover your
Underground Greenhouse.
After you’ve created a PVC frame, lay it in place on the top of your hole. Then lay
plastic sheeting across the top of the frame and make sure that it extends past the
edge of the frame by at least 1 foot. This flap will prevent run off water from the
roof from running back into the greenhouse itself.
Once the plastic material is put on top of the roof frame, move inside and tack
another layer of plastic wrap along the inside of the roof frame. This internal
plastic sheeting will create a 4-inch barrier between the inside and outside of the
roof, and will act as an insulator that will keep the heat in more effectively.
You’ll want to make sure that you leave a few inches of plastic hanging down on the
lower (south) end of your roof. This will force moisture that collects on the roof
to drip off above the drainage system or on top of your plants instead of at the
base of the roof. If you allow the moisture to run to the base of the roof frame,
it may affect the soil at that location and break down your wall, etc.
Ventilation is always crucial. You have 3 options, such as: Installing two doors,
one at each end; installing a vent roughly the size of the door at the top of the
back wall; or installing a chimney at the center of the back wall. Good Luck on
your Greenhouse.
When you are ready for some great Small Farm-Grown Heirloom Seeds for your
Greenhouse, here at THE SEED GUY...we have our 60 Variety Heirloom Seed Package
that is Non GMO, all individually packaged, and then put in a 10 x 14 silver mylar
bag. There are 34,000 Seeds in the package, fresh from the New Fall 2022 Harvest,
with a 89-93% germination rate. You get 49 Vegetable Seed varieties, and then 11
Herb Seed varieties.(This includes the Wonder Herb Black Cumin or Nigella Sativa)
SALE Priced Now at $79 Until Midnight Jan 1st. You can see the Seed varieties in
this package, and Order on our website at--) https://theseedguy.net/.../50-60-
variety-heirloom-seed... ;
You can also call us at 918-352-8800 to ask questions or Place an Order, and we are
available 7 days a week, and up to 10:00 pm every night.
If you LIKE US on our Facebook page, you will be able to see more of our great
Gardening Articles, New Seed Offerings and healthy Juice Recipes. Thank you and God
Bless You and Your Family. 🙂 https://www.facebook.com/theseedguy