RENAULT 21, 2.

0 TXi & CAT (X48Q/Y/R)

1989 to 1994
Engine & Running Torque Notes &
Fuel Ignition Electrical Capacities
Cooling gear settings Illustrations

RENP2102052

Automotive
Technical

DATA Click on one of the

buttons above to view
data for this car. To

BOOK return to this screen and

make another choice,
click anywhere on the
data screen.

MENU HELP

Engine and cooling system 21, 2.0 TXi & CAT (X48Q/Y/R) 1989 to 1994
Type J7R-G7-54 (12 valve) 104kW1
Capacity (cm3) / number of cylinders 1995 / 4
Compression ratio / pressure bar 9.3 / _
Oil pressure bar 1.3 [3.0]
Oil temperature ºC 80
Valve clearance - inlet mm 0.15 to 0.20
Valve clearance - exhaust mm 0.20 to 0.25
Firing order 1-3-4-2
No 1 cylinder position FE
Thermostat opening temperature ºC 89 to 101
Radiator cap pressure bar 1.2

Fuel system 21, 2.0 TXi & CAT (X48Q/Y/R) 1989 to 1994
Idle speed - manual [auto] rpm 850±75. CAT: 800±50 N/A
Fast idle speed - manual [auto] rpm _
CO @ idle speed [3000 rpm] - see page VI % ≤0.3 N/A
HC @ idle speed [3000 rpm] - see page VI ppm ≤200
CO2 @ idle speed [3000 rpm] - see page VI % ≥14.5
O2 @ idle speed [3000 rpm] - see page VI % _
Carburettor / fuel injection Renix
Type / ref Fenix 3B MPI
Main jet / needle _
Injection pressure bar 2.5±0.2
Pump pressure bar 3.0±0.2
Octane rating RON 98[E 95 RON]2

Ignition system 21, 2.0 TXi & CAT (X48Q/Y/R) 1989 to 1994
Type Computerized
Ignition coil Renix
Primary resistance ohms 0.4 to 0.8
Ballast resistor ohms _
Voltage - Tmnl 15(+) to earth V _
Distributor Renix
Points gap (air gap) mm _
Dwell angle º (%) _
Condenser capacity µF _
Rotation _
Ignition timing - basic [static º Crankshaft @ rpm Computer control
V = Vacuum NV = No Vacuum _
Total ignition advance º Crankshaft @ rpm _
º Crankshaft @ rpm _
º Crankshaft @ rpm _
Centrifugal check. º Crankshaft @ rpm Computer control
º Crankshaft @ rpm _
º Crankshaft @ rpm _
Vacuum range check mbar Computer control
Maximum vacuum advance º Crankshaft _
Spark plugs Eyquem/Champion
Type FC62LS3 / C7YCC
Electrode gap mm 1.20 N/A

Electrical system 21, 2.0 TXi & CAT (X48Q/Y/R) 1989 to 1994
Battery V / CC / RC 12 / 210 / 65
Alternator voltage / full load current / engine rpm 13.5 to 14.8 / _ / 3000
Starter motor current / voltage - cranking A/V _
Starter motor current / voltage - locked A/V _

Running gear 21, 2.0 TXi & CAT (X48Q/Y/R) 1989 to 1994
Brakes -
Front (min. friction material thickness) mm 6.0 with backing
Rear (min. friction material thickness) mm 6.0 with backing
Tyres
Saloon Size 185/65x14: 185/55x15
Estate / Van Size _
Pressure - front / rear - Saloon bar 2.3 / 2.3
Pressure - front / rear - Estate / Van bar _
Front suspension / wheel alignment
Toe-in (+) / Toe-out (–) mm [º] -2.0±1.0
Camber -35’±30’
Castor +2°±30’
King pin inclination +13°5’±30’
Rear suspension / wheel alignment
Toe-in (+) / Toe-out (–) mm [º] +2.0 to 5.0
Camber -20’±10’

Torque wrench settings 21, 2.0 TXi & CAT (X48Q/Y/R) 1989 to 1994
Cylinder head - stage 1 Nm 20
Cylinder head - stage 2 Nm + 80° + 80°
Cylinder head - stage 3 Nm Run for 15 mins.
Cylinder head - stage 4 Nm Cool for 3 hours, then + 20°
Big-end bearings Nm 45 to 50
Main bearings Nm 88 to 98
Clutch cover Nm 25
Flywheel [driveplate] Nm 60 [65 to 70]
Front hubs Nm 250
Rear hubs Nm 160. 4x4: 210
Wheel nuts / bolts Nm 90
Spark plugs Nm 28±2

Capacities 21, 2.0 TXi & CAT (X48Q/Y/R) 1989 to 1994

Engine oil & filter litres 5.5
Gearbox - 4-speed [5-speed] litres 2.2. 4x4: 3.35
Automatic transmission - refill litres _
Final drive litres 4x4 rear: 1.3
Cooling system litres 7.1
Fuel tank litres 66. 4x4: 62

Notes and Illustrations

CAT: J7R-7-40
1

CAT: 95 [U]
2

1: Idle speed 2: CO / Mixture

1995 cm3, 12V Renix R electronic