SAFETY DATA SHEET 22-04-2022
Engine Degreaser
ACCORDING TO THE OCCUPATIONAL SAFETY AND HEALTH (CLASSIFICATION, LABELLING AND SAFETY DATA
SHEET OF HAZARDOUS CHEMICALS) REGULATIONS 2013 (CLASS REGULATIONS)
SECTION 1: IDENTIFICATION OF THE HAZARDOUS CHEMICAL AND OF THE SUPPLIER
1.1 Product identifier
Product Name Engine Degreaser
1.2 Other means of identification
Product code Not known.
Alternative names Not known.
Synonyms Not known.
1.3 Recommended use of the chemical and restrictions on use
Identified Use(s) Cleaning agent
Uses Advised Against Not known.
1.4 Details of principal suppliers
Company Identification YKF ACTIVE SDN BHD
Address of Supplier No. 26, Ground Floor, Jalan Perai Jaya 6,
Bandar Perai Jaya, 13600 Perai, Penang
Telephone 04-3809492
E-mail [email protected]
1.5 Emergency telephone number
Emergency Phone No. 016-4401455
Contact Mr.Jason
SECTION 2: HAZARDS IDENTIFICATION
2.1 Classification of the substance or mixture
Occupational Safety and Health Skin Corr. 1B :Causes severe skin burns and eye damage.
(Classification, Labelling and Safety Data Eye Dam. 1 :Causes serious eye damage.
Sheet of Hazardous Chemicals)
Regulations 2013 (CLASS Regulations)
2.2 Label elements
Product Name Engine Degreaser
Hazard Pictogram(s)
GHS05
Signal Word(s) Danger
Hazard Statement(s) H314: Causes severe skin burns and eye damage.
Precautionary Statement(s) P260: Do not breathe vapour.
P264: Wash hands and exposed skin thoroughly after handling.
P280: Wear protective gloves/protective clothing/eye protection/face protection.
P301+P330+P331: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting.
P303+P361+P353: IF ON SKIN (or hair): Take off immediately all contaminated
clothing. Rinse skin with water.
P305+P351+P338: IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing.
2.3 Other hazards which do not result in classification
None known.
2.4 Additional Information
For full text of H/P Statements see section 16.
SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS
3.1 Substances
Not applicable.
3.2 Mixtures
HAZARDOUS INGREDIENT(S) CAS No. %W/W Hazard Statement(s) Hazard Pictogram(s)
2-butoxyethanol 111-76-2 5 - 10 Acute Tox. 4 H302 GHS07
Skin Irrit. 2 H315
Eye Irrit. 2 H319
Acute Tox. 4 H332
2-(2-butoxyethoxy)ethanol 112-34-5 5 - 10 Eye Irrit. 2 H319 GHS07
Page: 1 - 6 Revision: 1
SAFETY DATA SHEET 22-04-2022
Engine Degreaser
Silicic acid (H2SiO3), disodium salt, pentahydrate 10213-79-3 1-5 Met. Corr. 1 H290 GHS05
Skin Corr. 1B H314 GHS07
STOT SE 3 H335
Benzenesulfonic acid, C10-14-alkyl derivs., 69669-44-9 1-5 Acute Tox. 4 H302 GHS07
sodium salts Skin Irrit. 2 H315
Eye Irrit. 2 H319
For full text of H/P Statements see section 16.
SECTION 4: FIRST AID MEASURES
4.1 Description of first aid measures
Inhalation If breathing is difficult, remove victim to fresh air and keep at rest in a position
comfortable for breathing.
Skin Contact Take off immediately all contaminated clothing. Rinse skin with water. Wash
contaminated clothing before reuse. Immediately call a POISON CENTRE/doctor.
Eye Contact Rinse cautiously with water for several minutes. Remove contact lenses, if present
and easy to do. Continue rinsing. Immediately call a POISON CENTRE/doctor.
Ingestion Wash out mouth with water.
4.2 Most important symptoms/effects, acute and delayed
Causes severe skin burns and eye damage.
4.3 Indication of immediate medical attention and special treatment needed, if necessary
Unlikely to be required but if necessary treat symptomatically.
SECTION 5: FIREFIGHTING MEASURES
5.1 Extinguishing media
Suitable Extinguishing media As appropriate for surrounding fire.
Unsuitable extinguishing media None known.
5.2 Special hazards arising from the chemical
May decompose in a fire, giving off toxic and irritant vapours.
5.3 Special protective equipment and precautions for fire fighters
Fire fighters should wear complete protective clothing including self-contained
breathing apparatus.
SECTION 6: ACCIDENTAL RELEASE MEASURES
6.1 Personal precautions, protective equipment and emergency procedures
Provide adequate ventilation. Wear suitable protective clothing, gloves and eye/face
protection.
6.2 Environmental precautions
Do not release large quantities into the surface water or into drains.
6.3 Methods and material for containment and cleaning up
Adsorb spillages onto sand, earth or any suitable adsorbent material. Transfer to a
container for disposal.
6.4 Reference to other sections
See Also Section 8, 13.
SECTION 7: HANDLING AND STORAGE
7.1 Precautions for safe handling
Do not breathe vapour. Wash hands and exposed skin thoroughly after handling.
Wear protective gloves/protective clothing/eye protection/face protection. Avoid
contact with skin and eyes.
7.2 Conditions for safe storage, including any incompatibilities
Storage temperature Ambient.
Storage life Stable under normal conditions.
Incompatible materials None known.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
8.1 Control parameters
8.1.1 Occupational Exposure Limits
SUBSTANCE. CAS No. LTEL (8 hr TWA ppm) LTEL (8 hr TWA mg/m³) STEL (ppm) STEL (mg/m³) Note
2-butoxyethanol 111-76-2 20 96.7 skin
Source: Occupational Safety and Health (Use and Standards of Exposure of Chemicals Hazardous to Health) Regulations 2000, Malaysia
Page: 2 - 6 Revision: 1
SAFETY DATA SHEET 22-04-2022
Engine Degreaser
Remark Notes
skin Refers to the possible contribution to overall exposure by the cutaneous route including the mucous membranes and eyes, either through
airborne, or more particularly, through direct contact with material.
8.2 Exposure controls
8.2.1. Appropriate engineering controls Ensure adequate ventilation. A washing facility/water for eye and skin cleaning
purposes should be present.
8.2.2. Individual protection measures,
such as personal protective equipment
Eye Protection Wear eye protection with side protection (EN166).
Skin protection Wear protective clothing and gloves: Impervious gloves (EN 374).
Breakthrough time of the glove material: refer to the information provided by the
gloves’ producer.
Respiratory protection Normally no personal respiratory protection is necessary.
Thermal hazards Not applicable.
8.2.3. Environmental Exposure Controls Do not release large quantities into the surface water or into drains.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
9.1 Information on basic physical and chemical properties
Appearance Liquid.
Colour: Colourless.
Odour Characteristic.
Odour threshold Not known.
pH 12-13
Melting point/freezing point Not known.
Initial boiling point and boiling range Not known.
Flash Point Not known.
Evaporation rate Not known.
Flammability (solid, gas) Not applicable.
Upper/lower flammability or explosive Not known.
limits
Vapour pressure Not known.
Vapour density Not known.
Relative density Not known.
Solubility(ies) Solubility (Water): Soluble.
Solubility (Other): Not known.
Partition coefficient: n-octanol/water Not known.
Auto-ignition temperature Not known.
Decomposition Temperature (°C) Not known.
Viscosity Not known.
9.2 Other information
None.
SECTION 10: STABILITY AND REACTIVITY
10.1 Reactivity
Stable under normal conditions.
10.2 Chemical Stability
Stable under normal conditions.
10.3 Possibility of hazardous reactions
No hazardous reactions known if used for its intended purpose.
Page: 3 - 6 Revision: 1
SAFETY DATA SHEET 22-04-2022
Engine Degreaser
10.4 Conditions to avoid
Heat and direct sunlight.
10.5 Incompatible materials
Not known.
10.6 Hazardous decomposition products
No hazardous decomposition products known.
SECTION 11: TOXICOLOGICAL INFORMATION
11.1 Information on toxicological effects
Acute toxicity Low acute toxicity
Skin corrosion/irritation Causes severe skin burns. No data.
Serious eye damage/irritation Causes serious eye damage. No data.
Skin sensitization data It is not a skin sensitiser.
Respiratory sensitization data Not classified.
Germ cell mutagenicity There is no evidence of mutagenic potential.
Carcinogenicity No evidence of carcinogenicity.
Reproductive toxicity No evidence of reproductive effects.
Lactation Not classified.
STOT - single exposure None anticipated.
STOT - repeated exposure None anticipated.
Aspiration hazard Not classified.
11.2 Symptoms related to the physical, chemical and toxicological characteristics
Eyes/Skin Contact: Redness, Irritation.
11.3 Delayed and immediate effects and also chronic affects from short and long term exposure
Causes severe skin burns and eye damage.
11.4 Numerical measures of toxicity (such as acute toxicity estimates)
None.
SECTION 12: ECOLOGICAL INFORMATION
12.1 Ecotoxicity
Low toxicity to aquatic organisms.
12.2 Persistence and degradability
No information on this formulation.
12.3 Bioaccumulative potential
No information on this formulation.
12.4 Mobility in soil
Soluble in water. The product is predicted to have high mobility in soil.
12.5 Other adverse effects
Not known.
SECTION 13: DISPOSAL CONSIDERATIONS
13.1 Disposal Method
Dispose of this material and its container to hazardous or special waste collection
point. Dispose of contents in accordance with local, state or national legislation.
SECTION 14: TRANSPORT INFORMATION
14.1 UN number
UN No. 1760
14.2 UN proper shipping name
UN proper shipping name CORROSIVE LIQUID, N.O.S. (Contains: Silicic acid (H2SiO3), disodium salt,
pentahydrate)
14.3 Transport hazard class(es)
Class 8
Labels
Labels 8
14.4 Packing Group, if applicable
Packing group II
14.5 Environmental hazards
Environmental hazards Not classified as a Marine Pollutant.
Page: 4 - 6 Revision: 1
SAFETY DATA SHEET 22-04-2022
Engine Degreaser
14.6 Transport in bulk according to Annex II of Marpol and the IBC Code
No information available
14.7 Special precautions for user
Special precautions for user Not known.
SECTION 15: REGULATORY INFORMATION
This SDS has been prepared in accordance to The Industry Code of Practice on Chemical Classification and Hazard
Communication 2019 (ICOP) and The Occupational Safety and Health (Classification, Labelling and Safety Data Sheet of
Hazardous Chemicals) Regulations 2013 (CLASS Regulations).
15.1 Safety, health and environmental regulations specific for the product in question
Part 1 List of Classified Chemical, ICOP 112-34-5
SECTION 16: OTHER INFORMATION
The following sections contain revisions or new statements: 1-16
Date of preparation 22/04/2022
Date of revision -
LEGEND
Hazard Pictogram(s)
GHS05
GHS07: GHS: Exclamation mark
Hazard classification Met. Corr. 1 : Substance or mixture corrosive to metals, Category 1
Acute Tox. 4 : Acute toxicity, Category 4
Skin Corr. 1B : Skin corrosion/irritation, Category 1B
Skin Irrit. 2 : Skin corrosion/irritation, Category 2
Eye Dam. 1 : Serious eye damage/irritation, Category 1
Eye Irrit. 2 : Serious eye damage/irritation, Category 2
Acute Tox. 4 : Acute toxicity, Category 4
STOT SE 3 : Specific target organ toxicity — single exposure, Category 3
Hazard Statement(s) H290: May be corrosive to metals.
H302: Harmful if swallowed.
H314: Causes severe skin burns and eye damage.
H315: Causes skin irritation.
H318: Causes serious eye damage.
H319: Causes serious eye irritation.
H332: Harmful if inhaled.
H335: May cause respiratory irritation.
Precautionary Statement(s) P260: Do not breathe vapour.
P264: Wash hands and exposed skin thoroughly after handling.
P280: Wear protective gloves/protective clothing/eye protection/face protection.
P301+P330+P331: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting.
P303+P361+P353: IF ON SKIN (or hair): Take off immediately all contaminated
clothing. Rinse skin with water.
P305+P351+P338: IF IN EYES: Rinse cautiously with water for several minutes.
Remove contact lenses, if present and easy to do. Continue rinsing.
P310: Immediately call a POISON CENTRE/doctor.
P363: Wash contaminated clothing before reuse.
P501: Dispose of contents in accordance with local, state or national legislation.
PP304+P340: Remove person to fresh air and keep comfortable for breathing.
Acronyms ATE : Acute Toxicity Estimate
CAS : Chemical Abstracts Service
LTEL : Long term exposure limit
STEL : Short term exposure limit
STOT : Specific Target Organ Toxicity
Page: 5 - 6 Revision: 1
SAFETY DATA SHEET 22-04-2022
Engine Degreaser
Other information deems necessary by a None.
supplier
Key literature references and sources for Occupational Safety and Health (Classification, Labelling and Safety Data Sheet of
data used to compile the SDS Hazardous Chemicals) Regulations 2013 (CLASS Regulations)
Disclaimers Information contained in this publication or as otherwise supplied to Users is believed
to be accurate and is given in good faith, but it is for the Users to satisfy themselves
of the suitability of the product for their own particular purpose.
Mutiara Chemie Venture gives no warranty as to the fitness of the product for any
particular purpose and any implied warranty or condition (statutory or otherwise) is
excluded except to the extent that exclusion is prevented by law.
Mutiara Chemie Venture accepts no liability for loss or damage (other than that
arising from death or personal injury caused by defective product, if proved), resulting
from reliance on this information. Freedom under Patents, Copyright and Designs
cannot be assumed.
Page: 6 - 6 Revision: 1
