Component Identifiers (CID¹) Wire Description Component Location

Module Identifier (MID²) Wire Wire Wire Wire Schematic Machine Schematic Machine
RENR7307-01 Harness And Wire Electrical Schematic Symbols
Description Description Component Component
Number Color Number Color Location Location Location Location June 2007
Engine Control System Power Circuits Lighting Circuits Cont.
A/C Unit I-7 A Sensor - Intake Air Temperature B-16 H
Symbols
(MID No. 036) 101 RD Bat (+) 638 WH Rotary Beacon
Alarm - Action F-2 A Sensor - Oil Pressure D-16 H
CID Component 102 BU Hd Lmp 645 RD Headlamp Relay
Alarm - Travel B-11 1 Sensor - Pump Pressure C-14 24
0001 Injector Cylinder 1 103 RD ET CONN / Dome Lamp / Monitor / Radio / Service Meter 646 RD Light Sw To Front Flood Relay
Alternator H-18 2 Sensor - Speed H-18 25
0002 Injector Cylinder 2 105 RD Key Sw 684 RD Cab Flood Lamp T
109 RD Alt Output (+) Term. A623 BU Right Cab Flood Lamp Sw To Relay Bateries I-18 D Sensor - Swing Pump Pressure C-14 26
0003 Injector Cylinder 3
Control Circuits Breaker - Alternator / Start Relay H-15 D Sensor - Turbo Outlet Pressure C-16 H Pressure Temperature Level Flow Circuit Breaker
110 RD Timer Relay
0004 Injector Cylinder 4
112 PU Main Power Rly Output 709 OR Sensor Power Supply Control - Engine F-18 H Sensor - Water Seperator Level F-15 8 Symbol Symbol Symbol Symbol Symbol
0005 Injector Cylinder 5 Control - Gateway Worldview H-6 4 Sensors - Oil Temperature B-16 H
113 OR Monitor Panel B+ Switched 788 YL Eng Speed (+)
0006 Injector Cylinder 6 114 RD Warning Horn (forward) A755 PK Throttle Sw #1 Control - Valve E-8 6 Service Meter E-2 A Symbols and Definitions
0091 Throttle Position Switch 115 RD Cab Lamp Relay A756 BU Throttle Sw #2 Control - Wiper E-2 A Solenoid - 1 AP Control Valve A-16 H
0094 Fuel Pressure Sensor 118 GY Wiper Control A757 GY Throttle Sw #3 Control Handle - LH L-2 C Solenoid - A/C Clutch H-18 F Fuse - A component in an electrical circuit that will open the circuit if too much current flows
0100 Engine Oil Pressure Sensor 120 YL Converter A758 BR Throttle Sw #4 Control Handle - RH J-1 B Solenoid - Auto Reverse Fan A-13 9
through it.
0102 Boost Pressure Sensor 123 WH Seat Heater Switch A768 BU Pump Control Valve #1 (+) Converters - 12v 7A H-8 5 Solenoid - Boom Anti-Drift A-14 F Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
0110 Engine Coolant Temperature Sensor 124 GN A/C Unit Switched B+ E789 PU Hex Machine Cntl Sol Return #1
Diode - Backup (1) I-13 D Solenoid - Boom Extend A-10 F circle indicates that the component has screw terminals and a wire can be disconnected from it.
125 RD A/C Unit E790 PK Hex Machine Cntl Sol Return #2
0168 System Voltage Diode - Backup (2) I-13 D Solenoid - Boom Retract B-14 F
127 OR Air Suspension F716 WH Shutdown
0172 Intake Manifold Air Temperature Sensor Diode - Backup (3) L-10 D Solenoid - Bucket Extend A-10 F Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
129 BU Cigar Lighter F717 YL Throttle Backup (Accelerate)
0174 Fuel Temperature Sensor Diode - Backup (4) K-11 D Solenoid - Bucket Retract A-14 F No circle indicates that the wire cannot be disconnected from the component.
130 RD Implement / Valve Control F718 BU Throttle Backup (Decelerate)
0190 Engine Speed Sensor 131 RD Implement / Valve Control H704 PK Impl Cont Reversing Fan Sol Diode - Chassis Lamp K-16 D Solenoid - Counter Weight Removal Control C-15 29
0248 Cat Data Link 135 BU Converter Output (24/12 Volt) H716 WH Impl Cont Sol Return Diode - Main Relay K-16 D Solenoid - Extend A-10 F Ground (Wired): This indicates that the component is connected to a grounded wire. The
0261 Engine Timing/Calibration 139 OR Radio Mute Sw. H733 BU Hex Backup Pump Resistor To Diode Diode - Refueling Relay B-6 18 Solenoid - Hydraulic Lock A-13 F grounded wire is fastened to the machine.
0262 5 Volt DC Supply 140 BU Auto Lube Circuit M732 OR MSS Relay 2 Diode - Start Relay J-13 D Solenoid - LH Front Travel A-10 F
0268 Programable Parameters 147 PU Pump & OLWD Sensor Power M733 PK MSS Relay 1 Fuse Block K-15 D Solenoid - LH Rear Travel B-14 F
Ground (Case): This indicates that the component does not have a wire connected to ground.
0274 Atmosphereic Pressure Sensor 148 WH Boom Lamp Relay 2 X738 PK Return Filter Sw. To Controller Indicator Unit I-1 B Solenoid - LH Swing B-8 F
It is grounded by being fastened to the machine.
149 PU Boom Lamp Relay 1 801 PK Auto Lube Relay Joystick - LH L-3 C Solenoid - Lowering Check Boom A-11 F
0291 Engine Cooling Fan Solenoid
150 RD Neutral Start Limit Switch 892 BR Cat Data Link (-) Joystick - RH J-2 B Solenoid - Lowering Check Stick A-11 F
0342 Secondary Engine Speed Sensor
151 GN Neutral Start Limit Switch 893 GN Cat Data Link (+) Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
2417 Start Aid Solenoid Monitor F-1 A Solenoid - Neutral Flow Bypass A-14 F
154 RD Neutral Start Limit Switch F853 BR Travel Speed contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Motor - A/C Condenser E-15 11 Solenoid - PS Pressure A-13 F
Implement / Pump Control System
365C Excavator
160 PU Chassis Lamp Relay F856 GN Boom Valve Driver
Motor - Auto Lube Pump C-4 14 Solenoid - Radiator Fan Speed Control B-14 30
(MID No. 039) 168 RD Refueling Power Relay Power F859 GY Backup Resistor - Boom
Motor - ELE Lube Pump C-4 15 Solenoid - Retract A-14 F Sender: A component that is used with a temperature or pressure gauge. The sender
172 RD Gateway Worldview Module / MSS / Product Link F874 PK Switch To Timer Input
CID Component Motor - Refueling Pump B-6 18 Solenoid - RH Front Travel B-10 F measures the temperature or pressure. Its resistance changes to give an indication to

& 365C Front Shovel

175 RD A/C Unit F889 WH Throttle Position Feedback T
0096 Fuel Level Sender Motor - Starter G-18 12 Solenoid - RH Rear Travel B-14 F the gauge of the temperature or pressure.
176 YL Aux Ckt H807 YL On/off Driver Return (1-8)
0110 Engine Coolant Temperature Sensor 179 BU Converter K847 PU Stem 3 Retract Switch Motor - Washer I-9 13 Solenoid - RH Swing B-8 F

Electrical System
0190 Engine Speed Sensor 180 GN Aux Ckt K848 WH Stem 4 Retract Switch Motor - Wiper K-1 A Solenoid - Start Aid G-15 31 Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.
0291 Engine Cooling Fan Solenoid 196 BU Aux Ckt L885 BU Switch Panel Option Switch Pedal - Center L-1 G Solenoid - Stick Anti-Drift B-10 F It has a coil that makes an electromagnet when current flows through it. The
0295 Control Module 199 OR Action Alarm / Beacon Relay L886 BR Switch Panel Option Switch Pedal - LH L-1 G Solenoid - Stick Extend A-10 F electromagnet can open or close the switch part of the relay.
0374 Swing Brake Solenoid Ground Circuits L887 PK Switch Panel Option Relay Pedal - RH K-1 G Solenoid - Stick Retract B-14 F
0376 Travel Alarm 200 BK Main Chassis 998 BR Digital Sensor Return Relay - Auto Lube J-13 D Solenoid - Swing Brake D-10 F Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
0379 Auto-Lube Pressure Sensor 210
229
BK
BK
Converter Output (24/12 Volt)
Bat (-)
C904
E997
GN
BR
MSS Relay 2
Hydraulic Lock
Relay - Beacon K-11 D Solenoid - Swing Pump Swash C-14 32 ELC1-UP coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.
0466 Left Track Steering Pedal Position Sensor Relay - Boom Lamp Relay (1) I-16 D Solenoid - System Pressure A-11 F
0467 Right Track Steering Pedal Position Sensor
235 BK Electronic Pump Ctrl Gnd E998 YL Radiator Fan Solenoid
Relay - Boom Lamp Relay (2) H-16 D Solenoid - Travel Speed Shift A-13 F MEM1-UP
251 YL CAN Data Link (-) G976 BU Water Separator Sensor MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is
0485 Engine Fan Reversing Solenoid 261 GN CAN Data Link (+) K907 BU Swing Brake Sol
Relay - Cab Lamp
Relay - Chassis Lamp
K-16
K-16
D
D
Solenoids - Injectors 1 - 6
Switch - Air Cleaner
D-16
F-15
H
33
FEN1-UP activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
0558 Auto-Lube Relay Basic Machine Circuits K909 BU Backup Sw that make electromagnet when current flows through them. It also has an internal switch that places
0586 Engine Speed Dial Switch 304 WH Starter Relay No. 1 Output K924 YL Safety Lock Solenoid Relay - Horn J-16 D Switch - Aux 1 Way / 2 Way Limit (1) C-11 10 PAR1-UP the latch coil circuit open at the time the coil latches.
0588 Monitoring System Display 306 GN Starter Relay Coil To Neut Start Sw Or Key Sw K927 BU Solenoid Return 1 Relay - Hydraulic Lock Solenoid J-16 D Switch - Aux 1 Way / 2 Way Limit (2) B-11 16
0590 Engine Control Module 307 OR Key Sw To Neutral Start Sw Or Vmis Sensor Module K928 GN Stick Sol Retract Relay - Lamp Delay Timer L-13 D Switch - Backup Boom K-3 C MCS1-UP
0598 Travel Speed Solenoid 308 YL Main Power Relay Coil K929 GN Bucket Sol Retract Relay - Main K-14 D Switch - Backup EPR Valve H-3 B
MCY1-UP Harness and Wire Symbols
310 PU Start Aid Sw To Start Aid Sol K930 GN Swing Sol Extend Relay - MSS (1) K-13 D Switch - Backup Governor H-2 B
0600 Hydraulic Oil Temperature Sensor
0790 Swing Pump (Outlet)Pressure Sensor
317 YL Start Aid Relay To Start Aid Sol K931 GN Bucket Sol Extend Relay - MSS (2) K-13 D Switch - Coolant Level F-15 37 1 Deutsch connector: Typical representation 1 Sure-Seal connector: Typical representation
320 RD Horn Relay Coil To Sw K932 BU Swing Sol Left of a Deutsch connector. The plug contains all of a Sure-Seal connector. The plug and receptacle
0864 Variable Implement Hydraulic Pump Pressure Sensor
Relay - Neutral Start I-16 D Switch - Counter Weight Removal C-15 38 2 sockets and the receptacle contains all pins. 2 contain both pins and sockets.
321 BR Backup Alarm Lamp Travel Alarm K934 BR Swing Sol Right Relay - Refueling (1) A-6 18 Switch - Disconnect H-16 D
1118 Neutral Flow Bypass Solenoid 322 GY Warning Horn (forward) K943 OR Travel Left Sol Rear Relay - Refueling (2) A-6 55 Switch - Engine Oil Level H-18 39 Harness Identification Letter(s):
1119 Boom Anti-Drift Solenoid 323 WH Fuel Pump Power K944 YL Travel Left Sol Front Wire, Cable, or Harness Assembly Identification: (A, B, C, ..., AA, AB, AC, ...)
Relay - Refueling Power B-6 54 Switch - Horn L-3 C Includes Harness Identification Letters and Harness
1120 Stick Anti-Drift Solenoid 325 PK Fuel Pump Relay Cut-out K945 GY Resistor To Left Backup Sw Harness Connector Serialization Code: The "C" stands
Relay - Start I-11 D Switch - Hydraulic Oil Filter (1) A-7 E Connector Serialization Codes
1121 Front System High Pressure Solenoid 329 YL Fuel Pump To Sw K946 OR Travel Right Sol Rear for "Connector" and the number indicates which
Relay - Start Aid I-16 D Switch - Hydraulic Oil Level A-7 E connector in the harness. (C1, C2, C3, .....)
1125 Left Hand Lever Forward/Backward Position Sensor 365 YL Fuel Pump Relay To Switch K947 YL Travel Right Sol Front Part Number for
A346 BU MSS Relay 2 K948 GY Resistor To Right Backup Sw
Relay - Timer L-16 D Switch - Key I-1 B C-C4 AG-C3 Connector Plug AG-C4 L-C12 Part Number For
1126 Left Hand Lever Left/Right Position Sensor 111-7898 3E-5179
A347 GN MSS Relay 1 K949 OR Boom Retract Sol Resistor - Backup LH Travel L-10 D Switch - LH Backup Travel K-3 C 130-6795 130-6795 Connector Recepticle
1127 Right Hand Lever Forward/Backward Position Sensor
Monitoring Circuits K950 YL Boom Extend Sol Resistor - Backup RH Travel K-10 D Switch - Manual Lube D-3 A 1
1128 Right Hand Lever Left/Right Position Sensor 325-AG135 PK-14 5A
403 GN Alternator (r) Term. K951 GY Resistor To Boom Backup Sw Resistor - Boom Backup L-11 D Switch - Neutral Start Limit L-3 C
1129 Right Side Attachment Pedal Sensor Pin Socket Fuse
405 GY Oil Press. (low Setting) K952 BR Sol Return 3 Resistor - Boom Down Backup L-16 D Switch - OLWD Warning Device D-4 A Receptacle
1130 Left Side Attachment Pedal Sensor Pin or Socket (5 Amps)
410 WH Action Alarm L919 YL Manual Lube Sw Resistor - CAN E-8 6 Switch - One Touch Low Idle J-2 B Single Wire
Number
9X-1123
1131 Joystick Switch # 1 Connector
412 BU Coolant Level Sw. L972 BU Low Idle Sw Resistor - CAN E-1 A Switch - Radio Mute D-3 A Component
1132 Joystick Switch #4 430 BU Opr Mon Air Filter L976 GN Excavator Fuel Pump Switch Sender - Hydraulic Oil Temperature A-7 E Switch - Refueling Level C-6 40 Part Number
Plug
1138 Boom Cylinder Rod Retract Solenoid 487 OR Hyd Oil Flow Sw L982 PK Counterweight Removal Control Solenoid Sensor - Atmospheric Pressure C-16 H Switch - Refueling Start A-4 56 Harness identification code: 2 200-L32 BK-14
491 PK Hyd Oil Temp Sensor M933 PU Swing Sol Return This example indicates wire
1139 Stick Cylinder Rod Extend Solenoid Sensor - Auto Lube Pressure C-4 56 Switch - Refueling Stop A-4 3 135 in harness "AG".
1140 Stick Cylinder Rod Retract Solenoid 495 GN Fuel Level Signal M935 BU PS Press Sol To Backup Resistor Ground Circuit Identification Wire Gauge
Sensor - Boom OLWD Pressure C-6 7 Switch - RH Backup Travel H-3 B Number Wire Color
496 WH Hyd Oil Level M937 GN Flow Control Prox Sw#1 To Abl Connection
1141 Bucket Cylinder Rod Extend Solenoid Sensor - Dual Cam Speed Timing (Crank) A-16 H Switch - Seat Heater D-4 A
497 OR Sensor Power (not used) M938 GY Flow Control Prox Sw#2 To Abl
1142 Bucket Cylinder Rod Retract Solenoid Sensor - Dual Cam Speed Timing (Ran) B-16 H Switch - Secondary Shutdown L-1 17
C468 BU Engine Oil Level M942 WH Lever Top Sw (lh-r)
1143 Swing Right Solenoid
C472 GN Front Pump Press M943 YL Lever Top Sw (lh-l)
Sensor - Engine Coolant Temperature B-16 H Switch - Throttle Position I-1 B © 2007 Caterpillar Printed in U.S.A.
1144 Swing Left Solenoid E456 WH Autolube Pressure M944 BU Lever Top Sw (rh-r) Sensor - Fuel Level B-7 22 Switch - Under Window Limit E-3 A All Rights Reserved
1145 Attachment Extend/CW Solenoid E480 WH Overload Warning Device Sw. M945 BR Lever Top Sw (rh-l) Sensor - Fuel Pressure C-16 H Switch - Window Limit G-2 A
1146 Attachment Retract/CW Solenoid G426 WH Swing Pressure M947 OR LH Joystick Sensor - HEUI Rail Pressure C-16 H Switch Panel E-1 A
1147 Medium Pressure Circuit #1-A Solenoid H441 GN Stick Lube Pressure M948 BR LH Joystick Machine locations are repeated for components located close together.
1148 Medium Pressure Circuit #1-B Solenoid H446 PK Boom Lower Check Pressure Sensor M949 PK LH Joystick A = Located inside of cab.
1149 Boom Lowering Check/Modulation Valve Solenoid Accessory Circuits M950 PU LH Joystick B = Located inside of right console.
500 BR Wiper - Front (park) M953 BU LH Joystick
1150 Swing Pump Swash Plate Angle Solenoid C = Located inside of left console.
501 GN Wiper - Front (low) M954 BU Hammer Pedal
1155 Implement Pump Power Shift Pressure Solenoid D = Located around relay panel.
506 PU Washer - Front M956 GN Travel Pedal
1159 Stick Lowering Check/Modulation Valve Solenoid E = Located around hydraulic oil tank.
508 PU Radio Speaker - Left M957 GY Travel Pedal
1160 Hydraulic Lock Solenoid 509 WH Radio Speaker - Left (commom) M960 PU Straight Travel Pedal F = Located around pilot manifold.
1163 Left Travel Backward Solenoid 511 BR Radio Speaker - Right M962 YL RH Joystick G =Located under platform.
1164 Right Travel Backward Solenoid 512 GN Radio Speaker - Right (common) M963 BU RH Joystick
1165 Right Travel Forward Solenoid 514 PU A/c Condensor Motor N957 PK Rxd - Comm #1 Connector Location
1166 Left Travel Forward Solenoid 530 OR Washer Right N959 PK Rxd - Comm #3 Schematic Machine Off Machine Switch Specification
590 GY Wiper Sw To Intermittent Module N960 OR Txd - Comm #1 Connector Number Part No. Function Actuate Deactuate Contact Position
1178 Machine Overload Warning Pressure Sensor Location Location
592 BU Dc/dc Converter Power Output N963 OR Txd - Comm #3 162-6208 Air Cleaner 635 ± 58 mmH2O Normally Open
1191 Main Hydraulic Valve CONN 1 D-17 H
A513 RD Dc/dc Converter Memory Output N970 YL Dtr - Comm #1
1192 Swing Hydraulic Valve CONN 2 HEP CONN A-15 H
A537 PK Seat Heater N973 BR Dcd - Comm #1
1193 Boom Cylinder Rod Extension Solenoid CONN 3 TDC PROBE A-15 H
A579 OR Wiper Motor + N979 GN Signal Gnd - Comm #1
1657 Left Joystick Thumbwheel CONN 4 E-16 19

(Dimensions: 39 inches x 28 inches)

A580 BR Wiper Motor - N981 GN Signal Gnd - Comm #3
1658 Right Joystick Thumbwheel A584 BU Front Window Limit Sw To Wiper Cont P943 GN Stick Lowering Sol CONN 5 E-16 19
A
¹ The CID is a diagnostic code that indicates which circuit is faulty. A586 OR Wiper Sw To Wiper Cont P944 GY Boom Lowering Sol CONN 6 F-16 19
² The MID is a diagnostic code that indicates which electronic control module C506 WH Hi Relay P945 OR Anti Drift Sol- Stick 5 CONN 7 F-16 19
16 10 C
C560 OR Left Rear Speaker P946 BR Anti Drift Sol- Boom

RENR7307-01
diagnosed the fault. CONN 8 H-16 D
C566 PK Left Rear Speaker (common) P949 PU Sys Press Up Sol- Front 24 2 30 12 F 33 40
11 B CONN 9 L-16 D
C569 YL Second Dc/dc Converter Power Output P955 BU Neutral Flow Bypass Sol #2 32 26 28
H D CONN 10 G-14 D
E554 PK A/C Controller To A/C Compressor Clutch P957 BR Att Extend Sol
31 E 4 CONN 11 C-14 38
Lighting Circuits P958 PK Att Retract Sol
22 3 56 Resistor, Sender and Solenoid Specifications
603 PK Rotary Beacon P959 GN Swing Pump Swash Sol 29 25 37
CONN 12 C-13 20
Failure Mode Identifiers (FMI)¹ 607 PK Flood Lamp - Front T901 YL MSS Exciter Coil In 39 27 9 8 1 23 6 CONN 13 C-12 20 Part No. Component Description Resistance (Ohms)¹
FMI No. Failure Description 615 YL Cab Flood Lamp / Rops T902 PK MSS Exciter Coil Out 38 20 15 54 18 55 CONN 14 C-12 20 111-9916 Solenoid: PS Pressure 11.7 ± 1.2
19 13 21 G
0 Data valid but above normal operational range. 616 BU Bucket Flood Lamp/boom Flood Lamp X976 BU Backup Diode 1 to Backup Diode 2 14 7 17 CONN 15 C-11 20 Swing LH
112-5874 Solenoid: 6.5 ± 0.4
633 BU Attach Lighting Ckt X977 YL Boom Down Backup Resistor to Backup Diode 2 CONN 16 G-13 D Swing RH
1 Data valid but below normal operational range.
CONN 17 G-13 D Hydraulic Lock
2 Data erratic, intermittent, or incorrect.
CONN 18 G-11 D 121-1491 Solenoid: Travel Speed Shift 32 ± 3.2
3 Voltage above normal or shorted high.
CONN 19 G-11 D Swing Brake
4 Voltage below normal or shorted low. 126-2941 Resistor: Boom Down Backup Positions 1 thru 4 : 25 ± 5%
CONN 20 G-10 D
5 Current below normal or open circuit. Positions 1 thru 3 : 10.7 ± 5%
CONN 21 C-10 21 145-3084 Resistor: Boom Backup
6 Current above normal or grounded circuit. Position 4: 55 ± 5%
CONN 22 C-9 21
7 Mechanical system not responding properly. Travel RH Rear
CONN 23 C-9 21
8 Abnormal frequency, pulse width, or period. Travel LH Rear
CONN 24 C-8 21
9 Abnormal update. Stick Retract
CONN 25 F-8 23
Boom Retract
10 Abnormal rate of change. CONN 26 F-8 23
Bucket Retract
11 Failure mode not identifiable. CONN 27 G-9 23 Retract
12 Bad device or component. CONN 28 G-9 23 148-2350 Solenoid: Travel RH Front 5 ± 0.3
13 Out of calibration. CONN 29 G-9 6 Travel LH Front
Related Electrical Service Manuals
14 Parameter failures. CONN 30 G-9 6 Stick Extend
Title Form Number CONN 31 K-8 6 Boom Extend
15 Parameter failures.
Alternator: 235-7133 DENSO HDB SENR4130 CONN 32 I-8 6 Bucket Extend
16 Parameter not available.
Electric Starting Motor: 237-1962 DELCO 50MT SENR3860 CONN 33 A-8 27 Extend
17 Module not responding.
CONN 34 C-7 7 Backup Travel LH
18 Sensor supply fault. Engine Control: RENR5092 31 13 D 151-9360 Resistor: 10.7 ± 5%
CONN 35 A-5 18 Backup Travel RH
37 5

30 Page, B&W
19 Condition not met. Gateway Worldview Module RENR7945 C 0% = 83.5 ± 1.5
11 17 CONN 36 A-5 18
20 Parameter failures. Implement and Pump Control: RENR8067 163-6700 Sender: Fuel Level 50% = 33.8 ± 2.0
8 A G CONN 37 B-5 55
¹The FMI is a diagnostic code that indicates what type of failure has occurred. Monitor System: RENR8068 100% = 8 (+1) (-0.5)
CONN 38 B-5 55
6 Lowering Check Boom
CONN 39 C-6 28 171-0028 Solenoid: 11.5 ± 0.5
33 B Lowering Check Stick
2 39 CONN 40 ET CONN D-5 A
4 174-3016 Resistor: CAN Data Link 120 ± 12
23 CONN 41 F-5 A
Boom Anti-Drift
20 21 CONN 42 G-5 A
Neutral Flow Bypass
CONN 43 G-4 A 189-0189 Solenoid: 32.6 ± 1.6
32 H 10 1 7
System Pressure
Event Codes 9 CONN 44 G-3 A Stick Anti-Drift
Engine Control CONN 45 H-4 B 239-1134 Solenoid: Start Aid 20
25 12
Event Code Condition F CONN 46 I-4 B 242-6880 Solenoid: Auto-Reverse Fan 32 ± 3.2
24 26 30 CONN 47 I-4 B
E172 High Air Filter Restriction 16 ¹ At room temperature unless otherwise noted.
19 CONN 48 J-4 B
E265 User Defined Shutdown 28 22 CONN 49 K-5 C
29 E 14
E360 Low Engine Oil Pressure CONN 50 L-5 C
27 40 CONN 51 I-2 B
E361 High Engine Coolant Temperature 38
CONN 52 C-4 16
E362 Engine Overspeed 3 56
CONN 53 B-4 17
E390 Fuel Filter Restriction 54 18 55 CONN 54 I-17 D
E539 High Intake Manifold Air Temperature CONN 55 G-15 D
CONN 56 H-4 17
The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.

Machine Harness Connector And Component Locations

 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

SECONDARY SHUTDOWN SW
103-A48 RD-16
105-A94 RD-16 103-A48 RD-16 103-A47 RD-16
CONSOL LH A-C15
1552273
1702512
113-A50 OR-18 105-A94 RD-16 103-A19 RD-16 3
RELAY PANEL 118-A51 GY-14
120-A110 YL-16
113-A50 OR-18
118-A51 GY-14
103-A48 RD-16
H-C3
NEUTRAL START LIMIT SW
1114799 H-C6 JOYSTICK LH 235-A63 BK-18 1
6
123-A52 WH-18 123-A52 WH-18 105-A94 RD-16 1552267 2305010 2277569 4
124-A46 GN-14 127-A140 OR-16 113-A49 OR-18 CONN 50 154-H16 RD-16 A 1 +8V 5
125-A72 RD-16 129-A61 BU-16 113-A98 OR-18 127-A140 OR-16 151-H15 GN-16 B 2 GND F716-A73 WH-18 2
127-A140 OR-16 150-A1 RD-16 150-A1 RD-16 A-C1 H-C1 C 3 SIG L/R
129-A61 BU-16 151-A75 GN-16 113-A50 OR-18 151-A75 GN-16 2304009 2434510 M950-H14 PU-18 4 SIG F/R
1 150-A1 RD-16 154-A74 RD-16 118-A65 GY-14 154-A74 RD-16 127-A140 OR-16 1 5
F856-E110 GN-18 X977-E86 YL-18 151-A75 GN-16 199-A135 OR-18 118-A124 GY-14 320-A77 RD-18 150-A1 RD-16 2 150-H2 RD-16 6
L 2 X977-E109 YL-18 154-A74 RD-16 251-A136 YL-18 K848-A148 WH-18 320-A77 RD-18 3 320-H3 RD-18 L
175-A106 RD-14 261-A137 GN-18 118-A51 GY-14 K909-A10 BU-16 K848-A148 WH-18 4 K848-H4 WH-18 H-C7 H-C8 A-C19 A-C26 ATCH PEDAL LH
F856-E111 GN-18 3 179-A112 BU-16 307-A23 OR-16 123-A52 WH-18 K943-A6 OR-18 K909-A10 BU-16 5 K909-H5 BU-16 2397352 2472693 2397352 2472693 2475276
199-A135 OR-18 308-A60 YL-16 127-A140 OR-16 K944-A7 YL-18 K945-A11 GY-18 6 K945-H6 GY-18 1 1 +B M947-A22 OR-18 1 1 +12V
4 ATCH LAMP DELAY TIMER WK-C1 E-C29 K909-E89 BU-16 307-A23 OR-16 308-A99 YL-16 129-A61 BU-16 K945-A11 GY-18 K951-A12 GY-18 7 K951-H7 GY-18 2 2 GND M948-A53 BR-18 2 2 GND
P944-E87 GY-18 1636704 3E3364 1552269 K951-E88 GY-18 E-C34 BACKUP DIODE 3 308-A101 YL-16 150-A1 RD-16 K949-A8 OR-18 M942-A149 WH-18 8 M942-H8 WH-18 3 3 PWM OUT M954-A56 BU-18 3 3 LEFT PEDAL
BOOM DOWN BACKUP RELAY 1 684-WK1 RD-18 1 684-E79 RD-18 1 7Y3952 1211022 320-A77 RD-18 151-A75 GN-16 K950-A9 YL-18 M943-A150 YL-18 9 M943-H9 YL-18 4 4 SW-COM 4 4 PWM (F-A)
1262941 5A LAMP SW 2 2 646-E50 RD-18 K909-E89 BU-16 1 603-A80 PK-18 308-A101 YL-16 154-A74 RD-16 K951-A12 GY-18 L153 M947-A2 OR-18 10 M947-H10 OR-18 5 5 SW-1 5 5 NU
5A L14 F859-E60 GY-18 2 K951-E49 GY-18 K909-E90 BU-16 2 607-A25 PK-16 308-A102 YL-16 199-A135 OR-18 M942-A149 WH-18 M949-A4 PK-18 11 M949-H13 PK-18 6 6 SW-2 6 6 NU
5A E-C31 E-C30 F859-E92 GY-18 K951-E88 GY-18 E997-E107 BR-18 615-A62 YL-16 320-A77 RD-18 251-A136 YL-18 M943-A150 YL-18 M950-A5 PU-18 12
10A 3E3370 1552267 3 645-A55 RD-18 403-A59 GN-18 261-A137 GN-18 M947-A2 OR-18 H-C4
AM-C1 AM-C2 TIMER RELAY E-C3 15A +B A A 105-E4 RD-16 F859-E92 GY-18 K909-E90 BU-16 646-A54 RD-18 405-A44 GY-18 307-A23 OR-16 M948-A3 BR-18 L16 7Y3967 1 A-C14 PEDAL
1552272 3E3376 1636703 1552272 15A GND B B 200-E47 BK-16 K909-E91 BU-16 E-C32 BACKUP RESISTOR TR LH K909-A24 BU-16 412-A35 BU-18 308-A60 YL-16 M949-A4 PK-18 A-C9 H-C2 M949-H13 PK-18 1 SW-3 2397352 2475275
1 110-AM9 RD-18 1 +B 1 110-E5 RD-18 C C 308-E62 YL-16 H733-E95 BU-18 4 1552269 1519360 K945-A11 GY-18 430-A34 BU-18 308-A99 YL-16 M950-A5 PU-18 2434510 2304009 1 M947-A57 OR-18
KEY OFF 1 +12V
2 200-AM10 BK-18 2 GND 2 200-E48 BK-18 K909-E93 BU-16 K909-E93 BU-16 1 K948-A93 GY-18 487-A29 OR-18 320-A77 RD-18 M953-A152 BU-18 151-A75 GN-16 1 151-H15 GN-16 H-C5 M948-A117 BR-18 2 GND
3 150-AM11 RD-18 3 OUT 3 150-E35 RD-18 10A 1 103-GJ2 RD-18 BOOM BACKUP RESISTOR K909-E94 BU-16 K945-E98 GY-18 2 K951-A12 GY-18 491-A30 PK-18 403-A59 GN-18 X976-A13 BU-16 154-A74 RD-16 2 154-H16 RD-16 7Y3967 M956-A118 GN-18 3 TRAVEL RIGHT
4 4 IN 4 10A 1 125-E106 RD-16 1453084 X976-A13 BU-16 495-A31 GN-18 405-A44 GY-18 200-A78 BK-16 K943-A6 OR-18 3 K943-H17 OR-18 200-H26 BK-18 1 ATCH CONT HANDLE LH M957-A119 GY-18 4 TRAVEL LEFT
10A 1 115-E9 RD-16 E-C35 BACKUP DIODE 4 235-A68 BK-18 496-A32 WH-18 412-A35 BU-18 118-A124 GY-14 K944-A7 YL-18 4 2277617 5 NU
CONN 9 E-C4 10A 114-E7 RD-16 7Y3952 1211022 235-A43 BK-18 506-A33 PU-18 430-A34 BU-18 F716-A73 WH-18 K949-A8 OR-18 5 HORN SW

101-WF1 RD-6
1 6 NU
F874-AM8 PK-18 7Y3952 5A 1 110-E5 RD-18 L15 H733-E95 BU-18 1 235-A131 BK-14 603-A80 PK-18 487-A29 OR-18 M947-A129 OR-18 K950-A9 YL-18 6 K950-H20 YL-18 ATCH AIR SUSPENSION 2220225
308-AM7 YL-18 200-E48 BK-18 15A 1 130-E16 RD-14 M935-E96 BU-18 2 235-A132 BK-14 607-A25 PK-16 491-A30 PK-18 M948-A128 BR-18 M948-A3 BR-18 7 M948-H21 BR-18 H-C9 H-C10 2405063
MAIN RELAY DIODE 1 200-E44 BK-16 5A 1 172-E69 RD-18 607-A142 PK-16 495-A31 GN-18 M954-A56 BU-18 M953-A152 BU-18 8 M953-H24 BU-18 2304011 2434505 A-C20 A-C27 ATCH PEDAL RH
1211022 2 308-E57 YL-18 10A 1 105-E2 RD-16 E997-E107 BR-18 E-C33 BACKUP RESISTOR TR RH CONN 31 615-A62 YL-16 496-A32 WH-18 M956-A118 GN-18 X976-A13 BU-16 9 X976-H25 BU-16 2 2 GND 2397352 2472693 2475276
308-E82 YL-18 15A 1 131-E34 RD-14 K945-E98 GY-18 1552269 1519360 C-C11 A-C11 645-A55 RD-18 506-A33 PU-18 M957-A119 GY-18 200-A78 BK-16 10 1 1 + B M947-A120 OR-18 1 1 +12V
5A 1 103-E1 RD-18 K909-E94 BU-16 1 1636637 1532620 646-A54 RD-18 603-A80 PK-18 M960-A122 PU-18 11 M948-A121 BR-18 2 2 GND
A623-E76 BU-18 15A 1 175-E30 RD-14 K948-E97 GY-18 K948-E97 GY-18 2 308-C184 YL-16 235-C189 BK-14 1 892-A37 BR-18 607-A25 PK-16 200-A141 BK-16 12 M960-A122 PU-18 3 3 RIGHT PEDAL
CHASSIS LAMP DIODE 1 684-E79 RD-18 30A 1 168-E27 RD-10 405-C100 GY-18 235-C190 BK-14 2 893-A36 GN-18 607-A108 PK-16 200-A126 BK-14 K950-H20 YL-18 4 4 PWM (F-A)
1211022 2 684-E41 RD-18 412-C169 BU-18 F717-C107 YL-18 3 F718-A87 BU-18 998-A89 BR-18 607-A142 PK-16 235-A43 BK-18 CONN 49 5 5 NU
E-C5 200-E43 BK-18 ATCH BEACON RELAY 430-C162 BU-18 F718-C108 BU-18 4 F717-A86 YL-18 A755-A81 PK-18 615-A62 YL-16
1495050 6 6 NU
7Y3952 15A 1 118-E11 GY-14 200-E46 BK-18 E-C28 487-C71 OR-18 M954-C119 BU-18 5 M954-A56 BU-18 A756-A82 BU-18 645-A55 RD-18 235-A63 BK-18 2 1
10A 1 160-E25 PU-16 200-E44 BK-16 1495051 491-C74 PK-18 M960-C127 PU-18 6 M960-A122 PU-18 A757-A83 GY-18 646-A54 RD-18 235-A64 BK-18 3
FUSE INSTRUCTION CHASSIS LAMP RELAY 5A 1 123-E13 WH-18 200-E70 BK-18 ATCH MSS RELAY 2 603-E58 PK-18 1 495-C73 GN-18 M963-C130 BU-18 7 M963-A95 BU-18 A758-A84 BR-18 892-A37 BR-18 103-A19 RD-16 K944-H18 YL-18
1613128 10A 1 129-E15 BU-16 L2 200-E78 BK-18 1495050 200-E61 BK-18 2 496-C72 WH-18 M949-C131 PK-18 8 M949-A4 PK-18 A768-A92 BU-18 893-A36 GN-18 105-A94 RD-16 2 1 5 4 A-C24
E-C6 5A 1 113-E6 OR-18 200-E45 BK-16 AM-C4 199-E36 OR-18 3 514-C176 PU-16 K909-C128 BU-16 9 K909-A153 BU-16 C468-A38 BU-18 998-A89 BR-18 113-A98 OR-18 3 6 1552272
FUSE BASE FUSE 1495051 10A 1 140-E52 BU-16 308-E68 YL-18 1495051 199-E108 OR-16 4 L79 607-C54 PK-18 487-C71 OR-18 10 487-A29 OR-18 F716-A73 WH-18 A755-A81 PK-18 307-A23 OR-16 A580-A123 BR-14 2
K 1831000 5A 1412759 1 10A 1 120-E12 YL-16 308-E59 YL-18 1 A346-AM4 BU-18 638-E53 WH-16 5 892-C192 BR-18 491-C74 PK-18 11 491-A30 PK-18 F717-A86 YL-18 A756-A82 BU-18 308-A99 YL-16 118-A124 GY-14 4 K
2 A623-E76 BU-18 10A 1 179-E32 BU-16 308-E56 YL-16 2 M732-AM2 OR-18 893-C194 GN-18 495-C73 GN-18 12 495-A31 GN-18 F718-A87 BU-18 A757-A83 GY-18 508-A28 PU-18 BACKUP SW BACKUP SW A579-A125 OR-14 3 WIPER MOTOR
10A 1138490 160-E26 PU-18 15A 124-E14 GN-14 308-E62 YL-16 307-AM5 OR-16 998-C102 BR-18 496-C72 WH-18 496-A32 WH-18 G976-A39 BU-18 A758-A84 BR-18 509-A20 WH-18 TRAVEL LH BOOM 200-A126 BK-14 + 2513482
15A 1138491 3 1 3 13 1
30A 1243548 4 160-E25 PU-16 10A 1 196-E22 BU-16 4 C468-C86 BU-18 14 H807-A17 YL-18 A768-A92 BU-18 511-A27 BR-18 1636711 2341155 S +1
5 607-E40 PK-16 10A 1 176-E17 YL-16 5 C904-AM6 GN-16 C506-C129 WH-16 M953-C164 BU-18 15 M953-A88 BU-18 K848-A148 WH-18 C468-A38 BU-18 512-A26 GN-18 -
10A 180-E33 GN-16 112-WG1 PU-6 E554-C89 PK-18 430-C162 BU-18 430-A34 BU-18 M943-A150 YL-18 F716-A73 WH-18 998-A89 BR-18 CONSOL LH

112-WG1 PU-6
SPARE WIPER/WASHER 1 16 L91
5A 1 147-E103 PU-18 F716-C110 WH-18 412-C169 BU-18 17 412-A35 BU-18 K909-A153 BU-16 F717-A86 YL-18 A537-A16 PK-16
5A 15A 15A 1 102-E105 BU-14 101-WF1 RD-6 F717-C107 YL-18 308-C184 YL-16 18 308-A102 YL-16 K909-A24 BU-16 F718-A87 BU-18 A755-A81 PK-18 118-A124 GY-14
10A 1 149-E101 PU-16 101-WE1 RD-6 F718-C108 BU-18 403-C140 GN-18 19 403-A59 GN-18 K943-A6 OR-18 G976-A39 BU-18 A756-A82 BU-18 F716-A73 WH-18
SPARE CHASSIS LAMP 10A 1 148-E84 WH-16 MAIN RELAY G976-C166 BU-18 893-C194 GN-18 20 893-A36 GN-18 K944-A7 YL-18 H807-A17 YL-18 A757-A83 GY-18 M947-A129 OR-18
5A 10A CAB LAMP RELAY 10A A199-E108 OR-16 2130772 H807-C77 YL-18 892-C192 BR-18 892-A37 BR-18 K945-A11 GY-18 K848-A148 WH-18 A758-A84 BR-18
1613128 1 L31 21
SEAT HEATER E-C7 10A 1 127-E71 OR-16 K909-C128 BU-16 A755-C136 PK-18 22 A755-A81 PK-18 K946-A14 OR-18 K847-A145 PU-18 A768-A92 BU-18 M947-A22 OR-18 607-A127 PK-16 CHASSIS LAMP 1
SPARE 1495051 10A 1 113-GJ1 OR-16 K943-C78 OR-18 A756-C137 BU-18 23 A756-A82 BU-18 K947-A103 YL-18 K909-A24 BU-16 F717-A86 YL-18 M947-A120 OR-18 200-A141 BK-16 1532523
10A 5A 115-E10 RD-18 10A 200-E45 BK-16 K944-C79 YL-18 A757-C132 GY-18 A757-A83 GY-18 K948-A93 GY-18 L96 F718-A87 BU-18 L98 M947-A57 OR-18
1 24
2 684-E41 RD-18 FUSE BASE 200-E19 BK-16 ATCH MSS RELAY 1 K946-C80 OR-18 A758-C133 BR-18 25 A758-A84 BR-18 K949-A8 OR-18 K909-A10 BU-16 H807-A17 YL-18 L150
SPARE CIGAR LIGHTER 3 1831000 VG01 2242862 200-E51 BK-14 K947-C81 YL-18 C468-C86 BU-18 26 C468-A38 BU-18 K950-A9 YL-18 K909-A45 BU-16 K847-A145 PU-18 M948-A128 BR-18
10A 10A 115-E9 RD-16 200-E63 BK-16 1495050 AM-C3 K949-C82 OR-18 514-C176 PU-16 514-A76 PU-16 K951-A12 GY-18 K909-A45 BU-16 L95 M948-A117 BR-18
4 27
5 615-E73 YL-16 200-E64 BK-16 1495051 K950-C83 YL-18 L85 M950-C125 PU-18 28 M950-A5 PU-18 K952-A18 BR-18 K909-A153 BU-16 L99 K946-A14 OR-18 M948-A53 BR-18
SPARE SW PANEL/RADIO 200-E47 BK-16 1 A347-AM3 GN-18 K952-C84 BR-18 E554-C89 PK-18 29 E554-A107 PK-18 L919-A40 YL-18 K943-A6 OR-18 K947-A103 YL-18 M948-A121 BR-18
15A 5A 200-E61 BK-18 2
3
M733-AM1
308-AM7
PK-18
YL-18 L15 235-C189 BK-14
235-C190 BK-14
F716-C110 WH-18 30
31
F716-A73 WH-18 L972-A85 BU-18
M942-A149 WH-18
K944-A7 YL-18
K945-A11 GY-18
K948-A93 GY-18
K952-A18 BR-18
M954-A56 BU-18
M956-A118 GN-18
CONSOLE RH
SPARE AUTO LUB 4 251-C63 YL-18 M962-C40 YL-18 32 M962-A100 YL-18 K847-A145 PU-18 K946-A14 OR-18 L972-A85 BU-18 M957-A119 GY-18
15A 10A HORN RELAY 5 F874-AM8 PK-18 261-C58 GN-18 L972-C138 BU-18 33 L972-A85 BU-18 M944-A146 BU-18 K947-A103 YL-18 M944-A146 BU-18 M960-A122 PU-18
1613128 105-E4 RD-16 GND RELAY PANEL 403-C140 GN-18 M947-C122 OR-18 34 M947-A21 OR-18 M945-A147 BR-18 K948-A93 GY-18 M945-A147 BR-18 200-A141 BK-16 1
12V 7A CONVERTER 1 E-C8 105-E3 RD-16 308-E62 YL-16 A755-C136 PK-18 M948-C120 BR-18 35 M948-A130 BR-18 M947-A21 OR-18 K949-A8 OR-18 M947-A15 OR-18 200-A126 BK-14 2
10A 1495051 105-E2 RD-16 L104 105-E4 RD-16 L5 L14 A756-C137 BU-18 M956-C126 GN-18 36 M956-A118 GN-18 M948-A130 BR-18 K950-A9 YL-18 M948-A97 BR-18 235-A63 BK-18 G-C7 JOYSTICK RH
1 114-E8 RD-18 140-E52 BU-16 L30 A757-C132 GY-18 M957-C152 GY-18 37 M957-A119 GY-18 M949-A4 PK-18 K951-A12 GY-18 M953-A151 BU-18 607-A127 PK-16 2305010 2277569
12V 7A CONVERTER 2 2 320-E66 RD-18 102-E105 BU-14 199-E108 OR-16 A758-C133 BR-18 607-C54 PK-18 38 607-A142 PK-16 M950-A5 PU-18 K952-A18 BR-18 M962-A100 YL-18 A579-A125 OR-14 ATCH SEAT HEATER
10A 3 114-E8 RD-18 103-E1 RD-18 306-E23 GN-16 A768-C142 BU-16 G976-C166 BU-18 39 G976-A39 BU-18 M953-A88 BU-18 L919-A40 YL-18 M963-A95 BU-18 A580-A123 BR-14 2299093 1 +8V
4 114-E7 RD-16 113-E6 OR-18 684-E79 RD-18 K848-C197 WH-18 40 M954-A56 BU-18 L972-A85 BU-18 T902-A139 PK-18 A-C5 G-C1 2 GND
A/C CONDEN A/C 5 322-E67 GY-16 118-E11 GY-14 E997-E107 BR-18 K847-C155 PU-18 L919-C139 YL-18 41 L919-A40 YL-18 M956-A118 GN-18 M942-A149 WH-18 T901-A138 YL-18 2304009 2434510 G-C5 G-C6 3 SIG L/R
10A 15A 120-E12 YL-16 X977-E86 YL-18 L919-C139 YL-18 C506-C129 WH-16 42 C506-A90 WH-16 M957-A119 GY-18 M944-A146 BU-18 200-A79 BK-18 A755-A81 PK-18 1 2304011 2434505 4 SIG F/R
123-E13 WH-18 102-E105 BU-14 L13 L972-C138 BU-18 A768-C142 BU-16 A768-A92 BU-18 M960-A122 PU-18 M943-A150 YL-18 200-A133 BK-18 A756-A82 BU-18 5
AUTOLUB RELAY 43 2 1 6
BOOM LAMP 2 INSP LAMP 124-E14 GN-14 130-E16 RD-14 1495050 M942-C171 WH-18 44 M962-A100 YL-18 M945-A147 BR-18 A757-A83 GY-18 3 2
J 10A 10A 125-E106 RD-16 131-E34 RD-14 E-C19 M943-C165 YL-18 998-C102 BR-18 45 998-A89 BR-18 M963-A95 BU-18 A758-A84 BR-18 4 J
HYD LOCK SOL RELAY 127-E71 OR-16 147-E103 PU-18 1495051 M944-C146 BU-18 405-C100 GY-18 46 405-A44 GY-18 T901-A138 YL-18 M947-A21 OR-18 607-A134 PK-16 F717-A86 YL-18 5 G-C8 G-C12
CAB LAMP AUX CKT 1 1613128 129-E15 BU-16 151-E31 GN-16 1 801-E39 PK-18 M945-C124 BR-18 K952-C84 BR-18 47 K952-A18 BR-18 T902-A139 PK-18 M947-A129 OR-18 607-A42 PK-16 F718-A87 BU-18 6 2397352 2472693
10A 10A E-C9 130-E16 RD-14 168-E27 RD-10 2 H807-E42 YL-18 M947-C122 OR-18 K950-C83 YL-18 48 K950-A9 YL-18 X976-A13 BU-16 M947-A15 OR-18 607-A25 PK-16 K847-A145 PU-18 7 1
1495051 L2 131-E34 RD-14 172-E69 RD-18 3 140-E104 BU-16 M948-C120 BR-18 K949-C82 OR-18 49 K949-A8 OR-18 200-A79 BK-18 M947-A2 OR-18 607-A142 PK-16 L972-A85 BU-18 8
HORN AUX CKT 2 1 151-E21 GN-16 140-E52 BU-16 310-E18 PU-18 4 140-E52 BU-16 M949-C131 PK-18 K947-C81 YL-18 50 K947-A103 YL-18 200-A66 BK-18 607-A108 PK-16 M944-A146 BU-18 9 2 1 +B
200-E46 BK-18 147-E103 PU-18 317-E83 YL-18 L6 709-E37 OR-16 M950-C125 PU-18 K946-C80 OR-18 K946-A14 OR-18 200-A133 BK-18 M948-A130 BR-18 607-A58 PK-16 M945-A147 BR-18 3 2
2 5 51 10 GND

E997-E107 BR-18
10A 10A

BU-16

YL-18
BR-18
BU-18
YL-18

199-E108 OR-16

K909-E89 BU-16
K945-E98 GY-18
K948-E97 GY-18
K951-E88 GY-18
M935-E96 BU-18
4

BU-16
GN-16
OR-16
PK-18

BK-16

308-E62 YL-16
646-E50 RD-18
684-E79 RD-18
200-E47 BK-16
199-E36 OR-18
603-E58 PK-18
638-E53 WH-16

200-E61 BK-18
3 E997-E38 BR-18 168-E27 RD-10 322-E67 GY-16 M953-C164 BU-18 K944-C79 YL-18 52 K944-A7 YL-18 200-A126 BK-14 M948-A3 BR-18 607-A127 PK-16 M947-A15 OR-18 11 3 PWM OUT

105-E4 RD-16
5

200-E63 BK-16
306-E54 GN-16
TIMER RLAY ATT SOL 4 E997-E107 BR-18 172-E69 RD-18 616-E102 BU-16 M954-C119 BU-18 K943-C78 OR-18 53 K943-A6 OR-18 200-A69 BK-14 M948-A128 BR-18 M962-A100 YL-18 12 6 4 SW-COM
5A 5A 5 K924-E77 YL-16 175-E30 RD-14 633-E85 BU-16 M956-C126 GN-18 H807-C77 YL-18 54 H807-A17 YL-18 200-A78 BK-16 M948-A97 BR-18 5 SW-1
176-E17 YL-16 892-E80 BR-18 M957-C152 GY-18 200-A141 BK-16 M949-A4 PK-18 103-A47 RD-16 CONN 48 6 SW-2

140-E104

H807-E42
P946-E28
X976-E72
X977-E86
G-C9

140-E52
306-E23
709-E37
801-E39

200-E64
ABL CONT 1 ENG CONT 179-E32 BU-16 893-E81 GN-18 M960-C127 PU-18 C-C16 A-C22 235-A43 BK-18 M950-A5 PU-18 113-A49 OR-18 A-C3 G-C2 7Y3967
101-CA1 RD-00 101-CC1 RD-00 200-CE1 BK-00 15A 15A 180-E33 GN-16 E997-E38 BR-18 M962-C40 YL-18 2434510 2304009 235-A68 BK-18 M953-A88 BU-18 118-A65 GY-14 2434510 2304009
199-E108 OR-16 K924-E77 YL-16 E-C16 M963-C130 BU-18 261-C58 GN-18 1 261-A137
GN-18 607-A108 PK-16 M953-A88 BU-18 123-A52 WH-18 307-A23 OR-16 1 1 1
101-CP1 RD-00 PRODUCT LINK BOOM LAMP 2 196-E22 BU-16 P944-E87 GY-18 7Y3952 L13 251-C63 YL-18 251-A136
YL-18 120-A110 YL-16 M953-A151 BU-18 129-A61 BU-16 308-A99 YL-16
NEUTRAL START RELAY L4 2 2 SW-3
5A 10A 1613128 160-E25 PU-16 200-E51 BK-14 K848-C197 WH-18 3 K848-A148
WH-18 179-A112 BU-16 M953-A152 BU-18 199-A135 OR-18 200-A79 BK-18 3 1
E-C10 149-E101 PU-16 308-E56 YL-16 START RELAY DIODE 1 200-E64 BK-16 M942-C171 WH-18 4 M942-A149
WH-18 200-A111 BK-16 M954-A56 BU-18 251-A136 YL-18 H807-A17 YL-18 4 1
POS NEG POS NEG
KEY SW SPARE 1495051 148-E84 WH-16 103-E1 RD-18 1211022 2 306-E54 GN-16 M943-C165 YL-18 5 M943-A150
YL-18 200-A113 BK-16 M956-A118 GN-18 261-A137 GN-18 K952-A18 BR-18 5 G-C10 ONE TOUCH ATCH CONT HANDLE RH
10A 5A 1 154-E24 RD-16 L3 115-E9 RD-16 105-E3 RD-16 306-E23 GN-16 E-C27 K847-C155 PU-18 6 K847-A145
PU-18 M957-A119 GY-18 308-A60 YL-16 T901-A138 YL-18 6 7Y3967 2277616
2 200-E43 BK-18 114-E7 RD-16 113-E6 OR-18 1552269 M944-C146 BU-18 7 M944-A146
BU-18 124-A46 GN-14 M960-A122 PU-18 403-A59 GN-18 T902-A139 PK-18 7 LOW IDLE SW
BATTERY RH BATTERY LH ABL CONT 2 SPARE 307-E55 OR-16 110-E5 RD-18 118-E11 GY-14 M945-C124 BR-18 M945-A147
BR-18 125-A72 RD-16 M962-A100 YL-18 405-A44 GY-18 998-A89 BR-18 2220225

2
1
1535710 1535710 3 L12 8 8
15A 5A 4 120-E12 YL-16 E-C17 9 175-A106 RD-14 M963-A95 BU-18 412-A35 BU-18 L145 A768-A92 BU-18 9 M-C2
5 306-E23 GN-16 110-E5 RD-18 123-E13 WH-18 BACKUP DIODE 1 7Y3952 L197 10 514-A76 PU-16 T901-A138 YL-18 430-A34 BU-18 M948-A97 BR-18 10 7Y3952
DOME LAMP/MEMORY SPARE 114-E7 RD-16 124-E14 GN-14 1211022 1 X976-E29 BU-18 T901-C67 YL-18 11 T901-A138 YL-18 C506-A90 WH-16 T902-A139 PK-18 487-A29 OR-18 M953-A151 BU-18 11 1 GND
5A 10A 115-E9 RD-16 125-E106 RD-16 2 P946-E28 BR-18 T902-C134 PK-18 12 T902-A139 PK-18 E554-A107 PK-18 X976-A13 BU-16 491-A30 PK-18 235-A64 BK-18 12 CONN 51 2 +B
148-E84 WH-16 127-E71 OR-16 START RELAY CONN 32 200-A109 BK-14 200-A66 BK-18 495-A31 GN-18 CONN 47 IND UNIT
CONN 54 A/C BLOWER SPARE 149-E101 PU-16 129-E15 BU-16 1251302 200-A105 BK-14 200-A133 BK-18 496-A32 WH-18 G-C11 M-C1 1709324
160-E25 PU-16 150-E35 RD-18 L7 E-C18 200-A126 BK-14 506-A33 PU-18 1027964 1211168
15A 10A ETHER RELAY 196-E22 BU-16 151-E20 GN-16 7Y3952 WASHER MOTOR A-C29 200-A69 BK-14 603-A80 PK-18 A-C2 G-C3 1 M-C3

E997-E107 BR-18
1613128

199-E108 OR-16

X977-E86 YL-18

K909-E89 BU-16
K945-E98 GY-18
K948-E97 GY-18
K951-E88 GY-18
X976-E72 BU-18

BU-16

YL-18
BU-18
BR-18
140-E52 BU-16
306-E23 GN-16
308-E62 YL-16
684-E79 RD-18

200-E61 BK-18
200-E64 BK-16
200-E63 BK-16
200-E47 BK-16
199-E36 OR-18
646-E50 RD-18

603-E58 PK-18

WH-16
OR-16
PK-18
BK-16
REFUELING PUMP SPARE E-C11 150-E35 RD-18 154-E24 RD-16 BACKUP DIODE 2 7T5957 A/C UNIT A-C16 200-A141 BK-16 615-A62 YL-16 2312295 2434509 2 1552273

105-E4 RD-16
7T8890

RD-8

304-WC1 WH-8
30A 10A 1495051 154-E24 RD-16 175-E30 RD-14 1211022 1 X976-E72 BU-18 MOTOR 12 200-A144 BK-18 2405036 2304009 200-A79 BK-18 645-A55 RD-18 105-A94 RD-16 1 3 1 BK COM
101-CR1 RD-00 1 317-E83 YL-18 306-E23 GN-16 176-E17 YL-16 2 X977-E86 YL-18 506-A33 PU-18 B/R 1 124-A46 GN-14 200-A78 BK-16 646-A54 RD-18 607-A42 PK-16 2 4 2 PK S1
2 200-E78 BK-18 307-E55 OR-16 179-E32 BU-16 200-A111 BK-16 B/W 2 200-A105 BK-14 235-A43 BK-18 892-A37 BR-18 A537-A16 PK-16 3 5 3 BU S2

140-E104

H807-E42
M935-E96
P946-E28
638-E53
709-E37
801-E39
200-E75
308-E82 YL-18 308-E59 YL-18 180-E33 GN-16 200-A141 BK-16 R 175-A106 RD-14 235-A68 BK-18 893-A36 GN-18 K909-A45 BU-16 6 4 GN

109- 1
3 3 4 S3

L148
I 4 308-E59 YL-18 308-E68 YL-18 307-E55 OR-16 200-A109 BK-14 R/G 4 E554-A107 PK-18 508-A28 PU-18 C468-A38 BU-18 K946-A14 OR-18 5 7 5 BR S4 I
5 310-E18 PU-18 310-E18 PU-18 320-E66 RD-18 L196 200-A133 BK-18 P 5 607-A108 PK-16 L92 509-A20 WH-18 G976-A39 BU-18 K947-A103 YL-18 6 8 6
317-E83 YL-18 607-E40 PK-16 200-A113 BK-16 B 6 200-A109 BK-14 511-A27 BR-18 L919-A40 YL-18 K948-A93 GY-18 7 9 THROTTLE POS SW
320-E66 RD-18 615-E73 YL-16 200-A66 BK-18 R/W 7 514-A76 PU-16 512-A26 GN-18 200-A69 BK-14 M963-A95 BU-18 8 10 1060107

L151
322-E67 GY-16 645-E100 RD-18 200-A105 BK-14 O/G 8 C506-A90 WH-16 A537-A16 PK-16 200-A66 BK-18 CONN 46 11
607-E40 PK-16 235-E65 BK-18 200-A78 BK-16 R/L 9 125-A72 RD-16 235-A68 BK-18 12
E-C14 BOOM LAMP RELAY 1 615-E73 YL-16 200-A79 BK-18 10 13
101-CF1 RD-00 101-CG1 RD-00 7T5957 1613128 616-E102 BU-16 L5 L9 200-A69 BK-14 11 L146 14 R
1 200-E19 BK-16 E-C12 633-E85 BU-16 200-A126 BK-14 12 15
2 196-E22 BU-16 1495051 645-E100 RD-18 L6 L11 16 C OFF
1 684-E79 RD-18 L147 17 S ON
POS NEG POS NEG 2 645-E100 RD-18 892-E80 BR-18 L9 A-C4 G-C4 18 B ST
L198 3 149-E99 PU-18 893-E81 GN-18 A-C23 ATT 12V 7A CONVERTER 1 A-C17 2434509 2312295 19
E-C15 4 149-E101 PU-16 E997-E38 BR-18 2434508 2341004 2305010 113-A98 OR-18 1 20 KEY SWITCH
ATCH BATTERY RH ATCH BATTERY LH 9W1951 5 616-E102 BU-16 E997-E107 BR-18 1 +12 V SWITCHED OUT 1 120-A110 YL-16 200-A133 BK-18 2 21 9G7641

BK-18
BK-14
BK-14
BK-16
BK-14
BK-18
BK-16
BK-16
BK-16
BK-18

BK-18
BK-14
1535710 1535710 A 308-E68 YL-18 616-E74 BU-18 K924-E77 YL-16 2 +12 V MEMORY OUT 2 135-A67 BU-16 509-A20 WH-18 3
B 235-E65 BK-18 P944-E87 GY-18 3 GROUND 3 210-A70 BK-16 120-A114 YL-16 512-A26 GN-18 4
X977-E86 YL-18 4 GROUND 4 200-A111 BK-16 120-A104 YL-16 607-A134 PK-16 5

A579-A125 OR-14
A580-A123 BR-14
C

YL-16

PK-16

OR-18
YL-18
GN-18

BU-18
BU-18
YL-18

PK-16
BU-16
BK-16
BK-16
PU-18
WH-18
BR-18
GN-18
RD-16
OR-18
GY-14
WH-18
BU-16

YL-16
GN-18
GY-18
BU-18
BU-18
OR-18
PK-18
GN-18
WH-18
PU-18
PK-18
PK-16
YL-16
RD-18
RD-18
BR-18
GN-18

BK-14
BK-18
BK-18
CONN 8 D 893-E81 GN-18 200-E19 BK-16 5 +24 V SWITCHED IN 5 120-A104 YL-16 179-A112 BU-16 103-A19 RD-16 6 M-C4 M-C5

200-A144
200-A105
200-A109
200-A111
200-A126
200-A133
200-A141
200-A113
200-A78
200-A79

200-A66
200-A69
E 892-E80 BR-18 BOOM LAMP RELAY 2 200-E44 BK-16 6 +24 V BATTERY IN 6 120-A114 YL-16 L149 508-A28 PU-18 7 1552269 3E3364
ALTERNATOR F 200-E43 BK-18 179-A115 BU-16 511-A27 BR-18 8 ANTENNA
1779953 1613128 E-C13 200-E78 BK-18 179-A116 BU-16 6C3431 ATCH RADIO AM/FM(JPN) 1
G CONN 45

C569-A91

A537-A16

199-A135
251-A136
261-A137

C468-A38
G976-A39
L919-A40
2

607-A127
135-A67
210-A70
229-A96
508-A28
509-A20
511-A27
512-A26
103-A47
113-A49
118-A65
123-A52
129-A61

308-A60
403-A59
405-A44
412-A35
430-A34
487-A29
491-A30
495-A31
496-A32
506-A33
603-A80
607-A58
615-A62
645-A55
646-A54
892-A37
893-A36

200-A69
200-A66
235-A68
109-C91 RD-4 H 1495051 200-E46 BK-18 A-C25 ATT 12V 7A CONVERTER 2 A-C18 200-A111 BK-16 2510537
B J 1 616-E74 BU-18 200-E70 BK-18 2434508 2341004 2305010 200-A113 BK-16 M-C6 1
R 403-C88 GN-16 2 200-E70 BK-18 235-E65 BK-18 1 +12 V SWITCHED OUT 1 135-A67 BU-16 1532541 2
3 148-E84 WH-16 151-E21 GN-16 2 +12 V MEMORY OUT 2 C569-A91 YL-16 C569-A91 YL-16 ANTENNA ACC 1
109-WH1 RD-6
101-WJ1 RD-6
E
200-C87 BK-4 4 3 GROUND 3 229-A96 BK-16 210-A70 BK-16 A-C4 AJ-C1 GND 2 ATCH EXCITER COIL

125-E106 RD-16

645-E100 RD-18

K909-E89 BU-16
K945-E98 GY-18
K948-E97 GY-18
K951-E88 GY-18
X976-E72 BU-18

BU-14

PU-18

BU-16

BR-18
YL-16
GY-18
BU-16

YL-18
BU-18
BR-18
118-E11 GY-14
120-E12 YL-16
123-E13 WH-18
124-E14 GN-14
127-E71 OR-16
129-E15 BU-16
150-E35 RD-18
151-E20 GN-16
154-E24 RD-16
175-E30 RD-14
176-E17 YL-16
179-E32 BU-16
180-E33 GN-16
307-E55 OR-16
308-E56 YL-16
320-E66 RD-18
607-E40 PK-16
615-E73 YL-16
200-E51 BK-14
235-E65 BK-18
199-E36 OR-18
646-E50 RD-18

603-E58 PK-18
200-E75 BK-16

RD-10
RD-14
RD-14
GN-16
RD-18
PU-18
YL-18
GY-16
BU-16
BR-18
GN-18

OR-16
PK-18
5 633-E85 BU-16 151-E20 GN-16 4 GROUND 4 200-A113 BK-16 229-A96 BK-16 SPKR LH(-) 3

103-E1 RD-18
105-E3 RD-16
113-E6 OR-18
2434509 2312295 2065208
151-E31 GN-16 5 +24 V SWITCHED IN 5 179-A115 BU-16 1 113-AJ1OR-18 AUX-SPKR(-) 4
A/C CLUTCH SOL C-C25 GND PLATFORM 6 +24 V BATTERY IN 6 179-A116 BU-16 2 200-AJ3BK-18 SPKR RH(-) 5
2597243 2304011 509-AJ4WH-18 ILLUM 6

102-E105

147-E103

616-E102

E997-E38
K924-E77
P944-E87
140-E104

H807-E42
M935-E96
P946-E28
3 2 3

168-E27
130-E16
131-E34
151-E31
172-E69
310-E18
317-E83
322-E67
633-E85
892-E80
893-E81

709-E37
801-E39
1 E554-C89 PK-18 L105 L105 4 512-AJ5GN-18 BACKUP 7
2 200-C92 BK-18 196-E22 BU-16 1 SPKR LH(+) 8

638-E53 WH-16
200-E75 BK-16
308-E68 YL-18 5 5 6 AUX-SPKR(+) 9
L198 892-E80 BR-18 6 103-AJ6 RD-16 4 M-C7
ATCH MSS CONT 7 508-AJ7 PU-18 8 9 SPKR RH(+) 10
H 893-E81 GN-18 BREAKER 307-AL17 OR-16 307-AL14 OR-16 2075262 8 511-AJ8 BR-18 2 1 7Y3966 H
200-E19 BK-16 1712210 307-AL16 OR-16 307-AL15 OR-16 AL-C1 2 1 7 1
235-E65 BK-18 A346-AL5 BU-18 1506766 L144 CONN 56 3 11 12 3
ENG OIL LEVEL SW K-C7 109-WH1 RD-6 L184 A347-AL13 GN-18 172-AL1 RD-18 +B 10 M-C8
2130677 1 BACKUP SW BACKUP GOV SW
1552269 80A M732-AL28 OR-18 2 GN-C2 GATEWAY WORLDVIEW MODULE L171 BACKUP EPR 7Y3967
1 C468-K24 BU-18 M733-AL31 PK-18 235-AL4 BK-18 3 GND 1607690 2399954 TRA RH 1636711 1
235-K25 BK-18 101-WJ1 RD-6 L8 L10 4 VALVE SW
2 1 1636711 1636710
A346-AL5 BU-18 5 DRVR #2 OUT 2
308-AL12 YL-16 T901-AL6 YL-18
6
7 EXCITER COIL
3
4
CONSOLE RH

168-E27 RD-10
DISCONNECT SW E-C20 403-AL20 GN-18 T902-AL29 PK-18 53 EXCITER COIL 5

101-WJ1 RD-6
101-WE1 RD-6
109-WH1 RD-6
109-WA1 RD-8
304-WC1 WH-8
L183

645-E100 RD-18

RD-16
GY-18
GY-18
BU-18
BU-16
GY-18

BU-18
PK-18
OR-18
GN-18

GN-16
RD-14
BK-18
YL-16
OR-16
RD-18
RD-18
PK-16
RD-16
YL-16
GY-14

124-E14 GN-14
120-E12 YL-16
199-E36 OR-18
179-E32 BU-16
129-E15 BU-16
603-E58 PK-18
307-E55 OR-16
200-E75 BK-16
123-E13 WH-18
200-E51 BK-14

GN-16
RD-18
K-C6 7N0718 7Y3967 172-AL2 RD-18 172-AL1 RD-18

OR-16
8 6
RD-16

RD-18

113-E6 OR-18
E-C36

BR-18
PU-18

BU-16

YL-16

102-E105 BU-14
YL-18

BR-18
GY-18
BU-18

BU-16
SPEED SENSOR

RD-14

YL-18

172-E69 RD-18
801-E39 PK-18
GN-18
BR-18

GY-16
RD-14
PU-18

GN-16
OR-16
BU-16
1552269 7N0719 1 180-E33 GN-16 2304011 308-AL8 YL-16 308-AL8 YL-16 9 DRVR #1 SPLY 7

A579-A125 OR-14

A580-A123 BR-14
6V2455

A537-A16 PK-16
199-A135 OR-18

G976-A39 BU-18

C569-A91 YL-16

YL-18

BU-18
1 788-K22 YL-18 C-C17 C-C26 AL-C4 308-AL9 YL-16 10 8 CAT DATA LINK +

200-A66 BK-18
892-A37 BR-18
893-A36 GN-18
103-A47 RD-16
113-A49 OR-18
430-A34 BU-18
487-A29 OR-18
506-A33 PU-18
118-A65 GY-14
129-A61 BU-16

603-A80 PK-18

135-A67 BU-16
210-A70 BK-16
229-A96 BK-16

646-A54 RD-18
123-A52 WH-18
BK-18
RD-18
PK-16
GN-18
GY-18
BU-18
PK-18
GN-18
WH-18
YL-16

BK-14
YL-16
PU-18
WH-18
BR-18
GN-18
M953-K23 BU-18 E-C21 E-C37 2305010 2434508 2434508 308-AL10 YL-16 A347-AL13 GN-18 DRVR #1 OUT CAT DATA LINK -

1
2
2 11 9

125-E106
K948-E97
K951-E88
X976-E72
K909-E89
K945-E98

251-A136 YL-18
261-A137 GN-18
A346-AM4
M733-AM1
M732-AM2
A347-AM3

C904-AM6
175-E30
235-E65
615-E73
127-E71
320-E66
150-E35
607-E40
154-E24
308-E56
118-E11

151-E20
646-E50
200-CE1 BK-00 7Y3967 2434505 172-C65 RD-18 172-AL3 RD-18 403-AL19 GN-18

307-AM5
105-E3

103-E1

1 1 12 10

E997-E38
147-E103

140-E104

K924-E77
H807-E42

P946-E28
P944-E87
M935-E96

616-E102
130-E16

317-E83
893-E81
892-E80

322-E67
131-E34
310-E18

151-E31
709-E37
633-E85
1 176-E17 YL-16 308-C183 YL-16 2 2 308-AL11 YL-16 892-AL25 BR-18 13 11

L919-A40

C468-A38
200-CH1 BK-00 403-C195 GN-18 3 3 403-AL21 GN-18 14 12

235-A68
645-A55
607-A58
403-A59
405-A44
412-A35
491-A30
495-A31
496-A32
308-A60
CONN 30

200-A69
615-A62
508-A28
509-A20
511-A27
512-A26
STARTER MOTOR 892-C191 BR-18 4 4 892-AL27 BR-18 893-AL22 GN-18 15 13 RS-232 PORT #1-TXD
272-7123 893-C193 GN-18 5 5 893-AL24 GN-18 235-AL4 BK-18 16 14
304-K20 WH-8 235-C188 BK-18 6 6 235-AL46 BK-18 235-AL18 BK-18 17 15
G S E-C23 E-C24 E-C25 E-C26 AM-C5 235-AL44 BK-18 307-AL14 OR-16 18 DRVR #2 SPLY 16
E-C22 235-AL18 BK-18 19 GND 17
MTR BAT 101-K21 RD-4 2304009 2434510 2312295 2304009 2434510 2305010 892-AL26 BR-18 A-C28 A-C7
20 18 1211168 1027964
10
11
12

10
11
12

10
11
12

10
11
12
CONN 10 A-C10 CONN 16 CONN 17 CONN 19 CONN 20 893-AL23 GN-18 A-C8
1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9
CONN 18 21 19

1
2
3
4
5
6
101-CR1 RD-00 CONN 55 2434510 A-C12 A-C13 BLOCK AS 235-AL32 BK-18 22 20 1288951
AL-C6 CONN 42 CONN 43 CONN 44
MOTOR C-C15 C-C19
CAB

10
11
12
13
14
15
16
17
18
19
20
21

10
14

11
12
13
15
16
17
18
19
20
21
101-CA1 RD-00 2434509 7Y5499

1
2
3
4
5
6
7
8
9

1
2
3
4
5

6
7
8
9

1
2
3
4
5
6
7
2304009 2434510 2304009 2434508 23 21
C-C33 C-C34 AL-C10 AL-C3 AL-C2 308-AL10 YL-16 24 KEY ON 22 RS-232 PORT #1-RXD F-C10

E997-C150 BR-18

P946-C157 BR-18
175-A106 RD-14

127-A140 OR-16

308-A101 YL-16

YL-16
OR-18
BU-16

200-A143 BK-14

GY-18
GY-18
BU-16
BU-16
GY-18

130-C154 RD-14
147-C181 PU-18
893-C117 GN-18
892-C115 BR-18
H807-C57 YL-18
131-C153 RD-14
310-C158 PU-18
K924-C56 YL-18
317-C106 YL-18

801-C147 PK-18

P944-C59 GY-18
M935-C60 BU-18
151-C148 GN-16
F-C8

172-C65 RD-18
RD-18
F-C9
235-A71 BK-14
105-A94 RD-16
615-A62 YL-16
320-A77 RD-18
103-A48 RD-16
607-A25 PK-16
154-A74 RD-16
118-A51 GY-14

GN-14

BU-16
PK-18
RD-18
OR-16
113-A50 OR-18
123-A52 WH-18

GN-16
RD-16

168-C52 RD-10

140-C64 BU-16
322-C55 GY-18

102-C93 BU-14

709-C61 OR-16
616-C62 BU-16
2304011 2434505 2434505 1552269 1552269 25 23 RS-232 PORT #1-DTR 1114815

101-C97 RD-4
109-C91 RD-4
304-C96 WH-8
150-A1 RD-16

101-CF1 RD-00 T901-C67 YL-18 T901-AL7 YL-18 1 1 T901-AL6 YL-18 403-AL19 GN-18 26 ALT R TERM. 24 1027964 1211168
1 1 +

PK-18
OR-18

GN-16
GN-18
BU-18
OR-16
T902-C134 PK-18 2 CONN 29 2 T902-AL30 PK-18 2 2 T902-AL29 PK-18 27 25 -
STRAP PC 28 26 ATCH CAB LAMP(LH)
120-A110
199-A135
179-A112

K948-A93
K951-A12
X976-A13
K909-A24
K945-A11
646-A54
124-A46

129-A61
603-A80
645-A55
307-A23

151-A75
125-A72
1288886 FERRITE COIL AS 29 27 SPEAKER(R) F-C13 R-C1 R-C3 1673441
AL-C5 AL-C9 GN-C1 2223870 30 28 7Y3967 7Y3966 7Y3967

M733-AL31
M732-AL28

C904-AL45
A347-AL13
2148889

A346-AL5
307-AL17
G GND CHASSIS 1 2305010 2434508 2434508 307-AL15 OR-16 31 CRANK POSN IP 29 1 1 RD-16 G
172-AL2 RD-18 1 1 32 30 RS-232 PORT #1-CDC
308-AL12 YL-16 2 2 33 31 RS-232 PORT #1-GND F-C14 R-C2 R-C4
403-AL20 GN-18 3 3 34 32 + 7Y3966 7Y3967 7Y3966
892-AL26 BR-18 4 CONN 28 4 35 33 - 1 1 WH-16
893-AL23 GN-18 5 5 36 34 J1939 LOW ATCH CAB LAMP(RH)
235-AL32 BK-18 6 6 37 35 SPEAKER(L) F-C15 R-C1 R-C3 1673441
38 36 2148889 7Y3967 7Y3966 7Y3967
C-C8 C-C23 39 37 1 1 RD-16
3E3364 1552269 GL-C2 GL-C1 GN-C5 40 38

10
11
12
1
2
3
4
5
6
7
8
9
1 1 310-C158 PU-18 L88 AL-C7 8T8732 2434508 2305010 41 39 F-C19 R-C2 R-C4
2 2 200-C159 BK-18 2304009 B 1 1 893-AL22 GN-18 42 CDL(+) 40 7Y3966 7Y3967 7Y3966
C 2 2 43 41 1 1 WH-16
START AID SOL A 3 CONN 27 34 44 42
2391134 L152 4 892-AL25 BR-18 45 CDL(-) 43 F-C12
(Dimensions: 39 inches x28 inches) RED

ENG CONT K-C1 5 5 46 44 2304011 WINDOW LIMIT SW

1723353 1607689 6 6 235-AL44 BK-18 47 GND 45 DOME LAMP 1892054
F-C31 6C9121

1
2
1 48 46
ANALOG SENSOR POWER 2 C-C12 49 47 2434505
ANALOG SENSOR RETURN 3 7Y3966 50 48 CONN 41
THROTTLE POWER 4 1 200-C160 BK-18 51 49
THROTTLE RETURN 998-K1 BR-18 AIR CLEANER SW C-C13 M732-AL28 OR-18 DRVR #2 RTN J1939 HIGH AJ-C3

1
2
5 CONN 26 52 50
6 1626208 7Y3967 54 51 2434505

P946-C157 BR-18

E997-C150 BR-18
147-C181 PU-18

310-C158 PU-18
317-C106 YL-18

892-C115 BR-18
893-C117 GN-18
H807-C57 YL-18
K924-C56 YL-18
M935-C60 BU-18
P944-C59 GY-18
130-C154 RD-14
131-C153 RD-14
151-C148 GN-16
801-C147 PK-18

120-A110 YL-16

127-A140 OR-16

175-A106 RD-14
179-A112 BU-16
199-A135 OR-18
308-A101 YL-16

K909-A24 BU-16
K948-A93 GY-18
K945-A11 GY-18
K951-A12 GY-18
X976-A13 BU-16
BK-14
BK-14

BK-14

BK-14

BK-14
102-C93 BU-14
140-C64 BU-16
168-C52 RD-10
172-C65 RD-18

322-C55 GY-18
616-C62 BU-16
709-C61 OR-16

103-A48 RD-16
105-A94 RD-16
113-A50 OR-18
118-A51 GY-14
123-A52 WH-18
124-A46 GN-14
125-A72 RD-16
129-A61 BU-16
151-A75 GN-16
154-A74 RD-16

307-A23 OR-16
320-A77 RD-18
603-A80 PK-18
607-A25 PK-16
615-A62 YL-16
645-A55 RD-18
646-A54 RD-18

BK-18
BK-18
BK-14

BK-18
BK-18
430-C162 BU-18 GK-C1 GN-C3 55 UNSWITCHED POWER
101-C97 RD-4
109-C91 RD-4

304-C96 WH-8

7 52

150-A1 RD-16
1 MONITOR
CAT DATA LINK (+) 8 893-K2 GN-18 2434508 2305010 56 53 F-C22 2218941
CAT DATA LINK (-) 9 892-K3 BR-18 1 57 54 ALTERNATOR R-TERM 2397356
10 2 M733-AL31 PK-18 58 DRVR #1 RTN 55 1 FUEL LEVEL

113-AJ1 OR-18
139-AJ9 OR-18
235-A131
235-A132

200-A143

235-A131

235-A132
235-A68
235-A43
235-A71

235-A43
235-A68
11 109-C91 RD-4 ATCH WATER SEPARATOR LEVEL SEN 3 59 56 2 COOLANT TEMP

GN-14
YL-16
OR-18
BU-16
BU-16
RD-18
OR-16
BK-16
OR-18
WH-18
BK-14

A513-AJ10 RD-18
12 403-C88 GN-16 1719091 C-C21 C-C20 60 LED RED 57 3

A513-AJ10 RD-18
4 HYD OIL TEMP

592-AJ11 BU-18
592-AJ11 BU-18
200-AJ2 BK-18

200-AJ2 BK-18
509-AJ4 WH-18
508-AJ7 PU-18

512-AJ5 GN-18
511-AJ8 BR-18

200-AJ3 BK-18
103-AJ6 RD-16
13 C468-C86 BU-18 3E3376 1552272 5 61 58 4 ALT R-TERM.
14 E554-C89 PK-18 +B 1 1 147-C163 PU-18 6 62 LED GREEN 59 GROUND-CAB 2 5 NU
15 GND 2 2 235-C121 BK-18 63 60 6 NU

124-AL33
120-AL34
199-AL35
179-AL36
129-AL37
645-AL39
307-AL16
200-AL40
113-AL41
123-AL42
200-AL43
16 200-C87 BK-4 SIGNAL 3 3 G976-C166 BU-18 1 308-AL9 YL-16 64 DRVR #2 ENABLE 61 7 NU
17 200-C92 BK-18 4 4 GK-C3 2 65 62 RS-232 PORT #3-TXD 8 ENG OIL PRESS.
18 1552252 3 66 63 RS-232 PORT #3-RXD 9 ENG OIL LEVEL
F F

10
11
12
K-C5 C-C28 RS-232 PORT #3-GND

1
2
3
4
5
6
7
8
9
19 4 67 64 10 COOLANT LEVEL
ETHER RELAY 20 317-K19 YL-18 1275486 1275485 5 68 65 GROUND 11 HYD OIL LEVEL
235-C123 BK-18 235-C167 BK-18 GND CHASSIS 2

GND
304-K20 WH-8 304-C96 WH-8 12

BATT +
21 1 69 66

KEY SW ON
AIH CONT STATUS

ALT R-TERM
RS-232 TXD
RXD
GND
DTR
DCD
AL-C8 6
THROTTLE BACKUP (ACCEL) 22 F717-K5 YL-18 CONN 7 2434510 GK-C2 GN-C4 70 67 AJ-C4 AJ-C2 F-C23

10
11
12
THROTTLE BACKUP (DECEL) 23 F718-K6 BU-18 COOLANT LEVEL SW 68 2304009

1
2
3
4
5
6
7
8
9
2305010 2434508 2312295 2305010

RS-232
RX-232
RX-232
RX-232
24 K-C4 C-C29 2459206 L97 69 1 + BATTERY
1275483 1275484 C-C14 CONN 25 KEY SWITCH ON AJ-C5

1
2
3
4
5
6
7
8

1
2
3
4
5
6
25 L41 70 3 ACC
26 101-K21 RD-4 1 101-C97 RD-4 1552269 2434509 4 NU

+12 V MEMORY OUT

+12 V SWITCHED OUT
12V GROUND
24V GROUND
+24 V BATTERY IN
+24 V SWITCHED IN
27 CONN 6 1 412-C169 BU-18 7 CDL +
LOW OIL PRESSURE OUTPUT 28 405-K7 GY-18 2 235-C123 BK-18 PROD LINK 2ND GENERATION RADIO 8 CDL -
RENR7307-01

29 2429230 5 CAN3 +
30 K-C3 C-C2 F-C7 ACTION ALARM 6 CAN3 -
31 2434508 2305010 L77 L89 1552269 1321829 2 GND
32 C468-K24 BU-18 1 C468-C86 BU-18 UNDER WINDOW 1 9
LIMIT SW J1939 SHIELD
33 235-K25 BK-18 2 235-C90 BK-18 2 10 J1939 +
34 3 1892054 11 J1939 -
35 788-K22 YL-18 4 788-C98 YL-18 12 ALARM
36 M953-K23 BU-18 5 M953-C99 BU-18 200-C160 BK-18 C-C10 RESISTOR 1 F-C5 SERVICE METER
37 405-K7 GY-18 405-K7 GY-18 6 405-C100 GY-18 3E3370 1743016 1532602 1978832
38 102-K9 BU-14 200-C159 BK-18 251-C141 YL-18 A 1 +B F-C3
39 102-K8 BU-14 CONN 5 261-C156 GN-18 B F-C20 9G1906
40 102-K10 BU-14 K-C2 C-C22 200-C177 BK-16 C RADIO CONVERTER 1532602 1 CIGAR LIGHTER
41 102-K17 BU-14 2434510 2304009 2341004 1 GROUND 2382318
102-K17 BU-14 102-K17 BU-14 102-C93 BU-14

1
42 1 L78 F-C21
43 229-K12 BK-14 229-K18 BK-14 2 229-C101 BK-14 1532602 F-C6
44 229-K13 BK-14 998-K1 BR-18 3 998-C102 BR-18 A/C CONDENSOR 200-C173 BK-16 VALVE CONT C-C31 1 SIGNAL 1532602
45 229-K14 BK-14 892-K3 BR-18 4 892-C103 BR-18 1449712 1607689 C-C1 1573200 1607690
46 229-K18 BK-14 893-K2 GN-18 5 893-C104 GN-18 BK-14 C-C24 F889-C109 WH-18 1 THROTTLE POSITION (TO ADEM) +B 1 130-C1 RD-14 F-C32 RESISTOR
47 L39 6 1552267 M962-C40 YL-18 2 RH JOYSTICK (X-AXIS) GND 2 235-C2 BK-14 WIPER CONT 3E3370 1743016
+B 48 102-K8 BU-14 308-K16 YL-16 L40 317-K19 YL-18 7 317-C106 YL-18 + A 514-C176 PU-16 M957-C152 GY-18 3 TRAVEL LEFT PEDAL STICK (RETRACT) 3 K928-C11 GN-18 1887681 A
49 317-K19 YL-18 F717-K5 YL-18 8 F717-C107 YL-18 MOTOR B C506-C129 WH-16 M954-C119 BU-18 4 LEFT ATT PEDAL ATT RETRACT 4 P958-C12 PK-18 +24V 11 B
50 892-K3 BR-18 F718-K6 BU-18 9 F718-C108 BU-18 - C 200-C177 BK-16 403-C196 GN-18 5 ALTERMATOR (R TERM) UNUSED 5 BRAKE WIP 10 C
PU-18

893-K2 GN-18 F889-K15 WH-18 F889-C109 WH-18 261-C143 GN-18 M935-C144 BU-18
BU-18

BR-18

GN-18

WH-16
51 10 6 CANL 6 MOT WIPER 9
P946-C157 BR-18

F889-C109 WH-18

M953-C112 BU-18

M953-C164 BU-18

BU-16

WH-18
YL-18
BU-18
BU-18
PS PRESS SOL
PU-18

GN-18
GY-18
OR-18
PU-18
BU-18
BR-18
PK-18
BK-18

BU-18
PK-18
SWITCH PANEL
147-C181 PU-18

310-C158 PU-18
317-C106 YL-18

892-C115 BR-18
893-C117 GN-18
H807-C57 YL-18
K924-C56 YL-18
M935-C60 BU-18
P944-C59 GY-18

403-C195 GN-18

403-C140 GN-18
403-C196 GN-18

892-C113 BR-18
893-C116 GN-18
C472-C39 GN-18
E456-C43 WH-18
G426-C46 WH-18
H441-C49 GN-18
H446-C45 PK-18
M937-C41 GN-18
M938-C42 GY-18
M953-C99 BU-18
M953-C94 BU-18

M953-C94 BU-18
E789-C38 PU-18
PU-18
PU-18
PK-18
PK-18
PK-18
BU-18
YL-18
BR-18
WH-18
YL-18
PK-18
BU-18
GN-18
GN-18
GN-18
GN-18
BU-18
BR-18
OR-18
YL-18
OR-18
YL-18
OR-18
YL-18
BR-18
PK-18
PU-18
PU-18

BK-14
BK-14
YL-16
YL-16
YL-16
GY-18
BU-18
BU-18

PU-16
BR-18
BR-18
BR-18
893-C118 GN-18
893-C193 GN-18
893-C194 GN-18
BR-18

YL-18

OR-18
YL-18
OR-18
YL-18
OR-18
YL-18
BR-18
PU-18
BU-14
BU-16

168-C52 RD-10
172-C65 RD-18

F-C1
322-C55 GY-18
616-C62 BU-16
709-C61 OR-16

403-C88 GN-16

497-C95 OR-18
788-C98 YL-18

321-C13 BR-18

OR-18
PK-18
GN-18
WH-18

PK-18
+B 998-K1 BR-18 F716-K11 WH-18 F716-C110 WH-18 BK-14 251-C141 YL-18 892-C113 BR-18
RD-4
RD-4

304-C96 WH-8

52 102-K9 BU-14 11 7 CAT DATA LINK (-) UNUSED 7 WASHER SW 8

E +B 53 102-K10 BU-14 F716-K11 WH-18 308-K16 YL-16 12 308-C111 YL-16 251-C135 YL-18 893-C116 GN-18 8 CAT DATA LINK (+) UNUSED 8 12V/7A SOCKET A INT-2 7 1636659 2277576 E
54 F717-K5 YL-18 261-C156 GN-18 M948-C120 BR-18 9 JOYSTICK GND SWING PUMP SWASH 9 P959-C145 GN-18 130-C154 RD-14 1210987 INT-1 6 A1 ACC
F718-K6 BU-18 CONN 4 261-C143 GN-18 H704-C66 PK-18 GND
M933-C151

A2
M935-C144

P946-C149

P959-C145

C506-C129

55 10 TEMP SENSOR POWER 10 GND 5

K909-C128

F716-C110
F717-C107
F718-C108
G976-C166
UNUSED
147-C163
101-C97
109-C91

P943-C37
P944-C18
P945-C48
P949-C36
P955-C47
P957-C31
P958-C12
235-C188

C468-C86
E554-C89
E789-C69
E789-C76
E790-C75
E790-C68
E790-C33
K907-C28
E998-C30
F853-C29
H716-C27
H807-C15
H704-C66
K927-C14
K928-C11
K929-C26
K930-C24
K931-C25
K932-C34
K934-C35
K943-C21
K944-C20
K946-C23
K947-C22
K949-C19
K950-C16
K952-C17
L982-C32
M933-C44
M933-C70

235-C190
235-C189
308-C184
308-C183
308-C111
405-C100
412-C169
430-C162

514-C176
892-C114
892-C191
892-C192

998-C102

H807-C77

K943-C78
K944-C79
K946-C80
K947-C81
K949-C82
K950-C83
K952-C84
147-C53
102-C93
140-C64

487-C71
491-C74
495-C73
496-C72

607-C54
56 F889-K15 WH-18 497-C95 OR-18 11 +8V-SEN TRAVEL ALARM 11 321-C13 BR-18 130-C1 RD-14 MOT WASH 4 A3 CAN3 +
57 251-C63 YL-18 M953-C94 BU-18 12 SENSOR RETURN PROD DR RET 12 K927-C14 BU-18 130-C4 RD-14 3 A4 CAN3 -
M947-C122 OR-18 E789-C38 PU-18 130-C6 RD-14 A5

1
58 13 JOYSTICK +12V PROD DR RET 13 WIPER SW 2 CAN3 SHIELD
USER DEFINED SHUTDOWN 59 F716-K11 WH-18 261-C58 GN-18 M950-C125 PU-18 14 LH JOYSTICK (Y-AXIS) STICK (EXTEND) 14 K930-C24 GN-18 F-C29 WINDOW SW 1 A6 AIR CLEANER SW
60 AH A755-C136 PK-18 M956-C126 GN-18 15 TRAVEL RIGHT PEDAL BUCKET (EXTEND) 15 K931-C25 GN-18 131-C153 RD-14 1532602 F-C26 A7 CAPSULE FILTER SW
-B 61 229-K12 BK-14 T962-AG47 WH-18 1 INJECTOR A756-C137 BU-18 M960-C127 PU-18 16 RIGHT ATT PEDAL BUCKET (RETRACT) 16 K929-C26 GN-18 131-C8 RD-14 1886406 A8 SP FILTER SW
62 SOL 1 A757-C132 GY-18 17 KEY PAD UNUSED 17 131-C10 RD-14 GROUND-CAB 1 A9 WTR SPR LEVEL SW
-B 63 229-K13 BK-14 T956-AG36 GY-18 2 L90 A758-C133 BR-18 251-C135 YL-18 18 CANH PROD DR RET 18 H716-C27 WH-18 151-C148 GN-16 A10
64 CONN 1 A768-C142 BU-16 19 CAN SHLD SWING BRAKE SOL 19 K907-C28 BU-18 801-C147 PK-18 A11
-B 65 229-K14 BK-14 AG AH AH K847-C155 PU-18 20 ANGL/PWM 5K TRAVEL SPEED SHIFT SOL 20 F853-C29 BR-18 E997-C150 BR-18 A12
THROTTLE 66 F889-K15 WH-18 K848-C197 WH-18 M945-C124 BR-18 21 LEVER TOP SW FLOW CONT RH-L UNUSED 21 K927-C14 BU-18
67 T962-AG47 WH-18 13 T961-AG46 GN-18 1 INJECTOR L919-C139 YL-18 M942-C171 WH-18 22 LEVER TOP SW FLOW CONT LH-R GND 22 235-C3 BK-14 H704-C66 PK-18 12/7A SOCKET B 1
68 T956-AG36 GY-18 6 T955-AG35 GN-18 2 SOL 2 L972-C138 BU-18 K847-C155 PU-18 23 ANGL/PWM 5K +B 23 130-C4 RD-14 321-C13 BR-18 1210987 2 OLWD CANCEL SW
69 L76 L86 M942-C171 WH-18 M963-C130 BU-18 24 RH JOYSTICK (Y-AXIS) RADIATOR FAN SPEED 24 E998-C30 YL-18 E789-C38 PU-18 3 OPTION STG SW
IGNITION KEY SW 70 308-K16 YL-16 T961-AG46 GN-18 14 M943-C165 YL-18 M949-C131 PK-18 25 LH JOYSTICK (X-AXIS) ATT EXTEND 25 P957-C31 BR-18 E790-C33 PK-18 4
T955-AG35 GN-18 5 AH M944-C146 BU-18 26 UNUSED SPI LOAD 26 E998-C30 YL-18 5
M945-C124 BR-18 788-C98 YL-18 F853-C29 BR-18

1
1 T960 AG31 BU-18 15 T960 AG31 BU-18 1 INJECTOR 27 ENG SPEED SPI DATA 27 6
BOOST PRESS 2 G828-AG1 BR-18 SOL 3 M947-C122 OR-18 A757-C132 GY-18 28 THROTTLE DIAL S3 UNUSED 28 H716-C27 WH-18 F-C30 7
BOOST PRESS 3 G829-AG2 GN-18 T954-AG24 GY-18 4 T954-AG24 GY-18 2 M948-C120 BR-18 A758-C133 BR-18 29 THROTTLE DIAL S4 UNUSED 29 L62 H807-C15 YL-18 PLATFORM-CHASSIS 1532602 8 OPTION ROCKER SW
4 T959-AG30 BR-18 16 M949-C131 PK-18 30 HAMMAR 2 SPEED SW HYD LOCK SW 30 151-C148 GN-16 K907-C28 BU-18 STRAP PA 7G1060 9 WASHER
DIGITAL RETURN 5 998-AG3 BR-18 M950-C125 PU-18 L80 K848-C197 WH-18 31 ANLG/PWM 5K CTWT REMOVAL SW 31 L982-C32 PK-18 K909-C128 BU-16 10 WIPER INT-3
6 T953-AG23 BU-18 3 AH M954-C119 BU-18 32 DIR/PASSIVE (2+) LOW CUR SINK DR1 32 K928-C11 GN-18 11 WIPER INT-6
7 T958-AG29 YL-18 17 T959-AG30 BR-18 1 INJECTOR M956-C126 GN-18 33 DIR/PASSIVE (2-) LOE CUR SINK DR2 33 K929-C26 GN-18 12 WIPER LOW
SOL 4 M957-C152 GY-18 34 RS232 RX2 34 K930-C24 GN-18 13 CHAS LAMP RELAY
WH-16
BU-18

WH-18
YL-18
BU-18
WH-18

H807-C161 YL-18

OR-18

YL-18

OR-18

K947-C180 YL-18

K949-C174 OR-18
K950-C170 YL-18

BR-18

PU-18
BU-18

BU-18

P946-C157 BR-18
P946-C149 BR-18
P946-C179 BR-18

M953-C112 BU-18

P959-C145 GN-18

8 T952-AG22 BR-18 2 T953-AG23 BU-18 2 LOW CUR SINK DR3

PU-18
PU-18
BU-18
BU-18
PU-16

BK-18
BK-16
200-C173 BK-16

BK-18
BK-14

BK-14

YL-16
YL-18
GY-18
BR-18
BR-18
BR-18
BR-18
GN-18
GN-18
GN-18
GN-18
BR-18
BU-18
PK-18

BU-18
200-C187 BK-18
200-C185 BK-18
200-C186 BK-18
E789-C76 PU-18
E790-C75 PK-18
F853-C29 BR-18
H807-C57 YL-18
H807-C77 YL-18
H807-C15 YL-18

YL-18
BU-18
GN-18
GN-18
GN-18
GN-18
OR-18
OR-18

K944-C20 YL-18
K944-C79 YL-18

OR-18
OR-18

K947-C81 YL-18
K947-C22 YL-18

K949-C82 OR-18
K949-C19 OR-18

K950-C83 YL-18
K950-C16 YL-18

BR-18
BR-18

BU-18

GN-18
GY-18
GN-18
GY-18
GY-18
GY-18
P945-C48 OR-18

P949-C36 PU-18
P955-C47 BU-18
P957-C31 BR-18
P958-C12 PK-18
H704-C66 PK-18

C472-C39 GN-18
E456-C43 WH-18
E789-C69 PU-18
E998-C30 YL-18
G426-C46 WH-18
K932-C34 BU-18
K934-C35 BR-18
L982-C32 PK-18

M933-C70 PU-18
H441-C49 GN-18
H446-C45 PK-18
H716-C27 WH-18

308-C183 YL-16
403-C195 GN-18
892-C191 BR-18
893-C193 GN-18
235-C188 BK-18
E790-C68 PK-18
K907-C28 BU-18
BK-18
BK-18

BK-18
BK-18
BU-14

GN-16
YL-18

321-C13 BR-18

140-C64 BU-16
147-C53 PU-18
168-C52 RD-10
322-C55 GY-18
487-C71 OR-18
491-C74 PK-18
495-C73 GN-18
496-C72 WH-18
497-C95 OR-18
607-C54 PK-18
616-C62 BU-16
709-C61 OR-16

172-C65 RD-18

AIR HEATER RELAY J702-AG4 BK-18 M960-C127 PU-18 35 RS232 RX1 K931-C25 GN-18 14
BK-4
BK-4

RD-4
RD-4
WH-8

9 T957-AG28 PU-18 SPI CLOCK 35 GROUND-CHASSIS 7 GROUND-PLATFORM 2 BOOM LAMP RELAY

10 18 M962-C40 YL-18 36 SUCTION SHUT OFF ON/OFF RET 36 H807-C15 YL-18 K932-C34 BU-18 15 OPTION RELAY
11 T951-AG21 YL-18 1 AH M963-C130 BU-18 37 SUCTION SHUT OFF ON/OFF RET 37 E790-C33 PK-18 K934-C35 BR-18 16
AIR HEATER RELAY 12 G850-AG5 BU-18 M953-C164 BU-18 A755-C136 PK-18 38 THROTTLE DIAL S1 38 K909-C128 BU-16 K943-C21 OR-18 F-C27 17
C506-C129
G976-C166

F716-C110
F717-C107
F718-C108
F889-C109

K943-C178

K944-C175

K946-C182

K952-C172

M933-C151
M935-C144

M935-C168

T950-AG45 GN-18 T958-AG29 YL-18 INJECTOR BUCKUP SW

200-C87
200-C87

101-C97
109-C91
304-C96
147-C163
310-C158
412-C169
430-C162
514-C176

235-C167
200-C173

235-C167
229-C101

229-C101

308-C111
317-C106
405-C100
892-C103
892-C114
892-C115
892-C113
893-C117
893-C116
893-C118
893-C104
998-C102
C468-C86
E554-C89

M953-C99

K924-C56
K927-C14
K928-C11
K929-C26
K930-C24
K931-C25
K943-C78
K943-C21

K946-C23
K946-C80

K952-C84
K952-C17

M935-C60

M937-C41
M938-C42
P943-C37
P944-C59
P944-C18
P944-C85

7 1
200-C92
235-C90

235-C90
200-C92
102-C93

403-C88
788-C98

13 SOL 5 403-C140 GN-18 A756-C137 BU-18 39 THROTTLE DIAL S2 STB 4 39 K944-C20 YL-18 9W1951 18
ATM PRESSURE 14 A747-AG6 GY-18 T949-AG44 BU-18 8 T952-AG22 BR-18 2 40 DIR/PASSIVE (1+) SWING (LH) 40 K932-C34 BU-18 K946-C23 OR-18 B F-C2
15 T948-AG16 BR-18 9 41 DIR/PASSIVE (1-) SWING (RH) 41 K934-C35 BR-18 K947-C22 YL-18 D F-C16 F-C11 1636699
FUEL PRESSURE 16 C991-AG7 PK-18 403-C196 GN-18 42 RS232 TX2 GAIN/RESPONSE IND2 42 K949-C19 OR-18 E F-C18 1636803 F-C4 F-C28
D T947-AG15 YL-18 10 AH C-C32 497-C95 OR-18 K950-C16 YL-18 A F-C17 1636803 1636803 1636803 7Y3967 D
17 43 RS232 TX1 GAIN/RESPONSE IND1 43
30 Page, Color 2,

OIL TEMP COMMON 18 G833-AG8 PK-18 T946-AG10 PU-18 11 T957-AG28 PU-18 1 INJECTOR 1552269 788-C98 YL-18 44 UNUSED AUTO LUB RELAY 44 801-C147 PK-18 K952-C17 BR-18 CONN 40 C 1636803 1

4
3
2
1
5

4
3
2
1
5

4
1
3
2
5

4
1
3
2
5
19 SOL 6 K907-C28 BU-18 1 SWING BRAKE SOL 892-C113 BR-18 L972-C138 BU-18 45 ONE TOUCH LOW IDLE SW SYSTEM PRESS SOL 45 P949-C36 PU-18 L982-C32 PK-18 F

4
3
1
2
5
BRAKE RETURN 1 T945-AG9 GY-18 12 T951-AG21 YL-18 2 2 1211491 G
20 T945-AG9 GY-18 E790-C68 PK-18 893-C116 GN-18 46 NEUTRAL SW LH-X GND 46 235-C5 BK-14 M933-C44 PU-18 F-C24
BRAKE RETURM 2 21 T946-AG10 PU-18 L81 C472-C39 GN-18 L919-C139 YL-18 47 MANUAL LUB SW +B 47 130-C6 RD-14 M935-C144 BU-18 H 7Y3967
TDC PROBE 22 G856-AG11 WH-18 AG L64 E456-C43 WH-18 48 BACK LIGHT LOWERING CHECK STICK 48 P943-C37 GN-18 P943-C37 GN-18 J 1
TDC PROBE 23 G857-AG12 YL-18 994-AG13 GY-18 994-AG13 GY-18 WH F889-C109 WH-18 49 GAIN/RESPONSE SELECT SW PROD DR RET 49 P944-C18 GY-18
OIL PRESSURE 24 994-AG13 GY-18 C SENSOR SIGNAL OIL GND CHASSIS 4 G426-C46 WH-18 M943-C165 YL-18 50 LEVEL TOP SW CONT LH-L MED.PRESS CIRCUIT 1-A 50 P945-C48 OR-18 F-C25
25 G827-AG27 BU-18 G827-AG27 BU-18 B BK SENSOR COMMON PRESSURE H441-C49 GN-18 51 AMBIENT TEMP SENSOR BOOM (EXTEND) 51 K950-C16 YL-18 P946-C149 BR-18 7Y3967
26 G826-AG26 BR-18 G826-AG26 BR-18 A OR +5V L195 H446-C45 PK-18 C472-C39 GN-18 52 PUMP PRESS SENSOR PROD DR RET 52 K952-C17 BR-18 P949-C36 PU-18 1
P943-C37 GN-18
P944-C85 GY-16

PK-18

M937-C41 GN-18
M938-C42 GY-18
BU-18
GN-18
YL-18
BR-16
GN-18
BR-18
BU-18
OR-18

PU-18
PK-18
BR-18
PK-18
PU-18
YL-18
BU-18
PU-18

K947-C180 YL-18
K944-C175 YL-18
F853-C29 BR-18

200-C186 BK-18
OR-18
GN-18
OR-18

HEUI RAIL PRESSURE

OR-18
GN-18

M937-C41 GN-18 P955-C47 BU-18 ATCH SEAT HEATER SW ATCH OLWD WARNING DEVICE SW ATCH RADIO MUTE ATCH MANUAL LUB SW
BK-18

BR-18

YL-16

27 G849-AG14 BR-18 L83 53 NEUTRAL SW (HAMMER PEDAL) UNUSED 53

BRAKE RETUTN 3 28 T947-AG15 YL-18 M938-C42 GY-18 54 FLOW CONT ROCKER SW DRIFT REDUCTION VALVE 54 P946-C149 BR-18 P957-C31 BR-18 2382211 2382215 2382216 2382218
BRAKE RETURN 4 29 T948-AG16 BR-18 M953-C94 BU-18 M937-C41 GN-18 55 AUX 1WAY 2WAY LIMIT SW 1 HYDRAULIC LOCK SOL 55 E997-C150 BR-18 P958-C12 PK-18
30 G829-AG2 GN-18 M938-C42 GY-18 56 AUX 1WAY 2WAY LIMIT SW 2 GND 56 235-C7 BK-14 P959-C145 GN-18
147-U4 PU-18
M935-C168
K950-C170
K952-C172

H807-C161
M933-C151

P958-C12
K949-C174

K943-C178
K930-C24

K931-C25
P957-C31
P955-C47
P945-C48

P949-C36
H704-C66
K946-C182
E790-C75
E789-C76
K927-C14

K929-C26
K928-C11
200-C185

IDENT PART NO. LOC IDENT PART NO. LOC

321-C13

P946-C179

E456-C43 WH-18 131-C8 RD-14 235-C188 BK-18

K924-C56

31 57 AUTO LUB LOW LEVEL +B 57

COOLANT TEMP 32 995-AG17 BU-18 ATCH CWTE REMOVAL SW A768-C142 BU-16 58 KEY SW LOWERING CHECK BOOM 1 58 P944-C18 GY-18
OIL TEMP 33 K882-AG18 BU-18 1140521 M944-C146 BU-18 59 LEVER TOP SW FLOW CONT RH-R PROD DR RET 59 M933-C44 PU-18 235-C189 BK-14 HARNESS AS. WIRE AS. CONT.
OIL TEMP 34 E795-AG19 YL-18 G829-AG2 GN-18 B YL SENSOR COMMON 2434506 H441-C49 GN-18 60 AUTO LUB PRESS. SENSOR MED,PRESS CIRCUIT 1-B 60 616-N3 BU-16 ATCH BOOM LAMP LH A 251-0520 K-8 WJ 234-1193 H-12
INTAKE AIR TEMP C967-AG20 BU-18 ATMOSPHERIC 2 3 AH-C1 J-C21 H446-C45 PK-18 61 BOOM BTM PRESS SENSOR 61 K949-C19 OR-18 235-C9 BK-14 200-N4 BK-16
INJECTOR BRAKE 1
35 A747-AG6 GY-18 A747-AG6 GY-18 C GN SENSOR SIGNAL PRESSURE 1
L982-U1 PK-18 U-C1 2434506 2304013 G426-C46 WH-18
BOOM (RETRACT)
K944-C20 YL-18 235-C7 BK-14 J-C4 J-C26 N-C1 1532521 C 267-8049 K-8 WK 163-6758 L-12
36 T951-AG21 YL-18 G828-AG1 BR-18 OR L981-U2 YL-18 147-U4 PU-18 1 C-C3 C-C4 C-C5 C-C30 62 SWING PUMP PRESS SENSOR LH TRAVEL (FRONT) 62 E 224-2862 H-14
INJECTOR BRAKE 2 37 T952-AG22 BR-18 A +5V 5 6 L982-U1 PK-18 147-AH1 PU-18 1 147-J49 PU-18 2434510 2304009 2312295 2304013 63 STG 29 LH TRAVEL (REAR) 63 K943-C21 OR-18 2304011 2434505 2434505 WL 238-2440 C-6
INJECTOR BRAKE 3 T953-AG23 BU-18 4 2 2 L982-J49 PK-18 64 STG 28 64 K947-C22 YL-18 235-C190 BK-14 616-J22 BU-16 1 1 616-N1 BU-16 616-N5 BU-16 ATCH BOOM LAMP RH F 267-7682 G-4
38 200-U3 BK-18 3 RH TRAVEL (FRONT) CABLE AS.
10
11
12

10
11
12

INJECTOR BRAKE 4 200-J44 BK-18 CONN 12 L-C25 CONN 13 CONN 14 C-C27 G 251-0601 J-4
1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8

1
2
3

T954-AG24 GY-18 8 9 3 65 STG 27 65 K946-C23 OR-18 235-C5 BK-14 200-J23 BK-16 2 200-N9 BK-16 200-N6 BK-16
BOOST PRESSURE
39
40 A746-AG25 PK-18
G828-AG1 BR-18
7 2304009 2434506 66 STG 26
RH TRAVEL (REAR)
NEUTRAL FLOW BYPASS 66 P955-C47 BU-18 235-C2 BK-14 CONN 52 2 1532521 H 259-5098 L-4 CA 227-7049 J-18
OIL PRESSURE G826-AG26 BR-18 11 12 CONN 11 L-C26 L-C27 67 ATT PUMP PRESS SW P945-C48 OR-18 235-C3 BK-14
41 2434510 2434509 DRIFT REDUCTION VALVE STICK 67 J 251-0521 B-9 CC 8V-0622 J-17
OIL PRESSURE 42 G827-AG27 BU-18 10 68 AUTO LUB PISTON STICK UNUSED 68 K 224-2896 E-16
BR-18
PK-18
PU-18
YL-18
BU-18
PU-18

K947-L31 YL-18
K944-L33 YL-18
F853-L21 BR-18

BU-18
GN-18
YL-18
BR-16
GN-18
BR-18
BU-18
OR-18

PU-18
PK-18

P943-L27 GN-18
P944-L25 GY-16

PK-18
YL-16

CONN 15 CE 227-7050 J-17

BK-18

BR-18

OR-18
GN-18

OR-18
GN-18
OR-18

1
2
3

43 69 AUTO LUB PISTON SWING GND 69 235-C9 BK-14

INJECTOR RETURN 1 44 T957-AG28 PU-18 U-C2 147-J49 PU-18 70 AUTO LUB PISTON BUCKET +B 70 131-C10 RD-14 SYMBOL DESCRIPTION L 231-1664 C-13 CF 227-7135 H-18 (NOTE B)
INJECTOR RETURN 2 T958-AG29 YL-18 G829-AG2 GN-18 B YL SENSOR COMMON AN-C1 J-C3 M 251-0543 H-1
45 FUEL 1552269 2434506 CG 8V-0622 H-18 (NOTE B)
INJECTOR RETURN 3 46 T959-AG30 BR-18 G828-AG1 BR-18 A OR +5V L981-U2 YL-18 147-J53 PU-18 9X4813 ATCH ELE LUB PUMP N 251-0577 C-4
K952-L44
E790-L50
E789-L47
H807-L46
K927-L45
M933-L28

M935-L19
K930-L35
K950-L37
P946-L13
K931-L39
P957-L41
P955-L15
P945-L29

P949-L23
H704-L52

P958-L11
K924-L17

PRESSURE 1
200-L53

321-L48

K946-L1
K928-L5

K949-L7
K929-L9
K943-L3

INJECTOR RETURN 4 47 T960 AG31 BU-18 200-U3 BK-18 147-J17 PU-18 A A 1056989 CIRCUIT CONNECTED N 251-0578 C-4 (NOTE C) CH 227-7134 H-17 (NOTE B)
M937-AN3 GN-18
M938-AN5 GY-18

C991-AG7 PK-18 C991-AG7 PK-18 C GN SENSOR SIGNAL 2

200-AN1 BK-18

RUN 48 E964-AG32 WH-18 147-J11 PU-18 140-J26 BU-16 B B ON (KEY) P 251-0576 B-4 CP 234-1018 J-18 (NOTE B)
RUN 49 E963-AG33 BK-18 ATCH CWTW REMOVAL CONT SOL1 200-J27 BK-16 C C GND
OIL GRADE CODE 1 50 H477-AG34 YL-18 J-C12 R 167-3456 G-2 CR 2341017 I-18 (NOTE B)
C 1269992 PUMP PRESS. SENSOR 1552267 L82 CIRCUIT NOT CONNECTED R 170-9295 G-2 (NOTE D) C
51 2218859 STRAP AS.
52 +B 1 147-J11 PU-18 J-C6 J-C30 J-C5 J-C29 ATCH AUTO LUB PRESS.SENSOR T 234-1183 A-7
53 GROUND 2 M953-J3 BU-18 1552267 3E3370 2304013 2434506 2475177 ELECTRICAL CONNECTION TO U 238-2122 C-14 PA 7G-1060 D-6
INJECTOR BRAKE 5 54 T955-AG35 GN-18 G829-AG2 GN-18 BK SIGNAL 3 C472-J2 GN-18 L52 147-J52 PU-18 A A +B 140-J24 BU-18 1 1 +B X 238-1637 A-6 PC 128-8886 G-18
INJECTOR BRAKE 6 55 T956-AG36 GY-18 B SENSOR COMMON HEUI RAIL M953-J45 BU-18 B CONN 34 B GROUND OLWD PRESS SENSOR BOOM 200-J48 BK-18 2 2 GROUND
G828-AG1 BR-18 OR 2218859 MACHINE STRUCTURE Y 238-1595 A-4 PE 132-1805 G-16
P959-C145 GN-18

A +5V H446-J46 PK-18 C C SIGNAL H441-J4 GN-18 3 3 SIGNAL

M953-C112 BU-18
56 PRESSURE
G426-C46 WH-18
C472-C39 GN-18
H441-C49 GN-18

E998-C30 YL-18
H716-C27 WH-18
H446-C45 PK-18

AA 238-1597 A-4

L982-C32 PK-18
E789-C69 PU-18

K932-C34 BU-18
M933-C70 PU-18
K934-C35 BR-18
709-C61 OR-16
140-C64 BU-16
322-C65 GY-16
616-C62 BU-16

487-C71 OR-18
496-C72 WH-18
495-C73 GN-18
491-C74 PK-18

168-C52 RD-10
E456-C43 WH-18

497-C95 OR-18
57
607-C54 PK-18
147-C53 PU-18

G849-AG14 BR-18 G849-AG14 BR-18 C WH SENSOR SIGNAL L32 INTERNAL ELECTRICAL CONNECTION
CRANK 58 E966-AG37 YL-18 SWING PUMP PRESS. SENSOR J-C13 AH 238-2420 C-14 (NOTE E)
CRANK 59 E965-AG38 BU-18 2218859 +B 1552267 J-C2 J-C27 ATCH AUTO LUB PUMP TO SURFACE OF COMPONENT AJ 234-1124 F-5 COLOR ABBREVIATIONS
OIL GRADE CODE 2 H478-AG39 BU-18 1 147-J17 PU-18 140-J51 BU-16 L33 1552269 3E3364 2022916
60 AL 259-5008 G-9
CONN HEP 61 G854-AG40 PK-18 GROUND 2 M953-J6 BU-18 L56 140-J24 BU-18 ATCH REFUELING LEVEL SW WL-C1 709-J28 OR-16 1 1 ON (KEY) AM 238-1640 L-16
PU-18
PU-18
PU-18
PU-18
PK-18
PK-18
PK-18
BR-18
PK-18
YL-18
YL-18
YL-18
YL-18
YL-18
YL-16
BU-18
BU-18

BU-18

GN-18
GN-18

YL-18
YL-18
YL-18

BR-18
BR-18
BR-18
BR-18
BR-18
BR-18
BR-18
PU-18
BU-18
GN-18
GY-16
OR-18
BR-16
PU-18
BU-18
BR-18
PK-18

ATCH AUX 1WAY 2WAY LIMIT SW 1 J-C25 J-C8 ABBREV COLOR

BR-18

BU-18

GN-18
GN-18

OR-18
OR-18

OR-18
BR-18
BR-18
BR-18

200-L53 BK-18
200-L18 BK-18
200-L51 BK-18

CONN HEP 62 G855-AG41 PU-18 SIGNAL 3 G426-J5 WH-18 3E5181 140-J30 BU-16 5C6108 2304011 2434505 200-J29 BK-16 2 2 GND CONNECTOR
1 APC 63 E798-AG42 PK-18 G828-AG1 BR-18 A OR +5V TURB AN-C2 140-J26 BU-16 2304011 AN 238-2389 B-11
1 APC E797-AG43 WH-18 A746-AG25 PK-18 A746-AG25 PK-18 GN OUTLET 200-AN1 BK-18 1552272 322-J33 GY-16 325-WL1 PK-18 1 1 325-J39 PK-18 J-C1 J-C28 GH 259-5256 F-15 RD RED
64 C SENSOR SIGNAL 1 2 L59 2 CONN 39 2
BRAKE RETURN 5 65 T949-AG44 BU-18 PRESSURE 1 C-C18 607-J35 PK-18 1552267 3E3370 A ON (KEY) GJ 259-5285 F-15
E789-L42
E789-L40
E789-L36
E789-L47
E790-L22
E790-L49
E790-L50
F853-L21
H704-L52
H807-L24
H807-L16
H807-L14
H807-L30
H807-L46
K924-L17
K927-L12
K927-L10

K927-L45

K930-L35
K931-L39

K944-L33
K947-L31
K950-L37

K952-L20
K952-L43
K952-L38
K952-L34
K952-L32
K952-L26
K952-L44
M933-L28
M935-L19
P943-L27
P944-L25
P945-L29
P946-L13
P949-L23
P955-L15
P957-L41
P958-L11

G829-AG2 GN-18 B YL SENSOR COMMON 4 3 C-C6 C-C7 C-C9 168-J37 RD-10

321-L48

K927-L6

K928-L5
K929-L9

K946-L1
K943-L3

K949-L7
K952-L4
K952-L2
K952-L8

BRAKE RETURN 6 J-C14 200-AN2 BK-18 4 2434510 616-J22 BU-16 L60 140-J30 BU-16 H# CIRCUIT GROUPING DESIGNATION WH WHITE
66 T950-AG45 GN-18 2434509 2304009 1343296 200-J40 BK-18 A B GND GK 259-4967 F-9 (NOTE F)
INJECTOR RETUN 5 67 T961-AG46 GN-18 1552269 M937-AN3 GN-18 3 CONN 24 709-J28 OR-16 L32 200-J38 BK-10 200-J31 BK-16 B C SIG GL 259-4969 G-9 (NOTE F) OR ORANGE
10
11
12

10
11
12
INJECTOR RETUN 6 SWING PUMP SWASH SOL 1 P959-J7 GN-18 2 CONN 21 CONN 22 CONN 23 E456-J32 WH-18 E456-J32 WH-18
1
2
3
4
5
6
7
8

1
2
3
4
5
6
7
8
9

1
2
3
4
5
6
7
8
9
68 T962-AG47 WH-18 L53 J-C16 C GN 259-4968 F-8 (NOTE F)
69 2161397 2 H716-J8 WH-18 J-C17 J-C22 J-C20 H441-J4 GN-18 ATCH WIRE, CABLE, COMPONENT YL YELLOW
70 2312295 2434510 1343295 2304009 200-J48 BK-18
AG K882-AG18 BU-18 K882-AG18 BU-18 1 GN SENSOR SIGNAL ATCH AUX 1WAY 2WAY LIMIT SW 2 200-J23 BK-16 J-C31 P-C1 WIRE AS.
OIL TEMP

168-J37 RD-10
200-J38 BK-10
3E5181 PK PINK
E456-J32 WH-18

PK-18

L982-J43 PK-18
E789-J10 PU-18

BU-18
PU-18
BR-18
BU-18
2304011 2434505

BK-16
BK-18
BK-18
BK-16
BK-18
BK-16
BK-16
BK-16
BK-10
BK-18
BK-18

BK-18

325-J39 PK-18
200-J40 BK-18
607-J35 PK-18
147-J42 PU-18

C472-J2 GN-18
H441-J4 GN-18

709-J28 OR-16
BU-16
GY-16
BU-16
WH-18
GN-18
OR-18
WH-18
GN-18
PK-18

168-J37 RD-10

YL-18
WH-18

BK-16
BK-18
BK-18
BK-16
BK-16
BK-10
BK-16
BK-18
BK-16
BK-18
G833-AG8 PK-18 2 YL SENSOR COMMON J-C15 AN-C3 200-J31 BK-16 WA 234-1198 H-12
1552269 1552272 1 2 200-J34 BK-16 322-J33 GY-16 1 322-P1 GY-16 CIRCUIT CONNECTED WC 234-1199 H-12 BK BLACK
RADIATOR FAN SPEED CONT SOL 1 E998-J9 YL-18 L49 1 200-J27 BK-16 200-J1 BK-16 2 322-P2 GY-18 HORN LH LOW
2095939 2 E789-J10 PU-18 200-AN4 BK-18 4 4 3 200-J29 BK-16 200-P3 BK-16 2130710 WE 234-1197 K-13 GY GRAY
H446-J46

K932-J15
M933-J12
K934-J13
M953-J55
WF 234-1195 K-13

200-J34
200-J44
200-J48
200-J29
200-J40
200-J27
200-J23
200-J31
200-J38
235-J54
235-J20

235-J20
CONN 53
140-J51
322-J33
616-J22
G426-J5
P959-J7
487-J21
496-J18
495-J41
491-J19

E998-J9
H716-J8

200-J27
200-J44
200-J48
200-J34
200-J23
200-J38
200-J29
200-J40
200-J31
235-J54
M938-AN5 GY-18 3 200-P4 BK-18 BLADE, SPADE, RING OR SCREW
2 168-J37 RD-10 L33 WG 234-1196 K-13 PU PURPLE
E795-AG19 YL-18 E795-AG19 YL-18 1 GN SENSOR SIGNAL OIL TEMP 200-J40 BK-18 J-C10 TERMINAL WH 234-1194 H-12
YL-18
YL-18
BU-18
BU-18

BR-16
BU-18
PK-18
PK-18
BR-18
PK-18
YL-16
BR-18
BU-18

PK-18
YL-18
BR-18
PU-18
GN-18
GY-16
PU-18
PU-18
PU-18
PU-18
YL-18
GN-18
GN-18
YL-18
YL-18
YL-18
BR-18
BR-18
BR-18
OR-18
BR-18

200-J36 BK-18
BU-18
GN-18
GN-18
OR-18
OR-18
OR-18
BR-18
BR-18
BR-18

BK-18
BK-18
BR-18

200-J38 BK-10 ATCH REFUELING RELAY DIODE J-C9 2304011 322-P5 GY-18 HORN MID HIGH BR BROWN
G833-AG8 PK-18 2 YL SENSOR COMMON
FUEL LEVEL SENSOR1 1974385 X-C8 1160126 2130711
J-C7 1636700 1552269 J-C11 200-P6 BK-18 SPLICE GN GREEN
G833-AG8 PK-18 1552269 168-X14 RD-18 J-C19 2434505 200-J34 BK-16

1
2

1
2
1
H807-L16
H807-L14
K927-L12
K927-L10

P946-L13
P955-L15
P958-L11
E790-L22
F853-L21
H704-L52
K924-L17
K952-L20
M935-L19

E790-L49
H807-L24
K952-L26
M933-L28
P943-L27
P944-L25
P949-L23
E789-L42
E789-L40
E789-L36
H807-L30
K930-L35
K931-L39
K944-L33
K947-L31
K950-L37
K952-L32
K952-L38
K952-L34
P945-L29
P957-L41

607-J35 PK-18 BU BLUE

K927-L6
K928-L5
K929-L9
K943-L3
K946-L1
K949-L7
K952-L2
K952-L4
K952-L8

200-L18
200-L51
321-L48

495-J41 GN-18 1 2 329-X15 YL-18 CONN 38 1211038 CONN 37

235-J54 BK-18 2
B L-C1 168-X2 RD-18 X-C7 X-C1 322-P5 GY-18 HORN RH LOW B

1
2

1
2
G833-AG8 PK-18 2 YL SENSOR COMMON ENGINE 1552269 GND CHASSIS 3 329-X17 YL-18 1211038 2434505 2130710
995-AG17 BU-18 995-AG17 BU-18 1 GN SENSOR SIGNAL COOLANT TEMP TRAVEL RH SOL REAR 1 K946-L1 OR-18 168-X16 RD-18
1482350 2 K952-L2 BR-18 323-X5 WH-10 168-X1 RD-10
L57 168-X3 RD-18
L-C4 L-C18 ATCH REFUELING POWER RELAY
2130722 200-J36 BK-18 CHASSIS LAMP 2

200-X18 BK-18
1552269 1552269

325-X6 PK-18
607-J35 PK-18

200-X4 BK-10
TRAVEL LH SOL REAR 1 K943-L3 OR-18 P945-L29 OR-18 1 ANTI DRIFT SOL STICK J-C24 1532523
G833-AG8 PK-18 YL 1482350 K952-L4 BR-18 L37 H807-L30 YL-18 1890189 1552269
2 SENSOR COMMON INTAKE AIR TEMP 2 2
C967-AG20 BU-18 C967-AG20 BU-18 1 GN SENSOR SIGNAL K934-J13 BR-18 1 SWING RH SOL ATCH REFUELING PUMP
M933-J14 PU-18 2 1125874 1654962
L-C6 L-C19
PU-18

PK-18

M953-J45 BU-18
BU-18

WH-18
PK-18
BU-18
BR-18
PU-18
PU-18
PU-18
BK-18
GN-18
YL-18
WH-18
WH-18
GN-18
BU-18
BU-18
147-J53 PU-18
147-J52 PU-18
147-J42 PU-18

PU-18
BU-16
RD-10
BK-16
BK-16
GY-16
BK-18
BK-10
OR-18
PK-18
GN-18
WH-18
PK-18
BU-16
OR-16

GN-18

BK-16
BK-16
BK-18
BK-16
BK-18
BK-18

1552269 ATCH TRAVEL ALARM 1552269 BK-14 X-C6

E963-AG33 BK-18 E963-AG33 BK-18 GN DUAL CAM STICK SOL RETRACT 1 K928-L5 GN-18 L35 L-C3 L-C28 2139100 K947-L31 YL-18 1 TRAVEL RH SOL FRONT J-C23 1160126 WIRE GROUP COLOR DESCRIPTIONS
1 S/T - SPEED/TIMING 1482350 2 K927-L6 BU-18 1552269 3E3364 K952-L32 BR-18 2 1482350 1552269 + 1 323-X5 WH-10
E964-AG32 WH-18 E964-AG32 WH-18 2 YL S/T + (RAN) 321-L48 BR-18 1 K932-J15 BU-18 1 SWING LH SOL MOTOR 2 200-X4 BK-10 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.
E789-J10

L982-J43

M953-J55

E456-J32
H446-J46
K932-J15
K934-J13
M933-J14
M933-J16
M933-J12
200-J44
C472-J2
E998-J9
G426-J5
H716-J8
P959-J7
M953-J3
M953-J6

147-J42
140-J51
168-J37
200-J34
200-J31
322-J33
200-J40
200-J38
487-J21
491-J19
495-J41
496-J18
607-J35
616-J22
709-J28

H441-J4

200-J23
200-J29
200-J48
200-J27
235-J54
235-J20

E790-L49 PK-18 2 M933-J16 PU-18 2 1125874 -

L-C2 L-C20 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.
1552269 L-C13 L-C5 L-C15 1552269 BK-14
E965-AG38 BU-18 E965-AG38 BU-18 1 GN S/T - DUAL CAM BOOM SOL RETRACT 1 K949-L7 OR-18 3E3364 1552269 1552269 K944-L33 YL-18 1 TRAVEL LH SOL FRONT 140-J51 BU-16
SPEED/TIMING 1482350 2 K952-L8 BR-18 AUTO REVERSE FAN SOL H704-L52 PK-18 P949-L23 PU-18 1 SYSTEM PRESS. SOL K952-L34 BR-18 2 1482350 147-J52 PU-18 ATCH REFUELING VOLTAGE CONVERTER OUTPUT CIRCUIT.
E966-AG37 YL-18 E966-AG37 YL-18 2 YL S/T + (CRANK) 2426880
1
200-L51 BK-18 H807-L24 YL-18 2 1890189 168-J37 RD-10 T-C1 HYD OIL LEVEL SW STOP SW THIS SCHEMATIC IS FOR THE 365C EXCAVATOR.
2 1114760
322-J33 GY-16 1552269 ATCH REFUELING RELAY 2 X-C2 AA-C1 9X4184 STARTING CIRCUIT. 213-0900 HE02
L-C7 L-C21 495-J41 GN-18 496-T1 WH-18 1 1495050 2434505 230411
G856-AG11 WH-18 G856-AG11 WH-18 GN 1552269 L-C11 1552269 607-J35 PK-18 L34 235-T2 BK-18 2 X-C5 365-X7 YL-18 1 365-AA1 YL-18 GROUND CIRCUIT.
1 TDC + TDC PROBE BUCKET SOL RETRACT 1 K929-L9 GN-18 1552269 ATCH LOWERING CHECK SOL BOOM K930-L35 GN-18 1 STICK SOL EXTEND 616-J22 BU-16 1495051 325-X6 PK-18 2 325-AA2 PK-18
G857-AG12 YL-18 G857-AG12 YL-18 2 YL TDC -
CONN 3
1482350 2 K927-L10 BU-18 HYD LOCK SOL K924-L17 YL-16 1710028 E789-L36 PU-18 2 1482350 L56 709-J28 OR-16 1 L976-X13 GN-18 COMPONENTS ARE SHOWN INSTALLED ON A FULLY
1 L38
1211491 2 200-L18 BK-18 L54 E456-J32 WH-18 2 365-X8 YL-18 CONN 36
STARTING AID CIRCUIT. OPERABLE MACHINE WITH THE KEY AND ENGINE OFF.
L-C16 L-C29 H441-J4 GN-18 3 200-X18 BK-18
L-C8 1552269 3E3364 L-C22 H446-J46 PK-18 4 CAT DATA LINK.
G854-AG40 PK-18 G854-AG40 PK-18 1 GN IAPCV CONNECTOR 1552269 L-C12 L36 P944-L25 GY-16 1 1552269 M953-J45 BU-18 HYD OIL TEMP SENDER 5 329-X17 YL-18
G855-AG41 PU-18 G855-AG41 PU-18 2 YL COMMON HEP CONN 2 ATT SOL RETRACT 1 P958-L11 PK-18 1552269 K952-L26 BR-18 2 K950-L37 YL-18 1 BOOM SOL EXTEND 235-J54 BK-18 4I5394
J1939(CAN) DATA LINK. NOTE A: WIRE PAIRS MUST BE TWISTED AT LEAST
1482350 2 K927-L12 BU-18 PS PRESS. SOL 1 M935-L19 BU-18 K952-L38 BR-18 2 1482350 200-J23 BK-16 235-T7 BK-18
1119916 2 K952-L20 BR-18 200-J48 BK-18 1 TURN PER 25MM.
A ATCH LOWERING CHECK SOL STICK 200-J40 BK-18 235-T3 BK-18 A
L-C9 1710028 L-C23 200-J38 BK-10 T°
PRODUCT LINK CONTROL RS232 DATA LINK. NOTE B: USE WITH COLD WEATHER.
E798-AG42 PK-18 E798-AG42 PK-18 1 1 AP CONT 1552269 L-C14 1552269 200-J34 BK-16 491-T5 PK-18 ATCH REFUELING NOTE C: USE WITH REACH BOOM
E797-AG43 WH-18 E797-AG43 WH-18 VALVE ANTI DRIFT SOL BOOM 1 P946-L13 BR-16 1552269 L-C17 L-C30 K931-L39 GN-18 1 BUCKET SOL EXTEND 200-J27 BK-16 ATCH REFUELING RELAY 1 START SW MONITOR CIRCUIT.
2 1890189 H807-L14 YL-18 1552269 3E3364 E789-L40 PU-18 1482350 200-J29 BK-16 1495050 X-C3 Y-C1 6T9442 NOTE D: USE WITH FOGS CAB
2 TRAVEL SPPED SHIFT SOL 1 F853-L21 BR-18 2
1211491 2 E790-L22 PK-18 P943-L27 GN-18 1 200-J31 BK-16 T-C2 HYD OIL FILTER SW 1 X-C4 2304011 2434505 ENGINE CONTROL CIRCUIT. NOTE E: NOT USE ON CTWT REMOVAL.
M933-L28 PU-18 2 1552269 1733518 1495051 168-X3 RD-18 1 168-Y1 RD-18
998-AG3 BR-18 998-AG3 BR-18 A BK-18
L-C10
1552269
L-C24
1552269
487-T6 OR-18 2 SIGNAL 1 L976-X11 GN-18 L976-X10 GN-18 2 L976-Y2 GN-18 ENGINE PUMP CONTROL CIRCUIT. NOTE F: USE WITH PRODUCT LINK.
J-C18 T-C4 235-T7 BK-18 1 +GND 2 365-X9 YL-18
H477-AG34 YL-18 H477-AG34 YL-18 B NEUTRAL FLOW BYPASS SOL 1 P955-L15 BU-18 P957-L41 BR-18 1 ATT SOL EXTEND 2305008 2434507 3 168-X2 RD-18 MACHINE SECURITY CONTROL CIRCUIT. NOTE G: USE WITH JUMP START.
H478-AG39 BU-18 H478-AG39 BU-18 1890189 2 H807-L16 YL-18 E789-L42 PU-18 2 1482350 496-J18 WH-18 1 496-T1 WH-18 L28 4 CONN 35 NOTE H: USED ON EARLY SERIAL NUMBERS ONLY.
C 491-J19 PK-18 2 491-T5 PK-18 5 L976-X12 GN-18
L56 235-J20 BK-18 3 235-T3 BK-18 HEATER AND AIR CONDITIONER CIRCUIT.
487-J21 OR-18 4 487-T6 OR-18
CONN 33 TURN SIGNAL/WIPER/WASHER CIRCUIT.

18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1