Parts catalogue

Haulage BSIII
(Domestic | ECOMET 1214 - 4750mm WB
Ecomet 1214E3ST | ALVET879 | V2547520)
 FOREWORD

This Spare Parts Catalogue is applicable to Ecomet 1214E3ST(V2547520)

The following information regarding mode of supply is given in the Catalogue:

(A) When the components are supplied in the form of a sub-assembly or a set, or kit, specific mention is made.

(B) Similarly when parts are not serviced as components, specific mention is made. (Not Serviced Separately - NSS)

(C) Similarly when parts are not serviced currently, specific mention is made. (No Longer Serviced - NLS)

(D) No specific mention is made when component/assembly is supplied, as such.

(E) All standard fasteners (Prefix H & L) are not serviced.

While ordering for parts, due note of the above information should be taken.

In addition to the "Description" and the "Part Number", the "Aggregate" / "Unit Description", if given, will enable our Parts department to process the order quickly.

Since the process of development is continuous with design changes, part numbers are likely to change. The information given in this publication is current at the
time of release. In some of the models, Stage II Provisional specifications are used for preparing parts list. The possibility exists that the information may need to
be updated as a result of modification adopted by the manufacturer at any time for reason of a technical or commercial nature. Relevant changes would be updated
through our Service Circular / Bulletin, if found necessary. In some cases, where the part numbers are currently not available and likely to be allotted, specific
mention is made as TBA (To Be Allotted). Part Nos for TBA items will be intimated in the next release from time to time .

While all care has been taken to illustrate the components as they look, due to constraints of standardizing the illustrations, variations will be there. The
components shown in the illustration but not listed in description column are not applicable for the models referred above.

Though every care has been taken in preparing this Parts Catalogue, no liability is under taken for any error which may arise.

We welcome your suggestions and feedback on the contents of this catalogue . Should you require any clarifications concerning the contents of this catalogue,
please write to:

After Market - Technical Literature

Ashok Leyland Limited
Old Design Office - Technical centre,
Vellivoyalchavadi, Via Manali new town,
Chennai - 600103.
www.ashokleyland.com
https://www.catalogger.in PUBLICATION NO. PC:V2547520: 07-April-2016
 MODEL COVERAGE

MODEL - WHEEL BASE NOMENCLATURE SPEC (V NUMBER) DESCRIPTION

ECOMET 1214/ 4750 WB/ HA4CTI3N(120 PS) BS III ENGINE - B PLATFORM / 330
DIA AXIAL SPRING CLUTCH / ZF 6S ODGB (8.28 FGR)/ FRONT AXLE -FA90 /
ECOMET 1214 - 4750mm Ecomet 1214E3ST ALVET879(V2547520)
60SHO REAR AXLE (5.57 RAR) / ZF POWER STEERING / DAY CAB/ CAB
CHASSIS
 AGGREGATE SPEC DETAILS - Ecomet 1214E3ST (V2547520)

SL NO DESCRIPTION SPEC NUMBER A PART NUMBER

1 Engine Assembly HA4CTI3N/4 A2N19700

2 Air Intake Pipings ALAIP289 A0E05300

3 Cooling System ALAC67 A1V08900

4 Engine Mounting ALME96 A3X01000

5 Fuel Tank ALOT155 A5L09600

6 Fuel Piping ALPF354 A5J05700

7 Silencer and Exhaust System ALSPE403 A7F57400

8 Engine Interface Components ALEIC5 A3R00100

9 Clutch ALC52/1 A1M00700

10 Clutch Withdrawal Gear ALCWG78/1 A1N01500

11 Clutch Booster - Internal Components ALCWG78/1 A1N01500

12 Gearbox and Casing ALGB114/15 A5P09600

13 Input Shaft ALGB114/15 A5P09600

14 Main Shaft ALGB114/15 A5P09600

15 Reverse Shaft ALGB114/15 A5P09600

16 Lay Shaft ALGB114/15 A5P09600

17 Selector Forks ALGB114/15 A5P09600

18 Selector Housing ALGB114/15 A5P09600

19 Gear Shift Linkage ALGB114/15 A5P09600

20 Change Speed Operation ALCSO185/1 A1E03400

 AGGREGATE SPEC DETAILS - Ecomet 1214E3ST (V2547520)

SL NO DESCRIPTION SPEC NUMBER A PART NUMBER

21 Propeller Shaft ALPS377/3 A6N10600

22 Rear Axle ALBA226/19 A6T45200

23 Axle Housing ALBA226/19 A6T45200

24 Hub And Brake ALBA226/19 A6T45200

25 Rear Brake - Internal Components - BIL ALBA226/19 A6T45200

26 Rear Brake - Internal Components - AAL ALBA226/19 A6T45200

27 Front Axle ALFA90/64 A5C18800

28 Front Brake - Internal Components - AAL ALFA90/64 A5C18800

29 Track Rod ALFA90/64 A5C18800

30 Frame ALF497 A5B09000

31 Battery Carrier HABTB22 A6304800

32 Spare Wheel Carrier ALSWC27/1 A0912700

33 Badges ALBD7/1 A8H01100

34 Rear Bumper Bar ALRBB33 A6W01400

35 Front Shock Absorber ALFSA34 A7E04200

36 Front Suspension ALFFSA16 A5F06500

37 Rear Suspension ALFRSA12 A6Y05300

38 Drag Link ALDL96 A2C04800

39 Steering ALSG264/4 A2278000

40 Steering Reservoir ALSG264/4 A2278000

 AGGREGATE SPEC DETAILS - Ecomet 1214E3ST (V2547520)

SL NO DESCRIPTION SPEC NUMBER A PART NUMBER

41 Steering Gear - Internal Components ALSG264/4 A2278000

42 Steering Pump - Internal Components ALSG264/4 A2278000

43 Accelerator Pedal and Linkages ALCG183 A3743500

44 Air Piping ALPA710/1 A0F42100

45 Foot Brake ALFB354 A5A27800

46 Cab Mounting ALCM96/1 A1A02600

47 Cabin ALCAB172 A0Y25400

48 Ecomet Grille ALCAB172 A0Y25400

49 Fender, Cab Lock and Blanking Plugs ALCAB172 A0Y25400

50 Glass and Weather Strips ALCAB172 A0Y25400

51 Park Brake Valve & Proximity Mirror Complete ALCAB172 A0Y25400

52 Seat Belt ALCAB172 A0Y25400

53 Quarter Windows and Seats ALCAB172 A0Y25400

54 Switch Board, Switches and Gauges ALCAB172 A0Y25400

55 Kick Vent, RVM and Glove Box ALCAB172 A0Y25400

56 Steering Column and Accessories ALCAB172 A0Y25400

57 Operating Pedals ALCAB172 A0Y25400

58 Accl Pedal, Cab Mounting, Internal Bull Bar and Front Bumper ALCAB172 A0Y25400

59 Step Panel Lower & Step Cab Entry ALCAB172 A0Y25400

60 Doors (BIW) ALCAB172 A0Y25400

 AGGREGATE SPEC DETAILS - Ecomet 1214E3ST (V2547520)

SL NO DESCRIPTION SPEC NUMBER A PART NUMBER

61 Under Body (BIW) ALCAB172 A0Y25400

62 Roof With Side Rails ALCAB172 A0Y25400

63 Floor Carpets ALCAB172 A0Y25400

64 Door Trims ALCAB172 A0Y25400

65 Lamps and Signals ALCAB172 A0Y25400

66 Instrument Panel, Center Console ALCAB172 A0Y25400

67 Cabin Wiring Harness ALCAB172 A0Y25400

68 Wiping and Washer System ALCAB172 A0Y25400

69 Front Panel Trims ALCAB172 A0Y25400

70 Rear Trim, Roof Trim & Assist Handle ALCAB172 A0Y25400

71 Rear and Side Panel Trims ALCAB172 A0Y25400

72 Fender ALCAB172 A0Y25400

73 Hood ALCAB172 A0Y25400

74 Sundries and Miscellaneous ALCAB172 A0Y25400

75 Load Body Mounting Bracket ALBS184 A0T18500

76 Chassis Electricals ALCEL79 A2H15200

77 Electronic Diesel Control ALEDCS47 A2J18700

78 Front Wheel ALFW209/37 A5G04400

79 Rear Wheel ALRW209/52 A6Z04900

80 Spare Wheel ALSW209/28 A7H04100

 AGGREGATE SPEC DETAILS - Ecomet 1214E3ST (V2547520)

SL NO DESCRIPTION SPEC NUMBER A PART NUMBER

81 Chassis Statutory Items HACSR1 A8600200

82 Spray Suppression Device ALSSD2 A8607200

83 Front Under run Protection Device ALFUPD6/2 A8I02400

84 Lateral Protection Device ALSPD40 A5Z01000

85 Sundries and Finishes HASFS73 A7V21200

 ENGINE SPEC DETAILS - Ecomet 1214E3ST (V2547520)

SL NO DESCRIPTION SPEC NUMBER A PART NUMBER

1 Engine Assembly HA4CTI3N/4 A2N19700

2 Cylinder Head HAECH7/2 A9220900

3 Cylinder Block HAECB7 A9202300

4 Main Bearing ALEMB350 A7016600

5 Piston And Rings HAEPR27 A9221400

6 Connecting Rod HAECN8 A2X00500

7 Crank Shaft HAECS9 A9216900

8 Cam Shaft HAECM4 A8728300

9 Flywheel HAEFW29 A3F01700

10 Engine Flywheel Housing ALEFH300/16 A9221100

11 Timing Gear HAETG1/1 A8783800

12 Timing Gear Case HAETC3/5 A8760900

13 Engine Sump HAES13 A4H02900

14 Oil Strainer HAEOS7 A4C00200

15 Oil Pump HAEOP1 A8255000

16 Valves HAEVL4 A8728700

17 Oil Level Gauge HAOLG25 A6E04000

18 Intake Manifold HAEIM16 A9221500

19 Exhaust Manifold HAEEM4 A8729600

20 Oil Cooler HAEOC17 A3Z03800

 ENGINE SPEC DETAILS - Ecomet 1214E3ST (V2547520)

SL NO DESCRIPTION SPEC NUMBER A PART NUMBER

21 Oil Cooler - Internal Components HAEOC17 A3Z03800

22 Thermostat HAETH19 A4L05200

23 Breather Hose ALEBH300 A7015700

24 Fuel Injection Pump HAFIE28 A9221200

25 Fuel Injection Pump - Internal Components HAFIE28 A9221200

26 Feed Pump - Internal Components HAFIE28 A9221200

27 Nozzle HAENH15 A9221300

28 Nozzle - Internal Components HAENH15 A9221300

29 Coolant Pump HAEWP16 A9219400

30 Air Compressor HAECR10/1 A8747700

31 Air Compressor - Internal Components HAECR10/1 A8747700

32 Starter Motor HASM10 A9714800

33 Starter Motor - Internal Components - Lucas HASM10 A9714800

34 Alternator HADD12 A9221600

35 Alternator - Internal Components - Lucas HADD12 A9221600

36 Turbo Charger HAESC13/1 A9251500

37 Sundries And Finishes HAESF23 A9204900

 CONTENTS

SL. NO DESCRIPTION PAGE NO

1 ENGINE ASSEMBLY - HA4CTI3N/4 1

2 CYLINDER HEAD - HAECH7/2 3

3 CYLINDER BLOCK - HAECB7 7

4 MAIN BEARING - ALEMB350 11

5 PISTON AND RINGS - HAEPR27 13

6 CONNECTING ROD - HAECN8 15

7 CRANK SHAFT - HAECS9 17

8 CAM SHAFT - HAECM4 19

9 FLYWHEEL - HAEFW29 21

10 ENGINE FLYWHEEL HOUSING - ALEFH300/16 23

11 TIMING GEAR - HAETG1/1 27

12 TIMING GEAR CASE - HAETC3/5 29

13 ENGINE SUMP - HAES13 33

14 OIL STRAINER - HAEOS7 35

15 OIL PUMP - HAEOP1 37

16 VALVES - HAEVL4 39

17 OIL LEVEL GAUGE - HAOLG25 43

18 INTAKE MANIFOLD - HAEIM16 45

19 EXHAUST MANIFOLD - HAEEM4 47

 CONTENTS

SL. NO DESCRIPTION PAGE NO

20 OIL COOLER - HAEOC17 49

21 OIL COOLER - INTERNAL COMPONENTS - HAEOC17 51

22 THERMOSTAT - HAETH19 55

23 BREATHER HOSE - ALEBH300 57

24 FUEL INJECTION PUMP - HAFIE28 59

25 FUEL INJECTION PUMP - INTERNAL COMPONENTS - HAFIE28 67

26 FEED PUMP - INTERNAL COMPONENTS - HAFIE28 77

27 NOZZLE - HAENH15 81

28 NOZZLE - INTERNAL COMPONENTS - HAENH15 83

29 COOLANT PUMP - HAEWP16 91

30 AIR COMPRESSOR - HAECR10/1 93

31 AIR COMPRESSOR - INTERNAL COMPONENTS - HAECR10/1 95

32 STARTER MOTOR - HASM10 103

33 STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - HASM10 105

34 ALTERNATOR - HADD12 113

35 ALTERNATOR - INTERNAL COMPONENTS - LUCAS - HADD12 117

36 TURBO CHARGER - HAESC13/1 121

37 SUNDRIES AND FINISHES - HAESF23 125

38 AIR INTAKE PIPINGS - ALAIP289 127

 CONTENTS

SL. NO DESCRIPTION PAGE NO

39 COOLING SYSTEM - ALAC67 135

40 ENGINE MOUNTING - ALME96 149

41 FUEL TANK - ALOT155 153

42 FUEL PIPING - ALPF354 157

43 SILENCER AND EXHAUST SYSTEM - ALSPE403 163

44 ENGINE INTERFACE COMPONENTS - ALEIC5 167

45 CLUTCH - ALC52/1 169

46 CLUTCH WITHDRAWAL GEAR - ALCWG78/1 173

47 CLUTCH BOOSTER - INTERNAL COMPONENTS - ALCWG78/1 179

48 GEARBOX AND CASING - ALGB114/15 185

49 INPUT SHAFT - ALGB114/15 191

50 MAIN SHAFT - ALGB114/15 195

51 REVERSE SHAFT - ALGB114/15 203

52 LAY SHAFT - ALGB114/15 205

53 SELECTOR FORKS - ALGB114/15 209

54 SELECTOR HOUSING - ALGB114/15 211

55 GEAR SHIFT LINKAGE - ALGB114/15 217

56 CHANGE SPEED OPERATION - ALCSO185/1 219

57 PROPELLER SHAFT - ALPS377/3 223

 CONTENTS

SL. NO DESCRIPTION PAGE NO

58 REAR AXLE - ALBA226/19 227

59 AXLE HOUSING - ALBA226/19 241

60 HUB AND BRAKE - ALBA226/19 243

61 REAR BRAKE - INTERNAL COMPONENTS - BIL - ALBA226/19 251

62 REAR BRAKE - INTERNAL COMPONENTS - AAL - ALBA226/19 259

63 FRONT AXLE - ALFA90/64 267

64 FRONT BRAKE - INTERNAL COMPONENTS - AAL - ALFA90/64 281

65 TRACK ROD - ALFA90/64 291

66 FRAME - ALF497 297

67 BATTERY CARRIER - HABTB22 311

68 SPARE WHEEL CARRIER - ALSWC27/1 313

69 BADGES - ALBD7/1 317

70 REAR BUMPER BAR - ALRBB33 319

71 FRONT SHOCK ABSORBER - ALFSA34 321

72 FRONT SUSPENSION - ALFFSA16 323

73 REAR SUSPENSION - ALFRSA12 327

74 DRAG LINK - ALDL96 331

75 STEERING - ALSG264/4 333

76 STEERING RESERVOIR - ALSG264/4 341

 CONTENTS

SL. NO DESCRIPTION PAGE NO

77 STEERING GEAR - INTERNAL COMPONENTS - ALSG264/4 343

78 STEERING PUMP - INTERNAL COMPONENTS - ALSG264/4 353

79 ACCELERATOR PEDAL AND LINKAGES - ALCG183 357

80 AIR PIPING - ALPA710/1 359

81 FOOT BRAKE - ALFB354 367

82 CAB MOUNTING - ALCM96/1 373

83 CABIN - ALCAB172 379

84 ECOMET GRILLE - ALCAB172 381

85 FENDER, CAB LOCK AND BLANKING PLUGS - ALCAB172 383

86 GLASS AND WEATHER STRIPS - ALCAB172 389

87 PARK BRAKE VALVE & PROXIMITY MIRROR COMPLETE - ALCAB172 397

88 SEAT BELT - ALCAB172 401

89 QUARTER WINDOWS AND SEATS - ALCAB172 403

90 SWITCH BOARD, SWITCHES AND GAUGES - ALCAB172 409

91 KICK VENT, RVM AND GLOVE BOX - ALCAB172 413

92 STEERING COLUMN AND ACCESSORIES - ALCAB172 417

93 OPERATING PEDALS - ALCAB172 421

94 ACCL PEDAL, CAB MOUNTING, INTERNAL BULL BAR AND FRONT BUMPER - ALCAB172 425

95 STEP PANEL LOWER & STEP CAB ENTRY - ALCAB172 429

 CONTENTS

SL. NO DESCRIPTION PAGE NO

96 DOORS (BIW) - ALCAB172 433

97 UNDER BODY (BIW) - ALCAB172 435

98 ROOF WITH SIDE RAILS - ALCAB172 439

99 FLOOR CARPETS - ALCAB172 441

100 DOOR TRIMS - ALCAB172 443

101 LAMPS AND SIGNALS - ALCAB172 451

102 INSTRUMENT PANEL, CENTER CONSOLE - ALCAB172 455

103 CABIN WIRING HARNESS - ALCAB172 459

104 WIPING AND WASHER SYSTEM - ALCAB172 463

105 FRONT PANEL TRIMS - ALCAB172 467

106 REAR TRIM, ROOF TRIM & ASSIST HANDLE - ALCAB172 471

107 REAR AND SIDE PANEL TRIMS - ALCAB172 475

108 FENDER - ALCAB172 477

109 HOOD - ALCAB172 479

110 SUNDRIES AND MISCELLANEOUS - ALCAB172 481

111 LOAD BODY MOUNTING BRACKET - ALBS184 487

112 CHASSIS ELECTRICALS - ALCEL79 489

113 ELECTRONIC DIESEL CONTROL - ALEDCS47 493

114 FRONT WHEEL - ALFW209/37 499

 CONTENTS

SL. NO DESCRIPTION PAGE NO

115 REAR WHEEL - ALRW209/52 501

116 SPARE WHEEL - ALSW209/28 503

117 CHASSIS STATUTORY ITEMS - HACSR1 505

118 SPRAY SUPPRESSION DEVICE - ALSSD2 507

119 FRONT UNDER RUN PROTECTION DEVICE - ALFUPD6/2 509

120 LATERAL PROTECTION DEVICE - ALSPD40 511

121 SUNDRIES AND FINISHES - HASFS73 513

ENGINE ASSEMBLY - A2N19700 - HA4CTI3N/4 1
 2

ENGINE ASSEMBLY - A2N19700 - HA4CTI3N/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 A2N19700 ASSEMBLY OF ENGINE 1

CYLINDER HEAD - A9220900 - HAECH7/2 3
 4

CYLINDER HEAD - A9220900 - HAECH7/2

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B8715502 S/A OF ENGINE CYLINDER HEAD 1

1 1 F3145315 PLUG EXPANSION 30DIA 4

2 2 X1701113 MLS GASKET 1

4 3 X3716315 STUD - FOR INLET MANIFOLDMOUNTING 6

5 P0950951 COMPOSITE VALVE SEAT KIT 1 COMPRISES OF(SL.NOs.6,7)

6 4 X0900216 SEAT VALVE - INTAKE 4

7 5 X0900116 SEAT VALVE - EXHAUST 4

8 6 FYJ00711 SPECIAL FLANGED BOLT - BI-HEX - 12 X 1.5 CP X 118.0mm LONG X 13

GR 10.9

9 7 L9011035 FLANGED SCREW - M10X1.5X35L 4

10 8 FYJ00811 SPECIAL FLANGED BOLT - BI-HEX - 12 X 1.5 CP X 165.0mm LONG X 5

GR 10.9

11 9 F1135842 COVER CYLINDER HEAD 1

12 10 F1762100 GASKET CYLINDER HEAD COVER 1

13 11 F1100160 OIL FILLER CAP 1

14 12 F3769815 STUD M8X1.25 8

15 13 X3504211 STUD EMF 6

16 14 X3504311 STUD FOR EXHAUST MANIFOLD - SHORT 2

17 15 L9010832 FLANGED SCREW - M8X1.25X18L 6

CYLINDER HEAD - A9220900 - HAECH7/2 5
 6

CYLINDER HEAD - A9220900 - HAECH7/2

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 HEAD CYLINDER 1 NSS

19 17 F0531522 BUSHING VALVE GUIDE INTAKE 8

20 18 F4832510 BALL STEEL 4

21 19 F3144915 PLUG EXPANSION 4

23 - F3145415 PLUG EXPANSION 3

25 - F3145815 PLUG EXPANSION 8

CYLINDER BLOCK - A9202300 - HAECB7 7
 8

CYLINDER BLOCK - A9202300 - HAECB7

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B9202303 S/A OF CYLINDER BLOCK WITH PCN FITMENT 1 COMPRISES

OF(SL.NOs.2,3,4,5,6,7,8,9,10,11,12,13,14,15,16,17,18,19,20,25,30,
31,32)

2 1 CRANKCASE MODIFICATION FOR PISTON COOLING NOZZLE 1 NSS

3 1.1 BRG CAP-INTER- H-SERIES 4 NSS

4 1.2 BRG.CAP-CENTRE-H-SERIES 1 NSS

5 1.3 F9K00122 SERVICE LINER OD GRADE W AR (W-GREEN)

6 1.3 F9K00222 SERVICE LINER OD GRADE X AR (X-GREEN)

7 1.3 F9K00322 SERVICE LINER OD GRADE Y AR (Y-GREEN)

8 1.3 F9K00422 SERVICE LINER OD GRADE Z AR (Z-GREEN)

9 1.3 FCV01022 CYLINDER LINER (Z+-GREEN) AR (Z+ GREEN)

10 2 X3511115 BOLT MAIN BEARING CAP 10

11 3 F0234330 BEARING CAMSHAFT NO 1 1

12 3 F0234430 BEARING CAMSHAFT NO 2 1

13 3 F0234530 BEARING CAMSHAFT NO 3 1

14 4 F3145615 PLUG EXPANSION 5

15 5 F3145715 PLUG EXPANSION 5

16 6 F3145415 PLUG EXPANSION 3

17 7 F3144915 PLUG EXPANSION 1

CYLINDER BLOCK - A9202300 - HAECB7 9
 10

CYLINDER BLOCK - A9202300 - HAECB7

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 8 F0536230 BUSHING VALVE GUIDE 1

19 9 F3146615 EXPANSION PLUG 3

20 10 F3145015 PLUG EXPANSION 1

21 11 F0954515 PIN STRAIGHT(8X16) 2

22 12 F0954415 PIN STRAIGHT 2

23 13 X3108815 PLUG 2

24 14 F4832610 BALL STEEL 2

25 15 F0954615 PIN STRAIGHT (5X10) 1

26 16 F0954715 PIN REAR 2

27 17 F2702150 O-RING CAM AND SEAL 1

28 18 F7647314 SEAL PLATE 1

29 19 L9010818 FLANGED SCREW - M8X1.25X18L 2

30 20 B8784703 COOLING JET BODY 3

31 21 B9202301 COOLING JET BODY 1

32 22 FE702710 SCREW - 6 X 1.0 CP X 15.0 LONG X GR 12.9 4

MAIN BEARING - A7016600 - ALEMB350 11
 12

MAIN BEARING - A7016600 - ALEMB350

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F0235730 BEARING CRANKSHAFT 10

2 2 X4900201 THRUST WASHER - 82.25mm ID X 98.9mm OD X 2.15mm T 2

3 3 X4900301 THRUST WASHER - 82.25mm ID X 98.9mm OD X 2.15mm T 2

PISTON AND RINGS - A9221400 - HAEPR27 13
 14

PISTON AND RINGS - A9221400 - HAEPR27

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 P0982651 PISTON SET - 4CTI-E3 1

2 2 P0982751 RING SET - 4CTI-E3 1

3 3 P0983151 ENGINE SET - 4CTI-E3 1 COMPRISES OF(SL.NOs.1,2)

CONNECTING ROD - A2X00500 - HAECN8 15
 16

CONNECTING ROD - A2X00500 - HAECN8

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B2X00401 S/A OF CONNECTING ROD 4 COMPRISES OF(SL.NOs.2,3,9)

2 1 X0501030 BUSHING CON ROD 4

3 2 F3585615 BOLT CON ROD 8

4 3 P0951551 CON ROD BEARING KIT - STD 1

5 3 P0958351 CON ROD BEARING KIT - 0.25mm U/S AR

6 3 P0958451 CON ROD BEARING KIT - 0.50mm U/S AR

7 3 P0958551 CON ROD BEARING KIT - 0.75mm U/S AR

8 3 P0958651 CON ROD BEARING KIT - 1.00mm U/S AR

9 4 CONNECTING ROD AND CAP 1 NSS

CRANK SHAFT - A9216900 - HAECS9 17
 18

CRANK SHAFT - A9216900 - HAECS9

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F3568715 NUT - HEX M27 X 1.5 - X 15 LONG X 0 1

2 2 F1200210 SPACER 1

3 3 F2702650 O-RING 41.4 X 5.54 1

4 4 X7J00122 "POLY V PULLEY WITHOUT RUBBER DAMPER AND WITH 1

PROVISION FOR 2V FITMENT"

5 5 X1607511 GEAR CRANKSHAFT 1

6 6 F0954915 KEY FOR CRANKSHAFT 1

7 7 X3308511 CRANKSHAFT 1

8 8 F3438615 COLLAR 1
CAM SHAFT - A8728300 - HAECM4 19
 20

CAM SHAFT - A8728300 - HAECM4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B8728301 S/A OF CAM SHAFT 1 COMPRISES OF(SL.NOs.3,4,5,6,8,10)

2 B8728302 S/A OF CAMSHAFT 1 COMPRISES OF(SL.NOs.3,4)

3 1 X3307511 CAMSHAFT 1

4 2 F4832710 BALL STEEL 1

5 3 F0955115 KEY FOR CAMSHAFT 1

6 4 F7661614 PLATE CAMSHAFT 1

7 5 L9010822 FLANGED SCREW - M8X1.25X22L 2

8 6 F1655711 GEAR CAMSHAFT 1

9 7 F4945310 WASHER 44 OD X 15 ID X 6 T 1

10 8 X3511915 BOLT CAMSHAFT 1

FLYWHEEL - A3F01700 - HAEFW29 21
 22

FLYWHEEL - A3F01700 - HAEFW29

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B3F00401 S/A OF FLYWHEEL 1 COMPRISES OF(SL.NOs.2,3)

2 1 FLYWHEEL FOR 330 DIA CLUTCH 1 NSS

3 2 F0741822 STARTER RING 1

4 3 F0245410 DEEP GROOVE BALL BEARING 1

5 4 F7647114 STOPPER BEARING 1

6 5 L9010812 FLANGED SCREW - M8X1.25X12L 2

7 6 X3511015 BOLT FLYWHEEL 6

ENGINE FLYWHEEL HOUSING - A9221100 - ALEFH300/16 23
 24

ENGINE FLYWHEEL HOUSING - A9221100 - ALEFH300/16

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X1815822 FLYWHEEL HOUSING 1

2 2 X1102513 DUST COVER 2

3 3 X1102242 SENSOR MTG BLOCK 1

4 4 L9010822 FLANGED SCREW - M8X1.25X22L 2

5 5 F4945110 WASHER 22 OD X 12.5 ID X 2 T 2

6 6 X7472700 ENGINE SPEED SENSOR 1

7 7 FS401568 PLASTIC CAP ON SPEED SENSOR 1

8 8 L9010612 FLANGED SCREW M6X1X18 1

9 9 F4945010 LOCK WASHER 2

10 10 F3583615 BOLT 2

11 11 F3769515 STUD M10X1.5/1.25 3

12 12 L9010832 FLANGED SCREW - M8X1.25X18L 6

13 13 L9011440 FLANGED SCREW - M14X2X40L 8

14 14 X2705100 OIL SEAL FOR CRANKSHAFT REAR 1

15 14 X2705200 C/S REAR END PTFE OIL SEAL 1

16 15 X4402910 SHIM - SPEED SENSOR 1

17 16 X4403010 SHIM - SPEED SENSOR 1

ENGINE FLYWHEEL HOUSING - A9221100 - ALEFH300/16 25
 26

ENGINE FLYWHEEL HOUSING - A9221100 - ALEFH300/16

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 L9010812 FLANGED SCREW - M8X1.25X12L 4

TIMING GEAR - A8783800 - HAETG1/1 27
 28

TIMING GEAR - A8783800 - HAETG1/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F7661714 PLATE IDLER GEAR THRUST 1

2 B7014502 S/A OF SHAFT IDLER GEAR 1 COMPRISES OF(SL.NOs.3,4)

3 2 F3347211 IDLER GEAR SHAFT 1

4 3 F0955015 PIN STRAIGHT 2

5 B8783801 S/A OF GEAR IDLER 1 COMPRISES OF(SL.NOs.6,7)

6 4 X1607611 GEAR IDLER 1

7 5 F0536530 BUSHING 1

8 6 F7661814 PLATE IDLE GEAR THRUST 1

9 7 F3585715 BOLT IDLE GEAR 1

TIMING GEAR CASE - A8760900 - HAETC3/5 29
 30

TIMING GEAR CASE - A8760900 - HAETC3/5

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B8760901 S/A OF TIMING GEAR CASE 1

2 1 L9510813 FLANGED BOLT - M8X1.25X65L 5

3 2 L9010818 FLANGED SCREW - M8X1.25X18L 4

4 3 F1761500 GASKET FRONT END PLATE 1

5 4 X7200113 PLATE FRONT ENDTIMING BACK PLATE 1

6 5 F3145915 PLUG EXPANSION 1

7 6 X1104022 COVER TIMING GEAR CASE 1

8 7 L9010822 FLANGED SCREW - M8X1.25X22L 3

9 8 X1102622 FRONT COVER 1

10 9 F2749200 O-RING 81.2 X 3.3 1

11 10 X2706700 SEAL OIL FOR CRANKSHAFT FRONT 1

12 11 L9510817 FLANGED BOLT - M8X1.25X85L 3

13 12 L9510819 FLANGED BOLT - M8X1.25X95L 2

14 13 L9510815 FLANGED BOLT - M8X1.25X75L 1

15 14 L9010818 FLANGED SCREW - M8X1.25X18L 3

16 15 F3502400 BOLT 1

17 - FS400968 PLASTIC CAP ON T G CASE AND COVER THERMOSTAT 1

TIMING GEAR CASE - A8760900 - HAETC3/5 31
 32

TIMING GEAR CASE - A8760900 - HAETC3/5

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - FS401268 PLASTIC CAP FOR TG CASE & AIR INTAKE ELBOW 1

ENGINE SUMP - A4H02900 - HAES13 33
 34

ENGINE SUMP - A4H02900 - HAES13

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B4H02901 H4 HIGH CAPACITY SINGLE PIECE SUMP 1 COMPRISES OF(SL.NOs.2,3,4,5)

2 1 SUMP 1 NSS

3 2 FL800231 SPECIAL WASHER - MM - PLAIN - 16.2MM ID X 23MM OD X 2MM T 1

4 3 F3114515 DRAIN PLUG MAGNETIC 1

5 4 BOSS, OIL SUMP, M16X1.5 1 NSS

6 5 L9010812 FLANGED SCREW - M8X1.25X12L 26

OIL STRAINER - A4C00200 - HAEOS7 35
 36

OIL STRAINER - A4C00200 - HAEOS7

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B9255801 S/A OF SUCTION STAINER 1

2 1 FH500242 OIL STRAINER PIPE3 PIECE SUMP(FRONT WELL) 1

3 2 F4000310 SCREEN OIL STRAINER 1

4 3 F0743510 SNAP RING 1

5 4 F2702750 O-RING FLANGE SEAL 1

6 5 L9010822 FLANGED SCREW - M8X1.25X22L 2

OIL PUMP - A8255000 - HAEOP1 37
 38

OIL PUMP - A8255000 - HAEOP1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F1655811 GEAR OIL PUMP DRIVE SHAFT 1

2 B8255001 S/A OF OIL PUMP 1 COMPRISES OF(SL.NOs.1,5,7,8,9,11,12,13,14)

3 B8255003 S/A OIL PUMP COVER 1 COMPRISES OF(SL.NOs.5,7,14)

4 2 L9010818 FLANGED SCREW - M8X1.25X18L 3

5 3 X1101122 COVER OIL PUMP 1

6 4 L9010832 FLANGED SCREW - M8X1.25X18L 2

7 5 F0536430 BUSHING BODY OIL PUMP 1

8 6 F3355415 SHAFT OIL PUMP DRIVE 1

9 7 F1600126 GEAR OIL PUMP DRIVE SHAFT 1

10 8 F1761200 GASKET OIL PUMP COVER 1

11 9 F1600226 GEAR OIL PUMP DRIVEN SHAFT 1

12 B7014903 S/A OF GEAR 1 COMPRISES OF(SL.NOs.11,13)

13 10 F0536330 BUSH OIL PUMP DRIVE 1

14 11 F3355515 SHAFT OIL PUMP DRIVEN 1

15 12 F3502400 BOLT 2
VALVES - A8728700 - HAEVL4 39
 40

VALVES - A8728700 - HAEVL4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X0901011 SEAT.VALVE SPRING - LOWER 8

2 P0951051 COMPOSITE VALVE KIT 1 COMPRISES OF(SL.NOs.3,4)

3 2 VALVE INTAKE-STD 4 NSS

4 3 VALVE EXHAUST-STD. 4 NSS

5 B8728701 S/A OF ARM VALVE ROCKER 1 COMPRISES OF(SL.NOs.6,7,8,9,10,11,12,13,14,27,28,29)

6 4 F3576711 SCREW - HEX M5 X 0.8 CP X 8 LONG X 0 2

7 5 F7104522 SUPPORT VALVE ROCKER - FRONT 1

8 6 F3210322 ROCKER ARM.INLET 4

9 7 F3438415 COLLAR 4

10 8 F3210422 ROCKER ARM EXHAUST 4

11 9 F7104622 SUPPORT VALVE ROCKER - MIDDLE 3

12 10 F7104722 SUPPORT VALVE ROCKER - REAR 1

13 11 F3586215 NUT - HEX M8 X 1 FP X 5.5 LONG X 0 8

14 12 X3507615 SCREW VALVE ADJUSTING 8

15 13 X0900911 SEAT.VALVE SPRING - UPPER 8

16 14 F3438515 LOCK VALVE SPRING RETAINER 16

17 15 X2706400 VALVE STEM SEAL (DOUBLE LIP) 8

VALVES - A8728700 - HAEVL4 41
 42

VALVES - A8728700 - HAEVL4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 L9510812 FLANGED BOLT - M8X1.25X60L 5

19 17 X1100615 VALVE CAP 8

20 18 B7015004 S/A OF VALVE PUSH ROD 8

21 19 F4330722 LIFTERVALVE 8

22 20 X3606410 SPRING VALVE INNER (NON - NITRIDED IMPORTED) 8

23 21 X3607310 VALVE SPRING 8

24 22 P0997251 VALVE SPLIT CONE KIT 1

26 B7018802 S/A OF SHAFT VALVE ROCKER 1 COMPRISES OF(SL.NOs.27,28)

27 23 F3356415 ROCKER SHAFT 1

28 - F3146015 SPHERICAL PLUG 2

29 - FL600101 ENGINE INTAKE VALVE 1

30 - FFH00101 ENGINE EXHAUST VALVE 1

OIL LEVEL GAUGE - A6E04000 - HAOLG25 43
 44

OIL LEVEL GAUGE - A6E04000 - HAOLG25

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B6E04001 DIPSTICK FOR H4 SINLGE PIECE SUMP 1 COMPRISES OF(SL.NOs.2,3,4)

2 1 B6E04002 OIL LEVEL GAUGE FOR H4 SINGLE PIECE SUMP 1

3 2 FA401950 O-RING DIP STICK 1

4 3 B9252106 DIPSTICK GUIDE with O RING 1

5 4 F2702050 O-RING 1
INTAKE MANIFOLD - A9221500 - HAEIM16 45
 46

INTAKE MANIFOLD - A9221500 - HAEIM16

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B9221501 S/A OF INTAKE MANIFOLD 1 COMPRISES OF(SL.NOs.2,3)

2 1 X1803642 INTAKE MANIFOLD 1

3 2 X3714015 STUD FOR INJ PIPE CLAMPING 2

4 3 X1300742 AIR INTAKE ELBOW 1

5 4 X1708000 GASKET AIR INTAKE PIPE 1

6 5 L9510813 FLANGED BOLT - M8X1.25X65L 8

7 6 X3715115 STUD FOR AIR INTAKE PIPE 4

8 7 L9110818 FLANGED NUT - M8X1.25 4

9 8 X7478300 BOOST PRESSURE SENSOR 1

10 9 L9010618 FLANGED SCREW M6X1X18 1

EXHAUST MANIFOLD - A8729600 - HAEEM4 47
 48

EXHAUST MANIFOLD - A8729600 - HAEEM4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X1813022 EXHAUST MANIFOLD 1

2 2 FFF00213 GASKET 4

3 3 X1203515 SPACER 4

4 4 F7F00115 NUT - HEX M10 X 1.25 - X 11 LONG X 0 8

5 5 X3504411 SPECIAL STUD FOR TURBOCHARGER MOUNTING 4

6 6 X1111814 HEAT SHIELD 1

7 7 F1200410 SPACER 4

8 8 L9010818 FLANGED SCREW - M8X1.25X18L 2

9 9 L9010812 FLANGED SCREW - M8X1.25X12L 1

OIL COOLER - A3Z03800 - HAEOC17 49
 50

OIL COOLER - A3Z03800 - HAEOC17

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F2702550 O-RING 19 X 3 4

2 LO FASTENERS FOR OIL COOLER MOUNTING

3 2 L9010822 FLANGED SCREW - M8X1.25X22L 9

4 3 L9510808 FLANGED BOLT M8 X 1.25 X 40 3

5 4 L9510823 FLANGED BOLT - M8X1.25X115L 4

6 5 F1986715 CONNECTOR PIPE 1

7 6 F3587011 BOLT 1

8 7 F4930430 SPECIAL WASHER 3

9 8 B3Z01401 S/A OF OIL COOLER WITH OIL FILTER 1

OIL COOLER - INTERNAL COMPONENTS - A3Z03800 - HAEOC17 51
 52

OIL COOLER - INTERNAL COMPONENTS - A3Z03800 - HAEOC17

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B3Z01401 S/A OF OIL COOLER WITH OIL FILTER 1

2 B7015402 S/A CASE OIL COOLER 1 COMPRISES OF(SL.NOs.3,4,5,6,7,8,9)

3 2 F1842742 CASE OIL COOLER 1

4 3 F3147115 PLUG 2

5 4 F2749700 O-RING 17.6 X 2.6 5

6 5 F3147115 PLUG 3

7 6 F3639410 SPRING - OIL VALVE 2

8 7 F3639510 SPRING - OIL VALVE 1

9 8 F4231711 SAFETY VALVE - FILTER 3

10 9 X4000600 ELEMENT OIL FILTER 1

11 10 F2749900 O-RING 106.8 X 3.1 1

12 11 F2749800 O-RING 1

13 12 F4945610 WASHER 1

14 13 F7824800 S/A OF OIL COOLER ELEMENT - 4 PLATE 1

15 14 L9120818 FLANGED NUT - M8X1 4

16 15 X3512115 BOLT OIL FILTER BOWL 1

17 16 F3639610 SPRING OIL FILTER ELEMENT SUPPORT 1

OIL COOLER - INTERNAL COMPONENTS - A3Z03800 - HAEOC17 53
 54

OIL COOLER - INTERNAL COMPONENTS - A3Z03800 - HAEOC17

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 X1707700 GASKET OIL COOLER 1

19 18 X1102713 BOWL OIL FILTER 1

20 B8774802 S/A OF OIL FILTER (LONGER BOWL) 1 COMPRISES OF(SL.NOs.10,11,12,13,16,17,19)

21 - FS400568 PLASTIC CAP ON OP - CONNECTOR 1

22 - X3503815 NUT M8 4

23 - X4901010 CONICAL WASHER 4

THERMOSTAT - A4L05200 - HAETH19 55
 56

THERMOSTAT - A4L05200 - HAETH19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B4L05201 S/A OF THERMOSTAT HOUSING COVER - A PLATFORM 1 COMPRISES OF(SL.NOs.2,3,4,5,6,7,8,9)

2 1 F1825022 CASE THERMOSTAT 1

3 2 F1761400 GASKET THERMOSTAT 1

4 3 FF402100 TEMPERATURE SENSOR 1

5 4 F1985515 PIPE VENT 1

6 5 X0148515 ADAPTOR 1

7 6 X7468900 THERMOSTAT 1

8 7 L9010822 FLANGED SCREW - M8X1.25X22L 3

9 8 X1Y00542 THERMOSTAT HOUSING COVER 1

10 9 L9511014 FLANGED BOLT - M10X1.5X70L 3

11 10 F2701550 O-RING 31.2 X 3.5 2

12 11 L9510817 FLANGED BOLT - M8X1.25X85L 4

13 - F3132015 PLUG 1
BREATHER HOSE - A7015700 - ALEBH300 57
 58

BREATHER HOSE - A7015700 - ALEBH300

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F0837710 CLAMP - BREATHER 1

2 2 B7015701 BREATHER HOSE WITH INNER SPRING 1

3 3 X1407414 FLANGE VENT HOSE 1

4 4 X0807610 CLIP SPRING BAND 1

FUEL INJECTION PUMP - A9221200 - HAFIE28 59
 60

FUEL INJECTION PUMP - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B8742501 S/A OF FUEL INJECTION PUMP DRIVE 1 COMPRISES OF(SL.NOs.3,4,5,6,7,8,9,10,11,12,13,14)

2 B9208103 S/A OF FUEL INJ. PUMP DRIVE 1 COMPRISES OF(SL.NOs.3,4)

3 1 X1102322 HOUSING. INJECTION PUMP DRIVE 1

4 2 X0501330 BUSH 2

5 3 X3307811 SHAFT INJECTION PUMP DRIVE 1

6 4 X0705510 CIRCLIP 1

7 5 X7600410 WASHER THRUST 1

8 6 X4300211 ECCENTRIC DISC FEEDPUMP DRIVE 1

9 7 X0705410 CIRCLIP 1

10 9 F8R00922 HOUSING - FIP DRIVE END 1

11 8 F2749200 O-RING 81.2 X 3.3 1

12 10 X3503111 BOLT FOR FIP DRIVE GEAR 3

13 11 X3223015 COUPLING INJ PUMP DRIVE 1

14 12 X0705310 CIRCLIP 1

15 B9221206 S/A OF FUEL INJECTION PUMP 1 COMPRISES OF(SL.NOs.16,17,18,19)

16 13 X7477800 FUEL INJECTION PUMP 1

17 14 X1600815 SPLINED BUSH 1

FUEL INJECTION PUMP - A9221200 - HAFIE28 61
 62

FUEL INJECTION PUMP - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 15 X0139015 THREADED UNION 1

19 16 X4902830 COPPER WASHER 1

20 P0985651 INJECTOR PIPE KIT 1 COMPRISES OF(SL.NOs.21,22,23,24)

21 17 B9221201 S/A OF INJECTOR PIPE NO.1 1

22 18 B9221202 S/A OF INJECTOR PIPE NO.2 1

23 19 B9221203 S/A OF INJECTOR PIPE NO.3 1

24 20 B9221204 S/A OF INJECTOR PIPE NO.4 1

25 21 B8249510 CLAMP 2

26 22 B8249509 S/A OF CLIP 1

27 23 L9110818 FLANGED NUT - M8X1.25 2

28 24 B9221205 S/A OF INJECTOR LEAK OFF PIPE 1

29 25 B7049503 PIPE SUB ASSY THROUGH FEED 1

30 26 F1939660 HOSE FUEL 1

31 27 F0838610 CLIP 2

32 28 B7007801 S/A OF PIPE OIL SUPPLY FROM BLOCK TO COMPR. 1

33 29 B8742504 S/A OF PIPE OIL 1

34 30 X8000314 BRACKET FIP SUPPORT 1

FUEL INJECTION PUMP - A9221200 - HAFIE28 63
 64

FUEL INJECTION PUMP - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 31 L9011020 FLANGED SCREW - M10X1.5X20L 2

36 32 X1603411 GEAR INJ PUMP DRIVE 1

37 33 L9010820 HEXAGON SCREW FLANGED, M8x20 - 8.8 8

38 34 X7462300 FEED PUMP 1

39 35 X1706600 GASKET FEEDPUMP 1

40 36 L9110618 FLANGED NUT - M6X1 3

41 37 X1706700 GASKET - FIP MOUNTING 1

42 38 X3714015 STUD FOR INJ PIPE CLAMPING 3

43 39 L9110818 FLANGED NUT - M8X1.25 3

44 40 X3539311 BANJO BOLT 1

45 41 X4902830 COPPER WASHER 2

46 42 F2702450 O-RING 142.5 X 3 1

47 43 F3575511 BOLT 1

48 44 F3575611 BOLT 1

49 45 F4930530 WASHER 5

50 46 F3131415 BANJO CONNECTION 1

51 47 F4932940 WASHER 2
FUEL INJECTION PUMP - A9221200 - HAFIE28 65
 66

FUEL INJECTION PUMP - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 - L9011020 FLANGED SCREW - M10X1.5X20L 2

53 - X3965600 STRAINER BANJO BOLT 1

54 - L9010832 FLANGED SCREW - M8X1.25X18L 3

55 - B9210801 CLIP FOR COMPRESSOR LUB OIL PIPE MOUNTING 1

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28 67
 68

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 P1302905 BUSH 2

2 2 SHAFT SEALING RING 1 NSS

3 3 P1317239 VANE PUMP 1

4 4 P1302007 SUPPORT RING 1

5 5 P1320007 TORX FLAT HEAD SCREW 2

6 6 P1305433 ASSY OF PROPELLER SHAFT 1

7 7 P1302909 WOODRUFF KEY 1

8 8 P1318549 SLIDING WASHER 1

9 9 P1310330 CROSS DISC 1

10 10 P1311330 CAMPLATE 1

11 11 P1311430 SEALING PLATE 1

12 12 P1311742 TIMING DEVICE PISTON 1

13 13 P1301216 SLIDER 1

14 14 P1319636 COMPRESSION SPRING 1

15 15 P1311530 SEALING PLATE 1

16 16 P1314311 CLOSING COVER 1

17 17 P1334035 TORX FILLISTER SCREW 2

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28 69
 70

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 18 P1311630 COVER PLATE 1

19 19 P1334035 TORX FILLISTER SCREW 4

20 20 P1323139 DISTRIBUTOR HEAD 1

21 21 P1361544 SHIM 1

22 22 P1315709 SPRING SEAT 1

23 23 P1307109 SPRING SEAT 2

24 24 P1315809 GUIDE PIN 2

25 25 P1302951 SPRING SET 1

26 26 P1313427 O-RING 1

27 27 P1301917 GASKET 4

28 28 P1303901 DELIVERY VALVE 4

29 29 P1320235 TORX FILLISTER SCREW 3

30 30 P1323239 POSITIONER 1

31 31 P1354635 HEXAGON SCREW 1

32 32 P1301349 WASHER 1

33 33 P1354735 WASHER & SCREW ASSY OR FILLISTER HEAD SCREW 3

34 34 P1320149 PLAIN WASHER 4

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28 71
 72

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 35 P1354835 WASHER & SCREW ASSY OR TRIANGLE HEAD BOLT 1

36 36 P1308117 GASKET 1

37 37 P1302327 O-RING 1

38 38 P1308231 SCREW PLUG 1

39 39 P1341335 BLEEDER SCREW 1

40 40 P1310527 O-RING 1

41 41 P1310627 O-RING 3

42 42 P1311842 CONTROL VALVE 1

43 43 P1352435 OVERFLOW VALVE 1

44 44 P1304727 SEALING RING 3

45 45 P1354935 CAP NUT 1

46 46 P1314411 PROTECTION CAP 1

47 47 P1301234 PROTECTION SLEEVE 1

48 48 P1319736 COMPRESSION SPRING 1

49 49 P1307409 WOODRUFF KEY 1

50 50 P1312335 HEXAGON NUT 1

51 51 P1319836 SPRING WASHER 1

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28 73
 74

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 52 P1311730 SUPPORT PLATE 1

53 53 P1322335 TORX FILLISTER SCREW 1

54 54 P1301920 SOLENOID 1

55 55 P1355035 SCREW 2

56 56 P1355135 WASHER AND SCREW ASSY 1

57 57 P1302408 CLAMP 1

58 58 P1311942 SOLENOID OPERATED VALVE 1

59 59 P1334035 TORX FILLISTER SCREW 2

60 60 P1309318 PUMP HOUSING 1

61 61 P1320307 ROLLER RING 1

62 62 P1308109 BEARING PIN 4

63 63 P1304507 ROLLER 4

64 64 P1316449 FRICTION WASHER 4

65 65 P1315909 ADJUSTING PIN 1

66 66 P1307609 RETAINING PIN 1

67 67 P1302204 RETAINING BRACKET 1

68 68 P1301727 O-RING 1
FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28 75
 76

FUEL INJECTION PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

69 69 P1302104 BRACKET 1

70 - P1310505 BUSH 1

71 - P1310605 RUBBER BUSH 1

FEED PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28 77
 78

FEED PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 HOUSING 1 NSS

2 2 FEED PUMP PLUNGER 1 NSS

3 2 P1301542 FEED PUMP PLUNGER (BLUE) AR

4 2 P1301842 FEED PUMP PLUNGER (WHITE) AR

5 3 P1312936 PLUNGER SPRING 1

6 4 P1301331 SCREW PLUG 1

7 5 P1303733 PRESSURE SPINDLE 1

8 6 P1301442 OVERFLOW VALVE 2

9 7 P1302236 COMPRESSION SPRING 2

10 8 P1300125 REDUCING UNION 1

11 9 P1300427 O-RING 1

12 10 P1315139 HAND PRIMER 1

13 11 P1300235 SEALING RING 2

14 12 P1301707 SEALING RING 1

15 13 P1336535 HOLLOW SCREW WITH STRAINER ( INLET ) 1

16 14 P1301509 GUIDE PIN 2

17 15 P1300943 ROLLER TAPPET 1

FEED PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28 79
 80

FEED PUMP - INTERNAL COMPONENTS - A9221200 - HAFIE28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 P1301705 ROLLER RING 1

19 17 P1301409 BEARING PIN 1

20 18 P1300207 SNAP RING 1

21 - P1300429 BANJO CONNECTION 1

22 - P1314035 PACKING RING 2

23 - P1351635 SCREW 1
NOZZLE - A9221300 - HAENH15 81
 82

NOZZLE - A9221300 - HAENH15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X7473500 INJECTOR 3

2 1.1 X7473600 INSTRUMENTED INJECTOR 1

3 2 F1761300 GASKET NOZZLE HOLDER 4

4 3 F0131614 ADAPTOR NOZZLE HOLDER 4

5 4 L9110818 FLANGED NUT - M8X1.25 8

NOZZLE - INTERNAL COMPONENTS - A9221300 - HAENH15 83
 84

NOZZLE - INTERNAL COMPONENTS - A9221300 - HAENH15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - X7473500 INJECTOR 1

2 1 NOZZLE HOLDER BODY 1 NSS

3 2 P1336335 PRESSURE BOLT 1

4 3 P1309636 SPRING 1

5 4 SHIM 1

6 4 P1339644 0.80mm THICK AR

7 4 P1339744 0.82mm THICK AR

8 4 P1339844 0.84mm THICK AR

9 4 P1339944 0.86mm THICK AR

10 4 P1340044 0.88mm THICK AR

11 4 P1340144 0.90mm THICK AR

12 4 P1340244 0.92mm THICK AR

13 4 P1340344 0.94mm THICK AR

14 4 P1340444 0.96mm THICK AR

15 4 P1340544 0.98mm THICK AR

16 4 P1340644 1.00mm THICK AR

17 4 P1340744 1.02mm THICK AR

NOZZLE - INTERNAL COMPONENTS - A9221300 - HAENH15 85
 86

NOZZLE - INTERNAL COMPONENTS - A9221300 - HAENH15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 4 P1340844 1.04mm THICK AR

19 4 P1340944 1.06mm THICK AR

20 4 P1341044 1.08mm THICK AR

21 4 P1341144 1.10mm THICK AR

22 4 P1341244 1.12mm THICK AR

23 4 P1341344 1.14mm THICK AR

24 4 P1341444 1.16mm THICK AR

25 4 P1341544 1.18mm THICK AR

26 4 P1341644 1.20mm THICK AR

27 4 P1341744 1.22mm THICK AR

28 4 P1341844 1.24mm THICK AR

29 4 P1341944 1.26mm THICK AR

30 4 P1342044 1.28mm THICK AR

31 4 P1342144 1.30mm THICK AR

32 4 P1342244 1.32mm THICK AR

33 4 P1342344 1.34mm THICK AR

34 4 P1342444 1.36mm THICK AR

NOZZLE - INTERNAL COMPONENTS - A9221300 - HAENH15 87
 88

NOZZLE - INTERNAL COMPONENTS - A9221300 - HAENH15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 4 P1342544 1.38mm THICK AR

36 4 P1342644 1.40mm THICK AR

37 4 P1342744 1.42mm THICK AR

38 4 P1342844 1.44mm THICK AR

39 4 P1342944 1.46mm THICK AR

40 4 P1343044 1.48mm THICK AR

41 4 P1343144 1.50mm THICK AR

42 4 P1343244 1.52mm THICK AR

43 4 P1343344 1.54mm THICK AR

44 4 P1343444 1.56mm THICK AR

45 4 P1343544 1.58mm THICK AR

46 4 P1343644 1.60mm THICK AR

47 4 P1343744 1.62mm THICK AR

48 4 P1343844 1.64mm THICK AR

49 4 P1343944 1.66mm THICK AR

50 4 P1344044 1.68mm THICK AR

51 5 P1342512 DISTANCE PIECE 1

NOZZLE - INTERNAL COMPONENTS - A9221300 - HAENH15 89
 90

NOZZLE - INTERNAL COMPONENTS - A9221300 - HAENH15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 6 P1301407 CIRCLIP 1

53 7 P1310105 BUSH 1

54 8 P1310205 RUBBER BUSH 1

55 9 P1323135 BANJO BOLT 1

56 10 P1302249 WASHER 2

57 11 P1336435 NOZZLE RETAINING NUT 1

58 12 P1306456 NOZZLE FOR INJECTOR 1

COOLANT PUMP - A9219400 - HAEWP16 91
 92

COOLANT PUMP - A9219400 - HAEWP16

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X1503822 POLY V PULLEY - WATER PUMP 1

2 2 B8760406 S/A OF WATER PUMP 1

3 3 L9010830 FLANGED SCREW - M8X1.25X30L 4

4 4 L9510819 FLANGED BOLT - M8X1.25X95L 2

5 5 L9010822 FLANGED SCREW - M8X1.25X22L 4

AIR COMPRESSOR - A8747700 - HAECR10/1 93
 94

AIR COMPRESSOR - A8747700 - HAECR10/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F7474000 AIR COMPRESSOR ASSY 1

2 2 F1655611 GEAR AIR COMPRESSOR DRIVE 1

3 3 F2702850 O-RING 104.4 X 3.1 1

4 4 L9511023 FLANGED BOLT - M10X1.5X115L 2

5 5 L9011027 FLANGED SCREW - M10X1.5X27L 1

6 6 X7435600 COPPER WASHER 2

7 7 F3143815 BANJO BOLT 1

8 - F0110815 ADAPTOR 2
AIR COMPRESSOR - INTERNAL COMPONENTS - A8747700 - HAECR10/1 95
 96

AIR COMPRESSOR - INTERNAL COMPONENTS - A8747700 - HAECR10/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F7474000 AIR COMPRESSOR ASSY 1

2 1.1 P1010635 SETSCREW 4

3 2 P1006535 WASHER 4

4 3 P1000637 M6 STUD 1

5 4 P1001249 WASHER 1

6 5 P1004218 CYLINDER HEAD 1

7 6 P1003317 JOINT 1

8 P1008739 REED VALVE ASSY 1 COMPRISES OF(SL.NOs.9,10,11,12,13,14,15)

9 7 LOCATING PIN 2 NSS

10 8 DELIVERY REED 1 NSS

11 9 VALVE PLATE 1 NSS

12 10 INLET REED 1 NSS

13 11 LOCATING PIN 1 NSS

14 12 LOCATING PIN 1 NSS

15 13 P1003417 JOINT 1

16 P1007551 PISTON ASSY - STD 1 COMPRISES OF(SL.NOs.19,20,21,22,23)

17 P1007951 PISTON ASSY - 0.254 MM O/S I 1 COMPRISES OF(SL.NOs.19,20,21,22,23)

AIR COMPRESSOR - INTERNAL COMPONENTS - A8747700 - HAECR10/1 97
 98

AIR COMPRESSOR - INTERNAL COMPONENTS - A8747700 - HAECR10/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 P1008051 PISTON ASSY - 0.508 MM O/S II 1 COMPRISES OF(SL.NOs.19,20,21,22,23)

19 14 EXTERNALLY STEPPED RING 3 NSS

20 15 OIL CONTROL RING 1 NSS

21 16 PISTON 1 NSS

22 17 GUDGEON PIN 1 NSS

23 18 CIRCLIP 2 NSS

24 P1008839 CONNECTING ROD ASSY 1 COMPRISES OF(SL.NOs.25,26,27,28)

25 19 P1002432 CONNECTION ROD 1

26 20 THIN WALLED BEARING 2 NSS

27 21 LOCKING STRAP 1 NSS

28 22 P1000235 CONNECTING ROD BOLT 2

29 23 P1004618 CYLINDER BLOCK 1

30 24 BUSH 2 NSS

31 25 LOCK WASHER 1 NSS

32 26 NUT 1 NSS

33 27 JOINT 1 NSS

34 28 P1005211 COVER 1
AIR COMPRESSOR - INTERNAL COMPONENTS - A8747700 - HAECR10/1 99
 100

AIR COMPRESSOR - INTERNAL COMPONENTS - A8747700 - HAECR10/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 29 P1001649 SPRING WASHER 4

36 30 P1013435 HEXAGON SCREW 4

37 31 THRUST WASHER 1 NSS

38 32 P1001509 WOODRUFF KEY 1

39 33 P1000733 CRANK SHAFT 1

40 34 JOINT 1 NSS

41 35 P1003411 END COVER 1

42 36 P1001549 WASHER 4

43 37 P1010735 SETSCREW 4

44 38 P1012235 NUT 1

45 P1011451 CYLINDER HEAD GASKET REPAIR KIT 1 COMPRISES OF(SL.NOs.7,9,13,14,15)

46 P1007351 MINOR REPAIR KIT 1 COMPRISES OF(SL.NOs.9,13,14,27,33,40)

47 P1007451 MAJOR REPAIR KIT - STD 1 COMPRISES OF(SL.NOs.9,13,14,26,27,30,31,32,33,37,38,40)

48 P1007751 MAJOR REPAIR KIT - 0.254mm U/S 1 COMPRISES OF(SL.NOs.9,13,14,26,27,30,31,32,33,37,38,40)

49 P1007851 MAJOR REPAIR KIT - 0508mm U/S 1 COMPRISES OF(SL.NOs.9,13,14,26,27,30,31,32,33,37,38,40)

50 P1007651 PISTON RING REPAIR KIT - STD 1 COMPRISES OF(SL.NOs.19,20)

51 P1008151 PISTON RING REPAIR KIT - 0.254mm O/S 1 COMPRISES OF(SL.NOs.19,20)

AIR COMPRESSOR - INTERNAL COMPONENTS - A8747700 - HAECR10/1 101
 102

AIR COMPRESSOR - INTERNAL COMPONENTS - A8747700 - HAECR10/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 P1008251 PISTON RING REPAIR KIT - 0.508mm O/S 1 COMPRISES OF(SL.NOs.19,20)

53 P1011551 PISTON REPAIR KIT - STD 1 COMPRISES OF(SL.NOs.21,22,23)

54 P1009551 PISTON REPAIR KIT - 0.254mm O/S 1 COMPRISES OF(SL.NOs.19,20,21,22,23)

55 P1009651 PISTON REPAIR KIT - 0.508mm O/S 1 COMPRISES OF(SL.NOs.19,20,21,22,23)

STARTER MOTOR - A9714800 - HASM10 103
 104

STARTER MOTOR - A9714800 - HASM10

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X7822900 STARTER MOTOR PRE - ENGAGED 1

2 2 L9121018 FLANGED NUT M10X1.25 3

STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - A9714800 - HASM10 105
 106

STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - A9714800 - HASM10

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X7822900 STARTER MOTOR PRE - ENGAGED 1

2 1.1 P3702207 SHROUD 1

3 2 P3712139 PLUNGER ASSY 1

4 3 P3701220 SOLENOID SWITCH ASSY 1

5 4 P3708939 FIXING BRACKET ASSY 1

6 5 P3709445 DRIVE ASSY 1

7 6 P3705439 ENGAGING LEVER ASSY 1

8 7 P3708639 INTERMEDIATE BRACKET 1

9 8 P3703252 ARMATURE ASSY 1

10 9 P3701453 FIELD COIL ASSY 1

11 10 P3711739 BRUSH GEAR ASSY 1

12 11 P3709039 CE BRACKET ASSY 1

13 P3701651 ARMATURE ASSY KIT 1 COMPRISES OF(SL.NOs.14,15,16,17)

14 12 JUMP RING 1 NSS

15 13 THRUST COLLAR 1 NSS

16 14 THRUST WASHER 1 NSS

17 15 THRUST WASHER 2 NSS

STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - A9714800 - HASM10 107
 108

STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - A9714800 - HASM10

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 P3702351 BRUSH ASSEMBLING KIT 1 COMPRISES OF(SL.NOs.19,20,21,22)

19 16 BRUSH SPRING 4 NSS

20 17 INSUL BRUSH (LONG) 1 NSS

21 17 INSUL BRUSH (LONG) 1 NSS

22 18 EARTH BRUSH 2 NSS

23 P3702451 BEARING BUSH ASSEMBLING KIT 1 COMPRISES OF(SL.NOs.24,25,26)

24 19 BEARING BUSH ( INT. BRKT) 1 NSS

25 20 BEARING BUSH (CE BRKT) 1 NSS

26 21 BEARING BUSH (FIX. BRKT) 1 NSS

27 P3702151 FASTENERS ASSEMBLING KIT 1 COMPRISES

OF(SL.NOs.28,29,30,31,32,33,34,35,36,37,38,39,40,41,42,43,44,45
,46,47,48,49)

28 22 SCREW (SOLENOID) 2 NSS

29 23 SPRING WASHER 2 NSS

30 24 CUP WASHER 1 NSS

31 25 PLUNGER RETURN SPRING 1 NSS

32 26 NUT FOR PIVOT PIN 1 NSS

33 27 PIVOT PIN 1 NSS

34 28 SPRING WASHER (FIELD TERMINAL) 2 NSS

STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - A9714800 - HASM10 109
 110

STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - A9714800 - HASM10

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 29 POLE SCREW 4 NSS

36 30 PLAIN WASHER (THRO STUD) 1 NSS

37 31 BG FIXING SCREW 2 NSS

38 32 O' RING (INTER BRACKET) 1 NSS

39 33 O' RING (CE BRACKET) 1 NSS

40 34 PLAIN WASHER 1 NSS

41 35 SPRING WASHER 2 NSS

42 36 SPRING WASHER (THRO STUD) 2 NSS

43 37 INSULATOR(FIELD TERMINAL) 1 NSS

44 38 LEAD ASSEMBLY 1 NSS

45 39 EARTH TERMINAL 1 NSS

46 40 THROUGH BOLT 2 NSS

47 41 FLANGE NUT 1 NSS

48 42 EARTH TERMINAL NUT 2 NSS

49 43 NUT ( FIELD TERMINAL) 2 NSS

50 P3702251 SEALING ASSEMBLING KIT 1 COMPRISES OF(SL.NOs.51,52,53,54,55)

51 44 OIL SEAL 1 NSS

STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - A9714800 - HASM10 111
 112

STARTER MOTOR - INTERNAL COMPONENTS - LUCAS - A9714800 - HASM10

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 45 GROMMET (FIX. BRACKET) 1 NSS

53 46 INSUL BUSH (BG STUD) 2 NSS

54 47 SEAL ( THRO BOLT BG SCREW) 4 NSS

55 48 INSUL BUSH (TERMINAL) 1 NSS

ALTERNATOR - A9221600 - HADD12 113
 114

ALTERNATOR - A9221600 - HADD12

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X7485900 ALTERNATOR 1 BOSCH

2 1 X7490100 ALTERNATOR 1 LUCASTVS

3 2 X7103422 ALTERNATOR BRACKET 1

4 3 F3570911 LINK BOLT 1

5 4 F3583015 SPECIAL SCREW 1

6 4.1 F4922700 SPECIAL WASHER -mm - SINGLE COIL - 10.8MM ID X 18.1MM OD X 1

2.6MM T

7 4.2 L9110818 FLANGED NUT - M8X1.25 1

8 4.3 X4904510 WASHER 1

9 5 F0130711 ADAPTOR 1

10 6 F0535915 BUSH 1

11 7 X0301650 POLY V BELT 1

12 8 X4202111 VALVE COOLANT COCK 1

13 9 F2701850 O-RING 13.8 X 2.4 1

14 10 F1931322 PIPE COOLANT PUMP OUTLET 1

15 11 F2701650 O-RING 2

16 LO FASTENERS FOR ALT.BRKT MTG ON ENGINE

17 12 L9011027 FLANGED SCREW - M10X1.5X27L 2

ALTERNATOR - A9221600 - HADD12 115
 116

ALTERNATOR - A9221600 - HADD12

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 13 L9511015 FLANGED BOLT - M10X1.5X75L 2

19 14 L4111000 SC WASHER 10 DIA 4

20 LO FASTENERS FOR ALT BRKT TO ALTERNATOR

21 15 L1011226 BOLT 1

22 16 L3611218 NYLOC NUT 1

23 LO FASTENERS FOR ALT TO ADAPTOR PIECE

24 17 L9111018 FLANGED NUT - M10X1.5 1

25 18 L4111000 SC WASHER 10 DIA 1

26 LO FASTENERS TO ARREST ADAPTOR PIECE ON LNK BOLT

27 19 L3011218 NUT M12 X PC 8 X 1.75 2

ALTERNATOR - INTERNAL COMPONENTS - LUCAS - A9221600 - HADD12 117
 118

ALTERNATOR - INTERNAL COMPONENTS - LUCAS - A9221600 - HADD12

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X7490100 ALTERNATOR 1

2 2 P3705315 PULLEY 1

3 3 P3701215 ASYMMETRIC FAN 1

4 4 P3719135 THROUGH BOLT 4

5 5 P3703104 DE BRACKET ASSY 1

6 6 P3704352 ROTOR ASSY 1

7 7 P3703002 RR.BEARING 1

8 8 P3704152 STATOR WINDING ASSY 1

9 9 P3714039 RECTIFIER ASSY 1

10 10 P3713545 BRUSH 2

11 11 P3710139 REGULATOR AND BRUSH BOX ASSY 1

12 12 P3703204 BRACKET ASSEMBLY 1

13 P3701251 PULLEY ASSEMBLING KIT 1 COMPRISES OF(SL.NOs.14,15)

14 13 FLANGE NUT 1 NSS

15 14 BEARING COLLAR 1 NSS

16 P3701351 DE BEARING ASSEMBLING KIT 1 COMPRISES OF(SL.NOs.17,18,19,20,21)

17 15 SCREW (BEARING RET. FIX.) 3 NSS

ALTERNATOR - INTERNAL COMPONENTS - LUCAS - A9221600 - HADD12 119
 120

ALTERNATOR - INTERNAL COMPONENTS - LUCAS - A9221600 - HADD12

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 SPRING WASHER 3 NSS

19 17 DE' BALL BEARING 1 NSS

20 18 BEARING RETAINER 1 NSS

21 19 SPACING COLLAR 1 NSS

22 P3701451 RECTIFIER ASSEMBLING KIT 1 COMPRISES OF(SL.NOs.23,24,25,26,27,28,29,30,31,32)

23 20 SCREW (BRUSH BOX FIX.) 1 NSS

24 21 WASHER 1 NSS

25 22 INSUL BUSH 2 NSS

26 23 SPRING WASHER 6 NSS

27 24 NUT 6 NSS

28 25 LINK 2 NSS

29 26 INSUL BUSH 1 NSS

30 27 PLAIN WASHER 1 NSS

31 28 SPRING WASHER 2 NSS

32 29 NUT 2 NSS

33 P3701551 PLUG MOULDING ASSEMBLING KIT 1 COMPRISES OF(SL.NOs.34)

34 30 PLUG MOULDING ASSY. 1 NSS

TURBO CHARGER - A9251500 - HAESC13/1 121
 122

TURBO CHARGER - A9251500 - HAESC13/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 FK908000 TURBOCHARGER 1

2 2 X1707600 GASKET - T/C TO EMF 1

3 3 F3782115 STUD 3

4 4 X3504011 NUT - HEX M8 9

5 5 X3709115 STUD FOR T/C OUTLET (LONG) 2

6 6 X1301422 ELBOW EXHAUST 1

7 7 X1707500 GASKET ELBOW TO TC 1

8 8 X8000710 L - BRACKET EXH ELBOW 1

9 9 X4904810 SPECIAL WASHER 9

10 10 X1802342 PIPE TURBO COMPRESSOR OUTLET TO CAC 1

11 11 X3991900 V BAND CLAMP TC OUTLET TO CAC INLET 1

12 12 X2703350 O-RING 1

13 13 B4K02201 S/A OF PIPE TURBO OIL DRAIN (TC END) 1

14 14 F7Y01400 TURBO DRAIN GASKET 1

15 15 FE702710 SCREW - 6 X 1.0 CP X 15.0 LONG X GR 12.9 2

16 16 B8727103 S/A OF PIPE TURBO OIL INLET 1

17 17 X3110515 BANJO BOLT 1

TURBO CHARGER - A9251500 - HAESC13/1 123
 124

TURBO CHARGER - A9251500 - HAESC13/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 18 X4901530 WASHER 1

19 LO FASTENERS FOR BLOCK END OIL DRAIN PIPE

20 19 L9010832 FLANGED SCREW - M8X1.25X18L 2

21 20 L9010822 FLANGED SCREW - M8X1.25X22L 4

22 21 L9011035 FLANGED SCREW - M10X1.5X35L 2

23 - L9111018 FLANGED NUT - M10X1.5 2

24 22 X1710800 GASKET OIL OUTLET 1

25 23 X8008210 L - BRACKET CAC PIPE 1

SUNDRIES AND FINISHES - A9204900 - HAESF23 125
 126

SUNDRIES AND FINISHES - A9204900 - HAESF23

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F0845214 STRAP - SPECIAL OLAS 4

2 2 X1100267 EDC CABLE CORRUGATED TUBE 10mm DIA 1

3 3 X1100367 EDC CABLE COVER CORRUGATED TUBE 1

4 - X1100467 EDC CABLE COVER CORRUGATED TUBE 1

5 - X1100567 EDC CABLE COVER CORRUGATED TUBE 1

6 4 F6M00700 CABLE TIE - BLACK 153X3X6 mm 1

AIR INTAKE PIPINGS - A0E05300 - ALAIP289 127
 128

AIR INTAKE PIPINGS - A0E05300 - ALAIP289

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B0E05301 KIT AIR INTAKE SYSTEM 1 COMPRISES

OF(SL.NOs.3,4,5,6,7,8,9,10,11,12,13,14,15,16,17,18,19,20,21,22,23
,24,25,26,27,28,29,30,32,33,35,36,37,38,39,44,54,56,58)

2 B4846802 AIR CLEANER ASSEMBLY 1 COMPRISES OF(SL.NOs.3,4,5,6,7)

3 1 AIR CLEANER HOUSING AND COVER 1 NSS

4 2 F3517400 WING NUT 1

5 3 F1700158 GASKET 1

6 4 X8800114 AIR FILTER PRIMARY 1

7 5 X8800214 AIR FILTER SECONDARY 1

8 6 F3900410 HOSE CLAMP T - BOLT TYPE 1

9 7 F8614450 HOSE HUMP 1

10 8 B4846804 S/A OF PIPE - 2 1

11 9 L1020808 BOLT 1

12 10 L4010800 WASHER 8 DIA 3

13 11 L4110800 SC WASHER 8 DIA 1

14 12 F8603050 STRAIGHT HOSE 1

15 13 F3900310 HOSE CLAMP T BOLT TYPE 2

16 14 F8302160 PRE - CLEANER ASSY 1

17 15 L4011000 WASHER 10 DIA 2

AIR INTAKE PIPINGS - A0E05300 - ALAIP289 129
 130

AIR INTAKE PIPINGS - A0E05300 - ALAIP289

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 L4111000 SC WASHER 10 DIA 2

19 17 F4956210 SPL WASHER 2

20 18 L3021018 NUT M10 X PC 8 X 1 2

21 19 F1978550 STRAIGHT HOSE 1

22 20 X3900910 HOSE CLAMP (T BOLT TYPE) 2

23 21 F8824800 HOOD ASSY 1

24 22 L3010818 NUT M8 X PC 8 X 1.25 2

25 23 F1E01700 BRACKET - DIRTY AIR PIPE MOUNTING 1

26 24 F1504300 ASSY OF DAMPER 2

27 25 F1910160 ELBOW HOSE 1

28 26 F3900210 HOSE CLAMP T - BOLT TYPE 4

29 27 F8615514 PIPE 1

30 28 F1982250 ELBOW HOSE 1

31 29 F1200460 BALATA PACKING 2

32 30 B0E05304 PIPE ASSEMBLY - AIR CLEANER OUTLET II 1

33 31 F8P20358 REDUCER HOSE 1

34 32 F1200560 BALATA PACKING 2

AIR INTAKE PIPINGS - A0E05300 - ALAIP289 131
 132

AIR INTAKE PIPINGS - A0E05300 - ALAIP289

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 33 FB507410 TOP BKT 1

36 34 F1300400 REDUCER ELBOW HOSE 1

37 35 F8318300 T BOLT CLAMP 2

38 36 F8206510 TEE BOLT CLAMP 1

39 37 F8372400 VACUUM INDICATOR 1

40 38 F8919610 MIDDLE BKT 1

41 39 F8919710 TOP BRKT 1

42 40 F8919810 BOTTOM MOUNTING BRKT 1

43 41 L2010825 SCREW M8 X 25 X 1.25 6

44 42 L4010800 WASHER 8 DIA 6

45 43 F2608200 RUBBER WASHER 4

46 44 F2608300 RUBBER WASHER 1

47 45 F1E01210 AIR CLEANER MOUNTING BRACKET 1

48 46 L1011208 BOLT 7

49 47 L3011218 NUT M12 X PC 8 X 1.75 7

50 48 L4111200 SC WASHER 12 DIA 7

51 49 F8918410 STACK PIPE MTG BRKT ON RH FENDER 1

AIR INTAKE PIPINGS - A0E05300 - ALAIP289 133
 134

AIR INTAKE PIPINGS - A0E05300 - ALAIP289

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 50 L1011007 BOLT 2

53 51 L3011018 NUT M10 X PC 8 X 1.5 2

54 52 L4011000 WASHER 10 DIA 2

55 53 F3036310 STRAP 2

56 54 L4111000 SC WASHER 10 DIA 2

57 55 L3011018 NUT M10 X PC 8 X 1.5 4

58 - L4010800 WASHER 8 DIA 1

59 - L3020810 NUT M8 X PC 0 X 1 FP 3

60 B0E05305 KIT - AIR INTAKE SYSTEM CABIN SIDE 1 COMPRISES

OF(SL.NOs.8,9,16,17,18,19,20,21,22,23,24,26,44,54,56,58)

61 B0E05306 KIT - AIR INTAKE SYSTEM CHASSIS SIDE 1 COMPRISES

OF(SL.NOs.3,4,5,6,7,10,11,12,13,14,15,25,27,28,29,30,32,33,35,36,
37,38,39,44,58)

62 B0E05307 PIPE ASSEMBLY - AIR CLEANER INLET 1 COMPRISES OF(SL.NOs.10,11,12,13)

63 - FB507310 PIPE POWDER COATED 1

64 - F8949614 BRACKET FOR OUTLET PIPE 1

COOLING SYSTEM - A1V08900 - ALAC67 135
 136

COOLING SYSTEM - A1V08900 - ALAC67

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B1146301 S/A OF RADIATOR, CAC AND SHROUD 1 COMPRISES OF(SL.NOs.2,3,4), TATA TOYO MAKE

2 1 FD004245 RADIATOR 1

3 2 F8200444 INTER COOLER ASSEMBLY 1

4 3 F1102100 RADIATOR COWL 1

5 B1V08901 S/A OF RADIATOR CAC AND SHROUD 1 COMPRISES OF(SL.NOs.6,7,8), TATA TOYO MAKE

6 1 TBA RADIATOR 1

7 2 TBA INTERCOOLER ASSY 1

8 3 TBA RADIATOR COWL 1

9 4 F8027114 BRACKET RADIATOR TO F S M BRKT 2

10 5 F8027214 BRKT RADIATOR MTG 1

11 6 F8027314 BRACKET RADIATOR MOUNTING 1

12 7 F0530150 RUBBER BUSH 4

13 8 F1235415 DISTANCE PIECE 2

14 9 F4931410 WASHER 2.25 OD X 41/64 ID X 0.187 T 2

15 10 L1021616 BOLT 2

16 11 L3621618 NYLOC NUT 2

17 12 F7871920 BRACKET 1
COOLING SYSTEM - A1V08900 - ALAC67 137
 138

COOLING SYSTEM - A1V08900 - ALAC67

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 13 F2637500 PAD - RADIATOR SUP.BKT 2

19 14 F1292115 SPACER - RDTR SUP INSL 2

20 15 F7177714 BRKT - RADIATOR SUPPORT LOWER 1

21 - F3551811 SPECIAL NUT - CLEVELOC - M8 X 1.25CP X 0mm LONG X GR 2

22 - F4952810 WASHER 19 OD X 8.4 ID X 3 T 2

23 - F3551811 SPECIAL NUT - CLEVELOC - M8 X 1.25CP X 0mm LONG X GR 2

24 - F4949110 WASHER 2

25 16 B2Y03901 470MM DIAMETER OPEN FAN WITH ELECTROMAGNETIC 1 KENDRION MAKE

CLUTCH(LINNIG)

26 17 FF400134 THERMO SWITCH 1

27 18 F1939815 PIPE - TURBO CHARGER OUTLET TO CAC INLET 1

28 19 F8634715 PIPE - CAC OUTLET TO INTAKE MANIFOLD 1

29 20 X1912150 HOSE 2

30 21 X3900310 T BOLT CLAMP 8

31 22 F1977750 HOSE RADIATOR INLET 1

32 23 F0803400 WORM DRIVE CLIP 8

33 24 F1988850 ELBOW HOSE 1

34 25 FB511614 PIPE - RADIATOR OUTLET 1

COOLING SYSTEM - A1V08900 - ALAC67 139
 140

COOLING SYSTEM - A1V08900 - ALAC67

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 26 F1971350 HOSE 1

36 27 X0802410 C - CLAMP 1

37 B1V03207 - S/A OF DAT, DAT MOUNTING BRACKET, HOSES, 1 COMPRISES

CLAMPS AND HARDWARE OF(SL.NOs.38,39,40,41,42,43,45,51,54,56,57,58,59,60,61,62,63,64
), NSS

38 28 B1211616 S/A OF DAT WITH PRESSURE CAP - REMOTE MOUNTED 1

39 - L3010818 NUT M8 X PC 8 X 1.25 2

40 - L4110800 SC WASHER 8 DIA 2

41 29 P4L00016 RADIATOR FILLER CAP 1

42 30 F4L01568 DAT PRESSURE CAP 1

43 31 B1V03308 BRACKET - RADIATOR SUPPLY TANK SUPPORT 1

44 32 F0832210 DOUBLE CLIP 2

45 33 F7972114 BRKT - BRAKE PIPE 2

46 34 F0603260 NYLON STRAP 1

47 35 F1959150 PIPE - RADIATOR OVR FL 1

48 36 FB514414 PIPE - DAT TO RADIATOR 1

49 37 F0831810 CLIP 1

50 38 X0487314 L - BRACKET 1

51 39 F1927050 HOSE RADIATOR SUPPLY TANK 1

COOLING SYSTEM - A1V08900 - ALAC67 141
 142

COOLING SYSTEM - A1V08900 - ALAC67

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 40 F1973850 STRAIGHT HOSE - FOR RADIATOR PIPING 1

53 41 F0803400 WORM DRIVE CLIP 1

54 42 FP000310 WORM DRIVE CLAMP 3

55 43 F1928150 HOSE DAT TO ENGINE 1

56 44 F1927850 HOSE RADIATOR SUPPLY TANK 1

57 - L2010620 SCREW M6 X 20 X 1 CP 1

58 - L3010618 NUT M6 X PC 8 X 1 1

59 - L4110600 SC WASHER 6 DIA 1

60 - L2011030 SCREW M10 X 30 X 1.5 1

61 - L3011018 NUT M10 X PC 8 X 1.5 1

62 - L4111000 SC WASHER 10 DIA 1

63 - L2010835 SCREW M8 X 35 X 1.25 6

64 52 L3010818 NUT M8 X PC 8 X 1.25 3

65 45 X7185010 RADIATOR SUPPORT BRACKET 1

66 46 F8605750 HOSE 2

67 47 F4S02110 CLIP FOR VENT HOSES 4

68 B1V03206 - S/A OF DAT, DAT MOUTNING BRACKET, HOSES, 1 COMPRISES OF(SL.NOs.70,71,72,73,74,75,76,77,78,79,80), ALT
CLAMPS AND HARDWARE TO B1V03207
COOLING SYSTEM - A1V08900 - ALAC67 143
 144

COOLING SYSTEM - A1V08900 - ALAC67

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

69 B1V10518 DAT ASSEMBLY WITH CAP 1 COMPRISES OF(SL.NOs.70,71)

70 48 F4L01568 DAT PRESSURE CAP 1

71 49 DE-AERATION TANK 1 NSS

72 50 F5K00414 BRACKET - DAT MOUNTING 1

73 51 L2010840 SCREW M8 X 40 X 1.25 3

74 52 L3010818 NUT M8 X PC 8 X 1.25 3

75 53 L4010800 WASHER 8 DIA 3

76 54 FXZ00155 HOSE VENT LINE_FROM DAT TO RADIATOR 2

77 - L2010625 SCREW M6 X 25 X 1 CP 1

78 - L3010618 NUT M6 X PC 8 X 1 1

79 - L4110600 SC WASHER 6 DIA 1

80 - F1986550 HOSE -MAKE UP LINE 1

81 - X3900610 WORM DRIVE CLAMP 2

82 - L2111025 SOCKET - SCREW M10 X 25 X 1.5 CP PLATED 2

83 - F8P10358 L-HOSE - RADIATOR PIPING 1

84 - L2021240 SCREW M12 X 40 X 1.5 1

85 - FB511614 PIPE - RADIATOR OUTLET 1

COOLING SYSTEM - A1V08900 - ALAC67 145
 146

COOLING SYSTEM - A1V08900 - ALAC67

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

86 - FAG01299 ADD ON HARNESS FOR EMF CLUTCH 1

87 - F4930240 WASHER 30 OD X 22.5 ID X 1.5 T 1

88 LO FASTENERS : RADIATOR TO RADIATOR MOUNTING BRACKET

89 - L2020820 SCREW M8 X 20 X 1 FP PLATED 6

90 - L4110800 SC WASHER 8 DIA 6

91 LO FASTENERS : FSM MOUNTING BRACKET

92 - L2011235 SCREW M12 X 35 X 1.75 6

93 - L3611218 NYLOC NUT 6

94 - L4011200 WASHER 12 DIA 6

95 - L2011020 SCREW M10 X 20 X 1.5 4

96 - L4111000 SC WASHER 10 DIA 4

97 - L2011030 SCREW M10 X 30 X 1.5 1

98 - L3011018 NUT M10 X PC 8 X 1.5 1

99 - L4111000 SC WASHER 10 DIA 1

100 - L2010630 SCREW M6 X 30 X 1 CP 1

101 - L3010618 NUT M6 X PC 8 X 1 1

102 - L4010600 WASHER 6 DIA 1

COOLING SYSTEM - A1V08900 - ALAC67 147
 148

COOLING SYSTEM - A1V08900 - ALAC67

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

103 LO FASTENERS : DAT TO DAT MOUNTING BRACKET

104 - L2010815 SCREW M8 X 15 X 1.25 2

105 - L4110800 SC WASHER 8 DIA 2

106 - L4011000 WASHER 10 DIA 2

107 LO FASTENERS : VENT HOSES TO ENGINE COVER

108 - L2011030 SCREW M10 X 30 X 1.5 1

109 - L4111000 SC WASHER 10 DIA 1

110 - L2010625 SCREW M6 X 25 X 1 CP 1

111 - L3010618 NUT M6 X PC 8 X 1 1

112 - L4010600 WASHER 6 DIA 1

113 - L3021218 NUT M12 X PC 8 X 1.5 1

114 - L4011200 WASHER 12 DIA 1

ENGINE MOUNTING - A3X01000 - ALME96 149
 150

ENGINE MOUNTING - A3X01000 - ALME96

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 L1021624 BOLT 2

2 2 F4934715 WASHER 2 3/4 OD X 21/32 ID X 5/16 T 2

3 2 L4311600 I - STAR WASHER 16 DIA 2

4 3 F8401622 ENGINE MOUNTING BRACKET 2

5 4 F0915315 DOWEL 2

6 5 L4100800 SC WASHER 1/2 DIA 8

7 6 L1050811 BOLT 1/2 X 1 3/8 BSF 8

8 7 F2606800 ENGINE MOUNTING PAD - REAR 2

9 8 L4111200 SC WASHER 12 DIA 4

10 9 L2011225 SCREW M12 X 25 X 1.75 4

11 10 X3503410 NUT 8

12 11 F4956810 WASHER 23 OD X 12.1 ID X 2.5 T 8

13 12 F3589711 SCREW - HEX M12 X 1.75 CP X 40 LONG X GR 10.9 8

14 13 F8912410 ENGINE MTG BRKT REAR - LH 1

15 13 F8912510 ENGINE MTG BRKT REAR - RH 1

16 14 L3621618 NYLOC NUT 2

17 15 L4111000 SC WASHER 10 DIA 4

ENGINE MOUNTING - A3X01000 - ALME96 151
 152

ENGINE MOUNTING - A3X01000 - ALME96

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 L3011018 NUT M10 X PC 8 X 1.5 4

19 17 F2606700 ENGINE MOUNTING PAD - FRONT 2

20 18 L2011022 SCREW M10 X 22 X 1.5 4

21 19 L4111000 SC WASHER 10 DIA 4

22 20 F3564215 BOLT 8

23 21 F1273115 DISTANCE PIECE 2

24 22 F7873960 GROMMER RUBBER 1

25 23 F3587811 BOLT 8

26 24 F3551911 NUT M10X1.5 8

27 25 F8708110 CHANNEL CROSS MEMBER 1

FUEL TANK - A5L09600 - ALOT155 153
 154

FUEL TANK - A5L09600 - ALOT155

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B5009703 TANK ASSEMBLY 1

2 2 F3142315 PLUG 1

3 3 F1202050 PACKING - FUEL TANK STRAP 2

4 4 FF405700 FUEL LEVEL SENSOR 1

5 5 F1115000 FUEL TANK CAP 1

6 6 L4110500 SC WASHER 5 DIA 6

7 7 X7801110 BRACKET - FUEL TANK MOUNTING 2

8 8 F1201950 PACKING - FUEL TANK BRKT 2

9 9 X1904914 STRAP 2

10 10 F0965615 PIN - FUEL TANKSTRAP 2

11 11 F3591211 BOLT TANK STRAP FIXING 2

12 12 F4953710 WASHER 2

13 13 L3011018 NUT M10 X PC 8 X 1.5 4

14 14 F3588211 BOLT 12

15 15 F4953710 WASHER 12

16 16 L3611018 NYLOC NUT 12

17 17 F4932740 WASHER 1
FUEL TANK - A5L09600 - ALOT155 155
 156

FUEL TANK - A5L09600 - ALOT155

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

19 18 L2010510 SCREW M5 X 10 X 0.8 CP 6

20 19 F4931640 WASHER 1

21 - B5009709 S/A OF SUCTION PIPE 1

FUEL PIPING - A5J05700 - ALPF354 157
 158

FUEL PIPING - A5J05700 - ALPF354

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B4463201 HOSE ASSY - FUEL TANK TO STRAINER 1

2 2 F7873960 GROMMER RUBBER 1

3 3 B4463602 HOSE ASSY - STRAINER TO FEED PUMP 1

4 4 F8824500 FUEL STRAINER 1

5 5 F8474714 STRAINER BRACKET 1

6 6 F0804814 C - CLAMP 1

7 7 B4449802 TUBE ASSY F/P TO FILTER 850mm 1

8 8 B4461901 S/A OF FUEL FILTER 1 COMPRISES OF(SL.NOs.9,10)

9 9 F8835200 FUEL FILTER HEAD ASSY 1

10 10 F8835100 FUEL FILTER CUM WATER SEPARATOR 1

11 11 F2F01114 FUEL FILTER MOUNTING BRACKET 1

12 12 F3108815 ADAPTOR 1

13 13 F4930430 SPECIAL WASHER 2

14 14 F3590715 BANJO BOLT 1

15 15 X4901530 WASHER 2

16 16 B4463103 TUBE ASSEMBLY FILTER 1

17 17 F8200110 JUPITOR HOSE CLAMP 2

FUEL PIPING - A5J05700 - ALPF354 159
 160

FUEL PIPING - A5J05700 - ALPF354

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 18 B5018810 S/A OF RETURN PIPE 1

19 19 B5J05701 FORMED FUEL RETURN HOSE 1

20 20 F0830310 CLIP 1

21 21 F0114215 ELBOW ADAPTOR - DIA 9 X M 18 1

22 22 F3569715 NUT 1

23 23 F8031310 L - BRACKET 2

24 LO FUEL FILTER TO ITS BKT

25 24 L1021210 BOLT 2

26 25 L3021218 NUT M12 X PC 8 X 1.5 2

27 26 L4111200 SC WASHER 12 DIA 2

28 27 L4011200 WASHER 12 DIA 2

29 LO C CLAMP TO STRAINER L BRKT

30 28 L2010615 SCREW M6 X 15 X 1 CP 2

31 29 F0845214 STRAP - SPECIAL OLAS 6

32 30 F4900540 WASHER 30 OD X 20.5 ID X 1.5 T 1

33 31 F0830540 SCHEDULE OF CLIPS 2

34 32 F0832210 DOUBLE CLIP 1

FUEL PIPING - A5J05700 - ALPF354 161
 162

FUEL PIPING - A5J05700 - ALPF354

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 33 X7172210 L BRACKET - ON LH FSM NEAR RSF CROSS MBR 1

36 - L3010618 NUT M6 X PC 8 X 1 4

37 - L4110600 SC WASHER 6 DIA 2

38 - L2011035 SCREW M10 X 35 X 1.5 1

39 - L4011000 WASHER 10 DIA 1

40 - L3011018 NUT M10 X PC 8 X 1.5 2

41 - L2010625 SCREW M6 X 25 X 1 CP 2

42 - L4010600 WASHER 6 DIA 1

43 - L2011030 SCREW M10 X 30 X 1.5 1

44 - L4010600 WASHER 6 DIA 1

SILENCER AND EXHAUST SYSTEM - A7F57400 - ALSPE403 163
 164

SILENCER AND EXHAUST SYSTEM - A7F57400 - ALSPE403

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F8413914 SILENCER MOUNTING BRACKET ON FRAME 2

2 2 L2011025 SCREW M10 X 25 X 1.5 4

3 3 F1953415 SPACER MUFFLER SUPPORT 2

4 4 F4950010 WASHER 1.5 OD X 0.53 ID X 0.128 T 2

5 5 B9308801 S/A OF EXHAUST PIPE 1

6 6 L3011218 NUT M12 X PC 8 X 1.75 3

7 7 F8424014 BRACKET EXHAUST PIPE MOUNTING 1

8 8 F0839010 PIPE CLAMP 1

9 9 L3021018 NUT M10 X PC 8 X 1 6

10 10 B5146301 S/A OF SECOND EXHAUST PIPE 1

11 11 L3811018 CLEVELOC NUT M10 X PC 8 X 1.5 4

12 12 L2011030 SCREW M10 X 30 X 1.5 2

13 13 F8423014 SILENCER O CLAMP 2

14 14 FN102914 SHORTER TAIL PIPE WITH FLARING 1

15 15 F8088500 EXHAUST BRAKE ASSY 1

16 16 B7F57701 215 DIA REAR OUT MUFFLER WITHOUT GLASSWOOL 1

17 17 L4011000 WASHER 10 DIA 4

SILENCER AND EXHAUST SYSTEM - A7F57400 - ALSPE403 165
 166

SILENCER AND EXHAUST SYSTEM - A7F57400 - ALSPE403

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 18 L2011035 SCREW M10 X 35 X 1.5 2

19 19 L4111000 SC WASHER 10 DIA 6

20 20 L2021025 SCREW M10 X 25 X 1 6

21 21 FC108314 PLATE 2

22 22 L4111200 SC WASHER 12 DIA 3

23 23 L1011209 BOLT 3

24 24 L1021216 BOLT 2

25 25 L3621218 NYLOC NUT 2

26 26 F2638100 PAD MUFFLER SUPPORT 4

27 27 F7D01614 SILENCER REAR MOUNTING 2

28 28 F3430922 INSERT 1

29 29 F0810010 O CLAMP 2

30 30 L3611018 NYLOC NUT 4

ENGINE INTERFACE COMPONENTS - A3R00100 - ALEIC5 167
 168

ENGINE INTERFACE COMPONENTS - A3R00100 - ALEIC5

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F4930630 WASHER FOR PLUG 1

2 2 F2215200 LOW OIL PRESSURE SWITCH 1

CLUTCH - A1M00700 - ALC52/1 169
 170

CLUTCH - A1M00700 - ALC52/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B1305303 330 DIA AXIAL SPRING COVER ASSY 1

2 2 B1305306 330 DIA CLUTCH DISC 1 CLUTCH AUTO LIMITED

3 2 B1M00702 330 DIAMETER CLUTCH DISC WITH F510 LINING 1 AMREP MAKE

4 3 P2602730 PRESSURE PLATE ORGANIC 1

5 4 P2622639 CLUTCH HOUSING ORGANIC 1

6 5 L1010811 BOLT 8

7 6 L4110800 SC WASHER 8 DIA 8

8 LO SERVICE KITS

9 P2613551 MAJOR KIT 1 COMPRISES OF(SL.NOs.10,11,12,13,14,15,16,17,18)

10 7 RELEASE LEVER 4 NSS

11 8 ANTIRATTLE SPRING 4 NSS

12 9 LONG PIN 4 NSS

13 10 SMALL PIN 4 NSS

14 11 ADJUSTING NUT 4 NSS

15 12 PR. SPRING 16 NSS

16 13 SLEEVE 16 NSS

17 14 NIDDLE ROLLER 152 NSS

CLUTCH - A1M00700 - ALC52/1 171
 172

CLUTCH - A1M00700 - ALC52/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 15 SPLITCOTTER PIN 4 NSS

19 P2613651 MINOR KIT 1 COMPRISES OF(SL.NOs.20,21,22,23,24,25)

20 7 RELEASE LEVER 4 NSS

21 8 ANTIRATTLE SPRING 4 NSS

22 9 LONG PIN 4 NSS

23 10 SMALL PIN 4 NSS

24 11 ADJUSTING NUT 4 NSS

25 14 NIDDLE ROLLER 152 NSS

26 15 SPLITCOTTER PIN 4 NSS

27 P2613751 CYLINDER LINING KIT - 330 DIA AXIAL CLUTCH 1 COMPRISES OF(SL.NOs.28,29,30)

28 16 CLUTCH LINING 2 NSS

29 17 CLUTCH LINING RIVET 48 NSS

30 18 ROUND HEAD RIVET 12 NSS

31 - PD600225 Release Lever Kit 1

32 - PD600226 Spring Kit 1

33 - P7G00006 Pressure Plate 1

34 - PC800012 Cover Plate 1

CLUTCH WITHDRAWAL GEAR - A1N01500 - ALCWG78/1 173
 174

CLUTCH WITHDRAWAL GEAR - A1N01500 - ALCWG78/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F3422622 CLUTCH WITHDRAWAL SLEEVE 1

2 2 F0258210 CLUTCH RELEASE BEARING 1

3 3 F3634910 SPRING 1

4 4 F0155415 UNION 2

5 5 F4905400 M10 COPPER WASHER 2

6 6 F3321515 CLUTCH ROCKER SHAFT 1

7 7 F0949015 WOODRUFF KEY 2

8 8 F2419811 CLUTCH OPERATING LEVER - INNER 1

9 9 F2414911 CLUTCH OPERATING LEVER - OUTER 1

10 - L1080618 BOLT 3/8 inch UNF 2.25 inch LONG 1

11 - L3080611 NUT 1

12 10 F8489614 BOOSTER MOUNTING BRACKET 1

13 - F0103910 ADAPTOR ON CLUTCH BOOSTER 1

14 - F4930430 SPECIAL WASHER 1

15 - F3103815 BANJO BOLT 1

16 - F4905400 M10 COPPER WASHER 2

17 - L4110800 SC WASHER 8 DIA 4

CLUTCH WITHDRAWAL GEAR - A1N01500 - ALCWG78/1 175
 176

CLUTCH WITHDRAWAL GEAR - A1N01500 - ALCWG78/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 11 F5P00500 CLUTCH BOOSTER - 3 inch 1

19 - L1011007 BOLT 2

20 - L4111000 SC WASHER 10 DIA 2

21 - L3011018 NUT M10 X PC 8 X 1.5 2

22 12 F2111015 JAW END 1

23 13 F0933815 SPECIAL PIN 1

24 - L3550511 NYLOC THIN NUT 1

25 14 F2932115 GREASE NIPPLE 2

26 15 F7873530 CLUTCH MASTER CYLINDER 1

27 - P1602951 MASTER CYLINDER KIT - MINOR 1

28 - F3551811 SPECIAL NUT - CLEVELOC - M8 X 1.25CP X 0mm LONG X GR 2

29 16 F3140215 M12 BANJO 1

30 17 F8008200 BANJO BOLT 1

31 18 F4922300 GASKET 4

32 19 B1417401 BUNDY PIPE ASSEMBLY 1

33 20 F7988010 L - BRACKET 1

34 21 F3554115 NUT - HEX M12 X 1 - X 6.8 LONG X 0 3

CLUTCH WITHDRAWAL GEAR - A1N01500 - ALCWG78/1 177
 178

CLUTCH WITHDRAWAL GEAR - A1N01500 - ALCWG78/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 22 F3978000 SHAKE PROOF WASHER 3

36 23 B6600208 S/A OF FLEX. HOSE - ARMOURED 1

37 - F0845214 STRAP - SPECIAL OLAS 1

38 - X3004310 PLATE 1

39 - L2010825 SCREW M8 X 25 X 1.25 2

40 - L3010818 NUT M8 X PC 8 X 1.25 2

41 24 B6601232 SUB ASSY OF PIPE 1

42 - F0832010 DOUBLE CLIP 2

43 - F7972114 BRKT - BRAKE PIPE 1

44 - L2010620 SCREW M6 X 20 X 1 CP 2

45 25 F8P05050 HOSE ASSEMBLY 1

46 26 F0476714 BRACKET 1

47 27 L1080614 BOLT 3/8 inch UNF 1.75 inch LONG 1

48 28 L4100600 SC WASHER 3/8 DIA 2

CLUTCH BOOSTER - INTERNAL COMPONENTS - A1N01500 - ALCWG78/1 179
 180

CLUTCH BOOSTER - INTERNAL COMPONENTS - A1N01500 - ALCWG78/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 P1023151 CLUTCH BOOSTER KIT 1 COMPRISES

OF(SL.NOs.3,5,7,9,12,13,14,15,16,17,19,20,21,22,24,25,26,28,31,3
4,35,37,38,40,43,45,46,47)

2 1 HYDRAULIC BODY 1 NSS

3 2 STRAINER 1 NSS

4 3 BLEEDER SCREW 1 NSS

5 4 PROTECTION PLUG 1 NSS

6 5 SPRING WASHER 1 NSS

7 6 U-RING (PIN) 1 NSS

8 7 PIN 1 NSS

9 8 'O'-RING (PISTON) 1 NSS

10 9 PISTON 1 NSS

11 10 CATRIDGE CYLINDRICAL 1 NSS

12 11 U-RING 1 NSS

13 12 U-RING CATRIDGE OUTLET 1 NSS

14 13 INLET VALVE 1 NSS

15 14 U-RING INLET VALVE 1 NSS

16 15 SPRING-INLET VALVE 13 1 NSS

17 16 SPRING-INLET VALVE 12 1 NSS

CLUTCH BOOSTER - INTERNAL COMPONENTS - A1N01500 - ALCWG78/1 181
 182

CLUTCH BOOSTER - INTERNAL COMPONENTS - A1N01500 - ALCWG78/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - EXHAUST ASSY 1 NSS

19 17 VALVE GUIDE 1 NSS

20 18 PLATE 1 NSS

21 19 VALVE 1 NSS

22 20 EXHAUST PROTECTOR 1 NSS

23 21 HEX HEAD SCREW 8 NSS

24 22 U-RING (HYDRALIC) 1 NSS

25 23 'O' RING 1 NSS

26 24 GUIDE 1 NSS

27 25 'O' RING 1 NSS

28 26 'O' RING 1 NSS

29 27 PIPE 1 NSS

30 28 PNEUMATIC BODY 1 NSS

31 29 SPRING 1 NSS

32 30 GASKET SUPPORT 1 NSS

33 31 U-RING 1 NSS

34 32 HANGER 1 NSS
CLUTCH BOOSTER - INTERNAL COMPONENTS - A1N01500 - ALCWG78/1 183
 184

CLUTCH BOOSTER - INTERNAL COMPONENTS - A1N01500 - ALCWG78/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 33 'O' RING 1 NSS

36 34 PISTON ASSY 1 NSS

37 35 RETAINING RING (PUSH ROD) 1 NSS

38 36 GASKET 1 NSS

39 37 PUSH ROD 1 NSS

40 38 FRONT PLATE 1 NSS

41 39 BOOT 1 NSS

42 40 WEAR INDICATOR BODY 1 NSS

43 41 SPRING 1 NSS

44 42 STEM 1 NSS

45 43 RETAINING RING 1 NSS

46 44 'O' RING 1 NSS

47 45 'O' RING (WEAR INDICATOR ROD) 1 NSS

48 46 FILLISTER HEAD SCREW 2 NSS

GEARBOX AND CASING - A5P09600 - ALGB114/15 185
 186

GEARBOX AND CASING - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 A5P09600 ASSEMBLY OF GEARBOX - 8.28 FGR 1

2 2 F8R00642 GEARBOX HOUSING 1

3 3 F1758900 GASKET 1

4 4 F1332342 FILLER ELBOW 1

5 5 F3106915 FILLER PLUG 1

6 6 L4510800 WAVE WASHER 8 DIA 2

7 7 L2010825 SCREW M8 X 25 X 1.25 2

8 8 F1772900 GASKET REVERSE IDLER COVER 1

9 9 F1102313 REV. IDLER COVER 1

10 10 L4510800 WAVE WASHER 8 DIA 8

11 11 L2010816 SCREW M8 X 16 X 1.25 8

12 - F3110815 PLUG 1

13 12 F3107015 DRAIN PLUG - MAGNETIC 1

14 13 F3550410 HELICOIL INSERT - M18X1.5 1

15 14 F3143115 PLUG 2

16 15 F3550910 HAMMER DRIVE SCREW 4

17 16 IDENTIFICATION PLATE 1 NLS

GEARBOX AND CASING - A5P09600 - ALGB114/15 187
 188

GEARBOX AND CASING - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 B1545102 S/A OF DETENT PLUNGER 1

19 18 F1718800 GASKET - DETENT PLUNGER 1

20 19 F4944010 TAB WASHER 1

21 20 FF403400 PROXIMITY SENSOR 1

22 21 F4944110 SEALING RING 1

23 22 F8285000 REVERSE LIGHT SWITCH 1

24 23 F4905010 WASHER 27 OD X 18.4 ID X 2 T 1

25 24 F2717500 OIL SEAL (REAR) 1

26 25 F1718600 GASKET - END COVER 1

27 26 F1102013 END COVER 1

28 27 L2011225 SCREW M12 X 25 X 1.75 4

29 28 F1718500 GASKET - GEAR CASING 1

30 29 F1803942 CONNECTING HOUSING 1

31 30 F0928315 DOWEL 2

32 31 F7456300 BREATHER 1

33 32 L4511000 WAVY WASHER 10 DIA 1

34 33 L1011014 BOLT 20
GEARBOX AND CASING - A5P09600 - ALGB114/15 189
 190

GEARBOX AND CASING - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 34 L4511000 WAVY WASHER 10 DIA 20

36 35 F0R00222 CLUTCH HOUSING 1

37 36 F3771115 SPECIAL STUD 10

38 37 L3021218 NUT M12 X PC 8 X 1.5 10

39 38 L4111200 SC WASHER 12 DIA 10

40 39 F7656314 COVER PLATE 2

41 40 L2010816 SCREW M8 X 16 X 1.25 4

42 41 L4010800 WASHER 8 DIA 4

43 42 L4110800 SC WASHER 8 DIA 4

44 P2603017 GEAR BOX GASKET KIT 1 COMPRISES OF(SL.NOs.3,19,26,29)

INPUT SHAFT - A5P09600 - ALGB114/15 191
 192

INPUT SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 L2010828 SCREW M8 X 28 X 1.25 11

2 2 F7116422 INPUT SHAFT COVER 1

3 3 F2717600 IPS OIL SEAL 1

4 4 F1719000 GASKET - IPS COVER 1

5 5 F4930513 RETAINING RING 1

6 6 F0739510 SPLIT RING - 3.5 2

7 6 F0739410 SPLIT RING 2

8 6 F0739610 SPLIT RING - 3.6 2

9 6 F0739710 SPLIT RING - 3.7 1

10 7 F0704910 SNAP RING A=1.70 2

11 7 F0705010 SNAP RING A=1.60 2

12 7 F0705110 SNAP RING A=1.50 2

13 7 F0705210 SNAP RING A=1.40 2

14 7 F0705310 SNAP RING A=1.35 2

15 7 F0705410 SNAP RING A=1.30 2

16 7 F0705510 SNAP RING A=1.20 2

17 8 F0736710 CIRCLIP 1
INPUT SHAFT - A5P09600 - ALGB114/15 193
 194

INPUT SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 9 F0254110 IPS BEARING 1 ALT - F0259210

19 10 F3311411 INPUT SHAFT 1

20 11 F0741110 SPACER S=3.0 1

21 11 F0741210 SPACER S=3.3 1

22 11 F0741310 SPACER S=3.5 1

23 11 F0741410 SPACER S=3.7 1

24 11 F0741510 SPACER (4.0) 1

25 11 F0741610 SPACER S=4.3 1

26 11 F0741710 SPACER S=4.6 1

27 11 F0741810 SPACERS=4.9 1

28 11 F0741910 SPACER S=5.2 1

29 12 F1610411 CLUTCH BODY 1

30 P0976351 CIRCLIP KIT 1 COMPRISES OF(SL.NOs.17,20,21,22,23,24,25,26,27,28,29)

MAIN SHAFT - A5P09600 - ALGB114/15 195
 196

MAIN SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F0737310 CIRCLIP 1

2 2 F0254010 SPIGOT BEARING 1

3 3 F3424115 SLEEVE 1

4 4 F0720510 SPECIAL CIRCLIP - EXTERNAL - 48 X 1.9 1

5 B1545106 S/A OF SYNCHRO PACK 5TH & 6TH. 1 COMPRISES OF(SL.NOs.6,7,8,9,10,11)

6 5 F1624611 SYNCHRO-RING 5TH AND 6TH 1

7 6 F1609511 SYNCHRO BODY 1

8 7 F3651410 SPRING 3

9 8 F0927815 BALL PIN 3

10 9 F3400216 PRESSURE PIECE 3

11 10 F1609611 SLIDING SLEEVE (5/6) 1

12 11 F1610411 CLUTCH BODY 1

13 12 F8A04611 O/D GEAR ON MAINSHAFT 1

14 13 F0254910 NEEDLE ROLLER BEARING 1

15 14 F0720510 SPECIAL CIRCLIP - EXTERNAL - 48 X 1.9 1

16 15 F3427015 SLEEVE 1

17 16 F0256210 NEEDLE CAGE 1

MAIN SHAFT - A5P09600 - ALGB114/15 197
 198

MAIN SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 F8A02111 4TH GEAR ON MAINSHAFT 1

19 18 F1610511 CLUTCH BODY 2

20 B1545104 S/A OF SYNCHRO PACK 1 COMPRISES OF(SL.NOs.21,22,23,25,26,27)

21 19 F1624511 SYNCHRO-RING 3RD AND 4TH 3

22 20 F1610611 SYNCHRO BODY 1

23 21 F1608411 SLIDING SLEEVE 1

24 22 F1608911 GEAR ON MAINSHAFT 3RD 1

25 23 F3651410 SPRING 3

26 24 F0927815 BALL PIN 3

27 25 F3400216 PRESSURE PIECE 3

28 26 F1668111 GEAR ON MAINSHAFT 2ND 1

29 27 F1650111 CLUTCH BODY 1

30 B1545103 S/A OF SYNCHRO PACK 1ST & 2ND 1 COMPRISES OF(SL.NOs.31,32,33,34,35)

31 28 F1624411 SYNCHRO-RING 1ST AND 2ND 2

32 29 F1608111 SYNCHRO BODY 1

33 30 F3651410 SPRING 3

34 31 F3421010 PRESSURE PIECE 3

MAIN SHAFT - A5P09600 - ALGB114/15 199
 200

MAIN SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 32 F1608211 SLIDING SLEEVE 1

36 33 F0737810 SPECIAL CIRCLIP - EXTERNAL - 68 X 2.3 1

37 33 F0737710 SPECIAL CIRCLIP - EXTERNAL - 68 X 2.35 1

38 33 F0737610 SPECIAL CIRCLIP - EXTERNAL - 68 X 2.4 1

39 33 F0737510 SPECIAL CIRCLIP - EXTERNAL - 68 X 2.45 1

40 33 F0737410 SPECIAL CIRCLIP - EXTERNAL - 68 X 2.5 1

41 34 F0254310 NEEDLE BEARING 2

42 35 F1623411 1ST GEAR ON MAIN SHAFT 1

43 36 F1609411 REVERSE CLUTCH BODY 1

44 37 F1668311 REVERSE GEAR ON MS 1

45 38 F3424215 SLEEVE 1

46 39 F0737910 SPECIAL CIRCLIP - INTERNAL - 100 X 3 1

47 39 F0738010 SPECIAL CIRCLIP - INTERNAL - 100 X 2.9 1

48 39 F0738110 SPECIAL CIRCLIP - INTERNAL - 100 X 2.8 1

49 39 F0738210 SPECIAL CIRCLIP - INTERNAL - 100 X 2.7 1

50 39 F0704810 SPECIAL CIRCLIP - INTERNAL - 100 X 2.6 1

51 40 F0254410 ROLLER BEARING 1

MAIN SHAFT - A5P09600 - ALGB114/15 201
 202

MAIN SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 41 F1615211 PULSE DISC FOR ELECTRONIC SPEEDO 1

53 42 F1439511 OUTPUT FLANGE 1

54 43 F3553210 NUT OUTPUT FLANGE 1

55 44 F4931013 WASHER 1

56 P0976351 CIRCLIP KIT 1 COMPRISES OF(SL.NOs.1,4,15,36,37,38,39,40,46,47,48,49,50)

57 45 F0254710 NEEDLE ROLLER BEARING 1

58 46 F3318711 MAIN SHAFT 1

59 47 F0254610 NEEDLE ROLLER BEARING 1

REVERSE SHAFT - A5P09600 - ALGB114/15 203
 204

REVERSE SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F0255010 NEEDLE CAGE - REV IDLER GEAR 2

2 2 F8A02611 REVERSE IDLER GEAR 1

3 3 F2747400 O-RING 23 X 3 1

4 4 F0928415 REV IDLER SHAFT 1

5 5 F0450710 LOCK PLATE 1

6 6 L4510800 WAVE WASHER 8 DIA 1

7 7 L2010816 SCREW M8 X 16 X 1.25 1

LAY SHAFT - A5P09600 - ALGB114/15 205
 206

LAY SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F4904110 SPACER RING2.20mmTHK 2

2 1 F4904210 SPACER RING 2mm THICK 2

3 1 F4904310 SPACER RING 1.75mm THICK 2

4 1 F4904410 SPACER RING 1.7mm THICK 2

5 1 F4904510 SPACER RING 1.65mm THICK 2

6 1 F4904610 SPACER RING 1.6mm THICK 2

7 1 F4904710 SPACER RING 1.55mm THICK 2

8 1 F4904810 SPACER RING 1.5mm THICK 2

9 1 F4903310 SPACER RING 1.45mm THICK 2

10 1 F4903410 SPACER RING 1.4mm THICK 2

11 1 F4903510 SPACER RING 1.35mm THICK 2

12 2 F0736810 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.75 1

13 2 F0736910 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.7 1

14 2 F0738710 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.65 1

15 2 F0737010 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.6 1

16 2 F0738610 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.55 1

17 2 F0737110 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.5 1

LAY SHAFT - A5P09600 - ALGB114/15 207
 208

LAY SHAFT - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 2 F0737210 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.4 1

19 2 F0738510 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.45 1

20 2 F0704310 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.35 1

21 2 F0704410 SPECIAL CIRCLIP - EXTERNAL - 40 X 1.3 1

22 3 F0254210 TAPER ROLLER BEARING 1

23 4 F1668411 CONSTANT MESH GEAR ON LAYSHAFT 1

24 5 F1625411 OD GEAR ON LAYSHAFT 1

25 6 F1609211 GEAR ON LAYSHAFT 4TH 1

26 7 F1609011 GEAR ON LAYSHAFT 3RD 1

27 8 F3312711 LAYSHAFT 1

28 9 F0254510 TAPER ROLLER BEARING REAR 1

SELECTOR FORKS - A5P09600 - ALGB114/15 209
 210

SELECTOR FORKS - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B1545107 S/A OF SELECTOR FORK 1ST & 2ND 1

2 2 F3101710 SCREW 2

3 3 F3401031 SLIDING PAD 6

4 4 B1516601 S/A OF SELECTOR FORK 3RD & 4TH 1

5 5 F3101510 SCREW 4

6 6 F4903810 WAVY WASHER 6

7 7 B1547002 S/A OF SELECTOR FORK 5TH & OVERDRIVE 1

8 8 FF200114 OD SELECTOR PLATE 1

9 9 F2437514 SELECTOR PLATE 1

10 10 F2437614 SELECTOR PLATE 1ST & REVERSE 1

11 11 F3309911 REVERSE SELECTOR SHAFT 1

12 12 F2458611 REVERSE SELECTOR FORK 1

13 13 F0927915 ROLL PIN 1

14 14 F0928015 ROLL PIN 1

SELECTOR HOUSING - A5P09600 - ALGB114/15 211
 212

SELECTOR HOUSING - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F1805342 SELECTOR HOUSING 1

2 2 F1719100 GASKET - SELECTOR HOUSING 1

3 3 F1719200 GASKET 1

4 4 L1010814 BOLT 8

5 5 L1010810 BOLT 2

6 6 L4510800 WAVE WASHER 8 DIA 10

7 6 L4510800 WAVE WASHER 8 DIA 4

8 7 F3424315 BEARING BUSH 1

9 8 F2747200 OILSEAL 1

10 9 F2747300 SCRAPPER 1

11 10 F1102413 DUST CAP 1

12 11 F2419611 GEAR SHIFT LEVER 1

13 12 F3559615 BOLT 1

14 13 L4511000 WAVY WASHER 10 DIA 1

15 14 F3538010 NUT M10 DIN 934 10 1

16 15 F3424315 BEARING BUSH 1

17 16 F3351415 SELECTOR SHAFT 1

SELECTOR HOUSING - A5P09600 - ALGB114/15 213
 214

SELECTOR HOUSING - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 F4941710 WASHER 35 OD X 18.2 ID X 2 T 1

19 18 F3637610 COMPRESS SPRING 1

20 19 F3436915 SLEEVE 1

21 20 F0738810 CIRCLIP 1

22 21 F1719300 GASKET - SELECTOR HOUSING END 1

23 22 F1139013 COVER 1

24 24 L2010820 SCREW M8 X 20 X 1.25 4

25 25 F2421411 GEAR CHANGE FINGER 1

26 26 F2430712 LOCKING PIECE 1

27 27 F0928115 ROLL PIN 2

28 28 F0928215 ROLL PIN 2

29 29 B1582201 S/A OF DETENT PLUNGER 1

30 30 F4944010 TAB WASHER 1

31 31 F4206315 DETEND PLUNGER - 28.25 1

32 31 F4206415 DETEND PLUNGER - 28.4 1

33 31 F4206515 DETEND PLUNGER - 28.55 1

34 32 F3651310 SPRING 1
SELECTOR HOUSING - A5P09600 - ALGB114/15 215
 216

SELECTOR HOUSING - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 33 F4901140 SEALING RING 1

36 34 F3142515 PLUG 1

37 B1533103 S/A OF SELECTOR ARM 1 COMPRISES OF(SL.NOs.38,39)

38 35 F2431622 SELECTOR ARM 1

39 36 F0967215 PIN 1
GEAR SHIFT LINKAGE - A5P09600 - ALGB114/15 217
 218

GEAR SHIFT LINKAGE - A5P09600 - ALGB114/15

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B1558001 S/A OF CONNECTION FLANGE 1

2 2 L2011022 SCREW M10 X 22 X 1.5 2

3 3 F8319400 BALL JOINT ASSY RH 2

4 4 F3515610 NUT - HEX M18 X 1.5 EFP X 9 LONG X 0 2

5 6 L3021218 NUT M12 X PC 8 X 1.5 3

6 7 F1903615 REACTION TUBE 1

7 8 F3515710 NUT - HEX M18 X 1.5 EFP X 9 LONG X 0 1

8 9 F8319500 BALL JOINT ASSY LH 1

9 - L4111200 SC WASHER 12 DIA 3

10 10 F8406914 S/A OF SUPPORT BRACKET 1

11 - L4511000 WAVY WASHER 10 DIA 2

CHANGE SPEED OPERATION - A1E03400 - ALCSO185/1 219
 220

CHANGE SPEED OPERATION - A1E03400 - ALCSO185/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B1797503 S/A CSO BASE BRACKET 1

2 2 L2021030 SCREW M10 X 30 X 1 4

3 3 L4111000 SC WASHER 10 DIA 4

4 4 L3021018 NUT M10 X PC 8 X 1 4

5 B1797506 S/A OF GEAR SHIFT LEVER 1 COMPRISES OF(SL.NOs.6,7,8,9,10,11,32)

6 5 B1719102 GEAR SHIFT LEVER 1

7 6 F1837914 SEATING BLOCK 1

8 7 X1200260 DISTANCE PIECE 1

9 8 F0248710 SEALED DRAWN CUP 2

10 9 X4801460 KNOB SHIFT LEVER 1

11 10 F0969015 SPRING DOWEL 2

12 11 X7400150 SEALING BOOT 1

13 12 X3019810 SEALING PLATE - CSO 1

14 13 F1135650 GAITER - RUBBER 1

15 14 X3003110 COVER PLATE 1

16 15 L1020813 BOLT 4

17 16 L4010800 WASHER 8 DIA 8

CHANGE SPEED OPERATION - A1E03400 - ALCSO185/1 221
 222

CHANGE SPEED OPERATION - A1E03400 - ALCSO185/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 L3620818 NYLOC NUT 4

19 18 FC200613 PIN - GEAR SHIFT LEVER TO SHIFT ROD 1

20 19 F7D00611 CONNECTOR FLANGE 1

21 20 X4901810 WASHER - CSO PIN 2

22 21 L5013005 SPLIT - PIN 2

23 22 B1E03301 S/A OF CONTROL TUBE 1

24 23 L2010625 SCREW M6 X 25 X 1 CP 4

25 24 L4010600 WASHER 6 DIA 4

26 25 L3610618 NYLOC NUT 4

27 26 L2010835 SCREW M8 X 35 X 1.25 4

28 27 L4010800 WASHER 8 DIA 4

29 28 L3620818 NYLOC NUT 4

30 29 F4428110 SHIM 4

31 30 F2560010 GREASE NIPPLE 1

32 - FSP00168 EXTENSION PIECE 1

PROPELLER SHAFT - A6N10600 - ALPS377/3 223
 224

PROPELLER SHAFT - A6N10600 - ALPS377/3

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F3587811 BOLT 8

2 2 F3551911 NUT M10X1.5 8

3 - X3503310 NYLOC NUT 8

4 3 F8032114 BRKT - CENTRE BRG 1

5 4 L2011235 SCREW M12 X 35 X 1.75 2

6 5 F4953110 WASHER 2

7 6 F3552011 NUT M12X175 P/T (10GR) 2

8 7 F3504400 SCREW - C/B TO BRACKET 2

9 8 F4954210 WASHER 21 OD X 13 ID X 5 T 2

10 9 F3558510 LOCK NUT M12 - THIN. 2

11 10 FC702914 FIRST PROPELLER SHAFT 1

12 11 FC702514 SECOND PROPELLER SHAFT 1

13 LO FRONT PROPELLER SHAFT

14 12 P4500332 FLANGE YOKE 1

15 13 P4500451 UJ CROSS KIT 1

16 14 P4500432 TUBE YOKE 1

17 15 P4502533 MIDSHIP TUBE SHAFT 1

PROPELLER SHAFT - A6N10600 - ALPS377/3 225
 226

PROPELLER SHAFT - A6N10600 - ALPS377/3

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 P4501451 CENTRE BEARING KIT 1

19 17 P4500614 COMPANION FLANGE INTERMEDIATE 1

20 18 P4500835 NUT 1

21 LO REAR PROPELLER SHAFT

22 19 P4500332 FLANGE YOKE 2

23 20 P4500451 UJ CROSS KIT 2

24 21 P4501232 SLIP YOKE ASSEMBLY 1

25 22 P4500433 TUBE SHAFT 1

26 23 P4500432 TUBE YOKE 1

27 24 P4501932 FLANGE YOKE ASSY 1

28 25 F3507511 SPECIAL NUT - NYLOC 4

29 26 F3580110 BOLT 3/8 X 1 3/8 BSF 4

REAR AXLE - A6T45200 - ALBA226/19 227
 228

REAR AXLE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 A6T45200 BACK AXLE ASSY - DANA 60SHO-5.57RAR-1029 SS-1816 TR-1550 1

FLANGE

2 2 FD129500 CROWN WHEEL / PINION - HYPOID DRIVE-5.57 1

3 3 P4903439 DIFFERENTIAL CARRIER HEAD ASSEMBLY 1

4 4 FD167300 FD167300 - HALF AXLE ASSY 1

5 5 P4903239 DIFFERENTIAL CARRIER & CAPS ASSY 1

6 6 P4900109 COTTER PIN 2

7 7 P4900118 DIFF CASE FLANGED HALF 1

8 8 P4900302 FLANGED HALF BEARING CONE / CUP 1

9 9 P4900835 ADJUSTER BEARING DIFF (FLANGED HALF) 1

10 10 P4900635 BOLT 16

11 11 P4900535 PREVAILING TORQUE HEX NUT 16

12 12 P4900735 ADJUSTER BEARING DIFF (PLAIN HALF) 1

13 13 P4900202 PLAIN HALF BEARING CONE / CUP 1

14 14 P4900218 DIFF CASE PLAIN HALF 1

15 15 P4900349 WASHER THRUST GEAR SIDE DIFF 2

16 16 P8A00010 GEAR SIDE DIFF 2

17 17 P4900316 SPIDER DIFFERENTIAL 1

REAR AXLE - A6T45200 - ALBA226/19 229
 230

REAR AXLE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 18 PB400002 PINION SIDE DIFF 4

19 19 P4900249 WASHER THRUST PINION SIDE DIFF 4

20 20 P4901035 BOLT 12 POINT 12

21 21 P4900102 BEARING ROLLER CYLINDRICAL 1

22 22 P4900502 PINION INNER BEARING CONE / CUP 1

23 23 P4900112 SPACER BEARING - PINION 0.619 inch AR

24 23 P4900212 SPACER BEARING - PINION 0.620 inch AR

25 23 P4900312 SPACER BEARING - PINION 0.621 inch AR

26 23 P4900412 SPACER BEARING - PINION 0.622 inch AR

27 23 P4900512 SPACER BEARING - PINION 0.623 inch AR

28 23 P4904812 SPACER BEARING - PINION 0.624 inch AR

29 23 P4904912 SPACER BEARING - PINION 0.625 inch AR

30 23 P4905012 SPACER BEARING - PINION 0.626 inch AR

31 23 P4900912 SPACER BEARING - PINION 0.627 inch AR

32 23 P4901012 SPACER BEARING - PINION 0.628 inch AR

33 23 P4901112 SPACER BEARING - PINION 0.629 inch AR

34 23 P4901212 SPACER BEARING - PINION 0.630 inch AR

REAR AXLE - A6T45200 - ALBA226/19 231
 232

REAR AXLE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 23 P4901312 SPACER BEARING - PINION 0.631 inch AR

36 23 P4901412 SPACER BEARING - PINION 0.632 inch AR

37 23 P4901512 SPACER BEARING - PINION 0.633 inch AR

38 24 P4900144 SHIM - CAGE BRG AR

39 24 P4900244 SHIM CAGE BRG (0.020 inch) AR

40 24 P4900344 SHIM CAGE BRG (0.010 inch) AR

41 24 P4900444 SHIM CAGE BRG (0.005 inch) AR

42 24 P4900544 SHIM CAGE BRG (0.003 inch) AR

43 25 P4900518 PINION BEARING CAGE & CUPS ASSY 1

44 26 P4900402 PINION OUTER BEARING CONE / CUP 1

45 27 P4900127 PINION OIL SEAL 1

46 28 P4900311 SLINGER 1

47 29 P4900114 COMPANION FLANGE 1

48 30 P4900435 PINION END NUT 1

49 31 P4900335 HEX CAP SCREW (INPUT BEARING CAGE) 6

50 32 P4900135 THRUST SCREW 1

51 33 P4900235 JAM NUT 1

REAR AXLE - A6T45200 - ALBA226/19 233
 234

REAR AXLE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 LO SERVICE KITS

53 P4901051 DIFF CASE ASSY KIT 10TG 1 COMPRISES OF(SL.NOs.54,56,57,58,59,60,61,62,63)

54 7 CASE - DIFF FLANGED HALF 1 NSS

55 8 FLANGED HALF BEARING CONE / CUP 1 NSS

56 13 DIFF BEARING (27813 / 9803) 1 NSS

57 14 CASE - DIFF PLAIN HALF 1 NSS

58 15 WASHER 2 NSS

59 16 GEAR SIDE-DIFF. 2 NSS

60 17 SPIDER DIFFERENTIAL 1 NSS

61 18 PINION SIDE DIFF. 4 NSS

62 19 WASHER 4 NSS

63 20 SCREW 12 NSS

64 P4900551 DIFF SPIDER KIT 1 COMPRISES OF(SL.NOs.65,66,67,68,69)

65 15 WASHER 2 NSS

66 16 GEAR SIDE-DIFF. 2 NSS

67 17 SPIDER DIFFERENTIAL 1 NSS

68 18 PINION SIDE DIFF. 4 NSS

REAR AXLE - A6T45200 - ALBA226/19 235
 236

REAR AXLE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

69 19 WASHER 4 NSS

70 P4900151 PINION SPACER KIT 1 COMPRISES

OF(SL.NOs.71,72,73,74,75,76,77,78,79,80,81,82,83,84,85)

71 23 SPACER BEARING – PINION. ( 0.619“ ) AR NSS

72 23 SPACER BEARING – PINION. ( 0.620“ ) AR NSS

73 23 SPACER BEARING – PINION. ( 0.621“ ) AR NSS

74 23 SPACER BEARING – PINION. ( 0.622“ ) AR NSS

75 23 SPACER BEARING – PINION. ( 0.623“ ) AR NSS

76 23 SPACER BEARING – PINION. ( 0.624“ ) AR NSS

77 23 SPACER BEARING – PINION. ( 0.625“ ) AR NSS

78 23 SPACER BEARING – PINION. ( 0.626“ ) AR NSS

79 23 SPACER BEARING – PINION. ( 0.627“ ) AR NSS

80 23 SPACER BEARING – PINION. ( 0.628“ ) AR NSS

81 23 SPACER BEARING – PINION. ( 0.629“ ) AR NSS

82 23 SPACER BEARING – PINION. ( 0.630“ ) AR NSS

83 23 SPACER BEARING – PINION. ( 0.631“ ) AR NSS

84 23 SPACER BEARING – PINION. ( 0.632“ ) AR NSS

85 23 SPACER BEARING – PINION. ( 0.633“ ) AR NSS

REAR AXLE - A6T45200 - ALBA226/19 237
 238

REAR AXLE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

86 P4900251 PINION BEARING CAGE SHIM KIT 1 COMPRISES OF(SL.NOs.87,88,89,90,91)

87 24 PINION BEARING CAGE SHIM - 0.030"(0.8MM) AR NSS

88 24 PINION BEARING CAGE SHIM - 0.020"(0.5MM) AR NSS

89 24 PINION BEARING CAGE SHIM - 0.010"(0.25MM) AR NSS

90 24 PINION BEARING CAGE SHIM - 0.005"(0.13MM) AR NSS

91 24 PINION BEARING CAGE SHIM - 0.003"(0.08MM) AR NSS

92 P4900351 THRUST WASHER KIT 1 COMPRISES OF(SL.NOs.93,94)

93 15 WASHER THRUST GEAR SIDE DIFF 2 NSS

94 19 WASHER THRUST PINION SIDE DIFF 4 NSS

95 P4900651 GEAR HARDWARE KIT 1 COMPRISES OF(SL.NOs.96,97)

96 10 BOLT SPECIAL 16 NSS

97 11 PREVAILING - TORQUE HEX NUT 16 NSS

98 P4900751 THRUST SCREW & JAM NUT KIT 1 COMPRISES OF(SL.NOs.99,100)

99 32 THRUST SCREW 1 NSS

100 33 JAM NUT 1 NSS

101 P4901151 DIFFERENTIAL CASE KIT 1 COMPRISES OF(SL.NOs.102,103,104)

102 7 DIFF. CASE FLANGED HALF 1 NSS

REAR AXLE - A6T45200 - ALBA226/19 239
 240

REAR AXLE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

103 14 DIFF. CASE PLAIN HALF 1 NSS

104 20 HEX CAP SCREW 12 NSS

AXLE HOUSING - A6T45200 - ALBA226/19 241
 242

AXLE HOUSING - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 P4903418 AXLE HOUSING ASSY 1

2 2 P4900137 STUD 4

3 3 P4900649 WASHER 12

4 4 P4900117 HEX CAP SCREW 8

5 5 P4901235 HEX NUT 4

6 6 P4900133 AXLE SHAFT 2

7 LO SERVICE KIT

8 P4900851 CARRIER MOUNTING FASTENER KIT 1 COMPRISES OF(SL.NOs.9,10,11,12)

9 2 STUD 4 NSS

10 3 WASHER 12 NSS

11 4 HEX CAP SCREW 8 NSS

12 5 HEX NUT 4 NSS

HUB AND BRAKE - A6T45200 - ALBA226/19 243
 244

HUB AND BRAKE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B3043603 S/A OF HUB 2 COMPRISES OF(SL.NOs.2,3,4)

2 1 F1880222 REAR HUB - 8TG - 8WB 1

3 2 F3569410 WHEEL BOLT M22X2.5 8

4 3 F3732115 STUD 8

5 4 F0930115 PIVOT PIN 2

6 5 F1146514 OIL FLINGER 2

7 6 F1230022 DISTANCE PIECE 2

8 7 F1754700 JOINT 2

9 8 F1869022 BRAKE DRUM 2

10 9 F3141415 PLUG 2

11 10 F3530815 LOCKING BOLT 2

12 11 F3545011 AXLE TUBE NUT 2

13 12 F4430510 SHIM 0.003 inch AR

14 13 F4430610 SHIM 0.005 inch AR

15 13 F4430710 SHIM 0.010 inch AR

16 13 F4430910 SHIM 0.020 inch AR

17 13 F4431010 SHIM 0.040 inch AR

HUB AND BRAKE - A6T45200 - ALBA226/19 245
 246

HUB AND BRAKE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - F4919800 SPRING WASHER 1/2 inch DIA 36

19 - F7215414 ANCHOR BRACKET 2

20 14 F8895100 SPRING BRAKE ACTUATOR REAR LH 1

21 - P1022751 BRAKE CHAMBER REPAIR KIT 1

22 15 F8895200 SPRING BRAKE ACTUATOR REAR RH 1

23 - P1022751 BRAKE CHAMBER REPAIR KIT 1

24 - P9900239 DIAPHRAM 1

25 16 F9B00400 JOINT 2

26 17 L1050815 BOLT 1/2 X 1 7/8 BSF 20

27 18 L2010610 SET SCREW M6X1.0 16

28 19 L3050811 NUT 1/2 X PCP BSF 16

29 20 L3350511 CASTLE - NUT 3/8 X PCP BSF 2

30 - L3610818 NYLOC NUT 2

31 21 L3650611 NYLOC NUT 2

32 22 L3850811 CLEVELOC NUT 1/2 X PCP BSF 20

33 - L4010800 WASHER 8 DIA 2

34 23 L4110600 SC WASHER 6 DIA 16

HUB AND BRAKE - A6T45200 - ALBA226/19 247
 248

HUB AND BRAKE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 24 L5000406 SPLIT - PIN 1/16 DIA X 5/8 inch 2

36 - F0214310 TAPPER ROLLER BEARING 1 ALT, F0230110, F0271610

37 - F0701122 RING FOR OIL SEAL - INNER 1

38 25 F0701222 RING FOR OIL SEAL OUTER 1

39 - F2702000 OIL SEAL 1

40 - F4932540 WASHER FOR PLUG [BA] 1

41 26 F4937030 WASHER 16 OD X 10.5 ID X 2 T 1

42 27 F8377800 AUTOMATIC SLACK ADJUSTER 1 MEI

43 - P2601616 PINION ASSEMBLY 1

44 - P2603218 BODY 1

45 - P2616151 MINOR REPAIR KIT 1

46 - P2616251 MAJOR REPAIR KIT 1

47 27 F8821500 AUTOMATIC SLACK ADJUSTER 1 SABA

48 - P2616051 REPAIR KIT MAJOR FOR SLACK ADJUSTER 1

49 - P2616351 MAJOR KIT 1

50 - P2616451 MINOR KIT 1

51 - X8840900 AUTOMATIC SLACK ADJUSTER 1

HUB AND BRAKE - A6T45200 - ALBA226/19 249
 250

HUB AND BRAKE - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 28 F3P25700 BRAKE ASSY - RLH 1

53 28 F8859600 BRAKE ASSY REAR - LH 1 MERITOR

54 29 F3P25800 BRAKE ASSY - RRH 1

55 29 F8859700 BRAKE ASSY REAR - RH 1 MERITOR

56 - FA602400 OIL SEAL 100X130X12 1

57 - FD900611 RING FOR OIL SEAL OUTER 1

58 - F0214410 TAPER ROLLER BEARING 2

REAR BRAKE - INTERNAL COMPONENTS - BIL - A6T45200 - ALBA226/19 251
 252

REAR BRAKE - INTERNAL COMPONENTS - BIL - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F3P25700 BRAKE ASSY - RLH 1

2 1 F3P25800 BRAKE ASSY - RRH 1

3 P9900190 TORQUE PLATE ASSEMBLY - RLH/RRH 2 COMPRISES OF(SL.NOs.4,9,10)

4 1.1 TORQUE PLATE ASSY-RLH/RRH 2 NSS

5 2 P1601633 CAM SHAFT RLH 1

6 2 P1601733 CAM SHAFT RRH 1

7 3 P5J00129 DUST COVER LH 2

8 4 P5J00130 DUST COVER RH 2

9 5 P1601605 BUSH METAL 4

10 6 P1601205 BUSH ABUTMENT 4

11 7 P1600227 O-RING 4

12 8 P1601343 ROLLER 4

13 9 P1601605 BUSH METAL 2

14 10 P1602736 SPRING - ABUTMENT END 4

15 11 P8E00004 GROMMET 4

16 12 P1602409 FULCRUM PIN 4

17 13 P1620239 LINED SHOE ASSY 4

REAR BRAKE - INTERNAL COMPONENTS - BIL - A6T45200 - ALBA226/19 253
 254

REAR BRAKE - INTERNAL COMPONENTS - BIL - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 PTX00001 TUBE - FLANGE & BRACKET ASSEMBLY-RLH 1 COMPRISES OF(SL.NOs.19,20,21,22)

19 14 BRACKET ASSEMBLY-RLH 1 NSS

20 5 BUSH 4 NSS

21 15 GREASE NIPPLE 1 NSS

22 16 RELIEF VALVE 1 NSS

23 PTX00002 TUBE - FLANGE & BRACKET ASSEMBLY-RRH 1 COMPRISES OF(SL.NOs.24,25,26,27)

24 14 BRACKET ASSEMBLY-RRH 1 NSS

25 5 BUSH 4 NSS

26 15 GREASE NIPPLE 1 NSS

27 16 RELIEF VALVE 1 NSS

28 17 CIRCLIP 1 NSS

29 18 WASHER 1 NSS

30 19 SHIM 0.5 MM 1 NSS

31 20 SHIM 1 MM 2 NSS

32 21 P1601134 SLEEVE - DELRIN 2

33 P1609551 BUSH KIT 2 COMPRISES OF(SL.NOs.34,35,36,37,38,39,40,41,42,43,44)

34 5 P1601605 BUSH METAL 2

REAR BRAKE - INTERNAL COMPONENTS - BIL - A6T45200 - ALBA226/19 255
 256

REAR BRAKE - INTERNAL COMPONENTS - BIL - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 6 P1601205 BUSH ABUTMENT 2

36 7 P1600227 O-RING 2

37 9 P1601605 BUSH METAL 1

38 10 P1602736 SPRING - ABUTMENT END 2

39 15 GREASE NIPPLE 1 NSS

40 16 RELIEF VALVE 1 NSS

41 17 CIRCLIP 1 NSS

42 18 WASHER 1 NSS

43 19 SHIM 0.5 MM 1 NSS

44 20 SHIM 1 MM 2 NSS

45 P3616751 KIT LINING SET (STD) 1 COMPRISES OF(SL.NOs.46,47)

46 - LINING 8 NSS

47 - RIVET 80 NSS

48 P3616851 KIT LINING SET I / OS 1 COMPRISES OF(SL.NOs.49,50)

49 - LINING 8 NSS

50 - RIVET 80 NSS

51 P3616951 KIT LINING SET II / OS 1 COMPRISES OF(SL.NOs.52,53)

REAR BRAKE - INTERNAL COMPONENTS - BIL - A6T45200 - ALBA226/19 257
 258

REAR BRAKE - INTERNAL COMPONENTS - BIL - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 - LINING 8 NSS

53 - RIVET 80 NSS
REAR BRAKE - INTERNAL COMPONENTS - AAL - A6T45200 - ALBA226/19 259
 260

REAR BRAKE - INTERNAL COMPONENTS - AAL - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F8859600 BRAKE ASSY REAR - LH 1

2 1 F8859700 BRAKE ASSY REAR - RH 1

3 1.1 P4319939 BRAKE SHOE 2

4 2 P4320139 BRAKE SHOE LINING ASSY 2

5 3 SPRING - BRK SHOE RETAINING 4 NSS

6 4 P4300105 BUSHING - ANCHOR PIN 4

7 5 P4300509 ANCHOR PIN - BRAKE SHOE 4

8 6 P4302043 CAMSHAFT - RH 1

9 6 P4302143 CAMSHAFT - LH 1

10 7 WASHER-CAM HEAD 2 NSS

11 8 SEAL-CAM SHAFT 4 NSS

12 9 P4300505 BUSHING CAMSHAFT 4

13 10 PIN-RETURN SPRING 4 NSS

14 11 P4302243 ROLLER - BRAKE SHOE 4

15 12 RETURNSPRING-BRAKE SHOE 2 NSS

16 13 P4309316 SPIDER - BRAKE 2

17 13 P4305416 SPIDER ASSY(WITH BUSHES & SEAL) 2

REAR BRAKE - INTERNAL COMPONENTS - AAL - A6T45200 - ALBA226/19 261
 262

REAR BRAKE - INTERNAL COMPONENTS - AAL - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 14 P4300417 GASKET CHAMB. BRACKET 2

19 15 P4304004 BRACKET ASSY CAM SHAFT LH 1

20 15 P4304104 BRACKET ASSY CAMSHAFT RH 1

21 16 WASHER-BRACKET ASSY 8 NSS

22 17 CAP SCREW-BRACKET ASSY 8 NSS

23 18 P4300229 GREASE NIPPLE - CHAMBER BRACKET 2

24 19 WASHER (2.5 MM) 2 NSS

25 20 WASHER (2.5 MM) 2 NSS

26 21 WASHER (1.4 MM) 2 NSS

27 22 LOCK RING-CAMSHAFT 2 NSS

28 23 P4301111 DUST SHIELD (TOP - RH. BOTTOM - LH) 2

29 24 P4301211 DUST SHIELD (TOP - LH. BOTTOM - RH) 2

30 25 WASHER-DUST SHIELD 12 NSS

31 26 CAP SCREW-DUST SHIELD 12 NSS

32 27 P4301631 PLUG - DUST SHIELD 4

33 28 RIVETS 80 NSS

34 29 BRAKE LINING (CAM & ANCHOR END) 4 NSS

REAR BRAKE - INTERNAL COMPONENTS - AAL - A6T45200 - ALBA226/19 263
 264

REAR BRAKE - INTERNAL COMPONENTS - AAL - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 LO SERVICE KITS

36 P4317051 BRAKE MINOR O/H KIT - REAR 1 COMPRISES OF(SL.NOs.37,38,39,40,41)

37 28 RIVET 80 NSS

38 29 BRAKE LINING (CAM & ANCHOR END) 4 NSS

39 11 ROLLER - BRAKE SHOE 4 NSS

40 3 SPRING ANCHOR 4 NSS

41 12 SPRING -SHOE RETURN- EBL 2 NSS

42 P4316451 BRAKE MINOR SERVICE KIT - REAR 1 COMPRISES OF(SL.NOs.43,44,45,46)

43 10 PIN-BRK,SPRING 2 NSS

44 11 ROLLER - BRAKE SHOE 4 NSS

45 3 SPRING ANCHOR 4 NSS

46 12 SPRING -SHOE RETURN- EBL 2 NSS

47 P4316551 HLP BRK SPRING KIT 1 COMPRISES OF(SL.NOs.48,49)

48 3 SPRING ANCHOR 4 NSS

49 12 SPRING -SHOE RETURN- EBL 2 NSS

50 P4308651 BRAKE CAMSHAFT REPAIR KIT 1 COMPRISES OF(SL.NOs.51,52,53)

51 9 BUSHING CAMSHAFT 4 NSS

REAR BRAKE - INTERNAL COMPONENTS - AAL - A6T45200 - ALBA226/19 265
 266

REAR BRAKE - INTERNAL COMPONENTS - AAL - A6T45200 - ALBA226/19

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 22 CIRCLIP 2 NSS

53 8 SEALASSY. 4 NSS

54 P4317151 BRAKE LINERS KIT 1 COMPRISES OF(SL.NOs.55,56)

55 28 RIVET 80 NSS

56 29 BRAKE LINING (CAM & ANCHOR END) 4 NSS

57 P4309351 DUST SHIELD MOUNTING FASTENERS KIT 1 COMPRISES OF(SL.NOs.58,59)

58 26 CAP SCREW 6 NSS

59 25 SPRING WASHER 6 NSS

60 P4309551 REAR BRKT MOUNTING FASTENERS KIT 1 COMPRISES OF(SL.NOs.61,62)

61 17 CAP SCREW 4 NSS

62 16 SPRING WASHER 4 NSS

63 P4309651 REAR CAMSHAFT WASHERS KIT 1 COMPRISES OF(SL.NOs.64,65,66,67,68)

64 7 CAM HEAD WASHER 1 NSS

65 22 CIRCLIP 1 NSS

66 19 WASHER 1 NSS

67 20 WASHER 1 NSS

68 21 WASHER 1 NSS
FRONT AXLE - A5C18800 - ALFA90/64 267
 268

FRONT AXLE - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F2421511 STEERING LEVER 1

2 2 F0200111 THRUSTPAD FOR KINGPIN 1

3 3 F2754200 OILSEAL - HUB 2

4 4 F5G01215 COTTER PIN 2

5 5 L3821218 CLEVELOC NUT M12 X PC 8 X 1.5 12

6 6 L4110800 SC WASHER 8 DIA 12

7 7 FD900322 RING FOR OIL SEAL 2

8 8 F0P02900 THRUST BEARING 1

9 9 F8858600 FRONT BRAKE ASSY - LH 1

10 9 F8858700 FRONT BRAKE ASSY - RH 1

11 10 FXC03514 SHIM - 2.05 mm THICK 1

12 10 FXC03614 SHIM - 2.09 mm THICK 1

13 10 FXC03714 SHIM - 2.13 mm THICK 1

14 10 FXC03814 SHIM - 2.17 mm THICK 1

15 10 FXC03914 SHIM - 2.21 mm THICK 1

16 10 FXC04014 SHIM - 2.25 mm THICK 1

17 10 FXC04114 SHIM - 2.29 mm THICK 1

FRONT AXLE - A5C18800 - ALFA90/64 269
 270

FRONT AXLE - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 10 FXC04214 SHIM - 2.33 mm THICK 1

19 10 FXC04314 SHIM - 2.37 mm THICK 1

20 10 FXC04414 SHIM - 2.41 mm THICK 1

21 10 FXC04514 SHIM - 2.45 mm THICK 1

22 10 FXC04614 SHIM - 2.49 mm THICK 1

23 10 FXC04714 SHIM - 2.53 mm THICK 1

24 10 FXC04814 SHIM - 2.57 mm THICK 1

25 10 FXC04914 SHIM - 2.61 mm THICK 1

26 10 FXC05014 SHIM - 2.65 mm THICK 1

27 10 FXC05114 SHIM - 2.69 mm THICK 1

28 10 FXC05214 SHIM - 2.73 mm THICK 1

29 10 FXC05314 SHIM - 2.77 mm THICK 1

30 10 FXC05414 SHIM - 2.81 mm THICK 1

31 10 FXC05514 SHIM - 2.85 mm THICK 1

32 10 FXC05614 SHIM - 2.89 mm THICK 1

33 10 FXC05714 SHIM - 2.93 mm THICK 1

34 10 FXC05814 SHIM - 2.97 mm THICK 1

FRONT AXLE - A5C18800 - ALFA90/64 271
 272

FRONT AXLE - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 10 FXC05914 SHIM - 3.01 mm THICK 1

36 10 FXC06014 SHIM - 3.05 mm THICK 1

37 11 F3525310 SCREW - HEX 2

38 12 F3507811 SPECIAL BOLT 6

39 13 F0930115 PIVOT PIN 2

40 14 L4010800 WASHER 8 DIA 2

41 B2534201 S/A OF AXLE ARM 2 COMPRISES OF(SL.NOs.42,43,44)

42 15 F0500342 BUSH-KINGPIN - STD. 2

43 16 F2717400 OIL SEAL KING PIN 2

44 17 F3221311 AXLE ARM 1

45 18 L4110600 SC WASHER 6 DIA 12

46 19 F8377800 AUTOMATIC SLACK ADJUSTER 1

47 19 F8821500 AUTOMATIC SLACK ADJUSTER 1

48 20 L3650611 NYLOC NUT 2

49 21 F2500410 GREASE NIPPLE(M8X1) 90DEG WITH LOCK NUT 4

50 22 L5001220 SPLIT - PIN 3/16 DIA X 2 1/2 inch 2

51 23 L2010820 SCREW M8 X 20 X 1.25 12

FRONT AXLE - A5C18800 - ALFA90/64 273
 274

FRONT AXLE - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 24 L2010815 SCREW M8 X 15 X 1.25 4

53 25 F1R00113 ANCHOR BRACKET 2

54 26 F2417411 TRACK RODLEVER - LH 1

55 26 F2417511 TRACKROD LEVER - RH 1

56 27 F1875722 BRAKE DRUM 2

57 28 F1721500 JOINT FOR HUB CAP 2

58 29 F8894900 BRAKE CHAMBER - LH 1

59 29 F8895000 BRAKE CHAMBER - RH 1

60 - P1019851 BRAKE CHAMBER REPAIR KIT 1

61 - P1022551 REPAIR KIT BRAKE CHAMBER 2

62 30 F4916010 WASHER 20 OD X 8.5 ID X 2 T 4

63 31 F1769600 JOINT COVER PLATE 4

64 32 L2050806 SCREW 1/2 X 3/4 BSF 2

65 33 L2010615 SCREW M6 X 15 X 1 CP 12

66 34 F1117914 COVER PLATE 4

67 35 F3251311 FRONT AXLE BEAM 1

68 36 L4111200 SC WASHER 12 DIA 12

FRONT AXLE - A5C18800 - ALFA90/64 275
 276

FRONT AXLE - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

69 37 F1141913 HUB CAP 2

70 38 F8397200 TRACK ROD ASSY 1

71 - P2617051 MINOR REPAIR KIT 1

72 - P2616951 MAJOR REPAIR KIT 1

73 - P2633339 TRACK ROD END ASSY-RH 1

74 - P2633439 TRACK ROD END ASSY-LH 1

75 39 F0200111 THRUSTPAD FOR KINGPIN 1

76 40 F3507615 SPECIAL NUT - NYLOC 2

77 41 F5Z01022 DISTANCE PIECE - 35.88mm LENGTH 2

78 41 F5Z00422 DISTANCE PIECE - 35.64mm LENGTH 1

79 41 F5Z00822 DISTANCE PIECE - 35.8mm LENGTH 1

80 41 F5Z00622 DISTANCE PIECE - 35.72mm LENGTH 1

81 41 F5Z01122 DISTANCE PIECE - 35.92mm LENGTH 1

82 41 F5Z00922 DISTANCE PIECE - 35.84mm LENGTH 1

83 41 F5Z00722 DISTANCE PIECE - 35.76mm LENGTH 1

84 41 F5Z00322 DISTANCE PIECE - 35.6mm 1

85 41 F5Z00522 DISTANCE PIECE - 35.68mm LENGTH 1

FRONT AXLE - A5C18800 - ALFA90/64 277
 278

FRONT AXLE - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

86 41 F5Z01522 DISTANCE PIECE - 36.08mm LENGTH 1

87 41 F5Z01322 DISTANCE PIECE - 36mm LENGTH 1

88 41 F5Z01622 DISTANCE PIECE - 36.12mm LENGTH 1

89 41 F5Z01822 DISTANCE PIECE - 36.2mm LENGTH 1

90 41 F5Z01222 DISTANCE PIECE - 35.96mm LENGTH 1

91 41 F5Z01422 DISTANCE PIECE - 36.04mm LENGTH 1

92 41 F5Z01722 DISTANCE PIECE - 36.16mm LENGTH 1

93 42 F4913010 WASHER 2

94 43 F0P02610 FRONT AXLE TAPER ROLLER BEARING - OUTER 2

95 - L3050811 NUT 1/2 X PCP BSF 2

96 44 F0P02710 FRONT AXLE TAPER ROLLER BEARING - INNER 2

97 45 F3569310 WHEEL BOLT M22X2.5 16

98 46 F4906510 WASHER 27 OD X 10.319 ID X 3.175 T 4

99 47 F5G01015 COTTER PIN TOP 2

100 48 L3621018 NYLOC NUT 4

101 49 F1884022 FRONT HUB 8 WHEEL BOLT 2

102 50 F0993715 KING PIN - STD 2

FRONT AXLE - A5C18800 - ALFA90/64 279
 280

FRONT AXLE - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

103 - L3610818 NYLOC NUT 2

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64 281
 282

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 P4319839 BRAKE SHOE 4

2 2 P4322039 LINED SHOE ASSY 4

3 3 SPRING - BRK SHOE RETAINING 4 NSS

4 4 P4300105 BUSHING - ANCHOR PIN 4

5 5 P4300509 ANCHOR PIN - BRAKE SHOE 4

6 6 P4301843 CAMSHAFT RH 1

7 6 P4301943 CAMSHAFT LH 1

8 7 WASHER-CAM HEAD 1 NSS

9 8 SEAL-CAM SHAFT 2 NSS

10 9 P4300505 BUSHING CAMSHAFT 4

11 10 PIN-RETURN SPRING 4 NSS

12 11 P4302243 ROLLER - BRAKE SHOE 4

13 12 RETURNSPRING-BRAKE SHOE 2 NSS

14 13 SPIDER ASSY 1 NSS

15 14 P4300417 GASKET CHAMB. BRACKET 1

16 15 P4303104 BRACKET ASSY - LH 1

17 15 P4303204 BRACKET ASSY - RH 1

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64 283
 284

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 WASHER-BRACKET ASSY 4 NSS

19 17 CAP SCREW-BRACKET ASSY 4 NSS

20 18 WASHER (2.5 mm) 1 NSS

21 18 WASHER (2.5 mm) 1 NSS

22 19 WASHER (1.4 mm) 1 NSS

23 20 LOCK RING-CAMSHAFT 1 NSS

24 21 SLINGER OIL 1 NSS

25 22 P4302911 DUST SHIELD (TOP - RH. BOTTOM - LH) 1

26 23 P4303011 DUST SHIELD (TOP - LH. BOTTOM - RH) 1

27 24 WASHER-DUST SHIELD 6 NSS

28 25 CAP SCREW-DUST SHIELD 6 NSS

29 26 P4301631 PLUG - DUST SHIELD 2

30 27 RIVETS 40 NSS

31 28 BRAKE LINING (CAM END) 6''HLP 2 NSS

32 29 BRAKE LINING (ANCHOR END)6''HLP 2 NSS

33 30 P4314235 BOLT 6

34 31 F8858600 FRONT BRAKE ASSY - LH 1

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64 285
 286

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 31 F8858700 FRONT BRAKE ASSY - RH 1

36 32 P4300329 FITTING GREASE 1

37 LO SERVICE KITS

38 P4318951 BRAKE MINOR OVERHAUL KIT 1 COMPRISES OF(SL.NOs.39,40,41,42,43,44)

39 3 SPRING ANCHOR 4 NSS

40 11 ROLLER 4 NSS

41 12 SPRING -SHOE RETURN- EBL 2 NSS

42 27 RIVET 80 NSS

43 28 LINING-BRAKE, CAM END- RAF-7 4 NSS

44 29 LINING-BRAKE, ANCHOR END- RAF-7 4 NSS

45 P4316451 BRAKE MINOR SERVICE KIT - REAR 1 COMPRISES OF(SL.NOs.46,47,48,49)

46 3 SPRING ANCHOR 4 NSS

47 10 PIN-BRK,SPRING 2 NSS

48 11 ROLLER 4 NSS

49 12 SPRING -SHOE RETURN- EBL 2 NSS

50 P4316551 HLP BRK SPRING KIT 1 COMPRISES OF(SL.NOs.51,52)

51 3 SPRING ANCHOR 4 NSS

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64 287
 288

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 12 SPRING -SHOE RETURN- EBL 2 NSS

53 P4308651 BRAKE CAMSHAFT REPAIR KIT 1 COMPRISES OF(SL.NOs.54,55,56)

54 8 SEALASSY. 4 NSS

55 9 BUSHING CAMSHAFT 4 NSS

56 19 CIRCLIP 2 NSS

57 P4318851 BRAKE LINING KIT 1 COMPRISES OF(SL.NOs.58,59,60)

58 27 RIVET 80 NSS

59 28 LINING-BRAKE, CAM END- RAF-7 4 NSS

60 29 LINING-BRAKE, ANCHOR END- RAF-7 4 NSS

61 P4309351 DUST SHIELD MOUNTING FASTENERS KIT 1 COMPRISES OF(SL.NOs.62,63)

62 24 SPRING WASHER 6 NSS

63 25 CAP SCREW 6 NSS

64 P4309151 BRACKET MOUNTING FASTENERS KIT 1 COMPRISES OF(SL.NOs.65,66)

65 16 SPRING WASHER 4 NSS

66 17 CAP SCREW 4 NSS

67 P4309651 REAR CAMSHAFT WASHERS KIT 1 COMPRISES OF(SL.NOs.68,69,70,71,72)

68 7 CAM HEAD WASHER 2 NSS

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64 289
 290

FRONT BRAKE - INTERNAL COMPONENTS - AAL - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

69 18 WASHER 2 NSS

70 18 WASHER 2 NSS

71 19 WASHER 2 NSS

72 20 CIRCLIP 2 NSS
TRACK ROD - A5C18800 - ALFA90/64 291
 292

TRACK ROD - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F8397200 TRACK ROD ASSY 1

2 2 HOUSING - RH 1 NSS

3 3 BALL PIN - RH 1 NSS

4 4 BOTTOM CUP - RH 1 NSS

5 5 TOP CUP - RH 1 NSS

6 6 SPRING - RH 1 NSS

7 7 LOCKING RING - RH 1 NSS

8 8 DUST COVER - RH 1 NSS

9 9 SLOTTED NUT - RH 1 NSS

10 10 GREASE NIPPLE - RH 1 NSS

11 11 SEALING CAP - RH 1 NSS

12 12 TUBE 1 NSS

13 13 CLAMP 1 NSS

14 14 HEX BOLT 1 NSS

15 15 HEX NUT 1 NSS

16 16 SPRING WASHER 1 NSS

17 - PROTECTION CAP 1 NSS

TRACK ROD - A5C18800 - ALFA90/64 293
 294

TRACK ROD - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - PROTECTION CAP(GREASE NIPPLE) 1 NSS

19 17 HOUSING - LH 1 NSS

20 18 BALL PIN - LH 1 NSS

21 19 BOTTOM CUP - LH 1 NSS

22 20 TOP CUP - LH 1 NSS

23 21 SPRING - LH 1 NSS

24 22 LOCKING RING - LH 1 NSS

25 23 DUST COVER - LH 1 NSS

26 24 SLOTTED NUT 1 NSS

27 25 GREASE NIPPLE 1 NSS

28 26 SEALING CAP 1 NSS

29 - TUBE 1 NSS

30 27 CLAMP 1 NSS

31 28 HEX BOLT 1 NSS

32 29 HEX NUT 1 NSS

33 30 SPRING WASHER 1 NSS

34 - PROTECTION CAP 1 NSS

TRACK ROD - A5C18800 - ALFA90/64 295
 296

TRACK ROD - A5C18800 - ALFA90/64

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 - PROTECTION CAP(GREASE NIPPLE) 1 NSS

36 P2633339 TRACK ROD END ASSY-RH 1 COMPRISES OF(SL.NOs.2,3,4,5,6,7,8,9,10,11,13,14,15,16,17,18)

37 P2633439 TRACK ROD END ASSY-LH 1 COMPRISES

OF(SL.NOs.19,20,21,22,23,24,25,26,27,28,29,30,31,32,33,34,35)

38 P2617051 MINOR REPAIR KIT 1 COMPRISES OF(SL.NOs.3,4,5,20,21,22)

39 P2616951 MAJOR REPAIR KIT 1 COMPRISES OF(SL.NOs.3,4,5,6,7,8,20,21,22,23,24,25)

FRAME - A5B09000 - ALF497 297
 298

FRAME - A5B09000 - ALF497

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 A5B09000 FRAME ASSEMBLY 1

2 B5B09001 S/A FSM LH 1 COMPRISES OF(SL.NOs.3,4)

3 2 F7S15313 FRAME SIDE MEMBER LH 1

4 3 F8971514 Bracket - Cab 1

5 4 L2021650 SCREW M16 X 50 X 1.75 FP PLATED 1

6 5 L3621618 NYLOC NUT 1

7 6 L4011600 WASHER 16 DIA 1

8 7 F3589511 BOLT 2

9 8 X3503410 NUT 2

10 B5B09002 S/A FSM RH 1 COMPRISES OF(SL.NOs.11,12)

11 9 F7S15413 FRAME SIDE MEMBER RH 1

12 10 F8971614 Bracket - Cab 1

13 11 L2021650 SCREW M16 X 50 X 1.75 FP PLATED 1

14 12 L3621618 NYLOC NUT 1

15 13 L4011600 WASHER 16 DIA 1

16 15 X3503410 NUT 2

17 16 F1J01214 SUPPORT BRACKET - FSM 2

FRAME - A5B09000 - ALF497 299
 300

FRAME - A5B09000 - ALF497

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 F3588311 SCREW 6

19 18 F3588211 BOLT 4

20 19 F7900413 CROSS MEMBER INNER - FRT 1

21 20 F0988415 PIN ASSEMBLY - FRONT TOWING 1

22 - X0901710 CLIP 1

23 - F3588311 SCREW 12

24 - F3552011 NUT M12X175 P/T (10GR) 12

25 - F2707450 RING TOW PIN 1

26 21 B8166301 S/A ENGINE MOUNTING FRONT CROSS MEMBER 1

27 22 B0213702 S/A OF SUPPORT BRKT - LH 1

28 23 B0213701 S/A OF ENG. SUPPORT BRACKET FRONT - RH 1

29 24 L2011030 SCREW M10 X 30 X 1.5 8

30 25 L4011000 WASHER 10 DIA 8

31 26 L3011018 NUT M10 X PC 8 X 1.5 8

32 27 F3588311 SCREW 8

33 28 X3503410 NUT 8

34 29 F4956810 WASHER 23 OD X 12.1 ID X 2.5 T 8

FRAME - A5B09000 - ALF497 301
 302

FRAME - A5B09000 - ALF497

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 30 X0402822 FRONT SPRING FRONT BRKT 2

36 31 F3591811 BOLT 10

37 32 F3552011 NUT M12X175 P/T (10GR) 10

38 33 F4956810 WASHER 23 OD X 12.1 ID X 2.5 T 10

39 34 X7110613 REINF FRONT BUMP STOP 2

40 35 F4953910 WASHER 2

41 36 X0402522 FRONT SPRING REAR BRKT 2

42 - F3591811 BOLT 6

43 37 F3589711 SCREW - HEX M12 X 1.75 CP X 40 LONG X GR 10.9 4

44 38 F4956810 WASHER 23 OD X 12.1 ID X 2.5 T 10

45 39 F3552011 NUT M12X175 P/T (10GR) 10

46 40 F7901513 PLATE - FSM - REINF.LHS 1

47 41 F7901413 PLATE - FSM - REINF.RHS 1

48 42 X3503410 NUT 4

49 45 F3552011 NUT M12X175 P/T (10GR) 6

50 46 L3010518 NUT M5 X PC 8 X 0.8 6

51 47 L4110500 SC WASHER 5 DIA 6

FRAME - A5B09000 - ALF497 303
 304

FRAME - A5B09000 - ALF497

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 48 L4010500 WASHER 5 DIA 6

53 48 L4010500 WASHER 5 DIA 2

54 49 F3589511 BOLT 4

55 50 X7900713 REAR CLOSING MEMBER 1

56 51 F3551911 NUT M10X1.5 2

57 52 MANUFACTURE PLATE 1 NSS

58 53 F7874640 POP RIVET 4

59 54 X0503815 BUSH 4

60 55 F8733314 TUBULAR CROSS MEMBER 1

61 56 F8508714 Box Flitch 1

62 56 F8508714 Box Flitch 1

63 57 F3508011 BOLT - HEX M10 X 1.5 CP X 120 LONG X GR 10.9 8

64 58 X3503310 NYLOC NUT 6

65 59 F4953010 WASHER - BATTERY CLAMP 18

66 60 L2011035 SCREW M10 X 35 X 1.5 4

67 61 L4111000 SC WASHER 10 DIA 6

68 62 F3510710 PLAIN NUT M12 12

FRAME - A5B09000 - ALF497 305
 306

FRAME - A5B09000 - ALF497

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

69 64 F3593511 BOLT 4

70 - F3562810 NUT - HEX M14 X 2 CP X 12 LONG X GR 10 4

71 - F3589711 SCREW - HEX M12 X 1.75 CP X 40 LONG X GR 10.9 12

72 - F3510810 NUT - HEX M12 X 1.75 CP X 10 LONG X GR 10 12

73 - X4900810 HARDENED WASHER 12DIA 12

74 63 L6010520 PHILIPS PAN SC M5 X 20 6

75 64 F3591811 BOLT 8

76 65 FD300122 Rear Spring Bracket 4

77 66 FA800114 Packing Plate for Rear Spring bracket 4

78 67 F3589711 SCREW - HEX M12 X 1.75 CP X 40 LONG X GR 10.9 4

79 68 F3510710 PLAIN NUT M12 4

80 69 X4900810 HARDENED WASHER 12DIA 4

81 - F3589411 SCREW - BATTERY CABLE 8

82 - F3551911 NUT M10X1.5 8

83 - X3532611 BOLT 8

84 - F3517810 SPECIAL BOLT 8

85 - F4956910 WASHER 25 OD X 15 ID X 3 T 8
FRAME - A5B09000 - ALF497 307
 308

FRAME - A5B09000 - ALF497

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

86 - X4904310 CONICAL WASHER 8

87 70 FC101143 AL - HINDUJA NAME PLATE 1

88 71 F3591811 BOLT 10

89 - X4900810 HARDENED WASHER 12DIA 10

90 72 X3532611 BOLT 8

91 - F3517810 SPECIAL BOLT 8

92 73 F4956910 WASHER 25 OD X 15 ID X 3 T 8

93 74 X4904310 CONICAL WASHER 8

94 75 F3510810 NUT - HEX M12 X 1.75 CP X 10 LONG X GR 10 10

95 76 F7115022 BRKT HELPER SPRING 2

96 77 F7115122 HELPER SPRING BRKT 2

97 78 F3591811 BOLT 16

98 79 X3503410 NUT 16

99 80 F4956810 WASHER 23 OD X 12.1 ID X 2.5 T 16

100 81 F7900913 BUMP STOP REINF 2

101 82 F2637700 RUBBER BUFFER 2

102 - L3011218 NUT M12 X PC 8 X 1.75 2

FRAME - A5B09000 - ALF497 309
 310

FRAME - A5B09000 - ALF497

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

103 83 F3589511 BOLT 10

104 84 X3503410 NUT 10

105 85 F3588311 SCREW 4

106 86 F4953910 WASHER 4

107 87 X3503410 NUT 4

108 - X7904913 INTERMEDIATE X MBR 1

109 - L2011040 SCREW M10 X 40 X 1.5 4

110 - B5B09903 REAR SPRING FRONT CROSS MEMBER 1

111 - B5B09904 REAR SPRING REAR CROSS MEMBER 1

BATTERY CARRIER - A6304800 - HABTB22 311
 312

BATTERY CARRIER - A6304800 - HABTB22

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B6304801 BATTERY CARRIER 1

2 2 B6304802 SUB ASSY OF BATTERY CLAMP 1

3 3 L2011030 SCREW M10 X 30 X 1.5 2

4 4 L3611018 NYLOC NUT 2

5 5 L1011209 BOLT 4
SPARE WHEEL CARRIER - A0912700 - ALSWC27/1 313
 314

SPARE WHEEL CARRIER - A0912700 - ALSWC27/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B0912701 S/A OF SPARE WHEEL CARRIER 1 COMPRISES OF(SL.NOs.2,3,4,5,6,7,8,9,14,15,16,19)

2 1 F7176414 BRACKET SWC 1

3 2 F7900513 CHANNEL ASSY - SWC 1

4 3 B0912201 RATCHET ASSY 1

5 4 F7950514 LATCH PLATE 1

6 5 F8100100 CABLE ASSY 1

7 6 L3610818 NYLOC NUT 1

8 7 F3597615 SHOULDERED BOLT 2

9 8 F3551811 SPECIAL NUT - CLEVELOC - M8 X 1.25CP X 0mm LONG X GR 2

10 9 L3611218 NYLOC NUT 4

11 10 F4953910 WASHER 4

12 11 F3596115 WHEEL NUTS 2

13 12 L5000816 SPLIT - PIN 1/8 DIA X 2 inch 1

14 13 F1292015 SPECIAL WASHER 2

15 14 L4010800 WASHER 8 DIA 2

16 15 L3010818 NUT M8 X PC 8 X 1.25 1

17 16 L1011209 BOLT 4
SPARE WHEEL CARRIER - A0912700 - ALSWC27/1 315
 316

SPARE WHEEL CARRIER - A0912700 - ALSWC27/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 F3511200 SPLIT COTTER PIN 1

19 18 X0801214 PLATE REINF SWC 2

BADGES - A8H01100 - ALBD7/1 317
 318

BADGES - A8H01100 - ALBD7/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F7639160 ASHOK LEYLAND NAME PLATE 1

2 2 F4100268 L - LOGO 1

3 3 FH302400 ECOMET HD - DOME LABEL 2

4 4 F7636660 BS - III DOME LABEL 1

REAR BUMPER BAR - A6W01400 - ALRBB33 319
 320

REAR BUMPER BAR - A6W01400 - ALRBB33

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 FR201614 RUPD BRACKET RH 1

2 2 L4011200 WASHER 12 DIA 4

3 3 FR201514 RUPD BRACKET LH 1

4 4 L4111200 SC WASHER 12 DIA 4

5 5 X3503410 NUT 6

6 6 L3021218 NUT M12 X PC 8 X 1.5 4

7 7 F0459910 PLATE 2

8 8 L2021230 SCREW M12 X 30 X 1.5 4

9 9 B7400802 S/A OF REAR UNDER RUN PROTECTIVE DEVICE 1

10 10 F3589711 SCREW - HEX M12 X 1.75 CP X 40 LONG X GR 10.9 6

11 11 F3552011 NUT M12X175 P/T (10GR) 8

12 12 L4011200 WASHER 12 DIA 8

13 13 F3588311 SCREW 8
FRONT SHOCK ABSORBER - A7E04200 - ALFSA34 321
 322

FRONT SHOCK ABSORBER - A7E04200 - ALFSA34

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B7E00201 FRONT SHOCK ABSORBER 2

2 2 F4A00550 FRONT SHOCK ABSORBER MOUNTING BUSH 4

3 3 FL801610 RETAINING WASHER - INNER 2

4 4 FL801710 RETAINING WASHER - OUTER 2

5 5 F0M00310 NUT FOR THE FRONT SHOCK ABSORBER 4

6 6 F3A00413 FRONT SHOCK TOP MOUNTING BRACKET 2

7 7 F3588311 SCREW 8

8 8 F3552011 NUT M12X175 P/T (10GR) 8

FRONT SUSPENSION - A5F06500 - ALFFSA16 323
 324

FRONT SUSPENSION - A5F06500 - ALFFSA16

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B3115601 S/A OF SPRING SHACKLE 2 COMPRISES OF(SL.NOs.2,3)

2 1 F3240211 SPRING SHACKLE 1

3 2 F0531232 SPRING BUSH 1

4 3 F0923415 SHACKLE PIN 6

5 4 F2560010 GREASE NIPPLE 6

6 5 F3547415 NUT 3/4 inch BSF 8

7 - L2011220 SCREW M12 X 20 X 1.75 CP PLATED 2

8 6 L3050711 NUT 7/16 X PCP BSF 6

9 7 H1050722 BOLT 7/16 X 2 3/4 BSF 6

10 8 L4100700 WASHER 7/16 inch DIA 6

11 B5F06501 S/A OF FRONT SPRING 2 COMPRISES OF(SL.NOs.12,13)

12 9 F9F01500 FRONT SPRING 1

13 2 F0531232 SPRING BUSH 2

14 10 F4R02113 TOP CLAMP 2

15 11 F3A00313 FRONT SHOCK BOTTOM MOUNTING BRACKET 2

16 12 F2632200 S/A OF BUMP STOP 2

17 13 L2011022 SCREW M10 X 22 X 1.5 4

FRONT SUSPENSION - A5F06500 - ALFFSA16 325
 326

FRONT SUSPENSION - A5F06500 - ALFFSA16

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 14 L4111000 SC WASHER 10 DIA 4

19 15 F3581611 BOLT 4

20 16 P9F00144 MAIN LEAF - Front spring 1

21 17 P9F00145 2ND LEAF -Front spring 1

22 18 P9F00146 3RD LEAF -Front spring 1

23 19 P9F00147 4TH LEAF -Front spring 1

24 20 P9F00148 5TH LEAF -Front spring 1

25 21 PD600493 CENTER BOLT & NUT KIT 1

REAR SUSPENSION - A6Y05300 - ALFRSA12 327
 328

REAR SUSPENSION - A6Y05300 - ALFRSA12

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B3115601 S/A OF SPRING SHACKLE 2 COMPRISES OF(SL.NOs.2,3)

2 1 F3240211 SPRING SHACKLE 1

3 2 F0531232 SPRING BUSH 1

4 3 L4100700 WASHER 7/16 inch DIA 8

5 4 F4939515 WASHER 8

6 5 F2560010 GREASE NIPPLE 6

7 B6Y05301 S/A OF REAR SPRING LH 1 COMPRISES OF(SL.NOs.8,9)

8 2 F0531232 SPRING BUSH 2

9 6 F9F01600 REAR SPRING - LH 1

10 B6Y05302 S/A OF REAR SPRING RH 1 COMPRISES OF(SL.NOs.11,12)

11 7 F9F01700 REAR SPRING - RH 1

12 2 F0531232 SPRING BUSH 2

13 8 F0923415 SHACKLE PIN 6

14 9 F3563015 NUT M22 X 2.5 8

15 10 L1050721 BOLT 7/16 X 2 5/8 BSF 8

16 11 L3050711 NUT 7/16 X PCP BSF 8

17 12 F3526710 U BOLT 4
REAR SUSPENSION - A6Y05300 - ALFRSA12 329
 330

REAR SUSPENSION - A6Y05300 - ALFRSA12

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 13 F4R00522 TOP CLAMP 2

19 14 P9F00134 MAIN LEAF - 1ST LEAF 1

20 15 P9F00135 SECOND LEAF 1

21 16 P9F00136 THIRD LEAF 1

22 17 P9F00137 FOURTH LEAF 1

23 18 P9F00138 FIFTH LEAF 1

DRAG LINK - A2C04800 - ALDL96 331
 332

DRAG LINK - A2C04800 - ALDL96

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B2C04801 DRAG LINK SUB ASSEMBLY 1

STEERING - A2278000 - ALSG264/4 333
 334

STEERING - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 FJ601068 PLASTIC RESERVOIR ASSEMBLY 1

2 2 F2R00212 STEERING GEAR BOX ADAPTOR BRACKET 1

3 3 B2271101 STEERING PUMP 1

4 4 F0101222 ADAPTOR PLATE - P. STG PUMP MTG 1

5 5 F8A00122 STEERING GEAR Assy 1

6 6 F0E04911 DROP ARM 1

7 7 B2275801 S/A OF RETURN HOSE 1

8 8 F1B03111 BOLT - HEX M18 X 1.5 EFP X 50.5 LONG X GR 10.9 1

9 9 F1B03211 BOLT - HEX M18 X 1.5 EFP X 80.0 LONG X GR 10.9 3

10 10 F0842910 3/4 inch PIPE CLIP 1

11 11 X0416810 L - BRACKET 1

12 12 F3728815 STUD - STG BOX MOUNTING 2

13 13 F3588011 BOLT 1

14 14 F4954010 WASHER_21X45X6 3

15 15 F3552111 NUT 3

16 16 L3010618 NUT M6 X PC 8 X 1 1

17 17 X3106915 BANJOBOLT 2
STEERING - A2278000 - ALSG264/4 335
 336

STEERING - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 18 X4900207 DOWTEE WASHER 2

19 19 L2010620 SCREW M6 X 20 X 1 CP 1

20 20 X3107115 BANJO BOLT 1

21 21 X4900307 DOWTEE WASHER 2

22 22 F0B00611 STEERING OIL RESERVOIR MOUNTING BRACKET 1

23 23 FL800811 WASHER 29.4 OD X 18.2 ID X 3.5 T 4

24 24 F3149815 BANJO BOLT 1

25 26 L2011025 SCREW M10 X 25 X 1.5 2

26 27 L4011000 WASHER 10 DIA 6

27 28 L3611018 NYLOC NUT 6

28 29 F4S01410 WORM DRIVEN CLIP 1

29 30 F8200310 JUBILEE CLIP 1

30 31 FA400658 O-RING - STEERING PUMP 1

31 32 F1657211 GEAR POWER STEERING PUMP 1

32 33 X4900107 DOWTEE WASHER 2

33 35 F8611900 SUCTION HOSE - POWER STG 1

34 36 L4011000 WASHER 10 DIA 1

STEERING - A2278000 - ALSG264/4 337
 338

STEERING - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 37 B2268202 S/A OF PRESSURE PIPE LINE 1

36 38 B2268203 S/A OF RETURN LINE 1

37 39 B2256805 PRESSURE HOSE FROM PUMP TO S/A PIPE FOR STG BOX 1

38 40 X0416810 L - BRACKET 1

39 41 F0832010 DOUBLE CLIP 1

40 42 L2010620 SCREW M6 X 20 X 1 CP 1

41 43 L4110600 SC WASHER 6 DIA 1

42 44 L3010618 NUT M6 X PC 8 X 1 1

43 45 L2021230 SCREW M12 X 30 X 1.5 1

44 46 L4111200 SC WASHER 12 DIA 1

45 47 L3011218 NUT M12 X PC 8 X 1.75 1

46 48 X0416810 L - BRACKET 1

47 49 F0830110 CLIP 1

48 50 L2010620 SCREW M6 X 20 X 1 CP 1

49 51 L4110600 SC WASHER 6 DIA 1

50 52 L3010618 NUT M6 X PC 8 X 1 1

51 53 L2021230 SCREW M12 X 30 X 1.5 1

STEERING - A2278000 - ALSG264/4 339
 340

STEERING - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 54 L4111200 SC WASHER 12 DIA 1

53 55 L3011218 NUT M12 X PC 8 X 1.75 1

54 56 L4110600 SC WASHER 6 DIA 1

55 57 F3593915 NUT FOR DROP ARM 1

56 58 F4947910 TAB WASHER 1

57 - L3011011 NUT M10 X PC 1 X 1.5 CP PLATED 1

58 - L2011030 SCREW M10 X 30 X 1.5 1

59 - X3103015 BANJO BOLT 1

60 - L1011008 BOLT 4
STEERING RESERVOIR - A2278000 - ALSG264/4 341
 342

STEERING RESERVOIR - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 FJ601068 PLASTIC RESERVOIR ASSEMBLY 1

2 2 P4L00013 S/A OF CAP 1

3 3 P7A00010 S/A OF FILTER 1

4 4 P7A00011 STRAINER 1

5 5 P0Z00601 S/A OF SHELL 1

STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4 343
 344

STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

0 1 F8A00122 STEERING GEAR Assy 1

1 P2400851 INPUT SHAFT SEAL KIT 1 COMPRISES OF(SL.NOs.2,3,4,5,6)

2 2 SEAL PROTECTOR 1

3 3 SEAL 1

4 4 RETAINING RING 1

5 5 BACKUP WASHER 1

6 6 SEAL ASSY. AR

7 7 TBA VALVE HOUSING ASSEMBLY 1

8 8 P2404135 BOLT (1/2 inch) 1

9 9 P2406135 SEAL NUT - POPPET ADJ. SCREW 2

10 10 P2404335 ADJ SCREW POPPET 1

11 11 P2402327 O-RING - VALVE HSG 1

12 P2401551 THRUST BEARING KIT 1 COMPRISES OF(SL.NOs.13,14,15)

13 12 THRUST WASHER 1

14 13 NEEDLE THRUST BRG. 1

15 14 THRUST WASHER SPIGOTTED 1

16 P2403151 SEAL KIT - VALVE SLEEVE 1 COMPRISES OF(SL.NOs.17,18)

STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4 345
 346

STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

17 15 SEAL RING 2

18 16 O RING 2

19 17 P2401939 WORM RACK ASSY 1

20 18 P2400543 BALL 28

21 19 P2401234 BALL RETURN GUIDE 2

22 20 P2400408 CLIP 1

23 21 P2406935 SET SCREW 2

24 P2403251 POPPET VALVE KIT 1 COMPRISES OF(SL.NOs.25,26,27,28,29)

25 22 RETAINING RING 2

26 23 POPPET SEAT 2

27 24 POPPET 2

28 25 NYLON ROD 1

29 26 SPRING 1

30 P2403351 SEAL KIT - WORMSHAFT 1 COMPRISES OF(SL.NOs.31,32)

31 27 SEAL RING 1

32 28 O RING 1

33 P2403451 SEAL KIT - PISTON RACK 1 COMPRISES OF(SL.NOs.34,35)

STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4 347
 348

STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

34 29 SEAL RING 1

35 30 O RING 1

36 31 P2404535 ADJUSTING SCREW - THRUST 1

37 32 P2405935 SEAL NUT - WORM ADJ. SCREW 1

38 33 P2407435 ADJ.SCREW-POPPET 1

39 34 P2404835 NUT - DROP ARM 1

40 35 F4947910 TAB WASHER 1

41 36 P2404935 BOLT - TRUNNION COVER 4

42 37 P2400411 TRUNION COVER 1

43 P2400951 SEAL KIT - TRUNNION COVER 1 COMPRISES OF(SL.NOs.44,45,46,47)

44 38 SEAL PROTECTOR 1

45 39 TRUNNION SEAL 1

46 40 BACKUP WASHER 1

47 41 SEAL RING ASSY. 1

48 P2406751 SEAL KIT (T/COVER WITH O RING) 1 COMPRISES OF(SL.NOs.49,50,51,52,53)

49 42 SEAL PROTECTOR 1

50 43 TRUNNION SEAL 1
STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4 349
 350

STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

51 44 BACKUP WASHER 1

52 45 SEAL RING ASSY. 1

53 46 O RING 1

54 47 P2402427 O-RING 1

55 48 P2400802 ROLLER BEARING (HSG/SIDE COVER) 2

56 49 TBA HOUSING AR

57 50 PF700072 SECTOR SHAFT ASSY. 1

58 P2408335 S/S ADJ.CSREW KIT 1 COMPRISES OF(SL.NOs.59,60,61)

59 51 S/ SHAFT ADJ.SCREW 1

60 52 RETAINER 1

61 53 THRUST PLUG 1

62 P2401051 SEAL KIT - SIDE COVER 1 COMPRISES OF(SL.NOs.63,64,65,66,67)

63 54 RETAINING RING 1

64 55 SEAL RING ASSY. 1

65 56 BACKUP WASHER 1

66 57 PLUG 1

67 58 BACKUP WASHER 1
STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4 351
 352

STEERING GEAR - INTERNAL COMPONENTS - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

68 59 P2400117 GASKET - SIDE COVER 1

69 60 P2400311 SIDE COVER 1

70 61 P2405035 BOLT - SIDE COVER 6

71 62 P2405135 NUT - SECTOR SHAFT ADJUSTING SCREW 1

72 63 P2401631 PLUG 1

73 64 P2400643 STEEL BALL 1

74 65 P2402527 O-RING 1

75 66 P2401731 PLUG - CHECKVALVE 1

76 P2401251 MAJOR SEAL KIT 1 COMPRISES

OF(SL.NOs.2,3,4,5,6,9,11,17,18,31,32,34,35,37,44,45,46,47,54,63,6
4,65,66,67,68,74)

77 P2407051 MAJOR SEAL KIT(COMPACT) 1

STEERING PUMP - INTERNAL COMPONENTS - A2278000 - ALSG264/4 353
 354

STEERING PUMP - INTERNAL COMPONENTS - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B2271101 STEERING PUMP 1

2 PD600402 HOUSING SUB ASSEMBLY KIT 1 COMPRISES OF(SL.NOs.10,11,12,13,14,22,23,26,27)

3 P9900686 SHAFT SUB ASSEMBLY 1 COMPRISES OF(SL.NOs.6,15,20,21)

4 P2410139 CARTRIDGE ASSY 1 COMPRISES OF(SL.NOs.8,9,19,21,24)

5 P2405351 SEAL KIT 1 COMPRISES OF(SL.NOs.16,23,26)

6 2 P2402009 WOODRUFF KEY 1

7 3 P5J00179 END COVER 1

8 4 P2402109 DOWEL PIN 2

9 5 P2408935 ALLEN SCREW 2

10 6 P2401607 RETAINING RING (INT) 1

11 7 P0P00124 NEEDLE ROLLER BEARING 1

12 8 P2403149 SEAL WASHER 1

13 9 P9900687 PLUG SUB ASSEMBLY 1

14 10 P2400636 SPRING (FLOW CONTROL) 1

15 11 P2401707 RETAINING RING (EXT) 1

16 12 P2403227 O-RING 1

17 13 P2400312 SPACER 1
STEERING PUMP - INTERNAL COMPONENTS - A2278000 - ALSG264/4 355
 356

STEERING PUMP - INTERNAL COMPONENTS - A2278000 - ALSG264/4

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 14 P2401507 RETAINING RING 1

19 15 PRESSURE PLATE 1

20 16 SHAFT 1

21 17 BEARING 1

22 18 PUMP BODY 1

23 19 SEAL 1

24 20 VANE PLATE 1

25 21 CAM RING 1

26 22 SEAL 1

27 23 HOUSING 1
ACCELERATOR PEDAL AND LINKAGES - A3743500 - ALCG183 357
 358

ACCELERATOR PEDAL AND LINKAGES - A3743500 - ALCG183

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B8894820 PENDANT TYPE ELECTRONIC APM 1

2 2 F8201160 SENSOR KIT 1

3 3 F1105050 COVER TREADLE 1

4 4 L2010825 SCREW M8 X 25 X 1.25 2

5 5 L4110800 SC WASHER 8 DIA 2

6 6 L3010818 NUT M8 X PC 8 X 1.25 2

7 - F8201060 ROLLER KIT 1

8 - F8216710 TREADLE PIN KIT 1

AIR PIPING - A0F42100 - ALPA710/1 359
 360

AIR PIPING - A0F42100 - ALPA710/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B0F42103 MODULAR HOSE KIT 1 COMPRISES OF(SL.NOs.2,3,4,5,6)

2 1 B0F08904 LOOSE HOSE TO CONNECT EXHAUST BRAKE WITH SOLENOID 1

3 2 B0F42101 MODULAR HOSE ASSEMBLY 1

4 3 B0F42102 LOOSE HOSE TO CONNECT AUXILARY TANK TO SOLENOID AND 1

CLUTCH BOOSTER

5 4 B0F12610 NYLON HOSE 2

6 5 B0F09204 S/A OF PIPING FOR DUAL BRAKE VALVE TO FRONT BRAKE 1

CHAMBER

7 6 F4931440 WASHER 17 OD X 12.5 ID X 1.5 T 2

8 7 L2010615 SCREW M6 X 15 X 1 CP 2

9 8 L3611018 NYLOC NUT 1

10 9 B0F09101 COMPRESSOR INLET PIPE 1

11 10 B8009238 S/A OF METAL PIPE - 5/8 inch DIA 1

12 11 F0603260 NYLON STRAP 20

13 12 F0830910 CLIP 1

14 13 F0830910 CLIP 1

15 14 F0845714 HOSE CLAMP 2

16 15 F3923700 HOSE ASSEMBLY 2

17 16 F7972114 BRKT - BRAKE PIPE 1

AIR PIPING - A0F42100 - ALPA710/1 361
 362

AIR PIPING - A0F42100 - ALPA710/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 L2010620 SCREW M6 X 20 X 1 CP 1

19 18 L2010620 SCREW M6 X 20 X 1 CP 1

20 19 L2011235 SCREW M12 X 35 X 1.75 1

21 20 L3010618 NUT M6 X PC 8 X 1 1

22 21 L3010618 NUT M6 X PC 8 X 1 2

23 22 B0F11501 S/A of 5/8 inch PIPE - 550mm LONG 1

24 23 L2011235 SCREW M12 X 35 X 1.75 1

25 24 L2011030 SCREW M10 X 30 X 1.5 1

26 25 L2010620 SCREW M6 X 20 X 1 CP 1

27 26 L2010620 SCREW M6 X 20 X 1 CP 1

28 27 F4S00714 PIPE CLIP 2

29 28 F7459600 HOSE - PARKING 2

30 29 F0845214 STRAP - SPECIAL OLAS 20

31 30 F0830910 CLIP 1

32 31 F0830910 CLIP 1

33 32 B8009239 S/A OF METAL PIPE - 5/8 inch DIA 1

34 33 B6603209 S/A OF PIPE 1

AIR PIPING - A0F42100 - ALPA710/1 363
 364

AIR PIPING - A0F42100 - ALPA710/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 34 X7172210 L BRACKET - ON LH FSM NEAR RSF CROSS MBR 1

36 35 L2011030 SCREW M10 X 30 X 1.5 1

37 36 L4110600 SC WASHER 6 DIA 2

38 37 F0111515 ADAPTOR 2

39 38 X0802410 C - CLAMP 2

40 39 F1960050 STRAIGHT HOSE 1

41 40 B8342141 COMPRESSOR OUTLET PIPE 1

42 41 X0416810 L - BRACKET 2

43 42 L4110600 SC WASHER 6 DIA 1

44 43 L4110600 SC WASHER 6 DIA 1

45 44 X0416810 L - BRACKET 1

46 45 X0416810 L - BRACKET 1

47 46 X0416810 L - BRACKET 1

48 47 L4110600 SC WASHER 6 DIA 1

49 48 L3611218 NYLOC NUT 1

50 49 L4110600 SC WASHER 6 DIA 1

51 50 L3611218 NYLOC NUT 1

AIR PIPING - A0F42100 - ALPA710/1 365
 366

AIR PIPING - A0F42100 - ALPA710/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 51 L3611018 NYLOC NUT 1

FOOT BRAKE - A5A27800 - ALFB354 367
 368

FOOT BRAKE - A5A27800 - ALFB354

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - X1903060 SHIELD - FRONT BRAKE HOSE 2

2 1 B5A05601 E2 VALVE SUB ASSEMBLY WITH 3 WAY ADAPTOR 1

3 2 B6105404 ASSY OF STRAP RESERVOIR MTG 2

4 3 F1330311 FRONT ELBOW 2

5 4 F1932650 HOSE ASSY - FRONT BRAKES 2

6 - F1932850 HOSE ASSY (COMPRESSOR PIPE TO UNION) 1

7 5 F3523410 ADAPTOR 2

8 6 B6105403 BRACKET ASSY BRAKE AIR RESERVOIR 2

9 - F4930140 SPECIAL WASHER 2

10 7 L2011035 SCREW M10 X 35 X 1.5 4

11 - F4933140 WASHER 22 OD X 16.5 ID X 1.5 T 4

12 8 F8836500 DRIER AND DISTRIBUTOR VALVE 1

13 - P1019739 UNLOADER VALVE 1

14 - P1004641 DIAPHRAGM 1

15 - P1022951 REPAIR KIT 1

16 - P1009918 VALVE BODY 1

17 - P1010018 GOVERNOR VALVE BODY 1

FOOT BRAKE - A5A27800 - ALFB354 369
 370

FOOT BRAKE - A5A27800 - ALFB354

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - P1020039 PURGE TANK ASSY 1

19 9 F8837200 AIR TANK - 25L 1

20 10 L2010835 SCREW M8 X 35 X 1.25 2

21 11 L2011035 SCREW M10 X 35 X 1.5 4

22 12 L3610818 NYLOC NUT 2

23 13 L3611018 NYLOC NUT 2

24 14 L3811018 CLEVELOC NUT M10 X PC 8 X 1.5 4

25 15 F8837200 AIR TANK - 25L 1

26 - L4310800 M8 S.I. WASHER 1

27 16 L3811018 CLEVELOC NUT M10 X PC 8 X 1.5 4

28 17 B6105404 ASSY OF STRAP RESERVOIR MTG 2

29 - X0141315 ADAPTOR 1

30 18 L4111200 SC WASHER 12 DIA 4

31 19 L3811018 CLEVELOC NUT M10 X PC 8 X 1.5 4

32 20 L3611018 NYLOC NUT 2

33 21 L2021230 SCREW M12 X 30 X 1.5 4

34 22 L2011035 SCREW M10 X 35 X 1.5 4

FOOT BRAKE - A5A27800 - ALFB354 371
 372

FOOT BRAKE - A5A27800 - ALFB354

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 23 L2010830 SCREW M8 X 30 X 1.25 1

36 24 F8837100 AIR TANK 15L 1

37 25 F4937030 WASHER 16 OD X 10.5 ID X 2 T 1

38 26 F2630014 PAD 8

39 - F4930240 WASHER 30 OD X 22.5 ID X 1.5 T 1

40 - F0845214 STRAP - SPECIAL OLAS 12

41 27 B6105403 BRACKET ASSY BRAKE AIR RESERVOIR 2

42 B5A03002 S/A OF TEE PIECE ADAPTOR 1 COMPRISES OF(SL.NOs.43,44,45,46,47,48)

43 28 F2E00714 TEE - PIECE MOUNTING BRACKET 1

44 29 F1303711 TEE PIECE M22 X M22 X M18 1

45 30 F3545015 NUT - HEX M18 X 1.5 EFP X 9 LONG 2

46 31 F1303911 TEE PIECE M18 X M18 X M18 1

47 32 L4310800 M8 S.I. WASHER 1

48 33 F4949110 WASHER 1

49 34 B3949801 SUB ASSY OF AIR RESERVOIR MTG BRKT 2

50 - L3611018 NYLOC NUT 2

CAB MOUNTING - A1A02600 - ALCM96/1 373
 374

CAB MOUNTING - A1A02600 - ALCM96/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F8902922 BRACKET CAB PIVOT LOWER 2

2 2 F8014600 INSULATOR CAB MOUNTING FRONT 2

3 3 F3501311 SPECIAL FLANGED BOLT 6

4 4 F4912215 WASHER 12

5 5 F3513210 SPECIAL NUT - HEX - M12 X 1.5FP X 10.8mm LONG X GR 10 6

6 6 F3523500 Special Bolt - Hex - M16 X X 145mm LONG X GR 12.9 2

7 7 L3811618 NUT 2

8 8 F3643410 TORSION BAR RH 1

9 8 F3643510 TORSION BAR LH 1

10 9 L2011030 SCREW M10 X 30 X 1.5 2

11 10 L3011018 NUT M10 X PC 8 X 1.5 2

12 11 F0532360 SPLIT BUSH 4

13 12 L7100360 CIRCLIP 2

14 13 F0484710 BRACKET ASSEMBLY - CAB STAY TO FRAME 1

15 14 B0103401 ARM ASSEMBLY - CAB RETAIN 1

16 15 W8010820 SCREW 3

17 16 F4953510 WASHER 8.4X19X3 1

CAB MOUNTING - A1A02600 - ALCM96/1 375
 376

CAB MOUNTING - A1A02600 - ALCM96/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 F4952710 WASHER 17 OD X 8.4 ID X 2 T 2

19 LO FASTENERS: CAB STAY TO BRACKET

20 18 L2011025 SCREW M10 X 25 X 1.5 1

21 19 F3505600 BOLT 1

22 LO FASTENERS: CAB STAY BRACKET TO FRAME

23 20 X4904210 WASHER 1

24 21 F3551911 NUT M10X1.5 2

25 22 F4952910 WASHER - BRKT TO FSM 2

26 LO INSULATOR

27 23 B5425529 S/A BRACKET - CAB MTG 1

28 24 B5425530 S/A OF BRACKET - CAB MTG RR RH 1

29 25 F3589711 SCREW - HEX M12 X 1.75 CP X 40 LONG X GR 10.9 4

30 26 F3552011 NUT M12X175 P/T (10GR) 4

31 27 F2637300 INSULATOR 4

32 28 F3319915 PIN - CAB LOCK 2

33 29 F0745910 CIRCLIP 4

34 30 X3216215 ARM FOR CAB LOCK 1

CAB MOUNTING - A1A02600 - ALCM96/1 377
 378

CAB MOUNTING - A1A02600 - ALCM96/1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 31 F3551811 SPECIAL NUT - CLEVELOC - M8 X 1.25CP X 0mm LONG X GR 2

36 - L2021240 SCREW M12 X 40 X 1.5 2

37 - F4956810 WASHER 23 OD X 12.1 ID X 2.5 T 2

38 - L3621218 NYLOC NUT 2

39 - L4111200 SC WASHER 12 DIA 6

CABIN - A0Y25400 - ALCAB172 379
 380

CABIN - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - A0Y25400 ASSY OF CABIN 1

2 - B0Y25401 ASSY OF PAINTED SHELL 1

ECOMET GRILLE - A0Y25400 - ALCAB172 381
 382

ECOMET GRILLE - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B0Y02506 ASSY OF EC GRILLE RL RH LAMP 1

2 1 F0845214 STRAP - SPECIAL OLAS 1

3 2 F8F00300 GRILLE 1

4 3 X7901214 BRKT RAD GRILLE OUTER RHS 1

5 - X7401250 RUBBER SEAL 1

6 4 X7901114 BRACKET RAD GRILLE OUTER LHS 1

7 5 X7401150 RUBBER SEAL 3

8 - X7400950 RUBBER SEAL 1

9 6 X7400850 RUBBER SEAL 1

10 - Y2610825 CHEESE HEAD SCREW 4

11 - F4951610 WASHER 25 OD X 8.4 ID X 2 T 4

12 - F3542410 NUT & CAGE ASSY 5

FENDER, CAB LOCK AND BLANKING PLUGS - A0Y25400 - ALCAB172 383
 384

FENDER, CAB LOCK AND BLANKING PLUGS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 LO FENDER

2 - B5412693 ASSEMBLY OF FENDER 1

3 1 F7423250 SEAL - FRONT 2

4 2 F7423150 SEAL - FRONT FENDER 2

5 3 F4949110 WASHER 4

6 4 F7878700 INSULATOR FRONT FEND 2

7 5 F7878900 INSULATOR 2

8 6 F4956110 LOCK WASHER 20

9 - F4952810 WASHER 19 OD X 8.4 ID X 3 T 16

10 7 F7873210 HEX SCREW 20

11 8 F7423350 SEAL 2

12 - F7449500 BUTYL SEALER 1

13 LO CAB LOCK

14 - B5412628 ASSEMBLY OF CAB LOCK 1

15 9 F7874320 SCREW 4

16 10 F4952415 PLATE CAB LOCK 1

17 11 B5412246 HANDLE ASSEMBLY CABLOCK 1

FENDER, CAB LOCK AND BLANKING PLUGS - A0Y25400 - ALCAB172 385
 386

FENDER, CAB LOCK AND BLANKING PLUGS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 12 B5412208 HOOK ASSEMBLY - CAB 1

19 13 B5425536 CAB LOCK ASSEMBLY 2

20 14 F4953010 WASHER - BATTERY CLAMP 8

21 15 F7427800 CONTROL ASSEMBLY CAB LOCK 1

22 16 F7873850 SCREW M6X40 2

23 17 F3565910 TORX SCREW 4

24 18 L1011209 BOLT 1

25 - L2011025 SCREW M10 X 25 X 1.5 8

26 LO LIST OF BLANKING PLUGS

27 - B5412663 LIST OF BLANKING PLUGS 1

28 - F7871500 PLUG PLASTIC 4

29 - F7871700 PLUG PNL PLAS OVAL 6

30 - F7874590 PLUG 40

31 - F7869660 PLUG 1

32 - F7872100 PLUG PANEL 13

33 - F7869740 BUMPER SPECIAL 7

34 - F7871800 PLUG PNL OVAL SPCL 4

FENDER, CAB LOCK AND BLANKING PLUGS - A0Y25400 - ALCAB172 387
 388

FENDER, CAB LOCK AND BLANKING PLUGS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 - F7872400 BUMPER HOOD 2

36 - F3102560 DUMMY PLUG PANEL 3

37 - F7873910 PLUG - PNL PLAS 2

38 - F3102360 DUMMY PLUG 12

GLASS AND WEATHER STRIPS - A0Y25400 - ALCAB172 389
 390

GLASS AND WEATHER STRIPS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - S/A OF GLASS W/STRIPS 1 NSS

2 1 B0Y02357 W/S ASSY-FRONT DOOR OPENING LH/RH-EPDM 2

3 2 F7400150 STRIP W SHIELD GLASS 1

4 3 F7854800 GLASS BLACK WINDOW 2

5 F7879100 GLASS AND CHANNEL ASSY - RH 1 COMPRISES OF(SL.NOs.6,7,8)

6 4 F8061800 GLASS CHANNEL ASSY 1

7 5 F7428400 WEATHER STRIP - DOOR GLASS CHANNEL 1

8 6 X7902514 GLASS HOLDING CHANNEL - RH 1

9 B5412273 GLASS AND FRAME ASSEMBLY FIX 1 COMPRISES OF(SL.NOs.10,11,12,13,14)

10 7 F7401550 WEATHER STRIP - DOOR 1

11 8 F7987814 FRAME ASSY DOOR WINDOW - LH 1

12 9 F8061700 GLASS DOOR FIXED 1

13 10 F7987714 FRONT DOOR WINDOW FRONT 1

14 11 F7874680 RIVET BLD DOMED ALUM 2

15 12 X7400450 WEATHER STRIP 2

16 13 F4951510 WASHER 2

17 B5412547 CHANNEL ASSY DOOR - RH 1 COMPRISES OF(SL.NOs.18,19)

GLASS AND WEATHER STRIPS - A0Y25400 - ALCAB172 391
 392

GLASS AND WEATHER STRIPS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 14 B5412275 CHANNEL ASSEMBLY DOOR 1

19 15 X7800350 RUN DOOR GLASS 1

20 16 F4952315 REINF DOOR CHANNEL 2

21 17 F7872500 CLIP ROD PANEL 4

22 18 X7800150 RUN DOOR GLASS 2

23 19 F7401650 W/STRIP BACK WINDOW 2

24 B5412545 CHANNEL ASSY DOOR GL 1 COMPRISES OF(SL.NOs.25,26)

25 20 B5412232 CHANNEL ASSEMBLY DOOR 1

26 21 X7800250 RUN DOOR GLASS 1

27 B5412546 CHANNEL ASSY 1 COMPRISES OF(SL.NOs.28,29)

28 20 B5412223 CHANNEL ASSEMBLY DOOR 1

29 21 X7800250 RUN DOOR GLASS 1

30 B5412548 CHANNEL ASSY SHORT LH 1 COMPRISES OF(SL.NOs.31,32)

31 14 B5412274 CHANNEL ASSEMBLY DOOR 1

32 15 X7800350 RUN DOOR GLASS 1

33 22 F3560410 SCREW - SLOTTED SNAP M8 X 13 LONG 4

34 23 F3560410 SCREW - SLOTTED SNAP M8 X 13 LONG 8

GLASS AND WEATHER STRIPS - A0Y25400 - ALCAB172 393
 394

GLASS AND WEATHER STRIPS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 24 F7873280 SCREW ASSY 4

36 B5412590 WEATHERSTRIP DOORSTEP INNER 2 COMPRISES OF(SL.NOs.37,38)

37 25 F0841713 CLIP WEATHER STRIP 5

38 26 F8001250 WEATHER STRIP - DOOR INNER 1

39 27 F7873680 WEATHER STRIP DOOR - RH 1

40 27 F7873720 WEATHER STRIP DOOR - LH 1

41 B5412276 ASSY OF GLASS AND FRAME 1 COMPRISES OF(SL.NOs.42,43,44,45,55)

42 7 F7401550 WEATHER STRIP - DOOR 1

43 8 F7987614 FRAME ASSY DOOR WINDOW - RH 1

44 9 F8061700 GLASS DOOR FIXED 1

45 10 F7987714 FRONT DOOR WINDOW FRONT 1

46 11 F7874680 RIVET BLD DOMED ALUM 2

47 F7879000 GLASS AND CHANNEL ASSY - LH 1 COMPRISES OF(SL.NOs.48,49,50)

48 5 F7428400 WEATHER STRIP - DOOR GLASS CHANNEL 1

49 4 F8061900 GLASS CHANNEL ASSY 1

50 6 X7902414 GLASS HOLDING CHANNEL - LH 1

51 28 F8052100 GLASS WINDSHIELD 1

GLASS AND WEATHER STRIPS - A0Y25400 - ALCAB172 395
 396

GLASS AND WEATHER STRIPS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 29 F7400850 DOOR OTR.RH 1

53 30 FM000160 DOOR WIN WEATHER STRIP OUTER 2

PARK BRAKE VALVE & PROXIMITY MIRROR COMPLETE - A0Y25400 - ALCAB172 397
 398

PARK BRAKE VALVE & PROXIMITY MIRROR COMPLETE - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B0Y04716 ASSY OF PARK BRAKE VALVE 1

2 1 F1107313 CLOSER PLATE 1

3 - F3595310 BOLT - HEX M6 X 0.7 FP X 25 LONG 1

4 2 F7873970 STRAP SPCL PLAS 3

5 - L2010630 SCREW M6 X 30 X 1 CP 4

6 3 L3010618 NUT M6 X PC 8 X 1 4

7 4 L4110600 SC WASHER 6 DIA 4

8 5 F3V04100 GRADUATED HAND CONTROL VALVE 1

9 - P1023951 REPAIR KIT - HAND BRAKE VALVE 1

10 6 L4110600 SC WASHER 6 DIA 2

11 7 L3010618 NUT M6 X PC 8 X 1 2

12 8 F8447310 BRACKET - HAND CONTROL BRACKET MOUNTING IN CAB 1

13 - L3010618 NUT M6 X PC 8 X 1 2

14 - L4110600 SC WASHER 6 DIA 2

15 LO PROXIMITY MIRROR COMPLE

16 - B5412773 ASSEMBLY OF PROXIMITY MIRROR 1

17 9 L3010818 NUT M8 X PC 8 X 1.25 2

PARK BRAKE VALVE & PROXIMITY MIRROR COMPLETE - A0Y25400 - ALCAB172 399
 400

PARK BRAKE VALVE & PROXIMITY MIRROR COMPLETE - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 10 L4110800 SC WASHER 8 DIA 2

19 11 L4010800 WASHER 8 DIA 2

20 12 F8254600 ASSY PROXIMITY MIRROR 1

21 13 F0845214 STRAP - SPECIAL OLAS 4

SEAT BELT - A0Y25400 - ALCAB172 401
 402

SEAT BELT - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 B5438621 ASSY OF SEAT BELT KIT - DRIVER ELR - 8 inch RHD 1 COMPRISES OF(SL.NOs.2,3,4,5,6,7)

2 1 B5412583 KIT SEAT BELT 1

3 2 B5412582 KIT SEAT BELT ASSEMBLY 1

4 - B5412586 TONGUE ASSY RH 1

5 3 B5412585 KIT SEAT BELT 1

6 4 B5412584 KIT SEAT BELT ASSEMBLY 1

7 - B5581005 SEAT BELT ASSEMBLY 1

QUARTER WINDOWS AND SEATS - A0Y25400 - ALCAB172 403
 404

QUARTER WINDOWS AND SEATS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B5425512 S/A OF QUARTER WINDOWS 1

2 1 B5425542 S/A OF QUARTER WINDOW LH 1

3 2 X7468600 DOOR SEAL 1

4 - X7818900 WINDOW ASSY - LH 1

5 - F7424150 SEALANT ANABOND RTV 1

6 3 L2010515 SET SCREW M5 - 15LG 8

7 4 F4950810 WASHER 8

8 B5425544 S/A OF BOTTOM GLASS 2 COMPRISES OF(SL.NOs.9,10)

9 5 X7400650 WEATHER STRIP BOTTOM GLASS 1

10 6 X7819100 BOTTOM GLASS FIXED 1

11 B5425543 S/A OF QUARTER WINDOW RH 1 COMPRISES OF(SL.NOs.12,13)

12 - X7468600 DOOR SEAL 1

13 - X7819000 WINDOW ASSY - RH 1

14 - L4110500 SC WASHER 5 DIA 4

15 - L3010518 NUT M5 X PC 8 X 0.8 4

16 - F4955310 WASHER 4

17 7 L2010515 SET SCREW M5 - 15LG 4

QUARTER WINDOWS AND SEATS - A0Y25400 - ALCAB172 405
 406

QUARTER WINDOWS AND SEATS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 8 L4110500 SC WASHER 5 DIA 8

19 LO SEATS

20 - B5425504 ASSEMBLY OF SEATS 1

21 - L2010620 SCREW M6 X 20 X 1 CP 4

22 9 X3957800 ASSY OF CO - DRIVER SEAT 1

23 - F3504800 SCREW - STAR SLOTTED SNAP M8 X 0 X 50 LONG X GR 8.8 2

24 - L2010825 SCREW M8 X 25 X 1.25 4

25 - F3567910 WING SCREW 1

26 10 F7988314 BRACKET - DOBULE PASSENGER SEAT RHD 1

27 11 F8895700 ASSEMBLY OF DRIVER SEAT 1

28 12 F7988214 SUPPORT - SEAT TO FLOR 1

29 13 F7964114 SUPPORT ASSEMBLY FRONT 1

30 - F7879500 STRIP FRONT PASS ENG 3

31 14 L4010800 WASHER 8 DIA 4

32 15 F7871300 PLUG SPECIAL 6

33 - F7870820 PAN SCREW 2

34 16 F4955510 WASHER 17 OD X 6.4 ID X 2.5 T 4

QUARTER WINDOWS AND SEATS - A0Y25400 - ALCAB172 407
 408

QUARTER WINDOWS AND SEATS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 17 F4952710 WASHER 17 OD X 8.4 ID X 2 T 3

36 - F8911913 BRACKET CO DRIVER SEAT RETAINING 1

37 18 F7874570 CLIP 6

38 - L4010800 WASHER 8 DIA 1

SWITCH BOARD, SWITCHES AND GAUGES - A0Y25400 - ALCAB172 409
 410

SWITCH BOARD, SWITCHES AND GAUGES - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B0Y05505 ASSY OF SWITCH BOARD 1

2 1 F6M01600 CLAMP 3

3 2 F2200560 SWITCH - H/L LEVELER 1

4 - F3032140 NAME PLATE 1

5 3 F7425000 ASSY DOOR SWITCH 2

6 4 F7426100 CAB LATCH SWITCH 1

7 - F7423350 SEAL 1

8 - F7874750 SPECIAL SCREW - CROSS RECESSED PAN HEAD - M8 X 0 X 13mm 2

LONG X GR

9 5 F6M01400 CLAMP WITH RUBBERIZED / PVC SLEEVE - 35 mm 4

10 6 F7873960 GROMMER RUBBER 2

11 7 F7426100 CAB LATCH SWITCH 1

12 8 F7858600 HORN AND BRACKET ASSY 1

13 - F3560410 SCREW - SLOTTED SNAP M8 X 13 LONG 9

14 B5431567 ASSEMBLY OF STEERING MOUNTED IGNITION SWITCH WITH KEY 1 COMPRISES OF(SL.NOs.15,16)

15 9 F2200110 IGNITION KEY 1

16 - B5431019 IGNITION STG LOCK 1

17 10 F7478600 HAZARD WARNING SWITCH 1

SWITCH BOARD, SWITCHES AND GAUGES - A0Y25400 - ALCAB172 411
 412

SWITCH BOARD, SWITCHES AND GAUGES - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - L4110400 SC WASHER 4 DIA PLATED 1

19 - L4110600 SC WASHER 6 DIA 2

20 - L4010600 WASHER 6 DIA 3

21 - X7602060 PLUG SWITCH HOLE 4

22 11 X0444310 BRACKET - MICRO SWITCH 1

23 12 L4110800 SC WASHER 8 DIA 2

24 13 L2010820 SCREW M8 X 20 X 1.25 2

25 - L6010625 PHILIPS SCREW M6 3

26 14 FJ106300 DOUBLE LEVER COMBINATION SWITCH 1

27 - B0Y10402 ASSY OF ELECTRONIC INSTRUMENT CLUSTER 1

28 15 FJ118000 FLASHER 1

29 16 F8017900 HORN ASSEMBLY 1

KICK VENT, RVM AND GLOVE BOX - A0Y25400 - ALCAB172 413
 414

KICK VENT, RVM AND GLOVE BOX - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B5412694 S/A OF KICK VENT 1

2 - F4951810 WASHER 30 OD X 10.5 ID X 5 t 4

3 1 B5545131 S/A OF KICK VENT 2

4 LO RVM AND BRKTS

5 - B5425524 S/A OF RVM AND BRACKETS 1

6 - F7874320 SCREW 4

7 6 B5425555 S/A BRACKET RVM - RH 1

8 7 F7608860 PAD REAR VIEW - RH 1

9 8 F3559710 NUT 8

10 9 F8068100 ASSY REAR VIEW MIRROR 2

11 - F7608760 PAD REAR VIEW - LH 1

12 10 F8254500 ASSY WIDE ANGLE MIRROR 1

13 11 F3006313 MIRROR BRACKET REINF. - LH 1

14 - F3006213 MIRROR BRACKET REINF. - RH 1

15 - F4952510 WASHER 4

16 - B5425556 S/A BRACKET RVM - LH 1

17 - F7874320 SCREW 12
KICK VENT, RVM AND GLOVE BOX - A0Y25400 - ALCAB172 415
 416

KICK VENT, RVM AND GLOVE BOX - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 LO GLOVE BOX

19 - B5425576 S/A OF GLOVE BOX 1

20 12 F7874540 POP RIVET 6

21 13 F7607500 GLOVE BOX CAMPARTNUT 1

22 - F3542910 NUT BLIND ANCHER ASY 4

23 14 L4010400 WASHER 4 DIA 1

24 15 F7874710 MTG PLATE 5

25 16 L4110400 SC WASHER 4 DIA PLATED 4

26 - L4010300 WASHER 3 DIA 6

27 17 F7614960 DOOR GLOVE BOX 1

28 18 F3560810 SHEET METAL SCREW TA 2

29 19 F3542710 SPRING NUT 7

30 20 F7872860 HINGE ASSY - GLOVE 1

31 21 F7121100 GLOVE BOX LOCK 1

32 22 F7974410 PEG - GLOVE BOX LOCK 1

33 - F7872880 HINGE ASSY - GLOVE 1

34 - L6310616 SCREW GLOVE BOX M6X16 4

STEERING COLUMN AND ACCESSORIES - A0Y25400 - ALCAB172 417
 418

STEERING COLUMN AND ACCESSORIES - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - ASSY OF STG COLUMN AND ACCS 1 NSS

2 1 FH100315 STG COLUMN ASSEMBLY 1

3 2 B0Y04737 SUB ASSY OF STEERING WHEEL 1

4 3 B0Y04738 NACELLE MTG BKT 1

5 4 F7962814 BRKT STG COLUMN 1

6 5 F5J01700 COVER ASSEMBLY STG WHEEL 1

7 6 L4110800 SC WASHER 8 DIA 4

8 7 L4010800 WASHER 8 DIA 4

9 8 F3505000 SPECIAL BOLT 2

10 9 F3544210 NUT 2

11 10 F7962914 BRKT STRG COLUMN SHROUD 1

12 11 F7873460 RIVET POP 2

13 12 F3542710 SPRING NUT 6

14 13 F4A00168 BUSH SELF CANCELATION 1

15 - F7616760 BUSH 1

16 14 L2410408 SCREW 1

17 15 F3543310 NUT 1
STEERING COLUMN AND ACCESSORIES - A0Y25400 - ALCAB172 419
 420

STEERING COLUMN AND ACCESSORIES - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 F3560410 SCREW - SLOTTED SNAP M8 X 13 LONG 2

19 17 F7400650 STEERING COLUMN GAITER 1

20 18 F7606860 SHROUD LOWER 1

21 19 F7610760 SEAL 2

22 20 F7874640 POP RIVET 8

23 21 F5T00868 NACELLE FRONT 1

24 22 F4949460 WASHER SPECIAL 2

25 23 F5T00968 NACELLE REAR 1

26 - F7874180 SCREW 3

27 24 L3810818 CLEVELOC NUT M8 X PC 8 X 1.25 2

28 25 L4012000 WASHER 20 DIA 1

29 - F3587611 BOLT - HEX M8 X 1.25 CP X 45 LONG X GR 10.9 1

30 - L2510406 PH SCREW M4 X 6 X 0.7 CP ZP WP AND LUBRICATED 1

31 - F3551811 SPECIAL NUT - CLEVELOC - M8 X 1.25CP X 0mm LONG X GR 1

32 - L4010400 WASHER 4 DIA 2

33 - W8010820 SCREW 4
OPERATING PEDALS - A0Y25400 - ALCAB172 421
 422

OPERATING PEDALS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - ASSEMBLY OF CLUTCH AND BRAKE PEDAL 1 NSS

2 1 F7962014 BRACKET ASSY PEDAL SUPPORT 1

3 2 F7860900 SPNING PEDAL RETURN 1

4 3 F7861000 SPRING - CLUTCH PEDAL RETURN 1

5 4 F4951010 WASHER BOWED 2

6 5 F7401250 PAD - BRAKE AND CLUTCH PEDAL 2

7 6 L3010818 NUT M8 X PC 8 X 1.25 1

8 7 L3610818 NYLOC NUT 4

9 8 F7870240 RETAINER WIRE 2

10 9 F0847014 CLIP - FOOT VALVE 2

11 10 F4952710 WASHER 17 OD X 8.4 ID X 2 T 2

12 11 F7962114 PLATE - SUPPORT ASSY 1

13 12 F7600815 SHAFT FOR PEDAL 1

14 13 F7600715 PUSH ROD 1

15 14 F3551811 SPECIAL NUT - CLEVELOC - M8 X 1.25CP X 0mm LONG X GR 2

16 15 F4951610 WASHER 25 OD X 8.4 ID X 2 T 4

17 16 F0965815 CLEVIS PIN 1

OPERATING PEDALS - A0Y25400 - ALCAB172 423
 424

OPERATING PEDALS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 17 F1292915 PAD PADEL STOP 2

19 18 F7872320 SCREW M8X22 3

20 19 F4949560 WASHER 25.5 OD X 16.5 ID X 1.55 T 4

21 20 FG500200 SPACER - CARGO PEDAL 2

22 21 F3280215 PUSH ROD 1

23 B0Y04742 SUB ASSY OF CLUTCH PEDAL AND BUSH 1 COMPRISES OF(SL.NOs.24,25,26)

24 22 B5412217 PEDAL ASSY - CLUTCH 1

25 23 FG500200 SPACER - CARGO PEDAL 2

26 24 F7860700 BUSH BRAKE PEDAL 1

27 B0Y04743 SUB ASSY OF BRAKE PEDAL AND BUSH 1 COMPRISES OF(SL.NOs.28,29)

28 25 X2409814 PEDAL ASSY BRK 1

29 26 F7860800 BUSH BRAKE PEDAL 1

ACCL PEDAL, CAB MOUNTING, INTERNAL BULL BAR AND FRONT BUMPER - A0Y25400 - ALCAB172 425
 426

ACCL PEDAL, CAB MOUNTING, INTERNAL BULL BAR AND FRONT BUMPER - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F3505300 FLANGE SCREW - HEX M6 X - - X 16 LONG X GR 8.8 4

2 2 F7125013 BRACKET INNER ACCL PEDAL MOUNTING 1

3 3 F7125113 BRACKET OUTER ACCL PEDAL MOUNTING 1

4 - L2010825 SCREW M8 X 25 X 1.25 3

5 - L4010800 WASHER 8 DIA 3

6 LO CAB MOUNTING

7 B5444604 ASSEMBLY OF CAB MOUNTING 1 COMPRISES OF(SL.NOs.8,9,10,11,12,13,14)

8 4 L2011240 SCREW M12 X 40 X 1.75 8

9 5 L2010820 SCREW M8 X 20 X 1.25 2

10 6 X4900810 HARDENED WASHER 12DIA 4

11 - L1010811 BOLT 1

12 7 F7600222 BRACKET CAB PIVOT UPPER 1

13 7 F7600322 BRACKET CAB PIVOT UPPER 1

14 8 F7427600 PRESSURE PAD TORSION 2

15 LO INTERNAL BULL BAR

16 B5444605 ASSEMBLY OF INTERNAL BULL BAR 1 COMPRISES OF(SL.NOs.17,18,19,20,21)

17 - L4110800 SC WASHER 8 DIA 4

ACCL PEDAL, CAB MOUNTING, INTERNAL BULL BAR AND FRONT BUMPER - A0Y25400 - ALCAB172 427
 428

ACCL PEDAL, CAB MOUNTING, INTERNAL BULL BAR AND FRONT BUMPER - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - L4010800 WASHER 8 DIA 4

19 - L2010830 SCREW M8 X 30 X 1.25 4

20 9 B5429816 INTERNAL BULL BAR 1

21 - L3010818 NUT M8 X PC 8 X 1.25 4

22 - F1L00310 BRACKET - INTERNAL BULL BAR 2

23 - B5429820 INTERNAL BULL BAR 1

24 LO FRONT BUMPER

25 B5412631 ASSEMBLY OF FRONT BUMPER 1 COMPRISES OF(SL.NOs.26,27,28,29,30,31,32)

26 10 F7600113 BAR FRONT BUMPER 1

27 - F4953110 WASHER 4

28 11 F0842710 CLIP 2

29 - L2011235 SCREW M12 X 35 X 1.75 4

30 12 F7613460 FAIRING FRONT BUMBER RH 1

31 13 FE000110 RIVET BLIND DOMED ALUMINIUM 6

32 - F7613560 COVER FRONT BUMPER L.H. 1

STEP PANEL LOWER & STEP CAB ENTRY - A0Y25400 - ALCAB172 429
 430

STEP PANEL LOWER & STEP CAB ENTRY - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - ASSEMBLY OF STEP CAB ENTRY 1 NSS

2 1 F7873210 HEX SCREW 20

3 2 F4949110 WASHER 4

4 3 F7877900 INSULATOR - BODY 2

5 4 F7878000 INSULATOR - BODY 4

6 5 F4956110 LOCK WASHER 16

7 6 F7878100 INSULATOR - BODY 2

8 - L2010820 SCREW M8 X 20 X 1.25 4

9 7 F7878300 INSULATOR FRONT 2

10 - F7874550 SUPP ASSEMBLY BODY SIDE 1

11 8 F7874450 SCREW HEX 1

12 9 F7722110 SUPPORT BODY SIDE STEP LOW 2

13 10 F8702613 BOTTOM FOOT STEP - LH 1

14 11 F8702713 BOTTOM FOOT STEP - RH 1

15 - F7874400 SUPPORT ASSEMBLY BODY 1

16 - F7424550 STEP COVER FOOT 2

17 12 F7878200 INSULATOR - BODY SIDE 2

STEP PANEL LOWER & STEP CAB ENTRY - A0Y25400 - ALCAB172 431
 432

STEP PANEL LOWER & STEP CAB ENTRY - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 13 F4952810 WASHER 19 OD X 8.4 ID X 3 T 22

19 - L2010825 SCREW M8 X 25 X 1.25 8

DOORS (BIW) - A0Y25400 - ALCAB172 433
 434

DOORS (BIW) - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - S/A OF DOOR LH 1 NSS

2 1 F4650510 MIRROR MOUNTING BRACKET 1

3 2 B5412512 DOOR ASSEMBLY LH 1

4 2 B5425548 S/A OF RH DOOR 1

5 3 F7119513 CLAMP FITMENT BRACKET 1

6 3 F7119513 CLAMP FITMENT BRACKET 1

7 4 F7119413 HINGE FITMENT BRACKET 2

8 4 F7119413 HINGE FITMENT BRACKET 2

9 5 X3023513 S/A STIFFENER QTR WINDOW LH AND RH 1

10 5 X3023413 S/A OF STIFFENER QTR WINDOW LH/RH 1

11 - S/A OF DOOR RH 1 NSS

UNDER BODY (BIW) - A0Y25400 - ALCAB172 435
 436

UNDER BODY (BIW) - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B0Y02504 ASSY OF UNDERBODY 1

2 2 B5541410 S/A OF REINF BDY ROCKER PANEL 1

3 2 B5541409 S/A OF REINF BODY ROCKER PANEL 1

4 3 B5425531 S/A OF PAN FLR SIDE LH 1

5 3 B5541404 S/A OF PAN FLR SIDE RH - RHD 1

6 4 B0Y02514 SUB ASSY OF HEAD LAMP PANEL RH 1

7 4 B0Y02513 SUB ASSY OF HEAD LAMP PANEL LH 1

8 - F2801213 REINF FLOOR SEAT 1

9 - F3051513 MEMBER REAR FLOOR 2

10 5 B5425545 S/A OF REINF BODY FR INNER RH 1

11 - F2801313 REINF FLOOR LH A POST 1

12 - F3040713 MEMBER REAR FLOOR 1

13 - F3054513 MEMBER REAR FLOOR 1

14 6 B5425532 S/A OF MEMBER FRONT FLR CROSS 1

15 7 B0Y02418 SUB ASSY OF MEMBER FRONT FLOOR CROSS REAR 1

16 - F3041913 PAN FRONT CENTRE ASSEMBLY 1

17 - F3044213 PLATE BODY PIVOT 2

UNDER BODY (BIW) - A0Y25400 - ALCAB172 437
 438

UNDER BODY (BIW) - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 8 F3052613 BRACKET BODY ROCKER 1

19 9 B5541449 S/A OF MBR RR FLR CROSS 1

20 10 F3034513 PANEL BODY ROCKER 1

21 11 F3034413 PANEL BODY ROCKER 1

22 12 B5541407 S/A OF REINF BODY FRONT INNR 1

23 - X2800313 REINF FLOOR SEAT 1

24 - F8015000 CLinch FLANGE SEALANT 1

25 13 F3049513 BRACKET ASSEMBLY FRONT FENDER MTG REAR 2

26 - B5541411 S/A OF PNL HEAD LAMP 1

27 - B5541401 S/A OF PNL HEAD LAMP 1

28 - B5583105 S/A OF PAN REAR FLOOR CENTRE 1

29 - F7874410 PLUG SPECIAL - SLOT 11

30 - B5402926 S/A OF MBR RR FLR CROSSS FRONT 1

ROOF WITH SIDE RAILS - A0Y25400 - ALCAB172 439
 440

ROOF WITH SIDE RAILS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B5425534 S/A OF ROOF WITH SIDE RAILS 1

2 1 B5541434 S/A OF RAIL ROOF SIDE OUTER 1

3 1 B5425535 S/A OF RAIL ROOF SIDE OUT LH 1

4 2 B5412513 ROOF PANEL ASSEMBLY 1

FLOOR CARPETS - A0Y25400 - ALCAB172 441
 442

FLOOR CARPETS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B0Y02411 ASSY OF FLOORMAT RHD (PVC AND FOOTMAT) 1

2 2 F7606560 PLATE FRONT SCUFF 1

3 2 F7606460 PLATE FRONT SCUFF 1

4 3 F7606760 PLATE REAR SCUFF 1

5 3 F7606660 PLATE REAR SCUFF 1

6 4 F7874330 SHEET - METAL SCREWS TYPE AB 14

7 5 F5J00600 PVC FLOORMAT 8inch TUNNEL RHD 1

8 6 F5J00153 FOOT MAT 1

9 7 B5412689 ASSIST HANDLE 1

10 - B5412253 HANDLE 1

11 8 Y6310814 SCREW M8X14 RH 4

12 - B5412252 HANDLE LH 1

13 - L3010618 NUT M6 X PC 8 X 1 2

14 - F4955510 WASHER 17 OD X 6.4 ID X 2.5 T 2

15 9 B5412251 ASSY OF NUT& PLATE 4

16 10 L4010800 WASHER 8 DIA 4

DOOR TRIMS - A0Y25400 - ALCAB172 443
 444

DOOR TRIMS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - ASSY OF DOOR TRIMS 1 NSS

2 1 B5412270 HANDLE ASSY 2

3 2 F7961014 BRKT DOOR CHECK ARM 1

4 2 F7961214 BRKT DOOR CHECK ARM 1

5 3 F3566510 SCREW SHEET METAL 10

6 - L4110600 SC WASHER 6 DIA 4

7 4 F7961714 RETAINER DOOR LATCH 2

8 5 X7803800 REGULATOR ASSY RH 1

9 5 X7803900 REGULATOR ASSY LH 1

10 6 F7874680 RIVET BLD DOMED ALUM 2

11 7 F7962510 NUT PLATE DOOR PUL 2

12 B5425537 DOOR LOCK ASSY KIT RH / LH 1 COMPRISES OF(SL.NOs.13,14)

13 8 B5425553 DOOR LOCK ASSY LH 1

14 8 B5425552 DOOR LOCK ASSY RH 1

15 9 F7610960 HANDLE ASSY - DOOR 2

16 10 B5583111 ARM ASSY - DOOR CHECK 1

17 10 B5583112 ARM ASSY - DOOR CHECK 1

DOOR TRIMS - A0Y25400 - ALCAB172 445
 446

DOOR TRIMS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 11 F3541610 NUT RETAINER 2

19 12 F7601460 PAD DOOR LOCK CYLINDER 2

20 13 F3541710 NUT EXP PLAS 8

21 14 F7870680 SCREW 6

22 15 F4955310 WASHER 2

23 16 F7606160 ESEUTCHEE - DR WDW 2

24 17 F7865800 GUIDE - ASSY DOOR 2

25 18 F7600515 LINK ASSY - LH 1

26 19 F7600215 PAD - DOOR LATCH STRIKE 2

27 20 F4950360 WASHER DISHED STL 2

28 21 F7872000 PLUG - PANEL PLASTIC 6

29 22 F7870840 PAN SCREW 14

30 23 F7617360 GRAB HANDLE 2

31 24 L2010510 SCREW M5 X 10 X 0.8 CP 2

32 25 F4931750 WEATHER STRIP ASSY 2

33 26 F7605160 SEEL DOOR PANEL 2

34 27 L4010600 WASHER 6 DIA 14

DOOR TRIMS - A0Y25400 - ALCAB172 447
 448

DOOR TRIMS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 28 F3514100 LOCK SCREW 2

36 29 F7600315 LINK ASSY - RH 1

37 30 F7874060 SCREW ASSY 8

38 31 F7606260 COVER DOOR WDW 2

39 32 F7604060 PAD DOOR O/S HANDLE 2

40 33 F4951910 WASHER BOWED 2

41 34 L4010600 WASHER 6 DIA 4

42 - L3010618 NUT M6 X PC 8 X 1 4

43 35 L3110618 M6 LOCKNUT 4

44 36 F6B00168 DOOR TRIM LH 1

45 36 F6B00268 DOOR TRIM RH 1

46 37 F7606060 HOUSING DOOR INSIDE 2

47 - F7604260 PAD DOOR REMOTE CONT 2

48 - F4134360 TAPE DOOR SEAL 1

49 38 X3001313 SUPPORT PLATE - WWM 2

50 - F6B00410 FEMALE PLUG DIA 8.2 14

51 - F7873850 SCREW M6X40 4

DOOR TRIMS - A0Y25400 - ALCAB172 449
 450

DOOR TRIMS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

52 B5425520 S/A OF ROD - INNER LOCK 1 COMPRISES OF(SL.NOs.53,54,55)

53 39 F1104260 KNOB - INNER LOCK 1

54 40 F1104160 SLEEVE - INNER LOCK 1

55 41 F3301510 ROD - INNER LOCK 1

56 B5425568 S/A OF ROD RH 1 COMPRISES OF(SL.NOs.57,58,59)

57 39 F1104260 KNOB - INNER LOCK 1

58 40 F1104160 SLEEVE - INNER LOCK 1

59 41 F3301710 ROD - INNER RH 1

60 42 F7874270 SCREW 2

61 43 F4955510 WASHER 17 OD X 6.4 ID X 2.5 T 4

LAMPS AND SIGNALS - A0Y25400 - ALCAB172 451
 452

LAMPS AND SIGNALS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B0Y04748 ASSEMBLY OF LAMPS WITH BULB TYPE INTERIOR LAMP AND 1

ROUND HEADLAMP

2 1 F1L00514 BRACKET INNER LH ROUND HEAD LAMP MOUNTING 1

3 2 L3010618 NUT M6 X PC 8 X 1 2

4 3 F3542710 SPRING NUT 4

5 4 L4010600 WASHER 6 DIA 2

6 - F4951510 WASHER 2

7 5 F1L00614 BRACKET INNER RH HEAD LAMP MOUNTING 1

8 - F4950810 WASHER 8

9 6 L4010400 WASHER 4 DIA 4

10 7 L6010620 PHILIPS SCREW M6 4

11 8 X7819600 ROOF MARKER LAMP 2

12 9 F9E03500 ROUND HEAD LAMP ASSEMBLY SMART 2

13 10 L2010615 SCREW M6 X 15 X 1 CP 2

14 11 F1L00314 BRACKET OUTER LH ROUND HEAD LAMP MOUNTING 1

15 12 L4010600 WASHER 6 DIA 2

16 13 B5412522 INTERIOR LAMP ASSEMBLY 1

17 - FM866700 INTERIOR LAMP HARNESS 1

LAMPS AND SIGNALS - A0Y25400 - ALCAB172 453
 454

LAMPS AND SIGNALS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - L6010620 PHILIPS SCREW M6 2

19 - L6010520 PHILIPS PAN SC M5 X 20 8

20 - L4110500 SC WASHER 5 DIA 8

21 - F3541510 NUT 8

22 14 F1L00414 BRACKET OUTER RH ROUND HEAD LAMP MOUNTING 1

23 15 F9E03600 Front Turn signal ASSEMBLY 1

24 - L3010518 NUT M5 X PC 8 X 0.8 8

25 16 F9E05600 FRONT TURN SIGNAL RH 1

26 - F7874330 SHEET - METAL SCREWS TYPE AB 8

27 17 F3560410 SCREW - SLOTTED SNAP M8 X 13 LONG 4

28 18 L3010418 NUT M4 X PC 8 X 0.7 CP PLATED 4

29 19 L2010415 SCREW M4 X 15 X 0.7 CP PLATED 4

30 20 L4110400 SC WASHER 4 DIA PLATED 4

31 21 F9E16600 SIDE REPEATER LAMP LH/RH 2

INSTRUMENT PANEL, CENTER CONSOLE - A0Y25400 - ALCAB172 455
 456

INSTRUMENT PANEL, CENTER CONSOLE - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B0Y18302 ASSEMBLY OF INST PANEL FOR INST CLUSTER 1

2 1 F3560410 SCREW - SLOTTED SNAP M8 X 13 LONG 3

3 2 F3542710 SPRING NUT 3

4 3 F3542710 SPRING NUT 4

5 - F3560410 SCREW - SLOTTED SNAP M8 X 13 LONG 4

6 4 L4010400 WASHER 4 DIA 3

7 5 L4010400 WASHER 4 DIA 4

8 6 F7872300 RETAINER Q/TNFSTN 2

9 7 FA902368 SHROUD - INSTRUMENT CLUSTER 1

10 8 F7601015 LUG CONSOLE DUMMY 4

11 - L4010400 WASHER 4 DIA 8

12 9 F3527110 RIVET AVDAL 12

13 10 L3010518 NUT M5 X PC 8 X 0.8 4

14 11 F7975310 BRACKET - CONSOLE MTG 4

15 12 B0Y04718 SUB ASSY OF CLUSTER MTG PLATE 1

16 LO CENTER CONSOLE L2

17 - B0Y04725 ASSY OF CENTER CONSOLE L2 1

INSTRUMENT PANEL, CENTER CONSOLE - A0Y25400 - ALCAB172 457
 458

INSTRUMENT PANEL, CENTER CONSOLE - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - F7625360 PANEL SWITCH 1

19 13 F5T00678 UTILITY BOX 1

20 - Y6110412 PAN SCREW - M14X12 6

21 - F7619460 CONSOLE ASSEMBLY INSTRUMENTAL PANNEL TRIM 1

22 - F7607360 PLUG SWITCH HOLE 4

23 - L2010620 SCREW M6 X 20 X 1 CP 1

24 14 F5J00413 COIN HOLDER 2

25 - F7619260 PLUG ROTARY SWITCH 2

26 - F7872300 RETAINER Q/TNFSTN 4

27 - L4010400 WASHER 4 DIA 4

28 15 F5J01800 UTILITY BOX SMALL 2

29 16 F8038500 GLOVE BOX COMPARTMENT 1

30 - F6N08600 12V POWER SOCKET 1

CABIN WIRING HARNESS - A0Y25400 - ALCAB172 459
 460

CABIN WIRING HARNESS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - ASSY OF WIRING HARNESS 1 NSS

2 1 F8825100 MICRO RELAY - NO TYPE 12V/20A 6

3 2 L4010500 WASHER 5 DIA 2

4 3 L4310600 I - STAR WASHER 6 DIA 2

5 4 F0830540 SCHEDULE OF CLIPS 1

6 5 L4010600 WASHER 6 DIA 2

7 6 F4952810 WASHER 19 OD X 8.4 ID X 3 T 2

8 7 F7872580 CLIP PIPE - EDGE 1

9 8 L6010520 PHILIPS PAN SC M5 X 20 2

10 9 F7874130 CLIP ASSY - PIPE PNL 2

11 - FM839900 MAIN WIRING HARNESS 1

12 10 FJ101000 MICRO RELAY 2

13 11 L2010615 SCREW M6 X 15 X 1 CP 2

14 12 L2010825 SCREW M8 X 25 X 1.25 1

15 13 F7874110 CLIP - HOSE SUPPORT 1

16 14 F0845214 STRAP - SPECIAL OLAS 15

17 15 F0615200 W/H JUMPER ROOF MARK 2

CABIN WIRING HARNESS - A0Y25400 - ALCAB172 461
 462

CABIN WIRING HARNESS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 16 FM704700 HARNESS AUDIO SYSTEM 1

19 17 FM849000 PIGTAIL HARNESS FOR REVERSE SWITCH 1

20 - FM816100 MAIN ROOF MARKER HARNESS 1

WIPING AND WASHER SYSTEM - A0Y25400 - ALCAB172 463
 464

WIPING AND WASHER SYSTEM - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 LO WIPER ASSY RHD 12 VOLTS

2 - WIPER ASSEMBLY RHD 1 NSS

3 1 X5X01100 WIPER LINKAGE AND BRACKET ASSY 1 PCIN UPDATES

4 B5412588 S/A OF WIPER ARM & BLADE 2 COMPRISES OF(SL.NOs.5,6)

5 2 F7859700 BLADE ASSEMBLY WINDSHIEL 1

6 3 F7859600 ARM ASSY WINDSHIELD WIPER 1

7 4 F3542410 NUT & CAGE ASSY 2

8 5 X5X01200 12V 26NM WIPER MOTOR 1 PCIN UPDATES

9 LO WIND SHILD WASH UNIT

10 - B0Y04746 ASSY OF WIND SHIELD WASH 1

11 6 F0830540 SCHEDULE OF CLIPS 1

12 7 F3542810 CAGE NUT M6 1

13 - L3010618 NUT M6 X PC 8 X 1 1

14 - F3541610 NUT RETAINER 2

15 - F7962510 NUT PLATE DOOR PUL 2

16 8 F0845214 STRAP - SPECIAL OLAS 4

17 9 F4955510 WASHER 17 OD X 6.4 ID X 2.5 T 1

WIPING AND WASHER SYSTEM - A0Y25400 - ALCAB172 465
 466

WIPING AND WASHER SYSTEM - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 10 L2010620 SCREW M6 X 20 X 1 CP 1

19 11 F7617360 GRAB HANDLE 1

20 12 X5B00600 12V WINDSHIELD WASHER UNIT 1 PCIN UPDATES

21 - L6010625 PHILIPS SCREW M6 2

FRONT PANEL TRIMS - A0Y25400 - ALCAB172 467
 468

FRONT PANEL TRIMS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - S/A BRACKET BODY FRONT TRIM 1 NSS

2 1 X1700750 RUBBER GASKET - HINGE OPENING 2

3 - L2010620 SCREW M6 X 20 X 1 CP 12

4 2 F3046013 BRACKET BODY FRONT TRIM 2

5 - F7874660 RIVET BLD DOMED ALUM 1

6 3 X3021913 MIRROR BRACE - REINF-BRKT - RH 1

7 4 F3046213 BODY LOCK PILLER UPPER REINF 1

8 4 F3046113 REINF BODY LOCK PILL 1

9 - B5412265 HINGE ASSY DOOR LOWER 2

10 5 X3012013 STRIP PANEL BODY SID 2

11 6 X7900710 HINGE ASSY - LH 1

12 7 X7900810 HINGE ASSY - RH 1

13 8 F3046613 BRACKET ASSEMBLY BODY MOUNTING 1

14 - F4949660 WASHER 2

15 9 F3045213 BRKT ROOF BOW TO HEADER 2

16 10 F3565510 SCREW ASSY 24

17 11 X3022713 MRROR BRACE - REIN BRAKET / LH 1

FRONT PANEL TRIMS - A0Y25400 - ALCAB172 469
 470

FRONT PANEL TRIMS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 12 B5426409 S/A OF FOOT STEP LH 1

19 12 B5426408 S/A OF FOOT STEP RH 1

20 13 B5434104 ASSEMBLY OF FRONT BODY PANEL 1

21 - B5421522 S/A OF ROOF MARKER LAMP BRACKET 1

22 14 X3022113 ROOF MARKER LAMP MOUNTING BRACKET - RH 1

23 15 F3039413 PANEL FRONT BODY UPPER 1

24 16 B5427328 S/A OF PILLAR FR BODY INNER LH 1

25 16 B5427327 S/A OF PILLAR FR BODY INNER RH 1

26 17 B5583114 S/A OF PLR FRONT BDY LWR LH 1

27 17 B5583113 S/A OF PILLAR FRNT BDY PLRLWR RH 1

28 18 F3034740 NUMBER PLATE CAB 1

29 19 F7874660 RIVET BLD DOMED ALUM 2

30 20 B5421524 DASH PANEL SUB ASSEMBLY 1

31 21 F3037713 PILLAR FRONT BODY 1

32 - B5541420 S/A OF PILLER BODY INNER 1

33 - F3039013 PANEL ROOF HEANDER I 1

34 - B5541416 S/A OF DASH PANEL 1

REAR TRIM, ROOF TRIM & ASSIST HANDLE - A0Y25400 - ALCAB172 471
 472

REAR TRIM, ROOF TRIM & ASSIST HANDLE - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 LO REAR TRIM

2 - B0Y04729 ASSY OF REAR TRIM 1

3 1 FR700700 TRIM PLUG 8

4 2 FR700188 REAR TRIM JUTE COMPOSITE 1

5 3 L2010515 SET SCREW M5 - 15LG 2

6 4 F4955510 WASHER 17 OD X 6.4 ID X 2.5 T 2

7 5 L3010518 NUT M5 X PC 8 X 0.8 2

8 LO ROOF TRIM

9 - B5425513 ASSEMBLY OF ROOF TRIMS 1

10 6 X7801260 SIDE PANEL LH 1

11 7 FR700700 TRIM PLUG 23

12 8 X7820800 SUNVISOR 1

13 - F7870060 SCREW - SLOTTED SNAP M8 X 0 X 19 LONG X 0 4

14 9 FR700700 TRIM PLUG 4

15 - F7870180 NUT 4

16 10 X7820900 SUNVISOR 1

17 11 FR700288 ROOF TRIM 1

REAR TRIM, ROOF TRIM & ASSIST HANDLE - A0Y25400 - ALCAB172 473
 474

REAR TRIM, ROOF TRIM & ASSIST HANDLE - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 12 X7801360 SIDE PANEL 1

REAR AND SIDE PANEL TRIMS - A0Y25400 - ALCAB172 475
 476

REAR AND SIDE PANEL TRIMS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - B5438612 ASSEMBLY OF REAR PANEL 1

2 1 B5541423 S/A BODY LOCK PILLR RH 1

3 1 B5541425 S/A BODY LOCK PILLR LH 1

4 2 B5541428 S/A OF PILLER BODY LOCK 1

5 2 B5541427 S/A OF PILLER BODY LOCK 1

6 3 F3039113 RAIL ROOF REAR INNER 1

7 4 B5438613 S/A OF REAR PANEL 1

8 5 B5427334 S/A OF REINF BODY LOCK PLR RH 1

9 5 B5427335 S/A OF REINF BODY LOCK PLR LH 1

FENDER - A0Y25400 - ALCAB172 477
 478

FENDER - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 LO BODY FORNT FENDER RH

2 1 B5435404 S/A BODY FRONT FENDER RH 1

3 2 ADDL REINF - TO FALSE PANEL 2 NSS

4 3 REINF - TO FALSE PANEL 2 NSS

5 4 REINF FRONT FENDER 2 NSS

6 5 F3012913 SHIELD - FENDER RH 1

7 6 F7605113 FRONT FENDER - RH 1

8 7 F3051613 REINF FRONT 3

9 LO BODY FORNT FENDER LH

10 1 B5435405 S/A BODY FENDER FRONT lH 1

11 2 ADDL REINF - TO FALSE PANEL 2 NSS

12 3 REINF - TO FALSE PANEL 2 NSS

13 4 REINF FRONT FENDER 2 NSS

14 5 F3013013 SHIELD - FENDER LH 1

15 6 F7605013 FRONT FENDER - LH 1

16 7 F3051613 REINF FRONT 3

HOOD - A0Y25400 - ALCAB172 479
 480

HOOD - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B0Y02406 ASSY OF HOOD SHELL 1

2 2 F3049313 BRKT HOOD SUPPORT ROD 1

3 - F8014800 METAL TO METAL ADHESIVE 1

4 - F8015000 CLinch FLANGE SEALANT 1

5 - F8014900 EPOXY WELD THRO SEAL 1

6 3 B5541466 S/A BRKT HOOD HINGE MTG 2

7 4 F3034013 PANEL HOOD INNER 1

8 5 F3033913 PANEL HOOD OUTER 1

SUNDRIES AND MISCELLANEOUS - A0Y25400 - ALCAB172 481
 482

SUNDRIES AND MISCELLANEOUS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 - X1131050 GROMMET 1

2 B5412630 ASSEMBLY OF PIPE AND BRACKETS 1 COMPRISES OF(SL.NOs.3,4)

3 1 X0495510 BRACKET PIPE CLAMPING 1

4 2 L2010612 SCREW M6 X 12 X 1 CP PLATED 1

5 - B5444606 ASSEMBLY OF HEATER MOUNTING SLOT FASTENERS AND 1

NOZZLE

6 3 F4952810 WASHER 19 OD X 8.4 ID X 3 T 5

7 - L2010825 SCREW M8 X 25 X 1.25 4

8 - L2010820 SCREW M8 X 20 X 1.25 1

9 - L2010835 SCREW M8 X 35 X 1.25 2

10 4 F7611760 NOZZLE - WINDSHIELD 4

11 5 F3542410 NUT & CAGE ASSY 1

12 - L4310800 M8 S.I. WASHER 6

13 - B0Y04747 ASSY OF MISC COMPONENTS 1

14 - L4010600 WASHER 6 DIA 2

15 - L4010500 WASHER 5 DIA 8

16 6 F8E01050 RUBBER GROMMET 1

17 - L4010800 WASHER 8 DIA 4

SUNDRIES AND MISCELLANEOUS - A0Y25400 - ALCAB172 483
 484

SUNDRIES AND MISCELLANEOUS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - L4010600 WASHER 6 DIA 5

19 - L3010818 NUT M8 X PC 8 X 1.25 4

20 - L2010515 SET SCREW M5 - 15LG 8

21 - L4010600 WASHER 6 DIA 2

22 - F3540410 SPECIAL NUT - M6 X 1CP X 14.6mm LONG X GR 2

23 7 F7956614 BRACKET 1

24 8 B0Y04741 HANDLE CAB TILTING RH 1

25 - L6010635 PHILIPS SCREW M6X35MM L 4

26 - L3010618 NUT M6 X PC 8 X 1 2

27 - L2010820 SCREW M8 X 20 X 1.25 1

28 9 F7603300 FOOT REST 1

29 - L2010620 SCREW M6 X 20 X 1 CP 2

30 - L4010800 WASHER 8 DIA 4

31 - L4010600 WASHER 6 DIA 1

32 10 F7617360 GRAB HANDLE 2

33 - L4010800 WASHER 8 DIA 1

34 - L6010625 PHILIPS SCREW M6 6

SUNDRIES AND MISCELLANEOUS - A0Y25400 - ALCAB172 485
 486

SUNDRIES AND MISCELLANEOUS - A0Y25400 - ALCAB172

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 - L6010620 PHILIPS SCREW M6 1

36 - L2010415 SCREW M4 X 15 X 0.7 CP PLATED 2

37 - L6010650 PHILIP SCREW 2

38 - F7124910 BRACKET GRAB HANGLE 4

39 - L3010618 NUT M6 X PC 8 X 1 1

40 - L4110600 SC WASHER 6 DIA 2

41 11 F7100260 GRAB HANDLE 1

42 12 B0Y04717 ASSY OF ECU MTG PLATE 1

43 - B0Y04726 ASSY OF BOLSTER 1

44 - L3010618 NUT M6 X PC 8 X 1 2

45 13 F7962114 PLATE - SUPPORT ASSY 1

46 14 F5T00760 BOLSTER COVER - HIGH TUNNEL CARGO CAB 1

47 - L4010600 WASHER 6 DIA 4

48 - L4010600 WASHER 6 DIA 2

49 - L6010620 PHILIPS SCREW M6 4

50 15 B0Y04720 BOLSTER MOUNTING BKT 2

LOAD BODY MOUNTING BRACKET - A0T18500 - ALBS184 487
 488

LOAD BODY MOUNTING BRACKET - A0T18500 - ALBS184

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 FC182014 CLEAT PLATE 2

2 B0T13908 ASSY OF BODY MOUNTING BRACKET - 4 POINT 6 COMPRISES OF(SL.NOs.3,4,5,6,7)

3 2 F4N57514 TOP MOUNTING BRACKET 1

4 3 F4N57614 BOTTOM MOUNTING BRACKET - 4 POINT 1

5 4 F3521511 FLANGE SCREW - HEX M12 X 1.75 CP X 35 LONG 6

6 5 X3503410 NUT 6

7 6 L4011200 WASHER 12 DIA 2

8 B0T13910 SUBFRAME CHASSIS MOUNTING BRACKET ASSEMBLY 4 COMPRISES OF(SL.NOs.9,10,11,12,13,14)

9 7 F4N60114 CHASSIS MOUNTING BRACKET 1

10 8 F3600214 COMPRESSION SPRING 2

11 9 F4N59614 SUB FRAME MOUNTING BRACKET 1

12 10 L1011220 BOLT 2

13 11 F4N60214 COLLAR 2

14 12 F3522811 FLANGE NUT - HEX M12 X 1.75 CP 11.79 LONG X GR10 4

CHASSIS ELECTRICALS - A2H15200 - ALCEL79 489
 490

CHASSIS ELECTRICALS - A2H15200 - ALCEL79

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F1137650 GROMMET 1

2 2 F0417110 TAIL LAMP MOUNTING BRACKET 2

3 3 F7873960 GROMMER RUBBER 2

4 4 F8167600 EARTH STRAP 1

5 5 L2011022 SCREW M10 X 22 X 1.5 1

6 6 L3011018 NUT M10 X PC 8 X 1.5 1

7 7 F4954710 WASHER 10.5 ID 1

8 8 F0609000 WIRING ASSEMBLY STARTER SOLENOID INTER CONNECTION 1

9 9 F0845214 STRAP - SPECIAL OLAS 10

10 10 F7874110 CLIP - HOSE SUPPORT 2

11 11 L2021020 SCREW M10 X 20 X 1 FP PLATED 1

12 12 X3005810 PLATE 1

13 13 X0483110 REG PLATE BRACKET 2

14 14 F4L01660 SPEEDO CONNECTOR PROTECTIVE CAP 1

15 15 F0807710 CLIP 1

16 16 F6M00800 312 7.6mm - CABLE TIE - BLACK 5

17 17 F6M01300 CLAMP WITH RUBBERIZED/PVC SLEEVE - 25 mm 2

CHASSIS ELECTRICALS - A2H15200 - ALCEL79 491
 492

CHASSIS ELECTRICALS - A2H15200 - ALCEL79

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 18 F5J00163 FUSE BOX COVER 1

19 19 FM838000 CHASSIS WIRING HARNESS 1

20 20 FM717500 BATTERY CABLE +VE 1

21 21 X0801410 DOUBLE CLIP 2

22 22 FM838300 REAR WIRING HARNESS 1

23 - F3A04000 BATTERY NEGATIVE TO CHASSIS GND 1

24 23 FM859200 ENGINE WIRING HARNESS 1

25 24 F6M01200 CLAMP 17

26 25 F6M01500 CLAMP 2

27 26 X7172210 L BRACKET - ON LH FSM NEAR RSF CROSS MBR 2

28 27 FJ100600 SOLENOID VALVE 1

29 28 F8083000 TAIL LAMP ASSY 2

30 - F3A03400 STARTER MOTOR -VE TO CHASSIS GND 1

31 - F7873210 HEX SCREW 1

32 - F4949110 WASHER 1

33 - F6M01600 CLAMP 1
ELECTRONIC DIESEL CONTROL - A2J18700 - ALEDCS47 493
 494

ELECTRONIC DIESEL CONTROL - A2J18700 - ALEDCS47

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 B2J18701 SUB ASSY-ECU WITH DATASET 1

2 2 F6M01500 CLAMP 4

3 3 F8306000 MAIN RELAY 1

4 4 FM721300 EDC WIRING HARNESS 1

5 5 F0830540 SCHEDULE OF CLIPS 1

6 - L2010610 SET SCREW M6X1.0 1

7 6 F8314800 DIAGNOSTIC LAMP 1

8 7 F8313600 CLUTCH SWITCH 1

9 8 F8313500 BRAKE SWITCH 1

10 9 F0830640 SCHEDULE OF CLIPS 3

11 - L2010615 SCREW M6 X 15 X 1 CP 3

12 10 F0845214 STRAP - SPECIAL OLAS 15

13 - L4010600 WASHER 6 DIA 1

14 - L4111000 SC WASHER 10 DIA 1

15 - L2010625 SCREW M6 X 25 X 1 CP 4

16 - L4110600 SC WASHER 6 DIA 2

17 - F3585810 LOCK NUT 1

ELECTRONIC DIESEL CONTROL - A2J18700 - ALEDCS47 495
 496

ELECTRONIC DIESEL CONTROL - A2J18700 - ALEDCS47

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 - L4010600 WASHER 6 DIA 2

19 - L2011015 SCREW M10X1.5X15 1

20 - L4010600 WASHER 6 DIA 3

21 11 F0830840 SCHEDULE OF CLIPS 1

22 - L3010618 NUT M6 X PC 8 X 1 5

23 12 F0830840 SCHEDULE OF CLIPS 3

24 - L3010618 NUT M6 X PC 8 X 1 1

25 13 F8414210 BRACKET - CLUTCH SWITCH MOUNTING 1

26 - L4011600 WASHER 16 DIA 1

27 - L3010418 NUT M4 X PC 8 X 0.7 CP PLATED 2

28 - F4930140 SPECIAL WASHER 1

29 - L2011030 SCREW M10 X 30 X 1.5 2

30 - L2010415 SCREW M4 X 15 X 0.7 CP PLATED 2

31 - L4110400 SC WASHER 4 DIA PLATED 2

32 - L3010618 NUT M6 X PC 8 X 1 1

33 14 F6M01100 CABLE TIE - BLACK 315M 4.8 mm 5

34 - L3011018 NUT M10 X PC 8 X 1.5 2

ELECTRONIC DIESEL CONTROL - A2J18700 - ALEDCS47 497
 498

ELECTRONIC DIESEL CONTROL - A2J18700 - ALEDCS47

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 - L4111000 SC WASHER 10 DIA 2

36 15 F6M00800 312 7.6mm - CABLE TIE - BLACK 5

37 16 F6M00900 CABLE TIE - 551X9 mm 5

38 17 F6M01000 CABLE TIE - BLACK 8.00mm 5

39 18 F6M01100 CABLE TIE - BLACK 315M 4.8 mm 5

40 19 F6M00700 CABLE TIE - BLACK 153X3X6 mm 5

41 20 F6M01400 CLAMP WITH RUBBERIZED / PVC SLEEVE - 35 mm 4

42 21 F6M01300 CLAMP WITH RUBBERIZED/PVC SLEEVE - 25 mm 4

43 22 F6M01200 CLAMP 4
FRONT WHEEL - A5G04400 - ALFW209/37 499
 500

FRONT WHEEL - A5G04400 - ALFW209/37

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X5E00510 WHEEL 7X20 160MM OFFSET 2

2 2 F3569510 WHEEL NUT - M22 X 25 16

REAR WHEEL - A6Z04900 - ALRW209/52 501
 502

REAR WHEEL - A6Z04900 - ALRW209/52

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X5E00510 WHEEL 7X20 160MM OFFSET 2

2 2 F3569510 WHEEL NUT - M22 X 25 16

SPARE WHEEL - A7H04100 - ALSW209/28 503
 504

SPARE WHEEL - A7H04100 - ALSW209/28

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X5E00510 WHEEL 7X20 160MM OFFSET FLOW FORMING 1

CHASSIS STATUTORY ITEMS - A8600200 - HACSR1 505
 506

CHASSIS STATUTORY ITEMS - A8600200 - HACSR1

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 X0N02300 RFID TAG 1

2 2 F4105100 WARNING TRIANGLE 2

3 3 F4108700 WHEEL CHOKE 2

SPRAY SUPPRESSION DEVICE - A8607200 - ALSSD2 507
 508

SPRAY SUPPRESSION DEVICE - A8607200 - ALSSD2

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F1107960 TOP SUPPRESSION FRONT 2

2 - F1108260 BOTTOM SUPPRESSION - FRONT 2

3 - F1108760 SUPPRESSION - REAR TOP 1

4 - F1109260 SPRAY SUPPRESSION - TOP RH 1

5 - F1108960 SUPPRESSION - REAR BOTTOM 2

6 - F4600240 STIFFENER - SPRAY SUPPRESSOR 4

7 2 F4600440 STIFFENER - SPRAY SUPPRESSION 4

8 - F7122913 BRACKET SUPPRESSION MOUNTING 2

9 3 L2010825 SCREW M8 X 25 X 1.25 16

10 4 L4010800 WASHER 8 DIA 32

11 5 L3610818 NYLOC NUT 16

FRONT UNDER RUN PROTECTION DEVICE - A8I02400 - ALFUPD6/2 509
 510

FRONT UNDER RUN PROTECTION DEVICE - A8I02400 - ALFUPD6/2

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F3Y00914 FUPD BEAM 1

2 2 F3562810 NUT - HEX M14 X 2 CP X 12 LONG X GR 10 8

3 3 F3516710 SPL BOLT M14X2X40 LG 10.9 GRADE 8

4 4 L3011018 NUT M10 X PC 8 X 1.5 8

5 5 L4011000 WASHER 10 DIA 8

6 6 L1011008 BOLT 8

7 7 FR301914 FUPD MOUNTING BRACKET 2

8 8 L4011400 WASHER 14 DIA 8

LATERAL PROTECTION DEVICE - A5Z01000 - ALSPD40 511
 512

LATERAL PROTECTION DEVICE - A5Z01000 - ALSPD40

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F0D12413 LATERAL PROTECTION DEVICE - LH 1

2 2 B5Z01001 LATERAL PROTECTION DEVICE (RH SIDE) 1

3 3 F8600310 STAY SUPPORT - LPD 6

4 4 L2011035 SCREW M10 X 35 X 1.5 8

5 5 L3011018 NUT M10 X PC 8 X 1.5 8

6 6 L4011000 WASHER 10 DIA 16

7 7 L4111000 SC WASHER 10 DIA 8

8 8 L2010825 SCREW M8 X 25 X 1.25 12

9 9 L3010818 NUT M8 X PC 8 X 1.25 12

10 10 L4010800 WASHER 8 DIA 24

11 11 L4110800 SC WASHER 8 DIA 12

SUNDRIES AND FINISHES - A7V21200 - HASFS73 513
 514

SUNDRIES AND FINISHES - A7V21200 - HASFS73

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

1 1 F0830640 SCHEDULE OF CLIPS 1

2 2 F0845214 STRAP - SPECIAL OLAS 12

3 2 F0845214 STRAP - SPECIAL OLAS 46

4 - F4171800 RETRO REFLECTIVE TAPE - WHITE 2.20

5 - F4949110 WASHER 12

6 - F4953710 WASHER 6

7 4 F4700600 HYDRAULIC JACK 1

8 5 F1204115 DISTANCE PIECE 1

9 6 F0845214 STRAP - SPECIAL OLAS 5

10 7 F0831810 CLIP 1

11 8 B8027703 S/A OF AIR BREATHER HOSE - 600mm 1

12 - L2050609 SET SCREW 3/8 inch BSF 11/8 inch LONG 12

13 9 L3811018 CLEVELOC NUT M10 X PC 8 X 1.5 6

14 - L4110600 SC WASHER 6 DIA 1

15 - L4111000 SC WASHER 10 DIA 1

16 10 X0476810 BRKT - SPEEDO CABLE 1

17 11 X4100315 RING - KEY SET 1

SUNDRIES AND FINISHES - A7V21200 - HASFS73 515
 516

SUNDRIES AND FINISHES - A7V21200 - HASFS73

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

18 12 F6X00188 FENDER LH 1

19 13 F8952814 BRACKET FRONT FENDER REAR UPPER LH 1

20 14 FF200113 DRAIN WATER GUARD 1

21 15 L2011015 SCREW M10X1.5X15 2

22 16 F6X00288 FENDER RH 1

23 17 X3003140 PLATE - KEY TAG 1

24 - L4200600 WASHER 12

25 - L4110800 SC WASHER 8 DIA 1

26 - L4011000 WASHER 10 DIA 1

27 - L3010818 NUT M8 X PC 8 X 1.25 1

28 - L2021020 SCREW M10 X 20 X 1 FP PLATED 8

29 18 F7874050 GROMMET SPEEDO CABLE 1

30 - L1011012 BOLT 1

31 - L2010620 SCREW M6 X 20 X 1 CP 1

32 - L2010825 SCREW M8 X 25 X 1.25 1

33 - L2010825 SCREW M8 X 25 X 1.25 6

34 19 F7423300 SAFETY REFLECTOR 2

SUNDRIES AND FINISHES - A7V21200 - HASFS73 517
 518

SUNDRIES AND FINISHES - A7V21200 - HASFS73

SL. ITEM
PART NO DESCRIPTION QTY REMARKS
NO. NO.

35 20 F7102413 BRKT ASSEMBLY 1

36 21 F7102513 BRKT ASSEMBLY 1

37 22 F8952914 BRACKET FRONT FENDER REAR UPPER RH 1

38 23 L2010830 SCREW M8 X 30 X 1.25 6

39 24 L2011035 SCREW M10 X 35 X 1.5 6

40 - F4953710 WASHER 8

41 - L4011000 WASHER 10 DIA 4

42 - B5810502 ASSY OF TOOL KIT - OPTIMISED 1

43 - F4736000 WHEEL NUT STAINER 1

44 - F4701311 TOMMY BAR 1

No.1, Sardar Patel Road, Guindy, Chennai - 600 032. www.ashokleyland.com, https://www.catalogger.in