D ATA SH EET MOTIVE 31-AES

MODEL 31-AES
VOLTAGE 12
CAPACITY 102Ah @ 20Hr
MATERIAL Polypropylene
BATTERY VRLA AGM / Non-Spillable / Maintenance-Free
COLOR Maroon
WATERING No Watering Required

12 VOLT
PHYSICAL SPECIFICATIONS
BCI MODEL NAME TERMINAL TYPE DIMENSIONS C INCHES (mm) WEIGHT I LBS. (kg) HANDLES INSTALLATION ORIENTATION

LENGTH WIDTH HEIGHT F

Horizontal
29 31-AES M8/DT 69 (31) Plastic Handle
12.80 (325) 6.81 (173) 9.37 (238) and Vertical

ELECTRICAL SPECIFICATIONS
CAPACITY A
VOLTAGE CRANKING PERFORMANCE CAPACITY B AMP-HOURS (Ah) ENERGY (kWh) INTERNAL RESISTANCE (mΩ) SHORT CIRCUIT CURRENT (amps)
MINUTES
C.C.A. @0°F
D
C.A. @32°F
E
@ 25 Amps 5-Hr 10-Hr 20-Hr 100-Hr 100-Hr
12 4.80 2555
657 788 180 82 - 102 - -

CHARGING INSTRUCTIONS CHARGING TEMPERATURE COMPENSATION

CHARGER VOLTAGE SETTINGS (AT 77°F/25°C) ADD SUBTRACT

SYSTEM VOLTAGE 12V 24V 36V 48V 0.005 volt per cell for every 1°C below 25°C 0.005 volt per cell for every 1°C above 25°C
0.0028 volt per cell for every 1°F below 77°F 0.0028 volt per cell for every 1°F above 77°F
Maximum Charge Current (A) 50% of C 20

Absorption Voltage (2.40 V/cell) 14.40 28.80 43.20 57.60 OPERATIONAL DATA

Float Voltage (2.25 V/cell) 13.50 27.00 40.50 54.00 OPERATING TEMPERATURE SELF DISCHARGE

-40°F to 140°F (-40°C to +60°C). At

Do not install or charge batteries in a sealed or non-ventilated compartment. Constant under Less than 3% per month depending on
temperatures below 32°F (0°C) maintain
or overcharging will damage the battery and shorten its life as with any battery. storage temperature conditions
a state of charge greater than 60%.

RECYCLE RESPONSIBLY STATE OF CHARGE MEASURE OF OPEN-CIRCUIT VOLTAGE

PERCENTAGE CHARGE CELL 12 VOLT

12V 100 2.14 12.84

AGM

75 2.09 12.54

50 2.04 12.24

25 1.99 11.94

0 1.94 11.64
 TROJAN 31-AES PERFORMANCE PERCENT CAPACITY VS. TEMPERATURE
7 100 6 6 5 5 4 4 3 3 2 140 2 1 1 60
ZONE ZONE DESCRIPTION
DESCRIPTION REV DATE
REV DATE
ESS
S: OTHERWISE
UNLESS SPECIFIED
OTHERWISE SPECIFIED
INITIALINITIAL
RELEASE; COR5928
RELEASE; COR5928 120 A 3/15/17
A 3/15/17 50

H H 40
MENSIONS ARE NOMINAL.
LL DIMENSIONS ARE NOMINAL. 100

SEAL MELTMELT
EAT SEAL = 0.100"
= 0.100" 80
30

Temperature (C) (C)

Temperature (F)
Discharge Time (Hrs)

20

Temperature (F)
Time (hrs)

60

Temperature
10 10
G G
40
0
20
-10

0
-20

-20 F F -30

1 -40 -40
1 10 100 0% 20% 40% 60% 80% 100% 120%

Current (amps) Percent

Percent of of Available
Available CapacityCapacity

E E

BATTERY DIMENSIONS (shown with DT) SELF DISCHARGE VS. TIME H

100 2.14

12.80 (325)
12.80 (325) 6.81 (173)6.81 (173) SCALE 0.500
SCALE 0.500
LENGTH LENGTH WIDTH WIDTH
D D 10°C (50°F)
80 2.10
Recharge Threshold @ 75% SOC
75 2.09

Open Circuit Voltage Per Cell

State of Charge %
60 2.06
25°C (77°F)
C C

40 40°C (104°F) 2.02

9.37 (238)9.37 (238) 30°C (86°F)
8.54 8.54 HEIGHT HEIGHT
7 6 5 4 3 2 1
(217) (217) ZONE DESCRIPTION REV DATE
NOTES: UNLESS OTHERWISE SPECIFIED
INITIAL RELEASE; COR5928 A 3/15/17
20 1.98
B B
H H
1. ALL DIMENSIONS ARE NOMINAL.
2. HEAT SEAL MELT = 0.100" 0
THIS DRAWING AND THIS
DATADRAWING
PROPRIETARY INFORMATION
IS THE CONFIDENTIAL
OF TROJAN BATTERY
EMBODY AND DATA EMBODY
WHICH
PROPRIETARY
IS PROPERTY
OF
INFORMATION WHICH
THE CONFIDENTIAL PROPERTY
COMPANY
TROJAN BATTERY COMPANY 1.94
WHICH SHALL NOT BE COPIED,
WHICH SHALL NOT BE COPIED,
0 2 4
REPRODUCED DISCLOSED
OTHERS OR USED INOTHERS
TO
REPRODUCED
WHOLE OR
6
DISCLOSED TO
OR USED IN WHOLE OR
8 10 12 14 16
PART FOR ANY PURPOSE
PART WITHOUT
FOR ANY PURPOSE WITHOUT
THE EXPRESS WRITTEN
THE EXPRESS WRITTEN

Storage Time in Months

PERMISSION OF TROJAN BATTERY
PERMISSION OF TROJAN BATTERY
12.77 (324)
12.77 (324) 6.78 (172)6.78 (172) 12380 CLARK ST. SANTA
12380FE SPRINGS,
CLARK CA 90670
ST. SANTA
CO. THIS DRAWING IS
CONFIDENCE WITH THE
FE SPRINGS, CA 90670
LOANED
CO. IN
THIS DRAWING
CONFIDENCE WITH THE
IS LOANED IN

UNDERSTANDING THAT IT SHALL

UNDERSTANDING THAT IT SHALL
5194 MINOLA DR. LITHONIA, GA 30038
5194 MINOLA DR. LITHONIA, GA 30038

G
BE RETURNED ON DEMAND
BE RETURNED ON DEMAND

G TITLE TITLE
GROUP 31 AGM DT MKTGDT MKTG
UNLESS OTHERWISE
UNLESS OTHERWISE
SPECIFICED SPECIFICED
GROUP 31 AGM
TOLERANCES ARE:
TOLERANCES ARE: (SKIRT DESIGN)
(SKIRT DESIGN)
SCALE 0.500
SCALE 0.500 X.X
X.XX
0.1"
0.05"
X.X
X.XX
0.1"
0.05"
DWN BY
A. SAN A. SAN SCALE
DWN BY SCALE CHK
CSIZE=DWG SCALE
APPVD
CHK APPVD
CSIZE=DWG SCALE

X.XXX 0.02" X.XXX 0.02" DATE DATE DWG NO DWG NO REV REV

7 6 6 5 5 4 4 3 3
ANGLES = 2 ANGLES = 2
3/15/17 3/15/17 721138 721138A A

Confidential Information of Trojan

Confidential BatteryofCompany,
Information LLC. Company, LLC.
Trojan Battery
All unauthorized All
use, disclosure or
unauthorized distribution
use, disclosure is prohibited.
or distribution is prohibited.
Controlled document; user is
Controlled responsible
document; forisverifying
user revision
responsible is current
for verifying prior toisuse.
revision current prior to use.

F F

E E

TERMINAL TYPEG
12.80 (325) SCALE 0.500
15 D
M8 LENGTH M8 6 6.81 (173)
WIDTH
DT AUTOMOTIVE POST & STUD
D

Battery Height with Terminal in Inches (mm)

9.37 (238)
Battery Height with Terminal in Inches (mm)
8.69 (221) Torque Values in-lb (Nm)
C Connected to Stud: 95 – 105 (11 – 12) C
Torque Values in-lb (Nm) Connected to AP: 50 – 70 (6 – 8)
Bolt: 85 – 90 (10 – 11)
8.54 Bolt Size
9.37 (238)
HEIGHT
(217) 5/16" – 18
B
B

THIS DRAWING AND DATA EMBODY

PROPRIETARY INFORMATION WHICH
IS THE CONFIDENTIAL PROPERTY
OF TROJAN BATTERY COMPANY
WHICH SHALL NOT BE COPIED,
REPRODUCED DISCLOSED TO
OTHERS OR USED IN WHOLE OR
PART FOR ANY PURPOSE WITHOUT
THE EXPRESS WRITTEN
PERMISSION OF TROJAN BATTERY
12.77 (324) 6.78 (172) 12380 CLARK ST. SANTA FE SPRINGS, CA 90670
CO. THIS DRAWING IS LOANED IN
CONFIDENCE WITH THE
UNDERSTANDING THAT IT SHALL
5194 MINOLA DR. LITHONIA, GA 30038
BE RETURNED ON DEMAND

TITLE
A UNLESS OTHERWISE
SPECIFICED
GROUP 31 AGM DT MKTG
TOLERANCES ARE:
(SKIRT DESIGN)
SCALE 0.500 X.X
X.XX
0.1"
0.05"
DWN BY
A. SAN SCALE
CSIZE=DWG SCALE
CHK APPVD

X.XXX 0.02" DATE DWG NO REV

7 6 5 4 3
ANGLES = 2
3/15/17 721138 A

Confidential Information of Trojan Battery Company, LLC.

All unauthorized use, disclosure or distribution is prohibited.
Controlled document; user is responsible for verifying revision is current prior to use.

A. The number of minutes a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage above 1.75 V/cell. Capacities are E. C.A. (Cranking Amps) - the discharge load in amperes which a new, fully charged battery can maintain for 30 seconds at 32°F (0°C) at a voltage above 1.2
based on peak performance. V/cell. This is sometimes referred to as marine cranking amps @ 32°F or M.C.A. @ 32°F.
B. The amount of amp-hours (Ah) a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage above 1.75 V/cell. F. Height taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal.
Capacities are based on peak performance. G. Terminal images are representative only.
C. Dimensions may vary depending on type of handle or terminal. Batteries should be mounted with 0.5 inches (12.7 mm) spacing minimum. H. Batteries in storage should be charged when they decline to 75% State of Charge (SOC).
D. C.C.A. (Cold Cranking Amps) - the discharge load in amperes which a new, fully charged battery can maintain for 30 seconds at 0°F (-18°C) I. Weight may vary.
at a voltage above 1.2 V/cell.

TROJAN BATTERY
COMPANY WITH Designed in compliance with applicable BCI, DIN, BS and IEC standards.
QUALITY SYSTEM
CERTIFIED BY DNV Tested in compliance to BCI and IEC standards.
= ISO 9001:2015 =

800.423.6569 / +1.562.236.3000 / trojanbattery.com 2023010-31-AES-Datasheet

REV: 7/10/23
© 2023 Trojan Battery Company, LLC. All rights reserved. Trojan Battery Company is not liable for damages that may result from any information provided in or omitted
from this publication, under any circumstances. Trojan Battery Company reserves the right to make adjustments to this publication at any time, without notice or obligation.