Page 1 of 4

SAFETY DATA SHEET Revision Date 6/14/2016

CONFORMS TO OSHA HAZARD COMMUNICATION STANDARD Supersedes Date 7/30/2015
(HCS) 29 CFR 1910.1200

SECTION 1. IDENTIFICATION
Product identifier: JAX Air Tool / Rock Drill Oil SAE 10
Part number: 21010
Identified uses: Lubricant where there is no possibility of contact with food
Uses advised against: Not for use where there is the possibility of contact with food. Other uses advised against may be specified elsewhere in this
SDS.
Supplier: JAX INC.
W134 N5373 Campbell Drive
Menomonee Falls, WI 53051 USA
Email contact: [email protected]
Non-emergency Phone: 262-781-8850 Fax: 262-781-3906
contact:
Emergency telephone: INFOTRAC:
North America 1-800-535-5053 Australia 1-300-366-961 Germany 0800-181-2926
International 011-1-352-323-3500 (collect) China 400-120-0761

SECTION 2. HAZARD(S) IDENTIFICATION

Classification: While this material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200), this SDS
contains valuable information critical to the safe handling and proper use of the product. This SDS should be retained and
available for employees and other users of this product.
Label elements
PIctograms: Not applicable

Signal word: Not applicable

Hazard statements: Not applicable
Precautionary Not applicable
statements:
Hazards not otherwise Not applicable.
classified:
Additional information: Not applicable
SECTION 3. COMPOSITION / INFORMATION ON INGREDIENTS
Composition: Chemical name % CAS # Impurities
Lubricating oils (petroleum), C15-30, hydrotreated neutral oil-based* 80-99 72623-86-0 None
SECTION 4. FIRST-AID MEASURES
First aid measures
Eye contact: Remove contact lenses, if wearing, and flush eyes with water for at least 15 minutes or until irritation subsides. If irritation
persists, consult a physican.
Skin contact: Remove clothing and shoes, if contaminated. Wash skin with soap and water. Wash or clean contaminated clothing before
reuse and discard oil-soaked shoes. If irritation persists, consult a physician.
Ingestion: If swallowed, DO NOT induce vomiting. As a precaution, give the person a glass of water to drink and seek medical attention.
Never give anything by mouth to an unconscious person. Consult a physician.
Inhalation: Remove to fresh air. If breathing is difficult, give oxygen. If not breathing, give artificial respiration. Get medical attention
immediately.
Most important No further relevant information available.
symptoms and effects,
both acute and delayed:
Indication of any No further relevant information available.
immediate medical
attention and special
treatment available:

General information: No further relevant information available.

 JAX Air Tool / Rock Drill Oil SAE 10 Page 2 of 4
Revision Date 6/14/2016
Supersedes Date 7/30/2015

SECTION 5. FIRE-FIGHTING MEASURES

Suitable extinguishing Extinguishing media include dry chemical, alcohol foam, and carbon dioxide. Do not use direct stream of water. Water may be
media: used to keep fire-exposed containers cool.
Unsuitable Do not use direct stream of water.
extinguishing media:
Specific hazards: Pressure build-up due to heat exposure may cause containers to rupture. Use water spray to keep containers cool.
Advice for firefighters: Firefighters should wear full protective gear, including helmet. Use supplied-air breathing equipment for enclosed or confined
space or as otherwise needed.

SECTION 6. ACCIDENTAL RELEASE MEASURES

Personal precautions, In the event of a spill or accidental release, notify relevant authorities in accordance with all applicable regulations. Keep
protective equipment away from ignition sources. Wear protective equipment. Keep unprotected persons away.
and emergency
procedures:
Environmental Prevent entry into sewers, waterways or confined areas by diking or impounding. Dike far ahead of spill for later recovery and
precautions: disposal. Advise authorities if the product has entered or may enter sewers, watercourses, or extensive land areas.
Methods for Land spill: Stop leak if you can do so without risk. Recover free product using non-sparking tools. Add sand, earth, or other
containment and suitable absorbent material to the spill area. Recover by pumping or with suitable absorbents. Dispose of in accordance with
cleaning up national and/or local regulations relating to waste disposal.
Water spill: Stop leak if you can do so without risk. Confine the spill immediately with booms. Remove from the surface by
skimming or with suitable absorbents. Seek the advice of a specialist before using dispersants.
SECTION 7. HANDLING AND STORAGE
Precautions for safe Keep away from heat and direct sunlight. Ensure good ventilation/exhaustion at the workplace.
handling:

Conditions for safe Store in a cool, dry place in tightly sealed containers. Store out of direct sunlight. Do not store near heat, sparks, open flame,
storage, including any pilot lights, static electricity, or other sources of ignition. Do not store where temperature may exceed 49°C (120°F). Store
incompatibilities: away from oxidizing agents. Rotate stock.

SECTION 8. EXPOSURE CONTROLS / PERSONAL PROTECTION

Workplace exposure Chemical name Exposure limit and source
limits: Lubricating oils (petroleum), C15-30, hydrotreated 5 mg/m³ (oil mist), OSHA
neutral oil-based*
Exposure controls
Engineering controls: Provide exhaust ventilation or other engineering controls to keep the airborne concentration of vapors below their respective
occupational exposure limits.
Ventilation: Use in a well-ventilated area. See Engineering Controls.
Personal hygiene: Wash skin thoroughly after contact, before breaks and meals and at the end of the work period. Product is readily removed
from skin by waterless hand cleaners followed by washing thoroughly with soap and water.
Eye protection: Chemical splash goggles or face shield in compliance with OSHA regulations are advised when eye contact may occur.
Hand protection: Any lined non-permeable rubber gloves.
Respiratory protection: Use with adequate ventilation. Respiratory protective equipment is not normally required where there is adequate natural or
local exhaust ventilation to control exposure. In case of insufficient ventilation, wear suitable respiratory equipment. A
NIOSH/MSHA-approved air-supplied respirator is advised in absence of proper environmental control.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance / odor: Amber colored lube oil with slight sulfur odor Not available
Not available
Physical state: Liquid
Vapor pressure: Nil
Odor threshold: Not available Vapor density:
Not available
pH: Not available
Melting / freezing point: Not available Relative density: 0.88 (typical)
Initial boiling point Not available
and boiling range: Solubility in water: Nil
Flash point: Partition coefficient Not available
 JAX Air Tool / Rock Drill Oil SAE 10 Page 3 of 4
Revision Date 6/14/2016
Supersedes Date 7/30/2015

(n-octanol/water):
Evaporation rate: Nil Autoignition temperature: Not available

Decomposition temperature: Not available

Not applicable
Viscosity: Not available

SECTION 10. STABILITY AND REACTIVITY

Reactivity: Not reactive under normal conditions.
Chemical stability: Stable under recommended conditions.
Possibility of Hazardous reactions are not expected to occur.
hazardous reactions:
Conditions and Avoid heat, sparks, open flames and oxidizing materials.
materials to avoid:
Hazardous Carbon monoxide, carbon dioxide, sulfur oxides, nitrogen oxides, phosphates, smoke and irritating vapors as products of
decomposition incomplete combustion.
products:

SECTION 11. TOXICOLOGICAL INFORMATION

Information on likely routes of exposure
Eye contact: No known significant effects or critical hazards.
Skin contact: No known significant effects or critical hazards.
Inhalation: No known significant effects or critical hazards.
Ingestion: No known significant effects or critical hazards.
Component Components LD50 LC50
information: Lubricating oils (petroleum), C15-30, hydrotreated >5000 mg/kg (oral, rat) Not available
neutral oil-based*
Information on physical, chemical and toxicological effects
Symptoms: See Section 4 of this SDS for symptoms.

Delayed and immediate effects, and chronic effects, from short and long-terms exposure
Effects: No further relevant information available.
Carcinogenicity: No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated
carcinogen by NTP.
Numerical measures of Not determined
toxicity:

SECTION 12. ECOLOGICAL INFORMATION

Ecotoxicity: Not available
Component Components L(E)C50
information: Lubricating oils (petroleum), C15-30, hydrotreated Not available
neutral oil-based*
Persistence and Not determined
degradability:
Bioaccumulative Not determined
potential:
Mobility in soil: Not available
Other adverse effects: Not determined

SECTION 13. DISPOSAL CONSIDERATIONS

Waste treatment Disposal must be in accordance with current applicable laws and regulations, and material characteristics at time of disposal.
methods: Consult national or regional authorities for proper disposal and reporting procedures.

SECTION 14. TRANSPORTATION INFORMATION

Dangerous goods descriptions may not reflect package size, quantity, end-use or region-specific exceptions that can be applied to shipments. Consult
 JAX Air Tool / Rock Drill Oil SAE 10 Page 4 of 4
Revision Date 6/14/2016
Supersedes Date 7/30/2015

shipping documents for material-specific descriptions.

Hazard Packing
Proper Shipping Name: UN Number: Class: Group: Remarks:
U.S. D.O.T. Not regulated None None None None
ADR/RID Not regulated None None None None
IMDG Not regulated None None None None
IATA Not regulated None None None None

SECTION 15. REGULATORY INFORMATION

U.S. Federal Regulations
SARA Section 302 This product contains greater than 1.0% of the following chemical(s) on the SARA Extremely Hazardous Substances List:
Extremely Hazardous None
Substances:

SARA Section 304 Release of the following chemical(s) at quantities equal to or greater than the reportable quantities (RQ), is subject to
CERCLA Hazardous reporting to the National Response Center under CERCLA:
Substances: None
SARA Section 313 Toxic This product contains the following chemical(s) listed in Section 313 at or above the de minimis concentrations:
Chemicals: None
TSCA Inventory: All components of this material are on the U.S. TSCA Inventory.
U.S. State Regulations
California Proposition
This product does not contain chemical(s) known to the State of California to cause birth defects or other reproductive harm.
65 Status:
California 2-Propenoic acid, ethyl ester; Ethylene oxide; Propylene oxide; 1,4-Dioxane
Proposition 65
Listed Components:

International Regulations
Canada: This product has been classified in accordance with the hazard criteria of WHMIS 2015 and the SDS contains all of the
information required by those regulations.
Japan MITI: Not available
Australia: Not available
Switzerland: Not available

SECTION 16. OTHER INFORMATION

Sections Revised: Sections 2 and 3
Revision Date: 6/14/2016

The information and recommendations contained herein are, to the best of JAX INC.'s knowledge and belief, accurate and reliable as of the date issued.
JAX INC. makes no warranty or guarantee, expressed or implied, of their accuracy or reliability, and JAX INC. shall not be liable for any loss or damage
based upon the criteria supplied by the developers of these rating systems, together with JAX INC.'s interpretation of the available data.

*** END OF SDS ***