MATERIAL SAFETY DATA SHEET EIHE-N,
Product Name Trans DIESEL 20W-50
Application Motor oil
For special application advice refer to appropriate Technical Data Sheet or consult our
company representative.
Company BOUSTEAD PETROLEUM MARKEflNG SDB BHD (s783-T)
Address North Port Installation, Jalan Parang
P.O. Box 2,42007 Pelabuhan Klang, Selangor Darul Ehsan
Telephone +(6) 03 31617867 Fax : +(6) 03 31617891
Component Concentration Ingredient Name
100 o/o wt Motor Oil
Mixture >94 o/o wt Highly Refined Mineral Oil
Mixture <6 %owt Additives
Physical State Liquid
Appearance Dark Amber, bright & clear
Odor Mild Petroleum
Health Hazards No known immediate health hazards.
Physical Hazards No known physicals hazards.
Potential Health Effects
Eye May cause eye irritation.
S[in May cause skin irritation. Prolonged or repeated contact can lead to irritation
and / or dermatitis.
USED ENGINE OIL
used engine oil may contain hazardous components which have the potential to
cause skin cancer.
See Toxicological information, section 1i
I nhalation : May cause nose, throat, and respiratory tract irritation.
Ingestion : Ingestion may cause gastrointestinal irritation and diarrhoea'
Aqqravaterl Medical : Pre-existrng eye, skin and respiratory riisorders nlay ire aggravated by exlx.rsLtre
conditions to this Product.
For Additional health informaiion, refer to section B
Page 1 of 5
MATERIAL SAFETY DATA SHEET EITIE-N,
Eye Contact In case of contact, immediately flush eyes with plenty of water for at least 15 minutes.
Get medical aftention if irritation occurs.
Skin Contact Immediately wash exposed skin with soap and water. Remove contaminated clothing and
shoes. Wash clothing before reuse. Thoroughly clean shoes before reuse.
Inhalation If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is
difficult, give orygen. Get medical attention.
Ingestion DO NOT induce vomiting unless directed to do so by medical personnel. Never give
anything by mouth to an unconscious person. If large quantities of this material are
swallowed, call a physician immediately.
Flammability Of The Product : May be combustible at high temperafure.
Flash Point : 240 oC (Open Cup) Cleveland.
Unusual Fire / Explosion Hazards : This material is not explosive as defined by established regulatory
criteria.
Fire Fighting Media and Instruction : In case of fire, use water fog, foam, dry chemicals, or carbon dioxide.
DO NOT use waterjet.
Protective Clothing (Fire) Fire-fighters should wear positive pressure self-contained breathing
apparatus (SCBA) and full turnout gear.
Personal Precautions Immediately contact emergency personnel. Keep unnecessary personnel
away. Use suitable protective equipment (See Section B). Follow all fire
fighting procedure (See Section 5).
Environmental Precautions & Ifemergency personnel are unavailable, contain spilled material For snlall
Clean-UP Methods sprlls add absorbent (soil may be used in the absence of other suitable
materials), scoop up material and place in a sealed, liquid-proof container
for disposal. For targe spills, dike spilled material or otherwise cotrtain
material to ensure runoff does not reach a waterway' Place spilled material
in an appropriate container for disposal. Avoid contact of spilled n'laterial
with soil and prevent runoff entering surface waterways. (See Section 13).
Personnel Protection In Case of Splash goggles, full suit, boo[s, gloves. Suggested protective clothirlg rtltght
Large Spill not be sufficient, consult a specialist BEFORE handling this prorjtrct
P.rge 2 of 5
MATERIAL SAFETY DATA SHEET Elfll?.n,
Handling : Avoid prolonged or repeated contact with skin. Avoid contact with eyes. Use only
with adequatl ventilation. Wash thoroughly after handling. In accordance with good
industrial hygiene and safety work practices, airborne exposure should be controlled
to the lowest extent Practicable.
Storage : Keep container tightly closed. Keep container in a cool, well ventilated area' EmPty
coniainers may contain harmful, flammable / combustible or explosive residue of
vapours. Do not cut, grind, drill, weld, reuse or dispose of containers unless
adequate precautions are taken against these hazards.
Substance Occupational Exposure Limits
Lubricating Oil TWA: 5 mg/m3 B hour(s). Form: Oil mist
STEL: 10 mg7m3 15 minutes. Form: Oil mist
Control Measures or other engineering controls to keep the
Provide exhaust ventilation
relevant airborne concentration below their respective occupational
exposure limits. Ensure tha! eyewash station and safety showers are close
to the work-station location.
Hygiene Measures Wash hands, forearms and face thoroughly after handling chemical
products, before eating, smoking and using lavatory and at the end of the
working period.
Personnel Protection
Eyes Avoid contact with eyes. Wear Chemicals splash googles.
Skin & Body Avoid contact with skin and clothing' Wear suitable protective clothing'
Respiratory Use only with adequate ventilation. In accordance with good industrial
hygiene and safety work practices, airborne exposures should be controlled
to the lowest extent practicable.
Wear suitable gloves.
Consult your supervisor or S.O'P for special handling directions.
Consult local authorities for acceptable exposure limits,
Physical Stated : Liquid
: 240
.C
Flash Point (COC)
Appearance : Dark Amber, Bright & Clear
oC
Kinematic Viscosity : i70.0 mm2/s (t70.0 cst) at 40
oc
18.5 mm2/s (18.5 cst) at 100
Solubility : InsolL:ble ln waler
Specific Gravity : 0.BB (at 30
oC)
Pour Point : -15 oC
The Above data are typical values and do not constitute a specifications
Page 3 of 5
MATERIAL SAFETY DATA SHEET EIHE-O,
Stability and Reactivity : The product is stable under normal conditions.
Conditions to Avoid : Keep away from heat, sparks and flame.
Materials to Avoid : avoiO contact with strong oxidizing agents.
Hazardous Polymerisation : Will not occur.
Acute Toxicity : Dermal LD50 > 5.0 q/kg (Rabbit)
Oral LD50 > 5.0 g/kg (Rat)
OSHA: Non-toxic based on components
USED ENGINE OIL
Combustion products resulting from the internal combustion engines operation
contaminate engine oil during use. Used engine oil may contain hazardous
components which have the potential to cause skin cancer. Frequent or prolonged
contact with all types and nakes of used engine oil must therefore be avoided and
a high standard of personal hygiene maintained.
Carcinogenic Effects : No component of this product at levels greater than 0.1% is identified a
carcinogen by the International Agency for Research on cancer (IARC) or
Occupational Safety and Health Act (OSHA).
12. ECOLOGICAL INFORMATION
Environment Impact No ecological data available for this product. However, this product is an oil. It
is persistent and does not readily biodegrade. However, it does not
bioaccumulate.
Ecotoxicily Not expected to be toxic to aquatic organisms. Not expected to be inhibitory to
sewaqe bacteria.
Waste Information Use only approved transporter, recycles, treatment, storage or disposal
facilities. Dispose off in accordance with all applicable local and national
requlations
Consult your local or national authorities
14. TRANSPORT INFORMATION
ihis product is NOT classlfitd as dclngerolls fi-rr lrarrsl;orl
Page 4 of 5
MATERIAL SAFETY DATA SHEET GIHE-N,
EC Directives Waste Oil Directive, 87h}llEEC
Framework Waste Directive, 91/156/EEC
Statutory Instruments Health & Safety at Work, etc Act 1974
Consumer Protection Act 1987
Environmental ProtecUon Act 1990
Codes of Practice Waste Management, The DutY of Care
Guidance Notes Occupational Exposure Limits (EH40)
Carcinogenicity of Minerals Oils (EH58)
PREPAMTION I NFORMATION
Version
,.2
Date of Printing : 2412120t4
>> Indicates information that has changed from previously issued version
Notice to Reader!
This information and these recommendations are offered in good faith and believed to be correct
of
the date hereof. Information and recommendations are supplied uPon the condition that the
recipients will make their own decision as to safety and suitability for their purposes' No
representations or warranties, either expressed or implied, of merchantability, fitness for
a
particular purpose, or of any other nature, are made with respect to the product or the information
and recommendations. Boustead Petroleum Marketing Sdn Bhd makes no rePresentation as to
responsible
completeness of accuracy. In no event will Boustead Petroleum Marketing Sdn Bhd be
for damages of any nature whatsoever resuliing from the use or reliance upon the information and
recom mendations.
*** END OF MSDS***
Page 5 of 5
