Page 1 of 7
FOSTER 30-45N
Print Date: 01-30-2020 842291PM
SAFETY DATA SHEET
______________________________________________________________________________
REVISION DATE: 01-27-2020 SUPERSEDES: 04-08-2018
SECTION 1: IDENTIFICATION OF THE PRODUCT AND SUPPLIER
PRODUCT INFORMATION
PRODUCT: FOSTER 30-45N
PRODUCT DESCRIPTION: Sealant
INTENDED USE: Sealant
PRODUCT IDENTIFIER: 842291PM
COMPANY INFORMATION
H.B. Fuller Company
1200 Willow Lake Boulevard
Vadnais Heights, MN 55110
Telephone: 888-423-8553
Medical Emergency Phone Number (24 Hours): 1-888-853-1758
Transport Emergency Phone Number (CHEMTREC): 1-800-424-9300
SECTION 2: HAZARDS IDENTIFICATION
GHS Hazard Symbols:
GHS Signal Word: Warning
GHS Classification: Skin Sensitisation Category 1; Carcinogenicity Category 2; Flammable Liquid
Category 4
GHS Hazard Phrases: Combustible Liquid; May cause an allergic skin reaction.; Suspected of causing cancer.
GHS Precautions:
Safety Precautions: Obtain special instructions before use. Do not handle until all safety precautions have
been read and understood. Keep away from heat/sparks/open flames/hot surfaces. – No
smoking. Avoid breathing dust/fume/gas/mist/vapours/spray. Contaminated work
clothing should not be allowed out of the workplace. Wear protective gloves/protective
clothing/eye protection/face protection.
First Aid Measures: IF ON SKIN: Wash with plenty of soap and water. IF exposed or concerned: Get
medical advice/attention. Wash contaminated clothing before reuse. In case of fire:
Use water spray, foam, dry chemical or carbon dioxide to extinguish.
Storage: Store in a well-ventilated place. Keep cool. Store locked up.
Disposal: Dispose of contents/container in accordance with local/regional/national/international
regulation for chemical wastes.
SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS
Chemical Name CAS # PERCENT Classification Note
Stoddard solvent 8052-41-3 1 -5 Asp. Tox. 1; H304 Note P
Crystalline silica 14808-60-7 0.1 - 1 Carc. 1A; H350 * (see below)
STOT RE 1; H372
Ethyl alcohol:CAS:64-17-5 64-17-5 0.1 - 1 Eye Irrit. 2; H319
Page 2 of 7
FOSTER 30-45N
Print Date: 01-30-2020 842291PM
SAFETY DATA SHEET
______________________________________________________________________________
Flam. Liq. 2; H225
Cobalt bis(2-ethylhexanoate) 136-52-7 0.1 - 1 Aquatic Acute 1; H400
Aquatic Chronic 1; H410
Acute Tox. 4; H332
Skin Sens. 1; H317
Trimethyl benzene:CAS:25551-13-7 25551-13-7 0.1 - 1 Acute Tox. 4; H312
Acute Tox. 4; H302
Eye Irrit. 2; H319
Skin Irrit. 2; H315
Trimethylbenzene, 1,2,4- 95-63-6 0.1 - 1 Aquatic Chronic 2; H411
Acute Tox. 4; H332
Eye Irrit. 2; H319
Flam. Liq. 3; H226
Skin Irrit. 2; H315
STOT SE 3; H335, H336
Methyl ethyl ketoxime 96-29-7 0.1 - 1 Acute Tox. 4; H312
Acute Tox. 4; H332
Acute Tox. 4; H302
Carc. 2; H351
Eye Dam. 1; H318
Skin Sens. 1; H317
*This product contains one or more materials that may be hazardous when present as an airborne dust. During
normal handling of the product, the material is encapsulated within the product and will not present an exposure
risk. Once the product has reached its final state and is abraded or disturbed, dusting and exposure may occur. This
product contains crystalline silica. As provided, and during normal use of this product, the crystalline silica is
encapsulated within the product. As such, it is considered to be inextricably bound, and not readily available for
exposure. Use of this product would not subject the user to the compliance requirements of 29CFR1910.1053 or
1926.1153.
Unlisted ingredients are not 'hazardous' per the Occupational Safety and Health Administration Hazard
Communication Standard (29 CFR 1910.1200) and/or are not found on the Canadian Workplace Hazardous
Materials Information System ingredient disclosure list. See Section 8 for exposure limit guidelines.
SECTION 4: FIRST AID MEASURES
IF IN EYES: Use an eye wash to remove a chemical from your eye regardless of the level of hazard. Flush the
affected eye for at least twenty minutes. Tilt the head to prevent chemical from transferring to the uncontaminated
eye. Seek medical advice after flushing.
IF ON SKIN: Wash with soap and water. Get medical attention if irritation develops or persists.
IF INHALED: Remove to fresh air. Call a physician if symptoms persist.
IF SWALLOWED: Do not induce vomiting. Seek medical attention if symptoms develop. Provide medical care
provider with this MSDS. Induced vomiting may lead to aspiration of the material into the lungs potentially causing
chemical pneumonitis that may be fatal.
SECTION 5: FIRE FIGHTING MEASURES
EXTINGUISHING MEDIA: Use water spray, foam, dry chemical or carbon dioxide.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Vapors are heavier than air and can travel to a source of ignition
and flash back.
SPECIAL FIRE FIGHTING INSTRUCTIONS: Persons exposed to products of combustion should wear self-
contained breathing apparatus and full protective equipment.
HAZARDOUS COMBUSTION PRODUCTS: Carbon dioxide, Carbon monoxide Chlorine containing gases
Nitrogen containing gases
Page 3 of 7
FOSTER 30-45N
Print Date: 01-30-2020 842291PM
SAFETY DATA SHEET
______________________________________________________________________________
SECTION 6: ACCIDENTAL RELEASE MEASURES
SPECIAL PROTECTION: Exposure to the spilled material may be irritating or harmful. Follow
personal protective equipment recommendations found in Section 8 of
this MSDS. Additional precautions may be necessary based on special
circumstances created by the spill including; the material spilled, the
quantity of the spill, the area in which the spill occurred. Evaporation of
volatile substances can lead to the displacement of air creating an
environment that can cause asphyxiation.
METHODS FOR CLEAN-UP: Dike if necessary, contain spill with inert absorbent and transfer to
containers for disposal. Keep spilled product out of sewers, watersheds,
or water systems.
Shut off ignition sources; including electrical equipment and flames. Do
not allow smoking in the area.
Transport Emergency Phone Number (CHEMTREC): 1-800-424-9300
SECTION 7: HANDLING AND STORAGE
Handling: Avoid contacting and avoid breathing the material. Use only in a well ventilated
area.
Keep away from heat, sparks and flame.
Wash thoroughly after handling.
Keep container closed.
Emptied container retains vapor and product residue.
Observe all labeled precautions until container is cleaned.
Drums of this material should be grounded when pouring.
DO NOT CUT OR WELD ON OR NEAR THIS CONTAINER.
Storage: Store in a cool, dry, ventilated location. Keep away from heat and flame. Keep
container closed.
Consult the Technical Data Sheet for specific storage instructions.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
EXPOSURE LIMITS:
Chemical Name Note ACGIH EXPOSURE LIMITS OSHA PEL
Calcium carbonate * (see No data available. 15 mg/m3 TWA (total dust); 5 mg/m3 TWA
below) (respirable fraction)
Stoddard solvent Note P 100 ppm TWA 500 ppm TWA; 2900 mg/m3 TWA
Crystalline silica * (see 0.025 mg/m3 TWA (respirable particulate ((250)/(%SiO2 + 5) mppcf TWA
below) matter) (respirable)); ((10)/(%SiO2 + 2) mg/m3
TWA (respirable)); ((30)/(%SiO2 + 2)
mg/m3 TWA (total dust))
*This product contains one or more materials that may be hazardous when present as an airborne dust. During normal handling of the product, the
material is encapsulated within the product and will not present an exposure risk. Once the product has reached its final st ate and is abraded or
disturbed, dusting and exposure may occur. This product contains crystalline silica. As provided, and during normal use of this product, the
crystalline silica is encapsulated within the product. As such, it is considered to be inextricably bound, and not readily available for exposure.
Use of this product would not subject the user to the compliance requirements of 29CFR1910.1053 or 1926.1153.
ENGINEERING CONTROL METHODS:
Page 4 of 7
FOSTER 30-45N
Print Date: 01-30-2020 842291PM
SAFETY DATA SHEET
______________________________________________________________________________
VENTILATION: General room ventilation might be required under normal conditions
of use.
EYE PROTECTION: Wear safety glasses when handling this product.
SKIN PROTECTION: Not normally required. Wear chemically resistant gloves to prevent
prolonged or repeated contact.
GLOVES: Nitrile
RESPIRATORY PROTECTION: No respiratory protection required under normal conditions of use.
Respirators should be selected by and used following requirements
found in OSHA's respirator standard (29 CFR 1910.134).
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Liquid
COLOR: Gray
ODOR: Solvent
ODOR THRESHOLD: Not established
pH: Not established
FREEZING/MELTING POINT (deg. C): Not established
BOILING POINT (deg. C): Not established
FLASH POINT: 62°C; 144°F Pensky-Martens
EVAPORATION RATE: Not established
FLAMMABILITY: Not a flammable solid or gas
UPPER EXPLOSIVE LIMIT (% in air): Not established
LOWER EXPLOSIVE LIMIT (% in air): Not established
VAPOR PRESSURE (mm Hg): Not established
VAPOR DENSITY: Not established
WEIGHT PER GALLON (lbs.): 13.50
SPECIFIC GRAVITY: 1.620
SOLUBILITY: Not established
OCTANOL/WATER COEFFICIENT: Not established
AUTOIGNITION TEMPERATURE: Not established
DECOMPOSITION TEMPERATURE: Not established
VISCOSITY: No data available.
SOLIDS (% by weight): 95.0
VOC, weight percent 4.98
VOC, U.S. EPA Method 24, less water and exempt 85g/liter of material
solvents (theoretically determined)
SECTION 10: STABILITY AND REACTIVITY
STABILITY: Stable under normal conditions.
CHEMICAL INCOMPATIBILITY: Strong oxidizing agents
HAZARDOUS POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide Nitrogen
containing gases Chlorine containing gases
SECTION 11: TOXICOLOGICAL INFORMATION
Component Toxicity / Toxicology Data:
COMPONENT NAME LD50/LC50
No data available.
Page 5 of 7
FOSTER 30-45N
Print Date: 01-30-2020 842291PM
SAFETY DATA SHEET
______________________________________________________________________________
This product is a mixture. Unless noted, the information below is based on components.
Skin corrosion / irritation: No irritation hazard in normal industrial use.
Serious eye damage / irritation :No irritation hazard in normal industrial use.
Respiratory / skin sensitization: No data available.
Germ cell mutagenicity: No data available.
Carcinogenicity: Contains a material that may cause cancer.
Reproductive toxicity: Contains a substance that is a possible reproductive hazard based on animal studies.
Specific target organ toxicity-single exposure: No data available.
Respiratory irritation / Narcotic effects: No data available.
Specific target organ toxicity-repeated exposure: No data available.
Target organs potentially affected by exposure: Kidneys Central nervous system Lungs Heart
Aspiration hazard: Not an aspiration hazard.
Medical Conditions Aggravated by Exposure: Kidney disease, Lung disease
SECTION 12: ECOLOGICAL INFORMATION
OVERVIEW: No ecological information available for this product.
MOBILITY: No data available.
PERSISTENCE: No data available.
BIOACCUMULATION: No data available.
This product has not been tested for ecological effects. Relevant information for components is listed below:
Component： Ecotoxicity values:
Diisodecyl phthalate, branched Acute Toxicity (Fish): LC50 96 h Pimephales promelas >0.66 mg/L [static] (IUCLID);
LC50 96 h Pimephales promelas >1 mg/L [flow-through] (IUCLID); LC50 96 h
Oncorhynchus mykiss >1 mg/L [static] (IUCLID); LC50 96 h Oncorhynchus mykiss
>0.62 mg/L [flow-through] (IUCLID); LC50 96 h Lepomis macrochirus >0.55 mg/L
[static] (IUCLID)
Acute Toxicity (Daphnia): EC50 48 h Daphnia magna >0.18 mg/L (IUCLID)
Acute Toxicity (Algae): EC50 96 h Pseudokirchneriella subcapitata >1.3 mg/L
(IUCLID)
SECTION 13: DISPOSAL CONSIDERATIONS
To the best of our knowledge, this product does not meet the definition of hazardous waste under the U.S. EPA
Hazardous Waste Regulations 40 CFR 261. Dispose of in an approved landfill. Consult your state, local or
provincial authorities and your local waste vendor for more restrictive requirements.
SECTION 14: TRANSPORT INFORMATION
Consult Bill of Lading for transportation information.
US DOT: NOT REGULATED
IATA: NOT REGULATED
IMDG: NOT REGULATED
SECTION 15: REGULATORY INFORMATION
INVENTORY STATUS
Page 6 of 7
FOSTER 30-45N
Print Date: 01-30-2020 842291PM
SAFETY DATA SHEET
______________________________________________________________________________
U.S. EPA TSCA: This product is in compliance with the Toxic Substances Control Act's
Inventory requirements.
CANADIAN CEPA DSL: The components of this product are included on the DSL or are exempt
from DSL requirements.
EUROPEAN REACH: As a result of the introduction of REACH into Europe, this product
cannot be imported into Europe unless the REACH requirements are
met.
AUSTRALIA AICS: This product is in compliance with the Australian Inventory of
Chemical Substances requirements.
JAPAN ENCS: This product is in compliance with the Japanese Existing and New
Chemical Substances requirements.
KOREAN TCCL: This product is in compliance with the Korean Existing Chemicals List
requirements.
PHILIPPINES: This product is in compliance with the Philippine Inventory of
Chemicals and Chemical Substances requirements.
CHINA IECSC INVENTORY: This product is in compliance with the Inventory of Existing Chemical
Substances in China (IECSC) requirements.
If you need more information about the inventory status of this product call 651-236-5858.
This product may contain chemical substances that are regulated for export by various government agencies (such as
the Environmental Protection Agency, the Bureau of Industry and Security, or the Drug Enforcement
Administration, among others). Before exporting this product from the USA or Canada, we recommend you contact
us at [email protected] to request an export review.
FEDERAL REPORTING
*This product contains one or more materials that may be hazardous when present as an airborne dust. During
normal handling of the product, the material is encapsulated within the product and will not present an exposure
risk. Once the product has reached its final state and is abraded or disturbed, dusting and exposure may occur. This
product contains crystalline silica. As provided, and during normal use of this product, the crystalline silica is
encapsulated within the product. As such, it is considered to be inextricably bound, and not readily available for
exposure. Use of this product would not subject the user to the compliance requirements of 29CFR1910.1053 or
1926.1153.
EPA SARA Title III Section 313
Unless listed below, this product does not contain toxic chemical(s) subject to the reporting requirements of section
313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA) and 40 CFR part 372. EPA
has advised that when a percentage range is listed the midpoint may be used to fulfill reporting obligations.
Chemical Name CAS# %
Cobalt compounds 136-52-7 0.1 - 1
STATE REPORTING
Proposition 65, The Safe Drinking Water and Toxic Enforcement Act of 1986:
Unless listed below, this product does not contain known levels of any chemical known to the State of California to
cause cancer or reproductive harm.
Chemical Name/List CAS Percent
Quartz (Carcinogen) 14808-60-7 0.1 - 1
Diisodecyl phthalate (mixed (Developmental toxin) 68515-49-1 1 -5
isomers)
Substances of Very High Concern (SVHC) Content:
Unless listed below, this product does not contain SVHC’s at 0.1% or greater, as of the version date of this SDS.
Page 7 of 7
FOSTER 30-45N
Print Date: 01-30-2020 842291PM
SAFETY DATA SHEET
______________________________________________________________________________
SECTION 16: OTHER INFORMATION
SDS VERSION DATE: 01-27-2020
This Safety Data Sheet is prepared to comply with the United States Occupational Safety and Health Administration
(OSHA) Hazard Communication Standard (29 CFR 1910.1200) and the Canadian Workplace Hazardous Materials
Information System (WHMIS).
HMIS RATING: HEALTH -- 2 FLAMMABILITY -- 2 REACTIVITY -- 0
See SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION for personal protective equipment
recommendations.
Prepared by: The Global Regulatory Department
Phone: 651-236-5842
The information and recommendations set forth herein are believed to be accurate. Because some of the information
is derived from information provided to H.B. Fuller Construction Products, Inc. from its suppliers, and because H.B.
Fuller Construction Products, Inc. has no control over the conditions of handling and use, H.B. Fuller Construction
Products, Inc. makes no warranty, expressed or implied, regarding the accuracy of the data or the results to be
obtained from the use thereof. The information is supplied solely for your information and consideration, and H.B.
Fuller Construction Products, Inc. assumes no responsibility for use or reliance thereon. It is the responsibility of
the user of H.B. Fuller Construction Products, Inc. products to comply with all applicable federal, state and local
laws and regulations.
