Dongfeng Cummins

Techical
Operations

ENGINE MODEL： 6BTAA5.9-G2

CURVE & DATASHEET： FR93270

REV 00 26OCT2012
 Generator Engine Performance Data Basic Engine Model:
FR93270 @ 1500 RPM &1800RPM
DONGFENG CUMMINS ENGINE Co.,LTD 6BTAA5.9-G2
Configuration CPL Code Revision
Xiangfan, Hubei Province, China
http://www.dcec.com.cn
FR93270
D403076GX03 CPL: 3289 2009/4/15

Compression Ratio: 17.3:1 Aspiration: Turbocharged and Charge Air Cooled

Bore: 102 mm Displacement: 5.9 L
Storke: 120 mm No. of Cylinders: 6
Emission Certification: MEP STAGE I Fuel System: BYC PB/Electronic Governor
Governor Regulation: ≤3%

All data is based on the engine operating with fuel system, water pump, and 15.2 in H 2O (3.7 kPa) inlet air restriction with 5.98 in
(152mm) inner diameter, and with 3 in Hg (10 kPa) exhaust restriction with 4.02 in (102 mm) inner diameter; not included are
alternator, fan, optional equipment and driven components. Coolant flows and heat rejection data based on coolants as 50%
ethylene glycol/50% water. All data is subject to change without notice.

Engine Speed Standby Power Prime Power Continuous Power

RPM kW HP kW HP kW HP
1500 130 174 120 161 96 129

1800 145 194 132 177 TBD TBD

Engine Performance Data @ 1500 RPM Litre/hour

36.0
OUTPUT POWER FUEL CONSUMPTION
1500RPM
% kW HP g/kW.h L/h 30.0 (FR93270)
STANDBY POWER
24.0
100 130 174 216 34
PRIME POWER 18.0
100 120 161 208 30
75 90 121 207 23 12.0
50 60 80 214 16
6.0
25 30 40 252 9
CONTINUOUS POWER 0.0
100 56 75 208 24 0 20 40 60 80 100 120 140
Engine Power Output - kW

Engine Performance Data @ 1800 RPM Litre/hour

40.0
OUTPUT POWER FUEL CONSUMPTION 1800RPM
% kW HP g/kW.h L/h 32.0 (FR93270)
STANDBY POWER
100 145 194 215 38 24.0
PRIME POWER
100 132 177 211 34 16.0
75 99 133 212 25
50 66 88 223 18 8.0
25 33 44 264 11
CONTINUOUS POWER 0.0
0 30 60 90 120 150
TBD TBD TBD TBD TBD
Engine Power Output - kW

Curves shown above represent gross engine performance capabilities obtained and corrected in accordance with GB/T18297
conditions of 100kPa (29.61 in. Hg) barometric pressure, 25°C (77°F) inlet air temperature, and 1 kPa (0.30 in. Hg) water vapor
pressure with No.0 diesel fuel. The engine may be operated without changing the fuel setting up to 2200 m ( 7218ft.) altitude.
 FR93270 (Continued) Page: 2
GENERAL ENGINE DATA
Approximate Engine Weight (wet)………………………………………………………….. -kg 411
Mass Moment of Inertia of Rotating Components (No Flywheel)…………………………………………………….……
-kg·m 2
0.25
Center of Gravity from Front Face of Block…………………………………………………………………
-mm 391
Center of Gravity above Crankshaft Centerline………………………………………………… -mm 140
Fire Order……………………………………………………………………………………………………………… 1-5-3-6-2-4

ENGINE MOUNTING
Maximum (Static) Bending Moment at Rear Face of Block………………………………………………………….-N.m
-N.m 1356

EXHAUST SYSTEM
Maximum Back Pressure……………………………………………………………………….………..
-kPa 10

AIR INTAKE SYSTEM

Maximum Intake Air Restriction with Heavy Duty Air Cleaner
— Dirty Element……….…………………………………….……………………………. -kPa 6
— Clean Element……….…………………………….……………………………. -kPa 3.7
Minimum Dirt Holding Capacity with Heavy Duty Air Cleaner…………………………………………………
-g/cfm 53
Maximum Temperature Rise from Ambient to the Inlet of the Turbocharger……………….……………………………………
-℃ 17
Recommended intake piping size (inner diameter)……………….………………………………………………………….……
-mm 76

CHARGE AIR COOLING SYSTEM

Maximum Temp. Rise Between Engine Air Intake and Intake Manifold -℃ 25
Maximum Air Pressure Drop from Turbo Air outlet to Intake Manifold
— 1500RPM…………………………………………………………………………………………………………………… -kPa 13
— 1800RPM……….…………………………….……………………………………………………………………………. -kPa 13
Maximum Intake Manifold Temperature Differential (Ambient to IMT) (IMTD)…………………………………………………
-℃ 50
Maximum Intake Manifold Temperature for engine protection (Warning Threshold)…………………………………………
-℃ 58

LUBRICATION SYSTEM
Minimum Engine Oil Pressure for Engine Protection Devices:
-Idle Speed…………………………………………………………………-kPa -kPa 207
-Governed Speed……………………………………………………………-kPa -kPa 345
Maximum Oil Temperature……………….……………….…………………………………-℃ -℃ 121
Oil Capacity with OP 9006 Oil Pan : High - Low.…………..…..…………………………-litre -litre 14.2 - 12.3
Minimum Required Lube System Capacity - Sump plus Filters…….……………………………………….-litre
-litre 16.4
Angularity of Standard Oil Pan: (Values stated are for intermittent operation only):
— Front Down……………………………………………………………………………. -º 40
— Front Up…………………………………………………………………………………….- -º 40 º
— Side to Side……………………………………………………………………………….- -º 40º

FUEL SYSTEM
Type Injection System……………………………………………………………………………………………………… BYC PB Direct Injection
Maximum Restriction at Lift Pump………...……………………………………………………………………………. -kPa 13.6
Maximum Allowable Head on Injector Return Line (Consisting of Friction Head and Static Head)
...……………………………………………………………………… -kPa 67.7
Total Drain Flow (constant for all loads)…………..………………………………………………………………………….…
-litre/hr 30

COOLING SYSTEM
Coolant Capacity - Engine Only………………………………………………………………………………………… -litre 10
Maximum Coolant Friction Head External to Engine…………………………………………………………-kPa
-1800 rpm……………………………………………..…………………
-kPa 35
-1500 rpm……………………………………………..…………………
-kPa 28
Maximum Static Head of Coolant Above Engine Crank Centerline…………….………………………….
-m 14
Standard Thermostat (Modulating) Range………………………………….………...……….… -℃ 82 - 95
Minimum Pressure Cap……………………………………………………………………...…………………………-kPa -kPa 69
Maximum Top Tank Temperature for Standby / Prime Power…………….....…………………………………...………………
-℃ 104 / 100
 FR93270 (Continued) Page: 3
ELECTRICAL SYSTEM
Cranking Motor (Heavy Duty, Positive Engagement)……………………………………………………………………………
-volt 12V 24V
Battery Charging System, Negative Ground………………………………………………………………………………..
-ampere 63 40
Maximum Allowable Resistance of Cranking Circuit…………………………………………………...…………….
-ohm 0.00075 0.002
Minimum Recommended Battery Capacity
• Cold Soak @ 10 °F (-12 °C) and Above………………………………………………………………………….………..
-0°F CCA 800 400

EMISSIONS
Gaseous Emissions per GB 20891-2007, at 1500rpm：
—Weight-Specific NOx…………………………………………………………………… g/kW.h 9.2
—Weight-Specific HC………………………………………………………………………….-g/bhp-hr.
g/kW.h 1.3
—Weight-Specific CO………………………………………………………………………….-g/bhp-hr.
g/kW.h 5.0
—Weight-Specific Particulates………………………………………………………………………..-g/bhp-hr.
g/kW.h 0.70

Gaseous Emissions per GB 20891-2007, at 1800rpm：

—Weight-Specific NOx………………………………………………………………………… g/kW.h 9.2
—Weight-Specific HC………………………………………………………………………….-g/bhp-hr.
g/kW.h 1.3
—Weight-Specific CO………………………………………………………………………….-g/bhp-hr.
g/kW.h 5.0
—Weight-Specific Particulates………………………………………………………………………..-g/bhp-hr.
g/kW.h 0.54

Fuel Rating Option used for these Data: FR93270

STANDBY POWER PRIME POWER

Governed Engine Speed……………………………………………………….
-rpm 1800 1500 1800 1500
Engine Idle Speed………………………………………..……...…………-rpm
-rpm 750 - 850 750 - 850 750 - 850 750 - 850
Gross Engine Power Output……………………………………………………….….-kW
-kW 145 130 132 120
Piston Speed.......…………………………………….………………-m/s
-m/s 7.2 6 7.2 6
Friction Horsepower………………………………………………….….-kW
-kW 16.4 12.7 16.4 12.7
Engine Water Flow to Engine:……………………..………..……….-litre/sec.
-litre/sec. 2.4 2.0 2.4 2.0
Intake Air Flow………………………………………………..….-litre/sec.
-litre/sec. 142 120 135 114
Exhaust Gas Flow…………………………………………..……….-litre/sec.
-litre/sec. 401 328 369 295
Exhaust Gas Temperature…………………..…………………..……………………………………………………
-℃ 570 540 540 500
Air to Fuel Ratio…………………………………………………………………………
-air:fuel 21.0 : 1 20.0 : 1 22.5 : 1 21.5 : 1
Radiated Heat to Ambient…………..……………………….-kW
-kW 20 18 18 16
Heat Rejection to Coolant……………..………………….-kW
-kW 71 66 63 59
Heat Rejection to Exhaust……………..…………………………………….-kW
-kW 112 94 96 82

ALL DATA CERTIFIED WITHIN 5%

TBD = To Be Decided N/A = Not Applicable N.A. = Not Available
All data is subject to change without notice, sorry for inform.
Dongfeng Cummins Engine Co., Ltd.