Page 1/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 01/09/2014 Reviewed on 01/09/2014
* 1 Identification
· Product identifier
· Trade name: VpCI-368
· Relevant identified uses of the substance or mixture and uses advised against
No further relevant information available.
· Application of the substance / the preparation Corrosion inhibitors
· Details of the supplier of the safety data sheet
· Manufacturer/Supplier:
Cortec Corporation
4119 White Bear Parkway
St. Paul, MN 55110 USA
Phone (651) 429-1100
Fax (651) 429-1122
· Information department:
[email protected]
Product safety department.
· Emergency telephone number:
Spill, Leak, Fire, Exposure, or Accident
24 hour CHEMTREC contact:
USA and Canada 1-800-424-9300
International +1 703-527-3887 (collect calls accepted)
* 2 Hazard(s) identification
· Classification of the substance or mixture
The product is not classified according to the Globally Harmonized System (GHS).
· Classification according to Directive 67/548/EEC or Directive 1999/45/EC Void
· Information concerning particular hazards for human and environment: Harmful if swallowed.
· Label elements
· GHS label elements Void
· Hazard pictograms Void
· Signal word Void
· Hazard statements Void
· Classification system
· NFPA ratings (scale 0-4)
Health = 2
2 Fire = 2
2 0 Reactivity = 0
· HMIS rating system (0-4)
HEALTH *2 Health = *2
FIRE 2 Flammability = 2
REACTIVITY 0 Reactivity = 0
· Other hazards
· Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.
USA
(Contd. on page 2)
37.1.2
Page 2/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 01/09/2014 Reviewed on 01/09/2014
Trade name: VpCI-368
(Contd. of page 1)
* 3 Composition/information on ingredients
· Chemical characterization: Mixtures
· Description: Mixture of the substances listed below with nonhazardous additions.
· Dangerous components:
CAS: 64742-88-7 Solvent naphtha (petroleum), medium aliph. Xn R65 25-50%
EINECS: 265-191-7 H226; H302
· Additional information For the wording of the listed risk phrases refer to section 16.
* 4 First-aid measures
· Description of first aid measures
· General information No special measures required.
· After inhalation Supply fresh air; consult doctor in case of complaints.
· After skin contact If skin irritation continues, consult a doctor.
· After eye contact Rinse opened eye for several minutes under running water.
· After swallowing
If swallowed, do not induce vomiting: seek medical advice immediately and show this container or label
· Information for doctor
· Most important symptoms and effects, both acute and delayed No further relevant information available.
· Indication of any immediate medical attention and special treatment needed
No further relevant information available.
5 Fire-fighting measures
· Extinguishing media
· Suitable extinguishing agents
CO2, extinguishing powder or water spray. Fight larger fires with water spray or alcohol resistant foam.
· Special hazards arising from the substance or mixture
In case of fire, the following can be released:
Sulphur dioxide (SO2)
Nitrogen oxides (NOx)
Carbon monoxide (CO)
In certain fire conditions, traces of other toxic gases cannot be excluded.
· Advice for firefighters
· Protective equipment: Wear self-contained respiratory protective device.
* 6 Accidental release measures
· Personal precautions, protective equipment and emergency procedures
Wear protective equipment. Keep unprotected persons away.
Keep away from ignition sources
Ensure adequate ventilation
· Environmental precautions: Do not allow to enter sewers/ surface or ground water.
· Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
(Contd. on page 3)
USA
37.1.2
Page 3/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 01/09/2014 Reviewed on 01/09/2014
Trade name: VpCI-368
(Contd. of page 2)
· Reference to other sections
No dangerous substances are released.
See Section 7 for information on safe handling
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.
* 7 Handling and storage
· Handling
· Precautions for safe handling No special measures required.
· Information about protection against explosions and fires:
Keep ignition sources away - Do not smoke.
Protect against electrostatic charges.
Use explosion-proof apparatus / fittings and spark-proof tools.
· Conditions for safe storage, including any incompatibilities
· Storage
· Requirements to be met by storerooms and receptacles:
Use only receptacles specifically permitted for this substance/product.
Store only in unopened original receptacles.
· Information about storage in one common storage facility:
Store away from foodstuffs.
Store away from oxidizing agents.
· Further information about storage conditions: None.
· Specific end use(s) No further relevant information available.
* 8 Exposure controls/personal protection
· Additional information about design of technical systems: No further data; see item 7.
· Control parameters
· Components with limit values that require monitoring at the workplace:
471-34-1 calcium carbonate ( 2.5%)
PEL Long-term value: 15* 5** mg/m³
*total dust **respirable fraction
REL Long-term value: 10* 5** mg/m³
*total dust **respirable fraction
TLV TLV withdrawn
· Additional information:
CONTROL PARAMETERS: 10mg/m3 inhalable and 4mg/m3 respirable 8 hr TWA.
The lists that were valid during the creation were used as basis.
· Exposure controls
· Personal protective equipment
· General protective and hygienic measures
Immediately remove all soiled and contaminated clothing
Do not inhale gases / fumes / aerosols.
The usual precautionary measures for handling chemicals should be followed.
(Contd. on page 4)
USA
37.1.2
Page 4/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 01/09/2014 Reviewed on 01/09/2014
Trade name: VpCI-368
(Contd. of page 3)
· Breathing equipment:
In case of brief exposure or low pollution use respiratory filter device. In case of intensive or longer
exposure use respiratory protective device that is independent of circulating air.
· Protection of hands:
Neoprene gloves
Solvent resistant gloves
Use gloves of stable material (e.g. Nitrile) - if necessary tricoted to improve the wearability.
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation
· Penetration time of glove material
The exact break through time has to be found out by the manufacturer of the protective gloves and has to be
observed.
· Eye protection: Goggles recommended during refilling.
· Body protection: Protective work clothing.
* 9 Physical and chemical properties
· Information on basic physical and chemical properties
· General Information
· Appearance:
Form: Viscous liquid
Color: Dark brown
· Odor: Characteristic
· Odour threshold: Not determined.
· pH-value: Not determined.
· Change in condition
Melting point/Melting range: undetermined
Boiling point/Boiling range: undetermined
· Flash point: 70 °C (158 °F) (TCC)
· Flammability (solid, gaseous) Not applicable.
· Ignition temperature: 265 °C (509 °F)
· Decomposition temperature: Not determined.
· Auto igniting: Product is not selfigniting.
· Danger of explosion: Product is not explosive. However, formation of explosive air/vapor
mixtures are possible.
· Explosion limits:
Lower: 0.6 Vol %
Upper: 6.5 Vol %
· Vapor pressure at 20 °C (68 °F): 6.6 hPa (5 mm Hg)
· Density at 20 °C (68 °F): 0.90-0.93 g/cm³ (7.511-7.761 lbs/gal)
· Relative density Not determined.
· Vapour density Not determined.
· Evaporation rate Not determined.
(Contd. on page 5)
USA
37.1.2
Page 5/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 01/09/2014 Reviewed on 01/09/2014
Trade name: VpCI-368
(Contd. of page 4)
· Solubility in / Miscibility with
Water: Not miscible or difficult to mix
· Partition coefficient (n-octanol/water): Not determined.
· Viscosity:
dynamic: Not determined.
kinematic at 22 °C (72 °F): 1000-2000 cP (ASTM D 2196-99)
· Solvent content:
Organic solvents: 35-40 %
Solids content: 60-65 %
· Other information The above data are typical values and do not constitute a specification.
Vapor pressure data are calculated unless otherwise noted.
10 Stability and reactivity
· Reactivity
· Chemical stability
· Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications.
· Possibility of hazardous reactions No dangerous reactions known
· Conditions to avoid No further relevant information available.
· Incompatible materials: No further relevant information available.
· Hazardous decomposition products: No dangerous decomposition products known
* 11 Toxicological information
· Information on toxicological effects
· Acute toxicity:
· LD/LC50 values that are relevant for classification:
64742-88-7 Solvent naphtha (petroleum), medium aliph.
Oral LD50 >6500 mg/kg (rat)
Dermal LD50 >3000 mg/kg (rab)
Inhalative LC50/4 h >14 mg/l (rat)
· Components Type Value Species
Alkyltriazole LD-50 675 mg/kg Rat
· Primary irritant effect:
· on the skin: Repeated or prolonged skin contact with this product may produce skin irritation.
· on the eye: May be irritating.
· Sensitization: No sensitizing effects known.
· Additional toxicological information:
The product is not subject to classification according to the calculation method of the General EU Classification
Guidelines for Preparations as issued in the latest version:
When used and handled according to specifications, the product does not have any harmful effects according to
our experience and the information provided to us.
· Carcinogenic categories
· IARC (International Agency for Research on Cancer)
None of the ingredients is listed.
(Contd. on page 6)
USA
37.1.2
Page 6/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 01/09/2014 Reviewed on 01/09/2014
Trade name: VpCI-368
(Contd. of page 5)
· NTP (National Toxicology Program)
None of the ingredients is listed.
12 Ecological information
· Toxicity
· Aquatic toxicity: No further relevant information available.
· Persistence and degradability No further relevant information available.
· Behavior in environmental systems:
· Bioaccumulative potential No further relevant information available.
· Mobility in soil No further relevant information available.
· Additional ecological information:
· General notes:
Water hazard class 2 (Self-assessment): hazardous for water.
Do not allow product to reach ground water, water course or sewage system.
Danger to drinking water if even small quantities leak into the ground.
· Results of PBT and vPvB assessment
· PBT: Not applicable.
· vPvB: Not applicable.
· Other adverse effects No further relevant information available.
* 13 Disposal considerations
· Waste treatment methods
· Recommendation
Delivery of waste oil to offically authorized collectors only.
Must not be disposed of together with household garbage. Do not allow product to reach sewage
system.
· Uncleaned packagings:
· Recommendation: Disposal must be made according to official regulations.
* 14 Transport information
· UN-Number
· DOT, ADR, ADN, IMDG, IATA Void
· UN proper shipping name
· DOT, ADR, ADN, IMDG, IATA Void
· Transport hazard class(es)
· DOT, ADR, ADN, IMDG, IATA
· Class Void
(Contd. on page 7)
USA
37.1.2
Page 7/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 01/09/2014 Reviewed on 01/09/2014
Trade name: VpCI-368
(Contd. of page 6)
· Packing group
· DOT, ADR, IMDG, IATA Void
· Environmental hazards:
· Marine pollutant: No
· Special precautions for user Not applicable.
· Transport in bulk according to Annex II of
MARPOL73/78 and the IBC Code Not applicable.
· UN "Model Regulation": -
* 15 Regulatory information
· Safety, health and environmental regulations/legislation specific for the substance or mixture
· SARA Section 355 (extremely hazardous substances)
None of the ingredients is listed.
· SARA Section 313 (specific toxic chemical listings)
None of the ingredients is listed.
· TSCA (Toxic Substances Control Act)
All ingredients are listed.
· Prop 65 - Chemicals known to cause cancer
None of the ingredients is listed.
· Cancerogenity categories
· EPA (Environmental Protection Agency)
None of the ingredients is listed.
· NIOSH-Ca (National Institute for Occupational Safety and Health)
None of the ingredients is listed.
· OSHA-Ca (Occupational Safety & Health Administration)
None of the ingredients is listed.
· GHS label elements Void
· Hazard pictograms Void
· Signal word Void
· Hazard statements Void
· National regulations
· Technical instructions (air):
Class Share in %
NK 40.0
· Chemical safety assessment: A Chemical Safety Assessment has not been carried out.
* 16 Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
Cortec Corporation does not warranty any translation of this SDS not created by Cortec Corporation.
(Contd. on page 8)
USA
37.1.2
Page 8/8
Safety Data Sheet
acc. to OSHA HCS
Printing date 01/09/2014 Reviewed on 01/09/2014
Trade name: VpCI-368
(Contd. of page 7)
· Abbreviations and acronyms:
RID: Règlement international concernant le transport des marchandises dangereuses par chemin de fer (Regulations Concerning the
International Transport of Dangerous Goods by Rail)
ICAO: International Civil Aviation Organization
ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage
of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
DOT: US Department of Transportation
IATA: International Air Transport Association
EINECS: European Inventory of Existing Commercial Chemical Substances
ELINCS: European List of Notified Chemical Substances
CAS: Chemical Abstracts Service (division of the American Chemical Society)
NFPA: National Fire Protection Association (USA)
HMIS: Hazardous Materials Identification System (USA)
LC50: Lethal concentration, 50 percent
LD50: Lethal dose, 50 percent
· * Data compared to the previous version altered.
USA
37.1.2
