Cat Electronic Technician 2023B v1.

1
Product Status Report

8/11/2025 1:53 PM

Product Status Report

Parameter Value
Product ID KYD02747
Equipment ID 777E
Comments

Chassis 777 (KYD02747)

Parameter Value
Product ID KYD02747
Equipment ID KYD02747
Transmission Serial Number C5900682
ECM Part Number 3045687-06
ECM Serial Number 06829352MS
Software Group Part Number 6401351-00
Software Group Release Date MAY2023
Software Group Description 777-KYD/7W8/7G9/7G8/7W9

Logged Diagnostic Codes [Diagnostic Clock = 12026 hours] - Chassis 777 (KYD02747)
Code Description Occ. First Last
709- 5 Transmission Lockup Clutch Solenoid : Current 1 12025 12025
Below Normal
248- 9 Cat Data Link not communicating 1 11894 11894
2448- 9 Graphical Display Module : Abnormal Update Rate 1 11894 11894
3797- 2 Operator Seat Belt Switch : Erratic, Intermittent, or 127 9946 10509
Incorrect

Logged Event Codes [Diagnostic Clock = 12026 hours] - Chassis 777 (KYD02747)
Code Description Occ. First Last
E531 (2) Low Transmission Oil Level 1 12026 12026
E542 (3) Low Steering Pump Pressure 6 11397 11771

Active Diagnostic Codes - Chassis 777 (KYD02747)

Code Description
3797- 2 Operator Seat Belt Switch : Erratic, Intermittent, or Incorrect

Active Event Codes - Chassis 777 (KYD02747)

Code Description
No Active
Events
Current Totals - Chassis 777 (KYD02747)
Description Value Unit
Total Operating Hours 12027 hours
Total Distance 285701.35 Miles

Configuration - Chassis 777 (KYD02747)

Description Value Unit
Equipment ID KYD02747
Product ID KYD02747
Transmission Serial Number C5900682
Transmission Maximum Forward Gear 7
Machine Body Up Speed Limit 6 mph
Machine Overload Speed Limit Enable On
Status
Loaded Machine Speed Limit 0.0 mph
Maximum Reverse Ground Speed 24.9 mph
Maximum Forward Ground Speed 40.4 mph
Machine Speed Correction Factor 0.0000 %
Throttle Lock Enable Gear Limit 0
Transmission Second Forward Gear Start Enabled
Feature Enable Status
Transmission Neutral Idle Enable Status Enabled
Sound Reduction Engine Speed Limit Disabled
Enable Status
Hoist System Enable Status Enabled
Hoist Lower Valve Adjustment Status 0
Auto Lube System Installation Status Not Installed
Auto Lube Interval Unavailable min
Auto Lube Duration Unavailable sec
Operator Seat Belt Monitor Installation Installed
Status
Forced Fuel Economy Mode Configuration Not Forced
Automatic Economy Mode Minimum Fuel- 100.00 %
Speed Ratio Percentage
Automatic Economy Mode Maximum 16.00 %
Speed Loss Percentage
Manual Economy Mode Machine Power 10.00 %
Reduction Percentage
Heated Side Rear View Mirrors Installation Not Installed
Status
Ambient Air Temperature Sensor Installed
Installation Status
Total Tattletale 0

Lifetime:Time vs Actual Gear - Chassis 777 (KYD02747)

Actual Gear( ) hours %
1R 204.80 2.72
2R 0.00 0.00
1R L 0.00 0.00
2R L 0.00 0.00
Neutral 1626.05 21.58
1F 173.35 2.30
2F 524.90 6.97
3F 2.20 0.03
4F 1.80 0.02
5F 1.10 0.01
6F 0.20 0.00
7F 0.05 0.00
1F L 74.00 0.98
2F L 406.25 5.39
3F L 659.55 8.75
4F L 1165.80 15.47
5F L 1711.60 22.72
6F L 924.60 12.27
7F L 58.40 0.78

Transmission Filter Bypass Count vs Transmission Oil Temperature - Chassis 777 (KYD02747)
Transmission Oil Temperature( Count %
Deg F )
<14.0 0 0.00
14.0-31.9 0 0.00
32.0-49.9 0 0.00
50.0-67.9 0 0.00
68.0-85.9 0 0.00
86.0-103.9 0 0.00
104.0-122.0 0 0.00
>122.0 0 0.00

Transmission Filter Bypass Time vs Transmission Oil Temperature - Chassis 777 (KYD02747)
Transmission Oil Temperature( hours %
Deg F )
<14.0 0.00 0.00
14.0-31.9 0.00 0.00
32.0-49.9 0.00 0.00
50.0-67.9 0.00 0.00
68.0-85.9 0.00 0.00
86.0-103.9 0.00 0.00
104.0-122.0 0.00 0.00
>122.0 0.00 0.00

Lifetime:Time vs Torque Converter Oil Outlet Temperature And Transmission Oil Temperature -
Chassis 777 (KYD02747)
Deg F <122 122-157 158-193 194-211 212-229 230-247 248-265 266-283 284-302
Deg F
<14 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
14-103 14.05 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
104-139 23.60 50.05 0.00 0.00 0.00 0.00 0.00 0.00 0.00
140-157 0.00 95.25 11.55 0.00 0.00 0.00 0.00 0.00 0.00
158-175 0.00 3.80 419.65 0.25 0.00 0.00 0.00 0.00 0.00
176-193 0.00 0.00 6586.00 61.35 0.85 0.10 0.00 0.00 0.00
194-211 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
212-229 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
230-248 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
>248 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 37.65 149.10 7017.20 61.60 0.85 0.10 0.00 0.00 0.00

Lifetime:Time vs Torque Converter Oil Outlet Temperature And Transmission Oil Temperature -
Chassis 777 (KYD02747)
Deg F >302 Total
Deg F
<14 0.00 0.00
14-103 0.00 14.05
104-139 0.00 73.65
140-157 0.00 106.80
158-175 0.00 423.70
176-193 0.00 6648.30
194-211 0.00 0.00
212-229 0.00 0.00
230-248 0.00 0.00
>248 0.00 0.00
Total 0.00 7266.50

Shift Count Matrix [Transmission Shift Counts Start Time = 0 hours, Diagnostic Clock =
12026.6796 hours] - Chassis 777 (KYD02747)
To N R1 R2 1 2 3 4 5 6 7
From
N --- 46776 0 30218 68557 0 2 1 0 13
R1 58827 --- 0 820 7382 0 0 0 0 0
R2 0 0 --- 0 0 0 0 0 0 0
1 16911 3054 0 --- 47589 8 0 0 0 0
2 69562 17118 0 36249 --- 199924 0 0 0 0
3 142 70 0 208 197252 --- 250708 1 0 0
4 14 10 0 85 1650 248024 --- 247996 0 0
5 0 1 0 9 451 393 247007 --- 139260 0
6 2 0 0 1 38 31 62 139121 --- 18723
7 13 0 0 0 2 1 0 2 18718 ---

Counters - Chassis 777 (KYD02747)

Description Value
Lockup Clutch Count 179303
Load Count Abnormal/Incorrect Data
Total Load Count 24476

Product Link Elite (KYD02747)

Parameter Value
Product ID KYD02747
Machine Serial Number
Equipment ID 777E
ECM Part Number 4590786-05
ECM Serial Number 3511F539TR
Software Group Part Number 6288087-00
Software Group Release Date Nov2022
Software Group Description VIMS_TELEMATICS_2022_11_17
Application Software Part Number 6401355-00
Cellular Device ECM Serial Number NA
Cellular Device ECM Hardware Part Number NA
Cellular Radio Module Software Part Number NA
Satellite Device ECM Serial Number 3261V040YH
Satellite Device ECM Hardware Part Number 5441881-08
Satellite Radio Module Software Part Number 6279054-00

Logged Diagnostic Codes [Total Operating Hours = 12026 hours] - Product Link Elite (KYD02747)
Code Description Occ. First Last
2448- 9 Graphical Display Module : Abnormal Update Rate 1 11272 11272
839- 3 Right Front Strut Pressure Sensor : Voltage Above 1 11272 11272
Normal

Logged Event Codes [Total Operating Hours = 12026 hours] - Product Link Elite (KYD02747)
Code Description Occ. First Last
E2126 (1) Payload Overload Limit Exceeded 44 11774 12019
E2126 (2) Payload Overload Limit Exceeded 6 11783 12012
E237 (2) Machine Overloaded 68 11153 11783

Active Diagnostic Codes - Product Link Elite (KYD02747)

Code Description
No Active
Diagnostic
Codes

Active Event Codes - Product Link Elite (KYD02747)

Code Description
No Active
Events

Current Totals - Product Link Elite (KYD02747)

Description Value Unit
Total Operating Hours 12026.6 hours
Total Distance 285701.35 Miles

Configuration - Product Link Elite (KYD02747)

Description Value Unit
Product ID KYD02747
Equipment ID 777E
External Service Lamp Installation Installed
Configuration
External Service Lamp Display Mode Disabled
Setting
Telemetry Feature Installation Status Installed
Telemetry Feature Enable Status Enabled
TMAC Protocol Port Selection Disabled
Tire Monitoring System Installation Status Unavailable
CAT Data Link Module Identifier Gateway #1
Configuration
Machine Serial Number
Mining Aftermarket System Installation Unavailable
Status
Maintenance Mode Off
Data Acquisition System Installation Status Installed
Data Acquisition System Customer Enable Enabled
Status
Basic Payload Control System Installation Unavailable
Status
Basic Payload Control System Enable Unavailable
Status
Basic Payload Control System Temporary Unavailable
Installation Status
Basic Payload Control System Temporary Unavailable min
Installation Time Remaining
Target Payload 113.5 ton
Payload Overload Limit 120.0 %
Green TPMS Lamp Installation LED
Configuration
Red TPMS Lamp Installation Configuration LED
Truck Payload Last Pass Indicator Enable Enabled
Status
External Payload Indicator Configuration Disabled
OHT Payload Re-weigh Second Gear
Front Axle Strut Pressure to Payload 5100
Weight Ratio Configuration
Machine Payload Control System Installed
Installation Status
Machine Payload Control System Enable Enabled
Status
Road Analysis System Installation Status Not Installed
Tire Analysis System Installation Status Not Installed
Tire Analysis System Temporary Not Installed
Installation Status
Tire Analysis System Customer Enable Disabled
Status
Tire Analysis System Temporary 15000 min
Installation Time Remaining

Brake 777 (KYD02747)

Parameter Value
Product ID KYD02747
Equipment ID KYD02747
ECM Part Number 3045687-06
ECM Serial Number 06328671MS
Software Group Part Number 6401354-00
Software Group Release Date JUN2023
Software Group Description 777-KYD/7W8/7W9/7G8/7G9

Logged Diagnostic Codes [Diagnostic Clock = 12026 hours] - Brake 777 (KYD02747)
Code Description Occ. First Last
No Logged
Diagnostic
Codes

Logged Event Codes [Diagnostic Clock = 12026 hours] - Brake 777 (KYD02747)
Code Description Occ. First Last
E1223 (1) Front Brake Cooling Filter Plugged 127 11828 12026
E088 (2) High Left Rear Brake Oil Temperature 33 11311 12011
E284 (3) Low Brake Accumulator Pressure 1 12000 12000
E089 (2) High Right Rear Brake Oil Temperature 24 11311 11995

Active Diagnostic Codes - Brake 777 (KYD02747)

Code Description
No Active
Diagnostic
Codes

Active Event Codes - Brake 777 (KYD02747)

Code Description
No Active
Events

Configuration - Brake 777 (KYD02747)

Description Value Unit
Product ID KYD02747
Equipment ID KYD02747
Desired Engine Retard Speed 1800 rpm
Auto Retarder Control System Installation Installed
Status
Oil Cooled Front Brake Installation Status Not Installed
Traction Control System Installation Status Installed
Automatic Traction Control Enable Status Enabled
Brake Response Setting Configuration 10
Code
Third Party Collision Avoidance System Not Installed
Installation Status
Total Tattletale 1

Object Detection System 777

Parameter Value
Equipment ID KYD02747
ECM Part Number 4592220-05
ECM Serial Number 3281G036ZU
Software Group Part Number 5985811-00
Software Group Release Date May2020
Software Group Description OBJECT DETECTION SYSTEM

Logged Diagnostic Codes [Diagnostic Clock = 12026 hours] - Object Detection System 777
Code Description Occ. First Last
No Logged
Diagnostic
Codes

Logged Event Codes [Diagnostic Clock = 12026 hours] - Object Detection System 777
Code Description Occ. First Last
No Logged
Event Codes

Active Diagnostic Codes - Object Detection System 777

Code Description
No Active
Diagnostic
Codes

Active Event Codes - Object Detection System 777

Code Description
No Active
Events

Configuration - Object Detection System 777

Description Value Unit
Equipment ID KYD02747
Camera #1 Location Front
Camera #2 Location Right
Camera #3 Location Rear
Camera #4 Location Not Installed
Automatic Camera View Dimming Enable Disabled
Status
Object Detection System Activation Delay 0.0 sec
Time
Radar Profile Configuration Code 0
Object Detection Alarm Mode Unavailable
Medium Range Object Detection Sensor #3 Unavailable
Installation Status
Medium Range Object Detection Sensor #4 Unavailable
Installation Status

Monitor 777 (KYD02747)

Parameter Value
Equipment ID EQUIP_ID
ECM Part Number 4592222-05
ECM Serial Number 0242G046ZU
Software Group Part Number 6381668-00
Software Group Release Date MAY2023
Software Group Description OHT_Information Display

Logged Diagnostic Codes [Diagnostic Clock = 12026 hours] - Monitor 777 (KYD02747)
Code Description Occ. First Last
248- 9 Cat Data Link not communicating 2 11598 11598
800- 9 VIMS Main Module : Abnormal Update Rate 2 11598 11598
1273-14 Chassis Control Module : Special Instruction 1 11161 11161

Logged Event Codes [Diagnostic Clock = 12026 hours] - Monitor 777 (KYD02747)
Code Description Occ. First Last
No Logged
Event Codes

Active Diagnostic Codes - Monitor 777 (KYD02747)

Code Description
No Active
Diagnostic
Codes

Active Event Codes - Monitor 777 (KYD02747)

Code Description
No Active
Events

Configuration - Monitor 777 (KYD02747)

Description Value Unit
Equipment ID EQUIP_ID
Information Units Status Metric
Display Language Status Indonesian
Service Mode Enable Code 3647

C32 777 (ZRK00216)

Parameter Value
Equipment ID KYD02747
Engine Serial Number ZRK00216
ECM Serial Number 27519453VA
Software Group Part Number 6202645-00
Software Group Release Date MAY21
Software Group Description C32-777

Logged Diagnostic Codes [Diagnostic Clock = 12026 hours] - C32 777 (ZRK00216)
Code Description Occ. First Last
262- 4 5 Volt Sensor DC Power Supply : Voltage Below 1 12025 12025
Normal
827- 3 Left Exhaust Temperature Sensor : Voltage Above 1 12025 12025
Normal
828- 3 Right Exhaust Temperature Sensor : Voltage 1 12025 12025
Above Normal
2350- 3 Left Exhaust #2 Temperature : Voltage Above 1 12025 12025
Normal
2351- 3 Right Exhaust #2 Temperature : Voltage Above 1 12025 12025
Normal

Logged Event Codes [Diagnostic Clock = 12026 hours] - C32 777 (ZRK00216)
Code Description Occ. First Last
E362 (1) Engine Overspeed 4 4840 10775

Active Diagnostic Codes - C32 777 (ZRK00216)

Code Description
No Active
Diagnostic
Codes

Active Event Codes - C32 777 (ZRK00216)

Code Description
No Active
Events

Current Totals - C32 777 (ZRK00216)

Description Value Unit
Total Idle Time 2855:00 hours
Total Fuel 192561 gal
Total Idle Fuel 7171 gal
Total Max Fuel 608528 gal
Engine Lifetime Hours 12030.3 hours
Average Load Factor 30 %
Engine Starts 17214
Lifetime Total Engine 925195820 rev
Revolutions
Total Operating Hours 12027 hours
Total Engine Idle Shutdown 149
Count
Total Engine Idle Shutdown 1584
Overrides Count
Total Delayed Engine 4539
Shutdown Count
Total Delayed Engine 519
Shutdown Overrides Count
Starts/Hour 1.43
Average RPM 1281.75 rpm
Percentage Idle Time 23.73 %
Average Fuel Rate 16.01 gal/h
Overall Load Factor 31 %

Configuration - C32 777 (ZRK00216)

Description Value Unit
Equipment ID KYD02747
Engine Serial Number ZRK00216
ECM Serial Number 27519453VA
Software Group Part Number 6202645-00
Software Group Release Date MAY21
Software Group Description C32-777
Rating Number 1
Rated Power 1022 hp at 1800 rpm
Rated Peak Torque 3890 lb-ft at 1200 rpm
Low Idle Speed 700 rpm
High Idle Speed 2000 rpm
Ether Solenoid Configuration Not Installed
Low System Battery Voltage Elevated Idle Enabled
Engine Warm Up Elevated Idle Feature Enabled
Enable Status
Engine Coolant Dual Pressure Sensors Installed
Installation Status
Engine Idle Shutdown Enable Status Disabled
Engine Idle Shutdown Delay Time 3.0 min
Delayed Engine Shutdown Enable Status Enabled
Delayed Engine Shutdown Maximum Time 4.0 min
FLS 13
FTS 0
CAN Communication Protocol Write Seed and Key Access
Security
CAN Communication Protocol Read Seed and Key Access
Security
Total Tattletale 6830

Lifetime:Accumulated Time vs Intake Manifold Pressure - C32 777 (ZRK00216)

Intake Manifold Pressure( psi ) hours %
<11.603 24.40 1.31
11.603-13.052 20.25 1.09
13.053-14.503 25.40 1.37
14.504-15.953 32.85 1.77
15.954-17.404 44.90 2.42
17.405-18.854 70.50 3.80
18.855-20.304 122.15 6.58
20.305-21.755 290.40 15.63
21.756-23.205 752.90 40.53
23.206-24.655 469.40 25.27
24.656-26.106 4.40 0.24
26.107-27.556 0.00 0.00
27.557-29.007 0.00 0.00
29.008-30.457 0.00 0.00
30.458-31.907 0.00 0.00
31.908-33.358 0.00 0.00
33.359-34.808 0.00 0.00
34.809-36.258 0.00 0.00
36.259-37.709 0.00 0.00
37.710-39.159 0.00 0.00
39.160-40.610 0.00 0.00
40.611-42.060 0.00 0.00
42.061-43.510 0.00 0.00
43.511-44.961 0.00 0.00
44.962-46.411 0.00 0.00
46.412-47.861 0.00 0.00
47.862-49.312 0.00 0.00
49.313-50.762 0.00 0.00
50.763-52.213 0.00 0.00
52.214-53.663 0.00 0.00
53.664-55.113 0.00 0.00
55.114-56.564 0.00 0.00
56.565-58.014 0.00 0.00
58.015-59.464 0.00 0.00
59.465-60.915 0.00 0.00
60.916-62.365 0.00 0.00
62.366-63.816 0.00 0.00
63.817-65.266 0.00 0.00
65.267-66.716 0.00 0.00
66.717-68.167 0.00 0.00
68.168-69.617 0.00 0.00
69.618-71.067 0.00 0.00
71.068-72.518 0.00 0.00
72.519-73.968 0.00 0.00
73.969-75.419 0.00 0.00
75.420-76.869 0.00 0.00
76.870-78.319 0.00 0.00
78.320-79.770 0.00 0.00
79.771-81.220 0.00 0.00
81.221-82.670 0.00 0.00
82.671-84.121 0.00 0.00
84.122-85.571 0.00 0.00
85.572-87.023 0.00 0.00
>87.023 0.00 0.00

Engine Overspeed Histogram: Accumulated Time (sec) vs Engine Speed - C32 777 (ZRK00216)
Engine Speed( rpm ) Count %
2500.0-2599.9 161 81.31
2600.0-2699.9 30 15.15
2700.0-2799.9 4 2.02
2800.0-2899.9 3 1.52
2900.0-2999.9 0 0.00
3000.0-3099.9 0 0.00
3100.0-3199.9 0 0.00
3200.0-3299.9 0 0.00
3300.0-3400.0 0 0.00
>3400.0 0 0.00

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C32 777 (ZRK00216)
rpm <600.0 600.0- 650.0- 700.0- 750.0- 800.0- 850.0- 900.0- 950.0-
 649.9 699.9 749.9 799.9 849.9 899.9 949.9 999.9
%
<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
0.0-9.9 4.05 12.35 779.10 1329.40 28.15 23.75 21.80 21.25 21.05
10.0- 1.40 8.35 49.10 43.60 8.80 6.50 5.45 5.00 4.95
19.9
20.0- 1.95 13.40 209.05 230.20 10.35 7.30 5.70 5.70 6.25
29.9
30.0- 0.50 2.00 8.20 3.95 4.85 5.95 5.15 4.95 5.20
39.9
40.0- 0.30 0.10 0.40 1.10 1.95 2.70 3.00 3.35 4.15
49.9
50.0- 0.30 0.00 0.15 0.50 0.95 1.45 1.60 1.65 1.90
59.9
60.0- 0.30 0.00 0.10 0.25 0.50 0.85 1.10 1.35 1.75
69.9
70.0- 0.25 0.00 0.05 0.20 0.35 0.70 1.50 2.90 4.95
79.9
80.0- 0.30 0.00 0.15 0.40 0.90 1.60 2.20 2.65 2.40
89.9
90.0- 9.95 0.15 0.35 0.50 0.65 0.85 0.95 0.95 0.90
100.0
>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 19.30 36.35 1046.65 1610.10 57.45 51.65 48.45 49.75 53.50

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C32 777 (ZRK00216)
rpm 1000.0- 1050.0- 1100.0- 1150.0- 1200.0- 1250.0- 1300.0- 1350.0- 1400.0-
1049.9 1099.9 1149.9 1199.9 1249.9 1299.9 1349.9 1399.9 1449.9
%
<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
0.0-9.9 21.35 26.05 42.60 80.70 107.15 133.40 162.40 186.90 202.35
10.0- 5.25 6.25 9.05 15.95 20.90 24.30 29.30 33.60 35.40
19.9
20.0- 7.20 8.75 13.05 21.85 31.50 42.85 53.90 59.40 60.45
29.9
30.0- 5.40 6.95 10.60 16.25 21.95 28.25 36.60 44.00 46.85
39.9
40.0- 3.90 4.15 6.65 11.25 15.10 19.30 25.20 30.95 33.15
49.9
50.0- 2.40 3.10 5.40 10.25 14.75 19.40 26.15 33.40 37.60
59.9
60.0- 2.35 4.15 8.25 14.40 19.05 24.45 33.35 41.20 44.85
69.9
70.0- 7.35 7.50 6.90 10.10 17.30 24.95 31.80 38.60 43.15
79.9
80.0- 1.90 1.55 2.45 6.10 11.50 18.75 27.80 37.30 41.15
89.9
90.0- 1.45 2.85 8.70 27.65 59.55 92.95 125.55 156.40 177.95
100.0
>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 58.55 71.30 113.65 214.50 318.75 428.60 552.05 661.75 722.90
Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C32 777 (ZRK00216)
rpm 1450.0- 1500.0- 1550.0- 1600.0- 1650.0- 1700.0- 1750.0- 1800.0- 1850.0-
1499.9 1549.9 1599.9 1649.9 1699.9 1749.9 1799.9 1849.9 1899.9
%
<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
0.0-9.9 209.55 208.05 197.95 191.30 179.35 173.45 179.70 140.10 71.15
10.0- 36.55 35.30 31.60 29.70 25.65 22.65 17.45 5.95 2.80
19.9
20.0- 59.85 57.00 50.20 44.00 34.35 31.75 35.95 5.55 2.55
29.9
30.0- 45.65 42.20 36.95 32.45 26.90 28.80 41.95 5.45 2.65
39.9
40.0- 33.05 31.45 28.20 25.60 21.35 18.15 12.85 4.65 2.15
49.9
50.0- 38.30 37.80 35.15 32.20 27.85 23.95 16.45 7.15 2.95
59.9
60.0- 44.80 43.45 39.90 36.15 31.20 27.30 18.95 8.65 3.70
69.9
70.0- 44.10 43.15 40.05 36.75 32.70 28.10 20.40 9.70 4.25
79.9
80.0- 43.10 41.45 38.30 33.95 28.00 24.65 19.00 10.40 4.95
89.9
90.0- 180.80 181.95 177.55 162.95 140.15 121.50 103.95 81.55 38.35
100.0
>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 735.75 721.80 675.85 625.05 547.50 500.30 466.65 279.15 135.50

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C32 777 (ZRK00216)
rpm 1900.0- 1950.0- 2000.0- 2050.0- 2100.0- 2150.0- 2200.0- 2250.0- 2300.0-
1949.9 1999.9 2049.9 2099.9 2149.9 2199.9 2249.9 2299.9 2349.9
%
<0.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
0.0-9.9 44.40 34.30 25.90 14.35 6.30 1.95 0.75 0.40 0.20
10.0- 1.60 1.50 1.00 0.10 0.00 0.00 0.00 0.00 0.00
19.9
20.0- 1.50 2.20 2.25 0.05 0.00 0.00 0.00 0.00 0.00
29.9
30.0- 1.65 1.50 0.95 0.05 0.00 0.00 0.00 0.00 0.00
39.9
40.0- 1.40 1.30 0.95 0.05 0.00 0.00 0.00 0.00 0.00
49.9
50.0- 1.45 1.30 1.10 0.05 0.00 0.00 0.00 0.00 0.00
59.9
60.0- 1.75 1.35 0.95 0.05 0.00 0.00 0.00 0.00 0.00
69.9
70.0- 2.20 1.65 1.15 0.05 0.00 0.00 0.00 0.00 0.00
79.9
80.0- 2.70 2.45 1.60 0.05 0.00 0.00 0.00 0.00 0.00
89.9
90.0- 19.10 11.00 1.85 0.05 0.00 0.00 0.00 0.00 0.00
100.0
>100.0 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 77.75 58.55 37.70 14.85 6.30 1.95 0.75 0.40 0.20

Lifetime:Accumulated Time vs Engine Speed And Percent Engine Load at Current Engine Speed -
C32 777 (ZRK00216)
rpm 2350.0-2400.0 >2400.0 Total
%
<0.0 0.00 0.00 0.00
0.0-9.9 0.10 0.15 4883.20
10.0-19.9 0.00 0.00 525.00
20.0-29.9 0.00 0.00 1116.05
30.0-39.9 0.00 0.00 524.75
40.0-49.9 0.00 0.00 347.85
50.0-59.9 0.00 0.00 386.65
60.0-69.9 0.00 0.00 456.45
70.0-79.9 0.00 0.00 462.80
80.0-89.9 0.00 0.00 409.70
90.0-100.0 0.00 0.00 1889.05
>100.0 0.00 0.00 0.00
Total 0.10 0.15 11001.50

Lifetime:Accumulated Time vs Intake Manifold Air Temperature - C32 777 (ZRK00216)

Intake Manifold Air hours %
Temperature( Deg F )
<32.00 0.00 0.00
32.00-40.99 0.00 0.00
41.00-49.99 0.00 0.00
50.00-58.99 0.00 0.00
59.00-67.99 0.00 0.00
68.00-76.99 0.45 0.00
77.00-85.99 119.55 1.06
86.00-94.99 2220.10 19.65
95.00-103.99 4510.90 39.92
104.00-112.99 3430.05 30.36
113.00-121.99 861.50 7.62
122.00-130.99 151.70 1.34
131.00-139.99 5.10 0.05
140.00-148.99 0.05 0.00
149.00-157.99 0.00 0.00
158.00-166.99 0.00 0.00
167.00-175.99 0.00 0.00
176.00-184.99 0.00 0.00
185.00-193.99 0.00 0.00
194.00-202.99 0.00 0.00
203.00-211.99 0.00 0.00
212.00-220.99 0.00 0.00
221.00-229.99 0.00 0.00
230.00-238.99 0.00 0.00
239.00-248.00 0.00 0.00
>248.00 0.00 0.00

Lifetime:Accumulated Time vs Engine Speed - C32 777 (ZRK00216)

Engine Speed( rpm ) hours %
<550.0 11.70 0.10
550.0-599.9 8.65 0.08
600.0-649.9 37.35 0.33
650.0-699.9 1096.50 9.75
700.0-749.9 1678.75 14.93
750.0-799.9 60.35 0.54
800.0-849.9 54.10 0.48
850.0-899.9 50.75 0.45
900.0-949.9 52.05 0.46
950.0-999.9 55.85 0.50
1000.0-1049.9 60.85 0.54
1050.0-1099.9 73.75 0.66
1100.0-1149.9 116.50 1.04
1150.0-1199.9 218.85 1.95
1200.0-1249.9 324.10 2.88
1250.0-1299.9 434.90 3.87
1300.0-1349.9 559.85 4.98
1350.0-1399.9 670.60 5.96
1400.0-1449.9 732.30 6.51
1450.0-1499.9 745.35 6.63
1500.0-1549.9 731.30 6.50
1550.0-1599.9 684.50 6.09
1600.0-1649.9 633.25 5.63
1650.0-1699.9 554.65 4.93
1700.0-1749.9 506.95 4.51
1750.0-1799.9 471.75 4.19
1800.0-1849.9 282.15 2.51
1850.0-1899.9 137.20 1.22
1900.0-1949.9 78.80 0.70
1950.0-1999.9 59.65 0.53
2000.0-2049.9 38.40 0.34
2050.0-2099.9 14.90 0.13
2100.0-2149.9 6.45 0.06
2150.0-2199.9 2.00 0.02
2200.0-2249.9 0.80 0.01
2250.0-2299.9 0.40 0.00
2300.0-2349.9 0.20 0.00
2350.0-2399.9 0.10 0.00
2400.0-2449.9 0.10 0.00
2450.0-2499.9 0.05 0.00
2500.0-2549.9 0.05 0.00
2550.0-2599.9 0.00 0.00
2600.0-2649.9 0.00 0.00
2650.0-2699.9 0.00 0.00
2700.0-2749.9 0.00 0.00
2750.0-2799.9 0.00 0.00
2800.0-2849.9 0.00 0.00
2850.0-2899.9 0.00 0.00
2900.0-2949.9 0.00 0.00
2950.0-2999.9 0.00 0.00
3000.0-3049.9 0.00 0.00
3050.0-3099.9 0.00 0.00
3100.0-3149.9 0.00 0.00
3150.0-3199.9 0.00 0.00
3200.0-3249.9 0.00 0.00
3250.0-3299.9 0.00 0.00
3300.0-3349.9 0.00 0.00
3350.0-3400.0 0.00 0.00
>3400.0 0.00 0.00

Lifetime:Accumulated Time vs Air Inlet Temperature - C32 777 (ZRK00216)

Air Inlet Temperature( Deg F ) hours %
<(-4.00) 0.00 0.00
(-4.00)-4.99 0.00 0.00
5.00-13.99 0.00 0.00
14.00-22.99 0.00 0.00
23.00-31.99 0.00 0.00
32.00-40.99 0.00 0.00
41.00-49.99 0.00 0.00
50.00-58.99 0.00 0.00
59.00-67.99 0.00 0.00
68.00-76.99 38.40 0.34
77.00-85.99 4334.90 38.37
86.00-94.99 4988.15 44.15
95.00-103.99 1714.60 15.18
104.00-112.99 212.70 1.88
113.00-121.99 9.15 0.08
122.00-130.99 0.25 0.00
131.00-139.99 0.00 0.00
140.00-148.99 0.00 0.00
149.00-157.99 0.00 0.00
158.00-166.99 0.00 0.00
167.00-176.00 0.00 0.00
>176.00 0.00 0.00

High Exhaust Temperature Prevention Derate Time - C32 777 (ZRK00216)

Deg F <104.00 104.00- 113.00- 122.00- 131.00- 140.00- 149.00- 158.00- 167.00-
112.99 121.99 130.99 139.99 148.99 157.99 166.99 175.99
psi
<8.702 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
8.702- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
9.862
9.863- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
11.022
11.023- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
12.182
12.183- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
13.342
13.343- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
14.504
>14.504 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00

High Exhaust Temperature Prevention Derate Time - C32 777 (ZRK00216)

Deg F 176.00- 185.00- 194.00- 203.00- >212.00 Total
184.99 193.99 202.99 212.00
psi
<8.702 0.00 0.00 0.00 0.00 0.00 0.00
8.702-9.862 0.00 0.00 0.00 0.00 0.00 0.00
9.863-11.022 0.00 0.00 0.00 0.00 0.00 0.00
11.023- 0.00 0.00 0.00 0.00 0.00 0.00
12.182
12.183- 0.00 0.00 0.00 0.00 0.00 0.00
13.342
13.343- 0.00 0.00 0.00 0.00 0.00 0.00
14.504
>14.504 0.00 0.00 0.00 0.00 0.00 0.00
Total 0.00 0.00 0.00 0.00 0.00 0.00

High Turbo Speed Prevention Derate Time - C32 777 (ZRK00216)

Deg F <41.00 41.00- 59.00- 77.00- 95.00- 113.00- 131.00- >149.00 Total
58.99 76.99 94.99 112.99 130.99 149.00
psi
<8.702 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
8.702- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
9.862
9.863- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
11.022
11.023- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
12.182
12.183- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
13.342
13.343- 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
14.504
>14.504 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00

Lifetime:Accumulated Time vs Engine Coolant Temperature - C32 777 (ZRK00216)

Engine Coolant Temperature( hours %
Deg F )
<32.00 0.00 0.00
32.00-40.99 0.00 0.00
41.00-49.99 0.00 0.00
50.00-58.99 0.00 0.00
59.00-67.99 0.00 0.00
68.00-76.99 0.00 0.00
77.00-85.99 0.05 0.00
86.00-94.99 2.10 0.02
95.00-103.99 8.30 0.07
104.00-112.99 14.55 0.13
113.00-121.99 19.85 0.18
122.00-130.99 26.15 0.23
131.00-139.99 37.65 0.33
140.00-148.99 52.85 0.47
149.00-157.99 82.45 0.73
158.00-166.99 142.50 1.26
167.00-175.99 1323.75 11.72
176.00-184.99 9497.30 84.05
185.00-193.99 90.10 0.80
194.00-202.99 1.55 0.01
203.00-211.99 0.20 0.00
212.00-220.99 0.00 0.00
221.00-229.99 0.00 0.00
230.00-238.99 0.00 0.00
239.00-247.99 0.00 0.00
248.00-256.99 0.00 0.00
257.00-265.99 0.00 0.00
266.00-274.99 0.00 0.00
275.00-283.99 0.00 0.00
284.00-292.99 0.00 0.00
293.00-302.00 0.00 0.00
>302.00 0.00 0.00

Lifetime:Accumulated Occurrences vs Engine Speed And Engine Retarder Status - C32 777
(ZRK00216)
rpm <1000.0 1000.0- 1300.0- 1600.0- 1900.0- 2200.0- 2500.0- >2800.0 Total
1299.9 1599.9 1899.9 2199.9 2499.9 2800.0
Engine
Retarder
Status
1-1 0 0 0 0 0 0 0 0 0
2-2 0 0 0 0 0 0 0 0 0
3-4 0 0 0 0 0 0 0 0 0
Total 0 0 0 0 0 0 0 0 0

Lifetime:Accumulated Time vs Left #1 Exhaust Temperature - C32 777 (ZRK00216)

Left #1 Exhaust Temperature( hours %
Deg F )
<842.00 7621.45 67.54
842.00-868.99 298.45 2.64
869.00-895.99 311.15 2.76
896.00-922.99 308.20 2.73
923.00-949.99 326.40 2.89
950.00-976.99 352.50 3.12
977.00-1003.99 370.80 3.29
1004.00-1030.99 433.60 3.84
1031.00-1057.99 468.90 4.16
1058.00-1084.99 397.30 3.52
1085.00-1111.99 260.80 2.31
1112.00-1138.99 108.75 0.96
1139.00-1165.99 24.20 0.21
1166.00-1192.99 2.45 0.02
1193.00-1219.99 0.05 0.00
1220.00-1246.99 0.00 0.00
1247.00-1273.99 0.00 0.00
1274.00-1300.99 0.00 0.00
1301.00-1327.99 0.00 0.00
1328.00-1354.99 0.00 0.00
1355.00-1381.99 0.00 0.00
1382.00-1408.99 0.00 0.00
1409.00-1435.99 0.00 0.00
1436.00-1463.00 0.00 0.00
>1463.00 0.00 0.00

Lifetime:Accumulated Time vs Left #2 Exhaust Temperature - C32 777 (ZRK00216)

Left #2 Exhaust Temperature( hours %
Deg F )
<842.00 7727.75 68.47
842.00-868.99 304.05 2.69
869.00-895.99 318.55 2.82
896.00-922.99 324.55 2.88
923.00-949.99 337.45 2.99
950.00-976.99 365.90 3.24
977.00-1003.99 404.60 3.59
1004.00-1030.99 472.40 4.19
1031.00-1057.99 469.50 4.16
1058.00-1084.99 325.15 2.88
1085.00-1111.99 170.55 1.51
1112.00-1138.99 55.05 0.49
1139.00-1165.99 9.20 0.08
1166.00-1192.99 0.85 0.01
1193.00-1219.99 0.00 0.00
1220.00-1246.99 0.00 0.00
1247.00-1273.99 0.00 0.00
1274.00-1300.99 0.00 0.00
1301.00-1327.99 0.00 0.00
1328.00-1354.99 0.00 0.00
1355.00-1381.99 0.00 0.00
1382.00-1408.99 0.00 0.00
1409.00-1435.99 0.00 0.00
1436.00-1463.00 0.00 0.00
>1463.00 0.00 0.00

Lifetime:Accumulated Time vs Right #1 Exhaust Temperature - C32 777 (ZRK00216)

Right #1 Exhaust Temperature( hours %
Deg F )
<842.00 7522.75 66.67
842.00-868.99 267.95 2.37
869.00-895.99 276.25 2.45
896.00-922.99 278.95 2.47
923.00-949.99 293.50 2.60
950.00-976.99 313.30 2.78
977.00-1003.99 327.70 2.90
1004.00-1030.99 375.80 3.33
1031.00-1057.99 423.65 3.75
1058.00-1084.99 413.10 3.66
1085.00-1111.99 355.50 3.15
1112.00-1138.99 244.90 2.17
1139.00-1165.99 125.90 1.12
1166.00-1192.99 52.70 0.47
1193.00-1219.99 10.75 0.10
1220.00-1246.99 1.15 0.01
1247.00-1273.99 0.05 0.00
1274.00-1300.99 0.00 0.00
1301.00-1327.99 0.00 0.00
1328.00-1354.99 0.00 0.00
1355.00-1381.99 0.00 0.00
1382.00-1408.99 0.00 0.00
1409.00-1435.99 0.00 0.00
1436.00-1463.00 0.00 0.00
>1463.00 0.00 0.00

Lifetime:Accumulated Time vs Right #2 Exhaust Temperature - C32 777 (ZRK00216)

Right #2 Exhaust Temperature( hours %
Deg F )
<842.00 7615.20 67.48
842.00-868.99 271.35 2.40
869.00-895.99 279.50 2.48
896.00-922.99 283.40 2.51
923.00-949.99 293.75 2.60
950.00-976.99 308.80 2.74
977.00-1003.99 315.75 2.80
1004.00-1030.99 348.85 3.09
1031.00-1057.99 393.55 3.49
1058.00-1084.99 413.35 3.66
1085.00-1111.99 387.20 3.43
1112.00-1138.99 248.50 2.20
1139.00-1165.99 97.85 0.87
1166.00-1192.99 25.00 0.22
1193.00-1219.99 2.45 0.02
1220.00-1246.99 0.10 0.00
1247.00-1273.99 0.00 0.00
1274.00-1300.99 0.00 0.00
1301.00-1327.99 0.00 0.00
1328.00-1354.99 0.00 0.00
1355.00-1381.99 0.00 0.00
1382.00-1408.99 0.00 0.00
1409.00-1435.99 0.00 0.00
1436.00-1463.00 0.00 0.00
>1463.00 0.00 0.00

Injector Trim Calibration - C32 777 (ZRK00216)

Injector Serial Number File Version
Injector1 000000005A5422028919 0
Injector2 000000005A5422112201 0
Injector3 000000005A54221085FD 0
Injector4 000000005A5422107025 0
Injector5 000000005A5422114176 0
Injector6 000000005A54221083EF 0
Injector7 000000005A5422029621 0
Injector8 000000005A54221244D0 0
Injector9 000000005A54221428F7 0
Injector10 000000005A542211081D 0
Injector11 000000005A5422120583 0
Injector12 000000005A5422111339 0

Monitoring System - C32 777 (ZRK00216)

Description State Trip Point Delay Time
Engine Overspeed
Least Severe (1) Always On 2600 rpm 0 sec
High Air Inlet #1
Differential Pressure
Least Severe (1) Always On 0.9 psi 0 sec
Moderate Severity (2) Always On 0.9 psi 0 sec
High Air Inlet #2
Differential Pressure
Least Severe (1) Always On 0.9 psi 0 sec
Moderate Severity (2) Always On 0.9 psi 0 sec
High Engine Coolant
Temperature
Least Severe (1) Always On 230 Deg F 10 sec
Moderate Severity (2) On 232 Deg F 20 sec
High Fuel Filter
Pressure Restriction
Least Severe (1) Always On None 0 sec
High Fuel Temperature
Least Severe (1) Always On 194.0 Deg F 30 sec
Moderate Severity (2) Always On 195.8 Deg F 30 sec
High Intake Manifold
Air Temperature
Least Severe (1) Always On 179.6 Deg F 8 sec
Moderate Severity (2) Always On 186.8 Deg F 8 sec
High Left Exhaust #2
Temperature
Moderate Severity (2) Always On 1400 Deg F 5 sec
Most Severe (3) Always On 1436 Deg F 5 sec
High Left Exhaust
Temperature
Moderate Severity (2) Always On 1400 Deg F 5 sec
Most Severe (3) Always On 1436 Deg F 5 sec
High Right Exhaust #2
Temperature
Moderate Severity (2) Always On 1400 Deg F 5 sec
Most Severe (3) Always On 1436 Deg F 5 sec
High Right Exhaust
Temperature
Moderate Severity (2) Always On 1400 Deg F 5 sec
Most Severe (3) Always On 1436 Deg F 5 sec
Low Engine Oil
Pressure
Least Severe (1) Always On None 8 sec
Most Severe (3) Always On None 8 sec

Indication Display
Parameter Value
ECM Part Number 3732425-07
ECM Serial Number 2891D058DT
Software Group Part Number 5962842-00
Software Group Release Date APR2020
Software Group Description Indication Display