HARYANA STATE POLLUTION CONTROL BOARD
Regional Office,
SCO-55, Sec.25, HUDA, Panipat Ph. 0180-2672037
No. HSPCB/Consent/ : 19570815PITCTOHWM2097901 Dated:21/07/2015
To.
M/s :Anandtex India Pvt. Ltd
VILL:-BRAHMAN MAJRA
PANIPAT
Subject: Grant of consent for emission of Air under section 21/22 of the Air
(Prevention & Control of Pollution) Act, 1981, from 14/07/2015 to
13/10/2015 for Trial production
Please refer to your consent application received in this office on dated 14/05/2015 on the
subject cited above.
With reference to your above application for consent for the emission/ continuation of
emission of S.P.M. air pollutions into atmosphere under Air (Prevention & Control of Pollution) Act,
1981 hereinafter referred as the Act.
M/s Anandtex India Pvt. Ltd are authorized by the Haryana State Pollution Control Board to
discharge their
air pollution being emitted out of their factory premises in accordance with the condition as
mentioned below:-
1. The applicants shall maintain good house keeping both within factory and in the premises. All
hose pipelines values, storage tanks etc. shall be leak proof. In plant allowable pollutants levels,
if specified by State Board should be met strictly.
2. Two or more ducts with different nature of exhaust gases should neither be intermixed nor to be
through a common chimney.
3. Adequate facilities should be provided for sampling viz sampling holes at specified locations
and dimension. The platform of specified size and strengthful arrangements electric connection
also be provided.
4. The applicant/company shall comply with and carry out directive/orders issued by the Board in
this consent order at all subsequent times without negligence of his /its part. The
applicant/company shall be liable for such legal action against him as per provision of the
law/act in case of violation of any order/directives. Issued at any time and or non compliance of
the terms and conditions of his consent order.
5. The disturbed condition in any of plant/plants of the factory which is likely to result in increased
emission or result in violation of emission standards shall be forthwith reported to this Board
under intimation to the Member Secretary, Haryana State Pollution Control Board.
6. The toxic chemicals materials should be handled with due safety. The storage of toxic
chemicals should be such that in case of emergency the chemicals could be transferred to other
empty tank automatically and which should be followed by an approved air pollution control
equipment designed for worst conditions.
7. A green belt (having sufficient tall and dense tree) around the factory should be provided.
8. All the processes using toxic chemical/harmful gases should be equipped with an emergency
siren system in working conditions for alarming the general public in case of untoward incident.
9. The applicant shall furnish to all visiting officer and/or the State Board, any information
regarding the construction/installation or operation of the establishment or emission control
system and such other particulars as may be pertinent to prevention and control of air pollution.
The industry shall also maintain and make available inspection book to the officers of the Board
during their visits.
10. The air pollution control equipment of such specification which shall keep the emissions within
the emission standard as approved by the State Board from time to time shall be installed and
operated in the premises where the industry is carrying on/proposed to carry on its business.
11. The existing air pollution control equipment if required shall be alerted or replaced in
accordance with the direction of the Board.
12. All solid wastes arising in the factory premises shall be properly graded and disposed of by:-
(i)In case of Land fill material, care should be taken to ensure that the material does not give
rise to lechate which may percolate in ground water of carried away with storm run off.
(ii)Composting in case of bio degradable materials.
(iii)If the method of incineration is used for the disposal of solid waste the consent application
should be processed separately and it should be taken up which consent is granted.
13. The industry shall submit an undertaking to the effect that the above conditions shall be
complied with by them.
14. The applicant shall ensure that the emission of the air pollutants shall remain within emission
standards as approved by the State Board from time to time.
15. The applicant shall make an application for grant of fresh consent at least 90 days before the
date of expiry of this consent.
16. Necessary fee as prescribed for obtaining renewal consent shall be paid by the applicant
alongwith the consent application.
17. The applicant shall either:-
a)Not later than 30 days from the date of consent order, certify in writing to the Member
Secretary that the applicant had installed or provided for alternate electric power source
sufficient to operate all the facilities installed by the applicant to maintain compliance with the
terms and conditions of the consent.
b).Not later than 30 days from the date of this consent certify in writing to the Member
Secretary that upon the reduction loss or failure of one or more of the primary source of electric
power to any facilities installed by the application to maintain compliances with the term and
conditions of this consent, the application shall proportionally reduce or otherwise control
production and/or all emissions in order to maintain compliance with terms and conditions of
this consent.
18. There should not be any fugitive emission from the premises.
19. The liquid effluent arising out of the operation of the air pollution control equipment shall also
be treated in a manner and to the standards stipulated in the consent granted under Water
(Prevention & Control of Pollution) Act, 1974 by this Board.
20. If due to any technological improvement or otherwise this Board is of opinion that all or any of
the conditions referred to above required variation (including the change of any control
equipment either in whole or in part) this Board shall after giving the applicant an opportunity
of being heard vary all or such condition and there upon the applicant shall be bound to comply
with the conditions so varied.
21. If the industry fails to adhere to any of the condition of this consent order the consent so granted
shall automatically lapse.
22. The unit shall obtain consent under Water (Prevention & Control of Pollution) Act, 1974 and
authorization under HWTM Rules,2008.
23. (a) The industry shall discharge all the gases through a stack of minimum height.
(b) The height of stack shall conform to the following criteria:
(i)H = 14.Q^0.3 Where sulphur-dioxide is emitted.
Q = Sulphur dioxide emission as Kg/hr.
(ii)H = 74 Q^27 where particulate matter is emitted.
Q = particulate matter emission as tonne/hr. If by using the formula given above the stack
height arrived is more than 9 m then this higher stack should be used.
(iii)The minimum stack height should be 30 Mts.
24. Nothing in this consent shall be deemed to preclude the instruction of any legal action nor
relieve the applicant form any responsibility, liabilities of penalties to which the applicant is or
may be subject.
25. The industry shall maintain the following record to the satisfaction of the Board.
1.The industries shall install separate energy meter and maintain log books for running of all air
pollution control devices or pumps/motors used for running of the same.
2.Register showing the results of various tests conducted by industry for monitoring of stack
emission and ambient air.
26. The industry shall provide adequate arrangement for fighting the accidental leakages, discharge
of any pollutants gas/liquids from the vessels, mechanical equipment etc. which are likely to
cause environment pollution.
27. The consent being issued by the Board as above doesn’t imply that unit performance conforms
to law as required.The consent is being issued provisionally only with a view to accommodate
the unit to provide it an opportunity to modify its operation immediately so as bring them in
conformity with the law of the land.
28. The industry shall provide non-leachate storage facilities for proper disposal of Hazardous
wastes.
29. The industry shall provide acoustic chambers on DG sets to control noise pollution and ensure
noise level within the permissible limit.
30. The industry shall submit on site/off site emergency plan, if required.
31. The industry shall submit A/R within 3 months in case of 17 categories and once in 6 months,
other categories L & M and keep all the parameters within limit.
32. The industry shall comply the public liability insurance Rule, 1991 as amended to date.
33. The industry shall submit Environmental Audit report once in a year.
34. The industry shall comply noise pollution (Regulation and control) Rules, 2000.
35. The industry shall install ambient air station in case of 17 & other categories large & medium.
36. The industry shall obtain environmental clearance, if applicable as per MOEF notification.
37. The industry shall inform to HO/RO office immediately by FAX in case of failure of APCM.
38. In case of bye passing the emissions, the consent shall be deemed revoked.
39. The industry shall comply all the direction/Rules/Instructions as may be issued by the
MOEF/CPCB/HSPCB from time to time.
Specific Conditions :
Other Conditions :
1. 1.The unit will obtain regular CTO before expiry of trial CTO.
2. The unit will submit agreement with GEPIL.
3. That the unit will provide separate energy meter on their ETP/ APCM and
maintain the Log Book for energy consumption
Regional Officer, Panipat
Haryana State Pollution Control Board.
---It is system generated certificate no signature is required---
HARYANA STATE POLLUTION CONTROL BOARD
Regional Office, SCO-55, Sec.25, HUDA, Panipat Ph. 0180-
2672037
No. HSPCB/Consent/ : 19570815PITCTO2097901 Dated:21/07/2015
To
M/s :Anandtex India Pvt. Ltd
VILL:-BRAHMAN MAJRA
PANIPAT
Subject: Grant of Consent to operate for discharge of effluent under section
25/26 of the Water (Prevention & Control of Pollution) Act, 1974,
from 14/07/2015 - 13/10/2015 for Trial production.
Please refer to your consent application received in this office 14/05/2015 on the subject
cited above.
With reference to your above application for consent for the discharge of domestic effluent
and trade effluent under Water (Prevention & Control of Pollution) Act, 1974 hereinafter referred as
the Act M/s Anandtex India Pvt. Ltd is hereby authorized by the Haryana State Pollution Control
Board, to discharge their effluent arising out of their premises in accordance with the terms and
conditions as mentioned below:-
1. The daily quantity of domestic effluent from the factory shall not exceed 5 KLD
2. The daily quantity of the industrial effluent (Process, floor & equipment wash, cooling and
bleed water) from the factory shall not exceed 95 KLD
3. The industry has been assessed for the purpose of Consent to operate fee with investment
cost (land, building, plant and machinery) of Rs. 480.0 Lakh. In case the investment cost
varies as per the annual report for the years duly audited by the Chartered Accountant,
the difference of Consent to operate fee, if any, arises, the industry shall pay the same
amount within one month of the receipt of notice from the Board in this regard.
4. The consent to operate shall be valid for the period from 14/07/2015 - 13/10/2015
5. The industry shall ensure that various characteristics of the effluents remain within the tolerance
limits as specified in EPA Standard and as amended from time to time and at no time the
concentration of any characteristics should exceed these limits for discharge.
6. The industry would immediately submit the revised application to the Board in the event of any
change in the raw material in process, mode of treatment/discharge of effluent.
In case of change of process at any stage during the consent period, the industry shall submit
fresh consent application alongwith the consent to operate fee, if found due, which may be on
any account and that shall be paid by the industry and the industry would immediately submit
the consent application to the Board in the event of any change during the year in the raw
material, quantity, quality of the effluent, mode of discharge, treatment facilities etc.
7. The officer/official of the Board shall reserve the right to access for the inspection of the
industry in connection with the various process and the treatment facilities. The consent to
operate is subject to review by the Board at any time.
8. The industry shall not discharge any altered quantity/quality of the trade/domestic effluent
without prior permission of the Board.
9. Permissible limits for any pollutants mentioned in the consent to operate order should not
exceed the concentration permitted in the effluent by the Board.
10. The industry shall pay the balance fee, in case it is found due from the industry at any time later
on.
11. In case the industrial unit uses the Municipal/HUDA/Industrial Estate Sewerage system for
disposal of effluent for the final disposal they will submit the sewerage connection certificate.
12. If the industry fails to adhere to any of the conditions of this consent to operate order, the
consent to operate so granted shall automatically lapse.
13. The industry will plant minimum three varieties (Eucalyptus, Su Babul or any suitable variety)
of trees in the vacant area.
14. The consent to operate under Air (Prevention & Control of Pollution) Act, 1981 should be
obtained.
15. The industry shall obtain Authorization under Hazardous Waste (Management handling and
transbonding movement) Rules, 2008 as amended to date.
16. The industry shall install separate Energy Meter for ETP and also maintain log book for energy
and chemical consumption.
17. The industry shall obtain permission from Irrigation Department for discharging effluent into
any drain/water bodies.
18. If the industry is closed temporarily at its own, they shall inform the Board and obtain
permission before restart of the unit.
19. The industry shall provide non-leachate storage facilities for storage of Hazardous Waste or
dispose off same in the common facilities & will adhere to the norms laid down as per the
amended notification under HWTM Rules, 2008
20. The industry shall submit A/R once in 3 months in case of 17 categories and other categories.
The L&M shall submit A/R once in 6 months.
21. The industry shall comply the Public Liability Insurance Rules, 1991, as amended to date.
22. The industry shall submit Environmental Audit /Report once in a year.
23. The industry shall obtain Environmental Clearance, if applicable as per MOEF Notification.
24. The industry shall inform to HO/RO office immediately by FAX in case of failure of ETP.
25. In case of bye passing the effluent the consent to operate shall be deemed revoke.
26. The industry shall comply all the Directions/ Rules/Instructions issued from time to time by the
Board.
Specific Conditions :
Other Conditions :
1. 1.The unit will obtain regular CTO before expiry of trial CTO.
2. The unit will submit agreement with GEPIL.
3. That the unit will provide separate energy meter on their ETP/ APCM and
maintain the Log Book for energy consumption
Regional Officer, Panipat
Haryana State Pollution Control Board.
---It is system generated certificate no signature is required---
HARAYANA STATE POLLUTION CONTROL BOARD
C-11, SECTOR-6, PANCHKULA
Ph.01722577870-73
E-mail: hspcb.pkl@ sify.com
No. HSPCB/Consent/ : 19570815PITCTOHWM2097901 Dated:21/07/2015
To
M/s. Anandtex India Pvt. Ltd
VILL:-BRAHMAN MAJRA
Sub: Authorization for operating a facility for collection, reception, treatment,
storage, transportation and disposal of hazardous wastes from 14/07/2015 to
13/10/2015
Please refer to your authorisation application dated 14/05/2015 received in the
board on the subject cited above.
M/s Anandtex India Pvt. Ltd situated at above address is hereby granted an authorization
to operate a facility for collection, reception, treatment, storage, Transportation and disposal of
hazardous wastes on the premises of the unit.The authorization shall be in force for a period as
mentioned in the subject.
The authorization is subjected to the conditions stated below and such conditions as may
be specified in the rules for the time being in force under the Environment (protection) Act, 1986.
TERMS AND CONDITIONS OF AUTHORIZATION
1. The authorization shall comply with the provisions of the Environment (protection) Act, 1986
and the rules made thereunder.
2. The authorization or its renewal shall be produced for inspection at the request of an officer
authorized by the State Pollution Control Board.
3. The person authorized shall not rent, lend, sell transfer or otherwise transport the hazardous
wastes without obtaining prior permission of the State Pollution control Board.
4. An application for the renewal of an authorization shall be made as laid down in rule 5(6)(ii).
5. The unit should have the necessary facilities for collection, reception, treatment, Transport and
disposal of such wastes under the rule. In case of deadly toxic wastes such as Cyanide,
Chromium, Nickel, Zinc, etc., the unit shall make arrangement for the pre-treatment before
dumping it in the disposal site so that the toxic element does not leach down to pollute the
underground water resources.
6. The collection, reception and transportation of hazardous waste shall be carried out by the
authorized person/personnel, fully trained for this purpose.
7. Any unauthorized change in personnel, equipment as working conditions as mentioned in the
application by the person authorized shall constitute a breach of his authorization.
8. The unit shall ensure the proper usage of safety measures such as providing of gloves, gum
boots, face masks, goggles etc to the workers engaged in the handling of hazardous waste.
9. The authorization so granted shall be cancelled or suspended by the Board if the unit fails to
comply with any condition of grant of authorization under these rules.
10. Used containers should be pre-cleaned by neutralizing and cleaning agents/solvents/chemicals.
11. The occupier shall not sell or transfer such waste on payment or without payment to any
unauthorized people who do not hold any authorization.
12. The unit shall not dispose any Hazardous waste at any other Public Place.
13. Unit will maintain its non-leachate pucca storage site properly.
14. The unit will comply with provisions of all Environmental laws including HWTM Rules etc.
and comply with the directions issued by the Board from time to time.
Specific Conditions :
Other Conditions :
1. 1.The unit will obtain regular CTO before expiry of trial CTO.
2. The unit will submit agreement with GEPIL.
3. That the unit will provide separate energy meter on their ETP/ APCM
and maintain the Log Book for energy consumption
Regional Officer
For and On Be'half of the Chairman
Haryana State Pollution Control Board.
Panchkula.
---It is system generated certificate no signature is required---
