Workshop Manual For Honda Outboard Motors BF20A-BF25A, BF25D-BF30D.
Uploaded by
ScribdTranslationsWorkshop Manual For Honda Outboard Motors BF20A-BF25A, BF25D-BF30D.
Uploaded by
ScribdTranslationshonda
Paper book part number BFDOA2BA
66ZV700
PREFACE CONTENT
This manual covers the construction, operation and
O
outboard motor service procedures BUDGET 1
Honda BF20A/BF25A.
The careful compliance with these instructions will yield
as a result a better and safer service work. SERVICE INFORMATION 2
The illustrations in this manual are mainly based on
in the BF25A LRS.
MAINTENANCE 3
COVER OF 4
ALL THE INFORMATION, ILLUSTRATIONS,
MOTOR/ACELERADOR/ESTRANGULADOR
INSTRUCTIONS Y SPECIFICATIONS
Included in this publication are based on
FUEL SYSTEM 5
THE LATEST PRODUCT INFORMATION
AVAILABLE AT THE TIME OF APPROVAL FLYWHEEL/TIMING BELT 6
FOR PRINTING. HONDA MOTOR CO., LTD.
THE RIGHT TO PERFORM IS RESERVED
CHANGES SIN to incur EN NONE
REVERSE START (ONLY TYPE
STEERING WHEEL HANDLE 7
OBLIGATION. NO PART OF THIS
PUBLICATION CAN BE REPRODUCED WITHOUT
DISMANTLING/INSTALLATION OF THE ENGINE 8
WRITTEN PERMISSION. COVER OF THE SHIRT OF
WATER/THERMOSTAT/SWITCH 9
TERMOSTATO
PUBLICATIONS OFFICE OF
HONDA MOTOR SERVICE
CYLINDER HEAD/VALVES/PUMP 10
DE ACEITE
CO., LTD. CRANKCASE/CYLINDER BLOCK/
CRANKSHAFT 11
GEARBOX/PROPELLER/BOX
EXTENSION 12
OIL SUMP/LOWER CASE OF
MOTOR/ROTARY BOX 13
STEERING LINK ARM/BOX
REMOTE CONTROL (ONLY TYPE OF 14
CONTROL REMOTO)
GEAR LEVER/CABLE OF
THROTTLE/STEERING HANDLE (ONLY TYPE 15
MANIJA DEL TIMÓN)
ELECTRICAL EQUIPMENT 16
OPERATION 17
WIRING DIAGRAM 18
SUPPLEMENT BF30
Issue date April 1994 ©
HONDA MOTOR CO., LTD.
honda
3. BF3OA
MAINTENANCE
OIL OF 2.
DEVICE
OF ACCELERATION/SET
OF THE DIAPHRAGM
OIL OF
MOTOR
One
Used motor oil can cause
skin cancer if left in contact
repeated with the skin during periods
prolonged. While this is little
probably unless you handle oil
used a diary, it is recommended
wash your hands well with water and
soap as soon as possible after
manipulate used oil. MAINTAIN
KEEP OUT OF REACH OF CHILDREN.
1) Put the outboard motor in
vertical position.
Remove the engine cover.
3) Remove the oil level dipstick and clean it.
Insert it all the way into the hole.
measuring stick, then take it out and read the level
of oil.
5) If the oil level is low, add the
recommended necessary motor oil
to bring the oil level to the level
superior on the measuring rod. Do not fill
too much.
oil acidity of the 1.91 (2.00 quarts of gallon
or estadounidenses, 1,67 cuartos de galón
engine outlet
recommended
SAE5W - 30 API service classification
Fuel efficient SG, SH.
NOTE
This oil is usually identified with
Energy Savings II
Gasoline savings
"flammable", etc.
When a filter has been installed
new oil, check the level again
engine oil after doing
7
run the engine for a few minutes.
Drainage can be carried out in a way BF25D-BF30D
quick and complete when the engine is still
it is hot.
Place a workshop towel under the
oil filter when I remove it.
CAUTION
Make the engine work outside of
borda sine sufficient water of
Cooling will damage the water pump.
and it will overheat the engine. Make sure
that the water flows from the indicator
of the cooling system while the
the motor is running. In case
on the contrary, stop the engine and determine
the cause of the problem.
Keep away from moving parts.
Página: 275 - Manual de taller de motores fueraborda Honda BF20A-BF25A, BF25D-BF30D -
Check the starting pair
measuring the starting force BF25D-BF30D
using a spring scale in
the center of the grip of
accelerator. The engine should
start moving at 100 (10,0
kgf, 22.0 Ibf of force.
3) If the starting force is less than
100 N (10.0 kgf, 22.0 lbf), move the
throttle friction lever
completely to the left
(that is, to the blocking position)
and tighten the 8 self-locking nut
mm at the specified torque.
TORQUE: 8.5 Nm
(0.85 kgf·m, 6.1 lb-ft).
4) Recheck the strength of
start. If the starting force
is less than 100 N (10.0 kgf, 22.0
Ibf), check that the surface of the
friction block disk is not
contaminated with grease (p. 13-1).
FIST OF
PALAN
CA
Page: 275 - Honda BF20A-BF25A, BF25D-BF30D Outboard Motors Workshop Manual
3-9 BF25D-BF30D
Page: 275 - Workshop manual for Honda BF20A-BF25A, BF25D-BF30D outboard motors -
Outboard Motor Workshop Manual
boardHonda BF20A-BF25A, BF25D-
BF30D.
Original factory service manual from Honda. Buy this
manual
This manual covers the construction, operation, and service procedures of the
Honda BFZOAIBF25A outboard motors.
The illustrations in this manual are mainly based on the BF25A LRS.
Paper book part number 66ZV700
Chapters of the manual:
1. BUDGET
2. SERVICE INFORMATION
3. MAINTENANCE
4. ENGINE/THROTTLE/CHOKE COVER
5. FUEL SYSTEM
6. FLYWHEEL/TIMING BELT
7. REVERSE START (ONLY STEERING WHEEL TYPE)
8. DISMANTLING/INSTALLATION OF THE ENGINE
9. WATER JACKET COVER/THERMOSTAT/THERMO SWITCH
10. CYLINDER HEAD/VALVES/OIL PUMP
11. CRANKCASE/CYLINDER BLOCK/CRANKSHAFT/PISTON
12. GEARBOX/PROPELLER/EXTENSION BOX
13. OIL PAN/ENGINE SUMP/ROTARY BOX
14. STEERING LINK ARM/REMOTE CONTROL BOX (ONLY TYPE
REMOTE CONTROL
15. GEAR LEVER/ACCELERATOR CABLE/STEERING HANDLE (ONLY
STEERING WHEEL HANDLE TYPE
16. ELECTRICAL EQUIPMENT
17. OPERATION
18. WIRING DIAGRAM
SUPPLEMENT BF30
Buy this manual
SEARCH FOR
workshop manual library for Honda marine bf30d4 lrtd
year 2004 eBook and online manual, online manual store
repair and service of Honda BF25D outboard motors
BF30D, 1978-1999 Honda 2- 130HP 4-stroke outboards,
Honda marine BF20A BF25A BF25D BF30D manual
workshop repair in pdf-service manuals, 1997 Honda bf
25, Honda outboard motor, Repair and service manual
Honda outboard cylinder workshop BF20A BF25A BF30
Reconstruction of the carburetor of Honda outboard motor,
Outboard motor repair and workshop service manual
Honda Marine 1984-2004, Engine Repair Manual
Honda BF20A and BF25A outboard, Carburetor adjustment BF25A,
Honda marine BF20A BF25A BF25D BF30D, Honda BF25A
2002 Honda 30A marine service and owner manual
Workshop repair and service manual for the engine cylinder
Honda outboard BF20A BF25A BF30 download, Honda BF 25 of
from one side to the other of the trunk, adjusting the carburetor in an engine
Honda 25 HP outboard, clean a carburetor with steps
simple, Honda BF20A BF25A outboard motor, Workshop of
Honda BF25D BF30D outboard motors, Manual
Honda outboard motor setup instructions
BF20A BF25A Marine, Honda Outboard Motor Manual
BF20A BF25A, Honda BF25 Service Manual, Manual of
Honda BF25 BF25A Outboard Motor Owner's eBook
Honda 75HP carburetor synchronization tool,
Honda BF25 wash water file - trunk, Honda -
part, Honda BF 25 A, Outboard engine service manual
Honda BF20A BF25A marine, Honda BF25D outboard motor
BF30D, Honda BF25A outboard 2003, Repair manual and
Honda Marine BF25D outboard motor workshop service
BF30D download, Honda Thermostat BF25A3 2003, Filter of
oil Fram PH6017A Honda Marine BF25A sohc 4 stroke
25HP, Honda outboard BF20A BF25A BF30, Manual of
Honda BF25 BF25A Outboard Motor Owner's Manual
Honda BF20A BF25A outboard motor factory, Manual
Honda 4-stroke service 1978-2001 2-130 HP, Manual
Honda installation for series remote controls, Guide of
repair of the Honda 4-stroke outboard motor, Manual of
taller and service of the Honda Mariner BF20A outboard motor
BF25A
