Safety Data Sheet
This safety data sheet complies with the requirements of: 2012 OSHA Hazard Communication Standard ( 29CFR 1910.1200)
Product name Ansul R-102 Flushing Concentrate
1. Identification
1.1. Product Identifier
Product name Ansul R-102 Flushing Concentrate
1.2. Other means of identification
Product code GFN1070-2-002
Synonyms None
Chemical Family No information available
1.3. Recommended use of the chemical and restrictions on use
Recommended use No information available.
Uses advised against Consumer use.
1.4. Details of the Supplier of the Safety Data Sheet
Company Name Tyco Fire Protection Products
One Stanton Street
Marinette, WI 54143-2542
Telephone: 715-735-7411
Contact point Product Stewardship at 1-715-735-7411
E-mail address
[email protected]1.5. Emergency Telephone Number
Emergency telephone CHEMTREC 800-424-9300 or 703-527-3887
2. Hazards Identification
Classification
This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)
Skin Corrosion/Irritation - Category 2
Serious eye damage/eye irritation - Category 2A
Specific target organ toxicity (single exposure) - Category 3
2.2. Label Elements
Signal Word
WARNING
Hazard Statements
Causes skin irritation
Causes serious eye irritation
May cause respiratory irritation
_____________________________________________________________________________________________
Revision date 05-May-2017 Version 42
Product code GFN1070-2-002 /
Product name Ansul R-102 / PAGE 2 / 8
Flushing Concentrate
_____________________________________________________________________________________________
Precautionary Statements
Prevention
Wash face, hands and any exposed skin thoroughly after handling. Wear protective gloves/protective clothing/eye
protection/face protection. Avoid breathing dust/fume/gas/mist/vapors/spray. Use only outdoors or in a well-ventilated area.
Response
IF exposed or concerned: Get medical advice/attention.
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue
rinsing. If eye irritation persists: Get medical advice/attention.
IF ON SKIN: Wash with plenty of soap and water. If skin irritation occurs: Get medical advice/attention. Take off contaminated
clothing and wash before reuse.
IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or
doctor/physician if you feel unwell.
Storage
Store in a well-ventilated place. Keep container tightly closed. Store locked up.
Disposal
Dispose of contents/container to an approved waste disposal plant.
2.3. Hazards Not Otherwise Classified (HNOC)
Not Applicable.
2.4. Other Information
Unknown Acute Toxicity 0% of the mixture consists of ingredient(s) of unknown toxicity
3. Composition/information on Ingredients
3.1. Mixture
The following component(s) in this product are considered hazardous under applicable OSHA(USA)
Chemical name CAS No. weight-%
Potassium carbonate 584-08-7 15 - 40
4. First aid measures
4.1. Description of first aid measures
Eye Contact Rinse thoroughly with plenty of water for at least 15 minutes, lifting lower and upper eyelids.
Consult a physician.
Skin contact Wash skin with soap and water. Get medical attention if irritation develops and persists.
Inhalation Remove to fresh air. If breathing is difficult, give oxygen. (Get medical attention immediately
if symptoms occur.).
Ingestion Rinse mouth. Do not induce vomiting without medical advice. If swallowed, call a poison
control center or physician immediately.
4.2. Most Important Symptoms and Effects, Both Acute and Delayed
Symptoms No information available.
_____________________________________________________________________________________________
Revision date 05-May-2017 Version 42
Product code GFN1070-2-002 /
Product name Ansul R-102 / PAGE 3 / 8
Flushing Concentrate
_____________________________________________________________________________________________
4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed
Note to physicians Treat symptomatically.
5. Fire-fighting measures
5.1. Suitable Extinguishing Media
Product is extinguishing agent. Use extinguishing measures that are appropriate to local circumstances and the surrounding
environment.
5.2. Unsuitable Extinguishing Media
None.
5.3. Specific Hazards Arising from the Chemical
None known.
Hazardous Combustion Carbon oxides, Nitrogen oxides (NOx), Oxides of sulfur
Products
5.4. Explosion Data
Sensitivity to Mechanical Impact None.
Sensitivity to Static Discharge None.
5.5. Protective Equipment and Precautions for Firefighters
As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full
protective gear.
6. Accidental release measures
6.1. Personal precautions, protective equipment and emergency procedures
Personal Precautions Ensure adequate ventilation, especially in confined areas.
For emergency responders Use personal protection recommended in Section 8.
6.2. Environmental Precautions
Environmental Precautions Prevent further leakage or spillage if safe to do so. Prevent entry into waterways, sewers,
basements or confined areas. See Section 12 for additional Ecological Information.
6.3. Methods and material for containment and cleaning up
Methods for Containment Prevent further leakage or spillage if safe to do so.
Methods for Cleaning Up Pick up and transfer to properly labeled containers.
7. Handling and Storage
7.1. Precautions for Safe Handling
Advice on safe handling Avoid contact with skin and eyes. Handle in accordance with good industrial hygiene and
safety practice.
_____________________________________________________________________________________________
Revision date 05-May-2017 Version 42
Product code GFN1070-2-002 /
Product name Ansul R-102 / PAGE 4 / 8
Flushing Concentrate
_____________________________________________________________________________________________
7.2. Conditions for safe storage, including any incompatibilities
Storage Conditions Keep containers tightly closed in a dry, cool and well-ventilated place.
Incompatible Materials Strong oxidizing agents. Strong acids. Strong bases.
8. Exposure Controls/Personal Protection
8.1. Control Parameters
Exposure guidelines
8.2. Appropriate Engineering Controls
Engineering controls Ensure adequate ventilation, especially in confined areas.
8.3. Individual protection measures, such as personal protective equipment
Eye/Face Protection Avoid contact with eyes. Tight sealing safety goggles.
Skin and Body Protection Wear protective gloves and protective clothing.
Respiratory Protection If exposure limits are exceeded or irritation is experienced, NIOSH/MSHA approved
respiratory protection should be worn. Positive-pressure supplied air respirators may be
required for high airborne contaminant concentrations. Respiratory protection must be
provided in accordance with current local regulations.
Ventilation Use local exhaust or general dilution ventilation to control exposure with applicable limits
8.4. General hygiene considerations
Do not eat, drink or smoke when using this product. Handle in accordance with good industrial hygiene and safety practice.
9. Physical and Chemical Properties
9.1. Information on basic physical and chemical properties
Physical State Liquid
Odor Acetic acid Color Yellow
Odor Threshold No data available
Property Values Remar
ks •Met
hod
pH No data available
Melting point/freezing point No data available
Boiling point / boiling range > 100 °C / 212 °F
Flash Point > 100 °C / > 212 °F
Evaporation Rate No data available
Flammability (solid, gas) No data available
Flammability limit in air
Upper flammability limit: No data available
Lower flammability limit: No data available
Vapor Pressure No data available
Vapor Density No data available
Specific gravity No data available
Water Solubility No data available
_____________________________________________________________________________________________
Revision date 05-May-2017 Version 42
Product code GFN1070-2-002 /
Product name Ansul R-102 / PAGE 5 / 8
Flushing Concentrate
_____________________________________________________________________________________________
Solubility in Other Solvents No data available
Partition coefficient No data available
Autoignition Temperature No data available
Decomposition Temperature No data available
Kinematic viscosity No data available
10. Stability and Reactivity
10.1. Chemical Stability
Stable under recommended storage conditions.
10.2. Reactivity
No data available
10.3. Possibility of hazardous reactions
None under normal processing.
Hazardous Polymerization Hazardous polymerization does not occur.
10.4. Conditions to Avoid
Extremes of temperature and direct sunlight.
10.5. Incompatible Materials
Strong oxidizing agents. Strong acids. Strong bases.
10.6. Hazardous decomposition products
Carbon oxides. Nitrogen oxides (NOx). Oxides of sulfur.
11. Toxicological Information
11.1. Information on Likely Routes of Exposure
Product information No data available
Inhalation No data available.
Eye Contact No data available.
Skin contact No data available.
Ingestion No data available.
Acute Toxicity
Chemical name Oral LD50 Dermal LD50 Inhalation LC50
Potassium carbonate = 1870 mg/kg ( Rat ) - -
584-08-7
11.2. Information on Toxicological Effects
_____________________________________________________________________________________________
Revision date 05-May-2017 Version 42
Product code GFN1070-2-002 /
Product name Ansul R-102 / PAGE 6 / 8
Flushing Concentrate
_____________________________________________________________________________________________
Symptoms No information available.
11.3. Delayed and immediate effects as well as chronic effects from short and long-term exposure
Skin Corrosion/Irritation No information available.
Serious eye damage/eye irritation No information available.
Sensitization No information available.
Germ Cell Mutagenicity No information available.
Carcinogenicity No information available.
Reproductive Toxicity No information available.
STOT - Single Exposure No information available.
STOT - Repeated Exposure No information available.
Aspiration Hazard No information available.
11.4. Numerical Measures of Toxicity - Product information
The following values are calculated based on chapter 3.1 of the GHS document mg/kg
12. Ecological Information
12.1. Ecotoxicity
Not classified.
0% of the mixture consists of components(s) of unknown hazards to the aquatic environment
Chemical name Algae/aquatic plants Fish Crustacea
Potassium Acetate - LC50 (96h) semi-static = 6800 mg/L EC50 (24h) = 7170 mg/L Daphnia
127-08-2 Oncorhynchus mykiss magna
12.2. Persistence and Degradability
No information available.
12.3. Bioaccumulation
No information available.
12.4. Other Adverse Effects
No information available
13. Disposal Considerations
13.1. Waste Treatment Methods
Disposal of wastes Disposal should be in accordance with applicable regional, national and local laws and
regulations.
Contaminated Packaging Do not reuse container.
14. Transport Information
DOT NOT REGULATED
TDG NOT REGULATED
_____________________________________________________________________________________________
Revision date 05-May-2017 Version 42
Product code GFN1070-2-002 /
Product name Ansul R-102 / PAGE 7 / 8
Flushing Concentrate
_____________________________________________________________________________________________
MEX NOT REGULATED
ICAO (air) NOT REGULATED
IATA NOT REGULATED
IMDG NOT REGULATED
15. Regulatory Information
15.1. International Inventories
TSCA Complies
DSL/NDSL Complies
ENCS Complies
IECSC Complies
KECL Complies
PICCS Complies
AICS Complies
Legend:
TSCA - United States Toxic Substances Control Act Section 8(b) Inventory
DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List
ENCS - Japan Existing and New Chemical Substances
IECSC - China Inventory of Existing Chemical Substances
KECL - Korean Existing and Evaluated Chemical Substances
PICCS - Philippines Inventory of Chemicals and Chemical Substances
AICS - Australian Inventory of Chemical Substances
15.2. US Federal Regulations
SARA 313
Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any
chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372
SARA 311/312 Hazard Categories
Acute Health Hazard No
Chronic health hazard No
Fire Hazard No
Sudden Release of Pressure Hazard No
Reactive Hazard No
CWA (Clean Water Act)
This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR 122.21 and 40
CFR 122.42)
CERCLA
This material, as supplied, does not contain any substances regulated as hazardous substances under the Comprehensive
Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) or the Superfund Amendments and
Reauthorization Act (SARA) (40 CFR 355). There may be specific reporting requirements at the local, regional, or state level
pertaining to releases of this material
15.3. US State Regulations
_____________________________________________________________________________________________
Revision date 05-May-2017 Version 42
Product code GFN1070-2-002 /
Product name Ansul R-102 / PAGE 8 / 8
Flushing Concentrate
_____________________________________________________________________________________________
U.S. State Right-to-Know Regulations
Chemical name New Jersey Massachusetts Pennsylvania
Water - - X
7732-18-5
16. Other information, including date of preparation of the last revision
NFPA Health Hazards 1 Flammability 0 Instability 0 Physical and chemical
properties -
HMIS Health Hazards 1 Flammability 0 Physical Hazards 0 Personal Protection X
Revision date 05-May-2017
Revision note No information available.
Disclaimer
The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the
date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage,
transportation, disposal and release and is not to be considered a warranty or quality specification. The information
relates only to the specific material designated and may not be valid for such material used in combination with any other
materials or in any process, unless specified in the text.
End of Safety Data Sheet
_____________________________________________________________________________________________
Revision date 05-May-2017 Version 42
