Confined Space Rescue

Awareness

An Overview of Confined Space Rescue

1
 Course Objectives
 Provide the attendee with the basic understanding of the requirements of Confined Space
Rescue so that the attendee can go to the next step of becoming fully trained in Confined
Space Rescue.
 Review of why Confined Spaces can be dangerous.
 Review of the 3 rescue techniques
1. Non-entry
2. Entry by Others
3. Entry by Trained employees from the company
 Review the PPE – Personal Protective Equipment that may be required for Confined Space
Entry.
 Look at Response Time and importance of Response time.
 Become familiar with some of the Rescue Equipment that may be required in a CS Rescue.
 Review the importance of Lockout Tagout or elimination and removal of potential hazards.
 Review key points associated with a Confined Space Rescue Plan.

2
Disclaimer
“This material was produced under Grant
SH-21000-10-60-F-29 from the Occupational
Safety and Health Administration, U.S.
Department of Labor. It does not
necessarily reflect the views or policies of
the U.S. Department of Labor, nor does
mention of trade names, commercial
products, or organizations imply
endorsement by the U.S. Government.”

3
You have the right to a safe workplace
 You have the right to a safe workplace. The Occupational Safety and
Health Act of 1970 (OSHAct) was passed to prevent workers from being
killed or seriously harmed at work.
 The law requires that employers provide their employees with working
conditions that are free of known dangers. The Act created the
Occupational Safety and Health Administration (OSHA), which sets
and enforces protective workplace safety and health standards. OSHA
also provides information, training and assistance to workers and
employers.
 Workers may file a complaint to have OSHA inspect their workplace if
they believe that their employer is not following OSHA standards or
there are serious hazards.

4
 Workers' rights under the OSH Act
Workers are entitled to working conditions that do not pose a risk of serious
harm. To help assure a safe and healthful workplace, OSHA also provides
workers with the right to:
 Receive information and training about hazards, methods to prevent harm, and
the OSHA standards that apply to their workplace. The training must be in a
language you can understand;
 Observe testing that is done to find hazards in the workplace and get test results;
 Review records of work-related injuries and illnesses;
 Get copies of their medical records;
 Request OSHA to inspect their workplace; and
 Use their rights under the law free from retaliation and discrimination.

http://www.osha.gov/workers.html

5
This Presentation
This presentation is not designed to certify or train
you on Confined Space Rescue.
Confined Space Rescue training and certification
should only be completed by the authorization of your
company.
This program is designed as an Awareness Training
session.

6
Technical Rescue Awareness

The difference between a

hero and a fool is
training.
City of Anderson, SC - Fire Department

7
Let’s Review for a
Moment

8
Are Confined Spaces Dangerous?
• According to a report from the Canadian Centre for
Occupational Health and Safety (www.ccohs.ca):
• Many workers are injured and killed each year while working in
confined spaces. An estimated 60% of the fatalities have been
among the would-be rescuers.

9
 Emergency Rescue

 Emergency rescue teams must be

available while authorized
entrants are in the confined
space.
 Deaths often occur during
rescue. Employees attempt to
rescue an entrant without the
proper training and then get
caught themselves in the
confined space.

10
Rescue Techniques
There are 3 types of rescue techniques:
1. Non-entry
2. Entry by others
3. Entry by Trained employees from the
company

11
 Rescue Techniques
1. Non-entry – Rescue
that is conducted
without entry into
the confined space.
This can be
conducted by such
means as a rope or
winch.

12
 Rescue Techniques
2. Entry by others –
some companies do not
have trained personnel
for emergency rescue.
They depend on others to
conduct emergency
rescues such as the Fire
Department.

13
 Rescue Techniques
2. Entry by others
continued – in this case
the Fire Department
would need:

• To be familiar with the types of confined spaces located in the

facility,
• the hazards they may encounter,
• the entry means into the confined spaces,
• the types of rescue equipment to effect a rescue and
• the types of PPE required for any potential rescue.
14
 Rescue Techniques
3. Entry by Trained employees from the company – some
companies have trained personnel within the company
to conduct rescues. In this case:
• All members of the team must be specially trained in
confined space rescue work,
• The team must have at least
one member certified in CPR
and first aid,
• All members of the team must
be trained in the techniques
and equipment for specific
confined spaces.
15
 Emergency Rescue
 If a rescue is required, the rescue service must close off the area, get
authorized entrants out of the space and perform first aid when needed.
 It is best to use a retrieval system to bring the employee out of the space.
Never enter the space without proper training and unless it is necessary.
 Authorized entrants should wear harnesses connected to the retrieval line.
The retrieval equipment must be in place before employees enter the
permit space.

16
 Personal Protective Equipment
 One of the most important components of PPE in a confined
space is a respirator.
 All respirators must be fit tested prior to use.
 Cleaning the respirator after each use will help disinfect it.
 Before each use of the
respirator, it must be
inspected to make sure
that there are no
cracks, holes, signs of
wear or loose
connections.

17
Personal Protective Equipment
• Other forms of PPE
can include hard
hats, safety glasses,
clothing that
protects the torso
against chemicals,
fires and other
hazards, as well as
gloves and safety
shoes that protect
the hands and feet
from various hazards.
18
Let’s Take a Look at Response
Time

19
Defining Response Time
Reaction Time
Contact Time
Response Time
Assessment Time
Preparation Time
Rescue Time

20
Defining Response Time
Reaction Time
Time between the entrant having a problem requiring
rescue and the safety attendant’s recognition that the
entrant has problem
Contact Time
The time taken by the attendant to contact the rescue
team.
Response Time
The time taken by the rescuers to arrive at the scene of
the rescue after contact.
21
Defining Response Time
Assessment Time
The time taken by a rescue team to size up the problem
and determine the strategy to perform a safe, efficient
rescue.
Preparation Time
The time taken by a rescue team to set up for the rescue.
Rescue Time
The time taken for the team to reach, treat, package, and
evacuate the victim from the confined space.

22
 Rescue Equipment

 Confined Space Rescue can require a number of types of

equipment to effectively and safely perform a rescue.
 Let’s take a look at some of the equipment that can be
used in confined space rescues.

23
 Ropes
Used for
 Primary tool in technical
rescue
Vary in construction,
material and size
Most common in C.S.
 ½ inch, strength 9,000 lbs.
 Static kernmantle (low
stretch)
 Dynamic kernmantle (high
stretch)

24
 Harness
Used for
 Fall protection
 Confined space rescue
Most common in C.S.
 Flat nylon webbing
 Full body
 Point of attachment in the
center of the back at
shoulder level

25
 Tripods
Used for
 Access to vertical entry
Most common in C.S.
 9-foot height or greater

26
 Winches
Used for
 Assist with tripods
Most common in C.S.
 Retractable designated
for non-entry rescue
 Certified as a primary
lowering device

27
Ventilation Systems
Ventilate, eliminate, or
control the space’s
atmospheric hazards
Blind or disconnect and
cap all input lines so that
no hazardous materials
can enter the space

28
Lockout Tagout
When entrance covers
are removed, guard the
opening immediately
Remember, you may
have to be authorized to
perform lockout tagout,
depending on company
policy.

29
SCBA Units
SCBA (Self Contained
Breathing Apparatus)
– may be required to
enter some confined
spaces or to perform a
rescue.
There are special
guidelines that must
be followed prior to
wearing an SCBA.

30
SCBA Wearer Requirements
In order to wear a SCBA a
rescuer would have to
provide a Respirator
Clearance or Physician
Approval prior to wearing
a SCBA.
After the Respirator
Clearance the Rescuer
would have to be Fit
Tested for the SCBA Unit.

31
Rescue Equipment
As you can see, there are numerous types of rescue
equipment that is available to assist with rescues.
Each confined space must be evaluated to determine what
type of equipment is required to perform a rescue should
it become necessary.
If outside resources, such as the Fire Department, are
utilized to perform confined space rescues, the agency
should be given access to your facility to enable them to:
Be aware of the types of confined spaces you have
Determine the types of equipment and rescue techniques
they will need to perform a rescue
32
 Commanding the Confined
Space Rescue
 If you are part of a rescue team at your facility,
you must be familiar with your rescue plan. Let’s
discuss some key points associated with a rescue
plan and points that need to be considered to
keep rescuers safe.
 A confined space rescue will still have roles that
must be filled during the rescue.
 A Rescue Team will have an Incident Command
Supervisor.

33
Roles
Remember that the same roles apply in a confined
space rescue that apply to a normal confined space
entry.
 Entry Supervisor
 Attendant
 Entrant, Primary
 Entrant, Standby
With a confined space rescue, there is an additional
role that is assigned -
 Incident Commander

34
(Incident Commander)

IC Priorities
A Confined Space Rescue Scene will have a Incident Commander. The
priorities of the IC are mainly:
1. Responder safety
2. Safety of the victim
3. Assessment of the situation
4. Type of Rescue
5. Development of the rescue plan
6. General public control and safety

Must keep in mind that 60% of fatalities

are would be rescuers
35
1. Responder Safety
Assessment of the situation and confined space
 What PPE will be required
 Obtain air monitoring samples
 Assess hazards
 Characteristics of space
Hazard Mitigation
• Avoid the hazard
• Remove the hazard
• Control the hazard
• Use personal protective equipment

36
2. Safety of the Victim
Is the victim conscious?
Is the Victim unconscious?
Will medical attention be required?
Will medical personnel need to be notified?
What type of rescue equipment will be required to
safely remove the victim?
Is there a timeline associated with the rescue because
of the condition of the victim?

37
3. Assessment of the Situation
• Hazards Present
• Atmospheric
• Energy Sources
• Entrapment
• Fall
• Fire / Explosion
• Hazardous Material
• Hazard Mitigation
• Risks associated with the rescue
• Length of time to implement any hazard controls

38
3. Assessment of the Situation
Distance required for rescue
Rescue Problem within Capabilities of the
Department / Team

39
4. Type of Rescue
Offensive ( rescue)
1. Are lives at risk
2. Complexity of the rescue
3. Hazards are known and controllable
4. Resources are available for the rescue
5. Incident stabilization prompt and
probable
Defensive ( body recovery )
1. No life probability of victim
2. Complexity of the rescue
3. Hazardous conditions still exist
4. Resources available or unavailable
5. Stabilization unlikely

40
5. Development of the Rescue Plan
 Survival time of the victim
 Confined Space Characteristics
 Type
 Function
 Configuration
 Construction
 Size
 Entry Points (size, number, location)
 Assignment of roles
 Sufficient Personnel (numbers, experience, training)
 Appropriate equipment, Apparatus, Material
 Communication & Communication Equipment
 Interagency Coordination
41
5. Development of the Rescue Plan
 Ventilation of space
 Monitoring of space
 Air supply for
rescuer’s if required
 Control of all
sources of energy
and engulfment
hazards - Including
LOTO, Blocking, etc.

42
5. Development of the Rescue Plan
 Rigging - will need to
determine the types
of rescue equipment
needed.
 Slings
 Rescue Basket
 Ropes
 Victim Stabilizers
 Winche/s

43
 6. General Public Control and Safety
Perimeter Control – Depending on type of situation:
• May need police
• Barrier tape, ropes, barricades
• Controlling traffic
• Limiting access to the rescue area to assigned personnel

44
Rapid Intervention Team
Provides safety backup
Dressed in same PPE as
entry, ready to go
Cannot be assigned to
another task during the
rescue

45
 After the Rescue
• Debrief
• Re-supply
• Documentation
• Post incident analysis

46
F-A-I-L-U-R-E
Failure to understand the environment
Additional medical issues not considered
Inadequate rescue skills
Lack of teamwork or training and experience
Underestimating the logistics of the incident
Rescue verse recovery mode not considered
Equipment not mastered

47
 What’s Next?
What do you need to do
once you get back to your
facility?

48
 Next Steps
• If you are part of a rescue Team:
• Obtain a physician’s approval or clearance to wear a SCBA.
• Get fit tested.
• Know your rescue plan.
• Become familiar with the confined spaces that you have in your
facility.
• Know what equipment will be necessary for each Confined
Space, should a rescue be necessary.
• Know the hazards associated with each confined space.
• Know how to eliminate the hazards associated with the confined
spaces.
• Practice, practice, practice
• Retrain when new confined spaces are added or when
something regarding an existing confined space changes.
49
 Conclusion
 The entry supervisor needs to ensure that the confined space
operations conform to the permit. They should remove unauthorized
personnel from the area and keep them from entering the space. The
entry supervisor terminates and cancels the permit at the right time.
 Make sure each hazard is identified and controlled before entering a
confined space.
 Fully understand the requirements of a confined space rescue:,
including commanding the confined space rescue and control of the
area.
 Always report any concerns you may have regarding confined
spaces.
 Emergency rescues should only be made by trained personnel
or a rescue service.

50