Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING
Name of product Tudalen 13 F
Manufacturer/distributor H&R Malaysia Sdn Bhd
Lot 6579, Jalan Parang,
North Port, Locked Bag 203,
North Port, 42000,Port Klang, Selangor.
Emergency advice E-mail : [Link]@[Link]
60192505901
Recommended intended purpose(s)
Process oil
2. HAZARDS IDENTIFICATION
Special hazards in formation for humans and environment
The product is not dangerous/is not a dangerous preparation and therefore free of labelling.
3. COMPOSITION/INFORMATION ON INGREDIENTS
Chemical characterization
100% of mineral oil. CAS Nr. 64742-54-7, 64742-65-0
The PCA content (DSMO extract according to IP346) of dangerous components is lower than 3%.
4. FIRST AID MEASURES
General information
Remove contaminated soaked clothing immediately.
In case of inhalation
In the event of symptoms refer for medical treatment.
In case of skin contact
In case of contact with skin wash off immediately with soap and water.
Consult a doctor if skin irritation persists.
In case of eye contact
In case of contact with eyes rinse thoroughly with plenty of water and seek medical advice.
In case of ingestion
Do not induce vomiting.
Summon a doctor immediately.
Physician's in formation / possible dangers
In case of swallowing or vomiting of the melted product there is danger of penetration into the lungs.
Treatment (Advice to doctor)
Treat symptoms.
Page 1/6
Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
5. FIRE-FIGHTING MEASURES
Suitable extinguishing material
Foam
Dry powder
Carbon dioxide
Sand
Water spray jet
Water mist
Extinguishing material that may not be used for safety reasons
Full water jet
Special exposure hazards arising from the substance, combustible products or resulting gases
Soot and other organic products.
Nitrogen oxides (NOx)
Carbon monooxide (CO)
Sulphur dioxide (SO2)
Special protective equipment for firefighters
Use breathing apparatus with independent air supply (isolated).
Additional information
Cool containers at risk with water spray jet.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions
Use breathing apparatus if exposed to vapours/aerosol with filter Typ A2, A2/P2 or ABEX.
Use personal protective clothing.
Environmental precautions
Do not discharge into the drains/surface water/groundwater.
Prevent spread over a wide area (e.g. by containment or oil barrires).
Do not discharge into the subsoil/soil.
Methods for cleaning up
Take up with absorbent material (e.g. oil binder).
After taking up the material dispose according to regulation.
7. HANDLING AND STORAGE
Advice on safe handling
Avoid formation of oil dust.
Advice on protection against fire and explosion
Do not smoke.
Page 2/6
Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
Requirements for storage rooms and vessels
Only use containers that are approved specifically for the substance/product.
Advice on storage compatibility
Do not store together with oxidizing agents.
Futher information on storage conditions
To be store under control of light and temperature conditions.
Storage group 10
Fire class B
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Ingredients with occupational exposure limits to be monitored
CAS-No. Name Code [mg/m3] [ml/m3] Remark
oil mist 8 hours 5 TWA, 5h
Respiratory protection
Respiratory equipment in case of nebulosity or aerosol: Use a mask with a filter type A2, A2/P2 or ABEX.
Hand protection
Use safety gloves of following materials: NBR (nitrile) / neopren / viton (permeationslevel 5 -6), Cat. II according to norm EN 388
Eye protection
Safety goggles with side protection, in case of increased risk add protective face shield.
Skin protection
Oil-resistant and hardly inflammable protective clothing.
General protective measures
Do not inhale vapours.
Avoid contact with eyes and skin
It is recommended to use safety clothing, safety gloves and safety googles/safe screen.
Hyginene measures
Clean skin thoroughly after working.
Cloths contaminated with product should not be kept in trouser pockets.
At work do not eat, drink, smoke or take drugs.
Keep away from food and drink.
Page 3/6
Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
9. PHYSICAL AND CHEMICAL PROPERTIES
Form Colour Odour
liquid amber mild
Important health, safety and environmental information
Value Temperature at Method Remark
Flash point ca. 264 °C ASTM D 92
Lower explosion limit ca. 0.45 Vol-%
Upper explosion limit ca. 4.5 Vol-%
Vapour pressure < 0.1 hPa 20 °C calculated
Density ca. 877 kg/m³ 15 °C ASTM D 4052
Solubility in water Insoluble
Viscosity 1 Kinematic ca.95 mm²/s 40 °C ASTM D 445
Viscosity 2 Kinematic ca. 11 mm²/s 100 °C ASTM D 445
Additional information
The data are subject to usual tolerances.
10. STABILITY AND REACTIVITY
Conditions to avoid
No hazardous reactions known.
Materials to avoid
Reactions with strong oxidising agents.
Hazardous decomposition products
No hazardous decomposition products known.
11. TOXICOLOGICAL INFORMATION
Acute toxicity/Irritability/Sensitization
Value/Validation Species Method Remark
LD 50 acute oral > 5000 mg/kg rat
LD 50 acute dermal > 3000 mg/kg rabbit
Irritability skin non-irritant
Page 4/6
Irritability eye non-irritant
Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
Sensitization skin non-sensitising
Sensitization non-sensitising
respiratory system
Experiences made from practice
Frequent contact specially if dried out may cause skin and eye irritations.
12. ECOLOGICAL INFORMATION
Data on elimination (persistence and degradability)
Elimination rate Method of analysis Method Validation
Physico-chemical The product is slightly soluble in water. It can be largely eliminated from the water by abiotic processes, e.g.
degradability mechanical separation.
Biological not readily degradable
degradability
General regulation
Do not discharge product unmonitored into the environment.
13. DISPOSAL CONSIDERATIONS
Waste code No. Name of waste
13 02 05* mineral-based non-chlorinated engine, gear and lubricating oils
Wastes marked with an asterisk are considered to be hazardous waste pursuant to Directive 91/689/EEC on hazardous waste.
Recommendations for the product
The disposal code is just a recommendation. Contact your local experts to obtain information about use or disposal of the
material involved.
The indication about disposal refers to the product and its residues. If the product is mixed with other materials or preparations
an individual evaluation should be necessary.
Recommendations for packaging
Contaminated packaging should be emptied as far as possible and after appropiate cleaning may be taken for reuse.
14. TRANSPORT INFORMATION
Land and inland navigation transport ADR/RID
No hazardous material as defined by the prescriptions.
Marine transport IMDG
No hazardous material as defined by the prescriptions.
Page 5/6
Air trasport ICAO/IATA-DGR
No hazardous material as defined by the prescriptions.
Safety data-sheet according to Regulation (EC) No.
1907/2006 (REACH)
Printed 29-04-19
Revision 29-04-19 (GB) Version 2.4
Tudalen 13 F
15. REGULATORY INFORMATION
Remarks for classification
The product does not require a hazard warning label in accordance with EC directives/German regulations on dangerous substances.
National regulations
Decree for case of interference/ Accident regulation, appendix I: not specifed
remarks
Water hazard class 1 VwVwS of (german regulation) 27.7.2005
16. OTHER INFORMATION
Further information
Above information corresponds to our present knowledge and experience. It is not a guarantee that no errors or incompleate data
may be contained.
Sources of key data used
DGMK-Bericht 400-1, 400-2, 400-7 Concawe-Report " Health aspects of lubricants " 1/1983
Page 6/6
