ATR 72 Reliability Report – 2019

Chalair Aviation
Hangar Zone Est – Aeroport de Caen
14650 – Carpiquet – France
Intencionalmente em branco
Intentionally Blank
 Jan 2020
Annual Reliability Report ATR72
Page 1

Table of Contents

General Operational Statistics

F-HAPL (Chalair Fleet) Page 3

PIREP/MAREP

F-HAPL – PIREP/MAREP List Page 5

PIREP/MAREP - 12 MO Rolling Average / Graphs Page 13
 Jan 2020
Annual Reliability Report ATR72
Page 2

Intentionally Blank
 Jan 2020
Annual Reliability Report ATR72
Page 3

General Operational Statistics

Chalair ATR72 Fleet – F-HAPL

A/C F-HAPL A/C F-HAPL

Monthly 1 MO Daily
Days in FH Per FC Per Days in
Average Avg.
Service Month Month Service
Leg Time Utilization
jan/19 18 55,70 66 jan/19 18 0,84 3,09
fev/19 9 18,57 24 fev/19 9 0,77 2,06
mar/19 1 1,57 2 mar/19 1 0,78 1,57
abr/19 11 28,35 34 abr/19 11 0,83 2,58
mai/19 20 60,78 73 mai/19 20 0,83 3,04
jun/19 24 79,97 93 jun/19 24 0,86 3,33
jul/19 10 40,63 46 jul/19 10 0,88 4,06
ago/19 0 0,00 0 ago/19 0 0,00 0,00
set/19 1 0,72 1 set/19 1 0,72 0,72
out/19 14 73,57 90 out/19 14 0,82 5,25
nov/19 17 85,27 119 nov/19 17 0,72 5,02
dez/19 25 104,17 129 dez/19 25 0,81 4,17
Average 12,50 45,77 56,42 Average 12,50 0,74 2,91
 Jan 2020
Annual Reliability Report ATR72
Page 4
 Jan 2020
Annual Reliability Report ATR72
Page 5

PIREP/MAREP

List
F-HAPL

Date Opened Date Closed From Tech-Log Closing TechLog ATA Reported By Description Action Performed MEL Ref. Classification

PIREP

BOTTON
Pax seat 9D/F cabin crew call
22/01/2019 28/01/2019 25 CLEANED.OPERATIONAL CHECK PIREP
button inop
C/OUT

On pannel 622ct found fuel

leak and replaced both seals
Fuel leak on the top of the right
20/02/2019 22/02/2019 28 MLM acc to jic 57-14-12-RAI-10000- PIREP
wing
002Only the 622ct panel
checked no fuel leak

The lamp replaced by a new acc

On refuelling control panel :
06/03/2019 07/03/2019 28 FLB to jic 33-36-51RAI-10000 PIREP
right hand tank light inop
checked ok

EMERG BATTERY CONTACTOR

42PA ALL CONTACTS WERE
RETIGHTEN.RE RACKING
29/03/2019 31/03/2019 24 EMER BAT CHG fault OFBOTH MFCS C/OUT AS PIREP
WELL.SINCE PROBLEM WAS
NOT DUBLICATED ON GROUND
PLEASE REPORT AGAIN.

Batteries replaced,checked
22/05/2019 22/05/2019 25 DLP Cpt torche inop PIREP
found ok.

IAW ATR MM CH 05.51.11.11

DVI 10000-001,REV 00 JAN
Overspeed 250kt during 5
23/05/2019 24/05/2019 53 DLP 19,AIRCRAFT CAN BE RELEASED PIREP
seconds
TO SERVICE WITHOUT ANY
FURTHER ACTION.

RESPECTIVE EFIS SCREEN

REPLACED IAW JIC 34.75.81 RAI
EFIS CAPTAIN SIDE INOP (LOWER 10000.001 REV 00,JAN
28/05/2019 29/05/2019 34 LVI 34-71-01 A PIREP
SCREEN) 19.TESTED FOUND OK.P/N
7003110-912,S/N OFF
95119434,ON 94048166

No replacement is required as it
is with in the wear limits as
28/05/2019 28/05/2019 32 LVI VERTICAL CUT TYRE NUMBER 1 PIREP
described in atr mm jic 32.41.00
che 10010 001 rev00 jan19.

Cargo latch on fwd cargo

06/06/2019 07/06/2019 25 MTG Latch Installed PIREP
bmissing. Lhs bottom.

During passing on auto engine

one single channel light still
06/06/2019 07/06/2019 61 Resetted. Test found OK PIREP
remaîn on .need to shutt off all
the aircraft

PEC 1 REPLACED IAW612163 RAI

10000 002 REV 00 JAN 19. ALL
07/06/2019 09/06/2019 61 DLP Eng 1 PEC FAULT BEFORE START CHECKS PERFORMED PIREP
SATISFACTORILY. NO FAULTS
OBSERVED

14/06/2019 16/06/2019 25 MTG Armrest 15a damaged Arm rest installed 25-31-01-03 PIREP

Adf2 time to time giving false ACP REPLACED.IAW 235181. RAI

14/06/2019 17/06/2019 34 MTG indication. In flight and on 10000 TEST OK P/N ACP2351 SN 34-50-01-3 PIREP
ground. OFF 1134 SN ON 1065
 Jan 2020
Annual Reliability Report ATR72
Page 6

Date Opened Date Closed From Tech-Log Closing TechLog ATA Reported By Description Action Performed MEL Ref. Classification

PIREP

After third leg, fwd smoke FWD SMOKE DETECTOR

triggered with no smoke REMOVED INSPECTED AND
15/06/2019 16/06/2019 26 DLP detected (visual check). CLEANED.OPERATIONAL CHECK 26-15-01-01 PIREP
Continous Erroneous alert PERFORMED SATISFACTORILY
during turn around. IAW261500

Passing 7000 feet, FO speed

Thanks for info. Noted. No
indicator drops down during 2
15/06/2019 16/06/2019 34 DLP problem appeared during PIREP
seconds. Aural alert (VMO, stall
check on ground
?) triggered during 1 second.

10C door repaired it. All the

oxygen mask door inspected
Following pax oxygen box flap
and operational check
door closing mechanism trouble
performed one by one iaw
26/06/2019 26/06/2019 25 JCR (10C/A) troubles opening other 35-20-01 PIREP
352325 opt10010-001 All the
boxes. Pax oxygen system to
oxygen pax system works
check
propely. NOTE: pls you have to
open it with right way.

ATC TRANSPONDER REPLACED

IAW JIC 34.52.82 RAI 10000 001
During climb transpondeur REV00,MAR19.TESTED FOUND
05/07/2019 12/09/2019 34 CPR 34-52-02 A PIREP
number 2 was not working OK. P/N 622-9210-
007,S/N OFF 112BN,S/N ON
23GT
Static covers missing screw
and/or protective foam (see Foûd inboard aircraft second
10/10/2019 17/10/2019 2019-408 2019-437 25 JCR PIREP
attached picture-only mettalic statics kit, installed
part present)
Radio altimeter indicating three After captain
dashes in flight. Consequence reportnoproblemappeared
« Landing Gear Not Down » during flight. Radio altimeter
10/10/2019 10/10/2019 2019-408 2019-410 34 JCR indication on CAP with MASTER test performed on ground aw 34-42-01 PIREP
WARNING. TCAS failure 344200 opt 1000-001 rev
indicated as another mar01/19. Test performed
consequence satysfactorily.

Lamp replaced iaw 331280 rai

10/10/2019 10/10/2019 2019-408 2019-410 33 JCR Overhead flood light inoperative 33-10-01 PIREP
10000 .test ok

Lamp replaced iaw 334132 rai

10/10/2019 10/10/2019 2019-408 2019-410 33 JCR Left Nav Light Inop 10010 rev mar 01/19. PN 33-41-01 PIREP
29100A2140054K.Test ok

2 bugs missing altimeter 1 + 1 All the bugs installed. PN

10/10/2019 11/10/2019 2019-411 2019-412 34 FLB PIREP
bug missing altimeter 2 on4019565-101

Emergency locator transmiter System receted andtest

13/10/2019 13/10/2019 2019-416 2019-417 25 KWK transmits continously on perfomed satysfactorily iaw AT PIREP
ground. ASR filed. 25.

Radio Altimeter Failure during

Radio altimeter antennas
cruise. Consequently, GPWS
cleaned. Opeartioanl test of
fault and TCAS fault and LDG
radio altimeter performed iaw
14/10/2019 14/10/2019 2019-419 2019-422 34 LVI GEAR NOT DOWN Master 34-42-01 PIREP
AMM 34-42-00 OPT 10000-001
Warning. Event happened on
rev Jul 2019. MEL 34-42-01
first flight only, remaining flights
closed.
without no faults.
 Jan 2020
Annual Reliability Report ATR72
Page 7

Date Opened Date Closed From Tech-Log Closing TechLog ATA Reported By Description Action Performed MEL Ref. Classification

PIREP

Seat 16D traytable locking Locker table tray 16D fixed iaw
16/10/2019 16/10/2019 2019-431 2019-432 25 LVI PIREP
system out of place CMM 25-20-00

Plug connector of the RA

RA fault for 10min , 4 dash on
transceiver cleaned and
screen, during descent +/-
checked iaw AMM 34-42-81 RAI
18/10/2019 18/10/2019 2019-439 2019-442 34 passing 5000ft. All the PIREP
10000-001 ndf. Test of the RA
associated faults MW LD not
performed iaw AMM 34-42-00
down, GPWS fault, Tcas fail.
OPT 10000-001 test passed.

Ground cable (tresse de mise à la

Lead bonding on right MLG
masse) on right landing gear
18/10/2019 25/10/2019 2019-440 24 LVI door replaced iaw standart PIREP
panel broken. Found during
practice
walkaround.

After start-up in Hotel mode, Flow divider and dump valve

fuel leak under right engine via replaced iaw AMM 73-13-62 RAI
18/10/2019 23/10/2019 2019-441 72(T) CSE fuel drain. Continuous leak 10000-002. Run up for leakage PIREP
during 7 minutes until engine performed unsuccessfull. A/C
shut-off. nogo always fuel leak

During first flight, Radio

altimeter fault during climb. Radio alti transceiver replaced
24/11/2019 03/12/2019 34 DLP Radio altimeter comes ON again iaw JIC 34-42-81 RAI 10000-001. PIREP
during cruise. No fault during Test satis
next flights.

Flight attendant panlel inop, Relay 4MW replaces iaw IPC 31-
except when GPU connected. 17-80. Operational test of the
24/11/2019 28/11/2019 25 DLP Cabin crew unable to adjust flight attendant panel PIREP
cabin light. Reset with circuit performed iaw JIC 31-17-21 OPT
breaker unsuccessfull. 10000-001. Test satis on

Re adjsutement seats
Seats 9A and 16C not standing
24/11/2019 25/11/2019 25 DLP parformed. 9A and 16C work 25-31-01-01 PIREP
in upright position
correctly

Replacement bulb on xfeed

One light on XFeed fuel is
26/11/2019 26/11/2019 28 LBU push button performed test PIREP
broken
pass no defect found

Rotactor F/O wiper cleàned.

Operational test of windshield
28/11/2019 28/11/2019 30 LBU Wiper first officer inop. rain removal system performed 30-65-01-01 PIREP
iaw JIC 30-45-00 OPT 10000-001.
Test satis
 Jan 2020
Annual Reliability Report ATR72
Page 8

Date Opened Date Closed From Tech-Log Closing TechLog ATA Reported By Description Action Performed MEL Ref. Classification

PIREP
Plug and potentiometer 111VU
cleanedOperational test of the
flight compartment integeal
Breaker capt norm light pop out,
28/11/2019 28/11/2019 33 LBU lightîg performex iaw JIC 33-13- PIREP
after one reset pop out again
00 OPT 10000-001. All work
normaly breaker capt norm
light ok
Plug on indicator 3QT cleaned
Temporary Fuel Caution on CAP
iaw JIC 28-42-81 RAI 10000-001.
in cruise with R LO LVL
Test of the FQI performed iaw
indication and 000kg on right
29/11/2019 29/11/2019 28 JCR JIC 28-42-00 TST 10000-001 para PIREP
FUEL QTY INDICATOR. Fuel
6. Test satis. Memory misc 2 on
indicator went back to normal
MFC checked. Found code
value in short delay.
0011.

Replacement relay 8DB and opt

wiper performed iaw jic
29/11/2019 09/12/2019 56 LBU Wiper first officer inop 30-65-01-01 PIREP
304500opt10000 test pass no
defect found

After initial power up, only FWD

SMK red light appeared on CAP
without MW. One reset was
unsuccessful, until the cargo
Fwd cargo smoke detector
door opening (spurious failure).
replacement performed iaw JIC
When taxiing on the runway, the
26-15-21 RAI 10000-001.
red light with MW triggered.
01/12/2019 05/12/2019 26 PRA Operational test of the smoke 26-15-01-01 PIREP
Recirc fans has been turned off
detection performed iaw JIC 26-
with the 3 items of the fwd
15-00 OPT 10000-001. Test satis
smoke with passengers
MEL 26-15-01-01 closed
configuration. During cockpit
preparation, others spurious
failures appeared (crcdb in
progress)

Due to ext pwr not connected

and eng starer#2 fault TSM 24-
46-00 applied. Operational test
of DC BPCU performed iaw JIC
04/12/2019 04/12/2019 24 Eng starter no2 fault. 24-46-83 OPT 10000-001. Found PIREP
FLRU CNTR magnetic indicator
energized. Contactor 8PX
checked and cleaned. DC ext
power ON and system normal.
Circuit breaker- Flight Cleaning rotary selector of
compartment - CPT NORM LT flood light ( lot of dust inside )
09/12/2019 09/12/2019 24 PIREP
does not hold in - no light on and opt flood light performed.
Captain side - flight deck Test pass no defect found
No flood light on FO side - flight Replacement bulb performed
09/12/2019 09/12/2019 33 PIREP
deck test pass no defect found
Proximity switch 10GB replaced
Landong gear right unlock in
15/12/2019 19/12/2019 32 CTT iaw JIC 32-61-00 rai 10000-001 32-61-01 PIREP
flight on system 2
and test ok / mel closed
Vmo 250kts not exceeded ias
recorded 239 kts. All load factor
In cruise we have VMO alert
18/12/2019 18/12/2019 51 valid. No maintenance action PIREP
during 2seconds.
required iaw JIC 05-51-11 DVI
10000-001 rev March 2019.
Operational test of the weather
radar performed iaw jic 34-41-
20/12/2019 20/12/2019 34 CHE Weather radar inop 00 opt 10000-001 / test ok / no 34-41-01 PIREP
defects found during test on
ground

R/I bulb iaw jic 33-47-41 RAI

27/12/2019 28/12/2019 33 FLB Logo light 1 inop 33-47-01 PIREP
10010

Switch copil master warning

27/12/2019 31/03/2020 31 FLB Master Warning cap worn out PIREP
replaced
 Jan 2020
Annual Reliability Report ATR72
Page 9

Date Opened Date Closed From Tech-Log Closing TechLog ATA Reported By Description Action Performed MEL Ref. Classification

MAREP

Yellow bug on IAS indicator right SPEED BUG INSTALLED IAW

22/01/2019 28/01/2019 34 MAREP
side MISSING 34_13_81

RESPECTIVE FLUORESANT TUBE

REPLACED IAW ATR MM CH
CABIN LATERAL LIGHTING ABOVE
21/03/2019 21/03/2019 33 ACP 33.21.23 RAI 10000.001 MAREP
SEAT 9AC INOP.
RV10,MAR 19 TESTED FOUND
OK

RH TAXI LIGHT LAMP REPLACED

IAW ATR MM CH 33.46.13 RAI
24/03/2019 24/03/2019 33 ACP RH TAXI LIGHT INOPERATIVE MAREP
10010 002 REV 10,MAR 19
TESTED FOUND OK

Ceiling lamps above seats 1-2,3-

27/03/2019 33 ACP Lamps replaced,checked ok MAREP
4,17-18 u/s

TAXI LIGHT LAMP REPLACED

IAW 33.46.13 RAI 10010 001 REV
10/05/2019 10/05/2019 33 ACP L/H TAXI LIGHT U/S MAREP
00 MAR 19.TESTED FOUND
OK.P/N 4626

RH OUTER M/W REPLACED BY A

SER.ONE IAW 12.37.32 RAI10000
RH OUTER M/W MUST BE 001 REV 00/MAR19.P/N OFF
14/05/2019 14/05/2019 32 ACP REPLACED DUE TO NORMAL AHA1890 S/N OFF 5040MY ,P/N MAREP
WEAR. ON AHA1890 S/N ON XX187. TQ
WRENCH USED S/N N230670
DUE 11/01/2020.

Blind assy replaced replaced by

29/05/2019 29/05/2019 25 ACP Window shade seat 15A is u/s a new one iaw ch25.Checked MAREP
ok.P/N 170-15922-990

RESPECTIVE MW REPLACED IAW

30/05/2019 30/05/2019 32 ACP LH OUTER MW FOUND WORN 12.37.32 RAI 10000 001 REV 00 MAREP
MAR 19

BOTH NOSE WHEELS REPLCED

BOTH NOSE WHEELS FOUND IAW 12.37.32 RAI 10010-001
31/05/2019 31/05/2019 32 ACP MAREP
WORN TO THE LIMITS REV00,JAN19. P/N
AH54474,S/Ns 5010NT,5009GC

Respective lamp replaced IAW

During line check R/H taxi light 33.46.13 RAI 10010 001
01/07/2019 01/07/2019 33 ACP MAREP
found U/S REV00,MAR19.Tested found
OK.P/N 4626.

THE EROSION FILM ON THE

ON THREE BLADES OF LH
THREE BLADES OF LH PROP
PROPELLER THE EROSION FILM
07/07/2019 07/07/2019 61 ACP REPLACED IAW HAMILTON MM MAREP
FOUND DAMAGED AND MUST BE
61.10.00.RAW MATERIAL USED
REPLACED.
PN 814761-2

SPRING PIN REPLACED IAW ATR

LH ENG,REAR OIL COOLER MM CH 79.26.61 RAI 10000 001
11/07/2019 11/07/2019 79 ACP FLAP,LH BELLCRANK SPRING PIN REV00 MAR19.FLAP TESTED, MAREP
FOUND BROKEN FOUND OK.SPRING PIN P/N
NSA5319-05-18

VHF control panel installed iaw

VHF No ROBBED TO SERVICE F-
18/07/2019 20/08/2019 23 ACP 231282 rai 10000 rev 00 mar19 MAREP
GPYK. AIRCRAFT AOG
PN 822-1120-003 SN on 13557

Radio altimeter tranceiver

RADIO ALTIMETER TRANSCEIVER
installed iaw 334281 rai10000
ROBBED TO SERVICE F-GPYN. P/N
22/07/2019 20/08/2019 34 ACP rev00 mar19.PN 9599-607-14562 MAREP
9599 607 14562,S/N
sn off 5300 sn on 05921 .MEL
5300.AIRCRAFT AOG
item removed
 Jan 2020
Annual Reliability Report ATR72
Page 10

Date Opened Date Closed From Tech-Log Closing TechLog ATA Reported By Description Action Performed MEL Ref. Classification

MAREP
Anticollision light replaced IAW
LOWER ANTICOLLISION LIGHT
334851 RAI 10000 REV 00
ROBBED TO SERVICE F-GPYM.P/N
24/07/2019 14/08/2019 33 ACP MAR19.Test ok.. MEL item MAREP
R25-1M2CW S/N NOT
removed Pn R25-1M2CW SN
VISIBLE.AIRCRAFT AOG
OFF 3314 SN ON 5230

VSI/TCAS INSTALLED IAW

341481 RAI 10000. PN
30/07/2019 20/08/2019 34 ANG VSIROBBEDTO SERVCEF-GPYM 34-14-01 MAREP
457400TC0812 SN OFF10823 SN
ON 3139. MEL ITEM REMOVED

Hinge Fitting from bin door

Bin doorbracket from seat 11
30/07/2019 25/08/2019 25 ANG installed IAW ATR SP MANUAL MAREP
robbed to service F-GPYM
PN ON S2521972020001

LH LANDING LIGHT LAMP

REPLACED IAW 33.42.51 RAI
04/09/2019 04/09/2019 33 ACP LH LANDING LIGHT FOUND U/S MAREP
10010.001 REV00-MAR19.P/N
Q4681.TESTED FOUND OK.

THE TWO FLUORESCANT TUBES

WERE RRPLACED IAW 33.21.23
RAI 10000 001 REV00-
MAR19,ALSO ONE BALLAST
CONVERTER FOUND FAULTY
TWO FLUORESCANT TUBES IN AND REPLACED IAW 33.21.21
04/09/2019 04/09/2019 33 ACP THE LATERAL CABIN LIGHTING RAI 10000 001 REV00- MAREP
FOUND U/S MAR19.TESTED FOUND
OK.PARTS USED TWO
FLUORECANT TUBES P/N
E0387-11 AND BALLAST
CONVERTER P/N 37.17.2 S/N
OFF 584,S/N ON 19682
Main wheel#3 replacement
25/10/2019 25/10/2019 32 Tudal, Olivier Main wheel#3 worn performed iaw AMM 12-37-32 MAREP
RAI 10000-002

Replacement 02 bottle
06/11/2019 06/11/2019 35 L’hermitte, Arnaud Level o2 bottle 1200psi MAREP
performed

Replacement of Ice Evidence

Out of line and weekly check, Probe lamp performed IAW
09/11/2019 09/11/2019 30 Carlut, Nicolas MAREP
found IEP light INOP. AMM JIC 30-83-11-RAI-10010.
OPT test okay.

Rack compartment 19AC

Rack compartment 19AC support
14/11/2019 21/11/2019 25 Tudal, Olivier actuator fitting replaced iaw JIC MAREP
actuator broken
25-24-21 RAI 10000-001

Window lights 19AC and 4DF Ballast unit 19AC and 4DF
u/s, ballalst unit inop( tube and replacement performed iaw JIC
14/11/2019 21/11/2019 33 Tudal, Olivier 33-10-02-01 MAREP
fuse replaced without effect), 33-21-21 RAI 10000-001 MEL 33-
part in order 10-02-01 closed

Seal of cockpit protective Cockpit smoke hood replaced

14/11/2019 28/11/2019 25 Tudal, Olivier 25-45-01 MAREP
breathing equipment broken iaw standart practice

Replacement anti collision light

During taxiing see bottom performed iaw amm jic 33-48-51-
20/11/2019 26/11/2019 33 Tudal, Olivier 33-48-01 (A) MAREP
beacon light u/s rai-10000-001 test pass/no
defect fou d
 Jan 2020
Annual Reliability Report ATR72
Page 11

Date Opened Date Closed From Tech-Log Closing TechLog ATA Reported By Description Action Performed MEL Ref. Classification

MAREP

Left ldg light replacement

During taxiing found left ldg
21/11/2019 21/11/2019 33 Tudal, Olivier performed iaw JIC 33-42-51 RAI MAREP
light u/s
10000-001 . Test satis

Replacement of the left nose

During WY check found left
29/11/2019 29/11/2019 32 Tudal, Olivier wheel performed iaw JIC 12-37- MAREP
nose wheel worn
32 RAI 10010-001

Replacement of the right nose

During WY check found right
29/11/2019 29/11/2019 32 Tudal, Olivier wheel performed iaw JIC 12-37- MAREP
nose wheel worn
32 RAI 10010-001.

Fwd smoke det checked and

cleaned iaw JIC 26-15-21 RAI
10000-001. Operatioan test of
Due to fwd smoke det inop MEL
03/12/2019 03/12/2019 26 Tudal, Olivier the smoke det system’performd MAREP
26-15-01-01
iaw JIC 26-15-00 OPT 10000-001.
Unsuccessfull for the fwd
smoke det. Part in order

Lateral light row 1DF replaced

04/12/2019 04/12/2019 33 Tudal, Olivier Lateral light row 1DF u/s iaw JIC 33-21-23 RAI 10000-001. MAREP
Test satis

F/O wiper selector replaced iaw

Due to MEL 30-65-01-01 FÔwiper
06/12/2019 06/12/2019 30 Tudal, Olivier IPC 30-45-80 page1-0. Test MAREP
inop
performed unsuccessfull
TSM’30-45-00 applied. Relay
7Db and 8DB swapped. Now
Due to MEL 30-65-01-01 F/ O trouble on cpt wiper. Relay put
06/12/2019 06/12/2019 30 Tudal, Olivier MAREP
wiper inop in normal config relay 8db
found pin1 damaged. Part in
order
Main wheel#2 replacement
performed iaw JIC 12-37-32 RAI
During wy check found main
13/12/2019 13/12/2019 32 Tudal, Olivier 10010-001 rev march 2019 MAREP
wheel#2 worn
Task cancelled automatically
(not found in status)
TSM 32-60-00 page 107 applied.
Limit switch 10GA and 11GA
swapped iaw JIC 32-61-00 RAI
10010-001. Free fall mechanism
Due to HIL 2019-584-1 MEL
16/12/2019 16/12/2019 32 Tudal, Olivier operational check percormd MAREP
opened by crew 32-61-01
iaw JIC 32-33-00 OPT 10000-001.
Test satis. Please confirm next
flight if trouble on l/h mlg or
always r/h mlg
Seat 7A recline button replaced
17/12/2019 23/01/2020 25 Tudal, Olivier Seat 7A button broken iaw CMM 25-28-31 Rev May MAREP
2017.
Limit switch 10GA and 11GA
swapped in normal config iaw
JIC 32-61-00 RAI 10010-001, free
fall mechanism operatioanal
check performed iaw JIC 32-33-
00 OPT 10000-001 test satis.
Due to HIL 2019-584-1 MEL 32-61-
17/12/2019 17/12/2019 32 Tudal, Olivier Proximity switch,target and MAREP
01opened by crew
connector plug 8GA 10GB 54GB
55GB cleaned. Reading of mfc
maintenance memory
performed iaw JIC 45-13-00
RDG 10000-001. No code
recorded.
R/I brake n 4 iaw jic 32-42-55
28/12/2019 28/12/2019 32 Freitas, Raoul Brake n 4 worn MAREP
RAI 10000
 Jan 2020
Annual Reliability Report ATR72
Page 12

Intentionally Blank
 Jan 2020
Annual Reliability Report ATR72
Page 13

Mean Standard Deviation 3x Stand. Deviation 3x Stand. Deviation + Average

ATA MAREP PIREP MAREP PIREP MAREP PIREP MAREP Limit PIREP Limit
21/29/36 0,00 0,34 0,00 0,36 0,00 1,08 0,00 1,42
22/27 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00
23/31 0,14 0,02 0,16 0,05 0,48 0,16 0,62 0,17
24/33 3,30 0,27 1,84 0,50 5,53 1,51 8,83 1,77
25/26/35/38 0,81 1,80 0,53 0,72 1,58 2,17 2,39 3,97
28 0,31 0,86 0,28 0,68 0,83 2,05 1,14 2,91
30 0,06 0,03 0,16 0,08 0,49 0,24 0,56 0,27
32 0,72 0,20 0,57 0,17 1,72 0,50 2,45 0,71
34 1,59 1,35 0,51 0,88 1,52 2,65 3,11 4,00
5X 0,26 0,23 0,23 0,18 0,69 0,55 0,94 0,79
61/7X/80 0,29 0,41 0,32 0,37 0,95 1,12 1,24 1,53

MAREP/PIREP – 12 MO Rolling Average

MAREP (12 MO Rolling Average)

ATA
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19
21/29/36 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00
22/27 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00
23/31 0,00 0,00 0,00 0,00 0,00 0,00 0,35 0,35 0,35 0,28 0,22 0,18
24/33 0,00 0,00 3,96 6,72 4,85 3,27 3,50 3,50 4,19 3,33 3,37 2,91
25/26/35/38 0,00 0,00 0,00 0,96 1,21 0,82 1,05 1,05 1,05 0,83 1,35 1,46
28 0,00 0,00 0,00 0,96 0,61 0,41 0,35 0,35 0,35 0,28 0,22 0,18
30 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,22 0,55
32 (CY) 0,00 0,00 0,00 0,00 1,51 1,03 0,89 0,89 0,88 0,93 1,09 1,48
34 1,80 1,35 1,32 2,88 1,82 1,22 1,75 1,75 1,75 1,39 1,12 0,91
5X (CY) 0,00 0,00 0,00 0,79 0,50 0,34 0,30 0,30 0,29 0,23 0,18 0,15
61/7X/80 0,00 0,00 0,00 0,00 0,00 0,00 0,70 0,70 0,70 0,56 0,45 0,36
TOTAL(Sum) 1,80 1,35 5,27 12,31 10,50 7,09 8,89 8,89 9,56 7,83 8,24 8,18

PIREP (12 MO Rolling Average)

ATA
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19
21/29/36 0,00 0,00 1,32 0,01 0,61 0,41 0,35 0,35 0,35 0,28 0,22 0,18
22/27 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00
23/31 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,18
24/33 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,83 0,90 1,46
25/26/35/38 1,80 1,35 1,32 0,01 1,21 2,45 2,10 2,10 2,10 2,50 2,47 2,18
28 0,00 1,35 2,64 0,02 1,21 0,82 0,70 0,70 0,70 0,56 0,90 0,73
30 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,00 0,22 0,18
32 0,00 0,00 0,00 0,00 0,50 0,34 0,30 0,30 0,29 0,23 0,18 0,30
34 0,00 0,00 1,32 0,01 1,21 1,63 1,75 1,75 1,75 2,50 2,25 2,00
5X 0,00 0,00 0,00 0,00 0,50 0,34 0,30 0,30 0,29 0,23 0,36 0,44
61/7X/80 0,00 0,00 0,00 0,00 0,00 0,82 0,70 0,70 0,70 0,83 0,67 0,55
TOTAL(Sum) 1,80 2,69 6,59 0,05 5,25 6,81 6,19 6,19 6,18 7,97 8,19 8,20
 Jan 2020
Annual Reliability Report ATR72
Page 14

1,60
ATA 21/29/36 0.5
MAREP MO (/100
FH)
1,40 0.5
PIREP MO (/100
1,20 0.4 FH)
0.4
1,00 MAREP (12 MO
0.3 Rolling Average)
0,80
0.3
0,60 PIREP (12 MO
0.2
Rolling Average)
0,40
0.2
0,20 MAREP ALERT
0.1
0,00 0.1
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19 PIREP ALERT
-0,20 0.0

1,00
ATA 22/27 1,00
MAREP MO (/100
FH)
0,90 0,90
PIREP MO (/100
0,80 0,80 FH)
0,70 0,70
MAREP (12 MO
0,60 0,60 Rolling Average)
0,50 0,50
PIREP (12 MO
0,40 0,40
Rolling Average)
0,30 0,30
MAREP ALERT
0,20 0,20
0,10 0,10
0,00 0,00 PIREP ALERT
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19

ATA 23/31 MAREP MO

0,70 3,00 (/100 FH)

0,60 2,50 PIREP MO (/100

FH)
0,50
2,00
MAREP (12 MO
0,40 Rolling Average)
1,50
0,30 PIREP (12 MO
1,00 Rolling Average)
0,20
MAREP ALERT
0,10 0,50

0,00 0,00 PIREP ALERT

jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19
 Jan 2020
Annual Reliability Report ATR72
Page 15

ATA 24/33 MAREP MO (/100

10,00 300,00 FH)
9,00
PIREP MO (/100
250,00
8,00 FH)
7,00 MAREP (12 MO
200,00
6,00 Rolling Average)

5,00 150,00 PIREP (12 MO

Rolling Average)
4,00
100,00 MAREP ALERT
3,00
2,00
50,00
PIREP ALERT
1,00
0,00 0,00
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19

ATA 25/26/35/38 MAREP MO

4,50 6,00 (/100 FH)
4,00
5,00 PIREP MO (/100
3,50 FH)
3,00 4,00
MAREP (12 MO
2,50
3,00 Rolling Average)
2,00
PIREP (12 MO
1,50 2,00
Rolling Average)
1,00
1,00 MAREP ALERT
0,50
0,00 0,00
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19 PIREP ALERT

3,50
ATA 28 70,00
MAREP MO (/100
FH)
3,00 60,00 PIREP MO (/100
FH)
2,50 50,00
MAREP (12 MO
2,00 40,00 Rolling Average)

1,50 30,00 PIREP (12 MO

Rolling Average)
1,00 20,00
MAREP ALERT
0,50 10,00

PIREP ALERT
0,00 0,00
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19
 Jan 2020
Annual Reliability Report ATR72
Page 16

0,60
ATA 30 2,50 MAREP MO (/100
FH)

0,50 PIREP MO (/100

2,00
FH)
0,40
1,50 MAREP (12 MO
Rolling Average)
0,30
1,00 PIREP (12 MO
0,20 Rolling Average)

0,50 MAREP ALERT

0,10

0,00 0,00 PIREP ALERT

jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19

3,00
ATA 32 4,50
MAREP MO
(/100 FH)
4,00
2,50 PIREP MO (/100
3,50 FH)
2,00 3,00
MAREP (12 MO
2,50 Rolling Average)
1,50
2,00 PIREP (12 MO
Rolling Average)
1,00 1,50
1,00 MAREP ALERT
0,50
0,50
0,00 0,00 PIREP ALERT
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19

ATA 34
4,50 70,00 MAREP MO
4,00
(/100 FH)
60,00
3,50 PIREP MO (/100
50,00 FH)
3,00
MAREP (12 MO
2,50 40,00 Rolling Average)
2,00 30,00 PIREP (12 MO
1,50 Rolling Average)
20,00
1,00 MAREP ALERT
10,00
0,50
PIREP ALERT
0,00 0,00
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19
 Jan 2020
Annual Reliability Report ATR72
Page 17

1,00
ATA 5x
3,50
MAREP MO
(/100 FH)
0,80 3,00
PIREP MO (/100
2,50 FH)
0,60
MAREP (12 MO
2,00
Rolling Average)
0,40
1,50 PIREP (12 MO
0,20 Rolling Average)
1,00
MAREP ALERT
0,00 0,50
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19
PIREP ALERT
-0,20 0,00

ATA 61/7X/80
1,80 6,00 MAREP MO
1,60 (/100 FH)
5,00
1,40 PIREP MO (/100
FH)
1,20 4,00
MAREP (12 MO
1,00 Rolling Average)
3,00
0,80 PIREP (12 MO
0,60 2,00 Rolling Average)

0,40 MAREP ALERT

1,00
0,20
PIREP ALERT
0,00 0,00
jan/19 fev/19 mar/19 abr/19 mai/19 jun/19 jul/19 ago/19 set/19 out/19 nov/19 dez/19

*MAREP MO (/100 FH) and PIREP MO (/100 FH) to be read on the RH Axis
 Jan 2020
Annual Reliability Report ATR72
Page 18

Intentionally Blank