Safety Data Sheet
Revision Number: 004.1 Issue date: 07/09/2018
1. PRODUCT AND COMPANY IDENTIFICATION
Product name: LOCTITE STYCAST HD 3561 known as IDH number: 397720
HYSOL HD3561 QT
Product type: Epoxy Hardener Item number: HD3561-B30
Restriction of Use: None identified Region: United States
Company address: Contact information:
Henkel Corporation Telephone: +1 (860) 571-5100
One Henkel Way MEDICAL EMERGENCY Phone: Poison Control Center
Rocky Hill, Connecticut 06067 1-877-671-4608 (toll free) or 1-303-592-1711
TRANSPORT EMERGENCY Phone: CHEMTREC
1-800-424-9300 (toll free) or 1-703-527-3887
Internet: [Link]
2. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
DANGER: CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
MAY CAUSE AN ALLERGIC SKIN REACTION.
HAZARD CLASS HAZARD CATEGORY
SKIN CORROSION 1B
SERIOUS EYE DAMAGE 1
SKIN SENSITIZATION 1
PICTOGRAM(S)
Precautionary Statements
Prevention: Avoid breathing vapors, mist, or spray. Wash affected area thoroughly after handling.
Contaminated work clothing should not be allowed out of the workplace. Wear protective
gloves, clothing, eye and face protection.
Response: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. If on skin (or hair): Take off
immediately all contaminated clothing. IF INHALED: Remove victim to fresh air and keep at rest
in a position comfortable for breathing. Immediately call a POISON CENTER or physician. IF IN
EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing. If skin irritation or rash occurs: Get medical attention. Wash
contaminated clothing before reuse.
Storage: Store locked up.
Disposal: Dispose of contents and/or container according to Federal, State/Provincial and local
governmental regulations.
Classification complies with OSHA Hazard Communication Standard (29 CFR 1910.1200) and is consistent with the provisions of the
United Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS).
See Section 11 for additional toxicological information.
3. COMPOSITION / INFORMATION ON INGREDIENTS
IDH number: 397720 Product name: LOCTITE STYCAST HD 3561 known as HYSOL HD3561 QT
Page 1 of 5
Hazardous Component(s) CAS Number Percentage*
3,3'-Oxybis(ethyleneoxy)bis(propylamine) 4246-51-9 90 - 100
* Exact percentages may vary or are trade secret. Concentration range is provided to assist users in providing appropriate protections.
4. FIRST AID MEASURES
Inhalation: Move to fresh air. If not breathing, give artificial respiration. If breathing is
difficult, give oxygen. Get medical attention.
Skin contact: Immediately flush skin with plenty of water (using soap, if available). Remove
contaminated clothing and footwear. If symptoms develop and persist, get
medical attention. Wash clothing before reuse.
Eye contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15
minutes. Get medical attention.
Ingestion: Do not induce vomiting. Never give anything by mouth to an unconscious
person. Get medical attention.
Symptoms: See Section 11.
5. FIRE FIGHTING MEASURES
Extinguishing media: Foam, dry chemical or carbon dioxide.
Special firefighting procedures: Wear self-contained breathing apparatus and full protective clothing, such as
turn-out gear. In case of fire, keep containers cool with water spray.
Unusual fire or explosion hazards: Closed containers may rupture (due to build up of pressure) when exposed to
extreme heat.
Hazardous combustion products: Oxides of carbon, oxides of nitrogen, irritating organic vapors. Ammonia.
Collect contaminated fire extinguishing water separately. This must not be
discharged into drains.
6. ACCIDENTAL RELEASE MEASURES
Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected
personnel.
Environmental precautions: Do not allow product to enter sewer or waterways.
Clean-up methods: Ensure adequate ventilation. Isolate area. Keep unnecessary personnel
away. Soak up with inert absorbent material (e.g. sand, silica gel, acid binder,
universal binder, sawdust). Store in a partly filled, closed container until
disposal. Refer to Section 8 "Exposure Controls / Personal Protection" prior to
clean up.
7. HANDLING AND STORAGE
Handling: Use only with adequate ventilation. Prevent contact with eyes, skin and
clothing. Do not breathe vapor and mist. Wash thoroughly after handling. Do
not taste or swallow. Refer to Section 8.
Storage: Keep in a cool, well ventilated area away from heat, sparks and open flame.
Keep container tightly closed until ready for use. Do not store in reactive metal
containers.
For information on product shelf life, please review labels on container or check the Technical Data Sheet.
IDH number: 397720 Product name: LOCTITE STYCAST HD 3561 known as HYSOL HD3561 QT
Page 2 of 5
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure
controls and protective equipment for each task performed.
Hazardous Component(s) ACGIH TLV OSHA PEL AIHA WEEL OTHER
3,3'-Oxybis(ethyleneoxy)bis(propylamine) None None None None
Engineering controls: Provide adequate local exhaust ventilation to maintain worker exposure below
exposure limits.
Respiratory protection: Use a NIOSH approved air-purifying respirator if the potential to exceed
established exposure limits exists.
Eye/face protection: Safety goggles or safety glasses with side shields. Full face protection should
be used if the potential for splashing or spraying of product exists. Safety
showers and eye wash stations should be available.
Skin protection: Use chemical resistant, impermeable clothing including gloves and either an
apron or body suit to prevent skin contact. Neoprene, Butyl-rubber, or nitrile-
rubber gloves.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state: Liquid
Color: Colorless
Odor: Ammoniacal
Odor threshold: Not available.
pH: Alkaline
Vapor pressure: 3.00 mm hg (21 °C (69.8 °F))
Boiling point/range: 294.8 °C (562.6 °F)Estimated
Melting point/ range: Not available.
Specific gravity: 1.01 at 21 °C (69.8 °F)
Vapor density: 27.8481
Flash point: 121 °C (249.8 °F)
Flammable/Explosive limits - lower: Not available.
Flammable/Explosive limits - upper: Not available.
Autoignition temperature: 260 °C (500°F)
Flammability: Not applicable
Evaporation rate: Not available.
Solubility in water: Completely soluble
Partition coefficient (n-octanol/water): Not available.
VOC content: Negligible
Viscosity: Not available.
Decomposition temperature: Not available.
10. STABILITY AND REACTIVITY
Stability: Stable under normal conditions of storage and use.
Hazardous reactions: None under normal processing.
Hazardous decomposition Oxides of carbon. Oxides of nitrogen. Ammonia. Irritating vapors. Nitrogen oxide can react
products: with water vapor to form corrosive nitric acid.
Incompatible materials: Acids. Oxidizing agents. Peroxides. Sodium hypochlorite. This product slowly corrodes copper,
aluminum, zinc and galvanized surfaces.
Reactivity: Not available.
Conditions to avoid: Keep away from open flames, hot surfaces and sources of ignition. Store away from
incompatible materials.
IDH number: 397720 Product name: LOCTITE STYCAST HD 3561 known as HYSOL HD3561 QT
Page 3 of 5
11. TOXICOLOGICAL INFORMATION
Relevant routes of exposure: Skin, Inhalation, Eyes, Ingestion
Potential Health Effects/Symptoms
Inhalation: Severe respiratory tract irritation.
Skin contact: Causes skin burns. May cause allergic skin reaction.
Eye contact: Causes serious eye damage. Burns of the eye may cause blindness.
Ingestion: Irritation and corrosive action can occur in the mouth, stomach tissue and digestive tract if
swallowed. Danger of perforation of the esophagus and the stomach.
Hazardous Component(s) LD50s and LC50s Immediate and Delayed Health Effects
3,3'-Oxybis(ethyleneoxy)bis(propylamine) None Corrosive
OSHA Carcinogen
Hazardous Component(s) NTP Carcinogen IARC Carcinogen
(Specifically Regulated)
3,3'-Oxybis(ethyleneoxy)bis(propylamine) No No No
12. ECOLOGICAL INFORMATION
Ecological information: Not available.
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal: Follow all local, state, federal and provincial regulations for disposal.
Hazardous waste number: D002: Corrosive.
14. TRANSPORT INFORMATION
The transport information provided in this section only applies to the material/formulation itself, and is not specific to any
package/configuration.
U.S. Department of Transportation Ground (49 CFR)
Proper shipping name: Amines, liquid, corrosive, n.o.s. (Diethylene glycol di-(3-aminopropyl) ether)
Hazard class or division: 8
Identification number: UN 2735
Packing group: II
International Air Transportation (ICAO/IATA)
Proper shipping name: Amines, liquid, corrosive, n.o.s. (Diethylene glycol di-(3-aminopropyl) ether)
Hazard class or division: 8
Identification number: UN 2735
Packing group: II
Water Transportation (IMO/IMDG)
Proper shipping name: AMINES, LIQUID, CORROSIVE, N.O.S. (Diethylene glycol di-(3-aminopropyl)
ether)
Hazard class or division: 8
Identification number: UN 2735
Packing group: II
IDH number: 397720 Product name: LOCTITE STYCAST HD 3561 known as HYSOL HD3561 QT
Page 4 of 5
15. REGULATORY INFORMATION
United States Regulatory Information
TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act
Inventory.
TSCA 12 (b) Export Notification: None above reporting de minimis
CERCLA/SARA Section 302 EHS: None above reporting de minimis.
CERCLA/SARA Section 311/312: Immediate Health
CERCLA/SARA Section 313: None above reporting de minimis.
California Proposition 65: No California Proposition 65 listed chemicals are known to be present.
Canada Regulatory Information
CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Canadian Domestic
Substances List.
16. OTHER INFORMATION
This safety data sheet contains changes from the previous version in sections: 16
Prepared by: Product Safety and Regulatory Affairs
Issue date: 07/09/2018
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel
Corporation and its affiliates (“Henkel”) does not assume responsibility for any results obtained by persons over whose methods
Henkel has no control. It is the user’s responsibility to determine the suitability of Henkel’s products or any production methods
mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and
persons against any hazards that may be involved in the handling and use of any Henkel’s products. In light of the foregoing,
Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular
purpose, arising from sale or use of Henkel’s products. Henkel further disclaims any liability for consequential or incidental damages
of any kind, including lost profits.
IDH number: 397720 Product name: LOCTITE STYCAST HD 3561 known as HYSOL HD3561 QT
Page 5 of 5
